UENR6392-01

January 2019

70 7

UENR6392-01 VOL 1 of 4
49
25

(Dimensions: 56 inches x 35 inches)

18
CONN 8
17
20
48
12 29
28
19
CP56B, CS56B, CP68B, CS68B, CP74B,
26 CONN 14 CP76B, CS74B, CS78B and CS79B
8
11
15 Vibratory Soil Compactor
13
43
Electrical System
34 16
23 24 CP56B: CS56B: CP68B: CS68B:
22 32
MP61-UP M561-UP CM61-UP M681-UP
5081-UP 5071-UP 5101-UP 5091-UP
CONN 4

42 Page,
21 14 27 CP74B: CS74B: CS78B: CS79B:
46 CONN 5 5121-UP C741-UP 5131-UP CM71-UP
CONN 3 CP71-UP B7M1-UP M781-UP
47
45 CP76B:
4 J761-UP

3
44 42
9 10
Volume 1 of 4: Main Electrical System

© 2019 Caterpillar, All Rights Reserved Printed in U.S.A.

ELECTRICAL PANEL GP MACHINE WIRING GP

40 59 64 Component Location - Volume 1

Harness And Wire Electrical Schematic Symbols
Schematic Machine Schematic Machine
Component Component
62 Alarm - Backup
Location
H-16
Location
1 Module - Engine Control
Location
F-15
Location
37
Symbols
2 58 61 Antenna - Communications D-5 2 Motor - Alternator J-13 38
Battery - 12 Volt #1 I-16 3 Motor - Starter I-14 39
Battery - 12 Volt #2 I-16 4 Plugs - Glow J-14 40
T
Bead - Ferrite D-15 5 Radio - Communications D-5 41
Pressure Temperature Level Flow Circuit Breaker
CONN 2 38 Bead - Ferrite
Block - Power Junction
D-15
I-14
6
7
Receptacle - 12V Power Point
Receptacle - Jump Start
J-3
I-15
42
43
Symbol Symbol Symbol Symbol Symbol
Bus Bar - Unswitched Power +24V I-13 8 Receptacle - USB 12V Power Only I-3 44
Symbols and Definitions
CONN 1 50 Control - Machine
Converter - 24V to 12V
E-7
F-7
9
10
Relay - Glow Plugs
Relay - Reverse Alarm
I-12
J-7
45
46
Fuse - 12V Converter J-6 11 Relay - Shutdown H-12 47 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
Fuse - Cab I-6 12 Relay - Starter J-12 48
Fuse - Control J-5 13 Relay - Switched 24V Power J-7 49
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Fuse - Engine Control Module I-12 14 Resistor - Can 1 Terminal 1 (J1939) E-11 50
circle indicates that the component has screw terminals and a wire can be disconnected from it.
33 Fuse - Front Work Lights
Fuse - Glow Plug
J-5
I-12
15
16
Sender - Fuel Level Hi
Sender - Fuel Level Low
H-16
H-16
51
52
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
Fuse - Grade Control I-6 17 Sensor - Ambient Air Temprature F-11 53
41 Fuse - Grade Control 2 I-5 18 Sensor - Axle Speed D-8 54
No circle indicates that the wire cannot be disconnected from the component.

Fuse - Horn J-6 19 Sensor - Drum Speed J-8 55

CONN 4 Fuse - HVAC I-5 20 Sensor - Hydraulic Temperature D-11 56
Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
Fuse - Ignition Wakeuip J-6 21 Sensor - Water In Fuel (WIF) F-11 57

CONN 3 Fuse - Machine

Fuse - Machine ECM
J-5
J-6
22
23
Solenoid - Axle A
Solenoid - Axle B
F-9
F-9
58
59
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
Fuse - Main Power I-12 24 Solenoid - Brake Release E-9 60
Fuse - Product Link I-6 25 Solenoid - Drum A E-9 61 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Fuse - Rear Work Lights J-5 26 Solenoid - Drum B E-9 62 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
60 Fuse - Shutdown
Fuse - Shutdown Status
I-12
J-5
27
28
Solenoid - Fan
Solenoid - Valve Shift
F-11
D-10
63
64 Sender: A component that is used with a temperature or pressure gauge. The sender
Fuse - Wipers I-5 29 Solenoid - Vibratory A (Fixed Frequency) E-8 65 measures the temperature or pressure. Its resistance changes to give an indication to
CONN 13 CONN 8 Ground - Engine 1
Ground - Engine 2
I-13
I-13
30
31
Solenoid - Vibratory A (Variable Frequency)
Solenoid - Vibratory B (Fixed Frequency)
E-8
E-8
66
67
T
the gauge of the temperature or pressure.

CONN 10 Ground - Frame 1

Ground - Frame 2
I-14
E-14
32
33
Solenoid - Vibratory B (Variable Frequency)
Switch - Air Filter Restriction Pressure
E-8
F-11
68
69
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The

65 66 Ground - Panel
Ground - Rear Panel (Cab and Open Rops)
H-3
B-6
34
35
Switch - Disconnect
Switch - Hydraulic Filter Bypass Pressure
I-15
D-10
70
71
electromagnet can open or close the switch part of the relay.

Ground - Rear Panel (Open and Sun Canopy) B-9 36 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is

67 68 activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
71 Harness and Wire Symbols
55 Wire, Cable, or Harness
Assembly Identification: Includes
Harness Identification Letter(s):
(A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
L-C12
111-7898 3E-5179
35 Part Number: for Connector Plug 1
3E-5179
Part Number: for Connector Receptacle
2
Plug Receptacle
Pin or Socket Number
39 30 31 C0NN 7 1 Deutsch connector: Typical representation
5A
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123
CONN 9 2 sockets and the receptacle contains all pins.
Part Number

CONN 12 1 Sure-Seal connector: Typical representation Harness identification code:

325-AG135 PK-14
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

CAB / OPEN ROPS DRUM PROPEL MOTOR ENGINE ELECTRICAL SYSTEM MAIN HYDRAULIC ELECTRICAL SYSTEM

5 6 54 CONN 6 56
2 63
Connector Location - Volume 1
Schematic
Connector Number
Location
CONN 1 J-9
CONN 2 H-9
CONN 3 H-8
53 CONN 4 G-8
41 CONN 5 SERVICE TOOL F-8
CONN 6 D-9
CONN 7 C-9
CONN 8 B-7,B-10,I-3
CONN 9 A-5 , A-8
CONN 10 B-5,B-8,C-6
CONN 11 B-8
CONN 12 B-5 , B-8
CONN 13 B-5
CONN 14 F-3
69 The connectors shown in this chart are for harness to
harness connectors. Connectors that join a harness to a
component are generally located at or near the component.
See the Component Location Chart.

CONN 8 CONN 11 CONN 10

1 57

36

51

52
37

CONN 12 CONN 9

OPEN PLATFORM / SUN CANOPY ENGINE AIR INTAKE / FUEL TANK RH REAR VIEW ENGINE CONTROL MODULE RH REAR AXLE VIEW
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

183-M80 GY-16-GXL

B1
176-M82 PU-18-GXL
B2
200-M212 BK-18-GXL (21) IGNITION WAKEUP
D1 A1
331-M83 OR-18-GXL 7.5A 105-M79 RD-18-GXL (22) MACHINE
D1 B1 A1
101-E77 RD-6 403-E27 GN-18-GXL 7.5A 135-M1 BU-18-GXL
UENR6932-01 VOL 1 of 4

304-E76 WH-12
C1
86
+ 85
C1
D2
384-E79 BU-8 101-E77 RD-6 321-M28 BR-18-GXL (23) MACHINE ECM
C2 87 30 A2
403-E27 GN-18-GXL 304-E76 WH-12 15A 183-M80 GY-16-GXL (13) CONTROL
87a D2 B2 A2
384-E79 BU-8 10A 169-M77 PK-18-GXL
(46) REVERSE ALARM RELAY
J J
C2
109-E82 RD-4 2482841
B3
(11) 12V CONVERTER
B4 A3
384-E79 BU-8 15A 179-M81 BU-16-GXL (15) FRONT WORK LIGHTS
D3 D3 B3 A3
15A 115-M71 PK-16-GXL
C3
(48) STARTER RELAY C3 +
2313930 E-C28 86 85 (19) HORN
D4 A4
9X1054
(Dimensions: 56 inches x 35 inches)

(38) ALTERNATOR 6CYL 7.5A 114-M73 GN-18-GXL (26) REAR WORK LIGHTS
30 C4 87 30 D4 B4 A4
(40) GLOW PLUGS 6CYL 3218929 1 110-E74 RD-12-GXL 15A 116-M72 BR-16-GXL
W 86 5 314-E57 PU-18-GXL
87a C4

B+
SPARE RELAY
109-E82 RD-4 D+ 2 N762-E75 BR-18-GXL 2482841
304-E76 WH-12
85 4 304-E76 WH-12 183-M80 GY-16-GXL
B5 A5
(28) SHUTDOWN STATUS
B-
403-E27 GN-18-GXL
87 3 200-M202 BK-18-GXL
B6 D5 B5
10A
A5
176-M78 PU-16-GXL
87a 308-M102 YL-18-GXL
D5 C5
592-M98 BU-18-GXL (42) POWER POINT
200-M207 BK-18-GXL 1787539
C5
86
+ 85
A6
D6 D6 B6 A6
117-M85 YL-16-GXL
101-E77 RD-6 CONN 1 C6 87 30 C6

E-C23 F-C1 F-C2 87a M-C12

(55) DRUM SPEED (49) SWITCHED RELAY A7
1552272 3E3376 2305008 1552269

403-E27 GN-18-GXL
R807-E63 WH-18-GXL 3582399 2482841 SPARE FUSE1 (29) WIPERS

304-E76 WH-12
D7 B7 A7 USB (44) USB POWER

109-E82 RD-4
135-E78 BU-18-GXL J852-E64 OR-18-GXL 1 J852-F1 OR-18 1 +8V 7.5A 20A 118-M52 GY-14-GXL 592-M99 BU-18-GXL 1
(7) POWER JUNCTION BLOCK 200-BB1 BK-4 B7 C7 POWER
3547380
J853-E65 BK-18-GXL 2 J853-F2 BK-18 2 GROUND 200-M211 BK-18-GXL 2 ONLY
101-E77 RD-6 8C6358 B8
J718-E8 OR-18-GXL 3 J718-F3 OR-18 3 SIGNAL A (12) CAB

2304011
D7 A8
J719-E9 PU-18-GXL 4 J719-F4 PU-18 4 SIGNAL B 10A 122-M47 BU-18-GXL SPARE FUSE2 (20) HVAC

E-C26
101-EE1 RD-00-SGX D8 B8 A8
10A 20A 124-M53 GN-14-GXL
C7 C8
(31) ENGINE GND 2 D8
ALT GROUND (17) GRADE CONT M-C5

2
1
C8 A9
10A 174-M62 PK-16-GXL SPARE FUSE3 (18) GRADE CONT2 1673693
D9 B9 A9
15A 15A 111-M61 WH-16-GXL 122-M47 BU-18-GXL 1
C9
WIRING GP-SENSOR B9
608-M48 GN-16-GXL 2
200-JJ2 BK-00 101-JJ1 RD-00 2749872 (DRUM SPEED) B10
(25) PRODUCT LINK
A10
607-M49 PK-16-GXL 3
30A 384-E79 BU-8 101-E77 RD-6 7.5A 172-M57 GN-18-GXL SPARE FUSE4 603-M50 PK-18-GXL 4
1 2 50 D9 D10 B10 A10
(16) GLOW PLUG FUSE 304-E76 WH-12 20A 322-M51 GY-18-GXL 5

30 31
384-E79 BU-8
C9
110-M44 GN-10
C10
521-M25 YL-18-GXL 6 CONN 8
101-AA1 RD-00-SGX (43) JUMP START JJ-C1 200-MM1 STRAP-4GA 2749872 UNSWITCHED BUS 112-M43 PU-6 522-M26 WH-18-GXL 7 TO CONNECTOR Y-C1 SEE LOC B-7
D10
3509315 101-VV1 RD-00-SGX 30A 150-E80 RD-12-GXL 110-E44 RD-10 SHUTDOWN BUS 118-M52 GY-14-GXL 8 OR TO CONNECTOR YP-C1 SEE LOC B-10
C10
MOTOR (14) ECM FUSE 112-E43 PU-6 124-M53 GN-14-GXL 9
OR TO CONNECTOR P-C1 VOL2 LOC B-6
(39) STARTER 6CYL 200-E223 BK-18-GXL A513-M54 PK-16-GXL 10
I 3218968 (45) GLOW RLY
200-E223 BK-18-GXL
314-E57 PU-18-GXL
327-E17 PK-18-GXL
592-M55 BU-18-GXL
607-M56 PK-16-GXL
11
12
I
2731177

(8) BUS BAR 1

POS NEG POS NEG 327-E17 PK-18-GXL R807-E63 WH-18-GXL M-C1 172-M57 GN-18-GXL 13
200-JJ2 BK-00 3060282 M-C2 176-M58 PU-16-GXL 14
200-GG1 BK-00-SGX 200-WW1 BK-00-SGX 135-E78 BU-18-GXL 3767684 403-M27 GN-18-GXL 15 CONNECT TO OPERATOR STATION

2750553

2304011
(3) 12V BATTERY 1 (4) 12V BATTERY 2 200-CC1 BK-00-SGX 150-E80 RD-12-GXL 944-M59 OR-18-GXL 16

E-C25
3T5760 3T5760 (70) DISCONNECT SW N762-E75 BR-18-GXL 945-M60 BR-18-GXL 17
7N0718 111-M61 WH-16-GXL 18
(30) ENGINE GND 1 174-M62 PK-16-GXL 19

2
1
M10 1515-M104 YL-18-GXL 20
(32) FRAME GND 1 117-M85 YL-16-GXL 1516-M105 OR-18-GXL 21
8T3635 M12 110-M44 GN-10 176-M82 PU-18-GXL 1517-M106 WH-18-GXL 22
2749877 112-M43 PU-6 200-M202 BK-18-GXL 1518-M107 BU-18-GXL 23
50A 112-E43 PU-6 135-M1 BU-18-GXL 200-M212 BK-18-GXL 24
WIRING GP-BATTERY (27) SHUTDOWN FUSE 321-M28 BR-18-GXL 308-M102 YL-18-GXL 25
321-M28 BR-18-GXL 26
E-C4 2749872 105-M79 RD-18-GXL 331-M83 OR-18-GXL F711-M63 YL-18-GXL 27
1552269 30A 110-E44 RD-10 114-M73 GN-18-GXL F712-M64 GN-18-GXL 28
(1) BACKUP ALARM BK-18 1 321-E28 BR-18-GXL 321-E28 BR-18-GXL (24) MAIN POWER FUSE 110-E74 RD-12-GXL 115-M71 PK-16-GXL F711-M65 YL-18-GXL 29
3009546 BK-18 2 200-E222 BK-18-GXL 447-E29 PK-18-GXL 116-M72 BR-16-GXL 105-M79 RD-18-GXL F712-M66 GN-18-GXL 30
TO CONNECTOR MV-C1
42 Page,

H479-E30 OR-18-GXL 117-M85 YL-16-GXL 110-M44 GN-10 31

(47) SHUTDOWN RLY SEE VOL3 LOC E-3
3031256 169-M77 PK-18-GXL 114-M73 GN-18-GXL
E-C5 200-E205 BK-18-GXL 176-M78 PU-16-GXL 122-M47 BU-18-GXL
(51) FUEL LVL SENDER HI 1552269 200-E206 BK-18-GXL VARI VIBE OPTION 56 176-M82 PU-18-GXL 172-M57 GN-18-GXL
3235867 BK-18 1 447-E29 PK-18-GXL 200-E222 BK-18-GXL CONN 2 179-M81 BU-16-GXL 174-M62 PK-16-GXL
BK-18 2 200-E206 BK-18-GXL E-C27 NAME ID CLR 200-M202 BK-18-GXL 179-M81 BU-16-GXL
1552269 200-M212 BK-18-GXL
PANEL GP-BREAKER 450-E21 YL-18-GXL 1 VIBE TACH SIGNAL 450 YL-18 308-M102 YL-18-GXL 111-M61 WH-16-GXL
200-E207 BK-18-GXL 2 GROUND 200 BK-18 331-M83 OR-18-GXL 112-M43 PU-6 200-M200 BK-12-GXL
E-C6 115-M71 PK-16-GXL 200-M201 BK-12-GXL
1552269 355-3035
(52) FUEL LVL SENDER LO REF DIAGRAMS 111-M61 WH-16-GXL 116-M72 BR-16-GXL
3235867 BK-18 1 H479-E30 OR-18-GXL 135-E78 BU-18-GXL 118-M52 GY-14-GXL 118-M52 GY-14-GXL
BK-18 2 200-E205 BK-18-GXL 150-E80 RD-12-GXL 122-M47 BU-18-GXL 124-M53 GN-14-GXL
F711-E35 YL-18-GXL 200-E207 BK-18-GXL 124-M53 GN-14-GXL 135-M1 BU-18-GXL
F712-E34 GN-18-GXL J852-E64 OR-18-GXL 172-M57 GN-18-GXL 169-M77 PK-18-GXL (34) PANEL GND
F729-E23 GN-18-GXL J853-E65 BK-18-GXL 174-M62 PK-16-GXL 176-M78 PU-16-GXL 8T3635 M12
H F711-E35 YL-18-GXL
F711-E53 YL-18-GXL
J852-E6
J852-E64
OR-18-GXL
OR-18-GXL H
F711-E72 YL-18-GXL J853-E7 BK-18-GXL 450-E21 YL-18-GXL
J853-E65 BK-18-GXL J718-E8 OR-18-GXL 111-M61 WH-16-GXL
F712-E34 GN-18-GXL N762-E75 BR-18-GXL J719-E9 PU-18-GXL 118-M52 GY-14-GXL
F712-E54 GN-18-GXL 105-M79 RD-18-GXL 105-M68 RD-18-GXL 122-M47 BU-18-GXL
F712-E73 GN-18-GXL 110-E44 RD-10 CONN 3 105-M86 RD-18-GXL 124-M53 GN-14-GXL
135-E78 BU-18-GXL 112-E43 PU-6 E-C2 M-C3 172-M57 GN-18-GXL
150-E80 RD-12-GXL 327-E17 PK-18-GXL 9X0141 9X1343 114-M73 GN-18-GXL 174-M62 PK-16-GXL
F711-E53 YL-18-GXL N762-E75 BR-18-GXL 403-E27 GN-18-GXL 135-E1 BU-18-GXL 1 135-M1 BU-18-GXL 115-M71 PK-16-GXL
F711-E72 YL-18-GXL 450-E21 YL-18-GXL 2 116-M72 BR-16-GXL
F711-E35 YL-18-GXL 135-E1 BU-18-GXL R807-E63 WH-18-GXL J718-E8 OR-18-GXL 3 110-M44 GN-10
135-E60 BU-18-GXL 321-E28 BR-18-GXL J719-E9 PU-18-GXL J711-E4 PK-18-GXL 4 J711-M4 PK-18-GXL 112-M43 PU-6 117-M85 YL-16-GXL 117-M69 YL-18-GXL
F712-E54 GN-18-GXL 135-E71 BU-18-GXL 447-E29 PK-18-GXL J712-E5 BR-18-GXL 5 J712-M5 BR-18-GXL 135-M1 BU-18-GXL 117-M94 YL-18-GXL
F712-E73 GN-18-GXL 135-E78 BU-18-GXL F711-E35 YL-18-GXL 110-E44 RD-10 J852-E6 OR-18-GXL 6 J852-M6 OR-18-GXL 321-M28 BR-18-GXL 117-M97 YL-18-GXL
F712-E34 GN-18-GXL F712-E34 GN-18-GXL 112-E43 PU-6 J853-E7 BK-18-GXL 7 J853-M7 BK-18-GXL
F729-E23 GN-18-GXL 321-E28 BR-18-GXL 135-E1 BU-18-GXL 110-E44 RD-10 J718-E8 OR-18-GXL 8 J718-M8 OR-18-GXL 169-M77 PK-18-GXL 403-M27 GN-18-GXL
J852-E6 OR-18-GXL H479-E30 OR-18-GXL 447-E29 PK-18-GXL 307-E36 OR-18-GXL 112-E43 PU-6 J719-E9 PU-18-GXL 9 J719-M9 PU-18-GXL 403-M27 GN-18-GXL 176-M78 PU-16-GXL F711-M63 YL-18-GXL
J852-E64 OR-18-GXL J852-E6 OR-18-GXL 465-E38 OR-18-GXL 321-E28 BR-18-GXL 135-E1 BU-18-GXL K913-E10 GN-18-GXL 10 K913-M10 GN-18-GXL 450-M21 YL-18-GXL 176-M82 PU-18-GXL F712-M64 GN-18-GXL
J852-E66 OR-18-GXL J852-E64 OR-18-GXL 521-E25 YL-18-GXL 327-E17 PK-18-GXL 307-E36 OR-18-GXL K914-E11 YL-18-GXL 11 K914-M11 YL-18-GXL 465-M38 OR-18-GXL 179-M81 BU-16-GXL
J853-E7 BK-18-GXL 522-E26 WH-18-GXL 403-E27 GN-18-GXL 321-E28 BR-18-GXL K725-E12 GN-18-GXL 12 K725-M12 GN-18-GXL 751-M39 GN-18-GXL 200-M202 BK-18-GXL 403-M27 GN-18-GXL
J853-E65 BK-18-GXL 751-E39 GN-18-GXL 447-E29 PK-18-GXL 327-E17 PK-18-GXL K726-E13 BU-18-GXL 13 K726-M13 BU-18-GXL F711-M35 YL-18-GXL 200-M212 BK-18-GXL F711-M63 YL-18-GXL
J853-E7 BK-18-GXL F711-E35 YL-18-GXL 465-E38 OR-18-GXL 403-E27 GN-18-GXL 14 F712-M34 GN-18-GXL 308-M102 YL-18-GXL F712-M64 GN-18-GXL
J853-E65 BK-18-GXL 465-E38 OR-18-GXL F712-E34 GN-18-GXL 521-E25 YL-18-GXL 447-E29 PK-18-GXL 15 K918-M19 GN-18-GXL 331-M83 OR-18-GXL 176-M58 PU-16-GXL
J853-E67 BK-18-GXL 521-E25 YL-18-GXL F729-E23 GN-18-GXL 522-E26 WH-18-GXL 465-E38 OR-18-GXL 16 K919-M20 YL-18-GXL 200-M200 BK-12-GXL
135-E1 BU-18-GXL 522-E26 WH-18-GXL H479-E30 OR-18-GXL 751-E39 GN-18-GXL 521-E25 YL-18-GXL 327-E17 PK-18-GXL 17 327-M17 PK-18-GXL 105-M68 RD-18-GXL
135-E71 BU-18-GXL 751-E39 GN-18-GXL J852-E6 OR-18-GXL 944-E32 OR-18-GXL 522-E26 WH-18-GXL 777-E18 PU-18-GXL 18 777-M18 PU-18-GXL 105-M86 RD-18-GXL 200-M208 BK-16-GXL 200-M201 BK-12-GXL
200-E201 BK-16-GXL J852-E64 OR-18-GXL 945-E33 BR-18-GXL 751-E39 GN-18-GXL K918-E19 GN-18-GXL 19 K918-M19 GN-18-GXL 327-M17 PK-18-GXL 114-M73 GN-18-GXL 200-M209 BK-16-GXL 200-M207 BK-18-GXL
N762-E69 BR-18-GXL 200-E202 BK-18-GXL J853-E7 BK-18-GXL F711-E35 YL-18-GXL 777-E18 PU-18-GXL K919-E20 YL-18-GXL 20 K919-M20 YL-18-GXL 447-M29 PK-18-GXL 115-M71 PK-16-GXL 200-M210 BK-18-GXL 200-M211 BK-18-GXL
N762-E55 BR-18-GXL 200-E203 BK-18-GXL 135-E1 BU-18-GXL J853-E65 BK-18-GXL F712-E34 GN-18-GXL 944-E32 OR-18-GXL 450-E21 YL-18-GXL 21 450-M21 YL-18-GXL 777-M18 PU-18-GXL 116-M72 BR-16-GXL
N762-E75 BR-18-GXL 200-E204 BK-16-GXL 200-E207 BK-18-GXL F715-E22 PU-18-GXL 945-E33 BR-18-GXL F715-E22 PU-18-GXL 22 F715-M22 PU-18-GXL 944-M32 OR-18-GXL 403-M27 GN-18-GXL 117-M69 YL-18-GXL 322-M51 GY-18-GXL
200-E207 BK-18-GXL 465-E38 OR-18-GXL 200-E223 BK-18-GXL 200-E223 BK-18-GXL F716-E40 WH-18-GXL F711-E35 YL-18-GXL F729-E23 GN-18-GXL 23 F729-M23 GN-18-GXL 945-M33 BR-18-GXL 450-M21 YL-18-GXL 117-M94 YL-18-GXL 521-M25 YL-18-GXL
200-E209 BK-18-GXL 521-E25 YL-18-GXL 307-E36 OR-18-GXL 314-E57 PU-18-GXL F729-E23 GN-18-GXL F712-E34 GN-18-GXL 24 H479-M30 OR-18-GXL 465-M38 OR-18-GXL 117-M97 YL-18-GXL 522-M26 WH-18-GXL
200-E221 BK-18-GXL 522-E26 WH-18-GXL 314-E57 PU-18-GXL R807-E63 WH-18-GXL J852-E6 OR-18-GXL F715-E22 PU-18-GXL 521-E25 YL-18-GXL 25 521-M25 YL-18-GXL J711-M4 PK-18-GXL 751-M39 GN-18-GXL 169-M77 PK-18-GXL
J843-E58 BK-18-GXL F711-E72 YL-18-GXL 751-E39 GN-18-GXL 944-E32 OR-18-GXL J853-E7 BK-18-GXL F716-E40 WH-18-GXL 522-E26 WH-18-GXL 26 522-M26 WH-18-GXL J712-M5 BR-18-GXL 176-M78 PU-16-GXL 592-M98 BU-18-GXL
J843-E68 BK-18-GXL F712-E73 GN-18-GXL 945-E33 BR-18-GXL 135-E1 BU-18-GXL H479-E30 OR-18-GXL F729-E23 GN-18-GXL 403-E27 GN-18-GXL 27 403-M27 GN-18-GXL J718-M8 OR-18-GXL F711-M35 YL-18-GXL F711-M91 YL-18-GXL 176-M82 PU-18-GXL 592-M93 BU-16-GXL 592-M99 BU-18-GXL
J843-E81 BK-18-GXL F729-E70 GN-18-GXL F715-E22 PU-18-GXL 200-E207 BK-18-GXL J711-E4 PK-18-GXL 321-E28 BR-18-GXL 28 321-M28 BR-18-GXL J719-M9 PU-18-GXL F711-M100 YL-18-GXL 179-M81 BU-16-GXL 592-M55 BU-18-GXL
G J843-E68 BK-18-GXL
J843-E81 BK-18-GXL
F716-E40 WH-18-GXL
R807-E63 WH-18-GXL
307-E36 OR-18-GXL
944-E32 OR-18-GXL 777-E18 PU-18-GXL
J712-E5 BR-18-GXL
J852-E6 OR-18-GXL
447-E29 PK-18-GXL
H479-E30 OR-18-GXL
29
30
447-M29 PK-18-GXL
H479-M30 OR-18-GXL
J852-M6 OR-18-GXL
J853-M7 BK-18-GXL F711-M63 YL-18-GXL
200-M202 BK-18-GXL
200-M212 BK-18-GXL 603-M50 PK-18-GXL
G
J852-E66 OR-18-GXL 945-E33 BR-18-GXL J711-E4 PK-18-GXL J853-E7 BK-18-GXL 31 K725-M12 GN-18-GXL F711-M95 YL-18-GXL 308-M102 YL-18-GXL
F729-E23 GN-18-GXL J853-E67 BK-18-GXL F715-E22 PU-18-GXL J712-E5 BR-18-GXL H479-E30 OR-18-GXL 944-E32 OR-18-GXL 32 944-M32 OR-18-GXL K726-M13 BU-18-GXL F711-M91 YL-18-GXL 607-M70 PK-16-GXL 607-M49 PK-16-GXL
F729-E59 GN-18-GXL N762-E69 BR-18-GXL 135-E1 BU-18-GXL F716-E40 WH-18-GXL K725-E12 GN-18-GXL K725-E12 GN-18-GXL 945-E33 BR-18-GXL 33 945-M33 BR-18-GXL K913-M10 GN-18-GXL F712-M34 GN-18-GXL F712-M89 GN-18-GXL F711-M95 YL-18-GXL 607-M56 PK-16-GXL
F729-E70 GN-18-GXL 135-E71 BU-18-GXL K726-E13 BU-18-GXL K726-E13 BU-18-GXL F712-E34 GN-18-GXL 34 F712-M34 GN-18-GXL K914-M11 YL-18-GXL F712-M101 GN-18-GXL F712-M89 GN-18-GXL
200-E201 BK-16-GXL K913-E10 GN-18-GXL K913-E10 GN-18-GXL F711-E35 YL-18-GXL 35 F711-M35 YL-18-GXL F712-M96 GN-18-GXL 608-M48 GN-16-GXL
200-E202 BK-18-GXL K914-E11 YL-18-GXL K914-E11 YL-18-GXL 307-E36 OR-18-GXL 36 307-M36 OR-18-GXL F712-M96 GN-18-GXL 944-M59 OR-18-GXL
200-E203 BK-18-GXL K918-E19 GN-18-GXL K918-E19 GN-18-GXL 37 307-M36 OR-18-GXL F712-M64 GN-18-GXL 945-M60 BR-18-GXL
150-E80 RD-12-GXL 200-E204 BK-16-GXL K919-E20 YL-18-GXL K919-E20 YL-18-GXL 465-E38 OR-18-GXL 38 465-M38 OR-18-GXL 521-M25 YL-18-GXL 1515-M104 YL-18-GXL
150-E49 RD-18-GXL 200-E207 BK-18-GXL 751-E39 GN-18-GXL 39 751-M39 GN-18-GXL 522-M26 WH-18-GXL K918-M19 GN-18-GXL 1516-M105 OR-18-GXL
150-E50 RD-18-GXL F716-E40 WH-18-GXL 40 F716-M40 WH-18-GXL F715-M22 PU-18-GXL K919-M20 YL-18-GXL 331-M83 OR-18-GXL 1517-M106 WH-18-GXL
150-E51 RD-18-GXL 200-E209 BK-18-GXL 200-E223 BK-18-GXL F716-M40 WH-18-GXL 450-M21 YL-18-GXL 1518-M107 BU-18-GXL
150-E52 RD-18-GXL 135-E60 BU-18-GXL 200-E224 BK-18-GXL F729-M23 GN-18-GXL 465-M38 OR-18-GXL A513-M54 PK-16-GXL
150-E49 RD-18-GXL 200-E225 BK-18-GXL CONN 4 751-M39 GN-18-GXL F711-M65 YL-18-GXL
150-E50 RD-18-GXL E-C3 M-C4 K918-M19 GN-18-GXL F712-M66 GN-18-GXL
150-E51 RD-18-GXL 200-E221 BK-18-GXL 2039000 2038977 K919-M20 YL-18-GXL
150-E52 RD-18-GXL F711-E72 YL-18-GXL 1
200-E210 BK-18-GXL F712-E73 GN-18-GXL 2 TO CONNECTOR A-C8
200-E211 BK-18-GXL F729-E70 GN-18-GXL
(53) AMBIENT AIR TEMP
112-E43 PU-6 3 112-M43 PU-6 SEE VOL2 LOC I-14
200-E212 BK-18-GXL J843-E68 BK-18-GXL 110-E44 RD-10 4 110-M44 GN-10
E-C7 2566453
200-E213 BK-18-GXL J843-E81 BK-18-GXL
2304011
5 CONN 14 SIDE CONSOLE 56 CONN
200-E200 BK-12-GXL 200-E210 BK-18-GXL 200-E214 BK-18-GXL J852-E66 OR-18-GXL 6
200-E211 BK-18-GXL F711-E53 YL-18-GXL J853-E67 BK-18-GXL C829-E47 GN-18-GXL 1 327-M17 PK-18-GXL 1515-M104 YL-18-GXL M-C6 NAME ID CLR
F712-E54 GN-18-GXL T 1K 447-M29 PK-18-GXL 2253861
200-E212 BK-18-GXL N762-E69 BR-18-GXL J843-E68 BK-18-GXL 2 1516-M105 OR-18-GXL
200-E213 BK-18-GXL F729-E59 GN-18-GXL 777-M18 PU-18-GXL 1517-M106 WH-18-GXL 308-M67 YL-18-GXL 1 RUN 308 YL
200-E214 BK-18-GXL J843-E58 BK-18-GXL 944-M32 OR-18-GXL 1518-M107 BU-18-GXL 2 . . .
N762-E55 BR-18-GXL M-C7 105-M86 RD-18-GXL 945-M33 BR-18-GXL F712-M66 GN-18-GXL 307-M36 OR-18-GXL 3 START 307 OR
200-E208 BK-18-GXL 200-E221 BK-18-GXL 4518019 200-M204 BK-18-GXL H479-M30 OR-18-GXL F711-M65 YL-18-GXL 105-M68 RD-18-GXL 105-M68 RD-18-GXL 4 UNSWITCHED B+ 105 RD
200-E222 BK-18-GXL E-C8 A 200-M204 BK-18-GXL J711-M4 PK-18-GXL 521-M25 YL-18-GXL 114-M73 GN-18-GXL 603-M50 PK-18-GXL 5 BEACON 603 PK
(63) FAN SOL
B 105-M86 RD-18-GXL 944-M59 OR-18-GXL J712-M5 BR-18-GXL 522-M26 WH-18-GXL 115-M71 PK-16-GXL 117-M69 YL-18-GXL 6 BEACON POWER 117 YL
1552269 2112095 CONN 5 C F711-M91 YL-18-GXL 944-M32 OR-18-GXL J718-M8 OR-18-GXL 608-M48 GN-16-GXL 116-M72 BR-16-GXL 607-M70 PK-16-GXL 7 FRONT WORK LIGHTS 607 PK
C826-E56 GN-18-GXL 1
200-E201 BK-16-GXL D F712-M89 GN-18-GXL 944-M87 OR-18-GXL J719-M9 PU-18-GXL 607-M70 PK-16-GXL 117-M69 YL-18-GXL 608-M48 GN-16-GXL 8 REAR WORK LIGHTS 608 GN
N762-E69 BR-18-GXL 2
200-E202 BK-18-GXL E 945-M88 BR-18-GXL J852-M6 OR-18-GXL 944-M59 OR-18-GXL 169-M77 PK-18-GXL 115-M71 PK-16-GXL 9 FR WORK LTS PWR 115 PK
200-E203 BK-18-GXL SERVICE F 945-M60 BR-18-GXL J853-M7 BK-18-GXL 945-M60 BR-18-GXL 200-M208 BK-16-GXL 116-M72 BR-16-GXL 10 RR WORK LTS PWR 116 BR
200-E204 BK-16-GXL G 945-M33 BR-18-GXL K725-M12 GN-18-GXL 592-M93 BU-16-GXL 307-M36 OR-18-GXL F716-M40 WH-18-GXL 11 CAN (SHIELD) 234 BK
TOOL
F 200-E205
200-E206
BK-18-GXL
BK-18-GXL
H
J
944-M87 OR-18-GXL
945-M88 BR-18-GXL 1515-M104 YL-18-GXL
K726-M13 BU-18-GXL
K913-M10 GN-18-GXL
603-M50 PK-18-GXL
200-M200 BK-12-GXL
308-M67 YL-18-GXL
322-M51 GY-18-GXL
12
13
.
.
.
.
.
. F
200-E207 BK-18-GXL K 1516-M105 OR-18-GXL K914-M11 YL-18-GXL 200-M209 BK-16-GXL 603-M50 PK-18-GXL 14 . . .
200-E209 BK-18-GXL E-C9 (69) AIR FILTER RES SW L 1516-M105 OR-18-GXL 1517-M106 WH-18-GXL A513-M54 PK-16-GXL 607-M70 PK-16-GXL 15 . . .
2304011 3630591 M 1515-M104 YL-18-GXL 1518-M107 BU-18-GXL 200-M208 BK-16-GXL 608-M48 GN-16-GXL 16 ALT D+ TERM 309 GY
N 1518-M107 BU-18-GXL F711-M91 YL-18-GXL 331-M83 OR-18-GXL 176-M58 PU-16-GXL F711-M65 YL-18-GXL 200-M208 BK-16-GXL 17 MAIN CHASSIS 200 BK
430-E62 BU-18-GXL 1
P 1517-M106 WH-18-GXL F712-M89 GN-18-GXL 450-M21 YL-18-GXL 322-M51 GY-18-GXL F712-M66 GN-18-GXL 18 . . .
F729-E70 GN-18-GXL 2
465-M38 OR-18-GXL 200-M210 BK-18-GXL F715-M22 PU-18-GXL 114-M73 GN-18-GXL 19 HORN POWER 114 GN
E-C15 (59) AXLE SOL B 751-M39 GN-18-GXL F716-M40 WH-18-GXL 322-M51 GY-18-GXL 20 HORN 322 GY
135-E60 BU-18-GXL 1552269 3165999 K918-M19 GN-18-GXL F729-M23 GN-18-GXL F712-M66 GN-18-GXL 21 CAN (-) F712 GN
150-E49 RD-18-GXL K725-E12 GN-18-GXL 1 K919-M20 YL-18-GXL 105-M68 RD-18-GXL U734-M76 GN-18-GXL F711-M65 YL-18-GXL 22 CAN (+) F711 YL
150-E50 RD-18-GXL 200-E218 BK-18-GXL 2 105-M86 RD-18-GXL U735-M75 GY-18-GXL 176-M74 PU-18-GXL 23 BACKLIGHT POWER 176 PU
150-E51 RD-18-GXL E-C10 (57) WIF SENSOR 114-M73 GN-18-GXL F715-M22 PU-18-GXL 24 E-STOP N/O F715 PU
150-E52 RD-18-GXL 2304013 4395039 E-C16 (58) AXLE SOL A 307-M36 OR-18-GXL 115-M71 PK-16-GXL U735-M75 GY-18-GXL 25 PARKING BRAKE N/C U735 GY
200-E210 BK-18-GXL G976-E61 BU-18-GXL 1 SIGNAL 1552269 3165999 308-M103 YL-18-GXL 116-M72 BR-16-GXL U734-M76 GN-18-GXL 26 PARKING BRAKE N/O U734 GN
200-E208 BK-18-GXL 200-E211 BK-18-GXL 135-E71 BU-18-GXL 2 GROUND K726-E13 BU-18-GXL 1 (10) 24 TO 12 CONVERTOR M-C8 F715-M22 PU-18-GXL 117-M69 YL-18-GXL 176-M74 PU-18-GXL 27 REAR FUEL SENDER 447 PK
200-E209 BK-18-GXL 200-E212 BK-18-GXL 200-E221 BK-18-GXL 3 POWER 200-E217 BK-18-GXL 2 3407161 1552273 F716-M40 WH-18-GXL 117-M94 YL-18-GXL 28 FRONT FUEL SENDER H479 OR
200-E213 BK-18-GXL +24V BATTERY IN 1 179-M81 BU-16-GXL F729-M23 GN-18-GXL 117-M97 YL-18-GXL 176-M74 PU-18-GXL F729-M23 GN-18-GXL 29 SENSOR RETURN F729 GN
200-E205 BK-18-GXL 200-E214 BK-18-GXL E-C17 (61) DRUM SOL A +24V SWITCHED IN 2 176-M92 PU-16-GXL U734-M76 GN-18-GXL 169-M77 PK-18-GXL 105-M86 RD-18-GXL 169-M77 PK-18-GXL 30 DISPLAY/HORN POWER 169 PK
200-E206 BK-18-GXL F711-E53 YL-18-GXL 1552269 3165999 GROUND 3 200-M206 BK-16-GXL U735-M75 GY-18-GXL 176-M78 PU-16-GXL 117-M94 YL-18-GXL 31 . . .
200-E207 BK-18-GXL F712-E54 GN-18-GXL K913-E10 GN-18-GXL 1 +12V MEMORY 4 A513-M54 PK-16-GXL 176-M82 PU-18-GXL 117-M97 YL-18-GXL
377-2196
F729-E59 GN-18-GXL 200-E216 BK-18-GXL 2 +12V SWITCHED OUT 5 592-M93 BU-16-GXL 179-M81 BU-16-GXL 176-M58 PU-16-GXL REF DIAGRAMS
200-E200 BK-12-GXL J843-E58 BK-18-GXL GROUND 6 200-M205 BK-16-GXL 200-M202 BK-18-GXL 176-M78 PU-16-GXL
200-E201 BK-16-GXL N762-E55 BR-18-GXL E-C18 (62) DRUM SOL B 105-M86 RD-18-GXL 200-M212 BK-18-GXL 176-M82 PU-18-GXL
200-E202 BK-18-GXL 1552269 3165999 117-M94 YL-18-GXL F711-M91 YL-18-GXL 179-M81 BU-16-GXL
200-E203 BK-18-GXL K914-E11 YL-18-GXL 1 (9) MACHINE ECM 117-M97 YL-18-GXL F711-M95 YL-18-GXL 200-M200 BK-12-GXL
200-E204 BK-16-GXL 200-E215 BK-18-GXL 2 4872836 M-C11 179-M81 BU-16-GXL F712-M89 GN-18-GXL 200-M202 BK-18-GXL
(33) FRAME GND 2 2538112 F712-M96 GN-18-GXL 200-M209 BK-16-GXL
(37) ENGINE CONTROL 8T3635 M12 307-E36 OR-18-GXL E-C19 (60) BRAKE REL SOL POWER GROUND - 1 200-M209 BK-16-GXL 176-M92 PU-16-GXL 200-M210 BK-18-GXL
XXXXXXX 314-E57 PU-18-GXL 1552269 3829247 POWER SUPPLY + 2 117-M94 YL-18-GXL 176-M58 PU-16-GXL 200-M212 BK-18-GXL
E-C1 404-E48 YL-18-GXL 777-E18 PU-18-GXL 1 CAN 0 + 3 F711-M95 YL-18-GXL 176-M74 PU-18-GXL 308-M102 YL-18-GXL 308-M67 YL-18-GXL 521-M25 YL-18-GXL
2451042 430-E62 BU-18-GXL 200-E203 BK-18-GXL 2 CAN 0 - 4 F712-M96 GN-18-GXL 522-M26 WH-18-GXL
1 . BATTERY (-) 1 200-E210 BK-18-GXL 944-E32 OR-18-GXL 777-E18 PU-18-GXL . 5 176-M90 PU-16-GXL 308-M103 YL-18-GXL 592-M93 BU-16-GXL
2 . BATTERY (-) 2 200-E211 BK-18-GXL 945-E33 BR-18-GXL J711-E4 PK-18-GXL . 6 944-M59 OR-18-GXL
3 . BATTERY (-) 3 200-E212 BK-18-GXL C826-E56 GN-18-GXL J712-E5 BR-18-GXL . 7 176-M82 PU-18-GXL 945-M60 BR-18-GXL
4 . AMBIENT AIR TEMP SENSOR 4 C829-E47 GN-18-GXL C829-E47 GN-18-GXL K725-E12 GN-18-GXL (65) VIBE SOL A STD 8 V DC SENSOR POWER + 8 J852-M6 OR-18-GXL 176-M78 PU-16-GXL 307-M36 OR-18-GXL 1515-M104 YL-18-GXL
5 . AUX 1 TEMP SENSOR 5 404-E48 YL-18-GXL F715-E22 PU-18-GXL K726-E13 BU-18-GXL 3215984 SENSOR POWER GROUND - 9 J853-M7 BK-18-GXL F715-M22 PU-18-GXL 1516-M105 OR-18-GXL
E 6
7
.
. BATTERY (+)
6
7 150-E49 RD-18-GXL
F716-E40 WH-18-GXL
G976-E61 BU-18-GXL
K913-E10
K914-E11
GN-18-GXL
YL-18-GXL
KEY SW ON 10
POWER SUPPLY + 11
308-M103 YL-18-GXL
117-M97 YL-18-GXL
200-M2 BK-18-GXL
200-M3 BK-18-GXL
200-M210 BK-18-GXL F716-M40 WH-18-GXL
F729-M23 GN-18-GXL
1517-M106 WH-18-GXL
1518-M107 BU-18-GXL
E
8 . BATTERY (+) 8 150-E50 RD-18-GXL R807-E63 WH-18-GXL E-C11 (50) CAN 1 TERM1 K918-E19 GN-18-GXL POWER GROUND - 12 200-M2 BK-18-GXL U734-M76 GN-18-GXL A513-M54 PK-16-GXL
1740502 1342540
9 . BATTERY (-) 9 200-E213 BK-18-GXL K919-E20 YL-18-GXL (67) VIBE SOL B STD SHUTDOWN RELAY 13 327-M17 PK-18-GXL 200-M205 BK-16-GXL U735-M75 GY-18-GXL F711-M91 YL-18-GXL
10 . BATTERY (-) 10 200-E214 BK-18-GXL F711-E72 YL-18-GXL A 3215984 . 14 200-M206 BK-16-GXL F711-M95 YL-18-GXL
11 . 11 F712-E73 GN-18-GXL B 200-E215 BK-18-GXL E-C20 . 15 200-M204 BK-18-GXL F712-M89 GN-18-GXL
12 . 12 C 200-E201 BK-16-GXL 200-E216 BK-18-GXL 1552269 . 16 F712-M96 GN-18-GXL
13 . 13 K918-E19 GN-18-GXL 1 . 17
14 . 14 200-E217 BK-18-GXL 200-E219 BK-18-GXL 2 . 18 200-M203 BK-12-GXL
15 . BATTERY (+) 15 150-E51 RD-18-GXL 200-E202 BK-18-GXL 200-E218 BK-18-GXL FUEL LEVEL SENSOR 1 19 447-M29 PK-18-GXL 200-M202 BK-18-GXL
16 . BATTERY (+) 16 150-E52 RD-18-GXL E-C21 FUEL LEVEL SENSOR 2 20 H479-M30 OR-18-GXL 200-M212 BK-18-GXL
17 . 17 200-E203 BK-18-GXL 1552269 FRONT PROPEL PUMP FWD 21 K913-M10 GN-18-GXL 200-M200 BK-12-GXL
18 . FAULT ALARM 18 200-E201 BK-16-GXL K919-E20 YL-18-GXL 1 (66) VIBE SOL A VARI FRONT PROPEL PUMP REV 22 K914-M11 YL-18-GXL
19 . HIGH COOLANT TEMP 19 200-E202 BK-18-GXL 200-E219 BK-18-GXL 200-E220 BK-18-GXL 2 3165999 BRAKE RELEASE VALVE 23 777-M18 PU-18-GXL 200-M209 BK-16-GXL
20 . CAN (+) 20 F711-E53 YL-18-GXL 200-E203 BK-18-GXL 200-E220 BK-18-GXL CAN 1 + 24 521-M25 YL-18-GXL
21 . CAN (-) 21 F712-E54 GN-18-GXL 200-E204 BK-16-GXL CAN 1 - 25 522-M26 WH-18-GXL
22 . CAN A SHIELD 22 J852-E66 OR-18-GXL 200-E204 BK-16-GXL . 26 592-M93 BU-16-GXL
23 . CDL (+) 23 944-E32 OR-18-GXL J853-E67 BK-18-GXL (68) VIBE SOL B VARI . 27 944-M59 OR-18-GXL
24 . CDL (-) 24 945-E33 BR-18-GXL J852-E66 OR-18-GXL 3165999 . 28 945-M60 BR-18-GXL
25 . STARTER RELAY RTN 25 N762-E55 BR-18-GXL J853-E67 BK-18-GXL VIBE SPEED SENSOR 29 450-M21 YL-18-GXL 1515-M104 YL-18-GXL
26 . 26 . 30 1516-M105 OR-18-GXL
27 . 27 VIBE MA FWD 31 K918-M19 GN-18-GXL 1517-M106 WH-18-GXL
28 . 28 . 32 751-M39 GN-18-GXL 1518-M107 BU-18-GXL
29 . FAN SOLENOID (+) 29 C826-E56 GN-18-GXL VIBE MB REV 33 K919-M20 YL-18-GXL A513-M54 PK-16-GXL
30 . 30 (5) FERRITE BEAD (6) FERRITE BEAD ID 1 34 200-M3 BK-18-GXL F711-M91 YL-18-GXL
31 . 31 370-2583 370-2583 ID 2 35 F711-M95 YL-18-GXL
32 . STARTER RELAY 32 314-E57 PU-18-GXL
CONN 6 . 36 F712-M89 GN-18-GXL
33 . WATER IN FUEL RTN 33 E-C22 EA-C1 EA-C2 (54) AXLE SPEED PARKING BRAKE (N/C) 37 U735-M75 GY-18-GXL F712-M96 GN-18-GXL
34 . 34 J843-E58 BK-18-GXL 2305008 2305009 2305008 3582398 PARKING BRAKE (N/O) 38 U734-M76 GN-18-GXL
35 . THROTTLE SWITCH RETURN 35 F729-E59 GN-18-GXL J852-E66 OR-18-GXL 1 J852-EA1 OR-18-GXL 1 +8V FRONT PROPEL SPEED SENSOR 1 39 J718-M8 OR-18-GXL
36 . 36 J853-E67 BK-18-GXL 2 J853-EA2 BK-18-GXL 2 GROUND FRONT PROPEL SPEED SENSOR 2 40 J719-M9 PU-18-GXL
(56) HYD TMP
37 . KEY SWITCH START 37 307-E36 OR-18-GXL J711-E4 PK-18-GXL 3 J711-EA3 PK-18-GXL 3 SIGNAL A BACK UP ALARM RELAY 41 331-M83 OR-18-GXL
E-C12 1457028
38 . USER DEFINED SHUTDOWN (N/O) 38 F715-E22 PU-18-GXL J712-E5 BR-18-GXL 4 J712-EA4 BR-18-GXL 4 SIGNAL B REAR PROPEL PUMP FWD 42 K725-M12 GN-18-GXL
39 . USER DEFINED SHUTDOWN (N/C) 39 F716-E40 WH-18-GXL 1552269 REAR PROPEL PUMP REV 43 K726-M13 BU-18-GXL
40 . IGNITION SWITCH INPUT 40 135-E60 BU-18-GXL 404-E48 YL-18-GXL 1 BK-18
1K SPEED SENSOR ID 3 44
41 J843-E81 BK-18-GXL 2 BK-18 T
41 . +5V SENSOR SUPPLY JUMPER ID 4 45

D 42
43
.
.
+5V SENSOR SUPPLY
+8V THROTTLE SUPPLY
42
43
REF DIAGRAM 435-8065 . 46
HYD FILTER BYPASS SW 47 465-M38 OR-18-GXL D
44 . WATER IN FUEL 44 G976-E61 BU-18-GXL E-C13 (64) VALVE SHIFT SOL . 48
45 . AIR FILTER RESTRICTION SW (N/C) 45 430-E62 BU-18-GXL 1552269 2762609 REAR PROPEL SPEED SENSOR 1 49 J711-M4 PK-18-GXL
46 . PARK BRAKE SW (54) 46 751-E39 GN-18-GXL 1 REAR PROPEL SPEED SENSOR 2 50 J712-M5 BR-18-GXL
47 . 47 200-E224 BK-18-GXL 2
48 . HYDRAULIC FILTER BYPASS 48
PANEL GP-ELECTRICAL
49 . MPTS 1 (54) 49 (56B/68B/74B/78B)
50 . MPTS 2 (54) 50
51 . MPTS 3 (54) 51
52 . MPTS 4 (54) 52
53 . 53
54 . 54 E-C14 (71) HYD FILTER BYPASS SW
3496097 (2) ANTENNA AS
55 . 55 1552269
443-8462
56 . 56 200-E224 BK-18-GXL 465-E38 OR-18-GXL 1 BK-18
GPS SAT CELL
57 . START AID CONTROL 57 R807-E63 WH-18-GXL 200-E225 BK-18-GXL 200-E225 BK-18-GXL 2 BK-18
58 . CHECK ENGINE LAMP 58 465-E38 OR-18-GXL
59 . HIGH HYD OIL TEMP LAMP 59 751-E39 GN-18-GXL TO CONNECTOR H-C1 (41) RADIO GP - COMMUNICATION
60 . LOW OIL PRESSURE LAMP 60 SEE VOL 2 B-15
PL 631 (SAT) PL 641 (CELL)
61 . ACTION LAMP 61 442-7199 440-2105
62 . (FILTER BYPASS) LOW HYD OIL PRESS LAMP 62 AC COMPRESSOR CONN 56
63 . (WATER IN FUEL) HIGH INLET AIR TEMP 63 CONN 7 “OR”
64 . WAIT TO START LAMP 64 E-C24 NAME ID CLR TO CONNECTOR Y-C1 SEE LOC B-7
CABLE AS
1552269 OR TO CONNECTOR YP-C1 SEE LOC B-10 354-0703 SATELLITE ANTENNA OR CELLUAR
521-E25 YL-18-GXL 521-E25 YL-18-GXL 1 COMP ON 521 YL-18
522-E26 WH-18-GXL 522-E26 WH-18-GXL 2 COMP RTN 522 WH-18 PRODUCT LINK OPTION CONN 10 GPS ANTENNA

355-3031 NAME ID CLR YJ-C1 YJ-C2

REF DIAGRAMS
1907612 1552253

WIRING GP-VEHICLE PROD LINK POWER (+) 172 RD 1 172-YJ1 RD-18-GXL 1 BATTERY
(117 & 129 KW) GROUND 200 BK 2 200-YJ2 BK-18-GXL 2 GROUND
SW POWER (+) 176 PU 3 176-YJ3 PU-18-GXL 3 KEYSWITCH CABLE/ WIRE ASSEMBLY LIST
(56B/68B/74B/78B)
- NOT USED 4 4 +POWER BU
ROUTING PATH
ETHERNET TX+ 1515 YL 5 1515-YJ4 YL-18-GXL 5 ENET TX+ IDENT PART NO. GAGE
ENET TX-
END #1 LOC END #2 SH/LOC
ETHERNET TX- 1516 OR 6 1516-YJ5 OR-18-GXL 6
ETHERNET RX+ 1517 WH 7 1517-YJ6 WH-18-GXL 7 ENET RX+ AA 354-0263 00 BATTERY 1 (-) I16 BATTERY 2 (+) I16
ETHERNET RX- 1518 BU 8 1518-YJ7 BU-18-GXL 8 ENET RX- BB 456-0682 4 ALTERNATOR (-) J13 ENGINE GROUND I13
C -
-
NOT
NOT
USED
USED
9
10
9
10
-
ENET SHIELD
CC
EE
354-0260
354-0258
00
00
BATTERY 2 (-)
BATTERY 1 (+)
I16
I16
DISCONNECT SWITCH
POWER JUNCTION BLOCK
I15
I14
C
CAN (+)
CAN (-)
F711
F712
YL
GN
11
12
F711-YJ8 YL-18-GXL
F712-YJ9 GN-18-GXL
11
12
CAN (+)
CAN (-)
WIRE GROUP COLOR DESCRIPTIONS GG 354-0261 00 DISCONNECT SWITCH I15 FRAME GROUND STUD I14
00 DISCONNECT SWITCH I15
GROUND CIRCUIT JJ 373-4808 JUMPSTART RECEPTACLE I15
REF DIAGRAMS 1 SW TO GND 1 00 POWER JUNCTION BLOCK I14
PRODUCT LINK 2 SW TO GND 2 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF VV 454-0268 00 POWER JUNCTION BLOCK I14 STARTER TERMINAL 30 (+) I14
JUMPER 3
SW TO GND WAKEUP
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON MM 183-1025 * 00 STARTER TEMINAL 31 (-) I14 ENGINE GROUND I13
4
5 RELAY TERMINAL VOLTAGE CONVERTER OUTPUT CIRCUIT WW 379-8287 00 FRAME GROUND STUD I14 ENGINE GROUND I13
6 QQ 389-1403 12 PLATFORM GROUND STUD B9 UNDER SEAT PANEL GROUND STUD B9
STARTING CIRCUIT
7 * ITEM NOT CONTROLLED BY THIS SCHEMATIC, SHOWN FOR REFERECE ONLY.
8 SW TO GND 3 START AID CIRCUIT
MACHINE CONTROL CIRCUIT
MONITOR CIRCUIT
ENGINE CONTROL CIRCUIT
HEATER AND AIR CONDITIONER CIRCUIT
HARNESS ASSEMBLY
TURN SIGNAL / WIPER WASHER CIRCUIT
IDENT LOC PART NO. ATCH GROUP NAME SYMBOL DESCRIPTION
CAT DATA LINK E 487-3438 WIRING GP-MACHINE
MACHINE TO MACHINE CAN CONN CAN DATA LINK EA 488-5967* WIRING GP CIRCUIT CONNECTED
CONN 12 COMPACTION CONTROL CIRCUIT F 359-7583 WIRING GP-SENSOR
Y-C5 NAME ID CLR CIRCUIT NOT CONNECTED
3E3370 CAN DATA LINK 1 JPS DISPLAY M 487-5399 PANEL GP-ELEC
F711-Y40 YL-18-GXL A CAN (+) F711 YL-18 Y 501-2068 WIRING GP (CAB/ROPS) ELECTRICAL CONNECTION TO
CAN DATA LINK 2 GPS RECEIVER
MACHINE TO MACHINE CAN CONN F712-Y41 GN-18-GXL B CAN (-) F712 GN-18 YJ 462-7737 HARNESS AS MACHINE STRUCTURE
CONN 12 C - - - CAN DATA LINK 0 GPS DISPLAY , CAN 1 GPS RECEIVER / ACCUGRADE YP 502-9312 WIRING GP (CANOPY/OPEN) INTERNAL ELECTRICAL CONNECTION
YP-C5 NAME ID CLR ETHERNET * ITEM NOT CONTROLLED BY THIS SCHEMATIC, SHOWN FOR REFERECE ONLY. TO SURFACE OF COMPONENT
3E3370 REF DIAGRAMS
F711-YP40 YL-18-GXL A CAN (+) F711 YL-18
F712-YP41 GN-18-GXL B CAN (-) F712 GN-18 200-Y200 BK-16-GXL OTHER COLOR DESCRIPTIONS CONNECTOR

C - - - 200-Y201 BK-16-GXL OPERATOR STATION CONN H# CIRCUIT GROUPING DESIGNATION

CONN 13 HIGHWAYS
REF DIAGRAMS TO CONNECTOR C-C100 Y-C2 NAME ID CLR
SEE VOL2 LOC C-15 1552252 ATCH WIRE, CABLE, COMPONENT
B CONNECT TO GROUND STUD
(35) REAR PANEL GND
8T3635 M12 122-Y1 BU-18-GXL
608-Y2 GN-16-GXL
1
2
UNSWITCHED B+
REAR WORK LIGHTS
122
608
BU-18
GN-16
B
SPLICE
IN PANEL GP-ELEK 200-YP200 BK-16-GXL CONN 11 OPERATOR STATION CONN OPEN 607-Y3 PK-16-GXL 3 FRONT WORK LIGHTS 607 PK-16
200-QQ1 BK-12-GXL 200-YP201 BK-16-GXL 603-Y4 PK-18-GXL 4 BEACON LIGHT 603 PK-18 BLADE, SPADE, RING OR SCREW
TO CONNECTOR PN-C7 YP-C2 NAME ID CLR 200-Y200 BK-16-GXL 322-Y5 GY-18-GXL 5 FORWARD WARNING HORN 322 GY-18 TERMINAL
SEE VOL 2 A-15 1965330 Y-C1 200-Y201 BK-16-GXL 521-Y6 YL-18-GXL 6 COMP ON 521 YL-18
YP-C1 608-YP2 GN-16-GXL 1 REAR WORK LIGHTS 608 GN-16 1673692 522-Y7 WH-18-GXL 7 COMP RTN 522 WH-18
1673692 607-YP3 PK-16-GXL 2 FRONT WORK LIGHTS 607 PK-16 1 122-Y1 BU-18-GXL 111-Y18 WH-16-GXL F711-Y40 YL-18-GXL 118-Y8 GY-14-GXL 8 WIPER POWER 118 GY-14
1 (36) REAR PANEL GND 603-YP4 PK-18-GXL 3 BEACON 603 PK-18 CONN 8 2 608-Y2 GN-16-GXL 118-Y8 GY-14-GXL F712-Y41 GN-18-GXL 124-Y9 GN-14-GXL 9 HVAC POWER 124 GN-14
2 608-YP2 GN-16-GXL 8T3635 M12 322-YP5 GY-18-GXL 4 FORWARD WARNING HORN 322 GY-18 3 607-Y3 PK-16-GXL 122-Y1 BU-18-GXL A513-Y10 PK-16-GXL 10 12V RADIO UNSWITCHED A513 PK-18 ABBREV COLOR
CONN 8 3 607-YP3 PK-16-GXL
355-3031
TO CONNECTOR MC-5 4 603-Y4 PK-18-GXL 124-Y9 GN-14-GXL 118-Y8 GY-14-GXL 592-Y11 BU-18-GXL 11 12V RADIO SWITCHED 592 BU-18

TO CONNECTOR MC-5 4 603-YP4 PK-18-GXL REF DIAGRAMS SEE LOC I-3 5 322-Y5 GY-18-GXL 172-Y13 GN-18-GXL 122-Y1 BU-18-GXL 607-Y12 PK-16-GXL 12 DASH BACK LIGHTS 614 PU-18 RD RED
5 322-YP5 GY-18-GXL 200-YP200 BK-16-GXL 6 521-Y6 YL-18-GXL 174-Y19 PK-16-GXL 124-Y9 GN-14-GXL
SEE LOC I-3 355-3031
6 200-YP201 BK-16-GXL 7 522-Y7 WH-18-GXL 176-Y14 PU-16-GXL 322-Y5 GY-18-GXL REF DIAGRAMS WH WHITE
7
CONN 10
PRODUCT LINK OPTION 8 118-Y8 GY-14-GXL 322-Y5 GY-18-GXL 521-Y6 YL-18-GXL CALLOUTS
8 9 124-Y9 GN-14-GXL 521-Y6 YL-18-GXL 522-Y7 WH-18-GXL OR ORANGE
9 111-YP18 WH-16-GXL F711-YP40 YL-18-GXL TO CONNECTOR YJ-C1 YP-C3 NAME ID CLR 10 A513-Y10 PK-16-GXL 522-Y7 WH-18-GXL 592-Y11 BU-18-GXL PRODUCT LINK OPTION
10 172-YP13 GN-18-GXL F712-YP41 GN-18-GXL 1552253 11 592-Y11 BU-18-GXL 592-Y11 BU-18-GXL 603-Y4 PK-18-GXL
CONN 10 YL YELLOW
SEE LOC C-6 Callout Number Component
TO CONNECTOR YJ-C1 Y-C3 NAME ID CLR
11
12
174-YP19 PK-16-GXL
176-YP14 PU-16-GXL
172-YP13 GN-18-GXL
200-YP200 BK-16-GXL
1
2
PROD LINK POWER (+)
GROUND
172
200
RD
BK
12
13
607-Y12 PK-16-GXL
172-Y13 GN-18-GXL
603-Y4 PK-18-GXL
607-Y3 PK-16-GXL
607-Y3 PK-16-GXL
607-Y12 PK-16-GXL SEE LOC C-6 1552253 (Machine Location from (52) VALVE GP - CONTROL Name
PK PINK
Component Locations Table)
13 172-YP13 GN-18-GXL 322-YP5 GY-18-GXL 322-YP5 GY-18-GXL 176-YP14 PU-16-GXL 3 SW POWER (+) 176 PU 14 176-Y14 PU-16-GXL 607-Y12 PK-16-GXL 608-Y2 GN-16-GXL 172-Y13 GN-18-GXL 1 PROD LINK POWER (+) 172 RD 138-1234 Part Number
BK BLACK
14 176-YP14 PU-16-GXL 603-YP4 PK-18-GXL 603-YP4 PK-18-GXL 4 - NOT USED 15 608-Y2 GN-16-GXL A513-Y10 PK-16-GXL 200-Y200 BK-16-GXL 2 GROUND 200 BK
15 607-YP3 PK-16-GXL 607-YP3 PK-16-GXL 1515-YP20 YL-18-GXL 5 ETHERNET TX+ 1515 YL 16 1515-Y20 YL-18-GXL 176-Y14 PU-16-GXL 3 SW POWER (+) 176 PU
16 608-YP2 GN-16-GXL 608-YP2 GN-16-GXL 1516-YP21 OR-18-GXL 6 ETHERNET TX- 1516 OR 17 1516-Y21 OR-18-GXL 4 - NOT USED
GY GRAY
17 1515-YP20 YL-18-GXL 1517-YP22 WH-18-GXL 7 ETHERNET RX+ 1517 WH 18 111-Y18 WH-16-GXL 1517-Y22 WH-18-GXL 172-Y13 GN-18-GXL 1515-Y20 YL-18-GXL 5 ETHERNET TX+ 1515 YL
18 111-YP18 WH-16-GXL 1516-YP21 OR-18-GXL 172-YP13 GN-18-GXL 1518-YP23 BU-18-GXL 8 ETHERNET RX- 1518 BU 19 174-Y19 PK-16-GXL 1518-Y23 BU-18-GXL 176-Y14 PU-16-GXL 1516-Y21 OR-18-GXL 6 ETHERNET TX- 1516 OR
PU PURPLE
19
20
174-YP19 PK-16-GXL
1515-YP20 YL-18-GXL
1517-YP22 WH-18-GXL
1518-YP23 BU-18-GXL
176-YP14
200-YP200
PU-16-GXL
BK-16-GXL
9
10
-
-
NOT
NOT
USED
USED
20
21
1515-Y20
1516-Y21
YL-18-GXL
OR-18-GXL
A513-Y10 PK-16-GXL 200-Y200
1515-Y20
BK-16-GXL
YL-18-GXL
1517-Y22
1518-Y23
WH-18-GXL
BU-18-GXL
7
8
ETHERNET RX+
ETHERNET RX-
1517
1518
WH
BU
BR BROWN
21 1516-YP21 OR-18-GXL 1515-YP20 YL-18-GXL F711-YP32 YL-18-GXL 11 CAN (+) F711 YL 22 1517-Y22 WH-18-GXL F711-Y32 YL-18-GXL 1516-Y21 OR-18-GXL 9 - NOT USED GN GREEN
22 1517-YP22 WH-18-GXL F711-YP32 YL-18-GXL 1516-YP21 OR-18-GXL F712-YP35 GN-18-GXL 12 CAN (-) F712 GN 23 1518-Y23 BU-18-GXL F711-Y27 YL-18-GXL F711-Y33 YL-18-GXL 1517-Y22 WH-18-GXL 10 - NOT USED
23 1518-YP23 BU-18-GXL F711-YP27 YL-18-GXL F711-YP33 YL-18-GXL 1517-YP22 WH-18-GXL 24 1518-Y23 BU-18-GXL F711-Y32 YL-18-GXL 11 CAN (+) F711 YL BU BLUE
24 1518-YP23 BU-18-GXL REF DIAGRAMS 25 F711-Y32 YL-18-GXL F712-Y35 GN-18-GXL 12 CAN (-) F712 GN
25 F711-YP32 YL-18-GXL 26 F711-Y38 YL-18-GXL F711-Y34 YL-18-GXL F712-Y35 GN-18-GXL
26 F711-YP38 YL-18-GXL F711-YP34 YL-18-GXL F712-YP35 GN-18-GXL 27 F711-Y27 YL-18-GXL REF DIAGRAMS
27 F711-YP27 YL-18-GXL COMPACTION MEASUREMENT 28 F712-Y28 GN-18-GXL 111-Y18 WH-16-GXL
28 F712-YP28 GN-18-GXL 111-YP18 WH-16-GXL
CONN 9 29 F711-Y29 YL-18-GXL F711-Y29 YL-18-GXL F711-Y40 YL-18-GXL 200-Y201 BK-16-GXL

A 29
30
F711-YP29
F712-YP30
YL-18-GXL
GN-18-GXL
F711-YP29 YL-18-GXL F711-YP40 YL-18-GXL 174-YP19 PK-16-GXL
200-YP201 BK-16-GXL
TO CONNECTOR MG-C4 YP-C4
SEE VOL 3 LOC J-7 1552273
NAME ID CLR 30
31
F712-Y30 GN-18-GXL
F712-Y35 GN-18-GXL
174-Y19 PK-16-GXL
F711-Y34 YL-18-GXL
CONN 9 COMPACTION MEASUREMENT A
31 F712-YP35 GN-18-GXL F711-YP34 YL-18-GXL 111-YP18 WH-16-GXL 1 SW POWER 111 YL F712-Y28 GN-18-GXL F712-Y36 GN-18-GXL F712-Y37 GN-18-GXL TO CONNECTOR MG-C4 Y-C4
1552273
NAME ID CLR THIS SCHEMATIC IS FOR THE CP/CS56B, CP/CS68B, CP/CS74B, CP76B, CS78B AND CS79B ELECTRICAL SYSTEM
F712-YP28 GN-18-GXL F712-YP36 GN-18-GXL F712-YP37 GN-18-GXL 200-YP201 BK-16-GXL 2 GROUND 200 BK SEE VOL 3 LOC J-7
174-YP19 PK-16-GXL
F711-YP34 YL-18-GXL
3
4
POWER
CAN (+)
174
F711
PK
YL F712-Y39 GN-18-GXL F712-Y37 GN-18-GXL
111-Y18 WH-16-GXL
200-Y201 BK-16-GXL
1
2
SW POWER
GROUND
111
200
YL
BK
VOLUME 1 of 4: MAIN ELECTRICAL SYSTEM
F712-YP39 GN-18-GXL F712-YP37 GN-18-GXL F712-YP37 GN-18-GXL 5 CAN (-) F712 GN 174-Y19 PK-16-GXL 3 POWER 174 PK
6 CAN (SHIELD) 234 BK F711-Y34 YL-18-GXL 4 CAN (+) F711 YL MEDIA NUMBER: UENR6932-01
F712-Y30 GN-18-GXL F712-Y41 GN-18-GXL F712-Y37 GN-18-GXL 5 CAN (-) F712 GN
355-3035
F712-YP30 GN-18-GXL F712-YP41 GN-18-GXL REF DIAGRAMS 6 CAN (SHIELD) 234 BK
SCHEMATIC PART NUMBER: 452-5327, CHANGE: 05, VERSION: -
PANEL GP REF DIAGRAMS
355-3035
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
(OPEN & SUN CANOPY) PANEL GP
(CAB & OPEN ROPS) in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 UENR6392-01
January 2019
Component Location - Volume 2
Schematic Machine
Component
Location Location
85 Alarm - Action
Bead - Ferrite (C Harness)
J-8
D-14
80
81
Bead - Ground / AC Wires on MR Harness) E-15 82
Bead - Power / AC Wires on MR Harness) D-15 83

UENR6392-01 VOL 2 of 4
Diode - ARC Suprresor 1 B-16 84
Diode - ARC Suprresor 2 D-6 85
Display - Monitor I-4 86
Ground - Cab D-11 87
Ground - Platform (Canopy / Open) A-11 88
Ground - Platform (Shipping) A-5 89

(Dimensions: 56 inches x 35 inches)

Handle - Standard Propel I-5 90
Horn - Forward Warning E-3 91
Horn - Forward Warning (Shipping Platform) A-5 92
Horn - Forward Warniong (Canopy / Open) A-8 93
Keypad I-8 94
Motor - Blower B-10 95
Motor - Front Washer Pump E-15 96
Motor - Front Wiper E-3 91
Motor - Rear Washer Pump E-15 98
Motor - Rear Wiper D-16 99

113 Panel - AC Control

Receptacle - Bussed Ground
E-6
I-11
100
101
100 110 Resistor - Blower C-11 102
CONN 17 Resistor - Can 1 Term 1 (J1939) I-4 103
Seat - Air Ride D-13 104

106 82
CP56B, CS56B, CP68B, CS68B, CP74B,
Solenoid - Compresssor Clutch B-16 105
Switch - AC / Heat D-6 106
Switch - AC Pressure B-16 107

CP76B, CS74B, CS78B and CS79B

Switch - Beacon I-11 108
Switch - E-Stop I-5 109

Vibratory Soil Compactor

Switch - Front Wiper F-6 110
Switch - Horn I-8 111
Switch - Park Brake I-5 112

Electrical System
Switch - Rear Wiper F-6 113
Switch - Thermostat B-12 114
Switch - Work Lights J-11 115
Swittch - Key Start H-12 116
97 Valve - Water B-12 117
CP56B: CS56B: CP68B: CS68B:
99 MP61-UP M561-UP CM61-UP M681-UP
104 5081-UP 5071-UP 5101-UP 5091-UP

42 Page,
91 CP74B: CS74B: CS78B: CS79B:
Connector Location - Volume 2 5121-UP C741-UP 5131-UP CM71-UP
Connector Number
Schematic
Location
CP71-UP B7M1-UP M781-UP
CONN 7 B-15
CONN 8 B-6
CONN 11 A-15 CP76B:
CONN 13 C-15
CONN 14 I-14 J761-UP
83 CONN 15 E-14
CONN 16 B-10
87 CONN 17 G-6

The connectors shown in this chart are for harness to

harness connectors. Connectors that join a harness to a

98 component are generally located at or near the component.

See the Component Location Chart.
CONN 16 CONN 15 81 CONN 13 96 Volume 2 of 4: Side Console / Operator Station

© 2019 Caterpillar, All Rights Reserved Printed in U.S.A.

CAB ELECTRICAL SYSTEM

101 Harness And Wire Electrical Schematic Symbols

Symbols

80 Pressure
T

Temperature Level Flow Circuit Breaker

Symbol
103 Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
86 through it.

109 112 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
117 No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The
CONN 7 grounded wire is fastened to the machine.
94 Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

115 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender

90 108 T
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

114 111 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
102 116 coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
105 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
CONN 14 the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

107 84 Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
AG-C4 L-C12 harness (C1, C2, C3, ...).
L-C12
111-7898 3E-5179
95 Part Number: for Connector Plug 1
3E-5179
Part Number: for Connector Receptacle
2
Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

AIR CONDITIONER A/C COMPRESSOR SIDE CONSOLE

89

CONN 11
CONN 8

92

88 93

OPEN PLATFORM / SUN CANOPY SHIPPING PLATFORM

 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
UENR6392-01 VOL 2 of 4

SEAT MOUNTED SIDE CONSOLE

116-A10 BR-16-GXL
(115) WORK LIGHTS SWITCH
2614907
(56B/68B/74B/78B W/ ROTATING SEAT)
WIRES IN THE FOLLOWING
J 607-A60 PK-18-GXL
117-A6 YL-18-GXL A-C6
2234778 FRONTOFF BOTH
GROUPS SHALL BE TWISTED:
ONE TWIST PER 25 MM.
J
603-A5 PK-18-GXL
200-A200 BK-16-GXL 608-A54 GN-18-GXL 7 BOTH
LED
WIRE GROUP WIRE NAME
200-A201 BK-18-GXL 200-A210 BK-18-GXL 9
1 A TW1 F711-A22
200-A202 BK-18-GXL 115-A55 PK-16-GXL 1
2 A TW1 F712-A21
176-A61 PU-18-GXL 607-A56 PK-16-GXL 2
(Dimensions: 56 inches x 35 inches)

3
200-A204 BK-18-GXL 115-A57 PK-16-GXL 3 A TW2 F711-A65
4
200-A205 BK-18-GXL 4 A TW2 F712-A66
5
200-A206 BK-18-GXL 608-A58 GN-16-GXL 5
116-A10 BR-16-GXL 6
6 A TW3 F711-A51
607-A63 PK-18-GXL 200-A208 BK-18-GXL 8 FRONT 169-A48 PK-18-GXL + (80) ACTION AUDIBLE ALARM A TW3 F712-A53
LED
607-A7 PK-16-GXL 607-A56 PK-16-GXL 607-A59 PK-18-GXL 10 A487-A36 PU-18-GXL - 2321792 A TW4 F711-A67
607-A59 PK-18-GXL
A TW4 F712-A68
608-A8 GN-16-GXL 608-A54 GN-18-GXL A-C2 A TW5 F711-A42
608-A58 GN-16-GXL 3315048 A TW5 F712-A43
200-A201 BK-18-GXL 1 GROUND
A TW6 F711-A33
115-A9 PK-16-GXL 115-A55 PK-16-GXL (108) BEACON SWITCH (111) HORN SWITCH 169-A41 PK-18-GXL 2 BATTERY +
115-A57 PK-16-GXL 2549108 2631490 F711-A42 YL-18-GXL 3 CAN 0 HIGH A TW6 F712-A34
A487-A36 PU-18-GXL F712-A43 GN-18-GXL 4 CAN 0 LOW A TW7 F711-A37
200-A207 BK-18-GXL A-C7 200-A205 BK-18-GXL A-C5 5 CAN SHIELD A TW7 F712-A38
200-A208 BK-18-GXL 2234778 OFF ON 114-A19 GN-18-GXL 2234778 OFF ON 6 N/C
200-A209 BK-18-GXL 607-A60 PK-18-GXL 7 322-A20 GY-18-GXL 607-A49 PK-18-GXL 7
GC TW1 F711-GC7
BACKLIGHT BACKLIGHT

200-A210 BK-18-GXL 200-A209 BK-18-GXL 9

LED
200-A204 BK-18-GXL 200-A205 BK-18-GXL 9
LED (90) STD PROPEL HANDLE GC TW1 F712-GC8
200-A203 BK-16-GXL 1
1
1
1 3553040
2 2 K TW1 F711-K22
117-A6 YL-18-GXL 2 169-A48 PK-18-GXL 114-A19 GN-18-GXL 2
3 3 K TW1 F712-K21
603-A5 PK-18-GXL 3 169-A64 PK-18-GXL 169-A50 PK-18-GXL 322-A20 GY-18-GXL 3
4 4 A-C1 KC TW1 F711-KC7
4 169-A52 PK-18-GXL 4 169-A41 PK-18-GXL
5 5 2538110
176-A61 PU-18-GXL 5
6
5
6
F711-A42 YL-18-GXL KC TW1 F712-KC8
6 607-A63 PK-18-GXL 607-A49 PK-18-GXL 6 F712-A43 GN-18-GXL 200-A202 BK-18-GXL 1 GROUND
KC TW2 F711-KC15
200-A207 BK-18-GXL 8 ON 607-A60 PK-18-GXL 8 200-A201 BK-18-GXL 169-A32 PK-18-GXL 2 BATTERY +
638-A69 WH-18-GXL 10
LED
10 F715-A24 PU-18-GXL A-C3 (109) E STOP SW F711-A33 YL-18-GXL 3 CAN 0 HIGH KC TW2 F712-KC16
F711-A65 YL-18-GXL F716-A11 WH-18-GXL 1552272 3679470 F712-A34 GN-18-GXL 4 CAN 0 LOW KC TW3 F711-KC13
607-A63 PK-18-GXL F711-A22 YL-18-GXL F711-A51 YL-18-GXL U735-A25 GY-18-GXL F729-A35 GN-18-GXL 1 5 CAN SHIELD KC TW3 F712-KC14
176-A61 PU-18-GXL U734-A26 GN-18-GXL F715-A24 PU-18-GXL 2 6 N/C
A B
200-A206 BK-18-GXL F712-A66 GN-18-GXL 176-A46 PU-18-GXL F729-A44 GN-18-GXL 3 7 N/C
I 200-A204 BK-18-GXL
200-A205 BK-18-GXL
F712-A21 GN-18-GXL F712-A53 GN-18-GXL F716-A11 WH-18-GXL 4
C D
8
9
N/C
N/C
I
200-A201 BK-18-GXL 200-A211 BK-18-GXL 10 FUEL LEVEL SENDER 1
200-A200 BK-16-GXL A-C9 200-A206 BK-18-GXL 200-A212 BK-18-GXL 11 FUEL LEVEL SENDER 2
607-A7 PK-16-GXL A-C10 (101) BUSSED GND F711-A65 YL-18-GXL 2818811 200-A213 BK-18-GXL A487-A36 PU-18-GXL 12 ACTION AUDIBLE ALARM
200-A202 BK-18-GXL 1552253 2147404 F712-A66 GN-18-GXL 169-A50 PK-18-GXL 1 BATTERY +
607-A60 PK-18-GXL 200-A200 BK-16-GXL 1 A487-A36 PU-18-GXL 200-A204 BK-18-GXL 2 GROUND
(86) DISPLAY
608-A8 GN-16-GXL 200-A201 BK-18-GXL 2 169-A64 PK-18-GXL F711-A51 YL-18-GXL 3 CAN 0 HIGH F729-A29 GN-18-GXL
4512449
F729-A35 GN-18-GXL
TO CONNECTOR M-C6 603-A5 PK-18-GXL 200-A202 BK-18-GXL 3 4 SYSTEM WAKE UP F729-A44 GN-18-GXL
SEE VOL1 LOC F-3 115-A9 PK-16-GXL 200-A203 BK-16-GXL 4 169-A52 PK-18-GXL 5 KEY SWITCH
116-A10 BR-16-GXL 200-A204 BK-18-GXL 5 114-A19 GN-18-GXL F712-A53 GN-18-GXL 6 CAN 0 LOW (112) PARK BRAKE SWITCH
A-C12 (103) CAN 1 TERM1
SIDE CONSOLE 56 CONN 117-A6 YL-18-GXL 200-A205 BK-18-GXL 6 F712-A21 GN-18-GXL 2227890
CONN 14 200-A206 BK-18-GXL 7 F711-A22 YL-18-GXL
(94) KEYPAD 1740502 1342540
A-C8 3636756 A-C4
NAME ID CLR 308-A1 YL-18-GXL 200-A214 BK-18-GXL 8 322-A20 GY-18-GXL F711-A37 YL-18-GXL A
2253854 105-A4 RD-18-GXL 9 2234778 OFF ON F712-A38 GN-18-GXL B
RUN 308 YL 1 308-A1 YL-18-GXL 307-A3 OR-18-GXL 10 7 ON C
LED
. . . 2 307-A3 OR-18-GXL 11 607-A63 PK-18-GXL 200-A213 BK-18-GXL 9
CONNECT TO RIGHT SIDE 1
START 307 OR 3 307-A3 OR-18-GXL 308-A1 YL-18-GXL 12 607-A60 PK-18-GXL U735-A25 GY-18-GXL 1
CONSOLE MOUNTING STUD 2
UNSWITCHED B+ 105 RD 4 105-A4 RD-18-GXL 105-A4 RD-18-GXL 200-A204 BK-18-GXL 200-A211 BK-18-GXL 2
3
BEACON 603 PK 5 603-A5 PK-18-GXL 603-A5 PK-18-GXL 200-A205 BK-18-GXL U734-A26 GN-18-GXL 3
4
42 Page,

BEACON POWER 117 YL 6 117-A6 YL-18-GXL 200-A200 BK-16-GXL 607-A60 PK-18-GXL 200-A201 BK-18-GXL 777-A45 PU-18-GXL 4
5
FRONT WORK LIGHTS 607 PK 7 607-A7 PK-16-GXL 608-A8 GN-16-GXL 607-A63 PK-18-GXL A487-A36 PU-18-GXL U735-A25 GY-18-GXL 176-A46 PU-18-GXL 5
6
REAR WORK LIGHTS 608 GN 8 608-A8 GN-16-GXL 116-A10 BR-16-GXL 200-A204 BK-18-GXL F711-A65 YL-18-GXL U734-A26 GN-18-GXL 776-A47 YL-18-GXL 6
FR WORK LTS PWR 115 PK 9 115-A9 PK-16-GXL 115-A9 PK-16-GXL 200-A205 BK-18-GXL F712-A66 GN-18-GXL F715-A24 PU-18-GXL 176-A46 PU-18-GXL 200-A212 BK-18-GXL 8 OFF
LED
RR WORK LTS PWR 116 BR 10 116-A10 BR-16-GXL 117-A6 YL-18-GXL 169-A64 PK-18-GXL F716-A11 WH-18-GXL U734-A26 GN-18-GXL 10
CAN (SHIELD) 234 BK 11 F716-A11 WH-18-GXL 607-A7 PK-16-GXL 200-A206 BK-18-GXL 200-A206 BK-18-GXL U735-A25 GY-18-GXL
. . . 12 200-A202 BK-18-GXL 200-A206 BK-18-GXL F729-A29 GN-18-GXL F729-A29 GN-18-GXL
. . . 13 A-C11 200-A201 BK-18-GXL 176-A61 PU-18-GXL 200-A202 BK-18-GXL 200-A201 BK-18-GXL
1552272 R
. . . 14 114-A19 GN-18-GXL 176-A61 PU-18-GXL 200-A202 BK-18-GXL A487-A36 PU-18-GXL F715-A24 PU-18-GXL
. . . 15 F711-A22 YL-18-GXL 308-A1 YL-18-GXL 1 YL-16 F716-A11 WH-18-GXL
C OFF
ALT D+ TERM 309 GY 16 F712-A21 GN-18-GXL 2 PU-16 200-A201 BK-18-GXL 200-A206 BK-18-GXL HARNESS ASSEMBLY
S ON
MAIN CHASSIS 200 BK 17 200-A200 BK-16-GXL 322-A20 GY-18-GXL 307-A3 OR-18-GXL 3 OR-16 F711-A42 YL-18-GXL IDENT LOC PART NO. ATCH GROUP NAME
B ST
. . . 18 105-A4 RD-18-GXL 4 BR-16 308-A1 YL-18-GXL F712-A43 GN-18-GXL A I-14 454-0274 PANEL GP-INSTR -D (ELEC W/ ROT SEAT)
HORN POWER 114 GN 19 114-A19 GN-18-GXL (116) KEY SWITCH 200-A200 BK-16-GXL 176-A23 PU-18-GXL F711-A67 YL-18-GXL 169-A41 PK-18-GXL
HORN 322 GY 20 322-A20 GY-18-GXL 169-A30 PK-18-GXL 1107887 307-A3 OR-18-GXL F715-A24 PU-18-GXL F711-A65 YL-18-GXL F711-A42 YL-18-GXL
CAN (-) F712 GN 21 F712-A21 GN-18-GXL U734-A26 GN-18-GXL 607-A7 PK-16-GXL F716-A11 WH-18-GXL

H CAN (+)
BACKLIGHT POWER
F711
176
YL
PU
22
23
F711-A22
176-A23
YL-18-GXL
PU-18-GXL
U735-A25
F729-A29
GY-18-GXL
GN-18-GXL
115-A9 PK-16-GXL
608-A8 GN-16-GXL
U735-A25
U734-A26
GY-18-GXL
GN-18-GXL F712-A66 GN-18-GXL
F712-A68 GN-18-GXL
F712-A43 GN-18-GXL
F711-A67 YL-18-GXL
F712-A68 GN-18-GXL F711-A67 YL-18-GXL F711-A37 YL-18-GXL H
E-STOP N/O F715 PU 24 F715-A24 PU-18-GXL 176-A23 PU-18-GXL 105-A4 RD-18-GXL F729-A29 GN-18-GXL 169-A32 PK-18-GXL F711-A33 YL-18-GXL
PARKING BRAKE N/C U735 GY 25 U735-A25 GY-18-GXL 603-A5 PK-18-GXL 169-A30 PK-18-GXL 169-A41 PK-18-GXL A487-A36 PU-18-GXL
PARKING BRAKE N/O U734 GN 26 U734-A26 GN-18-GXL F715-A24 PU-18-GXL 116-A10 BR-16-GXL 169-A30 PK-18-GXL 169-A32 PK-18-GXL 200-A202 BK-18-GXL F712-A68 GN-18-GXL F712-A38 GN-18-GXL
REAR FUEL SENDER 447 PK 27 F716-A11 WH-18-GXL 117-A6 YL-18-GXL 169-A64 PK-18-GXL F712-A34 GN-18-GXL
FRONT FUEL SENDER H479 OR 28
SENSOR RETURN F729 GN 29 F729-A29 GN-18-GXL 176-A61 PU-18-GXL 176-A46 PU-18-GXL 169-A32 PK-18-GXL
DISPLAY/HORN POWER 169 PK 30 169-A30 PK-18-GXL 176-A23 PU-18-GXL 200-A202 BK-18-GXL
. . . 31 A487-A36 PU-18-GXL

377-2196
REF DIAGRAMS

SCHEMATIC PART NUMBER: 453-5373, CHANGE: 01, VERSION: - (SIDE CONSOLE)

G CONN 17 AUX POWER CONNECTOR G

C-C6 NAME ID CLR
1552272
200-C111 BK-18-GXL 1 GROUND 200 BK-14
122-C15 BU-18-GXL 2 24V UNSWITCHED 122 RD-16
A513-C39 PK-18-GXL 3 12V UNSWITCHED(MEM) A513 PK-16
592-C42 BU-18-GXL 4 12V SWITCHED 592 BU-16

C-C7
1552269
607-C20 PK-16 1 LF FLOODLIGHT
200-C118 BK-16 2 2196487

(110) FRONT WIPER SW

2511191
C-C3
2234778
614-C22 PU-18-GXL 7
200-C112 BK-18-GXL 9
1
500-C48 BR-16-GXL 1
2
LH SPEAKER
501-C53 GN-16-GXL 2 1688772
3 +
118-C33 GY-16-GXL 3
4
508-C55 PU-18-GXL
4
5
509-C54 WH-18-GXL -
118-C34 GY-16-GXL 5
6
506-C49 PU-18 6
8
10

WIRING GP CAB
F F
(113) REAR WIPER SW
2511194
C-C4
2234778
614-C23 PU-18-GXL 7
200-C113 BK-18-GXL 9
1
DOME LAMP
LR FLOODLIGHT 503-C50 BR-16-GXL 1
2
1076032
2196487 C-C10 504-C51 YL-16-GXL 2
3
1552269 118-C34 GY-16-GXL 118-C31 GY-16-GXL 3 122-C16 BU-18-GXL
4
1 608-C17 GN-16 118-C28 GY-14-GXL 4
5
200-C119 BK-18-GXL
2 200-C110 BK-16 118-C33 GY-16-GXL 118-C32 GY-16-GXL 5
6
507-C52 WH-18 6
8
10

C-C17 C-C15 L
1237615 1552273
118-C27 GY-16-GXL GND
1 506-C49 PU-18 1 MOTOR H
MOTOR 118-C8 GY-14-GXL 118-C28 GY-14-GXL 200-C125 BK-16-GXL 2 BK-16
2 200-C126 BK-18
118-C29 GY-16-GXL 500-C48 BR-16-GXL 3 BR-16 T

(96) FRONT WASHER PUMP 501-C53 GN-16-GXL 4 GN-16

B+ P
507-C52 WH-18 4 5 OR-16
7T8891
200-C107 BK-16-GXL 3 118-C29 GY-16-GXL 6 GY-16
506-C49 PU-18 2
C-C18 1
1237615 504-C51 YL-16-GXL C-C1 (100) AC CONTROL PANEL (97) FRONT WIPER
1 507-C52 WH-18
503-C50 BR-16-GXL 1552252 2484220 4 1555783
MOTOR 200-C101 BK-18 124-C38 GN-14-GXL 1 3
2 200-C128 BK-18 2
515-C58 GY-14-GXL 2 1
E (98) REAR WASHER PUMP
7T8891
200-C114
200-C116
BK-18-GXL
BK-18-GXL
C568-C67 WH-14-GXL
516-C59 GN-14-GXL
3
4
OFF
E
200-C105 BK-16-GXL 200-C115 BK-18-GXL 517-C60 BU-14-GXL 5
200-C117 BK-18-GXL 567-C47 WH-18-GXL 6
200-C121 BK-18-GXL 7
200-C113 BK-18-GXL 614-C25 PU-18-GXL 8
200-C106 BK-18-GXL 200-C112 BK-18-GXL 200-C122 BK-18-GXL 9
200-C111 BK-18-GXL 124-C37 GN-18-GXL 10
A524-C61 BR-18-GXL 11
(82) FERRITE BEAD A513-C10 PK-18-GXL A513-C40 PK-18-GXL 200-C123 BK-18-GXL 12
452-7730 A513-C39 PK-18-GXL 200-C117 BK-18-GXL
CONN 15 122-C14 BU-18-GXL
200-C129 BK-18-GXL
L
MR-C2 MR-C1 C-C12 122-C711 BU-18-GXL 122-C15 BU-18-GXL C-C16 (91) FORWARD WARNING HORN
1552273 3E3382 1552273 J-C2 J-C1 C-C14 122-C16 BU-18-GXL 1552269 3582293
GND
H MOTOR 1 1 1552272 3E3364 1552269 122-C711 BU-18-GXL 322-C5 GY-18 1 BK-18
BK-16 2 200-MR1 BK-16-GXL 200-MR1 BK-16-GXL 2 200-C127 BK-16-GXL 1 108-J1 BU-18-GXL 1 122-C710 BU-18-GXL 122-C1 BU-18-GXL 200-C101 BK-18 2 BK-18
T BR-16 3 503-MR2 BR-16-GXL 503-MR2 BR-16-GXL 3 503-C50 BR-16-GXL 2 200-J2 BK-18-GXL 2 200-C102 BK-18-GXL 122-C710 BU-18-GXL
P B+
GN-16 4 504-MR3 YL-16-GXL 504-MR3 YL-16-GXL 4 504-C51 YL-16-GXL 3 592-C41 BU-18-GXL
OR-16 5 5 MOTOR HEIGHT 4 592-C11 BU-18-GXL 592-C42 BU-18-GXL
GY-16 6 118-MR4 GY-16-GXL 118-MR4 GY-16-GXL 6 118-C27 GY-16-GXL ADJUST SW 122-C710 BU-18-GXL
504-C51 YL-16-GXL 567-C68 WH-18-GXL
(99) REAR WIPER OPERATOR 503-C50 BR-16-GXL 567-C65 WH-18-GXL
3597628 COMPRESSOR PRESENCE SW 506-C49 PU-18 567-C64 WH-18-GXL
507-C52 WH-18 567-C47 WH-18-GXL
(83) FERRITE BEAD (81) FERRITE BEAD
(104) AIR RIDE SEAT
452-7730 452-7730
AIR SEAT 614-C25 PU-18-GXL
200-C125 BK-16-GXL 614-C12 PU-18-GXL 614-C22 PU-18-GXL
ATCH - AIR RIDE SEAT 118-C27 GY-16-GXL
614-C23 PU-18-GXL

200-C104 BK-14-GXL 124-C37 GN-18-GXL RH SPEAKER

118-C27 GY-16-GXL 614-C12 PU-18-GXL 124-C35 GN-14-GXL 124-C38 GN-14-GXL 1688772
506-C49 PU-18 +
511-C57 BR-18-GXL
503-C50 BR-16-GXL 124-C35 GN-14-GXL 512-C56 GN-18-GXL
504-C51 YL-16-GXL 124-C9 GN-14-GXL -
507-C52 WH-18 124-C36 GN-18-GXL
603-C4 PK-16
D BEACON
2353937 608-C17 GN-16
D
C-C11 608-C18 GN-16 200-C104 BK-14-GXL
1552269 200-C104 BK-14-GXL 200-C107 BK-16-GXL 521-C6 YL-18-GXL C-C19 (85) ARC SUPRESSOR 2
1 603-C4 PK-16 608-C2 GN-16-GXL 200-C124 BK-14-GXL 200-C106 BK-18-GXL 607-C3 PK-16-GXL 1552269 1893158
2 200-C109 BK-16 200-C103 BK-16-GXL 200-C105 BK-16-GXL 200-C125 BK-16-GXL 567-C68 WH-18-GXL 1
200-C102 BK-18-GXL 322-C5 GY-18 200-C129 BK-18-GXL 2 501-C53 GN-16-GXL
200-C109 BK-16 522-C7 WH-18-GXL 500-C48 BR-16-GXL C-C8 L-C1 L-C2
200-C110 BK-16 1552269 3E3364 1552269
(87) CAB GND
607-C19 PK-16 1 607-L1 PK-16 607-L3 PK-18 1 RF FLOODLIGHT
200-C108 BK-16
200-C101 BK-18
(106) AC/HEAT SW 200-C120 BK-16 2 200-L2 BK-16 200-L4 BK-18 2 2196487 WIRE GROUP COLOR DESCRIPTIONS
200-C103 BK-16-GXL 2364610
200-C126 BK-18 GROUND CIRCUIT
200-C128 BK-18 C-C2 L-C3
200-C127 BK-16-GXL 2234778 1552269 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
200-C125 BK-16-GXL C536-C43 PK-18-GXL 7 607-L5 PK-18 1 RF FLOODLIGHT DRUM WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
200-C124 BK-14-GXL 608-C2 GN-16-GXL 200-C115 BK-18-GXL 9 200-L6 BK-18 2 2196487
603-C4 PK-16 1 VOLTAGE CONVERTER OUTPUT CIRCUIT
1
614-C12 PU-18-GXL 2
567-C65 WH-18-GXL 2 STARTING CIRCUIT
3
3
4
4 DRUM LIGHT OPTION START AID CIRCUIT
5
RR FLOOODLIGHT
567-C64 WH-18-GXL
521-C6 YL-18-GXL
5
6
6
WIRES IN THE FOLLOWING
(AT EACH CORNER) MACHINE CONTROL CIRCUIT
2196487 C-C9 GROUPS SHALL BE TWISTED:
MONITOR CIRCUIT
1552269 200-C116 BK-18-GXL 8
ONE TWIST PER 25 MM.
569-C66 PK-18-GXL 10 ENGINE CONTROL CIRCUIT
1 608-C18 GN-16 614-C12 PU-18-GXL WIRE GROUP WIRE NAME
HEATER AND AIR CONDITIONER CIRCUIT
2 200-C108 BK-16 603-C4 PK-16 PC TW1 F711-PC4
TO CONNECTOR Y-C2 608-C2 GN-16-GXL PC TW1 F712-PC5 TURN SIGNAL / WIPER WASHER CIRCUIT
SEE VOL 1 LOC B-5 CAT DATA LINK
OPERATOR STATION CONN HARNESS ASSEMBLY CAN DATA LINK
CONN 13 322-C5 GY-18 IDENT LOC PART NO. ATCH GROUP NAME
C-C100 COMPACTION CONTROL CIRCUIT
NAME ID CLR 607-C3 PK-16-GXL RADIO CONNECTOR B C-10 391-5002 * * CONDITIONER GP *
3E5179 122-C1 BU-18-GXL C C-15 467-6291 O WIRING GP-CAB CAN DATA LINK 1 JPS DISPLAY
UNSWITCHED B+ 122 BU-18 1 122-C1 BU-18-GXL 118-C8 GY-14-GXL C-C5 NAME ID CLR H B-15 362-4305 O COMPRESSOR GP-J CAN DATA LINK 2 GPS RECEIVER
REAR WORK LIGHTS 608 GN-16 2 608-C2 GN-16-GXL A513-C10 PK-18-GXL 1552264 RADIO J E-12 362-4306 O SEAT GP-MTG&
CAN DATA LINK 0 GPS DISPLAY , CAN 1 GPS RECEIVER / ACCUGRADE
C FRONT WORK LIGHTS
BEACON LIGHT
607
603
PK-16
PK-18
3
4
607-C3 PK-16-GXL
603-C4 PK-16
592-C11 BU-18-GXL
124-C9 GN-14-GXL
509-C54 WH-18-GXL
508-C55 PU-18-GXL
1
2
LH SPK(-)
LH SPK(+)
509
508
WH-18
PU-18
1
2
WH/BK,GN/BK
WH,GN
LH SPK (-)
LH SPK (+)
L D-3 359-3632 A LIGTHING GP (04)
ETHERNET C
FORWARD WARNING HORN 322 GY-18 5 322-C5 GY-18 522-C7 WH-18-GXL 200-C114 BK-18-GXL 3 GROUND 200 BK-14 3 BK GROUND 389-0481
PN A-15 O WIRING GP-PLAT
521-C6 YL-18-GXL 521-C6 YL-18-GXL
COMP ON
COMP RTN
521
522
YL-18
WH-18
6
7 522-C7 WH-18-GXL
122-C14 BU-18-GXL 4 +24V UNSWITCHED 122 RD-16 4
PC B-7
389-3981
420-4997 O WIRING GP-PLAT
OTHER COLOR DESCRIPTIONS
A513-C40 PK-18-GXL 5 +12V UNSWITCHED(MEM) A513 PK-16 5 YL +12V MEM
WIPER POWER 118 GY-14 8 118-C8 GY-14-GXL 592-C41 BU-18-GXL 6 +12V SWITCHED 592 BU-16 6 RD +12 VOLT
HVAC POWER 124 GN-14 9 124-C9 GN-14-GXL * ITEM NOT CONTROLLED BY THIS SCHEMATIC. REFERECE ONLY. HIGHWAYS
512-C56 GN-18-GXL 7 RH SPK(-) 512 GN-18 7 GY/BK,PU/BK RH SPK (-)
12V RADIO UNSWITCHED A513 PK-18 10 A513-C10 PK-18-GXL 511-C57 BR-18-GXL 8 RH SPK(+) 511 BR-18 8 GY,PU RH SPK (+)
12V RADIO SWITCHED 592 BU-18 11 592-C11 BU-18-GXL ANTENNA
DASH BACK LIGHTS 614 PU-18 12 614-C12 PU-18-GXL (102) BLOWER RESISTOR
REF DIAGRAMS
CONDITIONER GP 3495835
B-C4
3505886 1.3
1
2603157
517-B3 BU-14
516-B2 GN-14 SYMBOL DESCRIPTION
0.8 2
3 C568-B12 WH-14 HVAC CON 511-C57 BR-18-GXL SCHEMATIC PART NUMBER: 355-3031, CHANGE: 06, VERSION: - (OPERATOR STATION)
0.4
4 515-B1 OR-14 508-C55 PU-18-GXL CIRCUIT CONNECTED
5 515-B11 OR-14 B-C1 NAME ID CLR C-C13 509-C54 WH-18-GXL
THERMAL FUSE
152 C 3E3388 1552264 522-C7 WH-18-GXL 512-C56 GN-18-GXL
(114) TEMP SWITCH CIRCUIT NOT CONNECTED
3E5464 515-B1 OR-14 1 FAN HIGH 515 OR-14 1 515-C58 GY-14-GXL 124-C36 GN-18-GXL
B-C3 516-B2 GN-14 2 FAN MED 516 GN-14 2 516-C59 GN-14-GXL 200-C104 BK-14-GXL 607-C19 PK-16 ELECTRICAL CONNECTION TO
7T6739 522-B5 WH-16 522-B5 WH-16 3 A/C COMP GND 522 WH-16 3 522-C7 WH-18-GXL 607-C3 PK-16-GXL 607-C20 PK-16 MACHINE STRUCTURE
1 200-B4 BK-16 200-B4 BK-16 200-B10 BK-14 A524-B7 PU-16 4 TEMP CONTROL SIGNAL A524 PU-16 4 A524-C61 BR-18-GXL 515-C58 GY-14-GXL
INTERNAL ELECTRICAL CONNECTION
2 522-B5 WH-16 200-B6 BK-14 200-B6 BK-14 5 GND 200 BK-14 5 200-C104 BK-14-GXL 517-C60 BU-14-GXL 200-C118 BK-16
TO SURFACE OF COMPONENT
200-B9 BK-16 517-B3 BU-14 6 FAN LOW 517 BU-14 6 517-C60 BU-14-GXL 516-C59 GN-14-GXL 200-C107 BK-16-GXL 200-C119 BK-18-GXL
T
TO CONNECTOR E-C24 592-B8 BR-16 7 POWER 592 BR-16 7 124-C36 GN-18-GXL A524-C61 BR-18-GXL 200-C120 BK-16 CONNECTOR
C568-B12 WH-14 8 FAN MED/HIGH C568 WH-14 8 C568-C67 WH-14-GXL C568-C67 WH-14-GXL
SEE VOL 1 C-8 322-C5 GY-18
H#
VEH AC CONN 592-B8 BR-16 CONN 16 200-C125 BK-16-GXL CIRCUIT GROUPING DESIGNATION

(107) AC PRESSURE SW CONN 7 A524-B7 PU-16 122-C16 BU-18-GXL

3553148 H-C2 H-C1 NAME ID CLR 200-C101 BK-18 ATCH WIRE, CABLE, COMPONENT
1552269 3E3364 B-C2
1552272 118-C29 GY-16-GXL
3 BK-16 1 521-H1 YL-18-GXL 1 COMP ON 521 YL-18 SPLICE
2
BK-16 2 513-H4 OR-18-GXL 2 COMP RTN 522 WH-18
POWER 1 592-B8 BR-16 (95) BLOWER MOTOR
CONTROL SIGNAL 2 A524-B7 PU-16 B-C5 4383170
1 BLADE, SPADE, RING OR SCREW
1552269
522-H2 WH-18-GXL

FEEDBACK 3 TERMINAL

B H-C3
(84) ARC SUPRESSOR 1 1552269
(117) WATER VALVE
GROUND 4 200-B9 BK-16 200-B10 BK-14
515-B11 OR-14
1
2
WH/RD-14
BK-14
MOTOR
B
1893158 1 513-H5 OR-18-GXL
2 522-H7 WH-18-GXL 2790850
ABBREV COLOR
RD RED
(105) COMPRESSOR GP
3201291 H-C4 WIRING GP-CAB WH WHITE
1552269 CALLOUTS
BK-18 1 513-H6 OR-18-GXL OR ORANGE
BK-18 2 522-H8 WH-18-GXL Do not operate or work on this product unless you have
SIDE CONSOLE 54 OPT CONN1
CONN 8 Callout Number Component
YL YELLOW
LR FLOODLIGHT read and understood the instruction and warnings in the
MAIN VEHICLE SCHEMATIC 2196487 PN-C4 NAME ID CLR PC-C1
TO CONNECTOR M-C5 relevant Operation and Maintenance Manuals and
(Machine Location from (52) VALVE GP - CONTROL Name
PK PINK
1552269 PN-C1 1673692 Component Locations Table)
ATCH - CAB AC 1 608-PN5 GN-18 1552269 UNSWITCHED B+ 122 BU 1 SEE VOL1 SEE LOC I-3 PC-C2 (92) FORWARD WARNING HORN relevant service literature. Failure to follow the instruc- 138-1234 Part Number
BK BLACK
1552269 3582293
2 200-PN204 BK-18 607-PN8 PK-18 1 LF FLOODLIGHT REAR WORK LIGHTS 608 GN 2 tions or heed the warnings could result in injury or
200-PN207 BK-18 2 2196487 FRONT WORK LIGHTS 607 PK 3 607-PC1 PK-18-GXL 322-PC2 GY-18-GXL 1 BK-18
death. Proper care is your responsibility. GY GRAY
BEACON LIGHT 603 PK 4 200-PC201 BK-18-GXL 2 BK-18
FORWARD WARNING HORN 322 GY 5 322-PC2 GY-18-GXL PU PURPLE
COMP ON 521 YL 6
608-PN5 GN-18 COMP RTN 522 WH 7 BR BROWN
608-PN6 GN-18 WIPER POWER 118 GY 8
200-PN200 BK-18 HVAC POWER 124 GN 9
GN GREEN
608-PN1 GN-16-GXL 200-PN203 BK-16-GXL 200-PN201 BK-16-GXL 12V RADIO UNSWITCHED A513 PK 10
BU BLUE
BEACON 12V RADIO SWITCHED 592 BU 11
2353937 200-PN204 BK-18 607-PN7 PK-18 (93) FORWARD WARNING HORN
DASH BACK LIGHTS 607 PK 12
PN-C5 200-PN205 BK-18 (88) PLAT GND 607-PN2 PK-16-GXL 607-PN8 PK-18 PN-C6 BATTERY 172 GN 13 200-PC201 BK-18-GXL
1552269 1552269 3582293
200-PN206 BK-18 SW POWER 176 PU 14 200-PC202 BK-18-GXL
1 603-PN3 PK-18 200-PN207 BK-18 322-PN4 GY-18 1 BK-18 ALT R TERM 403 GN 15 200-PC200 BK-16-GXL
2 200-PN205 BK-18 200-PN203 BK-16-GXL 608-PN1 GN-16-GXL 200-PN201 BK-16-GXL 200-PN208 BK-18 200-PN200 BK-18 2 BK-18 CAT DATA LINK (+) 944 OR 16 PC-C3
603-PN3 PK-18 CAT DATA LINK (-) 945 BR 17 1552269
603-PN3 PK-18 322-PN4 GY-18 SW POWER 111 WH 18 607-PC1 PK-18-GXL 1 RF FLOODLIGHT
200-PN200 BK-18 POWER 174 PK 19 200-PC202 BK-18-GXL 2 2196487
608-PN1 GN-16-GXL . . . 20
603-PN3 PK-18 . . . 21

A . . . 22 THIS SCHEMATIC IS FOR THE CP/CS56B, CP/CS68B, CP/CS74B, CP76B, CS78B AND CS79B ELECTRICAL SYSTEM A
322-PN4 GY-18 . . . 23
TO CONNECTOR YP-C2
SEE VOL 1 B-8 RR FLOOODLIGHT
607-PN2 PK-16-GXL .
.
.
.
.
.
24
25
VOLUME 2 of 4: OPERATOR ARRANGEMENTS
2196487 PN-C3 . . . 26
OPERATOR STATION CONN OPEN CONN 11 1552269 PN-C2
1552269
CAN (+) F711 YL 27 F711-PC4 YL-18-GXL MEDIA NUMBER: UENR6392-01
1 608-PN6 GN-18 CAN (-) F712 GN 28 F712-PC5 GN-18-GXL
NAME ID CLR PN-C7
1552272
2 200-PN206 BK-18 607-PN7 PK-18
200-PN208 BK-18
1
2
RF FLOODLIGHT
2196487
CAN (+)
CAN (-)
F711
F712
YL
GN
29
30
SCHEMATIC PART NUMBER: 453-5373, CHANGE: 01, VERSION: - (SIDE CONSOLE)
REAR WORK LIGHTS
FRONT WORK LIGHTS
608
607
GN-16
PK-16
1
2
608-PN1 GN-16-GXL
607-PN2 PK-16-GXL
CAN (SHIELD) 234 BK 31
200-PC200 BK-16-GXL
SCHEMATIC PART NUMBER: 355-3031, CHANGE: 06, VERSION: - (OPERATOR STATION)
377-2195
BEACON 603 PK-18 3 603-PN3 PK-18 REF DIAGRAMS Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
FORWARD WARNING HORN 322 GY-18 4 322-PN4 GY-18 in neutral and with parking brake set.
(89) PLAT GND
WIRING GP-PLATFORM WIRING GP-PLATFORM Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
(CANOPY/OPEN) (SHIPPING PLATFORM) Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 UENR6392-01
January 2019
Component Location - Volume 3
Schematic Machine
Component
Location Location
Antenna - GPS F-16 130
Antenna - GPS Cab 2 E-16 131
Antenna - GPS Platform 2 E-15 132

UENR6392-01 VOL 3 of 4
Control - Compaction I-13 133
Module - Display (CB460) E-8 134
Radio - GPS CR900 E-16 135
Radio - GPS CR900 (Sun Canopy) B-16 136
Receiver - GPS M972 F-16 137
Receiver - GPS M972 (Sun Canopy) D-16 138
Resistor - Can 1 C-8 139

(Dimensions: 56 inches x 35 inches)

Resistor - Can 2 E-16 140
Resistor - Can 2 (Sun Canopy) B-16 141
Resistor - Can1 Term 1 (Machine Drive Power) H-2 142
Resistor - Can1 Term 2 (Compaction Measurement) F-2 143
Resistor - Can1 Term 3 I-14 144
Sensor - Angle AccuGrade G-2 145
Sensor - Angle MDP H-2 146
Sensor - Axle MA Port J-1 147
Sensor - Axle MB Port J-1 148
Sensor - Compaction Measurement F-1 149
Sensor - Drum MA Port J-1 150
Sensor - Drum MB Port I-1 151
Sensor - MDP / CMV Combined I-2 152
Sensor - Vibratory Tachometer E-2 153

CP56B, CS56B, CP68B, CS68B, CP74B,

Item 131,131,135 and 136 are not shown, field installed components

CP76B, CS74B, CS78B and CS79B

Vibratory Soil Compactor
Connector Location - Volume 3
Connector Number
Schematic
Location
Electrical System
CONN 2 E-3
CONN 9
CONN 18
J-7
A-12 , F-15
CP56B: CS56B: CP68B: CS68B:
CONN 19 E-15, MP61-UP M561-UP CM61-UP M681-UP
CONN 20 A-12 , C-15,
CONN 21 B-15, 5081-UP 5071-UP 5101-UP 5091-UP

42 Page,
CONN 22 B-12,D-11,E-12
CONN 23 B-12,E-11,E-12
CONN 24 C-12,F-12,I-14 CP74B: CS74B: CS78B: CS79B:
CONN 25 D-12,F-12,J-14
CONN 26 C-11
5121-UP C741-UP 5131-UP CM71-UP
CONN 27 C-11 CP71-UP B7M1-UP M781-UP
CONN 28 G-6,H-7,I-6
CONN 29 E-2

The connectors shown in this chart are for harness to CP76B:

harness connectors. Connectors that join a harness to a
component are generally located at or near the component. J761-UP
145 See the Component Location Chart.

143

Volume 3 of 4: Compaction Measurement / CAT Grade Control

© 2019 Caterpillar, All Rights Reserved Printed in U.S.A.

COMPACTION MEASUREMENT ELECTRICAL SYSTEM

Harness And Wire Electrical Schematic Symbols

Symbols

Pressure Temperature Level Flow Circuit Breaker

CONN 2 Symbol Symbol Symbol Symbol Symbol

CONN 29 150 Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The
153 147 grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender

149 149 T
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a

coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.

146 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

Wire, Cable, or Harness Harness Identification Letter(s):
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
146 142 AG-C4
111-7898
L-C12
3E-5179
L-C12
harness (C1, C2, C3, ...).

3E-5179
152 Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
2
LH STEER CYLINDER
Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

COMPACTION MEASUREMENT MACHINE DRIVE POWER ELECTRICAL SYSTEM

CONN 22
CONN 9
CONN 23
138 CONN 24 144 137 130
CONN 18
CONN 25 CONN 28 CONN 19

CONN 27

CONN 26

CONN 26

CONN 27 139

144 CONN 20 CONN 22

CONN 21 CONN 28 134
141 133 134 140 CONN 23
139 CONN 25 133

CONN 24
CONN 9

CONTROL MODULES SUN CAB SUN CAB DISPLAY CONTROL MODULES ROPS / CAB ROPS / CAB DISPLAY
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

TO CONNECTOR AG-C1
SEE LOC F-12
UENR6392-01 VOL 3 of 4

OR
TO CONNECTOR AP-C1 ME-C3 (147) AXLE MA PORT
111-ME23 YL-18-GXL A452-ME6 PU-18-GXL
SEE LOC D-12 2370227 3491178
200-ME1 BK-18-GXL A453-ME7 PK-18-GXL
J A452-ME6 PU-18-GXL A454-ME8 GN-18-GXL J850-ME10 WH-18-GXL 1 +8V J
ACCUGRADE ATCH TO CONNECTOR Y-C4 A453-ME7 PK-18-GXL A455-ME9 YL-18-GXL J851-ME11 BR-18-GXL 2 GROUND
CONN 25 SEE VOL1 LOC A-5 A454-ME8 GN-18-GXL J850-ME10 WH-18-GXL A452-ME6 PU-18-GXL 3 SIGNAL
NAME ID CLR MG-C3 OR A455-ME9 YL-18-GXL J850-ME12 WH-18-GXL
1552272 TO CONNECTOR YP-C4 J850-ME14 WH-18-GXL
(Dimensions: 56 inches x 35 inches)

SW POWER 111 YL 1 111-MG25 YL-18-GXL SEE VOL1 LOC A-8 J850-ME2 WH-18-GXL J850-ME22 WH-18-GXL J850-ME16 WH-18-GXL ME-C4 (148) AXLE MB PORT
GROUND 200 BK 2 200-MG27 BK-18-GXL J851-ME11 BR-18-GXL 2370227 3491178
POWER 174 PK 3 174-MG20 PK-16-GXL 111-MG25 YL-18-GXL 111-MG25 YL-18-GXL 111-MG2 YL-18-GXL
CONN 9 MAIN ELEC PANEL J850-ME10 WH-18-GXL J851-ME13 BR-18-GXL J850-ME12 WH-18-GXL 1 +8V
. . . 4 174-MG20 PK-16-GXL 111-MG25 YL-18-GXL 174-MG20 PK-16-GXL 111-MG14 YL-18-GXL 111-MG18 YL-16-GXL J850-ME30 WH-18-GXL J850-ME12 WH-18-GXL J851-ME15 BR-18-GXL J851-ME13 BR-18-GXL 2 GROUND
200-MG27 BK-18-GXL 174-MG20 PK-16-GXL 200-MG27 BK-18-GXL 111-MG21 YL-18-GXL MG-C4 NAME ID CLR J850-ME14 WH-18-GXL J851-ME17 BR-18-GXL A453-ME7 PK-18-GXL 3 SIGNAL
355-3036 3E3382
REF DIAGRAMS 200-MG27 BK-18-GXL 111-MG25 YL-18-GXL J850-ME16 WH-18-GXL
111-MG2 YL-18-GXL 111-MG18 YL-16-GXL 1 SW POWER 111 YL ME-C1 111-ME23 YL-18-GXL
Y959-MG23 YL-18-GXL 111-MG14 YL-18-GXL 174-MG20 PK-16-GXL 200-MG19 BK-16-GXL 2 GROUND 200 BK 1552252 J851-ME11 BR-18-GXL 200-ME1 BK-18-GXL ME-C5 (150) DRUM MA PORT
Y959-MG28 YL-18-GXL Y959-MG8 YL-18-GXL Y960-MG24 GN-18-GXL 200-MG1 BK-18-GXL 174-MG20 PK-16-GXL 3 POWER 174 PK 1 111-ME23 YL-18-GXL J851-ME3 BR-18-GXL J851-ME13 BR-18-GXL J850-ME22 WH-18-GXL 2370227 3491178
Y959-MG23 YL-18-GXL 200-MG36 BK-18-GXL 200-MG1 BK-18-GXL F711-MG34 YL-18-GXL 4 CAN 0(+) F711 YL 2 200-ME1 BK-18-GXL J851-ME15 BR-18-GXL Y959-ME4 YL-18-GXL J850-ME14 WH-18-GXL 1 +8V
ACCUGRADE ATCH CAN 1 Y960-MG9 GN-18-GXL 200-MG37 BK-18-GXL 200-MG36 BK-18-GXL F712-MG35 GN-18-GXL 5 CAN 0(-) F712 GN 3 J850-ME2 WH-18-GXL J851-ME17 BR-18-GXL Y960-ME5 GN-18-GXL J851-ME15 BR-18-GXL 2 GROUND
CONN 24 Y959-MG8 YL-18-GXL F711-MG34 YL-18-GXL 200-MG37 BK-18-GXL 200-MG19 BK-16-GXL 6 CAN (SHIELD) 234 BK 4 J851-ME3 BR-18-GXL A454-ME8 GN-18-GXL 3 SIGNAL
NAME ID CLR (144) CAN1 TERM3 MG-C2 Y960-MG29 GN-18-GXL Y960-MG9 GN-18-GXL F712-MG35 GN-18-GXL 200-MG22 BK-18-GXL 5 Y959-ME4 YL-18-GXL Y959-ME4 YL-18-GXL
1342540 1740502 435-8065
Y960-MG24 GN-18-GXL 200-MG27 BK-18-GXL REF DIAGRAMS CONN 28 6 Y960-ME5 GN-18-GXL Y960-ME5 GN-18-GXL
CAN 1 (+) Y959 YL A Y959-MG28 YL-18-GXL 111-MG21 YL-18-GXL 7 A452-ME6 PU-18-GXL ME-C6 (151) DRUM MB PORT
CAN 1 (-) Y960 GN B Y960-MG29 GN-18-GXL 200-MG22 BK-18-GXL F711-MG34 YL-18-GXL 8 A453-ME7 PK-18-GXL 2370227 3491178
. . . C F712-MG35 GN-18-GXL 9 A454-ME8 GN-18-GXL J850-ME16 WH-18-GXL 1 +8V
10 A455-ME9 YL-18-GXL J851-ME17 BR-18-GXL 2 GROUND
355-3036
REF DIAGRAMS ACCUGRADE ATTACHMENT 11 A455-ME9 YL-18-GXL 3 SIGNAL
REPLACES RESISTOR 12
TO CONNECTOR AG-C2
SEE LOC F-12
OR
TO CONNECTOR AP-C2 (133) ECM COMPACTION CONTROL
SEE LOC C-12 4872836 MG-C5
I POWER GROUND - 1
2538112
200-MG1 BK-18-GXL
ME-C8
1552273
(152) SENSOR
3901735
I
POWER SUPPLY + 2 111-MG2 YL-18-GXL 111-ME23 YL-18-GXL 1 BK +BATTERY
CAN 0 + 3 F711-MG34 YL-18-GXL 200-ME29 BK-18-GXL 2 YL/GN GROUND
CAN 0 - 4 F712-MG35 GN-18-GXL Y959-ME25 YL-18-GXL 3 BK CAN 1 +
- 5 Y960-ME27 GN-18-GXL 4 BK CAN 1 -
- 6 5
- 7 6
8V SENSOR PWR 8 J850-MG6 WH-18-GXL
8V SENSOR RTN 9 J851-MG7 BR-18-GXL
- 10
POWER SUPPLY +
POWER GROUND -
11
12
111-MG14 YL-18-GXL
200-MG36 BK-18-GXL Y959-MG23 YL-18-GXL COMPATION MEASUREMENT
MDP/CMV COMBINED
CONN 28
-
-
13
14
Y959-MG8 YL-18-GXL
Y960-MG9 GN-18-GXL
Y960-MG24 GN-18-GXL 111-MG2 YL-18-GXL
111-MG14 YL-18-GXL MG-C1 NAME ID CLR 111-ME23 YL-18-GXL
SENSOR SELECT
- 15 111-MG2 YL-18-GXL 200-MG1 BK-18-GXL 1642336 200-ME29 BK-18-GXL
- 16 111-MG14 YL-18-GXL 200-MG36 BK-18-GXL 111-MG21 YL-18-GXL 1 SW POWER 111 YL 111-ME23 YL-18-GXL Y959-ME25 YL-18-GXL
(142) CAN 1 TERM1
42 Page,

- 17 200-MG1 BK-18-GXL 200-MG37 BK-18-GXL 200-MG22 BK-18-GXL 2 GROUND 200 BK Y960-ME27 GN-18-GXL ME-C7
- 18 111-MG2 YL-18-GXL 200-MG36 BK-18-GXL F711-MG34 YL-18-GXL 111-MG21 YL-18-GXL J850-MG6 WH-18-GXL 3 200-ME28 BK-18-GXL 1740502 1342540
SENSOR POWER J850 WH 200-ME1 BK-18-GXL
- 19 111-MG14 YL-18-GXL 200-MG37 BK-18-GXL F712-MG35 GN-18-GXL 111-MG21 YL-18-GXL 200-MG22 BK-18-GXL J851-MG7 BR-18-GXL 4 SENSOR RETURN J851 BR 200-ME29 BK-18-GXL Y959-ME18 YL-18-GXL A
- 20 200-MG1 BK-18-GXL A452-MG10 PU-18-GXL 200-MG22 BK-18-GXL A452-MG10 PU-18-GXL Y959-MG23 YL-18-GXL 5 CAN 1 (+) Y959 YL Y960-ME19 GN-18-GXL B
- 21 200-MG36 BK-18-GXL A453-MG11 PK-18-GXL A453-MG11 PK-18-GXL Y960-MG24 GN-18-GXL 6 CAN 1 (-) Y960 GN J850-ME22 WH-18-GXL Y959-ME18 YL-18-GXL C
- 22 200-MG37 BK-18-GXL A454-MG12 GN-18-GXL A452-MG10 PU-18-GXL A454-MG12 GN-18-GXL A452-MG10 PU-18-GXL 7 AXLE MA PRES A452 PU Y960-ME19 GN-18-GXL
- 23 A452-MG10 PU-18-GXL A455-MG13 YL-18-GXL A453-MG11 PK-18-GXL A455-MG13 YL-18-GXL A453-MG11 PK-18-GXL 8 AXLE MB PRES A453 PK Y959-ME4 YL-18-GXL Y959-ME18 YL-18-GXL
CAN 1 + 24 Y959-MG8 YL-18-GXL A453-MG11 PK-18-GXL F711-MG34 YL-18-GXL A454-MG12 GN-18-GXL J850-MG6 WH-18-GXL A454-MG12 GN-18-GXL 9 DRUM MA PRES A454 GN Y959-ME24 YL-18-GXL 200-ME28 BK-18-GXL
CAN 1 - 25 Y960-MG9 GN-18-GXL A454-MG12 GN-18-GXL F712-MG35 GN-18-GXL A455-MG13 YL-18-GXL J851-MG7 BR-18-GXL A455-MG13 YL-18-GXL 10 DRUM MB PRES A455 YL Y959-ME21 YL-18-GXL J850-ME22 WH-18-GXL
- 26 A455-MG13 YL-18-GXL J850-MG6 WH-18-GXL J850-MG6 WH-18-GXL Y959-MG23 YL-18-GXL 11 Y959-ME25 YL-18-GXL Y959-ME21 YL-18-GXL ME-C2 (146) ANGLE SENSOR MDP
. . .
- 27 F711-MG34 YL-18-GXL J851-MG7 BR-18-GXL J851-MG7 BR-18-GXL 12 1552273 3341658
Y960-MG24 GN-18-GXL . . . Y960-ME20 GN-18-GXL
- 28 F712-MG35 GN-18-GXL Y959-MG23 YL-18-GXL Y960-ME5 GN-18-GXL Y960-ME19 GN-18-GXL 200-ME28 BK-18-GXL 1 GROUND
- 29 J850-MG6 WH-18-GXL Y960-MG24 GN-18-GXL REF DIAGRAMS Y960-ME26 GN-18-GXL Y960-ME20 GN-18-GXL 2 CAN 1 LOW

H -
-
30
31
J851-MG7 BR-18-GXL Y960-ME20 GN-18-GXL
Y960-ME27 GN-18-GXL
3
4
SELECT A
SELECT B H
- 32 Y959-ME21 YL-18-GXL 5 CAN 1 HIGH
- 33 J850-ME22 WH-18-GXL 6 8V POWER
- 34
POWER GROUND - 35 200-MG37 BK-18-GXL
- 36
-
-
37
38
MACHINE HARNESS
DRUM PRES MA
DRUM PRES MB
39
40
A454-MG12 GN-18-GXL
A455-MG13 YL-18-GXL
MACHINE DRIVE POWER (MP)
- 41
- 42
- 43
- 44
- 45
- 46
- 47
- 48
AXLE PRES MA 49 A452-MG10 PU-18-GXL
AXLE PRES MB 50 A453-MG11 PK-18-GXL

OPERATOR STATION
HARNESS (MD)
111-MA1 YL-18-GXL MA-C3 (145) ANGLE SENSOR ACCUGRADE
1552273 3341658
MA-C1 200-MA2 BK-18-GXL 200-MA21 BK-18-GXL 200-MA20 BK-18-GXL 1 GROUND

G 1
1552252
111-MA1 YL-18-GXL
200-MA20 BK-18-GXL
200-MA19 BK-18-GXL
200-MA20 BK-18-GXL
J850-MA3 WH-18-GXL
Y960-MA16 GN-18-GXL 2
3
CAN 1 LOW
SELECT A
G
2 200-MA2 BK-18-GXL Y959-MA14 YL-18-GXL 4 SELECT B

COMPACTION CONN 28
3
4
5
J850-MA3 WH-18-GXL

Y959-MA5 YL-18-GXL Y959-MA5 YL-18-GXL

J850-MA3 WH-18-GXL

Y959-MA13 YL-18-GXL
Y960-MA16 GN-18-GXL

111-MA1 YL-18-GXL
Y959-MA14 YL-18-GXL
J850-MA3 WH-18-GXL
5
6
CAN 1 HIGH
8V POWER

SENSOR SELECT 6
7
Y960-MA6 GN-18-GXL Y959-MA14 YL-18-GXL 200-MA19 BK-18-GXL
200-MA21 BK-18-GXL
8
9
Y960-MA6 GN-18-GXL Y960-MA15 GN-18-GXL
Y960-MA16 GN-18-GXL
Y959-MA13 YL-18-GXL
Y960-MA15 GN-18-GXL
ACCUGRADE HIGH
10
11
ACCURACY ATCH
12

(137) GPS RECEIVER MS972 AG-C5 TO CONNECTOR MG-C3

362-9716 1552252 SEE LOC J-14
(130) GPS ANT BAT+ 1 111-AG9 YL-18-GXL
338-5535 BAT- 2 200-AG13 BK-18-GXL ACCUGRADE ATCH
COM 1 TXD 3 CONN 25
CAN 1 + 4 Y959-AG20 YL-18-GXL AG-C1 NAME ID CLR
COM 2 TXD 5 3E3376 MA-C2 (149) SENSOR
CAN 2+ 6 L857-AG44 GN-18-GXL 111-AG1 YL-18-GXL 1 SW POWER 111 YL 1552273 3901735
1

HH-C2
CAN 2- 7 L856-AG47 YL-18-GXL 111-AG7 YL-18-GXL 111-AG1 YL-18-GXL 200-AG2 BK-18-GXL 2 GROUND 200 BK 111-MA1 YL-18-GXL 1 BK +BATTERY
3476369 COM 2 RXD 8 111-AG9 YL-18-GXL 111-AG6 YL-18-GXL 174-AG3 PK-18-GXL 3 POWER 174 PK
200-MA19 BK-18-GXL 2 YL/GN GROUND
CAN 1- 9 Y960-AG30 GN-18-GXL 111-AG8 YL-18-GXL 4 . . C4
Y959-MA17 YL-18-GXL 3 BK CAN 1 +
COM 1 RXD 10
355-3035 Y960-MA24 GN-18-GXL 4 BK CAN 1 -
ID PIN 11 REF DIAGRAMS
BOOT MONITOR 12 200-AG13 BK-18-GXL 200-AG2 BK-18-GXL 111-MA1 YL-18-GXL 5
HH-C1 200-AG11 BK-18-GXL 200-AG10 BK-18-GXL 200-MA19 BK-18-GXL 111-MA1 YL-18-GXL 200-MA21 BK-18-GXL 6
3476370 200-AG14 BK-18-GXL ACCUGRADE ATCH CAN 1 200-MA21 BK-18-GXL 200-MA19 BK-18-GXL
GPS TNC 1 CONN 24 200-MA21 BK-18-GXL
174-AG53 PK-18-GXL 174-AG53 PK-18-GXL AG-C2 NAME ID CLR Y959-MA17 YL-18-GXL Y959-MA17 YL-18-GXL
H775-HH1 COAX LMR 200 L857-AG42 GN-18-GXL 174-AG3 PK-18-GXL 1330973
Y959-MA13 YL-18-GXL Y959-MA18 YL-18-GXL Y960-MA24 GN-18-GXL
F L857-AG44 GN-18-GXL
200-AG13 BK-18-GXL
174-AG52 PK-18-GXL Y959-AG4 YL-18-GXL
Y960-AG5 GN-18-GXL
A
B
CAN 1 (+)
CAN 1 (-)
Y959
Y960
YL
GN
F
AG-C6 200-AG11 BK-18-GXL C . . . Y960-MA24 GN-18-GXL Y959-MA18 YL-18-GXL
1552253 Y959-AG4 YL-18-GXL Y960-MA15 GN-18-GXL Y960-MA25 GN-18-GXL Y960-MA25 GN-18-GXL
355-3035 MA-C4 (143) CAN 1 TERM2
CONN 18 1 111-AG7 YL-18-GXL L856-AG45 YL-18-GXL Y959-AG24 YL-18-GXL REF DIAGRAMS
2 200-AG14 BK-18-GXL 1740502 1342540
TO CONNECTOR PR-C1 3 N961-AG16 OR-18-GXL 111-AG8 YL-18-GXL TO CONNECTOR MG-C2 Y959-MA18 YL-18-GXL A
SEE LOC A-12 4 Y959-AG24 YL-18-GXL Y959-AG20 YL-18-GXL Y959-AG21 YL-18-GXL SEE LOC I-14 Y960-MA25 GN-18-GXL B
5 Y960-AG34 GN-18-GXL Y959-AG20 YL-18-GXL
EXPANSION PORT 6 N962-AG19 BR-18-GXL Y959-AG23 YL-18-GXL
C

OPTION 7
8
F903-AG39 BR-18-GXL
Y788-AG17 GN-18-GXL
111-AG9 YL-18-GXL
Y960-AG30 GN-18-GXL
9 Y787-AG18 YL-18-GXL 111-AG7 YL-18-GXL Y959-AG27 YL-18-GXL Y959-AG22 YL-18-GXL
10 F904-AG38 PK-18-GXL 200-AG14 BK-18-GXL
11 Y960-AG37 GN-18-GXL
12
L856-AG47 YL-18-GXL
Y959-AG24 YL-18-GXL
MACHINE HARNESS
Y960-AG34 GN-18-GXL
Y959-AG27 YL-18-GXL Y960-AG5 GN-18-GXL
COMPACTION MEASUREMENT (MA)
N957-AG28 PK-18-GXL Y960-AG34 GN-18-GXL
(141) CAN RESISTOR 2 AG-C7 N960-AG29 OR-18-GXL
1342540 1740502
A L856-AG45 YL-18-GXL Y960-AG31 GN-18-GXL AG-C4
B L857-AG42 GN-18-GXL Y960-AG30 GN-18-GXL 3E5179
C 174-AG52 PK-18-GXL 1
N961-AG16 OR-18-GXL 200-AG10 BK-18-GXL 2
WIRES IN THE FOLLOWING
Y788-AG17 GN-18-GXL Y960-AG33 GN-18-GXL 111-AG6 YL-18-GXL 3
INTERCONNECT HARNESS CONN 19 Y787-AG18 YL-18-GXL Y960-AG37 GN-18-GXL Y960-AG32 GN-18-GXL Y959-AG22 YL-18-GXL 4
GROUPS SHALL BE TWISTED:
AVAILABLE FROM DEALER AG-C8 N962-AG19 BR-18-GXL Y960-AG32 GN-18-GXL 5 CONN 23 ONE TWIST PER 25 MM.
2370164 F904-AG38 PK-18-GXL N957-AG28 PK-18-GXL 6 WIRE GROUP WIRE NAME
1 111-AG8 YL-18-GXL F903-AG39 BR-18-GXL N960-AG29 OR-18-GXL 7
(135) RADIO GPS CR900 2 200-AG11 BK-18-GXL L857-AG43 GN-18-GXL 8
MA TW1 Y959-MA5
305-6191 3 N960-AG29 OR-18-GXL U802-AG48 WH-18-GXL L856-AG46 YL-18-GXL 9 MA TW1 Y960-MA6
E + BATTERY
GROUND
4
5
Y959-AG27 YL-18-GXL
U802-AG48 WH-18-GXL
U803-AG49
U804-AG50
GN-18-GXL
BR-18-GXL L857-AG42 GN-18-GXL
L857-AG43 GN-18-GXL Y788-AG17 GN-18-GXL
Y787-AG18 YL-18-GXL
10
11
MA TW2 Y959-MA13 E
COM 2 TXD 6 U803-AG49 GN-18-GXL U805-AG51 BU-18-GXL L857-AG44 GN-18-GXL 12 MA TW2 Y960-MA15
COM 2 RXD 7 U804-AG50 BR-18-GXL MA TW3 Y959-MA14
CAN 1 (+) 8 U805-AG51 BU-18-GXL
COM 1 TXD 9 Y960-AG37 GN-18-GXL L856-AG46 YL-18-GXL AG-C3 MA TW3 Y960-MA16
COM 1 RXD 10 N957-AG28 PK-18-GXL L856-AG45 YL-18-GXL 3E3388
MA TW4 Y959-MA18 TO CONNECTOR E-C27
CAN 1 (-) 11 L856-AG47 YL-18-GXL N961-AG16 OR-18-GXL 1
12 174-AG53 PK-18-GXL N962-AG19 BR-18-GXL 2 AC-C2 MA TW4 Y960-MA25 SEE VOL1 LOC H-9
F904-AG38 PK-18-GXL 3 CONN 22 1552252
MA TW5 Y959-MA17 VARI VIBE MACH CONN
GPS TNC F903-AG39 BR-18-GXL 4 1 174-AC1 PK-18-GXL CONN 2 CONN 29
U802-AG48 WH-18-GXL 5 2 200-AC6 BK-18-GXL MA TW5 Y960-MA24
U803-AG49 GN-18-GXL 6 3 111-AC5 YL-18-GXL MC TW1 234-MC26 NAME ID CLR MV-C1 MV-C2 MW-C1
(131) GPS ANT2 CAB (132) GPS ANT2 PLAT N957-AG28 PK-18-GXL U804-AG50 BR-18-GXL 7 4 Y959-AC20 YL-18-GXL 3E3364 1552269 3E3364
290-2770 290-2770 U805-AG51 BU-18-GXL 8 CONN 23 5 Y960-AC25 GN-18-GXL WIRES IN THE FOLLOWING
MC TW2 Y959-MC29
WIRES IN THE FOLLOWING VIBE TACH SIGNAL 450 YL-18 1 450-MV1 YL-16 1 450-MW1 YL-16
6 N957-AC42 PK-18-GXL GROUPS SHALL BE TWISTED: GROUPS SHALL BE TWISTED: MC TW2 Y960-MC31 GROUND 200 BK-18 2 200-MV2 BK-16 2 200-MW2 BK-16
7 N960-AC43 OR-18-GXL ONE TWIST PER 25 MM. ONE TWIST PER 25 MM.
8 L857-AC30 GN-18-GXL MC TW3 F711-MC24 355-3029
(153) VIB TACH SENSOR
AC-C3 (134) DISPLAY IC WIRE GROUP WIRE NAME WIRE GROUP WIRE NAME REF DIAGRAMS 7R3145
N960-AG29 OR-18-GXL 9 L856-AC31 YL-18-GXL MC TW3 F712-MC25
1

10 Y788-AC41 GN-18-GXL 2485358 349-4610 AC TW1 Y787-AC40 AG TW6 Y959-AG24

JJ-C2 KK-C2
11 Y787-AC40 YL-18-GXL A SWITCH GND AC TW1 Y788-AC41 AG TW6 Y960-AG34
MC TW4 Y959-MC28
3476378 3476377
JJ-C1 KK-C1 12 J992-AC58 YL-18-GXL B SWITCH INPUT 0
AC TW10 U802-AC54 AG TW7 L856-AG46 MC TW4 Y960-MC30
3476375 3476375 N961-AG16 OR-18-GXL J993-AC59 PK-18-GXL J994-AC60 GY-18-GXL C SWITCH INPUT 3
1 1 Y788-AG17
Y787-AG18
GN-18-GXL
YL-18-GXL AC-C4
J994-AC60
J995-AC61
GY-18-GXL
PU-18-GXL
174-AC3 PK-18-GXL
C250-AC32 BK-18-GXL
D
E
BAT +
SWITCH COMMON GND
AC TW10
AC TW11
U803-AC55
U804-AC56
AG TW7
AG TW8
L857-AG43
N957-AG28
MC TW5
MC TW5
Y959-MC5
Y960-MC6
VIBE SPEED SENSOR
H775-JJ1 COAX LMR 200 H775-KK1 COAX LMR 200 N962-AG19
F904-AG38
BR-18-GXL
PK-18-GXL 1
1552264
N961-AC52 OR-18-GXL U802-AC54 WH-18-GXL
200-AC8 BK-18-GXL F
G
BAT - AC TW11 U805-AC57 AG TW8 N960-AG29 ME TW1 Y959-ME4 (VARI FREQ VIBE)
F903-AG39 BR-18-GXL 2 N962-AC53 BR-18-GXL U803-AC55 GN-18-GXL J995-AC61 PU-18-GXL H SWITCH INPUT 4
AC TW2 N957-AC42 AG TW9 Y959-AG27 ME TW1 Y960-ME5
CAB HIGH ACCURACY PLAT HIGH ACCURACY CONN 22 3 F904-AC50 PK-18-GXL U804-AC56 BR-18-GXL Y960-AC27 GN-18-GXL J CAN 0- AC TW2 N960-AC43 AG TW9 Y960-AG37
ME TW2 Y959-ME21
U802-AG48 WH-18-GXL 4 F903-AC51 BR-18-GXL U805-AC57 BU-18-GXL Y959-AC21 YL-18-GXL K CAN 0+ AC TW3 N961-AC52 AP TW1 Y959-AP14
RADIO ANTENNA RADIO ANTENNA U803-AG49 GN-18-GXL 5 U802-AC54 WH-18-GXL Y787-AC40 YL-18-GXL L CAN 1+ ME TW2 Y960-ME20
AC TW3 N962-AC53 AP TW1 Y960-AP15
U804-AG50 BR-18-GXL 6 U803-AC55 GN-18-GXL 111-AC5 YL-18-GXL Y788-AC41 GN-18-GXL M CAN 1-
ME TW3 Y959-ME18
U805-AG51 BU-18-GXL 7 U804-AC56 BR-18-GXL N957-AC42 PK-18-GXL N961-AC52 OR-18-GXL N RS-232 TXD 2 AC TW4 Y959-AC20 AP TW11 L856-AP9
8 U805-AC57 BU-18-GXL N960-AC43 OR-18-GXL N962-AC53 BR-18-GXL P RS-232 RXD 2 AC TW4 Y960-AC25 AP TW11 L857-AP8 ME TW3 Y960-ME19
N961-AC52 OR-18-GXL R RS-232 SGND 2 ME TW4 Y959-ME24
D WIRING GP 174-AC2 PK-18-GXL
Y788-AC41 GN-18-GXL
Y787-AC40 YL-18-GXL F904-AC50 PK-18-GXL
S
T
RS-232 SGND 1
RS-232 RXD 1
AC TW5
AC TW5
Y959-AC21
Y960-AC27
AP TW12
AP TW12
L856-AP34
L857-AP35 ME TW4 Y960-ME26
D
200-AC7 BK-18-GXL N962-AC53 BR-18-GXL F903-AC51 BR-18-GXL U RS-232 TXD 1 AC TW6 Y959-AC22 AP TW13 L856-AP19 ME TW5 Y959-ME25
Y960-AC26 GN-18-GXL F904-AC50 PK-18-GXL V SWITCH INPUT 5 AC TW6 Y960-AC26 AP TW13 L857-AP18
Y959-AC22 YL-18-GXL F903-AC51 BR-18-GXL 174-AC4 PK-18-GXL W +BATTERY ME TW5 Y960-ME27
(138) GPS RECEIVER MS972 AP-C5 TO CONNECTOR MG-C3 200-AC11 BK-18-GXL 111-AC5 YL-18-GXL AC TW7 Y959-AC24 AP TW14 Y787-AP11
X WAKEUP MG TW1 Y959-MG8
362-9716 1552252 SEE LOC J-14 L857-AC30 GN-18-GXL J992-AC58 YL-18-GXL Y SWITCH INPUT 1 AC TW7 Y960-AC29 AP TW14 Y788-AP10
BAT+ 1 111-AP16 YL-18-GXL L856-AC31 YL-18-GXL C250-AC62 BK-18-GXL Z SWITCH INPUT 6 MG TW1 Y960-MG9
AC TW8 Y959-AC23 AP TW15 N961-AP21
BAT- 2 200-AP202 BK-18-GXL GRADE CONTROL LRC OPEN 174-AC1 PK-18-GXL 174-AC3 PK-18-GXL U804-AC56 BR-18-GXL AA ETHERNET RX+ MG TW2 Y959-MG28
COM 1 TXD 3 CONN 25 J992-AC58 YL-18-GXL 174-AC2 PK-18-GXL 174-AC4 PK-18-GXL U805-AC57 BU-18-GXL BB ETHERNET RX-
AC TW8 Y960-AC28 AP TW15 N962-AP22
CAN 1 + 4 Y959-AP17 YL-18-GXL AP-C1 NAME ID CLR J993-AC59 PK-18-GXL U802-AC54 WH-18-GXL CC ETHERNET TX+ AC TW9 L856-AC31 AP TW16 F903-AP24 MG TW2 Y960-MG29
3E3376 HARNESS ASSEMBLY
COM 2 TXD 5 J994-AC60 GY-18-GXL U803-AC55 GN-18-GXL DD ETHERNET TX- AC TW9 L857-AC30 AP TW16 F904-AP23 MG TW3 Y959-MG23
IDENT SH/LOC PART NO. ATCH GROUP NAME
CAN 2+ 6 L857-AP18 GN-18-GXL 111-AP13 YL-18-GXL 1 SW POWER 111 YL J995-AC61 PU-18-GXL EE CAN SHIELD
AG TW1 Y959-AG4 AP TW17 U802-AP25 MG TW3 Y960-MG24 MA 359-7571 A SENSOR GP-MOUNTING
CAN 2- 7 L856-AP19 YL-18-GXL 200-AP200 BK-18-GXL 2 GROUND 200 BK C250-AC63 BK-18-GXL 200-AC6 BK-18-GXL 200-AC10 BK-18-GXL FF RS-232 RTS 0
COM 2 RXD 8 174-AP1 PK-18-GXL 3 POWER 174 PK 200-AC7 BK-18-GXL 200-AC8 BK-18-GXL GG RS-232 CTS 0 AG TW1 Y960-AG5 AP TW17 U803-AP26 MG TW4 F711-MG34 MA 379-8301 A SENSOR GP-MOUNTING (LRC)
CAN 1- 9 Y960-AP20 GN-18-GXL 4 . . C4 200-AC11 BK-18-GXL 200-AC9 BK-18-GXL N957-AC42 PK-18-GXL HH RS-232 RXD 0 AG TW10 L856-AG47 AP TW18 U804-AP27 MC 359-7587 A SENSOR GP-MOUNTING, SENSOR GP-PRESSURE
AC-C1 MG TW4 F712-MG35
COM 1 RXD 10
355-3035
N960-AC43 OR-18-GXL II RS-232 TXD 0 AG TW10 L857-AG44 AP TW18 U805-AP28 SENSOR GP-MOUNTING, SENSOR GP-PRESSURE
ID PIN 11 REF DIAGRAMS 1552252 JJ SWITCH OUTPUT MP TW1 Y959-MP5 MC 418-7851 A
(OPEN PLATFORM/SUN CANOPY LRC)
BOOT MONITOR 12 174-AC2 PK-18-GXL 1 J993-AC59 PK-18-GXL KK SWITCH INPUT 2
AG TW12 L856-AG45 AP TW2 Y959-AP31
AG TW12 L857-AG42 AP TW2 Y960-AP32
MP TW1 Y960-MP6 MP 359-7570 A SENSOR GP-PRESSURE
200-AC7 BK-18-GXL 2
CONN 26 Y959-AC20 YL-18-GXL Y959-AC21 YL-18-GXL 200-AC9 BK-18-GXL MM BAT-
MP TW2 Y959-MP21 MP 418-1430 A SENSOR GP-PRESSURE (LRC)
GRADE CONTROL LRC OPEN CAN 1 3 Y959-AC23 YL-18-GXL NN AWAKE RETURN AG TW15 Y787-AG18 AP TW3 Y959-AP41
GPS TNC
CONN 24 Y959-AC22 YL-18-GXL 4 PP AWAKE MP 359-7576 A SENSOR GP-PRESSURE (98kW)
AG TW15 Y788-AG17 AP TW3 Y960-AP43 MP TW2 Y960-MP23
AP-C2
1330973
NAME ID CLR Y960-AC26 GN-18-GXL 5 UTS CONNECTION 200-AC10 BK-18-GXL QQ RS-232 SGND 0
AG TW16 N961-AG16 AP TW4 Y959-AP17 MP TW3 Y959-MP22
MP
MV
379-8300
426-0862
A
A
SENSOR GP-PRESSURE (98kW LRC)
SENSOR GP-VIB
6 Y959-AC22 YL-18-GXL RR
111-AP29 YL-18-GXL 111-AP13 YL-18-GXL Y959-AP14 YL-18-GXL A CAN 1 (+) Y959 YL 7 OPTION Y959-AC24 YL-18-GXL AG TW16 N962-AG19 AP TW4 Y960-AP20 MP TW3 Y960-MP24 MW 426-0863 A SENSOR GP-VIB
111-AP16 YL-18-GXL 111-AP3 YL-18-GXL Y960-AP15 GN-18-GXL B CAN 1 (-) Y960 GN 8
AG TW17 F903-AG39 AP TW5 Y959-AP42 MW 426-0864 A SENSOR GP-VIB
CABLE GOES BETWEEN RECEIVER 111-AP36 YL-18-GXL C . . . 9 Y960-AC27 GN-18-GXL MV TW1 200-MV2
T 373-4810 A RECORDING MODULE SPEED SENSOR
AND HH CABLE ON OPEN PLATFORM AND 200-AC11 BK-18-GXL 10 Y960-AC25 GN-18-GXL AG TW17 F904-AG38 AP TW5 Y960-AP44
355-3035 MV TW1 450-MV1 U 359-7578 A RECORDING MODULE (FIXED FREQUENCY)
SUN CANOPY MACHINES REF DIAGRAMS L857-AC30 GN-18-GXL 11 Y960-AC28 GN-18-GXL AG TW18 U802-AG48 AP TW6 Y959-AP39
200-AP202 BK-18-GXL 200-AP200 BK-18-GXL L856-AC31 YL-18-GXL 12 MW TW1 200-MW2 V 359-7579 A RECORDING MODULE (VARIABLE FREQUENCY)
AG TW18 U803-AG49 AP TW6 Y960-AP40 ME 444-5935 A SENSOR GP-MOUNTING, SENSOR GP-PRESSURE
LL-C1 LL-C2 200-AP204 BK-18-GXL 200-AP201 BK-18-GXL TO CONNECTOR MG-C2 MW TW1 450-MW1
3476370 3476372 200-AP203 BK-18-GXL SEE LOC I-14 Y960-AC26 GN-18-GXL AG TW19 U804-AG50 AP TW7 Y959-AP4 ME 444-5936 A SENSOR GP-MOUNTING, SENSOR GP-PRESSURE
1 H775-LL1 COAX LMR 200 1 174-AP46 PK-18-GXL Y960-AC29 GN-18-GXL AG TW19 U805-AG51 AP TW7 Y960-AP5 T TW1 C973-T3 MG 492-7028 A SENSOR GP-MOUNTING, SENSOR GP-PRESSURE
AC-C5 (139) CAN RESISTOR 1
L857-AP35 GN-18-GXL 174-AP46 PK-18-GXL
1342540 AG TW2 Y959-AG20 AP TW8 N957-AP6 T TW1 C974-T4
C L857-AP18
200-AP202
GN-18-GXL
BK-18-GXL
174-AP1 PK-18-GXL
174-AP45 PK-18-GXL
AC-C6
1552264 C250-AC63 BK-18-GXL C250-AC32 BK-18-GXL Y959-AC24 YL-18-GXL
1740502
A REUSE CAN RESISTOR
AG TW2 Y960-AG30 AP TW8 N960-AP7 U TW1 C973-U5 C
200-AP204 BK-18-GXL 1 CONN 27 C250-AC62 BK-18-GXL Y960-AC29 GN-18-GXL B FROM SENSOR GP AG TW3 Y959-AG21 PR TW1 N957-PR2 U TW1 C974-U6
Y959-AP14 YL-18-GXL J992-AC58 YL-18-GXL 2 C AG TW3 Y960-AG31 PR TW1 N961-PR1
UNDER SEAT (OPEN/CANOPY) L856-AP34 YL-18-GXL J993-AC59 PK-18-GXL 3 EXTERNAL SWITCHES V TW1 C973-V5
AG TW4 Y959-AG22 PR TW2 N957-PR5
GPS RECEIVER ANTENNA Y959-AP31 YL-18-GXL J994-AC60 GY-18-GXL 4
CONNECTION L857-AC30 GN-18-GXL
AG TW4 Y960-AG32 PR TW2 N961-PR4
V TW1 C974-V6
111-AP36 YL-18-GXL J995-AC61 PU-18-GXL 5
Y959-AP17 YL-18-GXL 6 AG TW5 Y959-AG23 SCHEMATIC PART NUMBER: 355-3035, CHANGE: 07, VERSION: - (COMPACTION MEASUREMENT)
Y959-AP41 YL-18-GXL 7 L856-AC31 YL-18-GXL AG TW5 Y960-AG33
C250-AC63 BK-18-GXL 8
Y959-AP17 YL-18-GXL
AP-C6 Y960-AP20 GN-18-GXL Y959-AP42 YL-18-GXL
1552253 111-AP29 YL-18-GXL
1 111-AP29
200-AP203
YL-18-GXL
BK-18-GXL
200-AP203
Y960-AP40
BK-18-GXL
GN-18-GXL
Y959-AP4 YL-18-GXL AP-C4
1642336 MOUNTING GP-DISPLAY SYMBOL DESCRIPTION
CONN 20 2

TO CONNECTOR PR-C1 3 N961-AP21 OR-18-GXL Y959-AP39 YL-18-GXL 174-AP45 PK-18-GXL 1

CIRCUIT CONNECTED
SEE LOC A-12
4 Y959-AP31 YL-18-GXL L856-AP19 YL-18-GXL 200-AP201 BK-18-GXL 2
5 Y960-AP32 GN-18-GXL Y959-AP31 YL-18-GXL 111-AP3 YL-18-GXL 3
CIRCUIT NOT CONNECTED
EXPANSION PORT 6 N962-AP22 BR-18-GXL Y960-AP32 GN-18-GXL Y959-AP4 YL-18-GXL 4
7 F903-AP24 BR-18-GXL 111-AP16 YL-18-GXL Y960-AP15 GN-18-GXL Y960-AP5 GN-18-GXL 5 CONN 23 ELECTRICAL CONNECTION TO
OPTION 8 Y788-AP10 GN-18-GXL Y959-AP39 YL-18-GXL Y960-AP32 GN-18-GXL N957-AP6 PK-18-GXL 6 MACHINE STRUCTURE
9 Y787-AP11 YL-18-GXL N957-AP6 PK-18-GXL N960-AP7 OR-18-GXL 7
INTERNAL ELECTRICAL CONNECTION
10 F904-AP23 PK-18-GXL N960-AP7 OR-18-GXL L857-AP8 GN-18-GXL 8 TO SURFACE OF COMPONENT
11 Y960-AP43 GN-18-GXL L856-AP9 YL-18-GXL 9
Y788-AP10 GN-18-GXL
12
Y960-AP20 GN-18-GXL Y787-AP11 YL-18-GXL
10
11
WIRE GROUP COLOR DESCRIPTIONS CONNECTOR

N961-AP21 OR-18-GXL 12
GROUND CIRCUIT H# CIRCUIT GROUPING DESIGNATION
Y788-AP10 GN-18-GXL
Y787-AP11 YL-18-GXL Y960-AP44 GN-18-GXL Y960-AP5 GN-18-GXL WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
AP-C3 CABLE/ WIRE ASSEMBLY LIST ATCH WIRE, CABLE, COMPONENT
N962-AP22 BR-18-GXL ROUTING PATH WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
(140) CAN RESISTOR 2 AP-C7 F904-AP23 PK-18-GXL Y960-AP40 GN-18-GXL 1950534 IDENT PART NO. GAGE
1342540 1740502 END #1 SH/LOC END #2 SH/LOC VOLTAGE CONVERTER OUTPUT CIRCUIT SPLICE
F903-AP24 BR-18-GXL N961-AP21 OR-18-GXL 1
HH 362-4311 N/A GPS RECEIVER F8 GPS ANTENNA F9
A L856-AP34 YL-18-GXL N962-AP22 BR-18-GXL 2 STARTING CIRCUIT
HH 362-4312 N/A GPS RECEIVER F8 GPS ANTENNA F9 BLADE, SPADE, RING OR SCREW
B L857-AP35 GN-18-GXL U802-AP25 WH-18-GXL F904-AP23 PK-18-GXL 3 CONN 22 JJ 362-4313 N/A HIGH ACCURACY RADIO D8 HIGH ACCURACY ANTENNA D9 START AID CIRCUIT TERMINAL

B C U803-AP26
U804-AP27
GN-18-GXL
BR-18-GXL L857-AP8 GN-18-GXL
F903-AP24
U802-AP25
BR-18-GXL
WH-18-GXL
4
5
KK
LL
362-4314
379-8315
N/A
N/A
HIGH ACCURACY RADIO
GPS RECEIVER
D7
C8
HIGH ACCURACY ANTENNA
UNDER SEAT PANEL BLUKHEAD
D8
C8
MACHINE CONTROL CIRCUIT B
U805-AP28 BU-18-GXL L857-AP18 GN-18-GXL U803-AP26 GN-18-GXL 6 MONITOR CIRCUIT
INTERCONNECT HARNESS CONN 21 L857-AP35 GN-18-GXL U804-AP27 BR-18-GXL 7
MM 379-8316 N/A HIGH ACCURACY RADIO A8 UNDER SEAT PANEL BLUKHEAD A8
AP-C8 HH 379-8317 N/A UNDER SEAT PANEL BLUKHEAD F8 GPS ANTENNA F9 ENGINE CONTROL CIRCUIT
AVAILABLE FROM DEALER
2370164
U805-AP28 BU-18-GXL 8
KK 379-8318 N/A UNDER SEAT PANEL BLUKHEAD D7 HIGH ACCURACY ANTENNA D8 HEATER AND AIR CONDITIONER CIRCUIT
ABBREV COLOR
1 111-AP36 YL-18-GXL L856-AP9 YL-18-GXL TURN SIGNAL / WIPER WASHER CIRCUIT RD RED
(136) RADIO GPS CR900 2 200-AP204 BK-18-GXL L856-AP19 YL-18-GXL HARNESS ASSEMBLY CAT DATA LINK WH WHITE
305-6191 3 N960-AP7 OR-18-GXL L856-AP34 YL-18-GXL IDENT SH/LOC PART NO. ATCH GROUP NAME
+ BATTERY 4 Y959-AP39 YL-18-GXL CAN DATA LINK
GROUND 5 U802-AP25 WH-18-GXL
AC B3 399-9416 A MOUNTING GP-INSTR -A
COMPACTION CONTROL CIRCUIT
OR ORANGE
AG D7 399-9415 A WIRING GP
COM 2 TXD 6 U803-AP26 GN-18-GXL
COM 2 RXD 7 U804-AP27 BR-18-GXL
AC B3 415-7961 A MOUNTING GP-INSTR -A CAN DATA LINK 1 JPS DISPLAY YL YELLOW
AP A7 415-7960 A WIRING GP
CAN 1 (+) 8 U805-AP28 BU-18-GXL CAN DATA LINK 2 GPS RECEIVER PK PINK
PR A5 483-5927 A WIRING GP
COM 1 TXD 9 Y960-AP40 GN-18-GXL N957-AP6 PK-18-GXL CAN DATA LINK 0 GPS DISPLAY , CAN 1 GPS RECEIVER / ACCUGRADE CALLOUTS
COM 1 RXD 10 N957-AP6 PK-18-GXL BK BLACK
CAN 1 (-) 11 ETHERNET
12 174-AP46 PK-18-GXL Callout Number Component
GY GRAY
OTHER COLOR DESCRIPTIONS (Machine Location from (52) VALVE GP - CONTROL Name
PU PURPLE
GPS TNC N960-AP7 OR-18-GXL Component Locations Table)
HIGHWAYS 138-1234 Part Number
BR BROWN
GN GREEN
N961-AP21 OR-18-GXL
CABLE GOES BETWEEN RADIO Y788-AP10 GN-18-GXL PR-C1 BU BLUE
AND JJ OR KK CABLE ON OPEN PLATFORM Y787-AP11 YL-18-GXL 1907612 PR-C2
AND SUN CANOPY MACHINES N962-AP22 BR-18-GXL 1 4835928
F904-AP23 PK-18-GXL 2 N980-PR3 GN-18-GXL N980-PR6 GN-20-GXL 1
MM-C1 MM-C2 F903-AP24 BR-18-GXL CONN 18 3 N961-PR1 OR-18-GXL N961-PR4 OR-20-GXL N957-PR5 PK-20-GXL 2
3476375 3476377 TO CONNECTOR AG-C6 4 N961-PR4 OR-20-GXL 3 MATE WITH PRINTER
1 H775-MM1 COAX LMR 200 1 U802-AP25 WH-18-GXL SEE LOC F-15 5 4 CONNECTOR
U803-AP26 GN-18-GXL 6 N957-PR2 PK-18-GXL N957-PR5 PK-20-GXL N980-PR6 GN-20-GXL 5
U804-AP27 BR-18-GXL 7 6
U805-AP28 BU-18-GXL CONN 20 8 7

A OR CONNECTOR AP-C6
9
10
8
9
THIS SCHEMATIC IS FOR THE CP/CS56B, CP/CS68B, CP/CS74B, CP76B, CS78B AND CS79B ELECTRICAL SYSTEM A
UNDER SEAT (OPEN/CANOPY) SEE LOC C-15 11
Do not operate or work on this product unless you have
HIGH ACCURACY RADIO ANTENNA 12 read and understood the instruction and warnings in the VOLUME 3 of 4: CAT GRADE CONTROL / COMPACTION MEASUREMENT
relevant Operation and Maintenance Manuals and
ATCH PRINTER relevant service literature. Failure to follow the instruc- MEDIA NUMBER: UENR6392-01
WIRING GP tions or heed the warnings could result in injury or
SUN CANOPY death. Proper care is your responsibility. SCHEMATIC PART NUMBER: 355-3036, CHANGE: 06, VERSION: - (CGC)
SCHEMATIC PART NUMBER: 355-3036, CHANGE: 06, VERSION: - (CAT GRADE CONTROL) SCHEMATIC PART NUMBER: 355-3035, CHANGE: 07, VERSION: - (COMPACTION MEASUREMENT)
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 UENR6392-01
January 2019
Harness And Wire Electrical Schematic Symbols
Symbols

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.

CP56B, CS56B, CP68B, CS68B, CP74B,

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

CP76B CS74B, CS78B and CS79B

Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.

Vibratory Soil Compactor Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

Electrical System
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a

coil that makes an electromagnet when current flows through it. The electromagnet
CP56B: CS56B: CP68B: CS68B: can open or close a valve or move a piece of metal that can do work.

MP61-UP M561-UP CM61-UP M681-UP Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
5081-UP 5071-UP 5101-UP 5091-UP activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
CP74B: CS74B: CS78B: CS79B:
Harness and Wire Symbols
5121-UP C741-UP 5131-UP CM71-UP Wire, Cable, or Harness Harness Identification Letter(s):
CP71-UP B7M1-UP M781-UP Assembly Identification: Includes
Harness Identification Letters and
(A, B, C, ..., AA, AB, AC, ...)
Harness Connector Serialization Code:
Harness Connector Serialization
The "C" stands for "Connector" and the
Codes (see sample).
number indicates which connector in the
harness (C1, C2, C3, ...).
CP76B: AG-C4
111-7898
L-C12
3E-5179
L-C12
3E-5179
J761-UP Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
2
Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
Volume 4 of 4: Engine 1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle
Harness identification code:
This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

© 2019 Caterpillar, All Rights Reserved Printed in U.S.A.

UENR6392-01 VOL 4 of 4
CONN 42
206 205

(Dimensions: 18 inches x 24 inches)

209 204

200 201 CONN 41

CONN 40
207
203

202
208

ENGINE REAR ENGINE TOP

8 Page,

Component Location
Schem atic Machine
Com ponent Connector Location
Location Location
Schem atic
ECM - Engine E-5 200 Connector Num ber
Location
Sensor - Cam Speed D-1 201
CONN 40 E-2
Sensor - Crank Speed C-1 202
CONN 41 E-2
Sensor - Engine Coolant Temperature C-1 203
CONN 42 D-2
Sensor - Engine Intake Manifold Pressure D-1 204
The connectors show n in this chart are for harness
Sensor - Engine Intake Manifold Temperature C-1 205
to harness connectors. Connectors that join a
Sensor - Fuel Pressure E-1 206
harness to a component are generally located at or
Sensor - Oil Pressure D-1 207 near the component. See the Component Location
Solenoid - Fuel Pump D-3 208 Chart.
Wastegate - Smart D-3 209
 5 4 3 2 1

G G

F F

(200) ENGINE ECM E-C12 INJECTOR HARNESS 1

374-2640 (AC) E-C1 155-2272 375-8407
374-2641 (FC) 245-1043
X931-E6 YL-18 1 INJECTOR #6 LS
X925-E62 PK-18 2 INJECTOR #6 HS CONN 40
1 X930-E7 GY-18 3 INJECTOR #5 LS
2 X924-E63 BR-18 4 INJECTOR #5 HS
3
4
5
E INJECTOR #6 LS
INJECTOR #5 LS
6
7
X931-E6 YL-18
X930-E7 GY-18
E-C13
155-2272
INJECTOR HARNESS 2
375-8407
E
INJECTOR #4 LS 8 X929-E8 BU-18
9 X929-E8 BU-18 1 INJECTOR #4 LS E-C5
CRANK/CAM SUPPLY 10 996-E10 GN-18 X923-E64 OR-18 2 INJECTOR #4 HS CONN 41 374-6608
11 X928-E33 GN-18 3 INJECTOR #3 LS
12 X922-E59 WH-18 4 INJECTOR #3 HS Y948-E40 BR-18 1 RETURN (206) FUEL PRESSURE SENSOR (NOTE A)
13 Y946-E49 BU-18 2 OUTPUT 375-6988
14 R997-E48 OR-18 3 +5V
15
16 E-C14 INJECTOR HARNESS 3
SMART WASTEGATE SUPPLY17 M795-E17 WH-18 155-2272 375-8407
COMM. ADAPTER SUPPLY 18 E-C4
SMART WASTEGATE RETURN19 C211-E19 BK-18 X927-E34 YL-18 1 INJECTOR #2 LS 281-8804
CDL - 20 X921-E58 PK-18 2 INJECTOR #2 HS
CDL + 21 X926-E35 GY-18 3 INJECTOR #1 LS
CONN 42 769-E47 BU-18 1 +5V (207) OIL PRESSURE SENSOR
CAN A SHIELD 22 X920-E57 BR-18 4 INJECTOR #1 HS Y947-E39 BR-18 2 RTN 320-3060
CAN A - 23 994-E56 GY-18 3 SIG
CAN A + 24
PUMP SOLENOID SUPPLY 25 Y950-E25 YL-18
PUMP SOLENOID RETURN 26 Y951-E26 PU-18
27 E-C9 E-C3
28 238-8245 281-8804
29
30 C211-E19 BK-18 1 T997-E46 OR-18 1 +5V (204) ENG. INT. MANF. PRESSURE SENSOR
31 2 (209) SMART WASTEGATE (NOTE A) 2 RETURN
M795-E17 WH-18 T993-E38 BR-18 320-3062
376-4628
32 X731-E55 BU-18 3 SIGNAL
D INJECTOR #3 LS 33 X928-E33 GN-18 D
INJECTOR #2 LS 34 X927-E34 YL-18
INJECTOR #1 LS 35 X926-E35 GY-18
36 E-C2 E-C10
COOLANT & INTAKE AIR TEMP. RETURN 37 L731-E37 BR-18 368-4828 238-8247
INTAKE AIR PRESS. RETURN 38 T993-E38 BR-18
OIL PRESS. RETURN 39 Y947-E39 BR-18 Y950-E25 YL-18 1 (208) FUEL PUMP SOLENOID (NOTE A) 996-E70 GN-18 1 +8V (201) CAM SPEED SENSOR
FUEL RAIL PRESS. RETURN 40 Y948-E40 BR-18 Y951-E26 PU-18 2 375-8254 P920-E53 BR-18 2 SIGNAL 238-0120
41
INTAKE MANIFOLD TEMP. 42 C967-E42 BU-18
COOLANT TEMP. SIGNAL 43 995-E43 BU-18
44 E-C11
COMM. ADAPTER RETURN45 SPEED SNSR. PWR. (NOTE B) 238-8247
INTAKE AIR PRESS. SUPPLY 46 T997-E46 OR-18 996-E10 GN-18 996-E69 GN-18
OIL PRESS. SUPPLY 47 769-E47 BU-18 996-E70 GN-18 996-E69 GN-18 1 +8V (202) CRANK SPEED SENSOR
FUEL RAIL PRESS. SUPPLY 48 R997-E48 OR-18 E965-E52 BU-18 2 SIGNAL 238-0120
FUEL RAIL PRESS. SIGNAL 49 Y946-E49 BU-18
UENR6392-01 VOL 4 of 4

50 TEMP. SNSR. RTN.

51 L731-E37 BR-18 L731-E66 BR-18
CRANK SPEED SIGNAL 52 E965-E52 BU-18 L731-E68 BR-18 E-C6
CAM SPEED SIGNAL 53 P920-E53 BR-18 230-4011
54
INTAKE MANIFOLD PRESS. SIGNAL 55 X731-E55 BU-18 C967-E42 BU-18 1 (205) ENG. INT. MANF. TEMP. SENSOR
OIL PRESS. SUPPLY 56 994-E56 GY-18 T993-E38 BR-18 L731-E68 BR-18 2 256-6454
INJECTOR #1 HS 57 X920-E57 BR-18 Y947-E39 BR-18
INJECTOR #2 HS 58 X921-E58 PK-18 Y948-E40 BR-18
(Dimensions: 18 inches x 24 inches)

C INJECTOR #3 HS 59
60
X922-E59 WH-18 C967-E42 BU-18
995-E43 BU-18
C
E-C7
61 T997-E46 OR-18 230-4011
INJECTOR #6 HS 62 X925-E62 PK-18 769-E47 BU-18
INJECTOR #5 HS 63 X924-E63 BR-18 R997-E48 OR-18 995-E43 BU-18 1 (203) ENG. COOLANT TEMP. SENSOR
INJECTOR #4 HS 64 X923-E64 OR-18 Y946-E49 BU-18 L731-E66 BR-18 2 256-6454
E965-E52 BU-18
P920-E53 BR-18
X731-E55 BU-18
994-E56 GY-18

Do not operate or work on this product unless you have

B read and understood the instruction and warnings in the B
relevant Operation and Maintenance Manuals and
relevant service literature. Failure to follow the instruc-
tions or heed the warnings could result in injury or
death. Proper care is your responsibility.

SYMBOL DESCRIPTION ABBREV COLOR

CIRCUIT CONNECTED RD RED
CIRCUIT NOT CONNECTED WH WHITE
8 Page,

ELECTRICAL CONNECTION TO OR ORANGE

HARNESS ASSEMBLY MACHINE STRUCTURE
YL YELLOW
INTERNAL ELECTRICAL CONNECTION
IDENT PART NO. TO SURFACE OF COMPONENT PK PINK
CALLOUTS WIRE GROUP COLOR DESCRIPTIONS CONNECTOR BK BLACK
ENGINE CONTROL CIRCUIT E 417-1240 H# CIRCUIT GROUPING DESIGNATION GY GRAY
Callout Number Component
PU PURPLE
(Machine Location from (52) VALVE GP - CONTROL Name
OTHER COLOR DESCRIPTIONS ATCH WIRE, CABLE, COMPONENT
Component Locations Table)
138-1234 Part Number BR BROWN
HIGHWAYS SPLICE
GN GREEN
BLADE, SPADE, RING OR SCREW
TERMINAL BU BLUE
A A
THIS SCHEMATIC IS FOR THE CP/CS56B, CP/CS68B, CP/CS74B, CP76B, CS78B AND CS79B ELECTRICAL SYSTEM
VOLUME 4 of 4: ENGINE
MEDIA NUMBER: UENR6392-01
SCHEMATIC PART NUMBER: 417-1240, CHANGE: 02, VERSION: DX
Components are shown installed on a fully operable machine with the key and engine off and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

5 4 3 2 1