Safety Data Sheet

Revision Date 11-15-2016

Revision Number 28

SECTION 1 Identification of the substance/mixture and of the company/undertaking

Product identification used on label
Product identifier 4150
NOX-RUST® VCI 10
Details of the supplier of the safety Daubert Chemical Company
data sheet 4700 S. Central Avenue
Chicago, IL 60638
708-496-7350
Emergency telephone number Chemtrec: (800) 424-9300
Relevant identified uses of the Corrosion Preventive Compound
substance or mixture and uses
advised against

SECTION 2 Hazards identification

Classification of the chemical in accordance with paragraph (d) of §1910.1200;
GHS Hazard
Symbols

GHS Reproductive Toxicity Category 2

Classification
Signal Word Warning
Hazard Suspected of damaging fertility or the unborn child.
Statements
Precautionary
Statements
Prevention Obtain special instructions before use.
Do not handle until all safety precautions have been read and understood.
Wear protective gloves/protective clothing/eye protection/face protection.
Response IF exposed or concerned: Get medical advice/attention.
Storage Store locked up.
Disposal Dispose of contents/container in accordance with
local/regional/national/international regulation for hazardous wastes.

NOX-RUST® VCI 10 Page 1 of 6

 Safety Data Sheet
Revision Date 11-15-2016
Revision Number 28
SECTION 3 Composition/information on ingredients
Chemical Name CAS # %
2-Ethylhexanoic acid 149-57-5 0.1 - 1

Note: Specific chemical identities and/or exact percentages have been withheld as a trade secret.

SECTION 4 First aid measures

Inhalation If symptoms are experienced remove source of contamination or move victim to fresh air
and obtain medical advice.
Eyes Use an eye wash to remove a chemical from your eye regardless of the level of hazard.
Flush the affected eye for at least twenty minutes. Tilt the head to prevent chemical from
transferring to the uncontaminated eye. Seek medical advice after flushing.
Skin Contact Wash with soap and water. Remove contaminated clothing and launder. Get medical
attention if irritation develops or persists.
Ingestion No hazard in normal industrial use. Do not induce vomiting. Seek medical attention if
symptoms develop. Provide medical care provider with this SDS.
Most important See Section 11
symptoms/effects,
acute and delayed

Indication of Treat symptomatically.

immediate medical
attention and special
treatment needed

SECTION 5 Firefighting measures

Suitable extinguishing media: Use water fog, foam, dry chemical or carbon dioxide (CO2) to
extinguish flames.
Unsuitable extinguishing media: No data available
Fire and/or Explosion Hazards Material may be ignited only if preheated to temperatures above the
high flash point, for example in a fire.
Fire Fighting Methods and Protection Do not enter fire area without proper protection including self-
contained breathing apparatus and full protective equipment. Use
appropriate methods for the surrounding fire.
Hazardous Combustion Products Carbon dioxide, Carbon monoxide, Hydrocarbons

SECTION 6 Accidental release measures

Personal precautions, protective No adverse health affects expected from the clean-up of spilled
equipment and emergency procedures material. Follow personal protective equipment recommendations
found in Section VIII of this SDS.
Methods and materials for containment Collect and discard in accordance with local, state and national
and cleaning up regulations.

NOX-RUST® VCI 10 Page 2 of 6

 Safety Data Sheet
Revision Date 11-15-2016
Revision Number 28
SECTION 7 Handling and storage
Precautions for safe handling Avoid contacting and avoid breathing the material. Use only
in a well ventilated area. As with all chemicals, good
industrial hygiene practices should be followed when handling
this material. Wash thoroughly after handling. Do not get in
eyes, on skin and clothing.
Conditions for safe storage, including any Store in a cool dry place. Isolate from incompatible materials.
incompatibilities Do not store in direct sunlight
Incompatible materials Strong oxidizing agents

SECTION 8 Exposure controls/personal protection

Control parameters
Chemical Name ACGIH TLV ACGIH STEL OSHA PEL

No exposure limits in vapor form

Engineering Measures Local exhaust ventilation or other engineering controls are normally required when
handling or using this product to avoid overexposure.
Respiratory Protection Proper ventilation (at a minimum) will be required when handling this product. Use
respirators (NIOSH approved) only if ventilation cannot be used to eliminate symptoms
or reduce the exposure to below acceptable levels.
Eye Protection Wear chemically resistant safety glasses with side shields when handling this product.
Do not wear contact lenses.
Skin Protection Wear protective gloves. Inspect gloves for chemical break-through and replace at
regular intervals. Clean protective equipment regularly. Wash hands and other exposed
areas with mild soap and water before eating, drinking, and when leaving work.
Gloves Chemically resistant gloves

SECTION 9 Physical and chemical properties (Typical, not specification)

Physical State Oily liquid

Color Amber
Odor Slight Amine Type
Odor Threshold No data available
pH No data available
Melting Point/freezing point, °C No data available
Initial boiling point and boiling No data available
range, °C
Flash Point > 340 °F( 171 °C)
Evaporation Rate >1 (n-Butyl Acetate=1)
Flammability (Solid, Gas) No data available
Lower Flammable/Explosive Limit, No data available
% in air
Upper Flammable/Explosive Limit, No data available
% in air
Vapor Pressure No data available
Vapor Density >1 (Air=1)
NOX-RUST® VCI 10 Page 3 of 6
 Safety Data Sheet
Revision Date 11-15-2016
Revision Number 28
Specific Gravity @ 25°C 0.91
Solubility in Water Negligible; 0-1%
Octanol/Water Partition Coefficient No data available
Autoignition Temperature No data available
Decomposition Temperature No data available
Viscosity Typical 38 cSt @ 40°C
Volatiles, % by weight 6
VOC, Material, lb/gal .45
VOC, Material, grams/liter 54.0
VOC minus exempt solvents & water, 0.45
lb/gal

SECTION 10 Stability and reactivity

Reactivity No data available
Chemical stability Stable under normal conditions. Hazardous polymerization
will not occur.
Possibility of hazardous reactions Under normal conditions of storage and use, hazardous
reactions will not occur.
Incompatible materials Strong oxidizing agents
Hazardous decomposition products Under normal conditions of use & storage, decomposition and
hazardous decomposition products are unlikely.

SECTION 11 Toxicological information

Likely Routes of Entry Inhalation, Skin contact, Eye contact

Target Organs Potentially Affected by Exposure No organs known to be damaged from exposure to this
product.
Chemical Interactions That Change Toxicity No chemical interaction known to affect toxicity.
Medical Conditions Aggravated Skin contact may aggravate existing skin disease

Immediate (Acute) Health Effects by Route of Exposure

Inhalation Irritation Can cause minor respiratory irritation.
Skin Contact Can cause moderate skin irritation, defatting, and dermatitis. Not likely to cause
permanent damage.
Skin Absorption No absorption hazard expected in normal industrial use.
Eye Contact Can cause moderate irritation, tearing and reddening, but not likely to permanently injure
eye tissue.
Ingestion Irritation Irritating to mouth, throat, and stomach. Can cause abdominal discomfort, nausea,
vomiting and diarrhea.
Ingestion Toxicity Harmful if swallowed.

Long-Term (Chronic) Health Effects

Carcinogenicity There are no carcinogenic ingredients present at or over 0.1%.
Inhalation Upon prolonged and/or repeated exposure, can cause respiratory irritation.
Skin Contact Upon prolonged or repeated contact, can cause minor skin irritation, defatting, and
dermatitis.
Skin Absorption Upon prolonged or repeated exposure, no hazard in normal industrial use.
Ingestion Under normal industrial usage conditions, ingestion is highly unlikely.

NOX-RUST® VCI 10 Page 4 of 6

 Safety Data Sheet
Revision Date 11-15-2016
Revision Number 28

Component Toxicology Data

Chemical Name CAS Number LD50/LC50
No data available

SECTION 12 Ecological information

Overview No ecological information available
Mobility No data
Persistence No data
Bioaccumulation No data
Degradability No data

Ecotoxicity Data
Chemical Name CAS Number Aquatic EC50 Aquatic ERC50 Aquatic LC50
Crustacea Algae Fish
No data available

SECTION 13 Disposal considerations

Waste Description for Spent Product Spent or discarded material is not expected to be a hazardous waste.
Disposal Methods Dispose of in accordance with Local and National regulations.
Waste Disposal Code(s) Not applicable

SECTION 14 Transport information

Full shipping name for Rust Inhibitor / Non-Hazardous
Export, Air, Sea (any quantity
unless flash pt. >150ºF) or
vessels of 119 GL or more
Domestic Ground in vessels < Non-Hazardous
119 gal.

SECTION 15 Regulatory information

Status of formula components on selected national regulatory inventories:

LIST STATUS
TSCA All components in this product are on the TSCA Inventory or exempt.
Canadian DSL One or more chemical substances in this material are on the Canadian NDSL and the
remainder are included on the Canadian DSL or are exempt.

Chemical Name CAS # Regulation Percent

2-Ethylhexanoic acid 149-57-5 California Prop 65 0.1 - 1
No CERCLA-listed chemicals in this CERCLA
product.
No 313-listed chemicals in this SARA 313
product.
No SARA 302 EHS-listed chemicals in SARA EHS
this product.

NOX-RUST® VCI 10 Page 5 of 6

 Safety Data Sheet
Revision Date 11-15-2016
Revision Number 28
SECTION 16 Other information
Revision 11-15-2016
Date
Disclaimer Although the information contained herein is believed to be reliable, it is furnished without warranty
of any kind. This information is not intended to be all-inclusive as to the manner and conditions of
use, handling, and storage.
Version Reviewed
Comments Approved: M. Duncan

NOX-RUST® VCI 10 Page 6 of 6