TM

DT74
Parts Manual

DT74

Superior Broom
3707 W. McCormick
Wichita, KS 67213
Phone: (316) 941-9591
Toll Free: (888) 341-8707
Fax: (316) 942-5672

[email protected]
www.superiorbroom.com

DT74 Jan2023 M-F 8 a.m. - 5 p.m. CST

 Main Frame Weldment
Part # 01-11000-001 (Order By Serial No.)
Frame Complete With Decking, Side Walkway And
Rear Fenders.

Roll Over Bar, Step & Fenders

Item Part No. Description
1 01-11000-001 Main Frame Weldment
2 01-30000-002 Front Deck Plate (Smooth)
01-30000-002T Front Deck Plate (Tread Plate)
3 01-30000-003 Main Deck Plate (Smooth)
01-30000-003T Main Deck Plate (Tread Plate)
4 01-16000-002 Roll Over Bar Weldment (ROPS)
5 01-30000-100 Rear Step Weldment
6 01-30000-038 Front Fender - Left or Right
7 01-30000-037 Rear Fender - Right
8 01-30000-036 Rear Fender - Left
9 01-30000-040 Long Step Weldment
10 01-50000-069 "D" Ring

DT74 Jan2023 pg 1
 Bolster Assembly
Item Part No. Description
1 01-14000-001 Bolster A-Frame Assembly (w/Brgs. & Shaft) (Includes 2-8)
2 01-14000-002 Bolster Frame Mount (Not Sold Separately)
3 01-14000-007 Bolster A-Frame Weldment (Not Sold Separately)
4 01-14000-107 Oil Lite Bearing 1.5"O.D. X 2.5" Lg.
5 01-14000-014 Oil Lite Bearing 1.5"O.D. X 2" Lg.
6 01-14000-016 Oil Lite Bearing 1.5"O.D. X 1.5" Lg.
7 01-14000-017 Bolster Nose Bearing Mount
8 01-14000-121 Bolster Pivot Shaft
9 01-5000-107 15" X 5-Bolt Wheel (Without Tire)
01-5000-107B 15" X 6-Bolt Wheel (Without Tire)
01-50000-119 15" X 6-Bolt Wheel w/ 235/75/R15 Tire
01-50000-117 15" X 6-Bolt Wheel w/ 225/75/R15 Tire
01-5000-117 16" X 6-Bolt Wheel (Without Tire)
01-50000-118 16" X 6-Bolt Wheel w/ Tire
10 01-50000-106 Lug Nut (Not Shown)

Front Axle Assembly (Drum Brakes)

Item Part No. Description
1 01-14100-001 Cylinder Mount Assembly
2 01-14100-002 King Pin Kit - Does Both Sides
01-14100-002B King Pin Kit - One Side Only
3 01-14100-003 Grease Cap
4 01-14100-004 Castle Nut w/ Cotter Pin
5 01-14100-005 Outer Bearing - Bearing Only
5A 01-14100-005R Outer Bearing Race - Race Only
6 01-14100-006 Hub & Drum Assembly (5 Bolt) - Includes Race & Studs
01-14100-006B Hub & Drum Assembly (6 Bolt) - Includes Race & Studs
7 01-14100-007 Knuckle w/ Spindle - Left
8 01-14100-008 Cylinder Tie Rod Tube (Short)
9 01-50000-003 Front Axle Steering Cylinder
SK-ACAK2Q1Q Seal Kit - Steering Cylinder (Not Shown)
10 01-14100-009 King Pin Cap - Included in 01-14100-002/002B (Not Sold Separately)
11 01-14100-010 Knuckle w/ Spindle - Right
12 01-14100-011 Inner Seal
13 01-14100-012 Inner Bearing - Bearing Only
13A 01-14100-012R Inner Bearing Race - Race Only
14 01-14100-013 Left Tie Rod End
15 01-14100-014 Tie Rod Tube (Long)
16 01-14100-015 Spindle Washer
17 01-14100-016 Right Tie Rod End
18 01-14100-017 Cylinder Mount Bushing
19 01-50000-002 Front Axle Brake Drum Seals (Orange) (Not Shown)
20 35491-FB Wheel Stud
21 01-50000-106 Lug Nut
22 01-50000-013 Brake Hose (Rubber)
23 01-50000-014 Brake Line 3 16" X 144" (Not Shown)
24 01-50000-016 Brake Line 3 16" X 20" (Not Shown)
25 01-50000-017 Brake Line 3 16" X 40" (Not Shown)
26 01-50000-018 Brake Line 3 16" X 44" (Not Shown)

When ordering Tie Rod

Ends, the front axle requires
(2) Left's & (1) Right.

For Axle Assembly Order Part # 01-50000-001, Steering Cylinder & Brake Lines Sold Seperately

DT74 Jan2023 pg 2
 Front Brake Assembly
Item Part No. Description Qty.
01-14000-020L Backing Plate Assembly (Left) Includes items 1-11 1
01-14000-020R Backing Plate Assembly (Right) Includes items 1-11 1
2 01-14000-021 Pin 2
3 01-14000-022 Cover 1
4 01-14000-023 Spring 1
5 01-14000-024L Front Brake Adjusting Kit (Left) 1
01-14000-024R Front Brake Adjusting Kit (Right) 1
6 01-14000-028 Shoe Set (Includes 4 Shoes) Does Both Sides 1
7 01-14000-026L Wheel Cylinder (Left) 1
01-14000-026R Wheel Cylinder (Right) 1
8 01-14000-027 Push Rod 2
9 01-14000-025 Hold Down Spring w/Cap 2
10 01-14000-029 Return Spring 2
11 01-14000-030 Anchor 1

Wheel Cylinder Repair

Kit Is Not Available For
The Front Brake Assembly.

U-Bolts - 80lbs Torque

It is recommended that the U-Bolts be replaced

when replacing the Leaf Springs.
It is also recommended that both Leaf Springs be replaced
at the same time.

Rear Axle Springs

Item Part No. Description
1 01-50000-011 Leaf Spring (2 Req'd)
2 01-50000-009 "U" Bolt Plate (2 Req'd)
01-50000-009C "U" Bolt Plate (2 Req'd) (For Axle 01-50000-151B) 3 8" HD
3 01-50000-007 Spring Shackle (2 Per Side)
4 01-50000-010 "U" Bolt & Nuts (2 Per side)
01-50000-010C "U" Bolt & Nuts (2 Per Side) Fine Thread (For Axle 01-50000-151B)
5 01-50000-008 Shackle Bolt & Nut (3 Per Side)
6 01-50000-006 Rear Spring Hanger (1 Per Side)
7 01-50000-005 Front Spring Hanger (1 Per Side)

pg 3
DT74 Jan2023
 Rear Brake Assembly
Item Part No. Description Qty.
01-50001-004L Backing Plate Assembly (Left) Includes items 1-20 1
01-50001-004R Backing Plate Assembly (Right) Includes items 1-20 1
2 01-50001-005 Shoe Set (4 Shoes) - Does Both Sides 1
3 01-50001-006 Anchor 1
4 01-50001-007 Return Spring (Front) 1
5 01-50001-008 Return Spring (Rear) 1
6 01-50001-009L Wheel Cylinder (Left) 1
01-50001-009R Wheel Cylinder (Right) 1
7 01-50001-010 Push Rod 2
8 01-50001-011L Strut 1
01-50001-011R Strut 1
9 01-50001-012 Spring 1
10 01-50001-013 Guide 1
11 01-50001-014 Cable 1
12 01-50001-015L Parking Brake Lever (Left) 1
01-50001-015R Parking Brake Lever (Right) 1
13 01-50001-016 Pin, Shoe Hold Down 2
14 01-50001-017 Hold Down Spring 2
15 01-50001-018 Cup, Hold Down 2
16 01-50001-019 Spacer 1
17 01-50001-020 Retainer 1
18 01-50001-021L Adjusting Lever (Left) 1
01-50001-021R Adjusting Lever (Right) 1
19 01-50001-022L Adjusting Screw Assembly (Left) 1
01-50001-022R Adjusting Screw Assembly (Right) 1
20 01-50001-023 Spring 1
21 01-50001-024 Brake Drum (5-Bolt) 1
01-50001-024B Brake Drum (6-Bolt) Dana Axle 1
01-50001-024C Brake Drum (6-Bolt) Currie Axle 1
22 01-50001-025 Wheel Cylinder Repair Kit A/R

23 SB-BHDWR(L or R) Brake Hardware Kit, Specify Left or Right 2

pg 4
DT74 Jan2023
 22

Rear Axle 01-50000-151C - Heavy Duty (Serial # 820611- Current) 5.43 Ratio Quick Performance
Rear Axle 01-50000-151B - Heavy Duty (Serial # 816307 - 820610) 5.43 Ratio Currie
HD Axle Upgrade Kit - Part No. (BOM-Axle Quick Performance 3/4 BN)
Item Part No. Description Qty.
1 SB-2001L Rearend Housing 1
2 SB-9028N Housing Vent - Cap Style 1
3 SB-7000C Spring Pads - 2" Wide - Pair - Loose 2
4 SB-95031 3rd Member Housing Stud 10
5 SB-9007 3rd Member Gasket Kit w/ 10 Nuts & 10 Washers 1
6 SB-90D543SS Complete, Assembled 3rd Member, Including Yoke 1
SB-90D543LS Limited Slip 3rd Member 1
7 SB-4044N 1350 Short Yoke / Input Yoke 1
8 SB-1005 (L or R) 31 Spline CTF Axle (Specify Left or Right Side) 1/2" - 2
9 SB-9000C 20 Wheel Stud 12
10 35490 Wheel Bearing Retainer Plate 2
11 SB-TA20 Wheel Bearing w/ Outboard Seal and (2) Lock Rings 2
12 01-50001-024C Brake Drum 2
13 01-50001-004L Brake Backing Plate - Loaded - Left 1
01-50001-004R Brake Backing Plate - Loaded - Right 1
14 SB-8012 3/8" T-Bolt w/ Stover Nut 8
15 01-50001-005 Brake Shoes - Set of 4 (Does Both Sides) 1
16 01-50001-009L Wheel Cylinder, Left 1
01-50001-009R Wheel Cylinder, Right 1
17 SB-BHDWR (L or R) Brake Hardware Kit, Specify Left or Right 2
18 NA
19 01-50000-012B Drive Shaft HD Rear Axle (Starting July 2010) 1
20 01-50000-013UJ U-Joint 2
21 01-50001-012B Flange Yoke 1
22 02-30000-035T4F Differential Heat Shield 1

DT74 Jan2023 pg 5
 Rear Axle Open Carrier 3rd Member
Item Part No. Description Qty.
1 SB-4013 Ring & Pinion 5.43 Ratio 1
2 SB-95008 Open Carrier 1
3 SB-4026C Gear Case 1
4 SB-94031 Pinion Support 1
5 SB-4044N Input Yoke - 1350 Series 1
6 SB-8009 Third Member Gasket 1
7&8 SB-8006 Carrier Bearing & Race 2
9 SB-8011 Pinion Seal 1
10 & 11 SB-8002 Front Pinion Bearing & Race 1
12 & 13 SB-8003 Rear Pinion Bearing & Race 1
14 SB-8016 Pocket Bearing 1
15 SB-8020 Pocket Bearing Retainer 1
16 & 17 SB-4039 Solid Spacer w/ Preload Shims 1
18 SB-4053 Pinion Nut 1
19 & 20 SB-4060 U-Joint Strap Kit 1-3/16" Cup (Kit) 1
21 SB-4061 O-Ring 1
22 SB-4040 Pinion Depth Shim Kit (5 Shims) 1
23 SB-4075 Ring Gear Bolts - Each 10

pg 6
DT74 Jan2023
 Two Speed Gearbox Shifter Assembly
Item Part No. Description
1 01-30000-070 Shifter Bracket
2 01-30000-074 Shifter Lever
3 01-30000-075 Shift Linkage

Bronze Bushing
Pressed Into Gear

Two Speed Gearbox Assembly 01-50000-087

Item Part No. Description Item Part No. Description
1 01-50001-087 Main Housing 11 01-50001-097 Shift Fork
2 01-50001-088 Housing Cover 12 01-50001-098 Shift Rail Seal Kit
3 01-50001-089 Bearing Cap 13 01-50001-099 High Range Gear
4 01-50001-090 Bearing & Seal Cap 14 01-50001-100 Sliding Collar
5 01-50001-091 Vent Plug 15 01-50001-101 Low Range Gear
6 01-50001-092 Bearing Assembly (Input Shaft) 16 01-50001-102 Output Shaft
* 7 01-50001-093 Pinion Gear w/ Key 17 01-50001-103 Output Shaft Seal
* 8 01-50001-094 Input Shaft 18 01-50001-104 Output Flange
9 01-50001-095 Bearing Assembly (Output Shaft) 19 01-50001-105 Flange Nut
10 01-50001-096 Shift Rail 20 01-50001-106 Detent Kit
21 01-50001-107 Shim Kit (Not Shown)
* - Must Be Purchased Together 22 01-50001-108 Drain Plug (Not Shown)

DT74 Jan2023 pg 7
DT74 Jan2023 pg 8
DT74 Jan2023 pg 9
 Directional Control Pedal & Backup Alarm (Serial # 8 3 o Curren )
Item Part No. Description
1 01-50000-039 Backup / Reverse Alarm
2 01-50000-092B Hydrastat Pedal (Dual Pedal)
3 01-50600-056 Reverse Alarm Pressure Switch
4 01-50001-092SW Neutral Safety Switch (Ea.) (2 Req'd)
5 01-50001-092B Pedal Assembly Rubber Boot (Ea.)

Master Cylinder and Brake Pedal Assembly

Item Part No. Description
1 01-30000-011 Brake Pedal Weldment *BOM
2 01-50000-021 Master Cylinder Complete
3 01-50000-019 Brake Pedal Nyliner Bushing
4 01-50000-020 Brake Pedal Return Spring (Not Shown)
5 01-50000-025 Master Cylinder Rubber Bellow (Boot)
6 01-50000-031 Brake Pedal Pad
7 01-79000-004 Brake Pressure Switch
8 01-50300-000 Brake Adapter Kit
9 01-50000-114 Brake Pedal Bellows
10 01-50000-130 Brake Master Cylinder Clevis
11 01-17300-010 Master Cylinder Cover (Not Shown)
12 01-17300-015 Master Cylinder Cover Latch (Not Shown)
13 01-30000-079 Master Cylinder Push Rod

DT74 Jan2023 pg 10
 2B

1
5
6

DT74 Jan2023 pg 11
 For Details On Glass Windows
& Windshield Replacement
Information (See Page 55).

1A

West Coast Mirror

Item Part No. Description
1 01-76000-000 West Coast Mirror Assembly w/Bracket
2 01-76000-001 West Coast Mirror (No Bracket)
3 01-76000-002 Mirror Bracket
4 01-76000-005 5" Convex Mirror w/Bracket
01-76000-125 8-1/2" Convex Mirror w/Bracket
01-76000-110 10" Convex Mirror w/Bracket

pg 12
DT74 Jan2023
 Cab Air Filtration Assembly
Item Part No. Description
1 01-86000-002 Air Filter Canister (Complete w/Filter & Dust Ejection Valve)
2 01-86000-003 Clamp
3 01-50000-042 Elbow 3" X 3" X 90 (Long)
4 01-86000-012 Bulkhead Adapter
5 01-86000-015 Bracket
6 01-86000-018 Hump Hose
7 01-86000-120 Filter
8 01-86000-019 Cab Air Filtration Tube
9 01-86001-048 Dust Ejection Valve
10 01-86001-121 Air Cleaner Cap Clips (3 Per Unit) - Not Shown

11 01-86001-049 Air Cleaner Cap w/Clips - Does not include the Dust Ejection Valve
Item # 9, must be purchased separately.

Windshield Wiper Assembly

Item Part No. Description
1 01-16000-025 Wiper Blade
2 01-16000-026 Wiper Blade Arms (Set)
3 01-16000-027 Wiper Drive Assembly (Less Motor)
4 01-16000-028 Wiper Motor
5 01-83000-002 Washer Pump Kit (Bottle w/Pump)
01-83000-006 Washer Pump Kit (Dual Pump - Front & Rear) (Not Shown)
5A 01-83000-003 Washer 12V Pump
6 01-83000-001 Washer Kit (Washer Tube & Spray Nozzle) (Not Shown)
7 01-83000-004 Spray Tube (Not Shown)
8 01-81000-001 Rear Wiper Motor (Not Shown)
9 01-81000-002 Rear Wiper Blade (Not Shown)
10 01-81000-003 Rear Wiper Arm (Not Shown)
11 BOM-01-83000-000 Front Washer Assembly (Not Shown)
12 BOM-01-83000-000R Rear Washer Assembly (Not Shown)
13 BOM-01-81000-000 Rear Wiper Assembly (Not Shown)

pg 13
DT74 Jan2023
 1
4
6
7
2

Model DT74
DTAC Air Conditioner Parts
Item Part No. Description
1 31-50020 Housing Lid
2 07-00316 Evaporator Coil
3 04-15004 Expansion Valve
4 50-50500 Expansion Valve Bracket
5 02-17003 12V Motor (2)
6 02-16020 Blower Wheel (4)
7 31-50000 Intake Filter (1)
50-00005 Small Intake Filter (1)
8 31-50019 Bottom Housing
9 03-13006 Switch
10 03-14002 Thermostat
11 12-50419 Switch Plate
12 03-00165 Thermostat / Fan Control Knob
13 02-16061 3.5" Louver (6)
14 02-16060 Top & Bottom Housings
15 12-00315 Wiring Harness (Not Shown)
16 03-01702 Blower Motor Relay (Not Shown)
17 3051576 Blower Motor Assembly (Includes 5,6,14)
18 03-11126 Switch Pigtail (Not Shown)
19 03-13029 40A Circuit Breaker (Not Shown)

pg 14
DT74 Jan2023
 DT
AC

4 Machine

Air Conditioner Parts

Item Part No. Description
1 01-86000-007 Evaporator Unit (DTAC)
2 01-86000-014 Compressor
3 01-86000-013 Condensor
4 01-86000-009 Drier
5 01-86600-113 Compressor To Condensor Hose
6 01-86600-109 Drier To Condensor Hose
7 01-86600-107 Evaporator To Drier Hose
8 01-86600-114 Compressor To Evaporator Hose
9 04-86000-025 Cummins S-Bend Hose
10 01-86000-020 Hose Kit (Includes 5,6,7,8,12 & 13)
11 01-86000-010 Binary Switch
12 01-86600-110 Condensor To Drier Adapter
13 01-86600-112
DT
AC
Manufacturers Recommendations:
When Changing Lines #6 Or #7,
It Is Recommended To Change The Drier.

When Changing The Drier,

There Is A Possible Need To Change 4C 4P 4
The Expansion Valve. Machines
When Changing The Drier, Add 2 oz.
Of Ester Oil.

Pg. 15

DT74 Jan2023
 Canopy Assembly
Item Part No. Description
1 01-16500-001 Canopy Assembly - Complete
2 01-16500-002 Canopy Cover
3 01-16500-003 Canopy Cover Support Frame - Right
4 01-16500-004 Canopy Cover Support Frame - Left
5 01-16500-005 Canopy Support Frame Mount
6 01-16500-006 "U" Bolt - Canopy Mount
7 01-16500-007 "U" Bolt - Support Frame Mount
8 01-51000-050 Canopy Wiring Harness (Not Shown)
9 01-79000-008 Turn / Hazard Light
10 01-79000-009 Head Lamp/Driving Light
11 01-79000-012 Light Mounting Bracket
12 01-76000-001 West Coast Mirror
13 01-17500-112 West Coast Mirror Bracket - Left
14 01-17500-113 West Coast Mirror Bracket - Right

DT74 Jan2023 pg 16
 Seat Assembly
Item Part No. Description
1 01-50000-907 Seat Assembly (Complete, Less Base)
2 01-50000-112 Seat Bottom Cushion
3 01-50000-113 Seat Back Cushion
4 01-17200-001 Seat Base (Standard)
5 01-17200-010 Seat Base (Suspension)
6 01-17200-011S Seat Suspension Assembly
7 01-50000-095 Seat Belt Assembly
01-50000-095B Seat Belt / Shoulder Harness Assembly
8 01-17200-012 Tether Set (Qty. 2)
9 01-50000-114R Arm Rest (Right)
01-50000-114L Arm Rest (Left)
10 01-17200-013 Air Ride Mid-Back Seat (Air Ride Suspension & Compressor)
(Optional - Not Shown)

Pg. 17

DT74 Jan2023
 1
17
16

1
15

16

Engine Hood Assembly

Item Part No. Description
1 01 1 000 001
01 1 000 301
3 01 1 000 00
01 1 000 300
5 01 000 00
6 01 000 003
7 01 000 00
01 000 001
01 000 001 01 000 001
10 01 6000 0 1 1/
11 01 50000 0
1 01 000 005
13 01 1 000 01 6
1 01 1 000 010 5
15 0 50000 01
16 01 10000 01
17 01 1 000 00
1 01 1 000 51
1 01 1 000 50

Pg. 18

DT74 Jan2023
 2A

Fuel /Hydraulic Tank Assembly

Item Part No. Description
1 01-50000-070 3/8" Brass Straight Barb
2 01-90001-073 Fuel Pickup Tube
2A 01-90001-074 Fuel Return Tube (Cat / Perkins / Fiat)
3 01-50601-048 Return Filter Service Indicator (Not included with item #11)
4 01-51000-018 Fuel Sender - Includes Gasket & Hardware
5 01-90000-001 Hydraulic (27 Gallon) / Fuel Tank (35 Gallon)
01-90000-010 Hydraulic (27 Gallon) / Fuel Tank (41 Gallon)
01-90000-010B Hydraulic (22 Gallon) / Fuel Tank (38 Gallon)
6 01-50000-076 Tank Strap (Specify Tank Size & Serial #) (Not Shown)
7 01-50000-109 Tank Pads (Rubber)
8 01-50600-021 Sight Level Gauge
9 01-50500-017 Drain Valve
10 01-50500-051 Filter To Hose 45 Deg. Elbow
11 01-50600-012B Return Filter Assembly (w/ Filter)
12 01-50600-014 Return Filter Element
13 01-50600-016 Filter Cap (Hex Style Top) - Spring & O-Ring Included
01-50600-016B Filter Cap (New Style) - Spring & O-Ring Included Breather
14 01-50600-017 Filter
15 01-50600-022 Fuel Cap
16 02-50000-625 3/16" X 3/16" Brass Straight Barb (Not Shown)
17 02-50000-626 Brass Hose Splice Fuel Tank (JD) (Not Shown)
18 02-50000-627 Fuel Filter Inline (Not Shown)
19 01-50600-023B Filter Gasket
20 01-50600-020 Breather Cap
01-50600-020B Breather Cap (New Style)

Pg. 19

DT74 Jan2023
 3 Air Cleaner Assembly
01-50000-046B
11 12 16 20 15 Includes # 14,15,19 & 20

14 4
13 17
19

6
7
5
10 9 2
18

21

DT74 Jan2023 pg 20
 Air Cleaner Assembly
01-50000-046B
(Serial # 807519 & Up)
Includes # 16,17,23, & 24

12
18

28

2
2

26

1
1

pg 21
DT74 Jan2023
 John Deere Radiator and Engine Mounts T3 and T4F
Item Part No. Description
1 01-10000-010 Radiator Mount
2 02-10000-011 Radiator Mount Lower
3 02-10000-012 Radiator Top Support
4 02-10000-013F Radiator To Motor Mount-T4F Only
5 02-11000-002 Left Front Motor Mount
6 02-11000-003 Right Front Motor Mount
7 02-11000-004 Left Rear Motor Mount
8 02-11000-005 Right Rear Motor Mount
9 01-50000-058 Motor Mount Isolator
10 01-50000-062 Radiator Isolator
11 01-50000-067 Rubber Isolator
12 01-10000-111 Radiator Support Lower

Cat / Perkins / Fiat - Radiator and Engine Mounts

Item Part no. Description
1 01-10000-010 Radiator Mount
2 05-10000-011 Radiator Mount Lower
3 02-10000-012 Radiator Top Support
4 01-10000-111 Radiator Lower Support
5 05-10000-013 Radiator To Motor Mount
6 05-11000-006 Left Front Motor Mount
7 05-11000-007 Right Front Motor Mount
8 05-11000-004 Left Rear Motor Mount
9 05-11000-005 Right Rear Motor Mount
10 01-50000-058 Motor Mount Isolators
11 01-50000-067 Rubber Isolator
12 06-50000-062 Radiator Top Support Isolator
13 01-50000-062 Radiator Isolator
14 05-50000-108R Baffle Rubber • Right
15 05-50000-108L Baffle Rubber • Left

DT74 Jan2023 pg 22
 1 6

5
2

DT74 Jan2023 pg 23
DT74 Jan2023 pg 24
 Item Part No. Description
1 02-50000-620T4 Exhaust Pipe
1A 02-50000-003 Catalyst Clamp
2 02-50000-14 Turbo Exhaust Gasket
3 02-50000-004 Diesel Particulate Filter
4 02-50000-006 Exhaust Filter Bracket
5 02-50000-011 Isolator Flange Bolt
6 01-50000-010 Isolator Washer
7 02-50000-008 Flangenut
8 02-50000-007 DPF Isolators
9 02-50000-013 Turbo Exhaust V-Band Clamp
10 02-50000-015 DOC/DPC Inlet V-band Clamps
11 02-50000-008 U-clamp top lock nut
12 02-50000-009 U-clamp washer
13 02-50000-016 DOC/DPC Inlet Gasket
14 02-50000-020 DPF Filter Sensor W/Fittings
15 02-30000-065 Muffler Wrap

pg 25
DT74 Jan2023
 Additional Parts For Deere T4F - Not Shown
Part No. Description
1 02-50000-020 DPF Filter Sensor with Fittings
2 02-50000-025 DPF - 90 degree fitting - 1/4"
3 02-50000-026 DPF - 90 Degree fitting - 3/8"
4 02-50000-027 1/4" Fitting Clamp
5 02-50000-028 3/8" Fitting Clamp
6 02-50000-029 Oil Fill - Filler Neck
7 02-50000-030 Oil Fill - Filler Cap
8 02-50000-031 Oil Fill - Packing
9 02-50000-032 Oil Fill - Gasket
10 02-50000-033 Oil Fill - Complete Asm

Additional Parts Ca / Perkin / ia

Part No. Description
1 05-50000-006 ECU Bracket Cat / Perkins / Fiat
2 05-50000-007 ECU Isolator

DT74 Jan2023 pg 26
 Circle Frame Assembly
Item Part No. Description Circle Frame Assembly Requires 10 Circle Bearing Kits
1 01-12000-001 Circle Weldment 6 Vertical Bearings - Bearing Mount Angle Needed
2 01-13000-013 Core Shock Pin (2 Req'd) 4 Horizontal Bearings - Bearing Mount Angle Not Needed
3 01-13000-031 Core Pin (3 Req'd)
4 01-30000-004 Bearing Mount Angle (Does Not Include Item #9)
5 01-50000-032 Circle Bearing
6 01-50000-033 Circle Shift Cylinder 2 X 16 (Round Tube)
01-50000-037 Circle Shift Cylinder 2 X 15 (Square Tube)
7 01-50000-034 Shock Absorber
8 01-50000-036 Lift Cylinder 2 X 8
9 01-61000-002 Circle Bearing Kit ( Does Not Include Item #4)
10 01-15000-005 Cylinder Pin
11 01-50600-035 Shift Cylinder Check Kit (Not Shown)
12 SK1C4244 Core Lift/Shift Cylinder Seal Kit (Not Shown)

See Page 45 For Side Shift Assembly

Rock Guard Assembly

Item Part No. Description
1 01-30000-060 Rock Guard Angle
(May Either Be Bolted On Or Welded On)
2 01-50000-108 Rock Guard Rubber
3 01-30000-061 Rock Guard Angle Support Strap

pg 27
DT74 Jan2023
 Broom Core Assembly
Item Part No. Description
1 01-13000-002 Core Cover
2 01-13000-005 Core Cover End (Right)
3 01-13000-004 Core Cover End (Left)
4 01-13000-010 Idler Shaft Weldment Wafers - 10" I.D. X 32" O.D.
01-13000-010-10 Idler Shaft Weldment - 10"
5 01-13000-030 Core End Cap (Right)
6 01-13000-003 Core Cover Support Bracket Broom Core Assembly 01-13000-001
7 01-13000-006 Core End Plate (Left) Includes Items: 1, 2, 3, 6, 9, 10, 12, 21, & 27
8 01-13000-007 Drive Hub
9 01-13000-200 Motor Mount (Core Drive)
10 01-13000-100B Core Support Frame
11 01-13000-300 Core Frame
11A 01-13000-300AS Core Frame Assembly (Includes 4,5,7,8,11 & Hardware)
12 01-13000-028 Retainer Washer
13 01-78000-001 Individual Poly Wafer (Includes Spacer)
14 01-78000-101 Individual Wire Wafer (Includes Spacer)
15 01-50600-001B Hydraulic Core Motor
16 01-50000-035 1.25" Pillow Block Bearing (Includes item # 20 - 01-50001-035)
17 01-78000-000 Poly Wafer Set (Includes Spacers) (56 Per Set)
18 01-78000-100 1/2 & 1/2 Wafer Set (Includes Spacers) (56 Per Set)
19 SK61258 Brush Motor Seal Kit (Seal Kit For 01-50600-001) (Not Shown)
19A SK35535501 Brush Motor Seal Kit (Seal Kit For 01-50600-001B) (Not Shown)
20 01-50001-035 Lock Collar (Included w/ Pillow Block Bearing - 01-50000-035)
21 01-13000-045 Core Motor Shaft Guard (2 Req'd)
22 01-13000-107 Core Motor Mounting Pin
23 01-78000-301 Individual Convoluted Poly Wafer
24 01-78000-302 Individual Convoluted Wire Wafer
25 01-78000-300 Convoluted Poly Wafer Set (48 Per Set)
26 01-78000-310 Convoluted 1/2 & 1/2 Wafer Set (48 Per Set)
27 01-13000-029 Core Frame Cap

DT74 Jan2023 pg 28
 One Piece Poly Broom Core
Item Part No. Description
1 01-78000-201/96 Poly Tube Core Brush 96"
01-78000-201/90 Poly Tube Core Brush 90" (Non-Stock Item)
2 01-78000-202/96 Compression Core (Complete For 96" Core)
01-78000-202/90 Compression Core (Complete For 90" Core) (Non-Stock Item)
3 01-78000-205 Compression Disc - Rubber (2 Req'd)
4 01-78000-203 Brush Retainer Ring
5 01-13000-010 Idler Shaft Weldment (96" Core)
01-13000-010-10 Idler Shaft Weldment (90" Core)
6 01-78000-204 Brush Retainer Ring (Drive End For 96" Core)
01-78000-204/90 Brush Retainer Ring (Drive End For 90" Core)
7 01-13000-007 Drive Hub
8 01-78000-211 Poly / Wire Combination Brush 96"
01-78000-211/90 Poly / Wire Combination Brush 90" (Non-Stock Item)
9 01-78000-214 Compression Core Bolt Retaining Ring - Left End - 9-1/2" Long
10 01-78000-213 Compression Core Bolt Retaining Ring - Right End - Countersunk

Superior Broom Coreless Tube Brush

Item Part No. Description
1 01-78000-800 Core - Full Poly - Coreless Tube Brush 96" (Includes Items #2)
01-78000-810 Core - Poly / Wire Combination - Coreless Tube Brush 96" (Includes Items #2)
2 01-13000-806 Core End Plate - Coreless Brush
3 01-13000-010 Core Idler Shaft Weldment
4 01-13000-007 Drive Hub

DT74 Jan2023 pg 29
 Strip Brush
Item Part No. Description
1 01-78000-401/96 Strip Core 96" (Includes Item #3)
2 01-78000-402/96 Poly Strips (36 Per Set)
3 01-78000-403 Strip Core End Plates (4 Required)
4 01-13000-007 Drive Hub
5 01-13000-010 Core Idler Shaft Weldment

pg 30
DT74 Jan2023
 28
Control Console Ca / Perkin / ia / JD T4F
26 4

25 27

6
3

23 24
2

18
34

10

11

2A 2B

13 14
12

29 16

17

22
19

35 36
21
15
20

DT74 Jan2023 pg 31
 * - Top Panel May Vary Due
To Options - S/N Required

Hydraulic Control Panel - 01-50600-015

Is Obsolete - See Next Page For
Joystick Conversion Kit

Rocker Switch Parts

Item Part No. Description
1 01-50000-111B1 Mounting Panel - Plug
2 01-50000-111B2 Mounting Panel - Middle
3 01-50000-111B3 Mounting Panel - End
* 4 01-50000-111B4 Switch Actuator
* 5 01-50000-111B5 Switch Assembly (Less Actuator)

* - Typically Item #'s 4 & 5 Should Be Ordered Together

DT74 Jan2023 pg 32
 Scraper Blade & Gutter Brush Control Joystick
Item Part No. Description
1 01-50600-075JS Gutter Brush/Scraper Blade Accessory Control Joystick
2 01-17300-010JS Joystick Mounting Box
3 01-51000-075 GutterBrush / Scraper Blade Joystick Wiring Harness (Not Shown)

DT74 Jan2023 pg 33
 Tilt Steering Spare Tire Mount
Part Number 01-88000-001
Item Part No. Description
1 01-50000-097 Steering Wheel When Ordering, Please Indicate Intended
2 01-50000-098 Steering Wheel Center Method Of Installation; Either Bolt-On Or Welding.
3 01-77000-001 Telescopic Steering
4 01-77000-003 Tilt Lock Lever
5 01-77000-004 Tilt Steering Sleeve
6 Boot
7 Column Assembly
8 01-77000-005 Spring, Latch (2 Req'd)
9 01-77000-006 Spring, Counterbalance (2)
10 01-78000-003 Steering Wheel Nut

Battery 12V
Part Number 01-50000-051
950 CCA Battery
Battery Hold Down Bolts-Part Number 01-50000-052
Battery Hold Down Strap-Part Number 01-50000-052B

Work Light - LED w/Radio

Head Lamp / Driving Light Part Number 01-79000-022
Part Number 01-79000-009
Work Light - LED
Part Number 01-80000-903
Part Number 01-80000-902
Work Light - Halogen
Part Number 01-74000-001

Part Number 01-79000-021

Work Light Kit
Part Number BOM-01-74000-000
(Specify Side or Rear)

Brake / Tail Light

Part Number 01-79000-003

Brake / Tail Light LED

Part Number 01-79000-013
Rotating Beacon Cover Reflector 41 4"
Part Number 01-80000-101 Part Number 01-18000-052

Turn Signal Light Cover LED Strobe Light

Part Number 01-79000-050 Part Number 01-80000-004

Turn / Hazard Light Strobe Light

Part Number 01-79000-008 Part Number 01-80000-001
Turn / Hazard Light LED
Part Number 01-79000-016 Replacement Bulb w/Circuit
Turn / Hazard Light Bracket Board
Part Number 01-79000-108 (Used With Cab) Part Number 01-80000-003

DT74 Jan2023 pg 34
 Horn Cab Sliding Side Window

Cab Heater
John Deere
Starter Solenoid
2
Core Alignment Kit

Defroster Fan

Defroster Fan Kit

Fuse Panel

Ca ea er i
Ca /Perkin / ia 4

2
2
2
2

Ca ea er i
o n eere 4
lec rical Com onen 6 5 2 7
I

2
2
2
2
2
2

3 4

DT74 Jan2023 35
 2

4
8
9

11

17
19 21 7

8
6
5 17

10

12

13

14
15
16

22

* - Item 21 will be determined by the

head on the water pump. Only one
style will be needed, not both.

DT74 Jan2023 pg 36
 3
4

16 14

12 13

2 7
11
5A 6
10

5
13 18

1 5A

9 8

DT74 Jan2023 pg 37
 Side Shift Assembly BOM-01-39000-000
Item Part No. Description
1 01-12600-010 Side Shift - Circle Weldment
Below Items: Part #'s Not Assigned - For Reference Only
2 01-12600-030 Side Shift - Core Support Frame
Side Shift Hardware Bolts Washers Nuts
3 01-12600-006 Slide Frame Hydraulic Cylinder (1) - 1" NC X 4.5" Plated (2) - 1" Flat Plated (1) - 1" NC Nyloc
4 01-12600-022 Slide Channel Hydraulice Cylinder/Yoke (1) - 1" NC X 7.5" Plated (2) - 1" Flat Plated (1) - 1" NC Nyloc

5 01-50000-032 Circle Bearing - 8 Req'd Yoke Weldment (1) - 1" NC X 5" Plated (2) - 1" Flat Plated (1) - 1" NC Nyloc
Roller Assembly/Yoke (1) - 3/4" NC X 7" Plated (2) - 3/4" Flat Plated
6 01-12600-025 Yoke Weldment (1) - 1" NC Nyloc
Roller Assembly (1) - 3/4" NC X 6" Plated (2) - 3/4" Flat Plated (1) - 3/4" NC Nyloc
7 01-12600-038 Stepped Spacer - 2 Req'd (8) - 5/8" NC X 2.5" Plated (8) - 5/8" Flat Plated (8) - 5/8" NC Nyloc
8 01-12600-001 Hydraulic Cylinder
(8) - 5/8" Lock Plated
9 01-12600-009 Shift Pin - 2 Req'd
10 01-12600-044 Snap Ring - 4 Req'd
11 01-12600-029 Shift Pin Split Bushing - 2 Req'd
12 01-12600-024 Shift Pin Retainer - 4 Req'd
13 01-50000-036 Lift Cylinder 2 X 8
14 01-50000-033 Circle Shift Cylinder 2 X 16
15 01-50000-128 Core Cover Rock Guard
16 SK1C4244 Lift/Shift Cylinder Seal Kit (Not Shown) (For Items # 13 &14)
17 01-12600-031 Split Bushing Liner - 2 Req'd
18 SK207-099 Side Shift Hyd. Cylinder Seal Kit (Not Shown) (For Item# 8) - Serial # Req'd
19 SK4C6697 Side Shift Hyd. Cylinder Seal Kit (Not Shown) (For Item# 8) - Serial # Req'd

DT74 Jan2023 pg 38
 Gutter Brush Assembly 01-21000-000B
(Serial # 3 To Present)
Item Part No. Description
1 01-21000-048 Trip Spring (2)
2 01-22000-400 Motor Mount
3 01-21000-037 1/2" Cylinder Pin (4)
4 01-22000-100 Adjustment Arm
5 01-22000-200 Tilt Arm Assembly
6 Lynch Pin (3)
7 01-22000-040 Arm Pin (2)
7A 01-22000-040B 1" X 3.25" Shoulder Bolt (2)
8 01-21000-052B Hydraulic Tilt Cylinder
9 01-21000-045 Hub Assembly
10 01-22000-300 Lift Arm Assembly
11 01-21000-100 Mounting Bracket
12 01-21000-049 Primary Mount Pin
13 "E" Clips (8)
14 01-21000-051B Hydraulic Lift Cylinder
15 Eye Bolt (2)
16 01-21000-055 Wire Brush
16A 01-21000-055P Poly Brush
17 01-22000-036 Motor Mount Pivot Pin
17A 01-22000-036B 1" X 2" Shoulder Bolt
18 01-21600-002 Hydraulic Motor
19 01-21000-035 Brush Mounting Plate
20 SK4C5677 Lift/Tilt Cylinder Seal Kit (Not Shown)
21 01-48000-210 Decal - Joystick Control (Not Shown)
22 01-21600-001 Manifold (Not Shown)
23 01-50600-075JS Joystick (Not Shown)
24 01-51000-075 Joystick Harness (Not Shown)

DT74 Jan2023 pg 39
 Tow Bar Assembly
Item Part No. Description
1 BOM-01-19000-100 Tow Bar - Standard w/ Pintle Eye
2 BOM-01-19000-200 Tow Bar - Standard w/ 2 5/16 Ball Hitch
3 BOM-01-19000-300 Tow Bar - Surge Brake w/ Pintle Eye
4 BOM-01-19000-400 Tow Bar - Surge Brake w/ 2 5/16 Ball Hitch
5 01-19000-002 Tow Bar Jack

DT74 Jan2023 pg 40
 Front Axle Assembly (Disc Brakes)
Item Part No. Description
1 01-14100-001 Cylinder Mount Assembly
1A 01-14100-017 Cylinder Mount Bushing
2 01-14100-002 King Pin Kit - Does Both Sides
01-14100-002B King Pin Kit - One Side Only
3 01-50000-003 Front Axle Steering Cylinder
SK-ACAK2Q1Q Seal Kit - Steering Cylinder (Not Shown)
4 01-14100-003 Grease Cap
5 01-14100-104 Castle Nut w/ Cotter Pin
6 01-14100-015 Spindle Washer
7 01-14100-005DB Outer Bearing - Bearing Only
8 01-14100-106B Hub & Rotor Assembly (6 Bolt) - Includes Race & Studs
9 01-14100-012 Inner Bearing - Bearing Only
10 01-14100-011B Inner Seal
11 01-14100-008 Cylinder Tie Rod Tube (Short)
12 01-14100-130 Caliper (Left or Right)
13 01-14000-PAD Brake Pad Set (4 Pads) (Does Both Sides)
14 01-14100-114 Tie Rod Tube (Long)
15 01-14100-107 Knuckle w/ Spindle - Left
16 01-14100-110 Knuckle w/ Spindle - Right
17 01-14100-016 Right Tie Rod End
18 01-14100-013 Left Tie Rod End
19 35491-FB-DB Wheel Stud
20 01-50000-106 Lug Nut
21 01-50000-013DB Brake Hose (Rubber)
22 01-50000-014 Brake Line 3 16" X 144" (Not Shown)
23 01-50000-016 Brake Line 3 16" X 20" (Not Shown)
24 01-50000-017 Brake Line 3 16" X 40" (Not Shown)
25 01-50000-018 Brake Line 3 16" X 44" (Not Shown)
26 01-14100-135 Disc Brake Rotor Guard (Universal - For Right & Left)

When ordering Tie Rod

Ends, the front axle requires
(2) Left's & (1) Right.

For Axle Assembly Order Part # 01-50000-001DB, Steering Cylinder & Brake Lines Sold Seperately

41
DT74 Jan2023
DT74 Jan2023 pg 42
 P/N - Filter Kit-Deere DT74 ( Includes One Each Of The Items Below )
01-50001-046B Engine Air Cleaner - Outer Filter
01-50001-047B Engine Air Cleaner - Inner Filter
01-86000-120 Cab - Air Cleaner Filter
01-50600-004M Hydraulic Charge Filter Element (Spin On) (Serial # 815020 & Up)
01-50600-014 Hydraulic Return Filter Element (Tank Filter)
01-50600-017 Hydraulic Breather Filter
RE504836 Oil Filter
RE551507 Primary Fuel Filter
RE551508 Final Fuel Filter

P/N - Filter Kit Perkins (Includes One Each Of Following)

01-50001-046B Engine Air Cleaner Outer Filter
01-50001-047B Engine Air Cleaner Inner Filter
01-86000-120 Cab Air Cleaner Filter
01-50600-004M Hydraulic Charge Filter (spin On)
01-50600-014 Hydraulic Return Filter Element
01-50600-017 Hydraulic Breather Element
05-50000-402 Engine Oil Filter
05-50000-403 Engine Fuel Filter
05-50000-404 Engine Fuel Filter

P/N - Filter Kit Cat (Includes One Each Of Following)

01-50001-046B Engine Air Cleaner Outer Filter
01-50001-047B Engine Air Cleaner Inner Filter
01-86000-120 Cab Air Cleaner Filter
01-50600-004M Hydraulic Charge Filter (spin On)
01-50600-014 Hydraulic Return Filter Element
01-50600-017 Hydraulic Breather Element
05-50000-405 Engine Oil Filter
05-50000-406 Engine Fuel Filter
05-50000-407 Engine Fuel Filter

P/N - Filter Kit Fiat (Includes One Each Of Following)

01-50001-046B Engine Air Cleaner Outer Filter
01-50001-047B Engine Air Cleaner Inner Filter
01-86000-120 Cab Air Cleaner Filter
01-50600-004M Hydraulic Charge Filter (Spin On)
01-50600-014 Hydraulic Return Filter Element
01-50600-017 Hydraulic Breather Element
08-50000-402 Engine Oil Filter
08-50000-403 Engine Fuel Filter
08-50000-404 Engine Fuel Filter

DT74 Jan2023 pg 43
 Superior Broom
Recommended Stock List
John Deere T4F

* Stock Brush Sets According To Dealer Machine Sales

pg 44
DT74 Jan2023
 Superior Broom
Recommended Stock List
Cat / Perkins / Fiat T4F

DT74 Jan2023 pg 45
 Tinted Safety Glass
For Replacement Glass -
Take Information Below To Local Glass Supplier.
.25" Glass - BLUE/GREEN TINT- 73% LIGHT TRANS, LAMINATED

01-16000-007 Window Molding (Per Foot)

27.00 28.56

20.00
#4 EDGE ALL AROUND

4X R3.00 42.96
Door & Side Glass #4 EDGE ALL AROUND

01-16000-003
9' of Window Molding

15.92 88° 2X
4X R3.00 REF

84°
31.60

Windshield
01-16000-004
#4 EDGE 13' of Window Molding
ALL AROUND

45.96

31.00

20.00
#4 EDGE ALL AROUND
4X R3.00

11.48
4X R3.00
Corner Glass (Left or Right) Rear Glass
01-16000-005 01-16000-006
11' of Window Molding 10' of Window Molding

DT74 Jan2023 pg 46
 BYPASS CHECK VALVE
Valve-01-50600-018
Tee-01-50600-019

OIL COOLER
01-50001-061
HYDRAULIC MANIFOLD
01-50000-060T4B
01-50600-003B

FILTER
STEERING UNIT 01-50600-004
01-50600-011 HYDRASTAT
01-50600-004M
01-50600-009
GEARBOX DRIVE
01-50600-009R
MTR.
01-50600-008
01-50600-008R
COMPENSATOR PUMP
01-50600-002
01-50600-002B
01-50600-002R

SHIFT CYL. 2-SPEED GEARBOX

01-50000-033 01-50000-087

CORE MTR.
01-50600-001B

LIFT CYL.
STEERING CYL. 01-50000-036
01-50000-003

pg 47
DT74 Jan2023
 Hydraulic Manifold Assembly
01-50600-003B (Serial # 3 ) (Silver)
3C erial
Item Part No. Description
1 01-50600-050 Brush Compensator Valve
2 01-50600-051 Adjustable Speed Control Valve (Includes Item #4)
* 3 01-50600-052 Speed Control Coil
* 4 01-50600-053 Speed Control Coil Retainer Nut w/ "O" Ring
* 5 01-50600-054 Jammer Valve
6 01-50600-054F Float Valve
7 01-50600-055 Function Control Valve
8 01-50600-156 Coil Spacer
9 01-50600-057 Function Control Coil
10 01-50600-058 Retainer Nut
11 01-50600-059 Priority Steering Valve
12 01-51000-108 DEN Connector
13 01-50600-062 P.O. Check Valve (Not Shown)
14 01-50600-065 Orifice Disk
15 RV08-20A-0-NC-33/20 Brush Lift Cylinder Relief Valve
16 01-29600-003 Parking Brake Safety Valve Assembly
17 01-29600-002 Park Brake Valve
18 01-29600-001 Valve Body
19 2408T-0.1 Load Sensor Bleed Valve
* - Includes Part # 01-50600-058 Retainer Nut

pg 48
DT74 Jan2023
 Scraper Blade Hydraulic Manifold Assembly
Item Part No. Description
1 01-15200-001 Scraper Blade Hydraulic Manifold Assy.
2 01-50600-058 Retainer Nut
* 3 01-50600-054F Float Valve
* 4 01-50600-055 Function Control Valve
5 01-50600-156 Coil Spacer
6 01-50600-057 Function Control Coil

* - Includes Part # 01-50600-058 Retainer Nut

Gutter Brush Hydraulic Manifold Assembly

Item Part No. Description
1 01-21600-001 Gutter Brush Hydraulic Manifold Assy.
2 01-50600-058 Retainer Nut
* 3 01-50600-054F Float Valve
* 4 01-50600-055 Function Control Valve
5 01-50600-156 Coil Spacer
6 01-50600-057 Function Control Coil

* - Includes Part # 01-50600-058 Retainer Nut

DT74 Jan2023 pg 49
 SCRAPER BLADE - HYDRAULIC MANIFOLD
BLADE - FLOAT BLADE - FLOAT
GREY ORANGE

BLADE - RIGHT
YELLOW (BOTTOM)

BLADE - DOWN BLADE - UP BLADE - LEFT

TAN (TOP) BLUE (BOTTOM) GREEN (TOP)

GUTTER BRUSH - HYDRAULIC MANIFOLD

BRUSH - TILT UP
BLUE (BOTTOM)

BRUSH - LEFT
GREEN (BOTTOM)

BRUSH - ON/OFF BRUSH - FLOAT

PURPLE GREY

BRUSH - RIGHT BRUSH - FLOAT

YELLOW (TOP) ORANGE
BRUSH - TILT DOWN
BROWN (TOP)

BRUSH - HYDRAULIC MANIFOLD

JAMMER BRUSH - LEFT BRUSH - FLOAT BRUSH - FLOAT
PURPLE TAN (BOTTOM) - OLD WHITE ORANGE - OLD
YELLOW (BOTTOM) - NEW ORANGE/WHITE - NEW

BRUSH - UP
GREY (BOTTOM)

BRUSH - RIGHT BRUSH - DOWN

BRUSH - ON / OFF - GREEN PINK (TOP) - OLD BLACK / WHITE (TOP) - OLD
ORANGE (TOP) - NEW RED / WHITE (TOP) - NEW

pg 50
DT74 Jan2023
 John Deere T4F

pg 51
DT74 Jan2023
 CAT T4F Elec. Schem.

DT74 Jan2023 pg 52
 CATI--
- + ♦ I "' ,_..,...., 9' '::t

DT74 Jan2023
I �-------�!-. I
f J,wHlad I. I • I Grey
6lodc
a Grey/8lacf<
Yellow
-..Jl'l- -'- Green
..,...
_,.
,.,,_
CATI--

Right Rear'
Tum,'ll,ulce Light
Fiat T4F

,-i --- -- �-�

i

pg 53
L__ -.c:-,c..
··-­
··.....
........­_....
IY•­
Wiring Schematic for = Ol•Clmlp
..,..............
T4f FIAT machines. .....
Hom
··­­
�, T•r.
Mon �
-
-·.........
Hom -
• Call for info on
,.,....
Hydraulic Schematics. !
i
� ___::: i
l
I
,--�-
' -- --7' i i �I I
1�M��1
PV380 I I
S1174/SMSO
or ___J
HYD. ECU
!! !! PV450
L___________j I t t f I �•r.11 !
_____ .!,:!.________ � ________ ...J
DT74 Jan2023
CV5
RV2
OR6
.045
CV1
PV1 SV3 SV4
PC2
EC1 OR5
.045
CV2

PC1
OR2
.030 RV3

OR1
RV1
.031 SV5 SV6
EC2 OR3 0R4
.063 CV3 CV4 .063
PR1
SV1

pg 54
PRESSURES
Any function but brush on 1750 PSI
Brush on but no load 900-1200 PSI
Brush on in float 2100 PSI
 Lubrication and Maintenance Service Interval

Engine Oil:
Refer to the engine
owners manual.

Hydraulic Oil:
Conoco Megaflow AW46

Gearbox Oil:
Third Member Oil: 3 Quarts.
Conoco Universal Gear Oil
85W-140

Antifreeze:
Mach 4 Global
Premix 50/50 AF1/55

A/C Refrigerant
Freon -134A Refrigerant
Unit Should be Charged To 2 Lbs.

DT74 Jan2023 pg 55