SLV-GA30/GA50/GA66/GA70K/GA77K/

GF80/GF90K/GF99K/P66/PH99
RMT-V254/V254A

SERVICE MANUAL

East European Model

SLV-P66/PH99

Ver 1.0 1998.10

ME Model
SLV-GA30/GA50/GA66/GF99K

Philippine Model
SLV-GA77K/GF99K

E Model
SLV-GA30/GA50/GA70K/
GA77K/GF80/GF90K/GF99K
Photo: SLV-GF99K
RMT-V254

Thai Model
SLV-GA30/GA50/GA70K/
GA77K/GF80/GF90K/GF99K

S MECHANISM

Refer to the SERVICE MANUAL of VHS

MECHANICAL ADJUSTMENT for
MECHANICAL ADJUSTMENTS. (9-921-647-11)

SPECIFICATIONS

VIDEO CASSETTE PLAYER

MICROFILM

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH
MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.

SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
1.

2.
3.

Check the area of your repair for unsoldered or poorly-soldered

connections. Check the entire board surface for solder splashes
and bridges.
Check the interboard wiring to ensure that no wires are
"pinched" or contact high-wattage resistors.
Look for unauthorized replacement parts, particularly
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.

4.

Look for parts which, through functioning, show obvious signs

of deterioration. Point them out to the customer and
recommend their replacement.
5. Check the B+ voltage to see it is at the values specified.
6. Flexible Circuit Board Repairing
Keep the temperature of the soldering iron around 270C
during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.

MODEL (SLV-)
FEATURES
NTSC 3.58 REC/PB
NTSC 4.43 REC/PB
PAL REC/PB
MESECAM REC/PB
NTSC PB ON PAL TV
REC MODE
NTSC
PAL
PLAY MODE
NTSC
PAL
AUDIO SYSTEM
KARAOKE
KARAOKE PON
SOUNDS IN STEREO
SURROUND
TAPE SPEED
LINE IN (RCA PINS)
FRONT
REAR
LINE OUT(RCA PINS) FRONT
REAR
RF IN/OUT
REMOTE COMMANDER

MODEL (SLV-)
FEATURES
NTSC 3.58 REC/PB
NTSC 4.43 REC/PB
PAL REC/PB
MESECAM REC/PB
NTSC PB ON PAL TV
REC MODE
NTSC
PAL
PLAY MODE
NTSC
PAL
AUDIO SYSTEM
KARAOKE
KARAOKE PON
SOUNDS IN STEREO
SURROUND
TAPE SPEED
LINE IN (RCA PINS)
FRONT
REAR
LINE OUT(RCA PINS) FRONT
REAR
RF IN/OUT
REMOTE COMMANDER

PS

ME

3
3
3
3

MONO
O
O
X
O

SP

SP

GA77K
TK
O/O
PL

PS

USA

X/X
X/X
X/X
X

X
X
X
2
GK
RMT-V254A

MONO
X
X
X
X

X/X
X/O
X/O
X/O
O
X
X

GA30

GK
RMT-V254

SP

SP

O/O
O/O
O/O
O

SP/LP/EP
SP/LP

SG

SP
SP

GF80
O/O
O/O
O/O
O/O
O
SP
SP
SP
SP
Hi-Fi
X
X
X
X
X
3
3
X
3
GK
RMT-V254

PS

TK

TK

ME

O
X
2
X
2
GK
RMT-V254

MONO
X
X
X
X

O/O
O/O
O/O
O/O
O

GA50

PH99
EE
O/O
O/O
O/O
O/O
O
SP
SP
SP
SP
Hi-Fi
X
X
X
X
X
3
3
X
3
GK
RMT-V254

SP/EP
SP/LP
SP/LP/EP
SP/LP

SG

GF90K

SP
SP
SP
SP

O/O
O/O
O/O
O/O
O
SP
SP
SP
SP
Hi-Fi
O
O
X
X
X
3
3
X
3
GK
RMT-V254

PS

PS

TK

TK

ME

P66
EE
O/O
O/O
O/O
O/O
O
SP
SP
SP
SP
MONO
X
X
X
X
X
X
2
X
2
GK
RMT-V254

GK

O/O
O/O
O/O
O
SP
SP
SP
SP

PS

PS

TK

RMT-V254

3
3
3
3

Hi-Fi
O
O
O
O

O/O

GF99K

GA66
ME
O/O
O/O
O/O
O/O
O
SP/EP
SP/LP
SP/LP/EP
SP/LP
MONO
X
X
X
O
O
3
3
3
3
GK
RMT-V254

PL

TK

USA

X/X
X/X
X/X
X
SP/EP
X
SP/LP/EP
X

O/O
O/O
O/O
O/O
O
SP
SP
SP
SP
MONO
O
X
X
X
X
X
2
X
2
GK
RMT-V254

GA70K

Abbreviation
SG: Gulf Model
PS: Pan Asia Model
TK: Thai Model
EE: East European Model
PL: Philippine Model

TABLE OF CONTENTS
1.

GENERAL

Step 1 Unpacking 1-1

Step 2 Setting up the remote commander 1-1
Step 3 Connecting the unit 1-1
Step 4 Tuning your TV to the unit 1-2
Playing a tape 1-2
Playing/searching at various speeds 1-3
Karaoke sing-along 1-4
Enjoying the surround sound (Virtual Surround)
(SLV-GF-99KME/PS only) 1-5
Adjusting the picture (Resolution Control) 1-5
Editing with another VCR 1-6
Synchronised recording 1-6
Troubleshooting 1-7
Index to parts and controls 1-7

2.

DISASSEMBLY

2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.

Upper Case, Panel Block Assembly 2-1

FR-140, 141, 142, JK-166, MJ-91 Boards 2-1
Rear Panel 2-2
MA-336 Board 2-2
Mechanism Deck 2-3
Internal Views 2-4
Circuit Boards Location 2-5

3.

BLOCK DIAGRAMS

3-1.
3-2.
3-3.
3-4.
3-5.
3-6.

Overall Block Diagram 3-1

Video Block Diagram 3-3
Servo/System Control Block Diagram 3-5
Audio Block Diagram 3-7
Karaoke Block Diagram 3-9
Power Supply Block Diagram 3-11

4.

PRINTED WIRING BOARDS AND

SCHEMATIC DIAGRAMS

4-1. Frame Schematic Diagram 4-3

4-2. Printed Wiring Boards and Schematic Diagrams 4-5
MA-336 (Video, Audio)(1/4) Schematic Diagram 4-5
MA-336 (Servo/System Control)(2/4)
Schematic Diagram 4-7
MA-336 (HiFi, Tuner)(3/4) Schematic Diagram 4-9
MA-336 (Karaoke, Power Supply)(4/4)
Schematic Diagram 4-11
MA-336 (Video, Audio, Servo/System Control, Tuner,
Karaoke, Power Supply) Printed Wiring Board 4-13
SR-35 (Surround) Printed Wiring Board 4-16
SR-35 (Surround) Schematic Diagram 4-17
FR-142 (Mode Control) Printed Wiring Board 4-19
FR-142 (Mode Control) Schematic Diagram 4-21
FR-140 (Power, Eject Switches)
Printed Wiring Board and
Schematic Diagram 4-23
FR-141 (Tape Operation)
Printed Wiring Board and
Schematic Diagram 4-24
MJ-91 (MIC Jack, Amp)
Printed Wiring Board and
Schematic Diagram 4-25
JK-166 (Line In/Out)
Printed Wiring Board and
Schematic Diagram 4-26

5.

5-2. System Control Servo Peripheral Circuit Interface

(MA-336 Board IC201) 5-1
5-3. System Control Mechanism Interface
(MA-336 Board IC201) 5-2
5-4. System Control Audio Block Interface
(MA-336 Board IC201) 5-2
5-6. Servo/System Control Microprocessor Pin Functions
(MA-336 Board IC201) 5-3

6.

ADJUSTMENTS

6-1 Mechanical Adjustments 6-1

6-2. Electrical Adjustments 6-1
2-1. Preparation before Adjustment 6-1
2-1-1. Equipment Required 6-1
2-1-2. Equipment Connection 6-1
2-1-3. Set-up of Adjustment 6-1
2-1-4. Alignment Tape 6-1
2-1-5. Input/Output Levels and Impedance 6-2
2-1-6. Adjustment Sequence 6-2
2-2. POwer Supply Check 6-2
2-2-1. Output Voltage Check (MA-336 Board) 6-2
2-3. Servo System Check 6-3
2-3-1. RF Switching Position Adjustment (MA-336 Board) 6-3
2-4. Audio System Adjustment 6-3
2-4-1. Hi-Fi Audio System Adjustment (Hi-Fi model only) 6-3
1.
AF Switching Position Adjustment (MA-336 Board) 6-4
2-4-2. Normal Audio System Adjustment 6-4
1.
ACE Head Adjustment 6-4
2.
E-E Output Level Check 6-4
3.
Recording Bias Check 6-4
2-5. Adjusting Parts Location Diagram 6-6

7.

REPAIR PARTS LIST

7-1. Exploded Views 7-1

7-1-1. Front Panel and Upper Case Section 7-1
7-1-2. Chassis Section 7-3
7-1-3. Mechanism Deck Section-1 7-4
7-1-4. Mechanism Deck Section-2 7-5
7-1-5. Mechanism Deck Section-3 7-6
7-2. Electrical Parts List 7-7

INTERFACE, IC PIN FUNCTION

DESCRIPTION

5-1. System Control Video Block Interface

(MA-336 Board IC201) 5-1

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
This section is extracted from instruction
SECTION 1
manual.(SLV-GF90K/GF99K model)
GENERAL

1-1

1-2

1-3

1-4

1-5

1-6

1-7

1-8E

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
SECTION 2
DISASSEMBLY
NOTE: Follow the disassembly procedure in the numerical order given.

2-1. UPPER CASE, PANEL BLOCK ASSEMBLY

1 Tapping screw

3 Upper case

7 Flat cable
(From CN206 on
MA-335 board)
8 Flat cable
(From CN201 on
MA-335 board)
9 Connector
(From CN207 on
MA-336 board)

2 Tapping screw
4 Flat cable
(From CN206 on
MA-336 board)

Hooks

5 Connector
(From CN209 on
MA-336 board)

! Panel block assembly

(Engaged by the hook.)

6 Connector
(From CN208 on
MA-336 board)

Hooks

Hooks

Hooks

2-2. FR-140, 141, 142, JK-166, MJ-91 BOARDS

! BV sumitite (B3)
! MJ-91 board

! MIC jack holder

2 FR-140 board

5 B2.6 8

! B2.6 8
1 B2.6 8

6 FR-142 board
7 B2.6 8
8 JK-166 board

3 B2.6 8

Front panel assembly

4 FR-141 board

2-1

2-3. REAR PANEL

3 Rear panel
(Engaged by the hook.)

Hooks

1 BVTP 3 12

Hooks

Hooks
2 POWER code stopper

2-4. MA-336 BOARD

1 Sumitite (B3) +BV

2 MA-336 board with

mechanism deck

2-2

2-5. MECHANISM DECK

2 Three connectors
5 BVTP 3 12
3 BVTP 3 12
9 Mechanism deck
1

8 MA-336 board

4 MD base (R)

7 MD base (M)
6 MD base (R)

2-3

Abbreviation
SG: Gulf Model
PS: Pan Asia Model
TK: Thai Model

2-6. INTERNAL VIEWS

Top View
M901
Drum Assembly

EE: East European Model

PL: Philippine Model

DZH-78A-R 1-759-183-11
(GA30:PS,TK/GA50:PS,TK/GA70K:PS,TK/GA77K:PS,TK/P66)
DZH-91A-R 1-759-449-11
(GF80:PS,TK/GF90K:PS,TK/GF99K:ME,PS,TK/PH99)
DZH-90A-R 1-759-451-11
(GF99K:PL)
DZH-89A-R 1-759-453-11
(GA30:SG,ME/GA50:SG,ME/GA66:ME)
DZH-71D-R 1-759-455-11
ACE head block assembly
(GA77K:PL)
A-6759-620-A
FE head
1-500-144-11
Pinch press block assembly
A-6759-615-A

Reel (T) table

3-977-508-01

Reel (S) table

3-977-507-01

FL complete assembly
A-6759-619-B

Bottom View
M902
DC motor (capstan)
1-698-971-11

Rubber belt
3-977-510-01

M903
Cam motor assembly
X-3947-577-1

2-4

2-7. CIRCUIT BOARDS LOCATION

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

2-5E

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

SECTION 3
BLOCK DIAGRAMS
3-1. OVERALL BLOCK DIAGRAM
MA-336 BOARD

(SEE PAGE 4-5, 7, 9, 11)

VIDEO
HEAD

IC201

IC101

SP
CH1

REC/PB (RF)

SP
CH1

REC/PB (RF)

IC201

(1/2)

(1/2)

OSD

Q801

CNJ801

BUFF

VIDEO
LINE OUT1

DRUM DA

(SEE PAGE 4-26)

V1

JK-166
BOARD

CAPSTAN
FG

CTL
AUDIO
LINE OUT2

JS932

(SEE PAGE 4-26)

SYSTEM
CONTROL

JK-166
BOARD

V DATA / V CLK
QVD

V2

CSYNC

MODE1-4

GF80/GF90K/PH99

AFM
REC/PB
AMP
CH2

R1

AUDIO
PROCESSOR
(HIFI)

AF SWP
REC P

JS929

REC RF

GA66/
GA77K
GF80/PH99

JS903

GA30/GA50/GA66/P66

JS902

RF
JS930

CH1

L1

NA IN

JS910

NA OUT

AF ENV

AFM
REC/PB
HEAD

SDA/SCL

L2

R2

L1

R1

IC101

(2/2)

AUDIO
PROCESSOR
(NORMAL)

GF90K
/GF99K

GA30/GA50/
GA70K/P66

IC752

GA30/GA50/
GA66/GF80/
P66/PH99

CAM
S201
ENCODER

EXCEPT GF80/GF90K/
GF99K/PH99

JS904

JS908

JS927

JS905

JS909

JS928

CNJ801

Q601

AUDIO
LINE OUT1

GA66/GA77K

GA66/GF80/PH99

LED POWER
EXCEPT
GA30 MODEL

LED
DRIVE

RFU801

VIDEO

S601,602

KEY1

IN

KEY(1)

TV/VTR

GA66/GF90K

AUDIO

GA30/GA66/
GF90K/P66

AMS

BIAS
OSC

FULL
ERASE
HEAD

V DATA / V CLK

S606-609
S620

V ENV
GA50/GA70K/P66
MODEL

BIAS
OSC

EXCEPT
GA30 MODEL

KEY2
KEY(2)

QVD

JS901

T401
Q401-404 Q405,406

FR-140 BOARD
(SEE PAGE 4-23)

GA40K/GA70K/GA77K
GF90K/GF99K MODEL

EXCEPT
GA30

D601

FUNCTION
KEY

OUT

MESECAM

ERASE
HEAD

EXCEPT
GA77K:PL/GF99K:PL

Q602

JS907

IC301
PB RF

CAM
MOTOR

GA66/GA77K/GF99K MODEL

JS906

IC302

CTL
HEAD

IC202
CAM
MOTOR
DRIVE

V ENV

GF80/GF90K/GF99K/PH99 MODEL
AUDIO
HEAD

CAP FG

VIDEO
LINE OUT2

CAPSTAN
MOTOR

GF90K/GF99K
JS931

GA66/GA77K
GF80/GF90K/GF99K/PH99 MODEL

VIDEO
LINE IN 2

CAP RVS
CAPSTAN
SERVO

CNJ651

MESECAM

CNJ651

DRUM
FG/PG

Q224,225

EXCEPT
GA77K:PL/GF99K:PL

DRUM
MOTOR

DRUM
SERVO
DRUM FG/PG

VIDEO
REC/PB AMP
Y/C PROC.

CNJ801
VIDEO
LINE IN 1

MD BLOCK

(2/2)

KEY(4)

FUNCTION
KEY
D602

SYNC REC

IC751

(SEE PAGE 4-24)

IC752
CNJ801

JS921

AUDIO
LINE IN 1
R

EXCEPT
GA30

S615
GA66/GA77K/GF99K MODEL

INPUT
SELECTOR

JS922
GA66/GA77K

GA66 MODEL

SR-35 BOARD

JS701

(SEE PAGE 4-17)

CNJ651

GA66/GA77K
GF90K/GF99K MODEL

L2

S203

GA70K/GA77K
GF90K/GF99K MODEL

(SEE PAGE 4-26)

GA66/GA77K MODEL

S603

S610

IC502

NTSC
PB

GA66
GA77K/GF99K

IC701

IC702

IC703

IC503

VOCAL
CANCEL

SS/
SURR(A)

SURR(B)

KARAOKE
PROC.
/SRAM

S605
COLOR
SYSTEM

S611-614
KEY3
AMS
SDA / SCL

GF90K/GF99K

GA66/GA70K/GA77K
GF80/GF90K/GF99K/PH99

EXCEPT
GA77K:PL/GF99K:PL

SIGNAL
CONTROL

R2

GA66/GA77K/GF80/
GF90K/GF99K/PH99

VIRTUAL
SOUND

REC

GA77K/GF99K MODEL

AUDIO
LINE IN 1

LINE
SELECT

KEY4

JS702

JK-166
BOARD

FR-141
BOARD

CSYNC

EXCEPT
GA77K:PL/GF99K:PL

FUNCTION
KEY

S204
PAUSE
ADJ-A
ADJ-B

JS925
AF ENV
JS926

AF SWP

Q207-209
Q211-213

GF80/GF90K
/GF99K/PH99

REC P
Q233

D603-607

GA77K:PL/GF99K:PL

D608
PH202

MJ-91 BOARD (SEE

T REEL
FG

PAGE 4-25)

T REEL

MCJ501
MIC 1

IC501

T
SENS

MIC

S
SENS

2
MIC 2

KARAOKE

REMOTE
CONTROL
RECEIVER

RMC

RESET

KR SW/ECHO VR
ECHO

(SEE PAGE 4-21)

FR-142 BOARD
16

3-1

GA66/GA77K/GF99K MODEL

FR-142 BOARD
(SEE PAGE 3-21)

S SENS

IC203

KARAOKE PON

GA30:PL/GA40K/GA77K:PL/GF99K:PL

D614

IC601

T SENS

TE/LED
S501

GF80/GF90K/GF99K/PH99

D613

D615,616

Q202

MCJ502

GA70K/GA77K/GF90K/GF99K

D610-612

S REEL

Q201

IC501

EXCEPT GA30

D609

PH201
S REEL
FG

MIC IN

LED
DRIVE

3-2

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

3-2. VIDEO BLOCK DIAGRAM

CN101 3 REC/PB

MA-336 BOARD
5Vp-p
25Hz

Q102

FOR
CHECK

CN101 2 PB

2
DRUM
VIDEO
HEAD

0.1V/div 0.2sec/div

(SEE PAGE 4-5)

CN101
V SW P

PB RF

IC101

BUFF

VIDEO
REC/PB AMP
Y/C PROCESSOR
81

79

78

89

88

SP
CH1

SP1

SP
CH2

87

IC201

80

QVD

IC201

27

TO/FROM
SYSCON
BLOCK

RFU801

SP

SW29

(SEE PAGE 3-5)

B.D

REC
MUTE
SEP

SW19

CK

55

54

6dB
AMP

C
SQUELCH

IC101 *, * REC

6dB
AMP

BUFF

52

IC101 % REC/PB

(1/3)

SW24

C
LPF

LPF

VIDEO
ALC

REC:0.4Vp-p
PB:0.5Vp-p

SQUELCH

OSD

45

MIX
LEVEL

SW7

0.5V/div 0.1sec/div

2FL
VCO

1/2

IC201 $$ REC/PB

4 PHASE
GEN

(SEE PAGE 4-26)

CNJ801
MMS
DL

ATT
(-10dB)

VIDEO
AGC

G EQ
30

DLIM

1M
HPF
28

GA66/GA77K
GF80/GF90K/GF99K/PH99
MODEL

58

VCA

60

35

7M
LPF

DEMO

LPF

SUB
LPF

FM
MODE

ATT
(-10dB)

P
R

46

C
CCD

GA66/GA77K/GF99K
MODEL
REC:0.28Vp-p
PB:0.35Vp-p

SW23
IC101 ^ REC/PB

SW22

23

24

LPF

26

MAIN
DE-EMPH
MAIN EMPH
CARRIER
OFFSET W.C/DC

21

39

IC101 $ REC/PB

CLOCK 44
Y
LPF
P

SW17
R

REC:0.28Vp-p
PB:0.35Vp-p

42

SW10

SW5

SW11

IC101 $ REC/PB

SW13
N.L.
DE EMPH

0.45Vp-p

8.8671MHz

IC101 # REC/PB

N.L.
EMPH

D.E.

REC:0.5Vp-p
PB:0.6Vp-p

CLP

REC:0.35Vp-p
PB:0.38Vp-p

IC101 @ REC/PB

N.C.

IC101 % REC/PB
H

Y NR
FBC/
ALC

0.4Vp-p

SW14

DO

SYNC
SEP

DO REC

50

C SYNC

4.6Vp-p

IC201

54

CLP
IC101 ^ REC/PB

CR DET
2fSC
X-TAL
VCO/OSC

69
REC
APC

IC101 ! REC/PB

PB
APC

IC101 & REC/PB

REC
AFC

0.1Vp-p
3.579545MHz

75

73

71

8.667MHz

KILL
16

18 17

0.46Vp-p

63

V DATA

IC201 100

62

V CLOCK

IC201

99

64

KILL

IC201

19

19

X101
4.43MHz

SHARPNESS
CONT

X102
3.58MHz

0.54Vp-p

IC101 & REC/PB

EXCEPT GA77K:PL/GF99K:PL MODEL

Q104

Q103
PAL

Q204

SHARP 1

IC201

20

SHARP 2

IC201

29

SHAPNESS

IC201

94

NTSC

IC201

18

Q101

4.433619MHz

0.66Vp-p

16

3-3

TO/FROM
SYSCON
BLOCK

(SEE PAGE
3-5)

Q217-219

IC101 & REC/PB

4.433619MHz

SERIAL
CONT

REC:0.4Vp-p
PB:0.48Vp-p

PULSE
GEN.

76

CN651
V OUT2

JK-166
BOARD

REC:0.41Vp-p
PB:0.6Vp-p

Y
CCD

CN202

CN651

JK-166
BOARD
(SEE PAGE
4-26)

SW8
ATT
(-10dB)

CCD
LPF

C
LPF

P EQ

2.6Vp-p

IC101 $ REC/PB

DL

IC101 # REC/PB

SW26

DL

FM
AGC

2Vp-p

IC201 % REC/PB

51

B.E

SW25

MAIN
CONV.2

VIDEO
OUT 1

CN202

MAIN
CONV.1

629
TRAP

31

C.K

CNJ801

BUFF

53

8.86716MHz

Q801

52

2fSC
AMP

TRAP
P

43

Q205,214
CLEAR
SYNC

SW18

HPF

COMP

V IN2

IN
4 TV/VTR
OUT

IC201

VCA

VIDEO
IN 2

2 AUDIO

1 VIDEO

Q215,216
R
CTL TRAP
fH HPF

SP2

CNJ651

RFU AUDIO

SW21

ACC

REC:2.2Vp-p
PB:2.3Vp-p

0.58Vp-p

SW20

SW27

SP

SP2

VIDEO
IN 1

FROM
AUDIO
BLOCK

EXCEPT
GA77K:PL/ Q224,225
GF99K:PL

IC101 % PB

REC
MUTE

SP1
86

13

MESECAM

SW28
SW30

24

IC101 % REC/PB

ENV
DET

HPF

IC201
IC201

(SEE PAGE 3-8)

84 97

DRUM FF

CN102
6

RF SW P
V ENV

3-4

CNJ652
VIDEO
OUT 2

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

3-3. SERVO/SYSTEM CONTROL BLOCK DIAGRAM

MA-336 BOARD

FR-140 BOARD (SEE

(SEE PAGE 4-7)

IC204
12V

DRUM MOTOR
7

VCC

IC203

16 RESET

IC201

CN207
LED POWER

(2/3)

88 T REEL FG

5Vp-p

0.88MHz

D VS

26 DRUM DA

POWER
ON

EXCEPT
GA77K:PL/GF99K:PL
MODEL

S601

S602

ON
STANDBY

OUTPUT

Q602

CN605

KEY 1

KEY 1 3

PH202
T REEL
FG

D601

POWER
ON

TO
KARAOKE
BLOCK

M12V

SERVO CONTROL

OUTPUT
1

POWER ON IC502 4

POWER LED 67

(SEE PAGE 3-10)

D5V

PAGE 4-23)

Q601

SYSTEM CONTROL

7 RESET 8

(3/3)

IC201 @ REC/PB

CN204

M901

5V
REG

IC201

KEY (1)

89 S REEL FG

EJECT

IC201 # REC/PB

HALL
DEVICE

PH201
S REEL
FG

MATRIX
4.1Vp-p

25Hz

D PG

2
M12V

39 DRUM PG

FR-141 BOARD

Q201
TAKE END
SENSOR

D FG

38 DRUM FG

11 S SENS

KEY (2)

Q202
SUPPLY END
SENSOR

KEY (4)

Q203

CAPSTAN MOTOR
600Hz

CN205

V+

VM

VCC

TL

D5V
LIMITER

V-

GF80/GF90K/GF99K
/PH99

66 CAP PWM

A SWP
ADJ

CTL REF

SYNC REC

LED
DRIVE

5V

CAP VS

8 V SWP ADJ

5Vp-p

1.18MHz

12

14

X201
10MHz

40 CAP FG
4.6Vp-p

3.2Vp-p

32 CTL IN-

CTL
HEAD

VIRTUAL
SOUND

CN206
KEY 3

KEY 3 5

2 CAM-

95 CAM

IN2 4

ADJ-A

ADJ-A 92

MODE1
MODE2

IC201 @@ REC/PB

MODE3
MODE4

25Hz

5Vp-p

IC201 % REC/PB

IC101 81

RF SWP

IC101 84

V ENV

RFU801 4 ,Q220 C

MESECAM DET

IC101 51

QVD

63 MODE2

TO/FROM
VIDEO
BLOCK

Q207-209
Q211-213

65 MODE4

(SEE PAGE 3-4)

GA70K/GA77K
GF90K/GF99K MODEL

13 V ENV

SHARP LED 87

80 TV/VTR

TRACK LED 56
L LED 84

27 QVD

C SYNC

54 C SYNC

V DATA

100 V DATA

IC101 62

99 V CLK

IC101 64

KILL

Q217 B

SHARP 1

20 SHARP 1

SHARP 2

29 SHARP 2

IC101 17

SHARPNESS

IC101 18 ,Q204 B

NTSC

18 NTSC

AMS

58 AMS

Q250, 251

CN201 7

3-5

KR SW/
ECHO VR

L LED

PB

Q752 B

LINE 1

LED
DRIVE

HIFI LED
R LED
DNS 5 LED

C IN LED 57

94 SHARPNESS VR

21 AU MUTE
90 PB

S613
PICTURE
CONTROL

+5V

REMOTE
1 CONTROL 2
RECEIVER

D603-607

10

10

D608

11

11

D609

12

12

D610-612

CN201
REC LED
14
CASSETTE LED
13
TV/VTR LED
15

REC LED 81

CN601
2

EXCEPT GA30
GF80/GF90K/GF99K/PH99

D613

GA77K:PL/GF99K:PL

D614

GA66/GA77K/GF99K

D615,616

3
1

DNS 5 LED 79
DNS 3 LED
DNS 2 LED

DNS 3 LED 77
DNS 2 LED 76

DNS 1 LED

DNS 1 LED 75
DEST 2 7

91 LINE 1

Q221,222,226

IC301 41

SDA

98 AF DATA

IC301 42

SCL

97 AF CLK

IC301 39

AF ENV

14 A ENV

SUR CONT 1 59

,IC301 40

AF SWP

23 AF SWP

SUR CONT 2 60

IC302 5

REC P

17 REC P

SUR CONT 3 61

12

11

SURROUND LED

LED
DRIVE

OTHER
TV

FR-142 BOARD

S801

(SEE PAGE 4-21)

TV
SYSTEM
SR-C1
SR-C2
SR-C3

GA66/GA77K/GF99K
SW

ON SCREEN
DISPLAY

DNS 4 LED

(SEE PAGE 3-8)

IC302 1
FROM
KARAOKE
BLOCK

Q751 B

TRACKING LED

R LED 85

TO/FROM
AUDIO
BLOCK

GF90K/GF99K
(SEE PAGE 3-10)

A MUTE

13

SHARPNESS LED

DNS 4 LED 78

IC101 99

13

AUTO/
MANUAL

SP

GF80/GF90K/GF99K/PH99 MODEL

19 KILL IN

Q218 B

Q581 C

S612

GA77K:PL/GF99K:PL MODEL

Q233

24 RF SWP

V CLOCK

REMOCON

REMOCON 82

64 MODE3

IC101 63

IC101 50

4Vp-p

S614
SP/EP

S611

IC601
62 MODE1

HF LED 83
H

ADJ-B

ADJ-B 93
MODE1

EP

PAUSE

25Hz

MODE4

ON PAL TV

CN602
7

S204

3.1Vp-p

10 CAM+

NTSC
PB

EXCEPT GA77K:PL/GF99K:PL

GA66 /GA77K/GF99K

CAM
MOTOR DRIVE

S610

IC201 # REC

IC202
CN203

S605
COLOR
SYSTEM

NTSC 4.43

S603
31 CTL IN+

MODE3

LINE
SELECT

13

25Hz

MECHA
( POSITION
(

LINE 2

NTSC 3.58

KEY (2)

3.1Vp-p

CN401

MODE2

S615

NTSC

72 10M IN

CAM
ENCODER

LINE 1

IC201 & REC/PB

73 10M OUT

758Hz

16

GA66/GA77K/GF80/GF90K/GF99K/PH99

PAL/MESECAM

10MHz

CAM
MOTOR

11

1 REC PRF

55 CAP RVS

CAP FG

AUTO

KEY (1)

REC
PROOF

IC201 # REC

REC

IC201 $ REC/PB

CAPSTAN
FG

S203

S202

25 CAP VS

CAP RVS

D602

CN601

KEY 4

KEY 4 6

V SWP
ADJ

IC201 @ REC/PB

+5V

CN208

CN201
CN208
KEY (4)

96 CAP QR

SYNC
REC

9 A SWP ADJ

RV202

W-

S620

FF

REW

D5V

W+

S608

PLAY

S609

5V

RV201

S607

Q210

74 T/E LED
SYNC REC 86

M12V

S606
STOP

EXCEPT GA30

LED
DRIVE

4Vp-p

D5V

U-

EXCEPT GA30

(SEE PAGE 4-24)

CN604

KEY 2

KEY 2 4

T/S LED

IC201 # REC/PB

HALL
DEVICE

TEST

D203

FG

U+

12 T SENS

PG

M902

CN210
KEY (1)

EXCEPT GA30

6
5
4

CN702

3-6

TO
SURROUND
BLOCK
SR-35 BOARD
CN701

(SEE PAGE 3-9)

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

3-4. AUDIO BLOCK DIAGRAM

GF90K/GF99K

MA-336 BOARD
FOR
CHECK

(SEE PAGE 4-9)

C761

JK-166
BOARD

GF90K/GF99K

CN101
HF ADJ

CN202

JS931

11

11

GF80/GF90K/GF99K/PH99 MODEL

JS932

AUDIO
PROCESSOR
(HIFI)

18

EP
HF
LPF
3

VCC

24

FM PB

37

PNR
L

VCO

AGC
AMP

SP
HA

CH2

17

MUTE

PNR
L

VCO

20

AGC
AMP

16
PB ON

FM REC

9
H SW

39

SEL

42 41

VCA

GA66/GF80
/PH99

R
EXCEPT
GA30 MODEL

GA30
/GA50
/GA66
/P66

GA66
/GF90K

GA30
/GA50
/GA66
/GF90K
/P66

Q502

LINE OUT R IC502

LINE OUT L IC502

LINE IN L

IC502

LINE IN R

IC502

MIC RF

GA50/GA70K
/P66 MODEL

SR-L OUT

SR-R IN

14

C760
13

15
GA66/GA77K
MODEL

Q410

SP ON

IC752

C759

12

EXCEPT
GA30 MODEL

REC
EQ

100

JS921

GA70K/GA77K
GF90K/GF99K MODEL

GA66/GA77K MODEL

IC751

JS922

(SEE
PAGE
3-10)

SR-R OUT

INPUT SEL
L

TO/FROM
KARAOKE
BLOCK

GA70K/GA77K
GF90K/GF99K MODEL

AUDIO
LINE IN 1

FROM
VIDEO
BLOCK

SR-L IN

JS901

MUTE
7
Q753

11

BUFF

IC101

BUFF

IC581
AMS

9
10

GA66/GA77K/GF99K MODEL
Q581
BUFF

99

AMS

IC201

58

A MUTE

IC201

21

PB

IC201

90

(2/2)

AUDIO
PROCESSOR
(NORMAL)

10

9
Q751

CN651

AUDIO
LINE IN 2

JK-166
BOARD
L2 L

(SEE PAGE 4-26)

CN202
4

SW

TO/FROM
SYSCON
BLOCK

Q752
L2 R

SW
GA66/GA77KGF90K/GF99K MODEL

CN401

LINE 1

IC201

91

SDA

IC201

98

SCL

IC201

97

AF ENV

IC201

14

AF SW P

IC201

23

REC P

IC201

17

JS925
JS926

GF90K/GF99K MODEL

AUDIO
REC/PB
HEAD
2
NOMAL
AUDIO

ERASE
HEAD

4
T401
Q401-404

FULL
ERASE
HEAD

BIAS
ERASE
OSC

Q405,406
BIAS
SWITCH

CN402

EXCEPT
GA30 MODEL

16

3-7

TO/FROM
SURROUND
BLOCK
SR-35 BOARD
CN701

CN702

GA66/GA77K/GF80
/GF90K/GF99KPH99
MODEL

CNJ801
AUDIO
LINE OUT2

11

P
6

JS928
GA66/GA77K

GA30
/GA50
/GA70K
/P66

20

R
5

JS909

JS910

SDA

SCL

INPUT SEL

(SEE PAGE 4-26)

RFU AUDIO RFU801 2

NORMAL OUT

REC 5

JS927

JS903

21
LEVEL
DET

AGC
DET

11

L2 R

(SEE PAGE 3-4)

NORMAL IN

40 AF SWP

JS908

GF80/PH99

13

MUTE

HF
LPF

36

JS904

GA66/GA77K

12
CA

EXCEPT
GF80/GF90K/GF99K/PH99

JS905

16
OUTPUT

CH1
REC ON

14

MUTE

GA30/GA50/
GA66/GF80/
P66/PH99

JS907

17

JS902

JS929

15

HA

CN260

JS930

DRUM
AUDIO
HEAD

GF80/GF90K
/PH99

JS906

AFM
REC/PB
AMP

CNJ651

CNJ652
AUDIO
LINE OUT2

CN651

IC301
IC302

CNJ801

L2 L

C762

3-8

(SEE
PAGE 3-5)

(SEE PAGE 3-9, 10)

GA66/GA77K/GF99K
MODEL

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

3-5. KARAOKE BLOCK DIAGRAM

GA40K/GA70K/GA77K
GF90K/GF99K MODEL

(SEE PAGE 4-25)

MA-336 BOARD (SEE

IC501
9

MIC IN

MIC1

RV502

IC501
MCJ502
2

MIC2

IC501

CN502

MIC 1

MIC MIX

CN501

CN209
2

MIC OUT

26

CN502

IC502

IC503

KARAOKE PROCESS

SRAM

VR

20

COMPRESS
ALC

19

18

10

VR

CN501
VR

10
EXPAND

LPF

15

16

17

X501
455kHz

RV503
GA40K/GA70K
MODEL
CN601

MIC 2
PON

10

S501
KARAOKE

CN201

D501

SW

KARAOKE PON

31
VOCUL
CUT

ON
OFF

GA40K/GA70K/GA77K
GF90K/GF99K MODEL
GA70K/GA77K
GF90K/GF99K
MODEL

FR-142 BOARD (SEE

D502

JS510

12

JS511

MCJ501

PAGE 4-11)

CN502

OUTPUT SW

MJ-91 BOARD

D503
9

KR SW/ECHO VR

LINE OUT L CNJ801 L

LINE OUT R CNJ801 R

Q502

11

RV501

MIC RFU

RFU801 2

LINE IN L

CN702

LINE IN R

CN702

TO/FROM
AUDIO
BLOCK

(SEE PAGE
3-8)

ECHO

PAGE 4-21)

GF90K/GF99K
GA66/GA77K/GF99K
MODEL

KR SW/
ECHO VR Q250 B

CN702
BUFF

FROM
SYSCON
BLOCK

LED POWER IC201

Q206

67

(SEE PAGE 3-5, 6)

SR-35 BOARD

(SEE PAGE 4-17)

GA77K/GF99K MODEL

IC701
VOCAL CANSEL

CN701
7
9

AUDIO PON
SR L IN

15
9

IC702

L-R

10

SR R IN

13
SW1

L CH

Q702

JS702

6
5
4

CN701
Q705

R CH

11

Q704

12

SR L OUT

VIRTUAL
AUDIO
QXPANDER
PROCESS
1

13

SR R OUT

TO
AUDIO
BLOCK
MA-336 BOARD
CN702

(SEE PAGE 3-8)

ATT
20
SW
CONT

Q713

SR-C 1
SR-C 2
SR-C 3

(SEE PAGE 3-6)

16

3-9

21

ATT

JS701
GA66 MODEL ONLY

12

ATT

SW2
3

Q701

22

ATT

FROM
SYSCON
BLOCK
MA-336 BOARD
CN702

SURROUND-B

SS/SURROUND-A

L
L+R

FROM
AUDIO
BLOCK
MA-336 BOARD
CN702

(SEE PAGE 3-8)

IC703

LOGIC

3-10

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

3-6. POWER SUPPLY BLOCK DIAGRAM

MA-336 BOARD

CN951 F951
2A

LF951

(SEE PAGE 4-5, 7, 9, 10)

D951

T951

CN205
M12V

L953

AC
IN

D5V

DC/DC
CONV.

RFU801

L952

PS002

L802

IC203

IC204

5 BST +B

5V
REG

CN204
M12V

RESET

3 MOD +B

7 VCC

CAPSTAN
MOTOR

DRUM
MOTOR

IC202

IC201

REC/PB AMP
Y/C PROC.
AUDIO PROC.

OSD/
SERVO/SYSTEM CONT
MODE CONT

CAM
MOTOR DRIVE

CN203
CAM+

8 VCC1

15 AN5V

L109

D5V

IC101

90 RP VCC

CAM-

9 VCC2

CAM
MOTOR

22 VCC

12 Y VCC

Q220,224,225

L105
61 C VCC

PH201,202

CHROMA
SWITCH

L104
66 VCC

Q201,202

AMS

T/S
SENS

36 CCD VCC
38 CCD VCC

FR-140 BOARD

IC581

L106

(SEE PAGE 4-23)

T/S
REEL
CN207
D5V

CN605
5

LED
DRIVE

8 V+

(SEE PAGE 4-24)

40 CCD VCC
GA70K/GA77K
GF90K/GF99K MODEL

41 CCD VCC
43 CCD VCC

FR-141 BOARD
CN208
D5V

GF80/GF90K/GF99K/PH99 MODEL

EXCEPT
GA30 MODEL

IC302

T401
Q405,406 Q401-404
BIAS
OSC

AFM
REC/PB AMP

IC502

IC503

KARA PROC.

SRAM

FR-142 BOARD

L301
14 VCC

(SEE PAGE 4-21)

CN206
D5V

18 VCC

23 VCC

CN602
1

GA70K/GA77K
GF90K/GF99K MODEL

IC301

IC601

HIFI
AUDIO PROC.

REMCON

L302

2 5V

35 +12V
Q961

CN201
D12V

9V
REG
GA66/GA77K
GF90K/GF99K MODEL

GA70K/GA77K/GF90K/GF99K MODEL

MJ-91 BOARD
MIC AMP
VCC 5

IC751

IC752

INPUT SEL

BUFFER

CN209

CN502
1

A9V

16 VDD

CN601
10

GA66/GA77K/GF99K MODEL
Q205,214

8 VCC

2FSC
AMP

CN702
A9V

SR-35 BOARD
(SEE PAGE 4-17)

L701
3

3
CN701

IC701

IC702

IC703

VOCAL CANCEL

SS/SURA(A)

SURR(B)

1 VCC
16

3-11

GA66/GA77K MODEL

L207

IC501

D602

CN604

PS001

BIAS
SW

Q601,602

GA77K/GF99K MODEL

3-12E

13 VCC

22 VCC

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

SECTION 4
PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Abbreviation
SG: Gulf Model
PS: Pan Asia Model
TK: Thai Model

THIS NOTE IS COMMON FOR PRINTED WIRING

BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)

EE: East European Model

PL: Philippine Model

MA-336 BOARD (VIDEO BLOCK)

1 CN101 3 REC/PB
6 IC101 ! REC/PB

For Printed Wiring Boards.

b: Pattern from the side which enables seeing.

5Vp-p

Caution :
Pattern face side:
(Conductor Side)

4.6Vp-p

0.4Vp-p

REC:2.2Vp-p
PB:2.3Vp-p

0.1V/div 0.2sec/div

For Schematic Diagrams.

Caution when replacing chip parts.
New parts must be attached after removal of chip.
Be careful not to heat the minus side of tantalum
capacitor, because it is damaged by the heat.
All resistor are in ohms, 1/4 W unless otherwise noted.
Chip resistor are 1/10 W unless otherwise noted.
k: 1000 , M , : 1000 k.
All capacitors are in F unless otherwise noted. pF :
F. 50 V or less are not indicated except for electrolytics
and tantalums.
C: panel designation.
: internal component.

U : B+ Line.
V : B Line.
Circled numbers refer to waveforms.
Readings are taken with a PAL color-bar signal input.
Voltage are dc between ground and measurement points.
Readings are taken with a digital multimeter (DC10M).
Voltage variations may be noted due to normal production
tolerances.

3 IC101 *, * REC

8 IC101 # REC/PB

0.58Vp-p

0.5V/div 0.1sec/div

9 IC101 # REC/PB

4 IC101 ! REC

1.1Vp-p

! IC101 $ REC/PB

4 IC101 ! PB

1Vp-p

When indicating parts by reference number, please

include the board name.

4.1Vp-p
H

5 IC101 ! PB

4-1

8.8671MHz

REC:0.4Vp-p
PB:0.5Vp-p

! IC101 ^ REC/PB

REC:0.28Vp-p
PB:0.35Vp-p

! IC101 ^ REC/PB

0.45Vp-p

! IC101 $ REC/PB

0.25Vp-p

REC:0.35Vp-p
PB:0.38Vp-p

! IC101 $ REC/PB

5 IC101 ! REC

! IC101 % REC/PB

REC:0.5Vp-p
PB:0.6Vp-p

7.8MHz

0.45Vp-p

! IC101 ^ REC/PB

REC:0.28Vp-p
PB:0.35Vp-p

8.667MHz

4-2

0.1Vp-p
3.579545MHz

@ IC101 & REC/PB

4.433619MHz

0.66Vp-p

@ IC101 & REC/PB

! IC101 % PB

REC:0.41Vp-p
PB:0.6Vp-p

@ IC101 & REC/PB

! IC101 % REC/PB

7 IC101 @ REC/PB

2 CN101 2 PB

Parts on the pattern face side

seen from the pattern face are
indicated.
Pattern face side: parts on the parts face side seen
(Component Side) from the parts face are indicated.

REC:0.4Vp-p
PB:0.48Vp-p

25Hz

! IC101 % REC/PB

0.46Vp-p

4.433619MHz

0.54Vp-p

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
4-1. FRAME SCHEMATIC DIAGRAM

FRAME SCHEMATIC DIAGRAM

4-3

4-4

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

4-2. PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS

4-5

For schematic diagram

Refer to page 4-13 for printed wiring board.
Refer to page 4-2 for waveforms.

4-6

VIDEO, AUDIO
MA336 (1/4)

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
For schematic diagram
Refer to page 4-13 for printed wiring board.
Refer to page 4-15 for waveforms.

SERVO/SYSTEM CONTROL
MA-336 (2/4)

4-7

4-8

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

For schematic diagram

Refer to page 4-13 for printed wiring board.

4-9

4-10

HiFi, TUNER
MA-336 (3/4)

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

For schematic diagram

Refer to page 4-15 for waveforms.

KARAOKE, POWER SUPPLY

MA-336 (4/4)

4-11

4-12

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

MA-336 (VIDEO, AUDIO, SERVO/SYSTEM CONTROL, TUNER, KARAOKE, POWER SUPPLY) PRINTED WIRING BOARD
Ref. No. MA-336 Board; 1,000 Series
MA-336 BOARD
CN101
CN102
CN201
CN202
CN203
CN204
CN205
CN206
CN207
CN208
CN209
CN210
CN401
CN402
CN702
CN951

A-9
B-10
J-11
H-12
I-6
E-12
E-3
J-4
I-1
J-2
J-3
H-12
A-11
A-11
I-1
A-1

CNJ801 A-5
D201
D203
D250
D251
D581
D582
D807
D808
D809
D810
D951
D961

G-6
F-7
H-5
H-5
C-8
C-8
I-12
I-12
I-12
H-12
C-1
I-1

IC101
IC201
IC202
IC203
IC204
IC301
IC302
IC502
IC503
IC581
IC751
IC752

C-10
H-7
J-5
H-10
H-11
D-6
A-10
I-3
I-5
B-8
C-4
D-4

PH201 H-9
PH202 H-6

Q101
Q102
Q103
Q104
Q201
Q202
Q203
Q204
Q205
Q206
Q207
Q208
Q209
Q210
Q211
Q212
Q213
Q214
Q215
Q216
Q217
Q218
Q219
Q220
Q221
Q222
Q223
Q224
Q225
Q226
Q250
Q251
Q401
Q402
Q403
Q404
Q405
Q406
Q407
Q410
Q502
Q581
Q751
Q752
Q753
Q801
Q961

B-11
B-11
C-9
D-8
F-3
F-11
F-6
D-8
G-6
H-4
I-8
I-6
I-11
J-1
J-5
J-5
J-5
G-6
F-7
G-7
C-9
D-9
D-9
B-9
H-1
H-1
I-11
F-7
F-7
H-1
H-5
H-4
A-12
A-12
C-12
B-12
C-12
C-12
A-11
B-9
I-3
C-8
D-3
C-3
D-4
B-4
I-1

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

4-13

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

VIDEO, AUDIO, SERVO/SYSTEM CONTROL, TUNER, KARAOKE, POWER SUPPLY

MA-336

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

SR-35 (SURROUND) PRINTED WIRING BOARD

Ref. No. SR-35 Board; 2,000 Series

MA-336 BOARD (SERVO/SYSTEM CONTROL, KARAOKE BLOCK)

@ IC201 @@ REC/PB
# IC503 ! REC/PB
# IC201 $ REC/PB

25Hz

5Vp-p

@ IC201 @ REC/PB

1.18MHz

4.6Vp-p

758Hz

455kHz

3.6Vp-p
MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

# IC201 $$ REC/PB

5Vp-p

2Vp-p

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]

# IC201 % REC/PB

@ IC201 @ REC/PB

FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

5Vp-p

3.5Vp-p

0.88MHz

# IC201 % REC/PB

@ IC201 # REC

3.1Vp-p
25Hz

4.2Vp-p
H

# IC201 % REC/PB

@ IC201 # REC

2.6Vp-p

3.1Vp-p
8.86716MHz

25Hz

# IC201 % REC/PB

@ IC201 # REC/PB

4Vp-p
600Hz

4Vp-p

# IC201 & REC/PB

@ IC201 # REC/PB

25Hz

4.1Vp-p
10MHz

3.2Vp-p

4-15

SURROUND
SR-35

4-16

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

4-17

4-18

SURROUND
SR-35

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

FR-142 (MODE CONTROL) PRINTED WIRING BOARD

Ref. No. FR-142 Board; 1,000 Series

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

MODE CONTROL
FR-142

4-19

4-20

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

4-21

4-22

MODE CONTROL
FR-142

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

FR-140 (POWER, EJECT SWITCHES) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM
Ref. No. FR-140 Board; 1,000 Series

FR-141 (TAPE OPERATION) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM

Ref. No. FR-141 Board; 1,000 Series

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

POWER, EJECT SWITCHES

FR-140

/ TAPE OPERATION
FR-141

4-23

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

4-24

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

MJ-91 (MIC JACK, AMP) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM
Ref. No. MJ-91 Board; 2,000 Series

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

4-25

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

MIC JACK, AMP

MJ-91

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

JK-166 (LINE IN/OUT) PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM

Ref. No. JK-166 Board; 2,000 Series

MJ-91
MA-336
(MIC JACK, AMP)
VIDEO, AUDIO,
[GA70K/GA77K/GF90K/GF99K] SERVO/SYSTEM CONTROL,
TUNER, POWER SUPPLY

FR-140
(POWER,
EJECT SWITCHES)

JK-166
(LINE IN/OUT)
[GA66/GA77K/GF80/
GF90K/GF99K/PH99]
FR-142
(MODE CONTROL)
FR-141
(TAPE OPERATION)

LINE IN/OUT
JK-166

SR-35
(SURROUND)
[GA66/GA77K/GF99K]

4-26E

5-1. SYSTEM CONTROL VIDEO BLOCK INTERFACE (MA-336 BOARD IC201)

STOP
Signal

TAPE

TAPE

Pin No.

I/O

PB

PB PAUSE

SLOW

x2

CUE

REVIEW

REC

REC PAUSE

RF SWP

*1

*1

*1

*1

*1

*1

*1

*1

*1

*1

*1

QVD

*2

*3

*3

*2

*3

*3

C SYNC

*4

*5

*5

*5

*5

*5

*5

*5

*5

*5

*5

NT JUDGE

THREADING UNTHREADING

Synchronized with drum rotation. 25 Hz (PAL), 30 Hz (NTSC) 50% duty cycle.

Normally L. H when CTL signal is not generated.
V period H pulse.
Selected by REC mode. H in LP mode.
Composite sync signal (positive).

5-2. SYSTEM CONTROL SERVO PERIPHERAL CIRCUIT INTERFACE (MA-336 BOARD IC201)
TAPE

TAPE

Pin No.

I/O

STOP

FF

REW

CTL (+)

Hi-Z

Hi-Z

Hi-Z

CTL ()

*6

*6

DRM PG

*4

*1

*1

*5

DRM FG

*4

*7

*7

CAP FG

H/L

*6

*6

CAP VS

*8

*8

*8

*8

*8

*9

*8

*8

*9

*8

*9

*9

*8

DRM VS

*10

*10

*10

*10

*10

*10

*10

*10

*10

*10

*10

*10

*10

Signal

5-1

*1. 25 Hz (PAL), 30 Hz (NTSC) pulse.

*2. Pulse at tape running.
*3. Reverse logic pulse of STEP PLS.
*4. L when drum rotation stops.
*5. Unstable period pulse.
*6. Pulse in period in proportional to tape speed.
*7. 300 Hz (PAL), 360 Hz (NTSC) pulse.
*8. Pulse at tape running.
*9. Approx. 2 msec period H or L pulse.
*10. Approx. 1.5 msec period H or L pulse.
*11. L when FWD SLOW, H when RVS SLOW.

PB

PB PAUSE

SLOW

CUE

x2

REVIEW

REC

REC PAUSE

Hi-Z

Hi-Z

Hi-Z

Hi-Z

Hi-Z

Hi-Z

*1

Hi-Z

*1

H/L

*2

*6

*6

*6

*1

*5

*1

*1

*1

*1

*1

*1

*1

*1

*5

*5

*7

*7

*7

*7

*7

*7

*7

*7

*5

*5

*6

H/L

*2

*6

*6

*6

*6

H/L

THREADING UNTHREADING
Hi-Z

Hi-Z

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
SECTION 5
INTERFACE, IC PIN FUNCTION DESCRIPTION

*1
*2
*3
*4
*5

FF/REW

5-3. SYSTEM CONTROL MECHANISM INTERFACE (MA-336 BOARD IC201)

CASSETTE CASSETTE
Signal

I/O

CAM2

HI-Z

MODE 1 (*8)

*1

MODE 2 (*8)

*1

MODE 3 (*8)

MODE 4 (*8)

REC PRF

T REEL FG

S REEL FG

END LED

&

CAP RVS

TAPE

REC
STOP

FF

REW

PB

PB PAUSE

SLOW

x2

CUE

REVIEW

REC

*7

*7

*7

*7

*7

*7

*7

*7

*7

*7

*7

*1

*1

*1

*1

*1

*1

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

*2

H/L

H/L

H/L

H/L

H/L

H/L

*3

*3

*3

H/L

*3

*3

*3

*3

*3

H/L

H/L

H/L

H/L

*3

*3

H/L

*3

*3

*3

H/L

*3

*3

*3

*3

*3

H/L

O (O.D)

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

*4

H/L

L/*5

T SENS

*4

*4

*4

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

S SENS

*4

*4

*4

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*6

*1.
*2.
*3.
*4.
*5.
*6.

EJECTED

TAPE

Pin No.

LOADING

UNLOADING THREADING UNTHREADING

Uncertainly.
L when erasing protection tab is bent. H when not bent.
Pause of period in proportion to reel rotating speed.
Approx. 2 msec period H pulse.
Pulse at tape running.
Normally L. 2 msec period H pulse when tape top or tape end is detected.

*7. When transition to UNLOADING direction : L.

When transition to LOADING direction : H.
When CAM MOTOR is stopped : Hi-Z.
*8. When RVS slow : Mode 1=L
When RVS slow : Mode 2=L
When RVS slow : Mode 3=H
When RVS slow : Mode 4=L

5-2

5-4. SYSTEM CONTROL AUDIO BLOCK INTERFACE (MA-336 BOARD IC201)

STOP/FF/

TAPE

TAPE

REW

LOADING

UNLOADING

Pin No.

I/O

AF ENV

A MUTE

O (O.D)

*1

AF REC P

AF SWP

*1

*1

*1

*1

Signal

PB

PB PAUSE

SLOW

x2

CUE

REVIEW

REC

REC PAUSE

*1

*1

*1

*1

*1

*1

*1

AF RF envelope signal input terminal for automatic tracking.

*1. 30 Hz 50 % duty pulse approx. 5 msec delayed from RF SW P.

PAUSE

5-6. SERVO/SYSTEM CONTROL MICROPROCESSOR PIN FUNCTIONS

(MA-336 BOARD IC201)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50

Pin Name
REC PRF
AVSS
KEY1
KEY2
KEY3
KEY4
DEST2
V SWP ADJ
A SWP ADJ
DEST
S SENS
T SENS
VIDEO RF
AUDIO RF
AVCC
RESET
REC P
NTSC
KILL IN
SHARPCONT1
AU MUTE
VCC
AF SWP
RF SWP
CAP VS
DRUM VS
QVD
NC
SHARPCONT2
NC
CTL (+)
CTL ()
VSS (SERVO)
CTLI-1
CTLI-2
CTLI-3
CTLAMP
DRUM FG
DRUM PG
CAP FG
VCC (SERVO)
VCC (OSD)
CVIN
VREF
CVOUT
CHAR. BIAS
AFC LPF
AFC OSC
VSS(OSD)
DOSC IN

I/O
I
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I (A/D)
I
O
O
I
O
O
O
O
O
O
O
O
I/O
I/O

I
I
I

I
O

Function
Erasing protection tab. cassette in detection.
Analog circuit ground
Analog voltage (KEY) input 1.
Analog voltage (KEY) input 2.
Analog voltage (KEY) input 3.
Analog voltage (KEY) input 4.
Destination discrimination input 2
Video switching position adjustment
Audio switching position adjustment
Destination discrimination input 1
Supply side end sensor input
Take-up side end sensor input
Video RF envelope input
HiFi audio envelope input
Analog circuit power supply
Reset signal input
HiFi pre-amp, linear audio REC bias. REC PAUSE: L.
Video IC
NTSC: H, PAL: L
Video IC
SHARPNESS control H: Active
Video IC Mute on: H, Mute off: L
Power supply
AF switching pulse output
RF switching pulse output
Capstan error output
Drum error output
Quasi VD pulse output
Not connected
SHARPNESS control H: Active
Not connected
CTL signal I/O
CTL signal I/O
Servo circuit ground
CTL amp control output
CTL amp control input
CTL amp control output
CTL amp output
Drum FG input
Drum PG input
Capstan FG input
Servo circuit power supply
OSD circuit power supply
Video signal input for character generator
Video signal output from character generator
External character brightness level input
AFC LPF pin input
AFC oscillator pin input
OSD circuit ground
DOSC IN

5-3

Pin No.
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100

Pin Name
DOSC OUT
2FSC
2FSC IN
CSYNC
CAP RVS
TRACK. LED
C. IN LED
AMS
SUR. CONT1
SUR. CONT2
SUR. CONT3
MODE1
MODE2
MODE3
MODE4
CAP TRQ PWM
POWER LED
TEST
32 kHz (IN)
32 kHz (OUT)
VSS
10 MHz (IN)
10 MHz (OUT)
END LED
DNS 1 LED
DNS 2 LED
DNS 3 LED
DNS 4 LED
DNS 5 LED
MESECAM DET, TV/VTR
REC LED
SIRCS
HF LED
L LED
R LED
SUR LED-SYNC REC
SHARPNESS LED
T REEL
S REEL
PB
LINE1
ADJ-B
ADJ-A
SHARPNESS VR
CAM
CAP QR
AF CLK
AF DATA
V CLK
V DATA

I/O
O
O
I
I
O
O
O
I
O
O
O
I
I
I
I
O (PWM)
O

Function
DOSC OUT
2FSC
2FSC IN
Composite sync. signal input
Capstan reverse control signal in FWD: H, REV: L
Auto tracking LED On: H, Off: L
Cassette in LED On: H, Off: L
Auto music search
Surround control signal output 1
Surround control signal output 2
Surround control signal output 3
Mechanism CAM encoder input 1
Mechanism CAM encoder input 2
Mechanism CAM encoder input 3
Mechanism CAM encoder input 4
Capstan torque PWM output
Power LED control On: H, Off:L
Not used. Connected to ground.
I
32 kHz clock terminal
O
32 kHz clock terminal
Ground
I
10MHz clock terminal
O
10MHz clock terminal
O
LED pulse drive
O
LED On: L, Off: H
O
LED On: L, Off: H
O
LED On: L, Off: H
O
LED On: L, Off: H
O
LED On: L, Off: H
I/O
SECAM IC RF converter/TV/VTR select
O
REC LED On: H, Off: L
I
SIRCS signal input
O
HiFi LED On: H, Off: L
O
L ch LED On: H, Off: L
O
R ch LED On: H, Off: L
O
Surround/SYNC REC LED On: H, Off: L
O
SHARPNESS LED On: H, Off: L
I
Take-up reel FG input
I
Supply reel FG input
O
Play mode: L
O
LINE 1 select
I
PICTURE CONTROL signal input
I
PICTURE CONTROL signal input
O
Video IC Sharpness Voltage
O (3 VALUES) CAM motor drive H: Forward, M: Brake, L: Reverse
O
Capstan motor
O
I2C-bus clock(HiFi)
O
I2C-bus data(HiFi)
O
I2C-bus clock(Video)
O
I2C-bus data(Video)

5-4E

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
SECTION 6
ADJUSTMENTS
2-1-3. Set-up of Adjustment
In this adjustment, PAL or NTSC pattern generator is connected
with LINE input terminal. When check to tuner, connected AERIAL
terminal. Check that the synchronizing signal of the Y signal has
an amplitude of approximately 0.7 V and that the burst signal has
an amplitude of approximately 0.3 V and its waveform is flat. And
check that the level ratio of burst signal to red signal is 0.30 :
0.66. The video signal (color bar) used for electrical aligning this
unit is shown in Fig. 6-2-2.

6-1 MECHANICAL ADJUSTMENTS

For the mechanical adjustments, please refer to the
VHS MECHANICAL ADJUSTMENT MANUAL
(S MECHANISM) (9-921-647-11).

6-2. ELECTRICAL ADJUSTMENTS

See the adjusting part location diagram from on page 6-6
for the adjustment.

PAL model

2-1.
PREPARATION BEFORE ADJUSTMENT
2-1-1. Equipment Required
The measuring instruments used for this alignment include:
1) Monitor TV
2) Oscilloscope, dual-trace, bandwidth of 30 MHz or more, with
delay mode (A probe 10:1 should be used unless otherwise
specified.)
3) Frequency counter
4) NTSC Pattern generator
5) PAL Pattern generator
6) Digital voltmeter
7) Audio generator
8) Audio level meter
9) Audio attenuator
10) Alignment tapes
KRV-51P (PAL)
Part No. : 8-192-605-36
KRV-51N2 (NTSC) Part No. : 8-192-605-32

White (Approx. 75%)

Approx. 0.7 V
Approx.
0.3 V

Approx. 0.3 V

Red
Burst signal
(It must be flat.)

Horizontal sync signal

NTSC model

White (100%)

About 0.7 V

2-1-2. Equipment Connection

Unless otherwise specified, connect and adjust the measuring
instruments as shown in the following diagram.

About
0.3 V

About
0.3 V
Red

VIDEO LINE IN
Pattern generator

Horizontal sync signal

VCR

Monitor TV

Burst signal
(It must be flat.)

Fig. 6-2-2 Color Bar Signals of Pattern Generator

2-1-4. Alignment Tape
Contents of KRV-51N2/51P

Video output
(75)

VIDEO LINE OUT

Mode
1
2
3
4

Fig. 6-2-1

6-1

SP
LP

Period

Video signal

Audio signal
Hi-Fi
Normal

7 minutes
3 minutes
7 minutes
3 minutes

Color bar
Monoscope
Color bar
Monoscope

400Hz
(L/R)

400Hz

2-1-5. Input/Output Levels and Impedance

Video input: LINE IN
Input signal: 1 Vp-p, 75 ohms, unbalanced,
sync negative
Video output: LINE OUT
Output signal: 1 Vp-p, 75 ohms, unbalanced,
sync negative
Audio input: LINE IN
Input level: 7.5 dBs
(0 dBs= 0.775 Vrms)
Input impedance: more than 47 kilohms
Audio output:LINE OUT
Standard level: 7.5 dBs at load impedance 47
kilohms
Output impedance: less than 10 kilohms

2-2.
POWER SUPPLY CHECK
2-2-1. Output Voltage Check (MA-336 Board)
Mode
E-E

2-1-6. Adjustment Sequence

The adjustments should be performed in the following sequence.

Measuring Instrument
+12 V Check

Digital voltmeter

Measurement point
Specified value

CN201 pin !
11.5 13.0 V

+5 V Check
MP

CN206 pin !

SV
+9 V Check

5.0 5.6 V

MP
SV

Emitter of Q961
8.5 10.0 V

MTR12 V Check
Measurement point

CN204 pin 4

Specified value

11.5 13.0 V

Power Supply Check

[Check Method]
1) Each of these supply voltages must meet its specified value.
Servo/Video System Adjustments

Audio System Adjustments

6-2

2-3.
2-3-1.

SERVO SYSTEM CHECK

RF Switching Position Adjustment
(MA-336 Board)
[Adjustment Purpose]
To adjust the link of the A-ch and B-ch of the tape playback outputs.
To make the unit compatible with other tapes and units. If this
specification is not satisfied, the link will appear on the screen and
the screen will be disrupted, etc.

2-4.
AUDIO SYSTEM ADJUSTMENT
Adjust both L ch and R ch.
[Connecting Instruments]
Audio line OUTPUT L/R
Audio line INPUT L/R
Audio oscillator

Playback

Signal
Measurement point

Alignment tape: SP color bar portion

CH1: Video LINE OUT
(75 terminated)
(AF switching position)
CH2: CN101 pin 3 (V SWP)

Measuring instrument
Adjusting element

Oscilloscope
RV202

Specified value

6.5 1 H (413 60 ):
6.5 1 H (416 32 sec): PAL

Attenuator
VTR

Fig. 6-2-4
2-4-1.

Hi-Fi Audio System Adjustment

(Hi-Fi model only)
Perform the adjustment setting the switch on the following
positions.
AUDIO MONITOR ..................................................... STEREO

[Adjustment Method]
1) Playback the alignment tape.
2) Short-circuit between pins 1 and 2 of CN210.
3) Check that RF is indicated on FL display.
4) Check that switching position is 6.5 1 H.
5) If not meet the specified value, turn RV202 and repeat steps 1)
to 3).

[Adjustment Method]
1. ACE head adjustment.....Refer to the VHS mechanical
adjustment manual (S MECHANISM)(9-921-647-11).
2. E-E output level check
3. Recording Bias Adjustment

Approx.
1Vp-p

CH1

Approx.
5Vp-p

CH2
V
Enlargement

Vertical sync. signal

CH1

CH2
CN202 pin 3

47 k

600

Mode

Audio level meter

or distortion meter

6.5 1 H
(413 60 sec): NTSC
(416 32 sec): PAL

Fig. 6-2-3

6-3

1. AF Switching Position Adjustment

(MA-336 Board)
[Adjustment Purpose]
To adjust the link of the A-ch and B-ch of the tape playback outputs.
To make the unit compatible with other tapes and units. If this
specification is not satisfied, the link will appear on the screen and
the screen will be disrupted, etc.
Mode

Playback

Signal
Measurement point

Alignment tape: SP color bar portion

CH1: Pin 3 of CN101
CH2: Pin 1 of CN101

Measuring instrument
Adjusting element

Oscilloscope
RV201

Specified value

Fig. 6-2-5

2-4-2. Normal Audio System Adjustment

Make adjustment in the SP mode unless otherwise specified. Use
a normal VHS cassette for an adjustment tape.
Set AUDIO MONITOR to normal.
1. ACE Head Adjustment
Refer to the VHS mechanical adjustment manual
MECHANISM) (9-921-647-11).

(S

2. E-E Output Level Check

[Adjustment purpose]
Confirm that the output level adjust the reference input is within the
specification.
Mode
E-E

[Adjustment Method]
1) Playback the alignment tape.
2) Short-circuit between pins 1 and 2 of CN210.
3) Adjust RV201 to minimize a chipped portion. At this time,
confirm that a noisy sound is not heard.

Signal
Measurement point

400 Hz, 7.5 dBs

CJ461 L/R

Measuring instrument
Specified value

Audio level meter

7.5 2 dBs

[Check Method]
1) Input signal of 400 Hz and 7.5 dBs to the CJ461 L/R.
2) Check that the audio output level is 7.5 2 dBs.

CH2
RF SWP

3. Recording Bias Check

[Adjustment purpose]
Confirm that the frequency characteristic is within the specification.
Mode
REC and PB (SP mode)
OK

Signal

NG

Measurement point
Measuring instrument

400 Hz, 27.5 dBs

7 kHz, 27.5 dBs
Audio output terminal
Audio level meter

Specified value

0 3 dB

CH1
REC AFM

Note: Tape path adjustment must have been completed.

Should be minimized

[Confirmation Method]
1) Supply a signal of 400 Hz, 27.5 dBs to both L and R channels
of Audio Line Input.
2) Connect the audio level meter to the Audio Line Output.
3) Adjust the attenuator so that the audio level meter will indicate
27.5 dBs.
4) Make recording in the SP mode.
5) Set an audio line input signal to 7 kHz and make recording.
6) Playback a recorded portion, and measure output levels at 400
Hz and 7 kHz.
7) Confirm that the 7 kHz playback output level within a range of
the 400 Hz playback output level 0 3 dB.

RF signal dropout

Fig. 6-2-5

6-4

2-5.

ADJUSTING PARTS LOCATION DIAGRAM

MA-336 BOARD
(CONDUCTOR SIDE)
CN101
4

CNJ801

RF/AF SWP

VIDEO/AUDIO LINE
IN/OUT

CN204

MTR 12 V

6
7

2
1

RV202
RF SWP
AF SWP
RV201

CN210
RF/AF
SWP
B

2 1

Q961
+9 V
12

13

CN206
+5 V

6-6E

14

15

CN201
+12 V

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99
SECTION 7
REPAIR PARTS LIST
Ref. No.

7-1. EXPLODED VIEWS

NOTE:
-XX, -X mean standardized parts, so they may
have some differences from the original one.
Items marked * are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.

The mechanical parts with no reference number

in the exploded views are not supplied.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.

Abbreviation
SG: Gulf Model
EE: East European Model
PS: Pan Asia Model
PL: Philippine Model
TK: Thai Model

7-1-1. FRONT PANEL AND UPPER CASE SECTION

10

24

11

Part No.

Description

Part No.

Description

1
1
1
1
1

X-3949-068-1
X-3949-069-1
X-3949-070-1
X-3949-072-1
X-3949-073-1

FRONT PANEL, ASSY (GF99K)

PANEL ASSY, FRONT (GF90K:PS)
PANEL ASSY, FRONT (GF80)
PANEL ASSY FRONT (GA66)
FRONT PANEL, ASSY (GA70K)

*
*
*
*
*

13
13
13
13
13

A-6794-604-A
A-6794-610-A
A-6794-612-A
A-6794-613-A
A-6794-614-A

FR-142 BOARD, COMPLETE(GF99K:TK)

FR-142 BOARD, COMPLETE(GF90:TK)
FR-142 BOARD, COMPLETE(GA50:PS)
FR-142 BOARD, COMPLETE(GA50:ME,SG)
FR-142 BOARD, COMPLETE(GF80:TK)

1
1
1
1
1

X-3949-076-1
X-3949-077-1
X-3949-078-1
X-3949-081-1
X-3949-084-1

PANEL ASSY, FRONT (GA30:PS)

PANEL ASSY, FRONT (GA30:ME,SG)
PANEL ASSY FRONT (GA77K:PS)
PANEL ASSY FRONT (GA50)
PANEL ASSY FRONT (GA77K:PL)

*
*
*
*
*

13
13
13
13
13

A-6794-616-A
A-6794-617-A
A-6794-618-A
A-6794-619-A
A-6794-621-A

FR-142 BOARD, COMPLETE(GA30:PS)

FR-142 BOARD, COMPLETE(GA30:ME,SG)
FR-142 BOARD, COMPLETE(GA77K:TK)
FR-142 BOARD, COMPLETE(GA70K:TK)
FR-142 BOARD, COMPLETE(GA30:TK)

1
1
1
1
1

X-3949-188-1
X-3949-189-1
X-3949-192-1
X-3949-193-1
X-3949-194-1

PANEL ASSY, FRONT (GA77K:TK)

FRONT PANEL, ASSY (GF99K:TK)
FRONT PANEL, ASSY (GA30:TK)
FRONT PANEL, ASSY (GA50:TK)
FRONT PANEL, ASSY (GA70K:TK)

*
*
*
*

13
13
13
14

A-6794-637-A
A-6794-646-A
A-6794-656-A
A-6794-582-A

1
1
2

X-3949-195-1 FRONT PANEL, ASSY (GF80:TK)

X-3949-196-1 FRONT PANEL, ASSY (GF90K:TK)
X-3949-088-1 BUTTON ASSY, FUNCTION
(GA70K/GA77K/GF80/GF90K/GF99K/PH99)
X-3946-598-1 BUTTON ASSY, FUNCTION
(GA30/GA50/GA66/P66)
3-987-176-21 RING,BUTTON
(GA70K/GA77K/GF80/GF90K/GF99K/PH99)

2
3

25

4
4
4
4
5

9
16

16

not supplied

12
not supplied

23

19

6
7
* 8

* 8

22

* 8

5
17

13

16

18

* 9
* 9

14

10

16
1
2

10
11

15

Ref. No.

* 14

* 14
* 14
* 15
* 15

10
20

Remarks

3-051-651-01 PLATE, FROSTED(GA66/GF80/GF99K/PH99)

3-051-651-11 PLATE, FROSTED
(GA50/GA70K/GA77K:PS/P66)
3-051-651-21 PLATE, FROSTED(GA30/GF90K)
3-051-651-41 PLATE, FROSTED(GA77K:PL)
3-943-995-01 EMBLEM (NO.5), SONY

* 15

* 15

3-051-653-01 LENS,POWER
3-953-432-01 SPRING (GE), FL
A-6794-581-A FR-140 BOARD, COMPLETE
(GA30:ME,PS,SG/GA50:ME,PS,SG/GA66/GA70K:PS/
GA77K:PS/GF80:PS/GF90K:PS/GF99K:ME,PS)
A-6794-591-A FR-140 BOARD, COMPLETE
(GA77K:PL/GF99K:PL)
A-6794-602-A FR-140 BOARD, COMPLETE
(GA30:TK/GA50:TK/GA70K:TK/GA77K:TK/
GF80:TK/GF9OK:TK/GF99K:TK)
A-6794-584-A MJ-91 BOARD, COMPLETE
(GA70K:PS/GA77K:PS,PL/GF90K:PS/GF99K:ME,PS,PL)
A-6794-605-A MJ-91 BOARD, COMPLETE
( GA70K:TK/GA77K:TK/GF90K:TK/GF99K:TK)
3-710-901-01 SCREW, TAPPING
(GA70K/GA77K/GF80/GF90K/GF99K/PH99)
3-710-901-11 SCREW, TAPPING(GA30/GA50/GA66/P66)
3-053-078-11 CASE, UPPER (GA30/GA50/GA66/P66)

16
17
17
17

17
18

18
19

19

19

21

11
! 12
* 13
* 13
* 13
*
*
*
*
*

13
13
13
13
13

3-053-078-31 CASE, UPPER

(GA70K/GA77K/GF80/GF90K/GF99K/PH99)
1-777-851-41 CORD, POWER
A-6794-583-A FR-142 BOARD, COMPLETE(GF99K:ME,PS)
A-6794-587-A FR-142 BOARD, COMPLETE(GF90K:PS)
A-6794-589-A FR-142 BOARD, COMPLETE(GA77K:PL)
A-6794-590-A
A-6794-592-A
A-6794-593-A
A-6794-599-A
A-6794-601-A

FR-142 BOARD, COMPLETE(GF99K:PL)

FR-142 BOARD, COMPLETE(GF80:PS/PH99)
FR-142 BOARD, COMPLETE(GA77K:PS)
FR-142 BOARD, COMPLETE(GA66)
FR-142 BOARD, COMPLETE(GA70K)

19
20
21
22
23
24
24
25

FR-142 BOARD, COMPLETE(GF90K:MJ)

FR-142 BOARD, COMPLETE(GA50:TK)
FR-142 BOARD, COMPLETE(P66)
FR-141 BOARD, COMPLETE
(EXCEPT GA30/GA50:TK/GA70K:TK/GA77K:TK/
GF80:TK/GF90K:TK/GF99K:TK)
A-6794-603-A FR-141 BOARD, COMPLETE
(GA50:TK/GA70K:TK/GA77K:TK/GF80:TK/
GF90K:TK/GF99K:TK)
A-6794-622-A FR-141 BOARD, COMPLETE(GA30:TK)
A-6794-615-A FR-141 BOARD, COMPLETE(GA30:ME,PS,SG)
A-6794-585-A JK-166 BOARD, COMPLETE
(GA66/GA77K:PL,PS/GF99K:ME,PS,SG)
A-6794-588-A JK-166 BOARD, COMPLETE
(GF80/GF90K:PS/PH99)
A-6794-606-A JK-166 BOARD, COMPLETE
(GA77K:TK/GF99K:TK)
A-6794-611-A JK-166 BOARD, COMPLETE
(GF80:TK/GF90K:TK)
4-921-277-41 SCREW (B2.6X8), TAPPING, BIND
3-051-664-01 WHEEL, ROTARY
(GA66/GA70K:PS/GA77K:PL,PS/GF90K:PS/GF99K:ME,PL,PS)
3-051-664-11 WHEEL, ROTARY
(GA30:ME,PS,SG/GA50:ME,PS,SG)
3-051-664-21 WHEEL, ROTARY
(GA70K:TK/GA77K:TK/GF80:TK/GF90K:TK/GF99K:TK)
3-051-664-31 WHEEL, ROTARY(GA30:TK/GA50:TK)
3-051-663-01 KNOB, ROTARY
(GA66/GA70K:PS/GA77K:PL,PS/GF90K:PS/
GF99K:ME,PL,PS)
3-051-663-21 KNOB, ROTARY
(GA70K:TK/GA77K:TK/GF9OK:TK/GF99K:TK)
3-051-662-01 KNOB, SLIDE
(GA66/GA70K:PS/GA77K:PL,PS/GF90K:PS/
GF99K:ME,PL,PS)
3-051-662-11 KNOB, SLIDE
(GA30:ME,PS,SG/GA50:ME,PS,SG)
3-051-662-21 KNOB, SLIDE
(GA70K:TK/GA77K:TK/GF80:TK/GF90K:TK/GF99K:TK)
3-051-662-31 KNOB, SLIDE(GA30:TK/GA50:TK)
3-970-608-21 SUMITITE (B3), +BV
1-790-118-11 CABLE, FLAT (FJK-1)
(GA66/GA70K/GA77K/GF80/GF90K/GF99K/PH99)
1-790-119-11 CABLE, FLAT (FFR-6)
1-790-120-11 CABLE, FLAT (FFR-7)
1-418-060-11 COMMANDER, STANDARD (RMT-V254)
(EXCEPT GA30)
1-418-060-21 COMMANDER, STANDARD(RMT-V254A)(GA30)
3-709-269-01 LID, BATTERY CASE
(FOR REMOTE COMMANDER)

Note :

7-1

7-2

Remarks

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

7-1-2. CHASSIS SECTION

#1

7-1-3. MECHANISM DECK SECTION-1

#1

56

707

#1

#701

57

54

710
54

708

53

709
706

54

725

not
supplied

723

704

712

711

703
705
52

55

54

722

724

#1

702

701

713
720

51
not supplied

716

721

714

719

701

715

717
718

not supplied

Ref. No.

Part No.

* 51
* 52

3-959-383-01 BASE (R), MD

A-6794-586-A SR-35 BOARD, COMPLETE
(GA77K:PS,PL/GF99K:PS)
A-6794-600-A SR-35 BOARD, COMPLETE(GA66)
A-6794-607-A SR-35 BOARD, COMPLETE
(GA77K:TK/GF99K:TK)
A-6791-702-A MA-336 BOARD, COMPLETE(GF99K:ME,PS)

* 52
* 52
* 53

Description

Remarks

*
*
*
*
*

53
53
53
53
53

A-6791-703-A
A-6791-704-A
A-6791-705-A
A-6791-706-A
A-6791-707-A

MA-336 BOARD, COMPLETE(GF90K:PS)

MA-336 BOARD, COMPLETE(GF80:PS/PH99)
MA-336 BOARD, COMPLETE(GA77K:PL)
MA-336 BOARD, COMPLETE(GF99K:PL)
MA-336 BOARD, COMPLETE(GA77K:PS)

*
*
*
*
*

53
53
53
53
53

A-6791-710-A
A-6791-711-A
A-6791-712-A
A-6791-715-A
A-6791-716-A

MA-336 BOARD, COMPLETE(GA66)

MA-336 BOARD, COMPLETE(GA70K)
MA-336 BOARD, COMPLETE(GF99K:TK)
MA-336 BOARD, COMPLETE(GF90K:TK)
MA-336 BOARD, COMPLETE(GF80:TK)

* 53
* 53

Ref. No.

Part No.

Description

53
53
53
53
53

A-6791-719-A
A-6791-720-A
A-6791-721-A
A-6791-722-A
A-6791-724-A

MA-336 BOARD, COMPLETE(GA30:PS)

MA-336 BOARD, COMPLETE(GA30:ME,SG)
MA-336 BOARD, COMPLETE(GA77K:TK)
MA-336 BOARD, COMPLETE(GA70K:TK)
MA-336 BOARD, COMPLETE(GA30:TK)

* 53
* 53
54
55

A-6791-729-A
A-6791-744-A
3-970-608-21
3-052-070-01

*
*
*
*
*

55
55
55

A-6791-717-A MA-336 BOARD, COMPLETE(GA50:PS)

A-6791-718-A MA-336 BOARD, COMPLETE(GA50:ME,SG)

7-3

Remarks

MA-336 BOARD, COMPLETE(GA50:TK)

MA-336 BOARD, COMPLETE(P66)
SUMITITE (B3), +BV
PANEL (M) REAR
(GA50:ME,PS,SG/GA66/GA70K:PS/GA77K:PS/
GF80:PS/GF90K:PS/GF99K:ME,PS/P66/PH99)
3-052-070-21 PANEL (M) REAR(GA30:ME,PS,SG)

55
55
56

3-052-070-31 PANEL (M) REAR(GA77K:PL/GF99K:PL)

3-052-070-51 PANEL (M) REAR
(GA77K:TK/GF80:TK/GF90K:TK/GF99K:TK)
3-052-070-61 PANEL (M) REAR(GA50:TK/GA70K:TK)
3-052-070-71 PANEL (M) REAR(GA30:TK)
1-790-117-11 CABLE, FLAT (FDM-5)

57

3-987-560-02 PLATE, TOP, FL

Ref. No.

Part No.

Description

701
702
703
704
705

3-977-509-01
3-977-507-01
3-977-508-01
1-500-144-11
3-977-495-01

WASHER, THRUST
TABLE, REEL (S)
TABLE, REEL (T)
HEAD, FE
SHAFT TG2

706
707
708
709
710

3-977-494-01
A-6759-619-B
3-977-535-01
3-977-536-01
3-970-471-01

HOLDER, FEH
FLCOMPLETE ASSY
PLATE, LUMINOUS(END SENSOR)
PLATE, LUMINOUS(TOP SENSOR)
SPRING (DECK OPEN), TORSION

711
712
713

A-6759-615-A PRESS BLOCK ASSY, PINCH

3-958-455-01 SPRING (PINCH), TENSION
3-977-447-01 GEAR, ELEVATOR

Remarks

Ref. No.

7-4

Part No.

Description

714
715
716
717
718

3-977-514-01
3-977-441-01
3-977-445-01
3-977-465-01
X-3947-582-1

OPENER, LID
GEAR, PINCH PRESSING
GEAR, TG8 ARM DRIVING
SPRING,EXTENSION(RVS BRAKE)
ARMASSY, RVS BRAKE

719
720
721
722
723

3-977-446-01
X-3947-590-1
A-6759-620-A
3-974-556-01
3-979-508-01

GEAR, TG8 ARM

TG8ASSY
HEAD BLOCK ASSY, ACE (TDK)
+HEXA TT 2.6X9 (TAPER)
SCREW +HEXA TP SW 3X8

724
725

X-3947-568-1 TC(N17S) ASSY

3-979-112-01 SCREW SW(+)BVTP 3X10

Remarks

7-1-4. MECHANISM DECK SECTION-2

776

771

772
773

761
#701

764
760

762

763
758
759

762
774
763

757
#702

766

756

775
765

755
754

752

753

751

Ref. No.

Part No.

Description

Part No.

Description

751
752
753
754
755

X-3947-581-1
3-977-462-01
X-3947-573-1
X-3947-580-2
3-977-513-02

BRAKE ASSY,MAIN(T)
SPRING,EXTENTION. (MAIN BRAKE)
ARMASSY, PENDULUM
BRAKE ASSY, MAIN(S)
LEVER, REC. PROOF

Remarks

Ref. No.
766
771
772
773
774

3-977-501-01
A-6746-074-G
X-3947-255-1
3-975-724-07
X-3946-855-1

PLATE, LUMINOUS
ROLLER BLOCK ASSY, HC
ROLLER ASSY, HC
ARM, HC
SHUTTLE (S) ASSY

756
757
758
759
760

3-976-767-01
3-977-487-01
X-3947-587-1
X-3947-589-1
3-977-488-01

SPRING, TENS. (REC. PROOF)

BOSS, TG1 FULCRUM
TG1ASSY
BAND ASSY, TG1
SPRING (POWER TENSION)

775
776

761
762
763
764
765

A-6750-324-A
X-3944-378-1
3-965-178-01
3-969-632-04
A-6750-328-E

SHUTTLE (S) BLOCK ASSY

ROLLER ASSY, GUIDE
SPRING
BASE, DRUM
SHUTTLE (T) BLOCK ASSY

X-3946-856-1 SHUTTLE (T) ASSY

1-759-183-11 DRUM ASSY, DZH-78A-R
(GA30:PS,TK/GA50:PS,TK/GA70K:PS,TK/GA77K:PS,TK/P66)
1-759-449-11 DRUM ASSY, DZH-91A-R
(GF80:PS,TK/GF90K:PS,TK/GF99K:ME,PS,TK/PH99)
1-759-451-11 DRUM ASSY, DZH-90A-R(GF99K:PL)
1-759-453-11 DRUM ASSY, DZH-89A-R
(GA30:SG,ME/GA50:SG,ME/GA66:ME)

776
776
776

776

7-5

1-759-455-11 DRUM ASSY, DZH-71D-R(GA77K:PL)

Remarks

7-1-5. MECHANISM DECK SECTION-3

816
815
817

M902

803
818

803
814
#701

812

813
828

811

829

820

810
808
809

819

827

821

826

807
805

822

806

804

823
824

830

M903

803

801
825

802

Ref. No.

Part No.

Description

801
802
803
804
805

3-977-437-01
X-3947-584-1
3-977-443-01
3-977-438-01
3-977-506-01

RETAINER,CAM MOTOR
ASSY, REEL DIRECT
WASHER, STOPPER
WORM - WHEEL
ARM, LIMITTER SELECTION

806
807
808
809
810

3-977-444-01
3-977-515-01
3-977-517-01
3-977-519-01
3-977-518-02

811
812
813
814
815

3-977-516-01
3-977-877-01
3-977-504-01
X-3947-585-1
3-977-510-01

816

3-977-440-01 WASHER, STOPPER

Remarks

#703
Ref. No.

Part No.

Description

817
818
819
820
821

3-977-439-01
3-977-442-01
3-977-455-01
3-977-456-03
X-3947-579-1

GEAR, CAM
SLIDER
GEAR, LOADING(T)
SPRING, TORSION (LOAD T)
LEVER ASSY, LOADING(T)

GEAR, PINCH TRANSMISSION

GUIDE, FL SLIDER
PLATE, SLIDE, FL
SPRING, TENS. (LIMIT, FL)
PLATE, LIMITTER, FL

822
823
824
825
826

3-977-451-01
3-977-452-01
X-3947-578-1
X-3947-576-2
3-977-468-01

GEAR, LOADING(S)
SPRING, TORSION (LOAD S)
LEVER ASSY, LOADING(S)
CHASSIS ASSY, MECHANICAL
SHAFT, CAPSTAN BRAKE

HOLDER, FL SLIDER
PLATE, RETAINER
GEAR, CLUTCH
GEAR ASSY, PULLEY
BELT, RUBBER

827
828
829
830
M902
M903

3-977-467-02
X-3947-583-1
3-977-489-01
A-6759-616-A
1-698-971-11
X-3947-577-1

SPRING, CAP BRAKE

BRAKE ASSY, CAPSTAN
ARM, TG1 DRIVING
GEAR BLOCK ASSY, LOADING(S)
MOTOR, DC(CAPSTAN)
MOTOR ASSY, CAM

7-6

Remarks

FR-140

FR-141

FR-142

7-2. ELECTRICAL PARTS LIST

NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.

Description

CAPACITORS:
uF: F
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: H
SEMICONDUCTORS
In each case, u: , for example:
uA...: A... , uPA... , PA... ,
uPB... , PB... , uPC... , PC... ,
uPD..., PD...
Remarks Ref. No.
Part No.

Ref. No.

Part No.

A-6794-581-A FR-140BOARD, COMPLETE

**********************
(GA30:ME,PS,SG/GA50:ME,PS,SG/GA66/GA70K:PS/
GA77K:PS/GF80:PS/GF90K:PS/GF99K:ME,PS)

Abbreviation
SG: Gulf Model
EE: East European Model
PS: Pan Asia Model
PL: Philippine Model
TK: Thai Model
When indicating parts by reference number,
please include the board name.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.

Description

Remarks

A-6794-615-A FR-141BOARD, COMPLETE (GA30:ME,PS,SG)

***********************

A-6794-622-A FR-141BOARD, COMPLETE (GA30:TK)

***********************

A-6794-591-A FR-140BOARD, COMPLETE

**********************
(GA77K:PL/GF99K:PL)

(Ref.No.:1,000 Series)
< DIODE >

A-6794-602-A FR-140BOARD, COMPLETE

**********************
(GA30:TK/GA50:TK/GA70K:TK/GA77K:TK/
GF80:TK/GF90K:TK/GF99K:TK)

(Ref.No.:1,000 Series)

D602

8-719-045-62 DIODE

< CONNECTOR >

* CN604

1-564-005-11 PIN, CONNECTOR 6P

< RESISTOR >

< CONNECTOR >

* CN605

R606
R607
R616
R642

1-564-004-11 PIN, CONNECTOR 5P

< DIODE >

D601

8-719-064-11 DIODE

1-216-055-00
1-216-057-00
1-216-063-91
1-216-035-00

8-729-901-06 TRANSISTOR
8-729-421-19 TRANSISTOR

R601
R602
R640

1-216-055-00 METAL CHIP

1-216-035-00 METAL CHIP
1-216-035-00 METAL CHIP

R641

1-216-057-00 METAL CHIP

DTA144EK
UN2213
(EXCEPT GA77K:PL/GF99K:PL)

1.8K
5%
1/10W
270
5%
1/10W
270
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
2.2K
5%
1/10W

S606
S607
S608
S609
S620

5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(EXCEPT GA30)

SWITCH, TACTIL (STOP)

SWITCH, TACTIL (PLAY)
SWITCH, TACTIL (FF)
SWITCH, TACTIL (REW)
SWITCH, TACTIL (SYNCHRO REC)
(EXCEPT GA30)
************************************************************

S601
1-571-977-11 SWITCH, TACTIL (ON/STANDBY)
S602
1-571-977-11 SWITCH, TACTIL (EJECT)
************************************************************
A-6794-582-A FR-141BOARD, COMPLETE
**********************
(EXCEPT GA30/GA50:TK/GA70K:TK/GA77K:TK/
GF80:TK/GF90K:TK/GF99K:TK)
A-6794-603-A FR-141BOARD, COMPLETE
**********************
(GA50:TK/GA70K:TK/GA77K:TK/
GF80:TK/GF90K:TK/GF99K:TK)

1-571-977-11
1-571-977-11
1-571-977-11
1-571-977-11
1-571-977-11

A-6794-583-A FR-142BOARD, COMPLETE (GF99K:ME,PS)

**********************

A-6794-587-A FR-142BOARD, COMPLETE (GF90K:PS)

**********************

A-6794-589-A FR-142BOARD, COMPLETE (GA77K:PL)

**********************

A-6794-590-A FR-142BOARD, COMPLETE (GF99K:PL)

**********************

A-6794-592-A FR-142BOARD, COMPLETE (GF80:PS/PH99)

**********************

A-6794-593-A FR-142BOARD, COMPLETE (GA77K:PS)

**********************

A-6794-599-A FR-142BOARD, COMPLETE (GA66)

**********************

< SWITCH >

1.8K
2.2K
3.9K
270

< SWITCH >

< RESISTOR >

METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP

SPR-325MVW

< TRANSISTOR >

Q601
Q602

SLR-342VC-A-47 (EXCEPT GA30)

7-7

FR-142
Ref. No.

Part No.

A-6794-601-A FR-142BOARD, COMPLETE (GA70K:PS)

**********************

Description

Remarks

A-6794-604-A FR-142BOARD, COMPLETE (GF99K:TK)

**********************

A-6794-610-A FR-142BOARD, COMPLETE (GF90:TK)

**********************

A-6794-612-A FR-142BOARD, COMPLETE (GA50:PS)

**********************

Ref. No.

Part No.

Description

D605
D606
D607
D608
D609

8-719-056-07
8-719-056-07
8-719-056-07
8-719-045-62
8-719-056-07

DIODE
DIODE
DIODE
DIODE
DIODE

D610

8-719-056-07 DIODE

D611

8-719-056-07 DIODE

D612

8-719-056-07 DIODE

A-6794-613-A FR-142BOARD, COMPLETE (GA50:ME,SG)

**********************

D613
D614

8-719-056-07 DIODE
8-719-056-07 DIODE

SLR-342MC3F
(GF80/GF90K/GF99K/PH99)
SLR-342MC3F
(GF80/GF90K/GF99K/PH99)
SLR-342MC3F
(GF80/GF90K/GF99K/PH99)
SLR-342MC3F(GA77K:PL/GF99K:PL)
SLR-342MC3F(GA66/GA77K/GF99K)

A-6794-614-A FR-142BOARD, COMPLETE (GF80:TK)

**********************

D615
D616

8-719-056-07 DIODE
8-719-056-07 DIODE

SLR-342MC3F
SLR-342MC3F

A-6794-616-A FR-142BOARD, COMPLETE (GA30:PS)

**********************

A-6794-617-A FR-142BOARD, COMPLETE (GA30:ME,SG)

**********************

< IC >
IC601

A-6794-618-A FR-142BOARD, COMPLETE (GA77K:TK)

**********************

A-6794-619-A FR-142BOARD, COMPLETE (GA70K:TK)

**********************

A-6794-621-A FR-142BOARD, COMPLETE (GA30:TK)

**********************

A-6794-646-A FR-142BOARD, COMPLETE (GA50:TK)

**********************

Remarks

SLR-342MC3F
SLR-342MC3F
SLR-342MC3F
SLR-342VC-A-47(EXCEPT GA30)
SLR-342MC3F

8-749-011-03 IC

GP1U26X

< JUMPER RESISTOR >

JR072
JR073
JR074
JR075
JR076

1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/10W
1/10W
1/8W
1/8W
1/8W

JR077

1-216-296-00 METAL CHIP

5%

1/8W

< JUMPER RESISTOR >

A-6794-656-A FR-142BOARD, COMPLETE (P66)

**********************

JS510

1-216-295-00 METAL CHIP

JS511

1-216-295-00 METAL CHIP

(Ref.No.:1,000 Series)
< CAPACITOR >
C505
C506
C509
C601

1-126-157-11 ELECT

10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
1-164-159-21 CERAMIC
0.1uF
50V
(GA70K/GA77K/GF90K/GF99K)
1-126-157-11 ELECT
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
1-163-038-00 CERAMIC CHIP 0.1uF
25V

0
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
0
5%
1/10W
(GA70K)

< RESISTOR >

R520

1-216-081-00 METAL CHIP

22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
270
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
12K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)

R521

1-216-081-00 METAL CHIP

R522

1-216-035-00 METAL CHIP

R524

1-216-073-00 METAL CHIP

R603

1-216-075-00 METAL CHIP

R604

1-216-085-00 METAL CHIP

33K
5%
1/10W
(GA50:ME,SG/GA66/GA77K:PL/GF99K:PL)
1-216-075-00 METAL CHIP
12K
5%
1/10W
(EXCEPT GA30:PL/GA40K/GA77K:PL/GF99K:PL)
1-216-055-00 METAL CHIP
1.8K
5%
1/10W
1-216-067-00 METAL CHIP
5.6K
5%
1/10W
1-216-085-00 METAL CHIP
33K
5%
1/10W
(GA30/GA50:ME,SG/P66)

< CONNECTOR >

CN502
CN601
CN602

1-506-469-11 PIN, CONNECTOR 4P

(GA70K/GA77K/GF90K/GF99K)
1-691-047-21 HOUSING, CONNECTOR 15P
1-569-930-11 HOUSING, CONNECTOR 13P
< DIODE >

D501

8-719-991-33 DIODE

D502

8-719-991-33 DIODE

D503

8-719-991-33 DIODE

D603
D604

8-719-056-07 DIODE
8-719-056-07 DIODE

1SS133T-77
(GA40K/GA70K/GA77K/GF90K/GF99K)
1SS133T-77
(GA40K/GA70K/GA77K/GF90K/GF99K)
1SS133T-77
(GA40K/GA70K/GA77K/GF90K/GF99K)
SLR-342MC3F
SLR-342MC3F

R605
R608
R609
R610

R611

R612
R613
R614
R615

7-8

1-216-085-00 METAL CHIP

33K
5%
1/10W
(GA50:PS,TK/GA66/GA70K/GA77K:PS,TK/
GF80/GF90K/GF99K:ME,PS,TK/PH99)
1-216-057-00 METAL CHIP
2.2K
5%
1/10W
1-216-063-91 RES,CHIP
3.9K
5%
1/10W
1-216-067-00 METAL CHIP
5.6K
5%
1/10W
(GA50:ME,SG/GA66/GA77K:PL/GF99K:PL)
1-216-295-00 METAL CHIP
0
5%
1/10W

FR-142
Ref. No.

Part No.

Description

Remarks

R618
R619

1-216-035-00 METAL CHIP

1-216-035-00 METAL CHIP

270
270

5%
1/10W
5%
1/10W
(EXCEPT GA30)
1K
5%
1/8W
270
5%
1/10W
(GF80/GF90K/GF99K/PH99)
270
5%
1/10W
(GF80/GF90K/GF99K/PH99)

R620
R621

1-216-198-91 RES,CHIP
1-216-035-00 METAL CHIP

R622

1-216-035-00 METAL CHIP

R623

1-216-198-91 RES,CHIP

R624

1-216-035-00 METAL CHIP

R625

1-216-035-00 METAL CHIP

R626
R627

1-216-035-00 METAL CHIP

1-216-035-00 METAL CHIP

R628
R629
R630
R631
R632

1-216-230-00 RES,CHIP
22K
5%
1/8W
(GA66/GA77K/GF80/GF90K/GF99K/PH99)
1-216-035-00 METAL CHIP
270
5%
1/10W
1-216-035-00 METAL CHIP
270
5%
1/10W
1-216-035-00 METAL CHIP
270
5%
1/10W
1-216-035-00 METAL CHIP
270
5%
1/10W

R633
R634

1-216-055-00 METAL CHIP

1-216-085-00 METAL CHIP

1K
5%
1/8W
(GF80/GF90K/GF99K/PH99)
270
5%
1/10W
(GA77K:PL/GF99K:PL)
270
5%
1/10W
(GA66/GA77K/GF99K)
270
5%
1/10W
270
5%
1/10W

JK-166

Ref. No.

Part No.

A-6794-585-A JK-166BOARD, COMPLETE

**********************
(GA66/GA77K:PL,PS/GF99K:ME,PL,PS)

Description

Remarks

A-6794-588-A JK-166BOARD, COMPLETE

**********************
(GF80:PS/GF90K:PS/PH99)

A-6794-606-A JK-166BOARD, COMPLETE

***********************
(GA77K:TK/GF99K:TK)

A-6794-611-A JK-166BOARD, COMPLETE

***********************
(GF80:TK/GF90K:TK)
(Ref.No.:2,000 Series)
3-051-657-01 JACKHOLDER,

PIN

< CONNECTOR >

CN651

1-691-043-21 HOUSING, CONNECTOR 11P

< JACK >

R635
R636
R637

1.8K
5%
1/10W
33K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
1-216-234-00 RES,CHIP
33K
5%
1/8W
(GA66/GA77K/GF80/GF90K/GF99K/PH99)
1-216-085-00 METAL CHIP
33K
5%
1/10W
(GA50:ME,SG/GA66/GA77K:PL/GF99K:PL)
1-216-073-00 METAL CHIP
10K
5%
1/10W
(EXCEPT GF77K:PL/GF99K:PL)

CNJ651 1-785-606-11 JACK, PIN 3P(LINE-2 IN)

CNJ652 1-785-606-11 JACK, PIN 3P(LINE-2 OUT)
(GA66/GA77K/GF99K)
< DIODE >

< VARIABLE RESISTOR >

RV501
RV502
RV503

1-223-914-11 RES, VAR, CARBON 10K(ECHO)

(GA70K/GA77K/GF90K/GF99K)
1-223-914-11 RES, VAR, CARBON 10K(MIC VOL 1)
(GA70K/GA77K/GF90K/GF99K)
1-223-914-11 RES, VAR, CARBON 10K(MIC VOL 2)
(GA70K/GA77K/GF90K/GF99K)

S501
S603
S605
S610

S610
S611
S612
S613
S614

1-572-907-11 SWITCH, SLIDE(KARAOKE)

(GA77K/GF90K/GF99K)
1-572-908-11 SWITCH, SLIDE(KARAOKE)(GA70K)
1-571-977-11 SWITCH, TACTIL(VIRTUAL SURROUND)
(GA66/GA77K/GF99K)
1-572-907-11 SWITCH, SLIDE(COLOR SYSTEM)
(EXCEPT GA77K:PL/GF99K:PL)
1-572-907-11 SWITCH, SLIDE(NTSC PB)
(GA50:PS,TK/GA66/GA70K/GA77K/GF80/
GF90K/GF99K:ME,PS,TK)
1-572-908-11
1-571-977-11
1-571-977-11
1-418-059-11
1-572-908-11

SWITCH, SLIDE(NTSC PB)(GA50:ME,SG/P66)

SWITCH, TACTIL(AUTO/MANUAL)
SWITCH, TACTIL(ON SCREEN DISPLAY)
ENCODER, ROTARY(PICTURE CONTROL)
SWITCH, SLIDE(TAPE SPEED)
(GA50:ME,SG/GA66/GA77K:PL/GF99K:PL)

8-719-108-12
8-719-108-12
8-719-108-12
8-719-108-12
8-719-108-12

DIODE
DIODE
DIODE
DIODE
DIODE

D645
D651
D652

8-719-108-12 DIODE
8-719-988-62 DIODE
8-719-988-62 DIODE

RD9.1E-W (GA66/GA77K/GF99K)
RD9.1E-W (GA66/GA77K/GF99K)
RD9.1E-W (GA66/GA77K/GF99K)
RD9.1E-W
RD9.1E-W
RD9.1E-W
1SS355
1SS355

< JUMPER RESISTOR >

< SWITCH >

S501

D640
D641
D642
D643
D644

JR651
JR652
JR653
JR654
JR655

1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/8W
1/8W
1/8W

JR656

1-216-296-00 METAL CHIP

5%

1/8W

< RESISTOR >

5%
1/10W
(GA66/GA77K/GF99K)
R652
1-216-041-00 METAL CHIP
470
5%
1/10W
(GA66/GA77K/GF99K)
R653
1-216-023-00 METAL CHIP
82
5%
1/10W
************************************************************

S615

1-572-908-11 SWITCH, SLIDE(INPUT SELECT)

(GA66/GA77K/GF80/GF90K/GF99K/PH99)
************************************************************

7-9

R651

1-216-041-00 METAL CHIP

470

MA-336
Ref. No.

Part No.

A-6791-702-A MA-336BOARD, COMPLETE (GF99K:ME,PS)

***********************

Description

Remarks

A-6791-703-A MA-336BOARD, COMPLETE (GF90K:PS)

***********************

A-6791-704-A MA-336BOARD, COMPLETE (GF80:PS/PH99)

***********************

A-6791-705-A MA-336BOARD, COMPLETE (GA77K:PL)

***********************

A-6791-706-A MA-336BOARD, COMPLETE (GF99K:PL)

***********************

Ref. No.

Part No.

Description

C105
C106
C107
C108
C109

1-163-031-11
1-163-031-11
1-163-031-11
1-163-031-11
1-164-232-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.01uF
0.01uF
0.01uF
0.01uF
0.01uF

C110
C111
C112
C113
C114

1-126-160-11
1-163-017-00
1-124-257-00
1-124-465-00
1-163-037-11

ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP

1uF
0.0047uF
2.2uF
0.47uF
0.022uF

20%
5%
20%
20%
10%

50V
50V
50V
50V
25V

C115
C116
C118
C119
C120

1-163-038-00
1-126-163-11
1-163-222-11
1-126-163-11
1-163-037-11

CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
4.7uF
5PF
4.7uF
0.022uF

20%
0.25PF
20%
10%

25V
50V
50V
50V
25V

C121
C122
C123
C124
C125

1-124-584-00
1-163-038-00
1-163-031-11
1-163-031-11
1-163-038-00

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
0.1uF
0.01uF
0.01uF
0.1uF

20%

10V
25V
50V
50V
25V

1-164-489-11
1-163-031-11
1-163-031-11
1-124-584-00
1-163-038-00

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.22uF
0.01uF
0.01uF
100uF
0.1uF

10%

16V
50V
50V
10V
25V

1-163-263-11 CERAMIC CHIP

1-126-160-11 ELECT

330PF
1uF

C134
C135

5%
50V
20%
50V
(EXCEPT GA30)
1-126-160-11 ELECT
1uF
20%
50V
(GA66/GA77K/GF80/GF90K/GF99K/PH99)
1-124-584-00 ELECT
100uF
20%
10V
1-163-038-00 CERAMIC CHIP 0.1uF
25V

C136
C137
C138

1-163-121-00 CERAMIC CHIP

1-163-038-00 CERAMIC CHIP
1-163-233-11 CERAMIC CHIP

150PF
0.1uF
18PF

C140
C141

1-163-038-00 CERAMIC CHIP

1-164-232-11 CERAMIC CHIP

C142
C143
C144

1-163-038-00 CERAMIC CHIP

1-126-157-11 ELECT
1-163-038-00 CERAMIC CHIP

0.1uF
25V
0.01uF
50V
(GA30/GA50/GA70K/P66)
0.1uF
25V
10uF
20%
16V
0.1uF
25V

C145
C146
C147
C148
C149

1-163-038-00
1-126-162-11
1-126-157-11
1-164-232-11
1-124-257-00

CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT

0.1uF
3.3uF
10uF
0.01uF
2.2uF

C150
C151
C152

1-163-031-11 CERAMIC CHIP

1-163-031-11 CERAMIC CHIP
1-163-235-11 CERAMIC CHIP

0.01uF
0.01uF
22PF

A-6791-707-A MA-336BOARD, COMPLETE (GA77K:PS)

***********************

A-6791-710-A MA-336BOARD, COMPLETE (GA66)

***********************

A-6791-711-A MA-336BOARD, COMPLETE (GA70K:PS)

***********************

A-6791-712-A MA-336BOARD, COMPLETE (GF99K:TK)

***********************

A-6791-715-A MA-336BOARD, COMPLETE (GF90K:TK)

***********************

C126
C127
C128
C129
C130

A-6791-716-A MA-336BOARD, COMPLETE (GF80:TK)

***********************

C131
C132

A-6791-717-A MA-336BOARD, COMPLETE (GA50:PS)

***********************

C133

A-6791-718-A MA-336BOARD, COMPLETE (GA50:ME,SG)

***********************

A-6791-719-A MA-336BOARD, COMPLETE (GA30:PS)

***********************

A-6791-720-A MA-336BOARD, COMPLETE (GA30:ME,SG)

***********************

A-6791-721-A MA-336BOARD, COMPLETE (GA77K:TK)

***********************

A-6791-722-A MA-336BOARD, COMPLETE (GA70:TK)

***********************

A-6791-724-A MA-336BOARD, COMPLETE (GA30:TK)

***********************

A-6791-729-A MA-336BOARD, COMPLETE (GA50:TK)

***********************

C138
C139

A-6791-744-A MA-336BOARD, COMPLETE (P66)

***********************

(Ref.No.:1,000 Series)
< CAPACITOR >
C100
C101
C102
C103
C104

1-163-038-00
1-126-162-11
1-163-989-11
1-124-584-00
1-163-038-00

CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
3.3uF
0.033uF
100uF
0.1uF

20%
10%
20%

25V
50V
25V
10V
25V

C152
C153

7-10

Remarks
50V
50V
50V
50V
50V

20%

5%

50V
25V
5%
50V
(GA77K:PL/GF99K:PL)
1-163-235-11 CERAMIC CHIP 22PF
5%
50V
(EXCEPT GA77K:PL/GF99K:PL)
1-163-237-11 CERAMIC CHIP 27PF
5%
50V
(GA77K:PL/GF99K:PL)

20%
20%
20%

25V
50V
16V
50V
50V

50V
50V
5%
50V
(GA77K:PL/GF99K:PL)
1-163-241-11 CERAMIC CHIP 39PF
5%
50V
(EXCEPT GA77K:PL/GF99K:PL)
1-163-235-11 CERAMIC CHIP 22PF
5%
50V
(GA77K:PL/GF99K:PL)

MA-336
Ref. No.

Part No.

Description

Remarks

Ref. No.

39PF
5%
50V
(EXCEPT GA77K:PL/GF99K:PL)
33PF
5%
50V
0.1uF
25V
(EXCEPT GA77K:PL/GF99K:PL)
0.022uF 10%
50V
1uF
16V

C265
C266

C153

1-163-241-11 CERAMIC CHIP

C155
C160

1-163-239-11 CERAMIC CHIP

1-163-038-00 CERAMIC CHIP

C200
C201

1-163-063-91 CERAMIC CHIP

1-164-346-11 CERAMIC CHIP

C202
C203
C204
C205
C206

1-163-243-11
1-126-157-11
1-163-038-00
1-124-584-00
1-124-234-00

CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT

47PF
10uF
0.1uF
100uF
22uF

5%
20%

C207
C208
C209
C210
C211

1-163-229-11
1-163-241-11
1-163-241-11
1-163-251-11
1-163-031-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

12PF
39PF
39PF
100PF
0.01uF

5%
5%
5%
5%

C212
C213
C214
C215
C216

1-126-163-11
1-126-157-11
1-163-031-11
1-163-253-11
1-163-031-11

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

4.7uF
10uF
0.01uF
120PF
0.01uF

20%
20%

C217
C219
C221
C223
C224

1-164-232-11
1-163-038-00
1-163-038-00
1-163-231-11
1-163-231-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

0.01uF
0.1uF
0.1uF
15PF
15PF

C227
C229
C232
C233
C234

1-124-589-11
1-163-038-00
1-164-489-11
1-164-182-11
1-163-809-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

47uF
0.1uF
0.22uF
0.0033uF
0.047uF

20%

C235
C236
C237
C240
C241

1-163-037-11
1-163-038-00
1-124-589-11
1-163-009-11
1-163-009-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP

0.022uF
0.1uF
47uF
0.001uF
0.001uF

10%

C242
C243
C244
C245
C250

1-163-009-11
1-163-009-11
1-124-589-11
1-163-038-00
1-126-935-11

CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT

0.001uF
0.001uF
47uF
0.1uF
470uF

10%
10%
20%

C251
C252
C254
C255
C256

1-124-584-00
1-124-589-11
1-163-031-11
1-163-031-11
1-163-031-11

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP

100uF
47uF
0.01uF
0.01uF
0.01uF

20%
20%

C257
C259
C260
C261
C262

1-163-038-00
1-163-031-11
1-163-253-11
1-124-584-00
1-163-038-00

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP

0.1uF
0.01uF
120PF
100uF
0.1uF

C263
C264

1-163-038-00 CERAMIC CHIP 0.1uF

25V
1-163-237-11 CERAMIC CHIP 27PF
5%
50V
(GA30:PS,TK/GA50PS,TK/GA70K/GA77K:PS,TKG/F80/
GF90K:PS,TK/GF99K:ME,PS,TK/P66/PH99)
1-163-239-11 CERAMIC CHIP 33PF
5%
50V
(GA30:ME,SG/GA50:ME,SG/GA66/GA77K:PL/GF99K:PL)

C264

20%
20%

5%

5%
5%

10%
10%
10%

20%
10%
10%

20%

5%
20%

Part No.

Description

Remarks

C268
C290

39PF
5%
50V
1uF
16V
(EXCEPT GA77K:PL/GF99K:PL)
1-163-245-11 CERAMIC CHIP 56PF
5%
50V
(EXCEPT GA77K:PL/GF99K:PL)
1-163-017-00 CERAMIC CHIP 0.0047uF 5%
50V
1-163-009-11 CERAMIC CHIP 0.001uF 10%
50V

C298
C300

1-163-009-11 CERAMIC CHIP

1-164-161-11 CERAMIC CHIP

C301

1-164-232-11 CERAMIC CHIP

C302

1-164-004-11 CERAMIC CHIP

C304

1-164-004-11 CERAMIC CHIP

C305

1-164-161-11 CERAMIC CHIP

50V
16V
50V
50V
50V

C307

1-164-232-11 CERAMIC CHIP

C308

1-164-004-11 CERAMIC CHIP

C309

1-164-232-11 CERAMIC CHIP

50V
25V
25V
50V
50V

C310

1-163-038-00 CERAMIC CHIP

C311

1-124-589-11 ELECT

C312

1-163-037-11 CERAMIC CHIP

C313

1-163-037-11 CERAMIC CHIP

C314

1-163-038-00 CERAMIC CHIP

C315

1-124-589-11 ELECT

C316

1-164-004-11 CERAMIC CHIP

C317

1-163-016-00 CERAMIC CHIP

C319

1-124-589-11 ELECT

C321

1-126-157-11 ELECT

C323

1-124-257-00 ELECT

C325

1-126-157-11 ELECT

C326

1-124-589-11 ELECT

C327

1-163-016-00 CERAMIC CHIP

C328

1-126-157-11 ELECT

C331

1-164-004-11 CERAMIC CHIP

C332

1-126-160-11 ELECT

C333

1-126-157-11 ELECT

C334

1-126-157-11 ELECT

C351

1-126-157-11 ELECT

C352

1-126-157-11 ELECT

50V
16V
25V
10V
16V
50V
50V
50V
50V
50V

16V
25V
16V
50V
25V
25V
25V
16V
50V
50V
50V
50V
16V
25V
16V
10V
16V
50V
50V
50V
25V
50V
50V
10V
25V

7-11

C267

1-163-241-11 CERAMIC CHIP

1-164-346-11 CERAMIC CHIP

0.001uF 10%
50V
0.0022uF 10%
100V
(GF80/GF90K/GF99K/PH99)
0.01uF
50V
(GF80/GF90K/GF99K/PH99)
0.1uF
10%
25V
(GF80/GF90K/GF99K/PH99)
0.1uF
10%
25V
(GF80/GF90K/GF99K/PH99)
0.0022uF 10%
100V
(GF80/GF90K/GF99K/PH99)
0.01uF
50V
(GF80/GF90K/GF99K/PH99)
0.1uF
10%
25V
(GF80/GF90K/GF99K/PH99)
0.01uF
50V
(GF80/GF90K/GF99K/PH99)
0.1uF
25V
(GF80/GF90K/GF99K/PH99)
47uF
20%
16V
(GF80/GF90K/GF99K/PH99)
0.022uF 10%
25V
(GF80/GF90K/GF99K/PH99)
0.022uF 10%
25V
(GF80/GF90K/GF99K/PH99)
0.1uF
25V
(GF80/GF90K/GF99K/PH99)
47uF
20%
16V
(GF80/GF90K/GF99K/PH99)
0.1uF
10%
25V
(GF80/GF90K/GF99K/PH99)
0.0039uF 10%
50V
(GF80/GF90K/GF99K/PH99)
47uF
20%
16V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(GF80/GF90K/GF99K/PH99)
2.2uF
20%
50V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(GF80/GF90K/GF99K/PH99)
47uF
20%
16V
(GF80/GF90K/GF99K/PH99)
0.0039uF 10%
50V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(GF80/GF90K/GF99K/PH99)
0.1uF
10%
25V
(GF80/GF90K/GF99K/PH99)

1uF
20%
50V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(GF80/GF90K/GF99K/PH99)
10uF
20%
16V
(EXCEPT GA30/GA50/GA70K/P66)
10uF
20%
16V
(EXCEPT GA30/GA50/GA70K/P66)

MA-336
Ref. No.

Part No.

Description

C400
C401
C402
C403
C404

1-126-157-11
1-124-584-00
1-163-038-00
1-163-037-11
1-124-234-00

ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT

C405
C406
C407

1-163-009-11 CERAMIC CHIP

1-126-163-11 ELECT
1-164-161-11 CERAMIC CHIP

Remarks
10uF
100uF
0.1uF
0.022uF
22uF

20%
20%
10%
20%

C527
C528
C529

C408

0.001uF 10%
50V
4.7uF
20%
50V
0.0022uF 10%
100V
(GA77K:PL/GF99K:PL)
1-164-182-11 CERAMIC CHIP 0.0033uF 10%
50V
(EXCEPT GA77K:PL/GF99K:PL)
1-126-163-11 ELECT
4.7uF
20%
50V

C409
C410
C412

1-126-157-11 ELECT
1-163-038-00 CERAMIC CHIP
1-126-160-11 ELECT

10uF
0.1uF
1uF

C413
C414

1-124-234-00 ELECT
1-126-163-11 ELECT

22uF
4.7uF

C417

1-137-360-11 FILM

220PF

C418

1-137-374-11 FILM

C419

1-163-038-00 CERAMIC CHIP

C420

1-164-182-11 CERAMIC CHIP

C422

1-124-589-11 ELECT

C407

1-163-038-00 CERAMIC CHIP

0.1uF

C424

1-163-038-00 CERAMIC CHIP

0.1uF

C425
C426
C427

1-126-157-11 ELECT
1-124-259-11 ELECT
1-164-232-11 CERAMIC CHIP

10uF
4.7uF
0.01uF

C428
C513
C514

1-124-259-11 ELECT
1-126-157-11 ELECT
1-126-157-11 ELECT

C516

16V
25V
20%
50V
(EXCEPT GA30)
20%
16V
20%
50V

25V
(EXCEPT GA30)
25V
(EXCEPT GA30)
20%
16V
20%
16V
50V

4.7uF
20%
16V
10uF
20%
16V
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
1-164-346-11 CERAMIC CHIP 1uF
16V
(GA70K/GA77K/GF90K/GF99K)
1-164-346-11 CERAMIC CHIP 1uF
16V
(GA70K/GA77K/GF90K/GF99K)

C517

1-163-036-00 CERAMIC CHIP

C518

1-163-036-00 CERAMIC CHIP

C519

1-163-031-11 CERAMIC CHIP

C520

1-163-038-00 CERAMIC CHIP

C521

1-163-038-00 CERAMIC CHIP

C522

1-124-465-00 ELECT

C523

1-163-259-91 CERAMIC CHIP

C524

1-163-016-00 CERAMIC CHIP

C525

1-163-018-00 CERAMIC CHIP

C526

1-163-259-91 CERAMIC CHIP

C530
C531

Part No.

0.068uF
50V
(GA70K/GA77K/GF90K/GF99K)
0.068uF
50V
(GA70K/GA77K/GF90K/GF99K)
0.01uF
50V
(GA70K/GA77K/GF90K/GF99K)
0.1uF
25V
(GA70K/GA77K/GF90K/GF99K)
0.1uF
25V
(GA70K/GA77K/GF90K/GF99K)
0.47uF
20%
50V
(GA70K/GA77K/GF90K/GF99K)
220PF
5%
50V
(GA70K/GA77K/GF90K/GF99K)
0.0039uF 10%
50V
(GA70K/GA77K/GF90K/GF99K)
0.0056uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)
220PF
5%
50V
(GA70K/GA77K/GF90K/GF99K)

7-12

Description

Remarks

1-163-016-00 CERAMIC CHIP

0.0039uF 10%
50V
(GA70K/GA77K/GF90K/GF99K)
1-163-018-00 CERAMIC CHIP 0.0056uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)
1-124-465-00 ELECT
0.47uF
20%
50V
(GA70K/GA77K/GF90K/GF99K)
1-163-038-00 CERAMIC CHIP 0.1uF
25V
(GA70K/GA77K/GF90K/GF99K)
1-124-589-11 ELECT
47uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)

C532

1-126-160-11 ELECT

C533

1-126-163-11

C535

1-163-009-11

C536

1-126-157-11

C537

1-163-038-00

C538

1-124-589-11 ELECT

C539

1-163-077-00 CERAMIC CHIP

C541

1-163-017-00 CERAMIC CHIP

C542

1-163-017-00 CERAMIC CHIP

C543

1-163-017-00 CERAMIC CHIP

C544

1-163-017-00 CERAMIC CHIP

C581

1-163-038-00

C582

1-126-157-11

C584

1-126-157-11

C585

1-126-157-11

C753

1-163-038-91 CERAMIC CHIP

C754

1-163-077-00 CERAMIC CHIP

C759

1-124-259-11 ELECT

C760

1-124-259-11 ELECT

C761

1-126-160-11 ELECT

C762

1-126-160-11 ELECT

C800

1-128-057-11

C801
C802
C803

1-124-589-11
1-163-038-00
1-126-157-11

C804

1-126-157-11 ELECT

C805
C806
C807

1-128-057-11
1-124-584-00
1-163-017-00

C808

1-163-038-00

20%

5%
50V
(EXCEPT GA30)
0.047uF 5%
50V
(EXCEPT GA30)
0.1uF
25V
(EXCEPT GA30)
0.0033uF 10%
50V
(EXCEPT GA30)
47uF
20%
16V
(EXCEPT GA30)

C423

C515

Ref. No.

16V
10V
25V
25V
16V

1uF
20%
50V
(GA70K/GA77K/GF90K/GF99K)
ELECT
4.7uF
20%
50V
(GA70K/GA77K/GF90K/GF99K)
CERAMIC CHIP 0.001uF 10%
50V
(GA70K/GA77K/GF90K/GF99K)
ELECT
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
CERAMIC CHIP 0.1uF
25V
(GA70K/GA77K/GF90K/GF99K)
47uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
0.1uF
10%
25V
(GA70K/GA77K/GF90K/GF99K)
0.0047uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)
0.0047uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)
0.0047uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)

0.0047uF 5%
50V
(GA70K/GA77K/GF90K/GF99K)
CERAMIC CHIP 0.1uF
25V
(GA70K/GA77K/GF90K/GF99K)
ELECT
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
ELECT
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
ELECT
10uF
20%
16V
(GA70K/GA77K/GF90K/GF99K)
0.1uF

25V
(GA66/GA77K)
0.1uF
10%
25V
(GA66/GA77K)
4.7uF
20%
16V
(GA66/GA77K/GF90K/GF99K)
4.7uF
20%
16V
(GA66/GA77K/GF90K/GF99K)
1uF
20%
50V
(GF90K/GF99K)
1uF

20%
50V
(GF90K/GF99K)
ELECT
330uF
20%
6.3V
(GA66/GA77K/GF99K)
ELECT
47uF
20%
16V
CERAMIC CHIP 0.1uF
25V
ELECT
10uF
20%
16V
(EXCEPT GA30/GA50/GA70K/P66)
10uF

20%
16V
(EXCEPT GA30)
ELECT
330uF
20%
6.3V
ELECT
100uF
20%
10V
CERAMIC CHIP 0.0047uF 5%
50V
(GA77K:PL/GF99K:PL)
CERAMIC CHIP 0.1uF
25V
(EXCEPT GA77K:PL/GF99K:PL)

MA-336
Ref. No.

Part No.

Description

C809
! C951
! C952
! C953
! C955

1-164-232-11
1-104-706-11
1-113-898-11
1-113-898-11
1-104-706-11

CERAMIC CHIP
FILM
CERAMIC
CERAMIC
FILM

0.01uF
0.22uF
330PF
330PF
0.22uF

Remarks

! C956
! C958
C959
C960
C961

1-113-898-11
1-107-405-11
1-163-038-00
1-163-038-00
1-124-589-11

CERAMIC
ELECT(BLOCK)
CERAMIC CHIP
CERAMIC CHIP
ELECT

330PF
68uF
0.1uF
0.1uF
47uF

250V
400V
25V
25V
20%
16V
(EXCEPT GA30)

IC101

8-759-562-59 IC

IC101
IC201
IC202
IC203

8-759-568-04
8-759-562-79
8-759-481-46
8-759-248-87

25V
(EXCEPT GA30)
20%
16V
20%
6.3V

IC204
IC301

8-759-708-05 IC
8-759-486-64 IC

IC302
IC502

8-759-486-92 IC
8-759-344-05 IC

IC503

8-759-344-02 IC

IC581
IC751

8-759-909-71 IC
8-759-525-25 IC

IC752

8-759-909-71 IC

C962

1-163-038-00 CERAMIC CHIP

0.1uF

C963
C964

1-126-935-11 ELECT
1-128-057-11 ELECT

470uF
330uF

20%
10%
10%
20%

50V
250V
250V
250V
250V

Ref. No.

Part No.

Description

! F951

1-532-388-31 FUSE 2A 250V

< IC >

10%
20%

IC
IC
IC
IC

< CONNECTOR >

* CN101
CN102
CN201
CN202
* CN203

PIN, CONNECTOR 4P
HOUSING, CONNECTOR 8P
HOUSING, CONNECTOR 15P
CONNECTOR, FFC/FPC 11P
(GA66/GA77K/GF80/GF90K/GF99K)
1-766-716-11 CONNECTOR, BOARD TO BOARD 3P

CN204
CN205
CN206
* CN207
* CN208

1-695-330-31
1-779-723-11
1-569-930-11
1-564-004-11
1-564-005-11

CN209
* CN210
* CN401
* CN402
CN702

! CN951

Remarks

< FUSE >

1-560-892-00
1-691-040-41
1-691-047-21
1-784-490-11

HOUSING, CONNECTOR 7P
CONNECTOR, BOARD TO BOARD 9P
HOUSING, CONNECTOR 13P
PIN, CONNECTOR 5P
PIN, CONNECTOR 6P

HA118211BF
(EXCEPT GA77K:PL/GF99K:PL)
HA118211BNF(GA77K:PL/GF99K:PL)
HD6433975RB38F
LB1943
MM1256XF-BE
NJM78L05A
TDA9615H/N1,557
(GF80/GF90K/GF99K/PH99)
LA7256 (GF80/GF90K/GF99K/PH99)
BA7726AFS-E2
(GA70K/GA77K/GF90K/GF99)
BU9252F-E2
(GA70K/GA77K/GF90K/GF99K)
BA4558F (GA70K/GA77K/GF90K/GF99K)
BU4052BCF-E2
(GA66/GA77K/GF90K/GF99K)
BA4558F (GA66/GA77K)

< JUMPER RESISTOR >

1-564-002-11 PIN, CONNECTOR 3P

(GA70K/GA77K/GF90K/GF99K)
1-560-890-00 PIN, CONNECTOR 2P
1-560-894-00 PIN, CONNECTOR 6P
1-560-890-00 PIN, CONNECTOR 2P (EXCEPT GA30)
1-573-842-11 CONNECTOR, BOARD TO BOARD 10P
(GA66/GA77K/GF99K)
1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
< JACK >

CNJ801 1-779-010-21 JACK, PIN 4P (LINE-1 IN/OUT)(EXCEPT GA30)

* CNJ801 1-779-924-11 JACK, PIN 2P (LINE OUT) (GA30)
< DIODE >
D201
D203
D250
D251
D581

8-719-911-19
8-719-048-26
8-719-911-19
8-719-911-19
8-719-988-62

DIODE
DIODE
DIODE
DIODE
DIODE

1SS119
GL528V1
1SS119 (GF99K)
1SS119 (GF90K/GF99K)
1SS355
(GA70K/GA77K/GF90K/GF99K)

D582

8-719-988-62 DIODE

D807

8-719-108-12 DIODE

D808

8-719-108-12 DIODE

D809

8-719-108-12 DIODE

D810

8-719-108-12 DIODE

1SS355
(GA70K/GA77K/GF90K/GF99K)
RD9.1E-W
(GA66/GA77K/GF80/GF90K/GF99K)
RD9.1E-W
(GA66/GA77K/GF80/GF90K/GF99K)
RD9.1E-W
(GA66/GA77K/GF80/GF90K/GF99K)
RD9.1E-W
(GA66/GA77K/GF80/GF90K/GF99K)

! D951
D961

8-719-510-06 DIODE
8-719-110-18 DIODE

S1WB60
RD10ES-B3 (EXCEPT GA30)

JR001
JR002
JR003
JR004
JR005

1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/10W
1/10W
1/8W
1/8W
1/8W

JR006
JR007
JR008
JR009
JR010

1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/10W
1/8W
1/8W
1/8W

JR011
JR012
JR013
JR014
JR015

1-216-295-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/10W
1/8W
1/10W
1/8W
1/8W

JR016
JR017
JR018
JR019
JR020

1-216-296-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-295-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/10W
1/8W
1/10W

JR021
JR022
JR023
JR024
JR025

1-216-296-00
1-216-296-00
1-216-295-00
1-216-295-00
1-216-295-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/10W
1/10W
1/10W

JR026
JR027
JR028
JR029
JR030

1-216-295-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-295-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/10W
1/8W
1/10W
1/8W
1/10W

JR031
JR032
JR033
JR034
JR035

1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/8W
1/8W
1/8W

Note :

7-13

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

MA-336
Ref. No.

Part No.

Description

JR036
JR037
JR038
JR039
JR040

1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

Remarks
1/10W
1/8W
1/8W
1/8W
1/8W

JR041
JR042
JR043
JR044
JR045

1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/10W
1/8W
1/8W
1/8W

JR046
JR047
JR048
JR049
JR050

1-216-296-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/10W
1/8W
1/8W

JR051
JR052
JR053
JR054
JR055

1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-295-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

JR056
JR057
JR058
JR059
JR060

1-216-295-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

JR061
JR062
JR063
JR064
JR065

1-216-296-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

JR066
JR067
JR068
JR069
JR070

1-216-296-00
1-216-295-00
1-216-296-00
1-216-295-00
1-216-295-00

JR071
JR078
JR079
JR080
JR081

1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00

JR082

Ref. No.
JS930

Part No.

Description

1-249-429-11 CARBON

1-414-189-31
1-414-189-31
1-410-510-11
1-414-189-31
1-414-189-31

L107

1-410-520-11 INDUCTOR

1/8W
1/8W
1/8W
1/8W
1/10W

L108
L109
L110
L201
L206

1-410-520-11
1-414-189-31
1-410-509-11
1-410-511-11
1-410-503-11

5%
5%
5%
5%
5%

1/10W
1/8W
1/10W
1/8W
1/8W

L207
L208

1-414-189-31 INDUCTOR
1-410-513-11 INDUCTOR

L301

1-414-189-31 INDUCTOR

L302

1-414-189-31 INDUCTOR

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/8W
1/10W
1/8W
1/8W

L401
L501

1-414-189-31 INDUCTOR
1-414-189-31 INDUCTOR

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/8W
1/10W
1/8W
1/10W
1/10W

L801
L802
L952
L953

1-414-189-31
1-414-189-31
1-403-588-11
1-403-588-11

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
0
0
0
0

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

1-216-296-00 METAL CHIP

5%

1/8W

1-216-295-00 METAL CHIP

JS907

1-216-295-00 METAL CHIP

JS911

1-216-295-00 METAL CHIP

JS922

1-216-295-00 METAL CHIP

JS924

1-216-295-00

JS927

1-216-295-00

JS928

1-216-295-00

JS929

1-216-295-00

INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR

INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR

INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR

100uH
100uH
12uH
100uH
100uH
82uH
(EXCEPT GA77K:PL/GF99K:PL)
82uH
100uH
10uH
15uH
3.3uH
100uH
22uH
(EXCEPT GA77K:PL/GF99K:PL)
100uH
(GF80/GF90K/GF99K/PH99)
100uH
(GF80/GF90K/GF99K/PH99)
100uH (EXCEPT GA30)
100uH
(GA70K/GA77K/GF90K/GF99K)
100uH
100uH
22uH
22uH

1-423-850-11 FILTER, LINE

< PHOTO INTERRUPTER >

PH201
PH202

8-749-013-23 PHOTO INTERRUPTER GP3S120

8-749-013-23 PHOTO INTERRUPTER GP3S120
< IC LINK >

< JUMPER RESISTOR >

JS502

10K
5%
1/4W
(EXCEPT GA77K:PL/GF99K:PL)

< LINE FILTER >

! LF951

0
0

5%
1/10W
(GA66/GA77K)

< COIL >

L101
L102
L104
L105
L106

1-216-295-00 METAL CHIP

1-216-295-00 METAL CHIP

< JUMPER RESISTOR >

JW223

JS302
JS401

Remarks

1-216-295-00 METAL CHIP

! PS001
! PS002

1/10W
1/10W
(GA30)
0
5%
1/10W
(GF90K)
0
5%
1/10W
(GA66/GF90K)
0
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)

1-533-586-31 LINK, IC 0.315A

1-533-589-31 LINK, IC 0.75A

5%
5%

5%
1/10W
(GA66/GA77K)
METAL CHIP
0
5%
1/10W
(GA66/GA77K)
METAL CHIP
0
5%
1/10W
(EXCEPT GA30:PS,TK/GA50:ME,SG/
GF90K/GF99L)
METAL CHIP
0
5%
1/10W
(GA66/GA77K/GF80/PH99)
METAL CHIP
0
5%
1/10W
(GA66/GA77K)

< TRANSISTOR >

Q101

8-729-421-19 TRANSISTOR

Q102
Q103
Q104

8-729-010-29 TRANSISTOR
8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR

Q201

8-729-042-88 TRANSISTOR

Q202
Q203
Q204

8-729-042-88 TRANSISTOR
8-729-281-53 TRANSISTOR
8-729-421-19 TRANSISTOR

Q205
Q206

8-729-010-29 TRANSISTOR
8-729-421-19 TRANSISTOR

UN2213
(EXCEPT GA77K:PL/GF99K:PL)
MSD601-RST1
UN2213
UN2213
(EXCEPT GA77K:PL/GF99K:PL)
RPT-37PBT32

7-14

Note :

RPT-37PBT32
2SC1815-GR
UN2213
(EXCEPT GA77K:PL/GF99K:PL)
MSD601-RST1
UN2213
(GA66/GA77K/GF99K)

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

MA-336
Ref. No.

Part No.

Description

Remarks

Q207
Q208
Q209

8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR

UN2213
UN2213
UN2213

Q210
Q211

8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR

UN2213 (EXCEPT GA30)

UN2213
(GF80/GF90K/GF99K/PH99)

Q212

8-729-421-19 TRANSISTOR

Q213

8-729-421-19 TRANSISTOR

Q214
Q215
Q216

8-729-010-29 TRANSISTOR
8-729-010-05 TRANSISTOR
8-729-010-29 TRANSISTOR

UN2213
(GF80/GF90K/GF99K/PH99)
UN2213
(GF80/GF90K/GF99K/PH99)
MSD601-RST1
MSB709-RT1
MSD601-RST1

Q217
Q218
Q219
Q220

8-729-010-29
8-729-421-19
8-729-421-19
8-729-421-19

Q221

8-729-421-19 TRANSISTOR

Q222

8-729-421-19 TRANSISTOR

Q223

8-729-421-19 TRANSISTOR

Q224

8-729-421-19 TRANSISTOR

Q225

8-729-421-19 TRANSISTOR

Q226

8-729-421-19 TRANSISTOR

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

Q250
Q251
Q401

8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR
8-729-010-29 TRANSISTOR

Q402

8-729-010-29 TRANSISTOR

Q403

8-729-901-06 TRANSISTOR

Q404

8-729-012-31 TRANSISTOR

Q405
Q406
Q407
Q410

8-729-901-06
8-729-421-19
8-729-010-29
8-729-010-29

Q502

8-729-010-29 TRANSISTOR

Q581

8-729-421-19 TRANSISTOR

Q751
Q752

8-729-421-19 TRANSISTOR
8-729-421-19 TRANSISTOR

Q753

8-729-120-28 TRANSISTOR

Q801
! Q961

8-729-026-49 TRANSISTOR
8-729-012-31 TRANSISTOR

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

Ref. No.

MSD601-RST1
UN2213
UN2213
UN2213
(EXCEPT GA77K:PL/GF99K:PL)
UN2213
(GA66/GA77K/GF99K)
UN2213
(GA66/GA77K/GF99K)
UN2213
(GA77K:PL/GF99K:PL)
UN2213
(EXCEPT GA77K:PL/GF99K:PL)
UN2213
(EXCEPT GA77K:PL/GF99K:PL)
UN2213
(GA66/GA77K/GF99K)
UN2213(GF90K/GF99K)
UN2213(GF90K/GF99K)
MSD601-RST1
(EXCEPT GA30)
MSD601-RST1
(EXCEPT GA30)
DTA144EK (EXCEPT GA30)
2SC4040-TL2-Q
(EXCEPT GA30)
DTA144EK (EXCEPT GA30)
UN2213 (EXCEPT GA30)
MSD601-RST1
MSD601-RST1
(GA70K/GA77K/GF90K/GF99K)
MSD601-RST1
(GA70K/GA77K/GF90K/GF99K)
UN2213
(GA70K/GA77K/GF90K/GF99K)
UN2213(GA66/GA77K)
UN2213
(GA66/GA77K/GF90K/GF99K)
2SC1623-L5L6
(GA66/GA77K)
2SA1037AK-T146-R
2SC4040-TL2-Q
(EXCEPT GA30)

< RESISTOR >

R101
R102
R103
R104
R105

1-216-041-00
1-216-083-00
1-216-065-00
1-216-127-11
1-216-065-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

470
27K
4.7K
1.8M
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

Part No.

Remarks

1-216-295-00 METAL CHIP

R108
R109
R111
R150

1-216-049-00
1-216-069-00
1-216-055-00
1-216-073-00

R200

1-216-065-00 METAL CHIP

R201
R202
R203
R204

1-216-121-91
1-216-262-00
1-216-049-00
1-216-057-00

RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP

R205
R206
R207
R208
R209

1-216-049-00
1-216-081-00
1-216-025-91
1-216-099-00
1-216-055-00

METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP

1K
22K
100
120K
1.8K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R210
R211
R212
R213
R214

1-216-081-00
1-216-049-00
1-216-049-00
1-216-065-00
1-216-049-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

22K
1K
1K
4.7K
1K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R215
R216
R217
R218
R219

1-216-105-91
1-216-073-00
1-216-230-00
1-216-073-00
1-216-059-00

RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP

220K
5%
1/10W
10K
5%
1/10W
22K
5%
1/8W
10K
5%
1/10W
2.7K
5%
1/10W
(GA30/GA50/GF80/P66/PH99)

R219

1-216-069-00 METAL CHIP

6.8K

R219

1-216-077-00 METAL CHIP

15K

R219

1-216-689-11 METAL CHIP

39K

R220
R221

1-216-073-00 METAL CHIP

1-216-222-00 RES,CHIP

10K
10K

5%
1/10W
(GA70K/GF90K)
5%
1/10W
(GA66)
0.5% 1/10W
(GA77K/GF99K)
5%
1/10W
5%
1/8W

R222
R223
R224
R225
R226

1-216-073-00
1-216-073-00
1-249-429-11
1-216-073-00
1-216-089-00

METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP

10K
10K
10K
10K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/4W
1/10W
1/10W

R227
R228
R229
R230
R231

1-216-077-00
1-216-049-00
1-216-295-00
1-216-295-00
1-216-065-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
1K
0
0
4.7K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R232
R233
R234
R235
R236

1-216-073-00
1-216-065-00
1-216-037-00
1-216-065-00
1-216-073-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
4.7K
330
4.7K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R237
R238
R239

1-216-073-00 METAL CHIP

1-216-121-91 RES,CHIP
1-216-073-00 METAL CHIP

R240
R241

1-249-435-11 CARBON
1-216-049-00 METAL CHIP

Note :

7-15

Description

R107

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

0
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
1K
5%
1/10W
6.8K
5%
1/10W
1.8K
5%
1/10W
10K
5%
1/10W
4.7K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
1M
5%
1/10W
470K
5%
1/8W
1K
5%
1/10W
2.2K
5%
1/10W

10K
5%
1/10W
1M
5%
1/10W
10K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
33K
5%
1/4W
1K
5%
1/10W

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

MA-336
Ref. No.

Part No.

Description

R242
R243
R244
R245
R246

1-216-085-00
1-216-057-00
1-216-238-91
1-249-437-11
1-247-807-31

METAL CHIP
METAL CHIP
RES,CHIP
CARBON
CARBON

33K
2.2K
47K
47K
100

Remarks

R247
R248
R249
R250

1-216-033-00
1-247-807-31
1-216-182-00
1-216-073-00

METAL CHIP
CARBON
RES,CHIP
METAL CHIP

220
100
220
10K

R252

5%
5%
5%
5%
5%

Ref. No.

1/10W
1/10W
1/8W
1/4W
1/4W

Part No.

Description

Remarks

R285

1-216-073-00 METAL CHIP

10K

R290
R291
R296

1-216-037-00 METAL CHIP

1-216-037-00 METAL CHIP
1-216-089-00 METAL CHIP

330
330
47K

R297

1-216-073-00 METAL CHIP

10K

1-216-049-00 METAL CHIP

1K

5%
1/10W
5%
1/4W
5%
1/8W
5%
1/10W
(GA66/GA77K/GF99K)
5%
1/10W

R298
R299
R300

1-216-073-00 METAL CHIP

1-216-073-00 METAL CHIP
1-216-081-00 METAL CHIP

R253
R254

1-216-049-00 METAL CHIP

1-216-049-00 METAL CHIP

R301

1-216-065-00 METAL CHIP

R302

1-216-065-00 METAL CHIP

R255

1-216-049-00 METAL CHIP

R256

1-216-053-00 METAL CHIP

R303

1-216-033-00 METAL CHIP

R256

1-216-071-00 METAL CHIP

1K
5%
1/10W
1K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
1K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
1.5K
5%
1/10W
(GA50/P66)
8.2K
5%
1/10W
(GA66/GA70K/GA77K)

10K
5%
1/10W
10K
5%
1/10W
22K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
4.7K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
4.7K
5%
1/10W
(GF80/GF90K/GF99K/PH99)

R304

1-216-055-00 METAL CHIP

R305

1-216-083-00 METAL CHIP

R256

1-216-073-00 METAL CHIP

R306

1-216-073-00 METAL CHIP

R257

1-216-055-00 METAL CHIP

R309

1-216-091-00 METAL CHIP

R257

1-216-069-00 METAL CHIP

R257

1-216-071-00 METAL CHIP

R310

1-216-065-00 METAL CHIP

R258

1-216-073-00 METAL CHIP

R311

1-216-041-00 METAL CHIP

R259
R260
R261
R262
R263

1-216-073-00
1-216-073-00
1-216-073-00
1-216-021-00
1-216-021-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

10K
10K
10K
68
68

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R312

1-216-041-00 METAL CHIP

R313

1-216-041-00 METAL CHIP

R314

1-216-041-00 METAL CHIP

R264
R265
R266
R267
R268

1-216-089-00
1-216-081-00
1-216-037-00
1-216-019-00
1-216-071-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

47K
22K
330
56
8.2K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R315

1-216-689-11 METAL CHIP

R316

1-216-065-00 METAL CHIP

R317

1-216-091-00 METAL CHIP

R269
R270
R271
R272
R273

1-216-057-00
1-216-121-91
1-216-089-00
1-216-089-00
1-216-089-00

METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP

2.2K
1M
47K
47K
47K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R318

1-216-133-00 METAL CHIP

R340

1-216-033-00 METAL CHIP

R274

1-247-863-91 CARBON

R275
R276
R277
R279

1-216-065-00
1-216-057-00
1-216-073-00
1-249-403-11

METAL CHIP
METAL CHIP
METAL CHIP
CARBON

R400
R401
R402
R403
R404

1-216-103-00
1-216-025-91
1-216-073-00
1-216-079-00
1-216-232-00

R405

1-216-077-00 METAL CHIP

R280
R281
R282
R283

1-216-021-00
1-216-073-00
1-216-073-00
1-249-429-11

METAL CHIP
METAL CHIP
METAL CHIP
CARBON

R406

1-216-689-11 METAL CHIP

R407
R408

1-216-065-00 METAL CHIP

1-216-073-00 METAL CHIP

R284

1-216-065-00 METAL CHIP

R409

1-216-125-00 METAL CHIP

10K
5%
1/10W
(GA30/GF80/GF90K/GF99K/PH99)
1.8K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
6.8K
5%
1/10W
(GA50/GA66/GA70K/GA77K)
8.2K
5%
1/10W
(P66)
10K
5%
1/10W

22K
5%
1/4W
(GF80/GF90K/GF99K/PH99)
4.7K
5%
1/10W
2.2K
5%
1/10W
10K
5%
1/10W
68
5%
1/4W F
68
5%
1/10W
10K
5%
1/10W
10K
5%
1/10W
10K
5%
1/4W
(EXCEPT GA77K:PL/GF99K:PL)
4.7K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)

7-16

METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP

5%
1/10W
(GA66/GA77K/GF99K)
5%
1/10W
5%
1/10W
5%
1/10W
(GF90K/GF99K)
5%
1/10W
(GF90K/GF99K)

220
5%
1/10W
(GF80/GF90K/GF99K/PH99)
1.8K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
27K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
10K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
56K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
4.7K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
470
5%
1/10W
(GF80/GF90K/GF99K/PH99)
470
5%
1/10W
(GF80/GF90K/GF99K/PH99)
470
5%
1/10W
(GF80/GF90K/GF99K/PH99)
470
5%
1/10W
(GF80/GF90K/GF99K/PH99)
39K
0.5% 1/10W
(GF80/GF90K/GF99K/PH99)
4.7K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
56K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
3.3M
5%
1/10W
(GF80/GF90K/GF99K/PH99)
220
5%
1/10W
(GF80/GF90K/GF99K/PH99)
180K
100
10K
18K
27K
15K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/8W

5%
1/10W
(EXCEPT GA30)
39K
0.5% 1/10W
(EXCEPT GA30)
4.7K
5%
1/10W
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
1.5M
5%
1/10W

MA-336
Ref. No.

Part No.

Description

R410

1-216-073-00 METAL CHIP

10K

R411

1-216-073-00 METAL CHIP

10K

R412

1-249-432-11 CARBON

18K

R413

1-216-083-00 METAL CHIP

27K

R414

1-249-393-11 CARBON

10

R415
R416
R417
R418
R420

1-216-049-00
1-216-049-00
1-216-041-00
1-216-073-00
1-216-061-00

1K
1K
470
10K
3.3K

R420

1-216-065-00 METAL CHIP

R421

1-216-065-00 METAL CHIP

R422

1-216-295-00 METAL CHIP

R508

1-216-073-00 METAL CHIP

R509

1-216-089-00 METAL CHIP

R510

1-216-089-00 METAL CHIP

R511

1-216-079-00 METAL CHIP

R512

1-216-689-11 METAL CHIP

R513

1-216-689-11 METAL CHIP

R514

1-216-089-00 METAL CHIP

R515

1-216-081-00 METAL CHIP

R516

1-216-081-00 METAL CHIP

R517

1-216-129-00 METAL CHIP

R518

1-216-073-00 METAL CHIP

R519

1-216-077-00 METAL CHIP

R523

1-216-081-00 METAL CHIP

R553

1-216-077-00 METAL CHIP

R553

1-216-689-11 METAL CHIP

R555

1-216-077-00 METAL CHIP

R556

1-216-077-00 METAL CHIP

R556

1-216-689-11 METAL CHIP

R557

1-216-077-00 METAL CHIP

R558

1-216-073-00 METAL CHIP

R559

1-216-049-00 METAL CHIP

R560

1-216-037-00 METAL CHIP

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

Remarks

Ref. No.

5%
1/10W
(EXCEPT GA30)
5%
1/10W
(EXCEPT GA30)
5%
1/4W
(EXCEPT GA30)
5%
1/10W
(EXCEPT GA30)
5%
1/4W F
(EXCEPT GA30)

R561

1-216-037-00 METAL CHIP

R562

1-216-097-91 RES,CHIP

R563

1-216-097-91 RES,CHIP

R565

1-216-081-00 METAL CHIP

R570

1-216-073-00 METAL CHIP

5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(GA77K:PL/GF99K:PL)

R581

1-216-097-91 RES,CHIP

R582

1-216-049-00 METAL CHIP

R583

1-216-089-00 METAL CHIP

R584

1-216-089-00 METAL CHIP

R585

1-216-089-00 METAL CHIP

R586

1-216-073-00 METAL CHIP

R751

1-216-097-91 RES,CHIP

R752

1-216-097-91 RES,CHIP

R753

1-216-073-00 METAL CHIP

R754

1-216-073-00 METAL CHIP

R755

1-216-097-91 RES,CHIP

100K

R756

1-216-097-91 RES,CHIP

100K

R757

1-216-089-00 METAL CHIP

47K

R758

1-216-089-00 METAL CHIP

47K

R759

1-216-073-00 METAL CHIP

10K

R760

1-216-097-91 RES,CHIP

R761

1-216-097-91 RES,CHIP

R762

1-216-097-91 RES,CHIP

R763

1-216-097-91 RES,CHIP

R764

1-216-097-91 RES,CHIP

100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)

R765

1-216-097-91 RES,CHIP

R766

1-216-097-91 RES,CHIP

R767

1-216-097-91 RES,CHIP

R768

1-216-097-91 RES,CHIP

R769

1-216-097-91 RES,CHIP

4.7K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
4.7K
5%
1/10W
(EXCEPT GA30)
0
5%
1/10W
(EXCEPT GA30)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
18K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
39K
0.5% 1/10W
(GA70K/GA77K/GF90K/GF99K)
39K
0.5% 1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
2.2M
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
15K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
15K
5%
1/10W
(GA70K/GA77K/GF99K)
39K
0.5% 1/10W
(GF90K)
15K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
15K
5%
1/10W
(GA70K/GA77K/GF99K)
39K

1/10W
(GF90K)
15K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
1K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
330
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)

Part No.

Description

0.5%

7-17

Remarks
330
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
22K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
1K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
47K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
10K
5%
1/10W
(GA70K/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K)
100K
5%
1/10W
(GA66/GA77K)
10K
5%
1/10W
(GA66/GA77K)
10K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
5%
1/10W
(GA66/GA77K)
5%
1/10W
(GA66/GA77K)
5%
1/10W
(GA66/GA77K)
5%
1/10W
(GA66/GA77K)
5%
1/10W
(GA66/GA77K)

100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)
100K
5%
1/10W
(GA66/GA77K/GF90K/GF99K)

MA-336
Ref. No.

MJ-91

Part No.

Description

R770

1-216-097-91 RES,CHIP

R771

1-216-097-91 RES,CHIP

R800

1-216-021-00 METAL CHIP

R801
R802

1-249-412-11 CARBON
1-216-190-00 RES,CHIP

R803

1-216-051-00 METAL CHIP

R803

1-216-057-00 METAL CHIP

R804
R805
R806

1-249-403-11 CARBON
1-216-190-00 RES,CHIP
1-216-023-00 METAL CHIP

R807
R808

1-216-049-00 METAL CHIP

1-216-021-00 METAL CHIP

R808

1-216-069-00 METAL CHIP

R808

1-216-071-00 METAL CHIP

R809

1-216-097-91 RES,CHIP

R810

1-216-097-91 RES,CHIP

! R952
R961

Remarks
5%
1/10W
(GF90K/GF99K)
100K
5%
1/10W
(GF90K/GF99K)
68
5%
1/10W
(GA66/GA77K/GF99K)
390
5%
1/4W F
470
5%
1/8W
(EXCEPT GA30)

Ref. No.

Part No.

Description

100K

Z951
1-801-267-31 VARISTOR TNR10V431K660
************************************************************
*

A-6794-584-A MJ-91BOARD, COMPLETE

*********************
(GA70K:PS/GA77K:PS,PL/GF90K:PS/GF99K:ME,PS,PL)

A-6794-605-A MJ-91BOARD, COMPLETE

**********************
(GA70K:TK/GA77K:TK/GF90K:TK/GF99K:TK)

1.2K
5%
1/10W
(EXCEPT GA77K:PL/GF99K:PL)
2.2K
5%
1/10W
(GA77K:PL/GF99K:PL)
68
5%
1/4W F
470
5%
1/8W
82
5%
1/10W
(EXCEPT GA30)

1-214-947-00 METAL
1-247-807-31 CARBON

Remarks

< VARISTOR >

(Ref.No.:2,000 Series)
< CAPACITOR >

1K
5%
1/10W
68
5%
1/10W
(GF80/GF90K/GF99K/PH99)
6.8K
5%
1/10W
(GA50/GA66/GA70K/GA77K)
8.2K
5%
1/10W
(P66)
100K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
100K
5%
1/10W
(GF80/GF90K/GF99K/PH99)
2.7M
1%
1/2W
100
5%
1/4W
(EXCEPT GA30)

C501
C502
C503
C504
C507

1-124-234-00
1-164-159-21
1-164-159-21
1-163-259-91
1-164-159-21

ELECT
CERAMIC
CERAMIC
CERAMIC CHIP
CERAMIC

22uF
0.1uF
0.1uF
220PF
0.1uF

C508
C510
C511
C545
C546

1-163-259-91
1-164-159-21
1-164-159-21
1-163-121-00
1-163-121-00

CERAMIC CHIP
CERAMIC
CERAMIC
CERAMIC CHIP
CERAMIC CHIP

220PF
0.1uF
0.1uF
150PF
150PF

C550

1-163-038-00 CERAMIC CHIP

20%

5%

5%

5%
5%

0.1uF

16V
50V
50V
50V
50V
50V
50V
50V
50V
50V
25V

< CONNECTOR >

CN501
CN502

1-506-469-11 PIN, CONNECTOR 4P

1-564-002-11 PIN, CONNECTOR 3P

< MODULATOR >

< DIODE >
RFU801 1-473-226-11 MODULATOR, RF (RFU-2043)
(EXCEPT GA77K:PL/GF99K:PL)
RFU801 1-473-240-11 MODULATOR, RF (RFU-1048)
(GA77K:PL/GF99K:PL)

D504

RV202

1SS355

< IC >

< VARIABLE RESISTOR >

RV201

8-719-988-62 DIODE

IC501

1-223-239-11 RES, ADJ, CARBON 10K(AF SWP)

(GF80/GF90K/GF99K/PH99)
1-223-239-11 RES, ADJ, CARBON 10K(V SWP)

8-759-344-04 IC

BA7760F-E2

< JACK >

MCJ501 1-750-781-11 JACK, LARGE TYPE (MIC IN 1)
MCJ502 1-750-781-11 JACK, LARGE TYPE (MIC IN 2)

< SWITCH >

< RESISTOR >
S201
S202
S203
S204
S801

1-771-155-11
1-762-108-11
1-771-574-21
1-771-574-21
1-571-588-21

SWITCH, ROTARY(MECHANISM MODE)

SWITCH, PUSH (1 KEY)(REC PROOF)
SWITCH, TACTILE (REC) (EXCEPT GA30)
SWITCH, TACTILE (PAUSE)
SWITCH, SLIDE (TV SYSTEM) (EXCEPT GA30)

R501
R502
R503
R504
R505

1-216-081-00
1-216-073-00
1-216-097-91
1-216-097-91
1-216-073-00

METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP

22K
10K
100K
100K
10K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

< TRANSFORMER >

T401
T401
! T951

1-431-554-11 TRANSFORMER, BIAS OSCILLATION

(EXCEPT GA30)
1-433-494-11 BIAS OSCILLATION TRANSFORMER
(EXCEPT GA30)
1-468-248-12 POWER BLOCK

R506
1-216-081-00 METAL CHIP
22K
5%
1/10W
R507
1-216-089-00 METAL CHIP
47K
5%
1/10W
R550
1-216-689-11 METAL CHIP
39K
0.5% 1/10W
************************************************************

< VIBRATOR >

X101
* X102
X201
X501

1-760-708-11 VIBRATOR, CRYSTAL 4.433619MHz

(EXCEPT GA77K:PL/GF99K:PL)
1-760-709-11 VIBRATOR, CRYSTAL 3.579545MHz
(EXCEPT GA30)
1-767-855-11 VIBRATOR, CRYSTAL 10MHz
1-567-178-00 OSCILLATOR, CERAMIC 455kHz
(GA40K/GA70K/GA77K/GF90K/GF99K)

7-18

Note :

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

SR-35
Ref. No.

Part No.

A-6794-586-A SR-35BOARD, COMPLETE

**********************
(GA77K:PS,PL/GF99K:PS)

Description

Remarks

Ref. No.

Part No.

JR701
JR703

1-216-296-00 METAL CHIP

1-216-296-00 METAL CHIP

0
0

5%
5%

1/8W
1/8W

1/10W
(GA66)
1/10W
(GA66)

< JUMPER RESISTOR >

A-6794-607-A SR-35BOARD, COMPLETE

**********************
(GA77K:TK/GF99K:TK)

Remarks

< JUMPER RESISTOR >

A-6794-600-A SR-35BOARD, COMPLETE (GA66)

**********************

Description

JS701

1-216-295-00 METAL CHIP

5%

JS702

1-216-295-00 METAL CHIP

5%

(Ref.No.:2,000 Series)
< COIL >
< CAPACITOR >
L701
C701

1-126-157-11 ELECT

10uF

C702

1-126-157-11 ELECT

10uF

C703

1-124-234-00 ELECT

22uF

C704

1-164-489-11 CERAMIC CHIP

0.22uF

C705

1-163-809-11 CERAMIC CHIP

0.047uF

20%
16V
(GA77K/GF99K)
20%
16V
(GA77K/GF99K)
20%
16V
(GA77K/GF99K)
10%
16V
(GA77K/GF99K)
10%
25V
(GA77K/GF99K)

C706

1-126-157-11 ELECT

10uF

C707

1-126-157-11 ELECT

10uF

C708
C709
C710

1-126-157-11 ELECT
1-126-157-11 ELECT
1-163-038-00 CERAMIC CHIP

10uF
10uF
0.1uF

20%
16V
(GA77K/GF99K)
20%
16V
(GA77K/GF99K)
20%
16V
20%
16V
25V

C711
C712
C713
C714
C715

1-163-038-00
1-163-037-11
1-163-037-11
1-126-157-11
1-126-157-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

0.1uF
0.022uF
0.022uF
10uF
10uF

10%
10%
20%
20%

C716
C717
C718
C719
C720

1-126-157-11
1-164-161-11
1-164-232-11
1-163-038-00
1-126-157-11

ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT

10uF
20%
0.0022uF 10%
0.01uF
0.1uF
10uF
20%

16V
100V
50V
25V
16V

C721
C722
C723
C724
C725

1-126-157-11
1-126-157-11
1-126-157-11
1-126-157-11
1-164-232-11

ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP

10uF
10uF
10uF
10uF
0.01uF

16V
16V
16V
16V
50V

C726
C727
C728
C729
C730

1-164-232-11
1-164-232-11
1-164-232-11
1-126-157-11
1-126-157-11

CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT

0.01uF
0.01uF
0.01uF
10uF
10uF

20%
20%

50V
50V
50V
16V
16V

C731
C732
C733
C734

1-126-157-11
1-126-157-11
1-126-157-11
1-126-157-11

ELECT
ELECT
ELECT
ELECT

10uF
10uF
10uF
10uF

20%
20%
20%
20%

16V
16V
16V
16V

20%
20%
20%
20%

25V
25V
25V
16V
16V

< CONNECTOR >

CN701

1-573-824-11 CONNECTOR, BOARD TO BOARD 10P

< IC >

IC701
IC702
IC703

8-759-484-63 IC
8-752-068-78 IC
8-759-480-28 IC

BA3838F-E2 (GA77K/GF99K)
CXA1842S
MM1354BD

7-19

1-410-516-11 INDUCTOR

39uH

< TRANSISTOR >

Q701
Q702
Q703
Q704
Q705

8-729-424-67
8-729-424-67
8-729-900-51
8-729-424-67
8-729-424-67

TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR

UN2216
UN2216
DTA114TK
UN2216
UN2216

< RESISTOR >

R701

1-216-089-00 METAL CHIP

47K

5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA77K/GF99K)

R702

1-216-089-00 METAL CHIP

47K

R703

1-216-089-00 METAL CHIP

47K

R704

1-216-081-00 METAL CHIP

22K

R705

1-216-063-91 RES,CHIP

3.9K

R706

1-216-081-00 METAL CHIP

22K

R707

1-216-063-91 RES,CHIP

3.9K

R708
R709

1-216-089-00 METAL CHIP

1-216-049-00 METAL CHIP

47K
1K

R709

1-216-061-00 METAL CHIP

3.3K

R710

1-216-057-00 METAL CHIP

2.2K

R710

1-216-069-00 METAL CHIP

6.8K

R711

1-216-049-00 METAL CHIP

1K

R711

1-216-061-00 METAL CHIP

3.3K

R712

1-216-069-00 METAL CHIP

6.8K

1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%
1/10W

R713
R714
R715
R716
R717

1-216-077-00
1-216-069-00
1-216-075-00
1-216-069-00
1-216-069-00

METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP

15K
6.8K
12K
6.8K
6.8K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

R718
R719
R720
R721
R722

1-216-049-00
1-216-075-00
1-216-078-00
1-216-069-00
1-216-077-00

METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP

1K
12K
16K
6.8K
15K

5%
5%
5%
5%
5%

1/10W
1/10W
1/10W
1/10W
1/10W

5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
5%
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%

SR-35
Ref. No.

Part No.

Description

R723
R724
R725
R726
R727

1-216-081-00
1-216-073-00
1-216-075-00
1-216-097-91
1-216-097-91

METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP

R728
R729
R730

Remarks
22K
10K
12K
100K
100K

5%
5%
5%
5%
5%

1-216-037-00 METAL CHIP

1-216-037-00 METAL CHIP
1-216-049-00 METAL CHIP

330
330
1K

5%
5%
5%

R730

1-216-061-00 METAL CHIP

3.3K

R731

1-216-057-00 METAL CHIP

2.2K

R731

1-216-069-00 METAL CHIP

6.8K

R732

1-216-049-00 METAL CHIP

1K

R732

1-216-061-00 METAL CHIP

3.3K

R733

1-216-057-00 METAL CHIP

2.2K

R733

1-216-069-00 METAL CHIP

6.8K

R735
R736
R737

1-216-073-00 METAL CHIP

1-216-075-00 METAL CHIP
1-216-097-91 RES,CHIP

10K
12K
100K

R737

1-216-105-91 RES,CHIP

220K

R738

1-216-097-91 RES,CHIP

100K

R738

1-216-105-91 RES,CHIP

220K

Ref. No.

1/10W
1/10W
1/10W
1/10W
1/10W

3-052-159-02 INDIVIDUAL CARTON(GF80:EE)

3-864-834-11 MANUAL, INSTRUCTION(ENGLISH)
(GF90K/GF99K: ME ,PS)
3-864-834-21 MANUAL, INSTRUCTION(ARABIC)(GF99K: ME)
3-864-835-11 MANUAL, INSTRUCTION(ENGLISH)(GF80: PS)
3-864-836-11 MANUAL, INSTRUCTION(ENGLISH)
(GA66/GA70K:PS/GA77K: PS)

3-864-836-21 MANUAL, INSTRUCTION(ARABIC)(GA66)

3-864-837-11 MANUAL, INSTRUCTION(ENGLISH)
(GA30: ME, PS, SG/GA50: ME, PS, SG)
3-864-837-21 MANUAL, INSTRUCTION(ARABIC)
(GA30: ME, SG/GA50: ME, SG)
3-864-837-31 MANUAL, INSTRUCTION(PERSIAN)
(GA30: ME, SG/GA50: ME, SG)
3-864-837-41 MANUAL, INSTRUCTION(URDU)
(GA30: ME, SG/GA50: ME, SG)

5%
5%
5%

1/10W
1/10W
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA66)

3-864-837-51 MANUAL, INSTRUCTION(RUSSIAN)

(GA30: PS,SG/GA50: PS,SG)
3-864-838-11 MANUAL, INSTRUCTION(ENGLISH)(GA77K: PL)
3-864-918-11 MANUAL, INSTRUCTION(ENGLISH)(PH99)
3-864-918-21 MANUAL, INSTRUCTION(RUSSIAN)(PH99)
3-864-919-11 MANUAL, INSTRUCTION(ENGLISH)(P66)

5%
1/10W
(GA77K/GF99K)
R739
1-216-097-91 RES,CHIP
100K
5%
1/10W
(GA66)
R739
1-216-105-91 RES,CHIP
220K
5%
1/10W
(GA77K/GF99K)
R740
1-216-057-00 METAL CHIP
2.2K
5%
1/10W
(GA66)
R740
1-216-105-91 RES,CHIP
220K
5%
1/10W
(GA77K/GF99K)
************************************************************

1-777-851-41
1-790-118-11

22
23
56

1-790-119-11
1-790-120-11
1-790-117-11

704
721
776

1-500-144-11 HEAD, FE
A-6759-620-A HEAD BLOCK ASSY, ACE (TDK)
1-759-183-11 DRUM ASSY, DZH-78A-R
(GA30:PS,TK/GA50:PS,TK/GA70K:PS,TK/GA77K:PS,TK/P66)
1-759-449-11 DRUM ASSY, DZH-91A-R
(GF80:PS,TK/GF90K:PS,TK/GF99K:ME,PS,TK/PH99)
1-759-451-11 DRUM ASSY, DZH-90A-R(GF99K:PL)

776
776

Remarks

1-542-273-11 MICROPHONE (F-VJ5301)

(GA70K,GA77K,GF90K,GF99K)
1-569-008-21 ADAPTOR, CONVERSION 2P
(GA30:ME/GA66/GF99K)
1-575-334-11 CORD,CONNECTION (FOR AUDIO/VIDEO)
(GA66/GA77K/GF80/GF90/GF99K)
1-696-592-11 CORD,CONNECTION (NTSC)(FOR RF)
(GA77K:PL/GF99K:PL)
1-696-593-11 CORD,CONNECTION (PAL)(FOR RF)
(EXCEPT GA77K:PL/GF99K:PL)

5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)

! 12
21

Description

ACCESSORIES & PACKING MATERIALS

********************************

1/10W
1/10W
1/10W
(GA66)
5%
1/10W
(GA77K/GF99K)
5%
1/10W
(GA66)

MISCELLANEOUS
*************
CORD, POWER
CABLE, FLAT (FJK-1)
(GA66/GA70K/GA77K/GF80/GF90K/GF99K/PH99)
CABLE, FLAT (FFR-6)
CABLE, FLAT (FFR-7)
CABLE, FLAT (FDM-5)

Part No.

3-864-919-21 MANUAL, INSTRUCTION(RUSSIAN) (P66)

3-864-921-11 MANUAL, INSTRUCTION(ENGLISH)
(GF99K: PL)
3-865-418-11 MANUAL, INSTRUCTION(ENGLISH)
(GA70K: TK/GA77K: TK)
3-865-419-11 MANUAL, INSTRUCTION(ENGLISH)
(GF90K: TK/GF99K: TK)
3-865-506-11 MANUAL, INSTRUCTION(ENGLISH)
(GA30: TK/GA50: TK)
3-865-508-11 MANUAL, INSTRUCTION(ENGLISH)
(GF80: TK)
*
3-961-581-01 SHEET, PROTECTION
************************************************************
**************
HARDWARE LIST
**************
#1
#701
#702
#703

7-685-648-79
7-685-646-79
7-682-147-01
7-685-133-19

SCREW +BVTP 3X12 TYPE2 IT-3

SCREW +BVTP 3X8 TYPE2 IT-3
SCREW +P 3X6
SCREW (DIA. 2.6) (IT3B)

776

1-759-453-11 DRUM ASSY, DZH-89A-R

(GA30:SG,ME/GA50:SG,ME/GA66:ME)
776
1-759-455-11 DRUM ASSY, DZH-71D-R(GA77K:PL)
M902
1-698-971-11 MOTOR, DC(CAPSTAN)
M903
X-3947-577-1 MOTOR ASSY, CAM
************************************************************
Note :

7-20E

The components identified by mark ! or dotted

line with mark ! are critical for safety.
Replace only with part number specified.

SLV-GA30/GA50/GA66/GA70K/GA77K/GF80/GF90K/GF99K/P66/PH99

Sony Corporation
9-921-699-11

Home A&V Products Company

90

98J1615-1D
Printed in Japan 1998.10
Published by Quality Assurance Dept.
(Osaki East)