Material Safety Data Sheet
Revision Number: 003.3
Issue date: 09/14/2010
1. PRODUCT AND COMPANY IDENTIFICATION
Product name:
Product type:
Solvo-Rust Super Penetrating Oil
Lubricant
Company address:
Henkel Corporation
One Henkel Way
Rocky Hill, Connecticut 06067
IDH number:
235303
Item number:
81252
Region:
United States
Contact information:
Telephone: 860.571.5100
MEDICAL EMERGENCY Phone: Poison Control Center
1-877-671-4608 (toll free) or 1-303-592-1711
TRANSPORT EMERGENCY Phone: CHEMTREC
1-800-424-9300 (toll free) or 1-703-527-3887
Internet: www.henkelna.com
2. HAZARDS IDENTIFICATION
Physical state:
Color:
Odor:
EMERGENCY OVERVIEW
HMIS:
HEALTH:
Aerosol
FLAMMABILITY:
to, Pale yellow, Off white
PHYSICAL HAZARD:
Solvent
Personal Protection:
DANGER:
2
4
1
See MSDS Section 8
CONTENTS UNDER PRESSURE.
HARMFUL IF INHALED.
EXTREMELY FLAMMABLE.
MAY CAUSE EYE, SKIN AND RESPIRATORY TRACT IRRITATION.
Relevant routes of exposure:
Skin, Inhalation, Eyes
Potential Health Effects
Inhalation:
Central nervous system depression, including dizziness, drowsiness, fatigue, nausea,
headache, unconsciousness. Extreme overexposure may result in unconsciousness and
possibly death. May cause irritation to nose and throat.
May cause irritation due to defatting of the skin.
Direct spray or vapors will irritate and may harm eyes.
Not expected under normal conditions of use.
Skin contact:
Eye contact:
Ingestion:
Existing conditions aggravated by
exposure:
Eye, skin, and respiratory disorders.
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR
1910.1200).
See Section 11 for additional toxicological information.
3. COMPOSITION / INFORMATION ON INGREDIENTS
Hazardous components
CAS NUMBER
Distillates (petroleum), hydrotreated heavy naphthenic
Hydrocarbon aliphatic aromatic naphthenic C9-12
Butane
Propane
Kerosine (petroleum)
64742-52-5
64742-88-7
106-97-8
74-98-6
8008-20-6
30 - 60
10 - 30
10 - 30
10 - 30
10 - 30
IDH number: 235303
Product name: Solvo-Rust Super Penetrating Oil
Page 1 of 5
4. FIRST AID MEASURES
Inhalation:
Move to fresh air. If symptoms persist, seek medical advice.
Skin contact:
Remove contaminated clothing and footwear. If symptoms develop and
persist, get medical attention. Wash with soap and water.
Eye contact:
Immediately flush eyes with plenty of water for at least 15 minutes. Get
medical attention.
Ingestion:
Do not induce vomiting. Get medical attention.
5. FIRE FIGHTING MEASURES
Flash point:
< -18 C (< 0.4 F)
Flashback:
This product exhibits flashback when tested for flame extension.
Flame projection:
96 cm (37.8 inch)
Autoignition temperature:
Not available
Flammable/Explosive limits - lower:
0.7 %
Flammable/Explosive limits - upper:
9.5 %
Extinguishing media:
Carbon dioxide. Foam. Dry chemical.
Special firefighting procedures:
In case of fire, keep containers cool with water spray.
Unusual fire or explosion hazards:
Contents under pressure. Do not handle or store near an open flame, heat or
other sources of ignition. Do not puncture or incinerate pressurized
containers. Exposure to temperatures above 49C (120F) may cause
container to burst.
Hazardous combustion products:
Oxides of carbon. Irritating organic vapours. Oxides of sulfur.
6. ACCIDENTAL RELEASE MEASURES
Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected
personnel.
Environmental precautions:
Ventilate area. Remove all sources of ignition.
Clean-up methods:
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder,
universal binder, sawdust). Store in a partly filled, closed container until
disposal.
7. HANDLING AND STORAGE
Handling:
Keep away from heat, spark and flame. Prevent contact with eyes, skin and
clothing. Do not breathe vapor and mist. Wash thoroughly after handling.
Vapors will accumulate readily and may ignite explosively.
Storage:
Heat from sunlight, radiators, stoves, hot water, and other heat sources could
cause container to burst. Do not puncture, incinerate, or expose to
temperatures above 48.9 C (120 F). Store away from ignition sources. Keep
in a cool, well ventilated area.
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
IDH number: 235303
Product name: Solvo-Rust Super Penetrating Oil
Page 2 of 5
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.
Hazardous components
Distillates (petroleum), hydrotreated heavy
naphthenic
Hydrocarbon aliphatic aromatic naphthenic C9-12
Butane
ACGIH TLV
OSHA PEL
AIHA WEEL
OTHER
5 mg/m3 TWA mist
10 mg/m3 STEL
mist
Included in the
regulation but with
no data values.
See regulation for
further details
Exposure by all
routes should be
carefully controlled
to levels as low as
possible.
5 mg/m3 TWA mist
500 ppm (2,000
mg/m3) TWA
5 mg/m3 TWA
Mist.
None
None
100 ppm TWA
1,000 ppm TWA
Propane
1,000 ppm TWA
500 ppm (2,900
mg/m3) TWA
None
1,000 ppm (1,800
mg/m3) TWA
None
None
None
None
None
None
None
None
None
200 mg/m3 TWA
(as total
hydrocarbon vapor)
Non-aerosol.
(SKIN) (as total
hydrocarbon vapor)
Non-aerosol.
Kerosine (petroleum)
Engineering controls:
Use local ventilation if general ventilation is insufficient to maintain vapor
concentration below established exposure limits.
Respiratory protection:
Use NIOSH approved respirator if there is potential to exceed exposure
limit(s). When workplace hazards warrant the use of a respirator, appropriate
respirators must be used, and a program that follows 29 CFR 1910.134 must
be followed.
Eye/face protection:
Safety goggles or safety glasses with side shields.
Skin protection:
Chemical resistant, impermeable gloves.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state:
Color:
Odor:
Odor threshold:
pH:
Vapor pressure:
Boiling point/range:
Melting point/ range:
Specific gravity:
Vapor density:
Flash point:
Flashback:
Flame projection:
Flammable/Explosive limits - lower:
Flammable/Explosive limits - upper:
Autoignition temperature:
Evaporation rate:
Solubility in water:
Partition coefficient (n-octanol/water):
Aerosol
to, Pale yellow, Off white
Solvent
Not available
Not applicable
Not available
0 - 572 F (-17.8 - 300C) none
Not available
0.76
Heavier than air.
< -18 C (< 0.4 F)
This product exhibits flashback when tested for flame extension.
96 cm (37.8 inch)
0.7 %
9.5 %
Not available
Faster than ether.
Not available
Not available
IDH number: 235303
Product name: Solvo-Rust Super Penetrating Oil
Page 3 of 5
VOC content:
49.9 %
10. STABILITY AND REACTIVITY
Stability:
Stable
Hazardous reactions:
Will not occur.
Hazardous decomposition products:
Oxides of carbon. Oxides of sulfur.
Incompatible materials:
Strong oxidizing agents.
Conditions to avoid:
Do not puncture, incinerate, or expose to temperatures above 48.9 C (120
F).
11. TOXICOLOGICAL INFORMATION
Hazardous components
Distillates (petroleum), hydrotreated
heavy naphthenic
Hydrocarbon aliphatic aromatic
naphthenic C9-12
Butane
Propane
Kerosine (petroleum)
OSHA Carcinogen
NTP Carcinogen
IARC Carcinogen
Known carcinogen.
Group 1
No
No
No
No
No
No
No
No
No
No
No
No
No
Hazardous components
(Specifically Regulated)
Health Effects/Target Organs
Distillates (petroleum), hydrotreated heavy naphthenic
Hydrocarbon aliphatic aromatic naphthenic C9-12
Butane
Propane
Kerosine (petroleum)
Irritant
Central nervous system, Irritant
Cardiac, Central nervous system, Irritant
Cardiac, Central nervous system, Irritant
Blood, Bone Marrow, Central nervous system, Irritant, Kidney, Liver, Lung,
Spleen
12. ECOLOGICAL INFORMATION
Ecological information:
Not available
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal:
Do not incinerate. Depressurize cans. Follow all local, state, federal and
provincial regulations for disposal.
Hazardous waste number:
Waste from this product may be hazardous as defined under the Resource
Conservation and Recovery Act (RCRA) 40 CFR 261. Waste must be tested
for ignitability to determine the applicable EPA hazardous waste numbers.
14. TRANSPORT INFORMATION
U.S. Department of Transportation Ground (49 CFR)
Proper shipping name:
Aerosols
Hazard class or division:
2.1
Identification number:
UN 1950
Packing group:
None
Exceptions:
ORM-D, (Not more than 1 L), Consumer Commodity
IDH number: 235303
Product name: Solvo-Rust Super Penetrating Oil
Page 4 of 5
International Air Transportation (ICAO/IATA)
Proper shipping name:
Hazard class or division:
Identification number:
Packing group:
Exceptions:
Aerosols, flammable
2.1
UN 1950
None
(Not more than 500 ml), ID8000
Water Transportation (IMO/IMDG)
Proper shipping name:
Hazard class or division:
Identification number:
Packing group:
Exceptions:
AEROSOLS
2.1
UN 1950
None
Limited quantity (Not more than 1 L).
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status:
TSCA 12(b) Export Notification:
All components are listed or are exempt from listing on the Toxic Substances Control Act
Inventory.
None above reporting de minimus
CERCLA/SARA Section 302 EHS:
CERCLA/SARA Section 311/312:
CERCLA/SARA 313:
None above reporting de minimus
Immediate Health, Delayed Health, Fire
None above reporting de minimus
California Proposition 65:
No California Proposition 65 listed chemicals are known to be present.
Canada Regulatory Information
CEPA DSL/NDSL Status:
WHMIS hazard class:
All components are listed on or are exempt from listing on the Canadian Domestic
Substances List.
A, B.5, D.2.B
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: Not available
Prepared by: C.J. Michaels, Manager, Regulatory Affairs
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However,
Henkel Corporation does not assume responsibility for any results obtained by persons over whose methods Henkel
Corporation has no control. It is the user's responsibility to determine the suitability of Henkel's products or any
production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the
protection of property and persons against any hazards that may be involved in the handling and use of any of Henkel
Corporation's products. In light of the foregoing, Henkel Corporation specifically disclaims all warranties, express or
implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel
Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of any
kind, including lost profits.
IDH number: 235303
Product name: Solvo-Rust Super Penetrating Oil
Page 5 of 5
