.
- - - --
- - - - - - --
- -
-- ---------- --
---- -- - - - - - - - - - -
- -
PROVA COUNTACH
., :
..-:
.....
-,
:
. ,.
, ....
,
-----_.
OWN ERS l1ANDBOOK
PROVA
COUNTACH
\
REPLICA
OWNER'S
HANDBOOK
OWNER HANDBOOK AND SERVICE RECORD
INDEX AND SPECIFICATIONS
CONTROLS AND INSTRUMENTS
AND RELAYS
PAGE 2
PAGE 3
LUBRICATION POINTS
PAGE 4
RECOMMENDED LUBRICANTS ETC
PAGE 5
SERVICE SCH EDU
PAGE 6
RECORD
PAGE 7
PAGE 9
CIRCUIT DIAGRAM
SPJ;CIFICATIONS
LENGTH
163"
WIDTH
78"
42"
HT
GROUND CLEARAN
WHE
5"
96"
BASE
FRONT TRACK
58"
REAR TRACK
63"
KERB W
FU
CAPACITY
FRONT WH
2000 LBS /900 KILO
13 GAL'S / 61 lITRES
15x8 ALLOY WHEELS
205/50 VR15 TYRES
15x12 ALLOY WHEELS
COCKPIT CONTROLS
INDICATOR
HEADLIGHTS
HORN _ __
SIDELIGHTS
OFF
DIP BEAM
WIPER SPEED 2
WIPER SPEED 1
....... WASHER
OFF
WIPER DELAY
LH INDICATOR
IGNITION/STARTER
FRONT
SPOTS
RADIATOR FAN
OVER RIDE
REAR
FOGS
HEATER CONTROLS
HAZARD
WARNING.
HEATER FAN SWITCH
eIG LIGHTER
VOLTMETER. OIL TEMP. SPEEDO.OIL PRESSURE. RPM. WATER TEMP. FUEL
./
{
ALTERNATOR.LH IND.MAIN -- BEAM.
OIL"PRESSURE.RH IND.BRA.KB.
FUSES AND RELAYS
LOCATED UNDER THE DASH PANEL ON THE DRIVERS srDE OF THE CAR
-----------------------------------------------------~ -----
FUSE COLOURS AND RATINGS.
YELLOW=20 amp
RED
=10 amp
BLUE =14 amp
BROWN = 5 amp
RELAYS 2 WAY = I
RELAYS 1 WAY :::
SPARE
RELAY
RONIC
FLASHER UNIT
DIM/DIP RELAY
1 WAY
HAZARD RELAY
1 WAY
F 14/10 amp SIDE LIGHTS
----------------
F 13/10 amp SIDE LIGHTS
FUSES 10-15-20 amp
F 12/10 amp IND/HAZARD
HORN RELAY
1 WAY
MAIN BEAM RELAY
1 WAY
F 11/5
amp INT. LIGHT
FlO/IS amp MAIN BEAM
HEAD LIGHT LIFT
2 WAY
HEAD LIGHT LIFT
2 WAY
DIP BEAM Rf':LAY
1 WAY
FOG FLASH RELAY
2 WAY
RADIATOR FAN RELAY HEADLIGHT Up/DOWN
1 WAY
2 WAY
9/15 amp MAIN BEAM
8/10 amp DIP BEAM
7/10 amp DIP BEAM
6/10 amp BRAKE/REV
5/10 amp WIPER/WASHER
4/15 amp SPOT LIGHTS
3/10 ampHEATER/CIGAR
2/15 amp HORN
1120 RAD FANS
LUBRICATION AND FLUID POINTS
Ii
SCREEN WASHER
'"
BRAKE !CLUTCH FLUID
GREASE
ECATCH~
GREASE HINGES
GREASE DOOR LOCKS
RADIATOR
HEADER tANK
0
ENGINE OIL
FILLER
GREASE GEAR
LINKAGE
GEARBOX FILLER
MANUAL
FILLER AUTO
BATTERY
LUBRICATE
RECOMMENDED LUBRICANTS AND
ENGINE
ROVER VB
MULTIGRADE ZOW/50
5 .. 7 LITRES
UNIVERSAL ANTIFREEZE
4.0 LITRES
MULTIGRADE ZOW/50
5.7 LITRES
UNIVERSAL ANTIF,REEZE
3 .. 0,LITRES
MANUAL 5 SPEED
EP 80
3 .. 4 LITRES
AUTOMATIC
ELF DZ/DEXRON
3 .. 0 LITRES
AUTO DIPF.
EP 80
RENAULT VB
GEARBOX
REFILL
BEARINGS
LM GREASE
FRONT WHEEL
AND HI
GENERAL GREASE
COOLING SYSTEM
UNIVERSAL
/SUMMER ANTI
FUEL REQUIREMENTS
97 RON (4 STAR ****)
*LEADED FUEL UNLESS SPECIFIED*
1.6 LITRES
RECOMMENDED SERVICE DATA. (MAINTENANCE SCHEDULE)
----------------------------~-------------------
1st SERVICE (500 MILES) MUST BE CARRI
OUT BY POWERPLUS OR
THEIR AGENTS
S SERV E IS FREE OF CHARGE EXCEPT MATERIALS.
STANDARD SERVICE EVERY lO,OOO KM (6,000 MILES) OR 6 MONTHS
----------------------------------------------------------
CHECK
CHECK
CHECK
K
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
OIL AND COOLANT LEVELS
BRAKE AND CLUTCH FLUID LEVELS
ALL HOSES
LEAKS AND DAMAGE
AND ADJUST FAN BELT TENSION
FOR ANY OIL LEAKS
BRAKE PADS FOR WEAR
EXHAUST SYSTEM FOR LEAKS
WIPER BLADES
TYRE P SSUR
AND TREAD FOR WEAR
WHEEL NUTS FOR TIGHTNESS
HAND BRAKE OPERATION
ALL LIGHTS FOR OPERATION
WASHER FLUID LEVEL
DRIVE SHAFT GAITERS FOR DAMAGE
MAJOR SERVICE EVERY 20,000 KM (12,000 MILES) OR 12 MONTHS
IN ADDITION TO THE ABOVE
CHECK SPARK PLUGS AND RENEW IF NECESSARY
CHECK IGNITION TIMING AND RESET IF NECESSARY
CHECK GEARBOX AND OIL LEVELS
CHECK ALL
EERING COMPONENTS AND GAITERS
CHANGE ENGINE OIL AND FILTER
LUBRICATE HAND BRAKE
EMBLY
LUBRICATE THROTTLE
SEMBLY
LUBRICATE DOOR LOCKS AND
NGES
LUBRICATE BOOT, ENGINE COVER AND BOOT LOCKS
CHECK IDLE SPEED AND MIXTURE S
NGS
CLEAN AIR FILTER
LUBRICATE HEADLIGHT LI
MOTOR LINKAGE
IN ADDITION TO THE ABOVE
E FOLLOWI
SHOULD BE CARRIED OUT
-----------------------------------------------------------EVERY 40,000 KM (24,000 MI
DRAIN
DRAIN
RENEW
DRAIN
DRAIN
CHECK
K
S) OR 24 MONTHS
AND RENEW AUTOMATIC TRANMISSION OIL
AND RENEW DIFF. FLUID (AUTO ONLY)
FUEL FILTER
AND FLUSH COOLING SYSTEM RILL
AND REFILL BRAKI
SYSTEM AND CLUTCH
COND
ON OF ALL BRAKE,FUEL,CLUTCH AND WATER HOSES
CONDITION OF CLUTCH AND BRAKE LINES
CHASSIS NO: ..... .... ....... ...
ENGINE NO: .................................... .
151 SERVICE 500 MILES
2nd SERVICE 6000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE ............ .. ...... .. .. .
RECORDED MILEAGE .........................
DATE SERVICED ................. .............. ..
3 rd SERVICE 12000 MILES
4th SERVICE 18000 MILES
DEALER STAMP
DEALER STAM P
RECORDED MILEAGE ....... ...... ... ....... ..
RECORDED MILEAGE .. ....... ............. ...
DATE SERVICED ........ .. ....... .. ..... .. ...... .
DATE SERVICED ... ............................. .
5 th SERVICE 24000 MILES
6 th SERVICE 30000 MILES
DEALER STAMP
DEALER ST AM P
RECORDED MILEAGE .........................
RECORDED MILEAGE .........................
DATE SERVICED .. ..... ........................ ..
,
DATE SERVICED ..... ............. ............ .. .
7th
SERVICE 36000 MILES
DATE SERVICED ............................... ..
8 th SERVICE 42000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE .................. ..... ..
RECORDED MILEAGE ... .... ................. .
DATE SERVICED .......... .. ......... ... ...... .
DATE SERVICED ............................... ..
9 th SERVICE 48000 MILES
10 th SERVICE 54000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE .... ..... ... .. ....... .
RECORDED MILEAGE ....................... ..
DATE SERVICED ................... .... ..........
DATE SERVICED ... ........ ........ .. ....... .
CHASSIS NO: ... ...... ..... .. ... .. .. .. ...... ..
ENGINE NO: ...... ... ............... ..... ...... ..
1 5t SERVICE 500 MILES
2nd SERVICE 6000 MILES
DEALER ST AM P
DEALER STAMP
RECORDED MILEAGE ... ... .... ... .... .... .. ..
RECORDED MILEAGE ... ... ... ... ..... ..... .. .
DATE SERVICED .. ... .. .. .. .. .. .. ............. ..
DATE SERVICED .... .. ............. .. ........ .. ..
3 rd SERVICE 12000 MILES
4th SERVICE 18000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE ....... .... .. ....... .. .
RECORDED MILEAGE .. .. .................... .
DATE SERVICED ....... ...... ...... ....... ...... .
DATE SERVICED .......... ... .. ........ ......... .
5th SERVICE 24000 MILES
6 th SERVICE 30000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE .. ...... .. ... ... .. .. ... .
RECORDED MILEAGE ............. ........ .. ..
DATE SERVICED ....... .. .. .. ........... ....... ..
7th
SERVICE 36000 MILES
DATE SERVICED ................. ............... .
8 th SERVICE 42000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE .... .... ..... .. .... ..... .
RECORDED MILEAGE ............ ......... ... .
DATE SERVICED .. .. .. ............. ....... ..... .
DATE SERVICED ....................... ........ ..
9 th SERVICE 48000 MILES
10 th SERVICE 54000 MILES
DEALER STAMP
DEALER STAMP
RECORDED MILEAGE ..... ..... ......... .... ..
RECORDED MILEAGE .... ... .. .. ......... .. ...
DATE SERVICED ........ ............... .. .. .... ..
Il.L I
RL-Il.
~L3
0\1'\ 011'
~y
i II.
.J
Il
~/R..
r.J-...I
Wi
::-<D'U\oollS
I
~;;~
~.~
BN
IU.3
.C
- -f
J
, ,
P ,c
- -~ --?
I
I
...
\
!
lH~'1H,
~w .
iI
!
\
LL
I
.8
fl'-Vl.lt.U
L.l~
.1)
I""
w/s
~N.
,.
L7
10
HO~
IU..
n
,-r-" ---t-""I~~
~ol1-l l
L "l0
c.oWlO1Io1
~w"
au.
f!;
I~I--t-------'-t-----~~....J
...---
ljw
J.
.......-
INfUtI()Il.
.......1....11
U~ U,,'"f
r-I
!-----!L~-.:J
.
I
a/N
