SAFETY DATA SHEET

BELT DRESSING SPRAY

Page: 1
Revision date: 16/02/2018
Revision No: 10

Section 1: Identification of the substance/mixture and of the company/undertaking

1.1. Product identifier

Product name: BELT DRESSING SPRAY

1.2. Relevant identified uses of the substance or mixture and uses advised against

Use of substance / mixture: Belt Conditioning and Antislip material

1.3. Details of the supplier of the safety data sheet

Company name: ROCOL

ROCOL House
Swillington
Leeds
West Yorkshire
LS26 8BS
ENGLAND
Tel: +44 (0) 113 232 2700
Fax: +44 (0) 113 232 2740
Email: [email protected]

1.4. Emergency telephone number

Emergency tel: +44 (0) 113 232 2600

Section 2: Hazards identification

2.1. Classification of the substance or mixture

Classification under CLP: Aquatic Chronic 3: H412; Flam. Aerosol 1: H222; -: H229
Most important adverse effects: Extremely flammable aerosol. Pressurised container: May burst if heated. Harmful to
aquatic life with long lasting effects.

2.2. Label elements

Label elements:
Hazard statements: H222: Extremely flammable aerosol.
H229: Pressurised container: May burst if heated.
H412: Harmful to aquatic life with long lasting effects.
Hazard pictograms: GHS02: Flame

Signal words: Danger

Precautionary statements: P410+P412: Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 2
°F.
P251: Do not pierce or burn, even after use.
P210: Keep away from heat, hot surfaces, sparks, open flames and other ignition
sources. No smoking.
P211: Do not spray on an open flame or other ignition source.
P285: In case of inadequate ventilation wear respiratory protection.
P273: Avoid release to the environment.
P501: Dispose of contents/container to local/national regulations.

2.3. Other hazards

PBT: This product is not identified as a PBT/vPvB substance.

Section 3: Composition/information on ingredients

3.2. Mixtures

Hazardous ingredients:

CYCLOPENTANE - REACH registered number(s): 01-2119463053-47

EINECS CAS PBT / WEL CLP Classification Percent

206-016-6 287-92-3 - Flam. Liq. 2: H225; Aquatic Chronic 3: 70-90%
H412

CARBON DIOXIDE AEROSOL PROPELLANT - REACH registered number(s): EXEMPT - ANNEX IV / V

204-696-9 124-38-9 Substance with a Community Press. Gas: H280 1-10%

workplace exposure limit.

Section 4: First aid measures

4.1. Description of first aid measures

Skin contact: Wash immediately with plenty of soap and water.

Eye contact: Bathe the eye with running water for 15 minutes. Consult a doctor.
Ingestion: Wash out mouth with water. Do not induce vomiting. Consult a doctor.
Inhalation: Remove casualty from exposure ensuring one's own safety whilst doing so. Consult a
doctor.

4.2. Most important symptoms and effects, both acute and delayed

Skin contact: There may be irritation and redness at the site of contact.
Eye contact: There may be irritation and redness. The eyes may water profusely.
Ingestion: There may be soreness and redness of the mouth and throat. May cause dizziness.
Inhalation: There may be irritation of the throat with a feeling of tightness in the chest.
Delayed / immediate effects: No data available.

4.3. Indication of any immediate medical attention and special treatment needed

Immediate / special treatment: No data available.

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 3

Section 5: Fire-fighting measures

5.1. Extinguishing media

Extinguishing media: Use water spray to cool containers. Alcohol resistant foam. Carbon dioxide. Dry
chemical powder. Do not use water.

5.2. Special hazards arising from the substance or mixture

Exposure hazards: Highly flammable. Forms explosive air-vapour mixture. In combustion emits toxic fumes
of carbon dioxide / carbon monoxide.

5.3. Advice for fire-fighters

Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact
with skin and eyes.

Section 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures

Personal precautions: Refer to section 8 of SDS for personal protection details. Eliminate all sources of
ignition.

6.2. Environmental precautions

Environmental precautions: Do not discharge into drains or rivers.

6.3. Methods and material for containment and cleaning up

Clean-up procedures: Do not use equipment in clean-up procedure which may produce sparks. Absorb into dry
earth or sand. Transfer to a closable, labelled salvage container for disposal by an
appropriate method.

6.4. Reference to other sections

Reference to other sections: Refer to section 8 of SDS.

Section 7: Handling and storage

7.1. Precautions for safe handling

Handling requirements: Ensure there is sufficient ventilation of the area. Do not handle in a confined space.
Smoking is forbidden.

7.2. Conditions for safe storage, including any incompatibilities

Storage conditions: Store in a cool, well ventilated area. Keep away from sources of ignition. Keep away from
direct sunlight. Ensure lighting and electrical equipment are not a source of ignition.
Suitable packaging: Must only be kept in original packaging.

7.3. Specific end use(s)

Specific end use(s): No data available.

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 4

Section 8: Exposure controls/personal protection

8.1. Control parameters

Workplace exposure limits: No data available.

DNEL/PNEC Values

Hazardous ingredients:

CYCLOPENTANE

Type Exposure Value Population Effect

DNEL Dermal (repeated dose) 432 mg/m3 Workers Systemic
DNEL Inhalation (repeated dose) 3000 mg/m3 Workers Systemic
DNEL Dermal 214 mg/kg bw/day Consumers Systemic
DNEL Inhalation 643 mg/m3 Consumers Systemic
DNEL Oral 214 mg/kg bw/day Consumers Systemic

8.2. Exposure controls

Engineering measures: Ensure there is sufficient ventilation of the area. Ensure lighting and electrical
equipment are not a source of ignition.
Respiratory protection: Respiratory protection not normally required.
Hand protection: Gloves (oil-resistant). Nitrile gloves.
Eye protection: Safety glasses.
Skin protection: Protective clothing.
Environmental: No data available

Section 9: Physical and chemical properties

9.1. Information on basic physical and chemical properties

State: Aerosol
Colour: Colourless
Odour: Characteristic odour
Evaporation rate: Fast
Oxidising: Non-oxidising (by EC criteria)
Solubility in water: Miscible
Viscosity: Non-viscous
Boiling point/range°C: >35 Melting point/range°C: < 0
Flammability limits %: lower: 1.4 upper: 9.4
Flash point°C: -39 Part.coeff. n-octanol/water: No data available.
Autoflammability°C: > 200 Vapour pressure: No data available.
Relative density: 0.78 pH: Approx. 7
VOC g/l: 577

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 5

9.2. Other information

Other information: No data available.

Section 10: Stability and reactivity

10.1. Reactivity

Reactivity: Stable under recommended transport or storage conditions.

10.2. Chemical stability

Chemical stability: Stable under normal conditions. Stable at room temperature.

10.3. Possibility of hazardous reactions

Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions.

10.4. Conditions to avoid

Conditions to avoid: Direct sunlight. Heat. Sources of ignition.

10.5. Incompatible materials

Materials to avoid: Strong oxidising agents. Strong reducing agents.

10.6. Hazardous decomposition products

Haz. decomp. products: In combustion emits toxic fumes of carbon dioxide / carbon monoxide.

Section 11: Toxicological information

11.1. Information on toxicological effects

Hazardous ingredients:

CYCLOPENTANE

ORL MUS LD50 12800 mg/kg

ORL RAT LD50 11400 mg/kg

Toxicity values: No data available.

Symptoms / routes of exposure

Skin contact: There may be irritation and redness at the site of contact.
Eye contact: There may be irritation and redness. The eyes may water profusely.
Ingestion: There may be soreness and redness of the mouth and throat. May cause dizziness.
Inhalation: There may be irritation of the throat with a feeling of tightness in the chest.
Delayed / immediate effects: No data available.

Section 12: Ecological information

12.1. Toxicity

Ecotoxicity values: No data available.

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 6

12.2. Persistence and degradability

Persistence and degradability: Not readily biodegradable.

12.3. Bioaccumulative potential

Bioaccumulative potential: No bioaccumulation potential.

12.4. Mobility in soil

Mobility: Insoluble in water. Readily absorbed into soil.

12.5. Results of PBT and vPvB assessment

PBT identification: This product is not identified as a PBT/vPvB substance.

12.6. Other adverse effects

Other adverse effects: No data available.

Section 13: Disposal considerations

13.1. Waste treatment methods

Disposal operations: Transfer to a suitable container and arrange for collection by specialised disposal
company.
Recovery operations: No data available
Waste code number: 16 05 05
Disposal of packaging: Dispose of in a regulated landfill site or other method for hazardous or toxic wastes.
NB: The user's attention is drawn to the possible existence of regional or national
regulations regarding disposal.

Section 14: Transport information

14.1. UN number

UN number: UN1950

14.2. UN proper shipping name

Shipping name: AEROSOLS, FLAMMABLE

14.3. Transport hazard class(es)

Transport class: 2.1

14.4. Packing group

Packing group: n/a

14.5. Environmental hazards

Environmentally hazardous: No Marine pollutant: No

14.6. Special precautions for user

Special precautions: No data available

[cont...]
 SAFETY DATA SHEET
BELT DRESSING SPRAY
Page: 7

14.7. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code

Transport in bulk: No data available.

Section 15: Regulatory information

15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture

Specific regulations: No data available

15.2. Chemical Safety Assessment

Chemical safety assessment: A chemical safety assessment has not been carried out for the substance or the mixture
by the supplier.

Section 16: Other information

Other information

Other information: Contains only FDA listed ingredients. NSF H1 registered.

This safety data sheet is prepared in accordance with Commission Regulation (EU) No
2015/830.
Safety data sheet prepared in accordance with Commission Directive 2008/47/EC of 8
April 2008 amending, for the purposes of adapting to technical progress, Council
Directive 75/324/EEC relating to aerosol dispensers
Compiled in accordance with REACH.
Phrases used in s.2 and s.3: H222: Extremely flammable aerosol.
H225: Highly flammable liquid and vapour.
H229: Pressurised container: May burst if heated.
H280: Contains gas under pressure; may explode if heated.
H412: Harmful to aquatic life with long lasting effects.
Legal disclaimer: The above information is believed to be correct but does not purport to be all inclusive
and shall be used only as a guide. This company shall not be held liable for any
damage resulting from handling or from contact with the above product.

[final page]