TLP551
TOSHIBA Photocoupler IRED & Photo IC
TLP551
Controllers Unit: mm
Interfaces for Calculators and Control Devices
Noise Attenuation in Measurement and System Devices
Signal Transmission between circuits of different potential
The TOSHIBA TLP551 consists of a high-output infrared emitting diode
and a high speed detector of one chip photo diode-transistor. This unit is 8-
lead DIP.
TLP551 has an internal base connection. This base pin should be used
for analog application or enable operation.
• Isolation voltage: 2500 Vrms (min)
• Switching speed: tpHL = 0.5 μs (typ.)
tpLH = 0.6 μs (typ.)
(RL = 1.9 kΩ)
• TTL compatible
• If the base pin is open, external noise will cause interference to the
output signal. In this scenario, TLP550 will be recommended. JEDEC ―
• UL-recognized: UL 1577, File No.E67349
JEITA ―
• cUL-recognized: CSA Component Acceptance Service No.5A
File No.E67349 TOSHIBA 11-10C4S
Weight: 0.54 g (typ.)
Pin Configurations (top view)
1: N.C.
1 8
2: Anode
3: Cathode
2 7
4: N.C.
5: Emitter
3 6 6: Collector
7: Base
4 5 8: VCC
Schematic
ICC
8 VCC
IF IB
2 7 VB
VF IO
3 6 VO
5 GND
Start of commercial production
1981-09
© 2019 1 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
Absolute Maximum Ratings (Ta = 25°C)
Characteristics Symbol Rating Unit
Forward current IF 25 mA
Forward current derating (Ta≥ 70 °C) ΔIF/ΔTa -0.8 mA/°C
Pulse forward current (Note 1) IFP 50 mA
Pulse forward current derating (Ta≥ 70 °C) ΔIFP/ΔTa -1.6 mA/°C
LED
Peak transient forward current (Note 2) IFPT 1 A
Reverse voltage VR 5 V
Diode power dissipation PD 45 mW
Diode power dissipation derating (Ta ≥ 70 °C) ΔPD/ΔTa -0.9 mW/°C
Output current IO 8 mA
Peak output current IOP 16 mA
Output voltage VO −0.5 to 15 V
Detector
Supply voltage VCC −0.5 to 15 V
Base current IB 5 mA
Emitter-base reverse voltage VEB 5 V
Output power dissipation PO 100 mW
Output power dissipation derating (Ta≥ 70 °C) ΔPO/ΔTa -1.8 mW/°C
Operating temperature range Topr −55 to 100 °C
Storage temperature range Tstg −55 to 125 °C
Lead solder temperature (10 s) (Note 3) Tsol 260 °C
Isolation voltage (AC, 60 s, R.H. ≤ 60 %)
BVS 2500 Vrms
(Note 4)
Note: Using continuously under heavy loads (e.g. the application of high temperature/current/voltage and the
significant change in temperature, etc.) may cause this product to decrease in reliability significantly even if the
operating conditions (i.e. operating temperature/current/voltage, etc.) are within the absolute maximum ratings.
Please design the appropriate reliability upon reviewing the Toshiba Semiconductor Reliability Handbook
(“Handling Precautions”/“Derating Concept and Methods”) and individual reliability data (i.e. reliability test report
and estimated failure rate, etc).
Note 1: 50 % duty cycle, 1 μs pulse width.
Note 2: Pulse width ≤ 1 μs, 300 pps.
Note 3: Soldering portion of lead: up to 2 mm from body of the device.
Note 4: Device considered a two-terminal device: Pins 1, 2, 3 and 4 shorted together and pins 5, 6, 7 and 8 shorted
together.
© 2019 2 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
Electrical Characteristics (Ta = 25°C)
Characteristics Symbol Test Condition Min Typ. Max Unit
Forward voltage VF IF = 16 mA 1.45 1.65 1.85 V
Forward voltage temperature
∆VF/∆Ta IF = 16 mA ― −2 ― mV/°C
coefficient
LED
Reverse current IR VR = 5 V ― ― 10 μA
Capacitance between terminal CT VF = 0 V, f = 1 MHz ― 60 ― pF
IOH(1) IF = 0 mA, VCC = VO = 5.5 V ― 3 500 nA
IOH(2) IF = 0 mA, VCC = VO = 15 V ― ― 5 μA
Detector
High level output current
IF = 0 mA, VCC = VO = 15 V, ― ― 50
IOH μA
Ta = 70 °C
High level supply voltage ICCH IF = 0 mA, VCC = 15 V ― 0.01 1 μA
Coupled Electrical Characteristics (Ta = 25°C)
Characteristics Symbol Test Condition Min Typ. Max Unit
IF = 16 mA, VCC = 4.5 V, VO = 0.4 V 10 30 ―
Rank: O 19 30 ―
Current transfer ratio IO/IF %
IF = 16 mA, VCC = 4.5 V, VO = 0.4 V 5 ― ―
Ta = 0 to 70°C Rank: O 15 ― ―
IF = 16 mA, VCC = 4.5 V, IO = 1.1 mA
Low level output voltage VOL ― ― 0.4 V
(Rank O: IO = 2.4 mA)
Isolation Characteristics (Ta = 25°C)
Characteristics Symbol Test Condition Min Typ. Max Unit
Capacitance (input-output) CS VS = 0 V, f = 1 MHz ― 0.8 ― pF
5×
Resistance (input-output) RS VS = 500 VDC, R.H. ≤ 60 % (Note 1) 1014 ― Ω
1010
Isolation voltage BVS AC, 60 s 2500 ― ― Vrms
Note 1: Device considered a two-terminal device: Pins 1, 2, 3 and 4 shorted together and pins 5, 6, 7 and 8 shorted
together.
© 2019 3 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
Switching Characteristics (Ta = 25°C, VCC = 5 V)
Test
Characteristics Symbol Test Condition Min Typ. Max Unit
Circuit
IF = 16 mA, RL = 4.1 kΩ ― 0.3 0.8
Propagation delay time (H → L) tpHL 1 IF = 16 mA, RL = 1.9 kΩ μs
― 0.5 0.8
(Rank O)
IF = 16 mA, RL = 4.1 kΩ ― 1 2
Propagation delay time (L → H) tpLH 1 IF = 16 mA, RL = 1.9 kΩ μs
― 0.6 1.2
(Rank O)
IF = 0 mA, VCM = 200 Vp-p
Common mode transient immunity at
CMH 2 RL = 4.1 kΩ ― 400 ― V/μs
logic high output
(Rank O: RL = 1.9 kΩ)
IF = 16 mA, VCM = 200 Vp-p
Common mode transient immunity at
CML 2 RL = 4.1 kΩ ― −1000 ― V/μs
logic low output
(Rank O: RL = 1.9 kΩ)
Note: CMH: The maximum tolerable rate of rise of the common mode voltage to ensure that the output will remain in
the high output state (i.e., VO > 2.0 V). Measured in volts per microsecond (V/μs).
CML: The maximum tolerable rate of fall of the common mode voltage to ensure that the output will remain in
the low output state (i.e., VO < 0.8 V). Measured in volts per microsecond (V/μs).
Test Circuit 1: Switching Time Test Circuit
IF
Pulse input VCC = 5 V IF
1 8
0
PW = 100 μs 2 7 RL
Duty ratio = 1/10 VO 5V
IF monitor 3 6 VO 1.5 V
1.5 V
VOL
51 Ω
4 5 Output tpHL tpLH
monitor
Test Circuit 2: Common Mode Noise Immunity Test Circuit
VCC = 5 V
1 8
200 V
IF 90%
2 7 RL VCM
10% 0V
tr tf
3 6 VO
4 5 Output VO 5V
monitor (IF = 0 mA)
2V
VCM
0.8 V
Pulse generator VO VOL
ZO = 50 Ω (IF = 16 mA)
CMH = , CML =
© 2019 4 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
NOTE: The above characteristics curves are presented for reference only and not guaranteed by production test,
unless otherwise noted.
© 2019 5 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
NOTE: The above characteristics curves are presented for reference only and not guaranteed by production test,
unless otherwise noted.
© 2019 6 2019-06-24
Toshiba Electronic Devices & Storage Corporation
TLP551
RESTRICTIONS ON PRODUCT USE
Toshiba Corporation and its subsidiaries and affiliates are collectively referred to as “TOSHIBA”.
Hardware, software and systems described in this document are collectively referred to as “Product”.
• TOSHIBA reserves the right to make changes to the information in this document and related Product without notice.
• This document and any information herein may not be reproduced without prior written permission from TOSHIBA. Even with
TOSHIBA's written permission, reproduction is permissible only if reproduction is without alteration/omission.
• Though TOSHIBA works continually to improve Product's quality and reliability, Product can malfunction or fail. Customers are
responsible for complying with safety standards and for providing adequate designs and safeguards for their hardware, software and
systems which minimize risk and avoid situations in which a malfunction or failure of Product could cause loss of human life, bodily
injury or damage to property, including data loss or corruption. Before customers use the Product, create designs including the
Product, or incorporate the Product into their own applications, customers must also refer to and comply with (a) the latest versions of
all relevant TOSHIBA information, including without limitation, this document, the specifications, the data sheets and application notes
for Product and the precautions and conditions set forth in the "TOSHIBA Semiconductor Reliability Handbook" and (b) the
instructions for the application with which the Product will be used with or for. Customers are solely responsible for all aspects of their
own product design or applications, including but not limited to (a) determining the appropriateness of the use of this Product in such
design or applications; (b) evaluating and determining the applicability of any information contained in this document, or in charts,
diagrams, programs, algorithms, sample application circuits, or any other referenced documents; and (c) validating all operating
parameters for such designs and applications. TOSHIBA ASSUMES NO LIABILITY FOR CUSTOMERS' PRODUCT DESIGN OR
APPLICATIONS.
• PRODUCT IS NEITHER INTENDED NOR WARRANTED FOR USE IN EQUIPMENTS OR SYSTEMS THAT REQUIRE
EXTRAORDINARILY HIGH LEVELS OF QUALITY AND/OR RELIABILITY, AND/OR A MALFUNCTION OR FAILURE OF WHICH
MAY CAUSE LOSS OF HUMAN LIFE, BODILY INJURY, SERIOUS PROPERTY DAMAGE AND/OR SERIOUS PUBLIC IMPACT
("UNINTENDED USE"). Except for specific applications as expressly stated in this document, Unintended Use includes, without
limitation, equipment used in nuclear facilities, equipment used in the aerospace industry, lifesaving and/or life supporting medical
equipment, equipment used for automobiles, trains, ships and other transportation, traffic signaling equipment, equipment used to
control combustions or explosions, safety devices, elevators and escalators, and devices related to power plant. IF YOU USE
PRODUCT FOR UNINTENDED USE, TOSHIBA ASSUMES NO LIABILITY FOR PRODUCT. For details, please contact your
TOSHIBA sales representative or contact us via our website.
• Do not disassemble, analyze, reverse-engineer, alter, modify, translate or copy Product, whether in whole or in part.
• Product shall not be used for or incorporated into any products or systems whose manufacture, use, or sale is prohibited under any
applicable laws or regulations.
• The information contained herein is presented only as guidance for Product use. No responsibility is assumed by TOSHIBA for any
infringement of patents or any other intellectual property rights of third parties that may result from the use of Product. No license to
any intellectual property right is granted by this document, whether express or implied, by estoppel or otherwise.
• ABSENT A WRITTEN SIGNED AGREEMENT, EXCEPT AS PROVIDED IN THE RELEVANT TERMS AND CONDITIONS OF SALE
FOR PRODUCT, AND TO THE MAXIMUM EXTENT ALLOWABLE BY LAW, TOSHIBA (1) ASSUMES NO LIABILITY
WHATSOEVER, INCLUDING WITHOUT LIMITATION, INDIRECT, CONSEQUENTIAL, SPECIAL, OR INCIDENTAL DAMAGES OR
LOSS, INCLUDING WITHOUT LIMITATION, LOSS OF PROFITS, LOSS OF OPPORTUNITIES, BUSINESS INTERRUPTION AND
LOSS OF DATA, AND (2) DISCLAIMS ANY AND ALL EXPRESS OR IMPLIED WARRANTIES AND CONDITIONS RELATED TO
SALE, USE OF PRODUCT, OR INFORMATION, INCLUDING WARRANTIES OR CONDITIONS OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, ACCURACY OF INFORMATION, OR NONINFRINGEMENT.
• GaAs (Gallium Arsenide) is used in Product. GaAs is harmful to humans if consumed or absorbed, whether in the form of dust or
vapor. Handle with care and do not break, cut, crush, grind, dissolve chemically or otherwise expose GaAs in Product.
• Do not use or otherwise make available Product or related software or technology for any military purposes, including without
limitation, for the design, development, use, stockpiling or manufacturing of nuclear, chemical, or biological weapons or missile
technology products (mass destruction weapons). Product and related software and technology may be controlled under the
applicable export laws and regulations including, without limitation, the Japanese Foreign Exchange and Foreign Trade Law and the
U.S. Export Administration Regulations. Export and re-export of Product or related software or technology are strictly prohibited
except in compliance with all applicable export laws and regulations.
• Please contact your TOSHIBA sales representative for details as to environmental matters such as the RoHS compatibility of
Product. Please use Product in compliance with all applicable laws and regulations that regulate the inclusion or use of controlled
substances, including without limitation, the EU RoHS Directive. TOSHIBA ASSUMES NO LIABILITY FOR DAMAGES OR LOSSES
OCCURRING AS A RESULT OF NONCOMPLIANCE WITH APPLICABLE LAWS AND REGULATIONS.
https://toshiba.semicon-storage.com/
© 2019 7 2019-06-24
Toshiba Electronic Devices & Storage Corporation
