TEREX~CRANES

CNT500
PARTS MANUAL
P&H I•• regletered ~ of the lWnIechfeger Corp.

CNT500-2·PM
 SAFE OPERATING PRACTICES FOR MOBILE CRANE USERS

INTRODUCTION He must be alert, physically fit, and free

from the influences of alcohol, drugs, or
medications that might affect his
eyesight, hearing, or reactions.
NOTE
He must see that people, equipment, and
This material replaces Catalog 240. material are kept out of the work area.
The area around the machine should be
properly barricaded (see Operating Pre-
Century II P&H cranes are carefully de- cautions No.4 and 5).
signed, tested, and manufactured. When
used properly by qualified operators, When an operator's vision is blocked or
they will give safe, reliable service. when operating in hazardous areas such
There are Century II offices world-wide as near power lines or around people, a
to answer any questions about P&H pro- signalman must be used. Because the op-
ducts or thei r safe use. erator is not in the best position to judge
distances and can not see all parts of the
Because cranes have the ability to lift jobsite, a signalman may also be neces-
heavy loads to great heights, they also sary at other times. Operators must
have a potential for accidents if safe op- understand standard crane signals and
erating practices are not followed. This take signals only from designated signal-
booklet will help the operator prevent men; except that operators must always
accidents which could result in injury, obey a stop signal from anybody.
death, or property damage.
General safe practices for working on SIGNALMAN'S RESPONSIBILITY
machinery must be followed as well as the
safe operating practices recommended The primary duty of a signalman is to
here. assist the operator in safe and efficient
operation. Operators depend on desig-
nated signalmen to assist them in making
OPERATOR'S RESPONSIBILITY movements without endangering people or
property.
Safety must always be the operator's
most important concern. He must refuse Signalmen must have a clear understand-
to operate when he knows it is unsafe ing of the work to be done so that they
and consult his supervisor when safety can safely coordinate each job with oper-
is in doubt. ators and other crew members.
He must read and understand the Opera- Signalmen must place themselves where
tor's Manual, all instructions and signs they can be clearly seen and where they
on the crane. He must see that the ma- can safely observe the entire operation.
chine is in proper order before
operating. Standard crane signals must be used un-
less other methods of signaling such as
He must never lift a load without a load two way radios or flags have been agreed
rating plate in the cab. He must under- upon.
stand how to read the rating plate and
know that his crane can safely lift each
load before attempting to lift it.

Safe Operating Practices for Mobile Crane Users iii

RESPONSIBILITIES OF ALL CREW MEM- lifts (see Operating Precautions No. 28
BERS and 29).
Any unsafe condition or practice must be
corrected or reported to the job supervi- PLANN ING THE JOB
sor.
Most accidents can be avoided by careful
Everyone who works around cranes, in- job planning. The person in charge must
cluding riggers and oilers, must obey all have a clear understanding of the work
warning signs and watch out for his own to be done, consider all dangers at the
safety and the safety of others. Crew jobsite, develop a plan to do the job safe-
members setting up machines or handling Iy, and then explain the plan to all con-
loads are expected to know proper ma- cerned. Factors such as these should be
chine erection and rigging procedures. considered:
Watch for hazards during operations and • What crew members are needed and
alert the operator and signalmen of dan- what responsibilities will they be given?
gers such as power lines, the unex-
pected presence of people, other • What is the weight of the load to be
equipment, unstable ground conditions lifted, the lift radius, boom angle, and
and approaching storms. the rated capacity of the crane?
• How will the signalmen communicate
MANAGEMENT RESPONSIBILITY with the operator?
See that operators are trained, compe- • What equipment is required to do the
tent, physically fit and, if required, li- job safely? Is a crane the best equipment
censed. Good vision is required, as are for the job?
good judgment, coordination and mental
ability. Any person who lacks any of • How can the equipment be safely
these qualities must not be allowed to op- transported to the jobsite?
erate a crane.
• Are there gas lines, power lines or
Signalmen must have good vision and structures which must be moved or
sound judgment, know standard crane avoided?
signals and be able to give signals clear-
Iy. They must have enough experience to • Is the surface strong enough to sup-
be able to recognize hazards and signal port the machine and load?
the operator to avoid them.
• How will loads be rigged?
Riggers must be trained to determine
weights and distances and to select and • What special safety precautions will be
properly use lifting tackle. taken if a crane must travel with a sus-
pended load or if more than one crane is
Rigging is a complex subject far beyond needed to lift a load? (See Operating
the scope of this booklet. It is manage- Precautions No. 27, 28 and 29).
ment's responsibility to see that riggers
are properly trained. • Are unusual weather conditions such as
winds or extreme cold expected?
Management must assign a job supervisor
at the site to be responsible for overall • What steps will be taken to keep un-
job safety. Crane operators, riggers and necessary people and equipment safely
crew members must know who has been away from the work area?
assigned this responsibility.
• How can cranes be positioned to use
Crew members must be given specific the shortest boom and radius possible?
safety responsibilities and instructed to
report any unsafe conditions to their su-
pervisors. OPERATOR'S SAFETY CHECK
Management must assign specific people The operator must make a safety check
to coordinate and direct crane operations before starting to work each day to see
for pick and carry lifts and multi-crane

iv PARTS MANUAL MODEL CN T500

that the machine is in proper order. Trying to lift a load without knowing
Some things to check are: whether it is within the rated capacity
while expecting the crane to start to tip
• Check the machine log book to see that to warn of an overload is very
periodic maintenance and inspections dangerous. Cranes may suddenly tip
have been performed and all necessary over or collapse if the load is too heavy.
repairs made.
Crane mounted boom hoist upper angle
• Check the operation of the boom hoist limit switches, boom angle indicators,
upper angle limit switch, boom angle in- backup alarms, anti two-block warning
dicator, backup alarms, anti two-block devices, load moment or load indicator
warning devices, load moment or load in- devices and other operator aids are no
dicator devices, and other operator aids. substitute for following the rating chart,
operating instructions and safe operating
• Carefully inspect load bearing parts practices.
such as wire rope (load lines, boom hoist
cable, suspension lines), boom, outrig- Always stay within rated capacity. The
gers, and hooks. operator must reduce the load under ad-
verse field conditions until, in his judg-
• Be su re no unauthorized field modifica- ment, the machine can safely handle the
tions have been made; such as added lift.
counterweights and booms that have been
improperly repai red. (See Operating Precautions No.3, 11,
13,17,20,28and29).
• Check for air and hydraulic oil leaks.
2. Cranes may tip over or collapse if the
• After starting the engine, check all operating surface cannot support their
gauges and indicators for proper read- weight. Timber mats, steel plates or con-
ings. crete rafts may be needed under outrig-
gers pads or crawlers to distribute the
• Test all controls for proper operation. load under the crane so that the bearing
strength of the ground is not exceeded.
• Check brakes and clutches. Test load
brakes by lifting a load a few inches off Determine the load bearing capacity of
the ground and holding it. the ground or other surface on which
machines will be operating. Be sure
cranes are adequately supported. Avoid
OPERATING PRECAUTIONS soft or unstable ground, sand, areas
with high water tables, and partially fro-
1. Mistakes in calculating lifting capacity zen ground. When machines are working
can cause accidents. near trenches, the trenches should be
shored or sloped to prevent cave- ins or
Several factors must be considered, in- slides.
cluding:
3. The rated capacity of a crane is de-
A. Load radius (the distance between the termined with the crane leveled within 1
center of the crane rotation to the of grade (1 foot drop or rise in 100 foot
center of the load). Note that the ra- distance). Out of level more than 1 will
dius will increase when the load is drastically reduce the lifting capacity.
lifted.
Be sure cranes are level. Check fre-
B. Weight of the load, hook, and quently and relevel when necessary. Po-
rigging. sition outriggers according to the rating
chart. All tires must be off the ground
C. Boom length, jib, parts of line, and for "On Outrigger" ratings.
operating area (side, rear).
4. People can be crushed by the
Use the next lower rated capacity when scissors-like action of the upper rotating
working at boom lengths or radii between on the lower.
the figures on the rating chart. It is
dangerous to guess the capacity for boom Stay away from rotating cranes. Erect
lengths or radii between those listed on barricades to keep people away. Take
the rating plate.

Safe Operating Practices for Mobile Crane Users v

the time to determine that these areas C. Use a signalman to maintain a safe
are clear before swinging. distance between any part of the ma-
chine or load and power lines. The
5. People can be crushed by the rear operator is not in the best position to
(counterweight) of the machine if there judge distances.
is not enough room for it to swi ng.
D. Warn people to stay away from the
Position machine and use barricades so machine and load at all times. If the
that people cannot be trapped between load must be guided into place, ask
the counterweight and any obstructions. the Power Company about special pre-
cautions such as insulated poles or
6. Many people have been injured when hot sticks.
riding crane hooks or loads or while be-
ing lifted in manbaskets. They have no E. Slow Down. Give yourself time to re-
control over how they are handled and act to problems and to double check
no protection from impacts or falls. Small the distance between power lines and
mistakes can be fatal. any part of the machine or load.
It is strongly recommended that cranes Careful planning and supervision offer
not be used to lift people. Use ladders, better protection than any known device.
scaffolds, elevated work platforms or Insulated boom cages, proximity warning
other equipment designed to lift people. devices, and insulating links have limita-
tions and can fail without warning. In-
Cranes should never be used to lift peo- sulated boom cages and links only
ple unless there is no less hazardous way protect part of the crane and can break
to perform the needed work and every- down electrically when contaminated with
one involved has read, understood and dust and water. Operation of proximity
comp Iied with Cata log 275, " Importa nt warning devices can be affected by dif-
Safety Requirements When using Person- ferent arrangements of power lines, the
nel platforms with Mobile Construction movement of trucks, materials, and the
Cranes". Copies of Catalog 275 are crane itself, and other influences. Rely-
available from your distributor. ing on any of these devices could be
dangerous because operators may think
7. Power lines have killed or seriously they are providing protection when in
injured people working around cranes. fact they are not.
These accidents can be avoided by fol-
lowing a few simple rules. 8. The load line can break if the hook
block contacts the end of the boom. This
Always determine whether there are pow- is called "two-blocking". Two-blocking
er lines in the area before starting any can be caused by hoisting the hook into
job. OSHA regulations require at least the end of the boom, lowering the boom
ten (10) feet of clearance from lines car- or extending telescopic booms without
rying 50,000 volts or less. Greater clear- paying out load line. Two-blocking can
ances are required for lines with higher pull jibs and lattice crane booms over
voltages. Some states require greater backwards.
clearances than OSHA. Safety requires
that you stay as far as possible from Always keep space between the hook
power lines and never violate minimum block and boom point. Lower the hook
clearances. when extending telescopic booms to avoid
two-blocking.
Always take these precautions if power
lines are present. . 9. People can be injured if the hook,
boom, load or outriggers are moved be-
A. Notify the Power Company before be- fore everyone is clear.
ginning work.
Make sure everyone is in a safe place be-
B. You and the Power Company must fore moving the hook, boom, load or out-
take specific precautions. These may riggers. Do not move loads over people
include locating cranes and materials or veh icle cabs. Do not allow the load to
away from power lines, de-energizing bump or catch on anything.
and grounding lines, rerouting lines,
removing or barricading lines, and
insulating lines with rubber sleeves.

vi PARTS MANUAL MODEL CN T500

10. Injury and damage can occur if the Inspect the crane boom daily for damage.
engine is started before servicing is fin- Do not use damaged booms. (NOTE: Due
ished. to the high strength steels used in
booms, special repair procedures are re-
Prior to servicing the crane, place quired. Repair procedures for lattice
"Warning" or "Out of Order" signs on booms are described in Catalog 238, "Re-
the crane controls. pair Procedure for Mobile Construction
Crane Boom Sections". Consult your
Never start or operate the crane if warn- distributor for further information.)
ing signs are on the crane controls. Look
under and around the crane to be sure 17. Crane booms can buckle if side load-
everyone is clear. ed (pulled sideways). Typical causes of
side loading are rapid starts and stops
11. Rapid swings or sudden starts and while swinging, dragging or pushing a
stops can cause the hook and attached load sideways, winds, or lifting when the
load to swing out of control. crane is not level.
Always start and stop movements smooth- Take care to avoid side loading.
ly and swing at speeds that will keep the
load under control. 18. If the load strikes the boom or the
boom hits a building or other object, the
12. Dirty windows, darkness, bright boom may collapse.
sunlight, fog, rain, and other conditions
can make it difficult for the operator to Never let the load or any other object
see. strike the boom.
Keep windows clean. Do not operate if 19. Boom suspension lines will stretch
you cannot see clearly enough to operate when the load is lifted and contract when
safely. the load is released. At high boom angles
this may be enough to pull the boom
13. Even light winds can blow loads out backward over the crane.
of control, collapse booms, or tip ma-
chines. Winds aloft can be much stronger When releasing loads, be sure the boom
than at ground level. never tightens against the backstops.
Release loads slowly.
Do not lift loads if winds create a
hazard. Lower the boom if necessary. 20. The load will swing out of control if
See the rating plate for possible re- it is not di rectly beneath the boom point
strictions. when lifted. This can side load the boom
and may cause the crane to tip or col-
14. Carelessness in getting on and off lapse.
equipment can result in serious injuries.
Always place the boom point directly
Always wait until the machine has above the load when lifting.
stopped. Do not jump on or off. Always
use both hands and make sure you have 21. Trying to lift a load which is stuck,
good footi ng . frozen or attached to something else may
result in tipping, boom collapse or other
15. Slippery floors and steps, tools, damage.
trash, or other loose items can cause
falls. Be sure that loads are free before
lifting.
Keep the mach ine clean and dry.
22. If there is not enough wire rope on
16. Damaged crane booms may collapse. the drum, the rope can be pulled off.
Lattice type booms will be weakened by
damaged chords, bent or missing Keep at least two full wraps of wire rope
lacings, or cracked welds. Telescopic on drums when operating.
booms will be weakened by distorted bot-
tom or side plates. I n either case, the 23. Foot pedal brake locks are furnished
loss of strength is difficult to estimate. on some cranes to allow the operator to
rest his legs when suspending the load
for short periods of time.

Safe Operating Practices for Mobile Crane Users vii

The feet must be kept on the pedals whi- • Watch for people, power lines, low or
le foot pedal brake locks are in use. narrow clearances, bridge or road
Brakes may cool allowing the load to fall. load limits, steep hills or uneven ter-
rain. Use a signalman in close quar-
24. Trying to repair or adjust equipment ters. Know the height, width and
with a suspended hook or load or with weight of the machine. Set the swing
the boom raised could release machinery brake or lock before traveling. Store
and let it move unexpectedly. or tie empty hook to prevent
swinging.
Always lower the load to the ground and
the boom onto proper cribbing before do- • The job supervisor must specify a
ing maintenance or repair work. person to determine and di rect safe
operation before and du ring the pick
25. Pressure in hydraulic systems can be and carry lift.
retained for long periods of time. If not
properly released before maintenance • Check the rating plate for limitations
people attempt to work on the hydraulic and instructions.
system, this pressure can let machinery
move or cause hot oil and hose ends to • Position the boom in line with the di-
shoot out at high speed. rection of travel.
Release system pressure before attempt- • Reduce the maximum load while travel-
ing to make adjustments or repairs. ing to reflect operating conditions.
The safe load will vary depending on
26. Pin-connected booms and jibs may speed, crane, terrain, and other con-
fall if not properly supported when re- ditions.
moving pins.
• Inflate tires to specified pressure.
Make sure both ends of each boom and
jib section are supported and the boom • Travel slowly and avoid sudden stops
suspension lines completely slacked off and starts.
before removing pins. Never stand on,
inside, or under booms or jibs during • Avoid backing away from the load.
assembly or disassembly. This could increase the radius and
cause the machine to tip over.
27. As with all heavy equipment, care
must be taken when cranes are driven • Use tag lines to keep loads under con-
(traveled) whether on or off the jobsite. trol.
Watch for people, power lines, low or • Keep the load close to the ground.
narrow clearances, bridge or road load
limits, and steep hills or uneven terrain. • Use the shortest boom possible.
Use a signalman in close quarters. Know
the height, width, and weight of the ma- 29. Using two or more cranes to lift a
chine. Retract and lock the outriggers, load involves many hazards not normally
place the boom in the cradle, and set the encountered in single crane lifts.
swing brake or lock before traveling.
Store or tie empty hook to prevent Multi-crane lifts must be carefully engi-
swinging. neered, keeping the following points in
mind.
28. Load ratings for cranes are based on
the machine being stationary and level. • Since the load is not freely
Traveling a crane with a suspended load suspended, careful engineering stu-
(pick and carry operation) or with the dies must be made to ensu re that the
boom erected involves special hazards, load carried by each machine is less
including the possibility of side loading than its rated capacity.
or tipping over.
• Make sure slings are arranged to di-
Because of the many variables involved, vide the load as planned.
the user must evaluate conditions and
take precautions such as these: • Review the lifting plan with
operators, signalmen and other crew
members before beginning the lift.

viii PARTS MANUAL MODEL CN T500

• The job supervisor must designate a 1/16 inch for diameters 7/8 to
single person to determine and di rect 1-1/8 inches.
all crane operations before and during
every stage of the lift. 3/32 inch for diameters 1-1/4 to
1-1/2 inches.
• Avoid boom side loading (see No. 17).
30. Leaving a machine unattended can be • In standing ropes, more than two
very dangerous. broken wires in one lay in sections
between end connections or more than
Before leaving his seat, the operator one broken wire at an end connection.
must take the following steps to prevent
his machine from moving: • Evidence of kinking, bird caging
crushing, cuts, abrasions, sharp
• Lower the load to the ground. Lower bends or any other damage that re-
the boom when necessary. sults in distortion of the rope struc-
ture.
• Set the swing brake or lock.
• Rust or corrosion.
• Set all drum pawls.
• For rotation resistant ropes, any evi-
• Set parking brakes. dence of lengthening of rope lay with
a reduction in rope nominal diameter.
• Set propel brakes or locks on crawler
machines. 32. Improper wire rope connections may
fail under load.
• Disengage the engine clutch or shut
off the engine. Wire rope end connections must be in-
stalled properly and inspected daily.
31. All wire rope must be inspected daily
to determine whether it should be re- • Wedge sockets should be installed so
placed. See the inspection form in the that the loaded side of the rope is in
Operator's Manual and contact wire rope a straight line with the edge of the
manufacturers and their distributors for socket and not bent by the wedge.
more information. Prevent the rope end from slipping
out of the wedge socket by attaching
Wire rope should be replaced when any a short piece of rope to the rope end
of the following conditions exist: with two U-bolt clamps.
• In running ropes, six broken wires in • U-bolt clamps (clips) should be in-
one lay or three broken wires in one stalled so that the U-bolt is on the
strand in one lay. unloaded side and the saddle is on the
loaded side.
• Wear of one-third the original diam-
eter of the outside individual wires. • Review Operator's manual for installa-
tion example of U-bolt clamps.
• Evidence of heat damage from any
cause. 33. Wire rope running over drums and
through sheaves create pinch points.
• Reductions from nominal diameter of
more than: Do not use you r hands to guide wi re
rope onto drums. Keep clothing and all
1/32 inch for diameters 3/8 to 112 parts of the body away from running
inch. rope.
3/64 inch for diameters 9/16 to 3/4
inch.

Safe Operating Practices for Mobile Crane Users ix

This Parts Manual lists all standard and optional parts used on the machine
starting from the production number shown on the title page of this manual.
As this manual lists the standard and optional parts for two basic machine de-
signs, the user is cautioned to make sure the parts ordered are applicable to
the machine production number.

It is suggested that you write these important numbers in the space below for
future reference. The machine serial and production numbers are found on a
plate affixed inside the operators cab. The engine serial number can be found
on a plate attached to the engine.

MACHINE SERIAL NUMBER

PRODUCTION NUMBER
ENGINE SERIAL NUMBER
DATE DELIVERED

001-01-1
HOW TO ORDER PARTS

The following information must be given to the distributor when ordering parts
for this machine:
1. Machine Serial Number
2. Production Number
3. Part Number
4. Part Name
5. Quantity of Parts Required
6. Complete Shipping Address and Shipping Instructions

EXAMPLE

MODEL 00-0000 2438U257F1 Cylinder Assy. 1 Unit

(1) (2) (3) (4) (5)

HOW TO IDENTIFY A PART .'

The words in the left hand column below correspond the the headings on the
parts manual pages.
Item Parts assemblies are printed at the top of each parts list page.
The individual parts of an assembly are listed below as 1, 2, 3
and so on.
If within an assembly, there are sub-assemblies, then the indi-
vidual parts within the sub-assembly are numbered 1-1,1-2,1-3
and so on. If another sub-assembly is contained within a
sub-assembly, it will be number 1-1A, 1-18, 1-lC and so on.
Note: When service or repair kits are available, the kit is listed
at the end of the parts list.
Part No. The number assigned to the part.
Parts without a Part Number cannot be ordered separately; order
the next higher assembly.
Description The name of the part.
Remarks When clarification regarding interchangeability of parts is re-
quired, the following information is shown in the remarks column.
A <---> 8 or A <---> (8) The two parts connected with arrows
are completely interchangeable. Either part may be used.

001-01-2
 EXAMPLE: 1 <---> 10 or 1 <---> (10)
This means that item 1 is interchangeable with item 10 and item 10
is interchangeable with item 1. A number shown in brackets iden-
tifies the item number to be used.
A < __0- 8 or. A <--- (8) The two parts connected with an arrow
are not interchangeable. Part 8 replaces part A.
EXAMPLE: 1 <---- 10 or 1 <---- (10)
This means that item 10 replaces item 1. A number shown in
brackets identifies the item number to be used.
*1 remarks which do not fit in the remarks column are shown as
footnotes at the bottom of the page. Each footnote is numbered
for easy identification.
P.111-1 means that a fu rther breakdown of this part is shown on
page 111-1.
Q'ty Quantity indicates the number of that part on the machine. For
sub-assemblies, the quantity indicates the number of parts for a
sub-assembly even though the machine may have more than one of
these sub-assemblies.
Applicable If more than one part or assembly is shown, the applicable part
or assembly is identified by the applicable number shown in the
remarks column.
When no applicable number is shown, the part is common to all
machines covered by this manual. If the applicable number can-
not be shown in this column, they are shown as footnotes at the
bottom of the page, by A , 8 .

ABBREVIATIONS

The following abbreviations may be used in this manual.

Add Additional Mtg - Mounting
Ar - As Required Nega Negative
Assy - Assembly Planet Planetary
Att Attachment P-L Planetary
Auto Automatic Posi Positive
Aux Auxiliary Press Pressure
Conv Converter Qty Quantity
Elec Electrical Radia Radiator
Engl English Re Rear
Eng Engine R.H. Right Hand
Fr Front Spec Specification
Hydr Hydraulic Steer Steering
Inst Instrument Std Standard
Instal Installation Temp - T emperatu re
Lead Leader TIM Transmission
L.H. Left Hand Upp Upper
Low. Lower WI - With
Lub Lubrication WIO - Without
Mech - Mechanical

001-01-3
 CONTENTS
DESCRIPTION PAGE. No.
UPPER FIXED
INSTAL, CONTROL ...•.....•.•............................................. 11-01
CAB ASSY,OPERATORS .................................................. . 12-11
CONTROL LEVER ASSY,BOOM HOIST ...........•.......................... 13-12
CONTROL LEVER ASSY,AUX WINCH .•..................................... 14-12
CONTROL LEVER ASSY,SWING .......................................... . 15-12
CONTROL LEVER ASSY,BOOM TELESCOPE ................................. . 16-12
PANEL ASSY,CONTROL,FRONT .......................................... . 17-12
PANEL ASSY,CONTROL,SIDE ........................................... . 18-12
VALVE ASSY,RELEASE(SWING BRAKE) ................................... . 20-12
VALVE ASSY,THROTTLE ............................................... . 21-12
CYLINDER ASSY,MASTER(SWING BRAKE) ..........•....................... 24-12
INSTAL, REDUCT, SWING ..........•......••................................• 26-01
REDUCTION UNIT ........•.•............•............................... 27-26
MOTOR, SWING ....•...................•......•........•................. 28-26
INSTAL, DECK ...................•................•........................ 29-01
INSTAL, CAB ..........•.........•...................•...........•......... 31-01
CAB ASSY .........................•.•...............•................. 32-31
SASH ASSY ............•.•........•.................................. 33-32
DOOR ASSY ...•...................................................... 34-32
CAB GLASS .........•................................................ 35-32
INSTAL MIRROR ................................•......................... 36-01
HYD LINES,SWING .....•.................•...........•.................... 37-01
CONTROL VALVE, SWING ...........•........•............................. 38-37
HYD LINSE,BOOM HOIST &TELESCOPE ...................................... . 39-01
VALVE ASSY,BooM HOIST &TELESCOPE ..........•......................... 40-39
INSTAL, SHEET METAL ................•.........•.......................... 45-01
ELEC ASSY,UPPER •......•........••.........•...................•........ 47-01
INSTAL, SWIVEL ...•.......•...............•.............................. 48-01
SWIVEL ASSY .....•.....•........•.............................•....... 49-48

LOWER FIXED
FINEL ASSY,LOWER .•...................•.........................•....... 51-01
OUTRIGGER ASSY .............•.....•.........•............••............. 53-01
CYLINDER ASSY,VERTICAL ....................•.......................... 54-53
CYLINDER ASSY,HORIZONTAL ..•....•......•.............................. 56-53
AXLE ASSY,FRONT .••..............•......••....................•.•....... 57-01
FRONT AXLE ASSY,FRONT ...••........................................... 58-57
BRAKE ASSY,FRONT .........•.........................•............... 59-58
POWER CHAMBER .........•............................................ 60-58
CYCLINDER ASSY,STEERING ............................................. . 61-57
FRONT AXLE ASSY,REAR ........................•........................ 62-57
AXLE ASSY,REAR .........................................•............... 63-01
REAR AXLE ASSY,FRONT ..................................•.............. 64-63
DIFF CARRIER ASSY(R,F) ........•.................................... 65-64
CHAMBER, BRAKE ...........••......................................... 66-64
REAR AXLE ASSY,REAR ................................................. . 67-63
DIFF CARRIER ASSY(R,R) ..•.......................................... 68-67
SHAFT ASSY,PROPEL ..................................................... . 69-01
HYD LINS,LOW .......................................................... . 71-01
HYD LINS,STEER(CAT) ..•................................................. 72-01
HYD LINS,STEER(GM) ..•.....••..•.............••...•...•................. 72-02
VALVE ASSY,PRIORITY .•....•........................................•.. 73-72
003-11-1@
 CONTENTS
DESCRIPTION PAGE. No.
LINK ASSY;DRAG,FRONT ...........................••.................... 74-72
LINK ASSY,DRAG,REAR ......................•....................•...... 75-72
HYD LINES,OUTRLGGER ......•..................•............••........••.. 76-01
CONTROL VALVE,OUTRIGGER EXT/RET ...•..............••.................. 77-76
CONTROL VALVE,OUTRIGGER ..•......................•.........•.......... 78-76
TANK ASSY,HYD ................................•.•..........•............ 79-01
RESERVOIR ASSY,OIL .....•...............•......•••...........•........ 80-79
DRIVE ASSY,PUMP •......................•........•.................•... 81-79
PUMP ASSY,DRIVE ...••...................••...••...........•......... 82-81
GEAR PUMP,WINCH/BOOM HOIST ....•.........•......•................... 83-81
GEAR PUMP,STEER/W·BOOST/SWING ................•.•................... 84-81
INSTAL,CAB ASSY .......•••..........••........•......................... 86-01
CAB ASSY •.................•.............................•............ 87-86
DOOR ASSY ......••.••...........•.........•......................... 88-87
TANK ASSY,FUEL ............••••...........•..........................•.. 89-01
LINES ASSY,AIR ....•...•.•..........•.•.........•••.........•........... 91-01
LINES ASSY,AIR .........•••........•...•........•...........•••......... 91-01A
REAERVOIR ASSY,AIR .•.••..•.......••...........••........••••......... 92-91
VALVE ASSY ..........•.•.•...........•.•........•...........•......... 93-91
ELEC ASSY,LOWER .............•...•........................••............ 95-01
ELEC ASSY,LOWER •.....................•...•.........•••................. 95-01A
BOX ASSY,RELAY ................•..............•....................... 96-95
BOX ASSY,CONTROL •...•.................••••.........•.............•... 97-95
LIGHT ASSY,BUMPER ...............•.............•.•...........•........ 98-95

UPPER SELECTIONS
INSTAL, MAIN WINCH-1581 ••.•.................•...............•••. ,....... . 103-01
INSTAL,AUX.WINCH ••....•••..............•••••..............••........... 107-03
WINCH ASSY-1581 ...............................•••.•.•..........••.•.. 110-103
CONTROLVALVE,NEGA BRAKE ...•...•...........•.••.••...•.......•..•... 111-110
REDUCTION UNIT,WINCH ......•..••...........•••..........•........... 112-110
BRAKE ASSY,WINCH ......••..............•••...........•.•.......... 113-112
~TOR ASSY,WINCH •..•...................•............•••........•••. 114-110
WINCH MOTOR •..•••.••••..............•••............................ 115-114
ROTARY GROUP,WINCH MOTOR .......•..••..........•.....•.......••••. 116-115
CONTROL VALVE,WINCH MOTOR ••.•...•.....•••.............••......... 117-115
SOLENOID VALVE,WINCH MOTOR •...........•••.............•........ 118-117
TWO-SPEED VALVE,AUTOMATIC ...••.......•••..•...........•........ 119-117
HYD LINES,WINCH .........•.••••••.•..........•...•.........•............ 134-01
VALVE ASSY,MAIN AND AUX.WINCH .•.........•••.......................... 135-134
INSTAL,CONTROL, AUX.WINCH .............•.........••••...•................ 143-01
SWING-LOCK ASSY,SINGLE POSITION .......•.•......•..•.•...•..........••.. 161-01
SWING-LOCK ASSY,MULTI POSITION ..•.....•..•••............•.•............ 163-02
INSTAL, COUNTERWEIGHT (3. 6T) .•••.•.............••...............•........ 191-01
INSTAL,COUNTERWEIGHT(4.1T) ...........•...........•...••.............••. 192-02
INSTAL, COUNTERWEIGHT (REMOVABLE) .............•................•......... 193-03

. POWER-PLANT SELECTION
POWER PLANT ASSSY(CAT) ....................................•.•.......... 201-01
ENGINE AND TRANSMISSION GROUP(CAT) •.........•...................•.•.. 202-201
TRANSMISSION,CARRIER(SHIFT SYSTEM,AIR) ............................ . 203-202
TRANSMISSION,CARRIER(SHIFT TOWER) ................................. . 204-202
003-11-2®
 CONTENTS
DESCRIPTION PAGE. No.
--------------------------------------- ----
TRANSMISSION,CARRIER(SHIFT HOUSING,BARS AND YOKES) .......•......... 205-202
TRANSMISSION,CARRIER(MAIN CASE AND CLUTCH HOUSING) ..........••..... 206-202
TRANSMISSION,CARRIER(INPUT AND MAIN SHAFTS) ••••••...•••••........•. 207-202
TRANSMISSION,CARRIER(COUNTER SHAFT AND REV. IDLER) .........•.......• 208-202
TRANSMISSION,CARRIER(DRIVE GEAR AND COUNTER SHAFTS) ......••.....••. 209-202
TRANSMISSION,CARRIER(OUTPUT SHAFT) •.••.........••••••.......••••... 210-202
TRANSMISSION,CARRIER(CYLINDER,RANGE, INTERMEDIATE) .........••....... 211-202
POWER PLANT ASSY(GM) ••••••••..........••...••••............•••••......• 251-01
ENGINE AND TRANSMISSION GROUP(GM) ...•••••.•....•.......•..••......••• 252-251
CYLINDER ASSY,AIR .....•••••••••..........•.•.................•••••. 270-252
VALVE ASSY,BOOSTER .•....•..••••••........•••••..•..•............••. 271-252
PUMP, STEERING (GM) .......••.•...•••••.......................•....... 272-252
PUMP, STEERING (CAT) •.•.•............•....•.•••................•••••. 273-202
SHEET METAL ASSY ••..................••••••..•..................•••••.•• 282-01
INSTAL,CLEANER, AIR (CAT) .............••..•.••.........•...••...••..•.... 283-01
INSTAL,CLEANER,AIR(GM) ........••••••.•...•......•.•••••.•.............. 283-02
INSTAL, MUFFLER (CAT) ••.••••....•.......•.•...••••................••..••. 284-01
INSTAL, MUFFLER (GM) ................••••.••................••.•.......... 284-02

. LOWER SELECTION
CONTROL ASSY,LOWER(CAT) .....•.................•.••...............•..... 300-01
CONTROL ASSY,LOWER(GM) ...••.••.•••.••....•......•.•..............•..... 300-02
BASE ASSY,CAB(CAT) ..••....................•.•.................••..... 301-300
BASE ASSY,CAB(GM) ••...............•..•..••.........•.•.••............ 302-300
HEATER AND DEFROSTER ASSY ...............••••••.............••.•.... 303-302
CLUTCH ASSY ........••••••••..............•••.•...............•.•••• 304-302
CYLINDER ASSY,MASTER ....•.......•••••••••.........•..•....•.•••.... 305-304
VALVE ASSY,AIR •.•..........•.....••••••......•..•.••••.••••........ 306-302
STEERING ASSY .......••••••••.•.•...........•••••..••....•......•... 307-302
VALVE ASSY,CONTROL,2WAY •....•.••........•.••.................•.•••. 308-302
DASH ASSY,LOWER .••••.•................•••.••...............•••.•... 309-302
VALVE ASSY,AIR ..•..............•••.•••••.......•....•.•..•......... 310-302
PANEL ASSY ..........•.•••••••••.••..•....••••.•.......•............ 311-302
CONTROL ASSY,PTO .•.•••••••.•••..•••••......••••...............•..•.•. 312-300
COLUMN, STEERING ••••••....•................•................•..•..•• 313-307
SHIFTER, TRANSMISSION •••••••••••••......•.•.•••...•................. 314-302
TIRE AND WHEEL ASSY,F/15 ••••....•.........•••....................•••••. 351-01
TIRE AND WHEEL ASSY,F/16.5 ............••••.••........•......•....••..•. 352-01
INSTAL, STAB IRIZER •••.•••.••••••.•••.........••.••.•••....•............. 361-01
STABIRIZER ASSY,FRONT ••.....................•••••••..••.••••.......•. 362-361
CYLINDER ASSY,VERTICAL ..............•.....•••.....•••..•••......... 363-362
VALVE SOLENOID ...........................•.•••..•....•............. 365-362
BOX ASSY,CONTROL ••••..••.•...•.•...•.••••.•..••.•.................... 368-361
ACCESSORIES ASSY,AIR(DRYER AND INFLATION) ••.•••...•..............•.•... 381-01
ACCESSORIES ASSY,AIR(DRYER AND INFLATION) ..........••••.•••............ 381-01A
ACCESSORIES ASSY,AIR(DRYER) ......•....•....•••.•••..................... 382-02
ACCESSORIES ASSY,AIR(DRYER) ...•..•••.•...........•..•••.•••...••...••.. 382-02A
ACCESSORIES ASSY,AIR(INFLATION) .................•••.........•.•........ 383-03.
ACCESSORIES ASSY,AIR(INFLATION) ..............•..............•.•........ 383-03A
ACCESSORIES ASSY,AIR(NO OPTION) ...........•.••..........••.•.•......... 384-04
ACCESSORIES ASSY,AIR(NO OPTION) ...........•••.......................... 384-04A
DRYER, AIR ..•....••....•.•.•••.....•................................•. 387-381

003-11-3®
 CONTENTS
DESCRIPTION PAGE. No.
· ATTACHI1ENT SELECTION
INSTAL,BOOI1,110' ....................................................... 401-01
BOOI1 ASSY,110' .........................•...............•..•.......... 403-401
CYLINDER ASSY,TELESCOPE-LOWER ...........•..••......•.••.•......•... 404-403
CYLINDER ASSY,TELESCOPE-UPPER .......•..................•.•......... 406-403
BLOCK ASSY,SHEAVE ......••..........•............................... 408-403
ROLLER ASSY,GUIDE .......••................•..•..............•........ 409-403
REDUCER ASSY ............•...............••.•.•........•......•..... 410-403
POINT ASSY,Bool1 •...........•......................................... 411-403
VALVE ASSY,FLOW DIVIDER •..•...•..•................................... 412-403
INSTAL,CYLINDER,BOOI1 HOIST WO/E.R .....•••.............................. 505-02
CYLINDER ASSY,BOOI1 HOIST ....................................•.•...... 506-505

· TRADEI1ARKS AND OTHERS

DECAL ASSY,TRADEI1ARKS AND NAnEPLATES(llO') ............................. 601-01
TOOL ASSY ••....•..........••......•••...•.............................. 611-01
JUSTIN CASE ..............................•............................. 612-01

· UPPER AND LOWER OPT IONS

INDICATOR,DRUI1 TURN ...•••.•...•.•••.•.•..•............•......• ~........ 708-01
INDICATOR,DRUM TURN .........................•..••.....•.•............ 709-708
ROLLER ASSY,DRUM(I1AIN AND AUX.HINCH 1581) .......•.....•................. 713-01
INSTAL, PINTLE HOOK .........................••.•.•.••....•.....•..•..... 715-01
INSTAL, FLOOD LIGHT ........................•••..•......•................ 719-01
TACHO METER •...•.........•..•......•......•..•••••.•.••....••••..•.•••.. 721-01
BATTERY ••............•.•....•.........•..•••...•••...••......•..•...•... 722-01
ALARI1,BACK UP ASSY ............•••..•...•.•.......•....•.............••. 723-01
OPTIONS ON CAB ••..•...•.........••...••..•............................. 730-01

· ATTACHI1ENT OPTIONS
EXTENSION ASSY,35' H!STORAGE CRANK PINS •............................... 811-01
EXTENSION ASSY,35' H!OFF SET STORAGE CRANK PINS ••.......••...•........• 813-02
INSTAL, OFF SET FOR CRANK PINS HITH SPLIT HOUSING .......•............. 814-813
EXTENSION ASSY,35'-60' W!STORAGE H.H CRANK PINS .•••.....•...........•.. 821-01
EXTENSION ASSY,35'-60' H!OFF SET STORAGE CRANK PINS .•.................. 824-02
EXTENSION ASSY,35'-60' STORAGE HARDWARE ......•••••.•.....•..•....•..•.. 831-01
INSTAL OFF SET FOR DRIVE PINS REPLACING SOLID HOUSING .................. 833-02
INSTAL, HOOK &WIRE ROPE .•.••..••......•...•...•........................ 835-01
SHEAVE ASSY,AUX. ...•...............•..•.•...••...••.................... 841-01

003-11-4@
 I NSTAL,CONTROL
TG-OOO 1-
241 OOJ 9045F 1

LEVER OF THROTTL VALVE

30-1
1-
'~32
30

35~
36~
38~~
25
,I!

33

FI G 11-01-1 <D (03)

 I NSTAL,CONTROL
241 OOJ 9045F 1 TG-0001-

THROTTLE

\ A

)
3

:~
34~
10~
B

03) \- - - - - c --.J FIG 11-01-2(j)

 I NSTAL,CONTROL TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY· APPLICABLE .,,:,', ~",

24100J9M5 F1

1 24100J8848F2 CAB ASSY, OPERATORS P. 12-11 1

2 2416N4662 BRACKET 1
3 2416P1027301 BRACKET 1
4 2416P1027302 BRACKET 1
5 2416P10274 BRACKET 1
6 2406T2140 YOKE 3
7 ZJ11F06042 YOKE 1
8 ZP45X12032 PIN 3
9 ZP45X08025 PIN 1
10 ZP15003022 PIN 3
11 ZP15K02015 COTTER PIN 1
12 2416T15050 BRACKET 1
13 2416T13850 BLOCK 1
14 2416T15054 WIRE, LOCK 1
15 2432T1393 CLAMP 1
16 2418R325 WASHER 4
17 2416R299 RUBBER 4
18 2418T15570 SPACER 4
24 ZC45X29011 CLIP 3
25 ZC45X12011 CLIP 1
26 2479T13200212 JUMPER 1
27 2432Z29004 wIRE TIE 6
28 ZS18C20050 CAPSCREW 8
29 ZW16H20000 WASHER 8
30 ZS18C16110 CAPSCREW 4
31 ZN78C16023 NUT 4
32 ZW16H16000 WASHER 4
33 2416N4343 BRACKET 1
34 ZW16X12000 WASHER 3
35 ZN18C10008 NUT 11
36 zw26X10000 LOCK WASHER 12
38 2418T5373C2 WASHER 6
40 ZS18C06035 BOLT 1
41 ZS18C06020 BOLT 2
42 ZN18C06005 NUT 4
43 ZW26X06000 LOCK WASHER 3
44 ZS31C05014 MACHINESCREW 2
45 ZW26X05000 LOCKWASHER 2
47 ZW16X10000 wASHER 2
48 ZS18C10016 CAPSCREW 1
49 ZH31M08008 ELBOw 1
50 ZH31M06006 ELBOW, 90 1
51 ZW16X16000 WASHER 2
52 ZW16X06000 WASHER 2
53 ZNl6C05004 NUT 2
54 ZW16X05000 WASHER 2
55 ZW16X08000 WASHER 1
56 ZE72X06000 PLUG 2
57 2420T583501 SHIM 2
58 2420T583502 SHIM 2

11-01-1 <D (03)

 TG.0001-- I NSTAL,CONTROL

ITEM PART.NO OESCR I PTI ON REMARKS &TY APPLICABLE

59 ZS18C06014 CAPSCREw 1

(03) 11-01-2 CD
 CAB ASSY,OPERATORS
TG-OOO 1....... 241 OOJ 8848F2

37-11

,,------ B ---~)

\.'-------- A --------/
FIG 12-11-1(D (03)
 CAB ASSY, OPERATORS
CAB ASSy,OPERATORS TG.0001--

ITEM PART.NO DESCRIPTION REMARKS <ilTY APPLICABLE

24100J8848F2 CAB ASSY, OPERATORS

2 2416J1310 DECK 1
4 2416P9591 BRACKET 1
5 2416J1304 CONSOLE, SIDE 1
1 ·2406P3303 PEDAL 1
8 2406P3304 PEDAL 1
9 . 2416P9885 BRACKET 1
10 2406P3164 PEDAL 1
11 2416P9963 BRACKET 1
12 2406T2214 YOKE 1
13 2406T2206 YOKE 1
14 2416T15156 BLOCK 2
15 2420T5209D3 BOLT 4 :
16 2416P9058 BRACKET 2
18 2416Tl3859 BRACKET 4
19 2414T3184 COvER 1
20 2414T3185 COVER 1
21 2414T3186 COVER 1
22 2416T13840 BRACKET 1
24 2414T3181 COVER 1
25 2414T3188 COVER 1
28 2416T13844 BRACKET 2
29 2416Tl5314 BRACKET 2
30 2430R121D8 CABLE ASSY, CONTROL 1
31 2432P1310 NAME-PLATE 1
32 2436U1416F2 VALVE ASSY' RELIEF P. 20-12 1
33 2436U1631F1 VALVE P. 21-12 1
34 24100J9043F1 PANEL ASSY, CONTROL P. 18-12 1
35 2414T3189 COVER 2
36 2414T3190 COVER 1
37 2448U131F1 SEAT ASSy 1
31-1 2448U131S1 CUSHION 1
31-2 2448U131S2 HEADREST 1
31-11 2448U131S11 CUSHION, BACK 1
42 2448U122F1 SUSPENSION DEVICE 1
43 2421P2373 TANK, AIR 1
44 2436U1612F1 VALVE 1
45 R38POO09D2 VALVE 1
46 2420T2211D10 U-BOLT 1
41 2420R312D124 GROMMET 1
48 2419R838F2 SWITCH ASSY 1
49 24100J8935F2 PANEL ASSY, FRONT P. 11-12 1
51 24100P1418F2 BRACKET, SW ITCH 1
52 2419u240F1 HORN ASSy 1
53 2419U240F2 HORN 1
54 2416Tl5101 BRACKET 1
55 ZP16D04022 PIN 1
59 2420R372D122 GROMMET 1
60 2416T4189 PAD, RUBBER 3
62 ZR16X01800 RING, SNAP 4
63 2405U101D1820 BUSHING 4

(03) 12-11-1 CD
 CAB ASSY,OPERATORS
241 OOJ 8848F2 T G-OOO 1-

~92

60
~ 35

"-- - - C----~.//
03) FIG 12 -11-2Q)
 CAB ASSy, OPERATORS
TG.OU01-- CAB ASSY,OPERATORS

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLICABLE

64 ZP45X12030 PIN 1
65 2420R429D5 GROMMET 1
61 2438U1296F2 CYLINDER, MASTER P. 24-12 1
69 24~8T15898 PLATE 1
10 2418T15911 PLATE 1
71 2414T3521 COVER 1
72 ZP~5X08021 PIN 1
13 24~8T16194 PLATE 1
14 ZP~6K02015 PIN 1
15 2416Z218D33 RUBBER 1
16 24~4T3136 COVER 1
11 2489R380 LEVEL ASSY 1
18 2416Z236 RUBBER 1
19 2432Z290D1 CLIP 1
84 ZW~6K18000 WASHER 4
85 ZW~6H08000 WASHER 1
86 20~5VOO3 NUT 1
88 ZS~8C10080 BOLT 2
89 ZS~8C081l0 BOLT 4
90 ZS18C10065 CAPSCREW 6
92 ZM;lC06016 CAPSCREW 18
94 ZM;lC10025 SEMS-BOLT 1
95 ZM~lC10020 SEMS-BOLT 1
96 ZM;lC08020 BOLT 14
91 ZS18C08030 CAPSCREW 4
98 ZN18C12010 NUT 4
99 ZM11C10030 SEMS-BOLT 3
100 24~OOJ8616F6 LEVER ASSY, CONTROL P. 14-12 1
10~ 24~OOJ8616F1 LEVER ASSY, CONTROL P. 1~-12 1
102 24~OOJ8616F8 LEVER ASSY, CONTROL P. 13-12 1
103 24;OOJ8616Fl0 LEVER ASSY, CONTROL P. 15-12 1
104 24~OT5549D6 MACHI NSCREW 21
105 24~8T14259D2 WASHER 21
106 ZS31C06045 MACHINESCREW 3
101 ZS31C05010 MACHINESCREW 4
108 ZN16C05004 NUT 4
109 ZS31C06012 SCREW 1
110 ZN~8C10008 NUT 23
111 ZW26X10000 LOCK WASHER 5
113 ZW16Hl0000 WASHER 22
115 2416Z218D34 RUBBER 1
116 ZW26X08000 LOCK WASHER 4
111 ZN18C08001 NUT 14
118 ZW16X06000 WASHER 4
119 ZN45C08015 NUT 8
120 ZW16X08000 WASHER 4
121 ZW26X06000 LOCK WASHER 4
122 ZN16C06005 NUT 3
123 ZW26X05000 LOCK WASHER 4
124 ZW16K05000 WASHER 4
125 ZG22E08000 NIPPLE 1
121 ZH31K08008 ELBOW 1
128 ZH21K04004 CONNECTOR 2
129 ZH31K04002 ELBOW 1

(03)
 CAB ASSV.OPERATORS
TG-OOO 1---
24100J8848F2

51-6
&bf 51-1

~
51-5

'JI'i
.
_. I.
51-7
51-4

100
(CI~@
~ 48

8'-/
\.---------- 0 --------) "-- - - - - - - E - - - - - - - - - - )

75

30

'--~=----=~------ F --------)

FIG 12-11-3
(03)
 CAB ASSY, OPERATORS
CAB ASSy,OPERATORS TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

130 ZH31K04004 ELBOW 1

131 ZH311C.06004 ELBOW 1
132 ZG52U08000 TEE 1
131 ZG21B08004 CONNECTOR 1
139 ZX15K06135 TUBE 1
142 ZX15K04230 TUBE 1
143 ZX15K04090 TUBE, NYLON 1
141 ZX15K08255 TUBE, NYLON 1
148 2420R189D13 GROMMET 2
149 ZC45X12011 CLIP 2
151 2432Z220D15 CLAMP 2
201 2401U12 SEAT BELT(OPTION) 1

'~,'

(03)
12-11-3 CD
 CONTROL LEVER ASSY. BOOM HOIST
TO-0001 - 24100 J 8676 F8
TG-0001 -

FIG 13-12-1
 LEVER ASSY, CONTROL
HOIST TG.0001--

ITEM PART.NO DESCRIPTION REMARJ<S 6lTy APPLICABLE

24100J8676 F8 LEVER ASSY, CONTROL

1 2406P2397 BALL, LEVER 1

3 2406P3731 LEVER 1
6 2416N4373 BRACKET 1
7 2445T146 BOOT 1
8 2416T14487D2 BRACKET 2
'I 2406T2223 YOKE 2
10 ZP45X06025 PIN 2
11 ZW16X06000 WASHER 2
12 ZP16K01614 PIN 2
13 2405U105D1210 BUSHING 2
14 2418T15682 WASHER 1
15 ZN18C08007 NUT 1
16 ZS31C04008 MACHINESCREW 4
17 ZW26X04000 LOCK WASHER 4
23 2406R296D125 CABLE, CONTROL 1
:l6 2406R296D305 CABLE, CONTROL 1

1)-12-1
 CONTROL LEVER ASSY, WI NCH
TD-OOO' ...., 24100J8676F6
TG-OOO' ~

FIG 14-12-1
 LEVER ASSY, CONTROL
WINCH TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100J8676F6 LEVER ASSY, CONTROL

1 2406P2397 BALL, LEVER 1

2 2406P3730 LEVER 1
5 2416N4372 BRACKET 1
7 2445Tl46 BOOT 1
8 2416Tl4487D2 BRACKET 2
9 2406T2223 YOKE 1
10 ZP45X06025 PIN 1
11 ZW16X06000 WASHER 1
12 ZP16K01614 PIN 1
13 2405U105D1210 BUSHING 2
14 2418Tl5682 WASHER 1
15 ZN18C08007 NUT 1
16 ZS31C04008 MACHINESCREw 4
17 ZW26X04000 LOCK WASHER 4
24 2406R296D335 CABLE, CONTROL 1

14-12-1
 CONTROL LEVER ASSV, SWI NG
TG-0001 '" 24100J8676F10

FIG 15-12-1
 LEvER ASSY, CONTROL
SWING TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTY APPLICABLE

24100J8676F10 LEVER ASSY, CONTROL

2 2406P3730 LEVER 1
5 2416N4372 BRACKET 1
7 2445T146 BOOT 1
8 2416T14487D2 BRACKET 2
9 2406T2223 YOKE 1
10 ZP45x06025 PIN 1
11 Z.W16X06000 WASHER 1
12 ZP16K01614 PIN 1
13 2405U105D1210 BUSHING 2
14 2418T15682 wASHER 1
15 ZN18C08007 NUT 1
16 l.S31C04008 MACHINESCREw 4
17 ZW26X04000 LOCK WASHER 4
28 2406P2398D3 GRIP 1
29 2406R307D1 CABLE, CO~HROL 1

15-12-1
 CONTROL LEVER ASSY, BOOM TELE.
TO-0001 '" 24100J8676F7
TG-0001 ......

25

FIG 16-12-1
 LEVER ASSY, CONTROL
TELESCOPE TG.0001--

ITEM PART.NO OESCR I PTI ON REMARKS &TY APPLICABLE

24100J8676F7 LEVER ASSY, CONTROL

1 2406P2397 BALL, LEVER 1

2 2406P3730 LEVER 1
5 2416N4372 BRACKET 1
7 2445T146 BOOT 1
8 2416T1448702 BRACKET 2
9 2406T2223 YOKE 1
10 lP45X06025 PIN 1
11 lW16X06000 WASHER 1
12 lP16K01614 PIN 1
13 2405u10501210 BUSHING 2
14 2418T15682 WASHER 1
15 lN18C08007 NUT 1
16 lS31C04008 MACHINESCREW 4
17 lW26X04000 LOCK WASHER 4
25 2406R2960332 CABLE, CONTROL 1

16-12-1
 TH-0001",,""-
TG-0001-. PANEL ASSV CONTROL,FRONT
241 0 0J8935F2

21
/ 17

~
15

14

16

FIG 17-12-1

( 04)
 PANEL ASSY, FRONT
FRONT TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IilTY . APPLICABLE

24100J8935F2 PANEL ASSY, FRONT

1 2479N425 PANEL, FRONT 1

3 2489U179F1 GAUGE, AIR PRESS 1
4 891il80 GAUGE,HYD OIL TEMP 1
5 . 2489U191 GAUGE,FUEL 1
6 2418T15963 PLATE 2
7 . 2489u189 GAUGE,E/G OIL PRES 1
8 2489U190 GAUGE,E/G COOL TEM 1
9 2479U636 VOLT METER 1
10 2479R610 SWITCH, STARTER 1
11 R79P0060F3 LAMP, SIGNAL 2
11-1 R79T0048D7 BULB, LIGHT 1
12 2420Z6~6D1 GROMMET 1
13 2420R429D1 GROMMET 2
14 2420R429D15 GROMMET 6
15 2420R429D16 GROMMET 3
16 2479J269. HARNESS, WIRING 1
17 4079Z22 RELAY, HORN 1
18 2479Z1178 BUZZER 1
19 791il760D1 SWITCH 1
20 2416N4569 BRACKET 1
21 ZS31C06016 SCREw 1
22 ZS31C05012 MACHINESCREW 5
23 ZS31C04020 SCREW 2
24 ZS31C04012 MACH I NESCREw 3
26 ZN16C06005 NUT 1
27 ZN16C05004 NUT 5
?8 ZN16C04003 NUT 5
30 ZW26X06000 LOCK WASHER 1
31 ZW26X05000 LOCK WASHER 5
32 ZW26X04000 LOCK WASHER 5
33 3487Z3902 CLIP,HOSE 4
35 2479N426 HARNESS, WIRING 1
36 2479N427 HARNESS, WIRING 1
37 2479N428 HARNESS, WIRING 1

(04) 17-12-1 CD
 PANEL ASSY,CONTROL, SIDE
TG-OOO 1 - 24100J9043Fl

11
6

FIG 18-12-1<D (0 I)
 PANEL ASSY, CONTROL
SIDE TG.0001--

ITEM PART. NO DESCRIPTION REMARKS 6lTY APPLICABLE

24100J9043F1 PANEL ASSY, CONTROL

1 2479N432 PANEL, CONTROL, SIDE 1

2 796l760D11 SW,OUTRIGGER CONTR 8
3-1 796l760D1 SW,OUTRIGGER MASTE 1
3-1A· 796l760D1 SW,DEFROSTER 1
3-1B 796l76DD1 SW,MANUAL EXTENSIO 1
4 R79P0060F1 LAMP, SIGNAL 1
5 2420R429D15 GROMMET 1
6 2479J282 WIRING HARNESS 1
7 2479N332 WIRE HARNESS 1
8 2479N333 WIRE HARNESS 1
9 2479N334 WIRE HARNESS 1
10 R79POO07F2 LIGHT, PANEL 1
11 3487Z39D2 CLlP,HOSE 1

(Ol) 18-12-1 <D

 VALVE ASSY. RELEASE
TE-OOOI,,-- 2436UI476F2
TH - 0001.......,
TO - 00 01"'-'
- 00 01-
TG _ 00 01-
i~-0001--

"
2

o 6
o

B.9

11

----7

10

FIG 20 -12 -I (01)

 VALVE, RELEASE <SWING BRAKE) TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IilTy APPLICABLE

2436U1476F2

1 O-RING 2
2 VALVE, CHECK 1
3 2436U1476S3 SPRING 1
4 2436U1476S4 PLUG 1
5 ZD12P01500 O-RING 1
6 SHAFT 1
7 CRANK 1
8 ZDl1P01090 O-RING 2
9 ZD95P01090 RING, BACK-UP 2
10 2436U1476S10 LEVER 1
11 ZP26D03014 SPRING PIN 1
2436U1476Rll0 REPAIR KIT 1
CONSISTS OF ITEM 5, 8, 9

(01)
 VALVE ASSY • THROll LE
TE-OOO 1 2436U1631Fl
TH-OOO 1::-
TO-0001 ......
TG -000''''''''

33

32

22 ~ _ _ _ 24

~
16~

:~
12 _ _

13 I
,:-1
11
-0

FIG 21-12-1
(on
 VALVE
TG.0001--

ITEM PART.NO DESCRIPTION REMARIf.S 6lTY . APPLICABLE

2436U1631Fl VALVE

1 BODY 1
2 2436U1631S2 CAP, VALVE 1
3 2436U1631S3 VALVE ASSY 1
4 2436U1631S4 SPRING 1
5 2436U1631S5 GUIDE, VALVE 1
6 2436U1631S6 VALVE 1
7 2436U1631S7 O-RING 1
8 2436U1631S8 SPRING 1
9 PISTON 1
10 2436U1631S10 O-RING 1
11 2436U800S3 O-RING 1
12 2436U1631S12 SPRING 1
13 2436U1631S13 SPRING 1
14 2436U1631S14 SEAT, SPRING 1
15 ZW16P06000 WASHER 1
16 2436U1631S16 BOLT 1
17 2436U1631S17 SEMS-BOLT 1
18 2436U1631S18 DIAPHRAGM 1
19 2436U690S41 WASHER 1
20 2415R157S26 LOCK WASHER 1
21 2436U690S42 SCREW, TAPPING 1
22 PLATE, MTG 1
23 2436U1631S23 BUSHING 1
24 2436U1631S24 BUSHING 2
25 2436U1631S25 PLUNGER 1
26 2436U1119S26 BOOT 1
27 2436U1631S27 PEDAL 1
28 2436U1631S28 BOSS 1
29 2436U1631S29 BOOT 1
30 2436U1119S29 PIN 1
31 2436U1631S31 PIN 1
32 2436U1631S32 LEVER 1
33 2436U1631S33 PIN 1
34 2436U1119S30 PIN 1
35 2436U1119S31 ROLLER 1
36 2436Ul119S32 PIPE 1
37 2436U804S33 PIN 2
38 2436U1631S38 SETSCREW 1
39 2436U804S35 NUT 1
40 2436U690S55 SEMS-BOLT 3

2436U1631Rl02 1
CONSISTS OF ITEM 2, 3, 4, 5, 6
7, 10, 11, 18, 26

(01) 21-12-1 CD
 CYLINDER ASSY. MASTER
TE-0001- 2438U1296F2
TH-0001-
TG-0001-

FIG 24-12-1
 CYLINDER, M~STER
SWING BRAKE TG.0001--

ITEM PART~NO DESCRIPTION REMARKS (ilTY APPLICABLE

2438U1296F2 CYLINDER, M~STER

1 CYLINDER 1
2 2445Z8 SPRING 1
3 PISTON&CUP ASSY 1
4 2429Z8 STOPPER 1
5 2418Z30 RING 1
6 RING, GASKET 1
1 2438U1296S1 ROD ASSY, PUSH 1
8 2438U1296S8 RING,STOP 1
9 BOOT 1
10 2438U1250S10 CAP ASSY, FILLER 1
11 2438U1250S11 O-RING 1
13 20Z63 BOLT, CONNECTOR 1
14 GASKET 1
15 GASKET 1
16 2444Z1290 SCREW,BLEEDER 1
11 20Z31 CAP, BLEEDER J.
18 2425Z252 BALL 1
2438U1296RllO REPAIR KIT 1
CONSiSTS OF ITEM 3, 6, 9, 14, 15

(OJ) 24-12-1 CD
 INSTAL,REOUCT, SWING
TE-0001,,--, 24100J8733F2
TH-0001'"'-'
TO-0001"'-"
TG-0001'"'-'

3-4
3-5

3-6

3 -7

3 3-3 ---1\,0

FRAME UPP

FIG 26-01-1
(03)
 INSTAL, REDUCT, SWIN
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS QTy APPLICABLE

24100J8133F2 INSTAL, REDUCT, SWIN

2 ZS23C20060 CAPSCREw 10
3 24100N4536F3 REDUCTION ASSY,SWING 1
3-3 24100J8134F3 REDUCTION UNIT P. 21-26 1
3-4 2441U854F1 MOTOR P. 28-26 1
3-5 ZS18C12030 CAPSCREW 2
3-6 2420R502Dl DIPSTICK 1
3-7 2420T4039D12 PIPE 1

(03) 26-01-1
 REOU CT ION UNIT
TE-0001-- 24100J8734F3
TH - 000 1 ......,
TO-0001""
TG-0001-v

72
70
*
84

79

10 ----J}=---~

19-----0 11iIrinII_ _ _
14---© 78

::=i! s ,---80

'4~'~_81

14---..j13:-Q
16---tl'i=;:;i'lI
A=::
83
15--."..,~

14--""- '-oN

FIG 27 -26 -1 CD (05)

 REDUCTION UNIT
24100J87 34F3 f~~ goo 1 __
001......"
TO - 000'
TG - 000''::::

48

43
26

67 38
39

63

23
41
22
-40
42 52

54
69
20 53
77

I
* ~

(05) FIG 27-26-2(1)

 REDUCTION UNIT
SWING TG.0001--

ITEM PART.NO DESCRIPTION REMARI(S GlTy . APPLICABLE

24100J8734F3 REDUCTION UNIT

1 2401N618 SHAFT, PINION 1

2 ZOllG09500 O-RING 1
3 2418T14545 SLEEVE 1
4 Z021T17000 OIL-SEAL 1
5 2418R5075 RING, SNAP 1
6 2425H90 BEARING, ROLLER 1
7 ZS83C20020 BOLT 2
8 2418T13612 SPACER 1
9 25Z494011 BEARING, ROLLER 1
10 ZR16X08500 RING, SNAP 1
11 ZS23C08014 CAPSCREW 8
12 2418T9848 PLATE, LOCI( 4
13 SHAFT 1
14 PLATE' THRUST 2
15 PINION 1
16 BEARING, NEEDLE 2
17 PI.NION 3
18 BEARING, NEEDL!; 3
19 RING, SNAP 3
20 R25P0045D2 BEARING 2
21 ZS18C12030 CAPSCREW :;3
22 R25P004503 BEARING 1
23 2420T5922D1 SHIM 0.1 1
23-1 2420T5922D2 SHIM 0.2 1
23-2 2420T5922D3 SHIM 0.3 1
23-3 2420T5922D4 SHIM 0.4 1
24 2418T4~8703 NIPPLE, PIPE 1
25 Z~91T12000 CAP 1
26 ZR26X01900 RING, SNAP 1
27 ZG31B04000 ELBOW 1
28 ZR26X07200 RING, SNAP 1
29 2438R7S16 SCREW, BLEEDER 1
30 2418T15737 PIPE 1
31 ZE72X04000 PLUG 1
32 2417T630 SPRING 6
33 2420T5944Dl SHIM 0.1 1
33-1 2420T5944D2 SHIM 0.2 1
33-2 2420T5944D3 SHIM 0.3 1
34 ZS18C12040 CAPSCREW 4
37 ZS18C14035 BOLT 12
38 21t15Z269 PLATE 4
39 2415Z268 DISI( 3
40 2418T15794 PLATE 1
41 ZS23C08020 CAPSCREW 6
42 2401P1029 PINION 1
43 2418N2901 COUPLING 1
44 ZD21T03500 OIL-SEAL 1
45 2417T629 SPRING 16
46 2439P256 PISTON 1
47 45Z91D74 O-RING 1

27-26-1 CD {OS>
 REOUCTl ON UN IT
TG.0001-- SWING

ITEM PART.NO DESCRIPTION REMARKS (ilTY - APPL I CABLE

,.8 2,.,.5Z106101 RING, BACK-UP 1

,.9 "5Z91091 O-RING ~
50 2"~5Z106102 RING, BACK-UP 1
51 2,.1"N3336 COVER 1
52 2,.39P255 PISTON 1
53 ZO~lGHOOQ O~RING 1
5" ZO~5GHOOO RING, BACK-UP 1
55 - ZO!lG12500 O-RING 1
56 Z085G12500 RING 1
57 - ZE82T02000 PLiJG 2
58 ZN51F06000 NUT 1
59 ZW~lB06000 WASHER 1
60 ZR26X06200 RING, SNAP 1
61 2,.20T592101 SHIM 0.1 1
61-1 2~~OT592102 SHIM 0.2 1
61-2 2"~OT592103 SHIM 0.3 1
61-3 2,.20T59210" SHIM ".0 1
62 2,.38J185 CYLINDER 1
63 2,.1,.J1722 HOUSING 1
65 ZE82T08000 PLUG 1
67 ZE82TO,.000 PLUG 1
68 2,.18Tl5736 SPACER 1
69 2"0~Pl030 - GEAR 1
70 ZS23C1U30 CAPSCREW 10
7~ 2"~8T7H3 SPACER 1
72 2"~"Jl536 HOUSING 1
73 ZE82Tl2000 PLUG 1
H 2~18PH8"3 RETAINER 1
75 ZS23C08030 CAPSCREW 12
77 R25P0035D6 BEARING 1
78 2~01pl031 PINION 1
79- 2,.01N632 GEAR, RING 1
80 2"~8TH525 SPACER 1
81 SPIDER ASSY 1
82 2~01Pl003 GEAR, SUN 1
83 2,.13J519 SPIDER 1
8~ 2"~8N308" RETAINER 1
2,.100J873,.Rl00 SPIDER ASSY 1
CONSISTS OF ITI;M 1~' 17, 18, 19, 81
2,.100J873"RllO KIT, PINION ~

CONSISTS OF ITEM 13, 1'" 15, 16

(ot) 27-26-2 <D

 TE-O OO, ........
TH-O OO, .......
TO ~OOO 1.......
TG -000 1_ MOTOR .SWING
2441U854Fl

9 11
8 2
 MOTOR ASSY, SWING
TG.0001--

ITEM PART.NO DESCRIPTION REMARI<S (ilTY " APPLICABLE

2441U854F1 MOTOR ASSY, SWiNG TG.0001

1 2441U854S1 CAp, END 1

2 2441U854S? SHAFT 1
3 SEAL 1
4 RING 1
5 ROTOR 1
6 2441U854S6 PLATE 1
7 SEAL 1
8 2441U854S8 RING 1
9 SEAL, SHAFT 1
10 HOUSING 1
11 SEAL 1
12 SEAL 1
13 SPRING 30
14 VANE 10
15 PIN 2
16 2441U854S16 BEARING, NEEDLE 1
21 2441U854S21 SCREw 4
23 2441U854S23 SCREW 1
24 2441U854S24 ADAPTER 1
25 2441U854S25 BALL 1
2441U854R100 REPAIR KIT 1
CONSISTS OF ITEM 4, 5, 13, 14, 15
2441U854RllO REPAIR KIT 1
CONSISTS OF ITEM" 3, 7, 9, 11, 12

(D1)
28-26-1CD
 INSTAL, Upp
TG-OO 01 '" 24100J8584F4

U-4 2

FRAME, LOW

FIG 29 - 01 - 1 CD (03)
 INSTAL, UPP
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (HY APPLICABLE

24100J85HF4 INSTAL, UPP

1 ZS13C30150 BOLT 32
2 ZW13H30000 WASHER 6
3 2420T5465D1 BOLT 2
4 ZS13C30190 SCREw 2
5 ZN13C30024 NUT 4
6 ZS18C16065 CAPSCREW 2
8 2406R298D7 ROO-END 2
9 ZN18C16013 NUT 'I
10 2'106T2191D2 ROO 1
101 2422J2423 FRAME, UPPER 1

COl)
 INSTAL,CAB
TE-OOOI,",", 24100 J9286F3, Fl.. F5. F6
TH-0001~
TO-0001"",
TH - 000 1 '"'"'

I
13

3,14

FI G 31-01-16) (01)
 INSTAL. CAB
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY . APPL I CABLE

24100J9286F4 INSTAL. CAB

4 2418T5313C2 WASHER ~2
5 ZN35C10010 NUT 6
6 2418T13201 PLATE 1
1 ' ZS18C10025 CAPSCREW 6
8 ZW26X10000 LOCK WASHER 6
9 2420T5422D~ SHIM 1.2 4
~O 2421T1220 PACKING 2
13 ZMllC06012 BOLT ~3
14 2421U495 MAT. FLOOR 1
15 2420T5422D2 SHIM 2.3 6
21 ZW16X06000 WASHER 3
25 24100J1628F5 CAB ASSY P. 32-31 1
26 2414N3431 COVER 1
21 2414P5632 COVER 1
28 2416Z218D19 CHANNEL, RUBBER 1

(01)
 CAB ASSy
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

51 2427Z712D6 SHEET, RUBBER 1

52 2420R429D17 GROMMET 1
53 2420R429D5 GROMMET 2
54 2479N352 WIRE HARNESS 1
55 24100N3618F4 DOOR ASSY P. 34-32 1
56 2406T2517 GRIP 1
57 ZMllC08020 BOLT 2
58 2427J2137 CAB 1
59 2414T3777 COVER 1

32-31-2 (03)
 SASH ASSV
TE-0001 2427U286F1
TH - 0 0 0 1::::;
TO - 000 1
TG - 000 1 ~

~ 9

,~
~--/~
,/,y
/' :

/-- I
eJ "

\ ) \ )
A B

FIG 33 -32-1 (02 )

 SASH
TG.0001--

ITEM PART .NO DESCRIPTION REMARKS &Tv APPLICABLE

2421U286F1 SASH

1 2421U286S1 FRAME 1
2 2421U286'S2 FRAME 1
3 2421U286S3 WIPER 1
4 2421U286S4 GLASS 1
5 2427U286S5 CHANNEL 1
6 2427U286S6 PAD 1
7 2427U286S1 KEy 1
8 2427U286S8 BRACKET 1
9 2427U286S9 RIvET 2
10 2427U286S10 PLATE 1
11 2427U286S11 STOPPER 2
12 2427U286S12 CAPSCREW 2
13 2427U286S13 CAPSCREW 2
14 2427U286S14 GLASS 1

(02) 33-.32-1
 DOOR ASSY
TE-OOOlrv 24100N3618F4
TH- 0001 "-'
TD-0001'"oJ
TG- 0001 "-'
TA- 0001 .........
TC-0001 .........

12
/ 11

4
~cil

21

11--$
12~

Y 17

(05)
FIG 34 -32 -1
 DOOR ASSy
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ®TV APPI ICABI E

24100N3618F4 DOOR ASSY

3 2427Z693 GLASS 1
~ R27T0006D?5 CHANNEL 1
5 2406P1956 LOCK, [)OOR 1
~ ZS31C05010 MACHINESCREW ~
7 2406Z213 HANDLE 1
8 ZS83CO~006 SCREW 1
!O ZS41C04010 CAPSCREW 2
11 ZR36X00900 RING, SNAP 4
!2 R25POO09D49 BEARING 4
!4 2427P2482 ROLLER, GUIDE 1
!5 ZMllC06014 SEMS-BOLT 2
H 2479R934 PANEL 1
!8 ZW16XO~000 WASHER 2
20 2406Z436 HANDLE 1
21 2427J2135 DOOR 1

(OS)
 CAB GLASS

TE-0001-
TH-0001-..J
TO-OOO' ........
TG-OOO'~ r-7~----------~~-'~
i 20mm(0.7Si)
i
i 329.Smm(12.97z")
I
623mm{Zk.S2S'') ~I 20mm(0.781) ;lSmm(0.S91"ldia
43mm(1.693")rad 774mm(30.472")

~
100mm(3.937")

74Smm(29.33() SOmm(1.969")

~90Smm(3S.630")
\..--________ A _ _ _ _ _ _ _ _-'J

r
i
463mm(18.22S")i

r-376mm(14.s0:i\-~ \..-------------- F - - - - - - - - - - - - )

II 43mm(1.693")raa

I Smm(0.197")thick
603mm(23 740") I
Smm(0,197")thick
I I I
9S1mm(37.44()

43mm(1.693")rad

~
\ . . - - - - - - - - E -------------

!
I
7SSmm(29.724")------'

' - - - - - - - B ----------)

Smm(O.197")thick

/
43mm(1.693")rad
1
I
4S4mm(17.874")
I
I
1
r--734mm(28.898")--~
\......- - - - - D ______J

Smm(0.197")thlck

/
"-2- S6mm(2.20S")rad 2- Smm(0.197")rad /Smm(0.197")thiCk

2 -'10mm(0.394")d ia
I
S02mm(19.764") 4Qmm(1.S7S')

2- Smm(0.197 )rad 2-

~
I "I
f--479mmC18.858 )-----. ~--7S7.Smm(29.S23") - - - - _

\......___________________ C __________________________.1

FIG 35 -32-1
 CAB GLASS

NOTE
All glass, except for the roof window and windshield are
clear, tempered. The roof window is tinted 70% to 80%
green, tempered. .The windshield is clear, laminated.
All glass may be obtained locally.

35-32-1 CD
 I NSTAL, MIRROR
TH-OOOt-- 24tOOJ7967F2
TG-OOOt~

6.5 4 7.5

5.6 5

DETAI L A

FIG 36-0t-1(D (03)

 INSTAL, MIRROR
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy APPLICABLE

24100J7967F2 INSTAL, MIRROR

1 2456R156F1 MIRROR, SIDE 1

2 2456Z274 MIRROR, UNDER 1
3 2406P3280 STAY 1
4 2416T14Q04 BRACKET 1
5 ZMllC08Q20 BOLT 5
6 ZN18C08007 NUT 2
7 ZW16X080QO WASHER 2
8 2416T14005 BRACKET 1

(03)
 HY 0 LINES, SWING
TG- 0001 #"ooJ 24100J9051Fl

\ ,

1
~I--II--::::=-i-
40
38
35
29
44 -1
44
48
46
40

~~]q~=Fr--t-:-r31

20

7
9 6

56
~_-2
8
9
33--_111
11'-=411---1 9

42.59.62 61.65.68

SECTION A - A
55 58

39.51 49 9
1~ 32 .42 .4B.43~
12
13 I
24-_-.1&11
50
23----~~jc====~==~~

SECTION B -B

FIG 37-01-1CD (03 )

 TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

2UOOJ9051F1

~ 2~36U1966F2 VALVE~ CONTROL ~. 38-3? _1

~ 2'36R1226.F~ VALVE~ CHECK 1
3 243~R1062D~1 VALVE, CHECK -1
4 ZX37M16060 HOS~ ASSY 1
5 ZX37M16115 HOSE ASSy 1
~ 2~4'R~~63D2 HOSE ~SSY 1
7 2~44R1375D~ HOSE ASSY 1
8 ZX22MO~195 HOSE ~SSY 1
9 ZX2?MO~250 HOSE ASSy 1
~O ZX25M04240 HOSE ASSY 1
g ZX27MO,060 HOSE ASSy 1
;~ ZX22MO~076 HOSE, HYDR _1
P 2~20R828D3 HOSE ASSY 1
;4 244~R402D8 CONNECTOR 2
;5 2444R388D5 ADAPTER 1
~~ 2~44Z2685 ELBOW, 90 2
;8 ZH22XO~000 CONNECTOR .1
;9 ZH22XO~006 CONNEc::TOR 1
~O 2~44R389D5 ELBOW~ 90 1
21 2444R399D6 ELBOW, 90 1
~2 244~P;257 ELBOW, 90 1
~3 ZH32XO~000 ELBOW 1
~4 ZH32XO~006 ELBOW 1
~5 ZH32X04000 ELBOW 2
~6 ZH32W04000 ELBOW,- 90 1
28 244~Z27~6 T~E 1
29 ZE12X16000 CLAMP, HALF 4
30 4~&2~D; FLANGe:, SPLIT 2
3; ZC45X3801~ CLIP 2
32 ZC47X22014 CLIP 2
33 2432Z290D4 WIRE TIE 4
~~ ZS18C1~035 BOLT 3
35 2420N458D;0035 CAPSCREW 8
~~ 2420N4~8DO~035 CAPSCREW 4
37 ZW26X12000 LOCK WASHER 3
~8 ZW2~K10000 LOCKWASHER 8
39 ZW26K08000 LOCKWASHER 6
40 ZD12P03400 O-RING ~
,; 45Z91D2 a-RING 1
42 ZN18C10008 NUT 3
43 ZW16X10000 WASHER 3
~4 2UOOP2034F1 BLOCK ASSY 1
44-1 2444N182 BLOCK 1
,4-2 2420T6093 SETSCREW 1
~4-3 ZE82T02000 PLUG 1
~6 20Z?l1D48 BOLT 8
~8 ZW26Xl.OOOO LOCK WASHER ;0
49 2~44P1097 MANIFOLD 1
50 ZE72xO~OOO PLUG 3
51 2420N458D08050 CAPSCREW 2

(03) 37-01-1(D
TG.0001-- HYD LINES,SWING

ITEM PART.NO DESCRIPTION REMARKS filTY APPLiCABLE

52 2444Z2627 CONNECTOR 2
53 2444R833D1 NOSE 1
55 ZH22X06000 CONNECTOR 2
56 2444T3529 CONNECTOR 1
57 2418P17665 TUBE 1
58 ZX21M06170 HOSE ASSY 1
59 ZC45X14011 CLIP 1
61 ZMllC08020 BOLT 2
62 ZMllC10020 SEMS-BOLT 3
65 ZW~6X08000 WASHER 2
68 2416Tl8575 BRACKET 1
69 2444Tl971 CONNECTOR 1
70 2444P1085D1 CONNECTOR 1
71 ZC45X25011 CLAMP 1
72 ZC45X29011 CLIP 1

37-01-2 <D (03)

 CONTROL VALVE,SWING
TO-0001", 2436U1966F2
TG-0001-"

11-6 14-15
7 11 14

5-4.5-3
2
10
10-1

9.9-1. 9-2

5.5-1.5-2

7-12 7-13 7-15

7-14
7-16
7-11
7-9
7- 8 --~=U;U-...t=::(

7-2 _ _ _...:::lIMi!:i~iiiiiiiiloI

7-7 o
7-3
DETAIL ITEM 7

F J G 38 - 37 -1 CD (01 )
 VALVE. CONTROL
VALVE.CONTROL SwiNG TG.0001--

ITEM PART~NO DESCRIPTION REMARKS &TV APPLICABLE

2436U19t.6F2 VALVE. CONTROL

1 2436U1108S1 NUT 4
2 2436U1591S2 TIE ROD 2
3 2436U1108S3 NUT 2
4 2436U1591S4 TIE ROD 1
5 2436R1311F1 SECTION ASSV. INLET 1
5-1 HOUSING 1
5-2 B36KOO19E212 a-RING 1
5-3 2436U338S16 NAME PLATE 1
5-4 2436R1311S4 SCREw.DRIVE 4
6 2436U1108S6 OUTLET SECTION 1
7 2436R1312F1 VALVE SECTION 1
7-1 HOUSING 1
7-2 SPOOL 1
7-3 2436U281S11 HEAD 1
7-6 O-RING 1
7-7 7707846 WASHER 1
7-8 O-RING 2
7-9 WIPER 2
7-10 ZS31C06010 MACHINSCREW 2
7-11 B36KOO19E220 PLATE 2
7-12 B36KOO19E221 CAPSCREW 1
7-13 B36KOO19E222 SEAT. SPRING 2
7-14 2436R593S14 SPRING 1
7-15 B36KOO19E223 CAP 1
7-16 ZS23C06022 CAPSCREW 2
7-970 2436R1312R100 R.KIT (6.8.9) 1
9 2420R918F1 PLUG ASSV 1
9-1 2436U618S28 a-RING 1
9-2 2444R1326S2 ELEMENT 1
10 2420R919F1 PLUG ASSV 1
10-1 2436R718S11 O-RING 1
11 2436R1095F1 VALVE 2
11-6 2445Z7D8 O-RING 1
14 2436R1313F1 VALVE.RELIEF 1
14-15 2445Z7D8 O-RING 2

(00 38-37-1(!)
 HVO LINES. UPP(BOOM HOIST & TELESCOPE)
TO-0001- 24100J8994F4
TG-OOO 1"'"

15.16.34.35 17.18.19.20

36.37.38.39.40 .41

48
A

't::::-:::f'-1"----1 I--~~/

VIEW B- B

48

40.41
37.38
36

24.25.26.27.3

51 56 49
25.29 52 18.17.20.19

15.16.18.59
18.19.20.59

58 55-2 55.16.20
55-2B
VIEW C-C

56.17.18.19.20 14 23.38.45

VIEW A-A

FIG 39-01-1(J) (04)

 HYD LINES ASSY
BOOM,HOIST I TELESCOPE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY· APPLICABLE

24100JB994F4 HyD LINES ASSY

5 241BN2937 TUBE LINE 1

10 2418P17606 LINES, TUBE 1
11 ZX27P16090 HOSE ASSy 2
13 ZX27P20120 HOSE ASSy 1
14 ZX32P20070 HOSE ASSY 1
15 ZE12X16000 CLAMP, HALF ~6
16 ZD12P03400 O-RING 9
17 2420N45BD10035 CAPSCREW 44
1B ZW26KlOOOO LOCKWASHER 52
19 ZE12X20000 CLAMP, HALF 14
20 ZD12P03BOO O-RING B
23 ZN18C1000B NUT 1
24 ZN1BC12010 NUT 5
25 ZW26X12000 LOCK WASHER 7
26 ZW16H12000 WASHER 4
27 ZC27X35014 CLAMP 3
28 ZC27X43014 CLAMP 1
29 ZSlBC12045 CAPSCREW 3
30 ZS18C120B5 BOLT 1
31 ZSlBC12075 CAPSCREW 3
34 0636V046 CAPSCREW 8
35 3619V010 WASHER B
36 2416TlB164 BRACKET 1
37 ZM11C10025 SEMS-BOLT 2
3B 241BT5373(2 WASHER 3
39 R20P0043 U-BOLT 2
40 ZN18C08007 NUT B
41 ZW16XOBOOO WASHER 12
42 ZC45X50014 CLIP 1
43 2416TlB467 BRACKET 1
45 ZW26X10000 LOCK WASHER 1
46 3487Z39D3 WiRE TIE 1
4B 241BN2957 TUBE LINE 1
~9 2418N295B TUBE LINE 1
50 ZM11C12035 CAPSCREW 1
51 241BN2962 TUBE LINE 1
52 2436U1975F1 VALVE, CONTROL P. 40-39 1
53 2444Z2627 CONNECTOR 1
54 2444RB33D1 &UICK COUPLER 1
55 24100p2144F1 MANIFOLD ASSY 1
55-2 ZE72X04000 PLUG 4
55-2B ZD12P01100 O-RING 1
55-3 SCREw 1
56 241BN3069 TUBE LINE 1
57 241BP18075 TUBE LINE 1
5B 2436U989D1F2 SOLENOID VALVE 1
59 2420N458D10065 CAPSCREW 8

(03)
39-01-1(!)
 VALVE ASSY.BOOM HOIST & TELESCOPE
TO-0001 rv 2436U1975F1
TG-0001~

3 32 20
4

2
37
37- 17
9
6
8

33
34

35
39-2.39-3 36
38- 2.38- 3 --"'-F=::~.

38-1
39-1
10
16
27
15
23
21
26
24
29
/
22 SECTION A-A
12 25 28

FIG 40 - 39 - 1 ill (02)

 VALVE, CONTROL
BOOM HOIST & TELESCOPE TG.0001--

ITEM PART :NO DESCRIPTION REMARKS QTy APPLICABLE

2436U1975F1 VALvE, CONTROL

1 SECTION, END 1
2 SECTION, END 1
3 VALVE, SECTION 1
4 VALVE, SECTION 1
5 2441U732S461 PLUG 1
6 2436U1752S154 PLUG 2
7 O-RING 1
8 O-RING 2
9 O-RING 2
10 O-RING 9
11 O-RING 3
12 2436Ul965S202 COvER 1
13 2436U1965S203 COVER 1
14 2436Ul965S208 COVER 2
15 2436U1965S231 WASHER 1
16 2436U1975S232 WASHER 1
17 PACKING 4
18 2420N458D06018 BOLT 10
19 SPOOL 1
20 SPOOL 1
21 2436Ul965S321 SPRING 1
22 2436Ul965S322 SPRING 1
23 2436Ul965S323 SPRING 1
24 2436U1965S331 VALVE, SPRING 2
25 2436U1965S332 VALVE, SPRING 2
26 2436U1965S333 PLUG 1
27 2436Ul965S334 PLUNGER 1
28 2436Ul965S335 SPACER 1
29 O-RING 1
30 2436U1965S371 BOLT 1
31 2436U1965S372 BOLT 1
32 2436U1975S401 PIN 2
33 2436U1537S511 POPPET 2
34 2436Ul965S521 SPRING 2
35 2436U1079S551 CAP 2
36 O-RING 2
37 2436R1310F2 VALvE, RELIEF 1
37-1 ZD12P01800 O-RING 1
37-2 ZD85P01800 RING, BACK-UP 1
37-3 ZD12P03000 O-RING 1
38 2436R1069F2 VALVE, RELIEF 1
38-1 ZD12P02200 O-RING 1
38-2 ZD12P01600 O-RING 1
38-3 ZD85P01600 RING, BACK-UP 1
39 2436R1069F4 VALVE,RELIEF 1
39-1 ZD12P02200 O-RING 1
39-2 ZD12P01600 O-RING 1
39-3 Z085P01600 RING, BACK-UP 1

(Ol)
40-39-l<D
 VALVE, CONTROL
TG.0001-- BOOM HOIST & TELESCOPE

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLICABLE

40 2436U'1915S813 STUD BOLT 4

41 2436U483S819 NUT 8
42 ZW26X16000 LOCK WASHER 8
2436U1915R100 REPAIR KIT 1
CONSISTS OF ITEM 1, 8, 9, 10, 11
11, 29, 36

40-39-2 <D (on

 I NSTAL, SH EE T METAL
TG-0001 ..., 241 00J8724 F6

FIG 45- 01 - 1 (03)

 INSTAL, SHEET METAL
UPPER TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY . APPL I CABLE

24100J8724F6 INSTAL, SHEET METAL

4 2414P5471 COVER 1
6 ZMllC10020 SEMS-BOLT 3
7 ZS31C05012 MACHINESCREW 4
8 ZW26X05000 LOCK WASHER 4
9 2418T5373C2 WASHER 9
10 ZW26X10000 LOCK wASHER 6
12 2416Z218D31 GASKET 1
13 ZN18C10008 NUT 6
14 ZN16C05004 NUT 4
15 ZW16K05000 WASHER 4
16 2414J1721 COVER, FRONT 1
17 2416Z2 18D32 GASKET 1
18 2414Jl737 COVER 1

(03)
 INSTAL, SWIVEL (28CR)
TH-0001"- 24100J7501F6
TG-OOOl -v

L_---1~

)0

1------21

FI G 48-01-1(D (06)
 INSTAL, SWIVEL
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100J1501F6 INSTAL, SWiVEL

3 2418N2646 PLATE 1
4 ZS18C12035 BOLT 2
5 ZW26X12000 LOCK WASHER 2
6 ZS18C20055 CAPSCREW 3
7 ZW26X20000 WASHER 3
8 ZS23C10025 CAPSCREW 2
10 2416T13639 BLOCK, TAPPED 2
11 ZS18C10035 CAPSCREW 2
12 ZW26K10000 LOCK WASHER 2
13 ZW26X10000 LOCK WASHER 2
15 77R37D1 RING, COLLECTOR 1
2; 24100X2309F3 SWIVEL ASSY P. 49-48 1

(06) 48-01-1 <D

 SWIVEL ASSY

TH-0001--v 24100X2309F3
TG-0001-v

18

~
, \

16,,1 \
\ 12
1-----23

3 (',-.

\ \

\
17
14
\ 5

"

(05)
FIG 49-48-1
 SWIVEL ASSY
TG.0001--

ITEM PART~NO DESCRIPTION REMARKS 61TY APPLICABLE

24100X2;09F3 SwIVEL ASSY

2 2436X11 STEM 1
3 2445R152D11 O-RING 3
4 2445R216F1 SEAL 12
5 2445R215 WEARING 1
6 2418R311 PLATE, THRUST 1
8 iS18C12030 CAPSCREW 4
9 ZW26K12000 LOCK WASHER 5
10 ZS18C12035 BOLT 1
11 ?418P14R02 STOPPER 1
12 2420P206403 PLUG 2
13 2420P2064D2 PLUG Q

14 2420P2064D1 PLUG 3
15 lD12P03800 O-RING 2
16 Zt>12P02900 O-RING 2
11 i012P02400 O-RING 3
18 iG91S02000 NIpPLE, GREASE 1
19' 2446P8F1 FILTER ASSY 1
20 2420P206601 PLUG 1
21 iD11P00800 O-RING 1
22 2418Pl1721 PLATE, COVER 1
23 2436X14 BODY 1

(05) 49-48-1
 FINAL ASSV. LOW
TG-0001 "" 2422J2336

1-33F

1-33E 1-33

FIG 51-01-1
 FINAL ASSY, LOW
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTy APPLICABLE

2422J2336 FINAL ASSY, LOW

1 2422J2338 FRAME, RE. 1

1-33 24100N4326F1 SLEWING RING 1
1-33E 2445Pl14D26 SEAL 1
1-33F 2445Pl14D25 SEAL 1
 OUTRIGGER ASSY
TG-0001 '" 24100J9001F1

9~1~
23~

~
30
31

~~2
';"-33

Fl G 53-01-1 (01)
 OUTRIGGER ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS QTy APPLICABLE

24100J9001F1 OUTRIGGER ASSY

1 24100U562F3 CYLINDER ASSY 4

1-1 2438U1317F3 CYLINDER ASSY, VERT. P. 54-53 1
1-2 2436U1628F1 VALVE, LOCK P. 364-362 1
1-2A ZD12POhOO O-RING 3
1-3 2420N458D08065 CAPSCREW 4
2 24100J7207F6 CYLINDER, HORIZONTAL P. 56-53 4
3 2429J381 BEAM, OUTRIGGER 4
4 ZX35M06430 HOSE ASSY 8
5 ZH22X06000 CONNECTOR 8
5-1 ZD12P01400 O-RING 1
6 2444T1320 CONNECTOR 8
7 24829N107 FLOAT 4
7-6 24829P85 SOCKET 1
8 2416T18692 PAD 8
9 2418T15860 PLATE 8
10 2416Pl1828 BRACKET 4
11 24819T197D3 PIN 4
12 2419T5260 PIN 4
13 19Z274033 PIN 4
14 24819T202 PIN 4
15 2419T3258 SPRING PIN 8
16 ZR16X02500 RING 8
17 2416T6682 RUBBER, CUSHION 2
18 2.432Z29004 WIRE TIE 8
19 ZC45X19011 CLIP 8
20 ZS18C16065 CAPSCREW 32
21 ZM11C10025 SEMS-BOLT 8
22 ZM11C10020 SEMS-BOLT 8
23 ZS68Cl0025 CAPSCREW 16
24 ZN18C10008 NUT 8
25 ZN11C05004 NUT 2
26 ZW16H16000 WASHER 32
27 ZW16X24000 WASHER 4
28 ZW26X05000 LOCK WASHER 2
29 ZP15D05040 COTTER PIN 4
30 2416Tl8693 PAO 8
31 2420T6077D1 SHIM 1.6 25
i
32 2420T6077D2 SHIH 0.8 25
33 Zs68Cl0030 CAPS CREW 16

(02) 53-01-1 ®
 CYLINDER ASSY, VERTICAL
TG-O 001 ..... 2438U1317F3

I
\

FIG 54-53-1
(01)
 CYLINDER,VERTICAL TG.0001--

ITEM PART~NO DESCRIPTION REMARKS &Ty APPLICABLE

2438U1317F3

1 2438U1317S1 TUBE, CYLiNDER 1

2 ZE82T04000 PLUG 1
3 2438U1317S3 ROD, PISTON 1
4 2438U1317S4 PISTON 1
5 ZD12G08500 O-RING 1
6 ZD75G08500 RING, BACK-UP 1
7 2438U1317S7 PACKING 2
8 2438U1317S8 RING, WEAR 2
9 ZS83C08010 SETSCREw 1
10 2438U1317S10 COVER, ROD 1
11 ZD12G13500 O-RING 1
12 ZD12G12500 O-RING 1
13 2438U1317S13 RING, BACK UP 1
14 2438U334S16 BUSHING 1
15 2438U1317S15 RING, RETAINING 1
16 2438Ul317S16 PACKING 1
17 2438U181-30 SEAL, DUST 1
18 24838U32S16 RING, SNAP 1
19 2438U506S18 LOCK WASHER 1
2438U1317R100 REPAIR KIT 1
CONSISTS OF ITEM 5, 6, 7, 8
2438U1317R110 REPAIR KIT 1
CONSiSTS OF ITEM 11, 12, 13, 16, 17

(01)
54-53-1 CD
 CYLl NDER ASSY HORIZONTAL
TH-OOOl ~ 241 00J7207 F6
TG-0001'""-'

FIG 56-53-1 ( 05)

 CYLINDER, HORIZONTAL
HORIZONTAL TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (uTy .APPL I CABLE

24100J7207F6 CYLINDER, HORIZONTAL

3 2439P159 PISTON 1
4 2414P6248 COVER, ROD 1
5 2U8Tl293302 WASHER 1
6 2439Tl17 STOPPER 1
7 R25NOO03022 BUSHING 1
8 PACKING, ROO 1
9 SEAL, OUST 1
10 a-RING 1
II O-RING 1
12 a-RING 1
13 RING, BACK-UP 2
20 RING, BACK-UP 1
23 2418J34106 TUBE •. CYLINDER 1
24 2439P15806 ROO 1
24038Zl6Fl REPAIR KIT 1
CONSiSTS OF ITEM 10. 11, 13
24038Z17Fl REPAIR KIT 1
CONSiSTS OF ITEM 8. 9. 12. 20

(OS)
 AXLE ASSV,FRONT
TG-0001- 24100J9022Fl

FA.

FRAME LOW

30--9 'S
31-:-£
29
28

1-5H
I-SA

FIG 57-01-1(D (02)

 AXL.E ASSY,FRONT TG.0001--

ITEM PART.NO DESCRIPTION REMAR~S 6lTy APPL.I CABL.E

24100J9022F1

1 24100J8768F1 AXLE ASSY F/F 1

1-1 24100J8767F1 AXLE, F/F P. 58-57 1 TG.0001--TG.0001
24100J8767F3 AXLE, F/F P. '8-57 1 TG.0002--
1-3 2438U1289F1 CYLINDER, STEER.ING P. 61-'7 1
1-4 24816P854Fl CLAMP ASSY 1
1-4A 24816P8,4 CLAMP 1
1-4E ZS13F12090 BOLT 3
1-4F ZN13F12010 NUT 3
1-4G ZW22X12000 L.OCKWASHER 7
1-4H ZS13F1206' BOLT 4
1-, 24810P34Fl JOINT ASSY 1
l-,A 24810P34 JOINT 1
l-'C 2'Z37 BEARING 2
1-'0 20Z'8 SPACER 1
l-'E 17Z13 SPRING 1
l-SF 20Z'9 PL.UG T
l-'G ZP1'D06070 COTTER PIN 1
l-SH ZS18C12060 CAPSCREW 1
l-SI ZN18C12010 NUT 1
l-'J ZG91S02000 NIPPLE, GREASE 1
1-6 ZP45X22100 PIN 1
1-7 ZP15D05040 COTTER PIN 2
1-8 24810T18 CONNECTOR 1
1-9 ZW16X30000 WASHER 1
1-10 ZP4'X30080 PIN 1
1-1~ 14Z126D3 COVER, DUST 1
2 24100J8768F2 AXL.E ASSY,F/R 1
2-2 24100J8767F2 AXLE,F/R P. 62-'7 1 TG.0001--TG.000l
24100J8767F4 AXL.E,F/R P. 62-'7 1 TG.0002--
2-3 2438U1289F1 CYLINDER, STEERING P. 61-57 1
2-tt 24816P8'4Fl CLAMP ASSY 1
2-4A 24816P8'4 CLAMP 1
2-4E ZS13F12090 BOLT 3
2-4F ZN13F12010 NUT 3
2-4G ZW22X12000 LOCK wASHER 7
2-4H ZS13F1206' BOLT 4
2-' 24810P34F1 JOINT ASSY 1
I
1 I
2-,A 24810P34 JOINT
2-SC 2'Z37 BEARING 2
2-'0 20Z'8 SPACER 1
2-'E 17Z13 SPRING 1
2-5F 20Z'9 PLUG 1
2-'G ZP1'D06070 COTTER PIN 1
2-5H ZS18C12060 CAPSCREw 1
2-'1 ZN18C12010 NUT 1
2-5J ZG91S02000 NIPPL.E, GREASE 1 I

2-6 ZP4'X22100 PIN 1 ,I

2-7
2-8
ZP1'DO'040
24810T18
COTTER PIN
CONNECTOR
2
1
I
2-9 ZW16X30000 WASHER 1

(02) 57-01-1 <D

TG.OOOl-- AXI.E ASSY.FRONT

ITEM PART.NO DEsCRIPTION REMARKS &TY APPI.I CABI.E

2-10 ZP45X30080 PIN 1

2-11 hZl2603 COVER. OUST 1
3 18Z3193 Bl.oCK 4
4 176127 SPRING 4
5 norso U-BOI.T 8
6 2420T5892 NUT 16
7 ZW~6H22000 WASHER 16
8 20&9701 ARM ASSY. TOR6IUE 1
9 206)9704 ROO 1
10 20Zl968 BOI.T 4
11 206112301 NUT 10
12 361~V011 1.0CKWASHER 10
13 20619801 ROO 1
14 20619804 ROO 1
15 166195 BUSHING 16
16 20Zl970 BOI.T 8
17 20Zl969 NUT. 1.0CK 8
18 18Z2853 WASHER 16
19 1661106 E6IUAI.IZER 2
20 2405R151 BUSHING 4
21 2410R130 SHAFT 2
22 2418Z973 WASHER 4
23 2420R839 BOI.T 4
24 2418Z972 1.0CK WASHER 4
25 206112201 BOI.T 6
26 18Z2854 ROI.I.ER 6 l
27 2416P1l616 BRACKET 4 ~~...
28 2418T15920 PI.ATE 8
29 2416U34 CUSHION 4
30 ZS18C12030 CAPSCREW 16
31 ZW26X12000 1.0CKWASHER 16

i
I
I
I

(02)
 FRONT AXLE ASSY,FRONT
TH-OOO 1--... 2 4 1 0 0 J 87 6 7 F 1, F3
TG-OOO 1 ~

FR.

FIG 58 - 57 - 1 <D (04)

 AXLE, FRONT/FRONT T6.0001--

ITEM PART .NO DESCRIPTION REMARKS 6lTy APPLICABLE

24100J8767F1 T6.0001--TG.0001
24100J8767F3 TG.0002--

1 2410J377D1 CENTER,AXLE 1 TG.0001--TG.0001

2 2410Z164 KNUCKLE 2
4 2420Z1156 NUT 2
5 2419Zl76 PIN 2
6 2418Z889 WASHER 2
7 2416Z278 BRACKET (R.H) '1
8 2416Z279 BRACKET (L.H) 1
9 2420Z1178 CAPSCREW 6
10 ZW22X12000 LOCK WASHER 12
11 2406Z275 ARM, KNUCKLE 1
12 2420Z1177 BOLT 2
13 2420Z1176 BOLT 2
H 2410Zl59 JOINT, BALL 2
15 2420Z1157 NUT 4
16 2418Z890 ARM 1
17 2418Z891 ARM 1
18 2420Z1175 BOLT 4
I
19 2420Z1159 NUT 8
20 24820P139D2 ROO, TIE 1
21 ZS18F12055 BOLT 4
22 ZN18F12010 NUT 4
23 2413Zl19 HUB 2
24 2413Z120 DRUM, BRAKE 2
25 2419Z177 PIN 10
26 2419Zl78 PIN 10
27 2420Zl564 NUT 20
28 2425Z491 BEARING 2
29 2425Z492 BEARING 2
30 2418Z892 WASHER 2
31 2420Z1164 NUT 2
32 2418Z893 WASHER 2
33 ZS18C06016 CAPSCREW 4
34 2414Z250 CAP 2
2418Z894 PACKING 2
"
36 ZS18C08014 CAPSCREW 12
37 ZW22X08000 LOCK WASHER 12
38 2414Z251 COVER 2
39 2418Z896 RING, SNAP 2
40 2418Z897 OIL-SEAL 2
41 2420Zl562 NUT 10
42 2420Z1160 NUT 10
44 ZN18F16013 NUT 8
45 ZW22X16000 LOCK WASHER 8
46 2438R219 CHAMBER P. 60-58 2 !
47 ZN16Fl6010 NUT 2
48 2406Z276 JOINT 2
49 2419Z179 PIN 2
50 2419Zl80 PIN 2
51 ZWllX16000 WASHER 2

(04) 58-57-1@

'.
TG.0001-- AXLE, FRONT/FRONT

ITEM pART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

52 2~20Z1172 BOLT 2
53 ZG91S02000 NIPPLE. GREASE ~

55 2~06Nl1~3 ARM, KNUCKLE 1

56 2415U179F1 BRAKE ASSY (R.H) P. 59-58 1
57 2415U179F2 BRAKE ASSY CL.H) P. 59-58 1
58 2420R681F1 ENO. TIE-ROO 1
59 2~20R681F2 ENO. TIE-ROO 1
61 2419R10F1 PIN 2
61-1 BOLT 1
61-2 BOLT 1
61-3 SPRING WASHER 1
61-~ SNAP RING 1
61-5 PLATE 1
61-6 NEEDLE BEARING 1
61-7 NEEDLE BEARING 1
61-8 SEAL 1
61-9 KING PIN 1
61-10 BEARING 1
62 Zw22X06000 LOCK WASHER ~

63 2418Z928 RING. SPRING 10

6~ 2418Z929 RING. SPRING 10
66 2~20T608301 CAPSCREW 2 TG.0001--TG.0001
68 2~20Zl17302 CAPSCREW ~ I
69 2410J~39 CENTER. AXLE 1 TG.0002--
71 2~20T6083D3 CAPSCREw 2 TG.0002--

I
I
I
I
I
i

58-57-2@ (04)
 BRAKE ASSY F
241 ' RONT
TH-0001- 5U179F1,F2
TG-O 001
.-..J

7
TRAILING LEADING

VIEW A

FIG 59-58-1 ( 01)

 BRAKE ASSY
BRAKE ASSY (R.H) TG.0001--

ITEM PART~NO DESCRIPTION REMARKS QTY APPLICABLE

;415U17QF1 BRAKE ASSY

1 2415Z264F1 BRACKET ASSY 1

1-1 24100J9086S3 BUSHING 2
1-4 24100J9086S4 OIL SEAL 1
5 24100J9086S10 RING, FELT 1
6 24100J9086S11 COLLAR 1
7 2415Ul79s7 PIN, ANCHOR 2
8 24100J9086S5 PLATE, LOCK 1
9 24100J9086S6 LOCK WASHER 1
11 2415Ul79S11 SHAFT, CAM 1
12 2415Ul79512 ADJU5TER, 5LACK 1
13 2415U179513 PLATE 1
14 24100J9086S19 SNAP RING 1
15 2415U179S15 SHOE ASSY 1
15-1 2415U1795104 BU5HING 1
15-3 2415U179S101 ROLLER 1
15-4 2415U179S102 PIN 1
15-5 24015U36S5 CLIP 1
15-6 2415U179S103 PIN, SPRING 1
16 2415U179S16 SHOE AS5V 1
16-1 2415U179S104 BUSHING 1
16-3 2415U179S101 ROLLER 1
16-4 2415U1795102 PIN 1
16-5 24015U36S5 CLIP 1
16-6 2415Ul79s103 PIN, SPRING 1
17 2415U179517 SPRING A5SY 1
18 7G91V02000 NIPPLE, GREASE 1
19 2415U179S19 COVER, DUST 1
20 2415U179520 COVER, DUST 1
21 24100J9086S29 GROMMET 2
22 24100J9086530 BOLT 7
23 24100U334S31 wASHER 6
24 24100J9086S32 SPACER 1
25 24100J9086S33 RING 1
2415U179R101 R,KIT LINING(STD) 1
LI NI NG (ITEM A) 8
RIVET ( ITEM B) 88
2415U179R102 R,KIT LINING 1
( OVER SIZF ) 1
LI NI NG (ITEM A) 8
RIVET ( ITEM B) 88

2415U179F2 BRAKE AS5Y

BRAKE ASSY (L.H)

(OJ) 59-58-1 CD
 BRAKE ASSY
TG.0001-- BRAKE ASSY (L.H)

ITEM PART.NO DESCRIPTION REMARIC:S IilTY APPLICABLE

5 24100J9086S10 RING, FELT 1

6 24100J9086S11 COLLAR 1
7 2415U179S7 PIN, ANCHOR 2
8 24100J9086S5 PLATE, LOCK 1
9 24100J9086S6 LOCK WASHER 1
13 2415U179S13 PLATE 1
14 24100J9086S19 SNAP RING 1
15 2415u179S15 SHOE ASSY 1
15-1 2415U179S104 BlJSHING 1
15-3 2415U179S101 ROLLER 1
15-4 2415U179S102 PIN 1
15-5 24015U36S5 CLIP 1
15-6 2415U179S103 PIN, SPRING 1
16 2415U179S16 SHOE ASSY 1
16-1 2415U179S104 BlJSHING 1
16-3 2415U179S101 ROLLER 1
16-4 2415U179S102 PIN 1
16-5 24015u36S5 CLIP 1
16-6 2415U179S103 PIN, SPRING 1
17 2415U179S17 SPRING ASSY 1
18 ZG91V02000 NIPPLE, GREASE 1
19 2415u179S19 CovER, DUST 1
20 2415u179S20 CovER, DUST 1
21 24100J9086S29 GROMMET 2
22 24100J9086S30 BOLT 7
23 24100U334S31 WASHER 6
24 24100J9086S32 SpACER 1
25 24100J9086S33 RING 1
26 24157264F2 BRACKET ASSy 1
26-1 24100J9086S3 BUSHING 2
26-4 24100J9086S4 OIL SEAL 1
28 2415u179S28 SHAFT, CAM 1
29 2415u179S29 ADJUSTER, SLACK 1
2415U179R101 R,K IT LI NING (STD) 1
1I NI NG (I TEM A) 8
RiVET (ITEM B) 88
2415U179R102 R,KIT LINING 1
( OVER SIZE ) 1
LINING (ITEM A) 8
RiVET ( ITEM B) 88

(01)
59-58-2 CD
 POWER CHAMBER
TH-OOO 1-- 2438R219
TG-0001-

(02)
FIG 60-58-1
 CHAMBER
TG.0001--

ITEM PART. NO DESCRIPTION REMARKS 6lTY APPLICABLE

243BR219 CHAMBER

1 243BR21.9S1 COVER, LOW 1

2 243BR219S2 SPRING 1
3 243BR219S3 ROD ASSY 1
4 243BR219S4 DIAPHRAGM 1
5 243BR219S5 COVER ASSY 1
6 243BR219S6 CLAMP ASSY 1
1 243BR219S1 BOLT 2
B 243BR219SB LOCK WASHER 2
9 243BR219S9 NUT 2
10 243BR219S10 RETAINER 1
11 243BR219S11 COVER 1

(02) 60-58-1
 TH-0001- CYlI N DER ASSY, STEER I NG
TG-OOO 1--- 2438U1289Fl

18

FIG 61-57-1

(01)
 CYLI NDER
STEERING TG.0001--

ITEM PART.NO DESCRIPTION REMARKS tilTY APPLICABLE

2438U1289Fl CYLINDER

1 2438U1289S1 TUBE, CYLI NDER 1

2 2438U1289S2 ROD, PISTON 1
3 2438U1289S3 HEAD, CYLI NDER 1
4 2438U856S4 BUSHING 1
5 2438U856S5 SNAP RING 1
6 2438U1289S6 RING, BUFFER 1
7 2438U1289S7 U-RING 1
8 2438U1289S8 RING, BACK UP 1
9 2438U1289S9 RING, wiPER 1
10 2438U1289S10 SNAP RING 1
II 2438U433S18 O-RING 1
12 2438U1289S12 RING, BACK UP 1
13 lD12G06500 O-RING 1
14 2438U1289S14 LOCK WASHER 1
15 2438U1289S15 PISTON 1
16 2438U1289S16 RING, SEAL 1
17 2438U1291S16 RING 2
18 2438U856S16 U-NUT 1
2438U1289R101 REPAIR KIT 1
CONSISTS OF ITEM 4, 5, 6, 7, 8
9, 11, 12, 13, 14
16, 17

(DI) 61-57-1 CD
 FRONT AX LE ASSY. REAR
TH-OOO 1-- 24100J8767F2,F4
TG-0001"-'

59

46
70
65

/ '

FIG 62 - 57 - 1<D
(03)
 AXLE, FRONT/REAR TG.0001--

ITEM PART.NO DESCRIPTION REMAr<KS tilTy APPLICABLE

24100J8767F2 TG.0001--TG.0001
24100J8767F4 TG.0002--

2 24101164 KNUCKLE 1
4 242011156 NUT 2
5 2419Z176 PIN 2
6 24181889 WASHER 2
7 24161278 BRACKET CR.H) 1
8 24161279 BRACKET CL .H) 1
9 2420l1l78 CAPSCREW 6
10 lW22X12000 LOCKWASHER 12
12 2420l1l77 BOLT 1
13 2420l1l76 BOLT 1
14 24101159 JOINT, BALL 1
15 2420l1l57 NUT 3
16 24181890 ARM 1
17 24181891 ARM 1
18 2420l1l75 BOLT 4
19 242011159 NUT 6
20 24820P139D2 ROD, TIE 1
21 lS18F12055 BOLT 4
22 lN18F12010 NUT 4
23 2413Z1l9 HUB 2
24 2413Z120 DRUM, BRAKE 2
25 24191177 PIN 10
26 24191178 PIN 10
27 2420Z1564 NUT 20
28 24251491 BEARING 2
29 24251492 BEARING 2
30 24181892 WASHER 2
31 242011164 NUT 2
32 24181893 WASHER 2
33 lS18C06016 CAPSCREW 4
34 24141250 CAP 2
35 24181894 PACKING 2
36 lS18C08014 CAPSCREW 12
37 lW22X08000 LOCK WASHER 12
38 24141251 COVER 2
39 24181896 RING, SNAP 2
40 24181897 OIL-SEAL 2
41 2420Z1562 NUT 10
42 2420l1l60 NUT 10
44 lN18F16013 NUT 8
45 lW22X16000 LOCK WASHER 8
46 2438R219 CHAMBER P. 60-58 2
47 lN16F16010 NUT 2
48 24061276 JOINT 2
49 2419Z179 PIN 2
50 24191180 PIN 2
51 lwllX16000 WASHER 2
52 2420l1l72 BOLT 2
53 lG91S02000 NIPPLE, GREASE 4

(04)
TG.OU01-- AXLE, FRONT/REAR

ITEM PART.NO DESCR I PTI ON REMARKS &TY APPLICABLE

54 2406N1l42 ARM, KNUCKLE 1

56 2415U119F1 BRAKE ASSY (R.H) P. 59-58 1
51 2415U119F2 BRAKE ASSY (L.H) P. 59-58 1
58 2420R681F1 END, TIE-ROD 1
59 2420R681F2 END, TI E-ROD 1
.60 2410Z162 KNUCKLE 1
61 2419R10Fl PIN 2
61-1 BOLT 1
61-2 NUT 1
61-.3 SPRING WASHER 1
61-4 SNUP RING 1
61-5 PLATE 1
61-6 NEEDLE BEARING 1
61-1 NEEDLE BEARING 1
61-8 SEAL 1
61-9 KING PIN 1
61-10 BEARING 1
62 ZW22X06000 LOCK WASHER 4
6.3 2418Z928 RING, SPRING 10
64 2418Z929 RING, SPRING 10
65 2410J.317D2 CENTER, AXLE 1 TG.0001--TG.0001
61 2420T608.3D2 CAPSCREw 1 TG.0001--TG.0001
68 2420Z1l1.3D2 CAPSCREw 4
10 2410J440 CENTER, AXLE 1 TG.0002--
72 2420T608.3D4 CAPSCREW 2 TG.0002--

62-57-2 CD (04)
 AXLE ASSY,REAR
241 00J9023F 1
TG-0001 .........

SHAFT, PROPEL

~
FR.
15~
12 14
1
1

13

(01)
FI G 63-01-1
 AXLE ASSy, RE.
REAR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &Ty APPLICABLE

24l00j9023Fl AXLE ASSY, RE.

1 24100J8216Fl AXLE ASSY, R.F. P. 64-63 1

2 24100J8217Fl AXLE ASSY, R.R. p. 67-63 1
3 316N121 BRACKET 2
4 2406U130D5F1 ROD, TOR&UE 2
5 10U133 BEAM 2
6 19Z33l PIN 2
7 l8Z2846 wASHER 4
8 2420T5975 CAPSCREW 2
9 ZS18F18100 CAPSCREW 4
10 ZN18F18D15 NUT 6
11 ZW16H18000 WASHER 12
12 18&326 ADAPTER 8
13 20Z2468 BOLT 4
14 18Z3440 ADAPTER 4
15 20Z2467 NUT 4
16 18Z3441 WASHER 8

(01) 63-01-1
 REAR AXLE(RF. )
TG-0001 ...... 24100J8215F~

.,
FR.

17,18

FIG 54-53-1 (01)

 REAR AXLE( R.F.)
24100J8216Fl TG- 0001--

20
55
56

~
FR.

r - - - - - - - - - - - - - - - - - - - - - -- ~
66
22
1
I
I

I
I
___________ ...1I

(01) Ff G 64-63-2
 AXLE ASSy, R.F.
REAR. FRONT TG.0001--

ITEM PART.NO DESCR I PTI ON REMARKS ®TY APPLICABLE

24100J8216F1 AXb E ASSY, R.F.

1 2410N602 HOUSING 1
.2 VH965930102 wASHER 1
3 VH961930104 PLUG 1
4 VH411232280 SHIM, 0.3 3
5 VH411232290 SHIM, 0.4 3
6 VH411232300 SHIM 3
1 VH411232310 SHIM, 0.5 3
8 VH411311010 RETAINER 1
9 VH982865112 OIL SEAL 1
10 VH988450101 BEARING 2
11 VH413911110 SHAFT 1
12 VH902112300 BOLT 4
13 VH929012360 LOCK WASHER 4
14 2418R451F1 FLANGE ASSY 1
14-1 VH313411330 DEFLECTOR 1
15 VH921933116 NUT 1
16 VH449211010 BREATHER 1
11 VH423113320 SHAFT, AXLE 1
18 VH423113300 SHAFT, AXLE 1
19 VH929016480 LOCK WASHER 24
20 VH920116130 NUT 24
21 VH901916113 BOLT ~6
22 VH435122421 DRUM, BRAKE 2
23 VH982801193 OIL SEAL 2
24 VH988490101 BEARING 2
25 VH901110200 BOLT 4
26 VH424111820 HUB 2
21 VH993322110 BEARING 2
28 VH900436116 PLATE, LOCK 2
29 VH921985108 NUT 2
30 VH900436113 PLATE, LOCK 2
31 VH982816101 OIL SEAL 2
32 VH918106160 BOLT 8
33 VH901914219 BOLT 20
34 VH929014420 LOCK WASHER 20
35 VH900426144 STUD BOLT 10
36 VH900425111 STUD BOLT 10
31 VH900422111 NUT 10
38 VH900421106 NUT 10
39 VH418812310 SHAFT, CAM 1
40 VH418822310 SHAFT, CAM 1
41 VH418891080 COLLAR 2
42 VH985131102 O-RING 2
43 VH900312246 SPACER 2
44 VH912910148 CONNECTOR 2
45 VH964504931 O-RING 2
46 VH980210101 FITTING 2
41 VH982840113 OIL SEAL 2
48 VH418891060 COLLAR 2
49 VH900313164 WASHER, THRUST 3

(01)
 AXLE ASSY, R.F.
TG.0001-- REAR.FRONT

ITEM PART.NO DESCR I PTI ON REMARKS GlTY APPLICABLE

50 VH981940112 RING 2
51 VH412441080 SLEEVE 1
52 2414U373F1 DIFF CARRIER ASSY P. 65-64 1
53 2413R231F1 SPIDER ASSY 2
53-1 VH986740113 BUSHING 1
54 VH474511010 PIN 4
55 2415U412F1 SHOE ASSY ( LH ) 1
56 2415U410F1 SHOE ASSY ( RH ) 1
57 VH938910106 SETSCREW 4
58 VH980330200 WIRE 2
59 2415U411F1 SHOE ASSY ( LH ) 1
60 2415U409Fl SHOE ASSY ( RH ) 1
61 VH470511680 CovER ASSY, DRUM 2
62 VH470511690 COVER ASSY, DRUM 2
63 VH918110200 BOLT 12
64 VH918114350 BOLT 8
65 VH474961110 PLUG 4
66 VH474831060 PIN 2
67 VH474801020 ADJUST ASSY 2
68 VH926012220 WASHER 2
69 VH951112360 PIN 2
70 VH950040200 PIN 2
71 2416R319F1 BRACKET ASSY (RH) 1
71-1 VH986740113 BUSHING 1
72 2416R320F1 BRACKET ASSY (LH) 1
72-1 VH986740113 BUSHING 1
73 2438U1672F1 CHAMBER ( RH ) P. 66-64 1
74 2438U1672F2 CHAMBER ( LH ) P. 66-64 1
75 2417Rl31Fl SPRING ASSY 2
76 VH987306105 SPRING 2
77 VH964401321 O-RING 4
78 VH931914102 STUD BOLT 4
79 VH928014350 LOCK WASHER 4
80 VH920114110 NUT 4
81 VH965918110 WASHER 1
82 VH961918103 PLUG 1
83 VH918914101 BOLT 12
84 VH415891020 GASKET 1
85 VH414501220 SHIFT ASSY 1
86 VH972910123 CONNECTOR 1
87 VH940112300 BOLT 4
88 VH900439106 WASHER 20
89 VH421471090 SLEEVE 2

(01) 64-63-2
 01 FF CARRIER ASSY (R.F.)
TG-0001-.. 2414U373Fl

29

..
FR.

FIG 65-64-l(i) (02)

 DIFFERENTIAL ASSY
DIFF I REAR FRONT TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CllTY APPLICABLE

2414U313F1 DIFFERENTIAL ASSY

1 VH411011621 CARRIER ASSY 1

1-1 VH411111521 CARRIER 1
1-2 VH900314133 COLLAR 4
1-3 VH901920101 CAPSCREW 4
1-4 VH411131180 CAP 2
6 VH980360550 WIRE 2
1 VH920920103 NUT ~2
8 VH901920104 CAPSCREW 12
9 VH413011110 CASE ASSY 1
9-1 VH413121310 CASE 1
9-2 VH901916233 CAPSCREW 6
9-3 VH901916222 CAPSCREw 6
9-4 VH920916102 NUT 12
9-5 VH413111150 CASE 1
15 VH988490110 BEARING 2
16 VH900436110 PLATE 2
11 VH918108160 CAPSCREW 2
18 VH413151020 NUT 2
19 VH413311460 GEAR 2
20 VH413511180 WASHER 4
21 VH413411280 PINION 4
22 VH413711080 SPIDER 1
23 VH413611380 WASHER 2
24 VH950412200 PIN 2
25 VH165542060 NAME PLATE 1
26 VH165531500 NAME PLATE 1
21 VH423211040 GASKET 1
28 VH411211071 COVER 1
29 VH988410103 BEARING 2
30 VH413311330 GEAR 1
31 VH411311420 CAGE 1
32 VH413011560 CASE ASSY 1
32-1 VH905912106 CAPSCREW 8
32-2 VH412911040 CASE 1
32-3 VH412911090 CASE 1
33 VH413411100 PINION 4
34 VH902110300 CAPSCREW 6
35 VH929010300 LOCK WASHER 6
36 VH413511090 WASHER 4
31 VH413711110 SPIDER 1
38 VH413311320 GEAR 1
39 VH411251100 GASKET 1
41 VH413611130 wASHER 2
42 VH900436138 PLATE 4
43 VH412111010 HOUSING 1
45 VH411232340 SHIM 0.3 5
46 VH411232330 SHIM 0.2 5
41 VH411232320 SHIH 0.1 5
48 VH990062130 BEARING 1
49 VH411311010 RETAINER 1

(02) 65-64-1 CD
 DIFFERENTIAL ASSY
TG.0001-- DIFF I REAR FRONT

ITEM PART.NO DESCRIPTION REMAR~S CilTY APPLICABLE

50 VH373042660 FLANGE ASSY 1

50-1 VH373411350 DEFLECTOR 1
50-2 VH373243360 FLANGE 1
53 VH982890104 OIL SEAL 1
54 VH921945104 NUT 1
57 VH411232200 SHIM 0.3 5
58 VH411232210 SHIM 0.4 5
59 VH411232220 SHIM 0.45 5
60 VH411232230 SHIM 0.5 5
61 VH962921105 PLUG 2
62 VH96191070 PLUG 1
63 VH412521070 GEAR 1
64 VH965930102 WASHER 1
65 VH921933116 NUT 1
66 VH412541050 GEAR 1
67 VH988460110 BEARING 1
68 VH411231430 SHIM 0.4 5
69 VH411231440 SHIM 0.45 5
70 VH411231450 SHIM 0.5 5
71 VH411311410 CAGE 1
72 VH903118450 CAPSCREW 6
73 VH929018540 LOCK WASHER 6
74 VH411232240 SHIM 0.3 5
75 VH411232250 SHIM 0.4 5
76 VH411232260 SHIM 0.45 5
71 VH411232270 SHP1 0.5 5
78 VH412311020 SPACER 1
79 VH940112350 CAPSCREW 23
80 VH988470108 BEARING 1
51 VH412011600 GEAR 1
82 VH901908162 CAPSCREW 2
83 VH900436134 PLATE 1
84 VH988335108 BEARING 1
85 VH900436133 PLATE 1
86 VH9900436127 PLATE 1
87 VH981932108 SNAP RING 1
88 VH921930105 NUT 1
89 VH985140104 O-RING 1
90 VH412511020 SHAFT 1
91 VH988440102 BEARING 2
92 VH412531030 GEAR 1
93 VH412311300 SPACER 1
94 VH412311310 SPACER 1
95 VH412311320 SPACER 1
96 VH412311330 SPACER 1
97 VH412311340 SPACER 1
98 VH412311350 SPACER 1
99 VH412311360 SPACER 1
100 VH412311370 SPACER 1
101 VH412311380 SPACER 1
102 VH412311390 SPACER 1
103 VH412311400 SPACER 1
104 VH41231hl0 SPACER 1
105 VH412311420 SPACER 1

(en
 DIFFERENTIAL ASSY
DIFF I REAR FRONT TG.0001--

ITEM PART.NO DESCR I PTI ON REMARKS <ilTY APPLICABLE

106 VH412311430 SPACER 1

101 VH412311440 SPACER 1
108 VH412311450 SPACER 1
109 VH412311460 SPACER 1
110 VH412311410 SPACER 1
111 VH412311480 SPACER 1

(01)
 CHAMBER
2438 ,BRAKE
TG-0001-- U 1672 F I,F2

27
1S
~6
19

°f:JO~' '
3

25 :(BREATHER KIT
NOT SHOWN)

FIG 66-64-1
(01)
 CHAMBER, MAXI BRA~E

CHAMBER,BRA~E TG.0001--

ITEM PART .NO DESCRIPTION REMARKS GlTY APPLICABLE

2438U1672F1 CHAMBER, MAXI BRA~E

1 CYLINDER 1
2 BUSHING 1
3 PISTON 1
4 RING, wIPER 1
5 2438U1672S5 SPRING 1
6 2438U131156 SUPPORT, SPRING 1
7 2438U1311S7 CAPSCREW 8
8 2438U1311S8 SEAL, SHAFT 1
9 2438U131159 PLATE, RETAINER 1
10 2438U1311S10 SPRING, RETURN 1
11 2438U1311S11 RETAINER, SPRING 1
12 2438U1672512 ROD, PUSH 1
13 2438U1672S13 DIAPHRAGM 1
14 PLATE 1
15 2438U1311S15 BAND 2
16 2438U1311S16 BOLT 2
17 2438U1311S17 NUT 2
18 2438U1311S18 NUT 1
19 2438U1672S19 JOINT 1
20 2438U1311S20 WASHER 8
21 RING, SEAL 1
22 RING, SEAL 1
25 2438U1672S25 BREATHER ASSY 1
26 2438U1311S26 BOOT 1
27 2438U1311S27 RETAINER 1
28 2438U1311S28 SPACER 2
2438U1672R100 1
CONSISTS OF ITEM 2, 4, 21, 22

2438U1672F2

PIN ARE SAME AS F1

<OJ) 66-64-1 CD
 REAR AXLE(R.R.)
TG-0001 ....... 24100J8217F1

~
FR.

FIG 67-63-1 (01)

 REAR AXLE(R R)
24100J8217~1' TG-0001 .........

FR.
~
5.0
51

_- - - -
1
-- - l
I

34

I
I
I
I
I
I I
I
t
'----- -1----- ____ J
I

52,53
59.60

co 1) FIG 67-63-2
 AXLE ASSy, R.R.
REAR.REAR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

24100J8217F1 A~LE ASSY, R.R.

1 2410N603 HOUSING, AXLE 1

2 2414U374F1 DIFF CARRIER ASSY P. 68-67 1
3 VH965930102 WASHER 1
4 VH961930104 PLUG 1
5 VH423113310 SHAFT, AXLE 2
6 VH981940112 RING 2
7 VH900313164 WASHER, THRUST 3
8 VH478891060 COLLAR 2
9 VH982840113 OIL SEAL 2
10 VH980210101 FITTING 2
11 VH972910148 CONNECTOR 2
12 VH964504931 O-RING 2
13 VH900312246 SPACER 2
14 VH985137102 O-IUNG 2
15 VH478891080 COLLAR 2
16 VH478822310 SHAFT, CAM 1
17 VH478812310 SHAFT, CAM 1
18 VH900422111 NUT 10
19 VH900421106 NUT 10
20 VH900426144 STUD BOLT 10
21 VH900425171 STUD BOLT 10
22 VH929014420 LOCK WASHER 24
23 VH901914219 BOLT 20
24 VH918106160 BOLT 8
25 VH982876101 OIL SEAL 2
26 VH900436113 PLATE, LOCK 2
27 VH921985108 NUT 2
28 VH900436116 PLATE, LOCK 2
29 VH993322170 BEARING 2
30 VH424111820 HUB 2
31 VH901110200 BOLT 4
32 VH988490107 BEARING 2
33 VH982801193 OIL SEAL 2
34 VH435122421 DRUM, BRAKE 2
35 VH920116130 NUT 24
36 VH929016480 LOCK WASHER 24
37 VH901916113 BOLT 16
38 2438U1672F1 CHAMBER P. 66-64 1
39 2438U1672F2 CHAMBER P. 66-64 1
40 VH987306105 SPRING 2
41 2417R131Fl SPRING ASSY 2
42 2416R320Fl BRACKET ASSY 1
42-2 VH986740113 BUSHING 1
43 2416R319F1 BRACKET ASSY 1
43-2 VH986740113 BUSHING 1
44 VH951112360 PIN 2
45 VH950040200 PIN 2
46 VH926012220 WASHER 2
t : ~.
47 VH474801020 ADJUST ASSY 2
48 VH474961110 PLUG 4

67-63-1 (01)
 AXLE ASSY, R.R.
TG.0001-- REAR. REAR

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

49 VH918114350 BOLT 8
50 VH470511680 COvER ASSY, DRUM 2
51 VH470511690 COVER ASSY' DRUM 2
52 2415U412F1 SHOE ASSY 1
53 2415U410F1 SHOE ASSY 1
54 VH474601481 SPIDER ASSY 2
55 VH980330200 WIRE 2
56 VH938910106 SETSCREW 4
57 VH474511010 PIN 4
58 VH474831060 PIN 2
59 2415U41lF1 SHOE ASSY 1
60 2415U409F1 SHOE ASSY 1
61 VH9201l41l0 NUT 4
62 VH931914102 STUD BOLT 4
64 VH964401321 O-RING 4
65 VH961918103 PLUG 1
66 VH965918110 .WASHER 1
67 VH449211010 BREATHER 1
68 VH918914101 BOLT 12
69 VH918110200 BOLT 12
70 VH900439106 WASHER 20
71 VH421471090 SLEEVE 2

(01) 67-63-2
 01 FF CARRI ER ASSY(R.R.)
TG-OOO 1-- 2414U374F1

"
k

40

FIG 68-67-1(1) (01)

 DIFFERENTIAL ASSY
DIFF I REAR REAR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IilTy . APPL I CABLE

2414U374F1 DIFFERENTIAL ASSY

1 VH918108160 CAPSCREw 2
2 VH900436110 PLATE 2
3 VH413151020 NUT 2
4 VH988490110 BEARING 2
5 VH900436134 PLATE 1
6 VH900436127 PLATE 1
7 VH981932108 SNAP RING 1
8 VH901920104 CAPSCREW 12
9 VH920920103 NUT 12
10 VH413011710 CASE ASSY 1
10-1 VH920916102 NUT 12
10-2 VH901916222 CAPSCREW 6
10-3 VH901916233 CAPSCREW 6
10-4 VH413111340 CASE 1
10-5 VH413121310 CASE 1
16 VH413711080 SPIDER 1
17 VH413611380 wASHER 2
18 VH413311460 GEAR 2
19 VH980360550 WiRE 2
20 VH413411280 PINION 4
21 VH413511180 WASHER 4
22 VH901908162 CAPSCREW 2
23 VH900436133 PLATE 1
24 VH988335108 BEARING 1
25 VH411011611 CARRIER ASSY 1
25-1 VH411131180 CAP 2
25-2 VH900314133 COLLAR 4
25-3 VH901920101 CAPSCREW 4
25-4 VH41111146i CARRIER 1
26 VH988470108 BEARING 1
27 VH412311020 SPACER 1
28 VH411311480 CAGE 1
29 VH988460105 BEARING 1
30 VH411231461 SHIM 0.4 5
31 VH411231471 SHIM 0.45 5
32 VH411231481 SHIM 0.5 5
33 VH411231491 SHIM 0.3 5
34 VH411231430 SHIM 0.4 5
35 VH411231440 SHIM 0.45 5
36 VH411231450 SHIM 0.5 5
37 VH412011600 GEAR 1
38 VH982880110 OIL SEAL 1
39 VH373042530 FLANGE ASSY 1
39-1 VH373243150 FLANGE 1
39-2 VH373411490 DEFLECTOR 1
39-3 VH905914110 BOLT 4
40 VH921933116 NUT 1
42 VH901118451 BOLT 6
43 VH928018460 WASHER 6

(01)
 SHAFT ASSY. PROPEL
TG-OOO 1--- 241 OOJ 9024F 1

I ,.

l 14 •

1/' 7
('
/i:...
'*
'",

11'f
~
, r- ..
1-2 14

1-3 ~ ((

'-....- -_ _ _ _ _ _ _ _ _ _ _ _ A _________________1

FIG 69-01-1 (01)

 SHAFT ASSY. PROPEL
241 OOJ 9024F 1 TG-0001-

2-8 2-5
. 2-9
2-10 i."J2-42-3

~
\ ~/ 2-2
2-2 0 ~
2-3

2-~~~'2_~ ~/
2-7

l~ _____________________________ B __________________________ ~1

3-5
3-6
i 3-4

~
' ~~
~
~=!~Q1)) ~/
3-2-_

3-5
3-6 3-1 .
3-7
3-8 3-16
3-12 3-8
3-7
3-1

"-------------- C --------------'1

(01) FIG 69-01-2

 SHAFT ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTy APPLIC1)BLE

24100J9024F1 'SHAFT ASSY

1 2410U300 SHAFT 1
, 1-1 YOKE 1
1-2 2410U300S2 BEARING 4
1-3 2410U300S3 COVER 4
1-4 2410U300S4 PLATE, LOCK 4
1-5 2410U300S5 CAPSCREW 8
1-6 2410U300S6 SPIDER 1
1-7 ZG91U02000 FITTING, GREASE 1
1-8 2410U300S8 WASHER, THRUST 4
1-9 2410U300S9 WASHER, THRUST 4
1-10 2410U300S10 WASHER, THRuST 4
1-11 TUBE ASSY 1
1-12 2410U300S12 OIL SEAL 2
1-13 2410U300S13 BEARING, BALL 1
1-14 2410U300S14 PLATE, THRUST 2
1-15 2410U300S15 SPACER 4
1-16 2410U300S16 RUBBER, CUSHION 1
1-17 2410U300S17 CAPSCREW 4
1-18 2410U300S18 NUT 4
1-19 2410U300S19 LOCK WASHER 4
1-20 2410U300S20 CASE 2
1-21 ZG91S02000 NIPPLE, GREASE 1
1-22 FLANGE 1
1-23 2410U300S23 NUT 1
2 2410U301 SHAFT 1
2-1 YOKE 2
2-2 2410U300S2 BEARING 8
2-3 2410U300S3 COVER 8
2-4 2410U300S4 PLATE, LOCK 8
2-5 2410U300S5 CAPSCREW 16
2-6 2410U300S6 SPIDER 2
2-7 ZG91U02000 FITTING, GREASE 2
2-8 2410U300S8 WASHER, THRUST 8
2-9 2410U300S9 WASHER, THRUST 8
2-10 2410U300S10 WASHER, THRUST 8
2-11 ZG91S02000 NIPPLE, GREASE 1
2-12 YOKE ASSy 1
2-13 2410U301S13 WASHER 1
2-14 2410U301S14 RING, FELT 1
2-15 2410U301S15 COVER, DUST 1
2-16 TUBE ASSY 1
3 2410U302 SHAFT 1
3-1 YOKE 2
3-2 2410U302S2 BEARING 8
3-3 2410U302S3 COVER 8
3-4 2410U302S4 PLATE, LOCK 8
3-5 2410U302S5 CAPSCREW 16
3-6 2410U302S6 CAPSCREW 16
3-7 2410U302S7 SPIDER 2
3-8 ZG91U02000 FITTING, GREASE 2

(011
 SHAFT ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS tHY APPLiCABLE

3-9 2410U302S9 WASHER, THRUST 8

3-10 2410U302S10 WASHER, THRUST 8
3-11 2410U302S11 WASHER' THRUST 8
3-12 ZG91S02000 NIPPLE, GREASE 1
3-13 YOKE 1
3-14 241OU302S14 COVER, DUST 1
3-15 2410U302S15 RING, FELT 1
3-16 YOKE 1
4 2416Pl1856 BRACKET 1
5 24816P903 BRACKET 1
6 ZS18F16050 CAPSCREW 12
7 2420T5691 CAPSCREW 8
8 ZS18C12030 CAPSCREW 4
9 ZN18C12010 NUT 8
10 ZN18F16013 NUT 12
11 2420T5692 NUT 8
12 ZW16H16000 WASHER 12
13 ZW16H12000 WASHER 16
14 ZW16H14000 WASHER 8
15 ZS18C12035 BOLT 4

{Ol)
"TI -I
Cl
I
Cl o
...a o
o
I
o l
.....
I

VIEW A-A

N J:
~
_ -<
0

111"11 ~'lt';U _II I I JI 11 I IV' ~ 3ic: sHNW" n~\ 11 ~ i tOm

B 0
o .CJ)
71 N r-
71-1 ~ ~
/------'7\
47.48.49.51

39.42.41.40

76.43.7169.65 32 33 39.44.45.46 61.67.50.77 10 39.44.45.46 46.45.44.39

VIEW B- B

....o
w
"'"
 HVD LINES. LOW
24100J9002Fl TG-0001-

II.
I
II.
Z
o
5
~

U o
I

U
I
o
z z
!2 E
t- t-
U
ILl
If)
frl
If)

(03) FIG ',-01-2(j)

 HVO LINES, LOW
TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS &TV APPLICABLE

21+100J9002F1 HVO LINES, LOW

1 2U8Pl1754 TUBE ASSV 1

2 2418Pl1753 TUBE ASSV 1
3 2418P17750 TUBE ASSV 1
4 2U8P17752 TUBE ASSV 1
5 2U8Pl7755 TUBE ASSV 1
6 2418Pl7751 TUBE ASSV 1
7 2418Pl7759 TUBE ASSY 1
8 2418Pl7758 TUBE ASSY 1
9 2418P17761 TUBE ASSV 1
10 2418P17757 TUBE ASSV 1
11 2418Pl7756 TUBE ASSV 1
12 2418P17760 TUBE ASSV 1
15 44.2607 FLANGE, SPLIT 2
16 45Z910104 O-RING 1
17 2420N458012045 CAPSCREW, SOCKET 4
19 2420N458010065 CAPSCREW 4
20 2U6P11662 BLOCK, VALVE 1
21 2418N2914 LINES, TUBE 1
! 22 2416T18247 BRACKET 1
23 2432P93304 CLAMP 1
25 ZX47P20092 HOSE ASSV 2
26 2444R144202 HOSE ASSV 1
27 2444R134402 HOSE ASSV 1
28 ZX37P16110 HOSE ASSV 1
29 2444R157501 HOSE ASSV 1
;,0 2444R144301 HOSE ASSV 1
31 ZX21M08750 HOSE ASSV 1
32 ZX37P20165 HOSE ASSV 1
33 2444R146002 HOSE ASSV 1
34 2444R144102 HOSE ASSV 1
35 ZX37P16235 HOSE ASSV 1
36 2444R144203 HOSE ASSV 1
39 ZW26K10000 LOCK WASHER 100
40 ZE12X16000 CLAMP, HALF 18
41 ZD12P03400 O-RING 9
42 2420N458D10030 CAPSCREW ;'6
43 ZW26Xl0000 LOCK WASHER 21
44 ZE12X20000 CLAMP, HALF 32
45 Z012P03800 O-RING 16
46 2420N458Dl0035 CAPSCREw 64
1t7 ZE12X2ltOOO CLAMP, HALF 6
1t8 ZD12P04800 O-RING 3
1t9 21t20N458D12035 CAPSCREw 12
50 ZW26X12000 LOCK WASHER 22
51 ZW26K12000 LOCItWASHER 16
53 ZC26X32011t CLAMP It
51t ZC26X28014 CLAMP It
55 21t32Z499D2 CLIP 2
56 ZC45X31014 CLIP 3
57 ZC45X22011 CLIP 9

(03)

'.
 HYD LINES, LOW
TG.OY01--

ITEM PART.NO DESCRIPTION REMARKS GlTY APPLICABLE

58 ZS16C12075 BOLT 9
60 ZS16C12025 CAPSCREW 6
61 ZS16C12070 CAPSCREW 7
62 ZS16C10025 CAPSCREW 5
63 ZS16C10060 CAPSCREW 4
64 ZS16C10065 CAPSCREW 4
65 ZN16C10008 NUT 12
66 ZN16C12010 NUT 4
67 ZC26X35016 CLAMP 8
68 ZC26X38016 CLAMP 8
69 ZC45X38014 CLIP 13
71 ZH32X08000 ELBOW 1
71-1 ZD12P01800 O-RING 1
72 24404R38805 ADAPTER 1
13 ZC45X50014 CLIP 2
75 ZW16P12000 WASHER 4
~6 ZW16X10000 WASHER 22
~7 ZW16X12000 WASHER 22

(OJ) 71-01-2 CD
 HYD LINES. STEER(CAT)
TG-OOO 1 - 24100J9025FI

11.11-1

34

VIEW A - A

FIG 72-01-1(j) (03)

 HYD.LINES,STEER (PIP CAT) TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GTy .APPL I CABLE

2UOOJ9025F1

1 24100N4690F1 LINIt ASSY p. 1/t-12 1

2 2UOON4691F1 LINIt ASSY P. 15-12 1
3 ZX24M06140 HOSE, HYDR 2
4 ZX44M06215 HOSE ASSY 1
5 ZX/t4M06285 HOSE ASSY 1
6 ZX22M08150 HOSE ASSY 1
1 2U8P11181 TUBE LINE 1
8 2/t20R524D02014 HOSE ASSY 2
9 ZH32x06000 ELBOW 2
9-1 Z012P01400 O-RING 1
10 2444Z2181 TEE 2
11 ZE12X12000 PLUG 1
11-1 ZP12P02240 O-RING 1
12 2lt8lt4T98D2 CONNECTOR 1
13 2UltU99D1 CONNECTOR 3
15 2444Z114001 RING 4
16 ZS18F160/t0 CAPSCREw 2
11 ZN18F16013 NUT 2
18 2406R215F2 ARM, PITMAN 1
19 ZS11C12025 CAPSCREW 1
20 ZS11C10020 BOLT 6
21 ZS11C10040 BOLT 1
22 ZS11C12065 BOLT 1
23 Z~16X12000 WASHER 1
24 ZW16X10000 WASHER 1
25 ZW26X12000 LOCItWASHER 2
26 ZW26X10000 LOCItWASHER 1
21 ZN11C12001 NUT 1
28 ZN11C10006 NUT 1
29 ZC15X05000 CLIP 6
30 ZC26X38016 CLAMP 1
31 ZC45X22011 CLIP 1
32 2432T2902 CLAMP 3
33 ZC45X50014 CLAMP 1
34 ZC41X20014 CLAMP 1
Z012P01400 2
"31 2432Z29005
O-RING
CLIP 2

(03) 12-01-1@
 HYD LINES. STEER (GM)
TG-0002- 24100J9417Fl

25.30.23. 22

"+
A

26,32,24
I
!

/
/ 1,1'\ \
4 5 40
13.15 15.13
34

VIEW A - A

FIG 72-02-1 (01)

 HYD.LINES,STEER (PIP GM) TG.0002--

ITEM PART.NO DEsCRIPTION REMARKS 6lTY APPLICABLE

24100J9417F1

1 2UOON4690F1 L.INK ASSY P. 74-72 1

2 2UOON4691Fl LINK ASSY P. 75-72 1
3 ZX24M06140 HOSE, HYDR 2
4 ZX44M06275 HOSE ASSY 1
5 ZX44M06285 HOSE ASSY 1
6 ZX24M08110 HOSE ASSY 1
7 2418P17781 TUBE LINE 1
8 2420R524D02014 HOSE ASSY 2
9 ZH32X06000 EL.BOW 2
9-1 ZD12P01400 O-RING 1
10 2444Z2781 TEE 2
11 2418P18633 TUBE LINE 1
12 ~4844T98D2 CONNECTOR 1
13 24844199D1 CONNECTOR 3
14 2436U1595F1 VALvE P. 73-72 1
15 2444Z1140D7 RING 4
16 ZS18F160~0 CAPSCREW· 2
17 ZN18F16013 NUT 2
18 2406R215F2 ARM, PITMAN 1
19 ZS17C12025 CAPSCREW 1
20 ZS17C10020 SOLT 4
21 ZS17C10085 BOL.T 2
22 ZS17C12065 BOLT 1
23 Z\.#16X12000 WASHER 1
24 zw26X10000 LOCK wASHER 8
25 zw26X12000 L.OCK WASHER 2
26 ZN17C10006 NUT 2
27 ZN17C12007 NUT 1
29 ZC15X05000 CL.IP 12
30 ZC26X38016 CL.AMP 1
31 2420R524D02012 HOSE ASSY 1
32 ZC45X31014 CLIP 4
33 ZC45X500l4 CLIP 1
34 ZC47X20014 CL.AMP .
35 ZD12POhOO O-RING 2
37 2432Z290D5 CL.IP 6
38 ZX32Ml2195 HOSE ASSY 1
39 ZX22M08072 HOSE ASSY 1
40 ZH22X12016 CONNECTOR 2
U 244412855 TEE 1
42 2444Z2739D3 ELBOw, 90 1
43 ZH32X06008 ELBOW 1
43-1 ZD12P01800 O-RING 1
44 ZX24M06130 HOSE ASSY 1
45 ZH22X12000 CONNECTOR 1
45-1 ZD12P02240 O-RING 1 I
46 ZX27M12400 HOSE ASSY 1 I
I
I

(Ol) 72-02-1
 VALVE ASSY,PRIORITY
TH-OOO 1--- 2436U 1595Fl
TG-0001--

FIG 73-72-1(D (0 t)
 VALvE ASSY,PRIORITY TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IilTy APPLICABLE

2436U1595Fl

1 BODY 1
2 SPOOL 1
3 2436U1595S3 SPRING 1
4 2420R912S1 PLUG 1
5 2436U1595S5 PLUG 1
6 ZS12D02900 O-RING 2
7 2436R1314 VALVE ASSY, RELIEF 1

(01)
 LI N K ASSY. DRAG (FRONT)
TG-0001- 24100N4690F1

11

2 12 3 '.5.6

12 11

10

8 9 7

SECTION A- A

FIG 74-72-1 (O1)

 LINK ASSY
LINK ASSy,FRONT DRAG TG.0001--

ITEM PART .NO DESCRIPTION REMARKS CilTY APPLICABLE

24100N4690 Fl LINK ASSY

1 2406P.382.3 LINK 1
2 2410P1049 JOINT 1
.3 24832T250 CLAMP 1
4 ZS18F12065 BOLT 1
5 ZN18F12010 NUT 1
6 ZW26X12000 LOCK wASHER 1
7 2414Z255 PLUG 2
8 2417Z209 SPRING 2
9 2418Z902 SEAT, BALL 4
10 2414Z256 BOOT 2
11 ZP15D05070 PIN 2
12 ZG91U02000 FITTING, GREASE 2

(01) 74-72-1
 LINK ASSY, DRAG(REAR)
TG-OOO 1- 24100N4691F1

12 3 4.5.6 2

12 11

10

7 9 B

SECTION A- A

FIG 75-72-1 (01)

 LINK ASSY
LINK ASSY,REAR DRAG TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100N4691F1 LINK ASSY

1 2406P3824 LINK 1
2 2410P1049 JOINT 1
3 24832T250 CLAMP 1
4 ZS18F12065 BOLT 1
5 ZN18F12010 NUT 1
6 ZW26X12000 LOCK WASHER 1
7 2414Z255 PLUG 2
8 2417Z209 SPRING 2
9 2418Z902 SEAT, BALL 4
10 2414Z256 BOOT 2
11 ZP15D05070 PIN 2
12 ZG91U02000 FITTING, GREASE 2

(01) 75-72-1
 ." ~
Cl
Cl I
o
-.J o
en o
I
o
l

B-1

14
13
12, 1\ j ~, ~~I~

~ A..? c-!. -- \ !L~~ /A z: g B-1

~ ~
---~
I

,..
N

o I'll
~
<
0
r-
z
o (/)
1,8-1 Jill I 1,4 11, .13.12 Y ~ .....-1 48 '-
to 0
.
o C
N -t
o'TI _;;C

SI' , il 1iL. ~I Ill.-. Cl

Cl
I'll
;;C
11 27.31.32.33
£RONT \ I / // I 'I. til! .Il '2IG ~" .... "9

.....
o
....,
Co)

~>j"\&\'\;,
"'"'
o
~

r~ ~I£i' ,_-'=r19
I
r'l
I

~ :J:
-<
C
23 12.13.14 43 N r-
51 12.13.14 14 14.13.12 46 ~
23-2
o Z
VI EW A-A o fTI
VIEW C-C '-Y'
~O
N c:
o -4
." XI
6-1
4.3 6 C)
17.24 2 I.n I.'
C)
m
XI
~
" =ar
11

lL _.... . _. -,

"TI
V lEW 0-0
c;l
-4
...a C)
en I
I o
o o
14 .13.12 12.1114 46 o
VI EW B-B
N 1
 HYD LINES, OUTRIGGER
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (HY APPLICABLE

24100J9020F1 HyD LINES, OUTRIGGER

1 36u379F1 VALVE, CONTROL OIR P. 78-76 2

2 2436U1602F2 VALVE, CONTROL P. 77-76 1
3 ZS16C08016 CAPSCREw 8
4 ZW26x08000 LOCK WASHER 8
5 ZH22W08DOO CONNECTOR 4
5-1 2445Z7D6 O-RING 1
6 ZH32W08000 ELBOW, 90 2
6-1 2445Z7D6 O-RING 1
7 ZX25M08134 HOSE 1
10 ZX25M08108 HOSE ASSY 1
11 ZX25M08494 HOSE ASSY 2
12 2418P14800D2 PLATE 8
13 2432T2902 CLAMP 8
14 ZM11C10020 SEMS-BOLT 22
15 ZN16C10QC8 NUT 6
16 ZW26X10000 LOCKWASHER 5
17 2444R1348D3 TEE 2
18 ZW16X10000 WASHER 5
19 ZH42W08000 ELBOW, 45 4
20 ZC47X24014 CLIP 5
21 ZC45X25011 CLAMP 1
22 2444R1473D1 HOSE ASSY 1
23 2444T3488 CONNECTOR 2
23-2 ZH52F08000 TEE 1
24 ZH22X08012 CONNECTOR 2
25 ZS16C10100 CAPSCREw 4
26 2444R389D5 ELBOW, 90 2
27 ZW26K10000 LOCK WASHER 4
28 2444R388D5 ADAPTER 1
29 ZX37M16070 HOSE ASSY 1
30 2432T3384 CLAMP 2
31 ZE12X16000 CLAMP, HALF 2
32 ZD12P03400 O-RING 1
33 2420N458D10030 CAPSCREw 4
36 2418P17376D1 TUBE LINE 4
37 2418P17376D2 TUBE LINE 8
38 2444T3409 CONNECTOR 4
39 ZH22X04000 CONNECTOR 8
40 2444Z2627 CONNECTOR 1
41 2444R83301 NOSE 1
42 2418P14800D5 PLATE 2
43 ZC45X46014 CLAMP 1
44 2414Z199D60 TUBE,SPIRAL 2
45 2414Z199D40 TUBE,SPIRAL 6
46 ZX25M08147 HOSE ASSY 2
47 ZX25M08157 HOSE ASSY 1
48 ZX25M08160 HOSE ASSY 4
49 ZX25M08163 HOSE ASSY 1
50 ZX25M08194 HOSE ASSY 1
51 ZX25M08198 HOSE ASSy 2

(03)
 HyD LINES, OUTRIGGER
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLIcABLE

52 ZX25M08203 HOSE ASSY 1

(03)
 CONTROL VALVE, OUTRIGGER
2436U1602F2 EXT.fRET.
TH-0001-
TG-0001 -v
TE-0001 .....
TD-OOOl ,...,

35
6-
21

8
~28

2 c. ~ 35
20

1125
8
~9
~15
- ______ 19
5

FIG 77-76-1(D (01)

 VALVE, CONTROL
VALVE,OUTRIGGER EXT/RET TG.OOO1--

ITEM PART ~NO DESCRIPTION REMARKS ~TY APPLICABLE

2436U1602F2 VALVE, CONTROL

1 COVER 1
2 BODY 1
3 COVER 1
4 SPOOL 1
5 2441U611S32 PLUG 3
6 2436U1602S6 PLUG 1
7 2436U1602S7 PLUNGER 1
8 BODY 2
9 SPOOL 2
10 2436U1602S10 RETAINER 2
11 2436U1602S11 ORIFICE 2
12 2436U1602S12 CAPSCREW 8
13 2436U1602S13 SHIM 8
14 2436U1602S14 STUD BOLT 4
15 2436U1602S15 SPRING 2
16 2436U1602S16 SPRING 1
17 2436U1602S17 SPRING 2
18 ZD11P00700 O-RING 4
19 ZD12P01100 O-RING 3
20 ZD11P01200 O-RING 2
21 ZD12P02100 O-RING 1
22 ZD11G03000 O-RING 2
23 2436U1695S14 O-RING 4
24 2436U1602S24 O-RING 2
25 2436U1000S17 PLUG 4
26 2436U1602S26 PLUG 1
27 2436U1602S27 PLUG 1
28 2420N458D04065 CAPSCREW 8
29 2420N458D08020 CAPSCREW 2
30 2420N458D08070 CAPSCREW 2
32 ZW26X12000 LOCK WASHER 8
33 2441U661S17 PLATE 1
34 2436U1OOOS30 SCREWDRiVER 4
35 2436U1602S35 SOLENOID 2
36 2436R1194F1 VALVE, RELIEF 1
37 2436U1602S37 O-RING 1
38 2436R1194S10 O-RING 1
39 2436U1602S39 CONNECTOR 1
40 ZS83C05006 SETSCREW 2
2436U1602R100 REPAIR KIT 1
CONSiSTS OF ITEM 18, 19, 20, 21, 22
23, 24, 37, 38

(Ol)
77-76-1(j)
 CONTROL VALVE. OUTRI GGER
TH-OOOl " J 36U319Fl
TG-OOOl "--'
TE-OOOl ~
TO-OOOl ~

5.6

1-4 1-15
1-23
1-14 1-22
1-16
1-21
1-18
1-8
1-17
1-19 1-21
1-2 1-11
1-3

1-1
1-5
1-6
1-2

SECTION A-A

FIG 18-16-1 (01)

 VALVE, SOLENOID
CONTROL VALVE,OUTRIGGER TG.0001--

ITEM PART~NO DESCRIPTION REMARKS &TV APPLICABLE

36U379Fi VALVE, SOLENOID

1 2436U2056F1 VALVE, SOLENOiD 4

1-1 SPOOL 1
1-2 36U379S2 SPRING 2
1-3 36U319S3 WASHER 1
1-4 36U379S4 NAME PLATE 1
1-5 BODY 1
1-6 O-RING 1
1-1 36U379S1 PLUG 1
1-8 36U319S8 COIL 1
1-9 36U319S9 PLATE, END 1
1-10 36U319S10 CASE 1
1-11 36U379S11 SLEEVE 1
1-12 36U319S12 SLEEVE 1
1-13 36U319S13 SPRING 1
1-14 36U319S14 CAPSCREW 4
1-15 RING 1
1-16 36U379S16 TUBE 1
1-17 36U319S11 PIN 1
1-18 36U319S18 PLUNGER 1
1-19 36U319S19 CONE 1
1-20 O-RING 1
1-21 O-RING 2
1-22 36U319S22 GUIDE 1
1-23 36U319S23 PIN 1
2436U2056R110 R,KlT 1-6,15,20,21 1
2 36U319S24 BRACKET 2
3 36U319S25 NUT 4
4 36U319S26 STUD 2
5 36U319S21 O-RING 3
6 36U319S28 SUPPORT, SEAL 3

(00 78- 7 6-1 CD

 TANK ASSY. HYD
TG-0001""" 24100J9008F1.F2

20.19
2.3
24.4
7.25
25.5
t t
A A
6.25 20.22.21

, , SECTION B-B
==-=-~-=---==-~~-=-==-.J::::.~=-=-~",== ~

22. 21.2Q19

12

15.14 6 7 4 5
SECTION A-A

FIG 79-01-1(1) (02)

 TANK ASSY, HyD
PIP CAT TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTY APPLICABLE

24100J90D8Fl TANK ASSY, HyD

1 24100J8852F4 RESERVOIR ASSY' OIL P. 80-79 1

2 24100J9009F1 PUMP ASSY P. 81-79 1
4 2418Pl1731 TUBE LINE 1
5 2418Pl1732 TUBE LINE 1
6 2418Pl1733 TUBE LINE 1
7 2418Pl1734 TUBE LINE 1
8 2420R524D04014 HOSE 2
9 2420R524D06014 HOSE 2
10 ZC15X06000 CLAMP 8
11 ZC15X08000 CLIP 8
12 ZE12X32000 CLAMP' HALF 6
13 ZE12X24000 CLAMP, HALF 2
14 ZS23C12035 SETSCREw 16
15 ZW26X12000 LOCK WASHER 16
19 ZS17C20070 CAPSCREW 6
20 ZW16X20000 WASHER 12
21 ZN17C20016 NUT 6
22 ZW26X20000 WASHER 6
24 ZD12P04800 O-RING 1
25 45Z91D84 O-RING 3
-

24100J9008F2 TANK ASSy

PIP GM

1 24100J8852F4 RESERVOIR ASSY, OIL P. 80-79 1

3 24100J9009F2 DRIVE ASSY, PUMP P. 81-79 1
4 2418Pl1731 TUBE LINE 1
5 2418Pl1732 TUBE LINE 1
6 2418Pl1733 TUBE LINE 1
7 2418Pl1734 TUBE LINE 1
8 2420R524D04014 HOSE 2
9 2420R524006014 HOSE 2
10 ZC15X06000 CLAMP 8
11 ZC15X08000 CLIP 8
12 ZE12X32000 CLAMP, HALF 6
13 ZE12X24000 CLAMP, HALF 2
14 ZS23C12035 SETSCREw 16
15 ZW26X12000 LOCK WASHER 16
19 ZS17C20070 CAPSCREw 6
20 ZW16X20000 wASHER 12
21 ZN17C20016 NUT 6
22 ZW26x20000 wASHER 6
24 Z012P04800 O-RING 1
25 45Z91084 O-RING 3

(02)
 Y 01 L
RESER VO IR ASS.
TG-0001'"'-' 24 1OOJ 88 52 F4

......--2-11
~2-10 9~
~2-9
£:+--14

0-- 2- 12
li 15

e-
~2-14
2- 13
15

22
22
®-2-15
0--2-16
0-
t-- 2 20
-
7

~ /~
v.
2-19

2-17~

~11

(03 )
FIG 80 -79-1 ®
 RESERVOIR ASSY' OIL
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy .APPL I CABLE

24100J8852 F4 RESERVOIR ASSY, OIL

2 2446U198F3 FILTER ASSY 2

2-9 2446U198S9 SPRING 1
2-10 2446U19SS10 NUT 1
2-11 2446U19SS11 PIN, SNAP 1
2-12 2446U19SS12 HOUSING 1
2-13 2446U198S13 VALVE 1
2-14 2446U19SS14 SPRING 1
2-15 2446U19SS15 SPACER 1
2-16 2446U19SS16 RING, RETAINING 1
2-11 2446U19SS17 PLATE, BOTTOM 1
2-19 2446U207F1 ELEMENT, FILTER 1
2-20 2446U19SS20 BOLT 1
3 R44P007SS4 STRAINER 1
4 24S46R2F1 CAP ASSY 1
5 2420P1925 PACKING 1
6 2414P5565 COVER 1
7 lD11G20000 O-RING 2
S 2450U6F1 INDICATOR 1
9 lE72T04000 PLUG 2
10 lD11P04400 O-RING 1
11 2444R409D7 PLUG 1
14 lSlSC10020 CAPSCREw 20
15 lW26X10000 LOCK WASHER 20
17 2479U476D2 SWITCH THERMO 1
lS 89l557D1 SENSER 1
19 24S9Z243 GAUGE, LEVEL 1
20 lH42XOSOOO CONNECTOR 1
20-1 lD12P01S00 O-RING 1
21 2427J2202 RESERVOI~, OIL 1
22 2414P6116 COVER 2

(03) 80-79-1 <D

 DRIVE ASSY
2410 ,PUMP
TG-OOO 1-- OJ 9009Fl, F 2

'0
~

~
..••,:'
oJ>..
9

®-'O
~1.2

',2

FIG 8 1-79-1(.1)
(Ol)
 PUMP ASSY
DRIVE ASSY,PUMP(P/P CAT) TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy .APPLICABLE

24100J9009F1 PUMP ASSY

1 24100U643F1 DRIvE ASSY, PUMP P. 82-81 1

3 2441U678F1 PUMP, GEAR P. 83-81 1
4 2441U849F1 PUMP, GEAR P. 84-81 1
5 2416P11603 BRACKET 2
6 ZS17C12040 CAPSCREW 8
7 ZS17C12030 CAPSCREW 4
8 ZW26X12000 LOCK WASHER 12
9 2416R161D2 RUBBER, MTG 4
10 2418T9088D2 WASHER 12
11 ZS17C08040 CAPSCREW 4
12 ZN17C08007 NUT 4

24100J9009F2 DRIVE ASSY, PUMP

DRIVE ASSY,PUMP(P/P GM)

2 24100U643F2 DRIVE ASSY, PUMP P. 82-81 1

3 2441U678F1 PUMP, GEAR P. 83-81 1
4 2441U849F1 PUMP, GEAR P. 84-81 1
5 2416P11603 BRACKET 2
6 ZS17C12040 CAPSCREW 8
7 ZS17C12030 CAPSCREw 4
8 ZW26X12000 LOCK WASHER 12
9 2416R161D2 RUBBER, MTG 4
10 2418T9088D2 wASHER 12
11 ZS17C08040 CAPSCREW 4
12 ZN17C08007 NUT 4

(OJ) 81-79-1 CD
 PUMP-DRIVE ASSY
TG-0001'"'-' 241 OOU 643 Flo F2

38

TA TA

'$1.22 22.35.36

9 22 32 12 20 34 10 3t 17

29 2 43 13 7 8 3 11 4 5 39 33 21
44 40 41
SECTION A-A

27 24 14 23 26 25 28 30 16

SECTION 8-8

FIG 82-81-teD (01)

 DRIVE ASSY, PUMP
PUMP-DRIVE ASSYCP/P CAT) TG.OOOl--

ITEM PART.NO DESCRIPTION REMARKS <ilTy . APPL I CABLE

24100U643F1 DRiVE ASSY, PUMP

1 24100US27S1 CASE 1
2 24100US27S2 CASE 1
3 24100US27S3 SHAFT 1
4 24100US87S4 GEAR 1
S 24100US87SS GEAR 1
7 2ST819D10 BEARING 2
8 24100US27S8 BEARING 1
9 2ST816D10 BEARING 2
10 24100US27S10 SLEEVE 1
11 24100US27S11 PLATE 1
12 24100US87S12 PLATE 1
13 24100US27S13 BEARING 1
14 24100U527S14 LEVER 1
15 24100U527S15 CLUTCH 1
16 24100U642S16 PIN 1
17 24100US27S17 COVER 1
18 24100US27S18 BALL 1
19 24100U642S19 SPRING 1
20 24100U527S20 NUT 1
21 ZS23C10020 CAPSCREW 16
22 ZS23C10025 CAPSCREw 14
23 ZN11C12010 NUT 2
24 ZN11C10008 NUT 1
25 ZS83C12030 CAPSCREW 1
26 ZS83C12025 SETSCREW 1
27 24100U527S27 SETSCREW 1
28 24100US27S28 PIN 1
29 24100U527S29 PIN 2
30 24100U527S30 OIL SEAL 2
31 24100U527S31 OIL SEAL 1
32 ZD11G04500 O-RING 1
34 24100US87S34 COUPLING 1
35 24100US27S35 BREATHER, AIR 1
36 24100US27S36 ELBOW 1
37 24100US27S37 COVER 1
38 ZE82T08000 PLUG 2
39 24100US27S39 BEARING 1
43 24100US87S43 GEAR 1

24100U643F2 DRIvE ASSY, PUMP

PUMP-DRiVE ASSYCP/P GM)

1 24100US27S1 CASE 1
2 24100US27S2 CASE 1

(00 82-81-1 CD
 DRIVE A55Y, PUMP
TG.0001-- PUMP-DRiVE A55Y(P/P GM)

ITEM PART .NO DE5CR I PTI ON REMARK5 CilTY APPLICABLE

3 24100U52753 5HAFT 1
7 25T819D10 BEARING 2
8 24100U52758 BEARING 1
9 25T816D10 BEARING 2
10 24100U527510 5LEEVE 1
11 24100U527511 PLATE 1
12 24100U587512 PLATE 1
13 24100U527513 BEARING 1
14 24100U527514 LEVER 1
15 24100U527515 CLUTCH 1
16 24100U642516 PIN 1
17 24100U527517 COVER 1
18 24100U527518 BALL 1
19 24100U642519 5PRING 1
20 24100U527520 NuT 1
21 Z523C10020 CAP5CREW 16
22 Z523C10025 CAP5CREW 14
23 ZN11C12010 NUT 2
24 ZN11C10008 NuT 1
25 Z583C12030 CAP5CREW 1
26 Z583C12025 5ET5CREW 1
27 24100U527527 5ET5CREW 1
28 24100U527528 PIN 1
29 24100U527529 PIN 2
30 24100U527530 OIL 5EAL 2
31 24100U527531 OIL 5EAL 1
32 ZDllG04500 a-RING 1
34 24100u587534 COUPLING 1
35 24100u527535 BREATHER, AIR 1
36 24100u527536 ELBOW 1
37 24100u527537 covER 1
38 ZE82T08000 PLUG 2
39 24100U527S39 BEARING 1
40 24100U527S4 GEAR 1
41 24100U527S6 GEAR 1
44 24100u527S5 GEAR 1

82-81-2(!) <OJ)
 GEAR PUMP• W INCH rSOOM
TH-0001 ,...,. 2441U678Fl HOIST
TG-OOOl ......
TE - 0001......,
TO-0001",

,
~"
21

12

FIG 83-81-1 (01 )

 PUMP, GEAR
WINCH/BOOM HOIST TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

2441U678F1 PUMP, GEAR

1 FRAME 1
2 BODY 1
3 BODY 1
4 CASE 1
5 SHAFT 1
6 GEAR 1
7 GEAR 1
8 GEAR 1
9 2441U678S9 PLATE 4
10 2441U678S10 COUPLING 1
11 2441U678S11 COLLAR 1
12 2441U678S12 BEARING 8
13 2441U678S13 BUSHING 1
14 RING 3
15 OIL SEAL 2
16 2441U678S16 RING, RETAINING 1
17 ZS18C18050 CAPSCREW 4
18 2441U678S18 LOCK WASHER 4
19 ZS18C12035 BOLT 4
20 ZW26X12000 LOCKWASHER 4
21 2420N458D18055 CAPSCREW 4
22 2441U678S22 WASHER 4
23 SEAL 4
24 SEAL 4
25 2441U678S25 PIN, KNOCK 4
2441U678RII0 REPAIR KIT 1
CONSISTS OF ITEM 14, 15, 23, 24

(OJ)
 GEAR PUMp, STEER I W. BOOST I SWI NG
TH-0001 "'-' 2441 U 84 9F1
TG-OOO' ......
TE-0001'"'"'
TO -0001 '"

~l
21

25

12

FIG 84-81-1 (01)

 PUMP, GEAR
STTER/w.BOOST/SWING TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TV APPLICABLE

2441U849F1 PUMP, GEAR

1 FRAME 1
2 BODY 1
3 BODY 1
4 CASE 1
5 SHAFT 1
6 GEAR 1
7 GEAR 2
9 2441U466S9 PLATE 4
10 2441U466S10 COUPLING 1
11 2441U466S25 COLLAR 1
12 2441U466S11 BEARING 8
13 2441U466S12 BUSHING 1
14 RING 3
15 OIL-SEAL 2
16 ZR26X04700 SNAP RING 1
17 ZS18C16045 CAPS CREw 4
18 Zw26X16000 LOCKWASHER 4
19 ZS18C10030 CAPSCREw 4
20 ZW26X10000 LOCK WASHER 4
21 2420N458D16055 CAPS CREW 4
22 2441U466S16 wASHER 4
23 O-RING 4
24 SEAL 4
25 2441U466S24 PIN 4
2441U849R110 REPAIR KIT 1
CONSiSTS OF ITEM 14, 15, 23, 24

(OJ) 84-81-1 <D

 CAB ASSY
TH-0001 -- 2.4800J565F3
TG-0001-

2-2

9--@l i -1513
11-'11
10

,;

17-i
21

26

FIG 86-01-1<D (03)

 CAB ASSY
TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS ClITY APPLICABLE

HSOOJ565F3 CAB ASSY

2 24S00N254F1 WIPER ASSY 1

2-1 2479U599 MOTOR, WIPER· 1
2-2 H88R114 BLADE 1
2-3 2lt06R217 ARM, WIPER 1
2-4 ZW26X06000 LOCK WASHER 4
2-5 ZS18C06016 CAPSCREW 3
2-6 ZS31C060ltO CAPSCREW 1
2-7 ZN18C06005 NUT 1
2-S ZW16X06000 WASHER 5
It 1t056RltF1 LIGHT ASSY, ROOM 1
4-1 4056RIt LIGHT 1
4-7 4056Zl9D1 BULB 1
6 2456R156F1 MIRROR, SIDE 1
7 2lt816PS60 BRACKET 1
8 H16T18767 BRACKET 2
9 ZN16COSOO7 NUT 4
10 ZW16X08000 WASHER 4
11 ZW22X08000 LOCKWASHER 2
12 ZM11COS020 BOLT 2
13 ZS16C06016 CAPSCREW 2
14 ZN16C06005 NUT 2
15 ZW16X06000 WASHER 2
16 ZW26X06000 LOCK WASHER 2
17 ZS16C10030 CAPSCREW 12
18 ZW22X10000 LOCKWASHER 12
19 ZN16C10008 NUT 7
20 ZM11C10020 SEMS-BOLT 5
21 ZW16X10000 WASHER 19
22 R3SNOO13 HORN, AIR 1
23 44&129002 CONNECTOR 2
24 44&12S9004012 HOSE 1
26 2427U483 MAT, FLOOR 1
28 24S00X207F4 CAB p. 87-S6 1
30 24879P15 WIRE HARNESS 1
31 H32Z290D2 CLIP 2
32 2420R189D6 GROMMET 1
33 ZS16C06020 CAPSCREW 6
34 2456R185 LAMP 3
31t-1 2479Z290 SENSOR, LOAD 1
35 ZS41C04008 MACHINESCREw 2
36 2418T9138 WASHER 2

I
I

(03)
 CAB
TH -0001 - 24800X207F4
TG-0001-

20

FIG 87-86-1(1) (04)

 CAS
TG.0001--

ITEM PART.NO DEsCRIPTION REMARI(S ~TY APPLICABLE

24800X207F4 CAB TG.0001--TG.9999

3 2427U361F1 WINDOw ASSY 1

4 2427X288 WELD, CAB 1
6 24816T1l58 BLOCK 2
7 24819T163 PIN 1
9 2427Z663 GLASS 1
10 2427Z661 GLASS 1
II 2427Z660 GLASS 1
12 2427Z664 GLASS 1
13 R27T00580367 RUBBER 1
14 R27T0058D215 RUBBER 1
15 R27T00580190 RUBBER 1
16 R27T0058D235 RUBBER 1
17 24870R1 INSULATION 1
18 24870R2 INSULATION 1
19 24870R3 INSULATION 1
20 24870R4 INSULATION 1
21 24870R5 INSULATION 1
22 2427R216D22 STRIP, WEATHER 1
23 ZS23C08020 CAPSCREW 16
24 ZW22K08000 LOCKWASHER 16
25 24870R6 INSULATION 1
26 24870R7 INSULATION 1
27 2427R216D51 STRIP, wEATHER 2
29 2420Zl686 STRIKER 1
30 ZS68C10018 CAPSCREW 2
32 24800J522F3 DOOR ASSY P. 88-87 1
33 2416P1l976 BRACKET 1
34 2420P2369 HINGE 2
35 2417T852 SPRING 2
36 2417T853 SPRING 2
37 ZS31C04006 MACHINSCREW 8
38 zw26X04000 LOCK WASHER 8

(04)
 DOOR ASSY
TH-0001 ..... 24800J522F3
TG-OOOl ~

15

24

10 9

14

FIG 88-87-1 (03)

 DOOR ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

24800J522F3 DOOR ASSY

2 24814P224 COVER 1
3 2406U141 REGULATOR 1
4 2406Z250 HANDLE 1
5 2420U116F2 LOCK ASSY 1
7 2406R189 HANDLE 1
8 2427Z662 GLASS 1
9 2427Z426D3 STRIP, WEATHER 2
10 2414R297 SHEET 1
11 ZS31C06012 SCREW 17
12 ZS31C06020 MACHINESCREW 11
13 ZW22X06000 LOCK WASHER 28
14 24818N164 PANEL 1
15 2427Z427D7 CHANNEL, RUBBER 2
16 2427Z427D8 CHANNEL, RUBBER 1
17 2427Z428 BUSHING, RUBBER 1
19 ZW22x08000 LOCK WASHER 2
23 2406R429 HANDLE 1
24 2427J2192 DOOR 1

(031 88-87-1
 TANK ASSV. FUEL
TG-0001-- 24100J9011Fl

13.14

I+- C I+-A

4 3.7

3 13 8 4 10.11.12 9 13

I
~....... '> I
'v/dtJ I
I
I
I
I
I
I
I
I
I

SECTION A- A SECTION C- C

FIG 89 -0 1-1 (02)

 TANK ASSV, FUEL
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IIITV APPLIC"BLE

24100J9011F1 TANK ASSV, FUEL

1 27U226D1 TANK, FUEL 1

2 1611186 BRACKET 3
3 1611187 STRAP 3
4 2479U641 SENDER, FUEL LEVEL 1
5 ZS18C12025 CAPS CREW 18
6 ZW16H12000 WASHER 18
7 1611117402 STRIP 3
8 2049VOO5 NUT 12
9 2414P6049 COVER 1
10 0661V039 CAPSCREW 5
11 ZW16K0500,? WASHER 5
12 ZW26X05000 LOCK WASHER 5
13 2418R14604 HOSE 1
14 2432Z29004 WIRE TIE 3

(02) 89-01-1
 Ll NES ASSV. A1R
T G- 0 0 0 1 "" 000 1. 24 1 00 J 9028 F 1

...z
II'
en
...z,
0 II)
...z, ...z,
....
II)
en
.... ...z
CD
N .... ~ ....0 cD

'---1--3
~"./
\I"""c~,"'i

=tift-----g
.,..ttt:7---_ _ ~
N
",

l,-
-
N ~ ....
en -
",

....
0'
...z

FIG 91-01-1(i) (02)

 LI NES ASSY, AIR
24100J9028Fl TG-0001-0001 .

....
.....
It>

II)
N

....
CD

....
ai

;; __----r-rIl

C02) FIG 91-0I-2eD

 LI NES ASSY. AIR
TG-OOO 1'"""0001. 24100J9028Fl

-
N

«
I-
UJ
C

o
In
o cD

~m .oJ
«
I-
ILl
o

CD
.oJ
«
I-
UJ
C

N
In
.oJ c;; .oJ
I In
.oJ o cD" «I-

- ~~Cfi
ILl
o
>
->

FIG 91-01-3G) (02)

 L.INES ASSY, AIR
TG.0001--

ITEM PART.NO DEsCRIPTION REMARI(S tHY APPL.ICABL.E

24100J9028 F1 LINES ASSY, AIR TG.0001--TG.0001

1 R38NOO01 VALVE, REL.AY 1

2 24100J8957F1 RESERVOIR ASSY' AIR P. 92-91 1
3 H100J8954F1 VALVE ASSY P. 93-91 1
4 2444J103 HARNESS, AIR 1
5 2444P1291 HARNESS, AIR 1
6 H44Z2654047 HOSE ASSY 2
7 2444Z2654078 HOSE 2
8 2444Z2654096 HOSE ASSY 2
10 446l1289D0608D HOSE 1
11 44611289008080 TUBE, NYL.ON 1
12 44611289006045 TUBE, NYLON 1
13 44\1l1289004017 TUBE, NYLON 1
14 H44Z2654088 HOSE ASSY 2
15 H44Z2654082 HOSE ASSY 4
16 ZC47X06007 CLIP 1
17 2432Z29004 WIRE TIE 5
18 H32Z29003 CLIP 10
19 ZC45X19011 CLIP 9
20 ZC47X20014 CLAMP 5
21 ZC45X38014 CLIP 6
22 ZC45X50014 CLIP 5
24 17Z8 SPRING 4
25 2444T957C1 ADAPTER 1
26 2444T3502 ADAPTER 4
27 2444P1270014 ADAPTER 1
28 H44P127009 ADAPTER 1
29 44&129203 TEE 1
30 4461129201 TEE 2
31 ZG52U04000 TEE 2
32 44\1l129202 TEE 1
33 ZG32B06000 ELBOW 10
1
34 '+46l129103 ELBOW
1
I
35 '+46l129105 ELBOW
36 ZD11P01400 O-RING 1
37 ZOllP01800 O-RING 1
38 244,+Z1l4002 PACKING 5
39 44&129002 CONNECTOR 5
40 44&129003 CONNECTOR 4
41 ZS17C06025 BOLT 1
42 ZS18C10035 CAPSCREW 2
43 ZS18C10025 CAPSCREW '+
44 ZS18C12025 CAPSCREW 4
45 ZS18C120'+0 CAPSCREW 2
46 ZN18C10008 NUT 25
I
47 ZN18C12010 NUT 2
48 ZN17C06005 NUT 1
49 ZW26X06000 L.OCK WASHER 1
50 ZW26X10000 L.OCKWASHER 25
51 ZW26X12000 LOCK WASHER 6
52 ZW16X10000 WASHER 21

(02)
 LINES ASSY, AIR
TG.OU01--

ITEM PART.NO DESCRIPTION REMARKS <ilTY APPLICABLE

53 ZW16X12000 WASHER 6
5. ZW16X06000 WASHER 1
55 ZS18C10030 CAPSCREW 1

91-01-2(1) (02)
 LI NES ASSV, AIR
TG-0002'" 24100J94SSFl

N
&n,
0 N
&n, &n
CD 0
,.,
~,
0 z
&n
cD
,.,
II) ~,
~
~
rft ,.,
~

CD
N
N
ai
-
~
,., -
c(
~

~
~
,.,
&n
0
~
CD
~
N

,.,0

t-
c(
u
,., a:
&n 0
IOu..
'-'---- &n, en
CD U.I
~, Z
N ::;

a:
c(

-
N

N -,.,
cot
cot

~ rft
a:
0 ..,
0
"-
en
ILl
z
~ :J

--
,., a:
c(

FIG 91-01A-l (01)

 LJ NES ASSV. AIR
24100J94SSFI TG-0002-

CD
N
CD
CO)

CD
an

.
~ ,,
-
'4

(01) FIG 91-01A-2

 LINES ASSV, AIR
TG-0002- 24100J9455Fl
It')
It')

N
N

-
•
N
It')

o
It')

~ <ri
~
~
<l
.... >
~
c
U)

~-1 ~.
I. 0

~~~
....J

....<l
~
c
(
"

o·
o.

~-1J

....<l
~
c

~
~

>

FIG 91-01A-3 (01)

 LINES ASSY, AIR
TG.0002--

ITEM PART .NO OESCR I PTI ON REMARKS (ilTY APPLICABLE

2'+l00J9455F1 LINES ASSY, AIR

1 R38NOO01 VALVE. RELAy 1

2 24100J8957F1 RESERVOIR ASSY' AI~ P. 92-91 1
3 24100J8954F1 VALVE ASSY P. 93-91 1
4 2444J132 HARNESS. AIR 1
5 2444P1291 HARNESS. AIR 1
6 2444Z2654060 HOSE 2
7 244'+Z2654D78 HOSE 2
8 2444Z2654096 HOSE 2
10 44&1289006080 HOSE 1
11 44&1289008080 TUBE, NYLON 1
12 446)12B9006045 TUBE. NYLON 1
13 44&12B9004017 TUBE. NYLON 1
14 2444Z2654DB8 HOSE ASSY 2
15 2444Z26540B2 HOSE ASSY 4
16 ZC45X12011 CLIP 1
17 2432Z29004 WIRE TIE 3
19 ZC45X19011 CLIP 9
20 ZC47X20014 CLAMP 2
21 ZC45X38014 CLIP 11
22 ZC45X50014 CLIP 3
23 ZC45X46014 CLAMP 7
24 1nB SPRING 4
25 2444T957C1 ADAPTER 1
26 244413502 ADAPTER 4
27 2444P1270D14 ADAPTER 1
28 2444P1270D9 ADAPTER 1
29 44&129203 TEE 1
30 44Cill29201 TEE 2
31 ZG52U04000 TEE 2
32 44(il1292D2 TEE 1
33 ZG32B06000 ELBOW 10
34 44(il129103 ELBOW 2
35 44&129105 ELBOW 1
36 ZOllP01400 O-RING 1
37 ZOl1P01800 O-RING 1
38 2444Zl140D2 PACKING 5
39 44&129002 CONNECTOR 1
40 44Cill29003 CONNECTOR 3
42 ZS18C10035 CAPSCREW 2
43 ZS18C10025 CAPSCREW 5
44 ZSlBC12025 CAPSCREW 4
45 ZS18C12040 CAPSCREW 2
46 ZN18C1000B NUT 28
47 ZNlBC12010 NUT 2
50 ZW26X10000 LOCK WASHER 30
51 ZW26X12000 LOCK WASHER 8 II

52 ZW16X10000 WASHER 5 !
I
53 zw16x12000 WASHER 27 I
55 ZSlBC10030 CAPSCRE,W 2
56 44&129102 ELBOw 2
57 ZS18C12016 BOLT 2

(OJ) 91-01A-l
 RESERVOIR ASSY.AIR
TH-OOOI - 24100J8957Fl
TG-0001--

23
2

30

11

(--
_L-/~, ...) 11-11
11-9
11-8
11-10
d:l2.11-13

11-6
11-5
2

FI G 92-91-1(1) (07)
 RESERVOIR ASSY' AIR
TG.0001--

ITEM PART.NO DESCRIPTION REMARI(.S GTy .APPL I CABLE

24100J8957 F1 RESERVOiR ASSY, AIR

1 2427R576D1 RESERVOIR, AIR 1

2 2427R576D2 RESERVOIR 3
3 2416N4480 BRACKET 1
4 2416Tl8488 BRACKET 6
5 2416Tl8489 BRACKET 2
6 2420T5464 BOLT 6
7 2420T6024 U-BOLT 2
8 ZN18C10008 NUT 32
9 ZW26X10000 LOCKWASHER 32
10 ZS18C10025 CAPSCREW 16
II 2436U1973 VALVE,DRAIN 1
ll-l BODY 1
11-2 VALVE ASSY 1
11-3 GUIDE, VALVE 1
11-4 RING, SEAL 1
11-5 COVER 1
11-6 2436U1973S6 THERMOSTAT 1
11-7 2436U690S55 SEMS-BOLT 4
11-8 ADAPTER 1
11-9 FILTER 1
11-10 RETAINER 1
11-11 2436U1973S11 FILTER 1
ll-12 2436U1973S12 MACHINE SCREW 2
11-13 2415R298S33 LOCK WASHER 2
2436U1973R101 REPAIR KIT 1
11-2,3,4,8,9,10
12 2436U1672F1 DRAIN,COCK 3
14 ZE82T08000 PLUG 6
15 ZE82T04000 PLUG 3
16 ZG22E08000 NIPPLE 3
17 ZG52U08000 TEE 3
18 ZG22E08004 CONNECTOR 1
19 R38T000103 VALVE 1
20 ZG32B04000 ELBOW, 90 1
21 R38POO0901 VALVE, CHECK 2
22 44&129106 ELBOW 5
23 44&129107 ELBOW 1
24 44&129006 CONNECTOR 3
25 44&129004 CONNECTOR 1
26 44&129103 ELBOW 3
27 44&1289008070 HOSE 1
28 44&1289008022 HOSE 1
29 44&1289008032 HOSE 1
30 441\11289006042 HOSE 1
31 ZG22B08006 BUSHING 1
32 2436R201 VALVE, CHECK 1

(07)
 VALVE ASSV
TH-0001-
TG-0001- 24100J8954Fl

FIG 93- 91- 1 <D

(03)
 VALVE ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS iilTy _APPL I CABLE

21+100J8951+F1 VALVE ASSY

1 21+816P871+ BRACKET 1
2 R38NOO01 VALVE, RELAY 2
3 36&192 VALVE, BRAKE 1
4 2436R201 VALVE, CHECK 1
5 ZG22E06000 CONNECTOR 1
6 ZG52U06000 TEE 1
7 ZG32B06000 ELBOW 5
8 ZG22B06004 CONNECTOR 1
9 ZE72T04000 PLUG 1
10 44&129102 ELBOW 1+
11 44&129104 ELBOW 1
12 44&129103 ELBOW 2
13 ZG22E04000 NIPPLE 1
14 44&129004 CONNECTOR 1
15 21+44R74002 CONNECTOR 4
16 1+4&129003 CONNECTOR 2
17 1+1+&1289004035 HOSE 1
18 1+4&1289004040 HOSE 1
19 1+4&1289006040 HOSE 1
24 ZS18C10035 CAPSCREW 1+
25 ZN18C10008 NUT 1+
26 ZW26X10000 LOCK WASHER 4
27 ZS18C08030 CAPSCREW 2
28 ZN18C08007 NUT 2
29 ZW26X08000 LOCK WASHER 2
30 44&129107 ELBOW 1
31 ZG52U08000 TEE 1
32 ZG22E08006 NIPPLE 1
33 ZG22B08006 BUSHING 1

(03)
 ELEC ASSY. LOWER
TG-OOO 1 ....... 0001. 24100J9027Fl

" , -_ _ 0
~

;;;
cO
N
r-:
N
N
.N

FIG 95-01-1(1) (01)

....o
....
'-J

31 27.28 13.24.35.37.13-1

22

26.7.25.37.7-1

30.6
VIEW H-H
5.29
VIEW p-p
~4' ITI
N
r-
ITI
VIEW L- L l-o
n
0
a l>
lJ)
'-
21. 20.18 CD lJ)
a :<
N
~ r-
5-3.5-2.5 "T'I 0
6-3.6-2.6 ~
ITI
:u

VIEW J-J
3.4

VIEW K-K 15.16.17

109~
"T'I 41~~ -t
(i)
I
(i)
~. .. . ..=4 14.34 o
a

o
CD
(II
I
DElAI L E
12
DElAI L A SECTION M-M
-l
a

o
a
I o
N :-
e
 ELEC ASSY, LOWER
TG.0001--

ITEM PART.NO OE SCR I PTI ON REMAR~S (HY APPLICABLE

24100J9027F1 ELEC ASSY, LowER TG.0001--TG.0001

1 24800J635F1 80X, RELAY P. 96-95 1

2 2479J286 HARNESS, WIRING 1
3 24800J639F1 80X ASSY, CONTROL P. 97-95 1
4 24800J639F2 80X ASSY, CONTROL P. 97-95 1
5 2456U23 LAMP 1
5-2 2456Z385 8UL8 1
5-3 2456Z384 8UL8 2
6 2456U24 LAMP 1
6-2 2456Z385 8UL8 1
6-3 2456Z384 8UL8 2
7 2456R186 LIGHT 1
7-1 405611901 BULB 1
8 24100J8947F2 LIGHT ASSY,8UMPER P. 98-95 1
9 87Z270 SOCKET 4
10 2456Z290 LAMP 4
11 56R101 MARKER, SiDE 2
12 56R102 MARKER, SIDE 2
13
13-1
56&4601
24791290
MARKER, RE.
SENSOR, LOAD ,
1

14 2416T18,43 BRACKET 1
15 ZC17C08020 CAPSCREW 14
16 ZN17C08007 NUT 6
17 ZW26X08000 LOCK WASHER 14
18 ZS17C06016 CAPSCREW 6
19 ZN.17C06005 NUT 2
20 ZW16X06000 WASHER 10
21 ZW26X06000 LOCK WASHER 8
22 ZC45X22011 CLIP 6
23 ZS31C04020 SCREw 8
24 ZS31C05016 MACHINESCREw 2
25 ZW16P05000 WASHER 4
26 ZN16CO'004 NUT 2
27 ZN17C10008 NUT 6
28 ZW26X10000 LOCKWASHER 10
29 2414Z344 COVER 1
30 24141345 COVER 1
31 ZW16H12000 WASHER 6
32 2416N4563 BRACKET 1
33 ZS17C06025 80LT 2
34 2416T18555 8RACKET 1
ZS17C10016 CAPSCREW 4
"
36 ZW16X10000 WASHER 4
37 ZW26X05000 LOCK WASHER 4
38 ZW26X04000 LOCK WASHER 8
39 ZN16C04003 NUT 8
40 2432Z29004 WIRE TIE 20
41 ZW16P04000 WASHER 8
42 2432Z309 CLAMP 4
It, ZC45X12011 CLIP 2
44 2420R18902 GROMMET 1

(OJ)
 ELEC ASSY, LOwER
TG.OU01--

ITEM PART.NO DESCRIPTION REMARI(.S ~TY APPLICABLE

45 2479P926 WiRE HARNESS 2

con
 ELEC ASSY. LOWER
TG-0002 ....... 24100J9374Fl

l"
a 0
~

r--
cci
an N
tSJ' cd
N ~ II)
r--'
N,
iii fS
I'"
N N
N N
cci N
N
N
a;
~
II)

S
CD
~

0
~

CD
ilL_---r-- ~

F J G 95 - 0 1A-1 (01)
......
o

13.24.35.37.13-1

19.21.1,9.50 13.?Io.25.37.13-1

j4-J

19.21.49.50
30.6 5.29
VIEW B-B ITI
N r
VIEW p-p ~ ITI
27.28.1,7.51 27.28.1,3.51 n
o ~
~ U)
21. 20.18 CD U)
....,
W
.-<
~ r
5-3.5-2.5 'TJ 0
6-3.6-2.6 ~
ITI
::0

VIEW A-A
3.4

VIEW J-J

'TJ

Q -4

CD
,
Cil
UI 12 o
I o
...
o
~
DETAIL L DETAIL F SECTION Q-Q o
N

N
I l
 ELEC ASSY, LOWER
TG.0002--

ITEM PART.NO DESCRIPTION REMARKS G1TY .APPL I CABLE

24100J9374F1 ELEC ASSY, LOWER

1 2_800J635F1 BOX, RELAY P. 96-95 1

2 2479J360 HARNESS, WIRING 1
3 24800J639F1 BOX ASSY, CONTROL P. 97-95 1

-5
5-2
24800J639F2
2.56U23
2456Z385
BOX ASSY, CONTROL
LAMP, COMBINATION
BULB
P. 97-95 1
1
1
5-3 2456Z384 BULB 2
6 2.56U24 LAMP, COMBINATION 1
6-2 2456Z385 BULB 1
6-3 2456Z3h BULB 2
7 2456R186 LAMP 1
7-1 4056Z1901 BULB 1
8 2UOOJ8947F2 LIGHT ASSY, BUMPER P. 98-95 1
9
10
87Z270
2456Z290
SOCKET
LAMP
•4
11 56R101 MARKER, SIDE 2
12 56R102 MARKER, SiDE 2
13 566)4601 MARKER, RE. 1
13-1 2479Z290 SENSOR, LOAD 3
14 2U6T18543 BRACKET 1
15 ZS17C08020 CAPSCREW 10
16 ZN17C08007 NUT 8
17 ZW26X08000 LOCK WASHER 12
18 ZS17C06016 CAPSCREW 6
19 ZN17C06005 NUT 5
20 ZW16X06000 WASHER 10
21 ZW26X06000 LOCK WASHER 11
22 ZC45X22011 CLIP 4
23 ZS31C04020 SCREw 8
24 ZS31C05016 MACHINESCREw 2
25 ZW16P05000 WASHER 4
26 ZN16C05004 NUT 2
27 ZN17C10008 NUT 16
28 ZW26X10000 LOCK WASHER 20
29 2UU3.4 COVER 1
30 2U4Z345 COVER 1
1 !
32 2U6N4563 BRACKET I
33 ZS17C06025 BOLT 2 I

34 2416T185"
ZS17C10016
BRACKET
CAPSCREW
1
4
I
"
36 ZW16X10000 WASHER 6
,.
37 ZW26X05000 LOCK WASHER
38 ZW26X04000 LOCK WASHER 8
39 ZN16C04003 NUT 8 II
40 2432Z29004 WIRE TIE 3 i
41 ZW16P04000 WASHER 8
42 2432Z309 CLAMP '+
!I
43 ZC.5X12011 CLIP 2 I
44 2420R189D2 GROMMET 1
"-.>'

"5 2479P926 WIRE HARNESS 2

95-01.4-1@
 ELEC ASSY, LOwER
TG.OY02--

ITEM PART .NO DESCRIPTION REMARK" tilTY APpl.ICABL~

46 ZC45X29011 CLIP 13
47 ZC45X16011 CLAMP 5
48 ZC47X14011 CLIP 2
49 ZC45X06007 CLAMP 4
50 ZW16X08000 WASHER 3
. 51 ZW16X12000 WASHER 16

,1
 BOX ASSY. RELAY
TH-0001-- 24800J635Fl
TG-0001-
12 13.17.19 14.17.19 16.19 9 8

6 16.19

19 .13
10

5
22

20.18.15
f;;.:;:::::==i-+--tt--"

23

6
2

19.17.13

7 15.18.20 3 4

SECTION A-A

A A
1: 1:

16
14
19

21 -===¥~~;2iif"-16

19
17 VIEW 8-8

FIG 96-95-1(D (02 )

 BOX, RELAY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &Ty. APPLICABLE

24800J635Fl BOX, RELAY

1 2418J342D2 BOX, CONTROL 1

2 2414J13f18 BOX, CONTROL 1
3 24879N19 WIRE HARNESS 1
4 24879N21 WIRE HARNESS 1
5 2479R284 RELAY,IGNITION(R3) 1
6 2479R731Dl RELAY (R4 & R12) 2
7 2479R425 RELAY,STARTER (Rl) 1
8 2479P804 BOARD, TERMINAL 1
9 79&69209 BREAKER 20A 2
10 79&692011 BREAKER 30A 7
11 2479Tl330 JUMPER 2
12 2418Tl3264 RUBBER, NEOPRENE 1
13 ZS31C05012 MACHINESCREw 6
14 ZS31C05025 MACHINESCREw 3
15 ZS31C06010 MACHINESCREw 4
16 2037v005 NUT 36
17 ZN16C05004 NUT 7
18 ZN16C06005 NUT 4
19 ZW26X05000 LOCKWASHER 27
20 ZW26X06000 LOCK WASHER 4
21 2418Tl3263Dl SPACER 3
22 2414Z194D7 CAP,TERMINAL 5
23 2414Zl94D12 CAP,TERMINAL 2

(02) 96-95-1 CD
 BOX ASSY,CONTROL(OUTRIGGER)
TH-0001- 24800J 639F1.F2
TG-0001-
I4-B
.--

C
!
2

r-------"\
I
I
I
I
I
I"'--_____ .--JI
)
9

~A:~;_----~~I~~~I~~B
L..-_...J

6 4

13
5
11.10

12 16.17.18

SECTION A-A (F1) SECTION C-C

SECTION B- B (F1)

14

SECTION A-A(F2)

SECTION B- B (F2)

FIG 97- 95-1 (02)

 BOX ASSY, CONTROL
RIGHT OUTRIGGER CONTROL TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24800J639F1 BOX ASSY, CONTROL

1 24832N18 PANEL 1
2 24814J63 BOx, CONTROL 1
3 24879Tl8 WIRE HARNESS 8
4 79&76001 SWITCH,MASTER 1
5 79&760011 SWITCH,CYL,CONTROL 4
6 R79P0060F1 LAMP, SIGNAL 1
6-5 R79T0048D7 BULB, LIGHT 1
7 24879N22D1 wiRE HARNESS 1
9 32Z1665 LABEL 1
10 ZS32T04010 SCREW, TAPPING 4
11 ZW16P04000 WASHER 4
12 2406R302 HANDLE 1
13 2406Z434 HANDLE 1
16 ZS31C04010 MACHINESCREw 3
17 ZN18C04003 NUT 3
18 ZW26X04000 LOCK WASHER 3

24800J639F2 BOX ASSY, CONTROL

LEFT OUTRIGGER CONTROL

2 24814J63 BOX, CONTROL 1

3 24879Tl8 WIRE HARNESS 8
4 79&76001 SWITCH,MASTER. 1
5 79&760011 SWITCH,CYL,CONTROL 4
6 R79P0060F1 LAMP, SIGNAL 1
6-5 R79T0048D7 BULB, LIGHT 1
8 24879N22D2 WIRE HARNESS 1
9 32Z1665 LABEL 1
10 ZS32T04010 SCREw, TAPPING 4
11 ZW16P04000 WASHER 4
12 2406R302 HANDLE 1
13 2406Z434 HANDLE 1
14 24832N17 PANEL 1
16 ZS31C04010 MACHINESCREW 3
17 ZN18C04003 NUT 3
18 ZW26X04000 LOCK WASHER 3

(02) 97-95-1CD
 LIGHT ASSV, BUMPER
TH-0001- 24100J8947F2
TG-0001 ........

"';---+-+-~I-.......I

~
-:
o

o o

o o
N
-:
~
N
S!

FIG 98-95-1(:D (05)

 LIGHT ASSY. BUMPER
TG.0001--

ITEM PART .NO DESCRIPTION REMARKS lilTY APPLICABLE

24100J8947F2 LIGHT ASSY. BUMPER TG.0001--

1 2456U25F1 LAMP. HEAD 1

2 2456U25F2 LAMP. HEAD 1
4 56R1D2 MARKER. SIDE 2
5 56l409D3 SEALED BEAM 2
6 56Z409D4 SEALED BEAM 2
8 2432l290D1 CLIP 7
9 ZS31C04020 SCREW 4
10 ZS31C06016 SCREw 16
11 lN17C06005 NUT 16
12 ZW26X06000 LOCI( WASHER 16
13 56U1D1 LIGHT. SIGNAL 1
14 56U1D2 LIGHT, SIGNAL 1
15 R79T0048D6 BULB 2
16 87Z270 SOCKET 2
17 24561290 LAMP 2
18 ZN16C04003 NUT 4
19 ZW16X04000 WASHER 4
20 ZW26X04000 LOCK WASHER 4
21 2045V001 NUT 4
22 3631V005 WASHER 4
23 3616VOO7 LOCKWASHER 4
24 2479N487 HARNESS, WIRING 1

(05) 98-95-1CD
 INSTAL,WINCH, MAIN
TO-0001 ...... 24100J 8838 F3
TG - 0001 ,...

,f; .'

FIG 103-01-1 (02)

 INSTAL, wiNCH, MAIN
1581 MAIN TG.0001--

ITEM PART.NO DESCRIPTION REMARKS COTY APPLICABLE

24100j8838F3 INSTAL, WiNCH, MAIN

3 ZW16H20000 WASHER 8
4 ZSlBC20075 CAPSCREW 8
5 ZN1BC20016 NUT 8
6 24100J8341F3 WINCH ASSY P. 110-103 1

(02)
 INSTAL, WINCH, AUX
TO-OOOl -- 24100J8838F4
TG-OOOl ..,

FIG 107 - 03-1

(02)
 INSTAL, wiNCH, AUX.
1581 AUx, TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &Ty APPLICABLE

24100J8838F4 INSTAL, WiNCH, AUX.

2 ZS18C20065 CAPSCREw 8
3 ZW16H20000 WASHER 8
6 24100J8341F3 WiNCH ASSY P. 110-103 1

\ .'

(02) 107-03-1
 WINCH ASSV-1581
TE-0001.-..... 24100J8341F3
TH- 0001--
TD-0001-.....
TG- 0001--

35
35-7

FIG 110-103-1G)
(05)
 WiNCH ASSY
1581 WINCH TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100J8341F3 WINCH ASSY TG.0001--TG.9999

2 2416T17210 BRACKET 1
6 ZF23F10004 CONNECTOR 7
10 ZF33F10004 ELBOW, 90 3
11 ZD12P01100 O-RING 11
12 ZC45X10009 CLIP 2
13 ZS18C06012 CAPSCREW 2
14 ZS18(06040 BOLT 2
15 ZN18C06005 NUT 2
16 ZW16X06000 wASHER 2
17 ZW26X06000 LOCK WASHER 4
19 2436U1809F1 VALVE P. 111-110 1
22 2418P17124 LINE, TUBE 1
27 2418P17828 TUBE 1
28 2418P17829 TUBE 1
29 2418P17744 TUBE 1
30 2418P17830 TUBE 1
31 2444T3518 CROSS 1
32 ZD12P01800 O-RING 1
33 2418T16218 TUBE 1
34 2444Z2800 TEE 1
35 24100J9018F2 wiNCH ASSY 1
35-2 2418P15276 COUPLING 1
35-3 ZS23C16060 CAPSCREW 4
35-4 ZD11G18500 O-RING 1
35-~ lw16H16000 WASHER 4
35-7 24100X2247F4 WiNCH ASSY P. 112-110 1
35-8 2441U868F1 MOTOR ASSY P. 114-110 1

(05) 110-103-1 <D

 CONTROL VALVE, NEGA BRAKE
TE-OOOlrv 2436U1809Fl
TO-0001"",
TH- 0001 "'"
TG- 0001 "'-

9 3 7 14 12 8 11 2 13 4 10

SECTION A-A

FIG 111-110-HD (01 )

 VALVE
NEGA BRAI(E TG.0001--

ITEM PART.NO DESCRIPTION REMARI(S (ilTy .APPLICABLE

2436U1809F1 VALVE

1 BODY 1
2 SPOOL 1
3 2436U1809S3 COVER 1
4 2436U1809S4 COVER 1
5 2436U1809S5 RETAINER 1
6 2436U1809S6 ORIFICE 1
1 2436U1809S1 SPRING 1
8 2420N458D06065 CAPSCREW 4
9 2420N458D06040 CAPSCREW 4
10 2420N458D06020 CAPSCREW 4
11 2436U1018S11 PLUG 4
12 2436U1000S11 PLUG 1
13 ZD12P02200 O-RING 1
14 2436U1809S14 O-RING 1
15 2436U1809S15 O-RING 4
16 2436U1809S16 PLATE, SUB 1
2436U1809RllO REPAIR I(IT 1
CONSISTS OF ITEM 13, 14, 15

(0]) 111-110-1 CD
 REDUCTION UNIT, WINCH-1581
TE-0001-- 24100X2247F4
TH- 0001--
TO - 0001 --
TG - 0001--

44
38

(OS)
FIG 112-110-1 CD
 WINCH ASSY
WINCH 1581 TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~Ty . APPL I CABLE

24100X2?47F4 WiNCH ASSY

1 2414J1378 HOUSING 1
2 2423J537 DRUM 1
4 2425J262 SUPPORT 1
5 2425J264 CARRIER, BEARING 1
7 2413J495 SPIDER 1
8 2413J503 SPIDER 1
9 2401N621 SHAFT, PINION 1
10 PINION 3
11 PINION 3
12 2401P917 GEAR, SUN 1
13 2401N622 GEAR, RING 1
15 2439P250 PINION 1
16 SHAFT 3
17 PIN 3
18 2418T9847 PLATE, LOCK 3
19 2418T14533 PLATE, LOCK 3
20 2418T13523 RETAINER 1
21 2408T270 WEDGE 1
22 2418T13524 SPACER 2
23 2418T14982 SPACER 1
24 2418T15685 WASHER, THRUST 1
25 2418T15684 WASHER, THRUST 1
26 2418T14927 WASHER, THRUST 1
27 WASHER, THRUST 6
28 2405T1167D2 BUSHING 1
29 2405T1184 BUSHING 1
30 2420T5323D1 BOLT, ROD 2
31 ZS18C16045 CAPSCREW 10
32 ZS18C12040 CAPSCREW 6
33 ZS18C08012 CAPSCREw 12
34 ZS23C14040 CAPSCREW 14
35 ZS23C06016 CAPSCREW 2
36 ZS23C12040 CAPSCREW 18
37 ZN32F20018 U-NUT 1
38 ZN32C18016 U-NUT 4
39 25Z259D82 BEARING 2
40 BEARING 6
41 BEARING, NEEDLE 3
42 2425Z583 BEARING 1
43 2418T13526 SLEEVE 2
44 SEAL, OIL 2
45 2446T104 FITTING, RELIEF 1
46 ZR16X03000 RING 1
47 O-RING 2
48
49
O-RING . 1
O-RING 1
50 O-RING 1
51 O-RING 1
52 RING, BACK-UP 1
53 RING, BACK-UP 1

(06) 112-110-1(D
 WINCH ASSY
TG.0001-- WiNCH 1581

ITEM PART .NO DESCR I PTI ON REMARKS 6lTY APPLICABLE

54 ZE82T08000 PLUG 1
55 2420T5324D1 SHIM, 0.10 1
56 2420T5324D2 SHIM, 0.2 2
57 2420T5324D3 SHIM, 0.5 5
64 2425J272 SUPPORT 1
.65 2414P5239 COVER 1
66 ZE72X04000 PLUG 1
67 ZE82T02000 PLUG 1
69 24100J8148F3 BRAKE ASSY P. 113-112 1
24100X2247R100 KIT, PINION 1
CONSISTS OF ITEM 10, 17, 27, 41
24100X2247RllO KIT, PINION 1
CONSISTS OF ITEM 11, 16, 40
24100X2247R120 KIT, SEAL 1
CONSISTS OF ITEM 44, 47, 48, 49, 50
51, 52, 53

112-110-2 <D (OS)

 BRAKE ASSY, WI NCH
TE-0001- 24100J8148F3
TH-OOOl "'"
TO - 000 1--
TG-0001~

(05)
FIG 113 -112 - 1 CD
 BRAKE ASSY
BRAKE ASSY'WINCH TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTy . APPL I CABLE

24100J8148F3 BRAKE ASSY

1 2413J502 SPIDER 1
4 2415T194 PLATE 2
5 2415U271 PLATE, DISK 6
6 2415U197 DISK, FRICTION 5
7 2415P332 PLATE, END 1
9 RACE, OUTER 1
10 RACE, INNER 1
12 WASHER, THRUST 2
13 BEARING 2
15 RING, SNAP 2
16 ZS18C12080 CAPSCREW 8
17 2420T5420 U-BOLT 1
18 2417T287 SPRING 18
19 25Z280D10 BEARING, NEEDLE 1
20 2439N261 ROD 1
21 2415P340 PLATE 1
22 24111T16148 WASHER 1
23 2418T16228 SPACER 8
24 CAM CLUTCH 1
24100J8148R100 CLUTCH ASSY 1
CONSiSTS OF ITEM 9, 10, 12, 13, 15
24

(06)
113-112-1 CD
 MOTOR ASSY. WINCH
TE-0001"",-, 2441U868Fl
TO- 0001 '"'-'
TH-OOOl -..
TG-OOOl -V .

2.2-1 2-2

5-1

5-2

4-3
4-2

4-1.

J, -1

DETAIL ITEM J,

FIG 11 4 - 11 0 - lID (01 )

 MOTOR ASSY
WINCH TG.0001--

ITEM PART.NO DESCRIPTION REMARKS IilTY APPLICABLE

2441U868F1 MOTOR ASSY

1 2441U869F1 MOTOR,WINCH P. 115-114 1

2 2405Z222F1 BUSHING 1
2-1 24100U305S4 PACKING 1
2-2 2405Z222S2 PACKING 1
4 2444R1488Fl PLATE 1
4-1 2444R1488S1 PLATE, SUB 1
4-2 2420N458D12030 CAPSCREW 6
4-3 zw26K12000 LOCK WASHER 6
4-4 ZD12G03500 O-RING 2
5 2436U1974Fl VALVE, COUNTER BALA. 1
5-1 2420N458D12080 CAPSCREW 6
5-2 ZD12G03500 O-RING 4

(OJ) 114-110-1(D
 WINCH MOTOR
TE-0001'"'-' 2441U869Fl
TO-0001'"'-'
TH-0001'"'-'
TG-0001'""'-'

II)
'j"
N

en
I
N

..,
N
I
N

FIG 115-114-1(D (01)

 MOTOR, WiNCH. TG.0001--

ITEM PART.NO DESCRIPTION REMARKS QTY APPLICABLE

2441U869F1

1 24UU852F1 ROTARY GROUP P. 116-115 1

2 2436U1931F1 CONTROL. UNIT 1
2-1 2436U1932F1 CONTROL IIALIIE P. 117-115 1
2-3 2436U1931S3 BO~Y 1
2-4 2441U432S28 PISTON 1
2-5 2H1U432S29 ROO 1
2-6 2436U1931S6 SEAL 1 I
2-7 2436U1862S7 SEAT, IIALIIE 2
2-8 Z011P01600 O-RING 1
2-9 2436U1931S9 CAP NUT 1
2-10 24UU658S33 PACKING 1
2-14 2420N458016045 CAPSCREW, SOCKET 8
2-15 2436U1931S15 SETSCREw 1
2-16 2436U1931S16 SETSCREw 1
2-17 2436U1931S17 PLUG 1
2-18 24UU720S49 PLUG 1
2-19 2436U1931S19 NUT 1
2-20 2UOOU607S4 LOCK WASHER 8
2-21 2436U1691S32 PACKING 2
2-22 2436U1691S28 BALL 2
2-23 2UOOU448S16 PLUG 4
2-25 24UU658S46 PIN 2
2-26 2436U1931S26 SEAL 1
2-27 2~36U1931S27 PIN 2
2-28 24UU720S48 PLUG 2 I
5 2441U869S5 HOUSING 1
6 24UU658S2 PLUG 1

(01)
 ROTARY GROUP.WI NCH MOTOR
TE -0001,...., 244' U852F ,
TO-OOO'"""
TH-OOO' .......
TG-0001-

FIG 116-115-1 (O, )

 ROTARY GROUP, wiNCH MOTOR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

2441U852Fl

1 2441U85251 SHAFT 1
2 2441U85252 BLOCK, CYLINDER 1
3 24100U607518 PIN 1
4 2441U85254 PISTON 7
5 2441U85255 RING 7
6 24100U607521 RETAINER 1
9 2441U658512 PLATE 1
12 24100U607512 BEARING 1
14 2441U658514 SPRING, CONED DISK 4
16 24100U607513 SPACER 1
17 24100U607523 CASE 1
19 2441U852519 PLATE 1
20 2441U658517 SPACER 1
21 24100U60759 SPRING, CONED DISK 2
22 2441U658S18 RING, SNAP 1
23 2441U432S20 RING, RETAINER 1
26 2441U658S20 O-RING 1
27 2441U658S21 SEAL, OIL 1
28 24100U607S10 BEARING, BALL 1
29 2441U852S29 BEARING 2
30 2441U658S25 MACHINESCREw 14
34 2441U658S27 SHIM 0.1 2
35 2441U658S28 SHIM 0.3 1
36 2.441U658S29 SHIM 0.2 1
37 2441U658S30 SHIM 0.3 1
38 2441U658S31 SHIM 0.5 1
40 2441U852S40 ORIFICE 7

(OJ)
 CONTROL VALVE.WINCH MOTOR
TE -0001""'" 2436U1932Fl
TO-0001'"
TH-0001"'"
T G- a a a 1"""

16

6
19

17
6
8

17
6 7
14
6 6
15
12
13
6
6
3
.;/
5
4
20
2 18
21

11 9 7 10 6 6 6

FIG '17-1'5-1 (02 )

 CONTROL VALvE, WiNCH MOTOR TG.0001--

ITEM PART~NO DESCRIPTION REMARIC.S IHy APPLICABLE

2436U1932Fl

1 20\36Ul816Fl VALVE, SOLENOiD P. 118-117 1

2 BODY 1
3 PISTON 1
0\ 2~36U1932S~ BLOCIC., VALVE 1
5 2~36U1932S5 PIECE 1
6 2UOOUo\US16 PLUG 11
7 2~36U1932S7 PLUG 2
8 2~36U1932S8 ORIFICE 1
9 Zol1G02500 O-RING 1
10 Zo12P01200 O-RING 1
11 Zo12P010\00 O-RING 1
12 2~36U1932S12 COvER 1
13 Zo12P03000 O-RING 1
14 2~36U1932S14 CAPSCREw ~

15 2441Uo\OO\S106 SPRING ~

16 24UU658S3 PLUG 1
17 24UU720S0\9 PLUG 2
18 2~36R1161Sl1 O-RING 1
19 20\36U1932S19 ORIFICE 1
20 2~36U1932S20 FILTER 1
21 2~36U1932S21 SHIM 1.0 1
23 2~36U1982F1 VALVE P. 119-117 1
2436U1932Rl00 REPAIR IC.IT 1
CONSiSTS OF ITEM 9, 10, 11. 13, 18

(OJ)
 SOLENOID VALVE,WINCH MOTOR
TE-OOOlt"V 2436U1816Fl
TO -0001 .....
TH-0001"'"
TG-0001""

152

4 113 29 302 302

F-l G 1 18 -11 7 - 1 {on

 SOLENOID VALVE, WINCH MOTOR TG.D001--

ITEM PART~NO DESCRIPTION REMARKS GlTy APPLICABLE

2.36U1816Fl

1 BODY 1

•
29
2.36U1852S. COVER
SPOOL
1
1
60 2.36U1852S60 RETAINER 2
71 2.36U1852S71 SPRING 2
105 H36U1852S105 O-RING 2
113 H36U1695S15 O-RING •
128 2.36U1852S128 CAPSCREW •
129
152
2.36U1852S129
H36U1852S152
CAPSCREw
VALVE, SOLENOID
•1
250
302
H36U1695S9
2.36U1852S302
CAPSCREW
O-RING
•2
H36Ul816Rl00 REPAIR KIT 1
CONSISTS OF ITEM 105,113
2.36U1816Rll0 REPAIR KIT 1
CONSiSTS OF ITEM 152,302

j
I

(01) 118-117-1
 TWO-SPEED VALVE. AUTOMATIC
TE-0001""" 2436U1962F1
TO-0001""
TH - 000 1""
TG-0001'"

2-3 2-12 2-7 2-6 2-18 2-4 2-1 2-13 2-18 2- 5

2-14 2 -13

2 -20
2- 2

2-16

2-15

-------- -----]l- 2 -18

2-21 ~:l-lUL':--l
I:::~:
,.,V I I
SECTION B-B

-~-~ j
L::::========:j-'------

,1&\)
2-22 2-18 2-19
SECTION C - C

r-t---- 2 -14
4
2-18

2-19

VIEW A-A

FI G 119 - 11 7 -1 (01)
 TWO-SPEED VALvE, AUTOMATIC TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS &TV APPLICABLE

2436U1982F1

1 2436U1982S1 PLATE, sue 1

2 2436U2069Fl TWO-SPPED VALVE 1
2-1 BODY 1
2-2 COVER 1
2-3 2436U2069S3 COVER 1
2-4 SPOOL 1
2-5 PISTON 1
2-6 2436U2069S6 RETAINER 1
2-7 2436U2069S7 SPRING 1
2-9 2436U2069S9 SHIM 0.1 2
2-10 2436U2069S10 SHIM 0.3 1
2-11 2436U2069S11 SHIM 0.5 3
2-12 ZD11G03000 O-RING 1
2-13 ZD11P01400 O-RING 1
2-14 ZD12P00700 O-RING 7
2-15 2441U643S327 ORIFICE 2
2-16 2436U1691S31 PLUG 1
2-18 2436U1692S28 PLUG 19
2-19 2436U2069S19 PIN 2
2-20 2436U2069S20 CAPSCREW 4
2-21 2436U2069S21 CAPSCREw 4
2-22 2436U2069S22 CAPSCREW 4
2-970 2436U2069Rl00 R,K1T C12,13,14) 1
3 2.436U1982S3 CAPSCREW 4
4 2436U1695S15 O-RING 4

(OJ) 119-117-1
 HYD LINES. WINCH(1S81 MAIN & AUX}
TG-0001- 24100J9039F1.F2
23.24.63.78

'"
A

46

T 27.28.29.30
50 88 20 56(F1)B
"" B

26.34.36.37.39. 40 38 9(F1)7
35 45 89(F2)
26 22
36 54
37 30

77 83.84.85.86.87
62

---.
28
2774
o~

(F1)9 ~~~~
(F2)89 7 - -
13
64
71.54.3022
20

72 44.22.3l.54
VIEW A-A

FIG 134-01-1C!) (03)

 HYD LINES. WINCH(1581 MAIN & AUX)
24100J9039Fl.F2 TG-0001-

69
77.62.31.32 8 57.58.92 51 60.26
27.28.62.77

77.62.28.27

77.27.28.62
27.28.62.77

23.24.63.78

59.61

VIEW 8-8

89(F 2)
39.37.36.34.26 9(F 1)13 7 19 49 8 69.70

93.51..30.22

40.37.36.35.26

45.22.38.54.30

70.69 2
VIEW C- C

(03) FIG 134- 01 - 2 CD

 HYD LINES, WINCH
TG.OOOl--

ITEM PART.NO DESCRIPTION REMARKS ~TV APPLICABLE

24100J9039F1 TG.0001--TG.0001
24100J9039F2 TG.0002--

1 2436U1971F1 VALVE ASSY, CONTROL P. 135-134 1

2 2436U1874F1 VALVE ASSY, CHECK 1
3 2418N2868 TUBE LINE 1
4 2418N2869 TUBE LINE 1
5 2418N2870 TUBE LINE 1
6 2418N2871 TUBE LINE 1
7 2418N2872 TUBE LINE 1
8 2418T16168 TUBE LINE 1
9 2418N2874 TUBE LINE 1 TG.0001--TG.0001
10 2418N2875 TUBE LINE 1
11 2418N2876 TUBE LINE 1
12 2418N2877 TUBE LINE 1 TG.0001--TG.0001
13 2418Pl1777 TUBE LINE 1
14 2420R812D2 HOSE ASSY 2
15 2420R769D2 HOSE ASSY 1
16 ZX22M08076 HOSE ASSy 1
18 ZX37P20110 HOSE 1
19 ZX27M04250 HOSE ASSy 1
20 ZX22M08350 HOSE ASSY 1
21 2416P11853 BRACKET 1
22 ZN18C10008
,
NUT 8 f
"
23 ZE12X24000 CLAMP, HALF 4
24 ZD12P04800 O-RING 2
26 ZW26X12000 LOCK WASHER 7
27 ZE12X20000 CLAMP, HALF 24
28 ZD12P03800 O-RING 12
30 ZW26X10000 LOCK WASHER 8
31 ZE12X16000 CLAMP, HALF 8
32 ZD12P03400 O-RING 6
34 ZS18C12070 CAPSCREw 3
35 ZS18C12080 CAPSCREW 3
36 ZN18C12010 NUT 6
37 ZW16H12000 wASHER 8
38 ZC27X28012 CLAMP 2
39 ZC27X35014 CLAMP 2
40 ZC27X43014 CLAMP 2
41 ZC37X43114 CLAMP 2
42 R16P0036D19 CLIP 3
43 ZC45X22011 CLIP 3
44 2416P11362 BRACKET 1
45 ZS18C10060 CAPSCREW 2
46 ZH32X08000 ELBOw 2
47 ZH32X04006 ELBOw 1
49 ZH22X04000 CONNECTOR 1
50 2444Z2695 TEE 1
51 ZF33F28012 ELBOW 1
52 ZG15F04500 COUPLING 1
53 ZS18C10085 BOLT 1
54 ZW16x10000 WASHER 7

(03)
 HYO LINES, WINCH
TG.0001--

ITEM PART.NO OESeR I PTI ON REMARKS <ilTY APPLICABLE

56 ZE72X08000 PLUG 1 TG.0001--T6.0001

57 244H2627 CONNECTOR 2
58 2444R83301 NOSE 2
59 ZS18C16080 CAPSCREW 2
60 ZS18C12035 BOLT 1
61 Zw26X16000 LOCK WASHER 2
62 Zw26KlOOOO LOCK WASHER 76
63 Zw26Kl2000 LOCK WASHER 8
64 2432Z29004 WIRE TIE 4
65 ZMllC12025 BOLT 2
66 ZE72X12000 PLUG 2
67 ZC37X35114 CLAMP 1
69 Z012P02400 O-RING 3
70 ZF23F28012 CONNECTOR 2
71 2416P11447 BRACKET 1
72 ZE72X06000 PLUG 1
73 ZE82T04000 PLUG 1 TG.0001--TG.0001
n 2444R148501 HOSE 1
75 zx27P20135 HOSE ASSY 1
76 ZX37P20105 HOSE 1
77 2420N458010035 CAPSCREw 72
78 2420N458012035 CAPSCREW 8
83 ZC45X31014 CLIP 1
84 ZS18C08030 CAPSCREW 1
85 ZN18C08007 NUT 1
86 Zw26X08000 LOCK WASHER 1
87 2418T908802 WASHER 2
88 ZH52X08000 TEE 1
89 2418N2964 TUBE LINE 1 TG.0002--
90 2418N3068 TUBE LINE 1 TG.0002--
91 2418T5373C2 WASHER 1
92 3487Z3903 WIRE TIE 2
93 2416P12133 BRACKET 1

(03) 134-01-2 CD
 VALVE ASSY,MAIN & AUX. WINCH
TE-0001'"'-' 2436U1971Fl
TO-0001""""
TH-OOOl '"'-'
TG-0001"-'

30-4
30-6

30-1
30-5 30-10
30-9
30-11

54 30-3
30-2
30-8

30-7

DETAIL ITEM 30

1. 1-1. 1-2

4.4-1
5.5-1
10

9
23
11

13 12 51-7
51-4
51-5
51-6
0

51-3
54 55 56 51-1

51-8 51-2 51-2

DETAIL ITEM 51

FI G 135-134-1(J) (01)
 VAL VE ASSY. MAIN & AUX. WINCH
2436U 1971 Fl TE-0001,""
TO-OOO1"'-'
TH-0001'"'-'
TG- 0001 "'"

5-1

SECT ION C-C

23-1
23-2 23 30
47
46

28

25 1'f-IH--.f----29
27
21
26
20

23-1
57-1
23
57

41
18
21
~--§§~_-14
22
17

59 15
"1----16
60
5 2-8-~~-=--=--=-i~~~Il;II~ 52-9
52-7 u----52-5
58 33 49
52-6
SECTION A-A
52
52-1
52-4 52-3 52-2

SECTION B-B

(01) FIG 135-134-2<D

 VALVE, CONTROL
Clv MAIN & AUX WINCH TG.0001--

ITEM PART.NO DESCRIPTION REMARKS QTY APPLICABLE

2436U1971F1 VALVE, CONTROL

1 2436R1300F1 SECTION ASSY, INLET 1

1-1 HOUSING 1
1-2 B36KOO19E212 O-RING 1
4 2420R911F1 PLUG ASSY 1
4-1 2445Z7D8 O-RING 1
5 2420R912F1 PLUG ASSY 2
5-1 2436R718S11 O-RING 1
9 2436U1971S9 ROD, TIE 1
10 2436Ull08S3 NUT 1
11 2436U1971S11 ROD, TIE 2
12 2436U1108S1 NUT 2
13 HOUSING 1
14 SPOOL 1
15 2436U1971S15 SPRING 1
16 2436U1971S16 CAP 1
17 2436U388S18 O-RING 1
18 2436U1971S18 SPACER 1
20 2436U1956S22 PLUG 1
21 2436U618S13 O-RING 2
22 2436U1707S12 PLUG 1
23 2420R914F1 PLUG ASSY 3
23-1 2483U283S9 O-RING 1
25 2436U1971S25 SLEEVE 1
26 2436U1971S26 O-RING 1
27 2436U1971S27 RING, BACK uP 1
28 2436U1971S28 O-RING 1
29 2436U1027S88 RING, BACK UP 1
30 2436R1304F1 VALVE ASSY, RELIEF 1
30-4 2436R1094S17 ADJUSTER 1
30-5 2436U1027S212 O-RING 1
30-6 2436R1094S12 SPRING 1
30-7 2436R1094S13 O-RING 1
30-8 2483U283S4 RING, BACK-UP 1
31 2436U1971S31 POPPET 1
32 2436U1971S32 SPRING 1
33 SPOOL 1
34 2436R1051S8 SEAL 4
35 2436R1051S9 WIPER 4
36 2436U291S25 PLATE 4
37 2436U291S26 SEAT, SPRING 4
38 2436U1971S38 SPRING 2
39 2436U1971S39 CAP 2
40 2436U291S27 CAPSCREw 2
41 2436U1971S41 PLUG 1
43 SPOOL 1
45 2441U598S22 O-RING 4
46 2483U283S11 O-RING 1
47 2436U1971S47 O-RING 1
48 2436R1050S14 BOLT, SOCKET 4
49 2436U291S31 BOLT 4

135-134-1 <D (on

 VALVE, CONTROL
TG.0001-- CIV MAIN & AUX WINCH

ITEM PART.NO DESCRIPTION REMARKS 61TY . APPL I CABLE

50 2436R1305F1 VALVE ASSY, RELIEF 2

50-1 2445Z7D8 O-RING 2
51 2436R1308F1 VALVE, SHUTTLE 2
51-1 BODY 1
51-2 O-RING 4
51-3 2436R1306S.3 CAPSCREw 2
51-4 SLEEVE 2
51-5 O-RING 2
51-6 RING, BACK-UP 2
51-1 2436U199S6 BALL 1
51-8 2436R1306S8 PLUG 2
51-950 2436R1308RllO R,KIT 51-2,5,6 1
52 2436R1301F1 VALVE, SHUTTLE 1
52-1 BODY 1
52-2 2436R1301S2 CAP 1
52-3 O-RING 1
52-4 2436U199S6 BALL 1
52-5 2436R1301S5 NUT 1
52-6 RING, BACK UP 1
52-1 O-RING 1
52-8 2436R1301S8 ORIFICE 1
52-9 2436R1301S9 FILTER 1
52-950 2436R1301RllO R,K IT 52-3,6,1 1
53 2436U1971S53 FITTING 1
54 2436U1971S54 FITTING 3
55 2436U1971S55 PIPE 1
56 2436U1971S56 PIPE 1
51 2420R916F1 PLUG ASSY 1
51-1 2436U388S25 O-RING 1
58 2436U1911S58 HEAD 2
59 2436U1971S59 SPRING 1
60 2436U1971S60 SEAT, SPRING 1
2436U1911RllO REPAIR KIT 1
CONSISTS OF ITEM 11, 21, 26, 21, 28
29, 34, 35, 45, 46
41

(01) 135-134-2 CD
 I NSTAL. CONTROL AUX WINCH
24100J9045 F2
TG- 0001 ....
",-'

. I;,'
"-/
',<
.'

!~
.'
t'.
'f,.. '":.~

.~~'
.~ ~ .

~'
·fF

8~
6
34
10~

(01 )
FIG 143-01-1
 CONTROL ASSY
AUX WiNCH <OPTION) TG.0001--

ITEM PART:NO DESCRIPTION REMARKS &Ty APPLICABLE

;4100J9045F, CONTROL ASSY

6 2406T2140 YOKE 1
8 ZP45X12032 PIN 1
10 ZP15D03022 PIN 1
19 24100J8616F6 LEVER ASSY, CONTROL P. 14-12 1
21 2416T15156 BLOCK 1
22 2419R838F2 SWITCH ASSY 1
23 24100P1418F2 BRACKET, SWiTCH 1
23-1 2416T13885 BRACKET 1
23-4 ZN16C05004 NUT 4
23-5 2432T2920 CLAMP 1
23-6 ZS31C05016 MACHINESCREw 4
23-1 ZW26X05000 LOCKWASHER 4
21 2432Z290D4 WIRE TIE 1
34 ZW16X12000 WASHER 1
31 iS18C081l0 BOLT 2
39 7N18C08001 NUT 2
46 2420T5209D4 BOLT 2

(03)
 SWING-LOCK ASSY/SINGLE POSITION
TO-0001 ..... 24100J8621 F2
T6 -0001 ow

51 DE CONSOLE

10

4---1

125\...--6

1---3

51 DE CONSOLE

r
7L'
i''
r=---=-===,lC -- ---J[--='ll
L
1~=:o=:dJ ~:
I'
"
il~-l,
J'L'
---=-:.--

CI il\ L __--J
I I
__ ---1,

:u:
II '
I I

__ L. ' .~
WINSHIELD WASHER TANK

FJ 6 161-01-1 (03)
 LOCK ASSy, SWING
SINGLE POSITION TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

24100J8621F2 LOCK ASSy, SWING

1 2419P2434 PIN 1
3 2420R486D7 JOINT, BALL 1
4 2406P3715 LEVER 1
5 ZM11C10020 SEMS-BOLT 2
6 ZN18C12010 NUT 2
7 32~1354 DECAL 1
8 ZW16X12000 WASHER 2
9 ZW26X12000 LOCK wASHER 1
10 ZP16D04022 PIN 2
11 2406P2397 BALL, LEVER 1
12 ZG91S02000 NIPPLE, GREASE 1
13 2416P11801 BRACKET 1
14 ZW16X10000 WASHER 2

(03) 161-01-1
 LOCK ASSY. SWI NG. MULTI POSITION
TD-0001 "- 24100J8969F1
TG-0001 ....

,-~-10
19

®--14
'"
SI DE CONSOLE

21

22

HEATER- BOX

FIG 163-02-1 (03)

 LOCK ASSY, SwiNG
MUL TI POS I TI ON TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 61TY APPLICABLE

24100J8969F1 LOCK ASSY, SWiNG

1 2419N152 PIN 1
2 2418N2939 TUBE 1
J 2416Pll780Fl BRACKET 1
4 2420T5526 KEY 1
5 2406P3801 LEVER 1
6 2418T15512 WASHER 1
1 2420R136D2 ROD-END 1
8 2406P3808 LINK 1
9 2420T5294D5 ROD 1
10 2420R486D2 JOINT, BALL 1
11 2406P2391 BALL, LEvER 1
12 ZMllC10025 SEMS-BOLT 4
13 ZW16X10000 WASHER 4
14 ZN18C06005 NUT 3
15 ZW26x06000 LOCK WASHER 2
16 ZP45X08030 PIN 1
11 ZW16X08000 WASHER 1
18 ZP16K02016 PIN 1
19 2418Pl1703 PLATE 1
20 ZG91S02000 NIPPLE, GREASE 1
21 2416T18656 SHEET, RUBBER 1
22 32611445 DECAL 1

(01) 163-02-1
 INSTAL, CTW 3.6 T
TG-0001-
241 OOJ 8881 F2

,
~.

FIG 1 9 1 - 01- 1
(02)
 INSTAL, CTW
3.6 T COUNTERWEIGHT TG.0001--

ITEM PART.NO DE SCR I PTI ON REMARKS (ilTY APPLICABLE

24100J8R81F2 INSTAL, CTW

2 ZS18C36110 CAPSCREW 2
4 ZN32C36033 U-NUT 2
5 ZS18C30070 CAPSCREW 4
6 ZW16X30000 wASHER 4
7 2422U13 COUNTERWEIGHT 1
12 ZW16X36000 LOCK WASHER 4

(02) 191-01-1.
 IN 5T AL, CTW 4.1T (WITHOUT AUX.)
TG-O 001 .... 24100J8881F3

10 ®

.
..

FIG 192-02-1
( 02)
 INSTAL, CTW
4.1 T COUNTERWEIGHT TG.OOOl--

ITEM PART.NO DESCRIPTION REMARKS (i)TY APPLICABLE

24100J8881F3 INSTAL, CTW

2 ZS1806110 CAPSCREW 2
4 ZN3206033 U-NUT 2
5 ZS1800010 CAPSCREw 4
6 Z.W16X30000 wASHER 4
1 2422U13 COUNTERWEIGHT 1
8 2422P934 COUNTERWEIGHT 1
9 ZS18C20110 CAPSCREW 4
10 ZW16H20000 WASHER 4
12 ZW16X36000 LOCK WASHER 4

(02) 192-02-1
 COUNTERWEI GHT ASS
241 OOJ 9069Fl.F2 Y (REMOVABLE)
T G-OOO 1 .......

,;~~-H.J~
4

FIG 193-03- 1 (i) (03)

 TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS (ilTY APPLICABLE

24100J9069F1 COUNTERWEIGHT ASSY

REMOVABLE <WITH/AUX WINCH)

1 2_22Ul41 COUNTERwEIGHT 1
2 2416J1313 BRACKET 1
3 2_07P856Fl SHEAVE ASSY 2

-
5
6
2419T5228
30&58
2419P2_81
PIN
ROPEASSY
PIN
2
1
1
7 2419P2532 PIN 2
8 20Z93905 PIN 2
9 19Z27_035 PIN 3
10 19Z27_0U PIN 2
11 ZP_5X16090 PIN 2
12 2_19T3258 SPRING PIN 2
13
1_
15
ZP15D06090
20Z93903
ZS18C36085
PIN
COTTER PIN
CAPSCREW
-
3
2
16 ZN32C36033 U-NUT 2
17
18
ZW16H36000
ZS18C30070
WASHER
CAPSCREW --
19
20
21
ZW16H30000
2416P12018
ZM11C12030
WASHER
BRACKET
SEMS-BOLT
1
2
-

24100J9069F2 COUNTERwEIGHT ASSY

REMOVABLE <WITHOUT/AUX WiNCH)
I
The parts are salll! as ( Fl ) except the following part.

22 2_22P93_ COUNTERWEIGHT 1
23
2_
ZS18C20170
ZW16H20000
CAPSCREW
WASHER --
I

I
I
!

(03)
 R PLANT ASSV (CAT)
TG-0001- POWE J9029FI
24100

~
aD.
p)

"'".
en
....
cD
cD -.
I
-.

:~~
C)

~ z
0
~
en U
en I&J
CI)
en
f"- ~

1 1 - -_ _ ....

en
en
en
cD ~
en U
"'" ~
I&J
CI)
f"- cD
~ ~
en
aD

FIG 2 01-01-1(2) (03)

 .....
o
w

56.84.88.89 21 Z--./ 94.31 34 31.94 22 56.84.68.89

94.33 33.94

29

z~
32 23
]-J 2]
HYD.INST.,OIL COOLER 3-4 ]-~ 3-~ ]-]
"U
SECTION Z-Z 0
~
25.44 26 24 50.96.84 ]-8 ITI
~ :0
61 76 o "U
]-2 o r

,,-;4JJ
rv' 5R
L. ~

~~:"f-~~.
79 U) z
]-1 'I~ o .....
11 N ~
(J)
..- U)

~;~
14 'TI (J)
• • I "--"---' -<
.....
67 n
.,. 80 687*7' ~

~~J
.....
......
24 DETAIL C

13 77 62
3-9
DETAIL ITEM]

"TI

N
o .;';"
]6 I I I
T- "

f /C tJ..---J .....
(i)
I
I 81 69 0
...
o
I
42 46 CONNECTION, BATTERY CABLE DETAIL D
0
0
HyD I NST., STEERING PUMP
N
9 l
 POwER PLANT ASSy
- CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 61Ty APPLICABLE

24100J9029F1 POwER PLANT ASSy

1 24100J9030F1 ENGINE/TRANS GROUP P. 202-201 1 TG.0001--TG.0001

-1-1 24100J9030F2 ENGINE/TRANS GROUP P. 202-201 1 TG.0002--
2 2410U303D3 SHAFT, DRIVE 1
3 2452U437 RAOIATOR ASSY 1
3-1 2452U437S1 CORE,OIL COOLER 1
3-2 2452U437S2 BOLT ASSY 8
3-3 2452U437S3 CORE,RADIATOR 1
3-4 2452U437S4 SHROUD 1
3-5 2452U437S5 BOLT ASSY 8
3-6 2452U132S5 CAP, PRESS 1
3-7 2452U205S5 PIPE 1
3-8 2452U136S8 CLIP 2
3-9 2452U437S9 COCK, DRAIN -1
4 2432U373 DECAL 1
6 2416P1l878 BRACKET 2
7 2414N3432 COVER 1
8 2427P2712 BAFFLE 2
11 2416R1l7 MTG, RUBBER 4
12 2416R151D2 MOUNT 4
13 2416R150 RUBBER, MTG 4
15 2418T16186 TUBE 1 ,.
16 2444R1564 HOSE 1 y'

17 2444R15" HOSE 1
18 2444Z2801 HOSE 1
19 2444Z2719D80 HOSE 1
20 2444Z1665D44 HOSE 1
21 2444R1475D4 HOSE ASSY 1
22 2444R1475D3 HOSE ASSY 1
23 ZX23M16074 HOSE ASSY 1
24 ZX44M06415 HOSE ASSY 1
25 44Zl002D38 HOSE 1
26 2418P17819 TUBE 1
27 44&1289D04170 TUBE, NYLON 1
28 2444R1476D2 HOSE ASSY 1
29 2444T3500 ELBOw, 90 1
31 2444T3349 TEE 2
32 2444R596D6 ELBOw 1
33 2418T16210 TUBE ASSY 2
34 2436R392F5 VALVE, BY-PASS 1
36 2479P817D8 CABLE, BATTERY 1
37 2479P817D9 CABLE, BATTERY 1
38 2479Pl177D1 CABLE, BATTERY 1
39 R79P0042011 CABLE, BATTERY 1
40 2414Zl94014 CAP, TERMINAL 4
42 ZC15X05000 CLIP 2
43 ZC15X06000 CLAMP 6
I 44 ZC15X03300 CLIP 3
I 45 ZC15X01500 CLIP 2
46 2432Z290D4 CLIP 12
47 ZC45X38014 CLIP 11

(03)
 POW;R PLANT ASSY
TG.OU01-- CAT ENGINE

ITEM PART.NO DEsCRIPTION REMARIC:S GlTY APPLICABLE

48 ZC47X22014 CLIP 7
49 ZC47X14Oll CLIP 6
50 ZC45X22011 CLIP 1
53 ZS18C10035 CAPSCREw 4
54 ZS18C10025 CAPSCREW 5
55 2'+20Z180102 CAPSCREW 4
56 2420N458010030 CAPSCREW 8
57 ZS18C12035 CAPSCREw 8
58 ZS18C12060 CAPSCREW '+
59 ZS18C12020 BOLT 1
60 ZS18C12030 CAPSCREw 5
61 ZS18C16110 CAPSCREw 2
62 ZS18C20130 CAPSCREW 2
65 ZN18C10008 NUT 15
66 ZN18C12010 NUT 5
67 ZN32C12011 U-NUT '+
68 ZN32C16015 U-NUT 2
69 ZN32C20018 U-NUT 2
73 ZW16X10000 WASHER 17
74 Zw16X12000 wASHER '+
75 ZW16H10000 WASHER 8
76 Zw16H16000 WASHER 2
77 Zw16H20000 WASHER 2
78 2'+18Tl3084 WASHER 8
79 2418T7994 WASHER 8
80 2418Tl451601 WASHER 2
81 2418Tl6065 WASHER 2
82 2418T5373C2 WASHER '+
84 Zw26X10000 LOCK WASHER 16
85 ZW26X12000 LOCK WASHER 14
88 ZEl2X16000 CLAMP, HALF 4
89 Z012P03400 a-RING 2
90 2444Z123302 NIPPLE 1
91 ZE82T04000 PLUG 1
92 44Gl1289004075 TUBE, NYLON 1
93 4'+(91289006060 TUBE, NYLON 1
94 Z012P02900 a-RING 2
95 2420Z180101 CAPSCREW '+
96 ZS18C10016 CAPSCREW 1
97 ZG32U08000 ELBOW 1

(03) 201-01-2 ®
 .,.. -t
C')
12
57-1 13
57 136 58
5 69 128 127 141 59.61 5 60.62 61.59 35
c-"4 32
140 (n)
127 (F 1)
G'I
I
\ \ \ I I o
N o
0 o
N

~
I
N
0
FIG. 2

e
IT!
Z
11 G'I
Z
IT!
I/O
-t
N :0
.t-- l>
Z
0 VI
0 ~
c....
CD VI

7 107.71 81.40 74.107 30 9(Fl) 120.113.78 65.10 75.107 29 6 2 33 34 84.104.106 39

0
w
0
-
VI
0
Z
"TI
3(F2)
.,.. G'I
:0
N 0
c:
(F2)139 137(F2) "0
82 124 88.90.103 82 100 126 125 86.100 101 91 (Ft) 91 45(Fl)36 83 102 35 83 102 133 n
l>
-t

100 90 103 103 90 100 87.90.103 123.122 37 38(F1) 91 112 .80 113 91 91.113 9(F 1)
138(F2) 3(F2)
DETAIL B DETAIL B VIEW C-C VIEW D-D VIEW F-F
(FIG.2) (FIG.l)

--
o
N
.......
o
.....
N

112.79 88.119.90.103.114 73 44 43

~
.'
100/ ~
53
",\M /'(;FIG.2 )

rn
z
(j)

z
rn
lID
-I
N ::0
l'- ~
Z
0 U'I
0
....
to
~

U'I
0

12 28 107.76 8 131.132.135
w U'I
0
."
-
0
Z
12
~
." (j)
8 3 27 N ::0
0
C
"0
25 46.93.115 47 94 51 .......
n
~
-I

134 vI Illt-· ,;', uml~ 26

." 15
(j)
VIEW L- L
(FIG.2) 20 48.49 92
N 121 9(F1)
0 9(F 1) 7 -I
N 3(F2) 3(F2) (j)
I
I
VIEW E-E VIEW G-G 23 DETAIL A o
N
0 o
o
DETAIL K
I
N ?
e
 ENGINE/TRANS GROUP (PIP CAT) TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &Ty APPLICABLE

24100J9030F1 TG.0001--TG.0001
24100J9030F2 TG.0002--

·1 51U122 ENGINE(CAT 3208T) 1

2 53U143 TRANSMISSION P. 203-202 1
3 2479J358 HARNESS, WIRING 1 TG.0002--
4 38U107 CYLINDER, AIR P. 270-252 1
5 2450U4F2 GOVERNOR ASSY 1
6 2436U525 BOOSTER, CLUTCH P. 271-252 1
7 31U131 PUMP, STEERING P. 213-202 1
8 2419T1663 CABLE 1
9 2419J284 WIRING HARNESS 1 TG.0001--TG.0001
10 2419U458 SENDER, OIL PRESS 1
11 2419R1102F1 SENDER, TEMP 1
12 89&44 SENDER 1
13 1014Z1462 COVER ASSY 1
14 1015Z338 PLATE 1
15 1015Z933 DISK ASSY, CLUTCH 1
16 1015Z934 DISK ASSY, CLUTCH 1
11 15Z484 BRAKE ASSY 1
18 6&238 YOKE 1
19 15Z518 SHAFT, CLUTCH 1
20 15Z519 SHAFT, CLUTCH 1
21 15Z531 KEY 1
22 20Z711D58 CAPSCREW 2
23 19Z314 PIN 4
24 1018Z2139 WASHER 2 TG.0002--
25 2406R306 LEvER ASSY 1
26 25T820D5 BEARING 1
21 2481611528 BRACKET 1 TG.0002--
28 2416J1300 BRACKET 1
29 2416J1301 BRACKET 1
30 2416N4559 BRACKET 1
31 2416P11843 BRACKET 1
32 24816N318 BRACKET 1
33 2416N4518 BRACKET 1
34 2416P11810 BRACKET 1
35 24832T252 CLIP 1
36 248061188 LINK 1
31 24806T189 YOKE 1
38 24820T320 ROD 1 TG.0001--TG.0001
39 24818Nl14 FLANGE 1
40 24818P1466 SPACER 1
41 2418T16169 TUBE 1
42 2418P11118 TUBE 1
43 2418Pl1719 TUBE 1
44 24820T312 GASKET 1
45 2406R125D2 ROD-END 1 TG.0001--TG.0001
46 2420R486D10 JOINT. BALL 1
41 2420P2112D3 ROO 1
48 2406P378401 LEvER 1
49 2418T16060 SPACER 1

202-201-1@ (02)
 TG.OOOl-- ENGINE/TRANS GROUP (P/P CAT)

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

50 2420T2589D3 BOLT, EyE 1

51 2417P238 SPRING 1
52 2420T6010 U-BOLT 1
53 2416T18439 SuPPORT 1
54 2432R173D1 COUPLING 1
55 2432R135 CLAMP ASSY 1
57 ZH22w06008 CONNECTOR 1
57-1 2445Z7D6 O-RING 1
58 44~14D1 HOSE-END 1
59 44~1291D1 ELBOW, 90 3 TG.0002--
44~1291D1 ELBOw,90 1 TG.0001--TG.000l
60 44Q129102 ELBOW 1
61 2444R740D1 CONNECTOR 3 TG.0002--
2444R74001 CONNECTOR 1 TG.0001--TG.0001
62 2444R740D2 CONNECTOR 1
63 44&129004 CONNECTOR 1
64 2444R740D3 CONNECTOR 1
65 2444T1101 BUSHING 1
66 2444Z1140D3 PACKING 1
67 44Q129001 CONNECTOR 1
68 2444T3507 ADAPTER 1
69 2444R740D4 CONNECTOR i
70 44&129002 CONNECTOR 2 TG.0002--
71 20Z711D89 CAPSCREw 2
72 20Zl0360151 BOLT 8
73 20Z10360152 BOLT 12
74 20Z711083 BOLT 2
75 20Z711D82 CAPSCREW 4
76 20Z7l1D80 CAPSCREw 4
78 20Z711021 CAPSCREW 3
79 0827V023 CAPSCREW 1
80 0827v023 CAPSCREw 1
81 0630V056 CAPSCREw 6
82 ZS18C10035 CAPSCREw 2
83 ZS18C08030 CAPSCREw 2
84 ZS18C12035 BOLT 4
85 0682v058 CAPSCREw 8
86 ZS18C10020 CAPSCREW 2 TG.0001--TG.0001
87 ZS18C10030 CAPSCREW 2 TG.0001--TG.0001
88 ZS18C10025 CAPSCREw 3
90 ZN18C10008 NUT 9
91 ZN18C08007 NuT 4
92 ZN18C06005 NUT 2
93 ZN18F16013 NUT 2
94 ZN17F12007 NUT 1
100 241815373C2 WASHER 6
101 Zw16K06000 WASHER 1
102 Zw16X08000 WASHER 4
103 Zw16x10000 WASHER 7
104 ZW16X12000 WASHER 4
106 2418T13084 WASHER 4
107 Zw16H12000 WASHER 12
112 3616V008
113 Zw26X08000
LOCK WASHER
LOCI( wASHER ,
7

(02)
 ENGINE/TRANS GROUP (P/P CAT) TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS ~TY APPLICABLE

114 ZW26X10000 LOCK WASHER 3

115 ZW26X16000 LOCK WASHER 1
118 2432Z290D4 WIRE TIE 10 TG.0002--
119 ZC45X22011 CLIP 2
120 ZC45X16011 CLAMP 2
121 ZC45X14011 CLIP 1
122 ZP16K01612 SPLIT PINS 1
123 ZP45X06018 PIN 1
124 2444P13S0 CONNECTOR 1 TG.0002--
124-2 ZG22UOSOOO CONNECTOR 1
124-3 ZG22U04000 CONNECTOR 2
125 2416Tl8562 BLOCK 1 TG.0001--TG.0001
126 2416TlS777 BRACKET 1 TG.0001--TG.0001
127 2418P17816 TUBE 1 TG.0001--TG.0001
128 2444R719D12 CONNECTOR 1
129 2444ZS0SD3 ELBOw, 90 1
130 2436Z370 COCK 1
131 2444Tl075 ADAPTER 1
132 2444T1734 ADAPTER, HOSE 1
133 2414Z194D12 CAP, TERMINAL 1
134 241H194D14 CAP, TERMINAL 1
135 2444lS0SD4 ELBOW 1
136 4H210D9 BUSHING 1
137 2420RS42D3 ROD END 1 TG.0002--
138 2420T6167 ROD 1 TG.0002--
139 2420ZS29 NUT 1 TG.0002--
140 241SP18337 TUBE 1 TG.0002--
141 2444R720D12 ELBOW 1 TG.0002--
142 44~1289D04178 TUBE, NYLON 2 TG.0002--

202-201-3@ (02)
 TRANSM 1551 ON , CARRIER (SHIFT SYSTEM,AIR)
53U143
TG-0001 "'"

LOCATED~INr:«;;;;:::=---­
OPERATOR'S C

~l~AB29
21 ,- 23 I ,-
~ ~ 24 I 28
20,~ 251 27
19,,!
'0 .". . EO"II 0--
~26
A 18 A L--_::"Y'
SLAVE
VALVE
W
NOTE. •
~
AIR LINES TO S
·17
- 32
CONNECTORS ,ELECTOR VALVE
SHOWN. ' TEM 3D, ARE NOT

09

Q /10
, /11

C) ~
G
04~ AIR FILTER
RANGE SHIFT 12
03 AND
CYLINDER REGULATOR
VALVE

INTERMEDIATE
SHI FT CYLINDER

FIG 203 -202-1

 TRANSMISSION, CARRIER (SHIFT SYSTEM, AIR)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

53UI43 SHIFT SYSTEM, AIR

I 1044Z339 ELBOW, 90 3
2 SCREW, HEX. HD. CAP 1/4-20UNC X 1-1/8-IN 4
3 I 044Z33 I ELBOW, 90· 4
4 1044Z735 HOSE ASSY I
5 1036ZI091 VALVE, SLAVE - RANGE SHIFT I
6 1020Z4490 HOSE ASSY I
7 1044Z543 HOSE ASSY I
8 1020Z6752 GASKET, SLAVE VALVE I
9 1018Z6804 SLEEVE, RANGE SHIFT PIN I
10 1017Z1680 SPRING, RANGE SHIFT PIN I
II IOl9Z1962 PIN, RANGE SHIFT I
12 I 044Z33 I ELBOW, 90· I
13 1046Z423 FILTER AND REGULATOR VALVE, AIR I
1046Z430 ELEMENT KIT, TRANS, AIR FILTER I
14 ELEMENT, AIR FILTER I
15 O-RING I
16 O-RING I
I 036Z1 082 VALVE, SELECTOR - TRANS. RANGE I
17 I 020Z583 I SCREW, COVER MOUNTING 3
18 BODY, VALVE I
1036Z765 REPAIR KIT, SELECTOR VALVE I
19 RETAINER I
20 SPRING, DETENT I
21 BLOCK, DETENT I
22 ACTUATOR, SELECTOR VALVE I
23 SPRING, ACTUATOR I
24 SEAL, ACTUATOR I
25 O-RING I
26 O-RING I
27 RETAINER, ACTUATOR I
28 SEAT, SELECTOR VALVE COVER I
29 1014Z1738 COVER, SELECTOR VALVE I
30 1044Z544 CONNECTOR, AIR LINE TO SELECTOR VALVE 3
31 1044Z553 HOSE ASSY I
32 2161V005 NUT, HEX JAM 1/2-13UNC I

203-202-1
 TG-0001"'v TRANSMISSION, CARRIER ( SHIFT TOWER)
53U143

05 06 07

......,----l=:e:t~~:::nft~0~6u.~ 11
23 I--~--==~c=~~

25

12 10

, .
.,.

,
):
,,-.

FI G 2 04-202-1
 TRANSMISSION, CARRIER (SHIFT TOWER)
TG.OOOI--

ITEM PART .NO DESCRIPTION REMARKS ~TY APPLICABLE

53UI43 SHIFT TOWER

I SCREW, HEX HD CAP 5/16-18UNC X 3/4-IN 4

2 IOl4Z491 COVER, SHIFT TOWER I
3 I020Z2437 GASKET, COVER I
4 20Z448 SCREW, LOCK I
5 I045Z754 BOOT, SHIFT SHAFT-OUTER I
6 I032Z117 CLAMP, BOOT 2
7 IOl8Z2702 FINGER, SHIFT-OUTER I
8 IOlOZ543 SHAFT, SHIFT-OUTER I
9 1045Z753 BOOT, SHIFT SHAFT-INNER I
10 1018Z2729 SEAL, SHAFT 2
II 1014Z499 HOUSING, SHIFT TOWER I
12 1005Z370 BUSHING 2
13 1005Z481 BUSHING, MIDDLE I
14 1005Z482 BUSHING, END I
15 1046Z168 BREATHER, HOUSING I
16 1020Z2654 PLUG, END I
17 NUT, HEX JAM 3/8-24UNF 4
IS NUT, HEX 3/8-24UNF 4
19 1020Z2655 STUD, 3/S-24UNF X 1-11/16-IN 4
20 1020Z7173 GASKET, SHIFT TOWER I
21 1020Z4135 SCREW, SPL. HEX HD CAP I
22 "1018Z2727 FINGER, SHIFT-INNER I
23 1018Z2728 RING, SNAP I
1010Z544 SHAFT AND LEVER ASSY., INNER SHI FT I
24 1010Z609 SHAFT, SHI FT-I NNER I
25 1006Z370 LEVER, RELAY I

204-202-1
 TRANSMISSION, CARRI ER (SHIFT HOUSING BARS AND YOKES)
TG-0001 "'-' 53U143

06\ r02
07 (.) j;
04

V
. / 03 .

;201
V
10 08 ___ ~1':

14 II
1~~3
1
30 .

16

21
18 19 20 It l- -
\~cbj ~§'

26

"
~ 21

F J G 205-202-1
 TRANSMISSION, CARRIER (SHIFT HOUSING BARS ANO YOKES)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS <ilTy APPLICABLE

53UI43 SHIFT HOUSING, BARS AND YOKES

I 1020Z9672 EYE, LIFTING I

2 SCREW, HEX. HD. 3/8-16UNC X I-IN 2
3 1025Z5 BALL, STEEL 3
4 17Z473D4 SPRING, BALL 3
5 1020Z5719 GASKET, NEUTRAL START SIVITCH I
6 1014Z494 COVER, SPRING I
7 1020Z2324 GASKET, SPRING COVER I
8 1020Z7192 PLUG, PIPE I
9 1010Z814 SHAFT, AIR VALVE I
10 1018Z6761 RING, ACTIVATION-NEUTRAL SWITCH I
II 1032Z362 CLIP, NEUTRAL SIVITCH I
12 1019Z650 PIN, REVERSE SWITCH I
13 1020Z2665 GASKET, REVERSE SWITCH I
14 SCREW, HEX. HD. CAP 3/8-16UNC X 1-1/4-IN II
15 1014Z3275 HOUSING, SHIFT BAR I
16 1020Z2322 GASKET, SHIFT BAR HOUSING I
17 1053Z68 BAR, YOKE ...- REVERSE I
18 1044Z328 PLUG, SHIFT DETENT I
19 1017Z694 SPRI NG, DETENT I
20 I 045Z75 I PLUNGER, SHIFT DETENT I
21 20Z448 SCREW, YOKE LOCK 3
22 1015Z780 YOKE, SHIFT - REVERSE I
23 1053Z66 BAR, YOKE - 2ND AND 3RD SPEED I
24 1025Z6 BALL, STEEL 2
25 19Z113 PIN, BALL I
26 1015Z781 YOKE, SHIFT - 2ND AND 3RD SPEED I
27 1015Z785 YOKE, SHI FT - 4TH AND DIRECT DRIVE I
28 1053Z67 BAR, YOKE - 4TH AND DIRECT DRIVE I
29 1079Z3069 SWITCH, REVERSE I
30 1079Z3068 SWITCH, NEUTRAL I

205-202-1
 TRANSMISSION, CARRIER (MAIN CASE AND CLUTCH HOUSING)
TG-OOO 1-- 53 U 143

19
MAIN
18
CASE

23

CLUTCH
HOUSING·

FI G 206-202-1
 TRANSMISSION, CARRIER (MAIN CASE AND CLUTCH HOUSING)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS 6lTV APPLICABLE

S3UI43 MAIN CASE AND CLUTCH HOUSING

I 1020Z3379 GASKET, PTO COVER I

2 1014Z794 COVER, PTO I
3 1020Z26S9 GASKET, CLUTCH HOUSING TO CASE I
4 SCREW, HEX. HD. CAP S/16-ISUNC X 1/2-IN 4
5 1014ZS74 COVER CLUTCH HAND HOLE I
6 20Z464 STUD, CLUTCH HOUSING 6
7 WASHER, LOCK SiS-IN 6
S NUT, HEX. S/S-ISUNF 6
9 1020Z26SS GASKET, BEARING COVER I
10 1014Z2319 COVER, FRONT BEARING I
SCR6V, HEX. HD. CAP 3/s-16UNC X 1-1!4-IN 4
"12 SCREW, HEX. HD. CAP 1/2-13UNC X 1/1/4-IN 2
13 NOT USED WASHER, LOCK 1/2-IN 2
14 1014Z11362 HOUSING, CLUTCH I
IS 100SZ3S1 BUSHING, CLUTCH ROD S
16 SCREW, HEX. HD. CAP 3/s-16UNC X 3/4-IN 6
17 1014Z490 COVER, PTO I
IS 20Z46 GASKET, PTO COVER I
19 1014Z1431 CASE, MAIN - TRANSMISSION I
20 10lSZ270S DISC, MAGNETIC 2
21 1019Z64S PIN, DOWa 2
22 1020Z6713 PLUG, PIPE I
23 1044Z342 PLUG, PIPE I
24 2423V005 PLUG, PIPE I
2S SCREW HEX. HD. CAP 7/16-14UNC X 7/s-IN S

206-202-1
 TRANSMISSION, CARR I ER (I NPUT AND MAIN SHAFTS)
TG-0001"'-' 53U143

~~.
/1
MAINSHAFT

06 INPUT 07
\:
1
\ SHAFT
) )
,/ / 1 '" /' / '
,/ >. ./
03
/
/ 14 Q 18
,/
,/
/' 13 /'

\
\ 1r1\.
~\J /
,/ ~~.
. .
/~cP
/ rt(' ~~28
24

./ .A ~ / ~ ~ JJ'

~-~ I ~ \ "
ff}~ ®~"
,/ 14\. '\

/ ,/ \. - 15 I
. ~,,26
~"0
\~
./ I '\ 21
./ l~.~~ii V "\ 22
,/
rclfb, 12
20

i~~C0J\--\ 11

'~\ 09 10

08

FI G 207-202-1
 TRANSMISSION, CARRIER (INPUT AND MAIN SHAFTS)

TG.OOOI--

ITEM PART.~O DESCRIPTION REMARKS <ilTy . APPLICABLE

53UI43 INPUT AND MAIN SHAFTS

I 1018Z5057 RING, SNAP

2 1025Z1202 BEARING, BALL
3 1018Z2720 SPACER, DRIVE GEAR
4 1018Z2721 RING, SNAP
5 100lZ2092 GEAR, MAIN DRIVE
6 1010ZI404 SHAFT, INPUT
7 I 005Z37 I BUSHING
8 1015ZI729 CLUTCH, SLI 0 I NG
9 1018Z2723 RING, SNAP
10 1018Z9807 WASHER
II IOOlZ2093 GEAR, 4TH
12 100lZI535 GEAR, 3RD SPEED - MAl NSHAFT
13 1015Z783 CLUTCH, SLI 0 I NG
14 1018Z2718 WASHER 4
15 100lZI534 GEAR, 2ND SPEED - MAl NSHAFT I
16 100lZI533 GEAR, 1ST SPEED - MAINSHAFT I
17 100lZ625 GEAR, REVERSE - MAINSHAFT I
18 1010ZI049 SHAFT, MAIN I
19 1020Z4992 KEY AND PIN, MAINSHAFT I
20 1018Z5059 WASHER I
21 1018Z5062 RING, CENTERING - MAINSHAFT 1
22 1017Z1013 SPRING, COMPRESSION 6
23 IOl8Z2724 RETAINER, BEARING I
24 IOl8Z2719 WASHER, LOCK 2
25 SCREW, HEX. HD. CAP 3/8-16UNC X I-IN 4
26 I025Z1201 BEARI NG, BALL I
27 1018Z5061 RETAINER, BEARING I
28 1018Z2706 RING, SNAP I

207-202-1
 ON CARRI ER (COUNTERS HAFT AND REV. IDLER)
TRANsMlssl. 53U143
TG-O 0 01""

06
~~2
11
18

TWIN
COUNTERSHAFTS

REVERSE
IDLER
SHAFT

FIG 208-202-1
 TRANSMISSION, CARRIER (COUNTERSHAFT AND REV. IDLER)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS (Hy APPLICABLE

53UI43 COUNTERS HAFTS AND REVERSE IDLER SHAFTS

I 1025Z2440 BEARING, ROLLER 2

2 1018Z2704 RING, SNAP 2
3 100lZI537 GEAR, DRIVE - COUNTERSHAFT 2
4 100lZI540 GEAR, 4TH SPEED - COUNTERSHAFT 2
5 100lZI538 GEAR, 3RD SPEED - COUNTERS HAFT 2
6 100lZ2094 GEAR, 2ND SPEED - COUNTERSHAFT 2
7 1010ZI418 COUNTERS HAFT 2
8 1020Z2668 KEY, COUNTERSHAFT 2
9 1019Z651 PIN, ROLL 2
10 I020Z2669 KEY, WOODRUFF 2
II I025Z2374 BEARING, ROLLER 2
12 1018Z2708 RING, SNAP 2
13 I 020Z5 137 NUT, ELASTIC STOP 2
14 WASHER, FLAT 1/2-IN 2
15 IOl8Z5058 WASHER, SPACER 2
16 I025Z1195 BEARING, ROLLER 2
17 IOOlZ630 GEAR, IDLER 2
18 IOIOZI0?:7 SHAFT, REVERSE IDLER 2
19 IOl9Z985 PIN, ROLL 2

208-202-1
 TRANSMISSION, CARRIER (DRIVE GEAR AND COUNTERSHAFTS)
TG-0001- 53U 143

AUXILIARY
DRIVE
GEAR

AUXILIARY
COUNTERSHAFT

01
REAR
OF \ 14 /16
MAINSHAFT

19-~ 18·~.
20-~/~
• I ~...- / A
21--, I I 17 /
I I 15
I

INTERMEDIATE
. HOUSING

-~""
~ 28

~27
I

o ............... 26

FI G 209-202-1
 TRANSMISSION, CARRIER (DRIVE GEAR AND COUNTERSHAFTS)
TG.OOOI--

ITEM PART .NO DESCRIPTION REMARKS (HY· APPLICABLE

53UI43 DRIVE GEAR AND COUNTERSHAFTS, AUXILI ARY

I 100lZI096 GEAR, AUXILIARY DRIVE I

2 1018Z5067 RING, SNAP I
3 1015Z1118 CLUTCH, SLI 0 I NG I
4 1018Z4957 RETAINER, SLIDING CLUTCH I
5 1018Z5065 WASHER I
6 1018Z5064 RING, SNAP 2
7 100lZI097 GEAR, MAINSHAFT I
8 1018Z5063 RETAINER, GEAR I
9 SCREW, HEX. HD. CAP 5/16-24 X I-IN 2
10 1018Z4472 RING, SNAP 2
II 1025Z3320 BEARtNG, BALL 2
12 1010ZI162 COUNTERSHAFT, AUXILIARY 2
13 1025Z1800 BEARI NG, ROLLER 2
14 1018Z5066 SPACER, BEARING 2
15 SCREW, HEX HD CAP 1/4-20UNC X 7/8-IN I
16 1018Z5068 SPACER, TROUGH I
17 1018Z5072 TROUGH, OIL I
18 1020Z5150 PLUG I
19 NUT, HEX. 5/8-18UNF 2
20 WASHER, LOCK 5/8-IN 2
21 I 020Z337 I STUD, MOUNTI NG 2
22 1020Z5144 SCREW, ESLOK HEX. HD. CAP 1-3/4-IN 4
1020Z5145 SCREW, ESLOK HEX. HD. CAP 1-1/2-IN II
23 1014Z1432 HOUSING, INTERMEDIATE I
24 1020Z2660 GASKET, INTERMEDIATE HOUSING I
25 2423VD05 PLUG, PIPE I
26 1018Z2705 DISC, MAGNETIC I
27 2423V007 PLUG, PIPE I
28 1019Z648 PIN, DDWs.. 2
29 1018Z6802 WASHER, DOUBLE LOCK I

209-202-1
 TRANSMI 551 ON , CARRIER
53U143 (OUTPUT SHAFT)
TG-0001"'-'

.08

04
03

\2\..~
20 21 22\

33 19 \~~
'~~~2'A
~~\26
23
25

28 • ~
27 /~
29

/'l~
~/
I •
,~ '
30
31
11 REAR 32
HOUSING

FIG 210-202-1
 TRANSMISSION, CARRIER (OUTPUT SHAFT)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS 6lTy APPLICABLE

53UI43 OUTPUT SHAFT

I 1053Z410 SYNCHRONIZER, HIGH I

2 1017Z696 SPRING 3
3 100lZI677 CLUTCH, SLI DING I
4 1053Z409 SYNCHRONIZER, LOW I
5 1010ZI428 SHAFT, OUTPUT I
6 1018Z4462 WASHER I
7 1018Z4461 SPACER, GEAR I
8 100lZI542 GEAR, LOW - OUTPUT I
9 1018Z4458 RING, SNAP I
10 1018Z6803 WASHER I
II 1020Z5149 SCREW, DRIVE 4
12 1018Z5071 PLATE, OIL RESERVOIR I
13 1020Z4474 GASKET, REAR HOUSING I
14 WASHER, LOCK 3/8-IN 2
15 SCREW, HEX. HD. CAP 3/8-16UNC X 1-1/4-IN 9
15 SCREW, HEX. HD. CAP 3/8-16UNC X 1-1/2-IN 8
15 SCREW, HEX. HD. CAP 3/8-16UNC X 2-1 N 2
16 1014Z1737 HOUSING, REAR I
17 1025Z1226 BEARING, ROLLER I
18 1020Z4483 GASKET, BEARING COVER I
19 1014Z3276 COVER, OUTPUT BEARING I
20 WASHER, LOCK 3/8-IN 5
21 SCREW, HEX. HD. CAP 3/8-16UNC X 2-3/4-1 N 5
21A 1020Z4497 SCRrW, ESLOK HEX. HD. CAP 2-3/4-IN I
22 1018Z5707 SLEEVE, SPEEDOMETER I
23 1018Z7147 COLLAR I
24 1020Z4476 NUT, OUTPUT YOKE I
25 1020Z4488 GASKET, CAPSCREW I
26 1018Z8506 SEAL, OUTPUT. I
27 1005Z367 BUSHING, SPEEDOMETER GEAR I
28 100lZI329 GEAR, SPEEDOMETER DRIVE I
29 100lZI330 GEAR, SPEEDOMETER DRIVEN I
30 SCREW, HEX. HD. CAP 3/8-16UNC X I-IN 8
31 1014Z1149 COVER, REAR BEARING 2
32 1020Z4487 GASKET, BEARING COVER - REAR 2
33 1019Z646 PIN, HIGH SYNCHRONIZER 3

210-202-\
 TRANSMISSION CARRIER (CYLINDER RANGE I NTERMADIATE)
TG-0001 "" 53U143

21

REAR 18

~% l~
HOUSING

/
//1I 16
'( ~ 19 22

I /. SHIFT CYLINDER
I
I / "- 15
1
v // "-
14

FIG 2 11-202-1
 TRANSMISSION, CARRIER (CYLINDER, RANGE, INTERMEDIATE)
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS CilTY. APPLICABLE

53UI43 CYLINDERS, RANGE AND INTERMEDIATE SHIFT

CYLINDER, SHIFT - RANGE I

I 1006Z586 YOKE, RANGE SHIFT I
Z SCREW, HEX. HD. CAP I/Z-ZOUNF X Z-IN Z
3 IOZOZ4480 GASKET I
4 1038ZZ36 BODY, CYLINDER I
5 1006Z587 BAR, SHIFT YOKE - RANGE I
6 SCREW, HEX. HD. CAP 3/8-16UNC X 1-1/4-IN 4
7 1039Z401 PISTON I
1045Z1441 SEAL KIT, RANGE SHIFT CYLINDER I
8 O-RING I
9 O-RING I
10 O-RING I
II I OZOZ448 I GASKET I
IZ IOZOZSI38 NUT, ESLOK I
13 1014ZZ091 COVER, CYLI NDER I
CYLINDER, SHIFT - INTERMEDIATE I
14 IOZOZS073 GASKET I
IS 1006Z68S YOKE, DIRECT. AND INTERMEDIATE SHIFT I
16 ZOZ448 SCREW, LOCK Z
17 1038ZZ73 BODY, CYLINDER I
104SZ144Z SEAL. KIT, INTERMEDIATE SHIFT CYLINDER I
18 O-RING I
19 IOZOZ6714 GASKET I
ZO O-RING I
ZI 1006Z1016 BAR, SHIFT YOKE - INTERMEDIATE I
ZZ I039Z433 PISTON I
Z3 IOZOZSISI GASKET I
Z4 IOZOZSI36 NUT, ELASTIC STOP I
ZS IOl4Z1134 COVER, CYLI NOER I
Z6 WASHER, FLAT S/16-IN 4
Z7 SCREW, HEX. HD. CAP S/16~18UNC X I-liZ-IN 4
Z8 1036Z744 VALVE, INSERT I
Z9 104SZZ0Z3 O-RING 3
30 IOZOZS07 I PLUG, VALVE I

NOTE
THE ABOVE PARTS LISTING APPLIES TO CARRIER
TRANSMISSION S3U143. REFER TO THE EDITING
SECTION IN THE FRONT OF THIS MANUAL FOR THE
CARRIER TRANSMISSION EQUIPPED WITH YOUR
MACHINE.

ZII-ZOZ-I
 POWE R PLANT ASSY (G M)
T6-0002"" 24100J9376Fl

j.-E 38

39.40

37.40
CONNECTION, BATTERY CABLE
6
G

44.20 19.45 46 8

62
6
1 3 •••'--r----,--t

74
81 69
67
61

DETAIL B DETAI L C DETAIL D

43. Ii 45.19.90 91.45 20.44

8

82
V 65.74.84
37.38.47

~48
VI EW E-E SECTION F-F DETAIL G DETAI L H

(02)
 POWER RLANT ASSY (GM)
24100J9376Fl TG-0002-

34 31 22

~-.
:
"~~ 5
..

J c:::J 0 LJ --
;; d
69.68.84.56 56.84.88.69

~+---- -lti=:::::::E4-----I- , - - - - - - "

~§..
= -
z--1
3-4 3-5 3-6 3-7 3-3

3-8

94.33 33.94
3-2
29

3-1

23

SECTION Z-Z

3-9

DETAIL ITEM 3

INST. BATTERY CABLE

(02) FIG 251-01-2

 POwER P~ANT ASSy
GM ENGINE TG.0002--

ITEM PART.NO DESCRIPTION REMARKS &Ty APP~ICABLE

24100J9376Fl POWER PLANT ASSY

1 2UOOJ9414Fl ENGINE/TRANS GROUP P. 252-251 1

2 2UOU303D4 SHAFT, DRIVE 1
3 2452U437 RADIATOR ASSY 1
3-1 2452U437S1 CORE,OIL COOLER 1
3-2 2452U437S2 BOLT ASSY 8
3-3 2452U437S3 CORE,RADIATOR 1
3-4 2452U417S4 SHROuD 1
i,
I
3-5 2452U437S5 BOLT ASSY 8
1
3-6 2452U132S5 CAP,PRESS
I 1
I 3-7 2452U205S5 PIPE
2
II 3-8
3-9
2452U136S8
2452U437S9
CLIP
COCK,DRAIN 1
I,, 4 2432U375 DECAL 1
I 6 2U6P12387 BRACKET 2
I 1
I 7 2414N3542 COVER
8 2427P2712 BAFFLE 2
11 2U6Rl17 MTG. RUBBER 4
..
12 2U6R151D3 MTG, RUBBER 4
13 2U6R334 MTG, RUBBER 4
15 2U8116471 TUBE 1
16 2444R1573 HOSE, RADIATOR 1

17 2444Z3171 HOSE, RADIATOR 1

18 2444Z3122 HOSE, RADIATOR 1
19 .2444Z1665D37 HOSE, RADIATOR 1
20 2444Z2719DllO HOSE, RADIATOR 1
22 2444R1475D7 HOSE ASSY 2
23 ZX23M16074 HOSE ASSY 1
27 44&1289004140 HOSE, NYLON 1
28 2444R1476D2 HOSE. ASSY 1
29 244413500 ELBOw, 90 1
I 30 ZG22U08000 CONNECTOR 1
31 244413349 TEE 2
32 2444R596D6 ELBOW 1
33 2U811621D PLATE, COVER 2
34 2436R392F5 VALVE, By-PASS 1
36 2479PB17D8 CABLE, BATTERY 1
37 2479P817D9 CABLE, BATTERY 1
I 38 2479P1177D1 CABLE, BATTERY 1
39 R79P0042D11 CABLE, BATTERY 1
40 2U4Z194D14 CAP, TERMINAL 4
43 ZC15X06000 CLAMP 6
44 ZC15X03300 CLIP 2 I
45 ZC15X01500 CLIP 2
46 2432Z290D4 WIRE TIE 8
47 ZC47XlB011 CLIP 5
48 ZC47X22014 CLIP 5
54 2420Z1801D1 BOLT 4
!
55 2420Z1801D2 BOLT 4
56 2420N458D10030 CAPSCREw 8
57 ZSlBC12035 BOLT 8

(02)
 POWER PLANT ASSY
TG.OU02-- GM ENGINE

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

58 ZS18C12060 CAPSCREW 4
61 ZS18C16120 CAPSCREW 2
62 ZS18C20130 CAPSCREW 2
65 ZN18C10008 NUT 10
67 ZN32C12011 U-NUT 4
68 ZN32C16015 U-NUT 2
69 ZN32C2D018 U-NUT 2
73 Zw16X10000 WASHER 8
74 ZW16X12000 WASHER 10
75 ZW16H10000 WASHER 8
76 ZW16H16000 WASHER 2
77 2 I
Zw16H20000 WASHER
78 2418T13084 WASHER 8 !
79 2418T7994 WASHER 8
80 2418T1451601 WASHER 4
81 2418T16065 WASHER 2
82 2418T5373C2 WASHER 4
84 Zw26X10000 LOCK WASHER 6
85 Zw26X12000 LOCK WASHER 8
88 ZE12X16000 CLAMP, HALF 4
89 ZD12P03_00 O-RING 2
90 244U1233D2 NIPPLE,HOSE(PT1/4) 1
91 ZE82T04000 PLUG (PTl14) 1
92 44&1289004075 TUBE, NYLON 1
93 44&1289006060 TUBE, NYLON .r-
94 Z012P02900 O-RING 2
I

i
I
I
i

(02) 251-01-2
'TI .....
G\
I
C> o
N
o
U1 o
N 129 N

N
I
l
U1

rTI
~.~ Z
Gl
103
~~l z
rTI
\ NQD
r-- .....
0::0
o l>
Hlr.III-. \. '- Z
1D(Jl

.~ r-- ~

r--(Jl
'TI~
o
26 Z
56
VIEW B-B Gl
::0
o
C
"tJ
15 Gl
.610 ~

103.72

85 23
2
SECTION A

....o
N
.....
o
....
N

59.61

*
~ 1

52
5 79.102 .91 7,9.101.91.102.112
53 112
VIEW J (MTG, GOVERNOR) ~
74.114

~
11331 ::
90 90.100.113
100 VIEW F-F f \ / \ 36 m
107 SECTION E-E z(j)
112.91.37 89 91 45.91.112
90
VIEW 0 -0 DETAIL G z
DETAIL H m
~ QO
~
o ::0
o ~
..... z
127.126.112.7 U) VI
~

~ -
~
VI

7.8.77.113 " ~
0
z
(j)
::0
0
c:
"lJ
.......
(j)
~
.......
27.

ql~oR I 40.81
:!!
tJ%:9rn~ I 39
(j)
~
N (j)
UI
I
N
I 0
N 0

-
UI

I
N
0
N

I
 ENGINE/TRANS GROUP (P/P GM) TG.0002--

I ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100J9414Fl

r 1 51U123 ENGINECGM/6L-71TA) 1
I i 53U134 TRANSMiSSiON 1
4
I 38Ul07 CYLINDER, AIR P. 270-252 1
5 2450U4F2 GOvERNOR ASSY 1
6 2436U525 BOOSTER, CLUTCH P. 271-252 1
7 2441U635Fl PUMP, VANE P. 272-252 1
8 2420P2183 GASKET 1
9 2479J362 HARNESS, WIRING 1
10 2479U458 SENDER, OiL PRESS 1
11 2479R1102F1 SENDER, TEMP 1
12 89&44 SENDER, SPEED 1
13 1014Z1462 COvER ASSY ·1
14 1015Z338 PLATE 1
15 1015Z933 DISK ASSY, CLUTCH 1
16 1015Z934 DISK ASSY, CLUTCH 1
17 15Z484 BRAKE ASSY 1
18 6Ql238 YOKE 1
19 15Z518 SHAFT. CLUTCH 1
20 15Z519 SHAFT, CLUTCH 1
21 15Z531 KEY 1
22 20Z711D58 CAPSCREW 2
23 19Z314 PIN 4
25 2406R306 LEVER ASSY 1
26 25T82005 BEARING 1
27 45Z33504 ADAPTER 1
28 2416J1407 BRACKET, ENGINE 1
29 2416J1408 BRACKET, ENGINE 1
30 2416P12419 BRACKET 1
31 2416P12418 BRACKET 1
32 1018Z2139 WASHER 2
33 2416N4578 BRACKET 1
34 2416P11870 BRACKET 1
35 24832T252 CLIP 1
36 24806T188 LINK 1
37 2420R842D3 ROO END 1
38 2420T616703 ROO 1
39 24818N174 FLANGE 1
40 2418P18606 SPACER 1
41 2418P18423 TUBE 1
42 2418P18539 TUBE 1
43 24816T1528 BRACKET 1
44 44&1289004125 HOSE, NYLON 2
45 2406R12502 ROD-END 1
46 2420R486D10
I 47 2420P2172D4
JOINT. BALL
ROD
1
1
48 2406P378401 LEVER 1
49 2418T16060 SPACER 1
50 2420T2589D3 BOLT, EYE 1
51 2417P238 SPRING 1
52 2420T6244 U-BOLT 1

(02)
 TG.0002-- ENGINE/TRANS GROUP (P/P GM)

ITEM PART.NO DESCRIPTION REMARKS IRTY APPLICABLE

53 2416T20763 SUPPORT 1
56 2432Z29004 WIRE TIE 10
57 44&129002 CONNECTOR 2
59 4461129101 ELBOw, 90 4
60 4461129102 ELBOW 1
61 2444R74001 CONNECTOR 4
62 2444R74002 CONNECTOR 1
1
I
63
64
44&129004
2444R74003
CONNECTOR
1
I
CONNECTOR
66 2444Z114003 PACKING 1
67 4461129001 CONNECTOR 1
68 2444T3507 ADAPTER 1
69 44Z21002 FITTING 1
72 20Zl0360151 BOLT 8
73 20Z10360173 BOLT 12
74 0827v023 CAPSCREW 1
75 20Z711024 CAPSCREW 2
76 20Z711D78 CAPSCREW 8
77 20Z711042 CAPS CREW 2
78 20Z7110513 CAPS CREW 1
79 ZS18C08025 BOLT 2
80 ZS18Cl0025 CAPSCREW 2
81 0630V045 CAPS CREW 5
82 ZS18Cl0035 CAPSCREW 2
83 20Z711072 CAPSCREW 2
84 ZS18C12035 BOLT 4
85 0682v058 CAPSCREW 8
89 2420Z168001 NUT 1
90 ZN18Cl0008 NUT 8
91 ZN18C08007 NUT 5
92 ZN18C06005 NUT 2
93 ZN18F16013 NuT 2
94 ZN17F12007 NUT 1
95 2444Z80803 ELBOW 1
96 2444R720013 ELBOW 1
97 2444R1484 ELBOW. 90 1
98 ZH32X12000 ELBOW 1
98-1 Z012P02240 a-RING 1
100 2418n373C2 WASHER 6
101 ZW16K10000 WASHER 1
102 Zw16X08000 WASHER 4
I
103 ZW16Hl0000 WASHER 8 I
104 2418T13084 WASHER 4
105 ZW16H12000 WASHER 22
106 ZW16X12000 WASHER 4
107 Zw16xl0000 WASHER 4
112 ZW26X08000 LOCK WASHER 6
113 Zw26Xl0000 LOCK WASHER 7
114 3616v008 LOCK WASHER 1 I
I

117 Z012P03800 O-RING 1

120 ZC45X16011 CLAMP 1
125 ZC45X22011 CLIP 1
126 2420T5267 GASKET 1
127 2418T13353 FLANGE 1

{02)
 ENGINE/TRANS GROUP (P/P GM) TG.0002--

ITEM PART.NO DESCRIPTION REMARKS &TV APPL.I CABL.E

!
128 2444P1609 CONNECTOR 1
II 129 2444R719D12 CONNECTOR 1
130 2436Z370 COCK 1
I 132
131 44&1401
44Z911Dll
HOSE-END
NIPPL.E, COMBINATION
1
1
133 2U4Zl94D14 CAP, TERMINAL. 1

2'2-2'1-3 (02)
 CYLINDER, AIR THROTTLE
TH-0001 '" 38U107
TG-0001 "-(

FIG 270-252-1
 CYLINDER, AIR THROTTLE
TG.0001--

ITEM PART.NO DESCRIPTION REMARI(S 6lTy .APPL I CABLE

38UI01 CYLINDER, AIR THROTTLE I

I 1014Z1811 CAP, CYLINDER I

2 I020Z6138 NUT, LOCK I
3 IOI1Z1160 SPRING, FAST IDLE I
4 1039Z513 PISTON, FAST IDLE I
5 1020Z6140 PLUG, PIPE I
6 1020Z1981 PLUG, PIPE I
1 1038Z322 BODY ASSY, CYLINDER I
8 1005Z590 BUSHING I
9 1020Z6141 NUT I
10 1018Z6083 FOLLOWER~ PISTON CUP I
II 1039Z514 PISTON I
12 1018Z6082 TUBE ASSY, PUSH I
13 1020Z6131 ROD, PISTON I
14 1011Z1159 SPRING, TAKE-UP I
15 1011Z1158 SPRING, GRADUATING I
16 1044Z664 ADAPTER, PUSH TUBE I
11 1020Z6139 SCREW, SET I
1031Z291 SEAL KIT, CYLINDER I
CONSIST OF ITEM 18 TO 23
18 SEAL, OIL I
19 GROMMET I
20 SEAL, OIL I
21 CUP, PISTON I
22 GROMMET I
23 GROMMET I

210-252-1
 VALVE, BOOSTER
TH-0001 ........ 2436U525
TG- 0001"-'

52 53 54 49 18 159 50

• ~
116 115

.88 87

41
86

29

5 6 7 8 9 10 111 110 11 63 61 143 66 67 68 99 91

FIG 271-252-1(j) (03)

 VALVE, BOOSTER
VALVE,BOOSTER TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTy APPLICABLE

2436U525 VALVE, BOOSTER

2 2436U525S2 END, PLATE 1

5 OIL SEAL 1
6 2436U525S6 WASHER 1
7 PACKING 1
8 2436U525S8 RETAINER 1
9 2436U525S9 wASHER 1
10 RING, RETAINING 1
11 2436U525S11 O-RING 1
12 FITTING 1
13 RING, RETAINING 1
14 GASKET 1
15 PISTON 1
16 PACKING 2
17 2436U1325S15 PLUG 1
18 2436U525S18 COVER 1
21 O-RING 1
29 2436U525S29 SEAL ASSY 1
30 ROD ASSY, PUSH 1
39 2436U525S39 O-RING 1
40 PISTON 1
41 PACKING 1
45 NUT 1
49 2436U525S49 BUSH 1
50 GASKET 1
51 2436U525S51 SPRING 1
52 2436U525S52 BOLT 4
53 2436U525S53 wASHER 7
54 2436U525S54 NUT 7
61 PISTON 1
63 PACKING 1
66 2436U525S66 CYLINDER 1
67 2436U525S67 WASHER 1
68 2436U525S68 RING, RETAINING 1
81 DIAPHRAGM 1
82 2436U525S82 BODY, VALVE 1
84 VALVE, POPPET 1
86 2436U525S86 SPRING 1
87 2436U525S87 CONNECTOR 1
88 GASKET 1
89 2436U525S89 SPRING 1
90 2436U525S90 CAPSCREw 5
91 2436U525S91 ROD ASSY, PUSH 1
99 GUARD 1
100 2436U1325S16 PROTECTOR 1
110 2436U525S110 CONNECTOR 1
111 GASKET 1
115 2436U525S115 BRACKET 1
116 2436U525S116 BRACKET 1
143 PACKING 1
159 2436U525S159 CLAMP 1

(03) 271-252-1 G)
 VALVE, BOOSTER
TG.0001-- VALVE,BOOSTER

ITEM PART.NO DESCRIPTION REMARKS CllTY APPLICABLE

2436U525R101 REPAIR KIT 1

CONSISTS OF ITEM 12, 13, 14, 15, 16
2436U525R102 REPAIR KIT 1
CONSISTS OF ITEM 30, 39, 40, 41, 45
2436U525R103 REPAIR KIT 1
CONSISTS OF ITEM 61, 63,143
2436U525Rl04 REPAIR KIT 1
CONSISTS OF ITEM 5, 7, 10, 11, 13
14, 16, 21, 39, 41
50, 63, 81, 84, 88
99,111,143

271-252-2 CD (03)
 PUMP, STEERING
TH-OOOl ~ 2441U635Fl
TG- 0001-

3 5 12 2 8 9 11

13 14 4 6 7 10 16

FIG 272-252-1@ (01)

 PUMP,STEERING .TG.0001--

ITEM PART.NO DEsCRIPTION REMAR"S ~TY APPLICABLE

2441U635Fl

1 2441U635S1 PLATE 1
2 RING 1
3 ROTOR 1
4 24UU635S4 PIN 2
5 VANE 12
6 2441U635S6 O-RING 2
7 2441U635S7 SEAL, SHAFT 1
8 2441U635S8 BEARING, BALL 1
9 2441U635S9 SNAP RING 1
10 2441U635S10 RETAINER 1
11 SHAFT 1
12 24UU635S12 SPRING 1
13 2441U635S13 BOLT, SOCKET 4
14 COVER 1
16 BODY 1

(01) 272-252-1
 PUMP STEERING (CAT)
TG-0001- 37U131

'~
A4
~1
2

31

12

FIG 273 -202 -1 G) (01)

 PUMP, STEERING (CAT)
TG.0001--

ITEM PART.NO DESCRIPTION REMARI(S GTY APPLICABLE

37UI31 PUMP, STEERING

I IU4::U£,;;)U;;) ;)IUU, .......... II K 2

2 1018Z7609 SPACER 2
3 1027Z246 RESERVO IR, STEER t"NG PUMP I
1045Z2368 SEAL KIT, RESERVOIR (SEE NOTE) 1
4 1020Z7506 NUT 2
0 WA:;t1t.K, SEALING 2
6 GASKET I
1037Z448 PUMP ASSEMBLY, STEERING 1
7 1014Z2404 HQLJSING, PUMP I
8 BUSHING I
'I I U4::U£(OU4 ~L.U", 1{4 IN DIA BALL I
10 1044Z832 ORIFICE I
II 1045Z2366 SEAL, SHAFT I
1045Z2367 SEAL KIT, PUMP I
II SEAL, SHAFT 1
14:: U-RING, PORT PLATES 4
13 1014Z2403 CAP, VALVE I
14 IOI7Z1376 SPRING, FLOW CONTROL 1
1036Z1536 VALVE, RELI EF 1
15 PLUNGER 1
10 SAL.L. , . 3{16 IN DI A 1
17 SPRING 1
18 BALL, 5/16 IN CIA 1
19 1020Z7507 KEY 1
20 1010ZI626 SHAFT, PUMP DRIVE 1
4::1 IUI'I£14·(0 PIN, UIHVE 1
22 1019Z1479 PIN, LOCATING 1
23 1018Z7607 RING, SNAP 2
24 1018Z7608 RING, RETAINING I
1018Z7610 CAM KIT 1
2:> PLATE, END-FRONT 1
26 CAM 1
27 CARRIER 1
28 ROLLS 12
29 PLATE, END-REAR 1
JU PLA TE, -COVER I
31 BUSHING 1

NOTE
ORDER SEAL KIT 1045Z2368 WHENEVER
RESERVOTR . IS Kt.MUVED.

REF 37UI31

(01 ) 273-202-1 CD
 SHEET METAL ASSY
TG-OOO 1 --- 24 1OOJ 9021 F I, F2

F1 : CAT ENGINE
F2 : G M ENGINE

65
-/75
~B5
~c;:r--3B
~I:-...
Q.:, -2

FIG 282-01-1<i) (04)

 SHEET META L ASSY
241 OOJ 902 1 F 1.F2 TG-0001-

58,

84~
24 4.98

91
k- 22 •
25 r
t$
, :;I'

(04) FIG 282-01-2®

 SHEET METAL ASSy
PIP CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GTY APPLICABLE

H100J9021 F1 SHEET METAL ASSy

1 21127J2147 COVER 1
2 21127J2148 COVER 1
3 21127J21119 COvER 1
II 2427J2150 HOOD,ENGINE(FRONT) 1
5 H27J2151 HOOD,ENGINE(REAR) 1
6 2427N21158 COVER 1
7 21127J2153 FENDER, FR.,L.H. 1
8 21127J2152 FENDER, FR.,R.H. 1
9 21127J2155 FENDER, RE.,L.H. 1
10 21127J21511 FENDER, RE.,R.H. 1
12 2416J1308 REST, BOOM 1
13 2416J1303 BUMPER 1
111 H16P11861 BRACKET 1
15 2416Pl1862 BRACKET 1
16 241I1Jl712 BOX 2
17 329J62 STEP 2
l8 316T2111 BRACKET 1
20 316P388 SUPPORT 1
21 318T195 SPACER 27
22 2427Z368 HANDLE 3
23 21129Z375 BLOCK, SKID 2
211 1I006Z111 CATCH 2
25 2416Z2711 RUBBER 2
26 2418T92111 SPACER 111
27 241913237 PIN 14
28 R25POO09DII9 BEARING 111
29 2416T6682 RUBBER, CUSHION 1
30 2416N1I577 BRACKET 1
31 21118T9138 WASHER 2
32 2416T18767 BRACI(ET 2
33 2416P11727 BRACKET 1
311 21156R156F1 MIRROR, SIDE 1
35 21156Z2711 MIRROR, UNDER 1
36 2418T15971 PIPE II
37 241913258 SPRING piN 9
38 2416Z2840330 SEAT, RUBBER 2
110 21116Z2840390 SEAT, RUBBER 1
41 21120P2185 HANDLE 4
112 21116N4473 SUPPORT 1
411 241I1T37112 COVER II
115 21118T16174 SPACER 8
46 21116P11863 8RACI(ET 1
47 2416P11864 8RACI(ET 1
48 ZS16C120110 CAPSCREW 6
49 ZMllC12025 BOLT 8
50 ZS41COIIOH SCREw II
52 ZS16C12090 BOLT 1
5) ZM11C08025 SEMS-80LT 2
511 ZS16C06025 CAPSCREW 2
55 ZS16C10035 CAPSCREW 4

(04)
 SHEET METAL ASSY
TG.0001-- pIP CAT ENGINE

ITEM PART.NO DESCRIPTION REMARIC.S IHY APPLICABLE

56 ZS16C20055 CAPSCREW 4
57 ZMllC12030 SEMS-BOLT 16
58 ZMllC08020 SEMS-BOLT 29
59 ZMllC10020 SEMS-BOLT 12
60 ZMllC06016 CAPS CREW 2
61 ZS16C16030 CAPS CREW 4
62 ZN16C05004 NUT 1
63 ZN16C06005 NUT 6
64 ZN16C08007 NUT 32
65 ZN16C10008 NUT 18
66 ZN16C12010 NUT 61
67 ZS16C16035 CAPSCREW 8
68 ZN16C20016 NUT '+
72 ZW26X05000 LOCK WASHER 1
74 Zw26X08000 LOCK WASHER 14
75 ZW26X10000 LOCK WASHER 20
76 ZW26X12000 LOCK WASHER 55
77 Zw26X16000 LOCK WASHER 12
78 Zw26X20000 WASHER '+
84 ZW16X08000 WASHER 39
85 ZW16X1OOOO WASHER 32
86 ZW16X12000 WASHER 6
87 ZW16X16000 WASHER 12
88
89
ZW16X20000
2418Tl6187
WASHER
WASHER
4
4
i
I
90 2418Tl3084 WASHER 47
91 ZS41C06030 MACHINESCREw 6 I
92 ZS61C10020 CAPSCREW 4
95 2414P5566 COvER 1
96 2418Tl5973 BOARD 1
97 2416P1185'+ SUPPORT 1

24100J9021F2 SHEET METAL ASSY

PIP GM ENGINE

The par ts are salle as ( F1 ) except the following part.

I
I

98 2427J2223 HOOD.ENGINE(FRONT) 1 i

I
I
I
I

I I
I
I

(04) 282-01-2 ®
 INSTAL. CLEANER. AIR(CAT)
TG-0001- 24100J9032Fl

1-1
1 5 4 6 8 7 9

~--~--------------------

2.10.12 3 11.13.14

2 3 1. 1-1

SECTION A- A

FIG 283 - 01 -1 CD (02)

 INSTAL, CLEANER, AIR
PIP CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTV APPLICABLE

24100J9032F1 INSTAL, CLEANER, AIR

1 2446R103D14 CLEANER 1
1-1 2446Z126D4 ELEMENT 1
2 2432Z162D7 BAND 2
3 R51POO05 INDICATOR 1

,
4 244'+Z1412D7
2432R181D16
REDUCER
CLAMP
1
1
6 2432R181D14 CLAMP 1
7 2432Rl81D12 CLAMP 2
8 2418N2961 TUBE 1
9 244'+Z1411D3 HUMP, STRAIGHT 1
10 ZS17C10035 CAPSCREW '+
11 ZS17C08020 CAPSCREW 4
12 ZW26X10000 LOCK WASHER 4
13 ZW26X08000 LOCK WASHER 4
14 2418T908802 WASHER '+

(02)
 INSTAL. CLEANER. AI R (GM)
TG-0002- 24100J9379Fl

2 1.1-1 9 6 8 5

11.15.18

1.1-2

12.14.16.17

13.16.17
SECTION A- A

FIG 283-02-1 (01)

 INSTAL, CLEANER, AIR
pIP GM ENGINE TG.0002--

ITEM PART.NO DESCRIPTION REMARI(.S (HY APPLICABLE

24100J9379F1 INSTAL, CLEANER, AIR

1 2.46R103D19 CLEANER 1
1-2 2446Zl2605 ELEMENT 1
2 2432Z16208 CLAMP 2
3 2416P12401 BRACKET 1
4 2.50R124 INDICATOR 1
5 2418Pl8420 TUBE 1
6 2444Zl412D9 REDUCER 1
7 2432R181012 CLAMP 2
8 2'+32R181017 CLAMP 1
9 2432R181D21 CLAMP 1
10 2444Zl60007 ELBOW, 90 1
11 ZS18C08020 CAPSCREW '+
12 ZS18C10020 CAPSCREW '+
13 ZS18C1OO35 CAPSCREW '+
14 ZN18C10008 NUT '+
15 ZW26X08000 LOCK WASHER '+
16 ZW26X10000 LOCI(. WASHER 8
17 ZW16X10000 WASHER 8
18 2418T908802 WASHER 4

(OJ) 283-02-1
 INSTAL. MUFFLER(CAT)
TG-0001- 24100J8909F2

5-2
5-1

FIG 284-01-t(j) (02)

 INSTAL, MUFFLER
piP CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTy APPLICABLE

24100J8909F2 INSTAL, MUFFLER

1 2427R808 MUFFLER 1
2 2418P17598 TUBE 1
3 2418T15975 TUBE 1
4 2432R146D1 CLAMP 1
5 2432P1404F1 CLAMP ASSY 2
5-1 2416T15333 BRACKET 1
5-2 2420T5529 U-BOLT 1
5-3 ZN16C08007 NUT 2
5-4 zw26X08000 LOCK WASHER 2
6 ZW16X08000 WASHER 4

(02)
 INSTAL. MUFFLER(GM)
TG-O 00 2 ..... 24100J9377F2

13

13 9,11

11.10,9

VIEW A- A

FIG 284-02-1 co 1)
 INSTAL, MUFFLER
pIp GM ENGINE TG.0002--

ITEM PART.NO DESCRIPTION REMAHKS GlTy APPLICABLE

24100J9377F2 INSTAL, MUFFLER

1 2427R777 MUFFLER 1
3 2418P18526 TUBE 1
4 2418T15975 TUBE 1
6 2432R14601 CLAMP 1
7 2416T15333 BRACKET 2
8 2420T5529 U-BOLT 2
9 ZS18C10020 CAPSCREW 2
10 ZN18C10008 NUT 1
11 ZW26X10000 LOCK WASHER 2
12 ZW16X08000 WASHER 4
13 2418T16466 PLATE 1
14 ZN16C08007 NUT 4
15 ZW26X08000 LOCK WASHER 4

(01)
 CONTROL ASSY, LOWER (CAT)
TG-0001- 241 OOJ 9444F2

4\~.~'~
CLUTCH-LEVER

0~l\\3
8-2
TRANSMISSION

DRIVE PUMP

34
25 1a
15

FIG 300-01-1 (01 )

 CONTROL ASSV
PIP CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &TV APPLICABLE

2UOOJ9444F2 CONTROL ASSV

1 2UOOJ8942F2 BASE ASSV, CAB p. 301-300 1

4 2UOOJ9034F2 CONTROL ASSV P. 312-300 1
5 2420T6094 ROD 1
8 2420P2187 ROD 1
8-2 24820T313 ROD 1
9 2420P2188 ROD 1
9-2 24820T313 ROD 1
9-3 248201314 ROD 1
11 18Z2211 U-JOINT 3
12 2425R201 BEARING 1
14 2418N3096 TUBE 1
14-1 44Z211D4 NUT 2
15 2444R639D3 HOSE 2
18 2444Z2764D2 HOSE 2
23 2432Z290D4 WIRE TIE 7
25 ZC15X02600 CLIP 6
26 ZC45X08007 CLIP 3
31 ZM11C06020 CAPSCREW 1
33 44Z20806 CONNECTOR 4
34 2444T2768 ADAPTER 1
35 244H3534 CONNECTOR 1
36 2435V002 COUPLING 1
37 24844T94 SOCKET 1
38 2444Z114005 PACKING 1
40 ZS18C08020 CAPSCREW 2
U ZS18C08055 CAPSCREW 1
42 ZS18C20050 CAPSCREW 7
44 ZW26X06000 LOCK WASHER 3
45 ZW26X08000 LOCK WASHER 1
47 ZN18C06005 NUT 3
48 ZN18C08007 NUT 3
49 ZN18C20016 NUT 7
52 ZW16X08000 WASHER 2
53 ZW16H20000 WASHER 7

300-01-1
 CONTROL ASSV, LOWER (G M)
TG-0002- 24100J9444F4

\
CLUTCH- LEVER

10
10-2
TRANSMISSION

18

ENGINE
34
25 19
15

Fl G 300-02-1
 CONTROL ASSY
Pip GM ENGINE TG.0002--

ITEM PART.NO DEsCRIPTION REMARKS GTY APPLICABLE

24100J9444F4 CONTROL ASSY

2 24100J8942F3 BASE ASSY, CAB p. 302-300 1

4 24100J9034F2 CONTROL ASSY P. 312-300 1
5 2420T6094 ROO 1
9 2420P2188 ROO 1
10 2420P2388 ROO 1
II 18Z22ll U-JOINT 3
12 2425R201 BEARING 1
14 2418N3096 TUBE 1
15 2444R639D3 HOSE 2
18 2444Z276402 HOSE 1
19 2444Z276403 HOSE 1
23 2432Z290D4 WIRE TIE 7
25 ZC15X02600 CLIP 6
26 ZC45X08007 CLIP 3
31 ZMllC06020 CAPSCREW 1
33 44Z208D6 CONNECTOR 4
34 2444T2768 ADAPTER 1
35 2444T3534 CONNECTOR 1
36 2435V002 COUPLING 1
37 24844T94 SOCKET 1
38 2444Zl14005 PACKING 1
40 ZS18C08020 CAPSCREW 2
41 ZS18C08055 CAPSCREW 1
42 ZS18C20050 CAPSCREW 7
44 ZW26X06000 LOCK WASHER 3
45 ZW26X08000 LOCK WASHER 1
47 ZN18C06005 NUT 3
48 ZN18C08007 NUT 3
49 ZN18C20016 NUT 7
52 ZW16X08000 WASHER 2
53 ZW16H20000 WASHER 7

300-02-1
 CNT650
( CNT 500 CUMMINS)
CAT
TH-0001 "'"
TG-0001-

20

5-1

5-1K

16

FI G 3 01-300-1 (05)
 BASE ASSY, CAB
TH- 0001-
2410 OJ8942F2 TG-0001-
76 62 63

75

77

51

,CAB BASE

55

FIG 301-300-2
(05)
 BASE ASSV' CAB
PIP CAT ENGINE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GTV APPLICABLE

24100J8Q42F2 BASE ASSV. CAB

I
I
3 24800N252F1 TANK ASSV. wASHER 1
3-1 24100U157 TANK ASSV 1
3-2 24100R43 NOZZLE 1
3-3 2413Z633 TUBE 1
3-4 2432Z309D1 CL.AMP 4
3-5 ZS18C06016 CAPSCREW 2
3-6 ZW26X06000 L.OCK WASHER 2
4 24800N253F1 HEATER. DEFROSTER P. 303-302 1
5 24100N4603F1 SEAT ASSV 1
5-1 2448U131F1 SEAT 1
5-1A 2448U131S1 CUSHION 1
5-1B 2448U131S2 HEADREST 1
5-lIt 2448U131S11 CUSHION.8ACK 1
5-2 2448U122Fl DEVICE.SUSPENSION 1
5-3 2448U130 BELT 1
5-4 2448U116F1 BEL.T ASSV' SEAT 2
5-5 ZS16C08020 CAPS CREW 4
5-6 ZN16C08005 NUT 4
5-7 ZW26X08000 L.OCK WASHER 4
6 16&109 SHIFT P. 314-302 1
7 14Z391 BOOT 1
8 2416T18569 PL.ATE 2·
9 24800J540F1 CL.UTCH ASSV P. 304-302 1
10 2420R429D17 GROMMET 1
11 2436Ul631F2 VALVE. AIR P. 310-302 1
12 R38KOO05 VALVE P. 306-302 1
13 24800J641F1 STEERING ASSY P. 307-302 1
14 2427R55502 MOUNT 4
15 2416J1280 SUPPORT. CAB 1
16 2416J1282 SUPPORT. CAB 1
18 2479Z325 SwiTCH. STOP L.IGHT 2
19 2436R1060 VAL.VE. CONTROL.. 2WAY P. 308-302 1
20 24100J8968F1 DASH ASSV. L.OW P. 309-302 1
21 2436R1224 VAL.VE 1
22 2436U159 VAL.VE ASSY 1
23 44&129103 EL.BOW 2
24 2432T3436 PL.ATE. CAUTION 1
25 ZG32B04000 EL.BOW. 90 2
26 ZG52U06000 TEE 2
27 44&129102 EL.BOW 4
28 R38POOll03 VAl.VE. AIR 1
29 4.&12900$ CONNECTOR 1
30 24.4T1869 CONNECTOR 1
31 2432T3408 Pl.ATE. CAUTION 1
32 44&129303 TEE 1
33 44&129302 TEE 3
35 ZG22E06000 CONNECTOR 2
36 ZG22B06004 CONNECTOR 4
37 .4&129104 EL.BOW 2
38 2436R201 VAl.VE. CHECK 1

(05)
 BASE ASSV. CAB
TG.0001-- piP CAT ENGINE

ITEM PART.NO DESCRIPTION REMARKS GlTV . APPL I CABLE

39 ZC4'X10009 CLIP 1
40
42
44&128900U3,
4"&1289006038
TUBE
TUBE
•1
.4 4.&1289004072 1
., 44&1289004061
TUBE
TUBE •1
46 44&1289004120 TUBE
47 44&1291D5 ELBOW 2
48 ZG52U04000 TEE 4
49 ZG22E04000 NIPPLE 1
50 20Z7110515 BOLT 3
51 ZS18C10025 CAPSCREW 8
52 ZS18C08025 BOLT 3
53 ZS18C16190 CAPSCREW 2
'4 ZS18C16090 CAPSCREW 2
55 ZN18C06005 NuT 2
56 ZN18C10008 NUT 8
57 ZN18C08007 NuT 4
58 ZN32C16015 U-NUT 4
59 ZW16X10000 WASHER 10
60 R16T0152D8 WASHER 4
61 ZW16H16000 WASHER 4
62 Zw16X08000 WASHER 4
63 ZS16C08020 CAPSCREW 4
64 ZW26X10000 LOCK WASHER 8
65 ZW26X08000 LOCK WASHER 3
66 ZW26X06000 LOCK WASHER 5
67 ZS16C06050 BOLT 2
68 .ZW16H10000 WASHER 3
69 ZS18C06020 BOLT 3
70 ZS31C03014 MACHINESCREW 6
71 ZW26X04000 LOCK WASHER 3
72 2UOOP2038F1 PANEL ASSV P. 311-302 1
73 2479Z324 SwITCH. LOW PRESSURE 3
75 448129002 CONNECTOR 1.
76 lC45X25011 CLAMP 3
77 ZS31C04016 MACHINESCREW 3
78 ZN11C04003 NUT 3
79 2.879P16 OIODE 1
80 24879P17 OIOOE 1
81 ZG22E04002 NIPPLE 1
82 ZE72T04000 PLUG 1
83 448129101 ELBOW. 90 1
84 24879P20 HARNESS. WIRING 1
85 2432T3435 PLATE, CAUTION 1
86 2420T554907 SCREW 10
87 2U8T1425902 WASHER 10
92 2432129003 CLIP 5
97 2420R189017 GROMMET 1
98 2427J2221 BASE, CAB 1

(05) 301-300-2
 ( G M)
TH-0003 ....
TG-0002 .....

20

5-1

5-1K

16

FIG 3 02 -300-1 (OS)

 BASE ASSY, CA B (G. M)
241 OOJ 8942 F3 TH-0003-
TG-0002-
76 62 63

75

77

97

CAB BASE 82

88 75

55

FIG 302-300-2
(05)
 BASE ASSY, CAB
PIP GM ENGINE TG.0002--

ITEM PART.NO DESCRIPTION REMARKS &TY APPLICABLE

24100J8942F3 BASE ASSY, CAB

3 24800N2'52F1 TANK ASSY, WASHER 1

3';'1 2UOOU157 TANK ASSY 1
3-2 24100R43 NOZZLE 1
3-3 2413Z633 TUBE 1
3-4 2432Z30901 CLAMP 4
3-5 ZS18C06016 CAPSCREW 2
3-6 ZW26X06000 LOCK WASHER 2
4 24800N253F1 HEATER, DEFROSTER P. 303-302 1
5 24100N4603F1 SEAT ASSY 1
5-1 2448U131F1 SEAT 1
5-1A 2448U131S1 CUSHION 1
5-1B 2448U131S2 HEADREST 1
5-1K 2448U131S11 CUSHION,BACK 1
5-2 2448U122 SUSPENSION DEVICE 1
5-3 H48U130 BELT, SEAT 1
5-4 2448Ul16F1 BELT ASSY, SEAT 2
5-5 ZS16C08020 CAPSCREW 4
5-6 ZN16C08005 NUT 4
5-7 ZW26X08000 LOCK WASHER 4
6 16&109 SHIFT P. 314-302 1
7 14Z391 BOOT 1
8 2416T18569 PLATE 2
9 24800J540F1 CLUTCH ASSY P. 304-302 1
10 2420R429D17 GROMMET 1
11 2436U1631F2 VALVE, AIR P. 310-302 1
12 R38KOO05 VALVE P. 306-302 1
13 24800J641F1 STEERING ASSY P. 307-302 1
14 2427R555D2 MOUNT 4
15 2416J1280 SUPPORT, CAB 1
16 2416J1282 SUPPORT, CAB 1
18 2479Z325 SwiTCH, STOP LIGHT 2
19 2436R1060 VALVE, CONTROL, 2WAY P. 308-302 1
20 24100J8968F1 DASH ASSY, LOW P. 309-302 1
21 2436R1224 VALVE 1
22 2436U159 VALVE ASSY 1
23 44&129103 ELBOW 2
24 2432T3436 PLATE, CAUTION 1
25 ZG32B04000 ELBOW. 90 2
26 ZG52U06000 TEE 2
27 44&129102 ELBOW 4
28 R38P0011D3 VALVE. AIR 1
29 44&129003 CONNECTOR 1
! 30 H44T1869 CONNECTOR 1
31 2432T3408 PLATE, CAUTION 1
32 44&129303 TEE 1
33 44&129302 TEE 4
35 ZG22E06000 CONNECTOR 2
36 ZG22806004 CONNECTOR 4
37 44&129104 ELBOW 2
38 2436R201 VALVE. CHECK 1

302-300-1 (OS)
 BASE ASSY, CAB
TG.0002-- pIP GM ENGINE

ITEM PART.NO DESCRIPTION REMAR~S &TY APPI.I CABI.E

40 44&128900413'5 TUBE 4
42 44Gl289006038 TUBE 1
44 44Gl289004072 TUBE 1
45 44Gl289004061 TUBE 4
46 44&1289004120 TUBE 1
47 44&129105 EI.BOW 2
48 z.G52U04000 TEE 4
49 z.G22E04000 NIPPLE 1
50 201.7110515 BOI.T 3
51 z.S18C10025 CAPSCREW 8
52 z.S18C08025 BOLT 3
53 z.S18C16190 CAPSCREW 2
54 z.S18C16090 CAPSCREW 2
55 z.N16C06005 NUT 4
56 z.N18C10008 NUT 8
57 z.N18C08007 NUT 3
58 z.N32C16015 U-NUT 4
59 z.w16X10000 WASHER 10
60 R16T015208 WASHER 4
61 z.W16H16000 WASHER 4
62 z.w16X08000 WASHER 3
63 z.S16C08020 CAPSCREw 3
64 Z.W26X10000 1.0C~ WASHER 9
65 z.W26X08000 1.0CK WASHER 3
66 z.W26X06000 1.0CK WASHER 7
67 z.S16C06050 BOLT 2
68 z.W16H10000 WASHER 3
69 z.S18C06020 BOI.T 3
70 z.S31C03014 MACHINESCREW 6
71 z.w26X04000 1.0CK WASHER 3
72 24100P2038F1 PANEL ASSY P. 311-302 1
73 24791.324 SWITCH, LOW PRESSURE 3
75 44&129002 CONNECTOR 16
76 z.C45X25011 CI.AMP 3
77 z.S31C04016 MACHINESCREW 3
78 z.N11C04003 NUT 3
79 24879P16 DiODE 1
80 24879P17 DIODE 1
81 z.G22E04002 NIPPI.E 1
82 ZE72T04000 PLUG 1
83 44&129101 EI.BOW, 90 2
84 24879P20 HARNESS, WIRING 1
85 2432T3435 PI.ATE, CAUTION 1
86 2420T554907 SCREW 10
87 2418T1425902 WASHER 10
88 2444R74002 CONNECTOR 3
89 36&329 VALVE. REI.AY 1
90 44&1289004055 HOSE, NYI.ON 1
91 44&1289004090 HOSE, NYI.ON 1
92 2432Z29003 C!.IP 5
93 z.C45X22011 CI.IP 1
94 z.S18C06016 CAPSCREW 2
95 ZS16C10016 CAPSCREW 1
96 ZN16C10008 NUT 1

(OS)
 BASE ASSY, CAB
PIP GM ENGINE TG.0002--

ITEM PART.NO DESCRIPTION REMARKS 6lTy APPLICABLE

97 2420R18q017 GROMMET 1
98 2427J2221 SASE, CAS 1

(as)
 HEATER & DEFROSTER ASSV
TH- 0001 - 24800N253Fl
TG- 0001 -

5 20 21

3
21

../'-......
13 -----=-

'--_---6
9

14

18 ,:-1
19~
17

8
16- A
11

FIG 303-302-1 (03)

 HEATER, DEFROSTER
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy APPLICABLE

24800N253F1 HEATER, DEFROSTER

1 2480P1F1 HEATER 1
2 ZS18C10020 CAPSCREW 4
3 ZN18C10008 NUT 4
4 ZW26X10000 LOCK WASHER 4
5 2432Z547 DECAL 1
6 2427R767Fl NOZZLE ASSY 2
7 2444Z2227 CONNECTOR 4
8 2444Z2765D1 HOSE 1
9 2444Z2765D2 HOSE 1
10 2444Z2772 JOINT, PIPE 1
11 2444Rl310 ELBOW 2
12 2444Z2175D1 HOSE 1
13 2444Z2576 PLUG 1
14 24321551 CLAMP 1
15 2432Z552 CLAMP 2
16 ZS17C06020 BOLT 3
17 ZN17C06005 NUT 3
18 ZW16x06QOO WASHER 3
19 ZW26XQ6000 LOCK WASHER 3
20 2444Z2173 HOSE 2
21 ZC15X02300 CLAMP 6

(03) 303-302-1
 CLUTCH ASSY
TH-OOOl - 24800J540F1
TG-OOOl ,..,

CAB BASE

17

29~

FIG 304-302-1 (02)

 CLUTCH ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTY APPLICABLE

24800J540F1 CLUTCH ASSY

1 24806P226 ARM, CLUTCH 1

2 24816P832 BRACKET 1
3 2436Ul960 CYLINDER ASSY P. 305-304 1
4 24806P227 YOKE 1
5 2414Z158 COVER 1
7 2419T4216 PIN 1
8 ZP15D04022 COTTER PIN 2
9 ZW16X16000 WASHER 2
10 2405U101D1625 BUSHING 2
11 ZP45X12032 PIN 1
12 ZP15D04018 PIN 2
13 ZS18C12120 CAPSCREw 1
14 2417Z204 SPRING 2
15 ZS18C06025 CAPSCREW 4
16 ZW26X06000 LOCK WASHER 4
17 ZM11ClO030 SEMS-BOLT 4
18 ZN18C10008 NUT 7
19 ZW26X10000 LOCK wASHER 3
20 ZS18C10035 CAPSCREw 3
21 ZN18C12010 NUT 1
22 ZW16X12000 WASHER 2
23 ZW26x12000 LOCKWASHER 2
24 2049V004 NUT 1
26 2418Tl6198 SHEET, RUBBER 1
27 2418Tl6197 PLATE 2
28 ZW16X06000 WASHER 2
29 ZW16H10000 WASHER 4

1Q21 304-302-1
 CYLINDER ASSY. MASTER
TH-0001rv 2436U1960
TG-0001---

19

18

17------~

16

14 13 12 11 2 4 3 6 7 8 5 9 10 20

FI G 305-304-1 (01 )
 CYLINDER ASSY
CYLINDER ASSY,MASTER TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

2436Ul960 CYLINDER ASSY

1 CYLINDER 1
2 2436U1960S2 SEAT, VALVE 1
3 2436U1960S3 VALVE ASSY, CHECK 1
4 2438U1250S2 SPRING 1
5 2436U1960S5 PISTON ASSY 1
6 2438U1250S4 STOPPER 1
1 2420Z31 GASKET 1
8 2418Z30 RING 1
9 2436U1960S9 ROD ASSY, PUSH 1
10 2438U1250S9 RING, STOP 1
11 20Z61 GASKET 1
12 2436Ul960S12 CONNECTOR 1
13 20Z62 PACKING 1
14 20Z63 BOLT 1
15 2436Ul960S15 SCREw, BLEEDER 1
16 2414Z4 CAP, BREATHER 1
11 ZD12G03500 O-RING 1
18 2438U1250S10 CAP AS5Y, FILLER 1
19 2438U819520 PLUG 2
20 2436U1960520 BOOT 1

(01) 305-304-1 <D

 APPLI CATION VALVE, AI R
TH-0001 ......, R38K0005
TG - 0001 -.J

40

52---~=-~~r==1~~m1i~:r.r~~~---
13
31 - ___----~~~~::::::,..,,.,.....,,,....,...-'1

32

3
2
4
5
6
11
13
15
222
23
28
3
29

FIG 306 -302-1

 APPLICATION VALVE, AIR
TG.0001--

ITEM PART.NO DESCRIPTIO~ HEMAHJ(S (illy APPLICABLE

R38KOOO5 APPLICATION VALVE, AIR

I R38KOOO5EI BOOY I
2 VALVE, UPPER I
3 RETAINER, VALVE I
4 SPRING, VALVE I
5 WASHER, .SPEC I AL I
6 O-RING I
7 RETA INER I
8 RING, RETAINER I
9 RING, RETAINER I
10 R38KOO05E27 PISTON, OUTER RELAY I
II O-RING I
12 R38KOO05E29 PISTON, INNER RELAY I
13 O-RING I
14 O-RING I
15 R38KOO05E32 SPRING I
16 R38KOO05E33 COVER I
17 O-RING I
18 R38KOO05E35 LOCKWASHER 4
19 R38KOO05E36 CAPSCREW 4
20 VALVE, LOWER I
21 RETAINER, VALVE I
22 SPRING, VALVE I
23 O-RING I
24 GUIDE, VALVE I
25 WASHER, SPECIAL I
26 RING, RETAINER I
27 O-RING 2
28 R38KOO05E45 SEAT, VALVE I
29 R38KOO05E46 CHECK, EXHAUST I
30 R38KOO05E47 RING, RETAINER I
31 R38KOO05E48 SPRING I
32 R38KOO05E49 PISTON I
33 R38KOO05E50 SPRING, RUBBER I
34 R38KOO05E51 WASHER, SPECIAL I
35 R38KOO05E52 SEAT, SPRING I
36 R38KOO05E53 CAPSCREW I
37 R38KOO05E2 PLATE, MOUNT ING I
38 ZW22X08000 LOCKWASHER 3
39 ZS IIC08020 CAPSCREW 3
40 R38KOO05E5 B'JTTON, STOP I
41 R38KOO05E6 PLUNGER I
42 R38KOO05E7 BOOT I
43 R38KOO05E54 TREADLE I
44 R38KOO05E55 FERRULE, FULCRUM I
45 R38KOO05E56 FERRULE, ROLLER 2
46 R38KOO05EI3 PIN, FULCRUM 2
47 R38KOO05EI4 PIN, ROLL I
48 R38K0005E I I PIN, ROLLER I
49 R38KOO05EI0 ROLLER 1
50 R36KOO05EI2 COTTER-PIN I

J06-J02-1(j)
 STEERIN G ASSV
TH;'0001 .... 24800J641Fl
TG -0001 ....

30

25

b 24

~ 4

21

.~/
~ ,
37

CAB BASE

34

FIG 307- 302-1(1) (04)

 STEERING ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CilTY . APPLICABLE

24800J641Fl STEERING ASSY

3 2413Z121 WHEEL' STEERING 1

4 2419U658 SWITCH 1
6 2416N4582 BRACKET 1
11 2445R214 BOOT 1
12 ZS18C08045 BOLT 2
13 ZS18C08020 CAPSCREW 4
15 ZS31C06008 MACHINESCREW 6
11 ZN18C08001 NUT 2
18 ZW26X08000 LOCK WASHER 6
19 ZW26X06000 LOCK WASHER 6
20 24818T1089 FLANGE 1
21 2420Z1194 SCREw.TAPPING 3
23 2414Z253 COWL 1
24 2414Z254 COWL 1
25 2420Z1161 SCREW 4
26 ZC15X09000 CLAMP 1
21 ZC15X10500 CLIP 1
28 2420Z1596 BOLT 1
29 ZW26X10000 LOCKWASHER 1
30 24832T264 DECAL 1
32 2401U1 GEAR. STEERING 1
33 ZS18C18065 CAPSCREW 1
34 ZS18F18045 CAPSCREW 3
35 ZN18C18015 NUT 1
36 ZW16H18000 WASHER 4
31 2410R123 CULUMN.STEERING P. 313-301 1
38 ZN16F20016 NUT 1
39 ZW26X20000 LOCK WASHER 1

(04) 301-302-1 CD
 VALVE, CONTROL, 2WAY
TH-0001 ........ 2436R1060
T G- 00 01 ""

/)
11

5
//"
6

2
7

9 10

FIG 308-302-1 (03)

 VALVE, CONTROL, 2WAY
VALVE,2WAY CONTROL TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy APPLICABLE

243bR1ObO VALVE, CONTROL, 2WAY

1 243bR1060S1 BOOY 1
2 SPRING, PLUNGER 1
3 Q-RING 1
4 2436R1060S4 PLUNGER 1
5 2436R1060S5 LEvER 1
6 2436R1060Sb PIN 1
7 VALVE 1
8 SPRING 1
9 2436R1ObOS9 CAP, VALVE 1
10 Q-RING 1
II 2436R1060S11 MACHINE SCREW 2
2436R1060R101 REPAIR KIT 1
CONSISTS OF ITEM 2, 3, 7, 8, 10

(03) 308-302-1CD
 TH-OOO J""-
TG-OOO 1-.. DASH ASSY,LOW
24 1 00 J 89 6 8F J

1
12-1

22,23

19

FIG 309-302_1

(04)
 DASH ASSy, LOW
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTy . APPLICABLE

24100J8968F1 DASH ASSy, LOW

1 2432J1801 PANEL 1
2 2489U191 GAUGE, FUEL 1
3 2489U189 GAUGE,OIL PRESSURE 1
4 2489U190 GAUGE,COOL TEMP 1
5 2419U636 VOLT METER 1
5-1 2456Z368 BULB 1
6 89u25 SPEEDOMETER 1
6-1 2456Z386 BULB 1
1 89Z154D1 TACHOMETER 1
8 2489U119F1 GAUGE, AIR PRESS 3
8-1 2456Z368 BULB 1
9 2419U451F2 HOURMETER 1
10 2419R610 SwiTCH, STARTER 1
11 2419Z1361 LAMP, TURN SIGNAL 2
11-1 R19T0048D1 BULB, LIGHT 1
12 R19P0060F1 LAMP, SIGNAL 5
12-1 R19T0048D1 BULB, LIGHT 1
13 R19P0060F3 LAMP, SIGNAL 1
13-1 R19T0048D1 BULB, LIGHT 1
14 2419Z1362 LAMP,SIGNAL 1
14-1 4056Z20D2 BULB 1
15 2419Z956 LIGHTER 1
16 2419R108 FUSE 1
11 19(il160D1 SWITCH, DOME 1
18 2420R429D5 GROMMET 3
19 24819J25 wiRING HARNESS 1
20 24819N20 WIRE HARNESS 1
21 2419R1040 SWITCH, HEATER 1
22 2419R1058 CONTROL, ILLUM. 1
23 2406Z282 KNOB 1
24 2419R651 S/w LIGHT(CARRIER) 1

<DO 309-302-1(D
 VALVE ASSY, THROTTLE
2
TH-0001- 2436U1631F
TG-OOOl -

27

~---7
~~--2
22

1 1 - - ...

FI G 310-302-1(D {on
 VALVE, AIR
VALVE,AIR TG.OOOl--

ITEM PART.NO DESCR I PTI ON REMARKS <llTy APPLICABLE

2436U1631F2 VALVE, AIR

1 BODY 1
2 2436U1631S2 CAP, VALVE 1
3 2436U1631S3 VALVE ASSY 1
4 2436U1631S4 SPRING 1
5 2436U1631S5 GUIDE, VALVE 1
6 2436U1631S6 VALVE 1
7 2436U1631S7 O-RING 1
8 2436U1631S8 SPRING 1
9 PISTON 1
10 2436U1631S10 O-RING 1
11 2436U800S3 O-RING 1
12 2436U1631S12 SPRING 1
13 2436U1631S13 SPRING 1
14 2436U1631S14 SEAT, SPRING 1
15 ZW16P06000 wASHER 1
16 2436U1631S16 BOLT 1
17 2436U1631S17 SEMS-BOLT 1
18 2436U1631S18 DIAPHRAGM 1
19 2436U690S41 WASHER 1
20 2415R157S26 LOCK WASHER 1
21 2436U690S42 SCREW' TAPPING 1
22 PLATE, MTG 1
23 2436U1631S23 BUSHING 1
24 2436U1631S24 BUSHING 2
25 2436U1631S25 PLUNGER 1
26 2436U1119S26 BOOT 1
27 2436U1631S27 TREADLE 1
29 2436U1631S29 BOOT 1
30 2436U1119S29 PIN 2
34 2436Ull19S30 PIN 2
35 2436Ull19S31 ROLLER 1
36 2436Ull19S32 PIPE 1
37 2436U804S33 PIN 2
38 2436U1631S38 SETSCREw 1
39 2436U804S35 NUT 1
40 2436U690S55 SEMS-BOLT 3

2436U1631Rl02 REPAIR KIT 1

CONSiSTS OF ITEM 2, 3, 4, 5, 6
7, 10, 11, 18, 26

(on 310-J02-1CD
 PANEL ASS V
TH-0001- 24100P2038F1
TG-OOO 1-

2 9.8.7 5 6

12.11.10

3-1.3
o
o ®

4·

FIG 311-302-1 co 1)
 PANEL ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (\lTy APPLICABLE

24100P2038F1 PANEL ASSY

1 2418Pl7815 PLATE 1
2 2419R131D2 RELAY 2
3 2419Z1l61 RELAY 1
3-1 R19T0012D4 FUSE 1
4 2419Z444 BUZlER 1
5 R38NOO14 VALVE, HORN 1
6 4461129102 ELBOW 1
1 ZS31C06016 SCREW 5
8 ZN18C06005 NUT 5
9 ZW26X06000 LOCK WASHER 5
10 ZS16C06014 CAPSCREW 2
11 lN16C06005 NUT 2
12 ZW16X06000 WASHER 2

(01) 311-302-1
 CONTROL ASSY, PTO
TG"-0001- 241 OOJ 9034 F1, F2

13

............~
17
'\
~
16
11
6

4,24

FIG 3 1 2 - 3 00-1(:1) (02)

 CONTROL ASSy,PTO TG.0001--

ITEM PART.NO DESCRIPTION ~EMARJ(.S <Hy APPLICABLE

24100J9034 F1 TG.0001--TG.0001
24100J9034F2 TG.0002--

1 2420P211b ROD 1
2 240bP3822 LEVER 1
3 241bP1l145 BRACI(ET <--(23) 1 TG.0001--TG.0001
4 241bP1l14b BRACI(ET <--(24) 1 TG.0001--TG.0001
5 240bR213D5 CABLE, CONTROL 1
b 2420Zb81 JOINT, BALL 1
1 2425R201 BEARING 2
8 240bR125D2 ROD-END 1
9 ZP2b00603b PIN 1
10 ZS18C08025 BOLT 4
11 ZN1bC08005 NUT 3
12 zw26X08000 LOCI( WASHER 5
13 ZR1bX02200 RING, SNAP 1
14 240bZ214 GRIP 1
15 ZW16X08000 WASHER 3
16 ZS18C10020 CAPS CREW 3
11 ZW2bX10000 LOCK WASHER 2
18 ZS18C08030 CAPSCREW <--(25) 1 TG.0001--T-G.0001
19 ZN16C08001 NUT 4
20 ZC45X14011 CLIP 1
21 ZW1bX10000 WASHER 1
22 ZN18C10008 NUT 1
23 2416P12114 BRACKET 1 TG.0002--
24 2416P12115 BRACKET 1 TG.0002--
25 ZS18C08035 CAPSCREW 1 TG.0002--

(02) 312-300-1 rj)

 CULUM,STEERING
TH-OOOl - 2410R123
TG-0001-

7 B

Y 9

---9-2

14

FIG 31 3 - 307-1 (02)

 COLUMN, STEERING
CULUMN,STEERING TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~Ty APPLICABLE

2410R123 COLUMN, STEERING

1 2410R123S1 SNAp RING 2

2 2410R123S2 BEARING, BALL 2
3 2410R123S3 BRACKET 1
4 2410R123S4 SCREW 3
5 2410R123S5 COLUMN, STEERING 1
6 2410R123S6 SHAFT 1
7 2410Rl23S7 YOKE 2
8 2410R123S8 BOLT 2
9 2410Rl23S9 JOINT ASSY 2
9-1 2410R123S91 SNAP RING 4
9-2 2410Rl23S92 NIPPLE, GREASE 1
10 2410R123S10 NIPPLE, GREASE 1
II 2410R123Sll TUBE ASSY 1
12 2410R123S12 WASHER 1
13 2410R123S13 RETAINER 1
14 2410R123S14 SHAFT 1
15 2410R123S15 YOKE 1

(D2)
313-307-1
 SHIFTER • TRANSMISSION
TH-0001- 16 Q1 09
TG-0001-

Refer to P
Installatlon
. ower Plant
for. Shift RodL

~\. 18

FI G 3 14-302-1 .
 SHIFTER, TRANSMISSION
TG.OOOI--

ITEM PART.NO DESCRIPTION REMARKS &Ty APPLICABLE

16QI09 SHIFTER, TRANSMISSION

I WASHER, LOCK 3/8-IN 4

2 SCREW, HEX HD CAP 3/8-16UNC X I-IN 4
3 1006ZI017 LEVER, CONTROL - GEAR SHIFT I
4 1045Z752 BOOT, SHIFT LEVER I
5 1006Z294 HOUSING, SHIFT LEVER I
6 1019Z1321 PIN, SHIFT LEVER I
7 1018Z2703 SEAT, SHIFT LEVER I
8 1018Z2147 WASHER, LEVER SEAT I
9 1006Z321 YOKE, SHI FT I
10 1014Z592 END CAP, HOUSING I
II 1005Z370 BUSHING I
12 1018Z2729 SEAL, OIL I
13 1044Z327 FI TTl NG, LUBE I
14 SCREW, HEX HD CAP 5/16-18UNC X 7/8-IN 4
15 WASHER, LOCK 5/16-IN 4
16 1020Z2438 GASKET, END CAP I
17 1014Z654 HOUSING, SHIFTER I
18 1005Z370 BUSHING I
19 1018Z2729 SEAL, OIL I

314-302-1
 TIRE AND WHEEL ASSY
TG-0001 '" 24100N 4 67 8F1

3-
148
1
3-14A 3-14

T--_3-50
8
~

FIG 351-01-1(j)
(02)
 TIRE & WHEEL ASSY
F/15R22.5 R/11.00-20 TG.0001--

ITEM PART.NO DESCRIPTION REMAR~S <ilTy . APPLICABLE

24100N4618F1 TIRE & WHEEL ASSY

1 24100N4106F1 TIRE & WHEEL ASSY 4

1-1 2454U32 TIRE 1
1-lA 2454U32S1 TIRE 1
1-15 2413U232 RIM 1
3 24100N4106F3 TIRE & WHEEL ASSY 8
3-5 2454U36 TIRE 1
3-5A 2454U36S1 TIRE 1
3-5B 2454U36S2 TUBE 1
3-5C 2454U36S3 FLAP 1
3-50 2454U36S'+ VALVE 1
3-14 2413U156 RIM 1
3-14A 2413U156S1 RIM 1
3-14B 2413U156S3 RING SIDE 1
1 2436R1228D2 VALVE (NOT SHOWN) 1
8 2436Z484 VALVE.!NFLAT TIRE '+
 TI RE AND WHEEL ASSY
TG-0001 'V 24100N4678F2

2-15
[""'II. / 4-148

4-14A 1
4-14

4-88

'r-- 4-80
8

FIG 352-01-1(D (02)

 TIRE & WHEEL ASSY
F/16.5R22.5 R/12.00-20 TG.0001--

ITEM PART.NO DESCRIPTION REMARKS 6lTY APPLICABLE

24100N4678F2 TIRE & WHEEL ASSY

2 24100N4706F2 TIRE & WHEEL ASSY 4

2-2 2454U33 TIRE 1
2-2A 2454U33S1 TIRE 1
2-15 2413U232 RIM 1
4 24100N4706F4 TIRE & WHEEL ASSy 8
4-8 2454U39 TIRE 1
4-8A 2454U39S1 TIRE 1
4-8B 2454U39S2 TUBE 1
4-8C 2454U36S3 FLAP 1
4-80 2454U36S4 VALVE 1
4-14 2413U156 RIM 1
4-14A 2413U156S1 RIM 1
4-14B 2413U156S3 RING,SIDE 1
7 2436R122802 VALVE (NOT SHOWN) 1
8 2436Z484 VALVE,INFLAT TIRE 4

(02)
 INSTAL, STABIR I ZER
F2
T G-OOO 1---- 241 OO P2055 Fl.

--~

9. 10
F1
[
.'

2-1

VIEW A-A
2_20~.
2-17 e l~~ '-F 1
--)
2-19

FIG 36 1-01-1(D ( 01)

 STABILIZER ASSY
STD/WITHOUT STABILIZER TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLICABLE

24100P2055F1 STABILIZER ASSY

1 24100J9012F1 INSTAL, STABILIZER 1

1-9 ZH22X08000 CONNECTOR 1
1-9A ZD12P01800 O-RING 1
1-16 zo12P01800 O-RING 1
1-21 ZE72X08000 PLUG 1
3 2414T3852 COVER 1
5 2427P2716 COVER 1
6 ZS17C06014 CAPSCREW 4
7 ZN17C06005 NUT 4
8 ZW26X06000 LOCK WASHER 4
9 ZW16x08000 WASHER 1
10 ZMllC08020 SEMS-BOLT 1

24100P2055F2 STABILIZER ASSY

OPTION/wiTH STABILIZER

2 24100J9012F2 INSTAL, STABILIZER 1

2-1 24100J8882F1 STABILIZER ASSY, FR. P. 362-361 1
2-2 ZS17C20060 CAPSCREw 4
2-3 ZN17C20016 NUT 4
2-4 ZW16H20000 WASHER 4
2-5 2444T3487 ELBOw, 90 1
2-6 2444T3491 ELBOw, 90 1
2-7 2444T3490 ORIFICE 1
2-8 ZX37M08140 HOSE 1
2-9 ZH22X08000 CONNECTOR 1
2-9A Zo12P01800 O-RING 1
2-10 2444R59703 TEE 1
2-11 ZX33M08052 HOSE ASSY 1
2-12 ZC45X25011 CLAMP 1
2-13 ZS18C10016 CAPSCREW 1
2-14 ZW26X10000 LOCK WASHER 1
2-15 2445Z705 O-RING 1
2-16 zo12P01800 O-RING 1
2-17 24829N107 FLOAT 1
2-18 24819T202 PIN 2
2-19 2419T3258 SPRING PIN 3
2-20 19Z274033 PIN 1
2-22 2432R191 DECAL 1
4 24800J638F1 BOX ASSY, CONTROL P. 368-361 1
6 ZN17C06014 NUT 4
7 ZN17C06005 NuT 4
8 ZW26X06000 LOCK WASHER 4

(OJ) 361-01-1(!)
 I NSTAL,STAB IR I ZER
TG-0001 ........ 24100J9012 Fl,F2

17- 1\

'--Fl-- J

FIG 361-01-1 ( 02)

 INSTAL, STABILIZER
STD/WITHOUT STABILIZER TG.0001--

ITEM PART .NO DESCRIPTION REMAHKS (ilTy APPLICABLE

24100J9012F1 INSTAL, STABILIZER

9 ZH22X08000 CONNECTOR 1
16 ZD12P01800 O-RING 1
21 ZE72X08000 PLUG 1

., >1 nn .t>n • .,,,.,

OPTION/wiTH STABILIZER

. .. ,,1 nn ... , .... ". ~~,~ . .- -, -. ~ ~ ...

2 ZS17C20060 CAPSCREW 4
3 ZN17C20016 NUT 4
4 ZW16H20000 WASHER 4
5 2444T3487 ELBOW, 90 1
.,
7
L

244413490
'.~~ .~.

ORIFICE
onL .n
-
1
8 ZX37M08140 HOSE 1
9 ZH22X08000 CONNECTOR 1
10 2444R597D3 TEE 1
11 • • ~ ... nan" .. " " ...
12 ZC45X25011 CLAMP 1
13 ZS18Cl0016 CAPSCREW 1
14 ZW26X10000 LOCK WASHER 1
15 2445Z7D5 O-RING 1
1<-

17
.. " • .,..,n ... nn

24829N107
n_,,. .• r-

FLOAT
-
1
18 24819T202 PIN 2
19 241913258 SPRING PIN 3
20 19Z274D33 PIN 1
22 2432R191 DECAL 1

(02) 361-01-1
 ABILIZER ASSY
FRONT ST OJ8882F1
TH- 000
TG-OOO
1:. 2410

16-1 16

7 8
29

15-1

FIG 362-361-1 (03)

 STABILIZER ASSY, FR.
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (i}TY APPLICABLE

24100J8882F1 STABILIZER ASSY, FR.

1 24100U466F2 CYLINDER, VERTICAL 1

1-1 2438U1251F2 CYLINDER,VERTICAL P. 363-362 1
1-3 2436U1628F1 VALVE,LOCK P. 364-362 1
1-3A ZD12P01400 O-RING 3
1-4 ZS23C08065 CAPSCREW 4
2 36U218D1 VALVE, SOLENOID P. 365-362 1
3 2436U1930F1 VALVE, RELI EF 1
4 2436U1929F1 VALVE, RELIEF 1
5 2416J1213 BRACKET 1
6 ZX33M08039 HOSE ASSY 2
1 ZX44M08052 HOSE ASSY 2
8 2444R1451D3 HOSE ASSY 2
9 2444T2855 TEE 2
9-1 ZD12P01800 O-RING 1
10 2444R1348D3 TEE 1
11 ZH52X08000 TEE 1
12 2444R596D3 ELBOW, 90 2
14 ZH32X08000 ELBOW 1
14-1 ZD12P01800 O-RING 1
15 ZH22W08000 CONNECTOR 3
15-1 2445Z1D6 O-RING 1
16 ZH22X06000 CONNECTOR 2
16-1 ZD12P01400 O-RING 1
11 ZS18C12050 CAPSCREW 8
18 ZS18C10025 CAPSCREW 4
19 ZS18C08080 BOLT 4
20 ZN18C10008 NUT 4
21 ZN18C08001 NUT 4
22 ZW16H12000 WASHER 8
23 ZW16H10000 WASHER 4
24 ZW16X10000 WASHER 4
25 ZW16X08000 WASHER 4
26 ZW26X10000 LOCKWASHER 4
21 ZW26X08000 LOCK WASHER 4
28 2432Z290D4 WiRE TIE 1

(03)
 CYLINDER ASSY. VERTICAL
TH-0001 ........ 243BU1257F2
TG-0001 ...,

14

FI G 363-362-1
 CYLINDER
CYLINDER,VERTICAL TG.0001--

ITEM PART.NO DE SCR I PTI ON REMARKS (HY· APPLICABLE

2438U1251F2 CYLINDER

1 2438U1251S1 TUBE 1
2 2438U1251S2 ROD,PISTON 1
3 2438U1251S3 PISTON 1
4 2438U1251S4 PACKING 2
5 2438U1251S5 RING,WEAR 2
6 ZD12G08000 O-RING 1
1 ZD15G08000 RING, BACK-UP 1
8 2438U1251S8 SETSCREW 1
9 2438U1251S9 COVER,ROD 1
10 2438U1251S10 PACKING 1
11 2438U321S15 BUSHING 1
12 2438U1251S12 RING,RETAINER 1
13 2438U368S16 SEAL, DUST 1
14 2418U112D18 RING.RETAINER 1
15 ZD12G11500 O-RING 1
16 2438U1251S16 RING.BACK-UP 1
11 ZD12G12500 O-RING 1
18 2438U1251S18 LOCK WASHER 1
21 ZE82T04000 PLUG 2
2438U1251R110 REPAIR KIT 1
CONSiSTS OF ITEM 4. 5, 6. 1
2438U1251R120 REPAIR KIT 1
CONSiSTS OF ITEM 10. 13, 15. 16. 11

(OJ)
363-362-1 (!)
 VALVE. SOLENOID
TH-0001- 36U278
TG- 0001....,

FIG 365 -362-1

 VALVE, SOLENOID
TG.0001 __

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

36U278DI VALVE, SOLENOID

I I081Z17 SOLENOID ASSEMBLY 2

2 I044Z512 GUIDE, TUBE ASSEMBLY 2
3 IOI7Z929 SPRING, CENTERING 2

365-362-1
 BOX ASSV. CONTROL
TH-0001- 24800J638Fl
TG-0001-

1+-8

~II
II
II
I,
II
C C I,
~ !
2

"'8

6 4 7

P&H 5
10.9

O~H~
~@1: 3

SECTION A- A
SECTION 8- 8

12

11 14.15.16

SECTION C- C

FIG 368-361-1 (02)

 BOX ASSY, CONTROL
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTy APPLICABLE

24800J6:38F1 BOX ASSY, CONTROL

1 248nN19 PANEL 1
2 24814J64 BOX, CONTROL 1
:3 24879P21 WIRE HARNESS 1
4 79Gl760D1 SWITCH 1
5 79Gl760Dll SWITCH 1
6 R79POO60F1 LAMP, SIGNAL 1
7 24879T17 wIRE HARNESS 1
8 :32Z1665 LABEL 1
9 ZSnT04010 SCREW, TAPPING 4
10 ZW16P04000 WASHER 4
11 2406R:302 HANDLE 1
12 2406Z4:34 HANDLE 1
14 ZS31C04010 MACHINESCREW :3
15 ZN18C0400:3 NUT :3
16 ZW26X04000 LOCK WASHER :3

(02)
 ACCESSORY ASSY. AIR(DRYER & INFLATION)
TG-0001-0001. 24100J9036FI

11.26 9.26 21.22 4

38.37 11 9

17.20 23 15 12 29 2

DETAIL D

14 6 18 10

11 24 30.32.34.36
4 VIEW a-a

QEIAIL E
21
25 24 6 7

39.35.31.28 16

~IEW
14

A-A
27.33.35
~\n~
-< AT TIRE INFLATION

30.32.34.36 8)d AT TRAVELLING

~IEyt !;-!; DETAIL ITEM 7. D

FIG 381-01-1(D (01)

 ACCESSORY ASSy,AIR(oRY.+INF.) TG.0001--

ITEM PART.NO DEsCRIPTION REMAR"S (!lTy APPLICABLE

2'+lOOJ9036Fl TG.OOO1--TG.OOOl

1 2'+15R298F1 DRYER, AIR p. 387-381 1

2 2'+16N'+'+81 BRACKET 1
3 2'+16T1879'+ BRACKET 1
'+ 2'+18P17832 TUBE LINE 1
6 2'+36Z229 IIALIIE 1
7 2'+'+'+Zl580 HOSE, TIRE CHARGE 1
8 2'+ 8l'+T 37 CAP 1
9 '+'+&128900'+2'+0 TUBE, NYLON 1
10 4'+&128900'+3'+0 HOSE ASSY 1
11 '+'+&128900'+590 TUBE, NYLON 1
12 '+'+&12890080'+1 HOSE ASSY 1
13 '+'+&129002 CONNECTOR 2
1'+ '+'+&129102 ELBOW 2
15 '+'+&129006 CONNECTOR 1
16 '+'+&129106 ELBOW 1
17 ZG22E12008 CONNECTOR 1
18 ZG22E0800'+ CONNECTOR 1
20 ZG32U08000 ELBOW 1
21 2'+'+'+R719012 CONNECTOR 2
22 ZG22U08000 CONNECTOR 1
23 R38POO0902 CHECK IIALIIE,AIR 1
2'+ ZC,+5X19011 CLIP 2
25 ZC'+5X380l'+ CLIP 1
26 2'+32Z2900'+ WIRE TIE 25
27 ZS18F12025 BOLT '+
28 ZS18C12030 CAPSCREw 1
29 ZS18C12035 BOLT 2
30 ZS18C10020 CAPSCREW 2
31 ZN18C12010 NUT 1
32 ZN18C10008 NUT 2
33 ZW16X12000 WASHER '+
3'+ ZW16X10000 WASHER 2
35 ZW26X12000 LOCK WASHER 5
36 ZW26X10000 LOCK WASHER 2
37 '+'+&129101 ELBOW 2
38 2'+'+'+R7'+001 CONNECTOR 2
39 2'+18T308'+ WASHER 1

(01)
 ACCESSORY ASSY. AIR (DRYER & I NFLATlON)
TG-0002 - 24100J9416F1

14 6 18

17.20 23 15 12 29 2
DETAIL P

DETAIL C

4 6 7

21
@~~
--< AT TIRE INFLATION

35.34.31.28 16 14 27.33.35
8~ AT TRAVELLING
DETAIL ITEM 7. D
VIEW A-A 36
24
30

VIEW B-B

FIG 381-01A-l (01)

 ACCESSORY ASSy,AIRCORY.+INF.) TG.0002--

ITEM PART.NO DESCRIPTION REMARI(S (HY APPLICABLE

24100J9416F1 TG.0002--TG.9999

1 2415R298F1 DRYER, AIR p. 387-381 1

2 2416N4481 BRACKET 1
4 2418P1B653 TUBE 1
6 2436Z229 VALVE 1
7 2444Zl580 HOSE, TIRE CHARGE 1
B 24814T37 CAP 1
12 44611289008041 HOSE ASSY 1
13 4461129002 CONNECTOR 2
14 44&129102 ELBOW 2
15 4461129006 CONNECTOR 1
16 4461129106 ELBOW 1
17 ZG22E12008 CONNECTOR 1
18 ZG22EOB004 CONNECTOR 1
20 ZG32UOBOOO ELBOW 1
21 2444R719012 CONNECTOR 2
23 R38POO0902 VALVE 1
-
24 ZC45x19011 CLIP 2
26 2432Z29004 WIRE TIE 5
27 ZS18F12025 BOL.T 4
28 ZS18C12030 CAPSCREW 1
29 ZS18C12035 BOLT 2
30 ZS18C10020 CAPSCREW 2
31 ZN18C12010 NUT 1
33 ZW16X12000 WASHER 4
34 2418Tl30B4 WASHER 1
35 ZW26X12000 LOCK WASHER 5
36 ZW26X10000 L.OCK WASHER 2

(OJ) 381-0lA-l
 ACCESSORV ASSV. AIR(DRVER)
TG-OOO 1 -- 0001 24100J9036F2

9.26 21.22 4

38.37 11 9

17.20 23 15 12 29 2

DETAIL D

24 30.32.34.36
VIEW B-B 14 19

21
25 24

39.35.31.28 16 14 27.33.35

VIEW A-A 10

30.32.34.36 DETAIl. ;
VIEW C-C

FIG 382-02-1(D (01)

 ACCESSORY ASSy,AIR (DRYER) TG.0001--

ITEM PART.NO DEsCRIPTION REMARI(S ~TY APPL I CABLE

211100J9036F2 TG.OOO1--TG.000l

1 2415R298F1 DRYER, AIR P. 387-381 1

2 21116NIIII81 BRACKET 1
3 21116T187911 BRACKET 1
II 2418P17832 TUBE LINE 1
9 1111&128900112110 TUBE, NYLON 1
10 1111&128900113110 HOSE ASSY 1
11 411&12890011590 TUBE, NYLON 1
12 411~1289008041 HOSE ASSY 1
13 411&129002 CONNECTOR 2
111 411&129102 ELBOW 2
15 411&129006 CONNECTOR 1
16 1111&129106 ELBOW 1
17 ZG22E12008 CONNECTOR 1
19 ZG22B080011 REDUCER 1
20 ZG32U08000 ELBOW 1
21 2444R719012 CONNECTOR 2
22 ZG22U08000 CONNECTOR 1
23 R38POO0902 CHECK VALVE,AIR 1
211 ZC1I5X19011 CLIP 2
25 ZC1I5X380111 CLIP 1
26 21132Z290011 WIRE TIE 25
27 ZS18F12025 BOLT 4
28 Zs18C12030 CAPSCREW 1
29 ZS18C12035 BOLT 2
30 ZS18C10020 CAPSCREW 2
31 ZN18C12010 NUT 1
32 ZN18C10008 NUT 2
33 ZW16X12000 WASHER 4
311 ZW16X10000 WASHER 2
35 zw26X12000 LOCK WASHER 5
36 zw26X10000 LOCK WASHER 2
37 1111&129101 ELBOW 2
38 24114RHOD1 CONNECTER 2
39 21118T30811 WASHER 1

II

(01)
 ACCESSORY ASSY I A I R (DRYER)
TG-0002 ..... 24100J9416F2

{
)

17.20 23 15 12 29 2

14 19

DETAIL C

21

DETAIL 0
35.34.31.28 16 14

VIEW A - A

VIEW B-B

FJ G 382-02A-1 (01)
 ACCESSORY ASSy,AIR (DRYER) TG.0002--

ITEM PART .NO DESCRIPTION REMAR~S GlTy APPLICA8LE

24100J9416F2

1 2415R298F1 DRYER. AIR P. 381-381 1

2 2416N4481 BRACKET 1
4 2418P18653 TUBE 1
12 446}1289008041 HOSE ASSY 1
13 446}129002 CONNECTOR 2
14 446}1291D2 ELBOW 2
15 446}129006 CONNECTOR 1
16 446}129106 ELBOW 1
17 ZG22E12008 CONNECTOR 1
19 ZG22B08004 REDUCER 1
20 ZG32U08000 ELBOw 1
21 2444R119012 CONNECTOR 2
23 R38POO0902 VALVE 1
24 ZC45X19011 CLIP 2
26 2432Z29004 WIRE TIE 5
21 ZS18F12025 BOLT 4
28 ZS18C12030 CAPSCREw 1
29 ZS18C12035 BOLT 2
30 ZS18C10020 CAPSCREW 2
31 ZN18C12010 NUT 1
33 ZW16X12000 WASHER 4
34 2418Tl3084 WASHER 1
35 ZW26X12000 LOCK WASHER 5
36 ZW26X10000 LOCK WASHER 2

(01)
 ACCESSORY ASSY. AIR(INFLATlON)
TG-OOOI -0001. 24100J9036F3

9.26 21.22 5

20.17 21 38 DETAIL D

14 6 18 10

24 30.32.34.36
VIEW B-B

DETAIL E

2S 24 6 7

~. \:utD:1~
S

SECTION A- A
~ AT TIRE INFLATION

30.32.34.36 8;§ AT TRAVELLING

VIEW C-C DETAIL ITEM 7.8

FIG 383-03-1(1) (01)

 ACCESSORY ASSY,AIR(INFLATION) TG.0001--

ITEM PART .NO DEsCRIPTION REMARKS IHY APPLICABLE

H100J9036F3 TG.0001--TG.0001

3 2416T18794 BRACKET 1
5 2418P17833 TUBE LINE 1
6 2436Z229 VALVE 1
7 2444Z1580 HOSE, TIRE CHARGE 1
8 24814TJ7 CAP 1
9 44611289004240 TUBE, NYLON 1
10 44611289004340 HOSE ASSY 1
13 4461129002 CONNECTOR 2
14 4461129102 ELBOW 2
17 ZG22E12008 CONNECTOR 1
18 ZG22E08004 CONNECTOR 1
20 ZG32U08000 ELBOW 1
21 2444R719012 CONNECTOR 2
22 ZG22U08000 CONNECTOR 1
24 ZC45X19011 CliP 2
25 ZC45X38014 CLIP 1
26 2432Z29004 WIRE TIE 25
30 ZS18C10020 CAPSCREW 2
32 ZN18C10008 NUT 2
34 ZW16X10000 WASHER 2
36 ZW26X10000 lOCK WASHER 2
38 2444R74001 CONNECTOR 1

(01)
 ACCESSORY ASSV. AIR (I NFLATlON)
TG-0002- 24100J9416F3

14 6 18

DETAIL D

20.17 21

DETAIL C

6 7

~.. \bl:tt:r:u~
~-< AT TIRE INFLATION

5 8~ AT TRAVELLING
VIEW A-A

YIEW B- B

Fl G 383-03A-1 (01)
 ACCESSORY ASSy,AIR(INFLATION) TG.0002--

ITEM PART.NO OESCR I PTI ON REMARiC:S GTY APPLICABLE

24100J9U6F3 TG.0002--TG.9999

5 2418P18654 TUBE 1
6 2436Z229 VALVE 1
7 2444Zl580 HOSE, TIRE CHARGE 1
8 24814T37 CAP 1
13 44Ql29002 CONNECTOR 1
14 44&129102 ELBOW 1
17 ZG22E12008 CONNECTOR 1
18 ZG22E08004 CONNECTOR 1
20 ZG32U08000 ELBOW 1
21 2444R719012 CONNECTOR 2
22 ZE82T04000 PLUG 1
24 ZC45X19011 CLIP 2
26 2432Z290D4 WIRE TIE 5
30 ZS18C10020 CAPSCREW 2
36 ZW26X10000 LOCK WASHER 2

(01)
 ACCESSORY ASSY, AIR (NO OPTION)
TG-0001-OOOl. 24100J9036F4

9.26 21.22 5

9
3

20.17 21

38
DETAIL D

24 30.32.34.36
VIEW B-B
14 19

5
25 24

SECTION A- A

10
30.32.34.36
DETAIL E
VIEW C-C

FIG 384-04-1(D (01)

 ACCESSORY ASSy,AIR(NO OPTION) TG.0001--

ITEM PART.NO DESCRIPTION REMARIt.S IilTY APPLICABLE

H100J9036F4 TG.0001--TG.0001

3 241bTl8794 BRACKET 1
5 2418P17833 TUBE LINE 1
9 441il1289004240 TUBE, NYLON 1
10 44&1289004340 HOSE ASSY 1
13 446)129002 CONNECTOR 2
14 44&129102 ELBOW 2
17 ZG22E12008 CONNECTOR 1
19 ZG22B08004 REDUCER 1
20 ZG32U08000 ELBOW 1
21 2444R719012 CONNECTOR 2
22 ZG22U08000 CONNECTOR 1
24 ZC45X19011 CLIP 2
25 ZC45X38014 CLIP 1
26 H32Z29004 WIRE TIE 25
30 ZS18C10020 CAPSCREW 2
32 ZN18C10008 NUT 2
34 ZW1bXlOOOO WASHER 2
36 ZW26X100OO LOCK WASHER 2
38 2444R74001 CONNECTOR 1

(01)
 ACCESSORY ASSY A I R (NO OPTION)
TG-0002- 24100J9416F4

20.17 21

II, 19

DETAIL C

5
DETAIL D

VIEW A-A

24

VIEW B-B

FIG 384-04A-1 (01)

 ACCESSORY ASSy,AIR(NO OPTION) TG.0002--

ITEM PART.NO DESCRIPTION REMARKS QTY APPLICABLE

24100J9416F4 TG.0002--TG.9999

, 2418P18654 TUBE 1
13 446l1290D2 CONNECTOR 1
14 446l1291D2 EL80W 1
17 ZG22E12008 CONNECTOR 1
19 ZG22808004 REDUCER 1
20 ZG32U08000 ELBOW 1
21 2444R719D12 CONNECTOR 2
22 ZE82T04000 PLUG 1
24
26
ZC45X19011
2432Z290D4
CLIP
WIRE TIE ,
2

30 ZS18C10020 CAPSCREW 2
36 ZW26X10000 LOCII'. WASHER 2

(OJ)
 DRVER. AI R
TE-0001- 241SR298Fl
TO-0001-
TH-OOOl "'"
TG-OOO 1 '"'J

15
14
4 6

38 37 3 7

2
16' 41

@ ] 39
11
BI4-

~~~~-I~~~1lL-~==:
10
25
BI4- 27
AI+- 28
40 36 35
17
11

29

32
18 19 22 20 21 23 24
SECTION A-A

31
33
30
34

SECTION B- B

FIG 387-381-1 {On

 DRYER, AIR
DRYER,AIR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS lilTY APPLICABLE

2415R298F1 DRyER, AIR TG.0001--

1 2415R298S1 SHELL 1
2 2415R29~S2 FILTER 1
3 VALVE, CHECK 1
4 PLATE, STOP 1
5 2415R298S5 CASE 1
6 2415R298S6 PLATE 2
7 FILTER 2
8 DESICCANT 1
9 GASKET 1
10 FILTER, OIL 1
11 GASKET 1
12 2415R298S12 SETSCREw 1
13 ZW16K16000 wASHER 1
14 2415R298S14 SPRING 1
15 2415R298S15 LOCK NUT 1
16 2415R298S16 RING, GASKET 1
17 2415R298S17 BODY, VALVE 1
18 2415R298S18 PISTON 1
19 O-RING 1
20 O-RING 1
21 O-RING 1
22 2415R298S22 VALVE,SPRING 1
23 VALVE 1
24 2415R298S24 LOCK NUT,NYLON 1
25 O-RING 1
26 2415R298S26 CAP, VALVE 1
27 O-RING 1
28 2415R298S28 RING 1
29 NIPPLE 1
30 2415R157S29 HEATER 1
31 2415R157S28 GASKET 1
32 2415R298S32 THERMOSTAT 1

"34 2415R298S33
2415R157S40
LOCK WASHER
SCREW
2
2
35 2415R298S35 PROTECTOR 1
36 2415R298S36 SCREW 2
37 2415R298S37 ELBOW 2
38 2415R298S38 TUBE 1
39 2436U804S37 PLUG,PIPE(1/4) 1
40 2415R298S40 PLUG,PIPEO/S) 2
41 2436U804S38 PLUG,P I PE UI2) 2
2415R298R110 REPAIR KIT 1
CONSISTS OF ITEM 3, 4, 7, 9, 10
11, 16, 19, 20, 21
23, 25, 27, 29

(01)
387-381-1
 INSTAL, BOOM (110')
TO-0001 ..... 24100J8474F3, F4
TG - 0001 --

FIG 401- 01-1 <D (04)

 INSTAL, BOOM
110 FEET BOOM TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLIcABLE

24100J8474F3 INSTAL, BOOM TG.0001--TG.0001

24100J8474F4 INSTAL, BOOM TG.OO02--

2 2419P2367 PIN 2
3 2405P321 BUSHING 2
4 2418T748 WASHER 4
5 ZS18C24040 CAPSCREW 2
6 ZW16H24000 WASHER 4
7 ZG91U02000 FITTING, GREASE 2
8 2420P2125D2 SHIM 12
9 2420P2125D1 SHIM 12
10 ZN18C12010 NUT 2
11 ZW26x12000 LOCK WASHER 2
12 2419P2369 PIN 2
13 ZS18C24065 CAPSCREW 2
14 ZN18C24019 NUT 2
15 2418T16111 WASHER 4
17 24100X2385F3 BOOM ASSy P. 403-401 1 TG.0001--TG.0001
24100X2385F4 BOOM ASSy P. 403-401 1 TG.0002--

(04) 401-01-1 CD
 BOOM ASSY, 110'
TD-0001- 24100X2385F3 F4
I

T G-OO 0 1 '"'" 137,

133
116

64

FIG 403-401-1(D (04)

 800M ASSY, 110'
24100X2385F3, F4 TO-0001-
TG-0001-

106 114 126

~ 128
~~

8'~0~11'
106':8 a.
82
~~
84 82 r
\ . ' - - - - - 8 _84_ _ _......)
I j
'\.'----A--~

84 82

l1~i
\.'---c ----)

I NSTAL,CRANK
16

~~------------------ 0-----------)

(04) FIG 403-401-2CD

 BOOM ASSY
110 FEET BOOM TG.0001--

ITEM PART.NO DESCR I PTI ON REMARI(.S &Ty APPLICABLE

24100X238,F3 BOOM ASSY TG.0001--TG.0001

24100X238'F4 BOOM ASSY TG.0002--

1 2411J3032 BOOM, FLY 1

4 2411J3031 BOOM, 3RD 1
7 2411J3030 BOOM, 2ND 1
10 2411J3029 BOOM, BASE 1
13 24100U'61F1 CYLINDER ASSY, TELE. 1
13-1 2438U1316F1 TELESC CYL P. 406-403 1
13-2 2436U1673F1 VALVE, PILOT 1
13-2A ZD12P02200 O-RING 2
13-3 2420N4'8D10100 CAPSCREW 4
16 24100U'60F1 CYLINDER ASSY, TELE. 1
16-1 2438U1315F1 TELESC CYL P. 404-403 1
16-2 2436U1673F1 VALVE, PILOT 1
16-2A ZD12P02200 O-RING 2
16-3 2420N4'8D10100 CAPSCREW 4
19 2418112974 PLATE, I(.EEPER 4
21 2~18P1'935 PLATE 14
22 2418P1'936 PLATE 4
23 2418P1'937 PLATE 4
24 2418P1'938 PLATE 2
27 2429R316 PAD 1
28 2429R317 PAD 1
29 2429R318 PAD 1
31 2429R319F1 PAD 6 TG.0001--TG.0001
32 2429R320D1 PAD 7
33 2429R320D2 PAD 2
34 2429R321 PAD 1
35 2416R32,F1 PAD 6 TG.0002--
36 2429R322F1 PAD 6 TG.0001--TG.0001
37 2429R324 PAD 1
38 2416R326F1 PAD 6 TG.0002--
39 2440P178 MANIFOLD 1
40 2418P17371 TUBE LINE 1
41 2440P173 MANIFOLD 1
42 2444P1103 BLOCI(., MANIFOLD 1
4' 2420P2126D1 SHIM T-0.70 6
46 2420P2126D2 SHIM T-1.60 8
47 2420P2127D1 SHIM T-0.70 32
48 2420P2127D2 SHIM T-1.60 6
49 2420P2128D1 SHIM T-0.70 28
'0 24181143'901 SHIM T-1.60 12
'1 24181143'902 SHIM T-3.20 12
'6 2416J1292 BRACKET 1
'8 2416114622 BRACKET 1
61 2444R1426D1 HOSE 1
62 2444R1427D1 HOSE 1
63 ZX37P120'1 HOSE ASSY 2
64 ZX37P12066 HOSE ASSY 1
67 2419P2371 PIN II
68 2419P2372 PIN 1

(04)
 BOOM ASSY
TG.0001-- HO FEET BOOM

ITEM PART.NO DESCRIPTION REMARI(.S GlTY APPLICABLE

70 2419Zl75Dl PIN, HITCH 1

71 2419T3258 SPRING PIN 1
74 ZP15D06040 COTTER PIN 2
77 24100N3897F2 SHEAVE ASSY P. 408-403 1
82 ZD12P02600 a-RING 13
83 ZD12P03400 a-RING 3
84 ZE12X12000 CLAMP, HALF 24
85 ZE82T04000 PLUG 1
86 2444R1314 JOiNT, SWIVEL 2
86-1 2444R1314S1 SHAFT 1
86-2 2444R1314S2 BODY 1
86-3 2444R1314S3 CAP 1
86-4 PACI(.ING 2
86-5 RING, BACK-UP 2
86-6 SEAL, DUST 2
86-7 2444R1314S7 RING, RETAINER 1
2444R1314Rl00 R,KIT (86-4,5,6) 1
87 2418P15940 TUBE 2
90 2483U302F2 DiViDER, FLOW P. 412-403 1
91 2430R298D3 ROPE, WIRE 1
93 2413T374 WHEEL 2
94 24l00P1480Fl SPRING ASSY 1
94-1 24l7T581 SPRING 1
94-2 2417T582 SPRING 2
95 ZS68C12020 CAPSCREW 12
96 ZS68C12025 CAPSCREW 8
98 ZS68Cl0025 CAPSCREW 22
99 ZS68C12040 CAPSCREW 8
100 ZS73C20050 BOLT 28
101 24100J8447F2 ROLLER ASSY, GUIDE P. 409-403 1
102 2420N458Dl0110 BOLT 3
103 2420T2277D2 U-BOLT 1
104 2420N458D08020 CAPSCREW 8
105 2420N458D08060 CAPSCREW 3
106 2420N458Dl0030 CAPSCREW 44
107 2420N458Dl0055 CAPSCREW 4
108 2420N458Dl0070 CAPSCREW 4
110 2420N458D08016 CAPSCREW 4
111 ZS18C12075 CAPSCREW 8
112 ZM11Cl0020 SEMS-BOLT 28
113 ZS18Cl0025 CAPSCREW 10
114 ZS18Cl0030 CAPSCREW 17
116 ZS18C12025 CAPSCREW 26
117 ZS18C20045 CAPSCREw 8
118 ZS18C20075 CAPSCREW 8
119 0630V046 CAPSCREW, SOCKET 4
120 0630V055 SCREW, SOCKET 4
122 ZN18C06005 NuT 4
123 ZN18Cl0008 NUT 1
124 ZN18C20016 NUT 28
126 zw26xl.0000 LOCK WASHER 16
127 Zw261(.08000 LOCK WASHER 3
128 Zw26K10000 LOCK WASHER 43
131 3619v01O WASHER 8

(04)
 BOOM ASSY
110 FEET BOOM TG.0001--

ITEM PART.NO DESCRIPTION REMAR~S IIlTy APPLICABLE

133 ZW16H12000 WASHER 34

134 ZW16H20000 WASHER 16
135 ZW16X10000 WASHER 1
136 ZW16X24000 WASHER 4
137 24100J8565F1 BOOM POINT ASSY P. 411-403 1 TG.0001--TG.0001
24100J8565F2 BOOM POINT ASSY P. 411-403 1 TG.0002--
138 H16P11080 PAD 14
139 24tl6P11081 PAD 4
140 2420N458D12025 BOLT 4
141 2'+18Tl6216 PLATE 1
142 H18Tl6217 PLATE 1
143 24100P1S83F3 CRAN~ ASSY 1
143-2 2432T3093 CLAMP 3
143-4 ZW26xlOOOO LOCK WASHER 3
143-6 2406N971 CRANK 1
143-7 2420R747D43 BOLT, WING 3
144 241ST5373C2 WASHER 2

(04)
 CVLI N DER ASSV. TE LESCOPE - LOW
TD-0001 "" 2438U1315F1
TG-0001 ---

\4

30

26

FI G 404-403-1(1)
(01)
 TELESC CYL
CYLINDER,TELE (LOWER) TG.0001--

ITEM PART.NO DESCRIPTION REMARI(;S (HY APPLICABLE

2438U1315F1 TELESC CYL

1 2438U1315S1 TUBE, CYLI NDER 1

2 2438U1315S2 ROD, PISTON 1
3 2438U1315S3 PISTON 1
4 ZD12GllOOO O-RING 1
5 2438U353S10 PACKING 2
6 2438U558S7 RING 2
7 2438Ul315S7 NUT, PISTON 1
8 2438Ul315S8 RING 1
9 2438U1315S9 SUPPORT, PACKING 1
10 2438U558S8 RING, wEAR 2
11 2438U1315S11 STOPPER 1
12 2438ul315S12 COVER, ROD 1
13 ZD12G15500 O-RING 1
14 2438U1258S14 RING, BACK-UP 1
15 2438U402S13 BUSHING 1
16 R45P0050D13 SEAL 1
17 R45P0051D27 O-RING 1
18 24100U463S16 U-PACKING 1
19 2418U131D27 SEAL, DUST 1
20 2438U402S18 CLIP 1
21 2438U1315S21 CASE 1
22 2438UB42S16 RING, WEAR 2
23 2438U1315S23 TRUNNION 1
24 2438U1282S24 PIN 1
25 2438U1315S25 BOLT 1
26 2438U125BS23 NUT, WELD 1
27 ZS73COB030 SETSCREw 1
28 2420N458D16070 CAPSCREW 8
29 ZW26X16000 LOCtr.WASHER 8
30 ZD12P02200 O-RING 2
31 ZG91S02000 NIPPLE, GREASE 2
243BU1315R100 REPAIR KIT 1
CONSiSTS OF ITEM 13, 14, 16, 17, 18
19, 22
2438U1315RllO REPAIR tr.1T 1
CONSiSTS OF ITEM 4, 5, 6, B, 10

(Ol) 404-403-1 CD
 CYLINDER ASSY, TELESCOPE- UPPER
TD-0001 '" 2438U1316F1
TG- 0001 ~

30

26

F J G 406-403-1Q)
(01)
 TELESC CYL
CYLINDER,TELECUPPER) TG.0001--

ITEM PART.NO DESCRIPTION REMAR~S ~TY APPLICABLE

2438U1316F1 TELESC CYL

1 2438U1316S1 TUBE, CYLI NDER 1

2 2438U1315S2 ROD, PISTON 1
3 2438Ul315S3 PISTON 1
4 ZD12GllOOO O-RING 1
5 2438U353S10 PACKING 2
6 2438U558S7 RING 2
7 2438U1315S7 NUT, PISTON 1
8 2438U1315S8 RING 1
9 2438U1315S9 SUPPORT, PACKING 1
10 2438U558S8 RING, WEAR 2
11 2438U1315S11 STOPPER 1
12 2438U1315S12 COVER, ROD 1
13 ZD12G15500 O-RING 1
14 2438U1258S14 RING, BACK-UP 1
15 2438U402S13 BUSHING 1
16 R45P0050D13 SEAL 1
17 R45POO51D27 O-RING 1
18 24100U463S16 U-PACKING 1
19 2418U131D27 SEAL, DUST 1
20 2438U402S18 CLIP 1
21 2438U1315S21 CASE 1
22 2438U842S16 RING, wEAR 2
23 2438U1315S23 TRUNNION 1
24 2438U1282S24 PIN 1
25 2438U1315S25 BOLT 1
26 2438U1258S23 NUT, WELD 1
27 ZS73C08030 SETSCREW 1
28 2420N458D16070 CAPSCREW 8
29 ZW26X16000 LOCKWASHER 8
30 ZD12P02200 O-RING 2
31 ZG91S02000 NIPPLE, GREASE 2
2438U1315R100 REPAIR KIT 1
CONSISTS OF ITEM 13, 14, 16, 17, 18
19, 22
2438U1315 RllO REPAIR KIT 1
CONSISTS OF ITEM 4, 5, 6, 8, 10

(OJ) 406- 4 03-1(!)

 BLOCK ASSY. SHEAVE
TE-0001"'J 24100N3897F2
TO-0001'"'-'
TG-0001-

/'
,,- ......
"- .......
,,/

/
/ " "-
/ ""
/ \
/ \
/ \
I \
I \
\
I
\ I
\ /
\ /
\ /
/
""""- /
/
.........
"-
- ,,/
./

17 2

6 6-2 12.18 13.14.15 5 10 8.9

FIG 408-403-1(1) (03)

 SHEAVE ASSY
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLICABLE

24100N3897F2 SHEAVE ASSY

2 2416P10233 BRACKET 2
5 2407P793 SHEAVE 1
6 2407T146Fl SHEAVE 1
6-2 2405R33D1212 BUSHING 1
8 ZP16D04032 PIN 1
9 ZP45X20040 PIN 1
10 ZW16K20000 WASHER 2
12 ZP16D04020 PIN 1
13 ZS18C12030 CAPSCREW 1
14 ZN18C12010 NUT 1
15 ZW26X12000 LOCK WASHER 1
17 2416T18817 BRACKET 2
18 ZP45X12030 PIN 1

(03) 408-403-1 CD
 ROLLER ASSY, GUIDE
24100J8447F2
TD-0001-
TG-0001-

(02)
FIG 409-403-1
 ROLLER ASSY, GUIDE
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS <ilTY APPLICABLE

24100J8447F2 ROLLER ASSY, GUIDE

1 24100U521F4 REDUCER ASSY P. 410-'+03 1

2 2416J1206 BRACKET 1
3 2416N3713 BRACKET 1
5 2420T5355 KEY 2
6 2413T374 WHEEL 2
7 ZW16X2,+000 WASHER '+
8 ZP15D06040 COTTER PIN 2
9 ZS83C12035 BOLT 2
10 ZN18C12010 NUT 2
11 ZS23C10020 CAP,SCREW 4
12 ZS18C10020 CAPSCREW 8
13 2418P1762'+ FLANGE 2

(02) 409-403-1
 BOOM POI TASSY
TO-0001 ..... 24100J8565 F1, F2
TG-0001-

~8 A

FIG 411-403-1(D (02)

 POINT ASSY. BOOM
TG.0001--

ITEM PART.NO DEsCRIPTION REMARKS (ilTY APPLICABLE

24100J8565F1 TG.0001--TG.0001
24100J8565F2 TG.0002--

1 2419JH4 PIN 2
2 2418P15939 SPACER 6
3 241915100 PIN 2
4 ZP15D04048 COTTER PIN 6 TG.0001--TG.0001
4- ZP15D04048 COTTER PIN 2 TG.0002--
5 2407p783F2 SHEAVE loSSY 2
5-4 ZG91V02000 FITTING. GREASE 1
5-6 2405P318 BUSHING 1
5-1 H18R2D54 RING. SNAP 2
6 H07P184F3 SHEAVE loSSY 5
6-3 ZG91V02000 FITTING. GREASE 1
6-6 H25R188D36 BEARING 1
1 24191451002 PIN 2
8 241913258 SPRING PIN 4 TG.0002--

(02)
 VALVE ASSY, FLOW DIVIDER
TD-0001"" 2483U302F2
TG-0001~
TE-0001 .......
TH-0001 .....

2-6

2-2

1-10,1-16
3-58

FIG 412-403-1Q)
(on
 DIvIDER, FLOW
w/SOLENOID TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

..
2483U302F2 DIVIDER, FLOW

1 2436U1792F1 VALVE, SOLENOID 1

1-10 2436U1792S10 SOLENOID 1
1-16 2436U1792S16 O-RING 2
1-17 2436Ul792S17 O-RING 4
2 2436U1793F1 VALVE,DIVIDER,FLOW 1
2-1 BODY 1
2-2 HEAD 2
2-3 SPOOL 1
2-4 SPOOL 1
2-5 2436U1793S5 CAPSCREW 1
2-6 2436U1793S6 SPRING 3
2-7 2436U1793S7 ORIFICE 2
2-8 2420N458D12035 CAPSCREW 8
2-9 ZD12P03200 O-RING 2
2-10 ZD12P02200 O-RING 2
2-11 ZE82T06000 PLUG 2
2-970 2436U1793RllO R,K IT 2-9 2-10 1
3 2436Ul794F1 RELIEF VALVE BLOCK 1
3-41 BODY 1
3-42 2436U1794S42 END 1
3-43 2436U1794S43 END 1
3-44 PLUNGER 2
3-45 PLUNGER 2
3-46 2436U1794S46' SPRING 2
3-47 2436U1794S47 SPRING 2
3-48 2436U1794S48 BALL 3
3-49 2436U1794S49 SPRING 3
3-50 2436U1794S50 PLUG 1
3-51 ZE82T08000 PLUG 1
3-52 ZE82T04000 PLUG 3
3-53 ZE82T02000 PLUG 3
3-54 2436U1794S54 PLUG 6
3-55 ZD12P02600 O-RING 6
3-56. 2420N458D10040 CAPSCREW 8
3-57 2420N458D10110 BOLTE 4
3-58 2436U1794S58 SHIM 2
3-59 2436U1843S26 DRAIN, AIR 2
3-60 PLUNGER 2

(01) 412-403-1(D
 INSTAL. CYLINDER BOOM HOIST(WITHOUT/E.R)
TD-0001- 24100J8702F2
TG-OOOl -

16 21.20.6.5 3 9.12.6.8

26
27
15.10
26

SECTION 0-0

16 8.7.6.5 3 4 5.6.7.8

8.7.6.5 18 13.14.15 28 25 19

15.11.10
\-

SECTION A-A

FIG 505-02-1 (03)

 INSTAL, CYLINDER
BOOM HOIST WITHOUT/E.R TG.0001--

ITEM PART. NO DESCRIPTION REMARKS (HY APPLICABLE

2'+l00j8702F2 INSTAL, CYLINDER

2 2419P2469 PIN 1
3 36R97D2 VALVE 2
4 2440P184 MANIFOLD 2
5 ZE12X16000 CLAMP, HALF 28
6 ZD12P03400 O-RING 16
7 2420N458D10030 CAPSCREW 32
8 ZW26K10000 LOCKWASHER 40
9 2420N458D10090 CAPSCREw 8
10 ZS18C12025 CAPSCREW 2
11 R16T0259D7 WASHER 1
12 ZW16XI0000 WASHER 8
13 ZC45X31014 CLIP 2
14 ZS18C12020 BOLT 2
15 ZW26X12000 LOCK WASHER 3
16 2444R816D2 HOSE ASSy 2
18 2444R1433Dl HOSE ASSY 2
19 ZG91S04000 NIPPLE 2
20 0630V046 CAPSCREW, SOCKET 16
21 3615V009 WASHER 24
23 2444Z2729D4 PLUG 1
24 20Z646D48 BOLT -a-
25 ZX27p16135 HOSE ASSy 2
26 ZC45X38014 CLIP 2
27 ZN18C12010 NUT 1
28 2438U1314F2 CYLINDER ASSY, HOiST P. 506-505 2

(03) 505-02-1
 TO-O 001 '"'- CYLINDER ASSY, BOOM HOIST
TG-O 001 ....
2438U1314F2

22
20

'~

FIG 50 6 -505-1(D

( 01)
 CYLINDER ASSy, HOiST
CYLINDER,HOIST wO/E.R TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CilTY APPLICABLE

2438U1314F2 CYLINDER ASSY, HOiST

1 2438U1314S1 TUBE, CYLI NDER 1

2 2438U1314S2 BEARING, SPHERIC~L 2
3 2438U339S34 RING, SNAP 4
4 2438u13HS4 ROD, PISTON 1
5 2438U1314S5 PISTON 1
6 ZD12P13000 O-RING 1
7 ZD75P13000 RING, BACK-UP 1
9 2438U1280S7 RING, TEFLON 1
10 2438U1280S8 PACKING 1
11 2438U1280S9 RING, BACK uP 1
12 2438U1280S10 RING, WEAR 2
13 ZS83C08012 CAPSCREW 1
14 2438U1280S34 COvER, ROD 1
15 2438U765S22 O-RING 1
16 ZD12G19000 O-RING 1
17 2438U765S21 RING, BACK-UP 1
18 2438U1280S37 BUSHING 2
19 2438U1249S34 CLIP 1
20 2438U1249S35 U-PACKING 1
21 2438U1249S36 SEAL, DUST 1
22 2438U882S26 CLIP 1
23 ZS23C20085 CAPSCREW 12
24 ZW26X20000 WASHER 12
25 ZG91S04000 NIPPLE 2
2438U1314R100 REPAIR KIT 1
CONSISTS OF ITEM 15, 16, 17, 20, 21
2438U1314RllO REPAIR IUT 1
CONSISTS OF ITEM 6, 7, 9, 10, 11
12

(01) 506-)05-1 CD
 DECAL ASSY(TRADEMARKS & NAME-PLATES 110' BOOM)
TG-0001- 24100J9085Fl

45 67 61 62 63 64 65 66

~~\\ \ ~ ~ ~.~1~
~ .i.s. ~ 40' 45' 115' fItj' 7s' .41~ .t
80 13 20 I. 2

17 42

3 5 78 79 20

57 81 82 83 36 22 42
19 18

55
39 21 54

39

VIEW FRONT VIEW REAR

FIG 601-01-1 (O1)

 DECAL ASSY(TRADEMARKS & NAME-PLATES 110' BOOM)
24100J9085F1 TG-0001-

15.9 29.28 10.16 33.58.59.60

30 50.48 56 41

VIEW 0
26.23 31 40 25 27

VIEW A

35 11 12 34 26 38 9 15 7 44
J
1.
46

24
10 16 14 VIEW E-E
VIEW C
VIEW F

52

0 32

(0 58
51

37
6
VIEW J-J VIEW G VIEW K
SECTION N
43
69

VIEW P
EXTENTION

(01) FIG 601-01-2

 TRADEMARK
110 FEET TG.0001--

ITEM PART~NO DESCRIPTION REMARKS <wTy APPLICABLE

24100J9085F1 TRADEMARK

1 32U2358 DECAL 3
2 32<w1452 DECAL 1
3 32<w1453 DECAL 1
4 32@1569D1 DECAL 1
5 32<w1570D1 DECAL 1
6 DECAL 1
7 DECAL 2
8 DECAL 1
9 DECAL 2
10 DECAL 2
11 DECAL 1
12 DECAL 1
13 DECAL 1
14 DECAL 2
15 DECAL 2
16 DECAL 2
17 320661 PLATE 2
18 321il1195 DECAL 1
19 32~1196 DECAL 1
20 2432R185D3 DECAL 2
21 32\ll1571 DECAL 1
22 2432Pll71 DECAL 1
23 3201121 DECAL 1
24 DECAL 1
25 DECAL 1
26 3201349 DECAL 2
27 3201516 DECAL 1
28 DECAL 2
29 DECAL 2
30 2432R192 DECAL 1
31 DECAL 1
32 2418P17992 PLATE 1
33 2418P17991 PLATE 1
34 32Z1162 DECAL 1
35 2432T1977 DECAL 1
36 32Z1786 DECAL 1
37 327.1787 DECAL 1
38 2432T1976 DECAL 1
39 DECAL 2
40 32Z2188 DECAL 1
'+1 32Z2193 DECAL 1
42 2432Z523D1 DECAL 2
43 2432T3710 DECAL 1
44 2432Nl273 DECAL 2
lf5 32U1479 DECAL 2
46 32U2357 DECAL 1
48 321il1345 PLATE 1
50 20Z144904 RivET, POP 4
51 2420R747D5 BOLT 2
52 2416T18S65 BRACKET 1

601-01-1 (01)
 TRADEMARK
TG.0001-- 110 FEET

ITEM PART.NO DESCRIPTION REMARKS (HY APPLICABLE

54 2432Z')23D10 DECAL 1
55 2432Z523D11 DECAL 1
56 DECAL 1
57 DECAL 1
58 lN41C06000 NUT 2
59 lN32C06005 NuT 2
60 lS18C06045 BoLT 2
61 32Z1319 DECAL 2
62 3211208 DECAL 2
63 3212426 DECAL 2
64 3212427 DECAL 2
65 32Z1883 DECAL 2
66 32611573 DECAL 2
67 32Z1781 DECAL 1
68 DECAL 1
69 DECAL 4
78 2432R185D1 DECAL 1
79 2432R185D2 DECAL 1
80 2432R185D7 DECAL 1
81 2432R185D5 DECAL 1
82 2432R185D6 DECAL 1
83 2432R185D4 DECAL 1
84 24100J9084F1 SHEET 1

(01) 601-01-2
 TOOL ASSY
TE-0001 ........ 24100J2390F6
TH-0001'"""
TO-0001'"""
TG-0001--
TA- 0001""'-'
TC- 0001.......,

29.53.
7.9.10.11.12.48.

49.50.52.55.

13.14.15.16.56.

3.-a
31

20.21.22.23.24.25.26.27.

32

28

FIG 611-01-1 (10 )

 TOOL ASSY
TG.0001--

ITEM PART .NO DESCRIPTION REMARKS &TY APPLICABLE

24100J2390F6 TOOL ASSy

1 ZT12B11013 SPANNER 11X13 1

9 ZT12B11019 SPANNER l1X19 1
10 ZT12B22024 SPANNER 22X24 1
11 ZT12B21030 SPANNER 21X30 1
12 ZT12Bn036 SPANNER 32X36 1
13 2421Z61D2 SPANNER 26 1
14 2421Z61D4 SPANNER 35 1
15 ZT12A41000 SPANNER U 1
16 2421Z61D5 SPANNER 46 1
20 ZT22A06000 KEY, SCREw 6 L=90 1
21 ZT22A08000 KEY,SCREW 8 L-100 1
22 ZT22A10000 KEY,SCREW 10 L~112 1
23 ZT22A12000 KEY,SCREW 12 L=125 1
24 ZT22A14000 KEY, SCREW 14 L"140 1
25 ZT22A11000 KEY,SCREw 11 L"160 1
26 ZT22A19000 KEY, SCREW 19 La.175 1
21 ZT22A05000 KEy, SCREW 5 L~80 1
28 ZT31Bl3250 RATCHET 12.1 1
29 ZT31D13150 EXTENSION 12.1 1
30 ZT31A19000 SOKET 19X12.1 1
31 ZT31A24000 SOKET 24X12.1 1
32 ZT31A30000 SOKET 30X12.1 1
48 ZT12B08010 SPANNER 8X10 L=.120 1
49 ZT31A13000 SOKET 13X12.7 1
50 ZT31A11000 SOKET 11x12.7 1
52 ZT32A41000 SOKET 41X19.05 1
53 ZT31D19200 EXTENSION 19.05 1
54 ZT31C19500 HANDLE,SLIDE L-500 1
55 ZTnA36000 SOKET 36x19.0~ 1
56 ZT12A36000 SPANNER 36 L.. 320 1
60 2421Z377 CASE S-450 1

00> 611-01-1(1)
 JUSTIN CASE
TA-0001"'-' 24100N3875F5
TC-0001"'-'
TO-0001""
TE-0001"'-'
TG-0001""
TH-OOOl ""

~~--JJ

1 2 42,45

I
3,4,5,6,7
1 ~ r f
8,9,10,11,12 18,25,26
27.31.32
23,24 21.22

f
~38.39
f
40.41

~ 43
6f 44

FIG 612-01-1(1) (05)

 JUSTIN CASE
TG.0001--

ITEM PART~NO DESCRIPTION REMARKS 61Ty , APPL I CABLE

"
24100N3875F5 JUSTIN CASE

1 24211377 CASE 1
2 2432P1441 LABEL 1
3 Z012POll00 O-RING 1
4 Z012P01400 O-RING 1
5 Z012P01800 O-RING 1
6 Z012P02240 O-RING 1
7 Z012P02900 O-RING 1
8 44&127601 ADAPTER 2
9 44&127602 ADAPTER 2
10 4461127603 ADAPTER 2
11 44&127604 ADAPTER 2
12 44&127605 ADAPTER 2
18 R79T0048D1 BULB, LIGHT 1
21 44&120601 ADAPTER 2
22 44&120602 ADAPTER 2
23 2479Z117605 FUSE 1
24 2479Z1176010 FUSE, 10AMP 1
25 R79TOO4806 BULB 1
26 2479U466S1 BULB 1
27 2456R1.52S1 LIGHT 1
31 2479Z445S1 BULB 1
32 R79POO07S3 BULB 1
33 2432P1442 LABEL 1
37 1!t44T0204 CONNECTOR 1
38 ZH22Z08000 CONNECTOR 1
39 ZH22Z06008 CONNECTOR 1
40 ZG22E08000 NIPPLE 1
41 ZG22E08006 NIPPLE 1
43 2444Z1748D1 SOCKET 1
44 44&119205 AOERPTER 1
4' 2432T3892 LAVEL 1

(05) 612-01-1(0
 INDICATOR, DRUM TURN
TO-0001 ,.". 24100J8982F1, F2
TG-0001-

FIG 708-01-1(1)
 INDICATOR, DRUM TURN
1581 MAIN TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &Ty APPLICABLE

24100J8982F1 INDICATOR, DRUM TURN

1 24100N4246F3 INDICATOR, DRUM TURN P. 709-708 1

2 2420R486D1 ROD-END 1
3 2406R304D585 CABLE, CONTROL 1
5 2416P11443 BRACKET 1
6 ZC47X08009 CLIP 7
7 ZC45X11009 CLIP 1
8 2432Z290 CLIP 1
9 2414T3281 CAP 1
10 2420T5323D2 BOLT 1
11 ZS31C08016 CAPSCREw 1
12 ZS18C12035 BOLT 1
13 ZN18C08007 NUT 7
14 ZN16C05004 NUT 2
15 ZW26X08000 LOCK WASHER 7
16 ZW16H12000 WASHER 1
17 ZW16H18000 WASHER 1
18 ZW16H05000 WASHER 1

24100J8982F2 INDICATOR, DRUM TURN

1581 AUX

1 24100N4246F3 INDICATOR, DRUM TURN P. 709-708 1

2 2420R486D1 ROD-END 1
4 2406R304D650 CABLE, CONTROL 1
5 2416P11443 BRACKET T
6 ZC47X08009 CLIP 1
7 ZC45X11009 CLIP 1
8 2432Z290 CLIP 2
9 2414T3281 CAP 1
10 2420T5323D2 BOLT 1
11 ZS31C08016 CAPSCREW 1
12 ZS18C12035 BOLT 1
13 ZN18C08007 NUT 1
14 ZN16C05004 NUT 2
15 ZW26X08000 LOCK WASHER T
16 ZW16H12000 WASHER 1
17 ZW16H18000 WASHER 1
18 ZW16H05000 WASHER 1

(OT) 708-01-1 CD
 INOICATOR,DRUM TURN
TH-0001 "" 24100N4246F3,F4
TO-0001....,
TG-0001..v
TE-OOO 1--

2.5

(04)
FIG 709-708-1 Q)
 INDICATOR' DRUM TURN
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS tilTY APPLICABLE

24100N4246F3 INDICATOR, DRUM TURN

2 2406P3785D1 LEVER 1
3 2418P15275 PLATE 1
4 2413T550 WHEEL 1
6 2410P1019 SHAFT 1
7 2425Z394D4 BEARING 2
8 2417T579 SPRING 1
9 2420T6006 SCREW 1
11 ZS18C08045 BOLT 1
12 ZS18C08025 BOLT 1
14 ZS18C06012 CAPSCREW 4
15 ZW26X06000 LOCK WASHER 4
16 ZW26X08000 LOCK WASHER 1
17 2418T15746 SPACER 1
19 ZW16X08000 WASHER 1
20 ZN18C08007 NUT 3
21 2420T5504D2 SHIM 0.2 4

<DO 709-708-l(y
 ROLLER AS SYI DRUM
TE-0001-v
TH-0001'"V
TO-0001",,",
TG - 0001 ""

7
69

(01)
FIG 71 3 -01-1@
 ROLLER 4SSY, DRUM
1581 M41N &. 4UX TG.0001--

ITEM PART.NO DESCRIPTION REMARItS tilTY .APPLICABLE

24100N4245F1 ROLLER ASSY, DRUM

1 2406T2089 LEVER 2
2 2417P331 SPRING 2
3 2420T5146 ROD-END 2
4 ZW16P08000 WASHER 2
5 ZN16C08005 NUT 4
6 2416Tl6250 BRACKET 2
7 ZM11C10025 SEMS-BOLT 4
9 ZP26006050 SPRING PIN 2
10 2418P15275 PLATE 2
11 ZS18C12035 BOLT 2
12 2420T532302 BOLT 1
13 ZN32C18016 U-NUT 2
14 ZR26X04700 SNAP RING 2
15 2406P354501 ARM 1
16 2406P3545D2 ARM 1
17 2405Z144 BUSHING 2
18 R25POO09D41 BEARING 2
19 2413P329 ROLLER 1
20 2419T419902 PIN 1
21 2418T12803 WASHER 2
22 ZP15004036 COTTER-PIN 2
23 ZW16H18000 WASHER 2

I
I1
I

(01)
 INSTAL. HOOK. PINTLE
TH-0001'- 24100P1513 F2
TG-OOOl '"'-J

I---!
, 2.3.4

\U=J,'~:

FIG 715-01-1 (01)

 INSTAL, HOOK, PINTLE
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

24100P1513F2 INSTAL, HOOK, PINTLE

1 2408U67 HOOK, PINTLE 1

2 ZS18C16060 CAPSCREW 4
:3 ZW16H16000 WASHER 8
4 ZN18C1601:3 NUT 4

(D1) 715-01-1
 INSTAL. FLOODLIGHT
TO-0001 ........ 24100J8875Fl
TG-0001 ........

2 -1
2 13 12 12 12 14

1-1 15
1

-~,-4I
20.19

n i

----JL. P
q(Q
__ ~
.

SECTION B - B 6 5.4 3
V I EW OF BACKSI DE OF UPPER
DASH PANEL IN CAB

FIG 719-01-1 co 1)
 INSTAL, FLOODLIGHT
110 FEET BOOM TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTy APPLICABLE

24100J8875F1 INSTAL, FLOODLIGHT

1 2456U3F2 LIGHT 2
1-1 2456U3S1 SEALED BEAM 1
2 2456R123D2 LIGHT 1
2-1 2456U3S1 SEALED BEAM,24V 1
3 79(il760D1 SWITCH 3
4 2479Z1175F1 HOLDER 3
5 2479Z1176D5 FUSE (5A) 3
6 2479T1327 HARNESS 3
8 ZC45X14011 CLIP 10
9 ZS18C10016 CAPSCREW 10
10 ZW16X10000 WASHER 10
11 ZW26X10000 LOCKWASHER 10
12 2420T3845D7 PIPE 3
13 2420T3845D11 PIPE 1
14 2420T3845D15 PIPE 1
15 2479P802D4 HARNESS 1
16 2479P802D2 HARNESS 1
19 3487Z39D3 CLIP,HOSE 14
20 2432Z534 RING, CLIP 7
21 2420R189D3 GROMMET 1

(OJ)
 TACHOMETER
TG-0001- 24100N4638F1.F2

')Cj-
L
o }

2.6 3.4.5

VIEW A-A

FIG 721-01-1(j) (03 )

 TG.0001--

ITEM PART.NO DESCRIPTION REMARK.S GTY APPLICABLE

24100N4638Fl TACHOMETER
PIp GM

1 2479U514 TACHOMETER 1
2 24nU515D5 TACHOMETER ItIT 1
3 ZS31C04012 MACHINESCREW 2
4 ZN16C04003 NUT 2
5 ZW26X04000 LOCIt WASHER 2

24100N4638F2 TACHOMETER
PIP CAT

1 2479U5h TACHOMETER 1
3 ZS31C04012 MACHINESCREW 2
4 ZN16C04003 NUT 2
5 ZW26X04000 LOCIt WASHER 2
6 2479U515D7 TACHOMETER ItIT 1

(03)
 BATTERY ASSY
TG-0001- 24100N464SF2.F3

6
o o 0 2.7

-• 8

5
3.7

(FtG.2)

@ @ @
6
o o o 2.7

".
o 9

5 3.7

::
o o o

(Ft G. 3)

FIG 722-01-1 (02)

 BATTERy ASSY
STANDARD TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

24100N4645F2 BATTERY ASSY

2 R20TOO84D13 CAPSCREW 1
3 R20TOO84D14 CAPSCREW 1
4 B16TOO39 SUPPORT 1
5 B16TOO40 PLATE 1
6 B16TOO41 PLATE 1
7 ZW26X1OOOO LOCK WASHER 2
8 84Z4K BATTERY, N150 2

24100N4645F3 BATTERY ASSY

HD IN200

2 R20TOO84D13 CAPSCREW 1
3 R20TOO84D14 CAPSCREW 1
4 B16TOO39 SUPPORT 1
5 B16TOO40 PLATE 1
6 B16TOO41 PLATE 1
7 ZW26X1OOOO LOCK WASHER 2
9 84Z52 BATTERy, N200 2

(02)
 ALARM. BACK UP
TH-0001- 24100P2022F2
TG-OOO 1 --

o o o

FIG 723-01-1 (02)

 ALARM.BACK UP
TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (!lTV APPLICABLE

24100P2022F2 ALARM.BACK UP

1 2447U5 ALARM 1
:3 2420R189D3 GROMMET 1

(02) 723-01-1
 OPTIONS ON CAB
TE- 0001 ......
TH -0001 .....
TO-0001-
TG-0001-

5-1

~
3 -1
3-2
3-3 I

3-4------f>~---GI

3-5

2-1

FIG 730-01-1 (01 )

 EXTINGUISHER
FIRE EXTINGUISHER TG.0001--

ITEM PART.NO DESCRIPTION REMARKS ~TY APPLICABLE

24100P1422F1 EXTINGUISHER

1-1 2437R126 EXT! NG 1

1-2 ZS31C05010 MACHINESCREw 3
1-3 Zw26X05000 LOCK WASHER 3
1-4 2416R163 SUPPORT 1

24100N4608F2
wASHER,wINDow

2 2488Z7 WASHER 1
2-6 2420Z1541D3 TUBE 1
2-7 3487Z39D3 CLlP,HOSE 2
2-8 ZMllC06012 BOLT 2
2-9 79~760D15 SWITCH 1

24100J8053F1 LI GHT, ROTARY

L1GHT,ROTARY

3-1 2456R151D3 LI GHT, ROTARY 1

3-2 2418Tl4773 SPACER 1
3-3 2418Tl4774 SPACER 1
3-4 2420R189D6 GROMMET 1
3-5 79~760Dl SWITCH 1

(Ol).
 INSTAL, WIPER
TG.0001-- wIPER ASSY,FRONT

ITEM PART.NO DESCRIPTION REMARKS GlTY APPLICABLE

24100J9053F1 INSTAL, WIPER

4-1 2479U599 MOTOR, WIPER 1

4-2 2406R217 ARM, wIPER 1
4-3 2488R114 BLADE 1
4-4 ZMllC06016 CAPSCREw 2
4-5 ZW16X06000 WASHER 2
4-6 79Gl760D2 SwITCH 1
4-7 2479U229 RELAY, SWITCH 2
4-8 ZS31C08014 MACHINESCREW 2
4-9 ZN16C08007 NUT 2
4-10 ZW26X08000 LOCK WASHER 2
4-11 2479R1067 RELAY 1

24100J8031F2 INSTAL, WIPER

wIPER ASSY,ROOF

5-1 2456R8D21 MOTOR, wIPER 1

5-2 R79P0022 ARM, wIPER 1
5-3 2488Z8D3 BLADE, WIPER 1
5-4 79Gl760D1 SwITCH 1
5-5 2418T13669 SPACER 1
5-6 2416P10526 BRACKET 1
5-7 ZS31C05014 MACHINESCREW 5
5-8 ZW26X05000 LOCKWASHER 5
5-9 2420R189D8 GROMMET 1
5-11 3487Z39D2 CLlP,HOSE 4
5-12 2432Z538 MOUNT 3
5-13 2479P1l68 HARNESS, wIRING 1

(OJ)
 EX TENSION ASSY, 35' W I STORAGE CRANK PI NS
TO-ODD 1 - 2410 OJ 8980F2, F4
TG-0001--

r
3
Q--S,35
7-2

7-3

7-1 7

7-3
7-2
8-9,36

A-t6
~

"

13

FIG 8"-0'-1<D
(04)
 EXTENSION ASSY
INSTAL 35 FT wlO OFFSET TG.0001--

ITEM PART.NO DESCRIPTION REMARKS &lTV APPLICABLE

24100J8980F2 EXTENSION ASSY TG.0001--TG.0001

24100J8980F. EXTENSION ASSY TG.0002--

3 2407P784F2 SHEAVE ASSY 1

3-2 2.25R188D35 BEARING 1
3-4 ZG91S02000 NIPPLE. GREASE 1
4 2419T4590D2 PIN 1 TG.0001--TG.0001
4- 2419T5444D2 PIN 1 TG.0002--
5 2418T14325 SPACER 6
6 ZP.5X20090 PIN 3
7 24100P2017F1 HOUSING ASSY 2 TG.0001--TG.0001
7- 24100P2017F2 HOUSING ASSV 2 TG.0002--
7-1 24HP5580 HOUSING 1 TG.0001--TG.0001
7-1A 2414P6194 HOUSING 1 TG.0002--
7-2 2.05T1388 BUSHING 2
7-3· ZG91S02000 NIPPLE. GREASE 2
8 2419P2515 PIN 2 TG.0001--TG.0001
9 2419P2516 PIN 2 TG.0001--TG.0001
10
11
ZS73C12035
ZN18C12010
SETSCREW
NUT
•6
13 2416J1274 BRACKET 1
1. zS18C20040 CAPSCREw •
15
16
ZW16H20000
24100Pl883F2
WASHER
CRANK ASSV
•1
16-2 2432T3093 CLAMP 2
16-4 ZW26x10000 LOCK WASHER 2
16-5 2406P3798 CRANK 1
16-7 2420R747D43 BOLT. WING 2
18 2419T3258 SPRING PIN 3
20 2416P1l530 PAD 1
21 2420T6043D1 SHIM 0.7 3
22 ZS68C12030 CAPSCREW 3
23 2420T6043D2 SHIM 2.3 3
24 ZS18C12035 BOLT •
25
26
2418T13084
2416N4495
wASHER
BRACKET
•1 TG.0001--TG.0001
27 2418P17633D1 SHIM 1.6 8
28 2418P17633D2 SHIM 3.0 2
29 2.20P2105D1 CAPSCREW 1 I
I
30 ZN37C12011 LOCKNUT 1
31
32
32Zl.00
2420T6079D1
WARNING BOOM PEPAIR
CAPSCREW
•2
34 2411J3295 EXTENSION. BOOM 1 TG.0001--TG.0001
35 2419P2829 PIN 2 TG.0002--
36 2419P2830 PIN 2 TG.0002--
38 2411J333. EXTENSION BOOM 1 TG.0002--
39 2416N4735 BRACKET 1 TG.0002--

(04)
 EXTENSION ASSY, 35' W I STORAGE DRIVE PINS
TO-OOO 1--
TG-OOO 1-..... 24100J8980F3. F5

13

FIG 813-02-1<1>

(04)
 EXTENSION ASSY
35FT WITH OFF SET TG.0001--

ITEM PART.NO DESCRIPTION REMARKS CHY APPLICABLE

24100J8980F3 EXTENSION ASSY TG.0001--TG.0001

24100J8980F5 EXTENSION ASSY TG.0002--

3 2407P784F2 SHEAVE ASSY 1

3-2 2425R188035 BEARING 1
3-4 ZG91S02000 NIPPLE, GREASE 1
4 2419T459002 PIN 1 TG.0001--TG.0001
2419T544402 PIN 1 TG.0002--
5 2418Tl4325 SPACER 6
6 ZP45X20090 PIN 3
10 ZS73C12035 SETSCREW 4
11 ZN18C12010 NUT 6
13 2416Jl274 BRACKET 1
14 ZS18C20040 CAPSCREW 4
15 ZW16H20000 WASHER 4
16 24100P1883F2 CRANK ASSY 1
16-2 2432T3093 CLAMP 2 TG.0001--TG.0001
16-4 ZW26xl0000 LOCK WASHER 2 TG.0001--TG.000l
16-5 2406P3798 CRANK 1 TG.0001--TG.000l
16-7 2420R747043 BOLT, WING 2 TG.0001--TG.0001
18 2419T3258 SPRING PIbI 3
20 2416P11530 PAD 1
21 2420T604301 SHIM 0.7 3
22 ZS68C12030 CAPSCREw 3
23 2420T604302 SHIM 2.3 1
24 ZS18C12035 BOLT 4
25 2418Tl3084 WASHER 4
26 2416N4495 BRACKET 1 TG.OO01--TG.0001
27 2418P1763301 SHIM 1.6 8
28 2418P1763302 SHIM 3.0 2
29 2420P210501 CAPSCREW 1
30 ZN37C12011 LOCKNUT 1
31 nZ1400 WARNING BOOM PEPAIR 4
32 2420T607901 CAPSCREw 2
33 24100J9151Fl EXTENSION,OFFSET P. 814-813 1 TG.0001--TG.000l
24100J9151F2 EXTENSION,OFFSET P. 814-813 1 TG.OO02--
34 2411J3295 EXTENSION, BOOM 1 TG.0001--TG.0001
38 2411J3334 EXTENSION,BOOM 1 TG.OO02--
39 2416N4735 BRACKET 1 TG.0002--

(04)
 I NSTAL, OFFSET
TO-O 001 .... 24100J9151 F1, F2
TG-0001-

18

FIG 8 14-813-1<D (02)

 EXTENSION. OFFSET
TG.0001--

ITEM PART.NO DESCRIPTION REMARIC:S 6lTy . APPL I CABLE

241OOJ9151F1 TG.0001--TG.0001
241OOJ9151F2 TG.0002--

1 241OOP2027F1 HOUSING ASSY 2 TG.0001--TG.0001

1- 241OOp2027F2 HOUSING ASSY 2 TG.0002--
1-1 24UN3411 HOUSING 1 TG.0001--TG.0001
1-1A 2414N3520 HOUSING 1 TG.0002--
1-2 2405T1388 BUSHING 1
1-3 2405T1230 BUSHING 1
1-4 241BTU576 PLATE 1
1-5 2417P338 SPRING 1
1-6 2420T5656 BOLT 1
1-7 ZN37C08008 NUT 2
1-8 ZP26D10025 PIN. SPRING 1
1-9 ZP26D05025 PIN SPRING 1
1-10 ZG91S02000 NIPPLE. GREASE 1
2 241OOP2028F1 HOUSING ASSY 2 TG.0001--TG.0001
2- 241OOp2028F2 HOUSIN6 ASSY 2 TG.0002--
2-1 2414N3412 HOUSING 1 T6.0001--TG.0001
2-1A 2U4N3521 HOUSIN6 1 T6.0002--
2-2 2405T1388 BUSHING 1
2-3 Z691S02000 NIPPLE. 6REASE 1
3 2406P3809 LINK 4
4 2406P3810 LINK 2
5 2419P2522 PIN 4
7 2416P11782 BRACKET 1
8 2U6Pl1783 BRACKET 1
10 2U6P10402 BRACKET 1
12 2U8P17692 COLLAR 2
U 24171499 SPRING 2
15 ZP26D10100 PIN. SPRIN6 1
16 2419T4552 PIN 3
17 241913258 SPRING PIN 7
18 32611343 DECAL 2
23 ZS18C16120 CAPSCREW 1
24 ZN37C16016 NUT 1
25 ZW16X16000 WASHER 2
26 ZS18C20080 CAPSCREW 2
27 ZN37C20018 NUT 2
28 ZS18C10020 CAPSCREW 4
29 ZW16H10000 WASHER 4
201 2419P2515 PIN 2 TG.0001--T6.0001
201- 2419P2829 PIN 2 T6.0002--
202 2419P2516 PIN 2 T6.0001--T6.0001
202- 2419P2830 PIN 2 TG.0002--

(02)
 CRANK PINS
TO-0001-
TG-0001 .......

~~~45
~ 17
1
1652
\)

51
; 50-
d.
I
I

66 2474 .

~ J~1
~~h~~2)74
(@{U-V 24

6~~ J,:'--25
7~
~~.,
~62
~ ____75
22 - TP---9

58
39"

FIG 821-01-1(.1) (05)

 EXTENSION ASSY
INSTAL 35FT-60FT TG.0001--

ITEM PART.NO DESCRIPTION REMARKS GlTY . APPLICABLE

24100J8937F5 EXTENSION ASSY TG.0001--TG.0001

24100J8937F7 EXTENSION ASSY TG.0002--

2 2411J3171 JIB, INNER 1

5 2407P784F2 SHEAVE ASSY 1
5-2 2425R188D35 BEARING 1
5-3 ZG91S02000 NIPPLE, GREASE 1
6 2419T4590D2 PIN 1 TG.0001--TG.0001
7 2418Tl4325 SPACER 6
8 ZP45X20090 PIN 3
9 2U9T3258 SPRING PIN 5
10 2419T5444D2 PIN 1 TG.0002--
11 2420T6042 SHIM 0.7 4
12 24100N4639F1 ROLLER ASSY 1
12-1 2416N4496 BRACKET 1
12-2 2416P1l697 BRACKET 1
12-3 2419T4840 PIN 1
12-4 2405Z221 BUSHING 2
12-5 2419T5227 PIN 2
12-6 2413T406 ROLLER 2
12-7 2418Tl4565 PLATE 1
12-8 ZP26D05045 PIN 2
12-9 ZS18C08020 CAPSCREw 2
12-10 ZW26X08000 LOCK WASHER 2
13 2429T430 PAD 4
14 2429R311F1 PAD 2
15 2418Tl4567D1 SHIM 1.6 8
16 2418Tl4566 PLATE 3
17 2418Tl4568D1 SHIM 1.6 11
18 2418Tl4568D2 SHIM 3.2 7
19 2416P11700 BRACKET 1
20 2418Tl6014 PLATE 1
21 2413T384 WHEEL 2
22 19Z274D35 PIN 1
23 2419T4524 PIN 1
24 ZP15D04040 COTTER PIN 2
25 ZP26D04040 PIN, SPRING 1
26 2416P10694 BRACKET 1
27 2416Tl5449 BAR 1
28 2419P2255 PIN 1
29 19Z274D15 PIN, HITCH 1
30 2413T406 ROLLER 1
31 2419T5227 PIN 1
32 ZP26D05045 PIN 1
33 2416P1l698 BRACKET 1
34 2416P1l699 PAD 1
35 24100p2017F1 HOUSING ASSY 2 TG.0001--TG.0001
24100P2017F2 HOUSING ASSY 2 TG.0002--
35-1 2414P5580 HOUSING 1 TG.0001--TG.0001

(05) 821-01-1 CD
 EXTENSION ASSy
TG.0001-- INSTAL 35FT-60FT

ITEM PART.NO OESCR I PTI ON REMARKS 6lTY APPLiCABLE

35-1A 2414P6194 HOUSING 1 TG.0002--

35-2 2405T1388 BUSHING 2
35-3 ZG91S02000 NIPPLE, GREASE 2
36 2419P2515 PIN 2 TG.0001--TG.OO01
37 2419P2516 PIN 2 TG.0001--TG.0001
3.8 2416Tl7871 BRACKET 2
39 2416N4495 BRACKET 1 TG.0001--TG.0001
40 2416J1274 BRACKET 1
42 2416P1l530 PAO 1
44 2418P1763301 SHIM 1.6 8
45 2418P1763302 SHIM 3.0 2
46 2420T604301 SHIM 0.7 3
47 2420T604302 SHIM 2.3 1
48 24100P1883F2 CRANK ASSY 1
48-2 2432T3093 CLAMP 2
48-4 Zw26X10000 LOCK WASHER 2
48-5 2406P3798 CRANK 1
48-7 2420R747043 BOLT, WING 2
50 ZS73C20050 BOLT 4
51 ZN18C20016 NUT 4
52 ZS68C08035 CAPSCREW 6
54 ZS68C12030 CAPSCREW 5
55 zs68C12040 CAPSCREW 6
56 ZS73C12035 SETSCREW 4
57 Zs18C12025 CAPSCREW 4
58 2416N4735 BRACKET 1 TG.0002--
59 ZS18C12035 BOLT 6
60 Zs18C12050 CAPSCREW 8
61 2420P210501 CAPSCREW 1
62 ZS18C16065 CAPSCREW 4
63 Zs18C20040 CAPSCREW 4
65 2411J3333 EXTENSION,BOOM 1 TG.0002--
66 ZN37C12011 LOCKNUT 1
67 ZN18C12010 NUT 20
68 ZN18C16013 NUT 4
69 Zw26X12000 LOCK WASHER 8
70 zw16H16000 WASHER 4
71 2418Tl3084 WASHER 4
72 Zw16H12000 WASHER 16
73 zw16H20000 WASHER 4
74 Zw16X24000 WASHER 2
75 ZW16X10000 WASHER 1
76 2420T607901 CAPS CREW 2
78 2411J3294 EXTENSiON, BOOM 1 TG.0001--TG.0001
79 2419P2829 PIN 2 TG.0002--
80 2419P2830 PIN 2 TG.0002--

821-01-2 <D ((
 EXTENSION ASSY
TG~OOOl-- 35FT-60FT W/OFF SET

ITEM PART.NO DESCRIPTION REMARKS GTY APPLiCABLE

47 2420T6043D2 SHIM 2.3 1

48 24100P1883F2 CRANK ASSY 1
48-2 2432T3093 CLAMP 2
48-4 ZW26X10000 LOCK WASHER 2
48-5 2406P3798 CRANK 1
4.8-7 2420R747D43 BOLT, WING 2
50 ZS73C20050 BOLT 4
51 ZN18C20016 NUT 4
52 ZS68C08035 CAPSCREW 6
54 ZS68C12030 CAPSCREW 5
55 ZS68C12040 CAPSCREW 6
56 ZS73C12035 SETSCREW 4
57 ZS18C12025 CAPSCREW 4
58 2416N4735 BRACKET 1
59 ZS18C12035 BOLT 6
60 ZS18C12050 CAPSCREW 8
61 2420P2105D1 CAPSCREW 1
62 ZS18C16065 CAPSCREW 4
63 ZS18C20040 CAPSCREw 4
65 2411j3333 EXTENSION 1
66 ZN37C12011 LOCKNUT 1
67 ZN18C12010 NUT 20
68 ZN18C16013 NUT 4
69 ZW26X12000 LOCK WASHER 8
70 ZW16H16000 WASHER 4
71 2418T13084 WASHER 4
72 ZW16H12000 WASHER 16
73 ZW16H20000 WASHER 4
74 ZW16X24000 WASHER 2
75 ZW16X10000 WASHER 1
76 2420T6079D1 CAPSCREW 2
77 24100j9151F1 EXTENSION,OFFSET P. 814-813 1 TG.0001--TG.OOO1
81 24100j9151F2 EXTENSION, OFFSET P. 814-813 1 TG.OOO2--
 EXTENSION ASSV, 35'-60' S TORAGE .
24100J8937F3 HARDWARE
TO-OOO 1---
TG-OOO 1 .......

~/'
40

~..

FIG 83 1 -0 1-1 CD (05)

 EXTENSION AsSY
EXTENSION STOR TG.0001--

ITEM PART.NO DESCRIPTION REMARKS (ilTY APPLICABLE

24100J8937F3 EXTENSION ASSY

8 ZP45X20090 PIN 1
9 2'419T3258 SPRING PIN 1
40 2416J1274 BRACKET 1
42 2416P1l530 PAD 1
44 2418P1763301 SHIM 1.6 8
45 2418P1763302 SHIM 3.0 2
46 2420T604301 SHIM 0.7 3
47 2420T604302 SHIM 2.3 1
54 ZS68C12030 CAPSCREw 5
58 2416N4735 BRACKET 1
59 ZS18C12035 BOLT 4
63 ZS18C20040 CAPSCREw 4
67 ZN18C12010 NUT 2
71 2418T13084 WASHER 4
73 ZW16H20000 wASHER 4
76 2420T607901 CAPSCREW 2

(05) 831-01-1 CD
 INSTA L,OFFSET
TO-0001 ,..., 24100J8981F1 • F2
. TG-0001 '"

18

FI G 8 33-02-1(j) (02)
 INSTAL, OFFSET
TG.0001--

ITEM PART .NO DESCRIPTION REMARKS &TV APPLICABLE

24100J8981F1 INSTAL, OFFSET TG.0001--TG.0001

24100J8981F2 TG.0002--

1 24100P2027F1 HOUSING ASSV 2 TG.0001--TG.0001

1- 24100P2027F2 HOUSING ASSV 2 TG.0002--
1-1 2414N3411 HOUSING 1 TG.0001--TG.0001
1-lA 2414N3520 HOUSING 1 TG.0002--
1-2 2405Tl388 BUSHING 1
1-3 2405Tl230 BUSHING 1
I 1 4
1-5
- 2418Tl4576
2417P338
PLATE
SPRING
1
1 i
1-6 2420T5656 BOLT 1 i
1-7 ZN37C08008 NUT 2
1-8 ZP26D10025 PIN, SPRING 1
1-9 ZP26D05025 PIN, SPRING 1
1-10 ZG91S02000 NIPPLE, GREASE 1
2 24100P2028F1 HOUSING ASSV 2 TG.0001--TG.0001
2- 24100p2028F2 HOUSING ASSV 2 TG.0002--
2-1 2414N3412 HOUSING 1 TG.0001--TG.0001
2-1A 2414N3521 HOUSING 1 TG.0002--
2-2 2405T1388 BUSHING 1
2-3 ZG91S02000 NIPPLE, GREASE 1
3 2406P3809 LINK 4
4 2406P3810 LINK 2
5 2419P2522 PIN 4
7 2416Pll782 BRACKET 1
I
8 2416P11783 BRACKET 1
10
12
2416P10402
2418P17692
BRACKET 1 I
COLLAR 2
14 2417T499 SPRING 2
15 ZP26D10100 PIN, SPRING 1
16 2419T4552 PIN 3
17 2419T3258 SPRING PIN 7
1'8 32&1343 DECAL 2 ,

23 ZS18C16120 CAPSCREW 1 I
24 ZN37C16016 NUT 1 I
I
25 ZW16X16000 WASHER 2
26 ZS18C20080 CAPSCREW 2
27 ZN37C20018 NUT 2
28 ZS18C10020 CAPSCREW 4
29 ZW16H10000 WASHER 4

The following parts are not included in this assy. (241OOJ8981)

01 24100P201fFl HOUSING ASSV t. rl:l.uuuJ.--'U.uvvJ.

01- 24100P2017F2 HOUSING ASSV 2 TG.0002--

I
101-1 2414P5580 HOUSING 1 TG.0001--TG.0001
01-lA 2414P6194 HOUSING 1 TG.0002--
01-2 2405Tl388 BUSHING 2
01-3 ZG91S0 000 NIPPLE, GR AS
01 2419P2515 PIN 2 TG.0001--TG.0001
01- 2419P2829 PIN 2 TG.0002--
02 2419P2516 PIN 2 TG.0001--TG.0001
02- 2419P2830 PIN 2 TG.0002--

(02)
 I NSTAL. HOOK & WIRE ROPE
TE-0001- 24100J8030F4.FS
TD-0001-
TG-0001 .....
TH-0001 .....

5.6

3.4

31 33.32

12

13

10.11

5.6

FIG 835-01-1(1) (04)

 INSTAL, HOOK
FOR 3/4 ROPE TG.0001--

ITEM PART.NO DESCRIPTION REMARKS QTy APPLICABLE

24100J8030F4 INSTAL, HOOK

3 8P190 SOCKET 1
4 8T89C2 WEDGE 1
5 2419T4871 PIN 1
6 ZP16D06056 SPLIT PINS 1
7 30Z1D8 CLAMP, ROPE 2
8 2430Z224 WIRE ROPE 1
31 2408R263D157 MAIN ROPE (3/4") 1

24100J8030F5 INSTAL, HOOK

FOR 518 ROPE

S 2419T4871 PIN 1
6 ZP16D060S6 SPLIT PINS 1
10 8P300 SOCKET 1
11 8T97 COTTER 1
12 30Z1D7 CLAMP, ROPE 2
13 2430Z253 ROPE 1
32 2408R287D140 AUX ROPE(3/4") 1
33 2408R301D140 AUX ROPE(S/8") 1

(OJ) 83'5-01-1
 SHEAVE ASSY, AUX.
T 0-0001 ..... 24100J 8680F1
TG-0001 -

1·2

FIG 841-01-1 (i) (02)

 SHEAVE ASSY
TG.0001--

ITEM PART .NO DESCRIPTION REMARK.S 6lTy . APPLICABLE

21t100J8680Fl SHEAVE ASSY

1 2407P784F2 SHEAVE ASSY 1

1-2 2425R188D35 BEARING 1
1-4 ZG91S02000 NIPPLE, GREASE 1
2 21t19T5444Dl PIN 1
3 21t18T14325 SPACER 2
4 21t19T4589 PIN 1
5 21t19T3528 PIN 6
6 2420P210501 CAPSCREw 1
7 ZN37C12011 LOCKNUT 1
8 21t16J1240 BRACKET 1
9 21t19P2457 PIN 2

I
I
I

(02)
 INDEX FOR PART.NO ( CNT500 )

PART.NO PAGE PART.NO PAGE pART.NO PAGE

7707846 38-37 ( 18) 20Z7110513 252-251

18&326 63-01 20Z7110515 301-300
18Z2211 300-01 302-300
( 6) 300-02 302-301
6&238 202-201 301-01 20Z93903 193-03
252-251 18Z2846 63-01 20Z93905 193-03
18Z2853 57-01 20Z1036olS1 202-201
18Z2854 57-01 252-251
( 8) 18Z3193 57-01 20ll0360152 202-201
8P190 835-01 18Z3440 63-01 20Z10360173 252-251
8P300 835-01 18Z3441 63-01 20Zl44904 601-01
8T89C2 835-01 20Zl968 57-01
8T97 835-01 20Z1969 57-01
( 19) 20Z1970 57-01
19Z2Ho15 821-01 20Z2467 63-01
( 10) 824-02 20Z2468 63-01
10Ul33 63-01 19Z274033 53-01
361-01
19Z274035 193-03 ( 25)
( 14) 821-01 25T816010 82-81
14Zl2603 57-01 824-02 25T819010 82-81
14Z391 301-300 19Z274041 193-03 25T82005 202-201
302-300 19Z314 202-201 252-251
302-301 252-251 25Z37 57-01
19Z331 63-01 25Z259082 112-110
25Z280010 113-112
< 15) 25Z377015 113-112
15Z484 202-201 < 20) 25Z494011 27-26
252-251 20&9701 57-01 25Z80703 112-110
15Z518 202-201 20&9704 57-01
252-251 20&9801 57-01
15Z519 202-201 20&9804 57-01 ( 27>
252-251 20&12201 57-01 27U22601 89-01
15Z"l 202-201 20&12301 57-01
252-251 20Z31 H-12
20Z58 57-01 ( 30)
20Z59 57-01 30&58 193-03
( 16) 20Z61 24-12 30llo7 835-01
16&86 89-01 305-304 30Z108 835-01
16&87 89-01 20Z62 305-304
16&95 57-01 20Z63 24-12
16&106 57-01 305-304 ( 32)
16&109 301-300 20Z646048 505-02 32&661 601-01
302-300 20Z711021 202-201 32&1121 601-01
302-301 20Z711024 252-251 3211191 601-01
314-302 20Z711042 252-251 32611195 601-01
16&17402 89-01 20Z711048 37-01 32611196 601-01
20Z711058 202-201 32&1343 814-813
252-251 833-02
( 17) 20Z711072 252-251 32&1345 601-01
17&27 57-01 20Z711078 252-251 32&1349 601-01
nZ8 91-01 20Z711080 202-201 32&1354 161-01
91-01A 20Z711082 202-201 601-01
17Z13 57-01 20Z711083 202-201 32&1445 163-02
20Z711089 202-201 32&1452 601-01
999-1-1
 INDEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

32611453 601-01 36U379S21 78-76 44611289004135 301-300

32611516 601-01 36U379S22 78-76 302-300
3261156901 601-01 36U379S23 78-76 302-301
32611'7001 601-01 36U379S24 78-76 44&1289004140 251-01
32611571 601-01 36U379S25 78-76 44611289004170 201-01
32611573 601-01 36U379S26 78-76 44&1289004178 202-201
32UU79 601-01 36U379S27 78-76 44&1289004240 381-01
32U2357 601-01 36U379S28 78-76 382-02
32U2358 601-01 383-03
32U2879 601-01 384-01t
32Z1162 601-01 < 37) 44611289004340 381-01
32Z1208 601-01 37U131 202-201 382-02
32Z1319 601-01 273-202 383-03
32Zl400 811-01 384-04
813-02 44&1289004590 381-01
32Zl665 97-95 < 38) 382-02
368-361 38Ul07 202-201 44&1289006038 301-300
32Z1781 601-01 252-251 302-300
32Zl786 601-01 270-252 302-301
32Zl787 601-01 44&12890060'+0 93-91
32Z1883 601-01 44&1289006042 92-91
32Z2188 601-01 < 44) 44&1289006045 91-01
32Z2193 601-01 44&1401 202-201 91-01A
32Z2426 601-01 252-251 44&1289006060 201-01
32Z2427 601-01 44612601 37-01 251-01
44612607 71-01 44&1289006080 91-01
4461119205 612-01 91-01"
< 36) 4461120601 612-01 44&1289008022 92-91
3661192 93-91 44&120602 612-01 44&1289008032 92-91
3661329 302-300 44&127601 612-01 44&1289008041 381-01
36R9702 505-02 44&127602 612-01 381-01A
36U27801 362-361 44&127603 612-01 382-02
365-362 44&127604 612-01 382-02A
36U379Fl 76-01 44&127605 612-01 44&1289008070 92-91
78-76 44&1289004012 86-01 44611289008080 91-01
36U379S1 78-76 44611289004017 91-01 91-01"
36U379S2 78-76 91-0lA 44&129001 202-201
36U379S3 78-76 44&1289004035 93-91 252-251
36U379S4 78-76 44&1289004036 302-301 44&129002 86-01
36U379S' 78-76 44611289004040 93-91 91-01
36U379S6 78-76 44&1289004055 302-300 91-01"
36U379S7 78-76 44&1289004061 301-300 202-201
36U379S8 78-76 302-300 252-251
36U379S9 78-76 302-301 301-300
36U379S10 78-76 44&1289004072 301-300 302-300
36U379Sll 78-76 302-300 302-301
36U379S12 78-76 302-301 381-01
36U379S13 78-76 44&1289004075 201-01 381-01"
36U379S14 78-76 251-01 382-02
36U379S15 78-76 44&1289004090 302-300 382-02A
36U379S16 78-76 44&1289004097 302-301 383-03
36U379S17 78-76 4481289004120 301-300 383-03A
36U379S18 78-76 302-300 384-04 '-
36U379S19 78-76 302-301 384-04A
36U379S20 78-76 44&1289004125 252-251 44&129003 91-01

999-1-2
 INOEX FOR PART.NO < CNT500 )

PART .NO PAGE PART.NO PAGE pART .NO PAGE

44&129003 91-01A 44&129106 381-01A 56&4601 95-01A

93-91 382-02 56Rl0l 95-01
301-300 382-02A 95-01A
302-300 44&129107 92-91 56Rl02 95-01
302-301 93-91 95-01A
44&129004 92-91 44&129201 91-01 98-95
93-91 91-01A 56Ul0l 98-95
202-201 302-301 56Ul02 98-95
252-251 44&129202 91-01 56Z40903 98-95
44&129006 92-91 91-01A 56Z40904 98-95
381-01 4461129203 91-01
381-01A 91-01A
382-02 44&129302 301-300 < 17)
382-02A 302-300 77R3701 48-01
44&129101 202-201 302-301
252-251 4461129303 301-300
301-300 302-300 < 79)
302-300 302-301 79&69209 96-95
302-301 44Z1101 32-31 79&692011 96-95
381-01 44Z20806 300-01 79&76001 17-12
382-02 300-02 18-12
44&129102 91-01A 301-01 97-95
93-91 44Z21002 252-251 309-302
202-201 44Z21009 202-201 368-361
252-251 44Z21104 300-01 719.-01
301-300 301-01 730-01
302-300 44Z911011 252-251 79&76002 730-01
302-301 44Z1002038 201-01 79&760011 18-12
311-302 97-95
381-01 368-361
381-01A < 45) 79&760015 730-01
382-02 45Z9102 37-01
382-02A 38-37
383-03 45Z91010 112-110 < 84)
383-03A 45Z91074 27-26 84Z41P\ 722-01
384-04 45Z91084 79-01 84Z52 722-01
384-04A 45Z91091 27-26
44&129103 91-01 45Z910104 71-01
91-01A 45Z910151 112-110 < 87>
92-91 45Z33504 252-251 81Z270 95-01
93-91 95-01A
301-300 98-95
302-300 < 51)
302-301 51U122 202-201
44&129104 93-91 51U123 252-251 < 89)
301-300 89&44 202-201
302-300 252-251
302-301 < 53) 89&80 17-12
44&129105 91-01 53U134 252-251 89U25 309-302
91-01A 53U143 202-201 89Z55701 80-79
301-300 203-202 89Z75401 309-302
302-300
302-301
44&129106 92-91 < 56) < 316)
381-01 56&4601 95-01 316N121 63-01

999-1-3
 INDEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

316P388 282-01 2405R33D1212 408-403 2406P3809 833-02

316T241 282-01 2405R151 51-01 2406P3810 814-813
2405T1161D2 112-110 833-02
2405T1184 112-110 2406P3822 312-300
< 318) 2405T1230 814-813 312-301
318T195 282-01 833-02 2406P3823 14-12
2405T1388 811-01 2406P3824 15-12
814-813 2406R125D2 202-201
< 320) 821-01 252-251
320T80 51-01 833-02 312-300
2405Ul01D1625 304-302 312-301
2405Ul01D1820 12-11 2406R189 88-81
< 329> 2405Ul05D1210 13-12 2406R213D5 312-300
329J62 282-01 14-12 312-301
15-12 2406R215F2 12-01
16-12 12-02
< 1014) 2405Z144 713-01 2406R211 86-01
1014Z1462 202-201 2405Z221 821-01 130-01
252-251 824-02 2406R290 32-31
2405Z222Fl 114-110 2406R296D125 13-12
2405Z222S2 114-110 2406R296D305 13-12
< 1015> 2406R296D332 16-12
1015Z338 202-201 2406R296D335 14-12
252-251 < 2406) 2406R298D1 29-01
1015Z933 202-201 2406N971 403-401 2406R302 91-95 fe'
252-251 2406N1142 62-51 368-361 Iit:;,_ 'f
1015Z934 202-201 2406N1143 58-51 2406R304D585 108-01
252-251 2406P1956 34-32 2406R304D650 108-01
2406P2391 13-12 2406R306 202-201
14-12 252-251
< 1018> 16-12 2406R301D1 15-12
1018Z2139 202-201 161-01 2406R429 88-81
252-251 163-02 2406T2089 113-01
2406P2398D3 15-12 2406T2140 11-01
2406P3164 12-11 143-01
< 2401> 2406P3280 36-01 2406T2191D2 29-01
2401N618 21-26 2406P3303 12-11 2406T2206 12-11
2401N621 112-110 2406P3304 12-11 2406T2214 12-11
2401N622 112-110 2406P3545Dl 713-01 2406T2223 13-12
2401N632 21-26 2406P3545D2 113-01 14-12
2401P953 112-110 2406P3115 161-01 15-12
2401P911 112-110 2406P3130 14-12 16-12
2401P980 112-110 15-12 2406T2511 32-31
2401Pl003 21-26 16-12 2406U130D5Fl 63-01
2401Pl005 21-26 2406P3131 13-12 2406Ul41 88-81
2401Pl006 21-26 2406P3184Dl 202-201 2406Z213 34-32
2401P1029 21-26 252-251 2406Z250 88-81
2401P1030 21-26 2406P3185Dl 109-108 2406Z214 312-300
2401Pl031 21-26 2406P3198 811-01 312-301
2401U1 301-302 813-02 2406Z215 58-51
821-01 2406Z216 58-51
824-02 62-51
< 2405> 2406P3801 163-02 2406Z282 309-302
2405P318 411-403 2406P3808 163-02 2406Z434 91-95
2405P321 401-01 2406P3809 814-813 368-361

999-1-4
 INOEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

3/t-32 2410R130 57-01 < 2411)

2410T299 112-110 2411J3029 403-401
2410T372 112-110 2411J3030 403-401
< 2/t07) 2410U300 69-01 2411J3031 /t03-401
2/t07P783F2 /t11-403 2410U300S1 69-01 2/t11J3032 403-401
2/t07P78/tF2 811-01 2410U300S2 69-01 2411J3177 821-01
813-02 2410U300S3 69-01 824-02
821-01 2410U300S4 69-01 2411J3294 821-01
824-02 2410U300S5 69-01 2411J3295 811-01
841-01 2410U300S6 69-01 813-02
2407P784F3 411-403 2410U300S8 69-01 2411J3333 821-01
2407P793 408-403 2410U300S9 69-01 824-02
2407PS56F1 193-03 2410U300S10 69-01 2411J3334 811-01
2407T146F1 408-403 2410U300S11 69-01 813-02
2407U12 12-11 2410U300S12 69-01
2410U300S13 69-01
2410U300S14 69-01 < 2413)
< 2408) 2410U300S15 69-01 2413J495 112-110
2408R2630157 835-01 2/t10U300S16 69-01 2413J502 113-112
2408R2870140 835-01 2410U300S17 69-01 2413J503 112-110
2408R3010140 835-01 2410U300S18 69-01 2413J519 27-26
2408T270 112-110 2410U300S19 69-01 2413P329 713-01
240SU67 715-01 2410U300S20 69-01 2413P335F1 27-26
2410U300S22 69-01 2413R231F1 64-63
2410U300S23 69-01 2413T374 403-401
< 2410) 2410U301 69-01 409-403
2410J37701 58-57 2410U301S12 69-01 2413T384 821-01
2410J37702 62-57 2410U301S13 69-01 824-02
2410J439 58-57 2410U301S14 69-01 2413T406 821-01
2410J/t/t0 62-57 2410U301S15 69-01 824-02
H10N602 64-63 2410U301S16 69-01 2413T550 709-708
2410N603 67-63 2410U302 69-01 2413U156 351-01
2410P1019 709-708 . 2410U302S1 69-01 352-01
2/t10P1032 27-26 2410U302S2 69-01 2413U156S1 351-01
H10P10/t9 74-72 2410U302S3 69-01 352-01
75-72 2410U302S/t 69-01 2413U156S3 351-01
2/t10R123 307-302 2UOU302S5 69-01 352-01
313-307 2410U302S6 69-01 2413U232 351-01
2410R123s1 313-307 2/tl0U302S7 69-01 352-01
2/t10R123S2 313-307 2410U302S9 69-01 2413Zl19 58-57
2/t10R123S3 313-307 2410U302S10 69-01 62-57
2410R123S/t 313-307 2410U302S11 69-01 24131120 58-57
2/t10R123S5 313-307 2410U302S13 69-01 62-57
2/t10R123S6 313-307 2410U302S14 69-01 2413Z121 307-302
2/t10R123S7 313-307 2410U302S15 69-01 24131633 301-300
2/t10R123S8 313-307 2410U302S16 69-01 302-300
2/t10R123S9 313-307 2410U30303 201-01 302-301
2410R123s10 313-307 2410U30304 251-01
2/t10R123S11 313-307 2410Zl59 58-57
2410R123S12 313-307 62-57 < 2414)
2/t10R123S13 313-307 2410Zl62 62-57 2414J1348 96-95
2/t10R123i;1/t 313-307 2410Z164 58-57 2414J1378 112-110
2410R123s15 313-307 62-57 2/t14J1536 27-26
2/t10R123S91 313-307 241/tJl712 282-01
21t10R123S92 313-307 2414J1721 45-01
 INDEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2414J1722 27-26 2414Zl94012 202-201 2415R298S18 387-381

2414J1737 45-01 2414Zl94014 201-01 2415R298519 387-381
2414N3336 27-26 202-201 2415R298520 387-381
2414N3411 814-813 251-01 2415R298521 387-381
833-02 252-251 2415R298522 387-381
2414N3412 814-813 2414Zl99040 76-01 2415R298523 387-381
833-02 2414Z199060 76-01 2415R298524 387-381
2414N3431 31-01 2414Z250 58-57 2415R298525 387-381
2414N3432 201-01 62-57 2415R298526 387-381
2414N3520 814-813 2414Z251 58-57 2415R298527 387-381
833-02 62-57 2415R29B528 387-381
2414N3521 814-813 2414Z253 307-302 2415R298529 387-381
833-02 2414Z254 307-302 2415R298532 387-381
2414N3542 251-01 2414Z255 74-72 2415R298533 92-91
2414P4441 32-31 75-72 387-381
2414P5239 112-110 2414Z256 74-72 2415R298S35 387-381
2414P5471 45-01 75-72 2415R298536 387-381
2414P5565 80-79 2414Z344 95-01 2415R298537 387-381
2414P5566 282-01 95-0111 2415R298538 387-381
2414P5580 8U-Ol 2414Z345 95-01 2415R298540 387-381
821-01 95-0111 2415T194 U3-112
833-02 2415U179Fl 58-57
2414P5632 :)1-01 59-58
2414P6049 89-01 < 2415) 62-57
2414P6116 80-79 2415P332 113-112 2415Ul79F2 58-57
2414P6194 8U-Ol 2415P333 113-112 59-58
821-01 2415P334 113-112 62-57
833-02 2415P340 113-U2 2415U179RI0l 59-58
2414P6248 56-53 2415R157S18 387-381 2415U179R102 59-58
2414R297 88-87 2415R157S26 21-12 2415U17957 59-58
2414T3117 32-31 310-302 2415U1795U 59-58
2414T3203 32-31 2415R157528 387-381 2415U179512 59-58
2414T3204 32-31 2415R157529 387-381 2415U179513 59-58
2414T3205 32-31 2415R157531 387-381 2415U179515 59-58
2414T3281 708-01 2415R157540 387-381 2415U179516 59-58
2414T3521 12-11 2415R298F1 381-01 2415U179517 59-58
2414T3736 12-11 381-0111 2415U179519 59-58
2414T3742 282-01 382-02 2415U179520 59-58
2414T3777 32-31 382-02A 2415U179528 59-58
2414T3784 12-11 387-381 2415U179529 59-58
2414T3785 12-11 2415R298R110 387-381 2415U1795101 59-58
2414T3786 12-11 2415R29851 387-381 2415U1795102 59-58
2414T3787 12-11 2415R29852 387-381 2415U1795103 59-58
2414T3788 12-U 2415R29854 387-381 2415U1795104 59-58
2414T3789 12-11 2415R29855 387-381 2415U197 113-112
2414T3790 12-11 2415R29856 387-381 2415U271 113-112
2414T3852 361-01 2415R29857 387-381 2415U409Fl 64-63
2414U373Fl 64-63 2415R29858 387-381 67-63
65-64 2415R298510 387-381 2415U410Fl 64-63
2414U374Fl 67-63 2415R298511 387-381 67-63
68-67 2415R298S12 387-381 2415U411F1 64-63
2414H 305-304 2415R2985H 387-381 67-63
2414Z158 304-302 2415R298515 387-381 2415U412F1 64-63
2414Z194D7 96-95 2415R298516 387-381 67-63
2414Zl94D12 96-95 2415R298517 387-381 2415Z264Fl 59-58
 INDEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO

2~UZ26~F2 59-58 2U6 N4662 11-01 2~16P1185~ 282-01

2~15Z268 21-26 2416N~735 811-01 2~16Pl1856 69-01
2~15Z269 27-26 813-02 2416Pl1861 282-01
821-01 2416P11862 282-01
824-02 2416Pl1863 282-01
< 2416) 831-01 2416P1186~ 282-01
2416J1206 409-403 2U6P9058 12-11 2~16P11870 202-201
2416J1240 841-01 2416P9597 12-11 252-251
2416J1273 362-361 2416P9885 12-11 2416Pl1878 201-01
2416J1274 811-01 2U6P9963 12-11 2416p11976 87-86
813-02 2416P10233 408-403 2416P12018 193-03
821-01 2U6Pl0273Dl 11-01 2~16P12133 134-01
824-02 2416P10273D2 11-01 2~16P12174 312-300
831-01 2416P10274 11-01 312-301
2416J1280 301-300 2416P10402 8h-813 2416p12175 312-300
302-300 833-02 312-301
302-301 2416 P 10526 730-01 2416P12319 833-02
2~16J1282 301-300 2416P10694 821-01 2416P12381 251-01
302-300 824-02 2416P12401 283-02
302-301 2U6Pll080 403-401 2~16P12418 252-251
2~16J1292 403-401 2U6Pll081 403-401 2~16P12~19 252-251
2~16J1300 202-201 2416Pl1362 134-01 2416R117 201-01
2416J1301 202-201 2416P1l443 708-01 251-01
2416J1303 282-01 2416P1l447 134-01 2~16R150 201-01
2~16J130~ 12-11 2416Pll530 811-01 2~16R151D2 201-01
2~16J1308 282-01 813-02 2416R151D3 251-01
2416J1310 12-11 821-01 2416R16102 81-79
2~16J1313 193-03 824-02 2~16R163 730-01
2416J1407 252-251 831-01 2416R299 11-01
2416Jh08 252-251 2U6P11603 81-79 2~16R319Fl 6~-63
2~16N3713 409-403 2416Pl1616 57-01 67-63
2416N4343 11-01 2416P1l662 71-01 2~16R320F1 6~-63
2~16N4372 h-12 2416Pl1697 821-01 67-63
15-12 824-02 2416R325Fl ~03-401

16-12 2416P11698 821-01 2416R326F1 403-401

2~16N4373 13-12 824-02 2416R33~ 251-01
2416N4473 282-01 2416P11699 821-01 2~16H189 12-ll
2416N4480 92-91 824-02 2416T6682 53-01
2416N~481 381-01 2416P11700 821-01 282-01
381-01A 824-02 2~16Tl3639 ~8-01

382-02 2416Pl1727 282-01 2~16Tl38~0 12-ll

382-02A 2416Pl1745 312-300 2~16Tl38~~ 12-ll
2416N4495 811-01 312-301 2416T13850 11-01
813-02 2U6Pl1146 312-300 2416Tl3859 12-ll
821-01 312-301 2416Tl3885 143-01
2416N4496 821-01 2416P1l780Fl 163-02 2416Tl400~ 36-01
824-02 2416P11781 833-02 2416Tl4005 36-01
2416N4559 202-201 2416Pl1782 814-813 2416Tl4481D2 13-12
2416N4563 95-01 833-02 14-12
95-01A 2416P11183 814-813 15-12
2416N4569 11-12 833-02 16-12
2416N4517 282-01 2416P11801 161-01 H16Tl4622 403-401
2416N4578 202-201 2416P1l828 53-01 2416T15050 11-01
252-251 2416P11843 202-201 2416T15054 11-01
2~16N4582 301-302 2416P11853 134-01 2416Tl5107 12-11
 INDEX FOR PART.NO (.CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2416T15156 i2-11 ( 2417> 2U8P15275 709-708

143-01 2,+17P238 202-201 713-01
2416T15314 12-11 252-251 2418P15276 110-103
2416T15333 284-01 2,+17P331 713-01 2418P15935 '+03-'+01
284-02 2417P338 814-813 2U8P15936 403-'+01
2416T15449 821-01 833-02 2418P15937 '+03-'+01
824-02 2,+17R131Fl 6'+-63 2'+18P15938 '+03-'+01
2416T16250 713-01 67-63 2'+18P15939 '+11-'+03
2416T16885 833-02 2,+17T287 113-112 2418P15940 403-'+01
2U6T17210 110-103 2,+17T'+99 81'+-813 2418P1712,+ 110-103
2416T17871 821-01 833-02 2,+18P17371 '+03-'+01
82,+-02 2,+17T579 709-708 2'+18P1737601 76-01
2416T18164 39-01 2417T581 '+03-'+01 2418P1737602 76-01
2416T18247 71-01 2417T582 '+03-'+01 2418P17598 28'+-01
2416T18439 202-201 2417T629 27-26 2418P17606 39-01
2U6T18'+67 39-01 2,+17T630 27-26· 2418P1762'+ '+09-'+03
2416T18'+88 92-91 2417T852 87-86 2'+18P1763301 811-01
2416T18'+89 92-91 2,+17T853 87-86 813-02
2416T185'+3 95-01 2,+17Z20'+ 30'+-302 821-01
95-0lA 2U7Z209 7'+-72 82'+-02
2416T18555 95-01 75-72 831-01
95-01A 2'+18P1763302 811-01
2U6T18562 202-201 813-02
2416T18569 301-300 ( 2418) 821-01
302-300 2'+18J3U06 56-53 82'+-02
302-301 2'+18J3'+202 96-95 831-01
2416T18575 37-01 2418N26'+6 '+8-01 2'+18P17665 37-01
2416T18656 163-02 2,+18N2868 13'+-01 2U8P17692 81'+-813
2416T18692 53-01 2'+18N2869 13'+-01 833-02
2416T18693 53-01 2,+18N2870 13'+-01 2'+18P17703 163-02
2416T18767 86-01 2'+18N2871 13'+-01 2'+18P17721 '+9-'+8
282-01 2,+18N2872 13'+-01 2'+18P17731 79-01
2416T18777 202-201 2,+18N287,+ 13'+-01 2U8Pl7732 79-01
2416T18794 381-01 2,+18N2875 13'+-01 2'+18P17733 79-01
382-02 2'+18N2876 13'+-01 2'+18P1773'+ 79-01
383-03 2418N2877 13'+-01 2U8P177'+,+ 110-103
38,+-04 2418N2901 27-26 2418Pl7750 71-01
2416T18817 '+08-403 2'+18N29l'+ 71-01 2418Pl7751 71-01
2416T18865 601-01 2418N2937 39-01 2U8Pl7752 71-01
2416T20763 252-251 2,+1SN2939 163-02 2418Pl7753 71-01
2'+16U3'+ 57-01 2'+18N2957 39-01 2'+18P1775'+ 71-01
2416Z218019 31-01 2'+18N2958 39-01 2'+18Pl7755 71-01
2416Z218031 '+5-01 2418N2961 283-01 2418P17756 71-01
2416Z218032 '+5-01 2418N2962 39-01 2418P17757 71-01
2416Z218033 12-11 2418N2964 13'+-01 2418P17758 71-01
2'+16z218034 12-11 241SN2968 301-01 2'+18P17759 71-01
2U6Z236 12-11 2418N3068 134-01 2'+18P17760 71-01
2U6Z27,+ 282-01 241SN3069 39-01 2'+18P17761 71-01
2U6Z278 58-57 2,+lSN308'+ 27-26 2418P17777 13'+-01
62-57 241SN3096 300-01 2'+18P17778 202-201
2416Z279 58-57 300-02 2'+18Pl7779 202-201
62-" 2418p1480002 76-01 2418P17781 72-01
2416Z2840330 282-01 2418p14S0005 76-01 72-02
2416Z28,+0390 282-01 2418P14802 '+9-'+8 2418P17815 311-302
2,+18P1'+8'+3 27-26 2,+18P17816 202-201
999-1-8
 INOEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2418P17819 201-01 24 18T12933D2 56-53 2418T14927 112-110

2418P17828 110-103 2418T12974 403-401 2418T14982 112-110
2418P17829 110-103 2418T13084 201-01 2418T15512 163-02
2418Pl7130 110-103 202-201 2418T15570 11-01
2418P17832 381-01 251-01 2418Tl5682 13-12
382-02 252-251 14-12
2418Pl7833 383-03 282-01 15-12
384-04 381-01" 16-12
2418P17991 601-01 382-02" 2418T15684 112-110
2418P17992 601-01 811-01 2418Tl5685 112-110
2418P18 0 75 39-01 813-02 2418Tl5736 27-26
2418P18337 202-201 821-01 2418Tl5737 27-26
2418P18420 283-02 824-02 2418Tl5746 709-708
2418P18423 252-251 831-01 2418Tl5794 27-26
2418P1s526 284-02 2418T13207 31-01 2418T15860 53-01
2418P18539 252-251 2418T13263Dl 96-95 2418T15898 12-11
2418P18606 252-251 2418T13264 96-95 2418T15911 12-11
2418Pl8633 72-02 2418Tl3353 252-251 2418Tl5920 57-01
2418P18653 381-0lA 2418T13523 112-110 2418Tl5963 17-12
382-02" 2418Tl3524 112-110 2418T15971 282-01
2418P18654 383-03A 2418T13526 112-110 2418Tl5973 282-01
384-04A 2418T13612 27-26 2418T15975 284-01
2418R2054 411-403 2418Tl3669 730-01 284-02
2418R5075 27-26 2418Tl3752 32-31 2418T16014 821-01
2418R14604 89-01 2418T1425902 12-11 824-02
2418R317 49-48 301-300· 2418Tl6049 47-01
2418R325 11-01 302-300 2418Tl6060 202-201
2418R457Fl 64-63 302-301 252-251
2418T748 401-01 2418T14325 811-01 2418T16065 201-01
2418T3084 381-01 813-02 251-01
382-02 821-01 2418Tl6111 401-01
2418T448703 27-26 824-02 2418Tl6148 113-112
2418T5373C2 11-01 841-01 2418Tl6168 134-01
31-01 2418T14359Dl 403-401 2418T16169 202-201
39-01 2418T1435902 403-401 2418Tl6174 282-01
45-01 2418T1451601 201-01 2418T16186 201-01
134-01 251-01 2418Tl6187 282-01
201-01 2418T14525 27-26 2418Tl6194 12-11
202-201 2418T14530 113-112 2418T16197 304-302
251-01 2418T14533 112-110 2418T16198 304-302
252-251 2418T14545 27-26 2418T16210 201-01
403-401 2418T14565 821-01 251-01
2418T7743 27-26 824-02 2418T16216 403-401
2418T7994 201-01 2418T14566 821-01 2418T16217 403-401
251-01 824-02 2418T16218 110-103
2418T9088D2 81-79 2418T1456701 821-01 2418Tl6228 113-112
134-01 824-02 2418T16466 284-02
283-01 2418Tl4568Dl 821-01 2418T16471 251-01
283-02 824-02 24181J112D78 363-362
2418T9138 86-01 2418T14568D2 821-01 2418U131D27 404-403
282-01 824-02 406-403
2418T9241 282-01 2418T14576 814-813 2418Z30 24-12
2418T9847 112-110 833-02 305-304
2418T9848 27-26 2418T14773 730-01 2418Z889 58-57
2418T12803 713-01 2418TH774 730-01 62-57
999-1-9
 JNDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2U81890 58-57 2419P2830 833-02 < 2420>

(,2-57 H19Rl0Fl 58-57 2420N458D04065 77-76
2U8Z891 58-57 62-57 2420N458006018 40-39
62-57 2419T3237 282-01 2420N458D06020 111-110
2U8Z892 58-57 2419T3258 53-01 2420N458D06040 111-110
62-57 193-03 2420N458D06065 111-110
2418Z893 58-57 282-01 2420N458D08016 403-401
62-57 361-01 2420N458D08020 77-76
2418Z894 58-57 403-401 403-401
62-57 411-403 2420N458D08035 37-01
2U8Z896 58-57 811-01 2420N458D08050 37-01
62-57 S13-02 2420N458D08060 403-401
2U8Z897 58-57 811t-813 2420N458008065 53-01
62-57 821-01 2420N458008070 77-76
2U8Z902 74-72 824-02 2420N458D10030 71-01
75-72 831-01 76-01
2418Z928 58-57 833-02 201-01
62-57 2419T3528 841-01 251-01
2418Z929 58-57 2419T4199D2 713-01 403-401
62-57 241974216 304-302 505-02
2U8Z972 57-01 2419T4524 821-01 2420N458010035 37-01
2418Z973 57-01 824-02 39-01
241974552 814-813 71-01
833-02 134-01
< 2419> 24191457002 411-403 2420N458010040 412-403
2U9J144 411-403 2419T4589 841-01 2420N458010055 403-401
,J
,t
2U9N152 163-02 24197459002 811-01 2420N458010065 39-01 "
2U9P2255 821-01 813-02 71-01
824-02 821-01 2420N458010070 403-401
2U9P2367 401-01 824-02 2420N458010090 505-02
2U9P2369 401-01 2419T48 4 O 821-01 2420N458010100 403-401
2U9P2371 403-401 S24-02 2420N458010110 403-401
2419P2372 403-401 2U9T4877 835-01 412-403
2U9P2434 161-01 2419T5100 411-403 2420N458012025 403-401
2419P2457 841-01 2419T5227 821-01 2420N458012030 114-110
2U9P2469 505-02 824-02 2420N458012035 71-01
2U9P24S1 193-03 2419T5228 193-03 134-01
2419P2515 811-01 2419T5260 53-01 412-403
8H-813 H19T544401 841-01 2420N458012045 71-01
821-01 2419T544402 811-01 2420N458D120S0 114-110
833-02 813-02 2420N458016045 115-114
2U9P2516 811-01 821-01 2420N458016055 84-81
814-813 824-02 2420N458D16070 404-403
821-01 2419Z17501 403-401 406-403
833-02 2419Z176 58-57 2420N458018055 83-81
2U9P2522 8H-813 62-57 2420P1925 80-79
833-02 2419Z177 58-57 2420P206401 49-48
2U9P2532 193-03 62-57 2420P2064D2 49-48
2419P2829 811-01 2419Z178 58-57 2420P2064D3 49-48
8H-813 62-57 2420P2066Dl 49-48
821-01 2419Z179 58-57 2420P2105D1 811-01
833-02 62-57 813-02
2U9P2830 811-01 2419Zl80 58-57 821-01
814-813 62-57 824-02
821-01 841-01
999-1-10
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE pART .NO PAGE

2420P212501 401-01 2420R524 0 04014 79-01 2420T554906 12-11

2420P212502 401-01 2420R524006014 79-01 2420T554907 301-300
2420P212601 403-401 2420R681Fl 58-57 302-300
2420P212602 403-401 62-57 302-301
2420P212701 403-401 2420R681F2 58-57 2420T5656 814-813
2420P212702 403-401 62-57 833-02
2420P212801 403-401 2420R73602 163-02 2420T5691 69-01
2420P217203 202-201 2420R74705 601-01 2420T5692 69-01
2420P217204 252-251 2420R747043 403-401 2420T583501 11-01
2420P2176 312-300 811-01 2420T583502 11-01
312-301 813-02 2420T5892 57-01
2420P2183 252-251 821-01 2420T592101 27-26
2420P2185 282-01 824-02 2420T592102 27-26
2420P2187 300-01 2420R76902 134-01 2420T592103 27-26
301-01 2420R81202 134-01 2420T592104 27-26
2420P2188 300-01 2420R82803 37-01 2420T592201 27-26
300-02 2420R839 51-01 2420T592202 27-26
301-01 2420R84203 202-201 24201592203 27-26
2420P2369 87-86 252-251 2420T592204 27-26
2420P2388 300-02 2420R911Fl 135-134 2420T594401 27-26
2420R18902 95-01 2420R912Fl 135-134 2420T594402 27-26
95-0lA 2420R91251 73-72 2420T594403 27-26
2420R18903 719-01 2420R914Fl 135-134 242015975 63-01
723-01 2420R916Fl 135-134 2420T6006 709-708
2420R18906 86-01 2420R918F1 38-37 2420T6010 202-201
730-01 2420R919Fl 38-37 2420T6024 92-91
2420R18908 730-01 2420T227702 403-401 2420T6042 821-01
2420R189012 32-31 2420T2277010 12-11 824-02
2420R189013 12-11 2420T258903 202-201 2420T604301 811-01
2420R189015 302-301 252-251 813-02
2420R189017 301-300 2420T384507 719-01 821-01
302-300 2420T3845011 719-01 824-02
2420R3720122 12-11 2420T3845015 719-01 831-01
2420R3720124 12-11 242014039012 26-01 2420T604302 811-01
2420R42901 17-12 2420T5146 713-01 813-02
2420R42905 12-11 2420T520903 12-11 821-01
32-31 2420T520904 143-01 824-02
309-302 2420T5267 252-251 831-01
2420R429014 32-31 2420T529405 163-02 2420T607701 53-01
2420R429015 17-12 2420T532301 112-110 2420T607702 53-01
18-12 2420T532302 708-01 2420T607901 811-01
2420R429016 17-12 713-01 813-02
2420R429017 32-31 2420T532401 112-110 821-01
301-300 2420T532402 112-110 824-02
302-300 2420T532403 112-110 831-01
302-301 2420T5355 409-403 2420T608301 58-57
2420R48601 708-01 2420T5420 113-112 2420T608302 62-57
2420R48602 163-02 2420T542201 31-01 2420T608303 58-57
2420R48607 161-01 2420T542202 31-01 2420T608304 62-57
2420R486010 202-201 2420T5464 92-91 2420T6093 37-01
252-251 2420T546501 29-01 2420T6094 300-01
2420R50201 26-01 2420T550402 709-708 300-02
2420R524002012 72-02 242015526 163-02 301-01
2420R524002014 72-01 2420T5529 284-01 2420T6167 202-201
72-02 284-02 2420T616703 252-251
 INDEx FOR PART.N.O < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2420T6174 39-01 < 2422) 2427J2153 282-01

2420T6244 252-251 2422J2336 51-01 2427J2154 282-01
2420U116F2 88-87 2422J2338 51-01 2427J21,5 282-01
2420Z37 305-304 2422J2423 29-01 2427J2192 88-87
2420Z666D1 17-12 2422P934 192-02 2427J2202 80-79
2420Z681 312-300 193-03 2427J2221 301-300
312-301 2422U13 191-01 302-300
2420Z829 202-201 192-02 2427J2223 282-01
2420Z1156 58-57 2422U141 193-03 2427N2234 32-31
62-57 2427N2458 282-01
2420Z1157 58-57 2427P2373 12-11
62-57 < 2423) 2427P2481 32-31
2420Z1159 58-57 2423J537 112-110 2427P2482 34-32
62-57 2427P2712 201-01
2420Z1160 58-57 251-01
62-57 < 2425) 2427P2716 361-01
2420Z1164 58-57 2425J262 112-110 2427R216D1 32-31
62-57 2425J264 112-110 2427R216D7 32-31
2420Z1167 307-302 2425J272 112-110 2427R216D22 87-86
2420Z1172 58-57 2425R188D35 811-01 2427R216D51 87-86
62-57 813-02 2427R555D2 301-300
2420Z1173D2 58-57 821-01 302-300
62-57 824-02 302-301
2420Z1175 58-57 841-01 2427R576D1 92-91
62-57 2425R188D36 411-403 2427R576D2 92-91
2420Z1176 58-57 2425R201 300-01 2427R580 32-31
62-57 300-02 2427R767F1 303-302
2420Z1177 58-57 301-01 2427R777 284-02
62-57 312-300 2427R808 284-01
2420Z1178 58-57 312-301 2427T1202 32-31
62-57 2425R202D6 27-26 2427T1220 31-01
2420Z1541D3 730-01 2425U190 113-112 2427T1272 47-01
2420Z1562 58-57 2425Z252 24-12 2427T1424 32-31
62-57 2425Z394D4 709-708 2427U286F1 32-31
2420Z1564 58-57 2425Z490 27-26 33-32
62-57 2425Z491 58-57 2427U286S1 33-32
2420Z1596 307-302 62-57 2427U286S2 33-32
2420Z168001 252-251 2425Z492 58-57 2427U286S3 33-32
2420Zl686 87-86 62-57 2427U286S4 33-32
2420Zl794 307-302 2425Z579 112-110 2427U286S5 33-32
2420Z1801D1 201-01 2425Z583 112-110 2427U286S6 33-32
251-01 2425Z585 112-110 2427U286S7 33-32
2420Z1801D2 201-01 2425Z587D9 27-26 2427U286S8 33-32
251-01 2425Z591 27-26 2427U286S9 33-32
2427U286S10 33-32
2427U286S11 33-32
< 2421> < 2427> 2427U286S12 33-32
2421Z61D2 611-01 2427J2135 34-32 2427U286S13 33-32
2421Z6104 611-01 2427J2137 32-31 2427U286S14 33-32
2421Z6105 611-01 2427J2147 282-01 2427U361F1 87-86
2421Z377 611-01 2427J2148 282-01 2427U483 86-01
612-01 2427J2149 282-01 2427U495 31-01
2427J2150 282-01 2427X288 87-86
2427J2151 282-01 2427Z368 282-01
2427J2152 282-01 2427H26D3 88-87
999-1-12
 INOEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2427Z42707 88-87 2432R135 202-201 2432Z29004 11-01

2427Z42708 88-87 2432R14601 284-01 37-01
2427Z428 88-87 284-02 53-01
2427Z47302 32-31 2432R17301 202-201 89-01
2427Z660 87-86 2432R181012 283-01 91-01
2427Z661 87-86 283-02 91-01A
2427Z662 88-87 2432R181014 283-01 95-01
2427Z663 87-86 2432R181016 283-01 95-01A
2427Z664 87-86 2432R181017 283-02 134-01
2427Z685 32-31 2432Rl81021 283-02 143-01
2427Z686 32-31 2432R18501 601-01 201-01
2427Z687 32-31 2432R18502 601-01 202-201
2427Z693 34-32 2432R18503 601-01 251-01
2427Z71201 32-31 2432R18504 601-01 252-251
2427Z71202 32-31 2432R18505 601-01 300-01
2427Z71203 32-31 2432R18506 601-01 300-02
2427Z71204 32-31 2432R18507 601-01 301-01
2427Z71205 32-31 2432R191 361-01 362-361
2427Z71206 32-31 2432R192 601-01 381-01
2432T1393 11-01 381-01A
2432T1976 601-01 382-02
< 2429) 2432T1977 601-01 382-02A
2429J381 53-01 2432T2842 47-01 383-03
2429R311Fl 821-01 2432T2902 72-01 383-03A
824-02 76-01 384-04
2429R316 403-401 2432T2920 143-01 384-04A
2429R317 403-401 2432T3093 403-401 2432Z29005 72-01
2429R318 403-401 811-01 72-02
2429R319F1 403-401 813-02 301-01
2429R32001 403-401 821-01 2432Z309 95-01
2429R32002 403-401 824-02 95-01A
2429R321 403-401 2432T3384 76-01 2432Z30901 301-300
2429R322Fl 403-401 2432T3408 301-300 302-300
2429R324 403-401 302-300 302-301
2429T430 821-01 302-301 2432Z49902 71-01
824-02 2432T3435 301-300 2432Z52301 601-01
2429Z8 24-12 302-300 2432Z523010 601-01
2429Z375 282-01 302-301 2432Z523011 601-01
2432T3436 301-300 2432Z534 47-01
302-300 719-01
< 2430) 302-301 2432Z538 730-01
243 0R12708 12-11 2432T3710 601-01 2432Z547 303-302
2430R29803 403-401 2432T3892 612-01 2432Z551 303-302
2430Z224 835-01 2432U373 201-01 2432Z552 303-302
2430Z253 835-01 2432U375 251-01
2432Z16207 283-01
2432Z16208 283-02 < 2436)
< 2432) 2432Z220015 12-11 2436R201 92-91
2432J1801 309-302 2432Z290 708-01 93-91
2432P93304 71-01 2432Z29001 12-11 301-300
2432Pl171 601-01 98-95 302-300
2432P1310 12-11 2432Z29002 86-01 302-301
2432P1404Fl 284-01 2432Z29003 91-01 2436R392F5 201-01
2432P1441 612-01 301-300 251-01
2432P1442 612-01 302-300 2436R593S14 38-37

999-1-13
 INDEX FOR F'ART.NO < CNT500 )

F'ART.NO F'AGE F'ART.NO F'AGE F'ART.NO F'AGE

2436R718511 38-37 2436R1311F1 38-37 2436U525554 271-252

135-134 2436R131151 38-37 2436U525561 271-252
2436R1050514 135-134 2436R131154 38-37 2436U525563 271-252
2436R105158 135-134 2436R1312F1 38-37 2436U525566 271-252
2436R105159 135-134 2436R1312R100 38-37 2436U525567 271-252
2436R1060 301-300 2436R131251 38-37 2436U525568 271-252
302-300 2436R131252 38-37 2436U525581 271-252
302-301 2436R1313F1 38-37 2436U525582 271-252
308-302 2436R1314 73-72 2436U52558'+ 271-252
2436R1060R101 308-302 2436U159 301-300 2436U525586 271-252
2436R106051 308-302 302-300 2436U525587 271-252
2436R106052 308-302 302-301 2436U525588 271-252
2436R106054 308-302 2436U281511 38-37 2436U525589 271-252
2436R106055 308-302 2436U291525 135-134 2436U525590 271-252
2436R106056 308-302 2436U291526 135-134 2436U525591 271-252
2436R106057 308-302 2436U291527 135-134 2436U525599 271-252
2436R106058 308-302 2436U291531 135-134 2436U5255110 271-252
2436R106059 308-302 2436U338516 38-37 2436U5255111 271-252
2436R1060511 308-302 2436U38855 135-134 2436U5255115 271-252
2436R1062021 37-01 2436U388518 135-134 2436U5255116 271-252
2436R1069F2 40-39 2436U388525 135-134 2436U52551'+3 271-252
2436R1069F4 40-39 2436U4835879 40-39 2436U5255159 271-252
2436R1094512 135-134 2436U525 202-201 2436U618513 135-134
2436R1094513 135-134 252-251 2436U618528 38-37
2436R1094517 135-134 271-252 2436U690541 21-12
2436R1095F1 38-37 2436U525R101 271-252 310-302
2436R1161511 117-115. 2436U525R102 271-252 2436U690542 21-12
2436R1194F1 77-76 2436U525R103 271-252 310-302
2436Rl194510 77-76 2436U525R104 271-252 2436U690555 21-12
2436R1224 301-300 2436U52552 271-252 92-91
302-300 2436U52555 271-252 310-302
302-301 2436U52556 271-252 2436U79956 135-134
2436R1226F1 37-01 2436U52557 271-252 2436U80053 21-12
2436R122802 351-01 2436U52558 271-252 310-302
352-01 2436U52559 271-252 2436U804533 21-12
2436R1300Fl 135-134 2436U525510 271-252 310-302
2436R130051 135-134 2436U525511 271-252 2436U804535 21-12
2436R1304F1 135-134 2436U525512 271-252 310-302
2436R1305F1 135-134 2436U525513 271-252 2436U804537 387-381
2436R130653 135-134 2436U525514 271-252 2436U804538 387-381
2436R130654 135-134 2436U525515 271-252 2436U81953 308-302
2436R130655 135-134 2436U525516 271-252 2436U819510 308-302
2436R130658 135-134 2.36U525518 271-252 2436U98901F2 39-01
2436R1307Fl 135-134 2436U525521 271-252 2436U1000517 77-76
2436R1307R110 135-134 2436U525529 271-252 111-110
2436R130751 135-134 2436U525530 271-252 2436U1000530 77-76
2436R130752 135-1 34 2436U525539 271-252 2436U1027588 135-134
2436R130755 135-134 2436U5255.0 271-252 2436U10275212 135-134
2436R130756 135- 1 34 2436U525541 271-252 2436U1078511 111-110
2436R130758 135-134 2436U525545 271-252 2436U10795551 40-39
2436R130759 135-134 2436U525549 271-252 2436U110851 38-37
2436R1308F1 135-134 2436U525550 271-252 135-134
2436R1308R110 135-134 2436U525551 271-252 2436U110853 38-37
2436R130851 135-134 2436U525552 271-252 135-134
2436R1310F2 40-39 2436U525553 271-252 2436U110856 38-37
999-1-14
 INDEx FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE pART.NO PAGE

2436U1116S11 364-362 2436U1602S35 77-76 2436U1631S23 21-12

2436U1116S14 364-362 2436U1602S37 77-76 310-302
2436U11 1 9S26 21-12 2436U1602S39 77-76 2436U1631S24 21-12
310-302 2436U1628F1 53-01 310-302
2436U11 1 9S29 21-12 362-361 2436U1631S25 21-12
310-302 364-362 310-302
21-12 2436U1628 R110 364-362 2436U1631S27 21-12
310-302 2436U1628S1 364-362 310-302
21-12 2436U1628S2 364-362 2436U1631S28 21_12
310-302 2436U1628S18 364-362 2436U1631S29 21-12
2436U11 1 9S32 21-12 2436U1628S21 364-362 310-302
310-302 2436U1631F1 12-11 2436U1631S31 21-12
2436U1192S28 135-134 21-12 2436U1631S32 21-12
2436U1325S15 271-252 2436U1631F2 301-300 2436U1631S33 21-12
2436U1325S16 271-252 302-300 2436U1631S38 21-12
2436U1476F2 12-11 302-301 310-302
20-12 310-302 2436U1672F1 12-11
2436U1476R110 20-12 2436U1631R101 21-12 92-91
2436U1476S2 20-12 310-302 2436U1673F1 403-401
2436U1476S3 20-12 2436U1631R102 21-12 2436U1691S28 115-114
2436U1476S4 20-12 310-302 2436U1691S31 119-117
2436U1476S6 20-12 21-12 2436 U1691S32 115-114
2436U1476S7 20-12 310-302 2436U1692S28 119-117
2436U1476S10 20-12 2436U1631S2 21-12 2436U1695S4 118-117
2436U1537S511 40-39 310-302 2436U1695S9 118-117
2436U1591s2 38-37 2436U1631S3 21-12 2436U1695S14 77-76
2436U1591S4 38-37 310-302 2436U1695S15 118-117
2436U1595F1 72-02 2436U1631S4 21-12 119-117
73-72 310-302 2436U1707S12 135-134
2436U1595S1 73-72 2436U1631S5 21-12 2436U1752S154 40-39
2436U1595S2 73-72 310-302 2436U1792F1 412-403
2436U1595S3 73-72 2436U1631S6 21-12 2436U1792S10 412-403
2436U1595S5 73-72 310-302 2436U1792S16 412-403
2436U1602F2 76-01 2436U1631S7 21-12 2436U1792S17 412-403
77-76 310-302 2436U1793Fl 412-403
2436U1602R100 77-76 2436U1631S8 21-12 2436U1793R110 412-403
2436U1602S1 77-76 310-302 2436U1793S1 412-403
2436U1602S2 77-76 2436U1631S9 21-12 2436U1793S2 412-403
2436U1602S3 77-76 310-302 2436U1793S3 412-403
2436U16 0 2S4 77-76 2436U1631S10 21-12 2436U1793S4 412-403
2436U1602S6 77-76 310-302 2436U1793S5 412-403
2436U1602S7 77-76 2436U1631S12 21-12 2436U1793S6 412-403
2436U1602S8 77-76 310-302 2436U1793S7 412-403
2436U1602S9 77-76 2436U1631S13 21-12 2436U1794Fl 412-403
2436U1602S10 77-76 310-302 2436U1794S41 412-403
2436U1602S11 77-76 21-12 2436U1794S42 412-403
2436U1602S12 77-76 310-302 2436U1794S43 412-403
2436U1602S13 77-76 2436U1631S16 21-12 2436U1794S45 412-403
2436U1602S14 77-76 310-302 2436U1794S46 412-403
2436U1602S15 77-76 2436U1631S17 21-12 2436U1794S47 412-403
2436U1602S16 77-76 310-302 2436U1794S48 412-403
2436U1602S17 77-76 2436U1631S18 21-12 2436U1794S49 412-403
2436U1602S24 77-76 310-302 2436U1794S50 412-403
2436U1602S26 77-76 2436U1631S22 21-12 2436U1794S54 412-403
2436U1602S27 77-76 310-302 2436U1794S58 412-403
 INDEx FOR PART.NO < CNT500 )

PART.NO pAGE PAGE PART.NO PAGE

2.36U1794560 U2-.03 2436U1932520 117-115 2.36U1971541 135-13.

2.36U1809F1 110-103 2436U1932521 117-115 2.36U19715.3 135-13.
111-110 2436U1956522 135-134 2.36U1971547 135-134
2.36U1809R110 111-110 2.36U1960 304-302 2436U1971553 135-134
2436U180951 111-110 305-30. 2.36U1971554 135-134
2436U180952 111-110 2436U196051 305-304 2436U1971555 135-134
2436U180953 111-110 2.36U196052 305-304 2436U1971556 135-134
2436U18095. 111-110 2.36U196053 305-304 2.36U1971558 135-134
2436U180955 111-110 2436U196055 305-304 2.36U1971559 135-134
2436U180956 lil-110 2.36U196059 305-304 2436U1971560 135-134
. 2.36U180957 111-110 2.36U1960512 305-304 2.36U1973 92-91
2436U180951. 111-110 2.36U1960515 305-304 2436U1973R10l 92-91
2.36U1809515 111-110 2.36U1960520 305-30. 2436U197351 92-91
2436U1809516 111-110 2.36U19655105 .0-39 2436U197352 92-91
2436U1816F1 li7-115 2.36U196551U 40-39 2.36U197353 92-91
118-117 2.36U19655123 .0-39 2.36U197354 92-91
2.36U1816R100 118-117 2.36U19655h9 .0-39 2436U197355 92-91
2436U1816R110 118-117 2.36u19655202 40-39 2436U197356 92-91
2.36U18.3523 .12-.03 2.36U19655203 ·0-39 2.36U197358 92-91
2436U18.3526 U2-.03 2436U19655208 .0-39 2436U197359 92-91
2436U185251 118-117 2436U19655231 ·0-39 2.36U1973510 92-91
2.36U18525. 118-117 2.36U19655264 40-39 2.36U1973511 92-91
2.36U1852560 118-117 2436U19655305 40-39 2.36U1973512 92-91
2436U1852571 118-117 2436u19655321 40-39 2.36U19HFl lh-110
2.36U18525105 118-117 2436U19655322 .0-39 2436U1975F1 39-01
2436U18525128 118-117 2436U19655323 .0-39 40-39
2436U18525129 118-117 2436U19655331 40-39 2436U1975Rl00 40-39
2436U18525152 118-117 2.36u19655332 40-39 2.36U19755232 40-39
2.36U18525302 118-117 2.36U19655333 .0-39 2436U19755304 40-39
2.36U186257 115-1h 2.36U1965533. .0-39 2436U19755401 40-39
2.36U18HF1 13.-01 2.36U19655335 .0-39 2436U19755873 40-39
2436U1929F1 362-361 2436U19655371 .0-39 2436U1982F1 117-115
2436U1930F1 362-361 2436U19655372 .0-39 119-117
2.36U1931F1 115-1h 2.36U19655521 .0-39 2.36U198251 119-117
2.36U193153 115-1h 2436U1966F2 37-01 2436U198253 119-117
2.36U193156 115-114 38-37 2436U2056F1 78-76
2.36U193159 115-1h 13.-01 2436U2056R110 78-76
2436U1931515 115-1h 135-13. 2.36U2069F1 119-117
2.36U1931516 115-1h 2436U1971R110 135-134 2.36U2069R100 119-117
2436U1931517 115-114 2436U197159 135-13. 2436U206951 119-117
2436U1931519 115-1h 2.36U1971511 135-134 2.36U206952 119-117
2436U1931526 115-1h 2436U1971513 135-13. 2436U206953 119-117
2436U1931527 115-1h 2.36U19715h 135-134 2436U206954 119-117
2436U1932F1 115-1h 2436U1971515 135-134 2436U206955 119-117
117-115 2.36U1971516 135-134 2.36U206956 119-117
2436U1932R100 117-115 2436U1971518 135-134 2436U206957 119-117
2436U193252 117-115 2436U1971525 135-134 2436U206959 119-117
2436U193253 117-115 2.36U1971526 135-13. 2436U2069510 119-117
2436U19325. 117-115 2.36U1971527 135-134 2436U2069511 119-117
2436U193255 117-115 2436U1971528 135-13. 2.36U2069519 119-117
2.36U193257 117-115 2436U1971531 135-134 2.36U2069520 119-117
2436U193258 117-115 2436U1971532 135-13. 2436U2069521 119-117
2436U1932512 117-115 2436U1971533 135-134 2.36U2069522 119-117
2436U1932514 117-115 2436U1971538 135-134 2436X11 49-48
2436U1932519 117-115 2.36U1971539 135-134 2436X14 49-48
 INDEX FOR P"RT.NO < CNT500 )

PART.NO PAGE P"RT.NO PAGE P"RT.NO PAGE

381-01 2438U856S16 61-57 2438U1296F2 12-11

381-01A 2438U882S26 506-505 24-12
383-03 2438U1249S34 506-505 2438U1296RllO 24-12
383-03A 2438U1249S35 506-505 2438U1296S1 24-12
2436Z370 202-201 2438U1249S36 506-505 2438U1296S3 24-12
252-251 2438U1250S2 305-304 2438U1296S7 24-12
351-01 2438U1250S4 305-304 2438U1296S8 24-12
352-01 2438U1250S6 24-12 2438U1296S9 24-12
2438U1250S9 305-304 2438U1311S2 66-64
2438U1250S10 24-12 2438U1311S3 66-64
< 2437> 305-304 2438U1311S4 66-64
2437R126 730-01 2438U1250S11 24-12 2438U1311S6 66-64
2438U1257F2 362-361 2438U1311S7 66-64
363-362 2438U1311S8 66-64
< 2438) 2438U1257R110 363-362 2438U1311S9 66-64
2438J185 27-26 2438U1257R120 363-362 2438U1311S10 66-64
2438R7S16 27-26 2438U1257S1 363-362 2438U1311S11 66-64
2438R219 58-57 2438U1257S2 363-362 2438U1311S14 66-64
60-58 2438U1257S3 363-362 2438U1311S15 66-64
62-57 2438U1257S4 363-362 2438U1311S16 66-64
2438R219s1 . 60-58 2438U1257S5 363-362 2438U1311S17 66-64
2438R219S2 60-58 2438U1257S8 363-362 2438U1311S18 66-64
2438R219S3 60-58 2438U1257S9 363-362 2438U1311S20 66-64
2438R219S4 60-58 2438U1257S10 363-362 2438U1311S21 66-64
2438R219S5 60-58 2438U1257S12 363-362 2438U1311S22 66-64
2438R219S6 60-58 2438U1257S16 363-362 2438U1311S26 66-64
2438R219S7 60-58 2438U1257S18 363-362 2438.U1311S27 66-64
2438R219S8 60-58 2438U1258S14 404-403 2438U1311S28 66-64
2438R219S9 60-58 406-403 2438U1314F2 505-02
2438R219S10 60-58 2438U1258S23 404-403 506-505
2438R219S11 60-58 406-403 2438U1314R100 506-505
2438U181-30 54-53 2438U1280S7 506-505 2438U1314RllO 506-505
2438U321S15 363-362 2438U1280S8 506-505 2438U1314S1 506-505
2438U334S16 54-53 2438U1280S9 506-505 2438U1314S2 506-505
2438U339S34 506-50' 2438U1280S10 506-505 2438U1314S4 506-505
2438U353S10 404-403 2438U1280S34 506-505 2438U1314S5 506-505
406-403 2438U1280S37 506-505 2438U1315F1 403-401
2438U368S16 363-362 2438U1282S24 404-403 404-403
2438U402S13 404-403 406-403 2438U1315R100 404-403
406-403 2438U1289F1 57-01 406-403
2438U402S18 404-403 61-57 2438U1315RllO 404-403
406-403 2438U1289R101 61-57 406-403
2438U433S18 61-57 2438U1289S1 61-57 2438U1315S1 404-403
2438U506S18 54-53 214e8U1289S2 61-57 2438U1315S2 404-403
2438U558S7 404-403 2438U1289S3 61-57 406-403
406-403 2438U1289S6 61-57 2438U1315S3 404-403
2438U558S8 404-403 2438U1289S7 61-57 406-403
406-403 2438U1289S8 61-57 2438U1315S7 404-403
2438U765S21 506-505 2438U1289S9 61-57 406-403
2438U765S22 506-505 2438U1289S10 61-57 2438U1315S8 404-403
2438U819s20 305-304 2438U1289S12 61-57 406-403
2438U842S16 404-403 2438U1289S14 61-57 2438U1315S9 404-403
406-403 2438U1289S15 61-57 406-403
2438U856S4 61-57 2438U1289S16 61-57 2438U1315S11 404-403
2438U856S5 61-57 2438U1291S16 61-57 406-403

999-1-17
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

2438U1315S12 404-403 < 2441> 2441U658S31 116-115

406-403 2441U404S106 111-115 2441U658S33 115-114
2438U1315S21 404-403 2441U432S20 116-115 2441U658S46 115-114
406-403 2441U432S28 115-114 2441U661S17 17-16
2438U1315S23 404-403 2441U432S29 115-114 2441U678F1 81-19
406-403 2441U466S1 84-81 83-81
2438U1315S25 404-403 2441U466S2 84-81 2441U618R110 83-81
406-403 2441U466S9 84-81 2441U678S1 83-81
2438U1316F1 403-401 2441U466S10 84-81 2441U678S2 83-81
406-403 2441U466S11 84-81 2441U678S3 83-81
2438U1316S1 406-403 2441U466S12 84-81 2441U678S4 83-81
2438U1317F3 53-01 2441U466S13 84-81 2441U618S5 83-81
54-53 2441U466S14 84-81 2441U618S6 83-81
2438U1317R100 54-53 2441U466S16 84-81 2441U618S7 83-81
2438U1317R110 54-53 2441U466S22 83-81 2441U618S8 83-81
2438U1317S1 54-53 84-81 2441U678S9 83-81
2438U1317S3 54-53 2441U466S23 83-81 2441U618S10 83-81
2438U1317S4 54-53 2441U466S24 84-81 2441U678S11 83-81
2438U1311S7 54-53 2441U466S25 84-81 2441U678S12 83-81
2438U1311S8 54-53 2441U598S22 135-134 2441U618S13 83-81
2438U1311S10 54-53 2441U611S32 17-76 2441U618S14 83-81
2438U1311S13 54-53 2441U634S2 84-81 2441U678S15 83-81
2438U1311S15 54-53 2441U634S5 84-81 2441U618S16 83-81
2438U1311S16 54-53 2441U634S1 84-81 2441U618S18 83-81
2438U1672F1 64-63 2441U635F1 252-251 2441U618S22 83-81
66-64 212-252 2441U678S25 83-81
61-63 2441U635S1 272-252 2441U120S48 115-114
2438U1672F2 64-63 2441U635S2 212-252 2441U120S49 115-114
66-64 2441U635S3 212-252 117-115
61-63 2441U635S4 212-252 2441U129S162 40-39
2438U1672R100 66-64 2441U635S5 272-252 2441U132S461 40-39
2438U1672S1 66-64 2441U635S6 212-252 2441U849F1 81-79
2438U1672S5 66-64 2441U635S7 212-252 84-81
2438U1672S12 66-64 2441U635S8 272-252 2441U849R110 84-81
2438U1672S13 66-64 2441U635S9 272-252 . 2441U849S3 84-81
2438U1672S19 66-64 2441U635S10 212-252 2441U849S6 84-81
2438U1672S25 66-64 2441U635S11 212-252 2441U849S23 84-81
2441U635S12 212-252 2441U852F1 1B-114
2441U635S13 212-252 116-115
< 2439> 2441U635S14 212-252 2441U852S1 116-115
2439N261 113-112 2441U635S16 272-252 2441U852S2 116-115
2439P158D6 56-53 2441U643S321 119-117 2441U852S4 116-115
2439P159 56-53 2441U658S2 115-114 2441U852S5 116-115
2439P250 112-110 2441U658S3 111-115 2441U852S19 116-115
2439P255 21-26 2441U658S12 116-115 2441U852S29 116-115
2439P256 21-26 2441U658S14 116-115 2441U852S40 116-115
2439T117 56-53 2441U658S17 116-115 2441U854F1 26-01
2441U658S18 116-115 28-26
2441U658S20 116-115 2441U854R100 28-26
< 2440> 2441U658S21 116-115 2441U854R110 28-26
2440P113 403-401 2441U658S25 116-115 2441U854S1 28-26
2440P178 403-401 2441U658S27 116-115 2441U854S2 28-26
2440P184 505-02 2441U658S28 116-115 2441U854S3 28-26
2441U658S29 116-115 2441U854S4 28-26
2441U658S30 116-115 2441U854S5 28-26
999-1-18
 INDEX FOR PART.NO < CNT500 >
PART.NO PAGE PART.NO PAGE PART .NO PAGE

2,+41085'+S6 28-26 2,+,+,+R719D12 381-01 2'+'+4R1475D4 201-01

2441U854S7 28-26 381-01A 2444R1475D7 251-01
2441U854S8 28-26 382-02 2444R147602 201-01
2441U854S9 28-26 382-02A 251-01
2441U854S10 28-26 383-03 2444R1484 252-251
2441U854S11 28-26 383-03A 2444R148501 13'+-01
2441U854S12 28-26 384-04 2444R1488F1 11'+-110
2441U854S13 28-26 381+-04A 2'+I+'+R1488S1 114-110
2441U85I+S14 28-26 241+4R720012 202-201 21+44R1564 201-01
2441U854s15 28-26 21+1+4R720013 252-251 241+I+R156S 201-01
2441U851+S16 28-26 2441+R71+001 202-201 2441+R1573 251-01
2441U854s21 28-26 252-251 21+44R1575D1 71-01
2441U854S23 28-26 381-01 21+44T957C1 91-01
2441U854S24 28-26 382-02 91-01A
2441U854s25 28-26 383-03 2444Tl075 202-201
2,+41U868F1 110-103 38'+-04 2444Tl101 202-201
114-110 2444R74002 93-91 2444Tl320 53-01
21+41U869F1 114-110 202-201 21+1+I+Tl734 202-201
115-111+ 252-251 241+4Tl869 301-300
2,+41U869S5 115-114 302-300 302-300
241+4RHOO3 202-201 302-301
252-251 21+41+Tl971 37-01
( 21+1+4) 21+1+I+RHOOl+ 202-201 21+44T2768 300-01
241+4J103 91-01 2HI+R816D2 505-02 300-02
241+I+J132 91-0lA 241+I+R833D1 37-01 301-01
21+1+4N182 37-01 39-01 21+1+1+T2855 72-02
241+I+P1085D1 37-01 76-01 362-361
21+1+I+P1097 37-01 134-01 241+4T3349 201-01
2444P1103 403-401 21+1+I+R1310 303-302 251-01
21+1+4P1257 37-01 241+1+R1314 1+03-401 2444T3409 76-01
2441+P127009 91-01 21+1+I+R1314R100 403-1+01 241+'+T3487 361-01
91-01A 21+1+1+R1314S1 403-1+01 241+4T3488 76-01
21+1+4P1270014 91-01 241+4R1314S2 403-401 2441+T3490 361-01
91-0lA 2H4R1314S3 1+03-1+01 241+1+T31+91 361-01
241+4P1291 91-01 21+41+R1314S4 403-401 2441+T3500 201-01
91-01A 24HR1314S5 1+03-401 251-01
21+44P1380 202-201 2441+R1314S6 1+03-1+01 2444T3502 91-01
21+41+P1609 252-251 2444R1314S7 403-1+01 91-01A
2444R388D5 37-01 2444R1326S2 38-37 2444T3507 202-201
71-01 2444R1344D2 71-01 252-251
76-01 2444R1348D3 76-01 2444T3518 110-103
2444R389D5 37-01 362-361 2444T3529 37-01
76-01 2444R137506 37-01 2444T3534 300-01
2444R399D6 37-01 2444R1426D1 403-401 300-02
241+4R40208 37-01 2444R142701 1+03-401 301-01
2444R40907 80-79 2444R143301 505-02 2444Z80803 202-201
2444R59603 362-361 2444R1441D2 71-01 252-251
2444R596D6 201-01 2444R144202 71-01 2444Z80804 202-201
251-01 2H4R1442D3 71-01 2444Zl14002 91-01
2444R59703 361-01 2444R1443D1 71-01 91-01A
2'+44R639D3 300-01 2444R1457D3 362-361 2444Z1hOO3 202-201
300-02 2444R1460D2 71-01 252-251
301-01 2444R1463D2 37-01 2444ZlhOO5 300-01
2444R719012 202-201 2444R147301 76-01 300-02
252-251 2444R1475D3 201-01 301-01
999-1-19
 INOEx FOR PART.NO ( CNT500 )

PART .NO PAGE PART.NO PAGE PART.NO PAGE

2444Z1l1tOO7 72-01 ( 2445> 2448U122 302-300

72-02 2445P1l4025 51-01 302-301
24441123302 201-01 2445P1l4026 51-01 2448U122F1 12-11
251-01 2445R152017 49-48 301-300
244411290 24-12 2445R257D1 56-53 2448U130 301-300
244411291 24-12 2445R27101 56-53 302-300
2444Z141103 283-01 2445R274 307-302 302-301
2444Z141207 283-01 2445R275 49-48 2448U131F1 12-11
2444Z141209 283-02 2445R276F1 49-48 301-300
2444Z1580 381-01 2445T146 13-12 302-300
381-0lA 14-12 302-301
383-03 15-12 2448U13151 12-11
383-03A 16-12 301-300
2444Z160007 283-02 2445Z705 361-01 302-300
2444Z1665037 251-01 2445Z706 76-01 302-301
2444Z1665D44 201-01 202-201 2448U13152 12-11
2444Z174801 612-01 362-361 301-300
2444Z2227 303-302 2445Z708 38-37 302-300
2444Z2576 303-302 135-134 302-301
2444Z2627 37-01 2445Z8 24-12 2448U131511 12-11
39-01 2445Z1033 56-53 301-300
76-01 2445Z104503 112-110 302-300
134-01 2445Z106101 27-26 302-301
2444Z2654047 91-01 2445Z106102 27-26
2444Z2654060 . 91-0lA
.1
2444Z2654078 91-01 ( 2450) .~

91-01A ( 2446) 2450R124 283-02

2444Z2654082 91-01 2446P8F1 49-48 2450U4F2 202-201
91-01A 2446R103014 283-01 252-251
2444Z2654D88 91-01 2446R103019 283-02 2450U6F1 80-79
91-01A 2446T104 112-110
2444Z2654D96 91-01 2446U198F3 80-79
91-0lA 2446U19859 80-79 ( 2452)
2444Z2685 37-01 2446U198510 80-79 2452U13255 201-01
2444Z2695 134-01 2446U198511 80-79 251-01
2444Z2719080 201-01 2446U198512 80-79 2452U13658 201-01
2444Z27190110 251-01 2446U198513 80-79 251-01
2444Z272904 505-02 2446U198514 80-79 2452U20555 201-01
2444Z2736 37-01 2446U198515 80-79 251-01
2444Z273903 72-02 2446U198516 80-79 2452U437 201-01
2444Z276402 300-01 2446U198517 80-79 251-01
300-02 2446U198520 80-79 2452U43751 201-01
301-01 2446U207F1 80-79 251-01
2444Z2764D3 300-02 2446Z12604 283-01 2452U43752 201-01
2444Z276501 303-302 2446Z12605 283-02 251-01
2444Z276502 303-302 2452U43753 201-01
244U2772 303-302 251-01
2444Z2773 303-302 ( 2447) 2452U43754 201-01
2444Z277501 303-302 2447U5 723-01 251-01
2444Z2781 72-01 2452U43755 201-01
72-02 251-01
2444Z2800 lio-l03 ( 2448) 2452U43;59 201-01
2444Z2801 201-01 244SU116Fl 301-300 251-01
2444Z3122 251-01 302-300
2444Z3171 251-01 302-301
999-1-20
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

< 2~5~> 2~79J284 202-201 2479U458 252-251

2~5~U32 351-01 2479J286 95-01 2479U466S1 612-01
2~5~U32S1 351-01 2479J358 202-201 2479U47602 80-79
2~5~U33 352-01 2479J360 95-01.1. 2~79U51~ 721-01
245~U33S1 352-01 2479J362 252-251 2~79U515D5 721-01
2~5~U36 351-01 2479J364 47-01 2479U515D7 721-01
2~5~U36S1 351-01 2479N332 18-12 2~79U599 86-01
2454U36S2 351-01 2479N333 18-12 730-01
2454U36S3 351-01 2479N334 18-12 2479U636 17-12
352-01 2479N352 32-31 309-302
2454U36S4 351-01 2~79N425 17-12 2~79U641 89-01
352-01 2~79N426 17-12 2479U658 307-302
2454U39 352-01 2479N427 17-12 2479Z290 86-01
245~U39S1 352-01 2~79N~28 17-12 95-01
2~5~U39S2 352-01 2479N432 18-12 95-01.1.
2479N487 98-95 2479Z32~ 301-300
2479P802D2 719-01 302-300
< 2~56> 2479P802D~ 719-01 302-301
2456R8021 730-01 2479P804 96-95 2479Z325 301-300
2~56R12302 719-01 2479P817D8 201-01 302-300
2456R15103 730-01 251-01 302-301
2456R152 32-31 2479P817D9 201-01 2~79Z44~ 311-302
2456R152S1 32-31 251-01 2~79Z4~5S1 612-01
612-01 2479P926 95-01 2479Z956 309-302
2456R156F1 36-01 95-01.1. 2~79Z1167 311-302
86-01 2479P1168 730-01 2~79Z1175F1 719-01
282-01 2479P1177D1 201-01 2~79Z117605 612-01
2456R185 86-01 251-01 719-01
2456R186 95-01 2479R284 96-95 2~79Z1176010 612-01
95-01.1. 2479R425 96-95 2479Zl178 17-12
2456U3F2 719-01 2479R610 17-12 2479Z1199 32-31
2456U3S1 719-01 309-302 2~79Z1218 32-31
2456U23 95-01 2479R651 309-302 2~79Z1361 309-302
95-01.1. 2479R708 309-302 2479Zl362 309-302
2~56U24 95-01 247~R731D1 96-95
95-01.1. 2479R73102 311-302
2456U25F1 98-95 2479R838F2 12-11 < 2~80>
2456U25F2 98-95 143-01 2~80P1F1 303-302
2~56Z214 36-01 2479R875 32-31
282-01 2479R934 34-32
2456Z290 95-01 2~79R1040 309-302 < 2~83>
95-01.1. 2479R1058 309-302 2~83R117S3 364-362
98-95 2479R1067 730-01 2~83R156S11 364-362
2456Z368 309-302 2479R1102F1 202-201 2~83R193S3 364-362
2456Z384 95-01 252-251 2~83U156S1~ 364-362
95-01.1. 2479713200212 11-01 2~83U252S2 364-362
2456Z385 95-01 247971327 719-01 2~83u252S5 364-362
95-01.1. 2~7971330 96-95 2~83U283S~ 135-134
2456Z386 309-302 247971663 202-201 2483U283S9 135-134
247971771 'H-01 2~83U283S11 135-134
2479U229 730-01 2~83U301S3 364-362
< 2479> 2479U240F1 12-11 2~83U302F2 ~03-401
2479J269 17-12 2479U240F2 12-11 412-403
2479J282 18-12 2479U457F2 309-302
2479J2S3 47-01 2479U458 202-201
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART .NO PAGE

< 2488> <24100> 24100J8161F4 51-01

2488R114 86-01 24100J2390F6 611-01 62-51
130-01 24100J1201F6 53-01 24100J8168F1 51-01
2488Z1 130-01 56-53 24100J8168F2 51-01
2488Z8D3 130-01 24100J1501F6 48-01 24100J8838F3 103-01
24100J1628F5 31-01 24100J8838F4 101-03
32-31 24100J8848F2 11-01
< 2489> 24100J1967F2 36-01 12-11
2489R380 12-11 24100J8030F4 835-01 24100J8852F4 19-01
2489U119F1 11-12 24100J8030F5 835-01 80-19
309-302 24100J8031F2 130-01 24100J8815F1 719-01
2489U189 11-12 24100J8053Fl 130-01 24100J8881F2 191-01
309-302 24100J8148F3 112-110 24100J8881F3 192-02
2489U190 11-12 113-112 24100J8882F1 361-01
309-302 24100J8148RI00 113-112 362-361
2489U191 11-12 24100J8216F1 63-01 24100J8909F2 284-01
309-302 64-63 24100J8935F2 12-11
2489Z243 80-19 24100J8211Fl 63-01 11-12
67-63 24100J8937F3 831-01
24100J8341F3 103-01 24100J8931F5 821-01
< 3481> 107-03 24100J8931F6 824-02
3487Z3902 11-12 110-103 24100J8931F7 821-01
18-12 24100J8441F2 403-401 24100J8937F8 824-02
130-01 409-403 24100J8942F1 301-01
3487Z3903 39-01 24100J8414F3 401-01 302-301
41-01 24100J8414F4 401-01 24100J8942F2 300-01 ~:-
134-01 24100J8565Fl 403-401 301-300
'j:\
119-01 411-403 24100J8942F3 300-02
730-01 24100J8565F2 403-401 302-300
411-403 24100J8945F2 301-01
24100J8584F4 29-01 24100J8941F2 95-01
< 4006> 24100J8621F2 161-01 95-01A
4006Z14 282-01 24100J8616F6 12-11 98-95
14-12 24100J8954F1 91-01
143-01 91-01A
< 4056) 24100J8676F7 12-11 93-91
4056R4 86-01 16-12 24100J8951F1 91-01
4056R4F1 86-01 24100J8676F8 12-11 91-01A
4056Z19D1 86-01 13-12 92-91
95-01 24100J8676FI0 12-11 24100J8968Fl 301-300
95-0lA 15-12 302-300
4056Z2002 309-302 24100J8680Fl 841-01 302-301
24100J8102F2 505-02 309-302
24100J8124F~ 45-01 24100J8969Fl 163-02
< 4019) 24100J8133F2 26-01 24100J8980F2 811-01
4019Z22 11-12 24100J8134F3 26-01 24100J8980F3 813-02
21-26 24100J8980F4 811-01
24100J8134RI00 27-26 24100J8980F5 813-02
<24015> 24100J8734RII0 21-26 24100J8981F1 833-02
24015U3655 59-58 24100J8167F1 51-01 24100J8981F2 833-02
58-51 24100J8982Fl 108-01
24100J8161F2 57-01 24100J8982F2 10a-Ol
<24038> 62-51 24100J8994F4 39-01
24038Z16Fl 56-53 24100J8161F3 51-01 24100J9001Fl 53-01
24038Zl7Fl 56-53 58-51 24100J9002Fl 11-01

999-1-22
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

24100J9008Fl 79-01 24100J9086S11 59-58 24100N4706Fl 351-01

24100J9008F2 79-01 24100J9086S19 59-58 24100N4706F2 352-01
24100J9009F1 79-01 24100J9086S29 59-58 241 00N4706F3 351-01
81-79 24100J9086S30 59-58 24100N4706F4 352-01
24100J9009F2 79-01 24100J9086S32 59-58 24100P1418F2 12-11
81-79 24100J9086S33 59-58 143-01
24100J9011F1 89-01 24100J9151F1 813-02 24100P1422F1 730-01
24100J9012F1 361-01 814-813 24100P1480F1 403-401
24100J9012F2 361-01 824-02 24100P1513F2 715-01
24100J9018F2 110-103 24100J9151F2 813-02 24100P1883F2 811-01
24100J9020Fl 76-01 814-813 813-02
24100J9021F1 282-01 824-02 821-01
24100J9021F2 282-01 24100J9286F4 31-01 824-02
24100J9022F1 57-01 24100J93HF1 95-01A 24100P1883F3 403-401
24100J9023F1 63-01 24100J9376Fl 251-01 24100P2017Fl 811-01
24100J9024F1 69-01 24100J9377F2 284-02 821-01
24100J902'F1 72-01 24100J9379F1 283-02 833-02
24100J9027F1 95-01 24100J941 4F1 251-01 24100P2017F2 811-01
24100J9028F1 91-01 252-251 821-01
24100J9029F1 201-01 24100J9416F1 381-01A 833-02
24100J9030F1 201-01 24100J9416F2 382-02A 24100P2022F2 723-01
202-201 24100J9416F3 383-03A 24100P2027Fl 814-813
24100J9030F2 201-01 24100J9416F4 384-04A 833-02
202-201 24100J9417F1 72-02 24100P2027F2 814-813
24100J9032F1 283-01 24100J944 4 F2 300-01 833-02
24100J9034F1 301-01 24100J9444F4 300-02 24100P2028Fl 814-813
312-300 24100J9455F1 91-01A 833-02
312-301 24100N3618F4 32-31 24100P2028F2 814-813
24100J9034F2 300-01 34-32 833-02
300-02 24100N3875F5 612-01 24100P2034Fl 37-01
312-300 24100N3897F2 403-401 24100P2038Fl 301-300
312-301 408-403 302-300
24100J9036Fl 381-01 24100N4245F1 713-01 302-301
24100J9036F2 382-02 24100N4246F3 708-01 311-302
24100J9036F3 383-03 709-708 24100P2055F1 361-01
24100J9036F4 384-04 24100N4326Fl 51-01 24100P2055F2 361-01
24100J9039F1 134-01 24100N4536F3 26-01 24100P2144Fl 39-01
24100J9039F2 134-01 24100N4603F1 301-300 24100R43 301-300
24100J9043F1 12-11 302-300 302-300
18-12 302-301 302-301
24100J9045F1 11-01 24100N4608F2 730-01 24100T369Fl 32-31
24100J9045F2 14.3-01 24100N4638Fl 721-01 24100U157 301-300
24100J9051F1 37-01 24100N4638F2 721-01 302-300
24100J9053F1 730-01 24100N4639Fl 821-01 302-301
24100J9059F1 47-01 824-02 24100U305S4 114-110
24100J9059F2 47-01 24100N4645F2 722-01 24100U334S31 59-58
24100J9069F1 193-03 24100N4645F3 722-01 24100U448S16 115-114
24100J9069F2 193-03 24100N4678F1 351-01 117-115
24100J9084F1 601-01 24100N4678F2 352-01 24100U463S16 404-403
24100J9085F1 601-01 24100N4690Fl 72-01 406-403
24100J9086S3 59-58 72-02 24100U466F2 362-361
24100J9086S4 59-58 74-72 24100U521F4 409-403
24100J9086S5 '9-58 24100N4691Fl 72-01 410-403
24100J9086S6 59-58 72-02 24100U521S1 410-403
24100J9086S10 59-58 75-72 24100U521S2 410-403
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE ' PART .NO PAGE

241OOU521S3 410-403 24100U607S9 116-115 24800N253F1 303-302

2UOOU521S4 410-403 24100U607S10 116-115 24800N254F1 86-01
2UOOU521S5 410-403 24100U607S12 116-115 24800X207F4 86-01
241OOU521S6 410-403 24100U607S13 116-1H 87-86
241OOU521S7 410-403 24100U607S18 116-115
241OOU521S8 410-403 24100U607S21 116-115
241OOU521S11 410-403 24100U607S23 116-115 <24806>
24100U521S12 410-403 24100U642S16 82-81 24806P226 304-302
241OOU521S13 410-403 24100U642S19 82-81 24806P227 304-302
241OOU521S14 410-403 24100U643F1 81-79 24806Tl88 202-201
24100U521S15 410-403 82-81 252-251
24100U521S16 410-403 24100U643F2 81-79 24806Tl89 202-201
2UOOU521S17 410-403 82-81
24100U521S18 410-403 24100X2247F4 110-103
24100U521S19 410-403 112-110 <24810>
24100U521S20 410-403 24100X2247R100 112-110 24810P34 57-01
24100U521S21 410-403 24100X2247R110 112-110 24810P34F1 57-01
24100U521S22 410-403 24100X2247R120 112-110 24810T18 57-01
241OOU521S23 410-403 24100X2309F3 48-01
241OOU521S27 410-403 49-48
241OOU521S39 410-403 24100X2385F3 401-01 <24814>
241OOU521S40 410-403 403-401 24814J63 97-95
24100U527S1 82-81 24100X2385F4 401-01 24814J64 368-361
241OOU527S2 82-81 403-401 24814P224 88-87
241OOU527S3 82-81 24814T37 381-01
241OOU527S4 82-81 381-01A
241OOU527S5 82-81 <24800> 38·3-03
241OOU527S6 82-81 24800J522F3 87-86 383-03A
241OOU527S8 82-81 88-87
241OOU527S10 82-81 24800J540F1 301-300
241OOU527S11 82-81 302-300 <24816)
24100U527S13 82-81 302-301 24816N318 202-201
241OOU527S14 82-81 304-302 24816P832 304-302
241OOU527S15 82-81 24800J565F3 86-01 24816P854 57-01
241OOU527S17 82-81 24800J635Fl 95-01 24816P854F1 57-01
241OOU527S18 82-81 95-01A 24816P860 86-01
241OOU527S20 82-81 96-95 24816P874 93-91
241OOU527S27 82-81 24800J638F1 361-01 24816P903 69-01
241OOU527S28 82-81 368-361 24816Tl158 87-86
241OOU527S29 82-81 24800J639Fl 95-01 24816Tl528 202-201
241OOU527S30 82-81 95-01A 252-251
241OOU527S31 82-81 97-95
241OOU527S35 82-81 24800J639F2 95-01
241OOU527S36 82-81 95-014 <24818)
24100U527S37 82-81 97-95 24818N164 88-87
241OOU527S39 82-81 24800J641F1 301-300 24818Nl74 202-201
24100U560F1 403-401 302-300 252-251
24100U561F1 403-401 302-301 24818P1466 202-201
24100U562F3 53-01 307-302 24818Tl089 307-302
241OOU587S4 82-81 24800N252F1 301-300
241OOU587S5 82-81 302-300
241OOU587S12 82-81 302-301 <24819)
241OOU587S34 82-81 2480ON253Fl 301-300 24819T163 ,----' -
87-86
241OOU587S43 82-81 302-300 24819T197D3 53-01
24100U607S4 115-114 302-301 24819T202 53-01
999-1-24
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE pART .NO PAGE

24819T202 361-01 <24870> R25P0045D2 27-26

24870R1 81-86 R25P0045D3 27-26
24870R2 81-86 R27T0006D13 32-31
<24820) 24870R3 81-86 R27T0006D25 34-32
24820P139D2 58-57 24870R4 87-86 R27T0006D38 32-31
62-57 24870R5 87-86 R27T0006D42 32-31
24820T312 202-201 24870R6 87-86 R27T0006D7 32-31
24820T313 300-01 24870R7 87-86 R27T0058D190 87-86
301-01 R27T0058D215 87-86
24820T314 300-01 R27T0058D235 87-86
301-01 <24879) R27T0058D367 87-86
24820T320 202-201 24879J25 309-302 R38KOO05 301-300
24879N19 96-95 302-300
24879N20 309-302 302-301
<24827> 24879N21 96-95 306-302
24827Jl71 302-301 24879N22D1 97-95 R38KOO05E1 306-302
24827J172 302-301 24879N22D2 97-95 R38K0005E10 306-302
24879P15 86-01 R38K0005Ell 306-302
24879P16 301-300 R38KOO05E12 306-302
<24829) 302-300 R38KOO05E13 306-302
24829N107 53-01 302-301 R38KOO05E14 306-302
361-01 24879p17 301-300 R38KOO05E2 306-302
24829P85 53-01 302-300 R38KOO05E5 306-302
302-301 R38KOO05E6 306-302
24879P20 301-300 R38KOO05E7 306-302
<24832) 302-300 R38KOO05E9 306-302
24832N17 97-95 302-301 R38NOO01 91-01
24832N18 97-95 24879P21 368-361 91-014
24832N19 368-361 24879T17 368-361 93-91
24832T250 74-72 24879T18 97-95 R38NOO13 86-01
75-72 R38NOO14 311-302
24832T252 202-201 R38POO09D1 92-91
252-251 . B1 6T0039 722-01 R38POO09D2 12-11
24832T264 307-302 B16T0040 722-01 381-01
B16TOO41 722-01 381-01A
B36KOO19E212 38-37 382-02
<24838) 135-134 382-02A
24838U32S16 54-53 B36KOO19E219 38-37 R38POOllD3 301-300
B36KOO19E220 38-37 302-300
B36KOO19E221 38-37 302-301
<24844> B36KOO19E222 38-37 R38T0001D3 92-91
21t844T94 300-01 B36KOO19E223 38-37 R44P0078SIt 80-79
300-02 R16P0036019 134-01 R44T0204 612-01
301-01 R16T015208 301-300 R45P0050013 404-403
24844T9802 72-01 302-300 406-403
72-02 302-301 R45P0051027 404-403
24844T9901 72-01 R16T025907 505-02 406-403
72-02 R20P0043 39-01 R51POO05 283-01
R20T0084013 722-01 R79POO07F2 18-12
R20T0084014 722-01 R79POO07S3 612-01
<24846) R2 5NOO03022 56-53 R79P0022 730-01
24846R2F1 80-79 R2'POO09041 713-01 R79P0042011 201-01
R2'POO09049 34-32 2,1-01
282-01 R79P0060F1 18-12
R2'POO3506 27-26 97-95

999-1-2'
 INOEx FOR PART.NO < CNT500 )

PART.NO PAGE PART .NO PAGE PART.NO PAGE

R79P0060Fl 309-302 ZC45X12011 95-01A ZC45X38014 505-02

368-361 ZC45x14011 37-01 ZC45X46014 76-01
R79P0060F3 17-12 202-201 91-01A
309-302 312-300 ZC45X50014 39-01
R79T004801 612-01 312-301 71-01
R79T004806 98-95 719-01 72-01
612-01 ZC45X16011 95-0lA 72-02
R79T004807 17-12 202-201 91-01
97-95 252-251 91-01A
309-302 ZC45x19011 47-01 ZC47X06007 91-01
R79TOO7204 311-302 53-01 ZC47X08009 708-01
ZC15X01500 201-01 91-01 ZC47X14011 95-01A
251-01 91-01A 201-01
ZC15X02300 303-302 381-01 ZC47X18011 251-01
ZC15X02600 300-01 381-0lA ZC47X20014 72-01
300-02 382-02 72-02
3i>1-01 382-021. 91-01
ZC15X03300 201-01 383-03 91-01A
251-01 383-03A ZC47X22014 37-01
ZC15X05000 72-01 384-04 201-01
72-02 384-04A 251-01
201-01 ZC45x22011 71-01 ZC47X24014 76-01
ZC15X06000 79-01 72-01 301-01
201-01 95-01 Z011G02500 117-115
251-01 95-01A ZOl1G03000 77-76
ZC15X08000 79-01 134-01 . 119-117
ZC15X09000 307-302 201-01 ZOl1G04500 82-81
ZC15Xl0500 307-302 202-201 ZD11G09500 27-26
ZC17C08020 95-01 252-251 ZDllG12500 27-26
ZC26X28014 71-01 302-300 ZD11G14000 27-26
ZC26X32014 71-01 ZC45X25011 37-01 ZDllG18500 110-103
ZC26X35016 71-01 47-01 ZDllG20000 80-79
ZC26x38016 71-01 76-01 ZDllP00700 77-76
72-01 301-01 ZD11P00800 49-48
72-02 301-300 ZD11P01090 20-12
ZC27X28012 134-01 302-300 ZDllP01200 77-76
ZC27X35014 39-01 302-301 ZDllP01400 91-01
134-01 361-01 91-01A
ZC27X43014 39-01 ZC45X29011 11-01 119-117
134-01 37-01 364-362
ZC37X35114 134-01 95-01A ZDllP01600 115-114
ZC37X43114 134-01 ZC45X31014 71-01 ZD11P01800 91-01
ZC45X06007 95-0lA 72-02 91-01A
ZC45X08007 47-01 134-01 112-110
300-01 301-01 ZDllP02900 112-110
300-02 505-02 ZD11P04400 80-79
301-01 ZC45X38014 37-01 ZD12G03500 114-110
ZC45X10009 110-103 71-01 305-304
301-300 91-01 ZD12G06500 61-57
302-301 91-0lA ZD12G08000 363-362
ZC45Xl1009 708-01 201-01 ZD12G08500 54-53
ZC45X12011 11-01 381-01 ZD12G11000 404-403
12-11 382-02 406-403
91-01A 383-03 ZD12G11500 112-110
95-01 384-04 363-362
999-1-26
 INOEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

Z012G12500 54-53 Z0 12P03200 412-403 ZE72T04000 301-300

363-362 Z012P03400 37-01 302-300
Z012G13500 54-53 39-01 302-301
Z012G15500 404-403 71-01 410-403
406-403 76-01 ZE72X04000 27-26
Z012G19000 506-505 134-01 39-01
Z012P00300 117-115 201-01 112-110
. Z012P00700 119-117 251-01 ZE72X06000 11-01
Z012P01000 40-39 403-401 37-01
Z012P01100 39-01 505-02 134-01
77-76 Z012P03800 39-01 ZE72X08000 134-01
110-103 40-39 361-01
612-01 49-48 ZE72X12000 72-01
Z012P01200 117-115 71-01 134-01
Z012P01400 53-01 134-01 ZE82T02000 27-26
72-01 252-251 37-01
72-02 Z012 P 04800 71-01 112-110
117-115 79-01 364-362
362-361 134-01 410-403
364-362 Z012P05300 56-53 412-403
612-01 Z012P06200 56-53 ZE82T04000 27-26
Z012P01500 20-12 Z012P13000 506-505 54-53
Z012P01600 40-39 Z021T03500 27-26 92-91
364-362 Z021T14000 112-110 134-01
Z012P01800 40-39 Z021T17000 27-26 201-01
71-01 Z075G08000 363-362. 251-01
72-02 Z075G08500 54-53 363-362
80-79 Z075P02900 112-110 383-03A
110-103 Z075P13000 506-505 384-04A
361-01 Z085G12500 27-26 403-401
362-361 Z085G14000 27-26 412-403
612-01 Z085P01600 40-39 ZE82T06000 412-403
Z012P02100 77-76 364-362 ZE82T08000 27-26
Z012P02200 40-39 Z085P01800 40-39 82-81
111-110 Z085P05300 56-53 92-91
364-362 Z095P01090 20-12 112-110
403-401 Z095P01400 364-362 412-403
404-403 ZE12X12000 403-401 ZE82T12000 27-26
406-403 ZE12X16000 37-01 LE91T12000 27-26
412-403 39-01 ZF23F10004 110-103
Z012P02240 72-02 71-01 ZF23F28012 134-01
252-251 76-01 ZF33F10004 110-103
612-01 134-01 ZF33F28012 134-01
Z012P02400 49-48 201-01 ZG15F04500 134-01
134-01 251-01 ZG21808004 12-11
Z012P02500 56-53 505-02 ZG22806004 93-91
Z012P02600 40-39 ZE12X20000 39-01 301-300
403-401 71-01 302-300
412-403 134-01 302-301
Z012P02900 49-48 ZE12X24000 71-01 ZG22808004 382-02
201-01 79-01 382-02A
251-01 134-01 384-04
612-01 ZE12X32000 79-01 384-04A
Z012P03000 40-39 ZE72T04000 80-79 ZG22808006 92-91
117-115 93-91 93-91

999-1-27
 INDEX FOR PART.NO ( CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

ZG22E04000 9.3-91 ZG52UQ4000 91-01A ZH31K0aOOa 12-11

301-300 301-300 ZH31M06006 11-01
302-300 302-300 ZH31MOaOOa 11-01
302-301 302-301 ZH32W04000 37-01
ZG22E04002 301-300 ZG52U06000 93-91 ZH32WOaoOO 76-01
302-300 301-300 ZH32X04000 37-01
302-301 302-300 ZH32X04006 37-01
ZG22E06000 93-91 302-301 134-01
301-300 ZG52UOaOOO 12-11 ZH32X06000 72-01
302-300 92-91 72-02
302-301 93-91 ZH32X0600a 72-02
ZG22EOaOOO 12-11 ZG91S02000 49-48 ZH32X08000 37-01
92-91 57-01 71-01
612-01 58-57 134-01
ZG22E08004 92-91 62-57 362-361
381-01 69-01 ZH32X12000 252-251
381-014 161-01 ZH42W08000 76-01
383-03 163-02 ZH42X08000 80-79
383-03A 404-403 ZH52F08000 76-01
ZG22E08006 93-91 406-403 ZH52X08000 134-01
612-01 all-01 362-361
ZG22E12008 381-01 813-02 ZJ11F06042 11-01
381-014 814-813 ZM11C06012 31-01
382-02 821-01 47-01
382-02A 824-02 730-01
383-03 833-02 ZM11C06014
/<
32-31
:E
383-03A 841-01 34-32 ".
384-04 ZG91S04000 505-02 ZM11C06016 12-11
384-04A 506-505 282-01
ZG22U04000 202-201 ZG91u02000 69-01 301-01
302-301 74-72 730-01
ZG22U08000 202-201 75-72 ZM11C06020 300-01
251-01 401-01 300-02
381-01 ZG91V02000 59-58 301-01
382-02 411-403 ZM11C08020 12-11
383-03 ZH21K04004 12-11 32-31
384·04 ZH22W06008 202-201 36-01
ZG31B04000 27-26 ZH22w08000 76-01 37-01
ZG32B04000 92-91 362-361 86-01
301-300 ZH22X04000 37-01 282-01
302-300 76-01 361-01
302-301 134-01 ZM11C08025 282-01
ZG32B06000 91-01 ZH22X04006 37-01 ZM11C10020 12-11
91-014 ZH22X06000 37-01 32-31
93-91 53-01 37-01
ZG32U08000 201-01 362-361 45-01
381-01 ZH22X08000 361-01 47-01
381-014 ZH22x08012 76-01 53-01
382-02 ZH22X12000 72-02 76-01
382-02A ZH22X12016 72-02 86-01
383-03 ZH22206008 612-01 161-01
383-03A ZH22Z08000 612-01 282-01
384-04 ZH31K04002 12-11 403-401
384-04A ZH311C04004 12-11 2M11C10025 12-11
ZG52U04000 91-01 ZH31K06004 12-11 39-01

999-1-28
 INDEX FOR PART.NO < CNT500 >
PART.NO PAGE PART.NO PAGE PART .NO PAGE

ZMllCl0025 53-01 ZN16Cl0008 71-01 ZN18C08007 1113-01

163-02 76-01 202-201
713-01 86-01 252-251
ZM11Cl0030 12-11 282-01 300-01
30~-302 302-300 300-02
ZM11C12025 13~-01 ZN16C12010 71-01 301-01
282-01 282-01 301-300
301-01 ZN16C20016 282-01 302-300
ZM11C12030 193-03 ZN16F16010 58-57 302-301
282-01 62-57 307-302
ZM11C12035 39-01 ZN16F20016 307-302 362-361
ZNllCO~003 301-300 ZN17C06005 91-01 708-01
302-300 95-01 709-708
302-301 95-01A ZN18C10008 11-01
ZN11C0500~ 53-01 98-95 12-11
ZN11Cl0008 82-81 303-302 37-01
ZN11C12010 82-81 361"01 39-01
ZN13C3002~ 29-01 ZN17C0601~ 361-01 45-01
ZN13F12010 57-01 ZN17C08007 81-79 47-01
ZN16CO~003 17-12 95-01 53-01
32-31 95-01A 91-01
95-01 ZN17Cl0006 72-01 91-01A
95-01A 72-02 92-91
98-95 ZN17Cl0008 95-01 93-91
721-01 95-01A 134-01
ZN16C0500~ 11-01 ZN17C12007 72-01 201-01
12-11 72-02 202-201
17-12 ZN17C20016 79-01 251-01
~5-01 361-01 252-251
95-01 ZN17F12007 202-201 283-02
95-01A 252-251 284-02
96-95 ZN18CO~003 97-95 301-300
H3-01 368-361 302-300
282-01 ZN18C06004 301-01 302-301
708-01 ZN18C06005 11-01 303-302
ZNlq.C06005 12-11 86-01 304-302
17-12 110-103 312-300
86-01 163-02 312-301
96-95 202-201 362-361
282-01 252-251 381-01
302-300 300-01 382-02
3"11-302 300-02 383-03
ZN16C08005 301-300 301-300 384-0~
302-300 302-301 403-~01

302-301 311-302 ZN18C12010 12-11

312-300 403-401 39-01
312-301 ZN18C08007 12-11 57-01
713-01 13-12 69-01
ZN16C08007 86-01 14-12 91-01
282-01 15-12 91-01A
28~-01 16-12 134-01
28~-02 36-01 161-01
312-300 39-01 201-01
312-301 93-91 301-01
730-01 134-01 304-302

999-1-29
 INDEX FOR .PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

ZN18C12010 381-01 ZN32F20018 112-110 ZP26 D06036 312-301

381-0lA ZN35C10010 31-01 ZP26D06050 713-01
382-02 ZN37C08008 814-813 ZP26D10025 814-813
382-02A 833-02 833-02
~01-01 ZN37C12011 811-01 ZP26D10100 814-813
~C8-403 813-02 833-02
409-403 821-01 ZP45X06018 202-201
505-02 824-02 IP~5X06025 13-12
811-01 841-01 14-12
813-02 ZN37C16016 814-813 15-12
821-01 833-02 16-12
824-02 ZN37C20018 814-813 Z?45X08025 11-01
831-01 833-02 ZP,+5X08027 12-11
ZN18C16013 29-01 IN41C06000 601-01 ZP'+5x08030 163-02
715-01 ZN45C08015 12-11 ZP,+5X12030 12-11
821-01 ZN51F06000 27-26 408-403
824-02 IN78C16023 11-01 ZP45X12032 11-01
ZN18C18015 307-302 ZP12P02240 72-01 143-01
IN18C20016 103-01 ZP15D03022 11-01 30'+-302
300-01 1~3-01 ZP~5X16090 193-03
300-02 IP15DO~018 304-302 ZP45X200'+0 '+08-403
301-01 IP15D04022 304-302 ZP,+5X20090 811-01
403-401 ZP15D04036 713-01 813-02
821-01 IP15D04040 821-01 821-01
82,+-02 824-02 824-02
ZN18C24019 ~01-01 IP15D040~8 ~11-~03 831-01
IN18F10008 58-57 ZP15D05040 53-01 ZP45X22100 57-01
62-57 57-01 ZP~5X30080 57-01
ZN18F12010 58-57 ZP15D05070 7~-72 ZR16X01800 12-11
62-57 75-72 ZR16X02200 312-300
7~-72 IP150060~0 ~03-'+01 312-301
75-72 '+09-403 ZR16X02500 53-01
ZN18F16013 58-57 ZP15006070 57-01 ZR16X03000 112-110
62-57 IP15006090 193-03 ZR16X04000 27-26
69-01 ZP15K02015 11-01 ZR16X06500 113-112
72-01 ZP16004020 408-403 ZR16X08500 27-26
72-02 IP16004022 12-11 IR26X01900 27-26
202-201 161-01 IR26xO~700 84-81
252-251 ZP16DO~032 408-'+03 713-01
IN18F18015 63-01 ZP16D06056 835-01 ZR26X06200 27-26
IN32C06005 601-01 IP16K01612 202-201 ZR26X07200 27-26
ZN32C12011 201-01 ZP16K016H 13-12 ZR36X00900 3~-32
251-01 14-12 Z511C08020 306-302
IN32C16015 201-01 15-12 Z512002900 73-72
251-01 16-12 Z513C30150 29-01
301-300 ZP16K02015 12-11 Z513C30190 29-01
302-300 ZP16K02016 163-02 Z513F12065 57-01
302-301 ZP26003014 20-12 Z513F12090 57-01
ZN32C18016 112-110 ZP26DO~040 821-01 Z516C06014 311-302
713-01 82~-02 Z516C06016 86-01
IN32C20018 201-01 ZP26005025 814-813 Z516C06020 86-01
251-01 833-02 Z516C06025 282-01
ZN32C36033 191-01 ZP26005045 821-01 Z516C06050 301-300
192-02 824-02 302-300
193-03 ZP26D06036 312-300 302-301
999-1-30
 INDEX FOR PART.NO < CNT500 )

PART.NO PAGE PART.NO PAGE pART .NO PAGE

ZS16C08016 76-01 ZS18 C06020 301-300 ZS18Cl0020 382-02

ZS16C08020 301-300 302-300 382-02A
302-300 302-301 383-03
302-301 ZS18C06025 304-302 383-03A
ZS16Cl0016 302-300 ZS18C06035 11-01 384-04
ZS16Cl0025 71-01 ZS18C06040 110-103 384-04A
ZS16C10030 86-01 ZS18C06045 601-01 409-403
ZS16C10035 282-01 ZS18C08012 112-110 8H-813
ZS16Cl0060 71-01 ZS18C08014 58-57 833-02
ZS16C10065 71-01 62-57 ZS18C10025 31-01
ZS16C10l00 76-01 ZS18C08020 283-02 91-01
ZS16C12025 71-01 300-01 91-01A
ZS16C12040 282-01 300-02 92-91
ZS16C12070 71-01 301-01 201-01
ZS16C12075 71-01 307-302 202-201
ZS16C12090 282-01 410-403 252-251
ZS16C16030 282-01 821-01 301-300
ZS16C16035 282-01 824-02 302-300
ZS16C20055 282-01 ZS18C08025 252-251 302-301
ZS17C06014 361-01 301-300 362-361
ZS17C06016 95-01 302-300 403-401
95-01A 302-301 ZS18Cl0030 84-81
ZS17C06020 303-302 312-300 91-01
ZS17C06025 91-01 312-301 91-01A
95-01 709-708 202-201
95-01A ZS18C08030 12-11 403-401
ZS17C08020 95-01A 93-91 ZS18C10035 48-01
283-01 134-01 91-01
ZS17C08040 81-79 202-201 9l-01A
ZS17Cl0016 95-01 312-300 93-91
95-01A 312-301 201-01
ZS17Cl0020 72-01 ZS18C08035 312-300 202-201
72-02 312-301 252-251
ZS17Cl0035 283-01 ZS18C08045 307-302 283-02
•
iS17Cl0040 72-01 709-708 304-302
ZS17Cl0085 72-02 ZS18C08055 300-01 ZS18Cl0060 134-01
ZS17C12025 72-01 300 0200
ZS18Cl0065 12-11
72-02 301-01 ZS18Cl0080 12-11
ZS17C12030 81-79 ZS18C08080 362-361 ZS18Cl0085 134-01
ZS17C12040 81-79 ZS18C08110 12-11 ZS18C12016 91-01A
ZS17C12065 72-01 143-01 ZS18C12020 201-01
72-02 ZS18Cl0016 11 0100
505-02
ZS17C20060 361-01 32-31 ZS18C12025 89-01
ZS17C20070 79-01 201-01 91-01
ZS18C06012 110-103 361-01 91-01A
709-708 719-01 403-401
ZS18C06014 11-01 ZS18Cl0020 80-79 505-02
410-403 202-201 821-01
ZS18C06016 58-57 283';02 824-02
62-57 284-02 Zs18C12030 26-01
86-01 303-302 27-26
301-300 312-300 49-48
302-300 312-301 57-01
302-301 381-01 69-01
ZS18C06020 11-01 381-01A 201-01

999-1-31
 INDEx FOR PART.NO < CNT500 )

PART.NO PAGE F'ART.NO F'AGE F'ART.NO PAGE

ZS18C12030 381-01 ZS18C16090 302-301 ZS23C08020 27-26

381-0111 ZS18C16110 11-01 87-86
382-02 201-01 ZS23C08030 27-26
382-02A ZS18C16120 251-01 ZS23C08065 362-361
408-403 814-813 ZS23Cl0020 82-81
ZS18C12035 37-01 833-02 409-403
48-01 ZS18C16190 301-300 ZS23Cl0025 48-01
49-48 302-300 82-81
69-01 302-301 ZS23C12035 79-01
83-81 ZS18C18050 83-81 ZS23C12040 112-110
134-01 ZS18C18065 307-302 Z523C14040 112-110
201-01 Z518C20040 811-01 Z523C1I+130 27-26
202-201 813-02 Z523C16060 110-103
251-01 821-01 Z523C20060 26-01
252-251 824-02 Z523C20085 506-505
381-01 831-01 Z531C03014 301-300
381-0111 Z518C20045 403-401 302-300
382-02 Z518C20050 11-01 302-301
382-02A 300-01 Z531CO'+006 87-86
708-01 300-02 Z531CO'+008 13-12
713-01 301-01 14-12
811-01 Z518C20055 48-01 15-12
813-02 Z518C20065 107-03 16-12
821-01 Z518C20075 103-01 Z531C04010 32-31
824-02 403-401 97-95
831-01 [518C20080 814-813 368-361
Z518C12040 27-26 833-02 Z531C04012 17-12
91-01 Z518C20130 201-01 721-01
91-0111 251-01 Z531C04016 301-300
112-110 Z518C20170 192-02 302-300
Z518C12045 39-01 193-03 302-301
Z518C12050 362-361 Z518C24040 401-01 Z531C04020 17-12
821-01 Z518C24065 401-01 95-01
824-02 Z518C30070 191-01 95-01A
ZS18C12060 57-01 192-02 98-95
201-01 193-03 Z531C05010 12-11
251-01 Z518C36085 193-03 34-32
Z518C12070 134-01 ZS18C36110 191-01 730-01
Z518C12075 39-01 192-02 Z531C05012 17-12
403-401 Z518F12025 381-01 32-31
ZS18C12080 113-112 381-01A '+5-01
134-01 382-02 96-95
ZS18C12085 39-01 382-02A Z531C05014 11-01
Z518C12120 304-302 Z518F12055 58-57 32-31
ZS18C14035 27-26 62-57 730-01
Z518C16045 84-81 Z518F12065 74-72 Z531C05016 95-01
112-110 75-72 95-01A
Z518C16060 715-01 ,518F16040 72-01 143-01
Z518C16065 29-01 72-02 Z531C05025 96-95
53-01 Z518F16050 69-01 Z531C06008 307-302
821-01 Z518F18045 307-302 Z531C06010 38-37
824-02 Z518F18100 63-01 96-95
Z518C16080 134-01 Z523C06016 112-110 Z531C06012 12-11
Z518C16090 301-300 Z523C06022 38-37 88-87
302-300 Z523C08014 27-26 Z531C06014 47-01
999-1-32
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

ZS31C06016 17-12 ZT12 8 22024 611-01 ZW16H16000 201-01

98-95 ZT12B27030 611-01 251-01
311-302 ZTl2B32036 611-01 301-300
ZS31C06020 88-81 ZT22A05000 611-01 302-300
ZS31C06040 86-01 ZT22A06000 611-01 302-301
ZS31C06045 12-11 ZT22A08000 611-01 115-01
ZS31C08014 130-01 ZT22Al0000 611-01 821-01
ZS31C08016 708-01 ZT22A12000 611-01 824-02
ZS32T04010 97-95 ZT22A14000 611-01 ZW16H18000 63-01
368-361 ZT22A17000 611-01 307-302
ZS41CO'+008 86-01 ZT22A19000 611-01 708-01
ZS41C04010 32-31 ZT31A13000 611-01 113-01
34-32 ZT31A17000 611-01 ZW16H20000 11-01
ZS41C04014 282-01 ZT31A19000 '611-01 103-01
ZS41C06010 32-31 ZT31A24000 611-01 107-03
ZS41C06030 282-01 ZT31A30000 611-01 192-02
ZS61Cl0020 282-01 ZT31B13250 611-01 193-03
ZS68C08035 821-01 ZT31C19500 611-01 201-01
824-02 ZT31D13150 611-01 251-01
ZS68Cl0018 81-86 ZT31D19200 611-01 300-01
ZS68C10025 53-01 ZT32A36000 611-01 300-02
403-401 ZT32A41000 611-01 301-01
ZS68C10030 53-01 ZWllX16000 58-57 361-01
ZS68C12020 403-401 62-57 403-401
ZS68C12025 403-401 ZW13H30000 29-01 811-01
ZS68C12030 811-01 ZW16H05000 708-01 813-02
813-02 ZW16H08000 12-11 821-01
821-01 ZW16Hl0000 12-11 824-02
824-02 201-01 831-01
831-01 251-01 ZW16H22000 57-01
ZS68C12040 403-401 252-251 ZW16H24000 401-01
821-01 301-300 Zw16H30000 193-03
824-02 302-300 Zw16H36000 193-03
ZS13C08030 404-403 302-301 Zw16K05000 12-11
406-403 304-302 45-01
ZS73C12035 811-01 362-361 89-01
813-02 814-813 Zw16K06000 202-201
821-01 833-02 Zw16K10000 252-251
824-02 ZW16H12000 39-01 ZW16Kl6000 387-381
ZS73C20050 403-401 69-01 Zw16Kl8000 12-11
821-01 89-01 ZW16K20000 .1&.08-403
824-02 95-01 ZW16P04000 95-01
ZS83C04006 34-32 134-01 95-01A
ZS83C05006 77-76 202-201 97-95
ZS83C08010 54-53 252-251 368-361
ZS83C08012 506-505 362-361 ZW16P05000 95-01
ZS83C12025 82-81 403-401 95-01A
ZS83C12030 82-81 708-01 Zw16P06000 21-12
ZS83C12035 409-403 821-01 310-302
ZS83C20020 27-26 824-02 ZW16P08000 113-01
ZT12A36000 611-01 ZW16H14000 69-01 ZW16P12000 11-01
ZTl2A41000 611-01 ZW16H16000 11-01 ZW16X04000 98-95
ZTl2B08010 611-01 53-01 Zw16X05000 11-01
ZT12B11013 611-01 69-01 Zw16X06000 11-01
ZTl2B17019 611-01 110-103 12-11

999-1-33
 INDEX FOR PART.NO. < CNnOO >
PART.NO PAGE PART.NO PAGE PART.NO PAGE

ZW16X06000 13-12 ZW16XI0000 252-251 ZW22X06000 58-57

14-12 282-01 62-57
15-12 283-02 88-87
16-12 301-300 ZW22X08000 58-57
31-01 302-300 62-57
34-32 302-301 86-01
86-01 312-300 88-87
91-01 312-301 306-302
95-01 362-361 ZW22XI0000 58-57
95-01A 381-01 62-57
110-103 382-02 86-01
303-302 383-03 ZW22X12000 57-01
304-302 384-04 58-57
311-302 403-401 62-57
730-01 505-02 ZW22X16000 58-57
ZW16X08000 11-01 719-01 62-57
12-11 821-01 Zw26K08000 37-01
36-01 824-02 403-401
37-01 ZW16X12000 11-01 ZW26KI0000 37-01
39-01 71-01 39-01
86-01 72-01 48-01
95-0lA 72-02 71-01
163-02 91-01 76-01
202-201 91-01A 134-01
252-251 95-0lA 403-401
282-01 143-01 505-02
284-01 161-01 ZW26K12000 49-48
284-02 201-01 71-01
300-01 202-201 114-110
300-02 251-01 134-01
301-01 252-251 ZW26X04000 13-12
301-300 282-01 14-12
302-300 304-302 15-12
302-301 381-01 16-12
3i2-300 381-01A 17-12
312-301 382-02 32-31
361-01 382-02A 87-86
362-361 ZW16X16000 11-01 95-01
709-708 282-01 95-01A
ZW16X10000 11-01 304-302 97-95
37-01 814-813 98-95
71-01 833-02 301-300
72-01 ZW16X20000 79-01 302-300
76-01 282-01 302-301
86-01 ZW16x24000 53-01 368-361
91-01 403-401 721-01
91-01A 409-403 ZW26X05000 11-01
95-01 821-01 12-11
95-01A 824-02 17-12
134-01 ZW16X30000 57-01 32-31
161-01 191-01 45-01
163-02 192-02 53-01
201-01 ZW16X36000 191-01 89-01
202-201 192-02 95-01
251-01 ZW22K08000 87-86 95-01A
999-1-3.
 INDEX FOR PART.NO < CNT500 >
PART.NO PAGE PART.NO PAGE PART .NO PAGE

ZW26X05000 96-95 ZW26X08000 821-01 ZW26X10000 821-01

H3-01 82~-02 8H-02
282-01 ZW26X10000 11-01 ZW26X12000 37-01
730-01 12-11 39-01
ZW26X06000 11-01 31-01 ~8-01
12-11 32-31 57-01
17-12 37-01 71-01
~7-01 39-01 72-01
86-01 ~5-01 72-02
91-01 47-01 74-72
95-01 48-01 75-72
95-01A 71-01 77-76
96-95 72-01 79-01
98-95 72-02 81-79
110-103 76-01 83-81
163-02 80-79 91-01
300-01 84-81 91-01A
300-02 91-01 134-01
301-)00 91-01A 161-01
302-300 92-91 201-01
302-301 93-91 251-01
303-302 95-01 282-01
304-302 95-01A 304-302
307-302 134-01 381-01
311-302 201-oi 381-01A
361-01 202-201 382-02
410-40) 251-01 382-02A
709-708 -252-251 ~01-01
ZW26X08000 12-11 282-01 408-403
76-01 283-01 505-02
93-91 283-02 821-01
95-01 28~-02 824-02
95-01A 301-300 Zw26X16000 40-39
1)~-01 302-300 84-81
202-201 302-301 134-01
252-251 303-302 202-201
282-01 304-302 282-01
283-01 )07-)02 404-403
283-02 312-300 406-403
284-01 312-301 Zw26X20000 48-01
284-02 361-01 79-01
300-01 362-361 282-01
300-02 381-01 307-302
301-01 381-01A 506-505
301-300 382-02 ZW51806000 27-26
302-300 382-02A ZX15KO~090 12-11
302-301 383-03 Zx15K04230 12-11
307-302 383-03A ZX15.K06135 12-11
312-300 384-04 ZX15K08255 12-11
312-301 384-04A ZX21H06170 37-01
362-361 403-401 ZX21H08750 71-01
~10-.03 719-01 ZX22HO~076 37-01
708-01 722-01 Zx22H06195 37-01
709-708 811-01 Zx22H08072 72-02
730-01 813-02 Zx22H08076 13~-01

999-1-35
 INDEX FOR PART.NO (CNT500 )

PART.NO PAGE PART.NO PAGE PART.NO PAGE

ZX22M08150 72-01 0636V046 39-01 VH411232290 64-63

ZX22M08350 134-01 0661v039 89-01 VH411232300 64-63
ZX23M16074 201-01 0682V058 202-201 VH411232310 64-63
251-01 252-251 VH411232320 65-64
ZX24M06130 72-02 0827V023 202-201 VH411232330 65-64
ZX24M06140 72-01 252-251 VH411232340 65-64
72-02 2037V005 96-95 VH411251100 65-64
ZX24M08110 72-02 2045V001 98-95 VH411311410 65-64
ZX25M04240 37-01 2049V004 304-302 VH41131H20 65-64
ZX25M08108 76-01 2049VOO' 89-01 VH41131H80 68-67
ZX25M08134 76-01 2065V003 12-11 VH411371010 64-63
ZX25M08147 76-01 2435V002 300-01 VMU1371070 65-64
ZX25M08157 76-01 300-02 VMU2011600 65-64
ZX25M08160 76-01 301-01 68-67
ZX25M08163 76-01 3615V009 505-02 VM412311020 65-64
ZX25M08194 76-01 3616i1007 98-95 68-67
ZX2'M08198 76-01 3616V008 202-201 VM412311300 65-64
ZX25M08203 76-01 252-251 VH412311310 65-64
ZX25M08494 76-01 3616VOll 57-01 VH412311320 65-64
ZX27M04060 37-01 3619V010 39-01 VH412311330 65-64
ZX27M04250 134-01 403-401 VHU2311340 65-64
ZX27M06250 37-01 3631V005 98-95 VH412311350 65-64
ZX27M12400 72-02 VH373042530 68-67 VH412311360 65-64
ZX27P16090 39-01 VH373042660 65-64 VH412311370 65-64
ZX27P16135 505-02 VH373243150 68-67 VH412311380 65-64
ZX27P20120 39-01 VH373243360 65-64 VH412311390 65-64
ZX27P20135 134-01 VH373411330 64-63 VH412311400 65-64
ZX32M12195 72-02 VH373411350 65-64 VH412311410 65-64
ZX32P20070 39-01 VH373411490 68-67 VHU2311420 65-64
ZX33M08039 362-361 VH411011611 68-67 VH412311430 65-64
ZX33M08052 361-01 VH411011621 65-64 VH412311440 65-64
ZX35M06430 53-01 VH411111461 68-67 VH412311450 65-64
ZX37M08140 361-01 VH411111521 65-64 VH412311460 65-64
ZX37M16060 37-01 VH411131180 65-64 VH412311470 65-64
ZX37M16070 76-01 68-67 VH41231H80 65-64
ZX37M16115 37-01 VH411211071 65-64 VH412441080 64-63
ZX37P12051 403-401 VH411231430 65-64 VH412511020 65-64
ZX37P12066 403-401 68-67 VHU2521070 65-64
ZX37P16110 71-01 VH411231440 65-64 VH412531030 65-64
ZX37P16235 71-01 68-67 VHU2541050 65-64
ZX37P20105 134-01 VH411231450 65-64 VH412771010 65-64
ZX37P20110 134-01 68-67 VH412911040 65-64
ZX37P20165 71-01 VH411231461 68-67 VH412911090 65-64
ZX44M06275 72-01 VH411231471 68-67 VHU3011560 65-64
72-02 VH411231481 68-67 VH413011710 65-64
ZX44M06285 72-01 VH411231491 68-67 68-67
72-02 VH411232200 65-64 VH413111150 65-64
ZX44M06415 201-01 VH411232210 65-64 VH413111340 68-67
ZX44M08052 362-361 VH411232220 65-64 VH413121310 65-64
ZX47P20092 71-01 VH411232230 65-64 68-67
0630V045 252-251 VH411232240 65-64 VH413151020 65-64
0630V046 403-401 VH411232250 65-64 68-67
505-02 VH411232260 65-64 VH413311320 65-64
0630V055 403-401 VH411232270 65-64 VH413311330 65-64
0630V056 202-201 VH411232280 64-63 VH413311460 65-64
999-1-36
 INDEX FOR PART.NO < CNT500 >

PART.NO PAGE PART.NO pAGE pART.NO PAGE

VH413311460 68-67 VH900314133 65-64 VH918914101 67-63

VH413411100 65-64 68-67 VH920114110 64-63
VH413411280 65-64 VH900421106 64-63 67-63
68-67 67-63 VH920116130 64-63
VH413511090 65-64 VH900422111 64-63 67-63
VH413511180 65-64 67-63 VH920916102 65-64
68-67 VH900425171 64-63 68-67
VH413611130 65-64 67-63 VH920920103 65-64
VH413611380 65-64 VH900426144 64-63 68-67
68-67 67-63 VH921930105 65-64
VH413711080 65-64 VH900436110 65-64 VH921933116 64-63
68-67 68-67 65-64
VH413711110 65-64 VH900436113 64-63 68-67
VH413911170 64-63 67-63 VH921945104 65-64
VH414501220 64-63 VH900436116 64-63 VH92198510S 64-63
VH415891020 64-63 67-63 67-63
VH42147 1 090 64-63 VH900436127 68-67 VH926012220 64-63
67-63 VH900436133 65-64 67-63
VH423113300 64-63 68-67 VH92S014350 64-63
VH423113310 67-63 VH900436134 65-64 VH92801S460 6S-67
VH423113320 64-63 68-67 VH929010300 65-64
VH423211040 65-64 VH90043613S 65-64 VH929012360 64-63
VH424111820 64-63 VH900439106 64-63 VH929014420 64-63
67-63 67-63 67-63
VH435122421 64-63 VH901110200 64-63 VH929016480 64-63
67-63 67-63 67-63
VH449211D10 64-63 VH901118451 6S-67 VH929018540 65-64
67-63 VH901908162 65-64 VH931914102 64-63
VH470511680 64-63 6S-67 67-63
67-63 VH901914219 64-63 VH938910106 64-63
VH470511690 64-63 67-63 67-63
67-63 VH901916113 64-63 VH940112300 64-63
VH474511010 64-63 67-63 VH940112350 65-64
67-63 VH901916222 65-64 VH950040200 64-63
VH474601481 67-63 ' 68-67 67-63
VH474801020 64-63 VH901916233 65-64 VH950412200 65-64
67-63 68-67 VH951112360 64-63
VH474831060 64-63 VH901920101 65-64 67-63
67-63 68-67 VH96191070 65-64
VH47496111D 64-63 VH901920104 65-64 VH96191S103 64-63
67-63 68-67 67-63
VH478S12310 64-63 VH902110300 65-64 VH961930104 64-63
67-63 VH902112300 64-63 67-63
VH478822310 64-63 VH903118450 65-64 VH962921105 65-64
67-63 VH905912106 65-64 VH964401321 64-63
VH478891060 64-63 VH905914110 68-67 67-63
67-63 VH918106160 64-63 VH964504931 64-63
VH478891080 64-63 67-63 67-63
67-63 VH918108160 65-64 VH96591S110 64-63
VH765531500 65-64 68-67 67-63
VH765542060 65-64 VH918110200 64-63 VH965930102 64-63
VH900312246 64-63 67-63 65-64
67-63 VH918114350 64-63 67-63
VH900313164 64-63 67-63 VH972910123 64-63
67-63 VH918914101 64-63 VH972910148 64-63

999-1-37
 INDEX FOR PART.NO (CNT500 >

PART.NO PAGE PART.NO PAGE PART.NO PAGE

VH972910148 67-63
VH980210101 64-63
67-63
VH980330200 64-63
67-63
VH980360550 65-64
68-67
VH981932108 65-64
68-67
VH981940112 64-63
67-63
VH982801193 64-63
67-63
VH982840113 64-63
67-63
VH982865112 64-63
VH982876101 64-63
67-63
VH982880110 68-67
VH982890104 65-64
VH985137102 64-63
67-63
VH9851401Q4 65-64
VH986740113 64-63
67-63
VH987306105 64-63
67-63
VH988335108 65-64
68-67
VH988440102 65-64
VH988450101 64-63
VH988460105 68-67
VH988460110 65-64
VH988470103 65-64
VH988470108 65-64
68-67
VH988490107 64-63
67-63
VH988490110 65-64
68-61
VH9900436127 65-64
VH990062130 65-64
VH993322110 64-63
67-63

999-1-311
 ALPHABETICAL INDEX < OMT450 >

<A> BLOCK, TAPPED ••••••••••••••••••••• 833-02

BLOCK, VALVE ••••••••••••••••••••••• 11-01
ADJUST ASSY ••••••••••••••••• 64-63 67-63 BODy •••••••••••••••••••••••• 21-12 40-39
ALARM ••••••••••••••••••••••••••••• 723-01 49-48 55-53
ARM ••••••••••••••••••••••••• 58-57 62-57 77-76 78-76
713-01 83-81 84-81
ARM ASSY, TOR@UE ••••••••••••••••••• 57-01 92-91 111-110
ARM, CLUTCH •••••••••••••••••••••• 304-302 115-114 116-114
ARM, KNUCKLE •••••••••••••••• 58-57 62-57 135-134 136-134
ARM, PITMAN •••••••••••••••••••••••• 72-01 306-302 308-302
ARM, WiPER ••••••••••••••••• 86-01 705-01 310-302 364-362
706-01 412-403
BODY, VALVE ••••••••••••• 271-252 405-403
BOOM ASSY •••••••••••••••• 401-01 403-401
<B> BOOM POINT ASSY ••••••••• 403-401 411-403
BOOM, TOP •••••••••••••••••••••••• 403-401
BALL •••••••••••••••••••••••• 24-12 28-26 BOOM, 2ND •••••••••••••••••••••••• 403-401
82-81 115-114 BOOM, 3RD •••••••••••••••••••••••• 403-401
135-134 405-403 BOOM, 4TH •••••••••••••••••••••••• 403-401
412-403 BOX ••••••••••••••••••••••••••••••• 282-01
BALL, LEVER ••••••••••••••••• 13-12 14-12 BOX ASSY, CONTROL ••••••••••• 95-01 97-95
16-12 161-01 368-361
163-02 BOX, CONTROL •••••••••••••••• 96-95 97-95
BAND ••••••••••••••••••••••• 66-64 283-01 368-361
BAR ••••••••••••••••••••••• 821-01 824-02 BOX, RELAy •••••••••••••••••• 95-01 96-95
BAR, EXTENSiON •••••••••••••••••••• 611-01 BRAKE ASSY •••••••••••••••••• 58-57 59-58
BATTERY ASSY •••••••••••••••••••••• 722-01 62-57 112-110
BATTERY, N150 ••••••••••••••••••••• 722-01 113-112 202-201
BATTERY, N200 ••••••••••••••••••••• 722-01 BULB •••••••••••••••••••••••• 86-01 95-01
BEARING ••••••••••••••••••••• 27-26 34-32 98-95 309-302
57-01 58-57 612-01
62-57 64-63 BULB, LIGHT ••••••••••••••• 17-12 309-302
65-64 67-63 612-01
68-67 69-01
82-81 83-81
84-81 112-110 <C >
113-112 202-201
282-01 301-01 CAB ••••••••••••••••••••••••• 32-31 86-01
312-301 411-403 87-86
709-708 713-01 CAB ASSY •••••••••••••••••••• 31-01 32-31
811-01 813-02 86-01
CAB ASSY, OPERATORS ••••••••• 11-01 12-11
BEARING ASSY ••••••••••••••••••••••• 51-01 CABLE •••••••••••••••••••••••••••• 202-201
BEARING, BALL ••••••••••••• 69-01 410-403 CABLE ASSY, CONTROL •••••••••••••••• 12-11
BEARING, NEEDLE ••••••••••••• 27-26 28-26 CABLE' BATTERy •••••••••••••••••••• 201-01
112-110 113-112 CABLE, CONTROL •••••••••••••• 13-12 14-12
BEARING, ROLLER ••••••••••• 27-26 410-403 15-12 16-12
BEARING, SPHERiCAL ••••••••••••••• 506-505 312-301 708-01
BLOCK ••••••••••••••••••••••• 11-01 12-11 712-02
37-01 57-01 CABLE,BATTERV ••••••••••••••••••••• 201-01
87-86 143-01 CAM CLUTCH ••••••••••••••••••••••• 113-112
202-201 412-403 CAP ••••••••••••••••••••••••• 27-26 38-37
BLOCK ASSV ••••••••••••••••••••••••• 37-01 40-39 55-53
BLOCK, MANIFOLD •••••••••••••••••• 403-401 58-57 62-57
BLOCK, SKID ••••••••••••••••••••••• 282-01 65-64 68-67
BLOCK, TAPPED ••••••••••••• 48-01 814-813 135-134 364-362

AAA-1-1
 ALPHABETICAL INDEX < OMT450 >

CAP ••••••••••••••••••••••• 381-01 383-03 COVER ••••••••••••••••••••••• 77-76 80-79

708-01 712-02 82-81 88-87
CAP ASSY ••••••••••••••••••••••••••• 80-79 89-01 92-91
CAP ASSY, FILLER •••••••••• 24-12 305-304 95-01 111-110
BREATHER •••••••••••••••••••• 305-304 112-110 116-114
END ••••••••••••••••••••••••••• 28-26 201-01 271-252
CAP, TERMINAL •••••••••••• 201-01 202-201 282-01 304-302
CAP, VALVE •••••••••••••••• 21-12 308-302 363-362 405-403
310-302 410-403
CAP,TERMINAL ••••••••••••••••••••••• 96-95 COVER ASSY •••••••••••••••••• 32-31 60-58
CARRIER ••••••••••••••••••••• 65-64 68-67 202-201
CARRIER ASSY •••••••••••••••• 65-64 68-67 COVER ASSY, DRUM •••••••••••• 64-63 67-63
CARRIER, BEARING ••••••••••••••••• 112-110 COVER, DUST ••••••••••••••••• 59-58 69-01
CLAMP ••••••••••••••••••••••• 11-01 12-11 COVER, FRONT ••••••••••••••••••••••• 45-01
32-31 37-01 COVER, LOw ••••••••••••••••••••••••• 60-58
39-01 47-01 COVER, RO~ •••••••••••••••••• 54-53 56-53
57-01 71-01 404-403 406-403
72-01 74-72 506-505
75-72 76-01 COVER, SlOE •••••••••••••••••••••• 410-403
79-01 91-01 CUSHION •••••••••••••••••••••••••••• 57-01
95-01 134-01 CyLINDER •••••••••••••••••••• 24-12 27-26
143-01 201-01 57-01 61-57
202-201 271-252 271-252 305-304
283-01 284-01 363-362
301-01 302-301 CYLINDER ASSY ••••••••••••• 53-01 304-302
303-302 307-302 305-304
361-01 403-401 CYLINDER ASSY, HOiST ••••• 505-02 506-505
811-01 813-02 CYLINDER, AIR ••••••••••• 202-201 270-252
CLAMP ASSY •••••••••••••••• 60-58 202-201 CYLINDER. HORiZONTAL •••••••• 53-01 56-53
284-01 CYLINDER, MASTER •••••••••••• 12-11 24-12
CLAMP, HALF ••••••••••••••••• 37-01 39-01 CYLINDER, TELESCOPE •••••••••••••• 403-401
71-01 76-01 CYLINDER, VERTICAL~ •••••••••••••• 362-361
79-01 134-01 CYLINDER,VERTICAL •••••••••••••••• 362-361
201-01 403-401
505-02
CLEANER ••••••••••••••••••••••••••• 283-01 <0 >
CLUTCH ••••••••••••••••••••••••••••• 82-81
CLUTCH ASSY ••••••••••••• 302-301 304-302 DIFFERENTIAL ASSY ••••••••••• 65-64 68-67
CONSOLE, CAB ••••••••••••••••••••• 302-301 DIODE •••••••••••••••••••••••••••• 302-301
CONSOLE, SIDE •••••••••••••••••••••• 12-11 DISK ••••••••••••••••••••••••••••••• 27-26
CONTROL ASSY ••••••••••••••• 11-01 143-01 DISK ASSY, CLUTCH •••••••••••••••• 202-201
CONTROL, ILLUM ••••••••••••••••••• 309-302 DISK, FRICTION ••••••••••••••••••• 113-112
CONTROL, UNIT •••••••••••••••••••• 115-114 DOOR •••••••••••••••••••••••• 34-32 88-87
COUNTERWEIGHT ••••••••••••• 191-01 192-02 DOOR ASSY ••••••••••••••••••• 32-31 34-32
193-03 87-86 88-87
COUNTERWEIGHT ASSY •••••••••••••••• 193-03 DRAIN, AIR ••••••••••••••••••••••• 412-403
COUPLING •••••••••••••••••••• 27-26 82-81 DRUM ••••••••••••••••••••••••••••• 112-110
83-81 84-81 DRUM, BRAKE ••••••••••••••••• 58-57 62-57
110-103 134-01 64-63 67-63
202-201 301-01
COVER ••••••••••••••••••••••• 12-11 27-26
28-26 31-01 <E >
32-31 40-39
45-01 58-57 ELEMENT •••••••••••••••••••••••••••• 38-37
60-58 62-57 ELEMENT, FILTER •••••••••••••••••••• 80-79
65-64 69-01 END •••••••••••••••••••••••••••••• 412-403

AAA-1-2
 ALPHABETICAL INDEx < OMT450 >

END, ~LATE ••••••••••••••••••••••• 2 7 1-252 HOSE ••••••••••••••••••••••• 93-91 134-01

END, TIE-ROD •••••••••••••••• 58-57 62-57 201-01 301-01
ENGINE ••••••••••••••••••••••••••• 202-201 303-302 361-01
EQUALIZER •••••••••••••••••••••••••• 57-01 403-401
HOSE ASSy ••••••••••••••••••• 37-01 39-01
53-01 71-01
<F > 72-01 76-01
91-01 134-01
FILTER •••••••••••••••••••••• 40-39 92-91 201-01 361-01
116-114 135-134 362-361 381-01
FILTER ASSy ••••••••••••••••• 49-48 80-79 382-02 383-03
FINAL ASSy, LOw •••••••••••••••••••• 51-01 384-04 403-401
FLOAT •••••••••••••••••••••• 53-01 361-01 505-02
FRAME ••••••••••••••••••••••• 33-32 83-81 HOUSiNG ••••••••••••••••••••• 27-26 28-26
84-81 38-37 64-63
FRAME, RE •••••••••••••••••••••••••• 51-01 65-64 80-79
FRAME, UPP ••••••••••••••••••••••••• 10-01 112-110 115-114
FRAME, wINDOW •••••••••••••••••••••• 32-31 135-134 811-01
FUSE •••••••••••••••••••• 309-302 311-302 814-813 833-02
612-01 719-01 HOUSING ASSy ••••••••••••• 811-01 814-813
FUSE, lOAMP ••••••••••••••••••••••• 612-01 821-01 .833-02
HOUSING, AXLE •••••••••••••••••••••• 67-63

<G >
<I >
GAUGE ••••••••••••••••••••• 17-12 309-302
GAUGE, AIR PRESS •••••••••• 17-12 309-302 INDICATOR •••••••••••••••••• 80-79 283-01
GAUGE, LEVEL •••••••••••••• 80-79 410-403 INDICATOR, DRUM TURN ••••• 708-01 709-708
GEAR •••••••••••••••••••••••• 27-26 65-64 712-02
68-67 82-81
83-81 84-81
GEAR, RING •••••••••••••••• 27-26 112-110 < J >
GEAR, STEERING ••••••••••••••••••• 307-302
GEAR, SUN~ •••••••••••••••• 27~26 112-110 JIB, INNER •••••••••••••••• 821-01 824-02
GUARD ••••••••••••••••••••• 32-31 271-252 JOINT ••••••••••••••••••••••• 57-01 58-57
62-57 66-64
74-72 75-72
<H > JOINT, BALL ••••••••••••••••• 58-57 62-57
161-01 163-02
HANDLE •••••••••••••••••••••• 34-32 88-87 202-201 312-301
97-95 282-01 JOINT, PIPE •••••••••••••••••••••• 303-302
368-361 JOINT, SWIVEL •••••••••••••••••••• 403-401
HANDLE, RATCHET ••••••••••••••••••• 611-01
HANDLE, SLIDE ••••••••••••••••••••• 611-01
HARNESS ••••••••••••••• ~ ••••••••••• 719-01 <K>
HARNESS, AIR ••••••••••••••••••••••• 91-01
HARNESS, WiRING ••••••••••••• 17-12 95-01 KEy •••••••••••••••••••••••• 33-32 163-02
302-301 706-01 202-201 409-403
HOOK, PiNTLE •••••••••••••••••••••• 715-01 410-403
HORN ••••••••••••••••••••••••••••••• 12-11 KEY, SCREW •••••••••••••••••••••••• 611-01
HORN ASSY •••••••••••••••••••••••••• 12-11
HORN, AIR •••••••••••••••••••••••••• 86-01
HOSE •••••••••••••••••••••••• 37-01 72-01 <L >
76-01 79-01
89-01 LABEL ••••••••••••••••••••• 97-95 368-361
92-91 612-01

AAA-1-3
 ALPHABETICAL INDEX < OMT450 >

LAMP •••••••••••••••••••••••• 86-01 95-01 LOCK WASHER ••••••••••••••• 712-02 721-01

98-95
LAMP ASSy •••••••••••••••••••••••• 309-302
LAMP, HEAD ••••••••••••••••••••••••• 98-95 <M>
LAMP, SiGNAL •••••••••••••••• 17-12 18-12
97-95 309-302 MOTOR ••••••••••••••••••••••• 26-01 28-26
368-361 115-114
LEVER ••••••••••••••••••••••• 13-12 14-12 MOTOR ASSY •••••••••••••• 110-103 114-110
15-12 16-12 MOTOR, WiPER ••••••••••••••• 86-01 705-01
20-12 21-12 706-01
82-81 161-01 MUFFLER ••••••••••••••••••••••••••• 284-01
163-02 202-201
308-302 312-301
709-708 713-01 <0 >
LEVER ASSY ••••••••••••••••••••••• 202-201
LEVER ASSY, CONTROL ••••••••• 12-11 13-12 OUTRIGGER ASSY ••••••••••••••••••••• 53-01
14-12 15-12
16-12 143-01
LIGHT ••••••••••••••••••••••• 32-31 86-01 <P >
95-01 612-01
719-01 PEDAL ••••••••••••••••••••••• 12-11 21-12
LIGHT ASSY, BUMPER •••••••••• 95-01 98-95 306-302
LIGHT ASSY, ROOM ••••••••••••••••••• 86-01 PINION •••••••••••••••••••••• 27-26 65-64
LIGHT, PANEL ••••••••••••••••••••••• 18-12 68-67 112-110
LIGHT, ROOM •••••••••••••••••••••••• 32-31 PowER DiViDER ••••••••••••••• 81-79 82-81
LIGHT' ROTARy ••••••••••••••••••••• 704-01 POwER PLANT ASSY •••••••••••••••••• 201-01
LIGHT, SiGNAL ••••••••••••• 98-95 309-302 PUMP ASSy ••••••••••••••••••• 79-01 81-79
LOCK ••••••••••••••••••••••••••••••• 32-31 PUMP' GEAR •••••••••••••••••• 81-79· 83-81
LOCK ASSy •••••••••••••••••••••••••• 88-87 84-81
LOCK AS$Y, SWiNG •••••••••• 161-01 163-02 PUMP, STEERING •••••••••• 202-201 273-252
LOCK WASHER ••••••••••••••••• 11-01 12-11
13-12 14-12
15-12 16-12 <R>
17-12 21-12
32-31 47-01 RADIATOR ASSY ••••••••••••••••••••• 201-01
54-53 57-01 RATCHET •••••••••••••••••••••••••••• 34-32
58-57 59-58 REDUCER ••••••••••••••••••• 283-01 382-02
61-57 62-57 384-04
64-63 65-64 REDUCER ASSY •••••••••••• 409-403 410-403
67-63 69-01 REDUCTION ASSY,SWING ••••••••••••••• 26-01
76-01 83-81 REDUCTION UNIT •••••••••••••• 26-01 27-26
86-01 88-87 REGULATOR •••••••••••••••••••••••••• 88-87
91-01 92-91 RELAy ••••••••••••••••••••• 96-95 311-302
93-91 95-01 705-01
96-95 97-95 RELAY, HORN •••••••••••••••••••••••• 17-12
98-95 110-103 RELAY, SWITCH ••••••••••••••••••••• 705-01
134-01 163-C2 RING •••••••••••••••••••••••• 24-12 27-26
202-201 282-01 28-26 53-01
283-01 284-01 59-58 61-57
301-01 302-301 64-63 67-63
303-302 304-302 72-01 78-76
307-302 310-302 83-81 84-81
311-302 312-301 112-110 305-30~ 1,'
362-361 368-361 363-362 404-~03

410-403 705-01 406-403

708-01 709-708 RING SIDE ••••••••••••••••••••••••• 351-01

AAA-1-4
 ALPHABETICAL INDEX < OMT450 >

RING, BACK UP ••••••••••••••• 54-53 61-57 SHAFT ••••••••••••••••••••••• 69-01 82-81

77-76 116-114 83-81 84-81
135-134 506-505 112-110 307-302
RING, BACK-UP ••••••••••••••• 20-12 27-26 410-403 709-708
3~-37 40-39 SHAFT ASSY ••••••••••••••••••••••••• 69-01
54-53 55-53 SHAFT, AXLE ••••••••••••••••• 64-63 67-63
56-53 112-110 SHAFT, CAM •••••••••••••••••• 59-58 64-63
135-134 363-362 67-63
364-362 404-403 SHAFT, CLUTCH •••••••••••••••••••• 202-201
406-403 506-505 SHAFT, DRIVE •••••••••••••••••••••• 201-01
RING, BUFFER ••••••••••••••••••••••• 61-57 SHAFT' PiNION ••••••••••••• 27-26 112-110
RING, CLip ••••••••••••••••• 47-01 719-01 SHAFT' WORM •••••••••••••••••••••• 410-403
RING, COLLECTOR •••••••••••••••••••• 48-01 SHEAVE •••••••••••••••••• 408-403 411-403
RING, FELT •••••••••••••••••• 59-58 69-01 811-01 813-02
RING, GASKET ••••••••••••••••••••••• 24-12 841-01
RING, RETAINING ••••••••••••• 54-53 80-79 SHEAVE ASSY •••••••••••••• 193-03 403-401
83-81 271-252 408-403 411-403
RING, SEAL •••••••••••••••••• 61-57 66-64 811-01 813-02
92-91 821-01 824-02
RING, SNAP •••••••••••••••••• 12-11 27-26 841-01
34-32 54-53 SHEET •••••••••••••••••••••• 88-87 601-01
58-57 62-57 SHEET METAL ASSY •••••••••••••••••• 282-01
113-112 312-301 SHEET, RUBBER •••••••••••••• 32-31 163-02
411-403 506-505 304-302
RING, SPRING •••••••••••••••• 58-57 62-57 SHOE ASSY ••••••••••••••••••• 59-58 67-63
RING, STOP ••••••••••••••••••••••• 305-304 SHOE ASSV LH ) ••••••••••••••••••• 64-63
RING, TEFLON ••••••••••••••••••••• 506-505 SHOE ASSY RH ) ••••••••••••••••••• 64-63
RING, WEAR •••••••••••••••• 54-53 404-403 SOCKET ••••••••••••• ~ •••••••• 53-01 95-01
406-403 506-505 98-95 301-01
RING, WiPER ••••••••••••••••• 61-57 66-64 611-01
RING,SJDE ••••••••••••••••••••••••• 352-01 SPIDER •••••••••••••••••••••• 27-26 65-64
RING,STOP •••••••••••••••••••••••••• 24-12 68-67 69-01
ROD ••••••••••••••••••••••••• 29-01 56-53 112-110 113-112
57-01 113-112 SPIDER ASSY ••••••••••••••••• 27-26 64-63
115-114 163-02 67-63
202-201
301-01 SPRING •••••••••••••••••••••• 20-12 21-12
312-301 24-12 27-26
ROD ASSY ••••••••••••••••••••••••••• 60-58 28-26 38-37
ROD ASSY, PUSH •••••••••••• 24-12 271-252 40-39 55-53
305-304 57-01 60-58
ROLLER •••••••••••••••••••••• 21-12 57-01 64-63 66-64
59-58 306-302 67-63 74-72
310-302 713-01 75-7,~ 77-76
821-01 824-02 78-7b 80-79
ROLLER ASSY ••••••••••••••• 821-01 824-02 82-81 91-01
ROLLER ASSY, DRUM ••••••••••••••••• 713-01 111-110 113-112
ROLLER ASSY, GUiDE •••••• 403-401 409-403 116-114 135-134
ROLLER, GUIDE •••••••••••••••••••••• 34-32 136-134 202-201
ROPE, WiRE ••••••••••••••••••••••• 403-401 271-252 304-302
305-304 308-302
310-302 3b4-362
<S ) 403-401 405-403
412-403 709-708
SHAFT ••••••••••••••••••••••• 20-12 27-26 713-01 814-813
28-26 57-01 833-02
64-63 65-64 SPRING ASSY ••••••••••••••••• 59-58 64-63

AAA-1-5
 ALPHABETiCAL INDEX < OMT450 >

SPRING ASSy ••••••••••••••• 67-63 403-401 <V>

SPRING PIN •••••••••••••••••• 20-12 53-01
193-03 282-01 VALVE ••••••••••••••••••••••• 12-11 21-12
361-01 403-401 38-37 55-53
713-01 811-01 80-79 92-91
813-02 814-813 110-103 111-110
821-01 824-02 134-01 302-301
831-01 833-02 306-302 308-302
SPRING WASHER ••••••••••••••• 58-57 62-57 310-302 351-01
SPRING, PLUNGER •••••••••••••••••• 308-302 352-01 364-362
SPRING, RETURN ••••••••••••••••••••• 66-6~ 381-01 383-03
STAy •••••••••••••••••••••••• 32-31 36-01 405-403 505-02
STEERING ASSy ••••••••••• 302-301 307-302 VALVE ASSY •••••••••••••••••• 21-12 91-01
STOPpER ••••••••••••••••••••• 24-12 32-31 92-91 93-91
33-32 49-48 302-301 310-302
56-53 305-304 VALVE ASSY, CHECK ••••••••• 55-53 136-134
404-403 406-403 305-304 364-362
STRAINER ••••••••••••••••••••••••••• 80-79 VALVE ASSy, RELIEF •••••••••• 12-11 20-12
SUPPORT ••••••••••••••••• 112-110 202-201 135-134
282-01 703-01 VALVE, AIR ••••••• ~ •••••• 302-301 310-302
722-01 VALVE, BOOSTER •••••••••• 202-201 271-252
SUPPORT, CAB ••••••••••••••••••••• 302-301 VALVE, BRAKE ••••••••••••••••••••••• 93-91
SUPPORT, PACKING •••••••• 404-403 406-403 VALVE, By-pASS •••••••••••••••••••• 201-01
SUPPORT, SEAL •••••••••••••••••••••• 78-76 VALVE, CHECK •••••••••••••••• 20-12 37-01
SUPPORT, SPRING ••••••••••••• 55-53 66-64 55-53 92-91
364-362 93-91 136-134
SWITCH •••••••••••••••••••••• 17-12 18-12 302-301 364-362
97-95 307-302 405-403
309-302 368-361 VALVE, CONTROL •••••••••••••• 37-01 38-37
704-01 705-01 39-01 40-39
706-01 716-01 76-01 77-76
719-01 134-01 135-134
SWITCH ASSy •••••••••••••••• 12-11 143-01 VALVE, CONTROL, 2WAY •••• 302-301 308-302
SWITCH MAGNET •••••••••••••••••••••• 96-95 VALVE, COUNTER BALA ••••• 114-110 116-114
SWITCH THERMO •••••••••••••••••••••• 80-79 VALVE, DIVIDER, FLOw ••••••••••••• 412-403
SWITCH, HEATER ••••••••••••••••••• 309-302 VALVE. HORN •••••••••••••••••••••• 311-302
SWiTCH, LOW PRESSURE ••••••••••••• 302-301 VALVE, PILOT •••••••••••••• 55-53 364-362
SWITCH, STARTER ••••••••••• 17-12 309-302 403-401 405-403
SWITCH, STOP LIGHT ••••••••••••••• 302-301 VALVE, POPPET •••••••••••••••••••• 271-252
SWiVEL ASSy ••••••••••••••••• 48-01 49-48 VALVE, RELAy •••••••••••••••• 91-01 93-91
VALVE, RELIEF ••••••••••••••• 40-39 77-76
116-114 362-361
<T > 366-362 367-362
VALVE, SECTION ••••••••••••••••••••• 40-39
TANK ASSy •••••••••••••••••••••••• 302-301 VALVE, SHUTTLE ••••••••••••••••••• 135-134
TANK ASSY, FUEL •••••••••••••••••••• 89-01 VALVE, SOLENOiD ••••••••••• 78-76 115-114
TANK ASSY, HYD ••••••••••••••••••••• 79-01 362-361 365-362
TANK ASSY, WASHER •••••••••••••••• 302-301 412-403
TANK, AIR •••••••••••••••••••••••••• 12-11 VALVE, SPRING •••••••••••••••••••••• · 40-39
TANK, .FUEL ••••••••••••••••••••••••• 89-01 VALVE,CONTROL •••••••••••••••••••• 115-114
TOOL ASSy ••••••••••••••••••••••••• 611-01 VALVE, CONTROL O/R •••••••••••••••••• 76-01
TRANSMISSiON •••••••••••• 202-201 203-202 VALVE,DRAIN •••••••••••••••••••••••• 92-91
VALVE,PILOT CHCECK ••••••••••••••••• 53-01
VALVE,PILOT CHECK •••••••••••••••• 362-361
VALVE,RELIEF ••••••••••••••••••••••• 38-37
 ALPHABETICAL INDEX < OMT450 >

< w>

WEDGE •••••••••••••••••••••••••••• 112-110

WINDOW ASSY •••••••••••••••••••••••• 87-86
WIPER ••••••••••••••••••••••• J3-32 38-37
135-134
WIPER ASSy ••••••••••••••••• 86-01 705-01
WIRE •••••••••••••••••••••••• 64-63 65-64
67-63 68-67
WIRE HARNESS •••••••••••••••• 18-12 32-31
86-01 95-01
96.,95 97-95
309-302 368-361
WIRE TIE ••••••••••••••• 11-01 37-01
39-01 53-01
89-01 91-01
95-01 134-01
143-01 201-01
301-01 362-361
381-01 382-02
383-03 384-04
WIRE, LOCK ••••••••••••••••••••••••• 11-01
WRENCH •••••••••••••••••••••••••••• 611-01

AAA-1-7