iF410

iF410S

SERVICE
MANUAL
iF420
iF420S

UHF FM TRANSCEIVER

iF410
iF410S
iF420
iF420S

Downloaded from www.dlmanuals.com

 Cover420s 99.2.17 10:40 AM Page 2

INTRODUCTION DANGER
This service manual describes the latest service information NEVER connect the transceiver to an AC outlet or to a DC
for the IC-F410, IC-F410S, IC-F420 and IC-F420S UHF FM power supply that uses more than 16 V. This will ruin the
TRANSCEIVERS at the time of publication. transceiver.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when

connecting the transceiver.
To upgrade quality, any electrical or mechanical parts and DO NOT apply an RF signal of more than 20 dBm (100 mW)
internal circuits are subject to change without notice or to the antenna connector. This could damage the transceiv-
obligation. er's front end.

iF410/F420

iF410S/F420S

ORDERING PARTS REPAIR NOTES

Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling the
replacement parts: transceiver.
2. DO NOT open the transceiver until the transceiver is dis-
1. 10-digit order numbers connected from its power source.
2. Component part number and name 3. DO NOT force any of the variable components. Turn
3. Equipment model name and unit name them slowly and smoothly.
4. Quantity required 4. DO NOT short any circuits or electronic parts. An insu-
lated tuning tool MUST be used for all adjustments.
<SAMPLE ORDER> 5. DO NOT keep power ON for a long time when the trans-
1150001670 IC SC-1322 IC-F410 MAIN UNIT 5 pieces ceiver is defective.
8810005840 Screw PH BT M3 x 8 NI-ZU IC-F410 Bottom cover 10 pieces 6. DO NOT transmit power into a signal generator or a
sweep generator.
Addresses are provided on the inside back cover for your 7. ALWAYS connect a 50 dB to 60 dB attenuator between
convenience. the transceiver and a deviation meter or spectrum ana-
Downloaded from www.dlmanuals.com lyzer when using such test equipment.
 EXPLICIT DEFINITIONS

• IC-F410/F410S [PMR (Personal Mobile Radio)] • IC-F420/F420S [LMR (Land Mobile Radio)]
Frequency Coverage Channel Spacing Frequency Coverage Channel Spacing
L-band 400–430 MHz 25/12.5 kHz L-band 400–430 MHz 25/12.5 kHz
ML-band 440–470 MHz 25/12.5 kHz ML-band 450–470 MHz 25/12.5 kHz
MH-band 470–490 MHz 25/12.5 kHz MH-band 470–490 MHz 25/12.5 kHz
H-band 490–520 MHz 25/12.5 kHz H-band 490–512 MHz 25/12.5 kHz

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEW

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION

4 - 1 RECEIVER CIRCUITS .................................................................................................................................4 - 1
4 - 2 TRANSMITTER CIRCUITS ..........................................................................................................................4 - 2
4 - 3 PLL CIRCUITS .............................................................................................................................................4 - 3
4 - 4 POWER SUPPLY CIRCUITS .......................................................................................................................4 - 4
4 - 5 PORT ALLOCATIONS..................................................................................................................................4 - 4

SECTION 5 ADJUSTMENT PROCEDURES

5 - 1 PREPARATION ............................................................................................................................................5 - 1
5 - 2 PLL ADJUSTMENT ......................................................................................................................................5 - 3
5 - 3 TRIMMER ADJUSTMENT............................................................................................................................5 - 4
5 - 4 BEEP ADJUSTMENT ...................................................................................................................................5 - 6

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS

9 - 1 FRONT UNIT (IC-F410/F420) ......................................................................................................................9 - 1
9 - 2 FRONT UNIT (IC-F410S/F420S) .................................................................................................................9 - 3
9 - 3 MAIN UNIT ...................................................................................................................................................9 - 5

SECTION 10 BLOCK DIAGRAM

SECTION 11 VOLTAGE DIAGRAM

11 - 1 FRONT UNIT ..............................................................................................................................................11 - 1
11 - 2 MAIN UNIT .................................................................................................................................................11 - 2

Downloaded from www.dlmanuals.com

 SECTION 1 SPECIFICATIONS

IC-F410/F410S (PMR) IC-F420/F420S (LMR)

Mesurement method ETS 300 086 EIA/TIA-152C/204D
400–430 MHz 400–430 MHz
440–470 MHz 450–470 MHz
Frequency coverage
470–490 MHz 470–490 MHz
490–520 MHz 490–512 MHz
F410 : 32 (16 ch × 2 banks) F420 : 32 (16 ch × 2 banks)
Number of channels
F410S: 8 ch, or 4 ch × 2 banks F420S: 4 ch
16K0F3E (25 kHz; Wide)
Type of emission
GENERAL

8K50F3E (12.5 kHz; Narrow)

Frequency stability ±1500 Hz ±0.0005%
Operating temperature range –20˚C to +55˚C –30˚C to +60˚C; –22˚F to +140˚F
Power supply voltage 13.2 V DC (negative ground) 13.6 V DC (negative ground)
TX max. power 7.0 A (at 25 W) / 5.0 A (at 10 W) 10.0 A (at 35 W)
Current drain
(approx.) max. audio 700 mA
RX
stand-by 200 mA
Antenna connector SO-239 (50 Ω)
Dimensions (proj. not included) 140(W) × 40(H) × 170(D) mm; 51⁄2(W) × 119⁄32(H) × 611⁄16(D) inch
Weight 1.2 kg; 2 lb 10 oz
Output power 25 W / 10 W 35 W
Modulation system Variable reactance frequency modulation
±5.0 kHz (Wide)
Max. freqequency deviation
TRANSMITTER

±2.5 kHz (Narrow)

Spurious emissions 0.25 µW 70 dB
70 dB (Wide)
Adjacent channel power
60 dB (Narrow)
55 dB typical (Wide) 46 dB typical (Wide)
Residual modulation
50 dB typical (Narrow) 40 dB typical (Narrow)
Limitting 60–100 % of modulation
Microphone connector 8-pin modular (600 Ω)
1st: 46.35 MHz
Intermediate freq.
2nd: 450 kHz
Sensitivity (typical)) –2 dBµV (emf) at 20 dB SINAD 0.25 µV typical at 12 dB SINAD
Squelch sencitivity –2 dBµV (emf) 0.25 µV typical
70 dB (Wide)
RECEIVER

Adjcent chnnel selectivity

60 dB (Narrow)
Spurious response 70 dB
Intermoduration 65 dB
50 dB typical (Wide) 46 dB typical (Wide)
Hum and noise
45 dB typical (Narrow) 40 dB typical (Narrow)
Audio output power 3.5 W typical at 5% distortion with a 4 Ω load
External SP connector 2-conductor 3.5 (d) mm (1⁄8")/4 Ω

All stated specifications are subject to change without notice or obligation.

1-1
Downloaded from www.dlmanuals.com
 SECTION 2 INSIDE VIEW

Power module (IC5)

Low-pass filter
AF power amplifier
(IC9: LA4425)

PLL reference TCXO *RF amplifier

(X2: CR-601) *(Q1: 3SK241)

I/O expander VCO circuit

(IC13: BU4094BCF) 2nd IF filter (FI3)
*1st mixer (Q3: 3SK241)
2nd IF filter (FI2)

1st IF filter (FI1)

*Level controller
*(IC12: M62363FP)

FM IF IC
AF switching IC
(IC11: BU4066BCF) (IC1: TA31136FN)

*Microphone amplifier Discriminator

*(IC8: NJM2904M) (X1: CDBCA450CX24)

High-pass filter
(IC6: NJM2902M)

Note:
* Located under side of the point.

2-1
Downloaded from www.dlmanuals.com
 SECTION 3 DISASSEMBLY INSTRUCTIONS

• Opening case 6 Lift the front portion of the main unit and remove it.
1 Unscrew 4 screws, A, and remove the bottom cover.
2 Unscrew 2 screws, B, and remove the front case.

• Instllation location
UT-96 TONE UNIT
UT-105 SmarTrank 2TM Logic Board

3 Unscrew 10 screws, C, and remove 2 clips, D.

4 Remove shield case, E.
5 Unsolder 3 points, F, from the antenna connector.

J5
UT-96
E UT-105

J4
D

C
F

3-1
Downloaded from www.dlmanuals.com
 SECTION 4 CIRCUIT DESCRIPTION

4-1 RECEIVER CIRCUITS 4-1-3 1ST MIXER AND 1ST IF CIRCUITS

4-1-1 ANTENNA SWITCHING CIRCUIT (MAIN unit) (MAIN unit)
The antenna switching circuit functions as a low-pass filter The 1st mixer circuit converts the received signals to a fixed
while receiving and as resonator circuit while transmitting. frequency of the 1st IF signal with the PLL output frequency.
The circuit does not allow transmit signals to enter receiver By changing the PLL frequency, only the desired frequency
circuits. will pass through a pair of crystal filters at the next stage of
the 1st mixer.
Received signals enter the antenna connector and pass
through the low-pass filter (L1–L3, C1, C2, C9–12). The fil- The RF signals from the bandpass filter are applied to the
tered signals are then applied to the RF circuit passed 1st mixer circuit (Q3). The applied signals are mixed with the
through the λ⁄4 type antenna switching circuit (D4, D5, L5). 1st LO signal coming from the RX VCO circuit (Q23) to pro-
duce a 46.35 MHz 1st IF signal. The 1st IF signal passes
through a pair of crystal filters (FI1a/b) to suppress out-of-
4-1-2 RF CIRCUIT (MAIN unit) band signals. The filtered signal is amplified at the 1st IF
The RF circuit amplifies signals within the range of frequen- amplifier (Q4) and applied to the 2nd IF circuit.
cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit pass through 4-1-4 2ND IF AND DEMODULATOR CIRCUITS
the attenuator circuit (D4, D5) and the two-stage tunable (MAIN unit)
bandpass filters (D7, D8). The filtered signals are amplified The 2nd mixer circuit converts the 1st IF signal to a 2nd IF
at the RF amplifier (Q2) and then enter other two-stage signal. A double-conversion superheterodyne system
bandpass filters (D9, D10) to suppress unwanted signals. improves the image rejection ratio and obtains stable receiv-
The filtered signals are applied to the 1st mixer circuit (Q3). er gain.

The tunable bandpass filters (D7–D10) employ varactor The 1st IF signal from the IF amplifier (Q4) is applied to the
diodes to tune the center frequency of the RF passband for 2nd mixer section of the FM IF IC (IC1, pin 16) and is then
wide bandwidth receiving and good image response rejec- mixed with the 2nd LO signal for conversion to a 450 kHz
tion. These diodes are controlled by the CPU (FRONT unit; 2nd IF signal.
IC1) via the level controller (IC12).
IC1 contains the 2nd mixer, limiter amplifier, quadrature
The attenuator circuit (D4, D5) functions only when the detector, active filter and noise amplifier circuits, etc. A
attenuator function is assigned to a programable key and tripled frequency from the PLL reference oscillator is used
turnes on to protect the RF amplifier from distortion caused for the 2nd LO signal (45.9 MHz).
by receiving excessively strong signals.
The 2nd IF signal from the 2nd mixer (IC1, pin 3) passes
When the attenuator function is turned on, the CPU (FRONT through ceramic filters (FI2 and FI3) during narrow channel
unit; IC1, pin 32) switches the voltage level of the “RF ATT” spacing selection or passes through FI2 (bypassing FI3)
line from high to low and then controls the attenuator switch only during wide channel spacing selection. It is then ampli-
(Q1). In this case, the current of D4, D5 is increased and D4, fied at the limiter amplifier section (IC1, pin 5) and applied to
D5 act as an attenuator. the quadrature detector section (IC1, pins 10, 11 and X1) to
demodulate the 2nd IF signal into AF signals.

The AF signals are output from pin 9 (IC1) and are then
applied to the AF amplifier circuit.

• 2nd IF and demodulator circuits

2nd IF filter PLL IC
IC10
45.9 MHz 17 16
FI3 FI2 BPF 3
8 7 5 3 2
Active
IC12 filter Noise
detector X2
Limiter 15.3 MHz
amp.
FM Mixer
detector
RSSI IC1
TA31136FN
9 10 11 13 16
1st IF from the IF amplifier (Q4)
AF signals
NOIS signal to the CPU (FRONT unit; IC1)
5V
X1 Discriminator

4-1
Downloaded from www.dlmanuals.com
 4-1-5 AF AMPLIFIER CIRCUIT (MAIN unit) A portion of the AF signals from the AF amplifier (IC7b)
The AF amplifier circuit amplifies the demodulated AF sig- passes through the low-pass filter (FRONT unit; Q5) to
nals to drive a speaker. remove AF (voice) signals and is applied to the CTCSS or
DTCS decoder inside the CPU (FRONT unit; IC1, pin 97) via
AF signals from the FM IF IC (IC1, pin 9) are amplified at the the “CTCIN” line to control the AF mute switch via the I/O
AF amplifier (IC7a) and then pass through the high-pass fil- expander IC (IC13).
ter (IC6) whose characteristics are controlled by the
“AFHPF” line. When “AFHPF” is at a high level, the cut off
frequency is shifted higher to remove CTCSS or DTCS sig-
nals. 4-2 TRANSMITTER CIRCUIT
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
The filtered signals from IC6 (pin 14) pass through the AF (MAIN unit)
switching IC ( IC11, pin 8, 9) and are applied to the level con-
The microphone amplifier circuit amplifies the audio signals
troller (IC12, pin 16, 15). The audio level controlled signals
from the microphone, within +6 dB/octave pre-emphasis
are again passed through the AF switching IC (IC11, pin 2,
characteristics, to a level needed for the modulation circuit.
1), applied to the de-emphasis circuit (IC4) with frequency
characteristics of –6 dB/octave, and are then power ampli-
The AF signals from the microphone are amplified at the AF
fied at the AF amplifier (IC9) to drive a speaker.
(IC8b) and limiter (IC8a) amplifiers and are then passed
through the pre-emphasis circuit (R152, C180) which has +6
dB/octave pre-emphasis characteristics.
4-1-6 RECEIVER MUTE CIRCUITS
(MAIN and FRONT units) The pre-emphasized signals are passed through the splatter
• NOISE SQUELCH filter (IC7a) and are then applied to the AF switching IC
The noise squelch circuit cuts out AF signals when no RF (IC11, pins 11, 10).
signals are received. By detecting noise components in the
AF signals, the squelch circuit switches the AF mute switch. The signals are applied to the level controller (IC12, pins 16,
15). The deviation level controlled signals are passed
A portion of the AF signals from the FM IF IC (IC1, pin 9) are through the AF switching IC (IC11, pins 3, 4), and are then
applied to the level controller (IC12, pin 24). The level con- applied to modulation circuit as the “MOD” signal.
trolled noise components are output from pin 23 and are
applied to the active filter in IC1 (pin 8). Noise components The narrow/wide switch (Q35) is connected to the input of
are amplified and output from pin 7 and are then applied to the splatter filter (IC7a) and switched by the “NWC” signal
the noise detector section (pins 10, 11). The detected noise coming from the I/O expander IC (IC13). When “NWC” is at
signals are rectified and output from pin 13 without smooth- a high level, the narrow/wide switch (Q35) shifts the filter
ing. cut-off frequency for narrow deviation selection.

The noise signal (NOIS) from IC1 (pin 13) is applied to the
CPU (FRONT unit; IC1, pin 19). The CPU analyzes the 4-2-2 MODULATION CIRCUIT (MAIN unit)
noise condition and outputs the RMUT signal via the I/O The modulation circuit modulates the VCO oscillating signal
expander IC (IC13) to toggle the AF mute switches (IC11a). (RF signal) using the microphone AF signals.

• CTCSS AND DTCS The “MOD” signals from the AF switching IC (IC11, pin 4)
The tone squelch circuit detects AF signals and opens the change the reactance of D21 to modulate the oscillated sig-
squelch only when receiving a signal containing a matching nal at the TX VCO circuit (Q25). The modulated signal is
subaudible tone (CTCSS or DTCS). When tone squelch is in amplified at the buffer amplifiers (Q28, Q30) and is then
use, and a signal with a mismatched or no subaudible tone applied to the drive amplifier circuit.
is received, the tone squelch circuit mutes the AF signals
even when noise squelch is open.

• AF circuit

AF mute AF mute AF power

AF signal IC7b IC6 switch IC12 switch IC4a amp.
from IC1 8 9 16 15 2 1
Amp. HPF Amp.
6 13
,,,,
IC11c ,,,,
,,,, IC11a
,,,, IC9
,,,, Speaker
,,,,
,,,,
,,,,
,,,,
,,,,
AF HPF ,,,, AF ATT
,,,,
,,,,
Volume control signal

TXC RMUT

4-2
Downloaded from www.dlmanuals.com
 4-2-3 DRIVE AMPLIFIER CIRCUIT (MAIN unit) The detected voltage is applied to the inverse amplifier
The drive amplifier circuit amplifies the VCO oscillating sig- (IC4b, pin 6), and the power setting voltage (T4) is applied
nal to the level needed at the power amplifier. to the other input (pin 5) for the reference. When antenna
impedance is mismatched, the detected voltage exceeds
The RF signal from the buffer amplifier (Q30) passes the power setting voltage. The output voltage of the inverse
through the T/R switch (D18) and is amplified at the buffer amplifier (IC4b, pin 7) controls the input current of the power
(Q21, Q20) and drive (Q19) amplifiers. The amplified signal module (IC5) and drive amplifier (Q19) to reduce the output
is applied to the power amplifier circuit. power via the APC controller (Q17, Q18).

4-2-4 POWER AMPLIFIER CIRCUIT (MAIN unit)

The power amplifier circuit amplifies the driver signal to an 4-3 PLL CIRCUITS
output power level. 4-3-1 PLL CIRCUIT
A PLL circuit provides stable oscillation of the transmit fre-
The RF signal from the drive amplifier (Q19) is applied to the quency and receive 1st LO frequency. The PLL circuit con-
power module (IC5) to obtain 35 W (for IC-F420/F420S; 25 sists of the PLL IC (IC2), loop filter and reference oscillator
W for IC-F410/F410S) of RF power. circuit and employs a pulse swallow counter.

The amplified signal is passed through the antenna switch- An oscillated signal from the VCO (Q23, Q25) passes
ing circuit (D3), low-pass filter and APC detector, and is then through the buffer amplifiers (Q28, Q29), is applied to the
applied to the antenna connector. PLL IC (IC10, pin 2) and is prescaled in the PLL IC based on
the divided ratio (N-data). The reference signal is generated
Collector voltages for the driver (Q19) and control voltage at the reference oscillator (X2) and is also applied to the PLL
for the power amplifier (IC5, pin 2) come from the APC con- IC. The PLL IC detects the out-of-step phase using the ref-
troller (Q17, Q18) to stabilize the output power. The transmit erence frequency and outputs it from pin 8. The output sig-
mute switch (Q16) controls the APC controller when transmit nal is passed thorough the loop filter (Q34, R180, R181,
mute is necessary. C203, C231) and is then applied to the VCO circuit as the
lock voltage.

4-2-5 APC CIRCUIT (MAIN unit) 4-3-2 VCO CIRCUIT (MAIN unit)
The APC circuit protects the power amplifier from a mis- The VCO circuit contains a separate RX VCO (Q23, D20,
matched output load and stabilizes the output power. D34) and TX VCO (Q25, D22, D33). The oscillated signal is
amplified at the buffer amplifiers (Q28, Q29) and is then
The APC detector circuit (D1) detects forward signals and applied to the T/R switching circuit (D18, D19). The Rx sig-
reflection signals. The combined voltage is at minimum level nal is applied to the 1st mixer circuit (Q3) and the Tx signal
when the antenna impedance is matched at 50 Ω and is to the driver (Q19) via the buffer amplifers (Q21, Q20).
increased when it is mismatched.
A portion of the signal from Q28 is amplified at the buffer
amplifier (Q29) and is then fed back to the PLL IC (IC10,
pin 2).

• PLL circuit

RX VCO Buffer
D18 to transmitter circuit
Q30

Q23, D20, D34 Buffer

to 1st mixer circuit
Q28
D19
TX VCO Buffer

Q29
Q25, D22, D33
Loop
filter IC10 (PLL IC)

8 Phase Programmable 2
Prescaler
detector counter
45.9 MHz signal 3
to the FM IF IC Programmable PLST
17 4
×3 Shift register SCK
divider 5 SO

X1 15
15.3 MHz

4-3
Downloaded from www.dlmanuals.com
 4-4 POWER SUPPLY CIRCUITS
4-4-1 VOLTAGE LINES (MAIN unit) CPU (IC1)—continued
Line Description Pin Port
Description
number name
VCC The voltage from a DC power supply.
Outputs RF attenuator control signal to
The same voltage as the VCC line which is con- 32 RFATT the attenuator switch (MAIN unit; Q1).
trolled by the power switching circuit (Q14, Q15). Low : While attenuator function is ON.
HV When the [POWER] switch is pushed, the CPU
outputs the “PWON” control signal to the power Input port for PLL unlock signal from
switching circuit to turn the circuit ON. 36 UNLK the PLL IC (MAIN unit; IC10).
High: During unlock.
Common 5 V for the CPU converted from the
VCC line by the CPU5V regulator circuit (IC3). 37 PWON Outputs control signal for the power
CPU5V switching circuit (MAIN unit; Q14, Q15).
The circuit outputs the voltage regardless of the
power ON/OFF condition. Outputs control signal for LCD back-
Common 8 V converted from the HV line by the 38 DIM light.
8V Low : While LCD backlight is ON.
8V regulator circuit (IC2).
Input port for the PTT switch from the
Common 5 V converted from the HV line by the
5V 39 EXTPTT external connector (MAIN unit; J5).
5V regulator circuit (Q12, Q13).
Low : External PTT switch is ON.
Receive 8 V controlled by the R8 regulator circuit
Input port for the LCD backlight control
R8 (Q10, Q11) using the “TXC” signal from the I/O
signal from the external connector
expander IC (IC13). 40 DIMIN
(MAIN unit; J5).
Transmit 8 V controlled by the T8 regulator circuit Low : External dimmer switch is ON.
T8 (Q8, Q9) using the “TXC” signal from the I/O Outputs strobe signals for the PLL IC
expander IC (IC13). 41 PLST
(MAIN unit; IC10).
Outputs strobe signals for the level
42 DAST
controller IC (MAIN unit; IC12).
Outputs strobe signals for the I/O
43 EXST
4-5 PORT ALLOCATIONS expander IC (MAIN unit; IC13).
4-5-1 CPU (FRONT unit; IC1) 45, 46 KS1, KS0 Output ports for the key matrix.
Pin Port
Description KR3–
number name 47–50 Input ports for the key matrix.
KR0
Input port for overvoltage detection Outputs control signal for the beep
1 VIN
from the connected power supply. 51 BM mute circuit (Q10).
Outputs clock signal to the EEPROM High: Beep muted.
(IC3), PLL IC (MAIN unit; IC10) and CTDA0– Output ports for the CTCSS/ DTCS sig-
12 SCK 52–54
expander ICs (MAIN unit; IC12, IC13), CTDA2 nals.
etc.
Input port for the microphone hanger
Input port for the data signals from the 55 HANG detection signal.
13 SI
EEPROM (IC3), etc. Low : Microphone on hook
Outputs data signals to the EEPROM Output port
(IC3), PLL IC (MAIN unit; IC10) and 90 MTONE beep audio while receiving.
14 SO
expander ICs (MAIN unit; IC12, IC13), 2/5 tone signals while transmitting.
etc.
91 TONED Outputs DTMF signals.
16 CLIN Input port for the cloning signal.
OPV3– Input port for the option connector state
17 CLOUT Output port for the cloning signal. 94–96
OPV1 (MAIN unit; J4).
Input for the POWER switch. Input port for the CTCSS/DTCS
Low : While POWER switch is 97 CTCIN
18 POSW decode signals.
pushed.
98 SD Input port for S-meter signal.
NOIS signal input port from the FM IF
99 LVIN Input port for PLL lock voltage.
19 NOIS IC (MAIN unit; IC1) for noise squelch
operation. Input port for the transceiver’s internal
100 TEMP
temperature.
Input port for the PTT switch.
26 PTT
Low : While PTT switch is pushed.

4-4
Downloaded from www.dlmanuals.com
 4-5-2 I/O expander IC
(1) IC12 (MAIN unit)
Pin Port
Description
number name
Output tunable band pass filter control
2, 3, 10 T1–T3
signals.
Output port for
tunable band pass filter control signal
11 T4 while receiving.
output power control signal while
transmitting.
Output port for reference frequency
14 REF
control voltage.

(2) IC13 (MAIN unit)

Pin Port
Description
number name
Outputs control signal for the R8 regu-
4 TXC rator circuits (MAIN unit; Q10, Q11).
High: While transmitting.
Outputs control signal for the T8 regu-
5 TMUT rator circuits (MAIN unit; Q8, Q9).
High: While Tx is muted.
Outputs AF mute switch (MAIN unit;
IC11) control signal for the receiver cir-
6 RM cuit.
High: While no receive audio is emit-
ed.
Outputs MIC mute control signal.
7 MM High: While DTMF signals are output,
etc.
Outputs external device control signal.
11 HORNO High: When matched 2/5-tone signals
are received.
Outputs control signal for the AF ampli-
12 AFATT fier regulator circuit.
High: When squelch is open, etc.
Outputs AF filter control signal.
13 AFHPF High: Filters out CTCSS or DTCS fre-
quency.
Outputs receive/transmit passband
width control signal.
14 NWC
High: While narrow bandwidth is
selected.

4-5
Downloaded from www.dlmanuals.com
 SECTION 5 ADJUSTMENT PROCEDURES

5-1 PREPARATION
‘ REQUIRED TEST EQUIPMENT
EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE
Output voltage : 13.2 (13.6) V DC Frequency range : 300–3000 Hz
DC power supply Audio generator
Current capacity : 15 A or more Measuring range : 1–500 mV
Measuring range : 1–50 W Frequency range : 0.1–600 MHz
Standard signal
RF power meter Frequency range : 300–600 MHz Output level : 0.1 µV–32 mV
generator (SSG)
(terminated type) Impedance : 50 Ω (–127 to –17 dBm)
SWR : Less than 1.2 : 1
Frequency range : DC–20 MHz
Oscilloscope
Frequency range : 0.1–600 MHz Measuring range : 0.01–20 V
Frequency counter Frequency accuracy : ±1 ppm or better
Sensitivity : 100 mV or better AC millivoltmeter Measuring range : 10 mV–10 V

Frequency range : DC–600 MHz Input impedance :4Ω

FM deviation meter External speaker
Measuring range : 0 to ±10 kHz Capacity : 5 W or more
Power attenuation : 50 or 60 dB
DC voltmeter Input impedance : 50 kΩ/V DC or better Attenuator
Capacity : 50 W or more

‘ ADJUSTMENT FREQUENCY DATA • ADJUSTMENT FREQUENCY

Before starting the adjustment, back up the original frequen-
cy data and program adjustment frequency at right using the Channel Frequency [MHz] Power
optional programming software (EX-2057 Rev. 1.0 or later No. L ∏ ML Ò ML MH ∏H Ò H selection
for IC-F410/F420, CS-F300S for IC-F410S/F420S), cloning 1 400.0 440.0 450.0 470.0 490.0 Low1
cable (OPC-478) and adaptor cable (OPC-592) for your con- 2 430.0 470.0 490.0 520.0 512.0 Low1
venience.
3 400.0 440.0 450.0 470.0 490.0 Low2
‘ TRIMMER ADJUSTMENT 4 400.0 440.0 450.0 470.0 490.0 High
When you adjust the contents on page 5-4, TRIMMER ∏: IC-F410/F410S (PMR), Ò: IC-F420/F420S (LMR)
ADJUSTMENT, the optional EX-2057 (or CS-F300S), OPC- L: L-band, ML: ML-band, MH: MH-band, H: H-band
478 and JIG CABLE (See illustration at CONNECTIONS.)
are required.

• STARTING TRIMMER ADJUSTMENT

Turn the transceiver power ON, connect a computer to the [MIC] jack using the optional OPC-478 CLONING CABLE and JIG
CABLE, then start up the "ADJUST" program in EX-2057 (or CS-F300S).

• STARTING THE PROGRAM

q Boot up DOS.
w Insert the EX-2057 (CS-F300S) backup disk into drive A. A:\>CD ADJ Boot up DOS,
e Type the following to start up the program: A:\>ADJ>ADJUST [/B] [/1] and change the
ADJ>ADJUST [/A : /B]*1 [/1 : /2]*2 [Enter] ∗∗∗∗∗ Trimmer Control Software for IC–F300 Series ∗∗∗∗∗ Rev. 1.0 directory.
A/D VIN 165 : A5h 13.23V D/A BP T1 98 : 62h 2.03V
A/D TEMPS 173 : ADh 24.81'C D/A BP T2 49 : 31h 1.41V
• The adjustment screen appears after reading set data from A/D
A/D
LVIN
SD
47 : 2Fh
38 : 26h
0.92V
0.75V
D/A
D/A
BP T3 41 : 29h
T4/POW 43 : 2Bh
1.31V
1.34V

the transceiver. D/A

D/A
DTCS BL 149 : 95h
SQL Lev 0 : 00h
58.43%
0.00%
D/A
D/A
REF
AF/Dev
147: 93h
0 : 00h
2.40V
0.00%
Startup command.
RX:440.20000MHz TX:440.10000MHz POW: High MODE: Wide
r After the adjustment screen appears, set or modify the data as Memory CH : 1

desired.
Power(Hi)
Power(L2)
: 174
: 88
‘‘‘‘‘‘‘‘‘‘‘–––––––––
‘‘‘‘‘‘‘––––––––––––––
BPF T1
BPF T2
:
:
40
- 9
‘‘‘‘‘–––––––––––––––––
‘‘‘‘––––––––––––––––––
Program starts up,
*1PLL reference crystal type.
Power(L1)
MODN
MODW
: 44
: 68
: 137
‘‘‘–––––––––––––––––––
‘ ‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – –
‘‘‘‘‘‘‘‘‘‘‘–––––––––
BPF T3
BPF T4
AF Vol.L
:
:
:
-17
-15
1
‘‘‘‘––––––––––––––––––
‘ ‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – –
– – – – – – –– – – – – – – – – – – – – – – –
then the adjust-
DTCS N
DTCS W
: 24
: 51
‘‘–––––––––––––––––––– SQL : 10 ‘‘––––––––––––––––––––
ment screen
/A: This does not activate for IC-F410/F410S/F420/F420S’s
‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – – –
TXF SET :
appears after read-
adjustment. [Space]: A/D, D/A Read ing set data from
[TAB]: Display Parameters [F8] at BPF: Sweep [F9] at BPF T1: Sweep T1~T4
/B: TCXO crystal type. (You must select [/B] for IC- [Enter] at TXF: REF Set Mode ↑ / ↓: Cursor Up/Down < / > : –/+ ESC : Quit
the transceiver.
F410/F410S/F420/F420S’s adjustment.)
*2RS-232C port number.
,,,,,,,,,,,,,,,,,,

NOTE: When the EEPROM (FRONT unit; IC3) is replaced or the transceiver displays an error message and beeps, the
,,,,,,

following operation is necessary before starting the ADJUSTMENT.

1. Download the programmed data using the EX-2057 or CS-F300S from an exact same version of the transceiver, then
save it. (See the instructions for detailed operation.)
2. Set the cursor to the [MODEL] and push the [↓] key on the computer keyboard.
3. Type "RESERVE" then push [Enter].
"Reserved" indicator flashes at the right hand, top corner on the computer screen.
4. Connect the transceiver which has been repaired, then write the data to the transceiver.

5-1
Downloaded from www.dlmanuals.com
 ‘ PROGRAM SCREEN EXAMPLE

∗∗∗∗∗ Trimmer Control Software for IC–F300 Series ∗∗∗∗∗ Rev. 1.0

Connected DC voltage A/D VIN 165 : A5h 13.23V D/A BP T1 98 : 62h 2.03V
Internal temperature A/D TEMPS 173 : ADh 24.81'C D/A BP T2 49 : 31h 1.41V
PLL lock voltage A/D LVIN 47 : 2Fh 0.92V D/A BP T3 41 : 29h 1.31V
A/D SD 38 : 26h 0.75V D/A T4/POW 43 : 2Bh 1.34V
DTCS balance level D/A DTCS BL 149 : 95h 58.43% D/A REF 147: 93h 2.40V
SQL level D/A SQL Lev 0 : 00h 0.00% D/A AF/Dev 0 : 00h 0.00%
RX:440.20000MHz TX:440.10000MHz POW: High MODE: Wide

Operating channel Memory CH : 1

Power(Hi) : 174 ‘‘‘‘‘‘‘‘‘‘‘––––––––– BPF T1 : 40 ‘‘‘‘‘–––––––––––––––––
RF output power Power(L2) : 88 ‘‘‘‘‘‘‘–––––––––––––– BPF T2 : - 9 ‘‘‘‘––––––––––––––––––
Power(L1) : 44 ‘‘‘––––––––––––––––––– BPF T3 : -17 ‘‘‘‘––––––––––––––––––
Receive sensitivity
FM deviation MODN : 68 ‘ ‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – – BPF T4 : -15 ‘ ‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – –
MODW : 137 ‘‘‘‘‘‘‘‘‘‘‘––––––––– AF Vol.L : 1 – – – – – – –– – – – – – – – – – – – – – – – Volume
DTCS balance DTCS N : 24 ‘‘–––––––––––––––––––– SQL : 10 ‘‘–––––––––––––––––––– Squelch
DTCS W : 51 ‘ ‘ ‘ ‘– – – – – – – – – – – – – – – – – –
Reference frequency TXF SET :

[Space]: A/D, D/A Read

[TAB]: Display Parameters [F8] at BPF: Sweep [F9] at BPF T1: Sweep T1~T4
[Enter] at TXF: REF Set Mode ↑ / ↓: Cursor Up/Down < / > : –/+ ESC : Quit

NOTE: The above values for settings are examples only. Each transceiver has its
own specific values for each setting.

‘ CONNECTIONS

Standard signal generator FM deviation meter RF power meter DC power supply

–17 to –125 dBm (DC measurable) 50 Ω / 1–50 W 13.2 (13.6) V /15 A
(32 mV to 0.13 µV)
Attenuator Frequency
50 dB or 60 dB counter
CAUTION:
DO NOT transmit while to DC cable
SSG is connected to to the antenna connector
the antenna connector.

Personal
computer
to an RS-232C port

Jig cable

DB9 female plug to the MIC connector

(incl. level converter circuit)
OPC-478

Jig cable
Pin 7 (GND)
Pin 6 ( MIC)

Audio generator AC
OPC-478 300 Hz to 3 kHz millivoltmeter
1 2 3 4 5 6 78

Pin 4 (PTT) Pin 5 ( MICE)

Pin 2 (Clone)
MIC connector

5-2
Downloaded from www.dlmanuals.com
 5-2 PLL ADJUSTMENT
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION UNIT ADJUST
PLL LOCK 1 • Operating frequency: (Ch1) MAIN Connect a digital 1.5 V MAIN L23
VOLTAGE [L-band] : 400.00000 MHz multi-meter or oscil-
[ML-band] ∏ : 440.00000 MHz loscope to the
[ML-band] Ò : 450.00000 MHz check point CP1.
[MH-band] : 470.00000 MHz
[H-band] : 490.00000 MHz
• Receiving
2 • Power selection : Low1 1.5 V L26
• Transmitting
3 • Operating frequency: (Ch2) 3.5–5.5 V Verify
[L-band] : 430.00000 MHz
[ML-band] : 470.00000 MHz
[MH-band] : 490.00000 MHz
[H-band] ∏ : 520.00000 MHz
[H-band] Ò : 512.00000 MHz
• Receiving
4 • Power selection : Low1
• Transmitting

DC power supply
13.2 (13.6) V / 15 A

CP1 L23
PLL lock voltage PLL lock voltage
check point adjustment for TX
L26
PLL lock voltage
adjustment for RX

5-3
Downloaded from www.dlmanuals.com
 5-3 TRIMMER ADJUSTMENT
Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

MEASUREMENT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION
REFERENCE 1 • Operating frequency: (Ch2) Rear Loosely couple a frequency 430.00000 MHz
FREQUENCY [L-band] : 430.00000 MHz panel counter to the antenna connec- [L-band]
[TXF SET] [ML-band] : 470.00000 MHz tor. 470.00000 MHz
[MH-band] : 490.00000 MHz [ML-band]
[H-band] ∏ : 520.00000 MHz 490.00000 MHz
[H-band] Ò : 512.00000 MHz [MH-band]
• Power selection : Low1 520.00000 MHz
• Transmitting [H-band] ∏
512.00000 MHz
[H-band] Ò
2 • Transmitting 430.00155 MHz
[L-band]
470.00155 MHz
[ML-band]
490.00155 MHz
[MH-band]
520.00155 MHz
[H-band] ∏
512.00155 MHz
[H-band] Ò
OUTPUT 1 • Operating frequency: (Ch4) Rear Connect an RF power meter to 35.0 W [LMR]
POWER [L-band] : 400.00000 MHz panel the antenna connector. 25.0 W [PMR]
[Power (Hi)] [ML-band] ∏ : 440.00000 MHz 10.0 W [Italy]
[ML-band] Ò : 450.00000 MHz
[MH-band] : 470.00000 MHz
[H-band] : 490.00000 MHz
• Power selection : High
• Transmitting
[Power (L2)] 2 • Power selection : Low2 (Ch3) 20.0 W [LMR]
• Transmitting 10.0 W [PMR]
5.0 W [Italy]
[Power (L1)] 3 • Power selection : Low1 (Ch1) 3.5 W [LMR]
• Transmitting 2.5 W [PMR, Italy]
FM DEVIATION 1 • Operating frequency: (CH1) Rear Connect an FM deviation meter ±4.2 kHz (Wide)
[MOD N] or [L-band] : 400.00000 MHz panel to the antenna connector ±2.1 kHz (Narrow)
[MOD W] [ML-band] ∏ : 440.00000 MHz through an attenuator.
[ML-band] Ò : 450.00000 MHz NOTE:
[MH-band] : 470.00000 MHz [Wide/Narrow] ver-
[H-band] : 490.00000 MHz sion must adjust
• Power selection : Low1 both setting.
• Connect an audio generator to the
[MIC] jack and set as:
1 kHz / 40 mV
• Set an FM deviation meter as:
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
Detector : (P–P)/2
• Transmitting

5-4
Downloaded from www.dlmanuals.com
 TRIMMER ADJUSTMENT — continued
Select an operation using [↑] / [↓]keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

MEASUREMENT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION
DTCS WAVE 1 • Operating frequency: (CH1) Rear Connect an FM deviation meter Set to flat wave
FORM [L-band] : 400.00000 MHz panel with an oscilloscope to the form
[ML-band] ∏ : 440.00000 MHz antenna connector through an
[ML-band] Ò : 450.00000 MHz attenuator.
[MH-band] : 470.00000 MHz
[H-band] : 490.00000 MHz
• Power selection : Low1
• No audio signal is applied to the [MIC]
jack
• DTCS code : 007
• Set an FM deviation meter as:
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
Detector : (P–P)/2
• Transmitting
RECEIVE • Operating frequency: (CH1) Rear Connect a SINAD meter with a 4 Minimum distortion
[BPF T1]– [L-band] : 400.00000 MHz panel Ω load to the external [SP] jack. level
[BPF T4] [ML-band] ∏ : 440.00000 MHz
[ML-band] Ò : 450.00000 MHz
[MH-band] : 470.00000 MHz
[H-band] : 490.00000 MHz
• Connect a standard signal generator to
the antenna connector and set as:
Level : 3.2 µV* (–97 dBm)
Modulation: 1 kHz
Deviation : ±3.5 kHz (Wide)
±1.75 kHz (Narrow)
• Receiving
CONVENIENT: The BPF T1–BPF T4 can be adjusted automatically.
q-1 Set each to 0, then push the [F9] key.
(The cursor must be set to the BPF T1 position.)
q-2 The connected PC tunes BPF T1–BPF T4 to peak levels.
or
w-1 Set the cursor to one of BPF T1, T2, T3 or T4 as desired.
w-2 Push [F8] to start tuning.
w-3 Pepeat w-1 and w-2 to perform additional BPF tuning.

SQUELCH 1 • Operating frequency: (CH1) Rear Connect a SINAD meter with a 4 At the point where
LEVEL [L-band] : 400.00000 MHz panel Ω load to the external [SP] jack. noise just appears.
[SQL] [ML-band] ∏ : 440.00000 MHz
[ML-band] Ò : 450.00000 MHz
[MH-band] : 470.00000 MHz
[H-band] : 490.00000 MHz
• Connect an SSG to the antenna con-
nector and set as :
Level : adjust SSG’s level to 8
dB SINAD on the con-
necting SINAD meter
Modulation: OFF
• Receiving
*This output level of a standard signal generator (SSG) is indicated as SSG’s open circuit.

5-5
Downloaded from www.dlmanuals.com
 5-4 BEEP ADJUSTMENT
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION UNIT ADJUST
BEEP AUDIO 1 • Operating frequency: Any Rear Connect an AC mil- 62.5 mV FRONT R60
• Connect an audio generator to panel livoltmeter with 4 Ω
pin 25 (MAIN unit; J2) and set load to the [SP]
as: jack.
1 kHz / 550 mV
• Squelch : OPEN
• Volume level : 1
• Receiving

• MAIN unit

SINAD DC power supply

meter 13.2 (13.6) V / 15 A

AC
millivoltmeter

Speaker
4Ω

1 15

J4

30 25 16

+
Audio
– generator

J4, pin 25
Audio input point

• FRONT unit

R60
Beep level
adjustment

5-6
Downloaded from www.dlmanuals.com
 SECTION 6 PARTS LIST

[FRONT UNIT] [FRONT UNIT]

REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
IC1 1140007911 S.IC HD6433875B20H R42 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)
IC2 1110003500 S.IC S-80742SL-A6-T1 R43 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)
IC3 1130008670 S.IC 25LC160T-I/SN R44 7410000950 S.ARRAY EXB-V8V 102JV
R45 7410000950 S.ARRAY EXB-V8V 102JV
R46 7410000950 S.ARRAY EXB-V8V 102JV
Q1 1530002060 S.TRANSISTOR 2SC4081 T107 R R47 7410000950 S.ARRAY EXB-V8V 102JV
Q3 1590000440 S.TRANSISTOR DTA143ZUA T106 C R48 7410000950 S.ARRAY EXB-V8V 102JV
1530002060 S.TRANSISTOR 2SC4081 T107 R E R49 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
Q4 1590000660 S.TRANSISTOR DTC144TU T107 R50 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q5 1590001650 S.TRANSISTOR XP4601 (TX) R51 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q6 1530002060 S.TRANSISTOR 2SC4081 T107 R R52 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q7 1530002060 S.TRANSISTOR 2SC4081 T107 R R53 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q10 1590000660 S.TRANSISTOR DTC144TU T107 R54 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C only
Q11 1530002060 S.TRANSISTOR 2SC4081 T107 R R55 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q12 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R56 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)
Q13 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R57 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
Q14 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R58 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
Q15 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R59 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q16 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R60 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC)103
Q17 1530002060 S.TRANSISTOR 2SC4081 T107 R E only R61 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q18 1590000430 S.TRANSISTOR DTC144EUA T106 E only R62 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q19 1590000430 S.TRANSISTOR DTC144EUA T106 E only R63 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R64 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R65 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
D1 1790001280 S.DIODE MA111 (TX) C only
D2 1750000130 S.DIODE DA204U T107 R66 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
D3 1750000130 S.DIODE DA204U T107 C only
D4 1750000130 S.DIODE DA204U T107 R67 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
D5 1790000620 S.DIODE MA77 (TX) C only
D6 1730002320 S.ZENER MA8051-M (TX) C only R68 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R69 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R70 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
X1 6050010150 S.XTAL CR-590 (6.8015 MHz) R71 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) E only
R72 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) E only
R73 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) E only
L1 6200001720 S.COIL NL 322522T-1R0J R74 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) E only
L3 6200003190 S.COIL NL 322522T-470J R75 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) E only
R76 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) E only
R77 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) E only
R1 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R78 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ) E only
R2 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R79 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) E only
R3 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R80 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R4 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) E only
R5 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R81 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R6 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) E only
R7 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R82 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R8 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) E only
R11 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) C only R83 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R12 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) C only E only
R14 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) C only R84 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R15 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) E only
R16 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R85 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) E only
R17 7410000950 S.ARRAY EXB-V8V 102JV R86 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) E only
R18 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R87 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) E only
R19 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R20 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R21 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C1 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R22 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) C2 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R24 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) C3 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R25 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ) C4 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R26 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) C5 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R27 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) C6 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R28 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C7 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R29 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C8 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R30 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C9 4550006200 S.TANTALUM ECST0JY106R
R31 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C10 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R32 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) C11 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R33 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) C12 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R34 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) C13 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R35 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C14 4550006140 S.TANTALUM ECST1EY474R
R36 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R37 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C16 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R38 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C17 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R39 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C18 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
R40 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C19 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A
R41 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) C20 4030009990 S.CERAMIC C1608 CH 1H 200J-T-A

C: LCD type (F410/F420), E: LED type (F410S/F420S) S.=Surface mount

6-1
Downloaded from www.dlmanuals.com
 [FRONT UNIT] [FRONT UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
C21 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A W1 7030000010 S.JUMPER MCR10EZHJ JPW (000)
C22 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W2 7030003860 S.JUMPER ERJ3GE JPW V
C23 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W3 8900007680 CABLE OPC-741
C24 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C25 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C26 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A EP1 0910049322 PCB B 5042B C
C27 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A 0910051231 PCB B 5289A E
C28 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A EP2 8930044930 LCD CONTACT SRCN-2055-SP-N-W C only
C29 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C30 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C32 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C33 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C34 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C35 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C36 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C37 4550006700 S.TANTALUM ECST1AY106R
C38 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
C39 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C40 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C41 4030008900 S.CERAMIC C1608 JB 1C 333K-T-A
C42 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C43 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C44 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C45 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C46 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C47 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C48 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C49 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C50 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C52 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C56 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C57 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C58 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C59 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C60 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C61 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C62 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C63 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C64 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C65 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C66 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C67 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C69 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C70 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C71 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C73 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C74 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C77 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C78 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C79 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C80 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C82 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C83 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C84 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C85 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C86 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C87 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C88 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C89 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C90 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A E only
C92 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A E only

J1 6450001470 CONNECTOR 95003-2881

J2 6510020510 S.CONNECTOR FH12-40S-0.5SV

DS1 5030001540 LCD LD-HU10140J C only

DS2 5040002310 S.LED SML-311YTT86 C only
DS3 5040002310 S.LED SML-311YTT86 C only
DS4 5040002310 S.LED SML-311YTT86 C only
DS5 5040002310 S.LED SML-311YTT86 C only
DS6 5040002310 S.LED SML-311YTT86 C only
DS7 5040002310 S.LED SML-311YTT86 C only
DS8 5040002310 S.LED SML-311YTT86
DS9 5040002310 S.LED SML-311YTT86
DS10 5040002310 S.LED SML-311YTT86
DS11 5040002310 S.LED SML-311YTT86
DS12 5040001760 S.LED SEC 2422C E only
DS13 5040002310 S.LED SML-311YTT86 E only
DS14 5040002310 S.LED SML-311YTT86 E only
DS15 5040002310 S.LED SML-311YTT86 E only
DS16 5040002310 S.LED SML-311YTT86 E only
DS17 5040002310 S.LED SML-311YTT86 E only

C: LCD type (F410/F420), E: LED type (F410S/F420S) S.=Surface mount

6-2
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
IC1 1110003490 S.IC TA31136FN (D,EL) D16 1790000700 DIODE DSA3A1
IC2 1180001250 S.IC TA7808F (TE16L) D17 1750000370 S.DIODE DA221 TL
IC3 1180000970 S.IC AN78L05M-(E1) D18 1790000620 S.DIODE MA77 (TX)
IC4 1110002700 S.IC NJM2904M-T1 D19 1790000620 S.DIODE MA77 (TX)
IC5 1150001670 IC S-AU27AL/SC-1322 ∏ [L-band] D20 1720000370 S.VARICAP HVU350TRF
1150001680 IC S-AU27AM/SC-1323 D21 1720000520 S.VARICAP 1T365-01-T8A
∏ [ML/[MH-band] D22 1720000370 S.VARICAP HVU350TRF
1150001690 IC S-AU27AH/SC-1324 ∏ [H-band] D23 1790001280 S.DIODE MA111 (TX)
1150001250 IC M57788L/SC1236 Ò [L-band] D24 1160000060 S.DIODE DAN202U T107
1150001260 IC M57788H/SC1237 Ò [ML-band] D25 1790001280 S.DIODE MA111 (TX)
1150001700 IC M57788UH/SC1325 Ò [MH-band] D27 1790001280 S.DIODE MA111 (TX)
1150001710 IC M57788SH/SC1326 Ò [H-band] D28 1730000520 ZENER RD20E B2
IC6 1110002680 S.IC NJM2902M-T1 D29 1160000060 S.DIODE DAN202U T107
IC7 1110002700 S.IC NJM2904M-T1 D30 1790001280 S.DIODE MA111 (TX)
IC8 1110002700 S.IC NJM2904M-T1 D31 1160000060 S.DIODE DAN202U T107
IC9 1110003090 IC LA4425A D32 1790001280 S.DIODE MA111 (TX)
IC10 1130007610 S.IC µPD3140GS-E1 (DS8) D33 1720000370 S.VARICAP HVU350TRF
IC11 1130007690 S.IC BU4066BCF-T1 D34 1720000370 S.VARICAP HVU350TRF
IC12 1190000350 S.IC M62363FP-650C
IC13 1130007700 S.IC BU4094BCF-T1
FI1 2010002230 XTAL FL-287 (46.350 MHz)
FI2 2020001270 CERAMIC CFWM450E
Q1 1590000720 S.TRANSISTOR DTA144EUA T106 FI3 2020001410 CERAMIC CFWM450G
Q2 1580000660 S.FET 3SK272-(TX)
Q3 1580000680 S.FET 3SK241-R (TX)
Q4 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) X1 6070000210 S.DISCRIMINATOR CDBCA450CX24
Q5 1530002060 S.TRANSISTOR 2SC4081 T107 R X2 6050010230 S.XTAL CR-601 (15.300 MHz)
Q7 1590000720 S.TRANSISTOR DTA144EUA T106
Q8 1540000550 S.TRANSISTOR 2SD1664 T100Q
Q9 1590000680 S.TRANSISTOR DTC114EUA T106 L1 6110002110 COIL LA-382 [H-band]
Q10 1540000550 S.TRANSISTOR 2SD1664 T100Q 6110001520 COIL LA-232 other
Q11 1590000680 S.TRANSISTOR DTC114EUA T106 L2 6110002110 COIL LA-382 [H-band]
Q12 1520000460 S.TRANSISTOR 2SB1132 T100 R 6110001520 COIL LA-232 other
Q13 1590001190 S.TRANSISTOR XP6501-(TX) .AB L3 6110002110 COIL LA-382
Q14 1550000020 S.FET 2SJ377 (TE16R) L4 6200005800 S.COIL 33CS-Y655LY-02M=P3 [H-band]
Q15 1590000680 S.TRANSISTOR DTC114EUA T106 6200005780 S.COIL 33CS-Y655LY-03K=P3 other
Q16 1590000430 S.TRANSISTOR DTC144EUA T106 L5 6200005780 S.COIL 33CS-Y655LY-03K=P3
Q17 1530002060 S.TRANSISTOR 2SC4081 T107 R L6 6170000230 COIL LW-25
Q18 1520000380 TRANSISTOR 2SB1143 S L7 6200002330 S.COIL LQN 1A 15NJ04
Q19 1530003291 S.TRANSISTOR 2SC4703-T1 SE L8 6200002330 S.COIL LQN 1A 15NJ04
Q20 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) L9 6200004440 S.COIL ELJFC 4R7M-F
Q21 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) L10 6200002330 S.COIL LQN 1A 15NJ04
Q22 1530002060 S.TRANSISTOR 2SC4081 T107 R L11 6200002330 S.COIL LQN 1A 15NJ04
Q23 1530003420 S.TRANSISTOR 2SC5110-O (TE85R) L12 6200005730 S.COIL ELJRE 39NG-F
Q24 1590000680 S.TRANSISTOR DTC114EUA T106 L13 6200003290 S.COIL ELJNC R12K-F
Q25 1530003420 S.TRANSISTOR 2SC5110-O (TE85R) L14 6200002150 S.COIL ELJNC 56NK-F
Q26 1590000680 S.TRANSISTOR DTC114EUA T106 L15 6200002520 S.COIL ELJNC R18K-F
Q27 1590000430 S.TRANSISTOR DTC144EUA T106 L16 6110001590 COIL LA-242
Q28 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) [L/ML-band], Ò [MH-band]
Q29 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) 6110001520 COIL LA-232 ∏ [MH-band], [H-band]
Q30 1530003420 S.TRANSISTOR 2SC5110-O (TE85R) L17 6200005690 S.COIL ELJRE 18NG-F
Q31 1530002060 S.TRANSISTOR 2SC4081 T107 R L18 6200005700 S.COIL ELJRE 22NG-F
Q32 1590000430 S.TRANSISTOR DTC144EUA T106 L19 6200005680 S.COIL ELJRE 15NG-F
Q33 1560000530 S.FET 2SK880-GR (TE85R) L20 6200005690 S.COIL ELJRE 18NG-F
Q34 1560000400 S.FET 2SK536-TA L21 6200005690 S.COIL ELJRE 18NG-F [H-band]
Q35 1530002060 S.TRANSISTOR 2SC4081 T107 R 6200005700 S.COIL ELJRE 22NG-F other
Q36 1590000430 S.TRANSISTOR DTC144EUA T106 L22 6200004230 S.COIL ELJNC R56K-F
Q37 1590000430 S.TRANSISTOR DTC144EUA T106 L23 6200003690 S.COIL MC152-E558ANA-100051=P3
Q38 1590000430 S.TRANSISTOR DTC144EUA T106 L24 6200001620 S.COIL ELJFC 1R0K-F
Q39 1590000430 S.TRANSISTOR DTC144EUA T106 L25 6200002520 S.COIL ELJNC R18K-F
Q40 1590001450 S.FET 2SJ144-GR (TE85R) L26 6200003690 S.COIL MC152-E558ANA-100051=P3
Q41 1590000990 S.TRANSISTOR DTC363EK T147 [L/ML-band]
Q42 1590000430 S.TRANSISTOR DTC144EUA T106 6200004110 S.COIL MC152-E558ANA-100050
Q44 1590000430 S.TRANSISTOR DTC144EUA T106 [MH/H-band]
Q45 1590000720 S.TRANSISTOR DTA144EUA T106 L27 6200001620 S.COIL ELJFC 1R0K-F
Q46 1590000720 S.TRANSISTOR DTA144EUA T106 L28 6200005710 S.COIL ELJRE 27NG-F
L30 6200005710 S.COIL ELJRE 27NG-F
L31 6200005690 S.COIL ELJRE 18NG-F
D1 1790000650 S.DIODE MA713 (TX) L32 6200004230 S.COIL ELJNC R56K-F
D3 1750000510 S.DIODE UM9401F ∏ L33 6200004230 S.COIL ELJNC R56K-F
1710000310 DIODE MI407 Ò L34 6200005690 S.COIL ELJRE 18NG-F
D4 1710000730 S.DIODE MI809-T11
D5 1790000620 S.DIODE MA77 (TX)
D6 1750000260 S.DIODE 1SS352 (TPH3) R1 7030000620 S.RESISTOR MCR10EZHJ 100 kΩ
D7 1720000370 S.VARICAP HVU350TRF R2 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
D8 1720000370 S.VARICAP HVU350TRF R3 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
D9 1720000370 S.VARICAP HVU350TRF R4 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470)
D10 1720000370 S.VARICAP HVU350TRF R5 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
D12 1160000060 S.DIODE DAN202U T107 R6 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
D13 1160000060 S.DIODE DAN202U T107 R7 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470)
D14 1750000300 S.DIODE 1SS302 (TE85R) R8 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)
D15 1750000300 S.DIODE 1SS302 (TE85R) R9 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)

∏: PMR, Ò: LMR S.=Surface mount

6-3
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
R10 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R79 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω)
R11 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R80 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R81 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R13 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R82 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
R14 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R83 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R15 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R84 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R16 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R85 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R17 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R86 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R18 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) R87 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R19 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R94 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R20 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R95 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R21 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R96 7030004850 S.RESISTOR ERJ3GEYF 913 V (91 kΩ)
R22 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R97 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R23 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R98 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R99 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R25 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R100 7030005490 S.RESISTOR RR0816R-363-D (36 kΩ)
R27 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω) R101 7030004270 S.RESISTOR ERJ3EKF 4121 V (4.12 kΩ)
R28 7030003230 S.RESISTOR ERJ3GEYJ 180 V (18 Ω) R102 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
R29 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω) R103 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)
R30 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) R104 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
R31 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R105 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
R32 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R106 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ)
R33 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) R107 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R34 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) R108 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R35 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R109 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R36 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R110 7510000910 S.THERMISTOR NTCCF2012 4AH 473KC-T
R37 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R111 7030005870 S.RESISTOR RR0816R-104-D (100 kΩ)
R38 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R112 7030005650 S.RESISTOR RR0816R-304-D (300 kΩ)
R39 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R113 7030005870 S.RESISTOR RR0816R-104-D (100 kΩ)
R40 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R114 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R41 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R115 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)
R42 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R116 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)
R44 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R117 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
R45 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ) R118 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R46 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R119 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
R47 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) [ML-band]
R48 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) other
R49 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R120 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R50 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R121 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R51 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R122 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R52 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R123 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R53 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R124 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R54 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩ R125 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R55 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩ R126 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
R56 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩ R127 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R57 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩ R128 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R58 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R129 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R59 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R130 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)
R60 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R131 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R61 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R132 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)
[H-band] R133 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) other R134 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R62 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) R135 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R63 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R136 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R64 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) R137 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R65 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R138 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)
R66 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R139 7030003230 S.RESISTOR ERJ3GEYJ 180 V (18 Ω)
R67 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R140 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)
R68 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R141 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R69 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) R142 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R70 7030000060 S.RESISTOR MCR10EZHJ 2.2 Ω (2R2) R143 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R71 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470) R144 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
∏ [L-band] R145 7030005640 S.RESISTOR RR0816R-753-D (75 kΩ)
7030000210 S.RESISTOR MCR10EZHJ 39 Ω (390) R146 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)
∏ [ML/MH-band] R147 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
7030000180 S.RESISTOR MCR10EZHJ 22 Ω (220) R148 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Ò [H-band] R150 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
7030000200 S.RESISTOR MCR10EZHJ 33 Ω (330) other R151 7030003820 S.RESISTOR ERJ3GEYJ 155 V (1.5 MΩ)
R72 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470) R152 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)
∏ [L/ML-band] R153 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
7030000210 S.RESISTOR MCR10EZHJ 39 Ω (390) R154 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
∏ [MH/H-band] R155 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
7030000200 S.RESISTOR MCR10EZHJ 33 Ω (330) R156 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)
Ò [L/ML/MH-band] R157 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ)
7030000190 S.RESISTOR MCR10EZHJ 27 Ω (270) R158 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
Ò [H-band] R159 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
R73 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R160 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R74 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) R161 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)
R75 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R162 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)
R76 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R163 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R77 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R164 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R78 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) R165 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)

∏: PMR, Ò: LMR S.=Surface mount

6-4
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
R166 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R260 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R167 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [MH-band]
R168 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) other
R169 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R264 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R170 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) R265 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R172 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R266 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R173 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R267 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ)
R174 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R268 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R175 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R269 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R176 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R270 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R177 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R271 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R178 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R272 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R179 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R273 7030003790 S.RESISTOR ERJ3GEYJ 824 V (820 kΩ)
R180 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R274 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R181 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R275 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R182 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R276 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R184 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) R277 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R185 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R278 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R186 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R280 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R187 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R281 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R188 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R282 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
R189 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R190 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R191 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω) C1 4030011090 S.CERAMIC GRM42-6 CH 070D 500PT
R193 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) [L/ML-band]
R194 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
R195 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) ∏ [MH-band]
R198 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 4030011080 S.CERAMIC GRM42-6 CH 060D 500PT
R199 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) Ò [MH-band], [H-band]
R204 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C2 4030011090 S.CERAMIC GRM42-6 CH 070D 500PT
R205 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) [L/ML-band]
R206 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
R207 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) ∏ [MH-band]
R208 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 4030011080 S.CERAMIC GRM42-6 CH 060D 500PT
R209 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) Ò [MH-band], [H-band]
R210 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C3 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R211 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C5 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R212 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C6 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R213 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C7 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
R214 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C8 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R215 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C9 4030011090 S.CERAMIC GRM42-6 CH 070D 500PT
R216 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) [L/ML-band]
R217 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
R218 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) ∏ [MH-band]
R219 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011060 S.CERAMIC GRM42-6 CH 040C 500PT
R220 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [H-band]
R221 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011080 S.CERAMIC GRM42-6 CH 060D 500PT
R222 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) Ò [MH-band]
R223 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C10 4030011110 S.CERAMIC GRM42-6 CH 090D 500PT
R224 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [L/ML-band]
R225 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011080 S.CERAMIC GRM42-6 CH 060D 500PT
R226 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) ∏ [MH-band]
R227 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011100 S.CERAMIC GRM42-6 CH 080D 500PT
R228 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) Ò [MH-band], [H-band]
R229 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C11 4030011040 S.CERAMIC GRM42-6 CK 020C 500PT
R230 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [L-band]
R231 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011020 S.CERAMIC GRM42-6 CK 010C 500PT other
R232 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C12 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
R233 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [L/ML-band], Ò [H-band]
R234 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011060 S.CERAMIC GRM42-6 CH 040C 500PT
R235 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) ∏ [MH/H-band]
R236 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011050 S.CERAMIC GRM42-6 CJ 030C 500PT
R237 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) Ò [MH-band]
R238 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C13 4030011240 S.CERAMIC GRM42-6 CH 470J 500PT ∏
R239 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4010005730 CERAMIC HM60SJ SL 470J 500V Ò
R240 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C14 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
R241 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) ∏ [L/ML/MH-band]
R242 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011050 S.CERAMIC GRM42-6 CJ 030C 500PT
R243 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) Ò [MH-band], [H-band]
R245 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011060 S.CERAMIC GRM42-6 CH 040C 500PT
R246 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) Ò [L/ML-band]
R247 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C15 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
R248 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C16 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
R249 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C17 4030011040 S.CERAMIC GRM42-6 CK 020C 500PT
R250 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [H-band]
R251 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 4030011100 S.CERAMIC GRM42-6 CH 080D 500PT other
R252 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C18 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-A
R254 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) C19 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R255 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C20 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-A
R257 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C21 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
R258 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R259 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)

∏: PMR, Ò: LMR S.=Surface mount

6-5
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
C22 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A [L-band] C73 4030004760 S.CERAMIC C2012 JF 1E 104Z-T-A
4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C74 4510005290 S.ELECTROLYTIC
ECEV1EA221P
[ML/H-band] C75 4510004630 S.ELECTROLYTIC
ECEV1CA100SR
4030009910 S.CERAMIC C1608 CH 1H 040B-T-A C76 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
[MH-band] C77 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C23 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A [L-band] C78 4510004630 S.ELECTROLYTIC
ECEV1CA100SR
4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-A C79 4510004630 S.ELECTROLYTIC
ECEV1CA100SR
[ML/MH-band] C80 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C24 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A [L-band] C81 4030004760 S.CERAMIC C2012 JF 1E 104Z-T-A
4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A other C82 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C25 4030009560 S.CERAMIC C1608 CH 1H R75B-T-A [H-band] C83 4030004760 S.CERAMIC C2012 JF 1E 104Z-T-A
4030009510 S.CERAMIC C1608 CH 1H 010B-T-A other C84 4510004510 ELECTROLYTIC 25 MV 470 HC
C26 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A [L-band] C85 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C86 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
[ML-band] C87 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C88 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
[MH/H-band] C89 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C27 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C90 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C28 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-A [L-band] C91 4510006850 S.ELECTROLYTIC
ECEV 1CA 4R7NR (16V 4.7)
4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A C92 4510004630 S.ELECTROLYTIC
ECEV1CA100SR
[ML/MH-band] C93 4030011050 S.CERAMIC GRM42-6 CJ 030C 500PT
C29 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-A [H-band] ∏ [L/ML-band]
4030009910 S.CERAMIC C1608 CH 1H 040B-T-A other 4030011060 S.CERAMIC GRM42-6 CH 040C 500PT
C30 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A ∏ [MH/H-band]
C31 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A 4010005440 CERAMIC HM60SJ CH 060D 500V
C32 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-A [L-band] Ò [L-band]
4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-A 4010005420 CERAMIC HM60SJ CH 040C 500V
[ML-band] Ò [ML/MH/H-band]
4030009520 S.CERAMIC C1608 CH 1H 020B-T-A C94 4030011050 S.CERAMIC GRM42-6 CJ 030C 500PT
[MH-band] ∏ [L/ML-band]
4030009510 S.CERAMIC C1608 CH 1H 010B-T-A [H-band] 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT
C33 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A ∏ [MH-band]
C34 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A [L-band] 4030011040 S.CERAMIC GRM42-6 CK 020C 500PT
4030011770 S.CERAMIC C1608 CH 1H 060B-T-A ∏ [H-band]
[ML-band] 4010005410 CERAMIC HM60SJ CJ 030C 500V
4030009910 S.CERAMIC C1608 CH 1H 040B-T-A Ò [L-band]
[MH/H-band] 4010005440 CERAMIC HM60SJ CH 060D 500V
C35 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A Ò [ML-band]
C36 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A 4010005420 CERAMIC HM60SJ CH 040C 500V
C37 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A [L-band] Ò [MH-band]
4030009570 S.CERAMIC C1608 CH 1H 0R3B-T-A other 4010005400 CERAMIC HM60SJ CK 020C 500V
C38 4030009550 S.CERAMIC C1608 CH 1H 2R5B-T-A [L-band] Ò [H-band]
4030009540 S.CERAMIC C1608 CH 1H 1R5B-T-A C95 4510005750 S.ELECTROLYTIC ECEV1EA220SP
[ML/MH-band] C96 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A [H-band] C97 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C39 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A [L-band] C98 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C99 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
[ML-band] C100 4510005750 S.ELECTROLYTIC ECEV1EA220SP
4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C101 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
[MH/H-band] ∏ [H-band]
C40 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A other
C41 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A C102 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A [H-band]
C42 4030009530 S.CERAMIC C1608 CH 1H 030B-T-A 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A other
C43 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C103 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A
C44 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C104 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C45 4030007110 S.CERAMIC C1608 CH 1H 680J-T-A C105 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C46 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C107 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C47 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A C108 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A [H-band]
C48 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A other
C49 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C109 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A [H-band]
C50 4030007110 S.CERAMIC C1608 CH 1H 680J-T-A 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A other
C51 4030007130 S.CERAMIC C1608 CH 1H 101J-T-A C110 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C52 4030007130 S.CERAMIC C1608 CH 1H 101J-T-A C111 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C54 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C112 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C55 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C113 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
C56 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C115 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C57 4550006320 S.TANTALUM ECST0JY475R C116 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C58 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C117 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C59 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C118 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C60 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C119 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C61 4030011280 S.CERAMIC C1608 CH 1H 271J-T-A C120 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C62 4030011280 S.CERAMIC C1608 CH 1H 271J-T-A C121 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C63 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C126 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C64 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C127 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C65 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C128 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C66 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C129 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C67 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C130 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C68 4510004630 S.ELECTROLYTIC ECEV1CA100SR C131 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C69 4550006540 S.TANTALUM ECST1CY475R C132 4030011310 S.CERAMIC C2012 JB 1A 564K-T-A
C70 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C133 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C71 4510004630 S.ELECTROLYTIC ECEV1CA100SR C134 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C72 4550006450 S.TANTALUM ECST1EY105R C135 4550006170 S.TANTALUM ECST1AY225R

∏: PMR, Ò: LMR S.=Surface mount

6-6
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
C137 4030006850 S.CERAMIC C1608
JB 1H 471K-T-A C187 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C138 4030006860 S.CERAMIC C1608
JB 1H 102K-T-A C188 4550006320 S.TANTALUM ECST0JY475R
C139 4030008230 S.CERAMIC C1608
UJ 1H 080D-T-A [L-band] C189 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
4030008210 S.CERAMIC C1608
UJ 1H 060D-T-A C190 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
[ML-band] C191 4030008850 S.CERAMIC C1608 JB 1C 123K-T-A
4030008190 S.CERAMIC C1608 UJ 1H 040C-T-A C193 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
[MH/H-band] C194 4510005290 S.ELECTROLYTIC ECEV1EA221P
C141 4030008270 S.CERAMIC C1608 UJ 1H 180J-T-A [L-band] C195 4510006260 S.ELECTROLYTIC ECEV1AA471UP
4030008260 S.CERAMIC C1608 UJ 1H 150J-T-A C196 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[ML/MH-band] C197 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030008250 S.CERAMIC C1608 UJ 1H 120J-T-A [H-band] C198 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C142 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A [L-band] C199 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C200 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[ML-band] C201 4550006360 S.TANTALUM ECST1VY104R
4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C202 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
[MH-band] C203 4550006430 S.TANTALUM ECST1VY474R
4030009530 S.CERAMIC C1608 CH 1H 030B-T-A [H-band] C204 4550006430 S.TANTALUM ECST1VY474R
C143 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A [L-band] C205 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030006990 S.CERAMIC C1608 CH 1H 080D-T-A C206 4510004630 S.ELECTROLYTIC ECEV1CA100SR
[ML-band] C207 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C208 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
[MH-band] C209 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030009920 S.CERAMIC C1608 CH 1H 050B-T-A [H-band] C210 4550006170 S.TANTALUM ECST1AY225R
C144 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C211 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C145 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C212 4510006850 S.ELECTROLYTIC ECEV 1CA 4R7NR (16V 4.7)
C146 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A C213 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C147 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A C214 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C148 4030008200 S.CERAMIC C1608 UJ 1H 050C-T-A C215 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
[L/MH-band] C216 4030007050 S.CERAMIC C1608 CH 1H 220J-T-A
4030008190 S.CERAMIC C1608 UJ 1H 040C-T-A C217 4030007050 S.CERAMIC C1608 CH 1H 220J-T-A
[ML/H-band] C218 4030007050 S.CERAMIC C1608 CH 1H 220J-T-A
C149 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A C219 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[MH-band] C221 4030008470 S.CERAMIC C1608 JB 1H 272K-T-A
4030009350 S.CERAMIC C1608 CH 1H 3R5B-T-A [H-band] C222 4030007040 S.CERAMIC C1608 CH 1H 180J-T-A
C150 4030008240 S.CERAMIC C1608 UJ 1H 100D-T-A [L-band] C223 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
4030008230 S.CERAMIC C1608 UJ 1H 080D-T-A C225 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
[ML-band] C226 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
4030008260 S.CERAMIC C1608 UJ 1H 150J-T-A C227 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
[MH-band] C228 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030008190 S.CERAMIC C1608 UJ 1H 040C-T-A [H-band] C229 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C151 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A [L-band] C230 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030009520 S.CERAMIC C1608 CH 1H 020B-T-A C231 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[ML-band] C232 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
4030006990 S.CERAMIC C1608 CH 1H 080D-T-A C233 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[MH-band] C234 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030009530 S.CERAMIC C1608 CH 1H 030B-T-A [H-band] C235 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C152 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A C236 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
[L/MH-band] C237 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
4030009910 S.CERAMIC C1608 CH 1H 040B-T-A C238 4510004630 S.ELECTROLYTIC ECEV1CA100SR
[ML-band] C239 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
4030009530 S.CERAMIC C1608 CH 1H 030B-T-A [H-band] C240 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C153 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C241 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C154 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C242 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C155 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A C243 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C156 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A C244 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C157 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A C245 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C158 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A C246 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C159 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A C247 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C160 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A C248 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C161 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A C249 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C162 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C250 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C163 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C251 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C164 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C252 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C165 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A C253 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C166 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C254 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C167 4510004630 S.ELECTROLYTIC ECEV1CA100SR C255 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C169 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A C256 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C170 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C257 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C171 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A C258 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C172 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A C259 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C173 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A C260 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C174 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C261 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C175 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C262 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C176 4550006560 S.TANTALUM ECST1CY225R C263 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C177 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C264 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C178 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A C265 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C179 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A C266 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C180 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C267 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C183 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A C268 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C184 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A C269 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C185 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C270 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C186 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C271 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A

∏: PMR, Ò: LMR S.=Surface mount

6-7
Downloaded from www.dlmanuals.com
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION REF ORDER DESCRIPTION
NO. NO. NO. NO.
C272 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A J3 6510020510 S.CONNECTOR FH12-40S-0.5SV
C273 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A J4 6510018430 S.CONNECTOR AXN330C038P
C274 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A J5 6510019250 S.CONNECTOR B11B-ZR-SM3-TF
C275 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A J6 6510014960 S.CONNECTOR B2B-ZR-SM3-TF
C276 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C277 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C278 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W2 7120000470 JUMPER ERDS2T0
C279 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W6 8900004540 CABLE OPC-453
C281 4030011600 S.CERAMIC C1608 JB 1C 104KT-N W7 7030003860 S.JUMPER ERJ3GE JPW V
C282 4510005430 S.ELECTROLYTIC ECEV0JA220SR W8 7030003860 S.JUMPER ERJ3GE JPW V
C283 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A W9 7030003860 S.JUMPER ERJ3GE JPW V
C284 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W10 7030000010 S.JUMPER MCR10EZHJ JPW (000)
C285 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A W11 7120000480 S.JUMPER MJP-0.4-T
C286 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W12 7120000480 S.JUMPER MJP-0.4-T
C287 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A W13 7030003860 S.JUMPER ERJ3GE JPW V
C288 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A W14 7030003860 S.JUMPER ERJ3GE JPW V
C289 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A W15 7030003860 S.JUMPER ERJ3GE JPW V
C291 4030011600 S.CERAMIC C1608 JB 1C 104KT-N W16 7030003860 S.JUMPER ERJ3GE JPW V
C292 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C293 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C295 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A EP1 0910050055 PCB B 5156E
C296 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A EP2 6910011560 BEAD HF70BB4.5X5X1.6
C297 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A EP3 6910006290 BEAD HF70BB9X5X4.5
C298 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C299 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C300 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
C301 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
C302 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C303 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C304 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
C306 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C307 4550006320 S.TANTALUM ECST0JY475R
C308 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A
C309 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C310 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C311 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C312 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C313 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C314 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C315 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C316 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C317 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C318 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C319 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C321 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C322 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-A
C323 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C324 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C325 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C326 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C327 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C328 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C329 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C330 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C331 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C332 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C333 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C334 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C335 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C336 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C337 4550006000 S.TANTALUM TEMSVB2 1V 225M-8L
C338 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A
∏ [H-band]
4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
[L/ML/MH-band]
C339 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C340 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C341 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C342 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C343 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C344 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C345 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C346 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C347 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C348 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-A
C349 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-A
C350 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C351 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A

J1 6450000140 CONNECTOR HSJ0807-01-010

J2 6510007080 CONNECTOR PI28A-02M

∏: PMR, Ò: LMR S.=Surface mount

6-8
Downloaded from www.dlmanuals.com
 SECTION 7 MECHANICAL PARTS

[FRONT UNIT] [UNPACKING]

REF NO. ORDER NO. DESCRIPTION QTY. REF NO. ORDER NO. DESCRIPTION QTY.

J1 6450001470 Connector 95003-2881 1 F1 5210000120 Fuse FGB 15A [PMR] 2

5210000080 Fuse FGB 20A [LMR] 2
W3 8900007680 Cable OPC-741 1
MC1 Optional product Microphone EM-99 1
DS1 5030001540 LCD LD-HU10140J 1
W1 Optional product Cable OPC-345 [PMR] 1
EP2 8930044930 LCD contact SRCN-2055-SP-N-W 1
Optional product Cable OPC-346 [LMR] 1
MP1 8210015090 2055 LCD reflector C only 1 W2 Optional product Cable OPC-049 1
8210016090 2266 reflector E only 1
MP1 8010016380 1542 MOBIL BLACKET (B) 1
MP2 8930044110 2055 LCD holder C only 1
MP3 8820000530 Flange volt M4 X 8 NI 4
8310045980 2266 plate E only 1
MP4 8810000470 PH M5 X 12 NI 4
C: LCD type (F410/F420), E: LED type (F410S/F420S) MP5 8810005840 PH A M5 X 20 4
MP6 8850000150 Flat washer M5 NI BS 4
MP7 8850000390 Spring waser M5 4
[CHASSIS PARTS] MP8 8830000120 Nut M5 4
MP9 6910004210 731 Mic hanger set (incl. screw, washer) 1
REF NO. ORDER NO. DESCRIPTION QTY. MP10 8310042780 Label 1705 LCD seal (A) 1

J1 6510004880 Connector MR-DS-E 01 1

Screw abbreviations BT: Self-tapping PH: Pan head
SP1 2510001030 Speaker VS-57-0837A 1 FH: Flat head ZK: Black
NI-ZK: Nickel-Zinc BS: Brass
WS1 8600036130 P1CH 1

MP1 8010017100 2055 Chassis 1

MP2 8010017120 2055 Cover 1 MC1 W1
MP9 W2
MP3 8210015070 2055 Front panel 1
MP4 8930044820 2055 Front key (A) 1
MP7 8810008660 PH BT M3 X 8 NI-ZU 24
MP8 8930044100 2055 Speaker plate 1
MP9 8930044761 2055 Speaker net-1 1 LCD-STICKER

MP11 8930027480 1126 TR-A clip 2 MP1 MP3

MP12 8930039890 Insulation sheet (AM) 2
MP4

MP5
[MAIN UNIT]
MP6 MP7 MP8 F1 MP10
REF NO. ORDER NO. DESCRIPTION QTY.

J1 6450000140 Connector HSJ0807-01-010 1

W6 8900004540 Cable OPC-453 1

EP3 6910006290 Bead HF70BB (9 X 5 X 4.5) 2

MP1 8510009980 1705 VCO case 1

MP2 8510010080 1705 VCO cover 1
MP3 8510011460 2055 Filter case 1
MP4 8510011610 2055 Filter cover (A) 1
MP5 8510000210 194 Shield plate 1
MP6 8510005070 599 Shield plate 1
MP7 8930045920 2056 Sponge 1
MP8 8930045930 2056 M-holder 1
MP9 8930046150 Rubber sheet (AK)-1 1
MP10 8930045390 Sponge (FL) 1
MP11 8930045920 2056 Sponge 1
MP12 8930045070 2056 M-plate 1
MP13 8930045920 2056 Sponge [LMR] only 1
MP14 8930046770 Thermally sheet (G) [LMR] only 1
MP15 8510002280 VCO cover 1
MP16 8930048870 2056 A-Sponge [H-band] only 1
MP17 8510002280 VCO cover [H-band] only 1
MP18 8930048870 2056 A-Sponge [H-band] only 1

7-1
Downloaded from www.dlmanuals.com
 MP1 (F) MP7 (C)
MP18 (M) MP13 (M) MP16 (M)
MP2 (F)

MP17 (M) MP15 (M)

MP1 (C) J1 (C)
QTY. MP5 (M)
TX MP11 (M)
/R
X
1

3 S

4
MP6 (M)

MAIN UNIT (Bottom side)

LED type only
(IC-F410S/F420S)

MP12 (M)
MP9 (M)
MP3 (M)
MP7 (C) J1 (M)

EP3 (M)
W3 (F)

MP7 (C)
J1 (F)

W6 (M)
MP7 (C)

MP4 (M)
MP10 (M)

FRONT UNIT
MP11 (C)

MP1 (F) MP14 (M)

MP1 (M)
MP9 (C)
EP2 (F)

DS1 (F) MP8 (M)

MP2 (F) SP1 (C)

LCD type only
(IC-F410/F420)
WS1 (C) MP2 (M)

MP7 (M)
MP4 (C)
MP3 (C) MP8 (C) MP7 (C)
MP2 (C)

MP7 (C)
MP12 (C)

MP12 (C) MP7 (C)

Unit abbreviations (F): FRONT UNIT (M): MAIN UNIT (C): CHASSIS PARTS

7-2

Downloaded from www.dlmanuals.com

 SECTION 8 SEMI-CONDUCTOR INFORMATION

• TRANSISTORS AND FET'S • DIODES

2SB1132 R 2SB1143 S 2SC4081 R 2SC4215 O 2SC4703 SE 1SS302 1SS352 1T365 DA221 DAN202U
(Symbol: BARB) (Symbol: BR) (Symbol: QO) (Symbol: SE) (Symbol: C3) (Symbol: C1) (Symbol: pink line)N) (Symbol: K) (Symbol: N)

B
E C

2SC5107 O 2SC5110 O 2SD1664 Q 2SJ144 GR 2SJ377 DAN204U HVU350 MA77 MA111 MA713
(Symbol: MF) (Symbol: MGO) (Symbol: DAQ) (Symbol: VG) (Symbol: 4L) (Symbol: K) (Symbol: 4) (Symbol: 4B) (Symbol: 1B) (Symbol: MIN)
D

S D
S
G

D
G
S

2SK241 R (TX) 2SK272 2SK536 2SK880 GR DTA143ZU MA8051 M (TX) MI809 UM9401F
(Symbol: DU) (Symbol: K) (Symbol: BJ) (Symbol: XG) (Symbol: 113) (Symbol: 5-1) (Symbol: Red dot)

D G2 D G2 G S

S G

S G1 S G1 D D

DTA144EU DTC114EU DTC144EU DTC144TU DTC363EK

(Symbol: 16) (Symbol: 24) (Symbol: 26) (Symbol: 06) (Symbol: H27)

XP4601 XP6501
(Symbol: 5C) (Symbol: 5N)

8-1

Downloaded from www.dlmanuals.com

 SECTION 9 BOARD LAYOUTS

9-1 FRONT UNIT (IC-F410/F420)

¡TOP VIEW

2 8
J1
HANGER
CLONE
PTT
MIC
MICE
GND
AFO
8V

1 7
to Microphone

9-1

Downloaded from www.dlmanuals.com

 ¡BOTTOM VIEW

Downloaded from www.dlmanuals.com

J2

40
8V

39
5V
CPU5V
AFO
GND
SI
OPINT
OPT3
OPCS
OPT2
BUSY
OPT1
BEEPOUT
OPV3
TONE
OPV2
BEEP
OPV1
DTCSIN
PTT
RFATT
PTTIN
NOIS

to MAIN unit J3
DET
UNLK
PWON
EXEN
EXPTT
EXST
DIMIN
DAST
SO
PLST
SCK
VIN
SD
TEMP
LVIN

2
MIC

1
GND

9-2
 9-2 FRONT UNIT (IC-F410S/F420S)
¡TOP VIEW

2 8
J1
HANGER
CLONE
PTT
MIC
MICE
GND
AFO
8V

1 7
to Microphone

9-3

Downloaded from www.dlmanuals.com

 ¡BOTTOM VIEW

Downloaded from www.dlmanuals.com

J2

40
8V

39
5V
CPU5V
AFO
GND
SI
OPINT
OPT3
OPCS
OPT2
BUSY
OPT1
BEEPOUT
OPV3
TONE
OPV2
BEEP
OPV1
DTCSIN
PTT
RFATT
PTTIN
NOIS

to MAIN unit J3
DET
UNLK
PWON
EXEN
EXPTT
EXST
DIMIN
DAST
SO
PLST
SCK
VIN
SD
TEMP
LVIN

2
MIC

1
GND

9-4
 J4
1

30
GND PTTIN

¡TOP VIEW
5V PTTOUT
HV MICOUT
MICMUTE MICIN
AFONOP NC

9-3 MAIN UNIT

BEEPOUT BUSY
RXMUTE NC
DET SIGOUT
AFOUT OPT1

to Optional unit
NC OPT2

2
1
1
2

1
OPCS OPT3

11
OPINT GND

J2
J6

J5
SO OPV3

IN
SP
HV

HV
DIM
PTT

DET

AFO
SI OPV2

GND

GND
GND
GND
GND

HORN
SPGND
to Speaker
SCK OPV1

16
15
to Optional cable

9-5

Downloaded from www.dlmanuals.com

J3

1
8V

2
5V
CPU5V
AFO
GND
SI
OPINT
OPT3
OPCS
OPT2
BUSY
OPT1
BEEPOUT
OPV3
TONE
OPV2
BEEP
OPV1
DTCS
PTT
RFATT
PTTIN
NOIS
DET
to FRONT unit UNLK
PWON
EXEN
EXPTT
EXST
DIMIN
DAST
SO
PLST
SCK
VIN
SO
TEMP
LVIN
MIC
39

GND
40

W1

NOTE:

,,
ANT

is Soldering portion.
J1
 ¡BOTTOM VIEW

SP

9-6

Downloaded from www.dlmanuals.com

 SECTION 10 BLOCK DIAGRAM

DET
AFOUT
NWC N/W N/W
SW SW R8V R8V
HV 8V FI3 D13 FI1 D10 D9 D8 D7 D3, D4, D5 FOR
IC6C, D D12 Q3
IC11 IC11
J1 RF TX/RX
AF AF MCF BPF BPF BPF BPF LPF LPF LPF
AMP AF D/A HPF AMP SW
AMP SW SW Q2
Q5 FI2 REV
IC9 IC4A IC12 B 46.35 MHz
N/W R8V T4 T3 T2 T1 T8V
5V 5V
RMUT TXC SW
Q22 D1
J2 H G X1 RFATT RF APC
SHIFT AFHPF 5V IF LPT
1 ATT DET
AF SW AMP
2 FM IC
MUTE BEEP Q33 Q1
AFO IC1 Q4
Q32 LVIN
AMP BUFF T8V T8V T8V VCC HV
2nd
AFATT Lo APC
AFON IC7B CTRL IC4B
D18, D19 Q17
NOIS SD Q23, D20, D34 TX/RX YGR DRIVE PWR Q18
AMP BUFF AMP
SW AMP
MICOUT RX IC5 T4
VCO Q21 Q20 Q19
MICIN
NOISOUT

5V 8V 8V APCV
NOISIN

Q24
IC7A IC11 IC11 TXC VCO Q26
5V SW Q27
MIC LIMIT SUPRA- AF AF
AMP SW MOD 24 BUFF BUFF LPF VCC
AMP TTER SW
A
IC8A 2 23 Q28 Q30
IC8B T1
MMUT
TXC TXC 3 21 TX
T2 D/A DTCS
SIGOUT VCO
BUFF N/W 10 IC12 22 Q25, D22, D33
T3 DTCSOUT CPU5V
TONE SW NWC D21 +5
IC6B 11 14 REG W6
T4 REF
DTCS Q35
MOD IC3
8V 5V 8V

TXC 5V IC10
SO
TMUT SCK LOOP PLL
DAST BUFF HV POWER
FIL IC
L32, L33 SW PWON
HORNO 2nd Q29
Q34
SO Lo +5V Q14
AFATT SCK BPF
EXP Q15
MAIN UNIT AFHPF IC13
EXST
EXEN
45.9MHz
REF 8V +8
15.3MHz REG
NWC TCXO DTCSOUT
SO
SCK IC2
PLST X2
MM RM UNLK

R8V
R8V TXC

DS8–DS11 Q3, Q8 Q10

VOLT VCC Q11
BACK DIM 8V D15 COMMON LINE
DET
LIGHT CTRL DIMIN
EXPTT
PWON LINE
RFATT T8V
T8V R8V
DS1 RX LINE
DS12–DS17
Q11–Q17 TEMP CPU5 Q8
LCD DET Q9 TMUT
LED TX LINE
LED CTRL
D14
DTCSIN CONV
TEMP

5V
NOIS

+5V DATA BUS LINE

LVIN
DIM

VIN

CPU5V RMUT MMUT CTRL CPU5V

SD

LED type (F410S/F420S) LCD type (F410/F420) CTDA0

Q6
CTDA2 Q12
Q13
AF, CH U/D, Etc RM RMUT RXMUT MM MMUT MIMUT
SWITCH x8 CTRL CTRL
SCK D24,Q37 D25,Q46
SI
SO
OPTION BUS

OPINT J4
OPCS
BUSY OPV1 15 16 SCK
POSW OPT1 OPV2 14 17 SI
POSW OPT2 OPV3 13 18 SO
HANG CPU OPT3
OPV1
GND 12
11
19
20
OPINT
HV
OPV2 OPT3 OPCS
IC1 OPT2 10 21 REM J5
OPV3 Q38
OPT1 9 22 AFOUT HV
1
CPU5V RES SIGOUT 8 23 DET DIMIN DIM DIM 2
RESET HORN
MDWN 7 24 RXMUT SW 3
Microphone BUSY 6 25 BEEPO 4
IC2, Q1, D1 AUX 5 26 AFON AFO
5
MICIN 4 27 MIMUT Q39 6
HANG HANGER CLIN 3 28 DISC
CLONE MICOUT HV 7
PTTIN PTT PTTOUT 2 29 5V HORNO HORN 8
I/F CLOUT IN
PTTIN 1 30 GND SW 9
8V Q4, D2 10
PTT
MTONE

PTTIN C 11
CTCIN

DTMF

CLONE SHIFT AFO

5V SW
BM

AFO X1 DET
D5
MIC Q40
MIC DET
LPF EE SIGOUT SIG
OPTION
PROM SW
Q5 CONV TONE UT-96
IC3 UT-105
BEEP EXPTT
MUTE
Q7
BEEPO
Q10

FRONT UNIT

10 - 1

Downloaded from www.dlmanuals.com

 SECTION 11 VOLTAGE DIAGRAM
¡FRONT UNIT

LED type only (LED type only) Connect to IC1(pin 69 pin 75)
DS12 Q11 R78

TX
RX
SEL
CH1
CH2
CH3
CH4
56k
TX
LCD type only
0.001

R71
C84

1k DS1
Q12 R79 LD-HU10140J
39k (LCD type only)
RX 1 SEG1
SEG1
2 SEG2
FRONT UNIT
0.001

75
74
73
72
71
70
69
SEG2
C85

R72 DS13 3 SEG3

470 SEG3 (LCD type only)
Q13 R80 4 SEG4 MEASUREMENT CONDITIONS
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
HANG
CTDA2
CTDA1
CTDA0
BM
SEG4
100k 5 SEG5
R73 SEL SEG5 DIGITAL MULTIMETER:50kΩ/VDC
6 SEG6
1.8k SEG6 OSCILLOSCOPE :20MHz
0.001

7 SEG7
C86

DS14 SEG7
(LCD type only)

75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
8 SEG8
Q14 SEG8
R81 9 SEG9
P97/SEG40
P96/SEG39
P95/SEG38
P94/SEG37
P93/SEG36
P92/SEG35
P91/SEG34
P90/SEG33
P87/SEG32
P86/SEG31
P85/SEG30
P84/SEG29
P83/SEG28
P82/SEG27
P81/SEG26
P80/SEG25
P77/SEG24
P76/SEG23
P75/SEG22
P74/SEG21
P73/SEG20
P72/SEG19
P71/SEG18
P70/SEG17
P67/SEG16
100k CH1 SEG9
R74 10 SEG10
1.8k SEG10
11 SEG11
0.001
C87

DS15 SEG11
12 SEG12
Q15 SEG12
R82 13 SEG13 76 50 KR0
SEG13 VCC P66/SEG15
100k CH2 14 SEG14 SEG21 77 49 KR1 NOTE;
R75 SEG14 PDO/SEG41 P65/SEG14
1.8k 15 SEG15 SEG22 78 48 KR2 R46 LCD type (F410/420)
0.001

SEG15 PD1/SEG42 P64/SEG13 EXB-V8V

C88

DS16 16 SEG16 SEG23 79 47 KR3 LED type (F410S/420S)

SEG16 PD2/SEG43 P63/SEG12 (1kx4)
Q16 17 SEG17 SEG24 80 46 KS0 EXEN
R83 SEG17 PD3/SEG44 P62/SEG11
18 SEG18 SEG25 81 45 KS1 EXST
R76 100k CH3 SEG18 PD4/SEG45 P61/SEG10
19 SEG19 SEG26 82 44 DAST
1.8k SEG19 PD5/SEG46 P60/SEG9
0.001

20 SEG20 SEG27 83 43 PLST

C89

DS17 SEG20 PD6/SEG47 P57/WKP7/SEG8

21 SEG21 SEG28 84 42

(LCD type only)

Q17 SEG21 PD7/SEG48 P56/WKP6/SEG7
R84 22 SEG22 SEG29 85 41 R48
SEG22 PE0/SEG49/M P55/WKP5/SEG6 EXB-V8V
R77 100k CH4 23 SEG23 SEG30 86 40
SEG23 PE1/SEG50/D0 P54/WKP4/SEG5 (1kx4)
1.8k 24 SEG24 SEG31 87 39 DIMIN
0.001

SEG24 PE2/SEG51/CL2 P53/WKP3/SEG4

C90

SEG25
25 SEG25 SEG32 88
PE3/SEG52/CL1
IC1 P52/WKP2/SEG3
38 DIM EXPTT
26 SEG26 89 HD6433875B20H 37 PWON CTCSS
4.0V
SEG26 AVCC P51/WKP1/SEG2
27 SEG27 MTONE 90 36 UNLK
SEG27 TONEM P50/WKP0/SEG1
C92 DS12- DS17 Q11- Q17 28 SEG28 DTMF 91 35 COM1 2.35V
2EC2422Cx6 2SC4081x6 SEG28 TONED PA0/COM1
47p 29 SEG29 92 34 COM2
SEG29 VTREF PA1/COM2 Q19 0.7V
30 SEG30 93 33 COM3 DTC144EU
SEG30 AVREF PA2/COM3
31 SEG31 OPV3 R53 1k 94 32 DTCS
R16

4.2V
2.2k

2.2k

SEG31 PB7/AN7 PA3/COM4

R15

32 SEG32 OPV2 R52 1k 95 31 LCD type

SEG32 PB6/AN6 VCC
DS8- DS11 33 COM1 OPV1 R51 1k 96 30 2.3V
COM0 PB5/AN5 V1

R54
SML-311YTx4 4.9V
DS10

34 COM2 CTCIN 97 29

R85
1k
DS8

0.4V

100k
COM1 PB4/AN4 V2

1k
R67
35 COM3 SD 98 28
COM2 PB3/AN3 V3
LVIN 99 27 RFATT
P20/IRQ4/AOTRG

PB2/AN2 VSS 3.9V

0.001

TEMP 100 26

100k
P17/IRQ3/TMIF

(LCD type only)

LED type

R66
DS11

LIGHT ON :7.5V PB1/AN1 P10/TMOW

C83

DS9

VIN R71
P12/TMOFH

LIGHT OFF:5.5V
P11/TMOFL
P21/SCK1

P24/SCK3

1k (LED type only)

P13/TMIG

W1

8V
P27/IRQ0

P16/IRQ2
P15/IRQ1
P25/RXD
PB0/AN0

P23/SO1

P26/TXD

R47 1.7V
P22/SI1

100k
Q3
R65
EXB-V8V
OSC1
OSC2
AVSS
TEST
R11
820

0.01

0.01

0.01

0.01

DTA143ZU
RES

R44
VSS

NMI

(1kX4)
P14
C1

C3

C5

C7

X2
X1

R87 DIM EXB-V8V 7.6V J2

820 (1kx4)
PTT 8V 40 39
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25

1 1
0.001

D6 5.0V
0.01

0.01

0.01

0.01

0.01
C9

C10
10

OPT1 CPU5V 38 37 AFO

C11
C2

C4

C6

C8

MA8051
CLOUT
R86

POSW

OPT2 36 35 SI
CLIN
1k

DS4 DS3 DS2 R12

DS5 DS7 DS6 R14

ECS
390

390

2.2k

2.2k
DS9 DS8 R15

DS11 DS10 R16

OPT3 OPINT 34 33 OPT3

Q18 IC2 5.0V OPCS 32 31 OPT2
Q3 S-80742SL-A6 OPCS BUSY 30 29 OPT1
SML-311YTx10

2SC4081 DTC144EU
BUSY BEEPOUT 28 27 OPV3
DS2 - DS11
DIM

OPINT TONE 26 25 OPV2

3 2 1 NOIS BEEP 24 23 OPV1
10k
R1

C14 R4 5.0V
VDD
OUT

CPU5V DICSIN 22 21 PTT

VSS

0.47 100k R45

IC3 EXB-V8V RFATT 20 19 PTTIN
25LC160T-I/SN (1kx4) NOIS 18 17 DET
Q1
MA111

DIM
ECS 1 8 UNLK 16 15 PWON
0.001
100k

220k

2SC4081
NC

NC

CS VCC
C15
R2

R3

8V
D1

2 7 EXEN 14 13 EXPTT
SO HOLD
100k

4 5 3 6 EXST 12 11 DIMIN
POSW WP SCK
S1 4 5 5.0V DAST 10 9 SO
R59 1k VSS SI
0.001

R17 CSHIFT PLST 8 7 SCK

PWR
C28

0.01
C21
R61

EXB-V8V VIN 6 5 SD
R43
(1kx4) 12k TEMP 4 3 LVIN
VOLUME KR0 X1 L3 R8 MIC 2 1
KR1 CR-590 47µ 10

47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p

47p
47p
47p
47p
47p
47p
47p
47p
47k

CHANNEL KR2
MA77

1k
1k
1k

KR3 C18 R7 to
12k

S2 S3 S4 S5
R5

D5

47p 1M R55 MAIN UNIT

0.001
0.01
C12

C63
C64
C65
C66
C70
C71
C73
C74
C77
C78
C79
C80
C46
C47
C48
C49
C50

C52
C56
C57
C58
C59
C60
C61
6.8MHz C62
C13

R18 J1
R70

3.2V 100k
R64
R63
R62

470 connect
KS0
0.001

C19

C20
0.001

20p
12k

with W3
CLOUT
R6

2.3V
C16

5p

POSW
C17

CLIN
SCK

S6 S7 S8 S9
SO

1.4V
SI

P0 P1 P2 P3 R19
470 HANG 5V 5V
KS1
BEEP IS SET
R58 W2 27.5mV 70mV
0.001

0.001

BEEP
C67

C69

47k
C22

C23

C24

C25

C26

C27

BEEPOUT 0mV 0mV

47p

47p

47p

47p

47p

47p

-27.5mV -70mV
CLOUT

DET
HANG

MTONE
AFO

CTCIN

Q4
MIC

CLIN

DTMF
PTTIN

D2
DA204U DTC144TU
R22 5V
10
R57
15k

CLON
Q7
180k

R29

R32

0.01

0.01

C37
22k
3.9k
R24

R26

C44

C45

J1 AFO
270k
1k

2SC4081
R41

10 R33 R36 R37 R39

8V
68k 12k 12k 100k
CLONE R69 100k CTDA0 Q6
TONE
DTCSIN

R21 TX:5.0V 2SC4081 C82 R50

AFO
1k RX:0.2V R27 0.1 100k
C42

R30 R31 R34 R40

0.1

PTT PTTIN 39k 1 6

to D3 10k 10k 27k 100k
MICE DA204U CTDA1 R60
MIC L1 1µ
R68
47k

MIC MIC 2 5
R49

RV-150
100

R56
C39

R35 (10KB)
0.1

GND 5.6k
R20 1k 10k
HANGER HANG 3 4 CTDA2 Q10
D4
DA204U DTC144TU
470p
0.001

0.001

0.001

0.001

0.022

0.047

0.033

330k
C34

R25

R28

R38
47p

0.01

0.01
56k

47k
C30

C36

C43

R42

2
C29

C32

C33

C35

C38

C40

C41
1k

Q5
5.0V XP4601 3.3V
BM 1.9V
0.5V

11 - 1

Downloaded from www.dlmanuals.com

 • MAIN UNIT

C14
W6 Q14 Q8 TX:7.9 V R8V R17 100k R16 47k
C23 C22 5p ( P -L/ML/MH)
EP3 2SJ377 13.6 V C20
VCC HV
2SD1664 RX:0 V T8V 5V 0V 2p (L-band ) 6p ( L-band ) 3p ( L -MH,H-band
TX:0 V 1.5p

C348
C313
TX:0 V 1.5p (ML/MH-band) 5p ( ML,H-band ) 4p ( L -L/ML)

1.5p (ML-band)
R36

R32
TX:0 V

0.22
100

100
RX:APPROX.

47p
C30

2.5p (L-band )
IC2 TA7808F RX:7.9 V

2p (MH-band)
4.7 H
D16 DSA3A1

FI2 CFWM450E RX:7.3 V RX:6.6 V 4p ( MH-band )

R47
R55 4.7k

1p (H-band)
EP3 TX:8.5 V +3 VdBm 0.001
R59

C33

L9
10k

47
GND 8V X1

HVU350
C67 47P

0.001

1SS352
C82 0.01

O I RX:0 V O I 2.5 (L-band)

C84 470

5.0 V 47p L7 15nH

C57
C83 0.1

C68 10

C58
CDBCA450CX24

MA77
G

4.7

4.7k
R10
4.7k

D14
R54

C49 0.001
1.5p (ML/MH-band)

C303 0.001
0.18 H
C76

C75

C74

C73

C317

C44 0.001
C50 68p
220

D5
C32

D6
7.9 V 1SS302 IC1

D7
C37
0.1

0.1

DC 1.8 V 0.5p (H-band)

R48 1.5k
10

R40

L15

C45 68p
100k
47p

1p ( L-band )
R42

0.12 H
TA31136FN 1p ( L-band )

15nH
L11 15nH

C25 0.5p (Other)

CABLE 1.8 V 2.2k

2.2k
R20
TX:0 V
R60
470

L10
L13
0.3p (Other)

220k
Q9 D13 FI3 CFWM450G D12 1 16 RX:7.7 V

R11
Q12 2SB1132 OSCIN MIXIN

0.001
5p (MH/H-band)
5.1 V DTC114EU DAN202U

2.5p
DAN202U

C18
Q15 2 15 0V

C19
C38

6p (ML-band )
I O OSCOUT GND C51

C24
C41 1p TX:0 V

7p ( L-band ) 0.75p (H-band)

4p (MH/H-band)
DTC114EU

7p (L-band )
3 14 R19 10
RD20E

100p R31

6p ( ML-band )
0.001

MIXOUT N-REC RX:2.5 V

C78

56nH
C77

7p ( L-band )
4 13 Q4 R35 22

6p ( ML-band ) 1p (Other)
D28

10

C64

L14
D31 VCC N-DET

100k
0V RX:2.9 V
C69 4.7

C36

C21
120K Q2

47p
C39
DAN202U 0.1 5 12 2SC4215
6

IFIN RSSI Q3 0.5p 3SK272

C34
C52 100p C29

39nH
0.001
TX:0 V 6 11 TX:0 V 3SK241 Q1

C42 3p
C48

L12
R52 22k

R51 12k

R50 22k
Q10 2SD1664 DEC IFOUT

5p ( MH/H-band )
0.5p (ML/MH-band)
Q13 RX:7.9 V 7 10 RX:0.7 V TX:0 V RX:2.2 V DTA144EU

0.1

C31 0.001
W5 W4

L8 15nH
FILOUT QUAD

R15 47k
0.001

R18 68
RX:0.7 V C308

R25 100k
C43 0.001
XP6501

HVU350
R46

R30 68
C54
TX:0 V 8 9 RX:2.3 V

1.5p ( L-band )
0.001
FILIN AFOUT 1p
47P
R57 4.7k

R53 15k

HVU350
R58 100k Y655LY-02M=P3

220k

220k
R34
R49

330
RX:8.5 V

R23

R21
15k

0.001
C46 R33

C26
D10
C63
PWON

4.7k TX:0 V (H-band)

C71 10

D9
R41
470

47k
47k
330

1.2k
0.001

R37
1

4.7k
R56

D15 Wide:0.6 V R28

270p
RX:0.9 V Y655LY-03K=P3

C61
FI1 FL-287

270
5.0 V 1SS302 Wide:5.1 V
C70

270

C28

R12
Narrow:0 V 18

10k
(Other)
IC3 AN78L05M Narrow:0 V

C56
C62 R14

C301
C59 R24 R22

C47 12p

C300 4p
4.5 V 270p 10k

R39
R38
C55
NOIS
RX:2.3 V

4p

FI1b

C35 47p
W8 CPU5 V Q5 10k 10k

FI1a
0.001

R27
R29
I O R44 820 2.5p (H-band)

SD
C66 0.01

C312 47p
2SC4081

C310
0.01
G

C65
4p (Other) R13

C311

47p

HVU350
C81

C315

C314
C40
47p
C80

C79

C309
47p
0.1

RFATT
C72 1 Q7 220k
0.1

47p

47p
10

C27

47p
47p
TMUT

NWC

R112 DTA144EU C60 0.01

TXC

WIDE:0 V

D8
T4

T1
T3

T2
330k VIN NAR:4.9 V
Q11 TX:4.7 V 5V

TXC
TEMP

TXC
R113

13.6 V
100k

R110 DTC114EU AFHPF RX:0 V HV

NTCCF20124AH (47k)
3.4 V T8V

18nH (H-band)
R8V
R111

5.0 V

C297
22nH (Other)
100k

R107 100

0.001
C110
Q44

47p
R45 330k TX:7.4 V

2 2k
R79

R73
Q22

R76
0.001
0.001

C111
C307 4.7

C115

22
DTC144EU

22
2SC4081 RX:0 V
R108 15k

C133 0.1

R86
R98

R84
47k
C131 470p
AFOUT

1k
DET

D17

1k
Q42 TX:0 V

C298
2.4 V 4

C329

47p

470
DA221

0.001
2 RX:7.8 V

C342
DTC144EU

47p
- 1 TX:4.7 V R270 1M
C132

5p (H-band)

18nH
R104 22k C130 C129
0.56

3 +

L21

L20
C121
RX:0 V

R95

C118
C120
47K
B 6p (Other)

4.7k
470p
470p

R81
R97

R87

3.3k
R85

R77

C107
0.047 0.047

47k

10k

470p
10k
10p
11

R74
C134 0.001

220
R109 10k

R99

R277
2.4 V 2.4 V 2.4 V
C135 2.2

R94 1.5k
2.4 V 2.2k W7
R280

6
100k

2.4 V - 7 R102 C128 Q21

IC6a 2.4V C113 7p Q20
4.12k
R101

5 + 1 0.047 10 12 2SC5107 C109

NJM2902M 2.4 V + 8 + 14 2SC5107
2.4 V
R106 270k

9 - 13

MA77

MA77
- C117

0.001
C339

D19

D18
R100

IC6c C127 C126 Q45

R105

Q19

R96
IC6d 47p
R103

91k
TX:7.6 V TX:1.7 V
220k

36k
22k

NJM2902M 0.047 0.047 DTA144EU

NJM2902M TX:Approx. RX:0 V RX:0 V 2SC4703
AFREF +7dBm

8p (H-band)

C105
0.001

0.001
C323

C108
C347

C112

10p (Other)
1.5k
R78

R75
R80

100
220

C338
2.7k

0.001
R82

4 0
C116
10p
4.7k
R83
IC7b 2.1 V
NJM2904M C330 47 ( P -L/ML)
2.4 V
47P 39 ( P -MH/H)
TX:2.3 V 2p ( P -H) 33 ( L -L/ML/MH)
RX:0 V 7p (L/ML/MH-band) 27 ( L -H)
VCC
5V 7.9 V
8V
Q31 2SC4081
C194
220

CPU5V

R133
R137
R128

MA111
0.001

0.001

0.001
C119

C345

C166

C295

C145
4.7k
13.6 V

0.001
C144
R129
R142 10

10

R131

47p
D23

0.1
6.7 V
C282

10k

C156
220
R147

470p
R150

10
R153

Q46 TX:2.0 V
100k
22

10k
100

C193
R167

R165

C195 5 0.1 DTA144EU RX:5.0 V

6.7 V
100

10k

1 IC6b

C167
470 C190 R141 6.8 V
J1 4 NJM2902M L30

C157
470p
10

R272 1k
2 0.1 2.4 V 10k

R132
3.9 V R139 L31 C162

180k
27nH Q24
R259 22k

C161
0.047 0.001

470p
SP JACK
C179
C351 C350
R173 10k

2.4 V
R172 10k

18 18nH 6p
R255

7.8 V
0.047

27nH

R130
DTC114EU
C292

R161 R118

150k
3
0.1
10k
0.001

L28
C196

R134
3.9 V 5 R144 C174
R166

470k 1k

4.7k
7 + 0.1 C158
R155

22k
10k

IC8b

R140

R138
C291 R169 8 6

C165

C164
10k

IC9 12p

270

270
1.1 V 0.1 1k 3 2.0 V NJM2904M -

6p

6p
LA4425A 1 + 3.9 V 2.0 V (*)TX:2.9
C281

C146
R148 2.8 V
- 2 5 R145 C175

0.5p
TX:2.0 V RX:0 V
0.1

SP1 + 7 100k 2.4 V 75k 0.1 6.4 V

P1 J2 6 - R265 8 RX:3.8 V C159
R163

IC4a W9
R160

4 A 3.1 V
R156

C349
10k

8.2k 2p
0.22
47k

NJM2904M 3 DTCS
56k

0.001
R135

C346
R136

C154
+ +

0.001
2.5 V

C163
1

C160
4.7k
R168 100k R157 270k C319 0.85 V

220
C176 R269

47p
R162 R146
R281 15k

- 2 - 0.7 V
0.7 V
C189

7p
0.1 470k p-p 82k 2.2 39k Q29
C187

Q41 4 Q28
0.1
0.001
C197

0.1

DTC363EK C191 0.012 C184 15p CTCSS Q30 2SC5107 2SC5107

IC8a

R268
CHASSIS 2.0 V 2SC5110
0.7 V

10k
NJM2904M
R158

p-p
R164

15k

C173 C171 C169 Q27

R264
47k

C283
470p

C322 (LMR only) 12p 4p C

10k

12p
MA111

0.22 D29 C186 DTMF W16 W15 W14 W13 DTC144EU 0

R151
0.1
D32

DAN202U 1.5M 3.5 V

R266

p-p
C180

C172 5p
10k

0.56 H

0.56 H

R143
C170
R258 47k

C296
0.1
R159

L33

L32
C185

1k
5p

R127

0.1
5 TONE
33k

4.7k
G 0.1

TONE
H

DTCS
C334

MICOUT
R170

3.2 V (PMR only)

R152
AFATT

47p
6.8k

AFON

MICIN

5.6k
BEEP

p-p
Q32
AFO
AFO

DTC144EU
CPU5V
MIC
8V 8V

5.1 V
C225

C333
R204 10k
R205

R154
0.01
MM D25 MA111

47p
10k

100
RM C183
OPINT
OPCS
BUSY
BEEPO
TONE
BEEP
DTCS
RFATT
NOIS
UNLK
EXEN
EXST
DAST
PLST
VIN
TEMP

LVIN
SD
SCK
SO
DIMIN
EXPTT
PWON
DET
PTTIN
PTTOUT
OPV1
OPV2
OPV3
OPT1
OPT2
OPT3
SI
AFO

0.1
R198
R199

IC13 RX MUTE: D24 IC11 C221

10k
470

BU4094BCF 5.1 V C232 DAN202U BU4066BCF 0.0027

EXST 1 16 0.01 1 14 5
STRB VDD 4.9 V I/O VDD 8
R195 R194
47p
47p
47p
47p

SO 2 15 2 13 2
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k

1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k

DATA OENA O/I CONT A - 1 2.4 V X2

SCK 220k 180k
3 CLK Q5
14 NWC IC12 3
O/I CONT D
12 3 + 2.5 V CR-601
TXC 4 13 AFHPF M62363FP-650C 4 11 4 IC7a 1
Q1 Q6 I/O I/O VCON V
Q37 C223 12p NJM2904M
R236
R245
R237
R246
R238
R247
R239
R248
R240
R249
R241
R250
R242
R251
R243
R252

R235
R226
R234
R225
R233
R224
R232
R223
R231
R222
R230
R221
R229
R220
R228
R219
R227

C328
C327
C326
C325

TMUT 5 12 AFATT 1 24 5 10 Q35 2

J3 Q2 Q7 DTC144EU VIN1 VIN6 CONT B O/I 2.2 V GND O

R267

R186
2SC4081

270k

100k
6 Q3 11 HORNO T1 2 23 6 9
Q8 VOUT1 VOUT8 CONT C O/I

C222

C306

R193

R254
470k

470k
8V 1 2 5V 7 10 T2 3 22 7 8

18p

47p
Q4 Q,S VOUT2 VOUT7 VEE I/O
CPU5V 3 4 AFO 8 9 4 21

C321
R206

VSS QS VIN2 VIN7

100k

R278

47p
GND 5 6 SI 5 20

10k
RMUT

C212

C211
VDD GND

4.7
OPINT 7 8 OPT3 EXEN DAST 6 19

0.1
LD RESET WIDE:0 V
OPCS 9 10 OPT2 SCK 7 18 NAR:0.6 V
CLK VDAREF L34
BUSY 11 12 OPT1 SO 8 17
DI D0 18nH
BEEPOUT 13 14 OPV3 9 16
100k
100k
100k

VIN3 VIN6 Wide:0 V

1M
1M
1M

TONE 15 16 OPV2 T3 10 15

C215
VOUT3 VOUT6 Narrow:4.8 V
BEEP 17 18 OPV1 T4 11 14

8p
VOUT4 VOUT5
DTCSIN 19 20 PTT J4 TO OPTION 12 13 TX:0 V
0.001
0.001
0.001
0.001

VIN4 VIN5
C331
470P

Q36
0.01
R218
R217
R216
R215
R214
R213

RFATT 21 22 PTTIN RX:5.1 V

DTC144EU D F
NOIS 23 24 DET OPV1 15 16 SCK
UNLK 25 26 PWON OPV2 14 17 SI TX:4.7 V

0.001
C177

C178

C332
C226 RX MUTE:0 V

47p

47p
C231
C230
C229
C228
C227

EXEN 27 28 EXPTT OPV3 13 18 SO 0.01 RX:0 V

E
EXST 29 30 DIMIN GND 12 19 OPINT
DTCS

RMUT

NWC

DAST 31 32 SO
TXC

OPT3 11 20 OPCS
PLST 33 34 SCK OPT2 10 21
VIN 35 36 SD OPT1 9 22 AF OUT 5V
TEMP 37 38 LVIN SIG OUT 8 23 DET SIGOUT Q40
MIC 39 40 GND 7 24 RXMUT C238 0 V
10 2SJ144 0V
BUSY 6 25 BEEPO
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
10p
47p
47p
47p
47p
47p
47p
47p

47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p

5 26 AF ON

R209
100k
R210

to Front unit MIC IN 4 27 MIMUT

1M

J2 R211 N
MIC OUT 3 28 HV HV
Through 100k
C279
C269
C278
C268
C277
C267
C276
C266
C275
C265
C274
C264
C273
C263
C272
C262
C271
C261
C270

C252
C243
C253
C244
C254
C245
C255
C246
C256
C247
C257
C248
C258
C249
C259
C250
C260
C251
C284

PTT OUT 2 29 5V P
W3 of front unit
PTT IN 1 30 GND P
C242

C241

0.001

0.001

R212

D27
C240

C239
47p

47p

C
1M

MA111 P
5.1 V P

COMPLETE VIEW 11 - 2

Downloaded from www.dlmanuals.com

 C14 TX:0.7 V C11 2p ( L-band ) LA382 (H-band) ANTENNA
5p ( P -L/ML/MH) R7 47 LA-382 (H-band)
C23 C22 RX:0 V 1p (Other) LA232 (Other)
6p ( L-band ) C20 3p ( L -MH,H-band) L5 LA-232 (Other)
2p (L-band ) C13 L3 FOR
1.5p
.5p (ML/MH-band) 5p ( ML,H-band ) 4p ( L -L/ML) Y655LY-03K=P3 L4 47p LA-382 L2 L1 J1
4p ( MH-band ) W2

5p (L/ML-band, L -H)

8p ( L -MH,H-band)
HVU350

1SS352

0.001
L7 15nH

C17
MA77
4.7k
REV

R10

MI809

7p
C9

C2

C1
9p (L/ML-band)
D5
D6
W12
D7

4p ( P -MH/H)
D4

R1 100k
1p ( L-band )

6p ( P -MH)
3p ( L -MH)

R4
C25 0.5p (Other)

47
C7
C8
C12
220k D3 CHASSIS
R11

UM9410F ( P )

0.001

2.5p
W11

C10
C18
MI407 ( L )

C19
C24

V
7p ( L-band ) 0.75p (H-band)

2P (H-band) R5 100 C3
5V 0.001
8p (Other) R2 100
6p ( ML-band ) 1p (Other)

V RX:2.9 V
C21

7p (L/ML-band)
47p

L6 W10
(*)TX:3.2 V

100

100
5p ( P -MH)

470p

R6

R3
LW-25

C16
Q1 D1
RX:2.8 V 6p ( L -MH,H-band)
5p ( MH/H-band )
0.5p (ML/MH-band)

DTA144EU
L8 15nH

MA713
7p (L/ML-band)
1.5p ( L-band )

0.001
0.001
Y655LY-02M=P3 5p ( P -MH) SC-1322 ( P -L)

C5
C26

C6
R9 220
(H-band) 4p (H-band)

220
3p ( P -L/ML)

R8
Y655LY-03K=P3
4p ( L -ML,MH/H-band)
6p ( L -MH) SC-1323 ( P -ML/MH)
C28

R12
10k

(Other)
14 6p ( L -L) SC-1324 ( P -H)
0k RX:2.3 V SC-1236 ( L -L)
L16 C94 3p ( P -L/ML, L -L)

C93
C15
47p
R13 LA-242 5p ( P -MH) SC-1237 ( L -ML)
HVU350

C315

C314
C309

(L/ML-band, L -MH)
RFATT

220k 2p (H-band)
47p

47p

SC-1325 ( L -MH)
C27

47p
47p

LA-232 6p ( L -ML)
D8

( P -MH,H-band) SC-1326 ( L -H)

T1

4p ( L -MH)
7p (H-band)

22k (H-band)
8p (Other)

18k (Other)

0.001

0.001
C302

C85
IC5 Q18

R61
C297

2SB1143
0.001

R70 2.2
C110

47p

TX:7.4 V
2.2k
R73
R76
0.001
C111

22

RX:0 V

C86
47p
C324

C104

C336

R62
470p

0.001

18k
22nH

C87
47p

47p

C89
4.7k
C91

R67
D17
L18

4.7
DA221 (*)TX:9.1 V EP2 47p
5p (H-band)
18nH

RX:0 V R271
L20

6p (Other) TX:8.9 V L19

3.3k

C107

10k
470p

L17 R64

1.2k
R68
R74
220

RX:0 V 15nH 18nH ( L only) (*)TX:11.5 V

150k

MA111
W7 RX:13.3 V
7p Q20 Q17

D30
C109 C103
C101 R69
C102

C304

2SC5107 2SC4081 R63

- 6
12p

6p 150 7 1M

0.001

0.001
0.001
0.001
T4

2.2
+ 5

47p

47p
TX:1.7 V Q19 R65

22
RX:0 V 2SC4703 TMUT

C92

C90
68k

0.1
10

R273
8p (H-band)

R66
Q16

820k
68k
0.001
C105

4p ( P -H)

0.022
0.001

C108

470p

C100
10p (Other)
C112

R72
1.5k

R71
R78

R75

C99
100

47p

DTC144EU
C98

C88
C286
C285

C344
C343

C337
5p (Other)
C97
C96

C95
22

47 ( P -L/ML) 47 ( P -L) (*)TX:2.1 V

39 ( P -MH/H) 39 ( P -ML/MH) RX:0 V
2p ( P -H) 33 ( L -L/ML/MH) 22 ( L -H) IC4b
7p (L/ML/MH-band) 27 ( L -H) 3.4 V 33 (Other) NJM2904M
6.8 V C141 C139
R116 6.8k R115 6.8k 18p (L-band) 8p (L-band)
15p (ML/MH-band) 6p (ML-bannd)
R128
C295

C145

R117 1 12p (H-band) 4p (MH/H-band)

0.001
C144
R129

10
R131

47p
0.1
C156
220

470p

10

5p (MH-band)
6p (ML-band)

Q23
10p (L-band)

HVU350
3p (H-band)

R275

2SC5110
1k

6.8 V D34
L22 R114 (*)TX:2.8 V
C157
470p

0.56 H 10
C142
R132
180k

Q24 RX:2.7 V 2.7k (ML-band)

6p (MH-band)
8p (ML-band)
27nH

R130

DTC114EU R118 L24 3.3k (Other)

12p (L-band)
150k

HVU350
5p (H-band)
L28

C158 1k 1H L23
MC152-E558ANA-100051=P3
D20
C143

12p C147 D21

(*)TX:2.9 V 3.4 V C150 1p 1T365
C146

2.8 V
0.5p

6.4 V RX:0 V 10p (L-band)

C159 R124 4.7k
W9 8p (ML-band) C148 R276
2p

R122
15p (MH-band ) 5p (L/MH-band)

470p
10

R119

C137

C188
0.001

10k
C346

0.001
C154

C153

R125 10 4p (H-band) 4p (ML/H-band)

4.7
47p

Q29
0.7 V 0.7 V Q25
Q28 2SC5110
8p (MH-band)
2p (ML-band)

2SC5107
HVU350

2SC5107 R123 4.7k

R274
3p (H-band)

C149
5p (L-band)

1k
C151

L25 R121
D33

C169 0.18 H 47
Q27 C155 Q26
12p DTC144EU R126 L27
DTC114EU
HVU350

0.5p 1H
560
0.001
1p (MH-band only)
C293
8p (L/MH-band)

8.2k (MH-band)
D22

3.5p (H-band only)

4p (ML-band)

0.001
R120
R143

C138
100k
3p (H-band)
C296

12k (Other)
0.001

0.001
C341

C340
1k

R127

0.1

(*)TX:0 V
4.7k

C152

RX:2.9 V L26
MC152-E558ANA-100051=P3 (L/ML-band)
R260
TXC

MC152-E558ANA-100050 (MH/H-band )

8V
(*)TX:3.3 V
LVIN

R174

RX:3.2 V
C316

C299

470

R177 CP1
R154

47p

47p
R185

R182
100

100

1.9 V 68k
10

C183 7.6 V J6
0.1
HV
0.001
C200

R178

R175
0.001
100k

C199

to
C198

10k

GND DC FAN
0.001
C206

C207

C233
470p

0.001

10
C205

5.0 V
R176
10

8
1M

2
- 1 2.4 V X2 Q33
3 + 2.5 V CR-601 2SK880 AFO
4 IC7a 1 4 R184 C208 0.34 V
VCON VCC 2.7k 0.0047
Q38
NJM2904M 2 3 p-p (*)TX:2.8 V DTC144EU
2.2 V GND OUT RX:2.7 V
20
19
18
17
16
15
14
13
12
11
R267

R186

15.3 MHz
270k

100k

DIMIN
C306

C318
R193

R254

C202
GND1
IN2
VCC2
XB
XI
XO
GND2
CP2
FI2
FO2
470k

470k
47p

10p

0V 5.0 V
0.022
J5
IC10 Q39 HV
C212

C210
0.001
C211

C209

PD3140GS C203 R180 R179 DTC144EU

4.7

DIM
2.2
0.1

0.47 10k 1k
VCC1

DATA

HORNO HORN
ENB

LOK
CLK

CP1

FO1
IN1

FI1

L34
T1

C213 GND
18nH
C204

C201

0.001 R181
0.47
1
2
3
4
5
6
7
8
9
10

AFO
0.1

1k R208 to
GND
C215

C214

R191

10k C236 0.1 Optional

DET DISC OPC-617
8p

8p

56

PLST R187 1k C216 22p 1.0 V GND

SCK R188 1k C217 22p IN
Q34 R207
SO R189 1k C218 22p 2SK536 GND
UNLK R190 1k C219 0.001 EXPTT 1k PTT
0.001
C177

C178

C332
47p

47p

0.001
0.001

0.001
0.001
47p
C235
C234
C287
C288
C289

Q40
R257 C237
V 2SJ144 0V 47 1
R209
100k

NOTE;
MEASUREMENT CONDITIONS
P -L :PMR L-band L -L :LMR L-band DIGITAL MULTIMETER
D27 P -ML:PMR ML-band L -ML:LMR ML-band INTERNAL RESISTANCE:50k‰/V
MA111 P -ML:PMR MH-band L -MH:LMR MH-band IC-F420/420S(LMR):f=460.1MHz,TX POWER=35W
IC-F410/410S(PMR):f=455.1MHz,TX POWER=25W
P -H :PMR H-band L -H :LMR H-band VOLTAGES INDICATED WITH(*)MARK ARE
CHANGED WITH THE FREGUENCY AND POWER.

COMPLETE VIEW
Downloaded from www.dlmanuals.com
 • MAIN UNIT

C14 TX:0.7 V C11 2p ( L-band ) LA382 (H-band) ANTENNA

W6 Q14 Q8 R17 100k R16 47k 5p ( P -L/ML/MH) R7 47 LA-382 (H-band)
TX:7.9 V R8V C23 C22 RX:0 V 1p (Other) LA232 (Other)
EP3 2SJ377 13.6 V C20 LA-232 (Other)
VCC HV
2SD1664 RX:0 V T8V 5V 0V 2p (L-band ) 6p ( L-band ) 3p ( L -MH,H-band) L5 C13 L3 FOR
TX:0 V 1.5p

C348
C313
TX:0 V 1.5p (ML/MH-band) 5p ( ML,H-band ) 4p ( L -L/ML) J1

1.5p (ML-band)
R36

R32
TX:0 V Y655LY-03K=P3 47p

0.22
100

100
RX:APPROX. L4 LA-382 L2 L1

47p
C30

2.5p (L-band )
IC2 TA7808F RX:7.9 V

2p (MH-band)
4.7 H
D16 DSA3A1

FI2 CFWM450E RX:7.3 V RX:6.6 V 4p ( MH-band ) W2

R47
R55 4.7k

1p (H-band)
EP3 TX:8.5 V +3 VdBm 0.001
R59

C33

L9
10k

5p (L/ML-band, L -H)
47

GND 8V X1

8p ( L -MH,H-band)
HVU350
C67 47P

0.001

1SS352
C82 0.01

0.001
O I RX:0 V O I 2.5 (L-band)
C84 470

5.0 V 47p L7 15nH

C57
C83 0.1

C17
C68 10

C58

CDBCA450CX24

MA77
G
4.7

4.7k
REV

R10

MI809
4.7k

D14
R54

C49 0.001
1.5p (ML/MH-band)

7p
C9

C2

C1
C303 0.001
0.18 H

9p (L/ML-band)
C76

C75

C74

C73

C317

C44 0.001
C50 68p
220

D5
C32

D6
7.9 V 1SS302 IC1 W12

D7
C37
0.1

0.1

0.5p (H-band)

4p ( P -MH/H)
D4
DC 1.8 V
R48 1.5k
10

R40
L15

C45 68p
100k

R1 100k
47p

1p ( L-band )
R42

6p ( P -MH)
0.12 H
TA31136FN 1p ( L-band )

3p ( L -MH)

R4
15nH
L11 15nH

C25 0.5p (Other)

47
CABLE 1.8 V 2.2k

2.2k
R20

C7
C8
C12
TX:0 V
R60
470

L10
D3

L13
0.3p (Other) CHASSIS

220k
Q9 D13 FI3 CFWM450G D12 1 16 RX:7.7 V

R11
Q12 2SB1132 OSCIN MIXIN UM9410F ( P )

0.001
5p (MH/H-band)
5.1 V DTC114EU DAN202U

2.5p
DAN202U W11

C10
C18
Q15 2 15 0V MI407 ( L )

C19
C38

6p (ML-band )
I O OSCOUT GND C51

C24
C41 1p TX:0 V

7p ( L-band ) 0.75p (H-band)

C3

4p (MH/H-band)
DTC114EU

7p (L-band )
3 14 R19 10 2P (H-band) R5 100
RD20E

100p R31

6p ( ML-band )
0.001

MIXOUT N-REC RX:2.5 V 0.001

C78

56nH
C77

8p (Other)

7p ( L-band )
4 13 Q4 R35 22 R2 100

6p ( ML-band ) 1p (Other)
D28

10

C64

L14
D31 VCC N-DET

100k
0V RX:2.9 V
C69 4.7

C36

C21
120K Q2 7p (L/ML-band)

47p
C39
DAN202U 0.1 5 12 2SC4215 L6 W10
6

IFIN RSSI Q3 0.5p (*)TX:3.2 V

100

100
3SK272 5p ( P -MH)

C34
C29

470p

R6

R3
C52 100p

39nH
0.001

LW-25

C16
TX:0 V 6 11 TX:0 V 3SK241 Q1 RX:2.8 V

C42 3p
C48

L12
6p ( L -MH,H-band)
R52 22k

R51 12k

R50 22k

Q10 2SD1664 DEC IFOUT D1

5p ( MH/H-band )
0.5p (ML/MH-band)
Q13 RX:7.9 V 7 10 RX:0.7 V TX:0 V RX:2.2 V DTA144EU
0.1

C31 0.001
W5 W4

L8 15nH
FILOUT QUAD

R15 47k
MA713
0.001

R18 68
RX:0.7 V C308

C43 0.001

R25 100k
XP6501

HVU350
R46

R30 68
C54

TX:0 V 8 9 RX:2.3 V 7p (L/ML-band)

1.5p ( L-band )

0.001
0.001

FILIN AFOUT 1p

0.001
47P
R57 4.7k

R53 15k

HVU350
R58 100k

220k
Y655LY-02M=P3

220k
R34

5p ( P -MH)
R49

330

RX:8.5 V

R23

R21
15k

SC-1322 ( P -L)
0.001

C46 R33

C5
C26
D10

C6
C63

R9 220
PWON

4.7k TX:0 V (H-band)

C71 10

D9
R41

4p (H-band)
470

47k
47k

330
1.2k

0.001
R37

220
3p ( P -L/ML)
1

4.7k
R56

D15 Wide:0.6 V R28

270p

R8
RX:0.9 V Y655LY-03K=P3 6p ( L -MH) SC-1323 ( P -ML/MH)
C61

FI1 FL-287

270
5.0 V 1SS302 Wide:5.1 V
C70

270
4p ( L -ML,MH/H-band)

C28

R12
Narrow:0 V 18

10k
(Other)
IC3 AN78L05M Narrow:0 V SC-1324 ( P -H)
C56

C62 R14 6p ( L -L)

C301

C59 R24 R22

C47 12p

4.5 V 270p C300 4p 10k

NOIS

R39
R38
C55

RX:2.3 V SC-1236 ( L -L)

4p

FI1b

C35 47p
W8 CPU5 V Q5 10k 10k
FI1a

0.001

R27
R29
2.5p (H-band) L16 C94 3p ( P -L/ML, L -L)

C93
I O R44 820
SD

C66 0.01

C312 47p

C15
2SC4081

C310

47p
0.01

G
C65

4p (Other) R13 LA-242 5p ( P -MH) SC-1237 ( L -ML)

C311

47p

HVU350
C81

C315

C314
C40
47p
C80

C79

C309
(L/ML-band, L -MH)

47p
0.1

RFATT
C72 1 Q7 220k 2p (H-band)
0.1

47p

47p
SC-1325 ( L -MH)
10

C27

47p
47p
TMUT

LA-232
NWC

R112 DTA144EU C60 0.01 6p ( L -ML)

TXC

WIDE:0 V

D8
( P -MH,H-band) SC-1326 ( L -H)

T4

T1
T3

T2
330k VIN NAR:4.9 V 4p ( L -MH)

Q11 TX:4.7 V 5V 7p (H-band)

TXC
TEMP

TXC

22k (H-band)
R113

13.6 V
100k

R110 DTC114EU AFHPF RX:0 V 8p (Other)

18k (Other)
HV
NTCCF20124AH (47k)

0.001

0.001
C302

C85
3.4 V T8V
IC5 Q18

18nH (H-band)
R8V

R61
R111

5.0 V

C297
22nH (Other)
2SB1143
100k

R107 100

0.001
R70 2.2

C110
Q44

47p
R45 330k TX:7.4 V

2.2k
R79

R73
Q22

R76
0.001
0.001

C111
C307 4.7

C115

22
DTC144EU

22
2SC4081 RX:0 V
R108 15k

C133 0.1

C86
47p
C324

C104

C336
R86
R98

R62
470p

0.001
R84
47k

18k
22nH
C131 470p C87

47p

47p
AFOUT

C89
4.7k
1k

C91

R67
DET

D17

1k
TX:0 V

L18
Q42
C298

4.7
2.4 V 4
C329

47p
47p

(*)TX:9.1 V

470
DA221
0.001

2 RX:7.8 V EP2
C342

DTC144EU
47p

- 1 TX:4.7 V R270 1M
C132

5p (H-band)

18nH
R104 22k C130 C129 RX:0 V R271
0.56

3 +

L21

L20
C121

RX:0 V
R95

C118
C120
47K

B 6p (Other)

4.7k
470p
470p

R81
TX:8.9 V L19
R97

R87

3.3k
R85

R77

C107
0.047 0.047 10k
47k

10k

470p
10k
10p

11 L17 R64

1.2k
R68
R74
C134 0.001

220
R109 10k

R99

R277
2.4 V 2.4 V 2.4 V RX:0 V 15nH ( L only) (*)TX:11.5 V
C135 2.2

R94 1.5k 18nH 150k

MA111
2.4 V 2.2k W7
R280

6 RX:13.3 V
100k

2.4 V - 7 R102 C128 Q21

IC6a 2.4V C113 7p Q20 Q17
4.12k

D30
R101

5 + 1 0.047 10 12 2SC5107 C109 R69

2.4 V

C101
C103

C102

C304
NJM2902M + 8 2SC5107 2SC4081 R63
+ 14 2.4 V - 6
R106 270k

12p
9 - 13 6p 150 7
MA77

MA77
C117 1M

0.001

0.001
0.001
0.001
- T4
0.001

2.2
C339

+ 5
D19

D18
R100

IC6c C127 C126 Q45

R105

47p

47p
Q19
R96

IC6d 47p
R103

91k

TX:7.6 V TX:1.7 V
220k

36k

R65

22
22k

NJM2902M 0.047 0.047 DTA144EU

NJM2902M RX:0 V RX:0 V 2SC4703 TMUT

C92

C90
TX:Approx. 68k

0.1
10
AFREF +7dBm

R273
8p (H-band)

R66
Q16

820k
68k
0.001
C105
4p ( P -H)

0.022
0.001

0.001
C323

C108

470p

C100
C347

C112

10p (Other)

R72
1.5k

R71
R78

R75
R80

C99
100
220

47p
DTC144EU

C338

C98
2.7k

0.001
R82

C116

C88
C286
C285

C344
C343

C337
10p
4.7k
R83

IC7b 5p (Other)

C97
C96

C95
22
2.1 V
NJM2904M C330 47 ( P -L/ML) 47 ( P -L) (*)TX:2.1 V
2.4 V RX:0 V
47P 39 ( P -MH/H) 39 ( P -ML/MH)
TX:2.3 V 2p ( P -H) 33 ( L -L/ML/MH) 22 ( L -H) IC4b
VCC
RX:0 V 7p (L/ML/MH-band) 27 ( L -H) 3.4 V 33 (Other) NJM2904M
5V 7.9 V 6.8 V C141 C139
8V
Q31 2SC4081 R116 6.8k R115 6.8k 18p (L-band) 8p (L-band)
C194
220

CPU5V R133 15p (ML/MH-band) 6p (ML-bannd)

R137

R128
MA111
0.001

0.001

0.001
C119

C345

C166

C295

C145
4.7k

13.6 V R117 1 12p (H-band) 4p (MH/H-band)

0.001
C144
R129
R142 10 10

R131

47p
D23

0.1
6.7 V
C282

10k

C156
220
R147

470p
R150

10
R153

Q46 TX:2.0 V

5p (MH-band)
100k

6p (ML-band)
Q23
22

10k
100

10p (L-band)
C193

HVU350
3p (H-band)

R275
R167

R165

C195 5 0.1 DTA144EU RX:5.0 V 2SC5110

6.7 V
100

10k

1 IC6b

1k
C167

470 6.8 V

D34
J1 4 C190 R141 L30 L22 R114 (*)TX:2.8 V
NJM2902M

C157
470p
10

R272 1k
2 0.1 2.4 V 0.56 H 10

C142
10k

R132
3.9 V R139 L31 C162

180k
27nH Q24 RX:2.7 V 2.7k (ML-band)
R259 22k

C161
0.047 0.001

470p

SP JACK
C179
C351 C350
R173 10k

R172 10k

2.4 V

6p (MH-band)
18 18nH 6p
R255

8p (ML-band)
7.8 V
0.047

27nH

R130
DTC114EU L24 3.3k (Other)
C292

R161 R118

12p (L-band)
150k
3
0.1

HVU350
5p (H-band)
10k
0.001

L28
C196

R134

3.9 V 5 R144 C174

R166

470k 1k 1H L23
4.7k

7 + 0.1 C158
R155

22k
10k

IC8b
R140

R138

C291 R169 MC152-E558ANA-100051=P3

D20
C143
8 6
C165

C164
10k

IC9 12p
270

270

1.1 V 0.1 1k 3 2.0 V NJM2904M - C147 D21

3.4 V
6p

6p

LA4425A 1 + 3.9 V 2.0 V (*)TX:2.9 V C150 1p 1T365

C281

C146
R148 2.8 V
- 2 5 R145 C175

0.5p
TX:2.0 V RX:0 V 10p (L-band)
0.1

SP1 + 7 100k 2.4 V 75k 0.1 6.4 V R124 4.7k

P1 J2 6 - R265 8 RX:3.8 V C159 8p (ML-band) C148
R163

IC4a W9 R276
R160

4 A 3.1 V
R156

C349
10k

8.2k 2p

R122
15p (MH-band ) 5p (L/MH-band)
0.22
47k

DTCS

470p
NJM2904M 3 10

R119

C137

C188
56k

0.001
R135

10k
C346
R136

0.001
C154
+

C153
+
0.001

2.5 V
C163

1
C160
4.7k

R168 100k R157 270k C319 0.85 V R125 10 4p (H-band) 4p (ML/H-band)

4.7
220

R146 C176 R269

47p
R162
R281 15k

2 -
- 0.7 V 0.7 V Q25
C189

7p

0.1 470k p-p 82k 2.2 39k Q29

C187

Q41 4 Q28 2SC5110

0.1

8p (MH-band)
0.001

8p (L/MH-band) 2p (ML-band)
C197

0.1

2SC5107

HVU350
C191 0.012 C184 15p Q30 2SC5107 R123 4.7k

R274
3p (H-band)
DTC363EK

C149
5p (L-band)
IC8a CTCSS
R268

CHASSIS 2.0 V 2SC5110

1k
C151
0.7 V L25 R121
10k

NJM2904M

D33
R158

p-p 0.18 H
R164

47
15k

C173 C171 C169 Q27

R264
47k

Q26
C283
470p

C322 (LMR only) 12p 4p C155

10k

12p L27
MA111

D29 C186 DTMF W16 W15 W14 W13 DTC144EU DTC114EU R126

HVU350
0.22 R151 0.5p 1H
0.1 560
D32

3.5 V

0.001
DAN202U 1p (MH-band only)

C293
1.5M
R266

8.2k (MH-band)
D22
p-p
C180

C172 5p
10k

3.5p (H-band only)

4p (ML-band)
0.56 H

0.56 H

0.001
R120
R143

C138
C170

100k
R258 47k

3p (H-band)
C296
0.1
R159

L33

L32

C185

12k (Other)
0.001

0.001
C341

C340
1k
5p

R127

0.1
5 TONE
33k

(*)TX:0 V

4.7k

C152
G 0.1
TONE

H
DTCS
C334

MICOUT

L26
R170

3.2 V (PMR only) RX:2.9 V

R152
AFATT

47p
6.8k

AFON

MICIN

5.6k
BEEP

p-p MC152-E558ANA-100051=P3 (L/ML-band)

R260
Q32

TXC
AFO
AFO

MC152-E558ANA-100050 (MH/H-band )
DTC144EU
CPU5V
MIC
8V 8V
(*)TX:3.3 V

LVIN
5.1 V

R174
RX:3.2 V

C316

C299

470
C225

C333

R204 10k R177 CP1

R205

R154

47p

47p
R185

R182
0.01

MM D25 MA111
47p
10k

100

100
1.9 V 68k

10
RM C183 7.6 V J6
OPINT
OPCS
BUSY
BEEPO
TONE
BEEP
DTCS
RFATT
NOIS
UNLK
EXEN
EXST
DAST
PLST
VIN
TEMP

LVIN
SD
SCK
SO
DIMIN
EXPTT
PWON
DET
PTTIN
PTTOUT
OPV1
OPV2
OPV3
OPT1
OPT2
OPT3
SI
AFO

0.1
R198
R199

IC13 RX MUTE: D24 IC11 C221 HV

0.001
10k

C200

R178

R175
470

0.001
100k

C199
0.0027 to

C198
BU4094BCF 5.1 V BU4066BCF

10k
C232 DAN202U GND DC FAN

0.001
C206

C207

C233
470p

0.001

10
C205
EXST 1 16 0.01 1 14 5.0 V

R176
10
STRB VDD 4.9 V I/O VDD 8

1M
R195 R194
47p
47p
47p
47p

SO 2 15 2 13 2 Q33
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k

1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k
1k

DATA OENA O/I CONT A - 1 2.4 V X2

SCK 220k 180k 2SK880
3 CLK Q5
14 NWC IC12 3
O/I CONT D
12 3 + 2.5 V CR-601 AFO
TXC 4 13 AFHPF M62363FP-650C 4 11 4 IC7a 1 4 R184 C208 0.34 V
Q1 Q6 I/O I/O VCON VCC Q38
Q37 C223 12p NJM2904M 2.7k 0.0047 p-p
R236
R245
R237
R246
R238
R247
R239
R248
R240
R249
R241
R250
R242
R251
R243
R252

R235
R226
R234
R225
R233
R224
R232
R223
R231
R222
R230
R221
R229
R220
R228
R219
R227

C328
C327
C326
C325

TMUT 5 12 AFATT 1 24 5 10 2 3 (*)TX:2.8 V DTC144EU

J3 Q2 Q7 DTC144EU VIN1 VIN6 CONT B O/I Q35 2.2 V GND OUT RX:2.7 V

20
19
18
17
16
15
14
13
12
11
R267

R186

2SC4081 15.3 MHz

270k

100k

6 Q3 11 HORNO T1 2 23 6 9 DIMIN
Q8 VOUT1 VOUT8 CONT C O/I
C222

C306

C318
R193

R254

C202

GND1
IN2
VCC2
XB
XI
XO
GND2
CP2
FI2
FO2
470k

470k

8V 1 2 5V 7 10 T2 3 22 7 8
18p

47p

10p
Q4 Q,S VOUT2 VOUT7 VEE I/O 0V 5.0 V
0.022
CPU5V 3 4 AFO 8 9 4 21 J5
C321
R206

VSS QS VIN2 VIN7

100k

R278

47p

GND 5 6 SI 5 20 IC10 Q39 HV

RMUT

10k

C212

C210
0.001
C211

VDD GND
C209

µPD3140GS C203 R180 R179 DTC144EU

4.7

OPINT 7 8 OPT3 EXEN DIM

2.2

DAST 6 19
0.1

LD RESET WIDE:0 V
0.47 10k 1k

VCC1

DATA
OPCS 9 10 OPT2 SCK 7 18 NAR:0.6 V HORNO HORN

ENB

LOK
CLK

CP1

FO1
CLK VDAREF

IN1

FI1
L34

T1
BUSY 11 12 OPT1 SO 8 17 C213 GND
DI D0 18nH

C204

C201
0.001 R181

0.47
1
2
3
4
5
6
7
8
9
10
BEEPOUT 13 14 OPV3 9 16 AFO

0.1
100k
100k
100k

VIN3 VIN6 Wide:0 V 1k to

R208
1M
1M
1M

TONE 15 16 OPV2 T3 10 15 GND

C215

C214

R191

VOUT3 VOUT6 Narrow:4.8 V 10k C236 0.1 Optional

BEEP 17 18 OPV1 T4 11 14 DET DISC OPC-617
8p

8p

56

VOUT4 VOUT5
DTCSIN 19 20 PTT J4 TO OPTION 12 13 TX:0 V PLST R187 1k C216 22p 1.0 V GND
0.001
0.001
0.001
0.001

VIN4 VIN5
C331
470P

Q36
0.01
R218
R217
R216
R215
R214
R213

RFATT 21 22 PTTIN RX:5.1 V SCK R188 1k C217 22p IN

DTC144EU D F Q34 R207
NOIS 23 24 DET OPV1 15 16 SCK SO R189 1k C218 22p 2SK536 GND
UNLK 25 26 PWON OPV2 14 17 SI TX:4.7 V UNLK R190 1k C219 0.001 EXPTT 1k PTT
0.001
C177

C178

C332

C226 RX MUTE:0 V
47p

47p
C231
C230
C229
C228
C227

EXEN 27 28 EXPTT OPV3 13 18 SO 0.01 RX:0 V

0.001
0.001

0.001
0.001
E

47p
EXST 29 30 DIMIN GND 12 19 OPINT
DTCS

RMUT

NWC

DAST 31 32 SO
TXC

OPT3 11 20 OPCS
PLST 33 34 SCK OPT2 10 21

C235
C234
C287
C288
C289
VIN 35 36 SD OPT1 9 22 AF OUT 5V
TEMP 37 38 LVIN SIG OUT 8 23 DET SIGOUT Q40
MIC 39 40 GND 7 24 RXMUT C238 0 V R257 C237
10 2SJ144 0V 47 1
BUSY 6 25 BEEPO
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
10p
47p
47p
47p
47p
47p
47p
47p

47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p
47p

5 26 AF ON
R209
100k
R210

to Front unit MIC IN 4 27 MIMUT

1M

J2 R211 NOTE;
MIC OUT 3 28 HV HV
Through 100k MEASUREMENT CONDITIONS
C279
C269
C278
C268
C277
C267
C276
C266
C275
C265
C274
C264
C273
C263
C272
C262
C271
C261
C270

C252
C243
C253
C244
C254
C245
C255
C246
C256
C247
C257
C248
C258
C249
C259
C250
C260
C251
C284

PTT OUT 2 29 5V P -L :PMR L-band L -L :LMR L-band DIGITAL MULTIMETER

W3 of front unit
PTT IN 1 30 GND P -ML:PMR ML-band L -ML:LMR ML-band INTERNAL RESISTANCE:50k‰/V
C242

C241

0.001

0.001

R212

D27
C240

C239
47p

47p

C IC-F420/420S(LMR):f=460.1MHz,TX POWER=35W
1M

MA111 P -ML:PMR MH-band L -MH:LMR MH-band

5.1 V IC-F410/410S(PMR):f=455.1MHz,TX POWER=25W
P -H :PMR H-band L -H :LMR H-band
VOLTAGES INDICATED WITH(*)MARK ARE
CHANGED WITH THE FREGUENCY AND POWER.

LEFT SIDE 11 - 2
RIGHT SIDE

Downloaded from www.dlmanuals.com

 6-9-16, Kamihigashi, Hirano-ku, Osaka 547-0002, Japan
Phone : 06 6793 5302
Fax : 06 6793 0013

< Corporate Headquarters > Communication Equipment

2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Himmelgeister Str. 100, D-40225 Düsseldorf, Germany
Phone : (425) 454-8155 Fax : (425) 454-1509 Phone : 0211 346047 Fax : 0211 333639
URL : http://www.icomamerica.com URL : http://www.icomeurope.com
< Customer Service >
Phone : (425) 454-7619
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
A Division of Icom America Inc. Phone : (93) 590 26 70 Fax : (93) 589 04 46
3071 #5 Road, Unit 9, Richmond, B.C., V6X 2T4, Canada URL : http://www.icomspain.com
Phone : (604) 273-7400 Fax : (604) 273-1900

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.

A.C.N. 006 092 575 Phone : 01227 741741 Fax : 01227 741742
290-294 Albert Street, Brunswick, Victoria, 3056, Australia URL : http://www.icomuk.co.uk
Phone : 03 9387 0666 Fax : 03 9387 0022
URL : http://www.icom.net.au
Zac de la Plaine, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan R.O.C. Phone : 561 36 03 03 Fax : 561 36 03 00
Phone : (02) 2559 1899 Fax : (02) 2559 1874 URL : http://www.icom-france.com

Downloaded from www.dlmanuals.com

 Cover420s 99.2.17 10:40 AM Page 1

iF410
iF410S
iF420
iF420S

Downloaded from www.dlmanuals.com