Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
SAFETY DATA SHEET
BRUSHBOND TGP
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
Product name BRUSHBOND TGP
Product number 1036004
1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses Cementitious Waterproofing System
1.3. Details of the supplier of the safety data sheet
Supplier Fosroc Sdn. Bhd.
8, Jalan Trompet 33/8,
Section 33, 40400, Shah Alam,
Selangor Darul Ehsan,
Malaysia.
+603-51025660
+603-51025668
[email protected]1.4. Emergency telephone number
Emergency telephone +60351025660
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture
Classification (EC 1272/2008)
Physical hazards Not Classified
Health hazards Skin Irrit. 2 - H315 Eye Dam. 1 - H318 Skin Sens. 1 - H317 STOT SE 3 - H335
Environmental hazards Not Classified
2.2. Label elements
Hazard pictograms
Signal word Danger
Hazard statements H315 Causes skin irritation.
H318 Causes serious eye damage.
H317 May cause an allergic skin reaction.
H335 May cause respiratory irritation.
1/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
Precautionary statements P261 Avoid breathing dust.
P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.
P302+P352 IF ON SKIN: Wash with plenty of water.
P362+P364 Take off contaminated clothing and wash it before reuse.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing.
Contains CEMENT, CALCIUM HYDROXIDE, TARTARIC ACID POWDER
Supplementary precautionary P264 Wash contaminated skin thoroughly after handling.
statements P271 Use only outdoors or in a well-ventilated area.
P272 Contaminated work clothing should not be allowed out of the workplace.
P310 Immediately call a POISON CENTER/ doctor.
P312 Call a POISON CENTRE/doctor if you feel unwell.
P321 Specific treatment (see medical advice on this label).
P332+P313 If skin irritation occurs: Get medical advice/ attention.
P333+P313 If skin irritation or rash occurs: Get medical advice/ attention.
P403+P233 Store in a well-ventilated place. Keep container tightly closed.
P405 Store locked up.
P501 Dispose of contents/ container in accordance with national regulations.
2.3. Other hazards
None known.
SECTION 3: Composition/information on ingredients
3.2. Mixtures
CEMENT 30-60%
CAS number: 65997-15-1
Classification
Skin Irrit. 2 - H315
Eye Dam. 1 - H318
Skin Sens. 1 - H317
STOT SE 3 - H335
SODIUM CARBONATE 10-30%
CAS number: 497-19-8 EC number: 207-838-8
Classification
Eye Irrit. 2 - H319
CALCIUM HYDROXIDE 1-5%
CAS number: 1305-62-0 REACH registration number: 01-
2119475151-45-XXXX
Classification
Skin Irrit. 2 - H315
Eye Dam. 1 - H318
STOT SE 3 - H335
2/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
TARTARIC ACID POWDER 1-5%
CAS number: 87-69-4 EC number: 201-766-4
Classification
Eye Dam. 1 - H318
The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16.
SECTION 4: First aid measures
4.1. Description of first aid measures
Inhalation Move affected person to fresh air and keep warm and at rest in a position comfortable for
breathing. Get medical attention if any discomfort continues.
Ingestion Do not induce vomiting. Rinse mouth thoroughly with water. Never give anything by mouth to
an unconscious person. Get medical attention immediately.
Skin contact Remove affected person from source of contamination. Wash skin thoroughly with soap and
water. Get medical attention if symptoms are severe or persist after washing. Wash
contaminated clothing before reuse.
Eye contact Do not rub eye. Remove any contact lenses and open eyelids wide apart. Rinse immediately
with plenty of water. Continue to rinse for at least 15 minutes. Get medical attention
immediately.
4.2. Most important symptoms and effects, both acute and delayed
Inhalation May cause respiratory irritation.
Skin contact Causes skin irritation. May cause an allergic skin reaction.
Eye contact Causes serious eye damage.
4.3. Indication of any immediate medical attention and special treatment needed
Notes for the doctor Treat symptomatically.
SECTION 5: Firefighting measures
5.1. Extinguishing media
Suitable extinguishing media The product is not flammable. Use fire-extinguishing media suitable for the surrounding fire.
5.2. Special hazards arising from the substance or mixture
Specific hazards Water used for fire extinguishing, which has been in contact with the product, may be
corrosive. No unusual fire or explosion hazards noted.
Hazardous combustion No known hazardous decomposition products.
products
5.3. Advice for firefighters
Protective actions during Fight fire from safe distance or protected location.
firefighting
Special protective equipment Wear positive-pressure self-contained breathing apparatus (SCBA) and appropriate protective
for firefighters clothing.
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
Personal precautions Wear protective clothing as described in Section 8 of this safety data sheet.
3/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
6.2. Environmental precautions
Environmental precautions Do not discharge into drains or watercourses or onto the ground.
6.3. Methods and material for containment and cleaning up
Methods for cleaning up Dry material: Collect powder using special dust vacuum cleaner with particle filter or carefully
sweep into suitable waste disposal containers and seal securely. Wet material: Clean up wet
material and place in a container. Allow to dry and solidify before disposal as described in
section 13.
6.4. Reference to other sections
Reference to other sections For waste disposal, see Section 13.
SECTION 7: Handling and storage
7.1. Precautions for safe handling
Usage precautions Avoid contact with skin and eyes. Avoid generation and spreading of dust. Avoid inhalation of
dust.
7.2. Conditions for safe storage, including any incompatibilities
Storage precautions Store in tightly-closed, original container in a dry and cool place.
7.3. Specific end use(s)
Specific end use(s) The identified uses for this product are detailed in Section 1.2.
SECTION 8: Exposure controls/Personal protection
8.1. Control parameters
Occupational exposure limits
CEMENT
Long-term exposure limit (8-hour TWA): WEL 2.0 mg/m³ total inhalable dust
Long-term exposure limit (8-hour TWA): WEL 1.0 mg/m³ respirable dust
CALCIUM HYDROXIDE
Long-term exposure limit (8-hour TWA): WEL 5 mg/m³
TARTARIC ACID POWDER
Long-term exposure limit (8-hour TWA): WEL 5 mg/m3 resp.dust
WEL = Workplace Exposure Limit
CALCIUM HYDROXIDE (CAS: 1305-62-0)
PNEC General population - Soil; 1080 mg/l
8.2. Exposure controls
Protective equipment
Appropriate engineering Provide adequate general and local exhaust ventilation. Eye wash facilities and emergency
controls shower must be available when handling this product.
Eye/face protection The following protection should be worn: Chemical splash goggles.
Hand protection Wear protective gloves made of the following material: Nitrile rubber.
4/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
Other skin and body Wear appropriate clothing to prevent repeated or prolonged skin contact.
protection
Hygiene measures Good personal hygiene procedures should be implemented. Use appropriate skin cream to
prevent drying of skin. Wash contaminated skin thoroughly after handling. Wash after use and
before eating, smoking and using the toilet.
Respiratory protection Wear a respirator fitted with the following cartridge: Particulate filter, type P2.
SECTION 9: Physical and chemical properties
9.1. Information on basic physical and chemical properties
Appearance Granulated Powder
Colour Grey.
Odour Odorless.
Odour threshold Not applicable.
pH > 12
Melting point Not available.
Initial boiling point and range Not applicable.
Flash point Not applicable.
Evaporation rate Not applicable.
Evaporation factor Not applicable.
Flammability (solid, gas) Not applicable.
Upper/lower flammability or The product is not flammable.
explosive limits
Other flammability Not applicable.
Vapour pressure Not applicable.
Vapour density Not applicable.
Bulk density Not available.
Solubility(ies) Slightly soluble in water. Hardens in contact with water.
Partition coefficient Not available.
Auto-ignition temperature Not available.
Decomposition Temperature Not available.
Viscosity Not applicable.
Explosive properties Not considered to be explosive.
Explosive under the influence Not considered to be explosive.
of a flame
Oxidising properties The mixture itself has not been tested but none of the ingredient substances meet the criteria
for classification as oxidising.
9.2. Other information
Other information None known.
5/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
SECTION 10: Stability and reactivity
10.1. Reactivity
Reactivity When mixed with water, hardens to form a stable mass that is not reactive in normal
conditions.
10.2. Chemical stability
Stability Stable under the prescribed storage conditions.
10.3. Possibility of hazardous reactions
Possibility of hazardous Hazardous reactions will not occur under normal transport or storage conditions.
reactions
10.4. Conditions to avoid
Conditions to avoid Water, moisture.
10.5. Incompatible materials
Materials to avoid Strong acids. Strong alkalis. Chemically-active metals.
10.6. Hazardous decomposition products
Hazardous decomposition No known hazardous decomposition products.
products
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Inhalation May cause respiratory irritation.
Skin contact Causes skin irritation. May cause an allergic skin reaction.
Eye contact Causes serious eye damage.
Toxicological information on ingredients.
CALCIUM HYDROXIDE
Acute toxicity - oral
Acute toxicity oral (LD₅₀ 7,300.0
mg/kg)
Species Mouse
ATE oral (mg/kg) 7,300.0
Acute toxicity - dermal
Acute toxicity dermal (LD₅₀ 2,500.0
mg/kg)
Species Guinea pig
ATE dermal (mg/kg) 2,500.0
TARTARIC ACID POWDER
Eye contact Causes serious eye damage.
SECTION 12: Ecological information
6/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
Ecotoxicity The product is not expected to be hazardous to the environment.
12.1. Toxicity
Toxicity The product is not expected to be toxic to aquatic organisms.
Ecological information on ingredients.
CALCIUM HYDROXIDE
Acute aquatic toxicity
Acute toxicity - fish LC₅₀, 96 hours: 33.884 mg/ml mg/l, Fish
TARTARIC ACID POWDER
Toxicity No data available.
12.2. Persistence and degradability
Persistence and degradability Not expected to be readily biodegradable.
Ecological information on ingredients.
TARTARIC ACID POWDER
Persistence and Expected to be readily biodegradable.
degradability
12.3. Bioaccumulative potential
Bioaccumulative potential The product is not bioaccumulating.
Partition coefficient Not available.
Ecological information on ingredients.
TARTARIC ACID POWDER
Bioaccumulative potential No data available on bioaccumulation.
12.4. Mobility in soil
Mobility The product hardens to a solid, immobile substance.
Ecological information on ingredients.
TARTARIC ACID POWDER
Mobility Soluble in water.
12.5. Results of PBT and vPvB assessment
Results of PBT and vPvB This product does not contain any substances classified as PBT or vPvB.
assessment
Ecological information on ingredients.
TARTARIC ACID POWDER
Results of PBT and vPvB This product does not contain any substances classified as PBT or vPvB.
assessment
12.6. Other adverse effects
Other adverse effects None known.
7/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
Ecological information on ingredients.
TARTARIC ACID POWDER
Other adverse effects None known.
SECTION 13: Disposal considerations
13.1. Waste treatment methods
Disposal methods Dispose of waste to licensed waste disposal site in accordance with the requirements of the
local Waste Disposal Authority.
SECTION 14: Transport information
General The product is not covered by international regulations on the transport of dangerous goods
(IMDG, IATA, ADR/RID).
14.1. UN number
Not applicable.
14.2. UN proper shipping name
Not applicable.
14.3. Transport hazard class(es)
No transport warning sign required.
14.4. Packing group
Not applicable.
14.5. Environmental hazards
Environmentally hazardous substance/marine pollutant
No.
14.6. Special precautions for user
Not applicable.
14.7. Transport in bulk according to Annex II of MARPOL and the IBC Code
Transport in bulk according to Not applicable.
Annex II of MARPOL 73/78
and the IBC Code
SECTION 15: Regulatory information
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
National regulations Occupational Safety and Health (Classification, Labelling and Safety Data Sheet of
Hazardous Chemicals) Regulations 2013 (CLASS Regulations)
Guidance Industry Code of Practise on Chemical Classification and Hazard Communication 2014
15.2. Chemical safety assessment
No chemical safety assessment has been carried out.
SECTION 16: Other information
General information For professional users only. Only trained personnel should use this material.
Revision comments NOTE: Lines within the margin indicate significant changes from the previous revision.
8/9
Revision date: 04/10/2019 Revision: 9 Supersedes date: 09/05/2019
BRUSHBOND TGP
Revision date 04/10/2019
Revision 9
Supersedes date 09/05/2019
SDS number 10676
Hazard statements in full H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H318 Causes serious eye damage.
H319 Causes serious eye irritation.
H335 May cause respiratory irritation.
This information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate
and reliable as of the date indicated. However, no warranty, guarantee or representation is made to its accuracy, reliability or
completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use.
9/9
