ih ng rs

tc lato STR-W6754

Data Sheet
i

28103.32
Sw egu
R
Universal-Input/100 W Off-Line Quasi-
Resonant Flyback Switching Regulator
The STR-W6754 is a quasi-resonant regulator specifically designed
to satisfy the requirements for increased integration and reliability in
switch-mode power supplies. It incorporates a primary control and drive
circuit with an avalanche-rated power MOSFET. The regulator exhibits
only low-level high-frequency EMI noise because of soft switching of
the MOSFET close to ground (bottom point). A bottom-skip function
minimizes an increase of operational frequency during light loads to
improve system efficiency over the entire load range.
Covering the power range from below 160 watts for a 230 VAC
input, or 100 watts for a universal input (85 to 264 VAC), this device
can be used in a range of applications, from DVD and VCR players to
ac adapters for cellular phones and digital cameras. An auto-standby
function, which is internally triggered by sensing on time, reduces
power consumption at light load. An externally triggered standby mode
reduces the input power further. Multiple protections, including the
avalanche-energy-guaranteed MOSFET, provide high reliability of
ABSOLUTE MAXIMUM RATINGS system design. Devices with an increased output power rating are the
at TA = +25°C STR-W6756.
Control Supply Voltage, VCC . . . . 35 V Cycle-by-cycle current limiting, undervoltage lockout with hyster-
Drain-Source Voltage, VDSS . . . . . . 650 V esis, and overvoltage protection protect the power supply during the
Drain Switching Current, ID . . . . . 15 A* normal overload and fault conditions. Overvoltage protection is latched
Peak Drain Switching Current, after a short delay. The latch may be reset by cycling the input supply.
IDM . . . . . . . . . . . . . . . . . . . . . . 15 A Low start-up current and a low-power standby mode selected from the
Single-Pulse Avalanche Energy, secondary circuit completes a comprehensive suite of features. The
EAS . . . . . . . . . . . . . . . . . . . 292 mJ STR-W6754 is provided in a fully molded TO-220-style flange-
OCP/BD Voltage Range, mounted, high power, isolated plastic package.
VOCP . . . . . . . . . . . . –1.5 V to +5 V
FB Input Current, IFB . . . . . . . . 10 mA FEATURES AND BENEFITS
FB Voltage Range, VFP –0.5 V to +9 V ■ Rugged 650 V Avalanche-Rated MOSFET
Package Power Dissipation, PD Simplified Surge Absorption
control (VCC × ICC(ON)) . . . . . . 0.8 W No VDSS Derating Required
MOSFET (VDSS × ID) . . . See Graph ■ 0.96 Ω Maximum rDS(on)
MOSFET Channel Temp., TJ . +150°C ■ Two Operational Modes by Automatic Switching:
Internal Frame Temp., TF . . . . +115°C Quasi-Resonant Mode for Normal Operation
Operating Temperature Range,
Burst Mode for Standby Operation or Light Loads
TA . . . . . . . . . . . . -20°C to +115°C
■ Automatic or Manually Triggered Burst Standby
Storage Temperature Range,
TS . . . . . . . . . . . . -40°C to +125°C
Input Power <0.1 W at No Load
■ Low Operating Current (6 mA typ)
* Drain switching current is limited by tem- — continued
perature (page 2) and safe operating area
(page 5).
Always order by complete part number, e.g., STR-W6754 .

Sanken Power Devices

from Allegro MicroSystems
 STR-W6754 ih ng rs
Universal-Input/100 W Off-Line Quasi- itc lato
Resonant Flyback Switching Regulator Sw egu
R
FUNCTIONAL BLOCK DIAGRAM

FEATURES AND BENEFITS (cont’d)

■ Auto-Bias Function
Stable Burst Operation Without Generating Interference
■ Internal Off-Timer Circuit
■ Built-In Constant-Voltage Drive
■ Multiple Protections:
Pulse-by-Pulse Overcurrent Protection
Overload Protection with Auto Recovery
Latching Overvoltage Protection
Undervoltage Lockout with Hysteresis
■ RoHS Compliant

115 Northeast Cutoff, Box 15036

2 Worcester, Massachusetts 01615-0036
Copyright © 2005 Allegro MicroSystems, Inc.
 ih ng rs STR-W6754
itc lato Universal-Input/100 W Off-Line Quasi-
Sw egu Resonant Flyback Switching Regulator
R
ELECTRICAL CHARACTERISTICS at TA = +25°C, VCC = 20 V, voltage measurements are referenced to S/GND terminal
(unless otherwise specified).

Limits

Characteristic Symbol Test Conditions Min. Typ. Max. Units

Start-Up Operation
Operation Start Voltage VCC(ON) Turn-on, VCC = 0
19.9 V 16.3 18.2 19.9 V

Soft-Start Operation Stop Voltage VSS/OLP 1.1 1.2 1.4 V

Soft-Start Oper. Charging Current ISS/OLP -390 -550 -710 µA

Operation Stop Voltage VCC(OFF) Turn-off, VCC = 19.9
8.8 V 8.8 9.7 10.6 V

Circuit Current in Non-Operation ICC(OFF) VCC = 15 V – – 100 µA

Normal Operation
Drain-Source Breakdown Voltage V(BR)DSS ID = 300 µA 650 – – V

Drain Leakage Current IDSS VDS = 650 V – – 300 µA

On-State Resistance rDS(on) ID = 1.9 A, TJ = +25°C – – 0.96 Ω

Switching Time tf – – 400 ns

Circuit Current ICC(ON) – – 6.0 mA

Oscillation Frequency fosc 19 22 25 kHz

Bottom-Skip Oper. Threshold Volt. VOCPBD(BS1) -605 -665 -720 mV

VOCPBD(BS2) -385 -435 -485 mV

Quasi-Resonant Oper. Threshold VOCPBD(TH1) 280 400 520 mV

VOCPBD(TH2) 670 800 930 mV

Feedback-Pin Threshold Voltage VFB(OFF) 1.32 1.45 1.58 V

Feedback-Pin Current IFB(ON) 600 1000 1400 µA

Standby Operation

Standby Operation Start Voltage VCC(S) VCC = 0
12.2 V 10.3 11.1 12.1 V
Standby Oper. Start Volt. Interval VCC 1.10 1.35 1.65 V

Standby Non-Operation Current ICC(S) VCC = 10.2 V – 20 56 µA

Feedback-Pin Current IFB(ON) VCC = 10.2 V – 4.0 14 µA

Feedback-Pin Threshold Voltage VFB(S) VCC = 12.2 V 0.55 1.10 1.50 V

Minimum ON Time ton(min) 0.5 0.8 1.2 µs

continued next page ...

www.allegromicro.com 3
 STR-W6754 ih ng rs
Universal-Input/100 W Off-Line Quasi- itc lato
Resonant Flyback Switching Regulator Sw egu
R
ELECTRICAL CHARACTERISTICS at TA = +25°C, VCC = 20 V, voltage measurements are referenced to S/GND terminal
(unless otherwise specified).

Limits

Characteristic Symbol Test Conditions Min. Typ. Max. Units

Protection Operation
OVP Operation Voltage VCC(OVP) Turn-off, VCC = 0
29.9 V 25.5 27.7 29.9 V

Maximum ON Time ton(max) 27.5 32.5 39.0 µs

OLP Operation Voltage VSSOLP 4.0 4.9 5.8 V

OLP Operation Current ISSOLP -6.0 -11 -16 µA

Overcurrent Detect. Threshold Volt. VOCPBD(LIM) -0.895 -0.940 -0.995 V

OCP/BD-Pin Current IOCPBD -40 -100 -250 µA

Latch Holding Current ICC(H) VCC = 29.9
VCC(OFF) – 0.3 V – 45 140 mA

Latch Release Voltage VCC(L) VCC = 29.9
6 V 6.0 7.2 8.5 V

Other
Thermal Resistance RθJF Output junction-to-frame – – 1.6 °C/W

NOTES: 1. Typical Data is for design information only.

2. Negative current is defined as coming out of (sourcing) the specified device termninal.

115 Northeast Cutoff, Box 15036

4 Worcester, Massachusetts 01615-0036
 ih ng rs STR-W6754
itc lato Universal-Input/100 W Off-Line Quasi-
Sw egu Resonant Flyback Switching Regulator
R
MOSFET TYPICAL CHARACTERISTICS

Avalanche energy is measured at VDD = 99 V,

L = 20 mH, IL = 5.1 A.

www.allegromicro.com 5
 STR-W6754 ih ng rs
Universal-Input/100 W Off-Line Quasi- itc lato
Resonant Flyback Switching Regulator Sw egu
R
MOSFET TYPICAL CHARACTERISTICS (cont’d)

WARNING — These devices are designed to be operated at lethal voltages and energy levels. Circuit designs
that embody these components must conform with applicable safety requirements. Precautions must
be taken to prevent accidental contact with power-line potentials. Do not connect grounded test
equipment.
The use of an isolation transformer is recommended during circuit development and breadboarding.

115 Northeast Cutoff, Box 15036

6 Worcester, Massachusetts 01615-0036
 ih ng rs STR-W6754
itc lato Universal-Input/100 W Off-Line Quasi-
Sw egu Resonant Flyback Switching Regulator
R
APPLICATIONS INFORMATION

Typical Application Complete product description and applications information

is provided in Application Note 28103.30, Series STR-
W6750 Off-Line Quasi-Resonant Flyback Switching
Regulators.

The products described herein are manufactured in Japan by Sanken Sanken products listed in this publication are designed and intended
Electric Co., Ltd. for sale by Allegro MicroSystems, Inc. for use as components in general-purpose electronic equipment or
Sanken and Allegro reserve the right to make, from time to time, such apparatus (home appliances, office equipment, telecommunication
departures from the detail specifications as may be required to permit equipment, measuring equipment, etc.). Their use in any application
improvements in the performance, reliability, or manufacturability of its requiring radiation hardness assurance (e.g., aerospace equipment) is
products. Therefore, the user is cautioned to verify that the information not supported.
in this publication is current before placing any order. When considering the use of Sanken products in applications where
When using the products described herein, the applicability and higher reliability is required (transportation equipment and its control
suitability of such products for the intended purpose shall be reviewed at systems or equipment, fire- or burglar-alarm systems, various safety
the users responsibility. devices, etc.), contact a company sales representative to discuss and
obtain written confirmation of your specifications.
Although Sanken undertakes to enhance the quality and reliability of
its products, the occurrence of failure and defect of semiconductor The use of Sanken products without the written consent of Sanken in
products at a certain rate is inevitable. applications where extremely high reliability is required (aerospace
equipment, nuclear power-control stations, life-support systems, etc.) is
Users of Sanken products are requested to take, at their own risk, strictly prohibited.
preventative measures including safety design of the equipment or
systems against any possible injury, death, fires or damages to society The information included herein is believed to be accurate and
due to device failure or malfunction. reliable. Application and operation examples described in this publica-
tion are given for reference only and Sanken and Allegro assume no
responsibility for any infringement of industrial property rights,
intellectual property rights, or any other rights of Sanken or Allegro or
any third party that may result from its use.

www.allegromicro.com 7
 STR-W6754 ih ng rs
Universal-Input/100 W Off-Line Quasi- itc lato
Resonant Flyback Switching Regulator Sw egu
R
PACKAGE DIMENSIONS
in Millimeters

Product weight: approx. 2.3 g.

Recommended mounting hardware torque: 0.588 ~ 0.785 NM, 6 ~ 8 kgf × cm.
Recommended silicon grease: Dow Corning SC102, Toshiba YG6260, Shin-Etsu G746, or equivalent.

115 Northeast Cutoff, Box 15036

8 Worcester, Massachusetts 01615-0036