12/30/2009 A 5HP Electrical Generator fully powered …
A 5HP Electrical Generator fully powered with the BingoFuel
Reactor
created on April 2, 2003 - JLN Labs - Last update April 18, 2003
Cliquez ici pour la version Française
Toutes les informations et schémas sont publiés gratuitement ( freeware ) et sont destinés à un usage personnel et non
commercial
All informations and diagrams are published freely (freeware) and are intended for a private use and a non commercial use.
On April 15th, 2003, an Electrical Generator powered with a 5HP ( 160 cm3 ) 4-stroke
combustion engine ( a Honda GC160 ) has been tested successfully with the BingoFuel
Reactor. The 5HP combustion engine has been fully powered with synthetic gas produced by
the BingoFuel Reactor.
The Electrical Generator tested with the BingoFuel Reactor is a Ranger2500 from SDMO (
see below ) :
bingofuel.online.fr/…/bfr5hpgen.htm 1/8
12/30/2009 A 5HP Electrical Generator fully powered …
ENGINE SPECIFICATIONS
MODEL HONDA GC160
Type 4-stroke, overhead camshaft single cylinder
Total Displacement 160 cm³ (9.8 cu in)
Bore & Strike 64 x 50 mm (2.5 x 2.0 in)
Max Horsepower (Gross) 3.7 kw ¹(5.0hp ) at 3,600 rpm
Max Torque (Gross) 10.3 N·m (1.05 kgf·m, 7.6 lbf·ft) at 2,500 rpm
Compression Ratio 8.5: 1
Fuel Consumption 313 g/kWh (230 g/HPh, 0.51 lb/HPh)
Cooling System Forced-air
Ignition System Transistorized magneto ignition
Ignition Timing 20° B.T.D.C
Spark Plug BPR6ES (NGK)
Carburetor Horizontal type, butterfly valve
Air Cleaner Dry (paper) type
Governor Centifugal mechanical governor
Lubricating System Splash
Oil Capacity 0.58 lt (0.61 US qt, 0.55 Imp qt)
Recommended operating -15°C to 40°C (5°F to 104°F)
ambient tempature
Starting System Recoil starter
Stopping System ignition primary circuit ground
Fuel Used Automotive unleaded gasoline (minimum 86 pump octane)
Fuel tank capacity 2.0 lt (0.53 US gal, 0.44 imp gal)
P.T.O. Shaft Rotation Counterclockwise (viewed from P.T.O. side)
bingofuel.online.fr/…/bfr5hpgen.htm 2/8
12/30/2009 A 5HP Electrical Generator fully powered …
bingofuel.online.fr/…/bfr5hpgen.htm 3/8
12/30/2009 A 5HP Electrical Generator fully powered …
Photo above: The fuel tank ( not used here ) has been completly removed for this test.
bingofuel.online.fr/…/bfr5hpgen.htm 4/8
12/30/2009 A 5HP Electrical Generator fully powered …
Photo above: The air filter has been removed and the synthetic gas output is directly placed
at the carburettor input.
Tests results with the BingoFuel Reactor v1.1
bingofuel.online.fr/…/bfr5hpgen.htm 5/8
12/30/2009 A 5HP Electrical Generator fully powered …
bingofuel.online.fr/…/bfr5hpgen.htm 6/8
12/30/2009 A 5HP Electrical Generator fully powered …
Two tests runs have been conducted successfully, in all the cases the 5HP engine has worked
without any problem.
See the video of the 5HP engine fully powered with the BingoFuel Reactor
To see the video, the free downloadable RealPlayer is required
You may download free the RealPlayer 8 Basic at : http://proforma.real.com/real/player/blackjack.html
bingofuel.online.fr/…/bfr5hpgen.htm 7/8
12/30/2009 A 5HP Electrical Generator fully powered …
Click on the picture above to see the video ( 937 Kb )
Comments from JL Naudin : These tests are very encouraging and confirms fully that the
synthetic gas generated by the BingoFuel Reactor can be used as fuel for a common
combustion engine...
See also the previous tests :
Burning gas tests generated by the BingoFuel Reactor
Email : JNaudin509@aol.com
return to the BingoFuel project home page
bingofuel.online.fr/…/bfr5hpgen.htm 8/8
The AquaFuel® generator
How to generate gas from water for use as Fuel
created on 12-06-98 - JLN Labs - last update on 04-03-2003
Toutes les informations et schémas sont publiés gratuitement ( freeware ) et sont destinés à un usage personnel et non commercial
All informations and diagrams are published freely (freeware) and are intended for a private use and a non commercial use.
Disclaimer: The author assumes no liability for any incidental, consequential or other liability from the use of this
information. All risks and damages, incidental or otherwise, arising from the use or misuse of the information contained
herein are entirely the responsibility of the user. Although careful precaution has been taken in the preparation of this
material.
On 12-06-98, I have built and reproduced successfully a very simple AquaFuel™ generator:
The AquaFuel™ is fully based on the Hilliary Eldridge patent US 603,058 "Electrical Retort"
granted on April 26, 1898.
This is a non fossil combustible gas which is produced by an electric discharge of carbon arcs within distilled,
fresh, salt or other types of water, thus being essentially composed of Hydrogen, Oxygen, Carbon and their
compounds.
Today, there are a lot of names for this synthetic gas such as Aquafuel™, Aqualene™, Magnegas™,
TrueFuel™, Carbo-hydrogen™....
AquaFuel: An example of the emerging new energies and the new methods for their
scientific study
Author: Ruggero Maria Santilli
Comments: 22 pages, Texture
Report-no: TTL-98-004
Subj-class: General Physics
Journal-ref: Hadronic Journal Supplement, Vol. 13, pp. 1-22, 1998
In this paper we initiate studies of the emerging new forms of energy by using as a representative example
the new combustible gas called AquaFuel, discovered and patented by William H. Richardson, jr., whose
rights are now owned by Toups Technology Licensing, Inc. (TTL), of Largo, Florida. In essence, AquaFuel
is a new energy converter capable of transforming Carbon and water into a new combustible gas via an
electric discharge. We show that AquaFuel can be produced easily, safely and rapidly in large amounts, and
exhibits greatly reduced emission pollutants as compared to fossil fuels of current use. Despite its simplicity,
the chemical and physical characteristics of AquaFuel are largely unknown at this writing. We then review
nine basic experimental measurements which are necessary for a scientific appraisal of AquaFuel. We
outline the limitations of quantum mechanics and chemistry for the treatment of {\it new} forms of energy,
namely, energies which by definition should be {\it beyond} said theories. We finally point out the
availability of broader theories specifically constructed for the study of new energies and point out available
applications.
Link to this paper : http://arxiv.org/abs/physics/9805031
This generator produces a mixture of carbon monoxide and hydrogen (COH2) and this is a gas wich burns very
cleanly in oxygen or air, and it can be used as fuel for an internal combustion engine. When burned, COH2
produces carbon dioxide and water vapor, so it generates very little, if any, pollution to the environnement.
Below, an analysis of this gas conducted by the NASA :
Hydrogen 46.483 %
Carbon
9.329
Dioxide
Ethylene 0.049
Ethane 0.005
Acetylene 0.616
Oxygen 1.164
Nitrogen 3.818
Methane 0.181
Carbon
38.370
Monoxide
Total 100.015
This simple experiment is only for testing purposes and only for a proof of the concept. This small
generator can't be used for a long working period and it must be used only for demonstration.
You need to get very few materials and it is very simple to build and test it....
Be Carefull, this device generates an explosive gas, you must conduct this test in a well ventiled room or better
in open air, you must not smoke during the test.. Don't forget that the carbon monoxide ( CO ) is a very toxic
gas, so never breath this gas before burning it. This experiment is not intended for the inexperienced. User of
this document should be very carefull to try anything out ! If you do it the risk of any results is just yours. I take
no responsibility of anything that might happen, let it be of a wrong information or anything else.
You need only to get :
- A little plastic soda bottle,
- two carbon rods ( 70mm length, 6mm diam )
- one 1 ohm 50Watts resistor
- a DC Power supply which is able to deliver 35v / 10A
- some wires, plugs and silicon cement.
Very few material is needed.....
1) Drill two opposite holes (10mm diam) at 60mm from the bottom of the bottle and insert the carbon rods
with a rubber washer and glue the washer with silicon cement. I suggest you to make one of the carbon
rod into round shape. The two carbon rods must be just slightly in contact before you switch on (see
below).
2) Connect the 1 ohm 50W resistor in serie with one of carbon rod and one pole of your DC power supply
( set for 34V/15A DC), the other pole of your power supply is connected to the other carbone rod. You
may add some additional multimeters for measuring the Current and the Voltage input. Fill up your
generator with only distilled or fresh water.
3) Now, your are ready to produce AquaFuel™......
Click here to see some animated videos of the AquaFuel(tm) generator in action
You will see below some videos which show my AquaFuel(tm) in action and some personal comments.......
click here to see the AquaFuel(tm) demo 1 (277kb)
click here to see the AquaFuel(tm) demo 2 (90kb)
( if you don't have the RealPlayer 5.0, you may download it freely at :
http://www.real.com/products/player/ )
Some reference documents and web link :
United States Patent 6,183,604 - Santilli - February - 6, 2001
Durable and efficient equipment for the production of a combustible and non-pollutant
gas from underwater arcs and method therefor
Abstract
A system for producing a clean burning combustible gas comprising an electrically conductive first
electrode and an electrically conductive second electrode. A motor coupled to the first electrode is adapted
to move the first electrode with respect to the second electrode to continuously move the arc away from the
plasma created by the arc. A water tight container for the electrodes is provided with a quantity of water
within the tank sufficient to submerge the electrodes.
Inventors: Santilli; Ruggero Maria (Palm Harbor, FL)
Assignee: Hadronic Press, Inc. (Palm Harbor, FL)
Field of the Invention
The present invention relates to durable and efficient equipment for the production of a combustible and
non-pollutant gas from underwater arcs and method therefor and more particularly pertains to producing a
combustible gas from the underwater arcing of electrodes moving with respect to each other.
Click here to see the full patent
Link to the MagneGas™ technology web site
United States Patent 6,217,713 - Lee , et al. - April 17, 2001
Process for producing aquafuel by using carbon fiber bundle electrodes
Abstract
The invention concerns a process for producing aquafuel by replacing conventional inflexible carbon bars
with thin, flexible and tough carbon fiber bundles as consumptive electrodes which thereby can be
sustainedly fed and can produce aquafuel continuously. Such carbon fiber bundle electrodes can be prepared
by pultrusion, and electrodes may be further carbonized or graphitized in order to increase the conductivity
and gas productivity thereof.
Inventors: Lee; Chi-Young (Hsin-Chu Hsien, TW); Chen; Swe-Kai (Hsin-Chu, TW); Tai; Nyan-Hwa
(Hsin-Chu, TW)
Assignee: National Science Council of Republic of China (Taipei, TW)
Field of The Invention
The invention relates to a process for producing aquafuel by using carbon fiber bundle electrodes, and in
particular, to a process for producing aquafuel by auto-feeding flexible carbon fiber bundle electrode in an
electrolytic reaction, wherein said flexible carbon fiber bundle electrodes are formed by impregnating
flexible, tough carbon fibers with a resin and said electrode can be used sustainedly in the electrolytic
reaction of water under low voltage for a long period of time.
Click here to see the full patent
US 603,058 - Electrical Retort by Hilliary Eldridge April 26, 1898 ( the TRUE original
Aquafuel patent )
US 5,159,900 - Method and means of generating gas from water for use as a fuel ( Aquafuel Patent )
US 5,417,817 - Biomass gasification process and apparatus
US 5,435,274 - Electrical Power Generation Without Harmful Emissions ( Aquafuel Patent )
US 5,692,459 - Pollution Free Vehicle Operation
US 5,792,325 - Electric Arc Material Processing System ( Aquafuel Patent )
US 5,826,548 - Power Generation Without Harmful Emissions ( Aquafuel Patent )
US 6,299,738 - Fuel Gas production by underwater arcing ( Aquafuel Patent )
EP1227142 - Method and system for producing hydrogen from solid carbon materials and water
Infinite Energy Vol.2, No9, 1996
Infinite Energy Vol.2, No10, 1996
Infinite Energy Vol.2, No11, 1997
Infinite Energy Vol.4, No19, 1998
Aqualux Corporation web site ( disabled )
MagneGas™ technology web site from Hadronic Press Inc
A new fuel produced from water and carbon by Alexander's Gaz and Oil production
Le gaz à l'eau ( gaz de houille )
The scientific research undelying Santilli's Plasm-Arc-Flow reactors, Magnegaz(Tm), and
Magneliquids(Tm) from IBR
AquaFuel by the Morgan Energy Group
AquaFuel Vs Diesel, analysis the Morgan Energy Group
AquaFuel Vs Gasoline, analysis the Morgan Energy Group
The TrueFuel™ : Technical informations by Advanced Energy Research Corporation
The Aquafuel™ is a trademark from Aqualux Corporation
The Magnegas™ is a trademark from Hadronic Press Inc
The TrueFuel™ is a trademark from Advanced Energy Research Corporation
The Carbo-Hydrogen™ is a trademark from DW Energy Research
Email : JNaudin509@aol.com
Return to the JLN Labs home page
