Safety Data Sheet

According to Regulation (EC) No 1907/2006, Annex II

and Commission Regulation (EU) 2020/878
Version 3.0: 30.08.2023
ZAP Grease COMPLEX Red EP 3
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product Identifier
ZAP Grease COMPLEX Red EP 3
1.2. Relevant identified uses of the substance or mixture and uses advised against
Lithium Complex lubricating grease.
1.3. Details of the supplier of the safety data sheet
ZAP LUBES SIA,
5 VISKALU STREET
LV-1026 RIGA, LATVIA
Phone: + 371 67543642
e-mail: [email protected]
www.zap-grease.com
1.4. Emergency telephone number
State Fire And Rescue Service Of Latvia: +371 112
Valsts Toksikoloģijas Centrs (National Toxicology Center), Saindēšanās un zāļu informācijas centrs
(Poisoning and Drug Information Centre)
Address: Hipokrāta 2, LV-1038 Riga, Latvia,
Phone: +371 67042473, service is available 24 hours

SECTION 2: Hazards identification

2.1. Classification of the substance or mixture
Classification according to Regulation (EC) No 1272/2008 (CLP)
Not classified.
This product does not meet the criteria for classification in any hazard class according to Regulation (EC) No 1272/2008 on
classification, labelling and packaging of substances and mixtures.

2.2. Label elements

Labelling according to Regulation (EC) No 1272/2008 (CLP)
Hazard pictograms Not applicable.
Signal word Not applicable.
Hazard Statements Not applicable.
Precautionary statements Not applicable.
Voluntary precautionary advices
- in general If medical advice is needed, have product container or label at hand (P101).
Keep out of reach of children (P102).
- for prevention None
- in reaction None
- at storage None
- for disposal Dispose of contents and container to hazardous or special waste collection point, in
accordance with local, regional, national and/or international regulation (Р501).
Supplemental label elements EUH210 Safety Data Sheet available on request.
2.3. Other hazards

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 1 of 8
 PBT, vPvB, SVHC or ED criteria Based on the manufacturer's data, the mixture does not contain any ingredients:
- which meet the PBT or vPvB criteria as laid down in Annex XIII to Regulation (EC) No 1907/2006,
- or which were included in the list established in accordance with Article 59(1) for having endocrine disrupting
..properties,
- or which were identified as having endocrine disrupting properties in accordance with the criteria set out in Commission
..Delegated Regulation (EU) 2017/2100 or Commission Regulation (EU) 2018/605,
at a concentration equal to or greater than 0.1 % by weight.

SECTION 3: Composition/information on ingredients

3.2. Mixtures
Mixture description Lithium Complex lubricating grease.

Substance name %, REACH EINECS/CAS No Classification according

weight Registration No. to regulation
(ЕC) No 1272/2008 (CLP)
Distillates (petroleum), hydrotreated heavy ≤ 60 01-2119484627-25-0035 265-157-1 / 64742-54-7 Not classified.
paraffinic
Residual oils (petroleum), solvent-dewaxed ≤ 35 01-2119480472-38-0013 265-166-0 / 64742-62-7 Not classified.
Phosphorodithioic acid, mixed O,O-bis(2- <1 01-2119521201-61-xxxx 288-917-4 / 85940-28-9 Skin Irrit. 2, H315
ethylhexyl and iso-Bu and iso-Pr) esters, Eye Irrit. 2, Н319
zinc salts Aquatic Chronic 2, Н411
Zinc bis[O,O-bis(2-ethylhexyl)] < 0.5 01-2119493635-27-xxxx 224-235-5 / 4259-15-8 Eye Dam. 1, Н318
bis(dithiophosphate) Aquatic Chronic 2, Н411
Benzeneamine, N-phenyl-, reaction ≤ 0.5 01-2119491299-23-xxxx 270-128-1 / 68411-46-1 Repr. 2, H361f
products with 2,4,4- trimethylpentane

NOTES:
All mineral oils are considered to be severely refined and not considered to be carcinogenic under IARC. All the oils in this product
contain < 3% DMSO extract (IP 346).
For a full text of H-statements: See SECTION 16.

SECTION 4: First aid measures

4.1. Description of first aid measures
General information Take off immediately all contaminated clothing and shoes that may cause /
already cause skin contact with the product.
Emergency medical attention is required when there is:
- unconsciousness,
- stopping breathing or sudden breathing problems,
- has severe injury or severe bleeding that is life-threatening,
- signs of a heart attack (sudden pain behind the sternum),
- signs of a stroke (sudden weakness of one side),
- other life-threatening situations.
See also: https://www.nmpd.gov.lv/lv/kad-zvanit-113.
After first aid, monitor the condition of the affected persons.
Delayed effects after exposure are unlikely.
In case of accident, seek medical advice immediately.
In all cases of doubt, or when symptoms persist, seek medical attention.
If unconscious, place in recovery position and get medical attention immediately.
Wash contaminated clothing before reuse, clean shoes or discard them.
Inhalation If irritation, headache, nausea, or drowsiness occurs, remove to fresh air.
Get medical attention if breathing becomes difficult or symptoms persist.
Skin contact Wash skin with plenty of soap and water for several minutes.
Get medical attention if skin irritation develops or persists.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 2 of 9
 Eye contact Remove contact lenses before flushing, if any and easy to do. Immediately flush
eyes with plenty of clean water keeping eyelids apart.
Get medical attention if eye irritation persists.
Ingestion DO NOT INDUCE VOMITING. Get medical attention. Never give anything by mouth
to an unconscious or convulsing person. If nausea or irritations do not appear after
ingestion, give medical carbon in water slurry (3 tablespoons in one litre water).
4.2. Most important symptoms and effects, both acute and delayed
Prolonged inhalation of unusually high concentrations of product mist or vapours
may cause nose and lung irritation, headache, nausea and drowsiness.
Prolonged or repeated skin contact may produce allergic reactions such as
redness, rash and dermatitis. Prolonged eye contact may cause irritation, redness
and discomfort. If more than several mouthfuls are swallowed, abdominal
discomfort, nausea, and diarrhoea may occur.
4.3. Indication of any immediate medical attention and special treatment needed
Treat symptomatically.

SECTION 5: Firefighting measures

5.1. Extinguishing media
Suitable extinguishing media Use water fog, dry powder, foam or carbon dioxide. Use water to cool fire-
exposed containers. If the leak or spill has not ignited, use water fog to disperse
the vapours and to provide protection for personnel attempting to stop the leak.
Unsuitable extinguishing media Water jet.
5.2. Special hazards arising from the substance or mixture
Smoke, carbon monoxide, carbon dioxide and other products of incomplete
combustion.
5.3. Advice for firefighters
Special protective equipment The nature of special protective equipment required will depend upon the size of
for firefighters the fire, the degree of confinement of the fire and the natural ventilation
available. Fire-resistant clothing and self-contained breathing apparatus is
recommended for fires in confined spaces and poorly ventilated areas. Full
fireproof clothing is recommended for any large fires involving this product.
Extinguishing procedures In case of fire - Always call the fire brigade. Small fires, such as those capable of
being fought with a hand-held extinguisher, can normally be fought by a person
who has received instruction on the hazards of flammable liquid fires. Fires that
are beyond that stage should only be tackled by people who have received hands-
on training. Ensure escape path’s available.

SECTION 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures
For non-emergency personnel No action shall be taken involving any personal risk or without suitable training.
Evacuate surrounding areas. Keep unnecessary and unprotected personnel from
entering. Do not touch or walk through spilled material. Do not breathe vapour or
mist. Provide adequate ventilation. Wear appropriate respirator when ventilation
is inadequate. Put on appropriate personal protective equipment.
For emergency responders If specialised clothing is required to deal with the spillage, take note of any
information in Section 8 on suitable and unsuitable materials. See also the
information in “For non-emergency personnel”.
6.2. Environmental precautions Prevent entry into sewers and waterways. Pick up free liquid for recycle and/or
disposal. Residual liquid can be absorbed on inert material.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 3 of 9
6.3. Methods and material for containment and cleaning up
Clean-up spill as soon as possible while following the requirements for exposure
control/personal protection. Use sand and sawdust to clean. Use appropriate
cleaning techniques such absorption by fire resistant material or pumping.
6.4. Reference to other sections See Section 8 for more information on personal protective equipment.
See Section 13 for waste disposal practices.

SECTION 7: Handling and storage

7.1. Precautions for safe handling
Avoid prolonged or repeated contact with skin. Avoid breathing of vapours.
Wash hands after handling. Do not smoke.
7.2. Conditions for safe storage, including any incompatibilities
Keep containers closed when not in use. Avoid exposure to heat. Store at ambient
temperature. Do not store near explosive substances, compressed, liquefied or
pressurized gases, flammable liquids or oxidizing agents.
7.3. Specific end use(s) In accordance with the relevant product specification.

SECTION 8: Exposure controls/personal protection

8.1. Control parameters
Occupational exposure limits Union occupational exposure limit values do not refer to any components of a
mixture specified in Section 3.
Please refer to National occupational exposure limits, if applicable.
Recommended monitoring In household conditions: Not applicable.
procedures: Working in professional / industrial conditions:
If this product contains ingredients with exposure limits, personal, workplace
atmosphere or biological monitoring may be required to determine the
effectiveness of the ventilation or other control measures and/or the necessity to
use respiratory protective equipment.
Management standards such as the following should be considered:
EN 689 (Workplace exposure - Measurement of exposure by inhalation to
chemical agents - Strategy for testing compliance with occupational exposure limit
values),
EN 482 (Workplace exposure - General requirements for the performance of
procedures for the measurement of chemical agents).
Control banding Not applicable.
recommendations:
8.2. Exposure controls
Appropriate engineering Use in well-ventilated areas.
controls
Individual protection measures, Follow the good occupational and personal hygiene practices to control product
such as personal protective exposures.
equipment
Eye/face protection Safety goggles.
Hand protection Neoprene gloves. Time for wearing out the gloves material >30 minutes.
Skin/body protection Exposed employees should exercise reasonable personal cleanliness. This includes
cleansing exposed skin areas several times daily with soap and water and
laundering or dry cleaning soiled work clothing.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 4 of 9
 Long sleeve shirt is recommended. Use chemically protective boots when
necessary to avoid contaminating shoes. Do not wear rings, watches or similar
apparel that could entrap the material and cause a skin reaction.
Respiratory protection No respiratory protection is normally required. If vapours or mist is generated, use
approved respirator as appropriate.
Thermal hazards Not applicable.
Hygiene measures When using, do not eat, drink or smoke. Always observe good personal hygiene
measures, such as washing after handling the material and before eating, drinking,
and/or smoking. Routinely wash work clothing to remove contaminants. Discard
contaminated footwear that cannot be cleaned.
Environmental exposure May form an oil film leading to de-oxygenation of water and possible harmful
control effect on aquatic life. Product can penetrate soil until reaching the surface of
ground water (in the presence of ground water).

SECTION 9: Physical and chemical properties

9.1. Information on basic physical and chemical properties
Appearance Semi-solid
Colour Red
Odour Petroleum
Odour threshold Not applicable.
pH Not applicable.
Freezing/Pour point Not applicable.
Initial boiling point and boiling range Not applicable.
Flash point > 230 C (for base oil; Pensky-Martens Closed Cup)
Evaporation rate No data available.
Flammability (solid, gas) Not applicable.
Upper/lower flammability or exposure limits Not applicable.
Vapour pressure Not applicable.
Vapour density Not applicable.
Relative density < 1 g/ml (20 C)
Solubility Soluble in hydrocarbons, insoluble in water
Partition coefficient: n-octanol/water No data available.
Auto-ignition temperature Not applicable.
Decomposition temperature Not applicable.
Kinematic viscosity 165 mm2/s at 40 C (for base oil)
Explosive properties None
Oxidising properties None
9.2. Other information
Dropping point > 260 C

SECTION 10: Stability and reactivity

10.1. Reactivity Not expected to enter reactions.
10.2. Chemical stability This product is considered chemically stable at normal storage and handling conditions.
10.3. Possibility of hazardous reactions
None.
10.4. Conditions to avoid This product is normally stable at moderately elevated temperatures and pressures.
10.5. Incompatible materials Strong oxidizing agents, strong acids.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 5 of 9
10.6. Hazardous decomposition products
None known.

SECTION 11: Toxicological information

11.1 Information on hazard classes as defined in Regulation (EC) No 1272/2008
Acute toxicity Based on data available for base oils: the classification criteria are not met.
LD50 oral (rats) > 5000 mg/kg (OECD 401)
LD50 dermal (rabbits) > 5000 mg/kg (OECD 402)
LC50 inhalation (rats) > 5 mg/l/4h (OECD 403)
Skin corrosion/irritation Not expected to cause skin corrosion or irritation. Repeated or prolonged contact
with skin may defat or dry the skin resulting in discomfort and dermatitis.
Serious eye damage/irritation Not expected to cause serious eye damage or irritation. May cause eyes irritation.
May cause minimal irritation or redness if accidental eye contact occurs.
Respiratory or skin sensitisation Not expected to be respiratory or skin sensitizer. Prolonged or repeated skin
contact as from clothes wetted with material may cause dermatitis.
Germ cell mutagenicity No data available to indicate product or any components present at levels greater
than 0.1% are mutagenic or genotoxic.
Carcinogenicity This product is not considered to be a carcinogenic by IARC, ACGIH, NTP or OSHA.
Nota L – meets EU requirement of less than 3% (w/w) DMSO extract for total
polycyclic aromatic compound using IP 346.
Reproductive toxicity Not expected to damage specific target organs. Based on date for similar
substances.
STOT-single exposure Not expected to damage specific target organs. Based on date for similar
substances.
STOT-repeated exposure Not expected to damage specific target organs. Based on date for similar
substances.
Aspiration hazard The mixture does not meet the criteria for classification.
Other information If material is misted or if vapours are generated from heating, exposure may cause
irritation of mucous membranes and the upper respiratory tract.
11.2 Information on other hazards
Endocrine disrupting properties Based on the manufacturer's data, the mixture does not contain any ingredients:
- which were included in the list established in accordance with Article 59(1) for having endocrine disrupting
..properties,
- or which were identified as having endocrine disrupting properties in accordance with the criteria set out in
..Commission Delegated Regulation (EU) 2017/2100 or Commission Regulation (EU) 2018/605,
at a concentration equal to or greater than 0.1 % by weight.
Other information No data available.

SECTION 12: Ecological information

12.1 Toxicity This product is of relatively low toxicity – based on data of product components.
LC50 for base oil (96 hours for fish) is > 100 mg/l (OECD 203)
EC50 for base oils (48 hours for Daphnia) is > 10 000 mg/l (OECD 202)
EC50 for base oils (72-96 hours for algae or other aquatic plants) > 100 mg/l (OECD
201)
NOEL/21 days (aquatic invertebrates) > 10 mg/l (OECD 211)

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 6 of 9
 NOEL/72 h (algae) > 100 mg/l
NOEL/10 min (micro organisms) > 1.93 mg/l (DIN 38412, DIN 38409)
12.2 Persistence and degradability This product is not readily biodegradable. Information about base oil -I inherent
biodegradability < 22 % after 28 days (OECD 301B).
12.3 Bioaccumulative potential Partition coefficient n-octanol/water (Log KOW) for base oils is > 4.0 - indicates
possible bioaccumulation.
12.4 Mobility in soil Low, due to low water solubility. Spillage may penetrate the soil causing ground
water contamination.
12.5 Results of PBT and vPvB assessment
This product is not and does not contain any substance that is potential PBT or
vPvB.
12.6 Endocrine disrupting properties
Based on the manufacturer's data, the mixture does not contain any ingredients:
- which were included in the list established in accordance with Article 59(1) for having endocrine disrupting
..properties,
- or which were identified as having endocrine disrupting properties in accordance with the criteria set out in
..Commission Delegated Regulation (EU) 2017/2100 or Commission Regulation (EU) 2018/605,
at a concentration equal to or greater than 0.1 % by weight.
12.7 Other adverse effects May form an oil film leading to deoxygenation of water and possible harmful
effect on aquatic life.

SECTION 13: Disposal consideration

13.1 Waste treatment methods Dispose of empty lubricant containers at approved for such wastes places. Follow
all state or local regulations and requirements for disposal, recycle or reclaiming of
waste oils and petroleum products.
Waste Code 13 08 99* in accordance with European Waste Catalogue (E. W. C.).
Other information Do not allow product to reach water bodies or soil.
Do not pierce, open or weld the uncleaned container.
Residues can cause an explosion.
Do not empty into drains, store in the original container or in an oil-resistant
container, or in a container rented / supplied by a waste collection company.

SECTION 14: Transport information

14.1 UN number or ID number None

14.2 UN proper shipping name Not applicable.

14.3 Transport hazard class(es) None

14.4 Packing group Not applicable.
14.5 Environmental hazards
ADR Not regulated as dangerous goods.
RID Not regulated as dangerous goods.
ADN Not regulated as dangerous goods.
IMDG Not regulated as dangerous goods.
IATA Not regulated as dangerous goods.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 7 of 9
14.6 Special precautions to user None

14.7 Maritime transport in bulk according to IMO instruments

Not applicable.

SECTION 15: Regulatory information

15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
Regulation (EC) No 1907/2006 of The European Parliament And Of The Council of
18 December 2006 concerning the Registration, Evaluation, Authorisation and
Restriction of Chemicals (REACH), establishing a European Chemicals Agency,
amending Directive 1999/45/EC and repealing Council Regulation (EEC) No 793/93
and Commission Regulation (EC) No 1488/94 as well as Council Directive
76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, 93/105/EC and
2000/21/EC
Commission Regulation (EU) 2020/878 of 18 June 2020 amending Annex II to
Regulation (EC) No 1907/2006 of the European Parliament and of the Council
concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals
(REACH)
Regulation (EC) No 1272/2008 of The European Parliament And Of The Council of
16 December 2008 on classification, labelling and packaging of substances and
mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and
amending Regulation (EC) No 1907/2006
15.2 Chemical safety assessment Not available.
Other information
REACH annexes
Annex XIV Not applicable.
Annex XVII Not applicable.
Regulation 649/2015/EU Not applicable.
Regulation 1005/2009/EC Not applicable.
Regulation 850/2004/EC Not applicable.
Seveso III, Directive 2012/18/EU Not applicable.

SECTION 16: Other information

Recommendations for In accordance with Article 35 of the REACH Regulation: „Workers and their representatives
training: shall be granted access by their employer to the information provided in accordance with Articles 31 and
32 in relation to substances or mixtures that they use or may be exposed to in the course of their work.”

Staff working with this product should be trained about the possible risks of
personal protective equipment and first aid. All first aid instructions must be in
accordance with safety, health and environmental regulations. Observe all safety
and hygiene requirements for handling chemicals.
Written first aid instructions must be freely available at the workplace.
Indication of which of the methods of evaluating information referred to in Article 9 of Regulation (EC) No
1272/2008 was used for the purpose of classification.
Classification in accordance Evaluation method used:
with regulation (EC) No
1272/2008:
None. Classification according to calculation procedure.

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 8 of 9
 Revision Information
Version 3.0
Revision date 30.08.2023
Revision No. 2
Revised sections 1 - 16 (full SDS update)
Replaces version 2.0 of 15.02.2021

List of abbreviations
PBT Persistent, Bioaccumulative, and Toxic
vPvB very Persistent and very Bioaccumulative
ED endocrine disrupting
SVHC Substances of Very High Concern
DMSO Dimethyl sulphoxide
IP 346 London Petroleum Institute standard “Determination of polycyclic aromatics in
unused lubricating base oils and asphaltene free petroleum fractions – Dimethyl
sulphoxide extraction refractive index method.”
LD50 Lethal Dose 50 (median concentration of a toxicant that will kill 50% of the test
animals within a designated period)
LC50 Lethal Concentration 50 (concentration in water having 50% chance of causing
death to aquatic life)
EC50 Half maximal effective concentration
NOEL No-Observed-Effect Level
OECD Organisation for Economic Cooperation and Development
IARC International Agency for Research on Cancer
ACCGIH American Conference of Governmental Industrial Hygienists
NTP National Toxicology Program (USA)
OSHA Occupational Safety and Health Administration (USA)
Log Kow Logarithm (base 10) of the octanol-water partition coefficient
ADR European Agreement concerning the International Carriage of Dangerous Goods by
Road
RID Regulation concerning the International Carriage of Dangerous Goods by Rail
ADN European Agreement concerning the International Carriage of Dangerous Goods by
Inland Waterways
IMDG International Maritime Dangerous Goods (code)
IATA International Air Transport Association
IMO International Maritime Organization
A list of relevant hazard statements and hazard classes
H315 Causes skin irritation
H318 Causes serious eye damage
H319 Causes serious eye irritation
H361f Suspected of damaging fertility
H411 Toxic to aquatic life with long lasting effects
Aquatic Chronic 2 Aquatic hazard (long-term) - Hazard Category 2
Eye Dam. 1 Serious eye damage - Hazard Category 1
Eye Irrit. 2 Eye irritation - Hazard Category 2
Repr. 2 Reproductive toxicity - Hazard Category 2
Skin Irrit. 2 Skin irritation - Hazard Category 2
This information is the best of our current knowledge, and is believed to be correct as of the date hereof, and is intended to describe the
product only in terms of health and safety and environmental requirements. Since the conditions of use are outside our control, any
recommendations and suggestions are made without guarantee.

End of safety data sheet

Revision No. 2
30.08.2023 ZAP Grease COMPLEX Red EP 3 Page: 9 of 9