Form No.

913228

RS5-34
Revision C
Jan. 2008

Telescopic Handler
Serial Number 12101 thru 12947

Parts Manual
Introduction RS5-34 Telescopic Handler

Grease fittings and common attaching hardware,

NOTE: This parts manual identifies both stan- such as cotter pins, set screws, woodruff keys,
dard and optional features for this model. screws, nuts, etc., are included in the parts list,
Depending on the features of your machine, indented below the part it is (they are) associated
some of the items identified in the parts lists may, with, but may NOT be illustrated, except where a
or may not be included with your machine. particular routing or special fastening arrangement
MUST be maintained. The hardware listed is for
mounting purposes and is NOT included when the
part is ordered for replacement.
The table of contents pages show the page location
of various component groups on the machine. Part numbers for standard hardware are listed indent-
ed under the component being fastened.
When ordering service parts, specify the correct part
A complete listing of part numbers for attaching
number, full description, quantity required, and the
washers/nuts used on this machine is included in the
unit model and serial number.
table on the facing page. Refer to the abbreviations
Model and serial numbers for this unit are stamped list on the facing page for descriptions.
on a plate located inside the operator’s station. The
Standard attaching hardware torque values are pro-
serial number is also stamped on the top front frame.
vided on the inside back cover. Unless otherwise
The following reference shows the breakdown of
specified, all cap screws are Grade 5, cadmium or
the serial number:
zinc plated; hexagon nuts for Grade 5 cap screws or
bolts are Grade 5.
Model Unit Number

Engine

RS5-34 J X 03 12000

Month

Year (X=06, Y=07, etc.)

“Right” and “left” are determined from a position

sitting on the seat and facing forward.

Gehl Company reserves the right to make changes or

improvements in the design or construction of any
part of the unit without incurring the obligation to
install such changes on any unit previously deliv-
ered.
RS5-34 Telescopic Handler Table of Contents
Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Front Cover
Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

DECALS
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

CAB
Standard Cab and Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Front and Rear Window Group (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Windshield Wiper / Top and Front (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Top and Left Windows (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Cab Door (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Instrument Panel, Switches and Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Heater (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Steering column and Shifter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Brake and Accelerator Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Cab Mounts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32

CHASSIS
Hydraulic Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34
Fuel Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Battery Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38
Hoods and Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
Front and Rear Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

PERSONNEL WORK PLATFORM (PWP)

Boom Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44
Chassis Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45
Radio Remote - Transmitter and Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46

ENGINE
External Engine Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48
Radiator and Cooler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50
Engine Air Intake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Engine Exhaust Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54

TRANSMISSION
External Transmission and Drive Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56
Converter Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58
Case and Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60
(TRANSMISSION continued on next page)

PRINTED IN U.S.A. 1 913228/CP0108

RS5-34 Telescopic Handler Table of Contents
Page
(TRANSMISSION Continued)
Torque Converter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Gear Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Pump Drive Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Charge Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67
Reverse Idler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68
Forward and Reverse Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Third Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72
First and Second Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74
Output Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76
Control Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78
Drive Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
Modulation Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81

AXLES
External Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82
Steering Cylinder and Tie Rods (Front Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84
Steering Cylinder and Tie Rods (Rear Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85
Differential Housing Group (Front Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86
Differential Housing Group (Rear Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87
Brake Group (Front Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88
Brake Group (Rear Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .89

AXLE, FRONT
Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92

AXLE, REAR
Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94
Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96

BOOM
Outer Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98
Intermediate Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100
Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
Dynattach ® Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104

HYDRAULIC SYSTEMS
Hydraulic Pump and Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106
Steer Motor and Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108
Brake Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110
Brake and Steering Lines Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .112
Main Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Main Valve / Hydraulic Controls (joysticks) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116
(HYDRAULIC SYSTEMS continued on next page)

913228/CP0108 2 PRINTED IN U.S.A.

Table of Contents RS5-34 Telescopic Handler
Page
(HYDRAULIC SYSTEMS continued)
Main Valve / Radio Remote Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118
Hydraulic Controls - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120
Hydraulic Controls - Auxiliary Hydraulic Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122
Hydraulic Controls - PWP Only . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124
Hydraulic Controls - PWP and Auxiliary Hydraulic Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126
Hydraulic Controls - Radio Remote Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .128
Hydraulic Controls - Radio Remote Option w/PWP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130
Frame Level Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132
Lift Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134
Tilt / Slave Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136
Boom Extend Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138
Auxilary Hydraulics Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140

HYDRAULIC COMPONENTS
Hydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .142
Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .143
Main Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .144
PWP Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .146
Steer Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .148
Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149
Radio Remote Option Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150
Controller - Tilt / Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152
Controller - Lift / Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .154
Controller - Auxiliary Hydraulics Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .156
Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .158
Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160
Slave Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162
Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .164
Boom Extend Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .166
Fork Shift Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .168
Rotate Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169

ATTACHMENTS
Carriage Forks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .170
Standard Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .172
Fork Shift Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174
Rotate Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .176
Boom Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .178
180O Swing Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .180
Bucket Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .182

NUMERICAL INDEX
Numerical Index List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .184

PRINTED IN U.S.A. 3 913228/CP0108

Filters RS5-34 Telescopic Handler

2 1

Hydraulic
Secondary Air
Primary Air

6
5

8
4

5”
3-1/2”

OIL Transmission
Fuel

Fuel

913228/CP0108 4 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Filters

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 137498 PRIMARY AIR FILTER (outer) . . . . 1 a Use Dust Seal P/N 102742 as needed.
02 137501 SECONDARY AIR FILTER (inner) . 1
03 L97489 HYDRAULIC FILTER. . . . . . . . . . . . 1 b Used with 99 hp John Deere TIER II
04a 102173 ENGINE OIL FILTER . . . . . . . . . . . . 1 engine. (Units equipped with this engine
05b L98978 FUEL FILTER . . . . . . . . . . . . . . . . . 1 use the manual accelerator pedal.) This filter
06c 102174 FUEL FILTER . . . . . . . . . . . . . . . . . 1 measures 3-1/2” high; as shown in the illustration.
07d 103441 SEDIMENT BOWL. . . . . . . . . . . . . . 1
08 L99184 TRANSMISSION FILTER . . . . . . . . 1 c Used with 115 hp John Deere TIER II
engine. (Units equipped with this engine
use the electronic accelerator pedal.) This filter
measures 5” high; as shown in the illustration.

d Replace as needed.

PRINTED IN U.S.A. 5 913228/CP0108

Decals RS5-34 Telescopic Handler

GENERAL INFORMATION NEW DECAL APPLICATION

Before applying the new decals, surfaces must be free
from dirt, dust, grease and other foreign material. To
CAUTION apply a solid-formed decal, remove the smaller por-
tion of the decal backing paper and apply this part of
ALWAYS follow the safety precautions on the exposed adhesive backing to the clean surface
decals. Replace decals if they are damaged, while maintaining proper position and alignment.
or if the unit is repainted. If repainting, be Slowly peel off the other portion of the backing paper
sure that all applicable decals are affixed in while applying hand pressure to smooth-out decal sur-
their proper locations. face. To apply a die-cut decal, first remove the back-
ing paper. Then, properly orient and position the decal
onto the clean mounting surface. After the decal is
Decal locations information is provided to assist in firmly applied and smoothly pressed down, remove
the proper selection and application of new decals, in the front covering paper.
the event original decals become damaged or the
machine is repainted. PAINT FINISH

For correct replacement of decals, compare the loca- Use this list to order paint for refinishing:
tion illustrations to your machine before starting to 167788 One Gallon Yellow
refinish the unit. Check off each required decal using 167789 6 (12 oz. Spray Cans) Yellow
the illustration reference number to find the part num- 167754 One Gallon Gun-Metal Gray
ber, description and quantity in the list. Refer to the 167755 6 (12 oz. Spray Cans) Gun-Metal Gray
appropriate illustration for replacement locations.
If there is a decal on a part that is to be replaced, be
sure that the decal is applied to the replacement part.

Boom Attachment Decals

L65927 WARNING - PINCH POINT

L65348 WARNING - WINCH
L66042 WARNING - TRUSS BOOM TILT

913228/CP0108 6 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Decals

10

6
11

7
1
2
2

4 8

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L70305 DANGER-HANDS OUT . . . . . . . . AR 07 L65928 DANGER-PERSONNEL INJURY . AR

02 L65927 WARNING-PINCH POINT . . . . . . AR (units without PWP)
03 184069 GEHL, 6-3/4” . . . . . . . . . . . . . . . . AR 08 L66613 DYNATTACH UNLOCKED . . . . . . AR
04 137632 HYDRAULIC OIL FILL . . . . . . . . . AR 09 137634 DIESEL FUEL. . . . . . . . . . . . . . . . AR
05 L65932 WARNING-NO RIDERS . . . . . . . . AR 10 103329 RS5-34, RIGHT HAND . . . . . . . . AR
06 102026 GEHL, 2”. . . . . . . . . . . . . . . . . . . . AR 11 L65942 HOT SURFACE . . . . . . . . . . . . . . AR

PRINTED IN U.S.A. 7 913228/CP0108

Decals RS5-34 Telescopic Handler

6
9 9
8

2
17
2

5
4

2
10

7
14 3
16
13
11

12

913228/CP0108 8 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Decals

DECAL LOCATIONS - FRAME AND BOOM

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L70305 DANGER-HANDS OUT . . . . . . . . AR 10 072798 COOLANT UNDER PRESSURE. . . 1

02 L65927 WARNING-PINCH POINT . . . . . . AR 11 L65932 WARNING-NO RIDERS . . . . . . . . AR
03 L65933 WARNING-JUMP START . . . . . . . AR 12 L63474 BRAKE FLUID . . . . . . . . . . . . . . . AR
04 102027 GEHL, 5”. . . . . . . . . . . . . . . . . . . . AR 13 100359 OPERATOR MANUAL WARNING. . 1
05 L65937 DYNATTACH DIAGRAM . . . . . . . AR 14 L65928 DANGER-PERSONNEL INJURY . AR
06 184069 GEHL, 6-3/4” . . . . . . . . . . . . . . . . AR (units without PWP)
07 056859 ANTI-FREEZE . . . . . . . . . . . . . . . AR 16 103229 LUBE CHART . . . . . . . . . . . . . . . . . 1
08 L62583 HALF ZONE MARKER . . . . . . . . . . 5 17 103328 RS5-34 LEFT HAND . . . . . . . . . . . . 1
09 L67718 NO. “0” EXTENSION MARKER . . . 1
L67719 NO. “1” EXTENSION MARKER . . . 1
L67720 NO. “2” EXTENSION MARKER . . . 1
L67721 NO. “3” EXTENSION MARKER . . . 1
L67722 NO. “4” EXTENSION MARKER . . . 1
L67723 NO. “5” EXTENSION MARKER . . . 1

PRINTED IN U.S.A. 9 913228/CP0108

Decals RS5-34 Telescopic Handler

7 8 9 10

12

6
1

11

DECAL LOCATIONS - OPERATOR STATION

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L70306 WARNING-TILT HAZZARD . . . . . . . 1 08 L63632 ATTACHMENT TILT/FRAME LVL . . 1

/GENERAL OPERATOR 09 L63631 BOOM CONTROL . . . . . . . . . . . . . . 1
02 L65930 WARNING-MACHINE LEVEL . . . . . 1 10 102718 AUX. HYD. CONTROL (optional) . . 1
03 L65926 WARNING-CARRY LOAD LOW . . . 1 11 102717 IGNITION/START/HORN. . . . . . . . . 1
04 L68295 F-N-R SHIFT . . . . . . . . . . . . . . . . . . 1 12 L70307 DANGER-HIGH VOLTAGE . . . . . . . 1
05 140516 MADE IN U.S.A. . . . . . . . . . . . . . . . 1 /MOVING PARTS
06 101506 WARNING-PARK BRAKE . . . . . . . . 1
/SEAT BELT
-- LOAD CHARTS--
07 101570 STANDARD CARRIAGE . . . . . . . . . 1
101666 ROTATING CARRIAGE . . . . . . . . . 1
101572 BUCKET LOAD CHART . . . . . . . . . 1
101574 TRUSS BOOM LOAD CHART . . . . 1
101573 WINCH LOAD CHART . . . . . . . . . . 1

913228/CP0108 10 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Decals

2
5 1

DECAL LOCATIONS - PWP EQUIPPED UNITS

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L71554 WARNING-PERSONNEL LIFT. . . AR 04 103334 PWP LOAD CHART . . . . . . . . . . . AR

02 L71555 WARNING-WORK PLATFORM . . AR 05 102969 PWP SWITCH . . . . . . . . . . . . . . . AR
/RULES 06 103028 PWP SYSTEM . . . . . . . . . . . . . . . AR
03 L71700 PERSONNEL LIFT SAFETY . . . . AR
/RULES

PRINTED IN U.S.A. 11 913228/CP0108

Cab RS5-34 Telescopic Handler

Standard Cab and Covers

3
2 4
25
26 27

4
29
24

INSTRUMENT PANEL 9
AND LOAD CHARTS 5 10
23 22 6 7

29

8 11

15 12
14

5
16
8
13 7 6 11

21 20 28
DASH ACCESS PANELS

15

18

FRONT

17

15

913228/CP0108 12 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Standard Cab and Covers

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 103089 CAB WELDMENT . . . . . . . . . . . . . . 1 24 102692 COVER, FUSE PANEL . . . . . . . . . . 1

02 103022 BULB SEAL, RIGHT WINDOW . . . . 1 L50202 1/4”-20X5/8” BUTTN HD . . . . . . . . 4
03 103021 GLASS, RIGHT HAND . . . . . . . . . . 1 25b 102882 PANEL, DASH . . . . . . . . . . . . . . . . . 1
103675 SCREEN (option) 26c L63634 LOAD CHART PLATE . . . . . . . . . . . 2
04 L500057 CLIP, WINDOW . . . . . . . . . . . . . . . . 3 27 L63887 1/4”-20 U-BOLT . . . . . . . . . . . . . . . . 1
L500055 SCREW, FLANGE . . . . . . . . . . . . . 6 28 NSS ACCESS STEP . . . . . . . . . . . . . . . . 1
05 L50051 1/4”-20 WHIZ LOCK NUT. . . . . . . AR 29 L70069 PLUG . . . . . . . . . . . . . . . . . . . . . . AR
06 L500022 WASHER, FLAT (BLACK) . . . . . . . . 3 (not shown)
07 L500020 BUSHING, NYLON . . . . . . . . . . . . . 3
08 L500021 GROMMET, 1/2”ID X 1/4”GROOVE 3 -- ITEMS NOT SHOWN--
09 102880 MOUNT, REAR GLASS UPPER . . . 2 00 102646 HARNESS, CANOPY . . . . . . . . . . . 1
10 L52025 5/16”-18X3/4” BUTT. HD BOLT . . . . 4 00a L63813 HOLE PLUG, 2-1/2” DIA . . . . . . . . . 1
11 L52024 1/4”-20X1” BUTT. HD BOLT . . . . . . 3 (defroster hole in dash)
12 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 1 00 L54002 TREAD STRIP, 6” WIDE (4 FT.) . . . 1
13 102881 MOUNT, REAR GLASS LOWER . . 1 00 L71305 PLUG (top of cab) . . . . . . . . . . . . . . 2
14 L50139 1/4” LOCK WASHER . . . . . . . . . . . . 2
15 L50202 1/4”-20X5/8” BUTT. HD BOLT . . . AR
16 103024 BULB SEAL, REAR WINDOW . . . . 1 a Use when not equipped with a heater.
17a 102728 PANEL, HEATER. . . . . . . . . . . . . . . 1
18a 102727 PANEL, DASH COVER . . . . . . . . . . 1 b Refer to Instrument Panel and Switches section on
19 NA .............................0 the next page for information regarding switches
20 102778 WLDMNT, BRAKE CYL COVER . . . 1 and gauges.
21 102769 COVER, HYD. CONTROLLERS . . . 1
L50202 1/4”-20X5/8” BUTT0N HEAD . . . . . 5 c Refer to Decal Section for Load Chart Decals.
22 L66011 INDICATOR/FRAME LEVEL . . . . . . 1
L50417 #8-32X1” SCREW . . . . . . . . . . . . . 2
23 L69297 PLATE, INCLMT MOUNT . . . . . . . . 1
L52025 5/16”-18X3/4” BUTT. HD BOLT . . . 4

PRINTED IN U.S.A. 13 913228/CP0108

Cab RS5-34 Telescopic Handler

Front and Rear Window Group (Option)

REAR WINDOW HINGE

2
1 FRONT WINDOW HINGE

8
4
6 5
7 5 1
1

2
4 6

3 9

12 11 10

18 13

17
14 14
16
16 15
16
19

20

FRONT

913228/CP0108 14 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Front and Rear Window Group (Option)

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L500038 5/16”-18 ACCORN NUT . . . . . . . . AR 15a 101730 MOUNT, REAR WINDOW LATCH . 1
02 651639 5/16”-18X1” BUTTN HD BOLT . . . . 4 16 L500019 PIN, ROLL - 3/16”x1/2” . . . . . . . . . . 3
03 651640 5/16”-18X3/4” BUTTN HD BOLT . . . 8 17 L500028 HOLD OPEN, L-STYLE. . . . . . . . . . 1
04 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 4 18 L500027 HOLD OPEN, L-STYLE. . . . . . . . . . 1
05 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 6 19a 103029 MOUNT, WIND. HOLD OPEN (RH) 1
06 651641 5/16” FLAT WASHER (BLACK) . . . . 4 20a 102722 MOUNT, WIND. HOLD OPEN (LH). 1
07 L500111 HINGE, FRONT WINDOW . . . . . . . 2
08 L500024 HINGE, PLASTIC (rear window) . . . 1
09 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 1 a Use the parts listed below to fasten mount to frame:
10 103024 BULB SEAL, REAR GLASS . . . . . . 1 00 650863 1/4” FLAT WASHER . . . . . . . . . . AR
11 103022 BULB SEAL, FRONT GLASS . . . . . 1 00 654002 1/4” LOCK WASHER. . . . . . . . . . AR
12 103019 GLASS, FRONT . . . . . . . . . . . . . . . 1 00 L50202 1/4”-20X5/8” BUTTN HD BOLT . . AR
13 101727 HOLD OPEN, T-STYLE. . . . . . . . . . 1
14 L500025 PIN, QUICK DETATCH . . . . . . . . . . 4

PRINTED IN U.S.A. 15 913228/CP0108

Cab RS5-34 Telescopic Handler

Wiper (Option) / Front and Top Glass

10
9

5 8
6
7 11

15
14
1
2

19 12

17
17 16
18 13

913228/CP0108 16 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Wiper (Option) / Front and Top Glass

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

Note: unless otherwise indicated, the following parts 16 L500711 SCREW / M5 16mm . . . . . . . . . . . . 1
are used on the top and front windows. 17 101717 WASHER, #10 WEATHERTITE . . . 2
18 L500004 NUT/ACORN #10-24 BLK . . . . . . . . 1
01 L500718 BOLT / 10-24x1.25 HEX GR5 . . . . . 1 19c L500694 BUSHING / NYLON. . . . . . . . . . . . . 2
02 L500001 WASHER/BLK NYLON . . . . . . . . . . 1 20 101495 BOTTLE, DUAL -PUMP WASHER . 1
03 L500696 COVER WIPER MOTOR. . . . . . . . . 1
04 L500695 WIPER MOTOR / TRICO . . . . . . . . 1 -- ITEMS NOT SHOWN --
05c L500708 TOWER SEAL / TRICO WIPER . . . 1 (Windshield Wiper Harness)
06 L500701 GASKET / PANTO ADAPTER . . . . . 1 00 103179 HARNESS, TOP WIPER . . . . . . . . . 1
07 L500719 PANTO ADAPTER PLATE. . . . . . . . 1 00 103180 HARNESS, FRONT WIPER . . . . . . 1
08 L500099 ADAPTOR/WET ARM . . . . . . . . . . . 1
09 102913 WIPER BLADE (16”) . . . . . . . . . . . . 1
10 L500707 ADAPTER / PIN LOCK . . . . . . . . . . 1 (Windshield Washer System)
11 WIPER ARM . . . . . . . . . . . . . . . . . . 1 00 102925 HARNESS, WASHER BOTTLE . . . 1
L500702 Note a (15-12/”) 00 103013 TUBING, WASHER (15-1/2’) . . . . . . 1
102912 Note b (18-1/2”)
12 L500700 M8 / ACORN NUT . . . . . . . . . . . . . . 1
13 L500706 M5 / ACORN NUT . . . . . . . . . . . . . . 1 a Used for front window
14 L500709 RAIN SHIELD . . . . . . . . . . . . . . . . . 1 b Used for top window
15 L500697 M18 / NUT . . . . . . . . . . . . . . . . . . . . 1 c Not used on top window

WASHER SYSTEM RESERVOIR

LOCATED OUTSIDE CAB -
UNDER RIGHT SIDE WINDOW

20

PRINTED IN U.S.A. 17 913228/CP0108

Cab RS5-34 Telescopic Handler

Top and Left Window (Option)

4
2 5
3 6
7

10

10
8

FRONT

913228/CP0108 18 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Top and Left Windows (Option)

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01a 103027 GLASS, TOP . . . . . . . . . . . . . . . . . . 1 08 103025 GLASS, LEFT REAR. . . . . . . . . . . . 1

02 L500038 5/16”-18 ACCORN NUT . . . . . . . . AR 09 103026 BULB SEAL, LEFT GLASS . . . . . . . 1
03 102711 WINDOW MOUNT. . . . . . . . . . . . . . 2 10 102712 WINDOW MOUNT. . . . . . . . . . . . . . 2
04 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 4
05 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 4 a Use P/N L500607 Adhesive Kit to attach
06 651641 5/16” FLAT WASHER (BLACK) . . . . 4 top glass to cab.
07 651639 5/16”-18X1” BUTTN HD BOLT . . . . 4

PRINTED IN U.S.A. 19 913228/CP0108

Cab RS5-34 Telescopic Handler

Cab Door (Option)

1
2
5
3

11

8
9 7
12
8 10
7
6
15

14

22 21

16

20

19
18 4
17
8
7 6 5

FRONT

913228/CP0108 20 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Cab Door (Option)

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

00 103014 CAB DOOR . . . . . . . . . . . . . . . . . . 1 (included with item #16 as a set)

(includes items 1-10, 12 and 15) 19 101719 GLASS MOUNT . . . . . . . . . . . . . . . 1
20 102948 HANDLE, EXT. DOOR LOCKING . . 1
01 102874 WELDMENT, CAB DOOR FRAME . 1 101792 KEY ONLY . . . . . . . . . . . . . . . . . . . 1
02 102705 BULB SEAL, DOOR FRAME . . . . . 1 21 102886 LATCH RELEASE, INTERIOR . . . . 1
03 102680 GLASS, UPPER DOOR . . . . . . . . . 1 651635 1/4-20X1-1/4” FLAT HD SCREW . . 2
04 102681 GLASS, LOWER DOOR . . . . . . . . . 1 L50202 1/4-20X5/8” BUTTN HD BOLT . . . . 1
05 651638 5/16”-18X1-3/4” BUTTN HD BOLT . 5 651636 M6-1X12 8.8 BOLT. . . . . . . . . . . . . 2
06 651641 5/16” FLAT WASHER (BLACK) . . . . 5 L500022 FLAT WASHER (BLACK) . . . . . . . . 1
07 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 8 L520003 1/4”-20 NYLON INSERT NUT . . . . 2
08 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 8 L70069 1/2” HOLE PLUG . . . . . . . . . . . . . . 2
09 L500038 5/16”-18 ACCORN NUT (BLACK) . . 7 22 101436 STRIKER . . . . . . . . . . . . . . . . . . . . . 1
10 651643 5/16”-18X2” BUTTN HD BOLT . . . . 3 654028 7/16” LOCK WASHER . . . . . . . . . . 1
11 650730 3/8”X5” BOLT. . . . . . . . . . . . . . . . . . 3 654046 7/16” FLAT WASHER . . . . . . . . . . . 1
12 102901 WELDMENT, DOOR HINGE . . . . . . 3 L50979 7/16”-14 NUT . . . . . . . . . . . . . . . . . 1
14 L520005 3/8” NYLON INSERT NUT . . . . . . . 3
15 102928 BUMPER, DOOR . . . . . . . . . . . . . . 1
16 L500036 HOLD OPEN/DOOR (SET) . . . . . . . 1 00 L70069 1/2” PLUG . . . . . . . . . . . . . . . . . . . . 1
(includes item #18) [mounts to cab] (access hole for door handle)
17 650588 1/4”-20x1-1/2” BOLT . . . . . . . . . . . . 1
18 NSS HOLD OPEN/DOOR STUD. . . . . . . 1

PRINTED IN U.S.A. 21 913228/CP0108

Cab RS5-34 Telescopic Handler

Instrument Panel, Switches and Fuses

REFER TO “NOTE”
ON FACING PAGE 34

1 2 3 4 5 6

9
F-N-R SHIFT MDDULE
LOCATED NEXT TO FUSES
UNDER LOAD CHARTS

10

33

16 15 14 13 12 11

103104
DIODE PACK
LOCATED UNDER
TRANS. HOOD
17
FUSES AND RELAYS
LOCATED UNDER LOAD CHARTS
ON SIDE DASH

25 26
27
24 28
23
29

HORN
SWITCHES LOCATED START 30
ON LOWER DASH

31
22

21
18
19
32
FRONT 20

913228/CP0108 22 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Instrument Panel, Switches and Fuses

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01c L63640 GAUGE, FUEL . . . . . . . . . . . . . . . . 1 29 103100 MICRO RELAY, 20 AMP . . . . . . . . . 1

02c L66437 GAUGE, WATER TEMP. . . . . . . . . . 1 30 103100 MICRO RELAY, 20 AMP . . . . . . . . . 1
03 L71075 SWITCH, STEER MODE. . . . . . . . . 1 31 103100 MICRO RELAY, 20 AMP . . . . . . . . . 1
04 101278 SWITCH, ENGINE FAULT. . . . . . . . 1 32 103100 MICRO RELAY, 20 AMP . . . . . . . . . 1
05 L71086 SWITCH, CLUTCH CUT OUT. . . . . 1 33 103104 DIODE PACK, 4 DIODES . . . . . . . . 1
06 L71074 SWITCH, PARK BRAKE . . . . . . . . . 1 (included with item 00 103265
07 L71082 SWITCH, LIGHTS . . . . . . . . . . . . . . 1 wire harness below)
08 L71084 SWITCH, TURN SIGNALS . . . . . . . 1 34 101877 MODULE, F-N-R SHIFTER . . . . . . . 1
09 L71077 SWITCH, HAZARD LIGHTS . . . . . . 1
10 L71691 SWITCH, PWP . . . . . . . . . . . . . . . . 1 -- ITEMS NOT SHOWN --
11a NA OPTIONAL SWITCH . . . . . . . . . . . . 1 00 103265 WIRE HARNESS, FRAME . . . . . . . 1
12 L71081 SWITCH, ETHER . . . . . . . . . . . . . . 1 (includes the following diode and fuse):
13 L71076 SWITCH, WIPER/WASHER . . . . . . 1 103104 DIODE PACK, 4 DIODES. . . . . . . . 1
14 L71076 SWITCH, WIPER/WASHER . . . . . . 1 (located under chassis cover just
15 072340 GAUGE, HOUR METER . . . . . . . . . 1 in front of transmission)
16 L63610 GAUGE, LIGHT CLUSTER . . . . . . . 1 L500225 60 AMP MAXI FUSE . . . . . . . . . . . 1
17 102882 PANEL, DASH . . . . . . . . . . . . . . . . . 1 (located near engine starter)
(does not include switches or gauges) 00 L630004 GROUND STRAP . . . . . . . . . . . . . . 1
18 L41848 SWITCH, PUSH BUTTON. . . . . . . . 2
19 089069 SWITCH, IGNITION w/KEY. . . . . . . 1
089070 KEY ONLY . . . . . . . . . . . . . . . . . . . 1 a Use P/N L71088 Switch Hole Plug to cover hole
20b 102646 HARNESS, CANOPY . . . . . . . . . . . 1 when switches are not present.
21 L70075 CHANGE OVER RELAY . . . . . . . . . 1
22 L70075 CHANGE OVER RELAY . . . . . . . . . 1 b Not all connections or terminals are shown in this
23 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 1 illustration. The fuse and relay blocks as shown
24 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 1 are located under the load chart panel on the
25 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 1 side dash.
26 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 1
27 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 1 c Back light kit #103227; for illuminating gauges.
28 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 1
Note: Switches shown in the llustration or listed on this
page are for reference purposes only. Your
machine might be configured differently or might not
include all of the options shown.

FUSE AND RELAY REFERENCE

21 (Relay #2) - 20 AMP change-over relay - PARK BRAKE
22 (Relay #1) - 20 AMP change-over relay - IGNITION

23 (Fuse #2) - 15 AMP fuse - (IGNITION) - transmission, park brake, PWP, steer select, injector
24 (Fuse #4) - 25 AMP fuse - (IGNITION) - heater, gauges
25 (Fuse #6) - 25 AMP fuse - (IGNITION) - front wiper motor
26 (Fuse #5) - 25 AMP fuse - (IGNITION) - top wiper motor
27 (Fuse #3) - 15 AMP fuse - (IGNITION) - lights, ether, clutch cutout
28 (Fuse #1) - 15 AMP fuse - (BATTERY) - ignition switch, horn, brake lights, backup alarm

29 (Relay) - 20 AMP micro relay - top wiper

30 (Relay) - 20 AMP micro relay - lights
31 (Relay) - 20 AMP micro relay - bulb check
32 (Relay) - 20 AMP micro relay - front wiper

PRINTED IN U.S.A. 23 913228/CP0108

Cab RS5-34 Telescopic Handler

Heater (Option)

2
FRONT

3
4 5

6
7

10

8
2

913228/CP0108 24 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Heater (Option)
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 102907 HEATER ASSEMBLY . . . . . . . . . . . 1 06 136305 SWITCH, VARIABLE SPEED . . . . . 1

(Includes items 1-9) 07 L50202 1/4”-20X5/8” BUTTN HD BOLT . . . 10
103033 BLOWER MOTOR (only). . . . . . . . . 1 08 L500163 VAVLE, WATER . . . . . . . . . . . . . . . . 1
02 L63545 GRILL, DEFROSTER . . . . . . . . . . . 2 09 137503 LOUVER . . . . . . . . . . . . . . . . . . . . . 1
03 102944 INSTRUMENT PANEL. . . . . . . . . . . 1 10 L500143 RESISTOR BLOCK . . . . . . . . . . . . . 1
04 102945 DECAL, HEAT CONTROL. . . . . . . . 1
05 103036 CONTROL, TEMPERATURE . . . . . 1 -- ITEMS NOT SHOWN--
L99983 KNOB ONLY . . . . . . . . . . . . . . . . AR 00 NSS 5/8” HEATER HOSE (10’) . . . . . . . . 1
00 L500161 HEATER HOSE CLAMP. . . . . . . . AR

PRINTED IN U.S.A. 25 913228/CP0108

Cab RS5-34 Telescopic Handler
Steering Column and Shifter Group

FRONT

5
7

9
10
8

T LS

F-N-R SHIFT MDDULE P STEER MOTOR

LOCATED NEXT TO FUSES PORTS
UNDER LOAD CHARTS
R
L

913228/CP0108 26 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab
Steering Column and Shifter Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
01 103359 CAP, STEERING WHEEL . . . . . . . . 1 07 L68282 CLAMP, SHIFTER(included w/ #6) . 1
02 L41261 NUT, STEERING WHEEL . . . . . . . . 1 08 L52026 3/8”-16X1-1/4” BUTTN HD BOLT . . 4
03 L69595 STEERING WHEEL . . . . . . . . . . . . 1 09 101882 MOTOR, STEER . . . . . . . . . . . . . . . 1
04 L50101 M5X.8X35mm HX SKTHD BOLT . . 2 10 101877 MODULE, F-N-R SHIFTER . . . . . . . 1
05 102783 COLUMN, STEERING. . . . . . . . . . . 1 102649 WIRE HARNESS, FNR SHIFTER. . 1
06 L68772 F-N-R/1-2-3 SHIFTER (includes #7) 1 (not shown)
L99425 BOOT . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 27 913228/CP0108

Cab RS5-34 Telescopic Handler
Seat

4
5 7
3
2 8
3
3 4 9
2

6 5 10
4
5
11 5 3
3 4

8 2
4 5
3
9
6

12

13

FRONT SUSPENSION SEAT

(OPTION)

913228/CP0108 28 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab
Seat

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 100135 SEAT, OPERATOR (w/armrest). . . . 1 10a 100071 SEAT RISER . . . . . . . . . . . . . . . . . . 1

L99454 ARM REST (only) . . . . . . . . . . . . . 1 11 L50823 5/16”-18X1” BOLT . . . . . . . . . . . . AR
02 L70634 SEAT BELT . . . . . . . . . . . . . . . . . . . 1 12b L68496 BELLOWS, SUSPENSION SEAT . . 1
(includes tethers) (includes seatbelt / tether bracket)
03 L510041 7/16”-20X1” BOLT . . . . . . . . . . . . AR 13 103195 PEDESTAL / BOLT ON SEAT . . . . . 1
04 L50196 7/16” FLAT WASHER . . . . . . . . . . AR
05 L50517 7/16”-20 NYLON INSERT NUT . . AR
06 L70212 BRACKET, TETHER . . . . . . . . . . . . 2 a Used for standard seat only. Not used with
07a L70201 MOUNT, SEAT BELT . . . . . . . . . . . . 1 suspension seat option.
08 L50141 5/16” FLAT WASHER . . . . . . . . . . AR
09 L50056 5/6”-18 NYLON INSERT NUT . . . AR b Used for suspension seat option only.

PRINTED IN U.S.A. 29 913228/CP0108

Cab RS5-34 Telescopic Handler

Brake and Accelerator Pedals

FRONT

29 28
27
26
ELECTRONIC THROTTLE
USED WITH
25 115 HP TIER II

1 24
MANUAL THROTTLE
USED WITH 99 HP TIER II

22
23
3
2
22

5 21
4
BRAKE PEDAL RETURN
SPRING - NOT SHOWN

9 7 6
8 20
19
18
10 17
11 16

11
12 13 14 12
15
14
13

913228/CP0108 30 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Cab

Brake and Accelerator Pedals

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L63230 PAD, BRAKE PEDAL . . . . . . . . . . . 1 24a L68641 PEDAL, ACCELERATOR . . . . . . . . 1

02 L50235 5/16”-18X1-1/4” BOLT . . . . . . . . . . . 2 L52024 1/4”-20X1” BUTTN HD BOLT . . . . . 3
03 L50056 5/16”-18 FLANGE NUT . . . . . . . . . . 2 L50051 1/4”-20 FLANGE NUT . . . . . . . . . . 3
04 102785 BRAKE LEVER ASSEMBLY . . . . . . 1 L98865 BOOT . . . . . . . . . . . . . . . . . . . . . . . 1
(includes item 7) 25b 101291 THROTTLE PEDAL, ELECTRONIC 1
05 102530 BRAKE LINKAGE, WLDMNT . . . . . 1 26b 102872 COVER, ELEC. THROTTLE . . . . . . 1
06 L50151 1/2” FLAT WASHER . . . . . . . . . . . . 1 27b L52025 5/16”-18X3/4” BUTTN HD BOLT . . . 2
07 L48179 BRONZE BUSHING . . . . . . . . . . . . 2 102432 5/16”-18 RETAIN/CLIP NUT. . . . . . 2
(included with item 4)
28b L50228 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2
08 102529 PIN, BRAKE LEVER PIVOT . . . . . . 1
29b L50141 5/16” FLAT WASHER . . . . . . . . . . . 2
09 L50628 ROLL PIN, .19X1 . . . . . . . . . . . . . . . 1
10 L10465 ZERK, GREASE 1/4”-28 . . . . . . . . . 1
11 L44859 PIN, CLEVIS 1/2”X27/64” . . . . . . . . 2
-- ITEMS NOT SHOWN--
12 L50607 1/8”X1” COTTER PIN . . . . . . . . . . . 2
(Throttle)
13 L580005 YOKE, CLEVIS 1/2”-13 . . . . . . . . . . 2
14 L50072 1/2”-13 NUT. . . . . . . . . . . . . . . . . . . 2 00a L63420 THROTTLE CABLE. . . . . . . . . . . . . 1
15 102534 ROD, BRAKE VALVE . . . . . . . . . . . 1 L64664 COUPLER (John Deere) . . . . . . . . 1
16 L50261 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 6 L64663 THROTTLE ROD (John Deere) . . . 1
17 L50145 3/8” FLAT WASHER . . . . . . . . . . . . 6
18 L520005 3/8”-16 NYLON INSERT NUT . . . . . 6 (Brake)
19 L50150 7/16” LOCK WASHER . . . . . . . . . . . 2 00 L561004 RETURN SPRING (Brake lever) . . . 1
20 L510041 7/16”-20X1” BOLT . . . . . . . . . . . . . . 2 (attaches to item 4)
21 L63363 VALVE, BRAKE MASTER CYL. . . . 2
a Used when equipped with a 99 hp TIER II engine.
22a L63629 BRACKET, THROTTLE RETRN . . . 2
b Used when equipped with a 115 hp TIER II engine.
23a L62926 SPRING, CABLE TENSION . . . . . . 1

PRINTED IN U.S.A. 31 913228/CP0108

Cab RS5-34 Telescopic Handler

Cab Mounts

4
2
7

1
2

4
3 5 6

7
2

FRONT
RS5-34 Telescopic Handler Cab

Cab Mounts
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 1 07 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 3
02 102782 1” SAE FLAT WASHER . . . . . . . . . . 7
03 102741 RETAINER, CANOPY NUT . . . . . . . 1 -- ITEMS NOT SHOWN--
04 102781 1”-8 CLASS C LOCK NUT . . . . . . . 4 00 L63813 HOLE PLUG, 2-1/2” DIA . . . . . . . . . 1
05 101667 WASHER, CANOPY NUT . . . . . . . 1 (plugs hole in cab where side bolt
06 L50403 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2 attaches)

PRINTED IN U.S.A. 33 913228/CP0108

Chassis RS5-34 Telescopic Handler

Hydraulic Tank Group

1
2

10
11

3
8
12
4

6
9 7
13 14

15
2

16

17

20
19
18

31

30

FRONT 29
28
24 27
21 26

25

22 23

913228/CP0108 34 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Chassis

Hydraulic Tank Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 101879 ASSEMBLY, IN-TANK FILTER. . . . . 1 18 103224 HYDRAULIC TANK WELDMENT . . 1
(includes items 1-3) (includes items 22 and 23)
02 102965 SEAL KIT (three o-rings) . . . . . . . . . 1 19 L50286 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 4
03 L97489 HYDRAULIC FILTER ELEMENT. . . 1 20 L520019 1/2”-13 NYLON INSERT NUT . . . . . 4
04 L50403 3/8”-16X1-1/14” BOLT . . . . . . . . . . . 4 21 L446025 PLUG, -8ORM SAE . . . . . . . . . . . . . 1
05 L50145 3/8” FLAT WASHER . . . . . . . . . . . . 4 22 L49327 STRAINER, HYD. OIL . . . . . . . . . . . 1
06 L277944 ADAP, -20ORM -12JICM . . . . . . . . . 1 23 L61620 1-1/2” THREADED PIPE . . . . . . . . . 1
07 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 1 24 L441010 ADAP, -24NPTM -24JICM . . . . . . . . 1
08 L63215 CAP ASSEMBLY, HYDRAULIC . . . . 1 25 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 1
(includes item 9) 26 103315 HOSE, -4 A6/DS6 60” . . . . . . . . . . . 1
09 L99163 GASKET, FILLER NECK . . . . . . . . . 2 27a 103318 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1
10 L63756 MIRROR, CONVEX 6-1/2”X10”. . . . 1 28 L68805 HOSE, -6 A6/DS8 70” . . . . . . . . . . . 1
11 103991 BRACKET, MIRROR . . . . . . . . . . . . 1 29 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1
12 L520003 1/4”-20 NYLON INSERT NUT . . . . . 1 30 L444002 ADAP, -6ORM -6JICM . . . . . . . . . AR
13 081379 5/16”x1/2” LOCK BOLT . . . . . . . . . . 4 31b L446048 PLUG, -6ORM SAE . . . . . . . . . . . . . 1
14 L50230 5/16”-18x3/4” BOLT . . . . . . . . . . . . 10
15 L50141 5/16” FLAT WASHER . . . . . . . . . . 10
16 L65142 PLATE, HYDRAULIC TANK COVR. 1 a Used on unit equipped with PWP.
17 L65144 GASKET, RUBBER . . . . . . . . . . . . . 1 b Used when unit is not equipped with PWP.

HOSE LOCATOR
07 HYDRAULIC FILTER MAIN VALVE “OUT”
25 HYDRAULIC TANK HYDRAULIC PUMP “IN”
26 HYDRAULIC TANK RETURN JOYSTICK
27a HYDRAULIC TANK RETURN PWP VALVE “T”
28 HYDRAULIC TANK RETURN STEER MOTOR “T”
29 HYDRAULIC TANK RETURN FLOW DIVIDER “T”

PRINTED IN U.S.A. 35 913228/CP0108

Chassis RS5-34 Telescopic Handler

Fuel Tank Group

7
2 4

3
5 8

1
10
11

13

FRONT 15
13
12
14

913228/CP0108 36 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Chassis

Fuel Tank Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103223 FUEL TANK WELDMENT . . . . . . . . 1 09 L50235 5/16”-18X1-1/25” BOLT . . . . . . . . . . 2
02 104303 CAP, FUEL ASSEMBLY. . . . . . . . . . 1 10 L520019 1/2”-13 NYLON INSERT NUT . . . . . 4
(includes item 3) 11 L50286 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 4
03 L99163 GASKET, FILLER NECK . . . . . . . . . 2 12 L446025 PLUG, -8ORM SAE . . . . . . . . . . . . . 1
04a L61867 SENDER, FUEL LEVEL . . . . . . . . . 1 13 L445005 ADAP, -8ORM -6JICM 90 DEG . . . . 2
L50418 #10-32X1/2” RD MACH SCREW . . 5 14 L68619 HOSE, -6 K6/XX 73” (Fuel Supply) . 1
05 L41854 GASKET, FUEL SENDER . . . . . . . . 1 15 102861 HOSE, -4 K6/XX 73” (Fuel Return) . 1
06b 136383 AIR CLEANER ASSEMBLY. . . . . . . 1
07 136443 CLAMP, AIR CLEANER MOUNT. . . 1 a Includes gasket; item #5
08 L50056 5/16”-18 WHIZ LOCK NUT . . . . . . . 2 b Refer to Engine Air Intake Group for individual
air cleaner components.

PRINTED IN U.S.A. 37 913228/CP0108

Chassis RS5-34 Telescopic Handler

Battery Group

1
2

10

3
9

99hp style cables

(shown) 5

FRONT

913228/CP0108 38 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Chassis

Battery Group
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L63334 BAR, BATTERY HOLD DOWN . . . . 1 08 L50061 3/8”-16 FLANGE NUT . . . . . . . . . . . 4
02 L630004 GROUND STRAP, 14GA.X14” . . . . 1 09 L70146 ROD, BATTERY HOLD DOWN. . . . 2
03 CABLE, NEG. BATTERY . . . . . . . . . 1 10 L530003 3/8”-16 WING NUT . . . . . . . . . . . . . 2
101954 Units w/ Electronic throttle pedal
L630001 Units w/ Manual throttle pedal -- ITEMS NOT SHOWN --
04 L630003 BOOT, RUBBER . . . . . . . . . . . . . . . 1 (Used on battery cables 101954 and 101956)
05 CABLE, POS. BATTERY . . . . . . . . . 1 00 101960 POWER PLUG (female end). . . . . . 1
101956 Units w/ Electronic throttle pedal 101963 #8 DUETCH PIN . . . . . . . . . . . . . . 1
L63248 Units w/ Manual throttle pedal 00 101961 POWER PLUG (male end) . . . . . . . 1
06 L41847 HORN, 12V ELEC B2I. . . . . . . . . . . 1 101962 #8 DUETCH SOCKET . . . . . . . . . . 1
07 NSS BATTERY, 4DLT TYPE . . . . . . . . . . 1

PRINTED IN U.S.A. 39 913228/CP0108

Chassis RS5-34 Telescopic Handler

Hoods and Covers

RIGHT

8 11

6
13

7
12

LEFT

2
3 MUFFLER GUARD

10

SKID PLATE
(UNDER CAB)

14

FRONT

913228/CP0108 40 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Chassis

Hoods and Covers

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L68866 FRONT COVER. . . . . . . . . . . . . . . . 1 08 L68186 RADIATOR PANEL (right) . . . . . . . . 1
L52025 5/16”-18X3/4” BOLT . . . . . . . . . . . . 4 L50141 5/16” FLAT WASHER . . . . . . . . . . . 2
L530004 FASTENER RETAINED NUT . . . . . 4 L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2
02 L41847 HORN, 12V . . . . . . . . . . . . . . . . . . . 1 L530004 FASTENER RETAINED NUT . . . . . 1
L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . . 1 09 L68185 RADIATOR PANEL (left) . . . . . . . . . 1
03 L67756 MUFFLER GUARD . . . . . . . . . . . . . 1 L50141 5/16” FLAT WASHER . . . . . . . . . . . 2
L50442 3/8”X1-1/4” BOLT . . . . . . . . . . . . . . 4 L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2
04 103268 HOOD/TRANS COVER. . . . . . . . . . 1 L530004 FASTENER RETAINED NUT . . . . . 1
L50056 5/16”-18 WHIZ NUT . . . . . . . . . . . . 1 10 103370 SKID PLATE . . . . . . . . . . . . . . . . . . 1
L50141 5/16” FLAT WASHER . . . . . . . . . . . 5 11 L68171 GRILLE, RADIATOR . . . . . . . . . . . . 1
L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 6 L68133 SCREW, CAPTIVE . . . . . . . . . . . . . 4
L530004 FASTENER RETAINED NUT . . . . . 5 L68134 RETAINER, SCREW . . . . . . . . . . . 4
05 L68200 COVER, BATTERY ACCESS . . . . . 1 L68135 RECEPTACLE, SCREW . . . . . . . . 4
06 103270 COVER, FUEL FILTER ACCESS . . 1 12 L68182 REAR HOOD EXTENSION . . . . . . . 1
L52025 5/16”-18X3/4” BOLT . . . . . . . . . . . . 4 L50141 5/16” FLAT WASHER . . . . . . . . . . . 2
L50141 5/16” FLAT WASHER . . . . . . . . . . . 4 L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2
07 103273 HOOD, ENGINE COVER . . . . . . . . 1 L530004 FASTENER RETAINED NUT . . . . . 1
L50056 5/16”-18 WHIZ NUT . . . . . . . . . . . . 6 13 103199 REAR HOOD. . . . . . . . . . . . . . . . . . 1
L50141 5/16” FLAT WASHER . . . . . . . . . . . 6 L50141 5/16” FLAT WASHER . . . . . . . . . . . 8
L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 4 L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . . 8
L530004 FASTENER RETAINED NUT . . . . . 2 L530004 FASTENER RETAINED NUT . . . . . 8
L50823 5/16”-18x1” BOLT . . . . . . . . . . . . . . 2 14 103371 BRACKET . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 41 913228/CP0108

Chassis RS5-34 Telescopic Handler

Front and Rear Lights

3
4

FRONT OF CAB

FRONT

REAR COVER

5
8
FRONT 7
10
6
8

913228/CP0108 42 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Chassis

Front and Rear Lights

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L70039 HEAD LIGHT . . . . . . . . . . . . . . . . . . 2 00 L63894 TURN SIGNAL FLASHER . . . . . . . . 1
02 L50145 3/8” FLAT WASHER . . . . . . . . . . . . 2 (located under dash through joystick
03 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2 access cover)
04 101712 GROMMET, 5/8” . . . . . . . . . . . . . . . 2 00 L70241 HARNESS, HEAD LIGHT . . . . . . . . 2
05 103199 HOOD, REAR . . . . . . . . . . . . . . . . . 1 (dash to head lights)
06 L70200 BACKUP ALARM. . . . . . . . . . . . . . . 1 00 103192 GROMMET 13/16”. . . . . . . . . . . . . . 2
L50230 5/16-18X3/4” BOLT . . . . . . . . . . . . . 2 (under dash for head light harness)
L50056 5/16”-18 NUT. . . . . . . . . . . . . . . . . . 2
L50141 5/16” FLAT WASHER . . . . . . . . . . . 2
07 L500339 BEZEL, RUBBER . . . . . . . . . . . . . . 2 a Standard wire harness, used when not equipped
(included with item #08) with turn signals.
08 L70701 LIGHT, BRAKE/TURN . . . . . . . . . . . 2
(includes item #07 bezel) . . . . . . . . . b Used with optional light package for units equipped
09 L500606 BEZEL, RUBBER . . . . . . . . . . . . . . 1 with turn signals. Wire harness 102647 is not used
(included with item #10) when unit is equipped with turn signals.
10 L71595 LIGHT, HALOGEN BACKUP . . . . . . 1
(includes item #09 bezel) Note: Refer to the Outer Boom - Front Section for the
100102 JUMPER WIRE, BACKUP LIGHT . 1 work lights and wire harness associated with the
boom.
-- ITEMS NOT SHOWN --
00a 102647 WIRE HARNESS, REAR LIGHTS. . 1
00b 102572 HARNESS, LIGHT PACKAGE . . . . 1
(dash to rear lights - includes the
following diodes:)
103101 DIODE PACK (see below). . . . . . . 1
L500748 DIODE PACK (see below). . . . . . . 1
L500747 CLEAR COVER, DIODE PACK . . . 2

103101 L500748 L500747

DIODE PACK DIODE PACK DIODE PACK
LOCATED NEAR LOCATED UNDER DASH CLEAR COVER
REAR LIGHTS NEAR SWITCHES

PRINTED IN U.S.A. 43 913228/CP0108

Personnel Work Platform RS5-34 Telescopic Handler

Boom Components

(Attached to Personnel
Work Platform)

110 “

5
612”

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 L71729 REMOTE SWITCH W/CABLE. . . . . 1 04 L71750 REMOTE SWITCH POUCH . . . . . . 1

(Includes item 1-4) 05 L71732 REMOTE SWITCH HARNESS . . . . 1
01 102408 CABLE ASSEMBLY . . . . . . . . . . . . . 1 (Consists of two cables)
02 L71726 REMOTE STOP SWITCH . . . . . . . . 1
03 L71725 REMOTE SWITCH ENCLOSURE. . 1

913228/CP0108 44 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Personnel Work Platform

Chassis

Located under
tank/engine cover
attached to inner
frame

5
4

Located under dash in 3

Joystick Access Cover

Chain and Shackle

(Used to secure
Personnel Work Platform)

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L71553 LEVEL SENSOR . . . . . . . . . . . . . . . 1 -- ITEMS NOT SHOWN --

02 102321 MANIFOLD, PWP JOYSTICK . . . . . 1 00 L71691 PWP SWITCH (located on dash) . . 1
03 104078 PWP CONTROL MODULE . . . . . . . 1 00 104064 PWP WIRE HARNESS . . . . . . . . . . 1
04a L71752 5/16” CHAIN SHACKLE . . . . . . . . . 1 (under dash)
05a L71751 5/16” CHAIN GR40 16 LINKS . . . . 1
a Chain shackle and chain are used to secure the
Personnel Work Platform.

PRINTED IN U.S.A. 45 913228/CP0108

Radio Remote RS5-34 Telescopic Handler

Transmitter and Receiver

1 3
2

Battery
To PWP/WPS harness and
radio remote manifold at
rear of machine

Radio receiver
mount bracket

913228/CP0108 46 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Radio Remote

Transmitter and Receiver

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
00 103414 COMPLETE, RADIO REMOTE . . . . 1
(Includes all items shown) -- ITEMS NOT SHOWN --
01a 103479 REMOTE TRANSMITTER. . . . . . . . 1 00 102968 DECAL/ REMOTE TRANSMITTER. 1
02 103482 SWITCH, TOGGLE 3 POS. MIL . . . 4 00 103424 WIRE HARNESS. . . . . . . . . . . . . . . 1
03 NSS REMOTE RECEIVER . . . . . . . . . . . 1 (to existing PWP wire harness)
04 NSS ENCLOSURE / CIRCUIT BOARD. . 1
05 103475 LANYARD (wire cable) . . . . . . . . . . 1 a Requires programming; refer to “Radio Remote
06 103476 SNAP RING, LANYARD . . . . . . . . . 1 Operators manual“ included with the
07 103994 BRACKET, RECEIVER MOUNT . . . 1 Radio Remote Control at the time of purchase.
L50209 1/4”X1/2” BOLT . . . . . . . . . . . . . . . . 2
L50051 1/4” WHIZNUT. . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A. 47 913228/CP0108

Engine RS5-34 Telescopic Handler

Engine - External Components

2 4
FRONT
19 1
3

18

17 20
16

15
14

09
JOHN DEERE
4045TF (SHOWN)
08

21
22
23
07
6
26
24

10

11

12 25

13 FUEL
TRANSFER
PUMP

913228/CP0108 48 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Engine

Engine - External Components

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 NSS ENGINE, JD 4045T . . . . . . . . . . . . 1 -- ITEMS NOT SHOWN --

02 L41179 RELAY, ENGINE STARTER . . . . . . 1 00 L65570 ENGINE BLOCK HEATER (opt.). . . 1
03 L68571 MOUNT, RELAY . . . . . . . . . . . . . . . 1
04 L64437 SENDER, WATER TEMP . . . . . . . . 1 (Throttle Cable)
05 L69166 FUEL LINE TUBE . . . . . . . . . . . . . . 1 00b L63420 CABLE, THROTTLE . . . . . . . . . . . . 1
06 103626 SENDER, OIL PRESSURE . . . . . . . 1
07 L68596 ENGINE MOUNT (right) . . . . . . . . . 1 (Electrical)
08 L68595 ENGINE MOUNT (left) . . . . . . . . . . 1 00a 101818 HARNESS, TIER II . . . . . . . . . . . . . 1
09 L50305 M16-2X35M BOLT GR8.8 . . . . . . . . 4
10 L50319 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 2 (Engine Electrical)
11 L64124 MOUNT, VIBRATION ISOLATOR . . 2 00af 103862 HARNESS, JD TIER II. . . . . . . . . . . 1
12 L64197 WASHER, ISOLATOR MOUNT. . . . 2 00af 104024 BRACKET, HARNESS MOUNT . . . 1
13 L520007 5/8”-11 NYLON INSERT NUT . . . . . 2 L50952 M10X1.5 BOLT . . . . . . . . . . . . . . . . 1
14 L69718 ADAP, M18 -6NPTF STR . . . . . . . . 2 654028 7/16” LOCK WASHER . . . . . . . . . . . 1
15 L68592 SHUTOFF, MANUAL/WATER . . . . . 1
16 L68591 STEM, HOSE . . . . . . . . . . . . . . . . . 1 (Ether - Optional)
17 L68613 FAN BELT . . . . . . . . . . . . . . . . . . . . 1 00 102926 HARNESS, ETHER KIT . . . . . . . . . 1
18c L447005 ADAP, M18 10 BEAD STR . . . . . . . 1 (includes 21” BLU/WHT jumper wire)
19 L68604 BRACKET, ALTERNATOR. . . . . . . . 1 00d L70629 ETHER KIT (optional) . . . . . . . . . . . 1
20be L66606 BRACKET, THROTTLE . . . . . . . . . 1 (includes: thermostat, atomizer,
21b L64664 COUPLER, ROD TO CABLE . . . . . 1 valve bracket, fitting, clamp and
L50050 #10-32 NUT . . . . . . . . . . . . . . . . . . 2 tubing. Does not include ether
22b L64663 ROD, THROTTLE EXTEND . . . . . . 1 canister.)
23b L580009 BALL JOINT #10-32 . . . . . . . . . . . . 1 00 L71081 SWITCH, ROCKER (ether) . . . . . . . 1
L50050 #10-32 NUT . . . . . . . . . . . . . . . . . . 1 (located in dash panel)
24 104340 ADAP, 5MJ -2MP90. . . . . . . . . . . . . 1
25 104341 ADAP, -6 PUSHON -5FEM JIC . . . . 1 (Fuel Line)
26 NSS FUEL TRANSFER PUMP . . . . . . . . 1 00 L65583 HOSE END, -5 JICF . . . . . . . . . . . . 1
00 L68619 HOSE, 3/8” X 73” (supply). . . . . . . . 1
00 102861 HOSE, 1/4” X 73” (return) . . . . . . . . 1

a When equipped with a 115 HP Tier II engine.

(equipped with an electronic throttle pedal)
ETHER KIT
-- OPTIONAL --
b When equipped with a 99 HP Tier II engine.
CLAMP (equipped with a manual throttle pedal)

c Replaces item 16 and (1) of item 14.

ATOMIZER

d Thermostat is located on engine block, and switch

is located on dash.
THERMOSTAT

e Used with 99 hp TIER II engine with a manual

throttle pedal. For 115 TIER II engine with
VALVE - BRACKET
electronic throttle pedal subsititue Harness
mount bracket P/N 102450.
TUBING

f S/N 12541 and Up

FITTING

PRINTED IN U.S.A. 49 913228/CP0108

Engine RS5-34 Telescopic Handler

Radiator and Cooler Group

7
6

25 1
9
2 6
5 8
4
3
19
24
4
5

21
23
22

11 10
12 4

13
3

18
14
17
4 16
19 5 15

10 4

20

FRONT

913228/CP0108 50 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Engine

Radiator and Cooler Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L76084 HOSE CLAMP . . . . . . . . . . . . . . . . . 1 15 L520019 1/2”-13 NYLON INSERT NUT . . . . . 2
02 102063 RADIATOR CAP (10 LB.) . . . . . . . . 1 16 L40805 VALVE, DRAIN COCK . . . . . . . . . . . 1
03 L63356 COOLER MOUNT . . . . . . . . . . . . . . 2 17 L67589 SHROUD WELDMENT . . . . . . . . . . 1
04 L50141 5/16” FLAT WASHER . . . . . . . . . . AR 18 L50677 M8X1.25X45MM BOLT . . . . . . . . . . 4
05 L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . AR 19 L76020 HOSE CLAMP . . . . . . . . . . . . . . . . . 3
06 L445001 ADAP, -12ORM -12JICM 90 DEG . . 2 20 L68580 LOWER RADIATOR HOSE . . . . . . . 1
07 L446020 ADAP -12JICFS -12JICM 90 DEG . 1 21 FAN GUARD (HALF) . . . . . . . . . . . . 2
08 L63406 HOSE -12 A12/DS12 114” . . . . . . . . 1 L63665 (STANDARD) (Shown)
09 L63399 HOSE -12 DS12/A12 82” . . . . . . . . 1 L67751 (WITH A/C)
10 L50230 5/16”-18X3/4” BOLT . . . . . . . . . . . AR 22 L66709 FAN SPACER 1” . . . . . . . . . . . . . . . 1
11 L530004 5/16” NUT RETAINING CLIP. . . . . . 4 23 L66265 FAN, 18” . . . . . . . . . . . . . . . . . . . . 1
12 L66119 COOLER/HEAT-EXCHANGER . . . . 1 24 L47212 VINYL CLAMP 3/8” HOSE . . . . . . . 2
13 L45934 RADIATOR (w/cap) . . . . . . . . . . . . . 1 25 L68539 UPPER RADIATOR HOSE . . . . . . . 1
14 L50151 1/2” FLAT WASHER . . . . . . . . . . . . 2

HOSE LOCATOR
07 TRANSMISSION (top right side - near filter) TRANSMISSION COOLER “RIGHT SIDE”
09 TRANSMISSION (left side - just under hyd. pump) TRANSMISSION COOLER “LEFT SIDE”

PRINTED IN U.S.A. 51 913228/CP0108

Engine RS5-34 Telescopic Handler

Engine Air Intake Group

Pre-cleaner
(Optional)
9

19
8
18
7

1 6

11
10 12
16

13
2

14

15
14

17
14

913228/CP0108 52 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Engine

Engine Air Intake Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 136383 AIR CLEANER ASSEMBLY. . . . . . . 1 10 136443 CLAMP, AIR CLEANER MOUNT. . . 1
(Includes items 1-6, 11 L50056 5/16”-18 WHIZ LOCK NUT . . . . . . . 2
does not include item10) 12 L50235 5/16”-18X1-1/25” BOLT . . . . . . . . . . 2
02 137659 EJECTOR/DUST . . . . . . . . . . . . . . . 1 13 183629 GAUGE, AIR RESTRICTION . . . . . 1
03 NSS END CAP. . . . . . . . . . . . . . . . . . . . . 1 14 L51099 CLAMP, #52 SAE . . . . . . . . . . . . . . 4
04 137498 PRIMARY AIR FILTER . . . . . . . . . . 1 15 136686 ELBOW, RUBBER 90 DEG. . . . . . . 1
05 137501 SECONDARY AIR FILTER . . . . . . . 1 16 L67657 ELBOW, METAL 3” OD 90DEG. . . . 1
06 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 1 17 L120041 ELBOW, RUBBER 3” ID 90 DEG . . 2
07 103088 REDUCER, 3.84’ TO 3.25” . . . . . . . 1 18 101926 PRE-CLEANER (optional) . . . . . . . . 1
08 L51781 CLAMP, #72 SAE . . . . . . . . . . . . . . 1 19 102974 REDUCER, RUBBER 4”-3.25” . . . . 1
09 L64863 CAP, AIR INLET (standard) . . . . . . . 1

PRINTED IN U.S.A. 53 913228/CP0108

Engine RS5-34 Telescopic Handler

Engine Exhaust Group

3
2

07

08

09

10

16

2
Muffler Bracket

15
14

2
12
13
5 11

FRONT

913228/CP0108 54 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Engine

Engine Exhaust Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 102433 TAILPIPE . . . . . . . . . . . . . . . . . . . . . 1 09 L60492 3” MUFFLER CLAMP . . . . . . . . . . . 1

02 L520005 3/8”-16 NYLON INSERT NUT . . . AR 10 L64821 MUFFLER . . . . . . . . . . . . . . . . . . . . 1
03 L120047 MUFFLER CLAMP (2-1/2” CLAMP) 1 11 L50442 3/8”-16X1-1/4” SELF TAP BOLT . . . 4
04 L64764 TAILPIPE HANGER. . . . . . . . . . . . . 1 12 L67756 MUFFLER GUARD . . . . . . . . . . . . . 1
05 L50145 3/8” FLAT WASHER . . . . . . . . . . . AR 13 L50836 3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 1
06 L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . AR 14 L61021 MUFFLER STRAP. . . . . . . . . . . . . . 1
07 L99434 TURBO CLAMP. . . . . . . . . . . . . . . . 1 15 L64572 MUFFLER BRACKET . . . . . . . . . . . 1
08 L68544 EXHAUST PIPE . . . . . . . . . . . . . . . 1 16 L50705 M12 1.75X30mm BOLT . . . . . . . . . . 2

PRINTED IN U.S.A. 55 913228/CP0108

Transmission RS5-34 Telescopic Handler

External Components Group

FRONT

7
5 6

RIGHT 4 8
3
2

10
1 9
16
18
10

25 11
12
21 13
10 11
20 13

19 24 14
10
15
11 16
23 22 17
11
LEFT

21 18

20
19

913228/CP0108 56 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

External Components Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
01 104425 SWITCH, REVERSE PRESSURE . 1 13b 650965 3/8”-24X1-1/4” GR 8 BOLT . . . . . . . 8
(activates back-up alarm) L50147 3/8” LOCK WASHER . . . . . . . . . . . 8
L444070 ADAP, -3ORM (not shown). . . . . . . 1 14 L446020 ADAP, -12JICM -12JICFS 90 DEG . 1
02 L63406 HOSE, -12 DS12/A12 114” . . . . . . . 1 15 L63399 HOSE, -12 DS12/A12 82” . . . . . . . . 1
03 L444007 ADAP, -10ORM -12JICM STR . . . . 1 16 L50319 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 2
04 L99184 FILTER, TRANSMISSION OIL . . . . 1 17 L68531 TRANS MOUNT (left) . . . . . . . . . . . 1
05 L66965 SENDER, TEMP 250 DEGREE . . . 1 18 L50704 M12X1.75X40mm BOLT . . . . . . . . . 4
06d L50727 M10X1.5X35mm . . . . . . . . . . . . . . . 2 19 L520007 5/8”-11 NYLON INSERT NUT . . . . . 2
07e 102450 BRACKET, HARNESS MOUNT . . . 1 20 L64197 WASHER, ISOLATOR MOUNT. . . . 2
08 L50952 M10X1.5X25mm . . . . . . . . . . . . . . 10 21 L64124 MOUNT, VIBRATION ISOLATOR . . 2
09c L50833 3/8”-24X2” GRADE 8 BOLT . . . . . . 8 22 102654 TRANSMISSION, 1106 T12000 . . . 1
10 L99182 UNIVERSAL JOINT . . . . . . . . . . . . . 4 23 L68562 DRIVESHAFT, FRONT . . . . . . . . . . 1
(includes bolts) 24 L444001 ADAP, -12ORM -12JICM STR. . . . . 1
11a L50468 3/8”-24X1-3/4” GR8 BOLT. . . . . . . 16 25 L68533 TRANS. MOUNT (right). . . . . . . . . . 1
12 L68563 DRIVESHAFT, REAR . . . . . . . . . . . 1
a Used to fasten universal joint to transmission
and to axle yokes.
b Used to fasten universal joint to driveshaft.
c Used to fasten flex plate to flywheel.
d Used to fasten wire harness bracket to transmission
e Used with 115 hp TIER II engine with electronic
throttle pedal. For 99 hp TIER II engine with
manual throttle pedal subsititue Throttle cable
bracket P/N L66606.

HOSE LOCATOR
02 TRANSMISSION (top right side - near filter) TRANSMISSION COOLER “RIGHT SIDE”
15 TRANSMISSION (left side - just under hyd. pump) TRANSMISSION COOLER “LEFT SIDE”

PRINTED IN U.S.A. 57 913228/CP0108

Transmission RS5-34 Telescopic Handler

Converter Housing Group

14

6
1
7
4
2
3

11
9

13
12 11

13

8 15 10
11

12 2

913228/CP0108 58 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Converter Housing Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L99286 HOUSING/CONVERTER . . . . . . . . 1 07 L99262 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1

02 NSS PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 08 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 6
(includes item 3) 09 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . . 3
03 L99284 O-Ring/Plug . . . . . . . . . . . . . . . . . . . 4 10 L99261 SCREW . . . . . . . . . . . . . . . . . . . . . . 1
(part of item 2) 11 L99029 WASHER/LOCK . . . . . . . . . . . . . . 10
04 L99246 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 12 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . 13
05 NSS PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 13 L99029 WASHER/LOCK . . . . . . . . . . . . . . 13
(includes item 6) 14 L98938 GASKET/HSG. TO PLATE. . . . . . . . 1
06 L99284 O-Ring/Plug . . . . . . . . . . . . . . . . . . . 1 15 L99249 PLUG/TEMP PICKUP . . . . . . . . . . . 1
(part of item 5)

PRINTED IN U.S.A. 59 913228/CP0108

Transmission RS5-34 Telescopic Handler

Case and Plate Group

31 7 28
29 24
30 10
25 27
13

36

12

21 31
19 17
29 18
30
2
11 16
23

14
15 21
18
20

19

17
6

33 3
4

26
32

22
35
1
34 8
9
5

913228/CP0108 60 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Case and Plate Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 NSS CASE-TRANSMISSION . . . . . . . . . 1 18 L99284 O-RING/PLUG . . . . . . . . . . . . . . . . . 3

02 L94824 BREATHER/AIR . . . . . . . . . . . . . . . 1 19 L99018 SCREW . . . . . . . . . . . . . . . . . . . . . . 7
03 L99251 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2 20 L99045 SCREW . . . . . . . . . . . . . . . . . . . . . . 2
(includes item 4) 21 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 9
04 L99013 O-RING/PLUG . . . . . . . . . . . . . . . . . 2 22 L98184 ASSY/TUBE & SCREEN . . . . . . . . . 1
(part of item item 3) 23 L99274 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
05 L99253 PLUG/MAGNETIC DRAIN. . . . . . . . 1 24 L99246 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
06 L98927 PIN/DOWEL PLATE TO CASE . . . . 2 25 L99262 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
07 L98926 GASKET/PLATE TO CASE . . . . . . . 1 26 L99270 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
08 L98185 RING/TUBE SEAL. . . . . . . . . . . . . . 1 27 L98734 TUBE/TRANS DIPSTICK . . . . . . . . 1
09 L98176 CLIP/OIL TUBE RETAINER . . . . . . 1 28 L98735 TRANS DIPSTICK TUBE . . . . . . . . 1
10 102949 PLATE, SPACER . . . . . . . . . . . . . . . 1 29 L99287 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2
11 L98935 SEAT/SAFETY VALVE . . . . . . . . . . 1 30 L99312 O-RING . . . . . . . . . . . . . . . . . . . . . . 2
12 L98932 SNAP RING . . . . . . . . . . . . . . . . . . . 1 31 L99288 SCREW . . . . . . . . . . . . . . . . . . . . . . 2
13 L98226 POPPET/SAFETY VALVE . . . . . . . . 1 32 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 1
14 L98218 SPRING . . . . . . . . . . . . . . . . . . . . . . 1 33 L99294 WASHER/SEAL . . . . . . . . . . . . . . . . 1
15 L98217 WASHER/POPPET . . . . . . . . . . . . . 1 34 L99295 WASHER/SCREW. . . . . . . . . . . . . . 1
16 L99246 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 35 L99296 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
17 NSS PLUG . . . . . . . . . . . . . . . . . . . . . . . . 3

PRINTED IN U.S.A. 61 913228/CP0108

Transmission RS5-34 Telescopic Handler

Torque Converter Group

8
13

10

11

13
6
9

4
14
12
2

16 5

15

913228/CP0108 62 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Torque Converter Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98203 ASSY/STATOR SUPPORT . . . . . . . 1 09 L98189 PLUG/BORE . . . . . . . . . . . . . . . . . . 1

02 L98204 BUSHING . . . . . . . . . . . . . . . . . . . . 1 10 L97525 O-RING/BORE PLUG . . . . . . . . . . . 1
03 L98197 BEARING/FRONT . . . . . . . . . . . . . . 1 11 L97526 RING/RET. BORE PLUG. . . . . . . . . 1
04 L98201 RING/PISTON . . . . . . . . . . . . . . . . . 1 12 L98199 IMPELLER/HUB GEAR . . . . . . . . . . 1
05 L98202 EXPANDER/RING . . . . . . . . . . . . . . 1 13 L98191 SNAP RING/IMPELLER HUB . . . . . 2
06 L98200 RING/SNAP . . . . . . . . . . . . . . . . . . . 2 14 L98205 WASHER/HUB GEAR . . . . . . . . . . . 1
07 L98194 SEAL/OIL CONV. HSG. . . . . . . . . . . 1 15 L98198 BEARING/TORQUE CONVERTER. 1
08 L99313 ASSY/TORQUE CONVERTER . . . . 1 16 L98196 RING/OIL DISTRIBUTOR . . . . . . . . 1

PRINTED IN U.S.A. 63 913228/CP0108

Transmission RS5-34 Telescopic Handler

Gear Group

13

12
11

9
5

10
4 6

1
3

15

14
8

16

913228/CP0108 64 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Gear Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 NSS ASSY/REV. GEAR & BEARING . . . 1 08 L500480 BEARING-3RD CLUTCH GEAR . . . 2

(includes ittems 2 and 3) (part of item 7)
02 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2 09 L98968 1st CLUTCH GEAR/BRG. ASSY . . . 1
(part of item 1) (includes item 9)
03 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1 10 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2
(part of item 1) (part of item 9)
04 NSS ASSY/FOR. GEAR & BEARING . . . 1 11 L98276 2nd CLUTCH GEAR/BRG. ASSY . . 1
(includes items 5 and 6) (includes item 12)
05 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2 12 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2
(part of item 4) (part of item 11)
06 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1 13 L98277 GEAR/THIRD DRIVEN - 18T . . . . . 1
(part of item 4) 14 L98284 GEAR/OUTPUT SHAFT - 40T . . . . 1
07 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 1 15 L98955 GEAR/REVERSE IDLER - 28T . . . . 1
(includes item 8) 16 L500409 GEAR/FIRST DRIVEN - 27T . . . . . . 1

PRINTED IN U.S.A. 65 913228/CP0108

Transmission RS5-34 Telescopic Handler

Pump Drive Group

6
1

6
2

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98945 IDLER/SHAFT & PIN. . . . . . . . . . . . 1 04 L98943 BEARING/IDLER GEAR . . . . . . . . . 1

(includes item 2) 05 L98211 GEAR/DRIVE. . . . . . . . . . . . . . . . . . 1
02 L98947 ROLL PIN . . . . . . . . . . . . . . . . . . . . 1 06 L98942 WASHER/THRUST . . . . . . . . . . . . . 2
(part of item1) 07 L98212 RING/SNAP . . . . . . . . . . . . . . . . . . . 1
03 L98944 GEAR/IDLER,PUMP DRIVE . . . . . . 1

913228/CP0108 66 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Charge Pump Group

14 13
15
1
16

12

17
11
6
7 10

8 2
4
9 5

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98220 PUMP/T12000 CHARGE. . . . . . . . . 1 11 L98948 O-RING . . . . . . . . . . . . . . . . . . . . . . 1

02 L99184 ASSY/ HYDRAULIC SPIN FILTER . 1 12 L98219 GASKET/CHARGE PUMP . . . . . . . 1
03 L98953 SLEEVE. . . . . . . . . . . . . . . . . . . . . . 1 13 L99025 SCREW . . . . . . . . . . . . . . . . . . . . . . 4
04 L98950 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 14 L99023 SCREW . . . . . . . . . . . . . . . . . . . . . . 1
05 L98951 SPRING . . . . . . . . . . . . . . . . . . . . . . 1 15 L99020 WASHER/LOCK . . . . . . . . . . . . . . . 5
06 L98224 PIN/CLARK TRANS. . . . . . . . . . . . . 1 16 L99027 SCREW . . . . . . . . . . . . . . . . . . . . . . 1
07 L98949 ASSY/BALL CHECK VALVE . . . . . . 1 17 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 1
(includes items 8 thru 11)
08 L98215 BALL . . . . . . . . . . . . . . . . . . . . . . . . 1 -- ITEMS NOT SHOWN --
09 L98216 SPRING . . . . . . . . . . . . . . . . . . . . . . 1 00 L98954 FILTER MOUNT ASSY. . . . . . . . . . . 1
10 L98214 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1 (includes items 3-6)

PRINTED IN U.S.A. 67 913228/CP0108

Transmission RS5-34 Telescopic Handler

Reverse Idler Group

7
5
9

913228/CP0108 68 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Reverse Idler Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98229 SHAFT IDLER & PILOT . . . . . . . . . 1 05 L98232 END PLATE . . . . . . . . . . . . . . . . . . . 1

02 L98228 RING/SNAP . . . . . . . . . . . . . . . . . . . 1 06 L99031 CAPSCREW . . . . . . . . . . . . . . . . . . 1
03 L98231 BEARING/REV IDLR GEAR . . . . . . 1 07 L99032 WASHER . . . . . . . . . . . . . . . . . . . . . 1
04 L98230 WASHER/THRUST . . . . . . . . . . . . . 1 08 L98233 END PLATE . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 69 913228/CP0108

Transmission RS5-34 Telescopic Handler

Forward and Reverse Group

21 11

19
20
19 12
14 11
17 13
16
15
17
10
5

8
9 18
17 7
16 16

19
1 6 19
22
7 17
17
17
6 17
20
5 17

9
3
8
16

10

15
13 14
12

913228/CP0108 70 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Forward and Reverse Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98248 ASY/TURB SHFT DRUM & PLUG . 1 12 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 2

02 L98251 SLEEVE/OIL DISTRIBUTOR. . . . . . 1 13 L98241 RETAINER/SNAP RING . . . . . . . . . 2
03 L98252 SCREW . . . . . . . . . . . . . . . . . . . . . . 1 14 L98240 CLUTCH/OUTER FWD . . . . . . . . . 12
04 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 3 15 L98239 CLUTCH/INNER FWD. . . . . . . . . . 12
05 L99278 ASY/PISTON . . . . . . . . . . . . . . . . . . 2 16 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 4
(includes items 6 and 7) 17 L98235 WASHER/THRUST . . . . . . . . . . . . . 8
06 L98246 SEAL/OUTER PISTON . . . . . . . . . . 2 18 L98249 BEARING/REAR . . . . . . . . . . . . . . . 1
(part of item 5) 19 L98253 BEARING/CLUTCH GEAR . . . . . . . 4
07 L98247 SEAL/INNER PISTON . . . . . . . . . . . 2 20 L98254 SPACER/CLUTCH GEAR . . . . . . . . 2
(part of item 5) 21 L98962 ASSY/REV. AND BRG. . . . . . . . . . . 1
08 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 2 (includes items 19 and 20)
09 L98237 RING/SNAP . . . . . . . . . . . . . . . . . . . 2 22 L98255 ASSY/FOR. GEAR AND BRG. . . . . 1
10 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 2 (includes items 19 and 20)
11 L98961 ASY/DISC SPRING Pkg 5. . . . . . . . 2

PRINTED IN U.S.A. 71 913228/CP0108

Transmission RS5-34 Telescopic Handler

Third Shaft Group

10

21
24

4
3
12
7 11
5
6 18
17

16
2
21
15
20
8 19
9 20
22
22

23

20
19
20
21
14
13

913228/CP0108 72 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Third Shaft Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500410 ASY-3RD SHAFT, DRUM & PLUG . 1 13 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 1

02 L500411 BEARING-ROLLER . . . . . . . . . . . . . 1 14 L98237 RING/SNAP . . . . . . . . . . . . . . . . . . . 1
03 L500273 ASSY/BEARING & SEAL . . . . . . . . 1 15 L98244 RING/SNAP . . . . . . . . . . . . . . . . . . . 1
04 L500412 WASHER-BEARING SUPPORT . . . 1 16 L98961 ASY/DISC SPRG PKG 5. . . . . . . . . 1
05 L98258 SLEEVE/OIL DISTRIBUTOR. . . . . . 1 17 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 1
06 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 1 18 L98241 RETAINER/SNAP RING . . . . . . . . . 1
07 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 2 19 L500413 BEARING-THRUST NEEDLE . . . . . 2
08 L99279 ASSY/CLTCH PISTON & BALL. . . . 1 20 L500414 WASHER/CLTCH GEAR THRUST . 4
09 L98246 SEAL/OUTER PISTON . . . . . . . . . . 1 21 L99696 RING/SNAP . . . . . . . . . . . . . . . . . . . 3
10 L98247 SEAL/INNER PISTON . . . . . . . . . . . 1 22 L500408 BEARING-3RD CLUTCH GEAR . . . 2
11 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 5 23 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 1
12 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 5 24 L500408 GEAR-FIRST DRIVEN . . . . . . . . . . 1

PRINTED IN U.S.A. 73 913228/CP0108

Transmission RS5-34 Telescopic Handler

First and Second Shaft Group

25

12

24

15 13
3 14
20
13
4
18
16
11
19
21 10
8 5
27
9
15 7
1 17
16

16 6 24
7

6 26
5 16 15
10
9
8

15
23
22
14

913228/CP0108 74 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

First and Second Shaft Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98274 ASY-1ST 2ND SHAFT . . . . . . . . . . . 1 16 L98235 WASHER/THRUST . . . . . . . . . . . . . 8

02 L98275 BEARING/REAR . . . . . . . . . . . . . . . 1 17 L98260 RING/SNAP . . . . . . . . . . . . . . . . . . . 2
03 L500273 ASSY/BEARING & SEAL . . . . . . . . 1 18 L98272 SLEEVE/OIL DISTRIBUTOR. . . . . . 1
04 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 2 19 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 1
05 L99038 PISTON/CLUTCH & SEALS . . . . . . 2 20 L98240 CLUTCH/OUTER FWD . . . . . . . . . 10
06 L98246 SEAL/OUTER PISTON . . . . . . . . . . 2 21 L98239 CLUTCH/INNER FWD. . . . . . . . . . 10
07 L98247 SEAL/INNER PISTON . . . . . . . . . . . 2 22 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 5
08 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 2 23 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 5
09 L98237 RING/SNAP . . . . . . . . . . . . . . . . . . . 2 24 L98253 BEARING/CLUTCH GEAR . . . . . . . 4
10 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 2 25 L98968 1ST CLUTCH GEAR/BRG ASSY . . 1
11 L98961 ASSY/DISC SPRG PKG 5 . . . . . . . 1 (includes item 24)
12 L98967 SPRING/DISC ASSY PKG (7). . . . . 1 26 L98276 2ND CLUTCH GEAR/BRG ASSY . . 1
13 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 2 (includes item 24)
14 L98241 RETAINER/SNAP RING . . . . . . . . . 2 27 L98277 GEAR/3RD DRIVEN . . . . . . . . . . . . 1
15 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A. 75 913228/CP0108

Transmission RS5-34 Telescopic Handler

Output Shaft Group

7
6
2
3
5
4
6
8 1

9
6

4
5
3
2

913228/CP0108 76 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Output Shaft Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500274 SHAFT/OUTPUT . . . . . . . . . . . . . . . 1 06 L98264 RING/SNAP . . . . . . . . . . . . . . . . . . . 4

02 L98282 BEARING/SHAFT . . . . . . . . . . . . . . 2 07 L98266 RING/SNAP . . . . . . . . . . . . . . . . . . . 2
03 L98281 SLEEVE/OIL SEAL . . . . . . . . . . . . . 2 08 L98279 FLANGE/OUTPUT & PLUG ASSY . 1
04 L98268 O-RING/SLEEVE. . . . . . . . . . . . . . . 2 09 L98278 PLUG/FLANGE . . . . . . . . . . . . . . . . 1
05 L96053 SEAL/OUTPUT SHAFT OIL . . . . . . 2

PRINTED IN U.S.A. 77 913228/CP0108

Transmission RS5-34 Telescopic Handler

Control Group

5
4 3
2

10

12
11

9
8
7
6

913228/CP0108 78 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Control Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 102950 SOLENOID, W / DEUTSCH CON. . 4 07 102956 O-RING, 18.0 X 2.20MM . . . . . . . . . 1

(includes items 2 thru 5) (included with item 6)
02 102951 O-RING, 21.5 X 1.5MM . . . . . . . . . . 4 08 102952 O-RING, 15.1 X 1.60MM . . . . . . . . . 1
(included with item 1) (included with item 6)
03 102952 O-RING, 15.1 X 1.60MM . . . . . . . . . 4 09 102954 O-RING, 12.1 X 1.60MM . . . . . . . . . 1
(included with item 1) (included with item 6)
04 102953 O-RING, 14.1 X 1.60MM . . . . . . . . . 4 10 102957 CLAMP, SOLENOID . . . . . . . . . . . . 6
(included with item 1) 11 102958 CAPSCREW . . . . . . . . . . . . . . . . . 12
05 102954 O-RING, 12.1 X 1.60MM . . . . . . . . . 4 12 102959 WASHER, PLAIN. . . . . . . . . . . . . . 12
(included with item 1)
06 102955 PLUG, SOLENOID BORE . . . . . . . . 1
(includes items 7, 8 and 9)

PRINTED IN U.S.A. 79 913228/CP0108

Transmission RS5-34 Telescopic Handler

Drive Plate Group

2
6

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 NSS ASSY/DRIVE PLATE . . . . . . . . . . . . 1 04 L99785 SCREW/DRIVE PLATE MNTG . . . . 6

(included in item 6) 05 L99030 LOCKWASHER/DRIVEPLATE . . . . 6
02 NSS DRIVE PLATE . . . . . . . . . . . . . . . . . 2 06 L98317 KIT/DRIVE PLATE ASSY . . . . . . . . 1
(included in item 6) (includes items 1 thru 5)
03 L98316 RING/DRIVE PLATE BACKING . . . 1

913228/CP0108 80 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Transmission

Modulation Valve Group

2
8
3 9

4 10

11
5
15 12

6 13

14

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98291 HOUSING MODULATOR VALVE . . 1 09 L98303 SPOOL ACCUMULATOR . . . . . . . . 1

02 L98292 O-RING . . . . . . . . . . . . . . . . . . . . . . 1 10 L98958 SPOOL . . . . . . . . . . . . . . . . . . . . . . 1
03 L98294 SPRING INNER. . . . . . . . . . . . . . . . 1 11 L98300 SPRING . . . . . . . . . . . . . . . . . . . . . . 1
04 L98295 SPRING MIDDLE . . . . . . . . . . . . . . 1 12 L98302 RETAINER. . . . . . . . . . . . . . . . . . . . 1
05 L98304 SPRING OUTER . . . . . . . . . . . . . . . 1 13 L98301 SPACER . . . . . . . . . . . . . . . . . . . . . 1
06 L98298 SLEEVE-MODULATION VALVE . . . 1 14 L98956 PIN-UPPER . . . . . . . . . . . . . . . . . . . 1
07 L98307 O-RING . . . . . . . . . . . . . . . . . . . . . . 1 15 L98957 PIN-LOWER . . . . . . . . . . . . . . . . . . 1
08 L98293 PIN STOP . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 81 913228/CP0108

Axles RS5-34 Telescopic Handler

External Components

FRONT

LEFT 1 4

5 AXLE MODEL AND

SERIAL NUMBER PLATE

10
8
9

11

22 RIGHT
Driveshaft info found in
transmission section

14
15
20
13 12

Front axle (shown)

16

19

18

17

913228/CP0108 82 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Axles

External Components
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 NSS TIRE AND WHEEL ASY . . . . . . . . AR 11 L68878 FRAME LEVEL MNT (front axle). . . 1
L63222 VALVE STEM. . . . . . . . . . . . . . . . . . 1 12 L69734 M22-1.5 WHEEL NUT . . . . . . . . . AR
L45049 TIRE, 15.00X19.5 12 PLY . . . . . . . . 1 13 L50084 3/4”-10 GR8 LOCK NUT . . . . . . . . . 8
L68875 WHEEL ONLY (for tire L45049). . . . 1 14 L68876 PLATE, FRAME LEVEL. . . . . . . . . . 1
15 651543 M20-2.50X130 C10.9 BOLT . . . . . . 4
L67499 TIRE, 405/70R 20XM27 . . . . . . . . . 1 16 L500543 THRUST BUSHING. . . . . . . . . . . . . 2
L68884 WHEEL ONLY (for tire L67499). . . . 1 17 L500544 SUPPORT . . . . . . . . . . . . . . . . . . . . 2
18 L98355 GREASE FITTING. . . . . . . . . . . . . . 2
L67502 TIRE, 9.00R 20XMINE D2. . . . . . . . 1 19 L500496 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2
L67504 WHEEL ONLY (for tire L67502). . . . 1 20 L500542 REDUCTION BUSING . . . . . . . . . . 4
21 NA .............................0
02a L50253 3/8”-16 BUTTON HD BOLT . . . . . . . 6 22b AXLE ASSEMBLY, 212
03a L99951 FENDER . . . . . . . . . . . . . . . . . . . . . 1 102668 FRONT (with internal park brake) . . 1
04a 103322 FENDER MOUNT (LF/RR) . . . . . . . 1 L68849 REAR. . . . . . . . . . . . . . . . . . . . . . . . 1
05a L50061 3/8”-16 FLANGE LOCK NUT . . . . . 4
06a L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4
a Available only on the left side of the front axle.
07a 102587 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 4
b Does not include any other items shown in
08a 103314 FENDER MOUNT . . . . . . . . . . . . . . 1
illustration.
09 L50201 M20-2.5 CLASS 10 LOCK NUT . . . 4
10 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 8

PRINTED IN U.S.A. 83 913228/CP0108

Axles RS5-34 Telescopic Handler

Steering Cylinder and Tie Rods (Front Axle)

RIGHT

FRONT
LEFT

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500546 ARTICULATED TIE ROD . . . . . . . . 1 03a L500541 ARTICULATED TIE ROD . . . . . . . . 1

(Right [Front Axle], Left [Rear Axle]) (Left [Front Axle], Right [Rear Axle])
02 L500540 STEER CYLINDER . . . . . . . . . . . . . 1
L500539 STEER CYLINDER BOLT . . . . . . . 4 a L99969 Nut and pin kit for tie rod
L500943 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

913228/CP0108 84 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Axles

Steering Cylinder and Tie Rods (Rear Axle)

LEFT

FRONT
1

RIGHT

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500546 ARTICULATED TIE ROD . . . . . . . . 1 03a L500541 ARTICULATED TIE ROD . . . . . . . . 1

(Right [Front Axle], Left [Rear Axle]) (Left [Front Axle], Right [Rear Axle])
02 L500540 STEER CYLINDER . . . . . . . . . . . . . 1
L500539 STEER CYLINDER BOLT . . . . . . . 4 a L99969 Nut and pin kit for tie rod
L500943 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 85 913228/CP0108

Axles RS5-34 Telescopic Handler

Differential Housing Group (Front Axle)

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 3 06 NA .............................0

02 L500451 INTERMEDIATE COVER . . . . . . . . 1 07 102575 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
03 102573 HOUSING . . . . . . . . . . . . . . . . . . . . 1 08 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 1
04 102574 COVER . . . . . . . . . . . . . . . . . . . . . . 1 09 L98373 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 1
05 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1

913228/CP0108 86 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Axles

Differential Housing Group (Rear Axle)

2
4 6
5
3

1
8

6
1

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 3 05 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1

02 L500451 INTERMEDIATE COVER . . . . . . . . 1 06 L500455 SEAL WASHER . . . . . . . . . . . . . . . . 2
03 L500452 HOUSING . . . . . . . . . . . . . . . . . . . . 1 07 L98318 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
04 L500453 COVER . . . . . . . . . . . . . . . . . . . . . . 1 08 L500456 MAGNETIC PLUG. . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 87 913228/CP0108

Axles RS5-34 Telescopic Handler

Brake Group (Front Axle)

2 23
22
4
25

5 26

19
10
3 18
6
14

7 8
9
11
21
20
12 17
13

15
16
24

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 102617 SPACER . . . . . . . . . . . . . . . . . . . . . 2 15 L500536 INTERMEDIATE BRAKE DISC . . . . 8

02 102618 SPRING . . . . . . . . . . . . . . . . . . . . . . 4 16 103390 SPACER . . . . . . . . . . . . . . . . . . . . . 2
03 102619 PISTON . . . . . . . . . . . . . . . . . . . . . . 2 17 103391 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 4
04 102620 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 18 103392 ADJUSTING BOLT . . . . . . . . . . . . . 6
05 102621 O-RING . . . . . . . . . . . . . . . . . . . . . . 4 19 102632 SPRING . . . . . . . . . . . . . . . . . . . . . . 6
06 102622 BACKUP RING . . . . . . . . . . . . . . . . 4 20 102633 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 4
07 102623 COVER . . . . . . . . . . . . . . . . . . . . . . 2 21 102634 LOCK WASHER . . . . . . . . . . . . . . . 4
08 L98368 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 22 L98430 BLEEDING BOLT . . . . . . . . . . . . . . 4
09 102624 BACKUP RING . . . . . . . . . . . . . . . . 2 23 L500496 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4
10 102625 PISTON . . . . . . . . . . . . . . . . . . . . . . 2 24 102635 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2
11 102626 INTERMEDIATE BRAKE DISC . . . . 2 102636 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2
12 102627 SPRING . . . . . . . . . . . . . . . . . . . . . . 6 102637 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2
13 102628 ADJUSTING BOLT . . . . . . . . . . . . . 6 25 102638 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 4
14 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 8 26 102639 SEAL WASHER . . . . . . . . . . . . . . . . 4

913228/CP0108 88 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Axles

Brake Group (Rear Axle)

10

2
3

1 4
5

12

14
11
6
7
9

13

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 6 09 L500535 O-RING . . . . . . . . . . . . . . . . . . . . . . 2

02 L500528 ADJUSTING BOLT . . . . . . . . . . . . . 6 10 L500536 INTERMEDIATE BRAKE DISC . . . . 8
03 L500529 SPRING . . . . . . . . . . . . . . . . . . . . . . 6 11 L98430 BLEEDING BOLT . . . . . . . . . . . . . . 2
04 NSS PISTON . . . . . . . . . . . . . . . . . . . . . . 2 12 L500496 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2
05 L500531 SPRING . . . . . . . . . . . . . . . . . . . . . . 6 13 L500537 DOWEL . . . . . . . . . . . . . . . . . . . . . . 2
06 L500532 BACK-UP RING. . . . . . . . . . . . . . . . 2 14 L500538 PISTON . . . . . . . . . . . . . . . . . . . . . . 2
07 L500533 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 (includes items 4-9)
08 L500534 BACK-UP RING. . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A. 89 913228/CP0108

Front Axle RS5-34 Telescopic Handler

Outer End Group

4
5
5

6
3
8 1
2

9
7

10

20
11
21 23 12 13
16
22 24 14
15
25
27
26
28 29

30, 31
37
35
36 17
38 18
39 19
33
36
27
41
29
32 42
44
34
43 45
24
23 46
40 47

51
50
48
49 8

913228/CP0108 90 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Front Axle

Outer End Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2 27 NSS (not used on this axle) . . . . . . . . . . . 0

02 L500484 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2 28 103396 BUSHING . . . . . . . . . . . . . . . . . . . . 2
03 103394 BOLT . . . . . . . . . . . . . . . . . . . . . . . 24 29 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 4
04 102614 STUD . . . . . . . . . . . . . . . . . . . . . . . . 8 30 L500501 STEERING CASE (LF AND RR) . . . 1
05 L500487 WASHER . . . . . . . . . . . . . . . . . . . . 32 (includes item 19)
06 102615 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 8 31 L500504 STEERING CASE (RF and LR) . . . 1
07 103393 AXLE CASE. . . . . . . . . . . . . . . . . . . 2 (includes item 19)
08 102575 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 32 L500498 PIVOT PIN (set). . . . . . . . . . . . . . . . 2
09 102576 MAGNET PLUG. . . . . . . . . . . . . . . . 2 33 L500500 BEARING. . . . . . . . . . . . . . . . . . . . . 2
10 L500488 REDUCTION BUSHING (set) . . . . . 2 34 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 12
11 L98372 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 35 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2
12 L98373 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 36 L500506 BEARING. . . . . . . . . . . . . . . . . . . . . 4
13 L98371 BALL BEARING. . . . . . . . . . . . . . . . 2 37 102601 WHEEL STUD . . . . . . . . . . . . . . . . 20
14 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 38 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 2
15 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 39 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 2
16 103395 JOINT ASSEMBLY . . . . . . . . . . . . . 2 40 L500519 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2
17 NSS (included as part of item 18) . . . . . . 0 41 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 2
18 102595 SEAL/DUST EXCLUDER . . . . . . . . 2 42 L500510 RING GEAR SUPPORT . . . . . . . . . 2
19 L500492 THRUST BUSHING. . . . . . . . . . . . . 2 43 L500522 LOCKING PLATE . . . . . . . . . . . . . . 2
20 102587 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 5 44 L500511 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 8
21 102583 WASHER . . . . . . . . . . . . . . . . . . . . . 8 45 L500512 PLANET GEAR . . . . . . . . . . . . . . . . 8
22 102893 STUD . . . . . . . . . . . . . . . . . . . . . . . . 8 46 L500513 BEARING. . . . . . . . . . . . . . . . . . . . . 8
23 L500496 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 47 103399 PLANET GEAR CARRIER . . . . . . . 2
24 L98355 GREASE FITTING. . . . . . . . . . . . . . 4 48 L500515 COUNTERSUNK BOLT. . . . . . . . . . 4
25 103398 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2 49 103401 PLANET GEAR CARRIER . . . . . . . 2
26 L500523 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2 (includes items 41-48)
L500524 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2 50 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 16
L500525 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2 51 L500517 STUD . . . . . . . . . . . . . . . . . . . . . . . 16

PRINTED IN U.S.A. 91 913228/CP0108

Front Axle RS5-34 Telescopic Handler

Differential Group

913228/CP0108 92 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Front Axle

Differential Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 1 13 L500472 FRICTION WASHER . . . . . . . . . . . . 4

02 L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 14 L500473 DIFFERENTIAL PINION . . . . . . . . . 4
L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 15 L500474 DIFFERENTIAL CARRIER . . . . . . . 1
L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 16 L500475 TAPER ROLLER BEARING . . . . . . 2
L500462 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 17 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 1 L98406 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
04 L98380 TAPER ROLLER BEARING . . . . . . 2 L500476 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
05 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 2 L500477 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
06 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 4 18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 1
07 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 2 19 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 1
08 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 12 20 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 1
09 L500468 FRICTION WASHER . . . . . . . . . . . . 2 21 NA .............................0
10 L500469 DIFFERENTIAL SIDE GEAR . . . . . 2 22 102863 FLANGE . . . . . . . . . . . . . . . . . . . . . 1
11 103402 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 4 23 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
12 L500471 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4 24 L500481 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A. 93 913228/CP0108

Rear Axle RS5-34 Telescopic Handler

Outer End Group

FRONT

3 4 14 8
15 47 7
1
13 16 6
25 2 9
17
49 10
24 12 19
21,26
27 29
28 30 23
2 22
31
20 11
28
1 45 19
18 32
44 48
13 33
16 34
46 35
15 36
50 37
43

38

41
42 39
40 25

913228/CP0108 94 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Rear Axle

Outer End Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2 25 L98318 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4

02 L500484 STEERING ADJUST BOLT . . . . . . . 2 26 L500504 STEERING CASE - RF/LR . . . . . . . 1
03 L500485 AXLE CASE. . . . . . . . . . . . . . . . . . . 2 (includes item 11)
04 L500486 BOLT . . . . . . . . . . . . . . . . . . . . . . . 32 27 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2
05 L500488 REDUCTION BUSHING . . . . . . . . . 2 28 L500506 BEARING. . . . . . . . . . . . . . . . . . . . . 4
(includes items 6-9, and 47) 29 L500507 WHEEL STUD . . . . . . . . . . . . . . . . 16
06 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 30 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 2
07 L98371 BALL BEARING. . . . . . . . . . . . . . . . 2 31 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 2
07 L98372 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 32 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 2
09 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 33 L500510 RING GEAR SUPPORT . . . . . . . . . 2
10 L500491 JOINT ASSEMBLY . . . . . . . . . . . . . 2 34 L500511 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 8
11 L500492 THRUST BUSHING. . . . . . . . . . . . . 2 35 L500512 PLANET GEAR . . . . . . . . . . . . . . . . 8
(included with items 21 and 26) 36 L500513 BEARING. . . . . . . . . . . . . . . . . . . . . 8
12 L500493 OUTER RACE . . . . . . . . . . . . . . . . . 2 37 L69734 WHEEL NUT . . . . . . . . . . . . . . . . . 16
13 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 20 38 L500455 SEAL WASHER . . . . . . . . . . . . . . . . 6
14 L500495 COVER . . . . . . . . . . . . . . . . . . . . . . 2 39 L500515 COUNTERSUNK BOLT. . . . . . . . . . 4
15 L500496 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 40 L500516 PLANET GEAT CARRIER . . . . . . . . 2
16 L98355 GREASE FITTING. . . . . . . . . . . . . . 2 41 L500517 STUD . . . . . . . . . . . . . . . . . . . . . . . 16
17 L500497 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2 42 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 16
(includes item 16) 43 L500519 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2
18 L500498 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2 44 L500554 ADJUSTING BOLT . . . . . . . . . . . . . 4
(includes items 16, 19 and 20) 45 L500521 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 4
19 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 46 L500522 LOCKING PLATE . . . . . . . . . . . . . . 2
20 L500500 ARTICULATION. . . . . . . . . . . . . . . . 2 47 L98373 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2
21 L500501 STEERING CASE - LF/RR . . . . . . . 1 48 L500555 SPACER . . . . . . . . . . . . . . . . . . . . . 2
(includes item 11) 49 L500523 SHIM - .15mm . . . . . . . . . . . . . . . . . 2
22 L500502 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 L500524 SHIM - .20mm . . . . . . . . . . . . . . . . . 2
23 L500503 DUST EXCLUDER . . . . . . . . . . . . . 2 L500525 SHIM - .50mm . . . . . . . . . . . . . . . . . 2
24 L500456 MAGNETIC PLUG. . . . . . . . . . . . . . 2 50 103401 PLANET GEAR CARRIER . . . . . . . 2
(includes items 32-36, 40-41)

PRINTED IN U.S.A. 95 913228/CP0108

Rear Axle RS5-34 Telescopic Handler

Differential Group

7 8

24 12

13 11 12
10 14 24
6
5
4 11
9 15
11 13
12
16 3 24 4
18
13
13 7
16 14
11 12
20
24 9
21
22
5
1
17
2
23 19

913228/CP0108 96 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Rear Axle

Differential Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 1 13 L500472 FRICTION WASHER . . . . . . . . . . . . 4

02 L500458 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 14 L500473 DIFFERENTIAL PINION . . . . . . . . . 4
L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 15 L500474 DIFFERENTIAL CARRIER . . . . . . . 1
L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 16 L500771 TAPER ROLLER BEARING . . . . . . 2
L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 17 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
L500462 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 L98406 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 1 L500476 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
04 L98380 TAPER ROLLER BEARING . . . . . . 2 L500477 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1
05 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 2 18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 1
06 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 4 19 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 1
07 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 2 20 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 1
08 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 12 21 L98394 COVERPLATE. . . . . . . . . . . . . . . . . 1
09 L500468 FRICTION WASHER . . . . . . . . . . . . 2 22 L500479 FLANGE . . . . . . . . . . . . . . . . . . . . . 1
10 L500469 DIFFERENTIAL SIDE GEAR . . . . . 2 23 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
11 L500470 PIN W/CLIP (includes item 12) . . . . 4 24 L500481 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4
12 L500471 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A. 97 913228/CP0108

Boom RS5-34 Telescopic Handler

Outer Boom Section

34 35
10 1

FRONT
32
27 33
2
30 31 3

4 5
36

6
27
7
29 28 42
43
B

23
8
24
9
27 10
22
25 25
26

12
11

21
13 14

15

15
20
19 REAR
16
16 18
17

913228/CP0108 98 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Boom

Outer Boom Section

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L68350 OUTER SECT. WELDMENT . . . . . . 1 24 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 2
02 L70242 5/16”-18 NUTSERT . . . . . . . . . . . . . 2 25 L50251 3/8”-16X3/4” BOLT . . . . . . . . . . . . . 6
03 L65640 PLATE, BOOM ANGLE IND. . . . . . . 1 26 L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2
04 L50141 5/16” FLAT WASHER . . . . . . . . . . . 2 27 L50147 3/8” LOCK WASHER . . . . . . . . . . . 12
05 L52048 5/16”-18X1” BTNHD BOLT . . . . . . . 2 28 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 4
06 L65638 INCLINOMETER-ANGLE IND. . . . . 1 29 L62733 SHIM .06”X3”X4” . . . . . . . . . . . . . . . 2
07 L50491 #8X5/8” RND HD MACH.SCREW. . 2 30 L50403 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 4
08 L50380 1/2”-20X1-1/4” BOLT . . . . . . . . . . . . 2 31 L64143 SHIM 1/2”X3”X4” . . . . . . . . . . . . . . . 2
09 L50152 1/2” LOCK WASHER . . . . . . . . . . . . 2 32 L50261 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 4
10 L50612 PIN, COTTER 1/16”X3/4” . . . . . . . . 6 33 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 2
11 L63169 PIN, OUTER BOOM CLEVIS . . . . . 1 34a L63166 CLEVIS, CHAIN ADJUSTMENT . . . 2
12 L63173 CLEVIS, OUTER BOOM . . . . . . . . . 1 35 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 4
13 L63131 REAR OUTER COVER . . . . . . . . . . 1 36 L71748 TOP CLAMP PLATE . . . . . . . . . . . . 1
14 L50226 5/16”-18X1” SELF TAP SCREW . . . 4 37b 103333 BRACKET, LIGHT MOUNT . . . . . . . 1
15 L68006 BUSHING 2.5IDX2.75ODX4” . . . . . 2 38b L70040 WORKLIGHT . . . . . . . . . . . . . . . . . . 2
16 L63017 LIFT CYL. PIVOT BUSHING . . . . . . 2 39b L50145 3/8” FLAT WASHER . . . . . . . . . . . . 4
17 L520004 5/16”-18 NYLON INSERT NUT . . . . 4
40b L50061 3/8”-16 WHIZ LOCK NUT . . . . . . . . 4
18 L50878 5/16”-18X3” STUD. . . . . . . . . . . . . . 4
41b L50403 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2
19 L68358 CUSHION TOP PLATE . . . . . . . . . . 2
42 103330 CLAMP, BOOM HOSES . . . . . . . . AR
20 L68348 .88 HOSE CUSHION SINGLE . . . . 4
43 103331 CLAMP, BOOM W/INSERT . . . . . AR
21 L63099 PIN, PIVOT PIN. . . . . . . . . . . . . . . . 1
L50462 CAPSCREW 1/2-13X5 . . . . . . . . . . 1
L520019 NYLON INSERT NUT 1/2-13 . . . . . 1
--- ITEMS NOT SHOWN ---
22 L63694 EXT. CYL. BRACKET . . . . . . . . . . . 1
L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2 00b L70462 WIRE HARNESS, WORKLIGHT . . . 1
L50147 3/8” LOCK WASHER . . . . . . . . . . . . 2
23 L61708 SLIDE PAD 5/8”X4”X6” . . . . . . . . . . 2 a Refer to Inner Boom Section for boom chains.
b When equipped with Optional Boom Work Lights.
(Refer to illustration below.)

38

40
39

40

41 39

Optional
Boom Work Lights 37
(mounts to front of boom;
reference B on facing page)

PRINTED IN U.S.A. 99 913228/CP0108

Boom RS5-34 Telescopic Handler

Intermediate Boom Section

12
8
11
10
9 8 1
13
14 2
3
7 4
15 5
FRONT 6
16
17
18

19
21
20
17

16

19

12
8
11
10 9
22 8
27
23 13 24
2 28
25

26 29

16
21 19
17
19 17
21

16
19

16
REAR
21
1

913228/CP0108 100 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Boom

Intermediate Boom Section

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L68744 INTERMEDIATE SECT WLDMNT. . 1 16 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . 12

02 L63006 TRAY, INTERMEDIATE . . . . . . . . . . 1 17 L62734 SHIM, .105”X3”X4” . . . . . . . . . . . . . 8
03 L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . . 1 18 L62733 SHIM, .06”X3”X4” . . . . . . . . . . . . . . 2
04 L50207 CLAMP, VINLYL .69 DBL . . . . . . . . 1 19 L50251 3/8”-16X3/4” BOLT . . . . . . . . . . . . 28
05 L520004 5/16”X18 NYLON INSERT NUT . . . 1 20 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 8
06 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2 21 L61709 SLIDE PAD, 5/8”X3”X4”. . . . . . . . . 12
07 L52026 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2 22 L50261 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 1
08 L68697 WASHER, CHAIN SHEAVE . . . . . . 6 23 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 1
09 L63158 RING, BEARING-INNER . . . . . . . . . 3 24 L68696 PIN, REAR SHEAVE . . . . . . . . . . . . 1
10 L63157 BEARING, BOOM SHEAVE . . . . . . 3 25 L63239 SPACER, TRAY BRACKET. . . . . . . 1
11 L63153 SHEAVE, CHAIN . . . . . . . . . . . . . . . 3 26 L61699 SLIDE PAD, 2”X3” . . . . . . . . . . . . . . 1
12 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2 27 L61708 SLIDE PAD, 5/8”X4”X6”. . . . . . . . . . 2
13 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2 28 L62731 SHIM, .06”X4”X6” . . . . . . . . . . . . . . 2
14 L68695 PIN, FRONT SHEAVE . . . . . . . . . . . 1 29 L62732 SHIM, .105”X4”X6” . . . . . . . . . . . . . 2
15 L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4
Note: Refer to Inner Boom Section for boom chains.

PRINTED IN U.S.A. 101 913228/CP0108

Boom RS5-34 Telescopic Handler

Inner Boom Section

3 REAR
5
14
13 16 17
6
12 15
7
9 10
8 11

1 2 18
19
7
4

21 20
27

26
10
7
9
11

25 9
24 23

22

22

FRONT

913228/CP0108 102 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Boom

Inner Boom Section

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
01 L68762 INNER BOOM WELDMENT . . . . . . 1 20 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 1
02 L63005 HOSE TRAY, INNER BOOM . . . . . . 1 21 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 2
03 L71748 TOP PLATE, HOSE CLAMP . . . . . . 1 22 L63017 BUSHING . . . . . . . . . . . . . . . . . . . . 2
04 L61699 SLIDE PAD 2”X3” . . . . . . . . . . . . . . 1 23 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 2
05 103330 CLAMP, BOOM HOSES . . . . . . . . . 1 24 L63716 CUSHION, HOSE-TWIN .68 . . . . . . 2
06 103331 CLAMP, BOOM W/INSERT . . . . . . 1 25 L63715 PLATE, TWIN CUSHION TOP . . . . 1
07 L50251 3/8”-16X3/4” BOLT . . . . . . . . . . . . 17 26 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2
08 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 1 27 L52026 3/8”-1-1/4” BOLT . . . . . . . . . . . . . . . 2
09 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 4
10 L62734 SHIM .105”X3”X4” . . . . . . . . . . . . . . 2
11 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 8 a Attaches from the rear of the inner boom to the
12 L66783 SHIM .105”X3”X8” . . . . . . . . . . . . . . 2 chain adjustment clevis’ located on the front of the
13 L66782 SHIM .06”X3”X8” . . . . . . . . . . . . . . . 2 outer boom section. (Refer to Outer Boom Section,
14 L66780 SLIDE PAD 3”x8”. . . . . . . . . . . . . . . 2 item #34, chain adjustment clevis.)
15a L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 2
16 L50612 PIN, COTTER 1/16”X3/4” . . . . . . . . 4 b Attaches from item #19 (chain adjustment clevis) to
17 L63168 PIN, INNER BOOM CLEVIS . . . . . . 1 outer boom clevis. (Refer to Outer Boom Section,
18b L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 1 item #12, outer boom clevis.)
19 L63166 CLEVIS, CHAIN ADJUSTMENT . . . 1

PRINTED IN U.S.A. 103 913228/CP0108

Boom RS5-34 Telescopic Handler

Dynattach® Assembly

FRONT

3
1
4
2 5
14
13

Tilt Cylinder
3
6
7
8
9
12

2
11

10

15 9

913228/CP0108 104 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Boom

Dynattach® Assembly
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L98700 DYANATTACH WELDMENT . . . . . . 1 13 L65097 LOCK SPRING . . . . . . . . . . . . . . . . 1
02 L520005 3/8”-16 NYLON INSERT NUT . . . . . 3 14 L65098 SPRING MOUNT. . . . . . . . . . . . . . . 1
03 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 3 15 L63957 LOCK AND PIN ASSEMBLY . . . . . . 1
04 L63274 PIN, TAPPED 1-1/2” DIA . . . . . . . . . 2 (includes items 10-11)
05 L63017 BUSHING . . . . . . . . . . . . . . . . . . . . 2
06 L63272 PIN, TILT CYL.(ROD END) . . . . . . . 1 -- ITEMS NOT SHOWN --
07 L63018 BUSHING, TILT CYL (ROD END) . . 1 00 L66613 DECAL, DYNATTACH UNLOCKED 1
08 TILT CYLINDER . . . . . . . . . . . . . . . 1 (adheres to item #11)
L63013 Note a
104128 Note b
09 L66456 BUSHING, LOCK PIN . . . . . . . . . . . 2 a Thru S/N12707 - refer to P/N stamped on cyl.
10c NSS PIN, DYNATTACH LOCK . . . . . . . . 1 b S/N 12708 and Up - refer to P/N stamped on cyl.
11c NSS DYNATTACH LOCK WLDMNT . . . . 1 c Not sold seperately, order item #15
12 L50646 3/16”X1-3/4” ROLL PIN . . . . . . . . . . 1

PRINTED IN U.S.A. 105 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Pump and Flow Divider

5 FRONT
2
6
10

11

12
3 9

13

10
14

10

20

15

18 21
19

17 14

16

913228/CP0108 106 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Pump and Flow Divider

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L445014 ADAP, -20ORM -24JICM 90DEG . . 1 14 L444002 ADAP, -6ORM -6JICM STR . . . . . AR
02 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 1 15 102313 FLOW DIVIDER. . . . . . . . . . . . . . . . 1
03 L46865 GASKET, HYD PUMP . . . . . . . . . . . 1 16 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1
04a 103130 HYDRAULIC PUMP . . . . . . . . . . . . 1 17 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 1
05 L50184 1/2” FLAT WASHER . . . . . . . . . . . . 2 18b 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
06 L50283 1/2”-13X1-1/4” BOLT . . . . . . . . . . . . 2 19c L63381 HOSE, -4A6/A6 15” . . . . . . . . . . . . . 1
07 L62842 ADAP, -4ORM -6JICM 90 DEG . . . . 1 20a L63406 HOSE, -12 A12/DS12 114” . . . . . . . 1
08 L69930 HOSE, -4 A6/A6 46” . . . . . . . . . . . . 1 21 L445004 ADAP, -6ORM -6JICM 45 DEG . . . . 1
09 L64660 ADAP, -8 RUN TEE . . . . . . . . . . . . . 1
10 L445012 ADAP, -12ORM -12JICM 45 DEG . . 3 a Refer to hydraulic breakdown section for a break
11 L68802 HOSE, -12 A12/A12 17” . . . . . . . . . 1 down of this component.
12 102836 HOSE, -6 A8/DS6 19” . . . . . . . . . . . 1
13 L63384 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 1 b Standard (not equipped with PWP).

c Option (when equipped with PWP).

HOSE LOCATOR
02 HYDRAULIC PUMP HYDRAULIC TANK
08 HYDRAULIC PUMP STEER MOTOR PORT “LS”
11 HYDRAULIC PUMP FLOW DIVIDER PORT “IN”
12 HYDRAULIC PUMT FLOW DIVIDER PORT “S”
13 HYDRAULIC PUMP STEER MOTOR PORT “P”
16 FLOW DIVIDER PORT “T” HYDRAULIC TANK RETURN MANIFOLD
17 FLOW DIVIDER PORT “PB” FRONT AXLE “PB” (LEFT SIDE)
18b FLOW DIVIDER PORT “J” JOYSTICKS
19c FLOW DIVIDER PORT “J” PWP PORT “P”
20 FLOW DIVIDER PORT “EF” MAIN VALVE PORT (FRONT LEFT)

PRINTED IN U.S.A. 107 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Steer Motor and Steer Select Valve

LEFT
1
Steer Motor
T LS
FRONT
17
L 2

3
P
16

15

12
13

14

Steer Select Valve

12 T

A 6

B
9

11

10
RIGHT

913228/CP0108 108 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Steer Motor and Steer Select Valve

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 101882 STEER MOTOR . . . . . . . . . . . . . . . 1 09 L444002 ADAP, -6ORM -6JICM STR. . . . . . . 2

02 L62842 ADAP, -4ORM -6JICM 90 DEG . . . . 1 10 L69936 HOSE, -6 A8/DS6 100” . . . . . . . . . . 1
03 L69930 HOSE, -4 A6/A6 46” . . . . . . . . . . . . 1 11 L69936 HOSE, -6 A8/DS6 100” . . . . . . . . . . 1
04 NA .............................0 12 L63383 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 1
05 L69747 VALVE, STEER SELECT . . . . . . . . 1 13 L63387 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 1
L50535 1/4”-20X3” BOLT . . . . . . . . . . . . . . 2 14 L63384 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 1
L520003 1/4”-20 NYLON INSERT NUT . . . . 2 15 L68805 HOSE, -6 A6/DS6 70” . . . . . . . . . . . 1
06 L445004 ADAP, -6ORM -6JICM 45 DEG . . . . 2 16 L64524 VALVE, CHECK, -8ORM . . . . . . . . 1
07 103319 HOSE, -6 A8/A6 22” . . . . . . . . . . . . 1 17 L444004 ADAP, -8ORM -8JICM STR. . . . . . . 3
08 NA .............................0

HOSE LOCATOR
03 STEER MOTOR PORT “LS” HYDRAULIC PUMP (item #8 on previous page)
07 STEER SELECT VALVE PORT “T” STEER CYLINDER, FRONT AXLE RIGHT SIDE
10 STEER SELECT VALVE PORT “B” STEER CYLINDER, REAR AXLE RIGHT SIDE
11 STEER SELECT VALVE PORT “A” STEER CYLINDER, REAR AXLE LEFT SIDE
12 STEER MOTOR PORT “R” STEER SELECT VALVE PORT “P”
13 STEER MOTOR PORT “L” STEER CYLINDER, FRONT AXLE LEFT SIDE
14 STEER MOTOR PORT “P” HYDRAULIC PUMP
15 STEER MOTOR PORT “T” HYDRAULIC TANK RETURN MANIFOLD

PRINTED IN U.S.A. 109 913228/CP0108

Hydraulics RS5-34 Telescopic Handler
Brake Valve Group

Located behind CLUTCH CUT-OUT

(OPTION)
joystick access
panel.

12

11 13
8
10
7

BRAKE LIGHT
PRESSURE
SWITCH
9
14
5 9
4

6 1
5 3

2
1

Front Axle
Service Brake
(right side tee)
Rear Axle
Service Brake
(left side tee)

FRONT

913228/CP0108 110 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics
Brake Valve Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
01 101320 HOSE, -4 A4/A4 45” . . . . . . . . . . . . 1 13 L51591 ADAP, -40RM -4JICM 90 DEG . . . . 3
02 102840 HOSE, -4 A4/A6 90” . . . . . . . . . . . . 1 14 103320 HOSE, -4 A4/A6 40” . . . . . . . . . . . . 1
03 L63651 HOSE, -4 A4/DM4 17” . . . . . . . . . . . 1
04 L446044 ADAP, -4 SWIVEL TEE . . . . . . . . . . 2 -- ITEMS NOT SHOWN--
05 L62741 ADAP, HYDROMAX -4JICM STR . . 2 00 L66162 WIRE, 16ga. 6” . . . . . . . . . . . . . . . . 1
06 L63651 HOSE, -4 A4/DM4 17” . . . . . . . . . . . 1 (ground wire for item #8)
07 L63363 VALVE, MASTER CYLINDER . . . . . 2 00b L60986 PLUG, -4ORM SAE . . . . . . . . . . . . . 1
08 L63564 SWITCH, DIFF. PRESSURE . . . . . . 1
09 L444005 ADAP, -4ORM -4JICM STR . . . . . AR
10 104428 SWITCH, PRESSURE 150 PSI. . . . 1 a Used when unit is equipped with Clutch Cut-Out
11 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 1 option.
12a 104428 SWITCH, PRESSURE 150 PSI. . . . 1
b Used when unit is not equippped with Clutch
Cut-Out option. Plug is used in place of pressure
switch.

PRINTED IN U.S.A. 111 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Brake and Steering Lines Group

FRONT
4

2
SERVICE BRAKE PORT
2
1 6 5
23
PARK BRAKE PORT

3
7 1
FRONT AXLE

18

8
16
9
FLOW DIVIDER
PORT “PB” 10 11
11

STEER SELECT
17
STEER MOTOR STEER MOTOR 15 VALVE
PORT “L” PORT “R”
14
6
BRAKE MASTER BRAKE MASTER
CYLINDER “TEE” CYLINDER “TEE”

BRAKE
MANIFOLD 12

3 2 SERVICE BRAKE PORT

19
13
22 20 1
1
21

REAR AXLE

RIGHT
8
8

24 15 14
9 9
LEFT

913228/CP0108 112 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Brake and Steering Lines Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L66139 ADAP, M14X1.5ORM -6JICM . . . . . 6 13 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 1
02 L60653 ADAP, -6JICFS -6JICM 90 . . . . . . . 3 14 L69936 HOSE, -6 A6/A8 100” . . . . . . . . . . . 1
03 P471370 ADAP, -6 SWIVEL TEE . . . . . . . . . . 3 15 L69936 HOSE, -6 A6/A8 100” . . . . . . . . . . . 1
04 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 1 16 L63383 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 1
05 103320 HOSE, -4 A6/A4 40” . . . . . . . . . . . . 1 17 102313 FLOW DIVIDER VALVE . . . . . . . . . 1
06 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 1 18 L69747 VALVE, STEER SELECT . . . . . . . . 1
07 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 1 19 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 1
08 100011 ADAP, M18 ORM - 8JICM STR. . . . 4 20 L445005 ADAP, -4ORM -4JJICM STR . . . . AR
09 L446017 ADAP, -8JICFS -8JICM 90 . . . . . . . 4 21 102837 HOSE, -4 A4/A4 52” . . . . . . . . . . . . 1
10 L63387 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 1 22 L51591 ADAP, -40RM -4JICM 90 DEG . . . . 1
11 103319 HOSE, -6 A8/A6 22” . . . . . . . . . . . . 1 23 102668 AXLE, FRONT (w/ int. park brake) . 1
12 102840 HOSE, -4 A4/A6 90” . . . . . . . . . . . . 1 24 L68849 AXLE, REAR . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 113 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Main Valve Group

1
2 Right Side
1 3 Bulkhead

Left Side
Bulkhead 17

18
21 16
22 15
20 4
19

5
6 28
14 7

13 7
8
9

12

EL 10
LEV
LIFT
M
BOO T B 11
TIL
A
23

7
FRONT

1 24

25
Optional
Hydraulics 26

27

913228/CP0108 114 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Main Valve Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01a L443011 ADAP, BLKHEAD 90 -10JICM. . . . . 4 17 L68807 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 1

02 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 18 L68808 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 1
03 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 19 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 1
04 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 20 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 1
05 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 21 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 1
06 L446026 ADAP, -8JICFS -8JICM RUN T . . . . 4 22 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 1
07a L444008 ADAP, -10ORM -8JICM . . . . . . . . . . 4 23 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1
08 L68817 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 1 24 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1
09 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 25 L68778 KIT, VALVE SECTION . . . . . . . . . . . 1
10 L50895 5/16”-18X3” BOLT . . . . . . . . . . . . . . 3 (includes item #27)
11 L520004 5/16”-18 NYLON INSERT NUT . . . . 3 26 L445003 ADAP, -6ORM -6JICM 90 DEG . . . 10
12 L68694 VALVE, MAIN CONTROL (V20) . . . 1 27 NSS BOLT KIT (included with item #25) . 1
13 L444001 ADAP, -12ORM -12JICM STR. . . . . 2 28 L444010 ADAP, -10ORM -10JICM . . . . . . . . . 2
14 L60253 ADAP, -10ORM -6JICM STR. . . . . . 2
15 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 a Add (2) to quanity when unit is equipped with
16 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 optional hydraulics

HOSE LOCATOR
02 MAIN VALVE SECTION 3 PORT “A” BULKHEAD FITTING TO (BOOM EXTEND)
03 MAIN VALVE SECTION 3 PORT “B” BULKHEAD FITTING TO (BOOM RETRACT)
04 MAIN VALVE SECTION 4 PORT “B” BULKHEAD FITTING TO (TILT CYL. RETRACT)
05 MAIN VALVE SECTION 4 PORT “A” BULKHEAD FITTING TO (TILT CYL. EXTEND)
08 MAIN VALVE SECTION 4 PORT “B” SLAVE CYLINDER (BOTTOM-RETRACT)
09 MAIN VALVE SECTION 4 PORT “A” SLAVE CYLINDER (TOP-EXTEND)
15 MAIN VALVE SECTION 2 PORT “A” LIFT CYLINDER (RIGHT) (OUTSIDE-EXTEND)
16 MAIN VALVE SECTION 2 PORT “B” LIFT CYLINDER (RIGHT) (INSIDE-RETRACT)
17 MAIN VALVE SECTION 2 PORT “B” LIFT CYLINDER (LEFT) (OUTSIDE-RETRACT)
18 MAIN VALVE SECTION 2 PORT “A” LIFT CYLINDER (LEFT) (INSIDE-EXTEND)
19 MAIN VALVE SECTION 1 PORT “B” LEVEL CYLINDER (OUTSIDE-RETRACT)
20 MAIN VALVE SECTION 1 PORT “A” LEVEL CYLINDER (INSIDE-EXTEND)
21 MAIN VALVE “IN” FLOW DIVIDER PORT “EF”
22 MAIN VALVE “OUT” HYDRAULIC TANK (FILTER COVER FITTING)
23 OPTIONAL HYD. SECTION PORT “B” BULKHEAD FITTING TO (OPTION - RETRACT)
24 OPTIONAL HYD. SECTION PORT “A” BULKHEAD FITTING TO (OPTION - EXTEND)

PRINTED IN U.S.A. 115 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Main Valve / Hydraulic Controls

TILT
LEVEL FRONT
3

LIFT

2 EXTEND

HYDRAULIC
OPTION
4
1
LEVEL “LEFT” (E) TILT “FORWARD” (R)

4
TILT “BACK”(E) LEVEL “RIGHT” (R)

BOOM “OUT” (E)

BOOM “DOWN”(R) 9

BOOM “UP”(E) BOOM “IN” (R)

5
6
EXTEND 6 9
RETRACT
5

6
4 6

7
7

LEVE
L (RIG
BOO HT) 8
M (U
P)
BOO
M (IN
)
TILT
(FOR
WAR
HYDR D)
AULIC
OPTIO
N

LEVE
L (LE
BOO FT)
M (D
BOO OWN
M (O )
(R) = retract UT)
TILT
(E) = extend (BAC
K)
HYDR
Main Valve shown with AULIC
OPTIO
Auxiliary Hydraulics Option 8 N

913228/CP0108 116 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Main Valve / Hydraulic Controls

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103264 CONTROLLER, AUX. HYD . . . . . . . 1 08ab L68694 MAIN VALVE . . . . . . . . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 09 L64275 HOSE, -4 A6/A6 102” . . . . . . . . . . . 2
03 103262 CONTROLLER, TILT/LEVEL. . . . . . 1
04 L444002 ADAP, -6ORM -6JICM STR . . . . . AR
05 L68811 HOSE, -4 A6/A6 108” . . . . . . . . . . . 2 a The illustration on the facing page shows the
06 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 4 (optional) auxiliary hydraulic work section with the
07 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 2 main valve. Refer to Main Valve Breakdown for
more information.

PRINTED IN U.S.A. 117 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Main Valve / Radio Remote Option

NOTE: Hose reference AA, BB, and CC attach to joysticks and manifolds. JS
Refer to “Hydraulic Controls - Radio Remote” section for more information.
E1
AA
E2
CC
3
4
BB 5 E3
2
6 E4

P INL
1
T
DN
EXT
J1 RET

UP
J2
J4
Boom Out
J3
7

Boom Down
8

Boom In

Boom Up

10

10 9

Boom Down FRONT

Boom In

Boom Out
Boom Up

913228/CP0108 118 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Main Valve / Radio Remote Option

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L68804 HOSE, -4 A6/DS6 26” . . . . . . . . . . . 4 06 L444012 ADAP, -4ORM -6JICM STR. . . . . . . 5
02 L69905 HOSE, -6 A6/A6 130” . . . . . . . . . . . 1 07 103413 MANIFOLD, RADIO REMOTE . . . . 1
03 L69905 HOSE, -6 A6/A6 130” . . . . . . . . . . . 1 08 103425 MOUNT, RADIO REMOTE . . . . . . . 1
04 103505 HOSE, -4 H6/A6 109” . . . . . . . . . . . 1 09 L69902 HOSE, -6 A6/H6 20” . . . . . . . . . . . . 4
05 L62842 ADAP, -4ORM -6JICM 90O . . . . . . . 6 10 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 4

PRINTED IN U.S.A. 119 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - Standard

FRONT

TILT
LEVEL

1
LIFT
EXTEND

2
P

3
T

5
3
5
5

5 FRONT

6
FLOW DIVIDER

7
8

HYDRAULIC
TANK

913228/CP0108 120 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls - Standard

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 05 L69903 HOSE, -4 A6/DS6 17”. . . . . . . . . . AR
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 06 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1
03 L444002 ADAP, -6ORM -6JICM STR. . . . . . . 4 07 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
04 L446049 ADAP, -6 SWVL RUN TEE . . . . . . AR 08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

PRINTED IN U.S.A. 121 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - Auxiliary Hydraulic Option

TILT
FRONT
LEVEL

LIFT 1
EXTEND

2
P
3
T
4
P
HYDRAULIC
OPTION
T
8
14
3 10
7
4
3
5 8
T
12
9
P
11
6 10
9

FLOW DIVIDER

13
11

HYDRAULIC
TANK

913228/CP0108 122 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls - Auxiliary Hydraulic Option

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 08 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 09 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
03 L444002 ADAP, -6ORM -6JICM STR . . . . . AR 10 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
04 L446049 ADAP, -6 SWIVEL RUN TEE . . . . AR 11 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
05 L60653 ADAP, -6JICM -6JICFS 90 DEG . AR 12 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1
06 L445003 ADAP, -6ORM -6JICM 90 DEG . . AR 13 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1 14 103264 CONTROLLER, AUX. HYD . . . . . . . 1

PRINTED IN U.S.A. 123 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - PWP Only

FRONT

TILT
LEVEL

1
LIFT
EXTEND

2 P

3
T

5 8
3
7
4

FLOW DIVIDER PWP VALVE

10
9

11

12 J2

J1

8
5

HYDRAULIC
TANK

913228/CP0108 124 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls - PWP Only

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 09 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
03 L444002 ADAP, -6ORM -6JICM STR . . . . . AR 10 102321 MANIFOLD, PWP JOYSTICK . . . . . 1
04 L446049 ADAP, -6 SWIVEL RUN TEE . . . . AR 11 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
05 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1 (to hydraulic tank)
06 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1 12 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 1
07 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1

PRINTED IN U.S.A. 125 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - PWP and Aux. Hydraulic Option

TILT
FRONT
LEVEL

1
LIFT
EXTEND

2
P
3

T
4
P
HYDRAULIC
OPTION

16
3 11
7

3 4

5 10 8
T
9
P 12

6
9

PWP VALVE

14
17
13

15
J2

J1

HYDRAULIC
TANK
11
8
FLOW DIVIDER

913228/CP0108 126 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls - PWP and Aux. Hydraulic Option

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 10 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 11 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
03 L444002 ADAP, -6ORM -6JICM STR . . . . . AR 12 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1
04 L446049 ADAP, -6 SWIVEL RUN TEE . . . . AR 13 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
05 L60653 ADAP, -6JICM -6JICFS 90 DEG . AR 14 102321 MANIFOLD, PWP JOYSTICK . . . . . 1
06 L445003 ADAP, -6ORM -6JICM 90 DEG . . AR 15 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 1
07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1 16 103264 CONTROLLER, AUX. HYD . . . . . . . 1
08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1 17 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
09 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1 (to hydraulic tank)

PRINTED IN U.S.A. 127 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - Radio Remote Option

TILT
LEVEL

LIFT
EXTEND

P
2
3
T

5 8
3
7
4

17 7

T
10 P
11

3
J

4 J2
5 J1 6
12 8
16 T
15
HYDRAULIC
TANK

14

AA BB
CC
NOTE: Hose reference AA, BB, and CC attach to radio remote manifold. 13
Refer to the “Main Valve - Radio Remote” section for more information.

913228/CP0108 128 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls -Radio Remote Option

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 10 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 11 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 1
03 L444002 ADAP, -6ORM -6JICM STR . . . . . AR 12 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1
04 L446049 ADAP, -6 SWIVEL RUN TEE . . . . AR 13 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
05 L60653 ADAP, -6JICM -6JICFS 90 DEG . AR 14 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
06 L445003 ADAP, -6ORM -6JICM 90 DEG . . AR 15 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1 16 103505 HOSE, -4 A6/H6 109” . . . . . . . . . . . 1
08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1 17 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1
09 102321 MANIFOLD, PWP JOYSTICK . . . . . 1

PRINTED IN U.S.A. 129 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Controls - Radio Remote Option w/PWP

TILT
LEVEL

1
LIFT
EXTEND

T
P
18

17
20 T

3
5
4
3
19 7
T

19

P 8
6
18

17
9

T
10 P
11

4 J2
T
5 J1 6
12 8
16
15
HYDRAULIC
TANK

14

AA BB
NOTE: Hose reference AA, BB, and CC attach to radio remote manifold.
CC 13
Refer to the “Main Valve - Radio Remote” section for more information.

913228/CP0108 130 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Hydraulic Controls -Radio Remote Option w/PWP

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 103262 CONTROLLER, TILT/LEVEL. . . . . . 1 11 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 1
02 103263 CONTROLLER, LIFT/EXTEND . . . . 1 12 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1
03 L444002 ADAP, -6ORM -6JICM STR . . . . . AR 13 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
04 L446049 ADAP, -6 SWIVEL RUN TEE . . . . AR 14 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
05 L60653 ADAP, -6JICM -6JICFS 90 DEG . AR 15 102313 MANIFOLD, JOYSTICK RELIEF. . . 1
06 L445003 ADAP, -6ORM -6JICM 90 DEG . . AR 16 103505 HOSE, -4 A6/H6 109” . . . . . . . . . . . 1
07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1 17 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1 18 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
09 102321 MANIFOLD, PWP JOYSTICK . . . . . 1 19 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1
10 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1 20 103264 CONTROLLER, AUX. HYD . . . . . . . 1

PRINTED IN U.S.A. 131 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Frame Level Group

3
1 2

6 4
5
6

7
7

8
9
16 10
11
15
12

FR
14 ON
TA
XL FRONT
Main Control
E
Valve (V20)

13

17

FRONT

913228/CP0108 132 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Frame Level Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 Note a LEVEL CYLINDER . . . . . . . . . . . . . 1 12 L68878 FRAME LEVEL MOUNT . . . . . . . . . 1
02 L64367 BRONZE BEARING . . . . . . . . . . . . 1 13 L68876 PLATE, FRAME LEVEL. . . . . . . . . . 1
03 L50277 3/8”-16X3-1/2” BOLT . . . . . . . . . . . . 1 14 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 4
04 L63276 PIN, CYLINDER (BASE END). . . . . 1 15 L50157 3/4” FLAT WASHER . . . . . . . . . . . . 4
05 L520005 3/8”-16 NYLON INSERT NUT . . . . . 1 16 L50084 3/4”-10 STOVER NUT . . . . . . . . . . . 4
06 L68794 ADAP, W/ORIFICE -8ORM -6JICM . 2 17 L60253 ADAP, -10ORM -6JICM . . . . . . . . . . 2
07 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 2
08 L50403 3/8”-16X1-1/4’ BOLT . . . . . . . . . . . . 1 a Refer to Hydraulics Component section for a listing
09 L68881 LOCK, PIVOT PIN . . . . . . . . . . . . . . 1 of hydraulic cylinders.
10 L68882 PIVOT PIN (ROD END). . . . . . . . . . 1
11 L63016 BRONZE BEARING . . . . . . . . . . . . 1

PRINTED IN U.S.A. 133 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Lift Cylinder Group

1
3
4

RIGHT
5

LEFT

11

7
12

Main
Valve
EXTEND 9

10

RETRACT

FRAME EXTEND
8
RETRACT LIFT
4

5
FRONT 3
FRAME
2

913228/CP0108 134 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Lift Cylinder Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 Note a LIFT CYLINDER . . . . . . . . . . . . . . . 2 10 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
02 L63017 BRONZE BUSHING . . . . . . . . . . . . 4 11 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
03 L63274 PIN, LIFT CYLINDER . . . . . . . . . . . 4 12 L445002 ADAP -8ORM -8JICM 90 DEG . . . . 4
04 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 4
05 L520005 3/8”-16 NYLON INSERT NUT . . . . . 4 a Refer to Hydraulics Component section for a listing
06 L446026 ADAP -8JICFS -8JICM RUN TEE . . 2 of hydraulic cylinders.
07 L444008 ADAP -10ORM -8JICM STR . . . . . . 2
08 L68807 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 1
09 L68808 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 1

PRINTED IN U.S.A. 135 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Tilt / Slave Cylinder Group

2
1

Extend

25
Retract 24 Right Bulkhead 4
5
15
12 23
13
18
17 22 14
6
Slave
Cylinder
12 13
16 7
11 11
21
8
10

20
13
Extend
Tilt
Cylinder 19
Main Valve
TILT
12
18
17 26
12 9
14

15

13

FRONT

913228/CP0108 136 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Tilt / Slave Cylinder Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L68351 TUBE, TILT/AUX . . . . . . . . . . . . . . . 2 20a L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 1
02 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 21a L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 1
03 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 22 L520004 5/16”-18 NYLON INSERT NUT . . . . 8
04 L443011 ADAP, -10JICM BLKHEAD 90DEG . 2 23 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 8
05 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 24 L63715 PLATE, TWIN CUSHION. . . . . . . . . 8
06 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 25 L68039 5/8” DOUBLE TUBE CUSHION . . 16
07 L446026 ADAP, -8JICFS -8JICM RUN TEE . 2 26 L445013 ADAP, -8ORM -8JICM 45 DEG . . . . 1
08 L444008 ADAP, -10ORM -8JICM . . . . . . . . . . 2
09 L68817 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 1
10 L63407 HOSE -6 A8/A8 48” . . . . . . . . . . . . . 1 --- ITEMS NOT SHOWN ---
11 L445002 ADAP, -8ORM -8JICM 90 DEG . . . . 3 00 L50207 VINYL CLAMP . . . . . . . . . . . . . . . . . 2
12 L520005 3/8”-16 NYLON INSERT NUT . . . . . 4 00 L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . . 2
13 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 4 00 L520004 5/16”-18 NYLON INSERT NUT . . . 2
14 L63272 PIN, CYLINDER (rod end). . . . . . . . 2
15 L63018 BUSHING BUSHING (rod end) . . . . 2 a Used with protective fabric sleeve part
16 Note b CYLINDER, SLAVE . . . . . . . . . . . . . 1 number L500784.
17 L63017 BUSHING (butt end) . . . . . . . . . . . . 2
18 L63273 PIN, CYLINDER BUSH. (butt end) . 2 b Refer to Hydraulics Component section for a listing
19 Note b CYLINDER, TILT . . . . . . . . . . . . . . . 1 of hydraulic cylinders.

PRINTED IN U.S.A. 137 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Boom Extend Cylinder Group

5
4
3
6
7

8
5 12 9
1
3
10

19 11

18 12

17 13 11

16

14

15

FRONT

Main Valve
Boom
Extend/Retratct

913228/CP0108 138 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Boom Extend Cylinder Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 Note a CYLINDER, EXTEND . . . . . . . . . . . 1 14 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 1
02 L443022 ADAP, -8ORM -8JICM 90 LONG. . . 2 15 L444010 ADAP, -10ORM -10JICM . . . . . . . . . 2
03 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2 16 L443011 ADAP, -10JICM 90 BLKHEAD. . . . . 2
04 L63273 PIN, CYLINDER (butt end) . . . . . . . 1 17 L63694 EXTEND CYL. BRACKET . . . . . . . . 1
05 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2 L50367 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2
06 L63017 BUSHING (butt end) . . . . . . . . . . . . 1 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 2
07 L68348 7/8” HOSE CUSHION, SINGLE . . . 4 18 L63018 BUSHING (rod end). . . . . . . . . . . . . 1
08 L68356 CUSHION TOP PLATE . . . . . . . . . . 2 19 L63272 PIN, CYLINDER (rod end). . . . . . . . 1
09 L50878 5/-16”-18X3” STUD . . . . . . . . . . . . . 4
10 L520004 5/16”-18 NYLON INSERT NUT . . . . 4
11 L68352 HOSE, -8 A8/DS10 73” . . . . . . . . . . 1 a Refer to Hydraulics Component section for a listing
12 L68352 HOSE, -8 A8/DS10 73” . . . . . . . . . . 1 of hydraulic cylinders.
13 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 1

PRINTED IN U.S.A. 139 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Auxiliary Hydraulics Group

1
2
3

12

11 10
14
13
9

8
16 7

21
22 6

17
Auxilary Hydraulics
Valve Section
11 13
18
5
Left Bulkhead
14
4

19

20

FRONT

913228/CP0108 140 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Auxiliary Hydraulics Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 L68351 TUBE, TILT/AUX . . . . . . . . . . . . . . . 2 17 L50545 5/16”-18X2-3/4” BOLT . . . . . . . . . . . 2
02 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 L50143 5/16” LOCK WASHER . . . . . . . . . . 2
03 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 18 L63716 11/16” DOUBLE TUBE CUSHI0N . . 4
04 L443011 ADAP, -10JICM BLKHEAD 90DEG . 2 19 L444004 ADAP, -8ORM -8JICM STR. . . . . . . 2
05a L68778 KIT, VALVE SECTION . . . . . . . . . . . 1 20 L65273 COUPLER SET . . . . . . . . . . . . . . . . 1
06 L444008 ADAP, -10ORM -8JICM . . . . . . . . . . 2 21 103330 CLAMP, BOOM HOSES . . . . . . . . AR
07 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 22 103331 CLAMP, BOOM W/INSERT . . . . . AR
08 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1
09 L520004 5/16”-18 NYLON INSERT NUT . . . 10
10 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 8
11 L63715 PLATE, TWIN CUSHION. . . . . . . . . 8 a Kit includes a single V20 valve section and tie
12 L68039 5/8” DOUBLE TUBE CUSHION . . 16 bolt kit for five section valve.
13b L68376 HOSE, -6 A8/H10 352” . . . . . . . . . . 1
14b L68376- HOSE, -6 A8/H10 352” . . . . . . . . . . 1 b Used with protective fabric sleeve part
15 NA .............................0 number L500784.
16 L71748 TOP PLATE, HOSE CLAMP. . . . . . . 1

PRINTED IN U.S.A. 141 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Hydraulic Pump

1
2

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 103130 HYDRAULIC PUMP . . . . . . . . . . . . 1 03 L500368 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1

02 L46865 GASKET . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

913228/CP0108 142 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Flow Divider

PARKING
BRAKE
2 VALVE
6

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
01 102313 MANIFOLD, FLOW DIVIDER . . . . .1 07 P471997 TEST PORT . . . . . . . . . . . . . . . . . . .3
(includes items 1-7) L62840 CAP, DUST COVER (not shown) . .3
02 103017 PILOTED SPOOL LOGIC ELEM. . .1 -- ITEMS NOT SHOWN --
03 L99927 RELIEF VALVE . . . . . . . . . . . . . . . .1 (Mounting Hardware)
L99925 SEAL KIT . . . . . . . . . . . . . . . . . . . .1 00 L50217 1/4”-20X3-1/2” BOLT . . . . . . . . . . . .2
04 NSS NUT, SOLENOID VALVE . . . . . . . . .1 00 L50139 1/4” LOCK WASHER . . . . . . . . . . . .2
(included with item 5) 00 L50137 1/4” FLAT WASHER . . . . . . . . . . . .2
05 L99908 12 VDC WEATHER PACK COIL . . .1
(includes item 4) NOTE: Items included in seal kits are not shown.
06 L99910 SOLENOID VALVE . . . . . . . . . . . . .1
L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . .1

PRINTED IN U.S.A. 143 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Main Valve

1
12
10 11
9
FRONT 3

8
4
3
13
7
6
3 9
5
4 6
3 TILT 14

‘B’ PORT 4

BOOM 14 21
2 IN 4
OUT

1 14
LIFT

14 15 ‘A’ PORT
12
17 16 LEVEL
3 4 19

21 4

18

Auxilary Hydraulics
Work Section

14
SEAL KITS

20

913228/CP0108 144 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Main Valve
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
00 L68694 MAIN VALVE [V20] (Complete) . . . . 1 14 L500135 HRO ACUATOR “A” END . . . . . . . . 4
01 L98891 STUD KIT (tie bolts and nuts) . . . . . 1 15 L500961 SCREW . . . . . . . . . . . . . . . . . . . . 32
02 L500954 INLET COVER. . . . . . . . . . . . . . . . . 1 654022 LOCK WASHER . . . . . . . . . . . . . . 32
03 L500134 HRO ACUATOR “B” END . . . . . . . . 4 16 L500129 RELIEF CARTRIDGE (RP51-A) . . . 1
04 L500132 NO RELIEF-NO ANTI-CAV.PLUG . . 4 L96580 RELIEF SEAL KIT . . . . . . . . . . . . . 1
L500130 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1 17 L500958 PLUG WITH TEST PLUG . . . . . . . . 1
05 L98895 WORK SECTION 1 (Level) . . . . . . . 1 18 SEAL KITS FOR WORK SECTIONS
(includes items 3, 4, 14 & 15) L500127 SECTION SEAL KIT . . . . . . . . . . 1ea
06 L500952 NO RELIEF - ANTI-CAV PLUG. . . . 1 (used with items 5-7 & 10)
07 L500953 WORK SECTION 2 (Lift) . . . . . . . . . 1 L98887 SPOOL SEAL KIT . . . . . . . . . . . . 1ea
(includes items 3, 4, 6, 14 & 15) (used with items 3 & 14)
08 L500956 WORK SECTION 3 (Boom Ext.) . . . 1 19 L98895 WORK SECTION (Aux. Hyd.) . . . . . 1
(includes items 3, 4, 6, 14 & 15) 20 L500960 STUD ASSEMBLY KIT (Aux. Hyd.) . 1
09 L98896 RELIEF CARTRIDGE . . . . . . . . . . . 2 (used with item 20)
L98897 SERVICE KIT (less seals) . . . . . . . 2 21 L500300 DUST BOOT. . . . . . . . . . . . . . . . . AR
L98898 SEAL KIT . . . . . . . . . . . . . . . . . . . . 2
10 L98899 WORK SECTION 4 (Tilt) . . . . . . . . . 1 -- ITEMS NOT SHOWN --
(includes items 3, 9, 14 & 15) 00 L68778 KIT, VALVE SECTION (AUX.) . . . . . 1
11 L500955 OUTLET COVER. . . . . . . . . . . . . . . 1 (includes all items shown on facing
12 L500957 PLUG SAE-12 page in the “Auxilary Hydraulics
13 L500959 PLUG SAE 12 (SOCKET HEAD) . . 1 Work Section” group and item 20)

PRINTED IN U.S.A. 145 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

PWP Valve

3
4

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 102321 MANIFOLD, PWP JOYSTICK . . . . . 1 04 L99910 SOLENOID VALVE . . . . . . . . . . . . . 1

(Complete assembly) L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
01 NSS NUT, SOLENOID VALVE . . . . . . . . . 2 (Items included are not shown)
(included with item 3 and 4) 05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1
02 L99908 12 VDC WEATHER PACK COIL . . . 2
03 L99909 SOLENOID VALVE . . . . . . . . . . . . . 1
L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
(Items included are not shown)

913228/CP0108 146 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Steer Valve

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 L69747 STEER SELECT VALVE, COMPL. . 1 -- ITEMS NOT SHOWN --
(Includes items 1and 2) 00 L68711 WIRE HARNESS . . . . . . . . . . . . . . 2
01 210018 WEATHER PAK VALVE. . . . . . . . . . 1 (connects wire leads to frame wiring)
02 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 147 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Steer Motor

LS
L

R
P

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 101882 STEERING CONTROL UNIT . . . . . 1 NOTE: Field service is limited to seals replacement.
L500968 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
(Items included are not shown)

913228/CP0108 148 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Brake Valve

REPAIR KIT

7 3

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 L63363 BRAKE VALVE ASY. (Complete). . . . 06 NSS PUSH ROD . . . . . . . . . . . . . . . . . . . 1
(Unit requires two brake valves) 07a L98537 REPAIR KIT . . . . . . . . . . . . . . . . . . . 1
01 NSS BAIL WIRE. . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)
02 L98533 COVER . . . . . . . . . . . . . . . . . . . . . . 1
L98534 DIAPHRAM GASKET . . . . . . . . . . . 1 a Repair kit includes seals, cups, return spring,
03 NSS BODY second arm piston, and snap ring. Piston is not
04 NSS TUBE SEAT (not shown) . . . . . . . . . 1 included or sold seperately.
05 L98536 RUBBER BOOT . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 149 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Radio Remote Manifold (Option)

2 3

913228/CP0108 150 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Radio Remote Manifold (Option)

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 103413 COMPLETE VALVE. . . . . . . . . . . . . 1 04 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

(includes all items shown and listed)
01 103508 2/4 WAY SOLENOID VALVE . . . . . . 1 -- ITEMS NOT SHOWN --
103511 SEAL KIT FOR VALVE . . . . . . . . . . 1 00 103514 SHUTTLE VALVE . . . . . . . . . . . . . . 4
02 103510 12 VDC COIL (DIN CONN.) . . . . . . 5 103513 SEAL KIT FOR VALVE . . . . . . . . AR
03 103509 PROPORTIONAL PRESS. VALVE . 4
103512 SEAL KIT FOR VALVE . . . . . . . . AR

PRINTED IN U.S.A. 151 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Controller - Tilt / Frame Level

10

913228/CP0108 152 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Controller - Tilt / Frame Level

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 103262 HYD. CONTROLLER (Complete) . 1 08 103403 METERING CURVE (as shown) . . . 4

01 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1 09 103404 RETURN SPRING. . . . . . . . . . . . . . 4
02 103112 LEVER ROD (as shown) . . . . . . . . . 1 10a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
03 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 1
04 102674 LOCK GATE . . . . . . . . . . . . . . . . . . 1
05 103114 SELECTOR DISC . . . . . . . . . . . . . . 1 a Items included in seal kit are not shown.
06 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 1
07 103116 PLATE / BOOT MOUNT . . . . . . . . . 1

PRINTED IN U.S.A. 153 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Controller - Lift / Extend

913228/CP0108 154 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Controller - Lift / Extend

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 103263 HYD. CONTROLLER (Complete) . 1 07 103403 METERING CURVE (as shown) . . . 4

01 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1 08 103404 RETURN SPRING. . . . . . . . . . . . . . 4
02 103112 LEVER ROD (as shown) . . . . . . . . . 1 09a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
03 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 1
04 103114 SELECTOR DISC . . . . . . . . . . . . . . 1
05 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 1 a Items included in seal kit are not shown.
06 103116 PLATE /BOOT MOUNT . . . . . . . . . . 1

PRINTED IN U.S.A. 155 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Controller - Auxiliary Hydraulics (Option)

913228/CP0108 156 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Controller - Auxiliary Hydraulics (Option)

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 103264 COMPLETE VALVE ASY. . . . . . . . . 1 05 103404 RETURN SPRING. . . . . . . . . . . . . . 2

01 103077 LEVER ROD (as shown) . . . . . . . . . 1 06a 103083 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
02 103084 BOOT (included with item #3) . . . . . 1
03 103078 CONTROL KIT. . . . . . . . . . . . . . . . . 1
(includes item #2 Boot) a Items included in seal kit are not shown.
04 103403 METERING CURVE (as shown) . . . 2

PRINTED IN U.S.A. 157 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Frame Level Cylinder (Stamped w/PN 104130)

2
5

1-1/4” Wide
Machined Groove
7
Cylinder
Part Number
Stamped Here

9
10

8
Internal
Threads

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 104130 FRAME LEVEL CYL. (Complete) . . 1 07 NSS TUBE WELDMENT . . . . . . . . . . . . . 1

(part number is stamped on cylinder) 08 104251 OIL LINE TUBE ASSEMBLY . . . . . . 1
01 104245 ROD (includes item 2) . . . . . . . . . . . 1 09 L70495 COUNTER BALANCE VALVE . . . . . 2
02 L63016 BUSHING . . . . . . . . . . . . . . . . . . . . 1 L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1
03 104264 HEAD GLAND . . . . . . . . . . . . . . . . . 1 10 104277 CYLINDER SEAL KIT . . . . . . . . . . . 1
04 104260 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)
05 104273 LOCKNUT . . . . . . . . . . . . . . . . . . . . 1
06 L64367 BUSHING . . . . . . . . . . . . . . . . . . . . 1

913228/CP0108 158 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Frame Level Cylinder (Stamped w/PN L63015)

2
7
6

External
9 Threads

Cylinder
Part Number
Stamped Here

12

10

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 L63015 FRAME LEVEL CYL. (Complete) . . 1 07 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 1
(part number is stamped on cylinder) 08 L64367 BUSHING 2.0X2.25X2.0” . . . . . . . . 1
01 L98503 ROD. . . . . . . . . . . . . . . . . . . . . . . . . 1 09 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
02 L63016 BUSHING . . . . . . . . . . . . . . . . . . . . 1 10 L98509 OIL LINE TUBE ASSEMBLY . . . . . . 1
03 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 1 11 L70495 COUNTER BALANCE VALVE . . . . . 2
04 L99857 5/16”-18x1/4” SET SCREW. . . . . . . 1 L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1
05 L98507 HEAD GLAND . . . . . . . . . . . . . . . . . 1 12 L98506 CYLINDER SEAL KIT . . . . . . . . . . . 1
06 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)

PRINTED IN U.S.A. 159 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Lift Cylinder (Stamped w/PN 104131)

4
3
2

5
Cylinder
Part Number
Stamped Here
1-1/4” Wide
Machined Groove

6
8

Internal
Threads 7

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 104131 LIFT CYLINDER (Complete) . . . . . . 2 06 104249 OIL LINE TUBE ASSEMBLY . . . . . . 1

(part number is stamped on cylinder) (includes nuts and ferrules)
Note: Quantities shown are for one cylinder. 07 L64175 COUNTER BALANCE VALVE . . . . . 1
01 104248 ROD WELDMENT . . . . . . . . . . . . . 1 L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1
02 104266 GLAND . . . . . . . . . . . . . . . . . . . . . . 1 08 104279 CYLINDER SEAL KIT . . . . . . . . . . . 1
03 104261 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)
04 104274 LOCKNUT . . . . . . . . . . . . . . . . . . . . 1
05 NSS TUBE WELDMENT . . . . . . . . . . . . . 1

913228/CP0108 160 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Lift Cylinder (Stamped w/PN L63199)

6
5

3
Cylinder
Part Number
Stamped Here
External
Threads

7 9
10
8

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 L63199 LIFT CYLINDER (Complete) . . . . . . 2 06 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 1

(part number is stamped on cylinder) 07 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
Note: Quantities shown are for one cylinder. 08 L98519 OIL LINE TUBE ASSEMBLY . . . . . . 1
01 L98518 ROD WELDMENT . . . . . . . . . . . . . . 1 (includes nuts and ferrules)
02 L98520 HEAD GLAND CAP. . . . . . . . . . . . . 1 09 L64175 COUNTER BALANCE VALVE . . . . . 1
03 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1
04 L98522 HEAD GLAND . . . . . . . . . . . . . . . . . 1 10 L98521 CYLINDER SEAL KIT . . . . . . . . . . . 1
05 L98523 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)

PRINTED IN U.S.A. 161 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Slave Cylinder (Stamped w/PN 104129)

1
2

5
4

Cylinder
Part Number
Stamped Here

1-1/4” Wide
Machined Groove

Internal
Threads

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 104129 SLAVE CYLINDER (Complete) . . . . 1 05 104272 LOCKNUT . . . . . . . . . . . . . . . . . . . . 1
(part number is stamped on cylinder) 06 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 1
01 104244 ROD (includes item 2) . . . . . . . . . . . 1 07 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 08 104275 CYLINDER SEAL KIT . . . . . . . . . . . 1
03 104263 HEAD GLAND . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)
04 104259 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

913228/CP0108 162 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Slave Cylinder (Stamped w/PN L63014)

1 2

5
4
3
Cylinder
Part Number
Stamped Here

External
Threads
10
8

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 L63014 SLAVE CYLINDER (Complete) . . . . 1 06 L98529 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

(part number is stamped on cylinder) 07 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 1
01 L98524 ROD WELDMENT . . . . . . . . . . . . . . 1 08 L63017 BUSHING . . . . . . . . . . . . . . . . . . . . 1
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 09 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
03 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 10 L98527 CYLINDER SEAL KIT . . . . . . . . . . . 1
04 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 1 (Items included are not shown.)
05 L98528 HEAD GLAND . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 163 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Tilt Cylinder (Stamped w/PN 104128)

5
4

Cylinder
Part Number
Stamped Here

1-1/4” Wide
6 Machined Groove

8
9

Internal
Threads
10

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 104128 TILT CYLINDER (Complete) . . . . . . 1 07 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 1

(part number is stamped on cylinder) 08 L48868A COUNTER BALANCE VALVE . . . . . 1
01 104246 ROD (includes item 2) . . . . . . . . . . . 1 L96838 SEAL KIT (CBV)
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 09 104278 CYLINDER SEAL KIT . . . . . . . . . . . 1
03 104265 HEAD GLAND . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)
04 104260 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 10 104252 HYDRAULIC LINE ASSY. . . . . . . . . 1
05 104273 LOCKNUT . . . . . . . . . . . . . . . . . . . . 1
06 NSS TUBE WELDMENT . . . . . . . . . . . . . 1

913228/CP0108 164 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Tilt Cylinder (Stamped w/PN L63013)

1
2

7
6

4
Cylinder 3
Part Number
Stamped Here
8

External
Threads

11
10

12

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 L63013 TILT CYLINDER (Complete) . . . . . . 1 08 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
(part number is stamped on cylinder) 09 L63017 BUSHING . . . . . . . . . . . . . . . . . . . . 1
01 L98545 ROD WELDMENT . . . . . . . . . . . . . . 1 10 L70495 COUNTER BALANCE VALVE . . . . . 1
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 L97889 SEAL KIT (CBV)
03 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 11 L98548 CYLINDER SEAL KIT . . . . . . . . . . . 1
04 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 1 (Items included are not shown.)
05 L99866 HEAD GLAND . . . . . . . . . . . . . . . . . 1 12 L98551 HYDRAULIC LINE ASSY. . . . . . . . . 1
06 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 1
07 L99405 1-1/4”-12 UN LOCKNUT . . . . . . . . . 1

PRINTED IN U.S.A. 165 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Boom Extend Cylinder (Stamped w/PN 104127)

1
2
6
5

7 Cylinder
Part Number 4
Stamped Here

1-1/4” Wide
Machined Groove
11

10

Internal
Threads

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 104127 EXTEND CYLINDER (Complete) . . 1 06 104274 LOCKNUT . . . . . . . . . . . . . . . . . . . . 1

(part number is stamped on cylinder) 07 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 1
01 104247 ROD (includes item 2) . . . . . . . . . . . 1 08 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 09 L48868A COUNTER BALANCE VALVE . . . . . 1
03 104271 DX BUSHING . . . . . . . . . . . . . . . . . 1 L96838 SEAL KIT (CBV)
04 104262 HEAD GLAND . . . . . . . . . . . . . . . . . 1 10 104250 HYDRAULIC LINE ASSY. . . . . . . . . 1
05 104258 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 11 104277 CYLINDER SEAL KIT . . . . . . . . . . . 1
(Items included are not shown.)

913228/CP0108 166 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Boom Extend Cylinder (Stamped w/PN L63012)

1
2
7

Cylinder
8 Part Number
Stamped Here

5
4
3
9

10

11
External
Threads
12

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 L63012 EXTEND CYLINDER (Complete) . . 1 07 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 1

(part number is stamped on cylinder) 08 L63017 BUSHING . . . . . . . . . . . . . . . . . . . . 1
01 L98511 ROD WELDMENT . . . . . . . . . . . . . . 1 09 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
02 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 1 10 L48868A COUNTER BALANCE VALVE . . . . . 1
03 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 L96838 SEAL KIT (CBV)
04 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 1 11 L98517 HYDRAULIC LINE ASSY. . . . . . . . . 1
05 L98515 HEAD GLAND . . . . . . . . . . . . . . . . . 1 12 L98558 CYLINDER SEAL KIT . . . . . . . . . . . 1
06 L98516 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown.)

PRINTED IN U.S.A. 167 913228/CP0108

Hydraulics RS5-34 Telescopic Handler

Fork Shift Cylinder

3 4

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

00 L68337 COMPLETE ASSEMBLY 04 L500367 3/4”-16 UNF LOCKNUT. . . . . . . . . . 1

01 L500763 ROD WELDMENT . . . . . . . . . . . . . . 1 05 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
02 L500762 HEAD GLAND . . . . . . . . . . . . . . . . . 1 06 L500370 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
03 L500761 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

913228/CP0108 168 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Hydraulics

Rotate Carriage Cylinder

1
2

9
8

10
12

11

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.
00 L63594 ROTATE CYLINDER (Complete) . . 1 07 L99175 SUPPORT WASHER. . . . . . . . . . . . 1
06 L98921 PISTON . . . . . . . . . . . . . . . . . . . . . . 1
01 L99168 ROD WELDMENT . . . . . . . . . . . . . . 1 09 L500367 3/4”-16 UN LOCKNUT. . . . . . . . . . . 1
02 L63593 BUSHING . . . . . . . . . . . . . . . . . . . . 1 10 L64175 COUNTER BALANCE VALVE . . . . . 1
03 L99169 HEAD GLAND CAP. . . . . . . . . . . . . 1 L97889 SEAL KIT (CBV)
04 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 11 NSS TUBE WELDMENT . . . . . . . . . . . . . 1
05 L99171 HEAD GLAND . . . . . . . . . . . . . . . . . 1 12 L99170 CYLINDER SEAL KIT . . . . . . . . . . . 1
06 L99174 SPACER, ROD . . . . . . . . . . . . . . . . 1 (Items included are not shown)

PRINTED IN U.S.A. 169 913228/CP0108

Attachments RS5-34 Telescopic Handler

Carriage Forks

2” Shaft x 42” Long

2” Shaft x 48” Long

FRONT

1
2
3 4 5 6

2” Shaft x 60” Long

2” Shaft x 72” Long

7 8
9

913228/CP0108 170 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Carriage Forks
Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
-- 2” FORK SHAFT DIAMETER -- 06 L47263 FORK, 48”X5”X2” (10,500 lbs.) . . . . 2
07 L47265 FORK, 60”X5”X2” (10,500 lbs.) . . . . 2
01 L71350 FORK, 42”X4”X2” (8,400 lbs.) . . . . . 2 08 L60961 FORK, 60”X6”X2-1/4” (12,500 lbs.). 2
02a L61001 FORK, 48”X2”X2” (4,200 lbs.) . . . . . 4 09 L68331 FORK, 72”X5”X2” (10,500 lbs.) . . . . 2
03 L61017 FORK, 48”X4”X2” (8,400 lbs.) . . . . . 2
04 L66406 FORK, 48”X4”X2-1/4” (12,000 lbs.). 2 a Requires 2 sets (4 forks).
05 L400929 FORK, 48”X5”X1-3/4” (8,500 lbs.). . 2

Note: ratings are based on 2 forks and the load is 24” on

center. Except for item 2; where 4 forks are required.

PRINTED IN U.S.A. 171 913228/CP0108

Attachments RS5-34 Telescopic Handler

Standard Carriage Attachment Group

2
3
4

913228/CP0108 172 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Standard Carriage Attachment Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 CARRIAGE, WELDMENT . . . . . . . . 1 03 L400425 WASHER, FORK SHAFT . . . . . . . . 2
L99192 48” Carriage 04 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2
L99193 66” Carriage 05 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2
02 FORK SHAFT BAR . . . . . . . . . . . . . 1
L63319 48” Carriage (50-1/2”)
L63320 66” Carriage (68-1/2”)

PRINTED IN U.S.A. 173 913228/CP0108

Attachments RS5-34 Telescopic Handler

Fork Shift Carriage Attachment Group

19 1

20

18

14
13
15
2
11 9 12
15 16
17

9
10
8

7
6

5
2
3
4

913228/CP0108 174 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Fork Shift Carriage Attachment Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L500215 FORK SHIFT CARR., WLDMNT . . . 1 11 L63716 TWIN HOSE CUSHION. . . . . . . . . . 1

02 L50519 3/4”-10 NYLON INSERT NUT . . . . . 3 12 L520004 5/16”-18 NYLON INSERT NUT . . . . 2
03 L400425 FORK SHAFT WASHER . . . . . . . . . 1 13a NSS COUPLER, MALE . . . . . . . . . . . . . . 1
04 L50333 3/4”-10X3” BOLT . . . . . . . . . . . . . . 1 14a NSS COUPLER, FEMALE. . . . . . . . . . . . 1
05 L66919 FORK SHAFT, 50” . . . . . . . . . . . . . . 1 15 L66918 CYLINDER MOUNT . . . . . . . . . . . . 2
06 L66931 FORK SLIDE PLATE . . . . . . . . . . . . 2 16 L68337 FORK SHIFT CYLINDER . . . . . . . . 1
07 L50875 3/4”-10X1-1/2” BOLT . . . . . . . . . . . . 1 17 L50562 3/4”-10X4” BOLT . . . . . . . . . . . . . . . 2
08 FORK SLIDE COUPLER. . . . . . . . . 1 18 L63143 ADAP -8ORM -6JICM W/.06 ORF . 2
L66921 Used with 4” wide forks 19 L66950 HOSE -6 A6/A6 59” . . . . . . . . . . . . . 1
L66948 Used with 5” wide forks 20 L66949 HOSE -6 A6/A6 56” . . . . . . . . . . . . . 1
09 L63715 TWIN CUSHION TOP PLATE . . . . . 2
10 L50242 5/16”-18X2-1/4” BOLT . . . . . . . . . . . 2
a Sold as a set. Order part # L65273 Quick Couplers

PRINTED IN U.S.A. 175 913228/CP0108

Attachments RS5-34 Telescopic Handler

Rotate Carriage Attachment Group

3
4

5
2 3

10

11
21
4
10
11 7
12 5
18 8
20 6

17 9
12
16

13

13
19 15
14

913228/CP0108 176 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Rotate Carriage Attachment Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.
01 ROTATE CARRIAGE, WELDMNT . 1 11 L63143 ADAP, -8ORM -6JICM STR. . . . . . . 2
L99225 48” Carriage (with orifice)
L99224 66” Carriage 12 L63344 HOSE, -6 A8/A6 20” . . . . . . . . . . . . 2
02 FORK SHAFT BAR . . . . . . . . . . . . . 1 13 L51968 ADAP, -6ORM -6JICM 90DEG . . . . 2
L63319 48” Carriage (50-1/2” long) 14 L520005 3/8”-16 NYLON INSERT NUT . . . . 1
L63320 66” Carriage (68-1/2” long) 15a L63968 BUTT END PIVOT PIN . . . . . . . . . . 1
03 L50237 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2 16 L50273 3/8”-16X2-3/4” BOLT . . . . . . . . . . AR
04 L400425 RETAINER. . . . . . . . . . . . . . . . . . . . 2 17 L63594 ROTATE CYLINDER . . . . . . . . . . . . 1
05 L520005 3/8”-16 NYLON INSERT NUT . . . . . 2 18a L63969 ROD END PIVOT PIN . . . . . . . . . . . 1
06 L50205 2”-12 CASTELLATED NUT . . . . . . . 1 L50294 1/2”-13X3-1/2” BOLT . . . . . . . . . . . 1
L61287 WASHER (not shown) . . . . . . . . . . 1 L520019 1/2”-13 NYLON INSERT NUT . . . . 1
07 L52026 3/8”-16X1-1/4” BOLT” . . . . . . . . . . . 6 19 NSS ROTATE PIN (welded to #20). . . . . 1
08 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 6 20 L63952 ROTATE, PLATE (incIudes #19) . . 1
09 L61709 SLIDE PAD 3”X4” . . . . . . . . . . . . . . 3 21 L64367 BUSHING (not shown) . . . . . . . . . . 1
10 L65273 QUICK COUPLER SET. . . . . . . . . . 1
(couplers are not sold separately)

PRINTED IN U.S.A. 177 913228/CP0108

Attachments RS5-34 Telescopic Handler

Boom Attachment Group

1
8’ Truss Boom

26

25

5’ Jib Boom
24

7 8 Hydraulic Winch
With Brake

6 27

15
16
19 18 17 14
23

4 11
3
13
9
22
21
20 12
5

10
9

913228/CP0108 178 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Boom Attachment Group

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 L99237 8’ TRUSS BOOM WELDMENT . . . . 1 21 L50371 3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2

02 L500214 5’ JIB BOOM WELDMENT . . . . . . . 1 22 L50147 3/8” LOCK WASHER . . . . . . . . . . . . 2
03 L64294 HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2 23 L60451 WINCH BALL. . . . . . . . . . . . . . . . . . 1
04 L64660 ADAP -8ORM -8JICM RUN TEE. . . 1 24 L61411 PINTLE HOOK . . . . . . . . . . . . . . . . 1
05 L50841 1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2 25 L50380 1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 4
L520003 1/4”-20 NYLON INSERT NUT . . . . 2 26 L50152 1/2” LOCK WASHER . . . . . . . . . . . . 4
06 L444004 ADAP -8ORM -8JICM STR . . . . . . . 2 27d L446017 ADAP -8JICFS -8JICM 90 . . . . . . . . 2
07a NSS COUPLER, MALE . . . . . . . . . . . . . . 1
08a NSS COUPLER, FEMALE. . . . . . . . . . . . 1 -- ITEMS NOT SHOWN --
09 L445002 ADAP -8ORM -8JICM 90 DEG . . . . 2 00 L500222 AUGER, ADAPTER PLATE. . . . . . . 1
10 L82358 RELIEF VALVE . . . . . . . . . . . . . . . . 1
11b 100963 HYDRAULIC WINCH. . . . . . . . . . . . 1
12 L50286 1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 6 a Sold as a set. Order part # L65273 Quick Couplers
13 L520019 1/2-13 NYLON INSERT NUT . . . . . 6
14 L444008 ADAP -10ORM -8JICM . . . . . . . . . . 2 b Used with 5’ truss booms after attachment
15 L400398 HOSE -6 A8/A8 18.5” . . . . . . . . . . . 2 serial number 11182. The winch on 5’ truss
16 L50815 5/16”X2-1/2” BOLT . . . . . . . . . . . . . 2 booms before attachment serial number 11183
17 100076 PIN, TRUSS WINCH . . . . . . . . . . . . 1 have been discontinued, you must purchase a
18 L520004 5/16”-18 NYLON INSERT NUT . . . . 2 boom and a winch.
19 L65338 WINCH SHEAVE . . . . . . . . . . . . . . . 1
20c L66946 3/8”X60’ WINCH CABLE . . . . . . . . . 1 c Used with 5’ truss booms with winch.
(Includes hook and swivel)
d Not used on some attachments.

PRINTED IN U.S.A. 179 913228/CP0108

Attachments RS5-34 Telescopic Handler

180o Swing Platform

2
1 3

4 5

7
9

13
10

15
11 12 1

14

913228/CP0108 180 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

180o Swing Platform

Ref. Part Description Qty. Ref. Part Description Qty.
No. No. Req. No. No. Req.

01 104478 VALVE ASSEMBLY . . . . . . . . . . . . . 1 13 103907 LEFT DOOR . . . . . . . . . . . . . . . . . . 1

02 104477 PUMP ASSEMBLY . . . . . . . . . . . . . 1 14 104467 BASE . . . . . . . . . . . . . . . . . . . . . . . . 1
03 104476 HARDWARE KIT (pivot) . . . . . . . . . 1 15 100883 DECAL, PLATFOM RULES. . . . . . . 2
04 104471 HUB ASSEMBLY . . . . . . . . . . . . . . . 2
05 104469 SHAFT AND KEY ASSEMBLY . . . . 1 -- ITEMS NOT SHOWN --
06 104475 THRUST PLATE . . . . . . . . . . . . . . . 2 00 104470 HOSE KIT . . . . . . . . . . . . . . . . . . . . 1
07 104473 BACK HALF (attachment) . . . . . . . . 1 00 103911 PIN AND CHAIN KIT . . . . . . . . . . . . 1
08 104468 ACUATOR . . . . . . . . . . . . . . . . . . . . 1 00 103910 HARDWARE KIT (platform bolts) . . 1
09 104472 FRONT HALF . . . . . . . . . . . . . . . . . 1 00 101149 DECAL, FALL HAZARD . . . . . . . . . 2
10 103909 BACK SIDE . . . . . . . . . . . . . . . . . . . 1
11 103906 RIGHT DOOR . . . . . . . . . . . . . . . . . 1
12 103908 FRONT SIDE . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A. 181 913228/CP0108

Attachments RS5-34 Telescopic Handler

Bucket Attachment Group

Ref. Part Description Qty. Ref. Part Description Qty.

No. No. Req. No. No. Req.

01 L500373 1.3 CU. YD. BUCKET WELDMNT . 1

L68831 CUTTING EDGE 98” (weld on) . . . . 1

913228/CP0108 182 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Attachments

Notes

PRINTED IN U.S.A. 183 913228/CP0108

Numerical Index RS5-34 Telescopic Handler

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

056859 9 07 102313 127 13 102674 153 04 102958 79 11

072340 23 15 102313 129 15 102680 21 03 102959 79 12
072798 9 10 102313 131 15 102681 21 04 102965 35 02
081379 35 13 102313 143 01 102692 13 24 102968 47 00
089069 23 19 102321 45 02 102705 21 02 102969 11 05
089070 23 19 102321 125 10 102711 19 03 102974 53 19
100011 113 08 102321 127 14 102712 19 10 103013 17 00
100071 29 10 102321 129 09 102717 10 11 103014 21 00
100076 179 17 102321 131 09 102718 10 10 103017 143 02
100102 43 10 102321 146 00 102722 15 20 103019 15 12
100135 29 01 102408 44 01 102727 13 18 103021 13 03
100359 9 13 102433 55 01 102728 13 17 103022 13 02
100883 181 15 102450 57 07 102741 33 03 103022 15 11
100963 179 11 102529 31 08 102769 13 21 103023 13 12
101149 181 00 102530 31 05 102778 13 20 103023 15 09
101278 23 04 102534 31 15 102780 33 01 103024 13 16
101291 31 25 102572 43 00 102780 33 07 103024 15 10
101320 111 01 102573 86 03 102781 33 04 103025 19 08
101436 21 22 102574 86 04 102782 33 02 103026 19 09
101495 17 20 102575 86 07 102783 27 05 103027 19 01
101506 10 06 102575 91 08 102785 31 04 103028 11 06
101570 10 07 102576 86 08 102836 107 12 103029 15 19
101572 10 07 102576 91 09 102837 113 21 103033 25 01
101573 10 07 102583 91 21 102840 111 02 103036 25 05
101574 10 07 102587 83 07 102840 113 12 103077 157 01
101666 10 07 102587 91 20 102861 37 15 103078 157 03
101667 33 05 102595 91 18 102861 49 00 103083 157 06
101712 43 04 102601 91 37 102863 93 22 103084 157 02
101717 17 17 102614 91 04 102872 31 26 103088 53 07
101719 21 19 102615 91 06 102874 21 01 103089 13 01
101727 15 13 102617 88 01 102880 13 09 103099 23 23
101730 15 15 102618 88 02 102881 13 13 103099 23 27
101792 21 00 102619 88 03 102882 13 25 103099 23 28
101818 49 00 102620 88 04 102882 23 17 103100 23 29
101877 23 34 102621 88 05 102886 21 21 103100 23 30
101877 27 10 102622 88 06 102893 91 22 103100 23 31
101879 35 01 102623 88 07 102901 21 12 103100 23 32
101882 27 09 102624 88 09 102907 25 01 103101 43 00
101882 109 01 102625 88 10 102912 17 11 103104 23 00
101882 148 01 102626 88 11 102913 17 09 103104 23 33
101926 53 18 102627 88 12 102925 17 00 103112 153 02
101954 39 03 102628 88 13 102926 49 00 103112 155 02
101956 39 05 102632 88 19 102928 21 15 103113 153 03
101960 39 00 102633 88 20 102944 25 03 103113 155 03
101961 39 00 102634 88 21 102945 25 04 103114 153 05
101962 39 00 102635 88 24 102948 21 20 103114 155 04
101963 39 00 102636 88 24 102949 61 10 103115 153 06
102026 7 06 102637 88 24 102950 79 01 103115 155 05
102027 9 04 102638 88 25 102951 79 02 103116 153 07
102063 51 02 102639 88 26 102952 79 03 103116 155 06
102173 5 04 102646 13 00 102952 79 08 103117 153 10
102174 5 06 102646 23 20 102953 79 04 103117 155 09
102313 107 15 102647 43 00 102954 79 05 103122 153 01
102313 113 17 102649 27 10 102954 79 09 103122 155 01
102313 121 07 102654 57 22 102955 79 06 103130 107 04
102313 123 13 102668 83 22 102956 79 07 103130 142 01
102313 125 09 102668 113 23 102957 79 10 103179 17 00

913228/CP0108 184 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Numerical Index

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

103180 17 00 103318 129 10 103509 151 03 104340 49 24

103192 43 00 103318 131 08 103510 151 02 104341 49 25
103195 29 13 103318 131 10 103511 151 01 104425 57 01
103199 41 13 103319 109 07 103512 151 03 104428 111 10
103199 43 05 103319 113 11 103513 151 00 104428 111 12
103221 23 24 103320 111 14 103514 151 00 104467 181 14
103221 23 25 103320 113 05 103626 49 06 104468 181 08
103221 23 26 103322 83 04 103675 13 00 104469 181 05
103223 37 01 103328 9 17 103862 49 00 104470 181 00
103224 35 18 103329 7 10 103906 181 11 104471 181 04
103229 9 16 103330 99 42 103907 181 13 104472 181 09
103262 117 03 103330 103 05 103908 181 12 104473 181 07
103262 121 01 103330 141 21 103909 181 10 104475 181 06
103262 123 01 103331 99 43 103910 181 00 104476 181 03
103262 125 01 103331 103 06 103911 181 00 104477 181 02
103262 127 01 103331 141 22 103991 35 11 104478 181 01
103262 129 01 103333 99 37 103994 47 07 136305 25 06
103262 131 01 103334 11 04 104024 49 00 136383 37 06
103262 153 00 103359 27 01 104064 45 00 136383 53 01
103263 117 02 103368 35 29 104078 45 03 136443 37 07
103263 121 02 103368 107 16 104127 166 00 136443 53 10
103263 123 02 103368 129 12 104128 105 09 136686 53 15
103263 125 02 103368 131 12 104128 164 00 137498 5 01
103263 127 02 103370 41 10 104129 162 00 137498 53 04
103263 129 02 103371 41 14 104130 158 00 137501 5 02
103263 131 02 103390 88 16 104131 160 00 137501 53 05
103263 155 00 103391 88 17 104244 162 01 137503 25 09
103264 117 01 103392 88 18 104245 158 01 137632 7 04
103264 123 14 103393 91 07 104246 164 01 137634 7 09
103264 127 16 103394 91 03 104247 166 01 137659 53 02
103264 131 20 103395 91 16 104248 160 01 140516 10 05
103264 157 00 103396 91 28 104249 160 06 183629 53 13
103265 23 00 103398 91 25 104250 166 10 184069 7 03
103268 41 04 103399 91 47 104251 158 08 184069 9 06
103270 41 06 103401 91 49 104252 164 10 210018 147 01
103273 41 07 103401 95 50 104258 166 05 650730 21 11
103314 83 08 103402 93 11 104259 162 04 651543 83 15
103315 35 26 103403 153 08 104260 158 04 654028 49 00
103315 121 06 103403 155 07 104260 164 04 L10465 31 10
103315 123 12 103403 157 04 104261 160 03 L120041 53 17
103315 125 06 103404 153 09 104262 166 04 L120047 55 03
103315 127 12 103404 155 08 104263 162 03 L277944 35 06
103315 129 17 103404 157 05 104264 158 03 L400398 179 15
103315 131 19 103413 119 07 104265 164 03 L400425 173 03
103317 107 17 103413 151 00 104266 160 02 L400425 175 03
103317 113 06 103414 47 00 104271 166 03 L400425 177 04
103318 35 27 103424 47 00 104272 162 05 L400929 171 05
103318 107 18 103425 119 08 104273 158 05 L40805 51 16
103318 121 08 103441 5 07 104273 164 05 L41179 49 02
103318 123 11 103475 47 05 104274 160 04 L41261 27 02
103318 125 05 103476 47 06 104274 166 06 L41847 39 06
103318 125 08 103479 47 01 104275 162 08 L41847 41 02
103318 125 11 103482 47 02 104277 158 10 L41848 23 18
103318 127 08 103505 119 04 104277 166 11 L41854 37 05
103318 127 11 103505 129 16 104278 164 09 L441010 35 24
103318 127 17 103505 131 16 104279 160 08 L443011 115 01
103318 129 08 103508 151 01 104303 37 02 L443011 137 04

PRINTED IN U.S.A. 185 913228/CP0108

Numerical Index RS5-34 Telescopic Handler

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

L443011 139 16 L500021 15 05 L500457 93 01 L500489 95 06

L443011 141 04 L500021 19 04 L500457 97 01 L500490 91 15
L443022 139 02 L500021 21 08 L500458 97 02 L500490 95 09
L444001 57 24 L500022 13 06 L500459 93 02 L500491 95 10
L444001 115 13 L500024 15 08 L500459 97 02 L500492 91 19
L444002 35 30 L500025 15 14 L500460 93 02 L500492 95 11
L444004 109 17 L500027 15 18 L500460 97 02 L500493 95 12
L444005 111 09 L500028 15 17 L500461 93 02 L500494 91 34
L444007 57 03 L500036 21 16 L500461 97 02 L500494 95 13
L444008 115 07 L500042 15 04 L500462 93 02 L500495 95 14
L444010 115 28 L500042 19 05 L500462 97 02 L500496 83 19
L444010 139 15 L500042 21 07 L500463 93 03 L500496 88 23
L444012 119 06 L500057 13 04 L500463 97 03 L500496 89 12
L444070 57 01 L500099 17 08 L500464 93 05 L500496 91 23
L445001 51 06 L500111 15 07 L500464 97 05 L500496 95 15
L445002 135 12 L500127 145 18 L500465 93 06 L500497 95 17
L445002 137 11 L500129 145 16 L500465 97 06 L500498 91 32
L445002 179 09 L500130 145 04 L500466 93 07 L500498 95 18
L445003 115 26 L500132 145 04 L500466 97 07 L500499 91 29
L445004 107 21 L500134 145 03 L500467 93 08 L500499 95 19
L445004 109 06 L500135 145 14 L500467 97 08 L500500 91 33
L445005 37 13 L500143 25 10 L500468 93 09 L500500 95 20
L445005 113 20 L500161 25 00 L500468 97 09 L500501 91 30
L445012 107 10 L500163 25 08 L500469 93 10 L500501 95 21
L445013 137 26 L500214 179 02 L500469 97 10 L500502 95 22
L445014 107 01 L500215 175 01 L500470 97 11 L500503 95 23
L446017 113 09 L500222 179 00 L500471 93 12 L500504 91 31
L446017 179 27 L500273 73 03 L500471 97 12 L500504 95 26
L446020 51 07 L500273 75 03 L500472 93 13 L500505 91 35
L446020 57 14 L500274 77 01 L500472 97 13 L500505 95 27
L446025 35 21 L500300 145 21 L500473 93 14 L500506 91 36
L446025 37 12 L500339 43 07 L500473 97 14 L500506 95 28
L446026 115 06 L500367 168 04 L500474 93 15 L500507 95 29
L446026 135 06 L500367 169 09 L500474 97 15 L500508 91 38
L446026 137 07 L500368 142 03 L500475 93 16 L500508 95 30
L446044 111 04 L500370 168 06 L500476 93 17 L500509 91 41
L446048 35 31 L500373 182 01 L500476 97 17 L500509 95 32
L446049 121 04 L500407 65 07 L500477 93 17 L500510 91 42
L447005 49 18 L500407 73 23 L500477 97 17 L500510 95 33
L44859 31 11 L500408 73 22 L500478 93 18 L500511 91 44
L45049 83 01 L500408 73 24 L500478 97 18 L500511 95 34
L45934 51 13 L500409 65 16 L500479 97 22 L500512 91 45
L46865 107 03 L500410 73 01 L500480 65 08 L500512 95 35
L46865 142 02 L500411 73 02 L500480 93 23 L500513 91 46
L47212 51 24 L500412 73 04 L500480 97 23 L500513 95 36
L47263 171 06 L500413 73 19 L500481 93 24 L500515 91 48
L47265 171 07 L500414 73 20 L500481 97 24 L500515 95 39
L48179 31 07 L500451 86 02 L500483 91 01 L500516 95 40
L48868A 164 08 L500451 87 02 L500483 95 01 L500517 91 51
L48868A 166 09 L500452 87 03 L500484 91 02 L500517 95 41
L48868A 167 10 L500453 87 04 L500484 95 02 L500518 91 50
L49327 35 22 L500454 86 05 L500485 95 03 L500518 95 42
L500001 17 02 L500454 87 05 L500486 95 04 L500519 91 40
L500004 17 18 L500455 87 06 L500487 91 05 L500519 95 43
L500019 15 16 L500455 95 38 L500488 91 10 L500521 95 45
L500020 13 07 L500456 87 08 L500488 95 05 L500522 91 43
L500021 13 08 L500456 95 24 L500489 91 14 L500522 95 46

913228/CP0108 186 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Numerical Index

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

L500523 91 26 L50084 83 13 L50875 175 07 L62842 107 07

L500523 95 49 L50084 133 16 L50952 49 00 L62842 109 02
L500524 91 26 L50086 99 35 L50952 57 08 L62842 119 05
L500524 95 49 L50086 103 21 L510041 29 03 L62926 31 23
L500525 91 26 L500943 84 02 L510041 31 20 L630001 39 03
L500525 95 49 L500943 85 02 L51099 53 14 L630003 39 04
L500527 88 14 L500952 145 06 L51591 111 13 L630004 23 00
L500527 89 01 L500953 145 07 L51591 113 22 L630004 39 02
L500528 89 02 L500954 145 02 L51781 53 08 L63005 103 02
L500529 89 03 L500955 145 11 L51968 177 13 L63006 101 02
L500531 89 05 L500956 145 08 L520004 101 05 L63012 167 00
L500532 89 06 L500957 145 12 L520007 49 13 L63013 105 08
L500533 89 07 L500958 145 17 L520007 57 19 L63013 165 00
L500534 89 08 L500959 145 13 L520019 35 20 L63014 163 00
L500535 89 09 L500960 145 20 L520019 179 13 L63015 159 00
L500536 88 15 L500961 145 15 L54002 13 00 L63016 133 11
L500536 89 10 L500968 148 01 L561004 31 00 L63016 158 02
L500537 89 13 L50101 27 04 L580005 31 13 L63016 159 02
L500538 89 14 L50150 31 19 L580009 49 23 L63017 99 16
L500539 84 02 L50151 31 06 L60253 115 14 L63018 105 07
L500539 85 02 L50151 51 14 L60253 133 17 L63099 99 21
L500540 84 02 L50152 99 09 L60451 179 23 L63131 99 13
L500540 85 02 L50152 179 26 L60492 55 09 L63143 175 18
L500541 84 03 L50157 133 15 L60653 113 02 L63143 177 11
L500541 85 03 L50184 107 05 L60653 123 05 L63153 101 11
L500542 83 20 L50196 29 04 L60653 127 05 L63156 103 15
L500543 83 16 L50201 83 09 L60653 129 05 L63156 103 18
L500544 83 17 L50205 177 06 L60653 131 05 L63157 101 10
L500546 84 01 L50207 101 04 L60961 171 08 L63158 101 09
L500546 85 01 L50283 107 06 L60986 111 00 L63166 99 34
L500554 95 44 L50286 35 19 L61001 171 02 L63166 103 19
L500555 95 48 L50286 37 11 L61017 171 03 L63167 99 33
L50056 29 09 L50286 179 12 L61021 55 14 L63167 103 20
L500606 43 09 L50305 49 09 L61287 177 06 L63168 103 17
L500668 163 07 L50319 49 10 L61411 179 24 L63169 99 11
L500668 167 07 L50319 57 16 L61620 35 23 L63173 99 12
L500694 17 19 L50333 175 04 L61699 101 26 L63199 161 00
L500695 17 04 L50371 179 21 L61699 103 04 L63215 35 08
L500696 17 03 L50380 99 08 L61708 99 23 L63222 83 01
L500697 17 15 L50380 179 25 L61708 101 27 L63230 31 01
L500700 17 12 L50491 99 07 L61709 99 28 L63239 101 25
L500701 17 06 L50517 29 05 L61709 101 21 L63248 39 05
L500702 17 11 L50519 175 02 L61709 103 09 L63272 105 06
L500706 17 13 L50562 175 17 L61709 177 09 L63272 137 14
L500707 17 10 L50607 31 12 L61867 37 04 L63272 139 19
L500708 17 05 L50612 99 10 L62583 9 08 L63273 137 18
L500709 17 14 L50612 103 16 L62715 99 24 L63273 139 04
L500711 17 16 L50628 31 09 L62715 101 16 L63274 105 04
L500718 17 01 L50646 105 12 L62715 103 11 L63274 135 03
L500719 17 07 L50677 51 18 L62731 101 28 L63276 133 04
L50072 31 14 L50704 57 18 L62732 101 29 L63309 35 25
L500747 43 00 L50705 55 16 L62733 99 29 L63309 107 02
L500748 43 00 L50712 83 10 L62733 101 18 L63319 173 02
L500761 168 03 L50712 133 14 L62734 101 17 L63319 177 02
L500762 168 02 L50727 57 06 L62734 103 10 L63320 173 02
L500763 168 01 L50815 179 16 L62741 111 05 L63320 177 02
L500771 97 16 L50841 179 05 L62840 143 07 L63334 39 01

PRINTED IN U.S.A. 187 913228/CP0108

Numerical Index RS5-34 Telescopic Handler

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

L63344 177 12 L63968 177 15 L66456 105 09 L68352 139 12

L63356 51 03 L63969 177 18 L66606 49 20 L68356 139 08
L63363 31 21 L64124 49 11 L66613 7 08 L68358 99 19
L63363 111 07 L64124 57 21 L66613 105 00 L68374 137 20
L63363 149 00 L64143 99 31 L66709 51 22 L68374 137 21
L63381 107 19 L64175 160 07 L66780 103 14 L68376 141 13
L63381 125 12 L64175 161 09 L66782 103 13 L68376- 141 14
L63381 127 15 L64175 169 10 L66783 103 12 L68496 29 12
L63381 129 11 L64197 49 12 L66918 175 15 L68531 57 17
L63381 131 11 L64197 57 20 L66919 175 05 L68533 57 25
L63383 109 12 L64275 117 09 L66921 175 08 L68539 51 25
L63383 113 16 L64294 179 03 L66931 175 06 L68544 55 08
L63384 107 13 L64367 133 02 L66946 179 20 L68562 57 23
L63384 109 14 L64367 158 06 L66948 175 08 L68563 57 12
L63387 109 13 L64367 159 08 L66949 175 20 L68571 49 03
L63387 113 10 L64367 177 21 L66950 175 19 L68580 51 20
L63399 51 09 L64437 49 04 L66965 57 05 L68591 49 16
L63399 57 15 L64524 109 16 L67499 83 01 L68592 49 15
L63406 35 07 L64572 55 15 L67502 83 01 L68595 49 08
L63406 51 08 L64660 107 09 L67504 83 01 L68596 49 07
L63406 57 02 L64660 179 04 L67589 51 17 L68604 49 19
L63406 107 20 L64663 31 00 L67657 53 16 L68613 49 17
L63406 115 21 L64663 49 22 L67718 9 09 L68619 37 14
L63406 115 22 L64664 31 00 L67719 9 09 L68619 49 00
L63407 115 09 L64664 49 21 L67720 9 09 L68641 31 24
L63420 31 00 L64764 55 04 L67721 9 09 L68694 115 12
L63420 49 00 L64821 55 10 L67722 9 09 L68694 117 08
L63474 9 12 L64863 53 09 L67723 9 09 L68694 145 00
L63545 25 02 L65097 105 13 L67751 51 21 L68695 101 14
L63564 111 08 L65098 105 14 L67756 41 03 L68696 101 24
L63593 169 02 L65142 35 16 L67756 55 12 L68697 101 08
L63594 169 00 L65144 35 17 L68003 162 06 L68711 147 00
L63594 177 17 L65273 141 20 L68003 164 07 L68744 101 01
L63610 23 16 L65273 177 10 L68003 166 07 L68762 103 01
L63629 31 22 L65338 179 19 L68006 99 15 L68772 27 06
L63631 10 09 L65570 49 00 L68039 137 25 L68778 115 25
L63632 10 08 L65583 49 00 L68039 141 12 L68778 141 05
L63634 13 26 L65638 99 06 L68171 41 11 L68778 145 00
L63640 23 01 L65640 99 03 L68182 41 12 L68794 133 06
L63651 111 03 L65926 10 03 L68185 41 09 L68802 107 11
L63651 111 06 L65927 7 02 L68186 41 08 L68804 119 01
L63665 51 21 L65927 9 02 L68200 41 05 L68805 35 28
L63694 99 22 L65928 7 07 L68239 137 02 L68805 109 15
L63694 139 17 L65928 9 14 L68239 137 03 L68807 115 17
L63715 103 25 L65930 10 02 L68239 141 02 L68807 135 08
L63715 137 24 L65932 7 05 L68239 141 03 L68808 115 18
L63715 141 11 L65932 9 11 L68282 27 07 L68808 135 09
L63715 175 09 L65933 9 03 L68295 10 04 L68809 115 19
L63716 103 24 L65937 9 05 L68331 171 09 L68809 115 20
L63716 141 18 L65942 7 11 L68337 168 00 L68809 133 07
L63716 175 11 L66011 13 22 L68337 175 16 L68810 117 06
L63756 35 10 L66119 51 12 L68348 99 20 L68810 117 07
L63813 13 00 L66139 113 01 L68348 139 07 L68810 119 10
L63813 33 00 L66162 111 00 L68350 99 01 L68811 117 05
L63894 43 00 L66265 51 23 L68351 137 01 L68814 115 02
L63952 177 20 L66406 171 04 L68351 141 01 L68814 115 03
L63957 105 15 L66437 23 02 L68352 139 11 L68814 139 13

913228/CP0108 188 PRINTED IN U.S.A.

RS5-34 Telescopic Handler Numerical Index

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

L68814 139 14 L69936 109 10 L76020 51 19 L98237 75 09

L68815 115 05 L69936 109 11 L76084 51 01 L98238 71 08
L68815 115 23 L69936 113 14 L82358 179 10 L98238 73 13
L68815 137 05 L69936 113 15 L94824 61 02 L98238 75 08
L68815 141 07 L70039 43 01 L96053 77 05 L98239 71 15
L68816 115 04 L70040 99 38 L96838 164 08 L98239 73 12
L68816 115 24 L70069 13 29 L96838 166 09 L98239 75 21
L68816 137 06 L70069 21 00 L96838 167 10 L98239 75 23
L68816 141 08 L70075 23 21 L97489 5 03 L98240 71 14
L68817 115 08 L70075 23 22 L97489 35 03 L98240 73 11
L68817 137 09 L70146 39 09 L97525 63 10 L98240 75 20
L68831 182 01 L70200 43 06 L97526 63 11 L98240 75 22
L68849 83 22 L70201 29 07 L97889 158 09 L98241 71 13
L68849 113 24 L70212 29 06 L97889 159 11 L98241 73 18
L68866 41 01 L70241 43 00 L97889 160 07 L98241 75 14
L68875 83 01 L70305 7 01 L97889 161 09 L98242 71 12
L68876 83 14 L70305 9 01 L97889 165 10 L98242 73 17
L68876 133 13 L70306 10 01 L97889 169 10 L98242 75 13
L68878 83 11 L70307 10 12 L98176 61 09 L98244 71 10
L68878 133 12 L70428 111 11 L98184 61 22 L98244 73 15
L68881 133 09 L70428 113 19 L98185 61 08 L98244 75 10
L68882 133 10 L70462 99 00 L98189 63 09 L98246 71 06
L68884 83 01 L70495 158 09 L98191 63 13 L98246 73 09
L69166 49 05 L70495 159 11 L98194 63 07 L98246 75 06
L69297 13 23 L70495 165 10 L98196 63 16 L98247 71 07
L69595 27 03 L70629 49 00 L98197 63 03 L98247 73 10
L69718 49 14 L70634 29 02 L98198 63 15 L98247 75 07
L69734 83 12 L70701 43 08 L98199 63 12 L98248 71 01
L69734 95 37 L71074 23 06 L98200 63 06 L98249 71 18
L69747 109 05 L71075 23 03 L98201 63 04 L98250 71 04
L69747 113 18 L71076 23 13 L98202 63 05 L98250 73 07
L69747 147 00 L71076 23 14 L98203 63 01 L98250 75 04
L69902 119 09 L71077 23 09 L98204 63 02 L98251 71 02
L69903 121 05 L71081 23 12 L98205 63 14 L98252 71 03
L69903 123 08 L71081 49 00 L98211 66 05 L98253 65 02
L69903 123 10 L71082 23 07 L98212 66 07 L98253 65 05
L69903 125 07 L71084 23 08 L98214 67 10 L98253 65 10
L69903 127 10 L71086 23 05 L98215 67 08 L98253 65 12
L69904 123 07 L71305 13 00 L98216 67 09 L98253 71 19
L69904 123 09 L71350 171 01 L98217 61 15 L98253 75 24
L69904 127 07 L71553 45 01 L98218 61 14 L98254 65 03
L69904 127 09 L71554 11 01 L98219 67 12 L98254 65 06
L69904 129 07 L71555 11 02 L98220 67 01 L98254 71 20
L69904 131 07 L71595 43 10 L98224 67 06 L98255 71 22
L69904 131 17 L71691 23 10 L98226 61 13 L98257 73 06
L69904 131 18 L71691 45 00 L98228 69 02 L98257 75 19
L69905 119 02 L71700 11 03 L98229 69 01 L98258 73 05
L69905 119 03 L71725 44 03 L98230 69 04 L98260 75 17
L69905 129 13 L71726 44 02 L98231 69 03 L98264 77 06
L69905 129 14 L71729 44 00 L98232 69 05 L98266 77 07
L69905 131 13 L71732 44 05 L98233 69 08 L98268 77 04
L69905 131 14 L71748 99 36 L98235 71 17 L98272 75 18
L69928 113 04 L71748 103 03 L98235 75 16 L98274 75 01
L69928 113 07 L71748 141 16 L98236 71 16 L98275 75 02
L69928 113 13 L71750 44 04 L98236 75 15 L98276 65 11
L69930 107 08 L71751 45 05 L98237 71 09 L98276 75 26
L69930 109 03 L71752 45 04 L98237 73 14 L98277 65 13

PRINTED IN U.S.A. 189 913228/CP0108

Numerical Index RS5-34 Telescopic Handler

Part Page Ref. Part Page Ref. Part Page Ref. Part Page Ref.
No. No. No. No. No. No. No. No. No. No. No. No.

L98277 75 27 L98515 167 05 L98958 81 10 L99284 59 06

L98278 77 09 L98516 167 06 L98961 71 11 L99284 61 18
L98279 77 08 L98517 167 11 L98961 73 16 L99285 59 08
L98281 77 03 L98518 161 01 L98961 75 11 L99285 61 32
L98282 77 02 L98519 161 08 L98962 71 21 L99286 59 01
L98284 65 14 L98520 161 02 L98967 75 12 L99287 61 29
L98291 81 01 L98521 161 10 L98968 65 09 L99288 61 31
L98292 81 02 L98522 161 04 L98968 75 25 L99294 61 33
L98293 81 08 L98523 161 05 L98978 5 05 L99295 61 34
L98294 81 03 L98524 163 01 L99013 61 04 L99296 61 35
L98295 81 04 L98527 163 10 L99018 61 19 L99312 61 30
L98298 81 06 L98528 163 05 L99020 67 15 L99313 63 08
L98300 81 11 L98529 163 06 L99023 67 14 L99405 159 07
L98301 81 13 L98533 149 02 L99025 67 13 L99405 161 06
L98302 81 12 L98534 149 02 L99027 67 16 L99405 165 07
L98303 81 09 L98536 149 05 L99029 59 11 L99425 27 06
L98304 81 05 L98537 149 07 L99029 59 13 L99434 55 07
L98307 81 07 L98545 165 01 L99029 61 21 L99454 29 01
L98316 80 03 L98547 159 03 L99029 67 17 L99696 73 21
L98317 80 06 L98547 165 04 L99030 80 05 L99785 80 04
L98318 87 07 L98548 165 11 L99031 69 06 L99866 165 05
L98318 95 25 L98550 159 06 L99032 69 07 L99908 143 05
L98355 83 18 L98550 165 06 L99038 75 05 L99908 146 02
L98355 91 24 L98551 165 12 L99045 61 20 L99909 146 03
L98355 95 16 L98558 167 12 L99163 35 09 L99910 143 06
L98368 88 08 L98700 105 01 L99163 37 03 L99910 146 04
L98371 91 13 L98734 61 27 L99168 169 01 L99911 143 06
L98371 95 07 L98735 61 28 L99169 169 03 L99911 146 03
L98372 91 11 L98865 31 24 L99170 169 12 L99911 146 04
L98372 95 07 L98887 145 18 L99171 169 05 L99925 143 03
L98373 86 09 L98891 145 01 L99174 169 06 L99927 143 03
L98373 91 12 L98895 145 05 L99175 169 07 L99951 83 03
L98373 95 47 L98895 145 19 L99182 57 10 L99983 25 05
L98380 93 04 L98896 145 09 L99184 5 08 P471370 113 03
L98380 97 04 L98897 145 09 L99184 57 04 P471997 143 07
L98394 97 21 L98898 145 09 L99184 67 02
L98395 93 20 L98899 145 10 L99192 173 01
L98395 97 20 L98921 169 06 L99193 173 01
L98396 93 19 L98926 61 07 L99224 177 01
L98396 97 19 L98927 61 06 L99225 177 01
L98404 93 17 L98932 61 12 L99237 179 01
L98404 97 17 L98935 61 11 L99246 59 04
L98406 93 17 L98938 59 14 L99246 61 16
L98406 97 17 L98942 66 06 L99246 61 24
L98417 86 01 L98943 66 04 L99249 59 15
L98417 87 01 L98944 66 03 L99251 61 03
L98417 91 39 L98945 66 01 L99253 61 05
L98417 95 31 L98947 66 02 L99260 59 09
L98430 88 22 L98948 67 11 L99260 59 12
L98430 89 11 L98949 67 07 L99261 59 10
L98503 159 01 L98950 67 04 L99262 59 07
L98506 159 12 L98951 67 05 L99262 61 25
L98507 159 05 L98953 67 03 L99270 61 26
L98509 159 10 L98954 67 00 L99274 61 23
L98511 167 01 L98955 65 15 L99278 71 05
L98513 163 04 L98956 81 14 L99279 73 08
L98513 167 04 L98957 81 15 L99284 59 03

913228/CP0108 190 PRINTED IN U.S.A.

 Torque Specifications
Use these torque values when tightening hardware (excluding: locknuts and self-tapping, thread-forming and metal screws)
unless otherwise specified.

Unified National Grade 2 Grade 5 Grade 8

Thread Dry Lubed Dry Lubed Dry Lubed
8-32 19* 14* 30* 22* 41* 31*
8-36 20* 15* 31* 23* 43* 32*
10-24 27* 21* 43* 32* 60* 45*
10-32 31* 23* 49* 36* 68* 51*
1/4-20 66* 50* 9 75* 12 9
1/4-28 76* 56* 10 86* 14 10
5/16-18 11 9 17 13 25 18
5/16-24 12 9 19 14 25 20
3/8-16 20 15 30 23 45 35
3/8-24 23 17 35 25 50 35
7/16-14 32 24 50 35 70 55
7/16-20 36 27 55 40 80 60
1/2-13 35 35 75 55 110 80
1/2-20 40 40 90 65 120 90
9/16-12 55 55 110 80 150 110
9/16-18 60 60 120 90 170 130
5/8-11 75 75 150 110 220 170
5/8-18 85 85 180 130 240 180
3/4-10 130 130 260 200 380 280
3/4-16 150 150 300 220 420 320
7/8-9 125 125 430 320 600 460
7/8-14 140 140 470 360 660 500
1-8 190 190 640 480 900 680
1-14 210 210 710 530 1000 740

Metric Course Grade 8.8 Grade 10.9 Grade 12.9

Thread
Dry Lubed Dry Lubed Dry Lubed
M6-1 8 6 11 7 13.5 10*
24M8-1.25 19 14 27 20 32.5 24*
M10-1.5 37.5 28 53 39 64 47
M12-1.75 65 48 91.5 67.5 111.5 82
M14-2 103.5 76.5 145.5 108 176.5 131
M16-2 158.5 117.5 223.5 165.5 271 200

* All torque values are in lb.-ft. except those marked with an *, which are in lb.-in.
For metric torque value (Nm), muiltiply lb.-ft. x 1.355 or lb.-in. value x 0.113.
 GEHL Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A

www.gehl.com

913228/CP0108 © 2008 Gehl Company. All rights reserved. PRINTED IN U.S.A.