Pioneer DEH-P6200BT
Uploaded by
sir FisherPioneer DEH-P6200BT
Uploaded by
sir FisherORDER NO.
CRT4526
DEH-P6200BT/XSUC
CD RECEIVER
DEH-P6200BT /XSUC
DEH-6250BT/XSES
CD RDS RECEIVER
DEH-6200BT/XSEW5
This service manual should be used together with the following manual(s):
Model No. Order No. Mech. Module Remarks
CX-3269 CRT4488 S11STD-DOUT CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
For details, refer to "Important Check Points for Good Servicing".
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2010
K-ZZZ FEB. 2010 Printed in Japan
1 2 3 4
SAFETY INFORMATION
CAUTION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or
other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
B
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists
of components, a symbol is used to indicate that a specific component shall be replaced only
by the component specified in that documentation for safety reasons, the following symbol shall
be used:
- Safety Precautions for those who Service this Unit.
When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable
results.
C Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION
CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
E
Laser diode characteristics
Wave length : 785 nm to 814 nm
Maximum output : 1 190 µW(Emitting period : unlimited)
Additional Laser Caution
Transistors Q101 in PCB drive the laser diodes.
When Q101 is shorted between their terminals, the laser diodes will radiate beam.
If the top cover is removed with no disc loaded while such short-circuit is continued,
the naked eyes may be exposed to the laser beam.
2 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol. A
Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise. B
3 Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
C
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary. D
a Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
3. Lubricants, Glues, and Replacement parts
E
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
DEH-P6200BT/XSUC
5 6 7 8
3
1 2 3 4
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 5
2. SPECIFICATIONS ............................................................................................................................................ 6
2.1 SPECIFICATIONS ..................................................................................................................................... 6
2.2 DISC/CONTENT FORMAT ........................................................................................................................ 9
2.3 PANEL FACILITIES.................................................................................................................................. 10
2.4 CONNECTION DIAGRAM ....................................................................................................................... 17
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 22
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 22
3.2 PCB LOCATIONS .................................................................................................................................... 22
3.3 JIGS LIST ................................................................................................................................................ 23
3.4 CLEANING............................................................................................................................................... 23
B 4. BLOCK DIAGRAM.......................................................................................................................................... 24
5. DIAGNOSIS.................................................................................................................................................... 27
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 27
5.2 ERROR CODE LIST ................................................................................................................................ 28
5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 31
6. SERVICE MODE ............................................................................................................................................ 32
6.1 DISPLAY TEST MODE ............................................................................................................................ 32
6.2 CD TEST MODE ...................................................................................................................................... 33
7. DISASSEMBLY .............................................................................................................................................. 34
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 41
8.1 CD ADJUSTMENT................................................................................................................................... 41
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 42
C
8.3 PCL OUTPUT CONFIRMATION(UC,ES) ................................................................................................ 44
9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 45
9.1 PACKING ................................................................................................................................................. 45
9.2 EXTERIOR (1) ......................................................................................................................................... 48
9.3 EXTERIOR (2) ......................................................................................................................................... 50
9.4 CD MECHANISM MODULE..................................................................................................................... 52
10. SCHEMATIC DIAGRAM............................................................................................................................... 54
10.1 TUNER AMP PCB 1/2 and BT ANT PCB (GUIDE PAGE)..................................................................... 54
10.2 TUNER AMP PCB 2/2 [MEDIA uCOM BLOCK] (GUIDE PAGE) ........................................................... 60
10.3 CD CORE UNIT (S11STD-DOUT) ......................................................................................................... 66
10.4 KEYBOARD ASSY ................................................................................................................................ 68
D 10.5 WAVEFORMS ........................................................................................................................................ 70
11. PCB CONNECTION DIAGRAM.................................................................................................................... 72
11.1 TUNER AMP PCB.................................................................................................................................. 72
11.2 BT ANT PCB .......................................................................................................................................... 76
11.3 CD CORE UNIT(S11STD-DOUT) .......................................................................................................... 78
11.4 KEYBOARD ASSY................................................................................................................................. 80
12. ELECTRICAL PARTS LIST .......................................................................................................................... 82
4 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations governing the product (safety, radio and noise, and other
regulations), and should keep the safety during servicing by following the safety instructions
described in this manual.
2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors
during power-on mode may damage the ICs inside the unit.
3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment
(shorting-solder) by referring to "the DISASSEMBLY".
4. After replacing the pickup unit, be sure to check the grating.
5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by
electrostatic induction. B
6. On CD Core Unit, actual cable colors and silk print are different.
C
Green Red
White Black
7. When a CD-DA (regular music CD) is played in the CD test mode, its sound quality will be temporarily
deteriorated. The CD will then repeat normal, deteriorated, normal… playback.
This is due to the difference in the playback modes between the normal operation mode and the CD test
mode, and the interval of generating deteriorated mode and the time taken to return to the normal mode
depend on the error of each clock.
D
The time taken to turn to the deteriorated mode is at a minimum around 20 seconds while the time to return
to the normal mode is maximum 40 seconds approximately.
Make sure to check the sound quality in the normal operation mode.
1.2 NOTES ON SOLDERING
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering. E
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts:
Parts numbers of lead-free solder:
F
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.
DEH-P6200BT/XSUC
5 6 7 8
5
1 2 3 4
2. SPECIFICATIONS
2.1 SPECIFICATIONS
A
DEH-P6200BT/XSUC
WMA decoding format ........ Ver. 7,7.1, 8, 9, 10, 11 (2ch
General audio)
Power source ..........................14.4 V DC (10.8 V to 15.1 V (Windows Media Player)
allowable) AAC decoding format...........MPEG-4 AAC (iTunes en-
Grounding system................. Negative type coded only) (.m4a)
Maximum current consumption (Ver. 8.2 and earlier)
...............................................10.0 A WAV signal format ............... Linear PCM & MS ADPCM
Backup current ....................... 5.0 mA or less
Dimensions (W × H × D): USB
B DIN USB standard specification
Chassis .................. 178 mm × 50 mm × 165 ............................................... USB 2.0 full speed
mm Maximum current supply .... 500 mA
(7 in. × 2 in. × 6-1/2 in.) USB Class .............................. MSC (Mass Storage Class)
Nose ....................... 188 mm × 58 mm × 23 mm File system.............................. FAT12, FAT16, FAT32
(7-3/8 in.× 2-1/4 in.× 7/8 in.) MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3
D WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
Chassis .................. 178 mm × 50 mm × 165 audio)
mm (Windows Media Player)
(7 in.× 2 in.× 6-1/2 in.) AAC decoding format...........MPEG-4 AAC (iTunes en-
Nose ....................... 170 mm × 48 mm × 23 mm coded only) (.m4a)
C
(6-3/4 in.× 1-7/8 in.× 7/8 in.) (Ver. 8.2 and earlier)
Weight ..................................... 1.4 kg(3.1 lbs) WAV signal format ................ Linear PCM & MS ADPCM
(Non-compressed)
Audio
Maximum power output ...... 50 W × 4 FM tuner
50 W × 2/4 ohm + 70 W Frequency range .................. 87.9 MHz to 107.9 MHz
× 1/2 ohm (for subwoofer) Usable sensitivity................... 9 dBf(0.8 μV/75 ohm, mono,
Continuous power output .. 22 W × 4 (50 Hz to 15 000 S/N: 30 dB)
Hz, 5 % THD, 4 ohm load, Signal-to-noise ratio.............. 72 dB (IHF-A network)
both channels driven)
Load impedance ................... 4 ohm to 8 × 4 AM tuner
4 ohm to 8 ohm × 2 Frequency range ...................... 530 kHz to 1 710 kHz
D + 2 ohm × 1 Usable sensitivity..................... 25 μV (S/N: 20 dB)
Preout maximum output level Signal-to-noise ratio............... 62 dB (IHF-A network)
.............................................. 4.0 V
Equalizer (5-Band Graphic Equalizer): Bluetooth
Frequency ......................100/315/1.25k/3.15k/8k Hz Version ..................................... Bluetooth 2.0 certified
Gain ................................. ±12 dB Output power ......................... +4 dBm Max.
HPF: (Power class 2)
Frequency ......................50/63/80/100/125 Hz
Slope ............................... –12 dB/oct CEA2006 Specifications
Subwoofer (mono):
Frequency ......................50/63/80/100/125 Hz
E Slope ............................... –18 dB/oct
Gain ................................. +6 dB to –24 dB
Phase .............................. Normal/Reverse
Bass boost:
Gain ................................. +12 dB to 0 dB Power output ........................ 14 W RMS × 4 Channels (4
ohm and 1 % THD+N)
CD player S/N ratio .................................. 91 dBA (reference: 1 W into
System ..................................... Compact disc audio system 4 ohm)
Usable discs ..........................Compact disc
Signal-to-noise ratio............. 94 dB (1 kHz) (IHF-A net-
Note
work)
F
Number of channels ............ 2 (stereo) Specifications and the design are subject to mod-
MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 ifications without notice.
6 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
DEH-6200BT/XSEW5
WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch A
General
Power source .........................14.4 V DC (12.0 V to 14.4 V audio)
allowable) (Windows Media Player)
Grounding system................. Negative type AAC decoding format...........MPEG-4 AAC (iTunes en-
Maximum current consumption coded only) (.m4a)
...............................................10.0 A (Ver. 8.2 and earlier)
Backup current ........................ 3.0 mA or less WAV signal format ................ Linear PCM & MS ADPCM
Dimensions (W × H × D): (Non-compressed)
DIN
Chassis .................. 180 mm × 50 mm × 165 USB
mm USB standard specification
B
Nose ....................... 188 mm × 58 mm × 23 mm ............................................... USB 2.0 full speed
D Maximum current supply .... 500 mA
Chassis .................. 178 mm × 50 mm × 165 USB Class .............................. MSC (Mass Storage Class)
mm File system.............................. FAT12, FAT16, FAT32
Nose ....................... 170 mm × 48 mm × 23 mm MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3
Weight ..................................... 1.4 kg WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
audio)
Audio (Windows Media Player)
Maximum power output ...... 50 W × 4 AAC decoding format...........MPEG-4 AAC (iTunes en-
50 W × 2/4 ohm + 70 W coded only) (.m4a)
× 1/2 ohm (for subwoofer) (Ver. 8.2 and earlier)
C
Continuous power output .. 22 W × 4 (50 Hz to 15 000 WAV signal format ............... Linear PCM & MS ADPCM
Hz, 5 % THD, 4 ohm load, (Non-compressed)
both channels driven)
Load impedance ................... 4 ohm to 8 ohm × 4 FM tuner
4 ohm to 8 ohm × 2 Frequency range .................. 87.5 MHz to 108.0 MHz
+ 2 ohm × 1 Usable sensitivity................... 9 dBf(0.8 μV/75 ohm ,
Preout maximum output level mono,S/N: 30 dB)
.............................................. 2.2 V Signal-to-noise ratio............... 72 dB (IEC-A network)
Equalizer (5-Band Graphic Equalizer):
Frequency ......................100/315/1.25k/3.15k/8k Hz
MW tuner
Gain ................................. ±12 dB D
Frequency range .................... 531 kHz to 1 602 kHz (9 kHz)
HPF:
Usable sensitivity.................... 25 μV (S/N: 20 dB)
Frequency ......................50/63/80/100/125 Hz
Signal-to-noise ratio............... 62 dB (IEC-A network)
Slope ................................–12 dB/oct
Subwoofer (mono):
Frequency ......................50/63/80/100/125 Hz LW tuner
Slope ............................... –18 dB/oct Frequency range .................... 153 kHz to 281 kHz
Gain ................................ +6 dB to – 24 dB Usable sensitivity..................... 28 μV (S/N: 20 dB)
Phase .............................. Normal/Reverse Signal-to-noise ratio................ 62 dB (IEC-A network)
Bass boost:
Gain ................................ +12 dB to 0 dB Bluetooth
Version ..................................... Bluetooth 2.0 certified E
CD player Output power ........................ +4 dBm Max.
System ..................................... Compact disc audio system (Power class 2)
Usable discs .......................... Compact disc
Signal-to-noise ratio............. 94 dB (1 kHz) (IEC-A net-
Note
work)
Number of channels ............ 2 (stereo) Specifications and the design are subject to mod-
MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 ifications without notice.
DEH-P6200BT/XSUC
5 6 7 8
7
1 2 3 4
DEH-6250BT/XSES
A
General WMA decoding format ......... Ver. 7, 7.1, 8, 9, 10, 11 (2ch
Rated power source..............14.4 V DC audio)
(allowable voltage range: (Windows Media Player)
12.0 V to 14.4 V DC) AAC decoding format...........MPEG-4 AAC (iTunes en-
Grounding system................. Negative type coded only) (.m4a)
Maximum current consumption (Ver. 8.2 and earlier)
...............................................10.0 A WAV signal format ................ Linear PCM & MS ADPCM
Backup current ......................5.0 mA or less (Non-compressed)
Dimensions (W × H × D):
DIN USB
Chassis .................. 178 mm × 50 mm × 165 USB standard specification
B
mm ............................................... USB 2.0 full speed
Nose ....................... 188 mm × 58 mm × 23 mm Maximum current supply .... 500 mA
D USB Class .............................. MSC (Mass Storage Class)
Chassis .................. 178 mm × 50 mm × 165 File system.............................. FAT12, FAT16, FAT32
mm MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3
Nose ....................... 170 mm × 48 mm × 23 mm WMA decoding format ........ Ver. 7, 7.1, 8, 9, 10, 11 (2ch
Weight ..................................... 1.4 kg audio)
(Windows Media Player)
Audio AAC decoding format...........MPEG-4 AAC (iTunes en-
Maximum power output ...... 50 W × 4 coded only) (.m4a)
50 W × 2/4 ohm + 70 W (Ver. 8.2 and earlier)
C
× 1/2 ohm (for subwoofer) WAV signal format ................. Linear PCM & MS ADPCM
Continuous power output .. 22 W × 4 (50 Hz to 15 000 (Non-compressed)
Hz, 5 % THD, 4 ohm load,
both channels driven) FM tuner
Load impedance ................... 4 ohm to 8 ohm × 4 Frequency range .................. 87.5 MHz to 108.0 MHz
4 ohm to 8 ohm × 2 Usable sensitivity................... 9 dBf(0.8 μV/75 ohm, mono,
+ 2 ohm × 1 S/N: 30 dB)
Preout maximum output level Signal-to-noise ratio ............. 72 dB (IEC-A network)
.............................................. 2.2 V
Equalizer (5-Band Graphic Equalizer): AM tuner
Frequency .......................100/315/1.25k/3.15k/8k Hz Frequency range .................. 531 kHz to 1 602 kHz (9 kHz)
D
Gain ................................. ±12 dB 530 kHz to 1 640 kHz (10
HPF: kHz)
Frequency ......................50/63/80/100/125 Hz Usable sensitivity................... 25 μV (S/N: 20 dB)
Slope ............................... –12 dB/oct Signal-to-noise ratio ............. 62 dB (IEC-A network)
Subwoofer (mono):
Frequency ......................50/63/80/100/125 Hz Bluetooth
Slope ............................... –18 dB/oct Version ..................................... Bluetooth 2.0 certified
Gain ................................. +6 dB to – 24 dB Output power ......................... +4 dBm Max.
Phase .............................. Normal/Reverse (Power class 2)
Bass boost:
Gain ................................ +12 dB to 0 dB Infrared remote control
E
Wavelength ............................ 940 nm ±50 nm
CD player Output ...................................... typ; 12 mw/sr per Infrared
System ..................................... Compact disc audio system LED
Usable discs ..........................Compact disc
Signal-to-noise ratio............. 94 dB (1 kHz) (IEC-A net- Note
work)
Number of channels ............ 2 (stereo) Specifications and the design are subject to mod-
MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 ifications without notice.
8 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
2.2 DISC/CONTENT FORMAT
The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc.
and any use of such marks by Pioneer Corporation is under license.
Other trademarks and trade names are those of their respective owners.
B
DEH-P6200BT/XSUC
DEH-P6200BT/XSUC
5 6 7 8
9
1 2 3 4
2.3 PANEL FACILITIES
DEH-P6200BT/XSUC
A
Head unit Remote control
123 5 678 j h k
4
B
t
1 l
s
q
p
ihg e b 9 m
f d c a o n
P art P art
1 SRC/OFF a indicator
C
PHONE / /CON-
2 b 6 /PAUSE
NECT Part Operation
3 (list) c 1 to 6 + /– (VO- Press to increase or decrease vo-
j
LUME) lume.
MULTI-CONTROL
4 d 3/
(M.C.) Press to select functions.
Press and hold to recall the initial
5 Disc loading slot e 2/ k FUNC
setting menu when the sources
6 (eject) f 1/iPod are off.
7 USB port g S.Rtrv/SAT Press to display the list depending
D
on the source.
AUX input jack (3.5 Move to perform manual seek
8 h /DISP/SCRL l Thumb pad
mm stereo jack) tuning, fast forward, reverse and
track search controls. Also used
9 Detach button i BAND /ESC
for controlling functions.
• indicator m DIRECT
Press to directly select the desired
Lights up when your cellular phone is con- channel for XM/SIRIUS tuner.
nected via Bluetooth wireless technology. Press to cancel the input number
n CLEAR
when 0 to 9 are used.
E
Press to directly select the desired
CAUTION channel or preset tuning. Buttons
Use an optional Pioneer USB cable (CD-U50E) to 1 to 6 can operate the preset tun-
0 to 9 but-
connect the USB audio player/USB memory as o ing.
tons
any device connected directly to the unit will pro- Press and hold one of the buttons
1 to 6 to preset the desired sta-
trude out from the unit and may be dangerous. tion.
Do not use unauthorized products.
Press to start talking on the
p OFF/H
phone while operating a phone.
While operating the phone, press
q ON/H to end a call or reject an incoming
F
call.
10 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Part Operation Indicator State
Press to quickly lower the volume An upper tier of folder or menu
5
level by about 90%. Press once exists.
r ATT
more to return to the original vo-
lume level. 6 (list) The list function is operated.
Press to operate the prepro- A lower tier of folder or menu ex-
grammed functions for each ists. B
s PGM 7 It flashes when a song/album re-
source. (Refer toUsing the PGM
button) lated to the song currently playing
is selected from iPod.
t AUDIO Press to select an audio function.
8 LOC The local seek tuning is on.
The selected frequency is being
9 (stereo)
broadcasted in stereo.
Folder repeat is on.
a (folder re- When repeat function is on, only
Display indication peat) is displayed.
C
Folder random is on.
2 1 b (folder ran- When random function is on, only
dom) is displayed.
Shuffle or shuffle all function is
(shuf-
c on while the iPod source is being
fle)
selected.
468 a
35 7 9 bc d e fg The sound retriever function is
d (sound re-
on.
Indicator State triever)
Tuner: band and frequency CTRL (control mode) is set to D
e iPod
Built-in CD, USB storage device iPod .
and iPod: elapsed playback time Tagged song is broadcasting.
Main dis-
and text information f (tag) While storing tag data on this
1 play sec-
When an SMS is received by the unit, flashes.
tion
connected cellular phone, a mes-
sage is displayed to notify you of (auto Shows when the automatic an-
g
the reception. answer) swering function is on.
The disc (track) artist name is dis-
played.
2 (artist)
Artist search refinement on the
iPod browsing function is in use. E
The disc (album) name is dis-
played.
3 (disc)
Album search refinement on the
iPod browsing function is in use.
The track (song) name is dis-
played.
A playable audio file has been se-
4 (song)
lected while operating the list.
Song search refinement on the
iPod browsing function is in use. F
DEH-P6200BT/XSUC
5 6 7 8
11
1 2 3 4
DEH-6200BT/XSEW5
A
Head unit Optional remote control
123 5 678 The remote control CD-SR110 is sold sepa-
4 rately.
k
B
n l
m
o
jih f d b 9 j 1
g e c a
P art P art
Part Operation
1 SRC/ OFF b 6 / PAUSE
Press to display the phone menu.
C PHONE / / CON- Press and hold to display the con-
2 c 1 to 6 k PHONE nection menu.
NECT
While operating a phone, press to
3 (list) d 4 / S.Rtrv change the source.
MULTI-CONTROL While operating the phone, press
4 e 3/
(M.C.) l to end a call or reject an incoming
call.
5 Disc loading slot f 2/
Press to perform manual seek
6 (eject) g 1/iPod
tuning, fast forward, reverse and
7 USB port h / DISP/ SCRL m / / / track search controls.
Also used for controlling func-
D AUX input jack (3.5
8 i TA/NEWS tions.
mm stereo jack)
Press to start talking on the
9 Detach button j BAND / ESC n
phone while operating a phone.
a indicator Press to increase or decrease vo-
o VOLUME
lume.
• indicator
Lights up when your cellular phone is con-
nected via Bluetooth wireless technology.
Display indication
E
CAUTION
Use an optional Pioneer USB cable (CD-U50E) to 2 1
connect the USB audio player/USB memory as
any device connected directly to the unit will pro-
trude out from the unit and may be dangerous.
Do not use unauthorized products.
468 a c
35 7 9 b de f g h
12 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Indicator State Indicator State
Tuner: band and frequency
The sound retriever function is
Built-in CD, USB storage device f (sound re-
on.
and iPod: elapsed playback time triever)
Main dis-
and text information
1 play sec- CTRL (control mode) is set to
When an SMS is received by the g iPod
tion iPod .
connected cellular phone, a mes-
B
sage is displayed to notify you of (auto Shows when the automatic an-
the reception. h
answer) swering function is on.
The disc (track) artist name is dis-
played.
2 (artist)
Artist search refinement on the
iPod browsing function is in use.
The disc (album) name is dis-
played.
3 (disc)
Album search refinement on the
iPod browsing function is in use.
C
The track (song) name is dis-
played.
A playable audio file has been se-
4 (song)
lected while operating the list.
Song search refinement on the
iPod browsing function is in use.
An upper tier of folder or menu
5
exists.
6 (list) The list function is operated.
A lower tier of folder or menu ex- D
ists.
7 It flashes when a song/album re-
lated to the song currently playing
is selected from iPod.
8 LOC The local seek tuning is on.
TA (traffic announcement stand-
9 TA
by) function is on.
a TP A TP station is tuned in.
The selected frequency is being E
b (stereo)
broadcasted in stereo.
Folder repeat is on.
c (folder re- When repeat function is on, only
peat) is displayed.
Folder random is on.
d (folder ran- When random function is on, only
dom) is displayed.
Shuffle or shuffle all function is
(shuf-
e on while the iPod source is being
fle) F
selected.
DEH-P6200BT/XSUC
5 6 7 8
13
1 2 3 4
DEH-6250BT/XSES
A
Head unit Remote control
123 5 678 j
4
B
i k
q l
p m
ihg e b 9 1 n
f d c a o
P art P art
1 SRC/OFF a indicator Part Operation
C PHONE/ /CON-
2 b 6 /PAUSE Press to increase or decrease vo-
NECT j VOLUME
lume.
3 (list) c 1 to 6 Press to mute. Press again to un-
k MUTE
MULTI-CONTROL mute.
4 d 3/
(M.C.) Press to perform manual seek
5 Disc loading slot e 2/ tuning, fast forward, reverse and
l / / / track search controls.
6 (eject) f 1/iPod Also used for controlling func-
tions.
7 USB port g /DISP/SCRL
D m AUDIO Press to select an audio function.
AUX input jack (3.5
8 h S.Rtrv/DISP OFF
mm stereo jack) Press to select different displays.
n DISP/SCRL Press and hold to scroll through
9 Detach button i BAND/ESC
the text information.
• indicator Press to pause or resume play-
o
back.
Lights up when your cellular phone is con-
nected via Bluetooth wireless technology. Press to select functions.
Press and hold to recall the initial
p FUNCTION
setting menu when the sources
are off.
E
CAUTION
Use an optional Pioneer USB cable (CD-U50E) to Press to display the track title,
connect the USB audio player/USB memory as folder, or file list depending on the
LIST/
q source.
any device connected directly to the unit will pro- ENTER
While in the operating menu,
trude out from the unit and may be dangerous. press to control functions.
Do not use unauthorized products.
14 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Display indication Indicator State
Folder random is on.
2 1 b (folder ran- When random function is on, only
dom) is displayed.
Shuffle or shuffle all function is
(shuf-
c on while the iPod source is being
fle)
468 a selected. B
35 7 9 bc d e f
The sound retriever function is
d (sound re-
on.
Indicator State triever)
Tuner: band and frequency CTRL (control mode) is set to
e iPod
Built-in CD, USB storage device iPod .
and iPod: elapsed playback time
Main dis- (auto Shows when the automatic an-
and text information f
1 play sec- answer) swering function is on.
When an SMS is received by the
tion
connected cellular phone, a mes-
sage is displayed to notify you of C
the reception.
The disc (track) artist name is dis-
played.
2 (artist)
Artist search refinement on the
iPod browsing function is in use.
The disc (album) name is dis-
played.
3 (disc)
Album search refinement on the
iPod browsing function is in use.
The track (song) name is dis- D
played.
A playable audio file has been se-
4 (song)
lected while operating the list.
Song search refinement on the
iPod browsing function is in use.
An upper tier of folder or menu
5
exists.
6 (list) The list function is operated.
A lower tier of folder or menu ex-
E
ists.
7 It flashes when a song/album re-
lated to the song currently playing
is selected from iPod.
8 LOC The local seek tuning is on.
The selected frequency is being
9 (stereo)
broadcasted in stereo.
Folder repeat is on.
a (folder re- When repeat function is on, only
peat) is displayed. F
DEH-P6200BT/XSUC
5 6 7 8
15
1 2 3 4
All model commonness
A
Fastening the front panel
If you do not plan to detach the front panel,
the front panel can be fastened with supplied
screw.
B
RESET button
1 Remove the front panel.
Screw
2 Press RESET with a pen tip or other UC, EW : BPZ20P060FTC
ES : CXX2204 (Service)
pointed instrument.
16 DEH-P6200BT/XSUC
1 2 3 4
When not connecting a rear speaker lead to a subwoofer
5
5
Microphone
Microphone input Power amp
IP-BUS input (Blue) Fuse (10 A) Rear output (sold separately)
To rear output Connect with RCA cables
Front output
(sold separately)
Subwoofer output Power amp
DEH-P6200BT/XSUC
This product
(sold separately)
To front output
Antenna jack
Wired remote input
Hard-wired remote control Power amp
adaptor can be connected (sold separately)
Pioneer IP-BUS To subwoofer
accessories (sold separately). output
IP-BUS cable
2.4 CONNECTION DIAGRAM
6
6
Yellow
Connect to the constant 12 V supply terminal.
Red System remote control
Connect to terminal controlled by Blue/white
ignition switch (12 V DC). Connect to system control terminal of the power
amp or auto-antenna relay control terminal (max.
300 mA 12 V DC).
Black (chassis ground) Perform these connections
Connect to a clean, paint-free metal location. when using the optional
DEH-P6200BT/XSUC
amplifier.
7
7
White Gray
Subwoofer Subwoofer
Front speaker Front speaker
White/black Gray/black
Left Right
Green Violet
Front speaker Front speaker
Rear speaker Rear speaker
Green/black Violet/black
Rear speaker Rear speaker
With a 2 speaker system, do not
connect anything to the speaker leads
that are not connected to speakers.
8
8
17
E
A
D
C
F
B
F
E
B
A
D
C
18
When using a subwoofer without using the optional amplifier
1
1
Microphone input
IP-BUS input (Blue) Fuse (10 A) Rear output
Front output
Subwoofer output
This product
Antenna jack
Wired remote input
Hard-wired remote control
adaptor can be connected
Pioneer IP-BUS
IP-BUS cable (sold separately).
accessories
2
2
Blue/white
Connect to system control
terminal of the power amp or
auto-antenna relay control
terminal (max. 300 mA 12 V DC).
White Gray
Front speaker Front speaker
White/black Gray/black
Left Right
DEH-P6200BT/XSUC
Green Violet
Yellow Subwoofer (4 ) Subwoofer (4 )
3
3
Connect to the constant 12 V supply terminal. Green/black Violet/black
Red
Connect to terminal controlled by ignition switch (12 V DC).
When using a subwoofer of 70 W (2 ), be sure to connect
with Violet and Violet/black leads of this unit.
Do not connect anything with Green and Green/black leads.
Black (chassis ground)
Connect to a clean, paint-free metal location. Green Violet
Not used. Subwoofer
Note (4 ) 2
Change the initial setting of this unit. Green/black Violet/black
The subwoofer output of this unit is monaural.
4
4
21. Microphone (sold separately)
2. Microphone input
5
5
8. Notes 1. This product
• Change the initial setting of this unit (refer to the 3. Rear output or 22. To rear output or
operation manual). The subwoofer output of this unit is subwoofer output subwoofer output
monaural. 24. Power amp
7. Antenna
• When using a subwoofer of 70 W (2 ), be sure to (sold separately)
jack
connect with Violet and Violet/black leads of this unit.
Do not connect anything with Green and Green/black 4. Front output 23. To front output
leads. 6. Fuse (10 A) 24. Power amp
5. Wired remote in (sold separately)
DEH-6200BT/XSEW5
Hard-wired remote
control adaptor can
9. Note be connected (sold
Depending on the kind of vehicle, 10. Speaker leads 25. Connect with RCA cables
separately).
the function of 2* and 4* may be White: Front left (sold separately)
different. In this case, be sure to White/black: Front left
connect 1* to 4* and 3* to 2*. Gray: Front right
2* 1* Gray/black: Front right
6
6
Green: Rear left or subwoofer
Green/black: Rear left or subwoofer 26. System remote control
Violet: Rear right or subwoofer
Violet/black: Rear right or subwoofer 18. Blue/white
4* 3* Connect to system control
terminal of the power amp (max. 27. Front speaker 27. Front speaker
11. Connect leads of the 300 mA 12 V DC).
same color to each other.
19. Blue/white (6*)
Connect to auto-antenna relay 28. Rear speaker 28. Rear speaker
control terminal (max. 300 mA or subwoofer or subwoofer
12. Yellow (2*) 13. Yellow (1*) 12 V DC).
Back-up (or Connect to the constant
accessory) 12 V supply terminal.
20. Blue/white (5*) 29. Perform these connections when
DEH-P6200BT/XSUC
The pin position of the ISO using the optional amplifier.
14. Red (4*) 15. Red (3*) connector will differ depending
7
7
Accessory Connect to terminal controlled by on the type of vehicle. Connect
(or back-up) ignition switch (12 V DC). 5* and 6* when Pin 5 is an
antenna control type. In another
type of vehicle, never connect
16. Black (chassis ground) 5* and 6*.
Connect to a clean, paint-free metal location.
17. ISO connector
Note
In some vehicles, the ISO connector may be
divided into two. In this case, be sure to
connect to both connectors.
8
8
19
E
A
D
C
F
B
F
E
B
A
D
C
20
2. Microphone input 23. Microphone
1. This product
1
1
26. Power amp
(sold separately)
6. Antenna jack 24. To rear output or
3. Rear output or subwoofer output
subwoofer output 25. Connect with RCA cables
5. Fuse (10 A) (sold separately)
DEH-6250BT/XSES
4. Wired remote input
Hard-wired remote control
adaptor can be connected
(sold separately).
7. Yellow
2
2
Connect to the constant 12 V supply terminal.
28. System remote control
8. Red
Connect to terminal controlled by
ignition switch (12 V DC). 27. Blue/white
Connect to system control terminal of the
power amp or auto-antenna relay control
terminal (max. 300 mA 12 V DC).
9. Black (chassis ground)
Connect to a clean, paint-free metal location. 29. Perform these connections
when using the optional
DEH-P6200BT/XSUC
amplifier.
10. White 12. Gray
3
3
14. Front speaker 14. Front speaker
11. White/black 13. Gray/black
15. Left 16. Ri g h t
17. Green 19. Violet
21. Rear speaker 21. Rear speaker 30. Rear speaker 30. Rear speaker
or subwoofer or subwoofer
18. Green/black 20. Violet/black
22. With a 2 speaker system, do not connect
anything to the speaker leads that are
not connected to speakers.
4
4
1. This product 2. Microphone input
3. Rear output or
5
5
6. Antenna jack subwoofer output
5. Fuse (10 A)
4. Wired remote input 27. Blue/white
Hard-wired remote control Connect to system control
adaptor can be connected terminal of the power amp or
(sold separately). auto-antenna relay control
terminal (max. 300 mA 12 V DC).
7. Yellow
Connect to the constant 12 V supply terminal.
10. White 12. Gray
6
6
14. Front speaker 14. Front speaker
8. Red
Connect to terminal controlled by 11. White/black 13. Gray/black
15. Left 16. Right
ignition switch (12 V DC).
17. Green 19. Violet
32. Subwoofer (4 ) 32. Subwoofer (4 )
9. Black (chassis ground) 18. Green/black 20. Violet/black
Connect to a clean, paint-free metal location.
31. Note 33. When using a subwoofer of 70 W (2 ), be sure to connect
Change the initial setting of this unit. with Violet and Violet/black leads of this unit.
DEH-P6200BT/XSUC
The subwoofer output of this unit is monaural. Do not connect anything with Green and Green/black leads.
7
7
17. Green 19. Violet
34. Not used. 35. Subwoofer
(4 ) x 2
18. Green/black 20. Violet/black
8
8
21
E
A
D
C
F
B
1 2 3 4
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING
A To keep the product quality after servicing, please confirm following check points.
No. Procedures Item to be confirmed
1 Confirm whether the customer complain has The customer complain must not be
been solved. reappeared.
If the customer complain occurs with the Display, audio and operations must be
specific media, use it for the operation check. normal.
2 CD Play back a CD. No malfunction on display, audio and
(Track search) operation.
3 FM/AM tuner Check FM/AM tuner action. Display, audio and operations must be
(Seek, Preset) normal.
B Switch band to check both FM and AM.
4 Check whether no disc is inside the product. The media used for the operating check must
be ejected.
5 Appearance check No scratches or dirt on its appearance after
receiving it for service.
See the table below for the items to be checked regarding audio:
Item to be checked regarding audio
Distortion
Noise
Volume too low
C
Volume too high
Volume fluctuating
Sound interrupted
3.2 PCB LOCATIONS
E:DEH-P6200BT/XSUC
A:DEH-6200BT/XSEW5
B:DEH-6250BT/XSES
Unit Number : YWM5471(E)
Unit Number : YWM5467(A)
Unit Number : YWM5468(B)
C CD Core Unit (S11 STD-DOUT) Unit Name : TUNER AMP ASSY
Unit Number : CWX3774
E
Unit Name : CD Core Unit (S11STD-DOUT)
Unit Number : YWM5476(E)
Unit Number : YWM5472(A)
Unit Number : YWM5473(B)
B BT ANT PCB Unit Name : KEYBOARD ASSY
TUNER AMP ASSY
Consists of
TUNER AMP PCB
BT ANT PCB
D Keyboard Assy
F
A Tuner Amp PCB
22 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
3.3 JIGS LIST
- Jigs List
Name Jig No. Remarks A
Test Disc TCD-782 Checking the grating
L.P.F. Checking the grating (Two pieces)
GGF15394 Remove the Cord Assy
- Grease List
Name Grease No. Remarks
Grease GEM1024 CD Mechanism Module B
Grease GEM1045 CD Mechanism Module
3.4 CLEANING C
Before shipping out the product, be sure to clean the
following portions by using the prescribed cleaning
tools:
Portions to be cleaned Cleaning tools
CD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008 D
DEH-P6200BT/XSUC
5 6 7 8
23
1 2 3 4
4. BLOCK DIAGRAM
A
A TUNER AMP PCB
1 3 5 6 8 9
FM/AM TUNER UNIT
10 14 11 18 19 20 21 4 13 17 23
DI
CK
VDD_3.3
Lch
AMANT
FMANT
LDET
VCC
RDS_CK
RDS_DATA
RDS_LOCK
RDS_HSLK
ROM_VDD
SL
CE2
CE1
DO
SYSTEM
JA401 TUNL COMP
1 IC6
VDD3.3V
SYS8V
ANTENNA
PEG6
LDET
CE2
2,3 PEG6
DO
DI
PEG6
CE2 63
TUNPCE2
TUNER3V REG.
CE1 64
3 IC431 1 TUNPCE1
SYS8V
JA101 NJM2885DL1-33 DO 67
TUNPDO
IPL+ BUSL+ DI 66
7 TUNPDI
IPL- BUSL- CK 65
11 TUNPCK
SL 95
SL
BUS+ 6 2 RX
1 BUS+ IP-BUS DRIVER ROUT Q402
B IP-BUS BUS- 5 IC101 1 TX
5 BUS- DIN1 RDS_CK 71
HA12241FP 8 IPPW RCK
STBY
Q101
A :DEH-P6200BT/XSUC RDS_DATA 77
RDSDT
ASENBO
8 BUP B :DEH-6200BT/XSEW5 Q401
ASENBO
C :DEH-6250BT/XSES RDS_LOCK 74
RDSLK
RDS_HSLK 78
RDS57K
A B
CN461 LPF
SPK1N 3 LDET 72
3 IN+1 IC451 1 BTTEL LDET B
4
SPK1P 2
IN-1 NJM4558MD OUT1
RX 27
RX
25
U1IN BTTX RX2
1 28
TX
U1OUT BTRX TX
14
52
NRST_CPU BTRST IPPW
9
38
ASENBO A
C
BT MODULE 75
BTTX
BT3V REG. 76
BTRX
5
VCC 1 IC882 VIN 85
2 VOUT BTRST
S-1132B33-U5 4 91
SW BT5VSENS
84 BTPW
BT+B
Q891 RESET 10
RESET
BUP 2 IC651 1
MIC1N Q892 VDD3.3V DD5V REG.
11 S-80827CNNB-B8M
MIC1P 2 1
12 DD5V SW IC161 VIN BUP
S651
BD9781HFP 7 24
EN SYNC
VDD5V REG.
Q901 USB5V REG.
5 4
VDD5V BUP USB5V VOUT VIN DD5V
VDD3.3V REG. Q902 IC151 1 21
IC902 R5523N001B EN 3 23
USBCTL
S-1132B33-U5 FLG USBFLG
JA661
1 5 35
6 VDD3.3V VOUT VIN DALMON
D RMIC
5 MIC1PF SW
4
4 MIC1N
3 KEYD 32
KEYD
WIRED 2 KEYAD 92
KEYAD
REMOTE 1 GND 42
FLASH ROM 16Mbit MEDRST
IC571 19
VDCONT
CWW1967
12 43
C CD CORE UNIT(S11STD-DOUT) RESET RESET
SYS_TXD
SYS_RXD
63
61
34
33
MED_RX
MED_TX
PICKUP UNIT RF AMP, CD DECODER, MP3&WMA DECODER MEDIAMUTE
59 43
MEDMUTE
(P10.5)(SERVICE) DIGITAL SERVO/DATA•PROCESSOR BRST
58 41
MEDSTBY
CPU, USB HOST CONTROLLER
FLASH ROM 16Mbit
CN101 IC201
PE5706A IC502
VCC VDD
VCC 12 12 V+3A SST25V040BIS
LD LD- GND 1 DA
15 15 Q101 LD IC
Q102
MD PD 2 V+3A
WM87
5 5 PD VDD
REFO
REFO 93 54 138 1
VREF 8
E 8 REFOUT PUEN A
DACLRCK
137 2
LRCIN
DACDATA DIN
AC,BD,E,F 139 3
HOLOGRAM DACSCK BCKIN
UNIT CN701 CN701 MECHA VD
105 12
FOM FOM Q751 DACDATA1 DEEMPH
3 3 136 14
FOP FOP VD 2 15 VD BUP DACCLK MCLK
FOCUS ACT. 2 2 ACTUATOR/ VD Q752
MD TOP 1 TOP MOTOR DRIVER 1 16
TRACKING ACT. 1 IC301
TOM
4 4 TOM BA5839FP MEDIA uCOM
LD+ LD+ TD,FD IC501
14 14 R5S7262ZD144FPU
12
VO1+ SD,MD
11 VO1-
14 VO2+ 148
85 CP_SDA
13 VDSENS
VO2- LOIN 22 41
LOEJ 149
CP_SCL
SOM 21 40 112
SPINDLE CNT CLCONT VDD CPRST
MOTOR M SOP VDD 9 8 VDD3.3V Q591
15
VO3+ MUTE 9 39
CONT
16 MED3.3V
VO3- 29 RESET RESET 113
LCOM 17 RESET 8 9 CDRST
LOADING/CARRIAGE VO4+
MOTOR M LCOP 18 111
VO4- CPPWR
37 CD DATA (CDSRQ,CDSTBY,SKIP, CD DATA (CDSRQ,CDSTBY,SKIP,
8SNS SCL,SDA,DATA,BCLK,LRCK,WAIT) SCL,SDA,DATA,BCLK,LRCK,WAIT)
38
F DSCSNS 71
35 DP
HOME
70
DM
S905 S903 S901
8SNS DSCSNS HOME
24 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
E.VOL
IC201
PM9012A
SYSTEM MICRO TUNL 36
COMPUTER S4B-L
IC601 25 FL JA301
BUSL+ 37 OUTFL
PEG635A8: A S3A+L 26 RL FL FL
PEG634A8: B BUSL- 38 OUTRL 6
BUZZER
A S2A-L 27 SWL
PEG636A8: C BZ601 OUTPL Q301
BTTEL 34
63 20 S6L
TUNPCE2 PEE AUXL 39 A
64 S1Q+L
TUNPCE1 CDL 35
67 S5B+L Q201 B
TUNPDO 20
55 21 VCCH
RCA OUT
66 VST STB RL RL
TUNPDI 2
54 22
65 VCK CLK
TUNPCK 53 23 Q302
VDT DATA
95
SL
Q402
71
B
RCK 9.3V REG. HI-OUT 14V
Q831 Q853 SWL SWL
77 4 A
RDSDT BUP
Q832 IC851 Q303
Q382 SWL B
Q401 OEL+B NJM2360M 5
Q834 BUP
74 6
V+ 1 C
RDSLK 50 CS
OELPW OEL+B 7
78 Q854 SI
RDS57K 8
CD
A B
Q833
A
72 AMP
LDET B IC351
PA2030A JA981
27 FL 11 9 FL1
RX SYS8V REG. IN1 OUT1(+) 1
25 IC911 RL 12 7 FL2
RX2 IN2 OUT1(-) 3
NJM2388F84 5 RL1
28 OUT2(+) 5
TX 36 4
SYSPW CONTROL 3 RL2
52 2 Q363 OUT2(-) 7
IPPW VOUT SYS8V
1 4
38 BUP VIN VDD5V STBY
ASENBO A
C
25 BRE1
SOURCE CONNECTOR
75 H-SW/VOS-DET 14
BTTX
76
BTRX
48 Q361
85
BTRST MUTE
22
91 MUTE
BT5VSENS Q381
84 BTPW
16 BUP
10 BSENS
RESET 18
ASENS
BUP
MED3.3V REG. BUP
24 ILM+B BUP 18
SYNC Q821 IC581 BSENS
BUP NJM2885DL1-33
BSENS
3 1
MED3.3V OUT IN DD5V
Q921
ASENS ACC1
DD5V 49 13
21 ILMPW MED1.2V REG.
USBCTL Q822 IC583
23 ASENS
USBFLG BH12PB3WHFV
4 3
35 SWVDD MED1.2V VOUT VIN MED3.3V
DALMON Q841 1
STBY D
VDD3.3V
32
KEYD
92
42
19
KEYAD
MEDRST
SWVDD
47
Q842 D KEYBOARD ASSY
VDCONT
90 CN801 CN1801 JA1801
FRONT AUX
SSENS
17 AUXR 3
DSENS
3 34 1 AUXL AUXL AUXL 2
MED_RX ROT1 19 19
1 33 2 AUXG 1
MED_TX ROT0
9 43 30 ILLUMI
MEDMUTE KYDT
8 41 29 ILM+B ILM+B
MEDSTBY DPDT 16 16
SW5V
3 3 SW3.3V
DAC Q1833
IC181 ADKEY1 17
9
WM8761GED G_ILM KEY MATRIX
ADKEY2 15
38 9 CDL
1 VOUTL
37 2
LRCIN
MICRO E
DIN DAC5V REG. SRC
IC182 S1801 COMPUTER
39 3
BCKIN NJM2872F05 SSENS SOURCE SOURCE IC1901
05 12 4 4 PEG642A8 REMOTE
DEEMPH 1 CONTROL SENSOR
36 14 8 5 VIN SYS8V DSENS DSENS DSEN
MCLK VDD VOUT 20 20
CONT
3
REM 10 1 IC1891 3
SW3.3V
GP1UXC14RK
ROTARY COMMANDER CN1921
iPod CP S1811
XI
IC591 MCLK 14 10
341S2162 ROT1 ROT0 Phase_B 18 XCS
14 14 ADKEY0 R_ILM 19 7
ROT0 ROT1 Phase_A XRES
48 13 12 12 XREST 11 6
I2C_SDA/SPI_SOMI
OEL MODULE
49 12 XCMD
I2C_SCL/SPI_SIMO XCMD 20 5
12 4 SCL
nRESET KYDT DCLK 1 4
Q591 6 KYDT 13
6 KYDT SI_RX
5 DPDT DOUT 2 3
MED3.3V VCC DPDT 12
10 10 DPDT
2 VDD
MODE1/SPI_nSS 8
SW3.3V
11 VAH
12
OEL+B VKH
OEL+B 8 8 13
CN1802
1 D+ D+ D+
F
15 15 4
USB
0 D- D- D-
13 13 3
VBUS VBUS(US5V) USB5V(US5V)
USB5V 11 11 2
DEH-P6200BT/XSUC
5 6 7 8
25
1 2 3 4
A
FM/AM TUNER UNIT
A 7 6 13 5 10 9 8 11 14 18 19 20 21
NC
CE2
ROM_VDD
SL
DI
CK
CE1
LDET
DO
RDS_CK
RDS_LOCK
RDS_HSLK
RDS_DATA
A
B
IC5
IC3 5V→3.3V
EEPROM 5.0V
OSC LPF
AM ANT FMRF
1 ATT
IC1 IC2
3.3V 2.5V
A FM ANT
MIXER, IF AMP
Lch
B
3 ATT
FMRF
DET, FM MPX,
RDS DECODER
23
A
RF adj
ANT adj
T51 CF52
A B
AUDIOGND
OSCGND
VDD_3.3
RFGND
IC4
DGND
VCC
3.3V 3.3V→2.5V 2.5V
NC
2 12 15 22 16 4 17
A
A :DEH-P6200BT/XSUC
B :DEH-6200BT/XSEW5
C :DEH-6250BT/XSES
C
B BT ANT PCB
ANTENNA
CN1101
1
BT MODULE
2,3
26 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
VCC1 = 3.3 V
Pin 14
BSENS
Pin 16
BSENS = L B
ASENS
Pin 18
ASENS = L
DSENS
Pin 17
Only /UC model
C
ASENBO <- H
Pin 38
Starts
communication
with Grille
microcomputer.
500 ms
SWVDD <- H
Pin 47 D
500 ms
In case of the above signal, the communication
Source keys
with Grille microcomputer may fail.
operative
If the time interval is not 500 msec, the oscillator
may be defective.
Source ON
SYSPW <- H
E
Pin 36
Completes power-on operation.
(After that, proceed to each source operation)
DEH-P6200BT/XSUC
5 6 7 8
27
1 2 3 4
5.2 ERROR CODE LIST
A ERROR CODES
If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a
cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from
customers and facilitate failure analysis and repair work in servicing.
(1) DISPLAY METHOD
If “0xFD” error mode is displayed in CD MODE (CD MODE area for display), an error code will be displayed in the MIN (minute
display) and SEC (second display) areas.
The same code is displayed in the MIN and SEC areas.
The TNO area is blank (#0FFH), as it conventionally was.
• Display example of the main unit
B
Depending on the display capability of LCDs, the display format varies, as shown below. XX denotes an error number.
Note: In a case of an OEM product, the error display format is subject to the specifications used by the equipment
manufacturer.
8-digit display 6-digit display 4-digit display
ERROR-xx ERR-xx E-xx
(2) LIST OF CD ERROR CODES (Error Mode: 0xFD)
C Code Classification Error code to be displayed Details and possible causes
7 Servo TOC reading NG TOC information cannot be read.
--> The partial disk or TOC content is illegal.
10 Servo Carriage Home NG The CRG cannot move toward the inner track.
The CRG cannot move from the inner track.
--> Defective HOME SW; Failure in CRG movement.
11 Servo Focus Search NG Focusing not available
--> Disc placed upside-down; Stains on the disc; excessive vibration.
12 Servo Spindle Lock NG Spindle not locked. Subcode not readable.
Subcode NG Proper RF AMP gain not obtained.
RF-amp NG --> Defective spindle; Scratches or stains on the disc; excessive vibration.
--> A CD-R disc that does not contain data loaded, or in a rare case, disc placed upside-down.
D --> CD signal error.
15 Servo Failure in RF data RF not read
--> A CD-R disc that does not contain data loaded
--> A CD-RW disc that does not contain data loaded
17 Servo Setup NG AGC protection does not work. Focus can be easily lost.
--> Scratches or stains on the disc; excessive vibration.
30 Servo Search Time Out Failed to reach a target address
--> CRG tracking error; Scratches on the disc; Stains on the disc
50 Mechanism Failure in ejection Disc ejection not completed
Load NG Disc loading not completed
--> A foreign object inserted in the mechanism; Disc jammed.
51 Mechanism Failure in retried Disc could not be ejected even after disc turning had been retried.
E turning for ejection --> A foreign object inserted in the mechanism; Disc jammed.
NOTES
• Indications of error codes are available only during disc operations, because CD operations are
unavailable if a mechanical error is generated.
• If the TOC cannot be read, this is not processed as an error, and operation continues accordingly.
• If you design a new head unit, be sure to use one of the display formats indicated in “Display example of
the main unit.”
• The 2 high-order digits of an error code denote the main • How to restore from each error is shown below.
classification, shown below. 0x, 1x and 3x: ACC-OFF then ON, CD-OFF then ON,
0x: Servo-related errors Disc ejection
1x: Servo-related errors 5X: ACC-OFF then ON, Disc ejection, Disc reloading
3x: Servo-related errors
F 5x: Mechanism-related errors
28 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
USB storage device A
Message Cause Action Message Cause Action
NO DEVICE When plug and • Turn the plug ERROR-23 USB storage de- USB storage de-
play is off, no and play on. vice is not for- vice should be for-
USB storage de- • Connect a com- matted with matted with FAT16
vice is con- patible USB sto- FAT16 or FAT32 or FAT32.
nected. rage device.
Format read Sometimes there Wait until the mes-
is a delay be- sage disappears iPod
tween the start of and you hear Message Cause Action
playback and sound.
when you start to NO DEVICE When plug and • Turn the plug
hear any sound. play is off, no and play on.
USB storage de- • Connect a com-
NO AUDIO There are no Transfer the audio vice or iPod is patible iPod. B
songs. files to the USB connected.
storage device and
connect. Format read Sometimes there Wait until the mes-
is a delay be- sage disappears
The connected Follow the USB tween the start of and you hear
USB storage de- storage device in- playback and sound.
vice has security structions to dis- when you start to
enabled able the security. hear any sound.
SKIPPED The connected Play an audio file ERROR-19 Communication Disconnect the
USB storage de- not embedded with failed. cable from the
vice contains Windows Media iPod. Once the
WMA files em- DRM 9/10. iPod's main menu
bedded with is displayed,recon-
Windows Med- nect the iPod and
ia™ DRM 9/10 reset it. C
PROTECT All the files in the Transfer audio files iPod failure Disconnect the
USB storage de- not embedded with cable from the
vice are em- Windows Media iPod. Once the
bedded with DRM 9/10 to the iPod's main menu
Windows Media USB storage de- is displayed, recon-
DRM 9/10 vice and connect. nect the iPod and
N/A USB Theconnected Connect a USB reset it.
USBstoragede- Mass Storage ERROR-16 The iPod firm- Update the iPod
viceisnotsup- Class compliant ware versions are version.
portedbythis device. old.
unit.
iPod failure Disconnect the
Not compatible Disconnect your cable from the
USB device device and replace iPod. Once the
it with a compati- iPod's main menu D
ble USB storage is displayed, recon-
device. nect the iPod and
CHECK USB The USB connec- Check that the reset it.
tor or USB cable USB connectoror N/A USB Non-compatible Disconnectyour
has short- USB cable is not iPod device and replace
circuited. caught in some- it with a compati-
thing or damaged. ble iPod.
The connected Disconnect the CHECK USB The iPod oper- Make sure the con-
USB storage de- USB storage de- ates correctly but nection cable for
vice consumes vice and do not does not charge the iPod has not
more than 500 use it. Turn the shorted out (e.g.,
mA (maximum ignition switch to not caught in
allowable cur- OFF, then to ACC metal objects).
rent). or ON and then After checking,
connect only com- E
turn the ignition
pliant USB storage switch OFF and
devices. back ON or discon-
ERROR-19 Communication Perform one of the nect the iPod and
failed. following opera- reconnect.
tions. STOP There are no Transfer songs to
–Turn the ignition songs. the iPod.
switch OFF and
back ON. There are no Select a list that
–Disconnect the songs in the cur- contains songs.
USB storage de- rent list.
vice.
–Change to a dif-
ferent source.
Then, return to the F
USB source.
DEH-P6200BT/XSUC
5 6 7 8
29
1 2 3 4
A iTunes tagging
Message Cause Action
TAG ERROR-01 iPod is full. Delete unneces-
sary data from the
iPod.
TAG ERROR-02 This unit’s mem- Transfer the tag
ory is full. data to the iPod.
This unit can store
the tag data up to
50.
TAG ERROR-03 Tag data transfer Check the iPod
failed. and try again.
TAG ERROR-04 Tag data captur- Try again.
B ing failed.
Bluetooth Telephone
Message Cause Action
ERROR-10 The power failed Turn the ignition
for the Bluetooth switch OFF and
module of this then to ACC or ON.
unit. If the error mes-
sage is still dis-
played after
performing the
above action,
C please contact
your dealer or an
authorized Pioneer
Service Station.
30 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
5.3 CONNECTOR FUNCTION DESCRIPTION
A
DEH-P6200BT/XSUC FRONT REAR
MICROPHONE
OUTPUT OUTPUT
ANTENNA IP-BUS INPUT WIRED REMOTE SUBWOOFER
CONTROL OUTPUT
8 9 10 11
5 6 7 15 13 11 9 7 5 3 1
1 2 3 4 16 14 12 10 8 6 4 2
C
1. BUS+ 1 FL+ 9 NC
2. GND 2 FR+ 10 NC
3. GND 3 FL- 11 NC
4. NC 4 FR- 12 NC
5. BUS- 5 RL+ 13 ACC
6. GND 6 RR+ 14 B.REM
7. L+ 7 RL- 15 B.UP
8. ASENB 8 RR- 16 GND
9. R+
10. R-
11. L-
D
REAR
or
DEH-6200BT/XSEW5
SUBWOOFER
DEH-6250BT/XSES MICROPHONE OUTPUT
ANTENNA WIRED REMOTE FRONT
CONTROL OUTPUT
(DEH-6200BT/XSEW5)
F
DEH-P6200BT/XSUC
5 6 7 8
31
1 2 3 4
6. SERVICE MODE
6.1 DISPLAY TEST MODE
A
The information such as the system version is checked and the lighting of every segment on the display is checked.
[Operation key]
Corresponding key Processing Remarks
TA/ASR/CLOCK + LIST Switching to next test display Also used as an entry key
[Test item]
Test mode is started
System Version information is displayed
B
S $ $ $ $ # # #
$ PEG number For PEG123A, "123A" is displayed
# System microcomputer version For Ver.7.01, "701" is displayed
Unit number information is displayed
U %%% % % % %
% System unit number For CWW1234, "CWW1234" is displayed
Display Version information is displayed
C (Both of Sys. and Disp.) Ver. 2.01 or later
D $ $ $ $ # # #
$ PEG number For PEG123A, "123A" is displayed
# Display microcomputer version For Ver.7.01, "701" is displayed
(Both of Sys. and Disp.) less than Ver. 2.01
D I S P $ $ $ $ # # #
$ PEG number For PEG123A, "123A" is displayed
# Display microcomputer version For Ver.7.01, "701" is displayed
Media microcomputer Version information is displayed
M V $ $ # #
D
$ Major version
# Minor version
Only /UC model
Manufacture_ID information is displayed
M I D $ $ $ $ $ $ $ $
$ Manufacture ID
E Display is normally updated
Usual product operation is implemented to outward appearances.
Display update is stopped
The screen gets still when entering this item.
Every segment lights up
Every segment including icons lights up.
Every segment goes out
F
Every segment including icons goes out.
32 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
6.2 CD TEST MODE
- Flow Chart NOTE A
When a CD-DA (regular music CD) is played in the CD test mode, its sound quality
[3] + [DISP] -> BUP + ACC ON [CD] or [SOURCE] [Key] will be temporarily deteriorated. The CD will then repeat normal, deteriorated,
Test Mode IN Source ON
Contents normal… playback.
This is due to the difference in the playback modes between the normal operation
TRK MIN
Display mode and the CD test mode, and the interval of generating deteriorated mode and
the time taken to return to the normal mode depend on the error of each clock.
The time taken to turn to the deteriorated mode is at a minimum around 20
seconds while the time to return to the normal mode is maximum 40 seconds
[BAND] [2] approximately.
Power On RF AMP *1 Make sure to check the sound quality in the normal operation mode.
(T.Offset is adjusted) Gain switching
TRK MIN SEC TRK MIN SEC
00 00 00 GG GG GG
[BAND] [3] [6] [1] [<] [>] [2]
Power Off Focus Close Focus Mode switching Tracking Servo CRG + CRG - Self-adjusting
S curve check *2 Close *8 *8 switching *3 B
TRK MIN SEC TRK MIN SEC TRK MIN SEC 00 00 00 00 00 00 00 00 00 TRK MIN SEC
91 91 91 0X 0X 0X or 99 99 99 or 99 99 99 or 99 99 99 ?? ?? ??
[BAND] [1] [3] [<] [>] [2]
Power Off T.Close & AGC RF AGC / CRG + CRG - T.Balance adjustment /
Applicable servomechanism RF AGC coefficient display T.BAL coefficient display
TRK MIN SEC TRK MIN SEC TRK MIN SEC 8X 8X 8X 8X 8X 8X TRK MIN SEC
?tr ?min ?sec ?? ?? ?? or 9X 9X 9X or 9X 9X 9X ?? ?? ??
[BAND] [1] [3] [<] [>] [2]
Power Off F,T,RF AGC*7 F,T AGC / F.Bias CRG/TR Jump + CRG/TR Jump - Tracking Open
F.Bias display switching RF AGC *4 *4
TRK MIN SEC TRK MIN SEC TRK MIN SEC TRK MIN SEC TRK MIN SEC 8X 8X 8X
?? ?? ?? ?tr ?min ?sec ?tr ?min ?sec ?tr ?min ?sec or 9X 9X 9X
*6 C
[BAND] [2]
Power Off Tracking Open
TRK MIN SEC 8X 8X 8X
or 9X 9X 9X
Operation
*1) TYP t + 6 dB t + 12 dB [Key] Test Mode
TRK MIN SEC TRK
06MIN06SEC06 TRK
12MIN12SEC12 [BAND] Power On/Off
[<] CRG + / TR Jump +
(Direction of the external surface)
*2) Focus Close t S. Curve t F EQ measurement setting [>] CRG - / TR Jump -
TRK
00MIN00SEC00 TRK
01MIN01SEC01 TRK
02MIN02SEC02 (Direction of the internal surface) D
(TRK99MIN99SEC99) [1] T. CLS & AGC & Applicable servomechanism /
AGC,AGC display setting
[2] RF Gain switching / Offset adjustment display /
*3) F.Offset Display t T.Offset Display t Switch to the T.Balance adjustment / T. Open
order of the original display
[3] F. Close,S. Curve / Rough Servo and RF AGC /
F,T,RF AGC
*4) 100TR Jump [6] F. Mode switching / Tracking Close
*7) TRK/MIN/SEC t F.AGC t T.AGC Gain t F.Bias t RF AGC
E
*8) CRG motor voltage = 2 [V]
*9) TYP (1X) t 2X t 1X *10) OFF(TYP) t FORCUS t TRACKING
TRK MIN SEC TRK
22MIN22SEC22 TRK
11MIN11SEC11 TRK MIN SEC TRK
70MIN70SEC70 TRK
71MIN71SEC71
After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete.
When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks
to Wall, causing the actuator to be damaged).
100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released.
When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the
default setting. F
Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)
DEH-P6200BT/XSUC
5 6 7 8
33
1 2 3 4
7. DISASSEMBLY
A - Removing the Case (not shown)
1. Remove the Case.
- Removing the CD Mechanism Module (Fig.1) CD Mechanism Module
1 Remove the four screws.
1
2 Disconnect the connector and then remove
B the CD Mechanism Module.
2
1 1
Fig.1
- Removing the Tuner Amp Assy (Fig.2)
1 Remove the two screws.
D
2 Remove the screw. 1
1
3 Disconnect the connector(using GGF1539).
4 Release the two latches and then remove
the Panel Assy.
5
5 Remove the screw.
6
E 6
6 Straighten the tabs at four locations
indicated and then remove the Tuner Amp
Assy.
6
6
4 2 4
3
F
Tuner Amp Assy
Panel Assy
Fig.2
34 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
When unplugging the Coaxial Jumper, make sure to use jig GGF1539.
If the antenna cable is directly unplugged without using jig GGF1539, you might damage your fingertip or fingernail.
A
- How to Remove the Coaxial Jumper
When unplugging Coaxial Jumper, hook the point of jig GGF1539 on the lid of Coaxial Jumper
and vertically draw out along with the engagement axis of connector.
GGF1539
Coaxial Jumper
B
Connector
- How to Attach the Coaxial Jumper
For inserting Coaxial Jumper, adjust cord assy with the engagement axis of connector and insert it as vertically
as possible.
Do not insert the Coaxial Jumper in extreme slant, as the connector might suffer damage.
C
DEH-P6200BT/XSUC
5 6 7 8
35
1 2 3 4
A How to Hold the Mechanism Unit
1. Hold the Upper and Lower Frames at the specified parts (circled with broken blue lines in the photo below).
2. You can hold the tabs of the Lower Frame (circled with broken green lines in the photo below) if you do so only while lifting
the Mechanism Unit from the table. Keeping the Mechanism Unit lifted by holding these tabs with your fingers may result in
deformation.
3. Be careful NOT to hold the front part of the Upper Frame or the CRG Mechanism and NOT to insert foreign objects into
these mechanisms. Doing so may result in deformation.
Proper handling
Improper handling
36 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Mechanism Module: How to Set to the Quasi-Clamp State (Driven by the Motor) A
1. Remove the solder from the CRG-motor lead wire (Fig. 1).
2. Push in the Disc Detection Arm while applying 4-V power to the CRG Motor (Fig. 2). (Apply 4-V power to the green lead
wire. The white lead wire is for grounding.)
The Mechanism Module is set to the clamped state, and the PU will move toward the outer track.
Note: NEVER apply power to the CRG-motor lead wire without removing the solder from the wire. Doing so may result in
damage to the ICs and the PU.
3. Stop the motor when the PU reaches around the middle track.
Note: Jumpiness will occur when the PU reaches the outermost track. Although jumpiness does not constitute a problem,
it is recommended that it occur as least frequently as possible.
Note: Be aware that the colors of the lead wires do not match the
Fig. 1 indications on the Core Board Pattern (green wire to O and
white wire to P).
Disc Detection Arm
Fig. 2
DEH-P6200BT/XSUC
5 6 7 8
37
1 2 3 4
A How to Remove the PU Unit
1. Set the unit to the quasi-clamp state, following the procedures described in “Mechanism Module: How to Set to the Quasi-
Clamp State (Driven by the Motor).”
2. Temporarily change the engagement position of the bias spring of the feed screw (Fig. 2b).
Be careful not to cut yourself on the tip of the spring.
3. Hold the PU unit by parts A in Fig. 1 then slide it toward the inner track.
4. Remove the backend of the feed screw from the outer holder, by first sliding it, as shown in Fig. 3, then lifting it.
5. Remove the PU unit, by lifting it. Lifting the PU unit will disengage the PU unit from the part B of the chassis.
Note: When reassembling the PU unit, be sure to securely engage the PU unit with the part B of the chassis, as shown in
Fig. 4. Also, be sure to change the engagement position of the bias spring of the feed screw to its original position
(Fig. 2a). After reassembling, perform the PU adjustment, following the description in the service manual.
B
Slide toward the inner track.
B
C
One end of the spring is engaged
Backend of Outer holder beneath the resin flange and
the feed screw plate bend.
Fig. 2a
Fig. 3 Original engagement
position
Fig. 1
Fig. 2b
Temporary engagement
position
[Improper assembly]
Properly assembled state The chassis is not properly pinched by
Fig. 4
the PU case and PU rack.
How to Move the PU toward the Outer Track
1. Set the unit to the quasi-clamp state, following the procedures described in “Mechanism Module: How to Set to the Quasi-
F
Clamp State (Driven by the Motor).”
2. Move the PU unit toward the outer track, by applying 1.5-V power to the CRG motor.
Note: After moving the PU toward the outer track and taking the necessary measures, be sure to solder the lead wires.
38 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
How to Remove the PU Rack A
1. Remove the PU Unit, following the procedures described in “How to Remove the PU Unit.”
2. Remove the PU Rack fixing screw (Fig. 1).
3. Remove the PU Rack, by applying force in the direction of the arrow in Fig. 2.
Notes:
While handling the PU Unit, be careful NOT to touch the actuator block shown in Fig. 6 or bang the actuator block against
your workbench.
Handle the PU and PU Unit with care, according to the description in “How to Hold the PU.”
When reattaching the PU Rack to the PU, first reassemble parts a and b shown in Fig. 3 into the PU case then attach the
boss shown in Fig. 4 to the PU case.
After reassembling the PU Rack, insert the feed screw from side c in Fig. 5 (insertion depth: Approx. 18 mm for the part
indicated in the photo). B
PU Rack
PU Rack
fixing screw
C
Fig. 4
Fig. 1
D
18 mm
Fig. 5
Fig. 2
Actuator block E
a
F
Fig. 3 b
Fig. 6
DEH-P6200BT/XSUC
5 6 7 8
39
1 2 3 4
A How to Hold the PU
1. Be sure to hold the PU at the positions shown in “Proper handling.” NEVER hold it as shown in “Improper handling.”
Proper handling Improper handling
Do not touch the object lens
and ACT.
Do not touch the VR.
Do not touch the Hologram.
Do not pull the FPC.
40 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
8. EACH SETTING AND ADJUSTMENT
8.1 CD ADJUSTMENT
A
1) Cautions on adjustments 2) Test mode
In this product the single voltage (3.3 V) is used for the This mode is used to adjust the CD mechanism module.
regulator. The reference voltage is the REFO1 (1.65 V) To enter the test mode.
instead of the GND. [3] + [DISP] -> Reset
If you should mistakenly short the REFO1 with the GND
during adjustment, accurate voltage will not be obtained, To exit from the test mode.
and the servo’s misoperation will apply excessive shock Turn off the ACC and back up.
to the pickup. To avoid such problems:
a. Do not mix up the REFO1 with the GND when Notes:
connecting the (-) probe of measuring instruments. a. During ejection, do not press any other keys than the B
Especially on an oscilloscope, avoid connecting the (-) EJECT key until the loaded disc is ejected.
probe for CH1 to the GND. b. If you have pressed the (→) key or (←) key during focus
b. In many cases, measuring instruments have the same search, turn off the power immediately to protect the
potential as that for the (-) probe. Be sure to set the actuator from damage caused by the lens stuck.
measuring instruments to the floating state. c. For the TR jump modes except 100TR, the track jump
c. If you have mistakenly connected the REFO1 to the GND, operation will continue even if the key is released.
turn off the regulator or the power immediately. d. For the CRG move and 100TR jump modes, the tracking
loop will be closed at the same time when the key is
Before mounting and removing filters or leads for released.
adjustment, be sure to turn off the regulator. e. When the power is turned off and on, the jump mode
is reset to the single TR (91), the RF amp gain is set to 0 dB,
For stable circuit operation, keep the mechanism and the auto-adjustment values are reset to the default C
operating for about one minute or more after the settings.
regulator is turned on.
When a CD-DA (regular music CD) is played in the CD
In the test mode, any software protections will not test mode, its sound quality will be temporarily
work. Avoid applying any mechanical or electrical deteriorated. The CD will then repeat normal, deteriorated,
shock to the mechanism during adjustment. normal… playback.
This is due to the difference in the playback modes
The RFAGC and RFO signals with a wide frequency range between the normal operation mode and the CD test
are easy to oscillate. When observing the signals, mode, and the interval of generating deteriorated mode
insert a resistor of 1k ohms in series. and the time taken to return to the normal mode depend
on the error of each clock. D
The load and eject operation is not guarantied with the The time taken to turn to the deteriorated mode is at a
mechanism upside down. If the mechanism is blocked minimum around 20 seconds while the time to return to
due to mistaken eject operation, reset the product or the normal mode is maximum 40 seconds approximately.
turn off and on the ACC to restore it. Make sure to check the sound quality in the normal
operation mode.
DEH-P6200BT/XSUC
5 6 7 8
41
1 2 3 4
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
B Symptoms of Mal-adjustment :
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment Oscilloscope, Two L.P.F.
Measuring Points E, F, REFO1
Disc TCD-782
Mode TEST MODE
CD CORE UNIT
E
C F
REFO1
L.P.F.
Xch Ych
E 100 kohm
Oscilloscope
VREF 390 pF
F 100 kohm
VREF 390 pF
D L.P.F.
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the right and left buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking
balance adjustment the display should now read "81". Press key 3. The display will change,
returning to "81" on the fourth press.
E 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase
difference is within 75 . Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
42 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Grating waveform Ech -> Xch 20 mV/div, AC
Fch -> Ych 20 mV/div, AC
A
0 degrees 30 degrees
45 degrees 60 degrees
75 degrees 90 degrees
DEH-P6200BT/XSUC
5 6 7 8
43
1 2 3 4
8.3 PCL OUTPUT CONFIRMATION(UC,ES)
- PCL output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode
cancelled), shift the TESTIN IC601(Pin 61) terminal to H.
The clock signal is output from the PCL terminal IC601(Pin 37).
The frequency of the clock signal is 625.0 kHz that is one 32th of the fundamental frequency.
The clock signal should be 625.0 kHz(- 10 Hz, + 15 Hz).
If the clock signal is out of the range, the X'tal (X601) should be replaced with new one.
B
44 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
9. EXPLODED VIEWS AND PARTS LIST
NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
A
Therefore, when replacing, be sure to use parts of identical designation.
"
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
9.1 PACKING
UC
EW5, ES
B
ES
EW5, ES
C
EW5
UC, ES
UC
EW5
UC, ES
EW5, ES
UC
E
EW5
DEH-P6200BT/XSUC
5 6 7 8
45
1 2 3 4
PACKING SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Polyethylene Bag See Contrast table (2) 18 Screw See Contrast table (2)
2 Protector See Contrast table (2) 19 Screw See Contrast table (2)
A
3 Protector See Contrast table (2) 20 Unit Box See Contrast table (2)
4 Microphone Assy CPM1083
5 Clip Holder CZN7912 21 Contain Box See Contrast table (2)
22 CD-ROM See Contrast table (2)
6 Cushion CZN7913 23 Case Assy See Contrast table (2)
7 Remote Control Unit See Contrast table (2) * 24-1 Warranty Card See Contrast table (2)
8 Cord Assy See Contrast table (2) 24-2 Owner's Manual See Contrast table (2)
* 9 Accessory Assy See Contrast table (2)
10 Screw See Contrast table (2) 24-3 Owner's Manual See Contrast table (2)
24-4 Installation Manual See Contrast table (2)
B 11 Cord Clamper Assy CEA4636 24-5 Quick Start Guide See Contrast table (2)
* 12 Clamper CNV8262 24-6 Quick Start Guide See Contrast table (2)
* 13 Polyethylene Bag E36-615 * 24-7 Caution Card See Contrast table (2)
14 Polyethylene Bag CEG1160
15 Handle CND3707 * 24-8 Caution Card See Contrast table (2)
* 24-9 Passport See Contrast table (2)
16 Screw Assy See Contrast table (2) * 24-10 Caution Card See Contrast table (2)
* 17 Polyethylene Bag See Contrast table (2) * 24-11 Caution Card See Contrast table (2)
(2) CONTRAST TABLE
DEH-P6200BT/XSUC, DEH-6200BT/XSEW5 and DEH-6250BT/XSES are constructed the same except for the fol-
C lowing:
Mark No. Description DEH-P6200BT/XSUC DEH-6200BT/XSEW5 DEH-6250BT/XSES
1 Polyethylene Bag CEG1173 QEG3001 QEG3001
2 Protector CHP3941 CHP3931 CHP3931
3 Protector CHP3942 CHP3932 CHP3932
7 Remote Control Unit Not Used Not Used CXE2758
8 Cord Assy YDP5039 YDP5041 YDP5039
* 9 Accessory Assy YEA5073 CEC2995 CEC2996
10 Screw BPZ20P060FTC BPZ20P060FTC Not Used
D 16 Screw Assy YEA5072 Not Used YEA5082
* 17 Polyethylene Bag CEG-127 Not Used CEG-127
18 Screw CRZ50P090FTC Not Used Not Used
19 Screw TRZ50P080FTC Not Used TRZ50P080FTC
20 Unit Box YHG5560 YHG5559 YHG5561
21 Contain Box YHL5560 YHL5559 YHL5561
22 CD-ROM Not Used YPJ5007 Not Used
23 Case Assy Not Used YXB5009 YXB5009
* 24-1 Warranty Card CRY1276 CRY1279 Not Used
E
24-2 Owner's Manual YRD5314 Not Used YRD5316
24-3 Owner's Manual Not Used Not Used YRD5317
24-4 Installation Manual YRD5315 YRD5313 YRD5318
24-5 Quick Start Guide Not Used YRD5311 Not Used
24-6 Quick Start Guide Not Used YRD5312 Not Used
* 24-7 Caution Card Not Used CRP1389 Not Used
* 24-8 Caution Card Not Used CRP1394 Not Used
* 24-9 Passport Not Used CRY1268 Not Used
* 24-10 Caution Card Not Used YRP5019 Not Used
F
* 24-11 Caution Card Not Used YRP5021 Not Used
46 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Owner's Manual,Installation Manual
Part No. Language
YRD5314 English, French, Spanish(Espanol)
A
YRD5315 English, French, Spanish(Espanol)
YRD5311 English, French, Italian, Spanish(Espanol)
YRD5312 German, Dutch, Russian
YRD5313 English, French, Italian, Spanish(Espanol), German ,Dutch, Russian
YRD5316 English,Spanish(Espanol),Portuguese(B)
YRD5317 Traditional Chinese, Arabic
YRD5318 English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic
DEH-P6200BT/XSUC
5 6 7 8
47
1 2 3 4
9.2 EXTERIOR (1)
A EW5
UC, ES
B
D
C
ES
48 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
EXTERIOR (1) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Holder CND3598 14 Holder CND5407
2 Panel CNU1016 15 Double Side Tape CNN1878
A
3 Detach Grille Assy See Contrast table (2)
4 Screw BPZ20P100FTC 16 Holder CNW1754
5 Button(DETACH) CAI2688 17 OEL Module See Contrast table (2)
18 Grille Unit See Contrast table (2)
6 Button(EJECT) CAI2689 19 Door(USB) CAT2911
7 Button(1-6) CAI2690 20 Knob Unit CXE2418
8 Button See Contrast table (2)
9 Spring CBH2210 21 Spring XBL7005
10 Cover CNU1012 22 Cord Assy See Contrast table (2)
23 Case YNB5063
11 Lighting Conductor CNW1752 24 Remote Control Unit See Contrast table (2) B
12 Lighting Conductor CNW1753 25 Cover See Contrast table (2)
13 Keyboard Assy See Contrast table (2)
(2) CONTRAST TABLE
DEH-P6200BT/XSUC, DEH-6200BT/XSEW5 and DEH-6250BT/XSES are constructed the same except for the fol-
lowing:
Mark No. Description DEH-P6200BT/XSUC DEH-6200BT/XSEW5 DEH-6250BT/XSES
3 Detach Grille Assy YXA5713 YXA5708 YXA5710
8 Button YAC5408 YAC5407 YAC5409
(SRC, PHONE, LIST, (SRC, PHONE, LIST, (SRC, PHONE, LIST,
C
BAND, S.Rtrv, RPT) BAND, TA, RPT) BAND, S.Rtrv, RPT)
13 Keyboard Assy YWM5476 YWM5472 YWM5473
17 OEL Module MXS4013 MXS4013 MXS4012
18 Grille Unit YXA5700 YXA5699 YXA5702
22 Cord Assy YDP5039 YDP5041 YDP5039
24 Remote Control Unit Not Used Not Used CXE2758
25 Cover Not Used Not Used CNS7068
DEH-P6200BT/XSUC
5 6 7 8
49
1 2 3 4
9.3 EXTERIOR (2)
B
C
A
B
D B A
C
F
50 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
EXTERIOR (2) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Screw ASZ26P040FTC 17 Holder See Contrast table (2)
2 Screw ASZ26P050FTC 18 CD Mechanism Module(S11) CXK5800
A
3 Screw BSZ26P060FTC 19 Cable YDE5064
4 Screw BSZ26P100FTC 20 Holder YND5048
5 Earth Plate CNC8915
21 Heat Sink YNR5142
6 Cushion CNM8890 22 Spring(Thin) CBH2961
7 Tuner Amp Assy See Contrast table (2) 23 Spring(Thick) CBH2962
8 Screw BPZ26P080FTC 24 Arm CNV9312
9 Screw BSZ26P060FTC 25 Arm CNW1439
10 Screw BSZ26P160FTC
26 Screw CSZ26P060FTB
11 Holder CND5423 27 Holder YNC5092 B
12 FM/AM Tuner Unit See Contrast table (2) 28 Panel Unit YXA5722
13 Holder CND4324 29 Button CAC4836
14 Bluetooth Module CWX3865 30 Spring YBH5012
15 Cord Assy YDE5065
31 Chassis Unit See Contrast table (2)
> 16 Fuse(10 A) YEK5001
(2) CONTRAST TABLE
DEH-P6200BT/XSUC, DEH-6200BT/XSEW5 and DEH-6250BT/XSES are constructed the same except for the fol-
lowing:
C
Mark No. Description DEH-P6200BT/XSUC DEH-6200BT/XSEW5 DEH-6250BT/XSES
7 Tuner Amp Assy YWM5471 YWM5467 YWM5468
12 FM/AM Tuner Unit CWE2097 CWE2097 CWE2098
17 Holder YNC5086 YNC5087 YNC5088
31 Chassis Unit YXA5720 YXA5719 YXA5720
DEH-P6200BT/XSUC
5 6 7 8
51
1 2 3 4
9.4 CD MECHANISM MODULE
A
(C)
(C)
B
B
(A)
(C)
(A)
D B C (A)
C
(D) (A)
D
C
(D)
(C)
(B)
(D)
(A)
(C) (A) (A)
D
(A) (A)
(C)
A C
(C)
(C) (A) : GEM1045
(B) : GEM1038
F (C) : GEM1024
(D) : GEM1043
52 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
CD MECHANISM MODULE SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Screw BMZ20P020FTC 50 Damper CNW1198
2 Screw BSZ20P040FTC A
3 Screw(M2 x 4) CBA1835 51 Arm CNW1726
4 Washer CBF1038 52 Motor Unit(M2)(LOAD/CRG) CXC4026
5 Spring CBH3010 53 Screw Unit CXC8894
54 Arm Assy CXC8896
6 Spring CBH2855 55 Washer CBF1037
7 Spring CBH2856
8 Spring CBH2860 56 Washer CBF1038
9 ••••• 57 Arm CND4554
10 Spring CBH3011 58 Collar CNV6906
59 Roller CNW1196
11 Spring CBH3012 60 Gear Unit CXC8893 B
12 Spring CBH3014
13 Spring CBH3015 61 Washer YE15FTC
14 Spring CBH3016 62 Chassis Unit CXE1946
15 Spring CBH3017 63 Motor Unit(M1)(SPDL) CXE2273
64 Screw JFZ20P025FTC
16 Spring CBH3018 65 Screw JGZ17P022FTC
17 Spring CBH3019
18 Spring CBH3020 66 Screw IMS20P030FTC
19 Spring CBL1797 67 CD Core Unit (S11STD-DOUT) CWX3774
20 Pickup Unit(S10.5)(Service) CXX1942
C
21 Bracket CND4553
22 Arm CND4555
23 Frame CND4557
24 Frame CND5217
25 Lever CND5398
26 Sheet CNN2280
27 Rack CNV8342
28 Guide CNW1171
29 Roller CNW1172 D
30 Arm CNW1173
31 Arm CNW1174
32 Roller CNW1175
33 Lever CNW1176
34 Arm CNW1177
35 Arm CNW1178
36 Gear CNW1180
37 Gear CNW1181
38 Gear CNW1182 E
39 Gear CNW1183
40 Rack CNW1184
41 Gear CNW1185
42 Gear CNW1186
43 Gear CNW1187
44 Gear CNW1188
45 Clamper CNW1190
46 Arm CNW1192
F
47 Holder CNW1193
48 Holder CNW1194
49 Damper CNW1197
DEH-P6200BT/XSUC
5 6 7 8
53
1 2 3 4
10. SCHEMATIC DIAGRAM
10.1 TUNER AMP PCB 1/2 and BT ANT PCB (GUIDE PAGE)
A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".
Large size
SCH diagram
A-a 1/2 : The power supply is shown with the marked box.
A-a A-b
uCOM_BUS
E.VOL
A 2/2 POWER_BUS
SYS8V BT3V C228 1u/10 BTTEL
BTTEL
NM
MIC1PF
CCG1236-A-T
R668 C211 1u/10
R667 R666 CDL CDL
NM
NM C209 0.22u/16
C661
TUNL TUNL
NM
BUSL+ E ONLY C226 1u/10 BUSL+
A-a A-b Guide page MIC1N C224 1u/10
JA661 A GND BUSL- BUSL-
C219
C221
KEYD1 C201 1u/10
1u/10
6 AUXL AUXL
(RMIC) 5 KEYD
WIRED REMOTE 4 AUXG
R202 C203 2.2u/10 AUXG
R662
&RMIC VR105C5R0AAA
VR105C5R0AAA
VR105C5R0AAA
3
VR105C5R0AAA
(W/R) 2 1k KEYAD1 100
1 1k
40
39
38
37
36
35
34
33
32
31
30
29
KEYAD
C204
NM
R207
R205
VA664
1u/10
VA663
22k
VA662
S1Q+R QCOM
YKS5035-A R661
MNL
MPL
SOL
S6L
S1Q+L
S3A+L
S6R S5B+L
VA665
INRL
INFL
S2A-L
S4B-L
PM9012A
IC201
A-a A-b Detailed page
S3A+R
S5B+R
S2A-R
S4B-R
INRR
INPR
AGND
INFR
MNR
MPR
SOR
GND
R208
R206
NM
22k
AGND
1
2
3
4
5
6
7
8
9
10
C222 11
12
B R468 C202 1u/10
C220
AUXR AUXR
1u/10
NM
C461 NM NM
Q465 BUSR- E ONLY C223 1u/10 BUSR-
NM BUSR+ C225 1u/10 BUSR+
R464
BTMICMUTE *E ON
R465
NM
TUNR C210 0.22u/16 TUNR
0
C212 1u/10
BT module CWX3865- CDR
BTTEL
C227 1u/10
CDR
BTTEL
C235
1000
CN461
C463
GND L461
0.1u/10
NM
D461
CKS6192-A
U3IN BT3V R474
U3OUT CTF1389-A EW5 ES UC
330u/10 Q471
BOOTS U3OUT C466 NM
U3IN 0
7 8 FM(10%) -12.51 dB -16.53 dB -11.25 dB
NBOOTS NRST_CPU
R473 NM R476
GND BTRST
6 9
VCC_MIC R472 0 C464NM GND NM BTRX
VSS AM(15%) -9.07 dB -13.19 dB -7.86 dB
R665
5 10 BTTX
MIC1N R470 NM C465NM
SPK1P
4 11 CD/USB
BT3V SPK1N MIC1P C462 NM BTTEL -10.13 dB -10.08 dB -8.36 dB
3 12 NM R458
C454
0
VSS SYS8V
VCC
C459
470p/50 IPBUS - - -8.64 dB
NM
2 13
R467 U1IN U1OUT R466 AGND LPF
1 14 R452 1 8
OUT1 VCC AUX IN
1k 1k 22k 2 7 R457 -8.26 dB -7.7 dB -3.32 dB
IN-1 OUT2 10
GND
3 6
IN+1 IN-2
4 5 10k
1u/10 GND IN+2
C452 0 R469 22k R451
C456
R455
220p/50
C457
C458
10u/16
R456
1u/10
IC451
10k
GND
SL
SSENS
KEYAD
R454
BTSENS
BTMICMUTE
22k NJM4558MD
C451 R471 22k
NM
R459
1u/10 NM R453 DACA GND
GND C455
JA101 470p/50
NM
CKS5271-A
R637
IPL- IP-BUS IP-BUS:-20.74 dB
R101 1k 47k
BUSL-
11 R624
IPR-
R102 1k BUSR-
10 IPR+ R103 22k
R104 RB751S-40
BUSR+ D602
9
NM
ASENBO R105
180
C611
8 R601 10k
C 7
IPL+ R106 180 22k
RX
BUSL+
PEE
1k
1
2
1 GND
R626
RX 2
6 IPG BUS-
R107 TX TX
5 IPPW BZ601
100 IPPW CPV1062-A
R109 R108
4
47
R111 VDD5V ILM GND
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
3 ASENBO1
BUS+ 2.2k IC101 ASENBO
R113
15
NC
NC
NC
NC
NC
NC
1k
AVCC
VREF
AVSS
MODEL
2
SL
1
KEYAD
SSENS
6 Q101 1
R112
ROT1
BT5VSENS
L101
R110 BUP
100
1 8
BTMICMUTE
1u
100
1 DIN1 STBY C1 E1 ROT0 2 ROT1
R114
NM
NM
2 7 5 2
ROUT VCC B2 B1 3 ROT0
C101
NM
C104
0.1u/16
5.6k
NM
C105
3 6 4 3 3.3k AANT
C102
C103
C106
DIN2 BUS+ E2 C2
0.1u/10
RESET 4
4 5 UMF23N R115 NC
GND BUS- 5
RWCNVSS NC
GND CNVSS 6
GND HA12241FP GND GND BYTE
*E only R602 7
CNVSS
SYS.MIC
DD5V 4.7k 8
C610 ISENS
D161 RESET 9
NC IC601
IC161 CRG03 VDD5V C604 NM 10
BD9781HFP RESET
CSS1797-A
C162
D162 12p/50 R604 11 (UC) PEG635A
C161
1u/16
220u
SYS8V
R603
X601
XOUT
1M
CRG03 0 12 (EW5) PEG634A
DDCON
20.000MHz
C605
GND
BUP VDD33 VSS1 (ES) PEG636A
VIN
INV
SW
EN
RT
FB
BLM15AG102SN1 13
10p/50 XIN
DD5V SYNC L602 14
1
3
4
5
6
2
GND C606
SYNC VCC1
USB5V 15
L161 0.1u/10 NMI
VDD3.3
SYS8V
CTH1253-A BSENS R605 100k 16
VDD5
BUP
BSENS
(15 uH) 17
NM
DSENS
R164
DSENS
1608
18
100k F
USB5V ASENS ASENS
R161
0.01u/16
VDCONT 19
220p/50
R163 C165
VDCONT
C167
CCH1804-A
C163
C164
0.1u/16
NM
470 1608
PEE 20
CMS02
D164
D163
C166
(150 u)
PEE
NM
100k D
USBCTL 21
R168
R165
68k
USBCTL
R167
33k
R162
NM
22
TELBEEP
23
USBFLG
R606 24
DALMON
D
R166
MED_RX
ASENBO
MED_TX
120 24k D
WRBSY
SYNC
SYSPW
DPDT
KEYD
KYDT
2.2k 25
PCL
NC
NC
RX
TX
RX2
R169
NM
R609 100k
R610 100k
NM
C607
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
R608
EPM
PCL1
MED_TX
MED_RX
GND
USB5V GND
R616
100k
R613 100k
IC151 USBCTL
R614 100k
L151 5 1 USBCTL
R619
VOUT EN R615 100k
DALMON 4.7k
2
R617
NM GND FLG
4 3 FLG D601
VIN FLG
RWCLK
KEYD2
GND RB551V-30
KYDT2
DPDT2
VDD3.3
SYS8V
C151
C152
R151
0.1u/10
0.1u/10
100k
R5523N001B
VDD5
BUP
R630 4.7k
R631 4.7k
GND
*E
TUNR
TUNER *only for C E TUNL
1200p/50
R410
1200p/50
100k
C408
R411
C409
100k
SYStoSH
SHtoSYS
SYSPW
RDSLK
EW UC:CWE2097- RCK
ES: CWE2098-
DALMON
ASENBO
DM
DP
DPDT
RWCLK
SYSPW
*only for A C E
SYNC
KEYD
CWE2097
KYDT
FLG
Y401 TUNR
RX
TX
2
2
B1 3
B1 3
E1 1
E1 1
22k
C2
C2
Rch TUNL 5 4
UMH1N
24 BUP
UMH1N
Q402
Lch
Q401
23 BEGND 6 3 VDD3.3
AGND RHSLK
22 7 2 VDD5
AGND
6 C1
6 C1
E2
5 B2
E2
5 B2
RDS_HSLK RLOCK 8 1
E 21 SYS8V SYS8V
4
RDS_LOCK R409
20 RDT
RDT
ROT1
SSENS
ROT0
FM/AM TUNER UNIT
RDS_DATA RCK RDS57K
19
GRILL
CCG1192-A
RDS_CK
CCG1201-A
18 TUN3V BTH1100-A
10u/10
VDD_3.3 1R0u
17 L402
CN801
0.01u/16
GND
C404
C405
C406
4.7u
NC2 TUNG
16 R408 CKS6188-A
DGND
15 DO C407 C410 1.5k DGND 0.1u/10
DGND 1
DO DGND
14 TD3V 0.01u/50 L403 ILMG SW3V C801
CCG1192-A ILMG 2
ROM_VDD OSCG R401 680 10u 1608
13 NM DI SW5V 3
OSCGND
R808 2.2k
SYS8V
12 LDET AGND R402 680 *only for A C LDET SOURCE
LDET SOURCE 4
11 DI R403 680 DO OELG 5 OELG
DI
10 CK R404 680 CK 6 KYDT1 R803 2.2k
CK KYDT
9 CE1 R405 680 CE1 USBG 7 USBG
CE1
8 OELB R805 2.2k
8
NC1
CE2
7
6
CE2
SL
R406
R407
680
680
CE2
SL
D OEL+B
USBG
DPDT
9
10
DPDT
C832
1u/10
R804 2.2k
R802 2.2k
SL
VCC
5 TUN8V
L401
CN1801 VBUS 11 VBUS
ROT11
4 ROT1 12
FMANT BTH1100-A
3 RFGND DM1 CTF1713-A R811
1R0u D- 13 1 6
RFGND 44 3 3
C401
ANT 8.2
0.01u/16
NM
VA811
ROT00
C402
2 1
2 IC431 ROT0 14 2 5
NM
NJM2885DL1-33 1608
CCG1192-A
AMANT
IMSA-6802-01Y900-T
10u/10
DP1
C403
1 22u D+ 15 3 4
X-2026 R810
L404
4
ILM+B
3
ZNR401
TUNER3V REG
JA401
2 GND
3 OUT
ILM+B 16 11 2 2 8.2
R814 100 L801
1 IN
1
AUXR 1608
CKX1070-A
AUX R 17 AUXR
KN401 R815 NM
3
AUXG
3.3V D431 D432 AUX G 18 AUXG
M2R6TP_GND R816 100
2
AUXL
AUX L 19 AUXL
NM NM
CCG1201-A
C432
DSENS
C433
R801 2.2k
C431
VA801 VR105C5R0AAA
VA802 VR105C5R0AAA
VA803 VR105C5R0AAA
VA806 VR105C5R0AAA
VA807 VR105C5R0AAA
VA808 VR105C5R0AAA
0.01u/16
DSENS 20
4.7u/6.3
1608 R809 100k
DZ2S068C
DZ2S068C
RFGND
DZ2S068C
DZ2S068C
DZ2S068C
D807
D808
D806
EW5 ES UC
F DGND
D805
D804
USB GND ILM GND
FM(10%) -33.42 dB -37.39 dB -35.46 dB OEL GND GND
ILM
AM(15%) -29.97 dB -34.07 dB -32.08 dB GND
AUX IN:-20.38 dB
A 1/2
54 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
rked box.
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
A-b 1/2 E:DEH-P6200BT/XSUC
A:DEH-6200BT/XSEW5
B:DEH-6250BT/XSES
Symbol indicates a capacitor. *
VOL R301-R306 Q301-Q303
NM : No Mount
No differentiation is made between chip capacitors and
discrete capacitors.
EXC E No Hi-out
E Hi-out
820
82
IMH3A-T
IMH23-T A 1/2 TUNER AMP PCB
SWL *
SWL C305 R305 R313
RL
R211 FL CCG1192-A 820 0 JA301
10U/10 for3P/O XKB7001-B
R311
NM 6 1E 1C 1
NM
22k
C311
14V
2SC4081(RS) 15V REFERENCE AREA MAP A 1/2 B 5 2B 2 RR P/O:1/2/3
NM
1 --/--/RR
C219
C221
1u/10
4 1B
14V
L202
NM Q201
R210
101
151
- 120
- 160
IP-BUS
USB H.SW
821 - 830 ILM+B
831 - 840 OEL+B
RCA OUT 2C
Q303
2E
3 RL
SWR
2 --/--/RL
3 SWR/SWR/SWR
C230 47u/16
161 - 170 DC-DC CONVERTOR 841 - 850 SWVDD
R312
NM
22k
C312
IMH3A SWL
0.1u/16
201 - 240 E.VOL 4 --/FR/SWL
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
100 851 - 860 HI-OUT FR
301 - 350 RCA 881 - 890 BT3V REG
S1Q+R QCOM
5 SWL/SWL/FR
UDZS15(B)
VREF DGND
C229
MNL
MPL
0.1u/16
SOL
OUTRL
VCCL DATA
OUTPL
CLK
VCCH STB
GND OUTFL
S6L
S1Q+L
D201
S3A+L
S6R S5B+L
C306 R306
NM 12 INPR INRL
OUTPR INPL
INRR INFL
S2A-L
S4B-L
351 - 380 AMP SWR FL
PM9012A
891 - 900 BT+B --/FL/FL
RCAG 6
C231
381 - 400 MUTE CCG1192-A 820
0
OUTRR
OUTFR
901 - 910 VDD5 & VDD3.3
S3A+R
S5B+R
10U/10 7 GND
S2A-R
S4B-R
401 - 430 TUNER
INFR
MNR
MPR
SOR
FILH
R203
431 - 440 TUNER 3V REG 911 - 920 SYS+B 8 GND
GND 921 - 930 ASENS&BSENS RL C303 R303
E ONLY 451 - 460 LPF
931 - 940 ISENS 9 GND
1
2
3
4
5
6
7
8
C220 9
1u/10 10
C222 11
13
14
15
16
17
18
19
20
CCG1192-A 820 for1or2P/O
461 - 490 BLUETOOTH&SWICTH 941 - 950 B.REM R316 10 GND
601 - 640 SYSTEM MICRO 951 - 960 TEL IN
10U/10
B
NM
R309
C309
6 1E 1C 1 NM
22k
Except E 641 - 650 ROM COLECTION 961 - 970 AUTO ANTENNA
R314
* For 3p/o * 5 2B 2
for3P/O
651 - 660 RESET
0
981 - 990 SOURCE CONNECTOR 1P/O YKB5010-
*E ONLY C234 4 1B
R209 0
661 - 670 WIRED REMOTE 3
R315 2P/O YKB5011-
1000p/50
801 - 820 GRILL 1101 ANTENNA 2C 2E 3P/O XKB7001-
Q302 NM
C213 CCG1192-A
CCG1192-A
NM
C235
miniSMDC075F/24
R310
8V
C310
IMH3A
22k
2
1000p/50 for2P/O
CCG1192-A
>
P301
C217 0.1u/10
C215 0.1u/10
CCG1192-A
C304 R304
C218
RR
1
CCG1192-A 820
C214
10U/10
FR C301 R301
FL
C216
10U/10
10U/10
10U/10
10U/10
RR CCG1192-A 820
AGND 10U/10
1
2
3
4
SWR ** except 1p/o
R201
NM
R307
C307
6 1E 1C 1 EW5 ES UC
22k
1k
D383 R385 Q382 ** 5 2B 2
FM(10%) 13.72 dB 9.72 dB 10.41 dB
8
7
6
5
E2 4 3 C2
1SS352 1k 4 1B 3 AM(15%) 17.25 dB 13.08 dB 13.14 dB
B2 5 2 B1 2C 2E
CD/USB 16.25 dB 16.2 dB 15.56 dB
R387
Q301
82
C1 6 1 E1
NM
R308
L201
22k
C308
IMH3A - -
C381
22u/16
RT3T22M IPBUS 15.25 dB
17.15 dB 17.63 dB 17.32 dB
VCK
VDT
AUX IN
VST
GND
NM FR C302 R302
IC351
GND CCG1192-A 820 PA2030A
BTPW
SL
AMP
SSENS
KEYAD
BTRST
RDT
BTSENS
BTMICMUTE
RDS57K
BTRX
10U/10
1
TAB
2
GND PW-GND2
RL2 3
Q363 OUT2(-)
R632
R365 4
680
STBY
R633
E2 4 3 C2
** RL1 5
0
R366
10k
10k
A-D E B2 5 OUT2(+)
47k 2 B1 C366 6
R624 R351~R354 0R0 3.6K VCC2
R638 C1 6 1 E1
R355-R358 NM 5.6K RT3T22M
NM FL2 7
RB751S-40 (2125) OUT1(-)
100k 100k C368-C371 22p NM 8
D602 PW-GND1
NM SYSPW
NM
R636 GND C365
R635 9
10uH ** FL1
C611
10k 1608
R626 GND
SG001528 3.3V
L601
BTH1103-A VDD3.3
R351 3.6k -4.3dB E only
10u/35
CCG1236-A
10
OUT1(+)
RIPPLE
C
FL C352 0.47u/10 C356 0.47u/16 11
CCG1201-A
FL
IN1
CCG1192-A
C603
C601
BTTESTMD
NM
C602
R352 RL C351 0.47u/10
10u/10
C355 0.47u/16
4.7u
BTTESTIN RL 3.6k 12
IN2
VDD3.3
SYS8V
13
BUP
PRE-GND
RR R353 3.6k RR C353 0.47u/10 C357 0.47u/16 14
98
97
96
95
94
93
92
91
90
89
88
87
86
BTRST 85
BTPW 84
83
82
NC 81
NC 80
NC 79
78
77
76
IN4
GND FR R354 3.6k FR C354 0.47u/10 C358 0.47u/16 15
NC
NC
NC
NC
NC
AVCC
R634
VREF
AVSS
MODEL
SL
BTTESTMD
75 IN3
KEYAD
SSENS
BTTX
BTTESTIN
BT5VSENS
22p/50
BTMICMUTE
BTTX C363 2.2u/10 16
R356
22p/50
22p/50
R357
C369
22p/50
R355
C368
C370
C371
R358
5.6k
5.6k
5.6k
5.6k
74 0 RDSLK MUTE3 AC-GND
RDSLK R384 2.2u/10 C364 17
RDS57K
FR1
RDSDT
73 R364 C372 C373 OUT3(+)
BTRX
NC 47k R361 R363 18
GND
72 LDET PW-GND3
LDET 10k 330 NM NM NM FR2 19
71 RCK MUTE D382 AGND OUT3(-)
RCK C362 20
CCG1192-A
70 TP70 R611 DAN202U VCC1
R362
C367
10U/10
NC 0.1u/16 21
SYS.MICRO
10k
TP69 RR1
69 100k C612 R383 OUT4(+)
NC 47p/50
MUTE 22
68 47k MUTE2 R382MUTE1 MUTE
NC C609 Q361 23
D381 LTC114EUB RR2
IC601 67 47p/50 DO OUT4(-)
TUNPDO 100k Q362 C361 24
Q381
66 DI UDZS8R2(B) 2SC4081(RS) NM PW-GND4
TUNPDI CCH1486-A 25
47k AGND 3300/16
(UC) PEG635A8 TUNPCK
65 R622 CK H-SW/VOS-DET
105
(EW5) PEG634A8 64 0 R381
(ES) PEG636A8 TUNPCE1
CE1 BT3V REG GND 5.2V GND GND
63 CE2 D881 BT5V BT+B
2SD2396(K)
CRG03
TUNPCE2 1 5 NM CRG03
D941
62 VOUT Q891
VSS R643 VIN
2
61 TEST1 R623 100k D891
TESTIN 100k VSS
3 4
60 L603 C608 0.1u/10 B.REM
R892
NC SW
R891 4.7k
VCC
R893
GND IC882
39k
59 IC641 S-1132B33-U5
NC GND RT3T22M
58 BLM15AG102SN1 NM
(1/4W)
1 8 C2 3 4 E2
0
ROMCS CS VCC IC881
57 2 7 B1 2 5 B2
NM
0.1u
C641
R894
NT SK
C893 (105)
ROMCK NC
10k
GND
OUT
56 3 6 E1 1
ROMDATA DI TEST 6 C1
UDZS5R6(B)
IN
R642 BT3V Q892
100u/16
55 4 5 BT3V
0.01u/50
D892
C892
VST DO
SYS8V
L GND
3
2
1
BUP
3.3V
VDD3.3
NM
100K
R641
54 NM
VCK
CRG03
EP
0.047u/50
1K NM GND
D942
C941
0.01u/50
53
4.7u/16
C882
C883
C891
47u/16
C885
C884
VDT
NM
G
47u/16
MEDMUTE
C881
1u/10
MEDSTBY
IPPW 52
DALMON
D
MEDRST
MED_RX
ASENBO
MED_TX
GND
SWVDD
WRBSY
SYSPW
50 OELPW
MUTE
ILMPW
DPDT
KEYD
KYDT
51 No MOUNT
PCL
NC
NC
NC
NC
NC
NC
RX
TX
BTSENS GND
ROM CORRECTION GND
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
BTPW
VST
CE
GND
MEDMUTE
EPM
VDD5
MEDSTBY
R620 VCK
PCL1
MED_TX
MED_RX
VDD5V
100k VDT VDD3.3 IC901
VDD5.0
2 GND
3 OUT
VDD5V
R616
100k
NM Q901 D901
1 IN
5.2V 2SD2396(K) CRG03
RESET2
R652 RESET
R619
R618 100k
R607 100k
DALMON 4.7k
VDD33
R902
R901
1.5k 1 5
R617
39k
6.8k
IC651
100k
CCH1201-A
CCG1192-A
CN601 RESET 1 4 VOUT VIN
1000u/16
2
10U/10
VDD2
C904
OUT VSS VDD33V Q902
NM
C903
NM VSS
RWCLK
3 4
KEYD2
C901
3.3V
KYDT2
DPDT2
C2 3 4 E2
10
3
9
8
7
6
5
4
3
2
1
2 NC SW
UDZS5R6(B)
VDD NC IC902 B1 2 5 B2
GND S-80827CNNB-B8M S-1132B33-U5
D902
0.01u/16
C902
VDD3.3
E1 1 6 C1
SYS8V
VDD5
RT3T22M
BUP
C906
NM
4.7u/6.3
C907
C905
1SS352-TRB
D651
4.7u/6.3
R651
SOURCE
100k
GND BUP CONNECTOR
GND GND
CSG1020-A
JA981
2
DALMON
S651
IC911
C651
NJM2388F84 600uH CKM1586-A
1u/10
SYS+B
CRG03
CRG03
D981
D982
BSENS&ASENS
>FUSE
ASENS
CONTROL
CTH1432-A
1
BSEN2 BSEN1
MEDMUTE
L981
MEDSTBY
D921
SYStoSH
SHtoSYS
MEDRST
VOUT
R921 18 YEK5001
SYSPW
GND
RT3CLLM(EF)
10A
VIN
SYS8V 100k HZU7L(C2) 17
C2
GND
E1
B1
R923
47k
1
2
3
GND2 GND1
4
3
2
1
16
Q921
SYS+B
RWCNVSS
BUP2 BUP1
DALMON
ASENBO
DALMON
SWVDD
8.4V 15
DM
OELPW
DP
DPDT
RWCLK
SYSPW
RWCLK
ILMPW
GND
RESET
MUTE
BRE1
KEYD
KYDT
KEYD
DPDT
KYDT
IPPW
GND
C1
6
5
4
B2
E2
8VCNT ASENS D922 14
BSENS R922 R926 ACC1
R911 13
10k HZU7L(A1) 1k
BUP BUP 1k 12
R924
R925
C921
0.1u/16
47k
4.7k
C912
NM
C911
R912
C913
11
47k
100u/16
VDD3.3
220u
VDD3.3
VDD5 VDD5 10
SYS8V SYS8V SYS8V GND
RR2 RR2
9
8
E
SYSPW
KYDT
DPDT
ROT1
SSENS
DSENS
ROT0
GND RL2 RL2
7
RR1 RR1
6
RL1 RL1
5
SWVDD
SYSPW
OELPW
OELPW
SYSPW
ILMPW
FR2 FR2
4
OEL+B 9.3V
FL2 FL2
2SD1767(R) BUP 3
SWVDD Q834 9.3V FR1 FR1
2SA1036K(QR) 2
Q831
1608 L841
3.3V
Q841 D832 FL1 FL1
1
LSA1576UB DAN202U
R851
B
1
R831
10u
R808 2.2k
BT ANT PCB
10k
NM R844 R835
10k Q832 R833 R834
10k
R843
R803 2.2k C2 3 4 E2
1k
R836
100 100
1k
(1/4W)
R841
HZU10(B1)
C841
C842
R842
1u/10
NM
Q842 1608 1608
NM
C831
B1 2 5 B2
0.047u/50
4.7k
D831
LTC114EUB
R805 2.2k R812 E1 1
Q833 6 C1
100k LTC114EUB RT3T22M
R804 2.2k
R802 2.2k BT ANTENNA
DGND DGND CN1101
GND ILM GND CKS5749-A-TLB
CTF1713-A R811 * E only 2 1
ILM+B BUP
44 3 3 8.2 15V RB551V-30 HI-OUT 14V 3
NM
1608 15V Q853 Q821
15V D851 L851 9.3V 13.9V R821 2SA1036K(QR)
2SA1036K(QR)
R810 1
15k
CTF1660-A
0.022u/50
11 2 2 8.2 R858
L801 IC851 R823
1608
CCG1236-A-T
C852
10u/35
R853
R852 10k
C853 NM 47u/16
1 8
R859
10k
1k
CS CD GNDRF
C854
R822
2 7 820
(1/4W)
4.7k
ES SI Q854
3 6 LTC114EUB
R854 3.3k
R813
C855
R801 2.2k
R855
CT V+
BT MODULE
2.2k
1608 R809 100k 4 5 Q822
100k GND INVIN
100u/16
0.1u/16
LTC114EUB
C857
470p/50
C856
C851
NJM2360M GND
GND GND
TUNER AMP ASSY F
ILM GND
The > mark found on some component parts indicates Consists of
the importance of the safety factor of the part. TUNER AMP PCB
Therefore, when replacing, be sure to use parts of BT ANT PCB
identical designation.
A 1/2
DEH-P6200BT/XSUC
5 6 7 8
55
F
E
B
A
D
C
56
NOTE : A-a A-b E:DEH-P6200BT/XSUC
A-b 1/2 Symbol indicates a resistor. A:DEH-6200BT/XSEW5
No differentiation is made between chip resistors and B:DEH-6250BT/XSES
discrete resistors.
Symbol indicates a capacitor. *
R301-R306 Q301-Q303
1
1
No differentiation is made between chip capacitors and EXC E No Hi-out 820 IMH3A-T
NM : No Mount discrete capacitors. E Hi-out 82 IMH23-T A 1/2 TUNER AMP PCB
SWL *
SWL C305 R305 R313
RL
FL CCG1192-A 820 0 JA301
R211 10U/10 XKB7001-B
for3P/O
NM 6 1E 1C 1
22k
R311
NM
14V RR P/O:1/2/3
C311
5 2B 2
2SC4081(RS) 15V REFERENCE AREA MAP A 1/2 B 1 --/--/RR
14V RL
NM
NM Q201 4 1B 3
C221
IP-BUS
C219
101 - 120 821 - 830 ILM+B 2 --/--/RL
1u/10
L202 RCA OUT 2C 2E SWR
151 - 160 USB H.SW 831 - 840 OEL+B
R210 Q303 3 SWR/SWR/SWR
161 - 170 DC-DC CONVERTOR 841 - 850 SWVDD IMH3A SWL
22k
NM
4 --/FR/SWL
33
32
31
30
28
27
R312
24
23
22
21
100 201 - 240 E.VOL
C312
851 - 860 HI-OUT FR
301 - 350 RCA
0.1u/16
881 - 890 BT3V REG 5 SWL/SWL/FR
SWR C306 R306 FL
MNL
MPL
SOL
CLK
STB
351 - 380 AMP --/FL/FL
C229
C230 47u/16
D201
891 - 900 BT+B RCAG 6
0
CCG1192-A 820
0.1u/16
OUTPL 26
OUTRL 25
381 - 400 MUTE
C231
TUNER 901 - 910 VDD5 & VDD3.3 10U/10 7 GND
401 - 430
UDZS15(B)
431 - 440 TUNER 3V REG 911 - 920 SYS+B 8 GND
MPR
SOR
INFR
INRR INFL
OUTPR INPL
OUTRR
OUTFR
GND OUTFL
VREF DGND
VCCL DATA
FILH
VCCH
R203
GND 921 - 930 ASENS&BSENS RL C303 R303
E ONLY LPF
8
9
451 - 460 9 GND
931 - 940 ISENS
13
14
15
16
17
18
19
20
CCG1192-A 820 for1or2P/O
461 - 490 BLUETOOTH&SWICTH 941 - 950 B.REM R316 10 GND
10U/10
601 - 640 SYSTEM MICRO 951 - 960 TEL IN
NM 12 INPR INRL 29
NM
C220
6 1E 1C 1
C222 11
1u/10 10
NM
22k
641 - 650 ROM COLECTION
R309
961 - 970 AUTO ANTENNA
C309
2
2
Except E 5 2B 2
0
651 - 660 RESET 981 - 990 SOURCE CONNECTOR * For 3p/o *
R314
*E ONLY C234 1P/O YKB5010-
661 - 670 WIRED REMOTE 4 1B 3
1000p/50 R315 2P/O YKB5011-
for3P/O
801 - 820 GRILL 1101 ANTENNA 2C 2E 3P/O XKB7001-
R209 0
Q302 NM
C235 8V IMH3A
2
for2P/O
NM
1000p/50
22k
R310
C310
C304 R304
P301
RR
>
CCG1192-A
1
C218
CCG1192-A 820
CCG1192-A
10U/10
C213 CCG1192-A
miniSMDC075F/24
CCG1192-A
C214
C215 0.1u/10
C217 0.1u/10
FR C301 R301
FL
RR CCG1192-A 820
C216
1
2
3
4
AGND 10U/10
10U/10
10U/10
10U/10
10U/10
SWR ** except 1p/o
6 1E 1C 1 EW5 ES UC
1k
NM
22k
R201
D383 Q382
R307
C307
R385 ** 5 2B 2
8
7
6
5
FM(10%) 13.72 dB 9.72 dB 10.41 dB
1SS352 1k E2 4 3 C2 4 1B 3 AM(15%) 17.25 dB 13.08 dB 13.14 dB
B2 5 2 B1 2C 2E
Q301 CD/USB 16.25 dB 16.2 dB 15.56 dB
82
L201 C1 6 1 E1 IMH3A
DEH-P6200BT/XSUC
R387
- -
22k
RT3T22M
NM
IPBUS 15.25 dB
R308
C308
C381
17.15 dB 17.63 dB 17.32 dB
22u/16
NM GND AUX IN
C302 R302
VDT
VCK
VST
FR
IC351
GND CCG1192-A 820 PA2030A
10U/10 AMP
RDT
1
BTPW
BTRX
TAB
3
3
SSENS
BTRST
2
RDS57K
BTSENS
GND PW-GND2
RL2 3
BTMICMUTE
Q363 OUT2(-)
R365 4
680
STBY
R632
E2 4 3 C2
0
** 10k RL1 5
R633
A-D E OUT2(+)
10k
B2 5 2 B1 C366
R366
47k 6
R624 R351~R354 0R0 3.6K VCC2
R638 C1 6 1 E1
R355-R358 NM 5.6K NM FL2 7
RT3T22M (2125) OUT1(-)
RB751S-40 100k C368-C371 8
100k 22p NM
D602 SYSPW PW-GND1
R636
NM GND C365
R635 10uH FL1 9
10k
L601
** 1608 OUT1(+)
GND 10u/35 10
R626 3.3V BTH1103-A VDD3.3 CCG1236-A RIPPLE
SG001528 -4.3dB E only
FL R351 3.6k FL C352 0.47u/10 C356 0.47u/16 11
BTTESTMD IN1
RL R352 RL C351 0.47u/10 C355 0.47u/16 12
BTTESTIN 3.6k
NM
IN2
C603
4.7u
C601
C602
13
10u/10
PRE-GND
CCG1201-A
C357 0.47u/16
BUP
RR C353 0.47u/10 14
CCG1192-A
VDD3.3
SYS8V
RR R353 3.6k
90
89
88
87
86
83
82
78
77
76
IN4
GND FR R354 3.6k FR C354 0.47u/10 C358 0.47u/16 15
75 R634 IN3
NC 81
NC 80
NC 79
BTTX
NC
NC
NC
BTTX C363 2.2u/10 16
BTPW 84
74 0 RDSLK AC-GND
BTRST 85
MUTE3
R356
2.2u/10
5.6k
5.6k
SSENS
R357
C369
C368
R355
C370
5.6k
C371
RDSLK R384 C364 17
5.6k
R358
22p/50
FR1
22p/50
22p/50
22p/50
73 R364 C372 C373 OUT3(+)
NC R361 R363
BTTESTIN
BTTESTMD
47k 18
BT5VSENS
GND
72 LDET PW-GND3
BTMICMUTE
RDS57K
RDSDT
BTRX
LDET 10k 330 NM NM NM FR2 19
71 RCK MUTE D382 AGND OUT3(-)
RCK C362 20
70 TP70 R611 DAN202U VCC1
NC 0.1u/16 21
4
RR1
4
TP69
10k
69 100k C612 R383 OUT4(+)
R362
C367
SYS.MICRO NC MUTE 22
10U/10
47p/50
68 47k MUTE
CCG1192-A
NC C609 MUTE2 R382MUTE1 Q361 23
D381 LTC114EUB RR2
IC601 67 47p/50 DO OUT4(-)
TUNPDO 100k Q362 C361 24
Q381
66 DI UDZS8R2(B) 2SC4081(RS) NM PW-GND4
TUNPDI CCH1486-A 25
65 R622 47k AGND 3300/16 H-SW/VOS-DET
UC) PEG635A8 TUNPCK CK
105
EW5) PEG634A8 64 0 R381
CE1 BT3V REG GND 5.2V GND GND
ES) PEG636A8 TUNPCE1 BT+B
63 CE2 D881 BT5V
TUNPCE2 1 5 2SD2396(K)
NM Q891 CRG03
62 VOUT VIN
VSS R643 2
D941
100k
CRG03
61 TEST1 R623 D891
TESTIN 100k VSS
3 4
60 L603 C608 0.1u/10 B.REM
VCC NC SW
GND IC882
R892
59 IC641 S-1132B33-U5
39k
NC
R893
GND RT3T22M
58 BLM15AG102SN1 1 8 NM
0
CS IC881 C2 3 4 E2
ROMCS VCC
R891 4.7k
57 2 7
(1/4W)
SK B1 2 5 B2
ROMCK NC
0k
641
894
05)
T
D
0.1u
NM
56 3 6
66 DI UDZS8R2(B) 2SC4081(RS) NM PW-GND4
TUNPDI CCH1486-A 25
65 R622 47k AGND 3300/16 H-SW/VOS-DET
UC) PEG635A8 TUNPCK CK
105
EW5) PEG634A8 64 0 R381
CE1 BT3V REG GND 5.2V GND GND
ES) PEG636A8 TUNPCE1 BT+B
63 CE2 D881 BT5V
TUNPCE2 1 5 2SD2396(K)
NM Q891 CRG03
62 VOUT VIN
VSS R643 2
D941
100k
CRG03
61 TEST1 R623 D891
TESTIN 100k VSS
3 4
60 L603 C608 0.1u/10 B.REM
VCC NC SW
GND IC882
R892
59 IC641 S-1132B33-U5
39k
NC
R893
GND RT3T22M
58 BLM15AG102SN1 1 8 NM
0
CS IC881 C2 3 4 E2
ROMCS VCC
R891 4.7k
57 2 7
(1/4W)
SK B1 2 5 B2
ROMCK NC
0.1u
NM
10k
56 3 6
C641
R894
DI E1 1 6 C1
ROMDATA TEST
OUT
GND
IN
R642 BT3V Q892
55 4 5 BT3V
VST
3
2
1
DO GND 3.3V
C893 (105)
54
D892
C892
NM
BUP
NM
VCK
100u/16
100K
R641
1K GND
SYS8V
0.01u/50
53 NM
VDD3.3
UDZS5R6(B)
VDT
D942
C941
NM
5
CRG03
5
C882
C883
C891
IPPW 52
C885
C884
GND
4.7u/16
47u/16
C881
1u/10
0.01u/50
0.047u/50
47u/16
51 No MOUNT
NC
MUTE
DALMON
SYSPW
PCL
ASENBO
WRBSY
NC
MEDSTBY
MEDRST
MEDMUTE
NC
NC
NC
SWVDD
ILMPW
BTSENS GND
ROM CORRECTION GND
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50 OELPW
BTPW
VST GND
CE
R620 VCK VDD5
EPM
VDD5V
PCL1
100k VDT VDD3.3 IC901
VDD5V Q901 VDD5.0 D901
MEDSTBY
MEDMUTE
NM CRG03
5.2V 2SD2396(K)
100k
R616
RESET2
3 OUT
2 GND
1 IN
R652 RESET
1.5k VDD33 1 5
IC651
R619
39k
1 4 VOUT VIN
R902
R901
6.8k
2
R617
100k
CN601 RESET OUT VSS Q902 VDD2
NM VDD33V VSS
3 4
R607 100k
3.3V
R618 100k
C904
NM
C903
9
C2 3 4 E2
8
7
6
5
4
3
2
1
10U/10
10
3 NC
1000u/16
2 SW
C901
CCH1201-A
CCG1192-A
VDD NC IC902 B1 2 5 B2
GND S-80827CNNB-B8M S-1132B33-U5 E1 1 6 C1
RT3T22M
D902
C902
NM
VDD3.3
SYS8V
BUP
SOURCE
VDD5
0.01u/16
C906
UDZS5R6(B)
C907
C905
D651
BUP
R651
100k
GND CONNECTOR
4.7u/6.3
4.7u/6.3
GND
2
GND
1SS352-TRB
DALMON JA981
IC911
NJM2388F84 600uH CKM1586-A
S651
ASENS BSENS&ASENS
C651
SYS+B
1
CTH1432-A
1u/10
D981
D982
BSEN2 BSEN1 L981
CSG1020-A
6
6
CRG03
CRG03
R921 D921
>FUSE
18 YEK5001
10A
CONTROL
GND
VOUT
VIN
GND SYS8V 100k HZU7L(C2) 17
1
E1
2
B1
3
C2
GND2 GND1
SYSPW
MEDSTBY
MEDRST
MEDMUTE
4
3
2
1
47k
16
R923
SYS+B
BUP2 BUP1
8.4V 15
Q921
GND
DM
DP
RT3CLLM(EF)
BRE1
6
5
4
GND 14
C1
B2
E2
8VCNT R922 ASENS D922 R926
MUTE
ILMPW
SWVDD
OELPW
BSENS ACC1
DALMON
SYSPW
ASENBO
IPPW
RESET
KYDT
KEYD
DPDT
RWCNVSS
RWCLK
DALMON
R911 13
10k HZU7L(A1) 1k
BUP BUP 1k 12
47k
VDD3.3 11
R924
R925
4.7k
C921
VDD3.3
NM
47k
C912
0.1u/16
C911
R912
C913
220u
VDD5 VDD5 10
100u/16
SYS8V SYS8V GND 9
RR2 RR2
8
GND RL2 RL2
7
KYDT
DPDT
ROT1
ROT0
RR1
SYSPW
RR1
SSENS
DSENS
6
RL1 RL1
5
FR2 FR2
4
OEL+B 9.3V FL2
SYSPW
OELPW
SWVDD
OELPW
SYSPW
ILMPW
FL2
2SD1767(R) BUP 3
SWVDD Q834 9.3V FR1 FR1
2SA1036K(QR) 2
DEH-P6200BT/XSUC
L841 Q831 FL1
Q841 D832 FL1
3.3V LSA1576UB DAN202U 1
1
10u
R851
NM R844 R835
10k
R831
BT ANT PCB
7
7
10k Q832 R833 R834
10k
C2 3 4 E2
B
1k
100 100
R843
1k
Q842 1608 1608
R836
B1 2 5 B2
NM
NM
LTC114EUB
R841
C841
C842
R842
1u/10
4.7k
(1/4W)
R812
C831
D831
Q833 E1 1 6 C1
100k LTC114EUB RT3T22M
HZU10(B1)
0.047u/50
BT ANTENNA
DGND DGND CN1101
GND ILM GND CKS5749-A-TLB
811 * E only 2 1
ILM+B BUP
2 15V
08 15V RB551V-30 HI-OUT 14V Q853 Q821 3
15V D851 L851 9.3V 13.9V R821 2SA1036K(QR)
2SA1036K(QR)
810 1
CTF1660-A
15k
8.2 R858
608 IC851 R823
1 8 R852 10k
10k
C852
0.022u/50
1k
CS CD
R853
GNDRF
10u/35
R859
2 7 820
ES SI Q854
C854
R822
4.7k
3 6 LTC114EUB
R813
CCG1236-A-T
(1/4W)
CT V+
4 5
C855
R809 100k Q822
R855
2.2k
100k GND INVIN LTC114EUB
BT MODULE
C853 NM 47u/16
R854 3.3k
C857
C856
0.1u/16
NJM2360M GND
C851
100u/16
470p/50
GND GND
8
8
ILM GND
TUNER AMP ASSY
The > mark found on some component parts indicates Consists of
the importance of the safety factor of the part. TUNER AMP PCB
Therefore, when replacing, be sure to use parts of BT ANT PCB
identical designation.
A-a A-b
A-b 1/2
57
E
A
D
C
F
B
F
E
B
A
D
C
58
A-a A-b
: The power supply is shown with the marked box.
A-b 1/2
A-a 1/2
uCOM_BUS
1
1
E.VOL
A 2/2 POWER_BUS
SYS8V BT3V C228 1u/10 BTTEL
BTTEL
NM
MIC1PF R668
R667 R666 CDL C211 1u/10 CDL
NM
NM TUNL C209 0.22u/16 TUNL
NM
C661
BUSL+ E ONLY C226 1u/10 BUSL+
CCG1236-A-T
MIC1N C224 1u/10
BUSL- BUSL-
JA661 A GND
6 KEYD1 AUXL C201 1u/10 AUXL
NM
(RMIC) KEYD
C219
C221
5 R202
1u/10
WIRED REMOTE 4 AUXG C203 2.2u/10 AUXG
3 R662
&RMIC 1k KEYAD1
(W/R) 2 100
1 1k KEYAD
40
39
37
35
34
33
32
31
30
29
28
27
YKS5035-A R661
NM
22k
C204
R207
R205
1u/10
S6L
MNL
MPL
SOL
VA664
VA663
VA662
VA665
S1Q+L 38
S2A-L
S3A+L 36
S4B-L
OUTPL 26
OUTRL 25
VR105C5R0AAA
VR105C5R0AAA
VR105C5R0AAA
VR105C5R0AAA
GND AGND IC201
PM9012A
S1Q+R QCOM
S2A-R
S3A+R
S4B-R
S5B+R
S6R S5B+L
MNR
MPR
SOR
INFR
INRR INFL
INPR INRL
OUTPR INPL
OUTRR
OUTFR
GND OUTFL
AGND
22k
NM
R208
R206
1
2
3
4
5
6
7
8
9
12
13
14
15
16
R468 AUXR C202 1u/10 AUXR
C461 NM
NM
C220
NM C223 1u/10
C222 11
1u/10 10
BUSR- E ONLY BUSR-
Q465
2
2
NM BUSR+ C225 1u/10 BUSR+
R464 C234
BTMICMUTE C210 0.22u/16
*E ONLY
TUNR TUNR 1000p/50
NM
0
R465
CDR C212 1u/10 CDR
BT module CWX3865- C235
C227 1u/10 1000p/50
BTTEL BTTEL
CN461 GND L461
CKS6192-A
NM
C463
BT3V R474
D461
U3IN U3OUT CTF1389-A ES UC
0.1u/10
330u/10
EW5
BOOTS NM Q471
U3IN U3OUT C466
7 8 0 FM(10%) -16.53 dB -11.25 dB
R473 NM R476 BTRST
-12.51 dB
NBOOTS NRST_CPU GND
6 9
C464NM GND NM BTRX
VSS VCC_MIC R472 0 AM(15%) -9.07 dB -13.19 dB -7.86 dB
5 10 BTTX
C465NM AG
R665
SPK1P MIC1N R470 NM
4 11 CD/USB
BT3V SPK1N MIC1P C462 NM BTTEL -10.13 dB -10.08 dB -8.36 dB
3 12 NM R458
0
C454 SYS8V
VCC VSS 470p/50
2 13 IPBUS - - -8.64 dB
R466
NM
R467 U1IN U1OUT AGND LPF
C459
1 14 R452 1 8
1k OUT1 VCC AUX IN
1k 22k 2 7 R457 -8.26 dB -7.7 dB -3.32 dB
IN-1 OUT2 10
GND
DEH-P6200BT/XSUC
3 6
IN+1 IN-2
4 5 10k
1u/10 GND IN+2
C452 0 R469 22k R451
R455
C456
GND IC451
R454
SL
C457
10k
C458
NJM4558MD
R456
1u/10
10u/16
22k
220p/50
C451 R471 22k
BTPW
3
3
SSENS
1u/10
BTRST
KEYAD
NM
NM
R453 DACA GND
BTSENS
R459
C455
BTMICMUTE
GND 470p/50
JA101
680
CKS5271-A
R632
NM
IPL- IP-BUS IP-BUS:-20.74 dB
R637
R101 1k BUSL- 47k
11 R624
IPR-
R102 1k BUSR-
10 IPR+ R103 22k
R104 RB751S-40
BUSR+ D602
9 ASENBO R105
180
NM
8 PEE R601 1 10k
IPL+ R106 22k GND
180 BUSL+ 1
C611
7 1k 2 R626
RX 2
BUS- RX
6 IPG
R107 TX TX BTTES
5 IPPW BZ601
100 IPPW CPV1062-A
4
47
R111 VDD5V ILM GND
ASENBO1
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
83
3
BUS+ 2.2k IC101 ASENBO
15
1k
2 ROT1 1
NC
NC
NC
SL
NC
NC
NC
R109 R108
R110 6 Q101 1 BUP
R113
100 1 8
1u
100
C1 E1
AVCC
VREF
AVSS
BTPW 84
1 DIN1 STBY
R112
L101
ROT0
BTRST 85
5 2 R114 2 ROT1
MODEL
KEYAD
SSENS
2 7
NM
NM
ROUT VCC B2 B1 3 ROT0
3 6 4 3 5.6k 3.3k AANT
BTTESTMD
BT5VSENS
NM
C101
NM
DIN2 BUS+ E2 C2
C104
4
C105
RESET
BTMICMUTE
4 5 R115
C102
C103
NC
0.1u/16
UMF23N
C106
GND BUS- 5
RWCNVSS
0.1u/10
NC
GND CNVSS 6
GND HA12241FP GND GND BYTE
4
4
*E only R602 7 SYS.MICRO
CNVSS
DD5V 4.7k 8
C610 ISENS
D161 RESET 9
NC IC601
IC161 CRG03 C604 NM 10
VDD5V RESET
BD9781HFP
D162 SYS8V 12p/50 R604 11 (UC) PEG635A8
XOUT
C162
1M
C161
220u
(EW5) PEG634A8
1u/16
CRG03 0 12
X601
R603
DDCON BUP C605 VSS1 (ES) PEG636A8
VDD33
13
VIN
SW
GND
EN
RT
FB
INV
BLM15AG102SN1
CSS1797-A
10p/50 XIN
SYNC L602
1
3
4
5
6
2
7
DD5V C606 14
GND VCC1
20.000MHz
SYNC
USB5V 15
L161 0.1u/10 NMI
CTH1253-A BSENS R605 100k 16
BSENS
(15 uH) 17
BUP
DSENS
SYS8V
VDD3.3
VDD5
DSENS
NM
USB5V ASENS 18
R164
1608
ASENS
R161 VDCONT 19
VDCONT
100k F
1u/16
A
3
p/50
4
6
165
67
8
20
M
IC161 CRG03 C604 NM 10
VDD5V RESET
BD9781HFP
D162 SYS8V 12p/50 R604 11 (UC) PEG635A8
XOUT
C162
1M
C161
220u
(EW5) PEG634A8
1u/16
CRG03 0 12
X601
R603
DDCON BUP C605 VSS1 (ES) PEG636A8
VDD33
13
VIN
SW
GND
EN
RT
FB
INV
BLM15AG102SN1
CSS1797-A
10p/50 XIN
SYNC L602
1
3
4
5
6
2
7
DD5V C606 14
GND VCC1
20.000MHz
SYNC
USB5V 15
L161 0.1u/10 NMI
CTH1253-A BSENS R605 100k 16
BSENS
(15 uH) 17
BUP
DSENS
SYS8V
VDD3.3
VDD5
DSENS
NM
USB5V ASENS 18
R164
1608
ASENS
VDCONT 19
R161
VDCONT
100k F
PEE 20
0.01u/16
C167
PEE
NM
220p/50
C163
C164
USBCTL 21
NM
D164
D163
C166
0.1u/16
USBCTL
CMS02
(150 u)
68k
22
R163 C165
100k D
470 1608
R168
R165
33k
CCH1804-A
R167
TELBEEP
NM
R162
23
USBFLG
5
R606
5
24
SYNC
R166
2.2k 25
RX2
NC
RX
TX
DPDT
KYDT
NC
KEYD
MED_TX
MED_RX
DALMON
SYSPW
PCL
ASENBO
WRBSY
NC
MEDSTBY
MEDRST
MEDMUTE
NM
120 24k D
R169
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
NM
C607
R608
R609 100k
R610 100k
EPM
GND
PCL1
USB5V GND R613 100k
MEDSTBY
MEDMUTE
MED_TX
MED_RX
IC151 USBCTL
100k
R616
R614 100k
L151 5 1 USBCTL
VOUT EN R615 100k
2
R619
NM GND FLG
R617
100k
4 3 FLG D601
VIN FLG
R607 100k
GND
R618 100k
RB551V-30
DALMON 4.7k
R5523N001B
KEYD2
RWCLK
KYDT2
DPDT2
C151
C152
R151
100k
R630 4.7k
SYS8V
VDD3.3
VDD5
BUP
0.1u/10
0.1u/10
R631 4.7k
GND
*E
TUNR
TUNER *only for C E TUNL
6
6
R410
100k
C408
R411
100k
C409
RDSLK
1200p/50
1200p/50
SYStoSH
SHtoSYS
SYSPW
MEDSTBY
MEDRST
MEDMUTE
EW UC:CWE2097- RCK
ES: CWE2098-
DM
DP
CWE2097 *only for A C E
DPDT
Y401 TUNR
2
2
FLG
SYNC
RX
TX
KYDT
RWCLK
KEYD
DALMON
SYSPW
ASENBO
22k
E1 1
E1 1
B1 3
C2
B1 3
C2
Rch TUNL
24 5 4
BUP BUP
Lch BEGND
23 6 3
VDD3.3 VDD3.3
Q402
Q401
UMH1N
AGND
UMH1N
22 RHSLK 7 2
AGND VDD5 VDD5
RDS_HSLK
E2
E2
21 RLOCK 8 1 SYS8V SYS8V
4
4
SYS8V
5 B2
5 B2
6 C1
6 C1
RDS_LOCK R409
20 RDT
RDT
RDS_DATA RCK RDS57K
19
ROT1
ROT0
RDS_CK GRILL
SSENS
DSENS
18 TUN3V BTH1100-A
VDD_3.3 1R0u
17 L402 GND
NC2 CN801
10u/10
TUNG R408 CKS6188-A
C404
C405
C406
4.7u
CCG1192-A
16
CCG1201-A
DGND
0.01u/16
15 DO C407 C410 1.5k DGND 0.1u/10
DGND 1
DO DGND
14 TD3V L403 ILMG SW3V C801
DEH-P6200BT/XSUC
0.01u/50 CCG1192-A ILMG 2
ROM_VDD OSCG 10u 1608
13 R401 680 NM SW5V 3
OSCGND DI
12 LDET AGND R402 680 *only for A C LDET SOURCE R808 2.2k
LDET SOURCE 4
7
7
11 DI R403 680 DO OELG 5 OELG
SYS8V
DI
10 CK R404 680 CK 6 KYDT1 R803 2.2k
CK KYDT
9 CE1 R405 680 CE1 USBG 7 USBG
CE1
8 OELB R805 2.2k R812
OEL+B 8
NC1
FM/AM TUNER UNIT
7 CE2 C832 R804 2.2k 100k
R406 680 CE2 USBG 9
CE2 SL
D DPDT
6 R407 680 SL 10 1u/10 R802 2.2k
SL DPDT
5 TUN8V VBUS 11 VBUS
VCC CN1801 ROT11
4 L401
ROT1 12
FMANT BTH1100-A
3 RFGND DM1 CTF1713-A R811
1R0u D- 13 1 6
RFGND
6
2 ANT IC431 ROT00 44 3 3 8.2
NJM2885DL1-33 ROT0 14 2 5 1608
NM
AMANT
2 1
5
C401
C402
DP1
NM
1
VA811
X-2026 22u D+ 15 3 4 R810
0.01u/16
4
L404
3
C403
ILM+B
10u/10
TUNER3V REG ILM+B 16 11 2 2 8.2
R814 100 L801
1
AUXR 1608
CCG1192-A
AUX R 17 AUXR
ZNR401
3
R815
3 OUT
2 GND
1 IN
KN401 AUXG NM
3.3V D431 D432 AUX G 18 AUXG
2
M2R6TP_GND AUXL R816 100
JA401
AUX L 19 AUXL
CKX1070-A
IMSA-6802-01Y900-T
NM NM DSENS R813
20 R801 2.2k
DSENS
C432
C433
C431
1608 R809 100k 100k
RFGND
0.01u/16
4.7u/6.3
CCG1201-A
EW5 ES UC
D807
D808
D806
DZ2S068C
DZ2S068C
DGND
USB GND ILM GND
DZ2S068C
DZ2S068C
DZ2S068C
8
OEL GND GND
8
FM(10%) -33.42 dB -37.39 dB -35.46 dB
D805
D804
ILM
VA801 VR105C5R0AAA
VA802 VR105C5R0AAA
VA803 VR105C5R0AAA
VA806 VR105C5R0AAA
VA807 VR105C5R0AAA
VA808 VR105C5R0AAA
AM(15%) -29.97 dB -34.07 dB -32.08 dB GND
AUX IN:-20.38 dB
A-a A-b
A-a 1/2
A-b 1/2
59
E
A
D
C
F
B
1 2 3 4
10.2 TUNER AMP PCB 2/2 [MEDIA uCOM BLOCK] (GUIDE PAGE)
A
A-a 2/2
MECHA VD BUP
VD2 Q751
7.4V 2SD2396(K) BUP BUP X503
CPPWR
SD_WP
SD_CMD
SD_CD
CPRST
SD_CLK
SD_DATA2
SD_DATA3
SD_DATA0
SD_DATA1
CSS1794-A
CCG1192-A 10U/10
16.93MHz 4 X2 3
GND2
NM
NM
Q752
R753
R751 R752
0.047u/16
47k
C550
12p/50
C2 3 4 E2 820 12p/50 1 2
NM GND1
HZU8R2(B1)
C751
X1
B1 2 5 B2 1608 1608
R529
C752
C753
C549
3.3k
VDCONT
R754
10k
E1 1 6 C1
RT3T22M
C754
D751
VDCONT
GND
VDSENS
CDRST
MECHA
VDD33
CN701
DEEMPH
FORMAT
DACMUTE
RSPCK0
MOSI0
R568 MISO0
R566 SSL00
VKN1192-A only E
CPPWR
CPRST
VD1
R704
100
R701
R703
VD 16
100
4.7k
4.7k
4.7k
R565
NM
DEEMPH
R526 220
VD 15
NM
R528
NM
R527
CDSRQ R705 220 47k
CDSRQ
DMUTE
CDSRQ 14
R525
CDSTBY R706 220 CDSTBY
R567
R530
FMT
CDSTBY 13
47k
47k
R707 100
B SCL 12
SCL
SKIP R708 220
CD_SCL
CDSKIP
except E
11
C
SKIP
SDA R709 100 C551
R522 47k
CD_SDA
C537
SDA 10
0.1u/10
C538
R710
0.1u/10
0.1u/10
0.1u/10
0.1u/10
NM
C536
C535
C534
1k
C533
RST2
0.1u/10
22p/50
R524
RESET CDRST
9 C552
CN701 VDD 8
VDD4 VDD33
3.3V
MOSI0
MISO0
22p/50
SSL00
DGND1 L701
GND C553
RX2
7 NM
DATA R711 150 CDDATAIN 1.2V
DATA 6 22p/50
RSPCK0
BCLK R712 100 CDSCKIN C547 TX2 TP1
BCLK 5
150
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
102
101
100
LRCK R713 CDLRCKIN
LRCK 4 22p/50
3.3V
1.2V
CPPWR
SD_WP
CDRST
SD_CMD
DACCS
GND 3
AUDIO-XOUT
NC2
SD_CD
CPRST
RAM_TEST2 NC1
DACCLK
MISO0
AUDIO-XIN
DACDATA1
133
SD_CLK
SD_DATA2
SD_DATA3
SD_DATA0
SD_DATA1
SSL00 Vss12
Vcc8
Vcc7
Vcc6
PVcc9
PVcc8
PVcc7
Vss11
Vss10
MOSI0
(RX)
(EJSW)
(TX)
PGND
PGND 2 CDSRQ 134
WAIT R714 CDWAIT
WAIT 1 135 RSPCK0
CDSTBY
0.01u/16
220 DACCLK CDSRQ
NM
R717
R716
C703
C704
C705
R715
C706
C701
C702
NM
47p/50
NM
R702
100k
100k
100k
R532
47p/50
220 136 CDSTBY
47k
DACCLK
R533 100 DACCLK
DACDATA DACDATA 137
DACLRCK CDDATAIN
DACLRCK R534 100 138
PGND D GND DACSCK CDLRCKIN
DACSCK R535 100 139
CDSCKIN
CDDATAIN CDDATAIN 140
CDLRCKIN C539 141 CDDATAIN
PVcc10
CDLRCKIN 0.1u/10 142
CDRCKIN
143
CDSCKIN Vss13
CDSCKIN 144
CDCKIN
C540 145
Vcc9
0.1u/10 146
CD_SDA
CD_SDA
CD_SCL 147
CD_SCL
CP_SDA CPSDA 148
CP_SDA
CP_SCL CPSCL 149
CP_SCL
CDWAIT 150
C CDWAIT
8
7
6
5
8
7
6
5
CDSKIP 151
R792
R793
10k
CDSKIP
10k
C554 22p/50 C541 152
PVcc11
MEDIA uCOM
2
3
4
2
3
4
1
C555 22p/50 0.1u/10 153
Vss14
SD_CMD C556 22p/50 154
PD15
C557 22p/50 155 R5S7262ZD144FPU
SD_CD PD14
PD15 156 IC501
SD_WP PD13
PD14 157
SD_DATA1 PD12
SD_DATA0 PD13 158
PD11
SD_CLK PD12 159
PD10
PD11 160
Vss15
SD_DATA3 PD10 C542 161
PVcc12
SD_DATA2 PD9 0.1u/10 162
PD9
PD8 163
PD8
C558 22p/50 164
PD7
C559 22p/50 165
PD6
C560 22p/50 166
PD5
C561 22p/50 167
PD4
C562 22p/50 168
PD3
C563 22p/50 C543 169
Vcc10
C564 22p/50 0.1u/10 170
PD2
C565 22p/50 171
Vss16
PD7 172
PD1
PD6 C544 173
PVcc13
PD5 0.1u/10 174 PD0
CS_SDRAM
CS_FLASH
PD4 175 RD
3 RD/WR
4 DQMU
PVcc1
PVcc2
PVCC
176
CKIO
PD3
Vcc1
Vss1
Vcc2
Vss2
Vss4
VCC
WE0
RAS
CAS
CKE
A10
A11
A12
A13
A14
A15
A16
A1
A2
A3
A4
A5
A6
A7
A8
A9
D PD2
1
2
6
7
8
9
5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
PD1
CP3V PD0
Q591
L591 LSA1576UB C566 22p/50
LCTC4R7K1608-T 22p/50
C567
47k
NM
C507
C510
C511
C512
R591
0.1u/10
C508 0.1u/10
0.1u/10
0.1u/10
0.1u/10
C509
CPPWR
C591
R596
0.1u/10
C568
47k
22p/50
4.7k
R593 10k R592 100 CP_SCL C569 22p/50
R503
R595 10k R594 100 CP_SDA FLCS
GND
RD
NM
R597
R547 0
WE0/DQML
11 12 13 14 15 IC591
341S2162
R544 4.7k
I2C_SCL/SPI_SIMO
NC8
MODE0/SPI_CLK
VSS
I2C_SDA/SPI_SOMI
10 NC7 16
NC6
MODE1/SPI_nSS
9 NC5 17
NC4 NC9
NC3 NC10 18
8 NC11
NC12
7 NC13 19
nRESET
6 20 MED3.3V
VCC
NC2
NC1
A10
A11
A12
A13
A14
A15
A16
A1
A2
A3
A4
A5
A6
A7
A8
A9
ipod CP
4
3
1
5
2
NM
R598
C592 R599 CPRST
0.1u/10 2.7k
R600
A16
4.7k
GND A15
E A14
A13
A12
A11
A10
A9
REFERENCE AREA MAP A 2/2 A20
1
181 - 200 DAC & LPF 591 - 600 ipod CP WE0/DQML 1
501 - 570 MEDIA uCOM 701 - 750 MECHA MEDRST2 1
571 - 580 FLASH ROM 751 - 780 MECHA VD 1
581 - 590 MED3.3V & MED1.2V 1
1
1
0.01u/16
C574
A19
A18 1
A8 1
A7 1
A6 2
A5 2
A4 22
A3 2
A2 24
F
SPA
F GND
A 2/2
60 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
A-b 2/2 A
A 2/2 TUNER AMP PCB
IC502
SST25V040BIS
(MEDIA uCOM BLOCK)
NM
1 8 R561
CS# VCC
2 7
SO HOLD#
R560 3 6 R562
CPPWR
W# SCK NM
0 4 5
GND SI
only for E
C548
GND
0.1u/16
A 1/2
R563
R564
100
100
RSPCK0
VDSENS
MISO0
MOSI0
SSL00
C197
DEEMPH
FORMAT
DACMUTE
270p/50
DAC GND
DAC C196 micro GND
CD/USB:-17.24 dB 680p/50
DACMUTE
NM
DEEMPH
R526 220
R185 DAC GND micro GND LPF
NM
DEEMPH
R528
NM
R527
4.7u
R191 C193
DMUTE
FORMAT NM CDL
R525
FMT
NM DACCLK 680 NM
R551
B
14
13
12
11
10
2200p/50
C191
9
8
POWER_BUS
NM
uCOM_BUS
0.1u/10
4 NC1 DEEMPH
6 VOUTR MUTE
FORMAT
8
7
6
5
VDD
MCLK
NC2
7 GND VOUTL
WM8761GED
R522 47k
R521 47k
0.1u/10
R557
C531
VTL1145-A
IC181
NM
C534
C533
C532
0.1u/10
0.1u/10
R524
L501
3 BCKIN
1 LRCIN
3.3V
2
3
4
1
5 CAP
2200p/50
2 DIN
ASEBRK
C192
3.3V 3.3V
CCG1192-A
CCG1192-A
NM
10u/10
C503
C502
C501
TRST
RX2
TMS
TDO
TCK
10u/10
4.7u
TDI
1.2V 1.2V C194
DACLRCK R192 CDR
TX2 TP1
DACDATA 680 NM
110
109
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
TDO 91
TRST 90
89
DACSCK C183
GND
CPPWR
ROM
0.01u/16
ASEBRKAK/ASEBRK
TMS
DACCS
NC2
TCK
RAM_TEST2 NC1
DACCLK
0.1u/10
DACDATA1
88 C530
RAM_TEST1 USB_SEL
TDI
Vcc6
Vcc5
Vss9
PVcc7
PVcc6
Vss10
(RX)
(EJSW)
(TX)
C184
87 C529 0.1u/10
CCG1192-A
DAC5V
DTL1107-A
10u/10
RAM_TEST0
AVCC 86
DAC5V
L181
AVREF SYS8V
AVSS 85 VDSENS IC182
VDSENS
CCG1192-A
84 TP3 R181 5 1 SYS8V SYS8V
10u/10
DACDATA VOUT VIN
NM
C182
C181
83 NM 2
DACLRCK GND
C188
82 TP4
0.1u/10
R554 47k 4 3
C185
C186
NM
DACSCK NB CONT
C190
1u/10
1u/10
81
C187
USBUVSS
0.1u/10
80 C528 NJM2872F05
USBUVCC
79 0.1u/10
USBAVSS
78 C527
USBAVCC
77 0.1u/10
R182
GND
NM
USBAPVSS
76 C526 VDD5V
USBAPVCC
75 0.1u/10 R519 R552 10k Q181
REFRIN 5.1V
74
NM VDD5V
5.6k
USBDVss C545 USB5V
73 C525 R183
USBDVcc 1u/10
0.1u/10 VBUS2 R518 100
72 USB5V NM
R184
NM
VBUS
71 DP2 DP
NM
C
NM
C189
C195
DP
70 DM2 DM
DM
69 1608 R515 NM Q182 SYSPW
USBDVSS ASEMD
uCOM 68 C522 0.1u/10 R514 NM NM
X2 3
USBDPVCC
GND1
67 C523 1608
CSS1760-A
ASEMD
uCOM_BUS
POWER_BUS
48MHz
4FPU 66 R558 NM 10p/50
USBX2 3.3V GND
65 R513 1k
GND2
USBX1 C524
C521
X501
64
X1
PVcc5
63 0.1u/10 10p/50 SHtoSYS
4
SYS_TXD
62
Vss8
61 SYStoSH
SYS_RXD
60 C520
Vcc4 MEDMUTE2
0.1u/10 R559 NM
59 MEDMUTE
MEDIAMUTE R512 NM IC581
58 MEDSTBY NJM2885DL1-33
BRST
MED33IN
57 MEDSTBY2 R511 NM NM D581 R581
Vss7 IC582 MED33
C546 2 GND
3 OUT
RTC_XOUT
56 1SS352 NM
MED33 1 IN DD5V
3 VOUT
55 1000p/50
1 VSS
RTC_XIN
2 VIN
54 C519 3.3V 5.2V D582 DD5V
PVcc4
53 0.1u/10 CRG03
CCG1192-A
Vss6 MED12
CCG1192-A
C584
C583
C582
R510 47k
NM
NM
D583
52 MED12
C581
10u/10
10u/10
MD_BOOT1
NM
R509 47k 1.2V 1.2V
51
MD_BOOT0
50
XOUT
CCG1192-A
49
XIN
NM
C587
R505 47k
C588
10u/10
48
C586
NM
MD_CLK1 NEW
PLLVss 47 4 VOUT VI 3 GND
MD_CLK0 GND 2
CCG1192-A
PLLVcc 46
WR_END
WR_SW
RESET
C585
10u/10
5 SEL STBY 1
PVcc3
PVcc2
PVCC
C516
CKIO
45
Vss4
Vcc3
Vss5
VCC
NMI
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
NC
0.1u/10
WR_SW
R504
IC583
BH12PB3WHFV
D
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
47k
1.2V 1.2V L502
CCG1192-A
CTF1410-A
CCG1192-A
3.3V
10u/10
C506
C505
NM
C504
R501
10u
C511
C512
C513
C514
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
TP2 47k
NEW GND
RESET3
C515
0.01u/16
WR_END USB USBA A GND GND
GND GND
R502 100 MEDRST
MEDRST2
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
CCG1192-A
NM
C571
L571
10u/10
IC571
CWW1967 C572
A16 1 48 0.1u/10 A17
A15 A16
A15 2 47
A14 /BYTE
A14 3
A13 Vss2
46 E
A13 4 45 PD15
A12
5 DQ15_A-1 44 5 4
A12 R575 PD7
A11 DQ7
6 43 6 3 220
A11 PD14
A10 DQ14
7 42 7 2
A10 PD6
A9 DQ6
8 41 8 1
A9 PD13
A8 DQ13
9 40 5 4
A20 R576 PD5
A19 DQ5
10 39 6 3 220
PD12
NC1 DQ12
11 38 7 2
WE0/DQML PD4
/WE DQ4
12 37 8 1
MEDRST2
/RESET Vcc
13 36 PD11
NC2 DQ11
14 35 5 4
R577 PD3
NC3 DQ3
15 34 6 3 220
PD10
RY_/BY DQ10
16 33 7 2
0.01u/16
C574
A19 PD2
A18 DQ2
17 32 8 1
A18 PD9
A17 DQ9
18 31 5 4
A8 R578 PD1
A7 DQ1
19 30 6 3 220
A7 PD8
A6 DQ8
20 29 7 2
A6 PD0
A5 DQ0
21 28 8 1 RD
A5
A4 /OE
A4 22 27
A3 Vss1
A3 23 26 FLCS
A2 /CE
A2 24 25 A1
A1 A0
R574 R572
FLASH ROM 4.7k 4.7k
NM
R573
SPANSION 16Mbit
GND
F
A 2/2
DEH-P6200BT/XSUC
5 6 7 8
61
F
E
B
A
D
C
62
A-a A-b
A-b 2/2
A 2/2 TUNER AMP PCB
1
1
IC502 (MEDIA uCOM BLOCK)
SST25V040BIS
NM
1 8 R561
CS# VCC
2 7
SO HOLD#
R560 3 6 R562
W# SCK NM
0 4 5
GND SI
only for E
C548
0.1u/16
GND A 1/2
100
100
R563
R564
SSL00
MISO0
MOSI0
RSPCK0
VDSENS
C197
270p/50
DAC GND micro
DAC C196 GND
FORMAT
DEEMPH
DACMUTE
CD/USB:-17.24 dB 680p/50
DACMUTE
DAC GND GND
NM
DEEMPH R185 micro LPF
2
2
4.7u
NM
NM
R191 C193
R528
R527
FORMAT NM CDL
DEEMPH
R526 220
R525
DACCLK 680 NM
DMUTE
FMT
R551 NM
14
13
12
11
10
9
8
8
7
6
5
NM
C191
NC2
VDD
2200p/50
0.1u/10
MCLK
VTL1145-A
L501
FORMAT
3.3V
R557
NM
2
3
4
C531
C533
C532
uCOM_BUS
IC181
R524
POWER_BUS
0.1u/10
R522 47k
R521 47k
0.1u/10
0.1u/10
3.3V 3.3V
WM8761GED
C192
1 LRCIN
2 DIN
3 BCKIN
4 NC1 DEEMPH
5 CAP
6 VOUTR MUTE
7 GND VOUTL
4.7u
NM
2200p/50
RX2
1.2V
ASEBRK
TCK
TMS
TDI
TDO
1.2V
C503
C502
C501
C194
TRST
R192
10u/10
DACLRCK CDR
10u/10
TX2 TP1
CCG1192-A
CCG1192-A
DACDATA 680 NM
109
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
89
DACSCK C183
GND
88 C530 0.1u/10 0.01u/16
C184
NC2
TCK
TMS
TDI
TDO 91
ROM
C529 0.1u/10
Vcc6
(RX)
(TX)
Vcc5
Vss9
TRST 90
87
Vss10
DACCS
PVcc7
PVcc6
CCG1192-A
(EJSW)
DACCLK
AVCC 86 10u/10
DAC5V
DACDATA1
AVREF SYS8V
DAC5V
AVSS 85 IC182
L181
DEH-P6200BT/XSUC
VDSENS VDSENS
R181
DTL1107-A
5 1
RAM_TEST2 NC1
84 TP3 SYS8V SYS8V
DACDATA VOUT VIN
RAM_TEST0
ASEBRKAK/ASEBRK
83 NM 2
NM
RAM_TEST1 USB_SEL
C182
DACLRCK GND
10u/10
C181
82 TP4 R554 47k 4 3
CCG1192-A
DACSCK NB CONT
C188
NM
81
C185
C186
0.1u/10
C190
1u/10
USBUVSS
1u/10
3
3
80 C528 NJM2872F05
C187
USBUVCC
79 0.1u/10
0.1u/10
USBAVSS
78 C527
USBAVCC
77 0.1u/10
USBAPVSS GND
76 C526
NM
VDD5V
R182
USBAPVCC
75 0.1u/10 R519 R552 10k Q181
REFRIN 5.1V VDD5V
74
NM
5.6k
USBDVss C545 USB5V
73 C525 R183
USBDVcc 1u/10
0.1u/10 VBUS2 R518 100
72 USB5V NM
VBUS
DP2
NM
71 DP
R184
DP
NM
DM2
NM
70 DM
C189
C195
DM
69 1608 R515 NM Q182 SYSPW
USBDVSS ASEMD
68 C522 0.1u/10 R514 NM NM
2
COM USBDPVCC
C523 1608
X2 3
67
ASEMD
R558 NM
GND1
U 66 10p/50
USBX2 3.3V GND
R513
48MHz
65 1k
USBX1 C524
CSS1760-A
64 C521
uCOM_BUS
GND2
X1
PVcc5
POWER_BUS
X501
0.1u/10
4
1
63 10p/50 SHtoSYS
SYS_TXD
62
Vss8
61 SYStoSH
4
4
SYS_RXD
60 C520
Vcc4 MEDMUTE2
0.1u/10 R559 NM
59 MEDMUTE
MEDIAMUTE R512 NM IC581
58 MEDSTBY NJM2885DL1-33
BRST
57 MEDSTBY2 R511 NM NM D581 R581
Vss7 IC582 MED33
56 C546 1SS352
RTC_XOUT
NM
MED33IN
MED33 DD5V
55 1000p/50
3 OUT
2 GND
1 IN
RTC_XIN
54 C519 3.3V 5.2V D582 DD5V
PVcc4
1 VSS
2 VIN
3 VOUT
53 0.1u/10 CRG03
Vss6 MED12
52 R510 47k
MD_BOOT1 MED12
NM
NM
C584
C583
C582
R509 1.2V
D583
51 47k 1.2V
C581
NM
MD_BOOT0
10u/10
10u/10
CCG1192-A
CCG1192-A
50
XOUT
49
XIN
R505 47k
192-A
6
48
/10
587
588
NM
MD CLK1
M
NEW
BRST
57 MEDSTBY2 R511 NM NM D581 R581
Vss7 IC582 MED33
56 C546 1SS352
RTC_XOUT
NM
MED33IN
MED33 DD5V
55 1000p/50
3 OUT
2 GND
1 IN
RTC_XIN
54 C519 3.3V 5.2V D582 DD5V
PVcc4
1 VSS
2 VIN
3 VOUT
53 0.1u/10 CRG03
Vss6 MED12
52 R510 47k
MD_BOOT1 MED12
NM
NM
C584
C583
C582
R509 1.2V
D583
51 47k 1.2V
C581
NM
MD_BOOT0
10u/10
10u/10
CCG1192-A
CCG1192-A
50
XOUT
49
XIN
48 R505 47k
NM
MD_CLK1 NEW
C587
GND
C588
4 VOUT VI 3
NM
PLLVss 47
10u/10
C586
MD_CLK0
CCG1192-A
PLLVcc 46 GND 2
45 C516 5 SEL STBY 1
C585
VCC
NC
PVCC
A10
A11
A12
A13
A14
A15
A16
Vss4
CKIO
A17
A18
A19
A20
Vcc3
Vss5
PVcc3
RESET
NMI
10u/10
WR_END
0.1u/10
WR_SW
IC583
5
CCG1192-A
5
R504
WR_SW BH12PB3WHFV
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
47k
1.2V 1.2V L502
3.3V CTF1410-A
R501
NM
10u
C506
C505
TP2
C504
47k
10u/10
CCG1192-A
NEW
C511
C512
C513
C514
GND
CCG1192-A
0.1u/10
0.1u/10
0.1u/10
0.1u/10
WR_END USB USBA A GND GND
RESET3
C515
GND GND
0.01u/16
R502 100 MEDRST
MEDRST2
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
6
6
NM
L571
C571
10u/10
IC571
CCG1192-A
CWW1967 C572
A16 1 48 0.1u/10 A17
A15 A16
A15 2 47
A14 /BYTE
A14 3 46
A13 Vss2
A13 4 45 PD15
A12
5 DQ15_A-1 44 5 4
A12 R575 PD7
A11 DQ7
6 43 6 3 220
A11 PD14
A10 DQ14
7 42 7 2
A10 PD6
A9 DQ6
8 41 8 1
A9 PD13
A8 DQ13
9 40 5 4
A20 R576 PD5
A19 DQ5
10 39 6 3 220
PD12
NC1 DQ12
11 38 7 2
WE0/DQML PD4
/WE DQ4
12 37 8 1
EDRST2
DEH-P6200BT/XSUC
/RESET Vcc
13 36 PD11
NC2 DQ11
14 35 5 4
R577 PD3
NC3 DQ3
15 34 6 3 220
PD10
7
7
RY_/BY DQ10
16 33 7 2
A19 PD2
A18 DQ2
8 1
C574
A18 17 32 PD9
A17 DQ9
0.01u/16
18 31 5 4
A8 R578 PD1
A7 DQ1
19 30 6 3 220
A7 PD8
A6 DQ8
20 29 7 2
A6 PD0
A5 DQ0
21 28 8 1 RD
A5
A4 /OE
A4 22 27
A3 Vss1
A3 23 26 FLCS
A2 /CE
A2 24 25 A1
A1 A0
R574 R572
FLASH ROM 4.7k 4.7k
NM
R573
SPANSION 16Mbit
GND
8
8
A-a A-b
A-b 2/2
63
E
A
D
C
F
B
F
E
B
A
D
C
64
A-a A-b
A-b 2/2
A-a 2/2
1
1
MECHA VD BUP
VD2 Q751
7.4V 2SD2396(K) BUP BUP X503
CSS1794-A
16.93MHz 4 X2 3
GND2
SD_WP
SD_CD
CPRST
CPPWR
NM
SD_CMD
SD_CLK
Q752 R751 R752
NM
47k
SD_DATA2
SD_DATA3
SD_DATA0
SD_DATA1
R753
C2 3 4 E2 12p/50 1 2
C550
820 NM GND1
12p/50
B1 2 1608 X1
5 B2 1608
0.047u/16
C549
C751
VDCONT
R529
C1
3.3k
E1 1
C752
C753
10k
RT3T22M 6
CCG1192-A 10U/10
VDCONT
R754
C754
D751
HZU8R2(B1)
GND
VDSENS
MECHA
CDRST
VDD33
CN701
VKN1192-A only E
MOSI0
RSPCK0
FORMAT
DEEMPH
VD1
DACMUTE
VD 16 R565
100
CPRST
CPPWR
100
R566 SSL00
R568 MISO0
R704
R701
4.7k
R703
4.7k
4.7k
NM
VD 15
47k
2
2
CDSRQ R705 220 CDSRQ
NM
NM
CDSRQ 14
R528
R527
DEEMPH
CDSTBY R706 220 CDSTBY
CDSTBY 13
R526 220
R525
DMUTE
47k
R707 100
FMT
SCL
47k
CD_SCL
R567
R530
SCL 12 except E
SKIP R708 220 CDSKIP
SKIP 11
SDA R709 100 CD_SDA C551
C SDA 10
RST2 R710 1k
C537
CDRST 22p/50
RESET 9
NM
C552
C538
C536
C535
C534
C533
R524
0.1u/10
VDD4 VDD33
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
CN701 VDD 8 3.3V
DGND1 L701 22p/50
GND 7 C553
150 NM
RX2
SSL00
MOSI0
MISO0
DATA R711 CDDATAIN 1.2V
DATA 6 22p/50
BCLK R712 100 CDSCKIN C547 TX2
BCLK 5
LRCK R713 150 CDLRCKIN
LRCK 22p/50
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
102
101
RSPCK0
4
3.3V
1.2V
GND 3 133
PGND
Vcc8
Vcc7
Vcc6
(RX)
(TX)
PGND 2 CDSRQ 134
MISO0
CDRST
PVcc9
Vss11
PVcc8
SD_WP
SD_CD
CPRST
CPPWR
Vss10
DACCS
PVcc7
R714
MOSI0
WAIT CDWAIT
SD_CMD
SD_CLK
(EJSW)
DACCLK
WAIT 1 135 RSPCK0
CDSTBY
AUDIO-XIN
SD_DATA2
SD_DATA3
SD_DATA0
SD_DATA1
DACDATA1
220 DACCLK CDSRQ
AUDIO-XOUT
R532 CDSTBY
SSL00 Vss12
DACCLK 220 136
DEH-P6200BT/XSUC
NM
47k
NM
NM
DACCLK
R717
100k
R716
100k
C703
C704
C705
R715
100k
C706
C701
C702
R702
R533 100 DACDATA 137
47p/50
0.01u/16
DACDATA
47p/50
DACLRCK CDDATAIN
DACLRCK R534 100 138
PGND D GND DACSCK CDLRCKIN
DACSCK R535 100 139
CDSCKIN
CDDATAIN CDDATAIN 140
3
3
CDLRCKIN C539 141 CDDATAIN
PVcc10
CDLRCKIN 0.1u/10 142
CDRCKIN
143
CDSCKIN Vss13
CDSCKIN 144
CDCKIN
C540 145
Vcc9
0.1u/10 146
CD_SDA
CD_SDA
CD_SCL 147
CD_SCL
CP_SDA CPSDA 148
CP_SDA
CP_SCL CPSCL 149
CP_SCL
CDWAIT 150
8
7
6
5
8
7
6
5
CDWAIT
CDSKIP 151
CDSKIP
10k
C554 C541 152
10k
22p/50
R792
R793
PVcc11
2
3
4
2
3
4
1
1
C555 22p/50 0.1u/10 153 MEDIA uCOM
Vss14
SD_CMD C556 22p/50 154
PD15
C557 22p/50 155 R5S7262ZD144FPU
SD_CD PD14
PD15 156 IC501
SD_WP PD13
PD14 157
SD_DATA1 PD12
SD_DATA0 PD13 158
PD11
SD_CLK PD12 159
PD10
PD11 160
4
4
Vss15
SD_DATA3 PD10 C542 161
PVcc12
SD_DATA2 PD9 0.1u/10 162
PD9
PD8 163
PD8
C558 22p/50 164
PD7
C559 22p/50 165
PD6
C560 22p/50 166
PD5
C561 22p/50 167
PD4
C562 22p/50 168
PD3
C563 22p/50 C543 169
Vcc10
C564 22p/50 0.1u/10 170
PD2
C565 22p/50 171
Vss16
PD7 172
PD1
PD6 C544 173
PV 13
PD8
C558 22p/50 164
PD7
C559 22p/50 165
PD6
C560 22p/50 166
PD5
C561 22p/50 167
PD4
C562 22p/50 168
PD3
C563 22p/50 C543 169
Vcc10
C564 22p/50 0.1u/10 170
PD2
C565 22p/50 171
Vss16
PD7 172
PD1
PD6 C544 173
PVcc13
PD5 0.1u/10 174 PD0
CS_FLASH
PD4 175 RD
PD3 176
VCC
A8
A9
PVcc2
A10
A11
A12
A13
A14
A15
A16
Vss4
RD/WR
RAS
CAS
Vcc1
CKE
Vss1
CS_SDRAM
PVcc1
A1
A2
A3
A4
A5
A6
A7
Vcc2
Vss2
PD2
5
5
1
2
3 WE0
4 DQMU
6
7
8
9
5
22
23
24
25
26
27
28
29
30
31
32
10
11
12
13
14
15
16
17
18
19
20
21
PD1
CP3V PD0
Q591
L591 LSA1576UB C566 22p/50
LCTC4R7K1608-T 22p/50
R591 C567
NM
47k
CPPWR
C568 22p/50
C507
C510
C511
C509
47k
4.7k
C591
R596
0.1u/10
0.1u/10
0.1u/10
0.1u/10
R593 10k R592 100 CP_SCL C569 22p/50
0.1u/10
R595 10k R594 100 CP_SDA FLCS
R503
C508 0.1u/10
GND
RD
R547 0
NM
WE0/DQML
R597
11 12 13 14 15 IC591
341S2162
R544 4.7k
16
NC8
VSS
10 NC7
NC6
9 NC5 17
NC4 NC9
NC3 NC10 18
8 NC11
NC12
7 NC13 19
MODE0/SPI_CLK
6 20 MED3.3V
I2C_SCL/SPI_SIMO
I2C_SDA/SPI_SOMI
VCC
nRESET
NC2
MODE1/SPI_nSS
NC1
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
ipod CP
4
3
1
5
2
6
6
NM
R598
C592 R599 CPRST
0.1u/10 2.7k
R600
A16
4.7k
GND A15
A14
A13
A12
A11
A10
A9
A20
REFERENCE AREA MAP A 2/2
181 - 200 DAC & LPF 591 - 600 ipod CP WE0/DQML
501 - 570 MEDIA uCOM 701 - 750 MECHA MEDRST2
DEH-P6200BT/XSUC
571 - 580 FLASH ROM 751 - 780 MECHA VD
581 - 590 MED3.3V & MED1.2V
7
7
A19
C574
A18
0.01u/16
A8
A7
A6
A5
A4
A3
A2
GND
8
8
A-a A-b
A-a 2/2
A-b 2/2
65
E
A
D
C
F
B
1 2 3 4
10.3 CD CORE UNIT (S11STD-DOUT)
CXX1942
PICKUP UNIT(P10.5)(SERVICE) V3R3
A E:P5+P10
R101 R102 R103
F:P1+P6
2.7
(1/10W)
(1/10SR,1608)
2.4
*
4.7u/6.3
R106
C104
(2125)
REFO
NM
2.4
PUEN
LD1 Q102
UNR511MG
0.047u/10
3300p/50
C213
C214
LD Q101 R109 LD
VCC
2.2k
2SA1577(QR) R215
* D101
* C102
NM
NM
39k
R214
10k
LD-
15 15
C215
LD+ ASY
14 14 V+3A
B+D F BD EFM
13 13
VCC V+3A ATEST
12 12
75
74
73
72
71
T E
C101
P5+P10
B 11 11
NM
EFM
ATEST
ASY
AD.Vdd
GND
*
10 10
T F
C111
C110
P1+P6
9 9
NM
NM
VREF REFO * 76
*
8 8 C221 A.Vdd1
VR 77
R108
7 7 A.GND1
1M
F 0.1u/10 C216 78
A+C
6 6
AC PD f RFI
MD PD 1800p/50 79
5 5 RFAGC AGCO
T TOM C220 80
TOM
HOLOGRAM UNIT 4 4 C3T
F FOM 0.1u/10 C219 81
FOM
3 3 AGCI
FOP F FOP 0.1u/10 82
2 2 RFO RFO
FOCUS ACT T C228 R229 83
TOP TOP
R217
5.6k
1 1 EQ2
470
C218
TRK ACT 84
4p/50
27p/50
EQ1
TOM
FOM
FOP
TOP
C217 R216 85
R218
4.7k
RF2-
F.ACT: Applying positive voltage to FOP, 56p/50 1.2k 86
RF-
the lens approaches DISC. CN101
AC
BD
87
E
F
CKS4808-A C222 A.GND2
T.ACT: Applying positive voltage to TOP, 88
A.Vdd2
the lens moves outer circumference of DISC. AC F 0.1u/10 89
A
BD F 90
B
T 91
C F
F
E T 92
E
REFO 93
REFO1 REFOUT
REFO2 C229 d C223 94
D Digital Out model only 68p/50 95
FE-
CIRCUIT No. 0.1u/10 FE FEO
96
A Analog Out model only C101 C102 C110 C111 C236 ADCIN
C224
ADCIN
* C204 C207 C235 C239 97
TE-
I IIC-BUS model only C240 C281 C282 C283 C284
C301 C307 C308
0.1u/10
c TE
47p/50 98
TEO
C601 C602 C225 99
P P-BUS model only C701 C702 C703 C705 C707 C708
0.01u/16 100
TE2
D101 TEC TEC
INTQ(INT1)
CN702
TH201
Q201
/RST
PD
LD
R106
* C239
NM
R297 R246
M1 SPDL MOTOR
1
2
3
4
5
R603 R604
R710 R711
CXE2273 R281 R282 R283
LD
D PD
RST
R291 R292 R293 R299
INTQ
BLK
S SOM C205 C206
A R601 R602 R606
D
RED I R225 R722 VDD
S SOP
P R242 R243 R707 R721 R723
GND
PL
C LCOM
REFO
OG
4 RESET
C LCOP Parts with Polarity
CN702
6 SO
M2 LOAD/CRG MOTOR
8 SI
IC201 IC301 * CKS5766-A
D101
2
Q101 Q102 Q201
CXC4026
C205 C301 C308
1 28 e
VR PreVcc
CVDD 3
5
SCK 7
VDD 1
TD T 2 OPIN2+ 27 MDX MDY 1608:PARTS
ICECK
OPIN3+ R308 S
3 OPIN2- 26 MD C209 C238 C240
9 OPIN3- 0.022u/16 18k C306 C307
R307
C305
4 OPOUT2 25
7
18k
C708
TIN
E HOME F OPOUT3
5 OPIN1+ 24 SIN R306 C R101 R102 R103
S901 HOME 3 FD SD
R243 R246
OPINSL
4
4 31
18k R606
R305
C304
6 OPIN1- 23 4700p/25
18k
HOME
a
2
CSN1067-A OPOUTSL
7 OPOUT1 22 CIN 8 LOEJ
2125:PARTS
8EJ FIN
S905 8SNS 2 LDIN C104
4 31
8SNS
2
29 30
CSN1068-A FIN1 FIN2
S903 DSCSNS
1 5
4 31
DSCSNS 8 21 CLCONT
2
GND1 CNT
CSN1068-A 9 20
CONT MUTE GND2 *
DSCSNS C306 10 PowVcc1 19 C307
PowVcc2 MOTOR DRIVER LOGIC TABLE
FOP F 1u/10 11 18 NM C
VO1- VO4- LOAD EJ PLAY OFF
F (1608) 12 17 (1608) C
FOM
VO1+ VO4+ CLCONT H H L L
TOM T 13 16 S
VO2- VO3- LOEJ L H
SWITCHES: TOP T 14 15 S
- -
CD CORE UNIT VO2+ VO3+ CONT L L H L
S901:HOME SWITCH.........ON-OFF IC301
S903:DSCSNS SWITCH.....ON-OFF BA5839FP
VD
S905:8EJ SWITCH..............ON-OFF
* C301
C308
F The underlined indicates the switch position.
NM
NM
PGND
*
CLCONT
LCOM
CONT
LCOP
LOEJ
SOM
SOP
C
66 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
MD
C CD CORE UNIT(S11STD-DOUT)
SD
TD
FD
PUEN
A
C232
PUEN
1000p/50
R236
10k C231 SIGNAL LINE
R263 F
1000p/50
FOCUS SERVO LINE
4.7k T
TRACKING SERVO LINE
TEMP
ADENA
VDSENS
R235
/CDSRQ
SKIP
10k
/WAIT
C
R262 CARRIAGE SERVO LINE
S
4.7k GND
SPINDLE SERVO LINE
0.047u/10
3300p/50
0.1u/10
C213
C214
C212
R246
C235
(1608)
NM
VDD TEMP
NM
*
TEMP
*
R215 *
b
NM
TH201
R260
P R707
39k
10k
NM
0.1u/10
R214
10k
T
F
C
S
MONI2
MONI1
MONI0
C215
C16M
*
ASY
Q201
TESTIN
EFM NM
BSCK0
LRCK0
GND
ATEST
ADENA
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
ADENA
B
TEST
MD
VDCONT
SD
IO.Vdd2
EFM
ATEST
TD
FD
AD.GND
TEMP
VDSENS
Monitor3
Monitor2
Monitor1
Monitor0
IO.GND2
PUEN
ASY
SD2
AD.Vdd
/ADENA
SKIP
/TESTIN
/CDSRQ
P R721
76 50 NM I R225 /WAIT
A.Vdd1 PC3 Mask Flash
77 49 R723 P 0 SDA R281 56 22
A.GND1 SDA R282 56 22
78 48 NM I R722 SCL
RFI SCL R291 56 22
79 47 0 D R291 LRCK
AGCO /WAIT *
80 46 C283 56
C3T TX/EMPH D
81 45 R283 NM D R292 0
BCLK
AGCI LRCK D * *
82 44 R281 0 C281 C282
56
RFO SCKO
83 43 R282 D NM NM D R293 DATA
EQ2 DOUT *
84 42 56 C284 0
EQ1 PA7
85 41 NM LOEJ
RF2- LOEJ
86 40 CLCONT
RF- CLCONT
87 39 R264 CONT
A.GND2 CONT R245
88 IC201 38 1k
100k
DSCSNS
A.Vdd2 DSCSNS R253
89
A
PE5706A 8SNS
37 8SNS 100k
90 36
B 12SNS R254
91 35
F HOME
EJSW
HOME 100k C
92 34 R240
E EJSW
93 33 /CDSTBY 47k
REFOUT /CDSTBY
94 32 ICECK
ICECK
FE- ICECK *
R297
R296
95 31
0
FEO IO.Vdd1 C211
96 30 NM
ADCIN IO.GND1 0.1u/10
97 29 R237 RESET
TE- RESET
98 28 C233 220
TEO C.GND
99 27 C210 0.01u/16
TE2 C.Vdd
00 26 0.1u/10 R232
R232
TEC Vpp
INTQ(INT1)
Mask 0
DA.GND1
0
DA.Vdd1
Flash 10k
DA.GND
DA.Vdd
VPP
REG16
D.GND
ICEMD
X.GND
REGC
REGS
ROUT
D.Vdd
/XTAL
X.Vdd
LOUT
XTAL
/SCK
/RST
/STB
SO
CVDD
PD
LD
A0
SI
NM
VPP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CVDD
1
0.1u/10
A
R294
470
SO
ICEMD
SCK
RST
A0
STB
C205
SI
2
INTQ
R294
X201 Mask 470
NM * CSS1603-A Flash 0
C203
VDD2
VDD1
3
C206 C207
C209 D
(1608)
(1608)
A NM NM
0.1u/16 (1608) VDD
* C240 NM
C238 NM
* C204 NM
C299 NM
D R299
0
SCK
GND
CVDD
SCK
VPP
VDSENS
6
ICECK
CDSTBY
CDSRQ
RESET
VDSENS
SKIP
SDA
SCL
VD1
VD2
CN701
4 RESET
CN702
10 GND
P R242 P R243
6 SO
CKS6146-A
8 SI
* CKS5766-A I/O
NM NM
2
(1608) VD
1 VD 7.5V
2 VD 7.5V
/CDSRQ R709
NM
NM
R601
R602
A 3 /CDSRQ
A 0 R706
CVDD 3
5
VPP 9
SCK 7
VDD 1
/CDSTBY /CDSTBY
* * 4
R702 220
ICECK
SCL
R603 R604 5 SCL
A 2/2
SKIP 100 R708
* NM NM * 6 SKIP
R701 0
C601 C602 SDA
7 SDA E
RESET 100
NM NM 8 RESET CN701
9 VDD 3.3V
LRCK
10 GND GND
A R606 BCLK DATA
11 DATA
NM (1608) DATA BCLK
12 BCLK
LRCK
13 LRCK
1000p/50
AAGND1 AAGND2
C710
* C705
* C707
* C708
14 GND GND
(1608)
NM
NM
NM
15 PGND GND
BLE /WAIT
16 WAIT
OFF
L
NM
NM
* R711
* R710
* C703
* C701
C702
i h g
NM
NM
NM
-
PGND
L
*
(AGND)
(ROUT)
(LOUT)
GND1
GND2
GND3
DATA
LRCK
BCLK
WAIT
F
* NO MOUNT PARTS (NM)
PGND1
PGND2
Land for manual soldering
C
DEH-P6200BT/XSUC
5 6 7 8
67
1 2 3 4
10.4 KEYBOARD ASSY
A
REFERENCE AREA MAP SW JOYST(V)
over~under A
1801 -1810 AUX & USB A(UP) 0.00 - 0.16
1811 -1820 B(LEFT) 0.16 - 0.54
ROTARY COMMANDER C(DOWN) 0.54 - 1.00 B PU
D(RIGHT) 1.00 - 1.59
1831 -1870 LED
PUSH 1.59 - 2.31
RELEASE 2.31 - 3.16
S1872 S1873 1871 -1890 BUTTON RELEASE 3.16 - 3.30 C
US DISP S.Rtrv 1891 -1900 to REM R1818
10k
EW5 TA DISP 1901 -1910 Grille MICRO
ES S.Rtrv DISP 1921 -1940 OEL CSX1120-A
Phase_B 10 1 Phase_A
Push 9 2 Enc_Com
D8 3A
R1817
8.2k
C7 4B
GND6 5 Com
B S1811
R1816 ILMGND R1815 DGN
R1871
R1877
3.3k 1.8k
10k
10k
Grille MICRO
CTF1379-A
R1901
47k
L1901
X1901
CSS1577-A
10.000MHz
BAND PHONE
MODE
1SS355
1 3
R1902
D1901
R1903
150k
47k
1 3 CSG1155-A CSG1155-A
3 1 3 1
2 2
RESET 4 2 4 2
GP1UXC14RK
S1871 S1877
R1872
R1878
1.2k
1.2k
IC1891
LIST
REM
GND
VCC
CSG1155-A CSG1155-A
C1901
0.1u/16
VSS
1
2
3
3 1 3 1 R1893 R1891
10u/10
4 2 4 2 2.2 120
S1872 S1878
R1892
R1873
R1879
YF106
NM
1.8k
1.8k
3
C1891
DGND
C
VCC
CSG1155-A CSG1155-A
3 1 3 1
4 2 4 2 DGND
10
S1873 S1879
9
8
7
6
5
4
3
2
1
R1874
R1880
3.3k
3.3k
RESET
VCC
VSS
ADKEY1 XOUT
R-ILM DOUT
MODE
DPDT G_ILM
REM
XCMD DCLK
XIN
1 4
PEG642A8
IC1901
CSG1155-A CSG1155-A
C1902
ADKEY2
18 ADKEY0
XREST
1u/10
MCLK
KYDT
VREF
3 1 3 1
4 2 4 2
S1874 S1880
11
12
13
14
15
16
17
19
20
R1881
R1875
8.2k
8.2k
2
CSG1155-A
5
CSG1155-A
R1909
R1904
1k
(1.25MHz)
47k 3 1 3 1
4 2 4 2
DGND S1875 S1881
R1905
R1882
R1906
R1907
R1876
33k
47k
47k
47k
33k
6 EJECT
R1849
CSG1155-A CSG1155-A
R1910
1/4W
47k
3 1 3 1
R1908
4 2 4 2
10k
DGND S1876 S1882
D
R1850
DGND DGND R1867 R1855
NM NM
KYDT
D1865
DPDT
C2 4
5
E1 6
B1
R1857
NM
Q1832
Q1831
NM
NM
R1854
NM
1 C1
E2
2 B2
L1922
R1859
R1856
NM
3
0
NM
8
7
6
5
NM
R1858
R1925
ILMGND
100
8
7
6
5
2
3
4
1
R1924
100
2
3
4
1
E
C1921
1u/10
C1922
1u/10
SW(V)
C1923
ADKEY1 ADKEY2
L1921 0.1u/16
over~under
BAND S.Rtrv 0.00 - 016
R1922
DISP LIST
51k
0.16 - 0.54
NM
CLK 3 0.54 - 1.00
1 4 1.00 - 1.59
2 5 1.59 - 2.31
6
NM
OELG EJECT 2.31 - 3.16
RELEASE RELEASE
R1923
3.16 - 3.30
OEL DGND
VSSK 15
14
VKH 13
VAH 12
VSSA 11
10
9
8
7
6
XCMD 5
SCL 4
3
2
1
CN1921
VSSD1
XRES
SO_TX
VSSD2
VDD
XI
XCS
IREF
SI_RX
CKS6036-A
F
OEL MODULE
D
68 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
A
OYST(V)
over~under A
0.00 - 0.16 ROTARY COMMANDER
0.16 - 0.54
0.54
1.00
1.59
2.31
- 1.00
- 1.59
- 2.31
- 3.16
B PUSH D
D KEYBOARD ASSY
3.16 - 3.30 C
R1818
10k
R1819
R1813
NM
10k
D1801
D1802
D1803
NM
NM
NM
CSX1120-A
10
9
1 Phase_A
2 Enc_Com
AUX ILMGND
D8 3A JA1801
YKN5006-A R1801
C7 4B 3
2 NM
D6 5 Com
R1814
1
1.2k
R1802
S1811
B
NM
R1815 DGND
1.8k
4700p/50
4700p/50
C1802
C1803
R1812
C1801
0.1u/16
1k
R1811
CN1801
CKS6049-A
1k
R1803
NM
C1807
1 DGND
DAN202U
D1804
1u/10 2 ILMG
DGND 3 SW3.3V
R1804
4 SOURCE
2.2k
R1805 5 OELG
2.2k 6 KYDT
DAP202U
D1805
7 USBG
OELG 8 OEL+B
C
9
10
USBG
DPDT
A 1/2
DGND
SRC
S1801
11 VBUS(US5V) CN801
2 4 12 ROT1
1 3 13 D-
CSG1155-A 14 ROT0
DGND 15 D+
16 ILM+B
17 AUXR
18 AUXG
19 AUXL
C1804
20 DSEN
BLUE NM
RED *BLUE/RED C1805
BLUE RED
NM
C1806
270 1/4W
330 1/4W
330 1/4W
330 1/4W
1/10W
1/10W
R1849
R1843
R1841
R1842
NM
R1947
R1844
NM
NM 1/10W NM
NM
NM
NM
NM
1/4W
R1831
1/10W
1/10W
NM
R1946
R1837
R1942
R1851
D1866
C1848
NM
R1862 1/10W
R1865 1/10W
R1839
R1838
DGND
220
150
1/4W
1/4W
1/4W
2 2
3 3
1/4W
1/10W
NM 1/4W
NM
NM
NM
NM
NM
R1863
R1864
R1866
USB D
R1832
1/10W
R1949
NM
1/4W
560
R1850
R1845
D1858
D1855
D1852
D1849
NM
R1945
R1944
R1943
R1835
R1861
L1801
R1840
CN1802
470
150
1/10W 150
1/10W 150
330
39
855
1/4W
YKS5036-A
1/4W
M
1/4W
1/10W
44
11
NM
1
D1865
D1861
D1859
D1856
D1853
D1850
C1835
D1831
C2 4
5
E1 6
R1860
NM
NM
NM
2
NM
NM
B1
NM
C1845
D1845
C1844
D1842
C1839
D1839
C1838
D1836
C1832
D1833
3
4
VA1801
VA1802
R1854
NM
NM
NM
5
D1862
D1860
D1857
D1854
D1851
NM
1 C1
E2
2 B2
NM
NM
C1846
D1846
D1843
C1840
D1840
C1837
D1837
C1833
D1834
NM
6
NM
Q1833
C1843
3
DTC124EUA
D1863
NM
NM
NM
NM
NM
NM
R1858
C1847
D1847
C1842
D1844
C1841
D1841
C1836
D1838
C1834
D1835
DGND
NM
LMGND NM
BLUE
RED UC,EW5 ES
D1831 D1866 CL-195SR-CD CL-197HB1-D(CDE)
D1833-D1846
R1835, R1837 NM
RS1/4SA331J
R1838, R1839
R1942-R1945 RS1/10SR151J NM
R1840 RS1/4SA471J NM
R1946 RS1/10SR221J NM
R1831 RS1/4SA271J NM
R1832 RS1/4SA561J NM
R1863, R1864 NM RS1/10SR821J
R1865, R1866 NM RS1/10SR152J
R1862 NM RS1/10SR222J
R1851 NM RS1/10SR821J F
R1949 NM RS1/10SR152J
R1861 RS1/16S121J RS1/16S390J
D1847 NM NM
D
DEH-P6200BT/XSUC
5 6 7 8
69
1 2 3 4
10.5 WAVEFORMS
- Waveforms Note : 1. The encircled numbers denote measuring points in the circuit diagram.
A
2. Reference voltage REFO1(1.65 V)
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
28SNS 5 V/div 5CLCONT 5 V/div 28SNS 5 V/div
4LOEJ 5 V/div 4LOEJ 5 V/div 4LOEJ 5 V/div
3HOME 5 V/div 6VD 10 V/div 3HOME 5 V/div
12 cm CD Loading operation 12 cm CD Loading operation 8 cm CD Loading operation
Ref.: Ref.: Ref.:
GND GND GND
B
Mode: Mode: Mode:
Normal Normal Normal
7SIN 1 V/div 2 s/div aFIN 200 mV/div 500 ms/div cTE 500 mV/div 200 ms/div
8CIN 500 mV/div bRFOK(MONI_3) 2 V/div dFE 500 mV/div
9TIN 500 mV/div 7SIN 2 V/div
12 cm CD-DA setup operation after loading 12 cm CD-DA Source On setup operation Source On setup operation
Ref.: Ref.: Ref.:
REFO REFO REFO
Mode: Mode: Mode:
Normal Normal Normal
dFE 500 mV/div 20 ms/div eMDX 2 V/div 50 ms/div eMDX 2 V/div 5 μs/div
aFIN 500 mV/div 7SIN 500 mV/div 7SIN 500 mV/div
cTE 500 mV/div
D 9TIN 500 mV/div
CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation
(Wider)
Ref.: Ref.: Ref.:
REFO REFO REFO
Mode: Mode: Mode:
Normal Normal Normal
E
aFIN 500 mV/div 200 ms/div cTE 500 mV/div 2 ms/div fRFAGC 1 V/div 500 μs/div
dFE 500 mV/div fRFAGC 500 mV/div cTE 500 mV/div
9TIN 500 mV/div
Focus Search waveform Track Open waveform 100 Track Jump waveform (32 Track Jump x 3)
Ref.: Ref.: Ref.:
REFO REFO REFO
Mode: Mode: Mode:
F TEST TEST TEST
70 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
A
fRFAGC 1 V/div 2 ms/div fRFAGC 1 V/div 200 ms/div gLRCK 2 V/div 10 μs/div
cTE 500 mV/div cTE 1 V/div hBCLK 2 V/div
9TIN 500 mV/div 8CIN 500 mV/div iDATA 2 V/div
7SIN 2 V/div
32 Tracks Jump waveform
(Zoom of 100 Track Jump waveform) Search operation(Outter to Inner) Digital Out waveform
Ref.: Ref.: Ref.:
REFO REFO GND
Mode: Mode: Mode:
TEST Normal Normal B
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
5CLCONT 5 V/div 28SNS 5 V/div 28SNS 5 V/div
4LOEJ 5 V/div 4LOEJ 5 V/div 4LOEJ 5 V/div
3HOME 5 V/div 3HOME 5 V/div
12 cm CD Eject operation 8 cm CD Eject operation 12 cm CD Eject operation
Ref.: Ref.: Ref.: C
REFO AGND GND
Mode: Mode: Mode:
Normal Normal Normal
fRFAGC 1 V/div 500 μs/div
9TIN 1 V/div
cTE 1 V/div
aFIN 1 V/div
Black Dot (800 μm) during play D
Ref.:
REFO
Mode:
Normal
DEH-P6200BT/XSUC
5 6 7 8
71
1 2 3 4
11. PCB CONNECTION DIAGRAM
11.1 TUNER AMP PCB
A NOTE FOR PCB DIAGRAMS
1.The parts mounted on this PCB
include all necessary parts for
A TUNER AMP PCB
several destination.
For further information for
respective destinations, be sure
150
to check with the schematic dia- WIRED REMOTE
gram.
RCA OUT &RMIC
2.Viewpoint of PCB diagrams JA661
JA301 VA665 C366
10
Connector Capacitor 140 10 R661 C362
5 1 R662 1 5
5 R363
1 Q361 R361 C364 C363
C367
R358
C371
VA662
R364
VA664
R385
VA663
SIDE A
C352 C356
R315
R316
R304 C381 E
R365
R366
R314 C311 C312 C310 R362 C365 R351
C308 Q381 E
C307 C309
C304 Q362 R352
R307 R308 R309 R311
130
D383
R381
D381
R303 R313 R312 R310 E 1
R301 1
C306
B R306 Q382
R357
R302
C370
R384
R305
Q363
5
5
5
C305 1
R382
1
1
SIDE B
1
Q302 Q303 R387 D382
Q301
P.C.Board Chip Part IC911
1 C301
C302 C303
1
R201
25
C221 IC201
120
30
C219
C913 P301 C228
C211
35
C912 C911 R205
C226
40
C224
R912
Q901
110 R911
D162 D161 C161
Q902
R901 C202
E 1
R902 C902 C203
C201
D902
C903
C904 D901 C901 C194
100 Q751 D164
C162
C193
C IC161
R751 D163
C188
R166
1 C165 5
R167
C754 R162
E 1
C164
R169
R163
Q752 R752
R161
C163
R753 R168
90 R754 R164
C167
R165
D751
C151 IC151
C752 L161
R608
C751 C753 C152 1
C166
L151
D583
C586 IC582
C584
IC583
80 D582
1
C581
C905
C582
D891 1 R581 IC581
C906 IC901 C583
Q891 IC902 C585 C588 1
R892 C907
D581
1 C587
Q892
R891 C892
1 D892
70 E R894 R893
C456
C884 1
R457 C661
D C891 C893 IC882 IC881 C459
C458
C883 R6
R455
1
C454
R452
D881 1
IC451 C457 R666 Q4
60
R454
C881
5
R456 R668
R451
R458
R459
R476
R453
R855
C853
R854
C885 Q471
R471 C455 L4
R853
R469 E
C856 C852
C882 C451 C452
R834
R474
5
R833 Q831 R852 C854
CN461 R473
50 Q832 IC851 R472
E C
10
R831
C831
R470
1
C462
1 C857 R
C851 D851
1
R467
D831
C855
L851
R851 R858
40 E D832
Q853
R859 1
Q854
E E Q822
E
Q833
R836 E
R822
30 E
R823
R835
E
Q834
Q821 R821
20 BT MODULE
C CN701 S651
10 1
RESET
Y
F
0
X 10
A 20 30 40 50 60 70 80
72 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
A
SIDE A
> P 301 (A,50,116) Poly Switch MINISMDC075F/24
SOURCE
10 20
CONNECTOR
IC351
JA981 L981
IP-BUS
1 5 15 25 2 4 10 16 18
1
JA101
R361 C364 C363 4 1
R358
C371
R364
7 5
C354 C358
C353 C357
C352 C356
C351 C355
R365
D981
R366
C365 R351 1 5 7
C369
R356
R353
R354
D942 15 17 D921
R109
R107
2 C368
R108
R352 D941 C921 11 8
D982
C104
C102
R110
C103
R355
1 R103
R926 R111
C218 R925 B
R357
C370
R104
Q363 R113
C217
C941 Q101
C101
R203 C230 D922
C234
C216 R209 C373
C361
1
IC101 ANTENNA
JA401
20
L101 C105
5
1 C235 C106
R115
R106
R112
R201 C215
25
L201 C231 R105
C214 C372 R114
15
C221 IC201 C222
C213 L202
D201
C229
ZNR401
30
C219 R211 Q201
R101
R102
10
C228 C220
C211 C227
E
KN401 L404
35
R205 C212 1
5
R206 R210
R624
R610
R635
R609
C226
C225
40
C224 IC651
C223 C651 R626 R633 Q921 R922
R924
R923
R921
R638 1 Y401
1
C209 D602 C611 R632
D651 C403
1
R208
X601 R636
R202
R207
C204 R634
C202 R651 L401 C402
C210 100 95 90 85 80 C401
C203 R652
75
1
C192
C201 C604 C612
C191
C610
5
70
C194 C195 R604 R408
R192 R622 R611
10
C189
65
R191 C605 C609 R407
5
C193 R603 R409
R183 IC601 R623 R406
C
L602
15
R184 R181 R182 C606 R405
60
E Q181 C608 R404
C188 IC182 C190 R605 1 R403
20
L603 R641 R643 Q402
55
1 E R402
C603 R606 C641 R401
1
C601
C602
9
25
30 35 40 45 50 1
Q182
C187
8 L601 C607 R642
R601 IC641
FM/AM TUNER UNIT
R630
R631
Q401
5
R151
R607
1
R617
R616
R618
R620
10
R614
R613
R615
R383
R608 1
C184
C186
C183
C185
C181
D601
6
D583
IC582 IC583
L502 R619 CN601
C182
C504 L181
5
C196 R185 L403
C502 C505
C506
IC181
10
C501 C553
C588 C551 R535
10
1 C197 C407
C503
L501 R533
C552
C546
R534 C410
R512
R559
R511
C587 R518 C545 R602
R514
R525
C523 C524
1
C547 R526
R528 R527
R515
R513 R558
C522
1
R532 X501
R505
R504
C516
R468
R465
R501
R510
C527
C528
R509
C526
R519
56 R554
15
C461
C521 C519
C530
C529
C661
C525
R457
C520 C574 D
R502
C515
R464 C531
C405
85 80 75 70 65 60 55 50 45
C458 R552 R557
R667 C532
R455
C406 C404
C466 R521
R522 R551
C514
90
IC451 C457 R666 Q465
C513
R524 1
40
C533 L402
95
5
R792 R793
C512
R456 R668 E C534
35
C511
R458
R476
R453
100
20
Q471 1 1
C455 L461
30
105 110
R469 E L701 C702
C510
25
R701
C409
R411
452 D461 C701
C509
IC501
R474 C463
CN461 R473
R705
R637
20
CN701
R702
115
C464 C535
20
15
10
R472
5
C550
1
C465
10
R665
15
5
R470 C536
C508
15
120
R410
C408
C549
R503
C462
X503 R529
10
R466
L571
1
125 130
1
R467 C507
R530
5
10
C537
C571
IC571
C572
C538 D431 D432
R568 R566
1
R547
R544
R710
R717 R706 R573
C705 135 140 145 150 155 160 165 170 175
C548 R560 C544
5
R707 C568 R574
R711 R708 C540 R572
R712 R709 C542
IC502 R565 C539
C554 C543 C431 C433
E
C432
C704
R716 C541
R561
R562
C569
C559
C564
R715
C558
C562
C560
C561
C563
C556
C557
R714 R704 C567
C555
C706
R595
R593
C703 R703 C566
R713 R592 1
C565
R594
R597
R563
R564
15 Q591 IC431
25
30
35
40
45
R567 E
R591
R812
R813
10
L591 R809
R811
R810
IC591 R596 1 1
BZ601
20
C591 R578 R577 1
R576
R814
R815
R816
1 5
R804
R844
R808
R803
R598 R801
VA802
R599 L801 R575
VA807
VA806
R802
R805
R843 C592
E R600
Q841 VA801 1
D806 D804
1
Q842 L841 1 VA808
D805
C801
VA803
D808
D807
R842
E 5
VA811
1 5 15
C841
S651 C832
C842
R841
RESET
CN801
10 20
D CN1801
FRONT F
70 80 90 100 110 120 130 140 150 160 170
A
DEH-P6200BT/XSUC
5 6 7 8
73
1 2 3 4
A
A TUNER AMP PCB
TEST1
C
PCL1
A 170 160 150 140 130 120 110 100 90
74 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
SIDE B
A
150
1
140
1
130
120
110
100
C
90
80
70
D
60
50
40
E
30
20
10
0 F
0 90 80 70 60 50 40 30 20 10 X A
DEH-P6200BT/XSUC
5 6 7 8
75
1 2 3 4
11.2 BT ANT PCB
B BT ANT PCB SIDE A
A
BT MODULE
CN1101
B
10
0
20 10 Y
B BT ANT PCB SIDE B
20 10 Y 0
D
E 10
B
76 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
DEH-P6200BT/XSUC
5 6 7 8
77
1 2 3 4
11.3 CD CORE UNIT(S11STD-DOUT)
C CD CORE UNIT (S11STD-DOUT) SIDE A
A
PICKUP UNIT(P10.5)(SERVICE)
B
60
1
CN101 M2
15 10 5 1 TH201
S901 LOADING/CARRIAGE
C102 HOME MOTOR
50 F
M1
REFO1
C218
D101
E SPINDLE
R217
C228
R218
C217
C216
C C235
MOTOR
CN702 C224 R216
R229 R246
C225
1
C223 C222 C219 C221
R214
10
100 95 90 85 80
C213
5
C214
40 R215
75
1
C215 R306
5
70
R308
C203 C305 C304
C238
10
C307
65
R263
R262
R235
R236
C212
C240 C299 IC201 R307 R305
C207
15
60
25 30 20 15
C204
30
20
55
X201 C209 R707
R294
25
IC301
R264
1
C702
30 35 40 45 50
D
R225
R282
C211
C210 R708
R232
R281 R709 1 5 29 10
C306
20 R710
C701
10
CN701
Y 15 10 5 1 A CN701
E
0 10 20 30 40 50 60 70
X
C
78 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
C CD CORE UNIT (S11STD-DOUT) SIDE B
A
R102
R101
60
C101 R103
C111
C110
C104
Q101
R108
E
Q102
R109
50
E
R106
C
C239
C220 C236
C229
40
C205
C301 C308
Q201
C206
R245
E
R296 R240 8EJ 30
R254 R253
C231
C232 S905 1
C233
R237
D
R721 R723
R722
R260
R702
R297
R701 20
R283
R242 C283 R602
C281
C602
R292
R291
R243 C282
R606 R604
R299
DSCSNS
R601
R706 C708 R293 C601
1 S903
C703
C710
C705
R603 10
C707 C284
R711
Y
E
70 60 50 40 30 20 10 0
X
C
DEH-P6200BT/XSUC
5 6 7 8
79
F
E
B
A
D
C
80
D
D
1
1
S1872 S1873
US DISP S.Rtrv
EW5 TA DISP
ES S.Rtrv DISP
KEYBOARD ASSY
11.4 KEYBOARD ASSY
EJECT
1
S1882
SRC
D1831 C1835
2
2
40 PHONE OEL MODULE D1865
S1801
LIST
R1877 1
S1877 1 USB
R1878 S1878 R1879
1 CN1802
R1907
1
D1849
D1862
C1846
D1850
D1846
D1833 D1851 Q1833 R1861
C1833 D1834 R1906
30 R1860 D1866
C1832 D1835 R1880
R1924 E C1848
C1834
5 C1921 IC1891 1
C1922 R1876
1
5
10
L1922 R1922
S1811 CN1921
C1845
D1845
D1861
R1881
20 1 ROTARY 15 10 5 1 R1882
COMMANDER JA1801
C1836
DEH-P6200BT/XSUC
C1837
C1838 D1838
D1836 D1837
D1854 1 6 AUX
D1852 D1853 21 3 41 5
C1840
C1844
C1842
C1839
D1842
D1858
R1875
C1841
D1843
C1843
D1839
D1860
D1857
D1841
D1840
D1855
D1859
D1856
D1844
R1873 R1874
10 R1871 BAND C1847 S1874 S1875 S1879 S1880 S1881 S1876
R1872 S1873
3
3
S1871 S1872
1 1 1
1
D1847
D1863
1 1 1 1
Y
0
X 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160
4
4
SIDE A
B
F
C
D
A
81
D
SIDE B
8
8
A CN801
R1949 R1851
R1831
R1832
40
R1850 R1849
7
7
C1801 R1902
D1901 R1903
R1862
1
R1840
R1845
C1805
C1804
DEH-P6200BT/XSUC
X1901 R1947 R1946
VA1801
C1807 R1866
L1901
VA1802
R1901 R1816
C1901 1 R1815
R1818 30
R1835
R1841
R1942
R1844
R1817
R1839
L1801 10 5 1
1 R1863 C1902
L1921 R1925 R1910
R1893
C1891 R1923 C1923 1 IC1901
R1909
R1891
C1806 R1943
R1905
R1892
R1945 15 20 R1811
D1802
C1802 R1802 R1904 R1805 R1865 20
D1803 R1908 Q1832 R1857
15 5 1 1 R1819 R1867
R1801 E R1856
D1805 D1804 R1855
1 R1814
R1854 R1837 R1842
C1803
R1858
R1813
R1804 R1864
R1812
R1803 CN1801 R1944 R1838 R1859
Q1831
5 10
1 R1843
D1801 1
20 10
6
6
Y
0
160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 X
KEYBOARD ASSY
5
5
D
1 2 3 4
12. ELECTRICAL PARTS LIST
NOTE:
A Parts whose parts numbers are omitted are subject to being not supplied.
The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Meaning of the figures and others in the parentheses in the parts list.
B Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
E:DEH-P6200BT/XSUC IC 201 (A,79,119) IC PM9012A
A:DEH-6200BT/XSEW5 IC 351 (A,84,143) IC PA2030A
IC 431 (A,161,26) IC NJM2885DL1-33
B:DEH-6250BT/XSES IC 451 (A,70,61) IC NJM4558MD
IC 501 (A,122,51) IC R5S7262ZD144FPU
Unit Number : YWM5471(E)
C
IC 502 (A,84,35) IC(E) SST25V040BIS
Unit Number : YWM5467(A) IC 571 (A,150,38) Software Unit CWW1967
IC 581 (A,57,77) IC NJM2885DL1-33
Unit Number : YWM5468(B) IC 583 (A,80,79) IC BH12PB3WHFV
Unit Name : TUNER AMP ASSY IC 591 (A,102,24) IC 341S2162
Unit Number : CWX3774 IC 601 (A,129,98) IC(E) PEG635A8
(A,129,98) IC(A) PEG634A8
Unit Name : CD Core Unit (S11STD-DOUT) (A,129,98) IC(B) PEG636A8
IC 651 (A,120,110) IC S-80827CNNB-B8M
Unit Number : YWM5476(E) IC 851 (A,31,49) IC(E) NJM2360M
Unit Number : YWM5472(A) IC 882 (A,45,65) Regulator IC S-1132B33-U5
D
Unit Number : YWM5473(B) IC 902 (A,23,76) Regulator IC S-1132B33-U5
IC 911 (A,8,123) IC NJM2388F84
Unit Name : KEYBOARD ASSY Q 101 (A,140,126) Transistor(E) UMF23N
Q 201 (A,100,117) Transistor(E) 2SC4081
Q 301 (A,16,128) Transistor(E) IMH23
TUNER AMP ASSY
(A,16,128) Transistor(A) IMH3A
Consists of Q 302 (A,23,128) Transistor(E) IMH23
TUNER AMP PCB Q 303 (A,31,128) Transistor(E) IMH23
BT ANT PCB (A,31,128) Transistor(A,B) IMH3A
Q 361 (A,58,134) Transistor LTC114EUB
E Q 363 (A,71,129) Transistor RT3T22M
Q 381 (A,63,130) Transistor 2SC4081
AB
Unit Number : YWM5471(E)
Q
Q
382
401
(A,45,130)
(A,153,87)
Transistor
Transistor(E,A)
RT3T22M
UMH1N
Unit Number : YWM5467(A) Q 402 (A,154,92) Transistor(E,A) UMH1N
Unit Number : YWM5468(B) Q 591 (A,110,26) Transistor LSA1576UB
Q 751 (A,8,95) Transistor 2SD2396
Unit Name : TUNER AMP ASSY Q 752 (A,16,93) Transistor RT3T22M
Q 821 (A,21,26) Transistor 2SA1036K
MISCELLANEOUS
Q 822 (A,31,33) Transistor LTC114EUB
IC 101 (A,148,126) IC(E) HA12241FP Q 831 (A,21,51) Transistor 2SD1767
F IC 151 (A,67,86) IC R5523N001B Q 832 (A,14,47) Transistor RT3T22M
IC 161 (A,58,101) Regulator IC BD9781HFP Q 833 (A,42,32) Transistor LTC114EUB
IC 181 (A,109,76) IC WM8761GED Q 834 (A,43,29) Transistor 2SA1036K
IC 182 (A,84,93) IC NJM2872F05
82 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
Q 841 (A,96,18) Transistor LSA1576UB VA662 (A,42,134) Varistor VR105C5R0AAA
Q 842 (A,94,16) Transistor LTC114EUB VA663 (A,45,134) Varistor VR105C5R0AAA
Q 853 (A,22,37) Transistor(E) 2SA1036K VA664 (A,44,134) Varistor VR105C5R0AAA
Q 854 (A,24,34) Transistor(E) LTC114EUB VA665 (A,60,140) Varistor VR105C5R0AAA A
Q 891 (A,8,72) Transistor 2SD2396 VA801 (A,108,17) Varistor VR105C5R0AAA
Q 892 (A,18,71) Transistor RT3T22M VA802 (A,116,17) Varistor VR105C5R0AAA
Q 901 (A,8,107) Transistor 2SD2396 VA803 (A,122,16) Varistor VR105C5R0AAA
Q 902 (A,16,105) Transistor RT3T22M VA806 (A,112,16) Varistor VR105C5R0AAA
Q 921 (A,138,109) Transistor RT3CLLM VA807 (A,113,16) Varistor VR105C5R0AAA
D 161 (A,41,105) Diode CRG03 VA808 (A,128,15) Varistor VR105C5R0AAA
D 162 (A,38,105) Diode CRG03 CN461 (A,73,47) Connector CKS6192
D 163 (A,47,94) Diode CMS02 CN701 (A,97,41) Connector VKN1192
D 201 (A,103,116) Diode(E) UDZS15(B) CN801 (A,115,5) Connector CKS6188
D 381 (A,57,129) Diode UDZS8R2(B) CN1101 (A,10,21) Connector CKS5749
D 382 (A,63,128) Diode MC2848-11 CN1101 (A,10,21) Connector CKS5749 B
JA101 (A,152,138) Connector(E) CKS5271
D 383 (A,55,130) Diode 1SS352
D 581 (A,42,76) Diode 1SS352 JA301 (A,26,139) Pin Jack(E) YKB5016
D 582 (A,46,77) Diode CRG03 (A,26,139) Pin Jack(A,B) YKB5011
D 601 (A,123,85) Diode RB551V-30 JA401 (A,170,130) Antenna Jack CKX1070
D 602 (A,123,109) Diode RB751S-40 JA661 (A,48,142) Jack YKS5035
JA981 (A,119,142) Plug CKM1586
D 651 (A,120,107) Diode 1SS352
D 751 (A,18,90) Diode HZU8R2(B1) FM/AM Tuner Unit(E,A) CWE2097
D 804 (A,120,14) Diode DZ2S068C FM/AM Tuner Unit(B) CWE2098
D 805 (A,117,14) Diode DZ2S068C > Fuse(10 A) YEK5001
D 806 (A,123,14) Diode DZ2S068C
RESISTORS C
D 807 (A,125,14) Diode DZ2S068C
D 808 (A,126,14) Diode DZ2S068C R 101 (A,145,120) (E) RS1/16SS102J
D 831 (A,15,44) Diode HZU10(B1) R 102 (A,146,120) (E) RS1/16SS102J
D 832 (A,43,37) Diode DAN202U R 103 (A,154,129) (E) RS1/16SS223J
D 851 (A,41,43) Diode(E) RB551V-30 R 104 (A,155,129) (E) RS1/16SS181J
R 105 (A,146,123) (E) RS1/16SS223J
D 891 (A,13,75) Diode CRG03
D 892 (A,25,69) Diode UDZS5R6(B) R 106 (A,145,123) (E) RS1/16SS181J
D 901 (A,16,98) Diode CRG03 R 107 (A,157,129) (E) RS1/16SS101J
D 902 (A,17,102) Diode UDZS5R6(B) R 108 (A,159,129) (E) RS1/16SS470J
D 921 (A,134,130) Diode HZU7L(C2) R 109 (A,161,129) (E) RS1/16SS150J
R 110 (A,162,127) (E) RS1/16SS101J
D 922 (A,132,128) Diode HZU7L(A1) D
D 941 (A,106,128) Diode CRG03 R 111 (A,142,128) (E) RS1/16SS222J
D 942 (A,110,130) Diode CRG03 R 112 (A,144,122) (E) RS1/16SS101J
D 981 (A,139,132) Diode CRG03 R 113 (A,153,127) (E) RS1/16SS102J
D 982 (A,139,129) Diode CRG03 R 114 (A,142,122) (E) RS1/16SS332J
R 115 (A,141,123) (E) RS1/16SS562J
ZNR401 (A,164,118) Surge Protector MSA-6802-01Y900
L 101 (A,154,124) Inductor(E) LCTC1R0K1608 R 151 (A,118,87) RS1/16SS104J
L 161 (A,45,85) Inductor CTH1253 R 161 (A,55,92) RS1/16SS1003F
L 181 (A,102,81) Chip Ferrite Bead DTL1107 R 163 (A,58,92) RS1/16SS683J
L 401 (A,153,105) Chip Coil BTH1100 R 165 (A,60,91) RS1/10SR1003D
R 166 (A,63,92) RS1/10SR2402D
L 402 (A,156,57) Chip Coil BTH1100
E
L 404 (A,161,115) Inductor LCTAW220J2520 R 167 (A,61,93) RS1/10SR333J
L 461 (A,81,54) Inductor CTF1389 R 168 (A,65,90) RS1/10SR471J
L 501 (A,97,75) Inductor VTL1145 R 169 (A,65,92) RS1/10SR121J
L 502 (A,97,81) Inductor CTF1410 R 191 (A,87,98) RS1/16SS681J
R 192 (A,87,100) RS1/16SS681J
L 601 (A,112,90) Chip Coil BTH1103
L 801 (A,119,18) Inductor CTF1713 R 201 (A,72,125) RAB4CQ102J
L 851 (A,33,40) Inductor(E) CTF1660 R 202 (A,83,104) RS1/16SS101J
L 981 (A,118,142) Choke Coil 600 uH CTH1445 R 203 (A,94,126) (E) RS1/10SR0R0J
X 501 (A,126,69) Oscillator 48.000 MHz CSS1760 R 207 (A,85,104) RS1/16SS223J
R 208 (A,84,105) RS1/16SS223J
X 503 (A,103,45) Oscillator 16.93 MHz CSS1794
X 601 (A,114,101) Oscillator 20.0 MHz CSS1797 R 209 (A,90,125) (A,B) RS1/16SS0R0J F
S 651 (A,76,9) Switch(RESET) CSG1020 R 210 (A,99,115) (E) RS1/10SR101J
P 301 (A,50,116) Poly Switch MINISMDC075F/24 R 301 (A,13,130) (E) RS1/16SS820J
BZ601 (A,85,22) Buzzer CPV1062 (A,13,130) (A) RS1/16SS821J
DEH-P6200BT/XSUC
5 6 7 8
83
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 302 (A,19,128) (E) RS1/16SS820J R 469 (A,69,55) RS1/10SR0R0J
(A,19,128) (A) RS1/16SS821J R 472 (A,79,49) RS1/10SR0R0J
R 473 (A,79,50) RS1/10SR0R0J
R 303 (A,21,130) (E) RS1/16SS820J R 501 (A,136,67) RS1/16SS473J
A
R 304 (A,38,132) (E) RS1/16SS820J
R 305 (A,28,129) (E) RS1/16SS820J R 502 (A,139,63) RS1/16SS101J
(A,28,129) (A,B) RS1/16SS821J R 503 (A,137,44) RS1/16SS473J
R 306 (A,34,129) (E) RS1/16SS820J R 504 (A,133,67) RS1/16SS473J
(A,34,129) (A,B) RS1/16SS821J R 505 (A,132,67) RS1/16SS473J
R 509 (A,131,67) RS1/16SS473J
R 309 (A,21,131) (E) RS1/16SS223J
R 310 (A,36,131) (E) RS1/16SS223J R 510 (A,130,67) RS1/16SS473J
R 311 (A,29,131) RS1/16SS223J R 513 (A,124,68) RS1/16SS102J
R 312 (A,33,131) RS1/16SS223J R 518 (A,96,72) RS1/16SS101J
R 313 (A,26,131) (E) RS1/16SS0R0J R 519 (A,119,66) RS1/16SS5601F
R 521 (A,107,56) RS1/16SS473J
B R 314 (A,26,132) (E) RS1/16SS0R0J
R 315 (A,25,131) (A) RS1/16SS0R0J R 522 (A,107,55) RS1/16SS473J
R 316 (A,28,131) (A,B) RS1/16SS0R0J R 526 (A,115,72) RS1/16SS221J
R 351 (A,79,132) (E) RS1/16SS362J R 529 (A,107,44) RS1/16SS332J
(A,79,132) (A,B) RS1/16SS0R0J R 530 (A,106,43) (A,B) RS1/16SS473J
R 532 (A,109,70) RS1/16SS221J
R 352 (A,79,131) (E) RS1/16SS362J
(A,79,131) (A,B) RS1/16SS0R0J R 533 (A,116,75) RS1/16SS101J
R 353 (A,87,129) (E) RS1/16SS362J R 534 (A,116,74) RS1/16SS101J
(A,87,129) (A,B) RS1/16SS0R0J R 535 (A,117,76) RS1/16SS101J
R 354 (A,88,129) (E) RS1/16SS362J R 544 (A,139,41) RS1/16SS472J
(A,88,129) (A,B) RS1/16SS0R0J R 547 (A,138,41) RS1/16SS0R0J
C R 355 (A,89,130) (E) RS1/16SS562J R 552 (A,104,63) RS1/16SS103J
R 356 (A,86,129) (E) RS1/16SS562J R 554 (A,113,68) RS1/16SS473J
R 357 (A,79,129) (E) RS1/16SS562J R 560 (A,90,37) (E) RS1/10SR0R0J
R 358 (A,79,133) (E) RS1/16SS562J R 563 (A,82,29) (E) RS1/16SS101J
R 361 (A,67,136) RS1/16SS103J R 564 (A,83,29) (E) RS1/16SS101J
R 362 (A,59,132) RS1/16SS103J R 565 (A,90,35) (E) RS1/16SS473J
R 363 (A,65,136) RS1/16SS331J R 566 (A,90,40) (E) RS1/16SS101J
R 365 (A,71,132) RS1/16SS103J R 567 (A,105,26) (A,B) RS1/16SS473J
R 366 (A,72,132) RS1/16SS103J R 568 (A,88,39) (E) RS1/16SS101J
R 381 (A,59,131) RS1/10SR473J R 572 (A,140,36) RS1/16SS472J
R 382 (A,59,129) RS1/10SR104J R 574 (A,140,37) RS1/16SS472J
D R 383 (A,136,86) RS1/16SS473J R 575 (A,152,18) RAB4CQ221J
R 384 (A,66,130) RS1/10SR473J R 576 (A,152,24) RAB4CQ221J
R 385 (A,49,134) RS1/16SS102J R 577 (A,149,24) RAB4CQ221J
R 387 (A,55,127) RS1/16SS820J R 578 (A,145,25) RAB4CQ221J
R 401 (A,158,93) RS1/16SS681J R 591 (A,112,26) RS1/16SS472J
R 402 (A,158,94) (A) RS1/16SS681J R 592 (A,107,30) RS1/16SS101J
R 403 (A,158,95) RS1/16SS681J R 593 (A,104,29) RS1/16SS103J
R 404 (A,158,96) RS1/16SS681J R 594 (A,109,29) RS1/16SS101J
R 405 (A,158,97) RS1/16SS681J R 595 (A,103,29) RS1/16SS103J
R 406 (A,158,98) RS1/16SS681J R 596 (A,108,24) RS1/16SS473J
R 407 (A,158,99) RS1/16SS681J R 599 (A,104,19) RS1/16SS272J
E
R 408 (A,156,100) RS1/16SS152J R 600 (A,102,18) RS1/16SS472J
R 409 (A,149,96) (E,A) RAB4CQ223J R 601 (A,84,89) RS1/16SS102J
R 410 (A,159,48) (E) RS1/16SS104J R 602 (A,145,73) RS1/16SS472J
R 411 (A,159,50) (E) RS1/16SS104J R 603 (A,118,98) RS1/16SS105J
R 451 (A,68,57) RS1/10SR223J R 604 (A,119,99) RS1/16SS0R0J
R 452 (A,63,62) RS1/10SR223J R 605 (A,118,94) RS1/16SS104J
R 453 (A,72,56) RS1/10SR223J R 606 (A,118,92) RS1/16SS222J
R 454 (A,66,57) RS1/10SR223J R 607 (A,131,85) RS1/16SS104J
R 455 (A,76,63) RS1/10SR103J R 609 (A,128,111) RS1/16SS104J
R 456 (A,75,59) RS1/10SR103J R 610 (A,127,111) RS1/16SS104J
R 457 (A,74,66) RS1/10SR100J R 611 (A,143,100) RS1/16SS104J
F
R 464 (A,85,66) RS1/10SR0R0J R 613 (A,125,85) RS1/16SS104J
R 466 (A,82,46) RS1/10SR102J R 614 (A,126,85) RS1/16SS104J
R 467 (A,78,43) RS1/10SR102J R 615 (A,124,85) RS1/16SS104J
84 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 616 (A,129,85) RS1/16SS104J R 831 (A,17,47) RS1/10SR103J
R 617 (A,130,85) RS1/16SS104J R 833 (A,16,50) RS1/10SR101J
R 618 (A,132,85) RS1/16SS104J R 834 (A,16,51) RS1/10SR101J
R 619 (A,126,83) RS1/16SS472J R 835 (A,39,28) RS1/16SS103J A
R 620 (A,133,85) RS1/16SS104J R 836 (A,39,31) RS1/4SA102J
R 622 (A,140,99) RS1/16SS0R0J R 842 (A,96,12) RS1/16SS472J
R 623 (A,140,97) RS1/16SS104J R 843 (A,94,18) RS1/16SS102J
R 624 (A,125,111) RS1/16SS473J R 844 (A,96,20) RS1/16SS103J
R 626 (A,122,111) RS1/16SS103J R 851 (A,19,39) RS1/10SR1R0J
R 630 (A,119,90) (E) RS1/16SS472J R 852 (A,26,49) (E) RS1/10SR821J
R 631 (A,121,88) (E) RS1/16SS472J R 853 (A,33,55) (E) RS1/10SR153J
R 632 (A,131,108) RS1/16SS681J R 854 (A,31,54) (E) RS1/10SR332J
R 633 (A,130,110) RS1/16SS0R0J R 855 (A,28,54) (E) RS1/10SR222J
R 634 (A,138,106) RS1/16SS0R0J R 858 (A,22,39) (E) RS1/16SS103J
B
R 636 (A,133,107) RS1/16SS104J R 859 (A,19,35) (E) RS1/16SS102J
R 638 (A,133,108) RS1/16SS104J R 891 (A,14,69) RS1/4SA0R0J
R 643 (A,146,94) RS1/16SS104J R 892 (A,15,74) RS1/10SR472J
R 651 (A,118,105) RS1/16SS104J R 893 (A,33,69) RS1/10SR393J
R 652 (A,119,104) RS1/16SS152J R 894 (A,30,69) RS1/10SR103J
R 661 (A,60,138) RS1/10SR102J R 901 (A,14,105) RS1/16SS682J
R 662 (A,60,137) RS1/10SR102J R 902 (A,14,104) RS1/16SS393J
R 665 (A,86,48) RS1/16SS0R0J R 911 (A,13,110) RS1/16SS102J
R 701 (A,102,50) RS1/16SS472J R 912 (A,13,112) RS1/16SS473J
R 702 (A,100,47) RS1/16SS473J R 921 (A,145,107) RS1/16SS104J
R 703 (A,107,31) RS1/16SS472J R 922 (A,142,110) RS1/16SS103J C
R 704 (A,107,32) RS1/16SS472J R 923 (A,144,108) RS1/16SS473J
R 705 (A,101,48) RS1/16SS221J R 924 (A,143,108) RS1/16SS473J
R 706 (A,106,38) RS1/16SS221J R 925 (A,129,128) RS1/16SS472J
R 707 (A,111,36) RS1/16SS101J R 926 (A,125,128) RS1/4SA102J
R 708 (A,105,36) RS1/16SS221J CAPACITORS
R 709 (A,108,35) RS1/16SS101J
R 710 (A,101,40) RS1/16SS102J C 101 (A,156,127) (E) CKSRYB104K16
R 711 (A,101,36) RS1/16SS151J C 106 (A,157,125) (E) CKSSYB104K10
R 712 (A,101,35) RS1/16SS101J C 151 (A,63,87) CKSSYB104K10
C 152 (A,64,85) CKSSYB104K10
R 713 (A,101,30) RS1/16SS151J C 161 (A,47,107) CEVW221M16
R 714 (A,101,32) RS1/16SS221J D
R 715 (A,120,32) RS1/16SS104J C 162 (A,52,98) CKSRYB105K16
R 716 (A,101,33) RS1/16SS104J C 163 (A,56,92) CKSRYB104K16
R 717 (A,101,39) RS1/16SS104J C 165 (A,58,93) CKSSYB103K16
C 166 (A,56,86) 150 uF/6.3 V CCH1804(P25)
R 751 (A,17,95) RS1/10SR821J C 167 (A,61,91) CCSRCH221J50
R 753 (A,15,90) RS1/16SS473J
R 754 (A,16,89) RS1/16SS103J C 182 (A,113,79) 10 uF CCG1192
R 792 (A,101,57) RAB4CQ103J C 183 (A,102,82) CKSSYB103K16
R 793 (A,104,57) RAB4CQ103J C 184 (A,104,82) 10 uF CCG1192
C 186 (A,100,82) CKSRYB105K10
R 801 (A,128,19) RS1/10SR222J C 187 (A,86,92) CKSSYB104K10
R 802 (A,114,17) RS1/10SR222J
E
R 803 (A,110,18) RS1/10SR222J C 188 (A,81,94) CKSSYB104K10
R 804 (A,122,18) RS1/10SR222J C 190 (A,97,94) CKSRYB105K10
R 805 (A,115,17) RS1/10SR222J C 191 (A,84,99) CCSRCH222J50
C 192 (A,85,100) CCSRCH222J50
R 808 (A,109,18) RS1/10SR222J C 196 (A,93,79) CKSSYB681K50
R 809 (A,122,23) RS1/10SR104J
R 810 (A,119,22) RS1/10SR8R2J C 197 (A,122,75) CKSSYB271K50
R 811 (A,118,22) RS1/10SR8R2J C 201 (A,80,102) CKSRYB105K10
R 812 (A,130,27) RS1/16SS104J C 202 (A,80,106) CKSRYB105K10
C 203 (A,80,104) CKSQYB225K10
R 813 (A,131,27) RS1/16SS104J C 204 (A,105,104) CKSRYB105K10
R 814 (A,123,19) RS1/10SR101J
R 816 (A,126,19) RS1/10SR101J C 209 (A,94,107) CKSRYB224K16 F
R 821 (A,42,23) RS1/10SR1R0J C 210 (A,94,106) CKSRYB224K16
R 822 (A,24,31) RS1/4SA472J C 211 (A,72,116) CKSRYB105K10
C 212 (A,85,115) CKSRYB105K10
R 823 (A,21,29) RS1/16SS103J
DEH-P6200BT/XSUC
5 6 7 8
85
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
C 213 (A,88,120) 10 uF CCG1192 C 456 (A,68,67) CEVW100M16
C 214 (A,86,122) 10 uF CCG1192 C 457 (A,75,61) CCSRCH221J50
C 215 (A,86,123) CKSSYB104K10 C 458 (A,74,65) CKSRYB105K10
A
C 216 (A,86,125) 10 uF CCG1192 C 463 (A,83,51) CKSSYB104K10
C 217 (A,89,127) CKSSYB104K10 C 466 (A,88,59) CEVW331M6R3
C 218 (A,91,127) 10 uF CCG1192 C 501 (A,97,76) 10 uF CCG1192
C 219 (A,72,119) CKSRYB105K10 C 503 (A,102,75) 10 uF CCG1192
C 220 (A,85,118) CKSRYB105K10 C 504 (A,97,79) 10 uF CCG1192
C 223 (A,85,111) (E) CKSRYB105K10 C 506 (A,102,78) 10 uF CCG1192
C 224 (A,72,113) (E) CKSRYB105K10 C 507 (A,139,43) CKSSYB104K10
C 225 (A,85,113) (E) CKSRYB105K10 C 508 (A,139,45) CKSSYB104K10
C 226 (A,72,114) (E) CKSRYB105K10 C 509 (A,138,49) CKSSYB104K10
C 227 (A,85,117) CKSRYB105K10 C 510 (A,139,50) CKSSYB104K10
B C 228 (A,72,118) CKSRYB105K10 C 511 (A,138,55) CKSSYB104K10
C 229 (A,105,117) (E) CKSRYB104K16 C 512 (A,139,56) CKSSYB104K10
C 230 (A,100,126) (E) CEVW470M16 C 513 (A,138,60) CKSSYB104K10
C 231 (A,100,121) (E) CKSRYB104K16 C 514 (A,139,61) CKSSYB104K10
C 234 (A,81,126) (E) CKSSYB102K50 C 515 (A,138,63) CKSSYB103K16
C 235 (A,84,123) CKSSYB102K50 C 516 (A,134,67) CKSSYB104K10
C 301 (A,28,122) 10 uF(E,A) CCG1192 C 519 (A,128,66) CKSSYB104K10
C 302 (A,33,123) 10 uF(E,A) CCG1192 C 520 (A,127,66) CKSSYB104K10
C 303 (A,37,124) 10 uF(E) CCG1192 C 521 (A,125,67) CKSSYB104K10
C 304 (A,39,131) 10 uF(E) CCG1192 C 522 (A,119,69) CKSSYB104K10
C 305 (A,37,126) 10 uF CCG1192 C 523 (A,124,71) CCSSCH100D50
C C 306 (A,38,129) 10 uF CCG1192 C 524 (A,127,72) CCSSCH100D50
C 351 (A,83,131) CKSRYB474K10 C 525 (A,120,67) CKSSYB104K10
C 352 (A,82,131) CKSRYB474K10 C 526 (A,118,66) CKSSYB104K10
C 353 (A,86,131) CKSRYB474K10 C 527 (A,116,67) CKSSYB104K10
C 354 (A,87,131) CKSRYB474K10 C 528 (A,115,67) CKSSYB104K10
C 355 (A,83,133) CKSRYB474K16 C 529 (A,111,66) CKSSYB104K10
C 356 (A,82,133) CKSRYB474K16 C 530 (A,110,66) CKSSYB104K10
C 357 (A,86,133) CKSRYB474K16 C 531 (A,107,59) CKSSYB104K10
C 358 (A,87,133) CKSRYB474K16 C 532 (A,107,57) CKSSYB104K10
C 361 (A,138,123) 3 300 uF/16 V CCH1486 C 533 (A,107,53) CKSSYB104K10
C 362 (A,67,138) CKSRYB104K16 C 534 (A,107,52) CKSSYB104K10
D C 363 (A,77,135) CKSQYB225K10 C 535 (A,107,48) CKSSYB104K10
C 364 (A,73,135) CKSQYB225K10 C 536 (A,107,46) CKSSYB104K10
C 365 (A,75,132) 10 uF CCG1236 C 537 (A,106,42) CKSSYB104K10
C 367 (A,63,134) 10 uF CCG1192 C 538 (A,107,40) CKSSYB104K10
C 368 (A,89,131) (A,B) CCSSCH220J50 C 539 (A,114,36) CKSSYB104K10
C 369 (A,85,129) (A,B) CCSSCH220J50 C 540 (A,118,35) CKSSYB104K10
C 370 (A,80,129) (A,B) CCSSCH220J50 C 541 (A,120,34) CKSSYB104K10
C 371 (A,80,133) (A,B) CCSSCH220J50 C 542 (A,125,36) CKSSYB104K10
C 381 (A,51,130) CEVW220M16 C 543 (A,130,35) CKSSYB104K10
C 401 (A,158,104) CKSSYB103K16 C 544 (A,131,36) CKSSYB104K10
C 402 (A,156,104) 10 uF CCG1192 C 545 (A,99,72) CKSRYB105K10
E
C 404 (A,157,62) 4.7 uF CCG1201 C 546 (A,138,71) CKSSYB102K50
C 405 (A,156,62) CKSSYB103K16 C 547 (A,105,71) CCSSCH220J50
C 406 (A,154,62) 10 uF CCG1192 C 548 (A,88,35) (E) CKSRYB104K16
C 407 (A,156,76) CKSRYB103K50 C 549 (A,106,44) CCSSCH120J50
C 408 (A,158,48) (E) CKSSYB122K50 C 550 (A,103,48) CCSSCH120J50
C 409 (A,158,50) (E) CKSSYB122K50 C 551 (A,113,75) CCSSCH220J50
C 410 (A,156,74) 10 uF CCG1192 C 552 (A,113,73) CCSSCH220J50
C 431 (A,159,34) CKSQYB475K6R3 C 553 (A,116,76) CCSSCH220J50
C 432 (A,157,32) CKSSYB103K16 C 554 (A,121,34) CCSSCH220J50
C 433 (A,163,34) 4.7 uF CCG1201 C 555 (A,122,31) CCSSCH220J50
F
C 451 (A,63,53) CKSRYB105K10 C 556 (A,123,30) CCSSCH220J50
C 452 (A,68,53) CKSRYB105K10 C 557 (A,124,30) CCSSCH220J50
C 454 (A,65,62) CCSRCH471J50 C 558 (A,125,30) CCSSCH220J50
C 455 (A,72,54) CCSRCH471J50 C 559 (A,126,30) CCSSCH220J50
86 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
C 560 (A,127,30) CCSSCH220J50
C
C
C
561
562
563
(A,128,30)
(A,129,30)
(A,130,30)
CCSSCH220J50
CCSSCH220J50
CCSSCH220J50
C
Unit Number : CWX3774
A
C 564 (A,131,30) CCSSCH220J50
C 565 (A,133,30) CCSSCH220J50
Unit Name : CD Core Unit (S11STD-DOUT)
C 566 (A,133,31) CCSSCH220J50 MISCELLANEOUS
C 567 (A,133,32) CCSSCH220J50
C 568 (A,135,36) CCSSCH220J50 IC 201 (A,28,33) IC PE5706A
C 569 (A,133,33) CCSSCH220J50 IC 301 (A,64,27) IC BA5839FP
C 571 (A,140,41) 10 uF CCG1192 Q 101 (B,8,56) Transistor 2SA1577
Q 102 (B,21,51) Digital TR(PNP) UNR511MG
C 572 (A,142,41) CKSSYB104K10 X 201 (A,15,27) Ceramic Resonator 16.934 MHz CSS1603
C 574 (A,144,65) CKSSYB103K16
C 581 (A,48,75) 10 uF CCG1192 S 901 (A,42,53) Switch CSN1067 B
C 583 (A,64,79) 10 uF CCG1192 S 903 (B,21,12) Switch CSN1068
C 585 (A,66,78) 10 uF CCG1192 S 905 (B,11,25) Switch CSN1068
CN101 (A,16,58) Connector CKS4808
C 588 (A,70,74) 10 uF CCG1192 CN701 (A,37,10) Connector CKS6146
C 591 (A,108,23) CKSSYB104K10
C 592 (A,102,19) CKSSYB104K10 RESISTORS
C 601 (A,108,91) 10 uF CCG1192
C 603 (A,116,90) 4.7 uF CCG1201 R 101 (B,6,59) RS1/10SR2R4J
R 102 (B,7,59) RS1/10SR2R4J
C 604 (A,110,102) CCSSCH120J50 R 103 (B,8,59) RS1/10SR2R7J
C 605 (A,110,100) CCSSCH100D50 R 108 (B,19,53) RS1/16SS105J
C 606 (A,119,96) CKSSYB104K10 R 109 (B,11,52) RS1/16SS222J
C 608 (A,140,96) CKSSYB104K10 C
C 609 (A,142,99) CCSSCH470J50 R 214 (A,38,41) RS1/16SS103J
R 215 (A,38,40) RS1/16SS393J
C 612 (A,143,102) CCSSCH470J50 R 216 (A,30,44) RS1/16SS122J
C 651 (A,117,110) CKSRYB105K10 R 217 (A,33,46) RS1/16SS562J
C 703 (A,101,31) CCSSCH470J50 R 218 (A,30,46) RS1/16SS472J
C 705 (A,101,38) CCSSCH470J50
C 706 (A,120,31) CKSSYB103K16 R 225 (A,33,23) RS1/16SS0R0J
R 229 (A,31,44) RS1/16SS471J
C 751 (A,22,84) 10 uF CCG1192 R 232 (A,19,21) RS1/16SS0R0J
C 754 (A,19,92) CKSSYB473K16 R 235 (A,45,32) RS1/16SS103J
C 801 (A,101,14) CKSSYB104K10 R 236 (A,46,32) RS1/16SS103J
C 831 (A,16,47) CKSRYB473K50
C 832 (A,96,9) CKSRYB105K10 R 237 (B,24,25) RS1/16SS221J D
R 240 (B,26,30) RS1/16SS473J
C 842 (A,98,12) CKSRYB105K10 R 245 (B,28,30) RS1/16SS104J
C 851 (A,33,46) (E) CCSRCH471J50 R 253 (B,27,30) RS1/16SS104J
C 852 (A,33,53) (E) CKSRYB223K50 R 254 (B,29,30) RS1/16SS104J
C 854 (A,41,50) (E) CEVW470M16
C 855 (A,42,41) 10 uF(E) CCG1236 R 260 (B,41,21) RS1/16SS103J
R 262 (A,44,32) RS1/16SS472J
C 856 (A,25,52) (E) CKSRYB104K16 R 263 (A,47,32) RS1/16SS472J
C 857 (A,23,44) (E) CEVW101M16 R 264 (A,44,25) RS1/16SS102J
C 881 (A,41,58) CEVW470M16 R 281 (A,31,22) RS1/16SS560J
C 882 (A,59,53) CKSRYB105K10
C 883 (A,40,66) CKSRYB103K50 R 282 (A,30,22) RS1/16SS560J
E
R 283 (B,32,18) RS1/16SS0R0J
C 884 (A,38,65) CKSYB475K16 R 291 (B,31,17) RS1/16SS560J
C 891 (A,19,63) CEVW470M16 R 292 (B,32,16) RS1/16SS0R0J
C 892 (A,21,70) CKSRYB103K50 R 293 (B,32,11) RS1/16SS0R0J
C 893 (A,30,64) CEVW101M16
C 901 (A,23,97) CEAT102M16 R 294 (A,18,28) RS1/16SS471J
R 296 (B,32,30) RS1/16SS0R0J
C 902 (A,18,104) CKSSYB103K16 R 299 (B,31,13) RS1/16SS0R0J
C 904 (A,13,99) 10 uF CCG1192 R 305 (A,60,34) RS1/16SS183J
C 905 (A,19,78) CKSQYB475K6R3 R 306 (A,61,37) RS1/16SS183J
C 907 (A,19,74) CKSQYB475K6R3
C 911 (A,33,114) CEVW221M16 R 307 (A,58,34) RS1/16SS183J
R 308 (A,58,36) RS1/16SS183J F
C 913 (A,18,115) CEVW101M16 R 701 (B,37,21) RS1/16SS101J
C 921 (A,129,130) CKSRYB104K16 R 702 (B,38,20) RS1/16SS101J
C 941 (A,110,129) CKSRYB473K50 R 706 (B,43,11) RS1/16SS221J
DEH-P6200BT/XSUC
5 6 7 8
87
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 708 (A,40,22) RS1/16SS0R0J D 1836 (A,9,13) LED(E,A) CL-195SR-CD
R 709 (A,40,21) RS1/16SS0R0J (A,9,13) LED(B) CL-197HB1-D(CDE)
R 722 (B,37,22) RS1/16SS0R0J D 1837 (A,20,14) LED(E,A) CL-195SR-CD
(A,20,14) LED(B) CL-197HB1-D(CDE)
A
CAPACITORS
D 1838 (A,31,14) LED(E,A) CL-195SR-CD
C 104 (B,11,55) CKSQYB475K6R3 (A,31,14) LED(B) CL-197HB1-D(CDE)
C 203 (A,18,35) CKSSYB104K10 D 1839 (A,78,9) LED(E,A) CL-195SR-CD
C 209 (A,17,28) CKSRYB104K16 (A,78,9) LED(B) CL-197HB1-D(CDE)
C 210 (A,21,21) CKSSYB104K10 D 1840 (A,88,9) LED(E,A) CL-195SR-CD
C 211 (A,24,23) CKSSYB104K10 (A,88,9) LED(B) CL-197HB1-D(CDE)
C 212 (A,38,33) CKSSYB104K10 D 1841 (A,102,9) LED(E,A) CL-195SR-CD
C 213 (A,40,41) CKSSYB332K50 (A,102,9) LED(B) CL-197HB1-D(CDE)
C 214 (A,40,40) CKSSYB473K10 D 1842 (A,112,9) LED(E,A) CL-195SR-CD
C 215 (A,38,37) CKSSYB104K10 (A,112,9) LED(B) CL-197HB1-D(CDE)
B C 216 (A,36,46) CKSSYB182K50 D 1843 (A,126,9) LED(E,A) CL-195SR-CD
(A,126,9) LED(B) CL-197HB1-D(CDE)
C 217 (A,31,46) CCSSCH560J50
C 218 (A,29,46) CCSSCH4R0C50 D 1844 (A,136,9) LED(E,A) CL-195SR-CD
C 219 (A,32,43) CKSSYB104K10 (A,136,9) LED(B) CL-197HB1-D(CDE)
C 220 (B,32,41) CKSSYB104K10 D 1845 (A,44,25) LED(E,A) CL-195SR-CD
C 221 (A,35,43) CKSSYB104K10 (A,44,25) LED(B) CL-197HB1-D(CDE)
D 1846 (A,65,29) LED(E,A) CL-195SR-CD
C 222 (A,29,43) CKSSYB104K10 LED(B) CL-197HB1-D(CDE)
C 223 (A,25,44) CCSSCH680J50
C 224 (A,23,44) CCSSCH470J50 D 1866 (A,145,30) LED(E,A) CL-195SR-CD
C 225 (A,20,43) CKSSYB103K16 (A,145,30) LED(B) CL-197HB1-D(CDE)
C 228 (A,32,46) CCSSCH270J50 D 1901 (B,99,32) Diode 1SS355
C L 1901 (B,80,29) Inductor CTF1379
C 229 (B,28,40) CKSSYB104K10 X 1901 (B,88,31) Radiator 10.0 MHz CSS1577
C 231 (B,44,28) CKSSYB102K50
C 232 (B,45,28) CKSSYB102K50 S 1801 (A,6,37) Push Switch CSG1155
C 233 (B,25,25) CKSSYB103K16 S 1811 (A,56,21) Switch CSX1120
C 236 (B,26,41) CKSSYB104K10 S 1871 (A,12,7) Push Switch CSG1155
S 1872 (A,23,8) Push Switch CSG1155
C 238 (A,15,35) CKSRYB104K16 S 1873 (A,35,8) Push Switch CSG1155
C 299 (A,17,33) CKSSYB104K10
C 304 (A,60,35) CKSSYB472K25 S 1874 (A,73,8) Push Switch CSG1155
C 305 (A,58,35) CKSSYB223K16 S 1875 (A,92,8) Push Switch CSG1155
C 306 (A,68,20) CKSRYB105K10 S 1876 (A,140,8) Push Switch CSG1155
S 1877 (A,22,35) Push Switch CSG1155
D C 710 (B,43,10) CKSSYB102K50 S 1878 (A,34,34) Push Switch CSG1155
S 1879 (A,96,8) Push Switch CSG1155
S 1880 (A,116,8) Push Switch CSG1155
D
S 1881 (A,121,8) Push Switch CSG1155
S 1882 (A,150,43) Push Switch CSG1155
Unit Number : YWM5476(E) CN1801 (B,109,11) Connector CKS6049
Unit Number : YWM5472(A) CN1802 (A,155,27) Connector YKS5036
Unit Number : YWM5473(B) CN1921 (A,99,23) Connector CKS6036
JA1801 (A,154,11) Jack YKN5006
Unit Name : KEYBOARD ASSY OEL Module MXS4013
E MISCELLANEOUS RESISTORS
IC 1891 (A,145,19) Remote IC GP1UXC14RK R 1804 (B,89,13) RS1/10SR222J
IC 1901 (B,88,24) IC PEG642A8 R 1805 (B,91,18) RS1/10SR222J
Q 1833 (A,131,29) Chip Transistor DTC124EUA R 1811 (B,71,19) RS1/10SR102J
D 1804 (B,88,15) Diode MC2848-11 R 1812 (B,48,14) RS1/10SR102J
D 1805 (B,92,16) Diode MC2846-11 R 1813 (B,50,14) RS1/10SR103J
D 1831 (A,153,40) LED(E,A) CL-195SR-CD R 1814 (B,69,14) RS1/10SR122J
(A,153,40) LED(B) CL-197HB1-D(CDE) R 1815 (B,63,28) RS1/10SR182J
D 1833 (A,8,30) LED(E,A) CL-195SR-CD R 1816 (B,47,30) RS1/10SR332J
(A,8,30) LED(B) CL-197HB1-D(CDE) R 1817 (B,47,28) RS1/10SR822J
D 1834 (A,19,30) LED(E,A) CL-195SR-CD R 1818 (B,43,29) RS1/10SR103J
F
(A,19,30) LED(B) CL-197HB1-D(CDE)
R 1831 (B,151,40) (E,A) RS1/4SA271J
D 1835 (A,31,29) LED(E,A) CL-195SR-CD R 1832 (B,157,40) (E,A) RS1/4SA561J
(A,31,29) LED(B) CL-197HB1-D(CDE)
88 DEH-P6200BT/XSUC
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 1835 (B,14,25) (E,A) RS1/4SA331J Miscellaneous Parts List
R 1837 (B,16,11) (E,A) RS1/4SA331J
R 1838 (B,68,10) (E,A) RS1/4SA331J M 1 Motor Unit(SPDL) CXE2273
M 2 Motor Unit(LOAD/CRG) CXC4026 A
R 1839 (B,121,24) (E,A) RS1/4SA331J
Pickup Unit(S10.5)(Service) CXX1942
R 1840 (B,32,28) (E,A) RS1/4SA471J
R 1851 (B,153,42) (B) RS1/10SR821J
R 1859 (B,44,9) RS1/10SR0R0J
R 1861 (A,142,29) (E,A) RS1/10SR121J
(A,142,29) (B) RS1/10SR390J
R 1862 (B,30,29) (B) RS1/10SR222J
R 1863 (B,123,25) (B) RS1/10SR821J
R 1864 (B,69,11) (B) RS1/10SR821J
R 1865 (B,12,18) (B) RS1/10SR152J
R 1866 (B,14,30) (B) RS1/10SR152J
B
R 1871 (A,7,9) RS1/10SR103J
R 1872 (A,16,8) RS1/10SR122J
R 1873 (A,31,9) RS1/10SR182J
R 1874 (A,40,9) RS1/10SR332J
R 1875 (A,82,10) RS1/10SR822J
R 1876 (A,120,23) RS1/10SR333J
R 1877 (A,18,34) RS1/10SR103J
R 1878 (A,27,34) RS1/10SR122J
R 1879 (A,39,33) RS1/10SR182J
R 1880 (A,119,28) RS1/10SR332J
R 1881 (A,123,20) RS1/10SR822J C
R 1882 (A,124,18) RS1/10SR333J
R 1891 (B,134,24) RS1/10SR121J
R 1893 (B,138,25) RS1/10SR2R2J
R 1901 (B,76,29) RS1/10SR473J
R 1902 (B,95,32) RS1/10SR154J
R 1903 (B,82,32) RS1/10SR473J
R 1904 (B,100,20) RS1/10SR473J
R 1905 (B,100,22) RS1/10SR473J
R 1906 (A,110,29) RS1/10SR473J
R 1907 (A,111,31) RS1/10SR473J
R 1908 (B,87,17) RS1/10SR103J D
R 1909 (B,72,22) RS1/10SR102J
R 1910 (B,76,25) RS1/10SR473J
R 1922 (A,90,22) RS1/10SR5102D
R 1924 (A,108,26) RAB4C101J
R 1925 (B,96,23) RAB4C101J
R 1942 (B,16,26) (E,A) RS1/10SR151J
R 1943 (B,14,21) (E,A) RS1/10SR151J
R 1944 (B,72,9) (E,A) RS1/10SR151J
R 1945 (B,123,22) (E,A) RS1/10SR151J
R 1946 (B,37,31) (E,A) RS1/10SR221J
E
R 1949 (B,156,42) (B) RS1/10SR152J
CAPACITORS
C 1801 (B,147,33) CKSRYB104K16
C 1802 (B,148,17) CKSRYB472K50
C 1803 (B,146,15) CKSRYB472K50
C 1807 (B,102,32) CKSRYB105K10
C 1891 (B,139,21) CKSYF106Z10
C 1901 (B,100,30) CKSRYB104K16
C 1902 (B,83,25) CKSRYB105K10
C 1921 (A,90,26) CKSRYB105K10 F
C 1922 (A,90,24) CKSRYB105K10
C 1923 (B,100,23) CKSRYB104K16
DEH-P6200BT/XSUC
5 6 7 8
89
You might also like
- Pioneer Deh 2200ub Deh 2220ub Deh 2210ubNo ratings yetPioneer Deh 2200ub Deh 2220ub Deh 2210ub75 pages
- Service (Repair) Manual For Pioneer DEH-P9800BTNo ratings yetService (Repair) Manual For Pioneer DEH-P9800BT148 pages
- C4505 Deh-4250sd, Deh-4290sd, Deh-3200ubNo ratings yetC4505 Deh-4250sd, Deh-4290sd, Deh-3200ub82 pages
- Pioneer DEH-P490IB - P4900IB (CRT3846) Receiver Audio CarNo ratings yetPioneer DEH-P490IB - P4900IB (CRT3846) Receiver Audio Car74 pages
- Pioneer Deh-2300ub Deh-2310ub Deh-2300ubb Deh-2320ub PDFNo ratings yetPioneer Deh-2300ub Deh-2310ub Deh-2300ubb Deh-2320ub PDF63 pages
- Pioneer DEH-P510UB 5100UB 5150UB 5190UBNo ratings yetPioneer DEH-P510UB 5100UB 5150UB 5190UB79 pages
- Pioneer DEH-2000MPB - 2020MP (CRT4043) S.MNo ratings yetPioneer DEH-2000MPB - 2020MP (CRT4043) S.M62 pages
- Service (Repair) Manual For Pioneer DEH-P9800BTNo ratings yetService (Repair) Manual For Pioneer DEH-P9800BT148 pages
- Pioneer Dvh-P6050ub crt4141 Car DVD ReceiverNo ratings yetPioneer Dvh-P6050ub crt4141 Car DVD Receiver133 pages
- Pioneer Deh-1000e 1020e 1050e crt4042 SMNo ratings yetPioneer Deh-1000e 1020e 1050e crt4042 SM56 pages
- DEH-P780MP Multi-Cd Control DSP High Power Cd-Mp3-Wma-A-Ac Player With TunerNo ratings yetDEH-P780MP Multi-Cd Control DSP High Power Cd-Mp3-Wma-A-Ac Player With Tuner104 pages
- Chainsaw Operator's Manual: Chainsaw Safety, Maintenance and Cross-cutting TechniquesFrom EverandChainsaw Operator's Manual: Chainsaw Safety, Maintenance and Cross-cutting Techniques5/5 (1)
- The Unofficial WG K7000 Repair Guide: Arcade Monitor Troubleshooting Guides, #1From EverandThe Unofficial WG K7000 Repair Guide: Arcade Monitor Troubleshooting Guides, #1No ratings yet
- Industrial Electric Motors: Installation, Running, Advanced Maintenance and ReliabilityFrom EverandIndustrial Electric Motors: Installation, Running, Advanced Maintenance and Reliability4/5 (1)
- JY - S (FIRE) Aligning With My Authentic SelfNo ratings yetJY - S (FIRE) Aligning With My Authentic Self3 pages
- Avison Young Vietnam Quarterly Knowledge Report Q42024 EN.02No ratings yetAvison Young Vietnam Quarterly Knowledge Report Q42024 EN.0262 pages
- Cost Accounting Traditions and Innovations: Process CostingNo ratings yetCost Accounting Traditions and Innovations: Process Costing31 pages
- Array-Based Lists: Data Structures Using Java 1No ratings yetArray-Based Lists: Data Structures Using Java 140 pages
- Xuelin Qian Pose-Normalized Image Generation ECCV 2018 PaperNo ratings yetXuelin Qian Pose-Normalized Image Generation ECCV 2018 Paper18 pages
- B.L.P. Land: Ang Bagong Lahing Pilipino Development Foundation, IncNo ratings yetB.L.P. Land: Ang Bagong Lahing Pilipino Development Foundation, Inc10 pages
- Rural Postal Life Insurance Intro Eligibility FeaturesNo ratings yetRural Postal Life Insurance Intro Eligibility Features3 pages
- Profitability: 2008 2010 Operating Profit Margin (%)No ratings yetProfitability: 2008 2010 Operating Profit Margin (%)4 pages
- 1996 - Process Design in Multi-Stage Cold Forging by The Finite Element MethodNo ratings yet1996 - Process Design in Multi-Stage Cold Forging by The Finite Element Method10 pages
- Onboard Processing in Satellite Communications Using AI AcceleratorsNo ratings yetOnboard Processing in Satellite Communications Using AI Accelerators22 pages
