Eurex Top 700
Eurex Top 700
en-GB
Contents
4 Introduction
4 Elementary safety warnings
7 Services
8 Product description
15 Technical condition
19 Article list
Introduction
Elementary safety warnings
User target groups Remarks on this booklet
▪ This booklet is aimed at all persons who will be work- ▪ This document can be used as general Instructions
ing with the Doka product or system that it describes. for Assembly and Use (Method Statement) or be
It contains information on the standard design for incorporated into site-specific Instructions for
setting up this system, and on correct, compliant uti- Assembly and Use (Method Statement).
lisation of the system. ▪ The graphics, animations and videos in this doc-
▪ All persons working with the product described ument or app sometimes depict partially assem-
herein must be familiar with the contents of this bled assemblies and may require additional
booklet and with all the safety instructions it contains. safety equipment and/or measures to comply
▪ Persons who are incapable of reading and under- with safety regulations.
standing this booklet, or who can do so only with dif- The customer must ensure all applicable regulations
ficulty, must be instructed and trained by the cus- are complied with, even if they are not shown or
tomer. implied in the graphics, animations and videos pro-
▪ The customer is to ensure that the information mate- vided.
rials provided by Doka (e.g. User Information book- ▪ Individual sections contain further safety
lets, Instructions for Assembly and Use, Operating instructions and/or special warnings as applica-
Instruction manuals, plans etc.) are up to date and ble.
available to all users, and that they have been made
aware of them and have easy access to them at the
usage location. Planning
▪ In the relevant technical documentation and form-
work utilisation plans, Doka shows the workplace ▪ Provide safe workplaces for those using the form-
safety precautions that are necessary in order to use work (e.g. for when it is being erected/dismantled,
the Doka products safely in the usage situations modified or repositioned etc). It must be possible to
shown. get to and from these workplaces via safe access
In all cases, users are obliged to ensure compliance routes!
with national laws, standards and regulations ▪ If you are considering any deviation from the
throughout the entire project and to take appropriate details and instructions given in this booklet, or
additional or alternative workplace safety precau- any application which goes beyond those
tions where necessary. described in the booklet, then revised static cal-
culations must be produced for checking, as well
as supplementary assembly instructions.
Hazard assessment
▪ The customer is responsible for drawing up, docu- Regulations; industrial safety
menting, implementing and continually updating a
hazard assessment at every job-site. ▪ All laws, Standards, industrial safety regulations and
This booklet serves as the basis for the site-specific other safety rules applying to the utilisation of our
hazard assessment, and for the instructions given to products in the country and/or region in which you
users on how to prepare and utilise the system. It are operating must be observed at all times.
does not substitute for these, however.
▪ If a person or object falls against, or into, the side-
guard component and/or any of its accessories, the
component affected may only continue in use after it
has been inspected and passed by an expert.
Tip
Points out useful practical tips.
Reference
Cross-references other documents.
Services
Support in every stage of the project High performance, in all stages of the project
Product description
CAUTION
Is not substitute for bracing on supporting sys-
tems.
➤ Only use for holding floor props upright!
G The Removable folding tripod 1.20m is mainly intended
to hold Doka floor props Eurex upright while they are
being set up (see table below).
The pivot-mounted legs facilitate positioning close to
walls and in corners, or elsewhere if space is at a pre-
mium.
Props and tripods have to be repositioned separately.
Setup:
➤ Open the clamping lever.
H A
A Head-plate
B Inner tube
C Fastening clamp
D Adjusting nut
E Toggle lever
F Rating label ➤ Open the legs of the tripod and place it in position.
G Outer tube ➤ Slip the floor prop into the tripod.
H Baseplate ➤ Close the clamping lever to secure the assembly.
Closing the clamping lever with the legs folded in
The main features: secures the legs in this position for transport and stor-
▪ DIB (German Institute of Construction Engineering) age.
approval n° Z-8.311-905
▪ EN 1065-compliant floor prop Possible clamping ranges:
▪ high load-bearing capacity Doka floor prop Outer tube Inner tube
- see the section headed 'Permitted carrying Eurex 20 top 400 X —
capacity' Eurex 20 top 550 X X
Eurex 20 top 700 X X
▪ numbered pegging holes, for easier height adjust-
Eurex 30 top 350 X —
ment
Eurex 30 top 400 X —
Eurex 30 top 450 X X
Eurex 30 top 550 X X
Eurex 60 550 — X
98017-200-01
For details of the permitted load-bearing capacities, For details of the permitted load-bearing capacities,
see the section headed "Permitted carrying capacity". see the section headed "Permitted carrying capacity".
Practical example
98008-201-01
Setup and removal ➤ Secure a rope underneath the head-plate and pull on
the rope to extend the floor prop.
NOTICE
For manual transport, grip the floor prop only
by the outer and inner tubes.
9720-006
Setting up with tripod
➤ Set up Removable folding tripod 1.20m.
➤ With one foot against the baseplate to prevent slip-
page, raise the floor prop upright.
98008-204-01
CAUTION
➤ Put the floor prop into the Removable folding tripod
1.20m and fix it in place with the clamping lever. ➤ If you do transport the floor props with the
Before stepping onto the formwork, check again to lowering heads still attached, you must
make sure that the props have been correctly fixed secure these with a Spring locked connect-
in the tripods. ing pin 16 mm to prevent them dropping out.
This is particularly important when they are
transported in the horizontal.
➤ Insert a Lowering head H20 into the floor prop.
Leave the correct amount of lowering play (a)!
Clearance a between wedge and head-plate:
6 cm
NOTICE
➤ Observe the safety rules of the working
scaffold!
a
98008-205-02
➤ With the prop upright, use the adjusting nut for preci- Bracing
sion adjustment.
NOTICE
Always hammer in the wedge from top to bot-
tom!
98008-205-01
B C B
C B
98017-202-01
98008-206-01
98008-207-01
A A
➤ To prevent toppling, use Supporting head H20 DF to
secure intermediate props for floor formwork (see
the User Information booklets for Dokaflex 1-2-4 or
Doka-Xtra, as applicable). Recommended dimensions of plank for the Doka
➤ When using props as temporary reshoring, press floor prop Eurex 20 top 700
them sufficiently tightly against the floor structure to Plank dimen-
α α
ensure that they cannot topple. sions
Outer tube Inner tube
[cm]
2.4 x 10 ≥ 14° ≥ 8°
Removal 3 x 10 ≥ 14° ≥ 10°
2.4 x 12 ≥ 24° ≥ 18°
➤ Removal is the reverse of the setup procedure. 3 x 12 ≥ 24° ≥ 20°
Planks of these sizes can also be connected to the Dokamatic table
frame (see Practical example).
Practical examples
D C
A
B
98008-208-02
98008-208-01
A Bracing clamp B
B Bracing plank (site-provided)
C Doka floor prop Eurex 20 top 700
D Dokamatic table frame 1.50m
B
B C
A
98008-212-01
C D
B
A
C
98008-210-01 98008-209-01 A Screw-on coupler 48mm 135
B Scaffold tube 48.3mm
A Screw-on coupler 48mm 135
C Doka floor prop Eurex 20 top 700
B Scaffold tube 48.3mm
D Transition swivel coupler 48/76mm
C Doka floor prop Eurex 20 top 700
C
D 98008-211-01
Note:
If there is 1 Doka beam H20 resting on the 4-way head
or Lowering head, then an extra scaffolding tube must
be attached so that the floor prop can be braced to the
table frame.
9790-209-01
9790-205-01 9790-207-01
9790-212-01
9790-200-01
9790-206-01
9790-204-01
Technical condition
The following quality criteria define the statically permit- Threads
ted degree of damage or weakening.
Use is prohibited if the damage is more extensive. ▪ must be greased over entire length and action must
be smooth.
Outer tube - inner tube
Inner tube
Head plate or baseplate bent out of shape ▪ When the inner tube is rotated inside the outer tube
so that the U-bolt fixing-holes of both tubes are lined
▪ a max. 1 mm outward and up, it must be possible to fully extend and retract the
inner tube.
▪ b max. 3 mm inward is permissible
a
Widening
9790-208-07
9790-208-04
9790-208-01
Cracks in welds
▪ not permissible
9790-208-02
Permitted capacities [kN] as a function of the exten- Permitted load-bearing capacity when used as tempo-
sion length and the position of the outer tube rary reshores (props restrained): 35 kN up to 7.00 m
(as per General Building-Inspectorate Approval prop length (with 2 Doka beams H20 as packers, up to
Z-8.311-905) 6.70 m prop length).
Eurex 20 top 700
Position of
Bottom Top
outer tube*) NOTICE
C70 C70 Prop category The increased load-bearing capacity applies
Prop length [m] D70 D70 to EN 1065 only if the prop is set up with head-plate or, as
7.0 20.6 21.7 applicable, baseplate directly against the
6.9 21.5 22.6 underside of the slab (2 Doka beams H20 or a
6.8 22.4 23.6 strip of formwork sheeting as packer permissi-
6.7 23.3 24.5 ble).
6.6 24.3 25.5
6.5 25.1 26.3 With increased load-bearing capacity
6.4 26.3 27.5
6.3 27.4 28.6
6.2 28.5 29.7 A
C
6.1 29.7 30.9
6.0 30.7 32.0
B B
5.9 32.1 33.9
5.8 33.5 35.7
5.7 35.1
5.6 36.5
5.5
5.4
5.3
5.2
5.1
5.0
4.9
4.8 36.7
4.7 36.7
98008-201-01 98008-201-01
4.6
4.5
4.4 Without increased load-bearing capacity
4.3
4.2
4.1 C
4.0
3.9 B
98008-201-01
For details of the permitted capacities of the
A Formwork sheet
Doka floor props when used with the Dokaflex
B Doka beam H20
and Doka Xtra systems, please refer to the rel-
evant User Information booklets. C Lowering head H20 or 4-way head H20
= =
a
92815-224-01
a
Doka stacking pallet 1.55x0.85m max. 4.5 m
Max. carrying capacity: 1100 kg (2420 lbs) Doka stacking pallet 1.20x0.80m max. 3.0 m
Permitted imposed load: 5900 kg (12980 lbs)
Repositioning by forklift truck or pallet stacking
truck
Using Doka stacking pallets as storage units
NOTICE
Max. n° of units on top of one another ▪ Load the items centrically.
Outdoors (on the site) Indoors ▪ Fasten the load to the stacking pallet so that
Floor gradients up to 3% Floor gradients up to 1% it cannot slide or tip out.
2 6
It is not allowed to stack empty
pallets on top of one another! Bolt-on castor set B
NOTICE
The Bolt-on caster set B turns the stacking pallet into a
▪ Stacked multi-trip boxes or pallets must fast and manoeuvrable transport device.
have the heaviest boxes at the bottom and
the lightest at the top. Suitable for drive-through access openings > 90 cm.
▪ How to use with Bolt-on castor set B:
- Always apply the fixing brake when the
container is 'parked'.
- When Doka stacking pallets are
stacked, the bottom pallet must NOT be
one with a bolt-on castor set mounted to The Bolt-on caster set B can be mounted to the follow-
it. ing multi-trip packaging items:
▪ Doka accessory box
▪ Doka stacking pallets
▪ Protective barrier Z pallet
Follow the directions in the 'Bolt-on castor set
B' Operating Instructions!
Doka floor prop Eurex 20 top 700 48.0 586139000 Swivel coupler 48mm 1.5 582560000
Doka-Deckenstütze Eurex 20 top 700 Drehkupplung 48mm
Galvanised Galvanised
Length: 383 - 700 cm Width-across: 22 mm
Follow the directions in the "Fitting
instructions"!
Removable folding tripod 1.20m 20.7 586145000 Bolt-on castor set B 33.6 586168000
Stützbein 1,20m Anklemm-Radsatz B
Galvanised Painted blue
Height: 120 cm
Delivery condition: folded closed
Doka is one of the world leaders in developing, manu- technical support are provided swiftly and profession-
facturing and distributing formwork technology for use in ally.
all fields of the construction sector. An enterprise forming part of the Umdasch Group, the
With more than 160 sales and logistics facilities in over Doka Group employs a worldwide workforce of more
70 countries, the Doka Group has a highly efficient dis- than 6000.
tribution network which ensures that equipment and
www.doka.com/floor-props
Doka GmbH | Josef Umdasch Platz 1 | 3300 Amstetten | Austria | T +43 7472 605-0 | F +43 7472 66430 | [email protected] | www.doka.com 999800802 - 02/2022