WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN.

REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

A A

PT ABB Sakti Industri

Jalan Gajah Tunggal km 1.0
Tangerang 15135, Indonesia

B B

Project Name : MV PANEL ABB

Switchgear Name : INCOMING 20KV

C C

Panel Type : UniSec, 24 kV - 50Hz - 630 A - 16kA x 1s

Customer Name : PT. KALTIM PRIMA COAL

D
Contract No. : - D

Title : Schematic Diagram SDC + LA

E E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 01 02
COVER SHEET
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

SHEET INDEX
A PAGE PAGE NAME REVISION A
=J01-INCOMING-301&CD/01 COVER SHEET 01

=J01-INCOMING-301&CD/02 TABLE OF CONTENT 01

=J01-INCOMING-301&CD/03 REFERENCE DESIGNATIONS 01

=J01-INCOMING-301&CD/04 REFERENCE DESIGNATIONS 01

=J01-INCOMING-301&CD/05 REFERENCE DESIGNATIONS 01

=J01-INCOMING-301&CD/06 MAIN CIRCUITS 01

=J01-INCOMING-301&CD/07 DISTRIBUTION OF AUXILIARY CIRCUITS 01

B =J01-INCOMING-301&CD/08 AUXILIARY MOTOR & RELAY 01 B

=J01-INCOMING-301&CD/09 AVAILABLE CONTACT 01

=J01-INCOMING-301&CD/10 LV DOOR LAYOUT 01

=J01-INCOMING-301&CD/11 LV BOX LAYOUT 01

=J01-INCOMING-301&CD/12 Part list 01

C C

STANDARD REFERENCES
THIS DRAWING IS IN COMPLIANCE WITH THE FOLLOWING INTERNATIONAL STANDARDS:
- IEC 60617: GRAPHICAL SYMBOLS FOR DIAGRAMS
D - IEC 61082: PREPARATION OF DOCUMENTS USED IN ELECTROTECHNOLOGY D
- IEC 81346: STRUCTURING PRINCIPLES AND REFERENCE DESIGNATIONS

THE DIAGRAM INDICATES COMPONENTS HAVING A MOVABLE PART IN THE FOLLOWING POSITION OR
OPERATIONAL STATE (IEC 61082-1 7.4.4.1):
- C.BREAKER OR CONTACTOR IN OPEN (OFF) AND SERVICE POSITION
- DISCONNECTORS AND EARTHING SWITCH IN OPEN POSITION
- WITHDRAWABLE VOLTAGE TRANSFORMERS IN CONNECTED POSITION
- CLOSING SPRINGS OF C.BREAKER IN DISCHARGED POSITION
- CONNECTOR OF C.BREAKER AUXILIARY CIRCUITS IN CONNECTED POSITION
E - CIRCUITS IN DE-ENERGIZED STATE E
- RELAYS IN NON-ACTUATED STATE
- GAS PRESSURE AT RATED SERVICE VALUE
- FUSES NOT OPERATED
- DOORS AND PRESSURE RELIEF FLAPS IN CLOSED POSITION

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 02 03
TABEL OF CONTENT
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

REFERENCE DESIGNATION -BGL1

-BGS1, -BGS2
POSITION SWITCH OF ELECTROMECHANICAL LOCK -RLE1
POSITION SWITCHES OF CIRCUIT-BREAKER SPRINGS
OF OBJECTS IN ELECTRICAL DOCUMENTS -BGS6, -BGS7 POSITION SWITCHES OF THE SPRINGS OF SWITCH-DISCONNECTOR FOR CONTROL CIRCUITS OF THE MOTOR
A OPERATOR A
(IN COMPLIANCE WITH STANDARD IEC 81346-2 AND ABB TECHNICAL STANDARD 2NBA000001) -BGT1 POSITION SWITCHES ON TRUCK SIGNALLING TRUCK IN SERVICE POSITION
-BGT2 POSITION SWITCHES ON TRUCK SIGNALLING TRUCK IN TEST POSITION
DESIGNATION DESCRIPTION -BGT3 POSITION SWITCH ON TRUCK SIGNALLING TRUCK NOT IN ISOLATING TRAVEL POSITION
-BGT4 POSITION SWITCHES ON SWITCHGEAR SIGNALLING TRUCK IN SERVICE POSITION
-AA MULTIFUNCTION UNIT (CENTRAL UNIT)
-BGT5 POSITION SWITCHES ON SWITCHGEAR SIGNALLING TRUCK IN TEST POSITION
-BAD1, -BAD4 CAPACITIVE VOLTAGE DIVIDER LOCATED ON PHASE L1
-BM HYGROSTAT
-BAD2, -BAD5 CAPACITIVE VOLTAGE DIVIDER LOCATED ON PHASE L2
-BPA4 PRESSURE SWITCH LOCATED IN CABLE COMPARTMENT FOR DETECTION OF INTERNAL ARCING
-BAD3, -BAD6 CAPACITIVE VOLTAGE DIVIDER LOCATED ON PHASE L3
-BPA5 PRESSURE SWITCH LOCATED IN CIRCUIT-BREAKER COMPARTMENT
-BAR VOLTAGE PROTECTION RELAY
B -BPA6 PRESSURE SWITCH LOCATED IN BUSBAR OR IN BUSBAR AND CIRCUIT-BREAKER COMPARTMENT FOR DETECTION B
-BAS1 VOLTAGE SENSOR LOCATED ON PHASE L1 OF INTERNAL ARCING
-BAS2 VOLTAGE SENSOR LOCATED ON PHASE L2 -BPS PRESSURE SWITCH LOCATED ON CIRCUIT-BREAKER
-BAS3 VOLTAGE SENSOR LOCATED ON PHASE L3 -BR FLAME DETECTORS, SMOKE DETECTORS
-BAT1 VOLTAGE TRANSFORMER LOCATED ON PHASE L1 -BT THERMOSTAT
-BAT2 VOLTAGE TRANSFORMER LOCATED ON PHASE L2 -BU BUCHHOLZ RELAY
-BAT3 VOLTAGE TRANSFORMER LOCATED ON PHASE L3 -BX1 UNIT WITH SENSORS FOR DETECTION OF INTERNAL ARCING
-BCD DIFFERENTIAL PROTECTIVE RELAY -BX2 ADDITIONAL CURRENT SENSING UNIT FOR DETECTION OF INTERNAL ARCING
-BCF FEEDER PROTECTION RELAY -BZ MULTIFUNCTION SENSORS
-BCG GENERATOR PROTECTION RELAY -BZ1 COMBINED CURRENT AND VOLTAGE SENSOR, LOCATED ON PHASE L1
-BCM MOTOR PROTECTION RELAY -BZ2 COMBINED CURRENT AND VOLTAGE SENSOR, LOCATED ON PHASE L2
C C
-BCN NEUTRAL (RESIDUAL) CURRENT TRANSFORMER COMBINED CURRENT AND VOLTAGE SENSOR, LOCATED ON PHASE L3
-BZ3
-BCP TRANSFORMER PROTECTION RELAY -CA CAPACITORS
-BCR CURRENT PROTECTION RELAY -EA1 LIGHTING LAMP LOCATED IN L.V. INSTRUMENT COMPARTMENT
-BCS1 CURRENT SENSOR LOCATED ON PHASE L1 -EA2 LIGHTING LAMP LOCATED IN CABLE COMPARTMENT
-BCS2 CURRENT SENSOR LOCATED ON PHASE L2 -EA4 LIGHTING LAMP LOCATED IN CIRCUIT BREAKER COMPARTIMENT
-BCS3 CURRENT SENSOR LOCATED ON PHASE L3 -EB1 HEATER LOCATED IN CABLE COMPARTMENT
-BCT1, -BCT4 CURRENT TRANSFORMER LOCATED ON PHASE L1 -EB3 HEATER LOCATED IN MOTOR CABINET
-BCT2, -BCT5 CURRENT TRANSFORMER LOCATED ON PHASE L2 -EB5 HEATER LOCATED IN L.V. INSTRUMET COMPARTMENT
-BCT3, -BCT6 CURRENT TRANSFORMER LOCATED ON PHASE L3 -EB8 HEATERS LOCATED IN RIGHT SIDE OF THE OPERATING MECHANISM ENCLOSURE
-BCZ DISTANCE PROTECTION RELAY -FA1 SURGE ARRESTER LOCATED ON PHASE L1
D D
-BEF FREQUENCY PROTECTION RELAY -FA2 SURGE ARRESTER LOCATED ON PHASE L2
-BER SUPERVISION RELAYS -FA3 SURGE ARRESTER LOCATED ON PHASE L3
-BES SYNCHRONIZING RELAY -FCD FUSE-DISCONNECTORS FOR PROTECTION OF AUXILIARY CIRCUITS
-BET THERMAL PROTECTION RELAY -FCF1 MEDIUM VOLTAGE FUSE LOCATED ON PHASE L1
-BGB1...-BGB3 POSITION SWITCHES OF CIRCUIT-BREAKER -FCF2 MEDIUM VOLTAGE FUSE LOCATED ON PHASE L2
-BGB5 POSITION SWITCH OF CIRCUIT-BREAKER SIGNALLING UNDERVOLTAGE RELEASE ENERGIZED -FCF3 MEDIUM VOLTAGE FUSE LOCATED ON PHASE L3
-BGB6 POSITION SWITCH OF CIRCUIT-BREAKER SIGNALLING UNDERVOLTAGE RELEASE EXCLUDED -FCM1 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF SPRINGS CHARGING MOTOR ON MAIN CIRCUIT-BREAKER
MECHANICALLY
-FCM2 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF CONTROL CIRCUITS
-BGD POSITION SWITCH OF L.V. INSTRUMENT COMPARTMENT DOOR
-FCM3 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF CIRCUIT-BREAKER SPRINGS CHARGING MOTOR
-BGD1 POSITION SWITCH OF CIRCUIT-BREAKER COMPARTMENT DOOR
E -BGD2 POSITION SWITCH OF CABLE COMPARTMENT DOOR
-FCM4 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF CIRCUITS OF MOTOR FOR SWITCH-DISCONNECTOR E
OPERATION
-BGE1 POSITION SWITCHES SIGNALLING EARTHING SWITCH -QCE IN OPEN POSITION -FCM5 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF AUXILIARY CIRCUITS IN ALTERNATING CURRENT
-BGE2 POSITION SWITCHES SIGNALLING EARTHING SWITCH -QCE IN CLOSED POSITION -FCM6 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF BROKEN DELTA SECONDARY CIRCUITS OF VOLTAGE
TRANSFORMERS
-BGF POSITION SWITCHES OF MEDIUM VOLTAGE FUSES
-FCM7 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF STAR CONNECTION SECONDARY CIRCUITS OF VOLTAGE
-BGI7 POSITION SWITCH SIGNALLING DICONNECTOR (OR SWITCH-DISCONNECTOR) -QBD NOT IN MANUAL OPERATION TRANSFORMERS, FIRST WINDING
-FCM8 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF STAR CONNECTION SECONDARY CIRCUITS OF VOLTAGE
-BGI41... POSITION SWITCHES SIGNALLING SWITCH-DISCONNECTOR -QBS CLOSED IN FEEDER POSITION TRANSFORMERS, SECOND WINDING
-BGI43... POSITION SWITCHES SIGNALLING SWITCH-DISCONNECTOR -QBS CLOSED IN EARTH POSITION -FCM9 MINIATURE CIRCUIT-BREAKER FOR PROTECTION OF CIRCUITS OF PROTECTION RELAYS OR MULTIFUNCION
-BGK POSITION SWITCH OF KEY LOCK UNITS
F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F
01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 03 04
REFERENCE DESIGNATIONS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8
-FCT THERMAL OVERLOAD RELEASES -PGS SYNCHRONOSCOPES
-GA GENERATORS -PGV VOLTMETERS
-KFA1 AUXILIARY RELAY SIGNALLING LOW GAS PRESSURE -PGW WATTMETERS
A -KFA2 AUXILIARY RELAY SIGNALLING INSUFFICIENT GAS PRESSURE -PJ ACOUSTICAL SIGNAL DEVICES (BELLS, SIRENS) A
-KFA3...-KFA9 AUXILIARY RELAYS OR CONTACTORS -QAB CIRCUIT-BREAKERS
-KFC CLOSING RELAYS OR CONTACTORS -QAC CONTACTORS (FOR POWER)

-KFI INTEGRATED CIRCUITS -QBD DISCONNECTORS

-KFL LOCKOUT RELAY -QBH MANUAL CIRCUIT-BREAKERS
-KFM MICROPROCESSORS -QBL LINKS
-KFN ANTIPUMPING RELAYS -QBM MINIATURE SWITCH-DISCONNECTORS
-KFO OPENING RELAYS OR CONTACTORS -QBS SWITCH-DISCONNECTORS
-KFP PROGRAMMABLE LOGIC CONTROLLERS (PLC) -QBT TRUCK
B -KFR RECLOSING RELAYS -QCE EARTHING SWITCH B
-KFS SYNCHRONIZING DEVICES -QQ CLUTCHES
-KFT AUXILIARY TIME RELAYS, DELAY ELEMENTS -RAA FERRO-RESONANCE DUMPING RESISTOR
-KFU CONTROL UNIT -RAD DIODES
-KFZ CONTROLLERS -RAI INDUCTORS
-MAD MOTOR FOR ELECTRICAL OPERATION OF SWITCH-DISCONNECTOR -QBS -RAR RESISTORS
-MAE MOTOR FOR ELECTRICAL OPERATION OF EARTHING SWITCH -QCE -RF FILTERS
-MAS MOTOR FOR CIRCUIT-BREAKER SPRINGS CHARGING -RLE1 ELECTROMECHANICAL LOCK PREVENTING CIRCUIT-BREAKER CLOSING
-MAT MOTOR FOR ELECTRICAL OPERATION OF TRUCK RACKING-IN/OUT -RLE2 ELECTROMECHANICAL LOCK PREVENTING TRUCK RACKING-IN/OUT
-MBC CLOSING RELEASE OF CIRCUIT-BREAKER -RLE3 ELECTROMECHANICAL LOCK PREVENTING INSERTION OF LEVER FOR CLOSING OPERATION OF EARTHING SWITCH
C -MBC4 CLOSING RELEASE OF SWITCH-DISCONNECTOR -QBS -RLE4 ELECTROMECHANICAL LOCK PREVENTING THE DOOR OPENING OPERATION C
-MBO1 FIRST OPENING RELEASE OF CIRCUIT-BREAKER -RLE5 ELECTROMECHANICAL LOCK PREVENTING INSERTION OF LEVER FOR CLOSING OPERATION OF LINE SWITCH
-MBO2 SECOND OPENING RELEASE OF CIRCUIT-BREAKER
-SFA AMMETRIC SWITCHES
-MBO3 OPENING SOLENOID FOR OVERCURRENT RELEASE OF CIRCUIT-BREAKER
-SFC CONTROL SWITCHES, CLOSING PUSH-BUTTONS
-MBO4 OPENING RELEASE OF SWITCH-DISCONNECTOR -QBS
-SFL LOCKING CONTACTS
-MBU UNDERVOLTAGE RELEASE OF CIRCUIT-BREAKER
-SFM MOTOR CONTROL PUSH-BUTTON
-MBU4 UNDERVOLTAGE RELEASE OF SWITCH-DISCONNECTOR -QBS
-SFO OPENING PUSH-BUTTONS
-PFB BLUE SIGNAL LAMPS
-SFR RESET PUSH-BUTTONS
-PFF FLAG RELAYS
-SFS SELECTOR SWITCHES
-PFG GREEN SIGNAL LAMPS
D -SFT TEST PUSH-BUTTONS D
-PFR RED SIGNAL LAMPS
-SFU UNLOCKING PUSH-BUTTONS
-PFS SHORT CIRCUIT INDICATORS
-SFV VOLTMETRIC SWITCHES
-PFV VOLTAGE INDICATORS
-TA POWER TRANSFORMERS
-PFV1 VOLTAGE INDICATOR ON FEEDER SIDE
-TB CONVERTER
-PFV2 VOLTAGE INDICATOR ON BUSBAR SIDE
-TFA ACTIVE POWER TRANSDUCERS
-PFW WHITE SIGNAL LAMPS
-TFC CURRENT TRANSDUCERS
-PFX CROSS INDICATORS, ELECTROMECHANICAL INDICATORS
-TFF FREQUENCY TRANSDUCERS
-PFY YELLOW SIGNAL LAMPS
-TFJ ACTIVE ENERGY TRANSDUCERS
-PGA AMMETERS
-TFK REACTIVE ENERGY TRANSDUCERS
-PGC COUNTERS
E -PGF FREQUENCYMETERS
-TFM MULTIFUNCTION TRANSDUCERS E
-TFP POWER-FACTOR TRANSDUCERS
-PGH HOURMETERS
-TFQ REACTIVE POWER TRANSDUCERS
-PGI PROTECTION AND CONTROL UNIT: HUMAN MACHINE INTERFACE
-TFS SIGNAL CONVERTERS
-PGJ ACTIVE ENERGY METERS
-TFV VOLTAGE TRANSDUCERS
-PGK REACTIVE ENERGY METERS
-WA BUSBARS
-PGM MULTIFUNCTION INDICATORS
-WBC POWER CABLES
-PGP POWER-FACTOR METERS
-WE EARTHING CABLES FOR L.V. INSTRUMENT COMPARTMENT
-PGQ VARMETERS
-WGC CONTROL CABLES
F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F
01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 04 05
REFERENCE DESIGNATIONS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

-WGS COMMUNICATION CABLES (SHIELDED TWISTED PAIRS) -XE5 EARTHING TERMINAL BLOCK FOR CABLE COMPARTMENT, VOLTAGE INDICATOR SIDE
-WH OPTICAL FIBRES -XE6 EARTHING TERMINAL BLOCK FOR CABLE COMPARTMENT, REAR BOTTOM SIDE
-XDA TERMINAL BLOCK FOR CIRCUITS OF CURRENT TRANSFORMERS -XE20 EARTHING TERMINAL BLOCK FOR CURRENT TRANSFORMERS
A A
-XDA1 CONNECTOR FOR CIRCUITS OF CURRENT TRANSFORMERS ON PHASE L1 -XE21 EARTHING TERMINAL BLOCK FOR VOLTAGE TRANSFORMERS
-XDA2 CONNECTOR FOR CIRCUITS OF CURRENT TRANSFORMERS ON PHASE L2
-XDA3 CONNECTOR FOR CIRCUITS OF CURRENT TRANSFORMERS ON PHASE L3
-XDA5 CONNECTOR FOR CIRCUITS OF NEUTRAL (RESIDUAL) CURRENT TRANSFORMER
-XDB CONNECTOR FOR ISOLATION OF CIRCUIT-BREAKER
-XDB1 TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF CIRCUIT-BREAKER
-XDB2 TERMINAL BLOCK FOR ADDITIONAL AUXILIARY CIRCUITS OF CIRCUIT-BREAKER
-XDB10...-XDB89CONNECTOR FOR CIRCUIT-BREAKER INTERNAL CIRCUITS
-XDB90 CONNECTOR FOR POSITION SWITCH OF EARTHING SWITCH ON BUSBAR
B B
-XDB91 CONNECTOR FOR OPENING RELEASE CIRCUITS OF SWITCH-DISCONNECTOR
-XDB92 CONNECTOR FOR CLOSING RELEASE CIRCUITS OF SWITCH-DISCONNECTOR
-XDB93 CONNECTOR FOR POSITION SWITCHES OF SWITCH-DISCONNECTOR
-XDB94 CONNECTOR FOR ELECTROMECHANICAL LOCK ON CLOSING OPERATION OF LINE SWITCH
-XDB95 CONNECTOR FOR ELECTROMECHANICAL LOCK ON CLOSING OPERATION OF EARTHING SWITCH
-XDB96 CONNECTOR FOR UNDERVOLTAGE RELEASE CIRCUITS OF SWITCH-DISCONNECTOR
-XDB97 CONNECTOR FOR CIRCUITS OF THE CONTACTOR CONTROL UNIT OF THE MOTOR FOR THE ELECTRICAL OPERATION OF
SWITCH-DISCONNECTOR
-XDC CUSTOMER TERMINAL BLOCK
-XDC1 CUSTOMER TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF CIRCUIT BREAKER
C -XDC2 CUSTOMER TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF SWITCH-DISCONNECTOR C
-XDC3 CUSTOMER TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF PROTECTION RELAY AND MULTIFUNCTION
UNIT
-XDC4 CUSTOMER TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF VOLTAGE TRANSFORMERS
-XDC5 CUSTOMER TERMINAL BLOCK FOR AUXILIARY CONTACTS OF MINIATURE CIRCUIT-BREAKERS
-XDE TERMINAL BLOCK FOR AUXILIARY CIRCUITS OF EARTHING SWITCH -QCE
-XDH TERMINAL BLOCK FOR AUXILIARY CIRCUITS IN ALTERNATING CURRENT
-XDH1 TERMINAL BLOCK FOR CIRCUITS OF ELECTROMECHANICAL LOCK PREVENTING THE DOOR OPENING OPERATION
-XDI TERMINAL BLOCK FOR INTERCONNECTION (CONNECTION BETWEEN PANELS)
-XDI1 TERMINAL BLOCK FOR INTERCONNECTIONS OF CONTROL CIRCUITS

D -XDI2 TERMINAL BLOCK FOR INTERCONNECTIONS OF CIRCUITS OF MOTOR FOR CIRCUIT-BREAKER SPRINGS CHARGING D
-XDI3 TERMINAL BLOCK FOR INTERCONNECTIONS OF CIRCUITS OF MOTOR FOR SWITCH-DISCONNECTOR ELECTRICAL
OPERATION
-XDI4 TERMINAL BLOCK FOR INTERCONNECTIONS OF AUXILIARY CIRCUITS IN ALTERNATING CURRENT
-XDI6 TERMINAL BLOCK FOR INTERCONNECTIONS OF VOLTAGE CIRCUITS
-XDI7 TERMINAL BLOCK FOR INTERCONNECTIONS OF MOD-BUS CIRCUITS
-XDI8 TERMINAL BLOCK FOR INTERCONNECTIONS OF CURRENT CIRCUITS
-XDI9 TERMINAL BLOCK FOR INTERCONNECTIONS OF SPECIAL CIRCUITS
-XDM SEALABLE TERMINAL BLOCK FOR MEASUREMENT
-XDS SOCKET OUTLETS
-XDT TERMINAL BLOCK FOR POSITION CONTACTS OF TRUCK
E E
-XDV TERMINAL BLOCK FOR CIRCUITS OF VOLTAGE TRANSFORMERS
-XDV1 CONNECTOR FOR CIRCUITS OF VOLTAGE TRANSFORMERS ON PHASE L1
-XDV2 CONNECTOR FOR CIRCUITS OF VOLTAGE TRANSFORMERS ON PHASE L2
-XDV3 CONNECTOR FOR CIRCUITS OF VOLTAGE TRANSFORMERS ON PHASE L3
-XDV4 CONNECTOR FOR CIRCUITS OF FERRO-RESONANCE DUMPING RESISTOR
-XDX SUPPORT TERMINAL BLOCKS
-XE1 EARTHING TERMINAL BLOCK FOR L.V. COMPARTMENT, LEFT SIDE
-XE2 EARTHING TERMINAL BLOCK FOR L.V. COMPARTMENT, RIGHT SIDE

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 05 06
REFERENCE DESIGNATIONS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

L1 3 AC 20kV 50Hz, 630A, 16kA for 1Sec

L2
A A
L3

-QBS

-BGI411 -BGI412 -BGI413 -BGI414 -BGI431 -BGI432 -BGI433

M LINE LINE LINE LINE EARTH EARTH EARTH
B B

/08.7D

/08.5D

/08.1C

/09.2C

/08.4D

/09.3C

/09.4C
C C

-FA1

-FA2

-FA3

D D

-PFV1
L1
-BAD1 1
-GND
L2 PE 1
-BAD2 1

L3
E -BAD3 1 E

L1 L2 L3 -GND
1

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 06 07
MAIN CIRCUITS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

FROM NEXT
COSTUMER DIODA BRIDGE OPERATING INDICATION HEATER PANEL
A SUPPLY SUPPLY RIGHT
A

-XDI1 1 230L -XDI1 1 -XDI1 2 -XDI1 1

-XDI1 3 230N -XDI1 3 -XDI1 4 -XDI1 3

B B

1 3 1 3
-FCM2 -FCM5
2P-2A 2 4 2P-2A 2 4
S202-C2 S202-C2
C C

D D

-GND 2
- + -EB
1

E E
/ 08.1A

/ 08.1A
/ 08.1F

/ 08.1F
DB +

DB +

DB +

DB +

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 07 08
MAIN CIRCUITS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

SWITCH DISCONNECTOR

INDICATION LAMP SWITCH DISCONNECTOR LOCAL REMOTE LOCAL REMOTE

A LBS CLOSE LBS OPEN MOTORIZED CLOSING CLOSING OPENING OPENING A

DB +
/ 07.2E
-XDX 1 -XDX 2

FCM2 L
/ 07.4E
-XDX1 1

2 4
-SFS -SFS
B LOCAL 1 REMOTE 3 B
-XDC1 8

-XDX 5 -XDX 6
-XDB93 8

-BGI413 9 10
/06.5B -KFC2 -KFO2
C LINE 5 6
EXTERNAL EXTERNAL
C
14 14 8 3 8 3
-KFC2 -KFO2 -KFC2 -SFC2 -KFO2 -SFO2
5 5 6 6 13 13 14 12 ON 4 12 OFF 4
-KFO2 -KFA1 -KFA1 -KFC2 -KFA1 CLOSE OPEN
-XDB93 7 9 9 9 10 10 13
3 3
-KFO2 -KFC2
-KFA1 11 11
3 11

-XDX 7 -XDX 8 -XDX 9 -XDX 10

-XDC1 7 -XDC1 9
D D

-XDB97 2 -XDB97 1 -XDC1 15 13 5 -XDC1 6 4 -XDC1 2 -XDC1 3 1

-XDB93 15 13 -XDB93 6 4 -XDB93 3 1
x1 x1
-PFG1 -PFR1 -MAD M
GREEN x2 RED x2
-BGI431 -BGI412 -BGI411
/06.6B /06.4B /06.4B
EARTH LINE LINE

E E
-XDB93 14 -XDB93 5 -XDB93 2

-XDX1 3
-XDC1 14
FCM2 N
/ 07.4E

-XDX 4
DB -
/ 07.2E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 08 09
DISTRIBUTION OF AUXILIARY CIRCUITS
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

SWITCH-DISCONNECTOR IN LINE POSITION SWITCH-DISCONNECTOR IN EARTH POSITION

A OPEN CLOSE OPEN CLOSE CLOSE
A

-XDC1 12 -XDC1 10 -XDC1 18 -XDC1 16 -XDC1 19

B B

-XDB93 12 10 -XDB93 18 16 19
-QBS -QBS

-BGI414 -BGI432 -BGI433

/06.5B /06.7B /06.7B
C LINE EARTH EARTH C

-XDB93 11 -XDB93 17 -XDB93 20

-XDC1 11 -XDC1 17 -XDC1 20

D D

E E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 09 10
AVAILABLE CONTACT
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

A A
500
UniSec No. EQUIPMENT DESCRIPTION ENGRAVING

1 -SFS (LOCAL-REMOTE SWITCH) -SFS, LOCAL-REMOTE SWITCH

2 -SFO2 (PUSH BUTTON ILUMINATEDOPEN, RED) -SFO2, LBS OPENED
3 -SFC2 (PUSH BUTTON ILUMINATED FOR LBS CLOSE, GREEN) -SFC2, LBS CLOSED

B B
280

C C

D D

E E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 10 11
LV DOOR LAYOUT
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

A A
500
No. EQUIPMENT DESCRIPTION ENGRAVING

1 -FCM5 (MCB 2P, 2A, S202-C2, ABB) -FCM5, FOR HEATER SUPPLY
2 -KFA1 (AUXILIARY RELAY, 220VDC, RXM, SCHNEIDER) -KFA1, FOR MOTORIZED
3 -KFC2 (AUXILIARY RELAY, 220VDC, RXM, SCHNEIDER) -KFC2, FOR LBS CLOSE
4 -KFO2 (AUXILIARY RELAY, 220VDC, RXM, SCHNEIDER) -KFO2, FOR LBS OPEN
B 5 -DB (DIODE BRIDGE, KBPC3510) -DB, FOR SUPPLY DC VOLTAGE B
280

KFA1 KFC2 KFO2

C C

D D

E E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 11 12
LV BOX LAYOUT
1 2 3 4 5 6 7 8
WE RESERVE ALL RIGHTS IN THIS DOCUMENT AND IN THE INFORMATION CONTAINED THEREIN. REPRODUCTION, USE OR DISCLOSURE TO THIRD PARTIES WITHOUT EXPESS AUTHORITY IS STRICTLY FORBIDDEN.
1 2 3 4 5 6 7 8

Summarized parts list IDABB_F02_005-IDABB-MVE

Carry over: 0.00
A QUANTITY A
TAG ID DESCRIPTION MANUFACTUR/BRAND PART NUMBER REMARKS

SWITCH-DISCONNECTOR TYPE GSEC 24.06.21 1

-QBS ABB G-SEC 24.06.21 /06.1A
ACCORDING TO CIRCUIT DIAGRAM 2RCA023392
MOTOR GEAR FOR LBS 1
-MAD ABB - /08.2D
220VDC
MCB S202-C2 2
-FCM5, -FCM2 ABB 2CDS252001R0024 /07.6C, /07.4C
MCB. 2P, 2A
B B
HEATER 1
-EB SANYANG CDXN010033P0009 /07.6E
230VAC, 50W
AUXILIARY RELAY 3
-KFA1, -KFC2, -KFO2 SCHNEIDER RXM4AB1MD /08.4C, /08.5C
220VDC
DIODE BRIDGE 1
-DB - KBPC3510 /07.5D

LOCAL/REMOTE, 2NO +2NC KN OR EQUIVALEN 1

-SFS 1SFASFSPL /08.6B
SELECTOR SWITCH WITHOUT KEY
C PUSH BUTTON ILLUMINATED LBS CLOSE 1 C
-SFC2 IDEC YW-DE /08.6C
220VAC
PUSH BUTTON ILLUMINATED LBS OPEN 1
-SFO2 IDEC YW-DE /08.8C
220VAC

D D

E E

F NR Project name Contractor Ref. designation =J01-INCOMING-301&CD Lang. Scale F

01 Issued As built 08/05/2024 LK Prepared Based on : -
Checked SY/AN
MV PANEL ABB PT. GRIDTECH INDONESIA
01 Issued For Production 22/04/2024 LK Document kind External doc. id.
Switchgear name
01 Issued For Approval 16/04/2024 LK
Approved HC Resp. (division/department) Title Document id. DCC Page Cont. page
INCOMING 20KV INCOMING
Rev. Description Date Name Date Prep. 08/05/2024 Work order id. - PT. ABB Sakti Industri IDABB224020085 12 12
PART LIST
1 2 3 4 5 6 7 8