Standard Features

MODEL SHX-100
 SUNKINGS Power provides one-source responsibility for the
kVA 110 generating system and accessories.
Standby
kW 100  The generator set and its components are prototype-tested,
factory- built, and production-tested.
kVA 100
Prime  The 50Hz generator set offers a AUS 2012 listing and CE 2015
Power kW 90 listing.
Pf.0.8 Frequency Hz 50  The generator set complies with ISO 8528-5, Class G3
requirements for transient performance.
Voltage V 400  The generator set accepts rated load in one step.
 The 50Hz generator set engine is certified by the Environmental
Rated speed rpm 1500
Protection Agency (EU or MEP) to conform to EU2、EU3
nonroad emissions regulations.(≤560KW)
 A one-year limited warranty covers all systems and
components. Two-, five-, and ten-year extended warranties
are also available.

Generator Features
 The brushless, rotating-field generator has broad range
reconnect ability.
 The pilot-excited, permanent-magnet generator (PMG) provides
superior short-circuit capability
 Controllers are available for all applications. See controller
features inside.
 The low coolant level shutdown prevents overheating (standard
on radiator models only)
 Integral vibration isolation eliminates the need for under-unit
vibration spring isolators
 An electronic, isochronous governor delivers precise frequency
SUNKINGS generator sets meet the standards of ISO9001, CE，
regulation.
BS5000, ISO 8528, ISO 3046, IEC 60034, NEMA MG-1.22.  Electronic engine controls and a generator microprocessor
controller combine to deliver one of the most advanced
Standard reference Conditions: control systems in today’s generator market.
Standard reference condition 25℃ (77℉ ) air inlet temp, 100m (328ft)
A.S.L 30% relative humidity. Fuel consumption data with diesel fuel
with specific gravity of 0.85 and conforming to BS 2869: 1998, Class
A2.

RATINGS: All three-phase units are rated at 0.8 power factor. Standby ratings: Standby ratings apply to installations served by a reliable utility source. The standby rating
is applicable to varying loads for the duration of a power outage. There is no overload capability for this rating. Ratings are in accordance with ISO-3046/1, BS 5514,
AS 2789, and DIN 6271. Prime power ratings:Prime power ratings apply to installations where utility power is unavailable or unreliable. At varying load, the number of
generator set operating hours is unlimited. A 10% overload capacity is available for one hour in twelve. Ratings are in accordance with ISO-8528/1, overload power in
accordance with ISO-3046/1, BS 5514, AS 2789, and DIN 6271.For limited running time and base load ratings, consult SUNKINGS. Obtain the technical information bulletin
(TIS-101) on ratings guidelines for the complete ratings definitions. SUNKINGS reserves the right to change the design or specifications without notice and without any
obligation or liability whatsoever.
Weichai engine Model: WP4.1D113E200

Main features:
• Accessory drive
Single Poly Vee belt drive for fan, alternator and water pump, with self-tension idle for
minimum maintenance
• Complete rebuild ability
Cylinder block has multiple rebore capability. Service cylinder sleeves and valve guides
are also available
• Compact size
Easy for installation and ready access for routine maintenance
• Filters
Fleetguard spin-on fuel filter and full-flow lubricating oil filter
• Cold start capability
Minimum ambient temperature for unaided cold start -12℃
Minimum ambient temperature for aided (with coolant heater) cold start -35℃

Engine Specifications

Engine Brand WEICHAI

Engine Model WP4.1D113E200

Cylinder No.& Configuration 4 cylinder Diesel L type

Working Mode Turbocharged,Aftercooled

Bore x Stroke mm 105*118

Displacement L 4.089

Compression Ratio 17.5:1

Standby Power kW 113

Rated Speed 1500

Lubrication System Splash Lubrication

Lube Oil Conforms above CF class or

SAE10W-30,15w-40

Lube Oil Capacity L 14

Battery Capacity 6-QW-45(380)*2

Fuel Type Diesel:0#(Summer),-

10#(Winter),-35#(Cold)

Fuel Consumption 25% load L/H 6.1

Fuel Consumption 50% load L/H 10.1

Fuel Consumption 75% load L/H 14.1

Fuel Consumption 100% load L/H 18.8

Alternator
 NEMA MG1, IEEE, and ANSI standards compliance
Type 4-Pole, Rotating-Field
for temperature rise and motor starting.
Exciter type Brushless, Permanent-Magnet,
 Sustained short-circuit current of up to 300% of the
Pilot Exciter
rated current for up to 10 seconds.
Voltage regulator Solid-State, Volts/Hz
 Sustained short-circuit current enabling downstream
Insulation NEMA MG1, Class H circuit breakers to trip without collapsing the
Material Synthetic, No hygroscopic generator field.
Temperature rise 130℃, 150℃ Standby  Self-ventilated and dripproof construction.
 Superior voltage waveform from two-thirds pitch
Bearing: quantity, type 1, Sealed
windings and skewed stator.
Coupling Flexible Disc  Digital solid-state.volts-per-hertz voltage regulator
Amortisseur windings Full with±0.25% no-load to full-load regulation.
Rotor balancing 125% 60 Hz, 150% 50 Hz  Brushless alternator with brushless pilot exciter for
Voltage regulation, no-load to excellent load response.
full-load(with < 0.5% drift due 3-Phase Sensing, ±0.25%
to temp. variation
One-step load acceptance 100% of Rating Unbalanced
load capability 100% of Rated Standby

Controller

Audiovisual annunciation with NFPA 110 Level 1 capability.

Programmable microprocessor logic and digital display
features. Safeguard circuit protection standard.
12- or 24-volt engine electrical system capability.
Remote start, remote annunciation, and remote
communication options. Refer to M6-46 for additional
controller features and accessories

Key Features ➢ Manual speed control

 4-line back-lit LCD text display ➢ Manual fuel pump control
 Five key menu navigation ➢ Engine exerciser
 Front panel editing with PIN protection ➢ “protections disabled” feature
 LED and LCD alarm indication ➢ kW overload protection
 Customizable status screens ➢ Power monitoring
 Power save mode ➢ Load switching (load shedding and dummy load
 Support for up to three remote display units outputs)
 9 configurable inputs ➢ Automatic load transfer
 8 configurable outputs ➢ Unbalanced load protection
 Flexible sender inputs ➢ Independent Earth Fault trip
 Configurable timers and alarms ➢ USB connectivity
 3 configurable maintenance alarms ➢ Backed up real time clock
 Multiple date and time scheduler ➢ Configurable display languages
 Configurable event log (250) ➢ User selectable RS232 and RS485 communications
 Control logic facilities ➢ SMS Messaging (additional external modem required)
 Easy access diagnostic page ➢ Additional display screens to help with modem
 CAN and Magnetic Pick-up / Alt. Sensing diagnostics
 Fuel usage monitor and low fuel alarms ➢ Integral PLC editor
 Charger alternator failure alarm
 Generating Sets Standard and Optional Features
Engine
Overview Dimension & Weight
➢ 4-stroke, water-cooled diesel engine
➢ Standard air filter
Ø Standard fuel filter
Ø Standard oil filter
➢ Oil temperature sensor
➢ Low coolant level sensor
Ø Radiator with blowing fan
Ø Industrial silence
➢ Fuel water separator
➢ Water jacket heater (optional)

Alternator
SHX-100(Silent type)
➢ Class H insulation Fuel Tank
Configuration L=Length(mm) W=Width(mm) H=Height(mm) Weight(kg)
➢ IP23 Protection Capacity(L)
➢ Automatic Voltage Regulator (AVR) Silent Type 2900 1100 1750 1600 /
➢ PMG excitation
➢ Single bearing alternator
➢
➢ Class F or class B temperature rise (optional)
➢ Digital Voltage Regulator (optional)
➢ Double bearing (optional)
➢ Condensed heater (optional)
➢ IP41 Protection (optional)

Electrical system
➢ Maintenance-free and anti-explosion battery
➢ Standard breaker
➢ ABB breaker (optional)
➢ ATS (optional)
➢ Battery charger (optional)
➢ GMS monitoring (optional)

Packing
➢ Engine manual
➢ Alternator manual
➢ Gensets operation and maintenance manual SHX-100(Open type)
➢ Tool kit Fuel Tank
Configuration L=Length(mm) W=Width(mm) H=Height(mm) Weight(kg)
Capacity(L)
Open Type 2100 800 1500 1200 /
Baseframe

➢ Forklift pockets
➢ Pulling slots
➢ Earth wire protection
➢ Built-in anti vibration mountings
➢ Fuel outlet value
➢ Standard fuel tank
➢ Enlarged fuel tank (optional)
➢ Separated fuel tank (optional)

Canopy Contact your distributor / dealer for more information

➢ Weatherproof & sound-attenated canopy GUANGDONG SUNKINGS ELECTRIC CO.,Ltd

➢ Sound-absorbing material No.1, Xinglong Road II, Guanglong Industrial
➢ Lifting lug Zone,Chencun Town.
➢ Emergency stop button Shunde District, Foshan City. China.
Web:www.sunkings.cn
➢ Inside silencer
Email: mona@sunkings.cn