Cat Electronic Technician 2017C v1.

0
Product Status Report

6/8/2025 7:00 AM

Product Status Report

Parameter Value
Engine Serial Number S2B00163
Equipment ID DG/1
Comments

3508B Engine - Genset #1 (S2B00163)

Parameter Value
Equipment ID DG/1
Engine Serial Number S2B00163
ECM Serial Number 05256056JP
Personality Module Part Number 5663901-00
Personality Module Release Date JUN18
Personality Module Description GENSET

Logged Diagnostic Codes [Diagnostic Clock = 53628.6004 hours] - 3508B Engine - Genset #1
(S2B00163)
Code Description Occ. First Last
No Logged
Diagnostic
Codes

Logged Event Codes [Diagnostic Clock = 53628.6004 hours] - 3508B Engine - Genset #1
(S2B00163)
Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - 3508B Engine - Genset #1 (S2B00163)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - 3508B Engine - Genset #1 (S2B00163)

Code Description
No Active
Event Codes

Current Totals - 3508B Engine - Genset #1 (S2B00163)

Description Value Unit
Total Time 53628 hours
Total Fuel 1076056 gal

Configuration - 3508B Engine - Genset #1 (S2B00163)

Description Value Unit
Equipment ID DG/1
Engine Serial Number S2B00163
ECM Serial Number 05256056JP
Personality Module Part Number 5663901-00
Personality Module Release Date JUN18
Rated Engine Speed 1800 rpm
Fuel Ratio Control Offset 0
Acceleration Delay Time 0 sec
Engine Acceleration Rate 250 rpm/s
Low Idle Speed 900 rpm
Cooldown Speed 900 rpm
Cooldown Duration 5 min
Engine Pre-Lube Duration 0 sec
Engine Pre-Lube System Configuration Automatic
Engine Continuous Pre-Lube Interval 0 min
Crank Duration 10 sec
Maximum Number of Crank Cycles 3
Crank Terminate RPM 400 rpm
Engine Speed Droop 3.0 %
Rated Fuel Position 24.100 mm
Fuel Correction Factor 0 %
Governor Gain Factor #1 26214
Governor Minimum Stability Factor #1 629
Governor Maximum Stability Factor #1 7864
FLS 0
FTS 0
Air Shutoff Disabled
Air Intake Shutoff Detection Installation Unavailable
Status
Ether Control Disabled
Engine Cooling System Config SCAC (Separate Circuit Aftercooled)
Cold Cylinder Cutout Disabled
Direct Fuel Control Mode Disabled
Desired Speed Input Configuration PWM
Throttle Air Pressure Sensor Installation Unavailable
Status
Throttle Input Low Idle Duty Cycle Setpoint Unavailable %
Throttle Input High Idle Duty Cycle Setpoint Unavailable %
Secondary Desired Speed Input Not Installed
Configuration
Fuel Enable Input Configuration Switch to Ground
Secondary Fuel Enable Input Enable Enabled
Status
Coolant Level Sensor Not Installed
Aftercooler Coolant Level Sensor Not Installed
Installation Status
Cat Data Link #2 Identifier Engine Control #1
Inlet Air Temperature Sensor Not Installed
Engine Oil Temperature Sensor Installation Not Installed
Status
Total Tattletale 16
MonSys Ovr SW Ins 17

Lifetime: Time vs Engine Speed - 3508B Engine - Genset #1 (S2B00163)

Engine Speed( rpm ) hours %
<400.0 1.10 0.00
400.0-499.0 0.20 0.00
500.0-599.0 0.25 0.00
600.0-699.0 0.30 0.00
700.0-799.0 0.25 0.00
800.0-899.0 4.45 0.01
900.0-999.0 4.70 0.01
1000.0-1099.0 0.40 0.00
1100.0-1199.0 0.60 0.00
1200.0-1299.0 0.45 0.00
1300.0-1399.0 0.40 0.00
1400.0-1499.0 0.55 0.00
1500.0-1599.0 0.40 0.00
1600.0-1699.0 0.50 0.00
1700.0-1799.0 19239.95 35.80
1800.0-1899.0 34491.95 64.17
1900.0-1999.0 2.35 0.00
>2000.0 0.00 0.00

Lifetime: Time vs Engine Load Factor - 3508B Engine - Genset #1 (S2B00163)

Engine Load Factor( % ) hours %
<5.0 1.10 0.00
5.0-9.0 182.25 0.34
10.0-14.0 244.20 0.45
15.0-19.0 571.95 1.06
20.0-24.0 4385.45 8.16
25.0-29.0 11633.05 21.64
30.0-34.0 18586.10 34.58
35.0-39.0 7315.95 13.61
40.0-44.0 3475.70 6.47
45.0-49.0 3211.55 5.98
50.0-54.0 1916.30 3.57
55.0-59.0 984.25 1.83
60.0-64.0 582.80 1.08
65.0-69.0 284.55 0.53
70.0-74.0 128.75 0.24
75.0-79.0 78.65 0.15
80.0-84.0 67.05 0.12
85.0-89.0 43.45 0.08
90.0-94.0 40.80 0.08
95.0-99.0 12.40 0.02
>100.0 2.40 0.00

Lifetime: Time vs Right Exhaust Temperature - 3508B Engine - Genset #1 (S2B00163)

Right Exhaust Temperature( hours %
Deg F )
<842.0 49808.85 92.67
842.0-868.0 1152.80 2.14
869.0-895.0 881.05 1.64
896.0-922.0 617.80 1.15
923.0-949.0 505.95 0.94
950.0-976.0 358.90 0.67
977.0-1003.0 193.50 0.36
1004.0-1030.0 84.25 0.16
1031.0-1057.0 45.50 0.08
1058.0-1084.0 22.05 0.04
1085.0-1111.0 5.95 0.01
1112.0-1138.0 3.55 0.01
1139.0-1165.0 1.55 0.00
1166.0-1192.0 3.25 0.01
1193.0-1219.0 0.10 0.00
1220.0-1246.0 0.05 0.00
1247.0-1273.0 0.05 0.00
1274.0-1300.0 0.75 0.00
1301.0-1327.0 0.00 0.00
1328.0-1354.0 0.05 0.00
1355.0-1381.0 7.05 0.01
1382.0-1408.0 15.15 0.03
>1409.0 40.45 0.08

Lifetime: Time vs Left Exhaust Temperature - 3508B Engine - Genset #1 (S2B00163)

Left Exhaust Temperature( Deg hours %
F)
<842.0 46878.70 87.22
842.0-868.0 1555.05 2.89
869.0-895.0 1535.85 2.86
896.0-922.0 988.55 1.84
923.0-949.0 785.80 1.46
950.0-976.0 731.10 1.36
977.0-1003.0 390.80 0.73
1004.0-1030.0 233.25 0.43
1031.0-1057.0 150.80 0.28
1058.0-1084.0 147.50 0.27
1085.0-1111.0 111.05 0.21
1112.0-1138.0 34.65 0.06
1139.0-1165.0 65.15 0.12
1166.0-1192.0 40.65 0.08
1193.0-1219.0 24.55 0.05
1220.0-1246.0 30.35 0.06
1247.0-1273.0 10.05 0.02
1274.0-1300.0 5.25 0.01
1301.0-1327.0 0.05 0.00
1328.0-1354.0 0.00 0.00
1355.0-1381.0 0.05 0.00
1382.0-1408.0 0.10 0.00
>1409.0 29.30 0.05

Monitoring System - 3508B Engine - Genset #1 (S2B00163)

Description State Trip Point Delay Time
Altitude (atmospheric
pressure)
Moderate Severity (2) On 13.4 psi 0 sec
Engine Overspeed
Least Severe (1) On 2070 rpm 0 sec
Most Severe (3) On 2070 rpm 0 sec
High Aftercooler
Coolant Temperature
Least Severe (1) On 216 Deg F 5 sec
Moderate Severity (2) On 225 Deg F 5 sec
Most Severe (3) On 225 Deg F 5 sec
High Air Filter
Restriction Pressure
Least Severe (1) On 28.1 " H2O 5 sec
Moderate Severity (2) On 28.1 " H2O 5 sec
High Boost Pressure
Least Severe (1) Off 58.0 psi 0 sec
Moderate Severity (2) Off 58.0 psi 0 sec
High Crankcase
Pressure
Least Severe (1) On 8.0 " H2O 3 sec
Moderate Severity (2) On 24.1 " H2O 10 sec
Most Severe (3) On 14.1 " H2O 3 sec
High Engine Coolant
Temperature
Least Severe (1) On 216 Deg F 5 sec
Moderate Severity (2) On 225 Deg F 30 sec
Most Severe (3) On 225 Deg F 5 sec
High Engine Oil Filter
Restriction Pressure
Least Severe (1) On 15 psi 5 sec
High Exhaust
Temperature
Least Severe (1) On 1112 Deg F 5 sec
Moderate Severity (2) On 1382 Deg F 5 sec
High Fuel Filter
Restriction Pressure
Least Severe (1) On 15 psi 5 sec
Low Aftercooler
Coolant Level
Least Severe (1) On None 30 sec
Most Severe (3) Off None 30 sec
Low Coolant Level
Least Severe (1) On None 30 sec
Most Severe (3) Off None 30 sec
Low Engine Coolant
Temperature
Least Severe (1) On 176 Deg F 5 sec
Low Engine Oil
Pressure
Least Severe (1) On None 4 sec
Most Severe (3) On None 9 sec
Low Fuel Pressure
Most Severe (3) On 32 psi 20 sec
Low System Voltage
Least Severe (1) On 20 Volts 10 sec

Injector Codes Calibration - 3508B Engine - Genset #1 (S2B00163)

Injector Code
Injector 1 2310
Injector 2 7920
Injector 3 5311
Injector 4 3111
Injector 5 1980
Injector 6 5845
Injector 7 5515
Injector 8 1886

Engine Room MPD - Center Engine

Parameter Value
ECM Part Number 259-217100
ECM Serial Number 0775G044MP
Software Group Part Number 244-102900
Software Group Release Date
Software Group Description

Configuration - Engine Room MPD - Center Engine

Description Value Unit
Display Location Engine Room
Engine Location Center