RSLogix 500 Project Report

P2.RSS

Processor Information

Processor Type: Bul.1763 MicroLogix 1100 Series B

Processor Name: UNTITLED

Total Memory Used: 195 Instruction Words Used - 43 Data Table Words Used

Total Memory Left: 6461 Instruction Words Left

Program Files: 6

Data Files: 9

Program ID: 5c76

Page 1 Tuesday, June 07, 2016 - 20:48:46

 P2.RSS

I/O Configuration

0 Bul.1763 MicroLogix 1100 Series B

1
2
3
4

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Channel Configuration

CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex

CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Edit Resource/Owner Timeout: 60
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Passthru Link ID: 1
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Write Protected: No
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Comms Servicing Selection: Yes
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex Message Servicing Selection: Yes
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex 1st AWA Append Character: \d
CHANNEL 0 (SYSTEM) - Driver: DF1 Full Duplex 2nd AWA Append Character: \a

Source ID: 1 (decimal)

Baud: 19200
Parity: NONE
Control Line : No Handshaking
Error Detection: CRC
Embedded Responses: Auto Detect
Duplicate Packet Detect: Yes
ACK Timeout(x20 ms): 50
NAK Retries: 3
ENQ Retries: 3

CHANNEL 1 (SYSTEM) - Driver: Ethernet

CHANNEL 1 (SYSTEM) - Driver: Ethernet Edit Resource/Owner Timeout: 60
CHANNEL 1 (SYSTEM) - Driver: Ethernet Passthru Link ID: 1
CHANNEL 1 (SYSTEM) - Driver: Ethernet Write Protected: No
CHANNEL 1 (SYSTEM) - Driver: Ethernet Comms Servicing Selection: Yes
CHANNEL 1 (SYSTEM) - Driver: Ethernet Message Servicing Selection: Yes

Hardware Address: 00:00:00:00:00:00

IP Address: 0.0.0.0
Subnet Mask: 0.0.0.0
Gateway Address: 0.0.0.0
Msg Connection Timeout (x 1mS): 15000
Msg Reply Timeout (x mS): 3000
Inactivity Timeout (x Min): 30
Bootp Enable: Yes
Dhcp Enable No
SNMP Enable: No
HTTP Enable: Yes
Auto Negotiate Enable: Yes
Port Speed Enable: 10/100 Mbps Full Duplex/Half Duplex
Contact:
Location:

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Program File List

Name Number Type Rungs Debug Bytes

[SYSTEM] 0 SYS 0 No 0
1 SYS 0 No 0
2 LADDER 4 No 30
IO 3 LADDER 8 No 115
CTRL 4 LADDER 6 No 214
CYCLE 5 LADDER 5 No 235

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File List

Name Number Type Scope Debug Words Elements Last

OUTPUT 0 O Global No 12 4 O:3

INPUT 1 I Global No 18 6 I:5
STATUS 2 S Global No 0 66 S:65
BINARY 3 B Global No 1 1 B3:0
TIMER 4 T Global No 3 1 T4:0
COUNTER 5 C Global No 3 1 C5:0
CONTROL 6 R Global No 3 1 R6:0
INTEGER 7 N Global No 1 1 N7:0
FLOAT 8 F Global No 2 1 F8:0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

LAD 2 - --- Total Rungs in File = 4

IO
JSR
0000 Jump To Subroutine
SBR File Number U:3

Control Logic
JSR
0001 Jump To Subroutine
SBR File Number U:4

Cycle
JSR
0002 Jump To Subroutine
SBR File Number U:5

0003 END

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

LAD 3 - IO --- Total Rungs in File = 8

Prox. Sw. Prox. Sw. Bit

I:0 B3:0
0000
0 0
Bul.1763

Level Sw. Level Sw. Bit

I:0 B3:0
0001
1 1
Bul.1763

Red Photo Eye Red Photo Eye Bit

I:0 B3:0
0002
2 2
Bul.1763

Blue Photo Eye Blue Photo Eye Bit

I:0 B3:0
0003
3 3
Bul.1763

Conveyor Motor Bit Conveyor Motor

B3:0 O:0
0004
4 0
Bul.1763

Walnut Hopper Bit Walnut Hopper

B3:0 O:0
0005
5 1
Bul.1763

Pecan Hopper Bit Pecan Hopper

B3:0 O:0
0006
6 2
Bul.1763

0007 END

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

LAD 4 - CTRL --- Total Rungs in File = 6

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
3 = Intermediate Conveyor Motor Bit
EQU B3:0
0000 Equal
Source A N7:0 4
0<
Source B 0
0<

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
3 = Intermediate
EQU
Equal
Source A N7:0
0<
Source B 2
2<

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station Walnut Hopper Open
3 = Intermediate Blue Photo Eye Bit ONS Trigger
EQU B3:0 B3:0 B3:0
0001 Equal ONS
Source A N7:0 3 12 8
0<
Source B 1
1<

Walnut Hopper Open

Trigger Walnut Hopper Bit
B3:0 B3:0
0002
8 5

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Walnut Hopper Bit 3 = Intermediate Level Sw. Bit
B3:0 EQU B3:0
Equal
5 Source A N7:0 1
0<
Source B 1
1<

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

LAD 4 - CTRL --- Total Rungs in File = 6

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station Pecan Hopper Open
3 = Intermediate Red Photo Eye Bit ONS Trigger
EQU B3:0 B3:0 B3:0
0003 Equal ONS
Source A N7:0 2 13 14
0<
Source B 1
1<

Pecan Hopper Open

Trigger Pecan Hopper Bit
B3:0 B3:0
0004
14 6

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Pecan Hopper Bit Level Sw. Bit 3 = Intermediate
B3:0 B3:0 EQU
Equal
6 1 Source A N7:0
0<
Source B 1
1<

0005 END

Page 2 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

LAD 5 - CYCLE --- Total Rungs in File = 5

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Prox. Sw. Bit Red Photo Eye Bit Blue Photo Eye Bit Level Sw. Bit 3 = Intermediate
B3:0 B3:0 B3:0 B3:0 MOV
0000 Move
0 2 3 1 Source 0
0<
Dest N7:0
0<

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Prox. Sw. Bit Red Photo Eye Bit Level Sw. Bit ONS 3 = Intermediate
B3:0 B3:0 B3:0 B3:0 MOV
0001 ONS Move
0 2 1 9 Source 1
1<
Blue Photo Eye Bit Dest N7:0
B3:0 0<

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Prox. Sw. Bit Red Photo Eye Bit Level Sw. Bit ONS 3 = Intermediate
B3:0 B3:0 B3:0 B3:0 MOV
0002 ONS Move
0 2 1 10 Source 2
2<
Blue Photo Eye Bit Dest N7:0
B3:0 0<

Cycle Stage:
0 = Bring Box
1 = Fill Box
2 = Unload Station
Prox. Sw. Bit Red Photo Eye Bit Blue Photo Eye Bit Level Sw. Bit 3 = Intermediate
B3:0 B3:0 B3:0 B3:0 MOV
0003 Move
0 2 3 1 Source 3
3<
Prox. Sw. Bit Red Photo Eye Bit Blue Photo Eye Bit Level Sw. Bit Dest N7:0
B3:0 B3:0 B3:0 B3:0 0<

0 2 3 1

0004 END

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File O0 (bin) -- OUTPUT

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

O:0.0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B

O:0.1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B
O:0.2 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B
O:0.3 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B

Page 1 (Radix Binary) Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File I1 (bin) -- INPUT

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0

I:0.0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B

I:0.1 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B
I:0.2 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B
I:0.3 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B
I:0.4 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B-Analog I
I:0.5 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Bul.1763 MicroLogix 1100 Series B-Analog I

Page 1 (Radix Binary) Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File S2 (hex) -- STATUS

Main

Processor Mode S:1/0 - S:1/4 = Remote Program Mode

On Power up Go To Run (Mode Behavior) S:1/12 = 0
First Pass S:1/15 = No
Free Running Clock S:4 = 0000-0000-0000-0000

Proc

OS Catalog Number S:57 = 1100 User Program Type S:63 = 8001h

OS Series S:58 = A Compiler Revision Number S:64 =
OS FRS S:59 =
Processor Catalog Number S:60 =
Processor Series S:61 = A
Processor FRN S:62 =

Scan Times

Maximum (x10 ms) S:22 = 0

Watchdog (x10 ms) S:3 (high byte) = 10
Last 100 uSec Scan Time S:35 = 0
Scan Toggle Bit S:33/9 = 0

Math

Math Overflow Selected S:2/14 = 0 Math Register (lo word) S:13 = 0

Overflow Trap S:5/0 = 0 Math Register (high word) S:14-S:13 = 0
Carry S:0/0 = 0 Math Register (32 Bit) S:14-S:13 = 0
Overflow S:0/1 = 0
Zero Bit S:0/2 = 0
Sign Bit S:0/3 = 0

Chan 0

Processor Mode S:1/0- S:1/4 = Remote Program Mode

Node Address S:15 (low byte) = 0 Outgoing Msg Cmd Pending S:33/2 = 0
Baud Rate S:15 (high byte) = ?
Channel Mode S:33/3 = 0
Comms Active S:33/4 = 0
Incoming Cmd Pending S:33/0 = 0
Msg Reply Pending S:33/1 = 0

Debug

Suspend Code S:7 = 0

Suspend File S:8 = 0

Errors

Fault Override At Power Up S:1/8 = 0 Fault Routine S:29 = 0

Startup Protection Fault S:1/9 = 0 Major Error S:6 = 0h
Major Error Halt S:1/13 = 0
Overflow Trap S:5/0 = 0 Error Description:
Control Register Error S:5/2 = 0
Major Error Executing User Fault Rtn. S:5/3 = 0
Battery Low S:5/11 = 0
Input Filter Selection Modified S:5/13 = 0
ASCII String Manipulation error S:5/15 = 0

Protection

Deny Future Access S:1/14 = No

Data File Overwrite Protection Lost S:36/10 = False

Mem Module

Memory Module Loaded On Boot S:5/8 = 0

Password Mismatch S:5/9 = 0
Load Memory Module On Memory Error S:1/10 = 0
Load Memory Module Always S:1/11 = 0
On Power up Go To Run (Mode Behavior) S:1/12 = 0
Program Compare S:2/9 = 0
Data File Overwrite Protection Lost S:36/10 = 0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File S2 (hex) -- STATUS

Forces

Forces Enabled S:1/5 = Yes

Forces Installed S:1/6 = No

Page 2 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File B3 (bin) -- BINARY

Offset 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 0 (Symbol) Description

B3:0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

Page 1 (Radix Binary) Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File T4 -- TIMER

Offset EN TT DN BASE PRE ACC (Symbol) Description

T4:0 0 0 0 .01 sec 0 0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File C5 -- COUNTER

Offset CU CD DN OV UN UA PRE ACC (Symbol) Description

C5:0 0 0 0 0 0 0 0 0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File R6 -- CONTROL

Offset EN EU DN EM ER UL IN FD LEN POS (Symbol) Description

R6:0 0 0 0 0 0 0 0 0 0 0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File N7 (dec) -- INTEGER

Offset 0 1 2 3 4 5 6 7 8 9

N7:0 0

Page 1 (Radix Decimal) Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Data File F8 -- FLOAT

Offset 0 1 2 3 4

F8:0 0

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

CDM 0 - Untitled

Address (Symbol) = Value [Description]

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Address/Symbol Database

Address Symbol Scope Description Sym Group D

B3:0/0 Prox. Sw. Bit

B3:0/1 Level Sw. Bit
B3:0/2 Red Photo Eye Bit
B3:0/3 Blue Photo Eye Bit
B3:0/4 Conveyor Motor Bit
B3:0/5 Walnut Hopper Bit
B3:0/6 Pecan Hopper Bit
B3:0/7
B3:0/8 Walnut Hopper Open Trigger
B3:0/9 ONS
B3:0/10 ONS
B3:0/11
B3:0/12 ONS
B3:0/13 ONS
B3:0/14 Pecan Hopper Open Trigger
I:0/0 Prox. Sw.
I:0/1 Level Sw.
I:0/2 Red Photo Eye
I:0/3 Blue Photo Eye
N7:0 Cycle Stage: 0 = Bring Box 1 = Fill Box 2 = Unload Station 3 = Intermediate
O:0/0 Conveyor Motor
O:0/1 Walnut Hopper
O:0/2 Pecan Hopper
S:0 Arithmetic Flags
S:0/0 Processor Arithmetic Carry Flag
S:0/1 Processor Arithmetic Underflow/ Overflow Flag
S:0/2 Processor Arithmetic Zero Flag
S:0/3 Processor Arithmetic Sign Flag
S:1 Processor Mode Status/ Control
S:1/0 Processor Mode Bit 0
S:1/1 Processor Mode Bit 1
S:1/2 Processor Mode Bit 2
S:1/3 Processor Mode Bit 3
S:1/4 Processor Mode Bit 4
S:1/5 Forces Enabled
S:1/6 Forces Present
S:1/7 Comms Active
S:1/8 Fault Override at Powerup
S:1/9 Startup Protection Fault
S:1/10 Load Memory Module on Memory Error
S:1/11 Load Memory Module Always
S:1/12 Load Memory Module and RUN
S:1/13 Major Error Halted
S:1/14 Access Denied
S:1/15 First Pass
S:2/0 STI Pending
S:2/1 STI Enabled
S:2/2 STI Executing
S:2/3 Index Addressing File Range
S:2/4 Saved with Debug Single Step
S:2/5 DH-485 Incoming Command Pending
S:2/6 DH-485 Message Reply Pending
S:2/7 DH-485 Outgoing Message Command Pending
S:2/15 Comms Servicing Selection
S:3 Current Scan Time/ Watchdog Scan Time
S:4 Time Base
S:5/0 Overflow Trap
S:5/2 Control Register Error
S:5/3 Major Err Detected Executing UserFault Routine
S:5/4 M0-M1 Referenced on Disabled Slot
S:5/8 Memory Module Boot
S:5/9 Memory Module Password Mismatch
S:5/10 STI Overflow
S:5/11 Battery Low
S:6 Major Error Fault Code
S:7 Suspend Code
S:8 Suspend File
S:9 Active Nodes
S:10 Active Nodes
S:11 I/O Slot Enables
S:12 I/O Slot Enables
S:13 Math Register
S:14 Math Register
S:15 Node Address/ Baud Rate
S:16 Debug Single Step Rung
S:17 Debug Single Step File
S:18 Debug Single Step Breakpoint Rung
S:19 Debug Single Step Breakpoint File
S:20 Debug Fault/ Powerdown Rung
S:21 Debug Fault/ Powerdown File
S:22 Maximum Observed Scan Time
S:23 Average Scan Time
S:24 Index Register
S:25 I/O Interrupt Pending

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Address/Symbol Database

Address Symbol Scope Description Sym Group D

S:26 I/O Interrupt Pending

S:27 I/O Interrupt Enabled
S:28 I/O Interrupt Enabled
S:29 User Fault Routine File Number
S:30 STI Setpoint
S:31 STI File Number
S:32 I/O Interrupt Executing
S:33 Extended Proc Status Control Word
S:33/0 Incoming Command Pending
S:33/1 Message Reply Pending
S:33/2 Outgoing Message Command Pending
S:33/3 Selection Status User/DF1
S:33/4 Communicat Active
S:33/5 Communicat Servicing Selection
S:33/6 Message Servicing Selection Channel 0
S:33/7 Message Servicing Selection Channel 1
S:33/8 Interrupt Latency Control Flag
S:33/9 Scan Toggle Flag
S:33/10 Discrete Input Interrupt Reconfigur Flag
S:33/11 Online Edit Status
S:33/12 Online Edit Status
S:33/13 Scan Time Timebase Selection
S:33/14 DTR Control Bit
S:33/15 DTR Force Bit
S:34 Pass-thru Disabled
S:34/0 Pass-Thru Disabled Flag
S:34/1 DH+ Active Node Table Enable Flag
S:34/2 Floating Point Math Flag Disable,Fl
S:35 Last 1 ms Scan Time
S:36 Extended Minor Error Bits
S:36/8 DII Lost
S:36/9 STI Lost
S:36/10 Memory Module Data File Overwrite Protection
S:37 Clock Calendar Year
S:38 Clock Calendar Month
S:39 Clock Calendar Day
S:40 Clock Calendar Hours
S:41 Clock Calendar Minutes
S:42 Clock Calendar Seconds
S:43 STI Interrupt Time
S:44 I/O Event Interrupt Time
S:45 DII Interrupt Time
S:46 Discrete Input Interrupt- File Number
S:47 Discrete Input Interrupt- Slot Number
S:48 Discrete Input Interrupt- Bit Mask
S:49 Discrete Input Interrupt- Compare Value
S:50 Processor Catalog Number
S:51 Discrete Input Interrupt- Return Number
S:52 Discrete Input Interrupt- Accumulat
S:53 Reserved/ Clock Calendar Day of the Week
S:55 Last DII Scan Time
S:56 Maximum Observed DII Scan Time
S:57 Operating System Catalog Number
S:58 Operating System Series
S:59 Operating System FRN
S:61 Processor Series
S:62 Processor Revision
S:63 User Program Type
S:64 User Program Functional Index
S:65 User RAM Size
S:66 Flash EEPROM Size
S:67 Channel 0 Active Nodes
S:68 Channel 0 Active Nodes
S:69 Channel 0 Active Nodes
S:70 Channel 0 Active Nodes
S:71 Channel 0 Active Nodes
S:72 Channel 0 Active Nodes
S:73 Channel 0 Active Nodes
S:74 Channel 0 Active Nodes
S:75 Channel 0 Active Nodes
S:76 Channel 0 Active Nodes
S:77 Channel 0 Active Nodes
S:78 Channel 0 Active Nodes
S:79 Channel 0 Active Nodes
S:80 Channel 0 Active Nodes
S:81 Channel 0 Active Nodes
S:82 Channel 0 Active Nodes
S:83 DH+ Active Nodes
S:84 DH+ Active Nodes
S:85 DH+ Active Nodes
S:86 DH+ Active Nodes
U:3 IO
U:4 Control Logic
U:5 Cycle

Page 2 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Instruction Comment Database

Address Instruction Description

Page 1 Tuesday, June 07, 2016 - 20:48:47

 P2.RSS

Symbol Group Database

Group_Name Description

Page 1 Tuesday, June 07, 2016 - 20:48:47