8:
Rheology
Zainab A. Radhi
Assistant Lecturer in pharmaceutics
Class: 2nd year
Baghdad College of Medical Sciences
Outlines
Introduction
Viscosity
Newtonian Systems
Non-Newtonian Systems
Thixotropy
Introduction
The term rheology is derived from the Greek words rheo “to flow,”
and logos “science”. It is defined as the study of the flow of
liquids and deformation of solids.
Viscosity is an expression of the resistance of a fluid to flow; the
higher the viscosity, the greater is the resistance. It is one of the
main components of rheology.
The simple liquids can be described in terms of absolute viscosity by a
single value.
The heterogeneous dispersions have
more complex rheological properties, and they cannot be
expressed by a single value.
Manufacturers of medicinal and cosmetic creams, pastes, and
lotions must be capable of
producing products with acceptable
consistency and smoothness. The rheology of product can affect
patient acceptability, physical stability, and even biologic availability.
Rheological properties of a pharmaceutical system can
influence the selection of processing equipment, and also valuable
information can be obtained by use of analytic methods of rheology, for
formulating better pharmaceutical products.
Materials can be classified, according to types of flow
and deformation, in one of two categories:
Newtonian systems: are the systems in which the viscosity stays
constant, as the applied force changes.
Non-Newtonian systems: are the systems in which the viscosity
changes as some function of applied force.
The classification depends on whether or
not the material flow properties obeys
Newton's law of flow.
Newtonian Systems
It is one of the simplest types of flow; water and low molecular-
weight oils show Newtonian flow.
Rate of shear or the velocity gradient: is the difference of velocity,
dv, between two planes of liquid separated by an infinitesimal
distance dr.
(𝒅𝒗 )=G
𝒅𝒓
Shearing stress : is the force per
unit
area required to bring about flow.
(
)=F
𝑨
Newton proposed that “the velocity (dv) of the material over the small
distance (dr) that it travels is directly proportional to the applied shear
stress”.
Newton recognized that the higher the viscosity of a liquid, the
greater force per unit area (shearing stress) required to produce a
certain rate of shear.
Hence, rate of shear should be directly proportional to shearing stress:
where the constant is known as the coefficient of viscosity
(or simply viscosity) of the Newtonian fluid.
Based on this equation, viscosity is defined as a parameter
that
measures resistance to flow.
where F = F′/A = shearing stress G
= dv/dr = rate of shear
A flow curve (rheogram),
obtained by plotting F versus
G.
For a Newtonian system, a
straight
obtained.
Unit of viscosity
The unit of viscosity is the poise, defined as the shearing force
required to produce a velocity of 1 cm/sec between two parallel
planes of liquid each 1 cm2 in area and separated by a distance of 1
cm.
The poise can be represented by (dyne.sec.cm-2) or (g.cm-1.sec-1)
A more convenient unit for most work is the centipoise (cp, plural
cps): 1 cp = 0.01 poise.
𝟏
Fluidity, φ, a term sometimes used, is defined as φ=
the reciprocal of viscosity: 𝜼
Kinematic viscosity is the absolute viscosity divided by the density of
the liquid at a specific temperature; represented by the equation:
𝜼
Kinematic viscosity = 𝝆 is the density of substance in g/cm3
𝝆
•The units of kinematic viscosity are poise/(g/cm3), and known as the
stoke (s).
•The centistoke(cs) is also used as kinematic viscosity unit.
Absolute viscosities of some Newtonian liquids at 20 C° commonly
used in pharmacy are given in this table :
Liquid Viscosity (cp)
Castor oil 1000
Olive oil 100
Water 1.0019
Note: Water is ordinarily used as a standard for viscosity of liquids.
Its viscosity at 25°C is 0.8904 cp.
Temperature Dependence and the Theory of Viscosity
The viscosity of liquid decreases as temperature is raised, and
the fluidity of a liquid (the reciprocal of viscosity) increases
with temperature.
The dependence of the viscosity of a liquid on temperature is expressed
approximately for many substances by an equation analogous to the
Arrhenius equation of chemical kinetics:
𝜂 = AeEvRT
where A is a constant depending on the molecular weight and
molar volume of the liquid and EV, is an "activation energy" required to
initiate flow between molecules.
Non-Newtonian Systems
The majority of fluid pharmaceutical products are not simple liquids and do
not follow Newton's law of flow. These systems are referred to as
non- Newtonian.
Non-Newtonian behavior is generally exhibited by liquid and
solid heterogeneous dispersions such as colloidal solutions, emulsions,
liquid suspensions, and ointments.
When non-Newtonian materials are analyzed in a rotational viscometer and
results are plotted, various consistency curves, representing three classes of
flow, are recognized:
1)Plastic 2)Pseudoplastic 3)Dilatant
1. Plastic Flow
The curve represents a body that
exhibits plastic flow; such materials are
known as Bingham bodies.
Plastic flow curves do not
pass through the origin but rather
intersect the shearing stress axis at a
particular point (or will if the straight
part of the curve is extrapolated to
the axis) referred to as the yield
value.
The yield value is defined as “the minimum shear stress required by
the system before it deforms and begins to flow”.
Once the yield value has been reached, the relationship between
shear stress and rate of shear becomes linear.
A Bingham body does not begin to flow until a shearing stress
corresponding to the yield value is exceeded. At stresses below the
yield value, the substance acts as an elastic material.
Yield value is an important property of certain dispersions.
The slope of the rheogram is termed
the mobility, analogous to fluidity in
Newtonian systems, and
its reciprocal is known as the
plastic viscosity, U.
where f is the yield
value, or intercept, on
the shear stress axis in
dynes/cm2,.
Plastic flow is associated with the presence of flocculated particles
in concentrated suspensions. A yield value exists because of the
contacts between adjacent particles (brought about by Van der Waals
forces), which must be broken down before flow can occur.
Consequently, the yield value is an indication of force of flocculation:
The more flocculated the suspension, the higher will be the yield
value.
2.Pseudo-plastic Flow
Many pharmaceutical products, including liquid dispersions of
natural and synthetic gums (e.g., sodium alginate, and
methylcellulose) exhibit pseudoplastic flow.
Pseudoplastic flow is typically exhibited by polymers in solution,
in contrast to plastic systems, which are composed of
flocculated particles in suspension.
The curve for a pseudo-plastic material begins at the origin; thus,
there is no yield value in this system.
Furthermore, because no part of the curve is linear, the viscosity of
a pseudoplastic material cannot be expressed by any single value.
The viscosity of a pseudoplastic substance
decreases with increasing rate of shear. For example: Ketchup.
• An apparent viscosity can be obtained at any rate of shear from the
slope of the tangent to the curve at the specified point.
• The most satisfactory representation for a pseudoplastic material,
however, is probably a graphic plot of the entire consistency curve.
• Objective comparisons between different pseudoplastic systems are
more difficult than with either Newtonian or plastic systems. For
example, Newtonian systems are completely described by viscosity, η,
and plastic systems are adequately described by yield value, f, and
plastic viscosity, U.
The pseudo-plastic viscosity is expressed by the exponential formula:
or FN = 𝜂' G
The term η′ is a viscosity coefficient for pseudo-plastic material.
The exponent N rises as flow becomes more pseudo-plastic.
When N = 1, the flow is Newtonian.
When the shearing stress is increased, the irregular molecules begin to
align in the direction of flow; it reduces the internal resistance of
the
material and allows a greater rate of shear at each successive
shearing stress and lower viscosity.
3. Dilatant flow
Certain suspensions with a high percentage of dispersed solids exhibit an
increase in resistance to flow with increasing rates of shear. Such
systems actually increase in volume when sheared and are hence
termed dilatant.
Whereas pseudoplastic materials are frequently referred to as "shear-
thinning systems," dilatant materials are often termed "shear-
thickening systems." When stress is removed, a dilatant system returns to
its original state of fluidity.
Equation:
FN = 𝜂 'G
This can be used to describe dilatancy in quantitative terms. In this case,
N is always less than 1 and decreases as degree of dilatancy increases.
As N approaches 1, the system becomes increasingly Newtonian
in behavior.
Substances possessing dilatant flow properties are
invariably suspensions containing a high concentration (about 50 % or
greater) of small, deflocculated particles.
THIXOTROPY
Several types of behavior are observed when rate of shear is progressively
increased and plotted against resulting shear stress.
This phenomenon, known as thixotropy, can be defined as "an isothermal
and comparatively slow recovery, on standing of a material, of
a consistency lost through shearing."
If the rate of shear were reduced when the maximum had been
reached, and the resulted down-curve is identical with the up-curve
(superimposable), this system is Newtonian systems.
With shear-thinning systems, the down-curve is displaced to the left of
the up-curve. Showing that the material has a lower consistency at the
downcurve than at upcurve.
This indicates a breakdown of structure (and hence shear thinning) that
does not reform immediately when stress is removed or reduced.
• Rheograms obtained with thixotropic materials are highly
dependent on the rate at which shear is increased or decreased and the
length of time a sample is subjected to any one rate of shear. So the
rheogram for same product is different depending on time of shear,
rate of shear, and degree of structure in the sample. This is an
important point to bear in mind when attempting to obtain a
quantitative measure of thixotropy.
Hysteresis loop: Is the area between the up-curve and
down-curve of rheogram.
Measurement of Thixotropy
The area of hysteresis has been proposed as a measure of
thixotropic breakdown; it can be obtained readily by means of a
planimeter or other suitable technique.
With plastic (Bingham) bodies, two approaches are frequently used
to estimate degree of thixotropy.
The first approach: is to determine structural breakdown with
time of a plastic system possessing thixotropy when subjected to a
constant rate of shear for time t. (the maximum shear rate is constant,
the time of holding before reducing shearing stress is different).
Based on such a rheogram, a thixotropic coefficient, B, the rate of
breakdown with time at constant shear rate, is calculated as follows:
𝑼𝟏−𝑼𝟐
B= 𝒍𝒏 𝒕 𝟐
𝒕𝟏
where U1, and U2 are
the plastic viscosities of the
two down-curves, calculated
from 𝑭− 𝒇
equation 𝑮
),
(U= afterfor
shearing at a constant rate
t1 and t2 seconds, respectively.
The second approach: is to determine the structural breakdown of a
plastic system possessing thixotropy when subjected to increasing
shear rates. (The maximum shear rate is different; the time of holding
before reducing shearing stress is constant).
The principle involved in this approach is two hysteresis loops
are obtained having different maximum rates of shear, v1, and v2.
In this case, a thixotropic coefficient, M, the loss in shearing stress per
unit increase in shear rate, is obtained from:
𝑈1−𝑈2
M=
UwhereandM U is2 inare
dynes.sec/cm and
2
1,
the
viscosities for twoplastic
separate down-
curves having maximum
shearing rates of v1 and v2,
respectively.
Negative Thixotropy (antithixotropy)
It is phenomenon represents an increase rather than a decrease in
consistency on the down-curve. This increase in thickness
with increased time of shear was observed in the rheologic
analysis of magnesia magma. It was detected at shear rates of greater
than 30 sec-1; below 30 sec-1 the magma showed normal thixotropy, the
down-curve appearing to the left of the up-curve.
Negative thixotropy should not be confused with dilatancy
or
rheopexy.
Dilatant systems are deflocculated and ordinarily contain greater than
50% by volume of solid dispersed phase, whereas antithixotropic
systems have low solids content (1%-10%) and are flocculated.
Rheopexy is a phenomenon in which solid forms a gel more
readily when gently shaken than when allowed to form the gel
while the material is kept at rest. In a rheopectic system, the
gel is the equilibrium form, whereas in antithixotropy, the
equilibrium state is the sol.
DETERMINATION OF RHEOLOGIC PROPERTIES
Choice of Viscometer
For Newtonian system, because shear rate is directly proportional
to shearing stress, instruments that operate at a single shear rate can be
used. These "single-point" instruments provide a single point on the
rheogram; extrapolation of a line through this point to the origin
will result in a complete rheogram.
For Non-Newtonian, a single-point determination is virtually
useless in characterizing its flow properties. It is therefore essential that,
with non-Newtonian systems, the instrument can operate at a
variety of shear rates. Such multipoint instruments are capable of
producing a complete rheogram for non-Newtonian systems.
The main instruments used for determination of rheological properties
are: capillary, falling-sphere, cup-and-bob, and cone-and-
plate viscometers.
The first two (capillary, falling-sphere viscometer) are single-shear-rate
instruments suitable for use only with Newtonian materials.
The latter two (cup-and-bob, cone-and-plate viscometers)
are multipoint, rotational instruments can be used with both
Newtonian and non-Newtonian systems.
VISCOELASTICITY
Viscoelastic measurements are based on the mechanical
properties of materials that exhibit both viscous properties of
liquids and elastic properties of solids. Many of the systems studied
in pharmacy belong to this class, as creams, lotions, ointments,
suppositories, suspensions, and the colloidal dispersing, emulsifying,
and suspending agents.
Pharmaceutical areas, in which rheology is significant, are:
1. Fluids
Mixing
Particle-size reduction of disperse systems with shear.
Passage through orifices, including pouring, packaging in bottles, and
passage through hypodermic needles.
Fluid transfer, including pumping and flow through pipes. Physical
stability of disperse systems.
2. Quasisolids
Spreading and adherence on the skin. Removal from jars or extrusion
from tubes.
Capacity of solids to mix with miscible liquids.
Release of the drug from the base.
3. Solids
Flow of powders from hoppers and into die cavities in tableting or into
capsules during encapsulation.
Package-ability of powdered or granular solids. Processing.
Production capacity of the equipment.
Processing efficiency.